gh
D PEL
sécheron
CCompiste Weiding Support
STANDARD REBAKING PROCEDURE
FOR LOW HYDROGEN ELECTRODES
i) Rebake the electrodes at 250-300°C for one hour.
ii) Cool themin the same oven to 100°C.
iii) Transfer them to a holding oven maintained at 60-70°C.
iv) Draw from this oven for use,
v) Donot keep rutile type electrodes in the same oven.
REPAIR WELDING OF CAST IRONS
Grind the area to be welded so that the casting skinis removed
Clean the area free ofall contaminates by degreasing, burning, brushing, grinding, etc.
If a crack has to be repaired drill crack arrester holes at the end of the cracks. Remove
the crack completely by gouging, grinding, etc. and ensure complete removal by a dye
penetrant test.
Deposit the welds in smalllengths of 50mm at a time.
Peen the welds.
After welding allow the casting to cool slowly.
These are the general steps in cast iron welding. However, the procedures may have to be
modified depending on the job. For complete welding procedure details contact our
technical service personnel.
info@dnhsecheron.net | www.dnhsecheron.com | fi) +91 9833550505