Professional Documents
Culture Documents
Uses Properties
For improving and bonding floor toppings, renders and Mechanical characteristics
mortars; repair of worn, damaged or spalled concrete.
Typical improvement in mechanical properties of a 3:1
Recommended primer for the Renderoc Cementitious Repair sand/cement mortar using Nitobond AR the test methods
System. used were in full accordance with BS 6319 at 28 days - air
cured.
Advantages
Typical
Test method Control results
Single component gauged as required.
Tensile strength *
N/mm2 2.0 2.6
Simply brushed onto concrete as a primer. (BS 6319 Part 17:1985);
Flexural strength *
Provides excellent bond to concrete, masonry, N/mm2 5.8 10.2
stonework, plaster and block-board. (BS 6319 Part 3:1990):
Curing efficiency
Improves tensile and flexural properties. Allows thin (BS 7542:1992): > 55%
section applications.
* results may vary due to cement variations & w/c ratio
Compatible with all common hydraulic cements.
Application instructions
Suitable for use in Middle East conditions. Used as a
curing membrane.
Surface preparation
Is economical in use. Clean the surface and remove any dust, unsound or
contaminated material, plaster, oil, paint, grease, corrosion
Description deposits or algae. Where breaking out is not required,
roughen the surface and remove any laitence by light
Nitobond AR a modified acrylic emulsion is specially scabbling or grit-blasting.
designed for use as a bonding aid, curing agent and gauging
liquid for cementitious systems. It is resistant to hydrolysis Expose fully any corroded steel in the repair area and
and can therefore be used for external application. remove all loose scale and corrosion deposits. Steel should
be cleaned to bright condition paying particular attention to
the back of the exposed steel bars. Grit-blasting is
Technical support recommended for this process.
Nitobond AR mortars, toppings and renders should not be Application of bonding aid
used when the temperature is below 5°C and falling. Neither
should they be exposed to moving water during application. The substrate should be thoroughly soaked with clean water
Exposure to heavy rainfall prior to the final set may result in with any excess removed prior to commencement of the
surface scour. If any doubts arise concerning temperature, works. Scrub Nitobond AR into the substrate, avoid
application or substrate conditions, consult the local Fosroc puddling and remove any excess. The repair mortar or
office. topping should be applied whilst the primer is still tacky.
Page 1
Nitobond AR
Curing Fire
Storage
Shelf life
Precautions
Important note:
Fosroc products are guaranteed against defective materials and manufacture and are sold subject to its standard Conditions
for the Supply of Goods and Services, copies of which may be obtained on request. Whilst Fosroc endeavours to ensure that
any advice, recommendation, specification of information it may give is accurate and correct, it cannot, because it has no direct
or continuous control over where or how its products are applied, accept any liability either directly or indirectly arising from the
use of its products, whether or not in accordance with any advice, specification, recommendation of information given by it.
www.fosroc.com Khamis Mushayt Tel: (017) 250 0469 Fax: (017) 250 0469 CSD Tel: (012) 608 0999 Fax: (012) 638 0693
Registered Office: Industrial Area, Phase 4, Road No. 102, Street No. 82
Page 2 FO SA/NITOBOND AR/2108/16