Professional Documents
Culture Documents
DAFTAR PUSTAKA
Al-Abadleh, H.A. 2015. Review of the Bilk and Surface Chemistry of Iron in
Atmospherically Relevant Systems Containing Humic-Like Substances.
RSC. Adv 5; 45785-45811.
Ariyani, N. & P.D. Wahyuni. 2007. Perbaikan Tanah Lempung Dari Grobogan
Purwodadi Dengan Campuran Semen Dan Abu Sekam Padi. Majalah Ilmiah
UKRIM (1).
Asuri, S., & P. Keshavamurthy. 2016. Expansive Soil Characterisation; an
Appraisal. INAEL 1; 29-33.
Badan Standarisasi Nasional (BSN), 2012. SNI 4144 : 2012. Metode Uji
Penentuan Faktor-Faktor Susut Tanah. Badan Standarisasi Nasional,
Bandung.
Balai Penelitian Tanah. 2005. Petunjuk Teknis Analisis Kimia Tanah, Tanaman,
Air dan Pupuk. Balai Penelitian Tanah, Badan Penelitian dan
Pengembangan Pertanian. Departemen Pertanian, Bogor.
Bamgbopa, O.S. 2016 Investigation of Shrinkage and Cracking in Clay Soil under
Wetting and Drying Cycles. International Journal of Engineering Research &
Technology (IJERT) 5(11): 283-320.
Barnhisel, R.I. & C.I. Rich. 1963. Gibbsite Formation From Aluminum Interlayer in
Montmorillonite. Soil Sci. Soc. Am. Proc. 27: 632-635.
Baser, O. 2009. Stabilization of Expansive Soils Using Waste Marble. Thesis
untuk Graduate School of Natural and Applied Sciences of Middle East
Technical University.
BasmenJ A.K., A. Mirjavan, M. Ghafoori & A. Cheshomi. 2016. Assessment of
the adhesion potential of kaolinite and montmorillonite using a pull-out test
device. Bull Eng Geol Environ 76(4): 1507-1519.
Bedel L., A. Legout, A. Poszwa, G. van der Heijden, M. Court, N. Goutal-Pousse,
E. Montarges-Pelletier. J. Ranger. 2018. Soil aggregation may be relevant
indicator of nutrient cation availability. Annals of Forest Science 75: 103.
Bell, F.G. 1996. Lime Stabilization of Clay Minerals and Soils. Engineering
Geology 42(4): 223-237.
Bieganowski, A., T. Zaleski, B. Kajdas, A. Sochan, A. Jozefowska, M. Beczek, J.
Lipiec, M. Turski & M. Ryzak. 2017. An Improved Method for Determination
of Aggregate Stability Using Laser Diffraction. Land Degrad Dev; 1-9.
Blacklock, J.R. & A.D. Pengelly. 1988. Soil Treatment for Foundations on
Expansive Clays. Special Topics in Foundadtions B M Das, ed, ASCE, new
York, USA,. pp 73-92.
Blokhuis. W.A., M.J. Kooistra & L.P. Wilding. 1990. Micromorphology of Cracking
Clayey Soils (Vertisols). Developments in Soil Science 19: 123-148.
Bokare, A.D. & W. Choi. 2014. Review of Iron-Free Fenton-Like Systems for
Activation H2O2 In Advanced Oxidation Processes. Journal of Hazardous
Materials 275: 121-135.
Bowles, J.E. 1991. Sifat-sifat Fisis dan Geoteknis Tanah (Mekanika Tanah).
Erlangga : Jakarta.
