ATP

INDEX COPYRIGHT 2006

COPYRIGHT IS NOT CLAIMED AS TO ANY PART OF AN ORIGINAL WORK

PREPARED BY A UNITED STATES GOVERNMENT OFFICER OR EMPLOYEE AS
PART OF THAT PERSONS OFFICIAL DUTIES OR BY ANY OTHER THIRD PARTY
OFFICER OR EMPLOYEE AS PART OF THAT PERSONS DUTIES.

"ATP" is a registered trademark of Aircraft Technical Publishers. All original

authorship of ATP is protected under U.S. and foreign copyrights and is subject
to written license agreements between ATP and its Subscribers.

ALL RIGHTS RESERVED. NO PART OF THIS PUBLICATION MAY BE

REPRODUCED, STORED IN A RETRIEVAL SYSTEM, OR TRANSMITTED IN ANY
FORM BY ANY MEANS, ELECTRONIC, MECHANICAL, PHOTOCOPYING,
RECORDING OR OTHERWISE, WITHOUT PRIOR WRITTEN PERMISSION OF THE
PUBLISHER.
 Aircraft Technical Publishers Customer Service
6AM-5PM PST M-F
~ZS 101 South Hill Drive
Brisbane, CA 94005 (800)227-4610

ATP Grid Index to Manufacturer’s Publications:

Twin Commander A/C

690A 690B
Illustrated Parts Catalog

Section Topic

General Information

Title Page
List of Chapters (Table of Contents)
Record of Revisions
Record of Temporary Revisions
List of Effective Pages

1 Introduction
Explanation of How to Identify a Part
Aircraft Assembly Complete
Station Diagram
Federal Supply Code for Manufacturers

2 Group Assembly Parts List

Power Plant
Propeller and Propeller Deicing Installation
Cowling Installation
Engine Mounting Installation
Engine Exhaust and Fireshield Installation
Engine Assembly and Accessories
Engine Piping Installation
Fuel and Oil System
Fuel and Oil Systems Installation
Fuel Equipment Installation
Fuel Vent Installation
Fuel Tanks Installation
Power Plant Controls
Power Plant Controls Installation
Quadrant Installation

03/21/2002 Copyright Aircraft Technical Publishers Page 1 of 3

GC 0831 PC)
Secti on Topi c

Landing Gear
Main Landing Gear Installation
Oleo Strut Assembly
Wheel and Brake Installation, MLG
Main Landing Gear Uplock Installation
Emergency Air Reservoir Installation MLG
Nose Landing Gear Doors and Actuating Mechanism
Nose Landing Gear Installation
Nose Landing Gear Controls Installation
Hydraulic System
Hydraulic System Fuselage Nose
Hydraulic System Center Fuselage and RH Nacelle

Hydraulic System LH Nacelle

Hydraulic System Main Landing Gear Doors

Electrical System
Electrical Equipment Installation
Overhead Switch Panel Installation
Battery Installation
External Power Receptacle and Access Door
Instruments
Instrument Group LH Instrument Panel
Instrument Group Center Instrument Panel
Instrument Group RH Instrument Panel
Instrument Sub-Panel Circuit Breaker Panel Instl

Instrument, Radio,Circuit Breaker Sub-Panels Instl

Instrument Equipment Installation
Nose Instrument Piping
Fuselage Instrument Piping Installation
Wing
Wing Plating
Wing Access Covers
Wing Structure
Truss Installation Main Landing Gear
Nacelle and Landing Gear Doors Installation
Empennage
Vertical Stabilizer and Rudder Installation
Horizontal Stabilizer and Elevator Installation
Flight Controls
Flap Control System
Aileron Control System
Elevator Control System

03/21/2002 Copyright Aircraft Technical Publishers Page 2 of 3

GC 0831 PC
Section Topic

Control Column Assembly Aileron and Elevator

Rudder Control System
Rudder and Elevator Trim Tab Control Systems
Fuselage
Fuselage Plating Complete
Fuselage Structure Assembly Nose Section

Fuselage Structure Assembly Forward Section

Fuselage Structure Assembly Aft Section
Cabin and Baggage compartment Floor Installation
Equipment Deck Installation
Fuselage Floor Beams and Related Frame Structure
Fuselage Windshield Installation
Cockpit Overhead Windows Installation
Fuselage Cockpit Window Installation
Fuselage Cabin Side Windows Installation
Fuselage Emergency Exit Window Installation
Main Cabin Door Assembly and Installation
Main Cabin Door Mechanism

