Professional Documents
Culture Documents
a.) 202.5 b.) 2001 c.) 707.6 d.) 1414 e.) none of these
5. A simply supported beam of length L carries a uniform load of ω( in kN/m) throughout its length. Which of the following
gives the midspan deflection?
a.) 5 ωL4/(384 EI) b.) 2. 5 ωL4/(384 EI) c.) ωL4/(384 EI) d.) 2 ωL4/(384 EI) e.) none of these
6. Which of the following gives the location of the maximum deflection from the left support, in m?
a.) 1.52 b.) 1.63 c.) 2.15 d.) 2 e.) none of these
7. Which of the following gives the maximum deflection of the beam in mm?
a.) 1.5 b.) 2.4 c.) 3.5 d.) 2.9 e.) none of these
8. Which of the following gives the rotation of the beam at the right support, in radian?
a.) 0.00432 b. ) 0.00211 c.) 0.00333 d.) 0.00132 e.) none of these
______________________________________________________________________________________
9. Which of the following gives the qualitative influence diagram for the shear at a point between the two supports on the
left of the beam shown below?
e.) none of these
_____________________________________________________________________________________
(Refer to the figure below for the next 3 questions)
10. The truss shown has members with Coefficient of linear expansion of 1.2 x 10-5 m/m°C. When the bottom chords were
subjected to an increase of 30 °C in the temperature which of the following gives the vertical deflection of joint C ( in
mm) assuming downward deflection is positive :
a.)4.498 b.) 2.881 c.) -2.881 d.)-4.498 e.) none of these
11. When the same truss is subjected to both the increase in temperature and the loads at B and D, which of the following
gives the vertical deflection of joint C in mm, assuming downward deflection is positive?
a.) 1.268 b.)10.264 c.)8.647 d.)2.884 e.) none of these
12. The same truss shown, with E = 200 GPa, when subjected to downward concentrated loads of 120 kN at both joints B and
D, which of the following gives the vertical deflection at joint C in mm, assuming downward deflection is positive?
a.) 7.566 b.)6.675 c.)5.766 d.)6.756 e.) none of these
___________________________________________________________________________________
14. Which of the following gives the absolute value of the deflection y (in mm)at the free end of the beam?
a.)1.2 b.)0.2 c.) 2.4 d.)3.5 e.)none of these
15. Which of the following gives EI t C/A ?
a.)-3304/45 b.) -3368/45 c.)-2208/45 d.)-1748/45 e.)none of these
16. If AD is the span between points 2&3 in the Method of three Moments, the value of the term 6Ab/L for the said span is
equal to:
a.)-166.67 b.) 241.33 c.)-187.6 d.) -107.6 e.)none of these
___________________________________________________________________________________
(Refer to the Situation below for the next 4 questions).
The non prismatic rectangular beam shown below is made of concrete with a compressive strength of 28 MPa ( E = 20125
MPa.) Section AB has the dimension b= 300 mm and d = 500 mm, section BD has the dimension b= 300mm and d = 450
mm.
21. Which of the following most nearly gives the vertical deviation of point B relative to the tangent drawn at A, in mm?
a.) 1.97 b.) 0.75 c.) 3.86 d.) 2.47 e.) 1.12
22. Which of the following most nearly gives the vertical deviation of point D relative to the tangent drawn at A, in mm?
a.) 0.72 b.) 3.58 c.) 2.73 d.) 1.13 e.) 4.12
23. Which of the following most nearly gives the vertical deflection at D, in mm?
a.) 0.187 b.) 0.342 c.)0.058 d.) 0.275 e.) 0.406
____________________________________________________________________________________
24. Which of the following best describes the classification of the structure shown below?
a.) Statically determinate b.) Statically indeterminate to the first degree c. ) Statically indeterminate to the second
degree d.) unstable e.) with geometric instability
__________________________________________________________________________________
(Refer to the figure shown below for the next 2 numbers/questions.)
25. Which of the following most nearly gives the horizontal component of the reaction at A, in kN?
a.) 255 b.) 285 c.) 305 d.) 295 e.) none of these
26. Which of the following most nearly gives the total force transmitted at the connecting pin at B, in kN?
a.) 324.2 b.) 287.3 c.) 309.2 d.) 254.7 e.) none of these
___________________________________________________________________________________
(Refer to the beam below for the next 2 numbers/questions )
27. Which of the following most nearly gives the maximum value of the vertical component of the reaction at the fixed
support due to a combination of a downward concentrated load of 100 N, and a downward uniform dead load of 50 N/m.
and live load of 40 N/m?
a.) 460 N b.) 335 N c.) 520 N d.) 235 N e.) none of these
28. Which of the following most nearly gives the maximum value of the vertical component of the reaction at the leftmost
support due to a combination of a downward concentrated load of 100 N, and a downward uniform dead load of 50 N/m.
and live load of 40 N/m?
a.) 235N b.) 335 N c.) 460 N d.) 520 N e.) none of these
_________________________ End of Exam.________________________