You are on page 1of 8

o m

.c Silicore
4 U
LOW FREQUENCY
e t POWER AMPLIFIER D8227

h e
Outline Drawing
S
GENERAL DESCRIPTION
D8227 tisa an audio power IC wit h built-in
a
. D
two Channels developed for portable radio

wcassette tape recorder with power ON/OFF


w switch. Th ermal shut do wn protection
w circuit is built in . Because of the parts
reduction and DIP (Dual in line package),
space merit is re markable.
o m
.c
FEATURES

4 U
z High Power
Pout=2.5W/CH(Typ.)

e t
:(Vcc=9V,R L =4 Ω,f=1kHz,THD=10%)

e
Pout=3.0W/CH(Typ.) :(Vcc=9V,R L =3 Ω,f=1kHz,THD=10%)

h
z Voltage Gain : Gv=45dB(Typ.)( Rf=120Ω ,f=1kHz)
Gv=56.5dB(Typ .)( Rf=0 Ω ,f=1kHz
z Low popping noise at power ON

a S
z
z
z a t
Small Quiescent Current : I C C Q =21 mA(Typ.) (Vcc=9V Vin=0)
Ripple Rejection Ratio : R.R.=-52dB(Typ.)(Vc c=9V, fripple=100Hz, Rg=600Ω )
Cross Talk : C .T.= -50dB(Typ.)(V cc=9V, f=1kHz, Rg=600Ω )
z Output Noise
BW=20Hz~20kHz) .D
Voltage : Vno=0.3mVrms (Typ .)(Vcc=9V , Rg=10k Ω ,

z Stand-By Switch
w
z Soft Clip
w
z
z
z
w
Built-in ther mal shut down protection circuit
Best fo r sup p ly vo ltage 9 V
Operation supply voltage rang e : Vcc=5~12 V m
o
.c
4 U
et
h e
a S
SHAOXING SILICORE TECHNOLOGY CO.,LTD
www. Silicore. com. cn at 1/8

CHMC .D
w
w
w
Silicore D8227

MAXIMUM RATINGS (Ta=25°C)


CHARACT ERISTIC SYMBOL RATING UNIT
Supply Vo ltage Vcc 20 V
Output Current (Peak/CH) IQ(peak) 2.5 A
Power Diss ipation* PD 4.0 W
Operating Te mperature Topr -25~75 °C
Storage Temp erature Tstg -55~150 °C
* Value for mounting on PC board(Refer to P D -Ta curve)

ELECTRICAL CHARACTERISTICS
(Unless otherwise specified , Vcc=9V,f=1kHz, Rg=600Ω, R L =4 Ω,Ta=25 °C)

CHARACT ERISTIC SYMBOL TEST CON DITI ON MIN. TYP. MAX. UNIT
Quiescent Current ICCQ V I N =0 - 21 45 mA
POUT(1) THD=10% 2.0 2 .5 -
Output Power W
POUT(2) THD=10%, R L =3 Ω - 3.0 -
To tal Harmonic Distortion THD P O U T =0.4W/CH - 0.2 1.0 %
Rf=120Ω
GV(1) 43 45 47
Voltage Gain V O U T =0dBm dB
GV(2) Rf=0,V O U T =0dBm - 56.5 -
Input Resistance RIN - - 30 - kΩ
Rg=10kΩ ,
Output Noise Vo ltage VNO - 0.3 1.0 mV r m s
BW=20Hz~20kHz
Rg=600Ω ,
Ripple Rejection Ratio R.R - -52 - dB
fripple =100Hz
Rg=600Ω ,
Cross Talk C.T - -50 - dB
V O U T =0dBm,
Input Offset Voltage V6,V7 - - 30 60 mV
Stand-By Cu rrent Istb SW1-OFF 1 μA

TYPICAL DC VOLTAGE OF EACH TERMINAL (Vcc=9V, Ta=25 °C)

TERMINAL NO. 1 2 3 4 5 6 7 8 9 10 11 12
DC VOLTA GE (V) Vcc 4.5 8.7 GND 0.7 0 .03 0 .03 0 .7 5.0 8.7 4.5 Vcc

SHAOXING SILICORE TECHNOLOGY CO.,LTD 2/8


www. Silicore. com. cn
CHMC
Silicore D8227

TEST CIRCUIT & BLOCK DIAGRAM

*(1) T h i s I C c a n b e u s e d w i t h o u t c o u p l i n g c a p a c i t o r ( C I N ) , I f v o l u m e s l i d e n o i s e o c c u r r e d b y
i n p u t o ff s e t v o l t a g e i s u n d e s i r a b l e , i t n e e d s t o u s e t h e c a p a c i t o r ( C I N ) .

