Professional Documents
Culture Documents
TDS Brushbond RFX India2
TDS Brushbond RFX India2
The product can be used on concrete, brick and blockwork sub- Surface Preparation
strates and is equally suitable for new and existing structures.
All surfaces which are to receive the coating must be free from
The product is designed to reface and even out variations in
oil, laitance, grease, wax, dirt or any other form of foreign matter
concrete and masonry surfaces and bridge shrinkage cracks.
which might affect adhesion. Typically concrete surfaces can
It provides a seamless, flexible waterproof coating suitable for be cleaned using high pressure water jet or grit blasting or by
water tanks, reservoirs, drainage culverts basements, roofs, proper wire brushing Spalled surfaces or those containing large
toilets & wet areas. The product provides a tough durable water blow holes, cracks and other such defects should be repaired
resistant coating which can withstand light pedestrian traffic and using Renderoc concrete repair mortars. For further advice on
also has excellent weather resistance for exterior applications. suitable repair mortars, contact the local Fosroc Office.
Advantages Mixing
Ex celle nt b arrie r to carbo n dioxide, chloride Brushbond RFX liquid concentrate should be poured into a
and sulphate ions. plastic container or metal drum. Clean fresh water is added in
Allows water vapour to escape from the structure. the proportions shown below and mixing commenced with a
Waterproof-suitable for water retaining structures. propeller agitator attached to a slow speed drill (500pm). The
High resistance to the effect of long-term weathering, powder component should be added gradually to the liquid to
durable in all climate conditions including UV attack. avoid lump formation and mixed for 2-4 minutes. Brushbond
Non toxic - ideal for potable water tanks. RFX should be immediately used after mixing. Do not mix
Flexible, with thermal expansion similar to concrete. more material than can be used within the pot life. Keep stirring
Excellent bond to concrete and masonry. Brushbond RFX during the application
Good crack accommodation capacity. Mixing ratio
Minimum surface preparation needed and low labour
costs.
Brushbond RFX Brush Application
Components Indl Pack Small
Standards compliance
Brushbond RFX powder 15kg 5kg
Tested to ASTM D4060, ASTM D4541, ASTM D638,
ASTM C836. Brushbond RFX liquid 5.088kg 1.71kg
Water 3L 1L
Description
Properties Brushbond RFX shall be applied as soon as the first coat has
reached touch dry state. It is recommended that for general
Pot life : 30 min @ 270C
surfacing Brushbond RFX should be applied at a minimum
Mixed density : 1 . 6 8 g / c c (b ru s h a b l e
consistency) thickness of 1mm. Areas subjected to moderate and heavy
page 1 of 2
Brushbond RFX
Important note :
Fosroc products are guaranteed against defective materials and manufacture and are sold
subject to its standard terms and conditions of sale, copies of which may be obtained on
request. Whilst Fosroc endeavours to ensure that any advice, recommendation specification
or information it may give is accurate and correct, it cannot, because it has no direct or
continuous control over where or how its products are applied, accept any liability either
Fosroc Chemicals directly or indirectly arising from the use of its products whether or not in accordance with
any advice, specification, recommendation or information given by it.
(India) Pvt. Ltd.
Head Office telephone fax e-mail
Embassy Point, No. 150,
2nd Floor, Infantry Road, +91 80-42521900 +91 80-22281510 enquiryindia@fosroc.com
Bangalore 560 001,
Karnataka
Regional Offices
www.fosroc.com
page 2 of 2 INDIA/2020/0802/B