You are on page 1of 2

Subject Code: R12A22EC02

ANURAG GROUP OF INSTITUTIONS


(Autonomous)
School of Engineering
II-B.Tech-II-Semester Supplementary Examinations, Dec - 2014
Subject: Electronic Circuirt Analysis
(Only for ECE)
Time: 3 Hours Max.Marks:75

Section – A (Short Answer type questions) (25Marks)


 Answer all questions

1. Why CC Amplifier is called as Emitter follower and Derive For ZI 3M


2. Draw Hybrid π equivalent circuit for CE Amplifier and Indicate resistance and
Capacitances. 2M
3. Discuss the method of coupling used in Multistage Amplifiers. 3M
4. Draw the circuit diagram of cascode Amplifier and Darlington amplifier 2M
5. Discuss the classification of Power Amplifiers 3M
6. What is cross over distortion? Explain 2M
7. How stagger tuned amplifiers are different from Single tuned Amplifier? 2M
8. What is the need of tuned Amplifiers and Compare Series and Parallel resonant
circuits. 3M
9. Draw General block diagram of the feed back System and derive for gain of the
negative and positive feedback in terms of open loop gain(A) and feedback ratio(β)
3M
10. State and briefly explain Barkhausen criterion for oscillator 2M

Section – B (Essay Type Questions)


 Answer all the questions (5x10=50Marks)

11. A. Draw the CE Amplifier with Emitter Resistor using Hybrid model and derive for
AV, AI, ZI and ZO.
OR
B. Explain the operation of a Common Source amplifier and Derive for AV, ZI and
ZO necessary small signal modeling.

12. A. Discuss the analysis of RC coupled (TwoStage) CE Amplifier at Mid frequency


band in the frequency Response Curve with proper mathematical Expression.
OR
B. Draw and Discuss the advantage and disadvantages of Transformer coupled and
Direct coupled Amplifiers.

13. A. Draw the circuit diagram of a Transformer Coupled class - A power amplifier and
explain its working and Derive the overall Efficiency.

P.T.O
OR
B. Draw and Derive the efficiency of the Complementary Symmetry Class B Push-Pull
Amplifier and Calculate the input power, output power and efficiency if
VCC=22volts,RL=15Ω and IMAX=2A.

14. a) Explain the working of the Single tuned Amplifier with Capacitive Coupling and
derive for Bandwidth.
OR
b) What are limitations of Single tuned Amplifiers and Draw and explain the
working of double tuned amplifier.

15. a) Explain the operation of RC Phase Shift Oscillator and Derive for Frequency of
Oscillations.
OR
b) Discuss the Advantages of Negative feedback Amplifiers with proper mathematical
derivations.

You might also like