* ( 2 ) T h e c o n d e n s e r b e t w e e n t h e ④ p i n a n d t h e G N D ( C 11 ) i s f o r r e d u c i n g p o p n o i s e w h e n t h e

p o w e r O N / O F F s w i t c h ( S W 1 ) i s s e t t o O N / O F F.

APPLICATION INFORMATION AND APPLICATION METHOD


1. ADJUSTMENT OF VOLTAGE GAIN
Th e vo ltage gain Gv is obtained as fo llo ws
by R1,R2 and Rf in Fig.1.
Gv=20log((Rf+R1+R2)/(Rf+R1))
When Rf=0 Gv=56.5dB(Typ.)
When Rf=120Ω Gv=45dB(Typ.)
By increasing Rf , redu ction of Gv is possible ,
Howev er, sin ce th e feed b ack Fig 1 .
increase is liable to produce oscillation , it is reco mmended to use this at 40dB or
over.
SHAOXING SILICORE TECHNOLOGY CO.,LTD 3/8
www. Silicore. com. cn
CHMC
Silicore D8227

2. THERMAL SHUT-DOWN CIRCUIT


The thermal shut-down circuit is built in for the purpose of preventing the
destruction of IC due to the abnormal te mp erature rise when the heat radiation is
insufficient.
The operation te mp erature is set at radiation Fin temp erature 175°C(Typ.)
At this temperature or over the bias is in terrupted to prevent the destruction of IC.
3. INPUT STAGE
The input circuit of this IC is as
shown in Fig.2. PNP TR: Q1 is provided
in the input circuit so as to make its
usage possible without the input
coupling capacitor.
However , at pins ⑥ and ⑦ , max
60mV offset voltage is produced.
Application after checking volu me
slide noise is recommended.
For cutting the volume slide noise,
Insert the input capacitor: C I N in series
to interrupt the DC component Fig.2
4. OSCILATION PREVENTIVE MEASURES
For oscillation preventive capacitor C6 and C7 between th e output ter minal and GND,
it is recommended to use Polyester fil m c apacitor having good characteristics for
te mperature and for high frequency.
Since the characteristics of th e capacito r is liable to be influenced by the
te mperature, use this capacitor after the te mp erature test to check the oscillation
allowance.
In addition, as the position of th e electrolytic capacitor has a re markable influence
on the oscillation ,connect C10 to Vcc at th e nearest possible position fro m power
GND.
At using this application with the voltage gain reduced, oscillation is liable to be
produced. Apply the capacitor after ch ecki ng en ough for its capacity, type and
mounting position.

SHAOXING SILICORE TECHNOLOGY CO.,LTD 4/8


www. Silicore. com. cn
CHMC
Silicore D8227

As the oscillation allowance varies according to the printed pattern layout, the
standard printed bo ard is recommended to be referred to des ign it
5. INPUT VOLTAGE
When the excessive signal is input, tu rning-up is produced in th e clip waveform.
The turning-u p po in t is V I N =300 mVr ms(Typ.) : Vcc=9V, R L =4 Ω, f=1k Hz : Enough care
mu st be taken for this phenomenon.
6. POWER ON/OFF SWITCH
There is po wer ON/OFF switch at pin 1. However, output po wer is changed by pin 1
supply voltage when pin 1 vo ltage in no t same pin 12 supply voltage, after referring
to attached date, select pin 1 supply voltage.
7. GND LINE
GND pin is not separated for Pre-GN D a nd for Pw - GND. That is liable to cause
distortion and cross talk worse. Before use this IC, please check it.

CHARACTERISTIC CURVES

SHAOXING SILICORE TECHNOLOGY CO.,LTD 5/8


www. Silicore. com. cn
CHMC
Silicore D8227

SHAOXING SILICORE TECHNOLOGY CO.,LTD 6/8


www. Silicore. com. cn
CHMC
Silicore D8227

SHAOXING SILICORE TECHNOLOGY CO.,LTD 7/8


www. Silicore. com. cn
CHMC
Silicore D8227

SHAOXING SILICORE TECHNOLOGY CO.,LTD 8/8


www. Silicore. com. cn
CHMC

You might also like