REKAYASA BASAL SPACING MINERAL LEMPUNG TANAH VERTISOL DENGAN PENYISIPAN
KATION UNTUK MEMPERKECIL
SIFAT KEMBANG-KERUTNYA
RISTIYA ADI WIRATAMA, Dr. Eko Hanudin, M.S., Dr. Ir. Benito Heru Purwanto, M.P., M.Agr., Dr. Agr. Makruf Nurudi
Universitas Gadjah Mada, 2020 | Diunduh dari http://etd.repository.ugm.ac.id/
73
REKAYASA BASAL SPACING MINERAL LEMPUNG TANAH VERTISOL DENGAN PENYISIPAN
KATION UNTUK MEMPERKECIL
SIFAT KEMBANG-KERUTNYA
RISTIYA ADI WIRATAMA, Dr. Eko Hanudin, M.S., Dr. Ir. Benito Heru Purwanto, M.P., M.Agr., Dr. Agr. Makruf Nurudi
Universitas Gadjah Mada, 2020 | Diunduh dari http://etd.repository.ugm.ac.id/
74
REKAYASA BASAL SPACING MINERAL LEMPUNG TANAH VERTISOL DENGAN PENYISIPAN
KATION UNTUK MEMPERKECIL
SIFAT KEMBANG-KERUTNYA
RISTIYA ADI WIRATAMA, Dr. Eko Hanudin, M.S., Dr. Ir. Benito Heru Purwanto, M.P., M.Agr., Dr. Agr. Makruf Nurudi
Universitas Gadjah Mada, 2020 | Diunduh dari http://etd.repository.ugm.ac.id/
75
REKAYASA BASAL SPACING MINERAL LEMPUNG TANAH VERTISOL DENGAN PENYISIPAN
KATION UNTUK MEMPERKECIL
SIFAT KEMBANG-KERUTNYA
RISTIYA ADI WIRATAMA, Dr. Eko Hanudin, M.S., Dr. Ir. Benito Heru Purwanto, M.P., M.Agr., Dr. Agr. Makruf Nurudi
Universitas Gadjah Mada, 2020 | Diunduh dari http://etd.repository.ugm.ac.id/
Katti, D.R. & K.S. Katti. 2001. Modeling Microarchitecture and Mechanical
Behavior of Nacre Using 3D Finite Element Techniques, Part I: Elastic
Properties, J. Mater. Sci., 36(6): 1411-1417.
Katti, D.R., M. ASCE & K.S. Katti. 2011. Molecular Intercations Barrier and
Mechanical Properties in Swelling Clays: A Multiscale Modeling and
Experimental Investigation. Geo-Frontiers, 4263-4272.
Katti, K. & D. Katti. 2006. Relationship of Swelling and Swelling Pressure on
Silica-Water Interactions in Montmorillonite. Langmuir 22: 532-537.
Katz, L.E., A.F. Rauch, H.M. Liljestrand, J.S. Harmon, K.S. Shaw & H. Albers.
2001. Mechanisms of Soil Stabilization With Liquid Ionic Stabilizer.
Transportation Research Record (TRB), Issue 1757, Paper no 01-3228. Pp
50-57.
Kishne, A.S., C.L.S. Morgan, G.E. Yufeng, W.L. Miller. 2010. Antecedent Soil
Moisture Surface Cracking of a Vertisols in Field Condition. Geoderma 157:
109-117
Kittrick, J.A. 1969. Interlayer Forces in Montmorillonite and Vermiculite. Soil Sci.
Soc. Am. Proc, 33: 217-222.
Kloprogge, J.T, L.V. Duong & R.L. Frost. 2005. A Review of The Synthesis and
Characterization of Pillared Clays and Related Porous Materials for Cracking
of Vegetable Oils to Produce Biofuels. Environ. Geol., 47: 967– 981.
Kloprogge, J.T. 1998. Synthesis of Smectites and Porous Pillared Clay Catalysts:
A Review. J.Por.Mat 5: 5-41
Krisnanto, S., H. Rahardjo, D.G. Fredlund, E.C. Leong. 2016. Water Content od
Soil Matrix During Lateral Water Flow Through Cracked Soil. Engineering
Geology 210: 168-179.
Kucerik J, 2019. Stabilization by adsorbed water and connection to content of
organic carbon, nitrogen, and clay minerals. Journal of Thermal Analysis and
Calorimetry. https://doi.org/10.1007/s10973-019-08802-8
Kumar, P., R.V. Jasra & T.S.G. Bhat. 1995. Evolution of Porosity and Surface
Acidity in Montmorillonite Clay on Acid Activation. Industrial & Engineering
Chemistry Research 34 (4): 1440–1448.
Laird, D.A. 2006. Influence of Layer Charge on Swelling of Smectites. Applied
Clay Science 34: 74-87.
Lambe, T.W. 1960. The Character and Identification of Expansive Soil, Fed.
Housing Administration. Washington DC.
Lang, L.Z., S. Tripathy, W. Baille, T. Schanz, & A. Sridharan. 2019. Linkage
between swelling pressure, total suction of saturated bentonites and suction
of saturating aqueous solutions. Applied Clay Science 171: 82-91
Langmuir I. 1938. The Role of Attractive and Role Repulsive Forces in The
Formation of Tactoids, Thixotropic Gel, Protein Crystals and Coacervates.
