Professional Documents
Culture Documents
FC8620
Service Manual
PRODUCT INFORMATION ACCESSORIES
- This product meets the requirements regarding - Nozzle : All purpose wheeled nozzle
interference suppression on radio and TV. - Additional nozzle : Hard Floor nozzle
- After the product has been repaired, it should function - Tubes : Metal lacquered telescopic tubes
properly and has to meet the safety requirements as - Accessories : Crevice nozzle and small nozzle
officially laid down at this moment.
- Accessory storage : Accessory clip on tube
- Coupling : Conical coupling
TECHNICAL INFORMATION
- Colour : Chocolate brown After sales accessoires.
- Power consumption : 1800 W - FC8032 : Super clean air filter +
(IEC) 230V Motor protection filter
- Maximum Air displacement 42 l/s :
- Vacuum 33 kPa : OPTIONAL (accessories)
- Type number dustbag FC8022 :
- FC 8021 : S-Bag Classic Long performance
- Duststorage capacity 3L :
- FC 8022 : S-bag Clinic
- Cord length 7m :
- FC 8023 : S-bag Anti-Odour
- Fiter system 5 Layer:
Ultra Filtration System:
- Double layered compatible S-bagTM
- 2 layer permanent motor protection filter
- Super clean air exhaust filter
- Dimensions of cleaner : 252 x 299 x 457 mm
- Dimensions of packaging : 580 x 375 x 280 mm
Published by Philips Consumer Lifestyle Printed in the Netherlands © Copyright reserved Subject to modification
09/07
FC8620
DISASSEMBLY- AND RE-ASSEMBLY ADVISE REPAIR INSTRUCTION
- Open the appliance, first pull off the vario knob button, - Cotton dustbags, are used in countries in which paper
then remove the ring under the knob, after that screw (A) dustbags are not available.
under the vario knob can be removed with a screwdriver. - The cord winder spring must be tensioned to the maximum
- After removing the filtercover the second screw (B) for level and then be rewound approx. 1.5 turn.
releasing the backpanel can be removed. - Item 8, air valve, opens to cool the motor if the air
- The dustcover, button panel, bumper and the PCB’s can displacement is too low or if the airflow is blocked.
now easily be removed. - If the function of the electronic control unit is not required,
- The upperhousing (dustchamber + motorhousing) can be the Triac must be short-circuited in the manner shown in
released by removing 6 screws (C). the circuit diagram.
- The wires for the motor are placed under the sealing ring of - When the vacuum cleaner is used to suck up fine dust the
the motor. pores of the dustbag may become clogged, causing the
- The sealing ring is placed in two grooves, which are made in passage of air through the dustbag to become obstructed.
the lower housing. As a result, the dustbag-full indicator will indicate that the
- When you re-assemble then make sure that the wires for the dustbag needs to be replaced, eventhough the dustbag is not
motor are placed underneath the sealing ring. full at all.
ELECTRICAL DIAGRAM
CORD WINDER
Blue
Brown Short-circuit
Triac
Black
M
Black/White
MOTOR
POWER
MODULE
2-6
PARTS LIST
FC8620
3-6
EXPLODED VIEW
FC8620
5
7 38
8 A 39
B
11
12
2
3 13
9a
X
9b Black
Black/White
9
Y
10 Blue
Brown
15
C
C C
C
4 16
C
4-6
EXPLODED VIEW
FC8620
17
18
27÷29
Black
Black/White
19
X
20
22 (2x)
Blue
Y
Brown
40
E
24
21
26
23
5-6
EXPLODED VIEW
FC8620
Swiss 29
30
31
36
32
33
34
35
37
6-6