Situation 1: For the truss shown at FIG 01, FIG 01
determine the following: 1. Determine the force (kN) acting in member BD
2. Determine the force (kN) acting in
member BE
Situation 2: A cantilever beam is subjected
to the following loads at FIG 02 and E = 11 GPa:
3. Determine the normal stress in MPa at
point b
4. Determine the shear stress in MPa at point FIG 02
a
5. Determine the deflection in mm at the
free end neglecting the effect of transverse load
Situation 3: Refer to FIG 03. A chain makes
angles of 30° and 60° at its supports as shown. Supports A and B are at different elevation.
6. Determine the location of the low point C FIG 03
of the chain relative to A in m
7. Determine the tension at support A, if the
cable has a mass per length of 0.6 kg/m
Situation 4: A cantilever beam with a
rectangular cross section carries the loading shown at FIG 04. If the modulus of elasticity of the beam is equal to 11 GPa FIG 04 8. Determine the maximum normal stress in MPa
9. At the face of the beam where the
maximum tensile and compressive stresses are located, determine how much does the neutral axis shift downward or upward in mm. 10. Determine the deflection at the free end in mm.