Journal of Chmeical Physics, 6: 873-898
Langroudi, A. & S. Yasrobi. 2009. A Micro-Mechanical Approach to Swelling
Behavior of Unsaturated Expansive Clay Under Controlled Drainege
Conditions. Applied Clay Science 45(12): 8-19.
76
REKAYASA BASAL SPACING MINERAL LEMPUNG TANAH VERTISOL DENGAN PENYISIPAN
KATION UNTUK MEMPERKECIL
SIFAT KEMBANG-KERUTNYA
RISTIYA ADI WIRATAMA, Dr. Eko Hanudin, M.S., Dr. Ir. Benito Heru Purwanto, M.P., M.Agr., Dr. Agr. Makruf Nurudi
Universitas Gadjah Mada, 2020 | Diunduh dari http://etd.repository.ugm.ac.id/
77
REKAYASA BASAL SPACING MINERAL LEMPUNG TANAH VERTISOL DENGAN PENYISIPAN
KATION UNTUK MEMPERKECIL
SIFAT KEMBANG-KERUTNYA
RISTIYA ADI WIRATAMA, Dr. Eko Hanudin, M.S., Dr. Ir. Benito Heru Purwanto, M.P., M.Agr., Dr. Agr. Makruf Nurudi
Universitas Gadjah Mada, 2020 | Diunduh dari http://etd.repository.ugm.ac.id/
78
REKAYASA BASAL SPACING MINERAL LEMPUNG TANAH VERTISOL DENGAN PENYISIPAN
KATION UNTUK MEMPERKECIL
SIFAT KEMBANG-KERUTNYA
RISTIYA ADI WIRATAMA, Dr. Eko Hanudin, M.S., Dr. Ir. Benito Heru Purwanto, M.P., M.Agr., Dr. Agr. Makruf Nurudi
Universitas Gadjah Mada, 2020 | Diunduh dari http://etd.repository.ugm.ac.id/
Qui, X. & W. Ji. 2018. Illuminating Interlayer Interactions. Nature Materials, 17;
211-213.
Ragland, J.L., & N.T. Coleman. 1960. The Hydrolysis of Aluminum Salts in Clay
and Soil Systems. Soil Science Society of America Journal 24(6): 457-460.
https://doi.org/10.2136/sssaj1960.03615995002400060013x
Reeve, R.C. 1965. Modulus of Rupture. Method of Soil Analysis. Part 1. Physical
and Mineralogy Properties. Hal: 466-471.
Rich C.I. 1968. Hydroxy Interlayers in Expansible Layer Silicates. Clays and Clay
Minerals 16: 15-30.
Rich, C.I. & S.S. Obenshain. 1955. Chemical and Clay Mineral Properties of a
Red-Yellow Podzolic Soil Derived from Muscovite Schist. Soil
Sci.Soc.Am.Proc. 19: 334-331.
Richards L.A. 1953. Modulus of Rupture as an Index of Crusting of Soil. Soil
Science Society of America Journal 17(4): 321-323.
Richards, L.A. 1941. Uptake and Retention of Water by Soil as Determined by
Distance to a Water Table. J.Am.Soc Agron 33: 778-786.
Rowley M.C., S. Grand, E.P. Verrecchia. 2018. Calcium-mediated stabilization of
soil organic carbon. Biogeochemistry 137: 27-49.
Rusman, I.I. Falah & R.H,A Alim. 2010. Interkalasi Cu pada Karbon Aktif dan
Pemanfaatannya sebagai Katalis Dehidrasi n-AMILAKOHOL. Indonesian
Journal of Chemenistry.
Santoso, S. & Sajidan. 2013. Keberadaaan Bakteri Penghasil Fitase Untuk
Perbaikan Kesuburan Tanah Vertisol Pada Berbagai Sistem Budidaya
Tanam di Kecamatan Gondangrejo Kabupaten Karangayar. BIOEDUKASI
6(1): 1-11.
Sanz, J., I. Lombrana, A.M. De Luis, M. Ortueta, & F. Varona. 2003. Microwave
and Fenton’s Reagent Oxidation of Wastewater. Environ Chem Lett 1; 45-
50.
