Professional Documents
Culture Documents
Project # 1 (Part a)
Hardware - 2021
Project # 1 - Require EPROM Burner
Power Crystal
Vcc
H8 H8
Resistor H8 H8 LEDs
bank for LEDs
LEDs 470
ohms P P
74ls245
O O 74ls245
Resistor
bank for
Tri-State Tri-State LEDs 470
8
Buffer
8-bit
R R 8-bit 8 Buffer
8 ohms
89C51/52
T T
Pull up
1 0 resistor
bank for
Port 0
Reset
Reset 10 K H8 H8
LEDs LEDs
P P
74ls245 Resistor
8
Tri-State O O 74ls245 bank for
Tri-State 8 LEDs 470
Buffer
8-bit
R R 8-bit
Buffer
ohms
T T
Resistor
3 2
bank for
LEDs 470 H8 H8
ohms
Note
Key • EA pin should be connected to
Vcc for using internal memory
JS = Jumper Selection
• Direction Selection Pin of 245
H8 = Header 8 Pin
• Reset circuitry
• Crystal ( 11.0592 Mhz)
Buffer
• Microcontroller has limited capability of ‘sourcing’
and ‘sinking’ current
• If microcontroller is interfaced with devices
exceeding this current requirement, we require
buffer e.g. 74LS245
PIN Source/Sink Current
74LS245 Sink 24 mA
8051 Port 0 pin Sink 3.2 mA
8051 Port 1,2,3 pin Sink 1.6 mA
74LS245 Source 15 mA
8051 Port 0,1,2,3 pin Source 60 uA
Buffer – 74LS245
Buffer – 74LS245
External
8051 port Device (e.g.
LEDs)
We require this
L means logic low (ground)
H means logic high (Vcc)
Resistor Bank
R8
10k
R7
10k
R6
10k
R5
10k
common R4
10k
R2
10k
R3
10k
Note:
pull-up: common is connected to Vcc R1
pull-down: common is connected to ground 10k
Printing of Name
DE 41 MTS – B
NS Muhammad Ali
PC M Danial
GC Ali
Project # 1/2021
• This is group project (Max 3 members in any group).
• Board Requirement
– Name and Degree, etched on the board. Writing with
permanent marker is not acceptable
– Compact board, must fit within 12*18 cm.
– Good finish on both side of the board.
– Minimum jumpers.
– Components placed in a sensible manner
– Quality of Soldering
Due date
• Tuesday 16th Nov, 2021 till 1630hrs