Professional Documents
Culture Documents
/ Required items.
You will need the following items to successfully update your TPS/i unit.
On the back of your power supply, you have a service port that looks like the image above.
Connect your Ethernet Cable (RJ45) to this port and allow 30sec to a min to elapse.
This will give the unit enough time to assign an IP address to the service port.
STEP 3: INSTALL FIRMWARE CONT‘D
Select Defaults
STEP 3: INSTALL FIRMWARE CONT‘D
Select System
STEP 3: INSTALL FIRMWARE CONT‘D
Select Information
STEP 3: INSTALL FIRMWARE CONT‘D
Locate IP Address
STEP 3: INSTALL FIRMWARE CONT‘D
Your webpage will turn to this. This is Xplorer Basic for TPS/i
STEP 3: INSTALL FIRMWARE CONT‘D
Click Update
STEP 3: INSTALL FIRMWARE CONT‘D
When the update is completely downloaded to the unit, it will ask you to
restart the power source. Choose Yes.
STEP 3: INSTALL FIRMWARE CONT‘D
After restarting, your unit will open to the main screen. Following the previous
steps from the beginning. You can verify that your update was successful.
CONCLUSION: UPDATE SUCCESSFUL
Congratulations! You have successfully updated your TPS/i Power Supply. If you have
any issues completing this process, please feel free to contact our TSN Technical
Support Team via the following means.
Email – tsna.techsupport@fronius.com
Phone – 1-877-Fronius (1-877-376-6487)
All information is without guarantee in spite of careful editing - liability excluded.
Intellectual property and copyright: all rights reserved. Copyright law and other laws protecting intellectual property apply to the content of this presentation and the documentation enclosed (including texts, pictures, graphics, animations
etc.) unless expressly indicated otherwise. It is not permitted to use, copy or alter the content of this presentation for private or commercial purposes without explicit consent of Fronius.