Sawhney, B.L. 1968. Alumium Interlayers in Layer Silicates Effect of OH/Al Ratio
of Al Solution, Time of Reaction, and Type of Structure. Clays and Clay
Mierals, 16: 157-163.
Sawhney. B.L. 1960. Aluminium Interlayering in Clay Minerals, Montmorillonite
and Vermiculite: Laboratorium Synthesis. NATURE 187: 261-262.
Schnitzer, M. & Hoffman, I, 1964. Pyrolisis of Soil Organic Matter1. Soil Science
Society of America Journal, 28 (4), 520.
doi:10.2136/sssaj1964.0361599500280004002.
Schwertmann, U. & M.L. Jackson. 1964. Influence of Hydroxy Aluminum Ions on
pH Titration Curves of Hydronium-Aluminum Clays. Soil Sci Soc, Proc. 179-
183.
Selvaraj, S., B.V. Mohan, K.N. Krishna, & B.S.J. Prakash, B.S., 1996. Pillaring of
smectites using an aluminium oligomer: A. study of pillar density and thermal
stability. App.Clay.Sci., 10: 439-450.
Seppala, A., E. Puhakka & M. Olin. 2016. Effect of layer charge on the crystalline
swelling of Na+, K+ and Ca2+ montmorillonites: DFT and molecular
dynamics studies. Clay Minerals 51(02): 197-211.
79
REKAYASA BASAL SPACING MINERAL LEMPUNG TANAH VERTISOL DENGAN PENYISIPAN
KATION UNTUK MEMPERKECIL
SIFAT KEMBANG-KERUTNYA
RISTIYA ADI WIRATAMA, Dr. Eko Hanudin, M.S., Dr. Ir. Benito Heru Purwanto, M.P., M.Agr., Dr. Agr. Makruf Nurudi
Universitas Gadjah Mada, 2020 | Diunduh dari http://etd.repository.ugm.ac.id/
80
REKAYASA BASAL SPACING MINERAL LEMPUNG TANAH VERTISOL DENGAN PENYISIPAN
KATION UNTUK MEMPERKECIL
SIFAT KEMBANG-KERUTNYA
RISTIYA ADI WIRATAMA, Dr. Eko Hanudin, M.S., Dr. Ir. Benito Heru Purwanto, M.P., M.Agr., Dr. Agr. Makruf Nurudi
Universitas Gadjah Mada, 2020 | Diunduh dari http://etd.repository.ugm.ac.id/
Tang, C.S., B. Shi, C. Liu, W. Bin & L. Gao. 2011. Experimental Characterization
of Shrinkage and Desiccation Cracking in Thin Clay Layer. Applied Clay
Science, 52: 69-77.
Tansel B., J. Sager, T. Rector, J. Garland, R.F. Strayer, L. Levine, M. Roberts, M.
Hummerick, & J. Bauer, 2006. Significance of hydrated radius and hydration
shells on ionic permeability during nanofiltration in dead end cross fow
modes. Separation and Purification Technology 51: 40-47.
Tingle, J.S. & Santori, 2003. Stabilization of Clay Soils With Non Traditional
Additive, National Research Council, Washington DC. Transportation
Research Record No 1819: 72-84.
Tjandra, D., Indarto & R.A.A. Soemitro. 2013. The effect of water content
variation on adhesion factor of pile foundation in expansive Soil. Civil
Enginerring Dimension 15(2): 114-119.
Tollenaar, R.N., L.A Van Paasen & C. Jommi. 2017. Observations on the
Desiccation and Cracking of Clay Layers. Engineering Geology, 230: 23-31.
Tomlinson, A.A.G. 1998. Characterization of Pillared Layered Structures,.
J.Por.Mat., 5: 259–274.
Toranzo, R., M.A. Vicente & B.M.A. Munoz. 1997. Pillaring of a Saponite with
Aluminum-Chromium Oligomers. Characterization of the Solids Obtained.
Chem. Mater, 9: 1829-1836.
Verwey, E.J. & J.G. Overbeek. 1948. Theory of the Stability of Lyophobic
Colloids. Elsevier Publishing Co.
Vidal, H.P., E.C. Garcia, E.L. Alejandro. 2006. Characterization of Pillared Clays
Containing Fe3+ and Cu. Solar Energy Materials & Solar Cells 90; 841-846.
Wan, Y., Q. Xue, L. Liu & S.Y. Wang. 2018. Relationship between the shrinkage
crack characteristics and the water content gradient of compacted clay liner
in a landfill final cover. Soil and Foundations 58: 1435-1445.
Wendlandt, W.W.M. 1986. Thermal Analysis. John Wiley and Sons, USA.
Whittig, L.D. 1959. Characteristics and Genesis of a Solodized-Solonetz of
California. Soil Sci.Soc.Am.Proc. 23: 469-473.
Wijaya, K., A.S. Pratiwi, S. Sudiono, & E. Nurahmi. 2002. Study of Thermal and
Acid Stability of Bentonite Clay. Indonesian Journal of Chemistry 2 (1): 22–
29.
Wijaya, K., E. Sugiharto, I. Tahir & I. Liawati. 2004. Synthesis of Iron Oxide-
Montmorillonite Composite and Study of its Structural Stability Againts
Sulfuric Acid. Indonesia Journal of Chemistry 4(1): 33-42.
Wuddivira, M.N. & G.C. Roach. 2007. Effects of organic matter and calcium on
soil structural stability. European Journal of Soil Science 58(3): 722-727.
Yang, W., T. Zhang, J. Zhou, W. Shi, J. Liu & K. Cen. 2015. Experimental study
on the effect of low melting point metal additives on hydrogen production in
the aluminum-water reaction. Energy 88; 537-543.
Yong, R.N. & V.R. Ouhai. 2007. Eksperimental Study on Instability pf Bases on
Natural and Lime/Cement-Stability Clayey Soil. Applied Clay Science 35(34);
238-249.
81
REKAYASA BASAL SPACING MINERAL LEMPUNG TANAH VERTISOL DENGAN PENYISIPAN
KATION UNTUK MEMPERKECIL
SIFAT KEMBANG-KERUTNYA
RISTIYA ADI WIRATAMA, Dr. Eko Hanudin, M.S., Dr. Ir. Benito Heru Purwanto, M.P., M.Agr., Dr. Agr. Makruf Nurudi
Universitas Gadjah Mada, 2020 | Diunduh dari http://etd.repository.ugm.ac.id/
Yuli. 2010. ‘’Modifikasi ampo melalui metode pilarisasi’’. Seminar rekayasa kimia
dan proses. ISSN: 1411-4216.
Yuliananda, S., S. Gede, R.R.A. Hastijanti. 2015. Pengaruh Perubahan Intensitas
Matahari Terhadap Daya Keluaran Panel Surya. J.Pengabdian LPPM Untag
Surabaya. 01(02): 193-202.
Yuliani, H.R., 2010. Modifikasi Ampo Melalui Metode Pilarisasi. Seminar
Rekayasa Kimia dan Proses. Universitas Diponegoro Semarang.
Yuliani, H.R., Prasetyo, Prasetya, & Kartika. 2010. ‘’Pembuatan dan Karakterisasi
Ampo Terpilar Besi Oksida (Kajian Rasio Hidrolisis Agen Pemilar (OH/Fe)’’.
Prosiding Seminar Nasional Teknik Kimia ‘’Kejuangan’’. Yogyakarta.
Yuliet, R., A. Hakam, & G. Febrian. 2011. Uji Potensi Mengembang Pada Tanah
Lempung Dengan Metoda Free Swelling Test. J.Rekayasa Sipil 7(1); 25-37.
Yun, S.K., V.R.L. Constantino, & T.J. Pinnavaia. 1995. New Polyol Route to
Keggin Ion-Pillared Layered Double Hydroxides. Microporo us Materials. 4:
21- 29.
Zhao, H. L. Ge., T.M. Petry & Y.Z. Sun. 2013. Effect of Chemical Stabilizers on
an Expansive Clay. KSCE Journal of Civil Engineering, Geotechnical
Engineering: 1-9.
82
REKAYASA BASAL SPACING MINERAL LEMPUNG TANAH VERTISOL DENGAN PENYISIPAN
KATION UNTUK MEMPERKECIL
SIFAT KEMBANG-KERUTNYA
RISTIYA ADI WIRATAMA, Dr. Eko Hanudin, M.S., Dr. Ir. Benito Heru Purwanto, M.P., M.Agr., Dr. Agr. Makruf Nurudi
Universitas Gadjah Mada, 2020 | Diunduh dari http://etd.repository.ugm.ac.id/
83