Step Installation Cabin Entrance

Fuselage Baggage Door Installation
Interior Furnishings
Interior Furnishings Installation
Environmental
Dual Outflow Valve Installation
Press Air Conditioning Instl Fwd Fuselage
Press Air Conditioning Instl Aft Fuselage
Bleed Air Piping Installation
Press Air Conditioning LH MLG Switch Instl
Miscellaneous
Oxygen System Installation
Wing Empennage Deicer Installation
Anti-Ice Equipment Installation
Deicer

Propeller Synchronizer Controls Installation

Placard and Decal Installation

3 Numerical Index
Numerical Index

End of Index

03/21/2002 Copyright Aircraft Technical Publishers Page 3 of 3

GC 0831 PC
IVI FG I

IN TRO
690n/B
r~ I~ I~

REISSUED: 14 NOVEMBER 1980

REVISED: 22 JULY 1994

rWIAI

AIRCRAFT CORPORATION
Aslington Airport PN M690002-4
18010 Sgth Dr. N. E Arlington, WA 98223
Tel: (360) 435´•9f97~ Far (360) 435~1112
 RECORD OF REVISIONS

Pa~
MFG
NO DESCRIPTION ISSUE DATE REV DA INSERTED BY

sn: i, 2&3INTIlC, LEP, TP 11/28/84 3/20/85 ATPIEL

SEC 2:2-43, 2-44 7/22/94 4/24/95L ATP/GH

 RECORD OF TEMPORARY REVISIONS

A$.
INSERT REV REMOVE

DESCRIPTION ISSUE DATE BY REMOVED INCOR BY

NO
OULWTREAM
ILLUSTRATED
COMMANDER PARTS CATALOG LIST OF EFFECTIVE FADES
090A/a90s

LIST OF EFFECTIVE PAGES

TOTAL NUMBER O6 P*OES IN THIS PUBLICATION 1S 479 CONSISTING OI THE ~OLLOWINO

Page Issue Page Issue

x TLtle 7122/94 2-162 thN 2-169 II/In/so

rA 7/22194 2-170 II/a 8/84
a sl~ 11/14/80 a-1?1 Lhru 2-117 11/14/80
I 11/14/80 a-17s thru 2-118 11/28/84
B 11/14/80 2-tao thru 2-182 11/14/80
ill Il/la/ao 2-183 11/28/84
I~ slan~ Il/la/ao 2-184 thru 2-165 11/14/80
1-1 thN 1-8 11/14/80 2-186. 11/28/84
1-a thlY 1-10 11/28/81 2-la7 thly 2-210´•´•..´•´•.´•.´•´• 11/14/80
2-1 thN a-a II/In/so 2-211. .11/28/84
2-s Ii/as/sc 2-212 thru 2-219........... 11/14/80
2-n II/In/so
L/1
2-6 11/28/84
2-110 11/28/84
a-B thN 2-11´•.....´•....... 11/14/80 2-221..................... 11/14/80
a-Is Il/as/sn
2-229 thru 2-aaS........... 11/28/84
a-aac thru 2-240........... 11/14/80
2-15 thru a-21 11/14/80
a-aa Il/as/# 2-241 11/28/84
a-as thlu a-at Ii/in/so 2-242 thru 2-254........... 11/14/80
a-as Il/as/sn 2-ass 11/28/84
a-as UIIV a-3a 11/11/80 2-258 thru 2-288........... 11/14/80
2-93 II/as/sc 2-ass Il/zs/sn
2-34 II/In/so 2-270 11/14/80
2-55 11/28/84 2-211. 11/as/sc
2-,a Ulru 2-42 11/1(/80 2-212 11/14/80
i 2-43 Lhru 2-44 1/1/94 2-213 II/as/sc
2-45 thru 2-48 11/14180 2-214 thru 2-218........... 11/14/8(1
a-no thN a-SO´•´•´•´•´•´•´•´•´•´• 11/28/84 a-218 11/28/81
a-ii thN 2-55´•.´•´•´•´•´•1´•´•´•´•. 11/11/80 2-280 Lhru 2-181........... 11/14/80
a-sa.......:.............. ll/ae/s4 2-282 11/28/84
2-57 thlu a-58............. 11/11/80 2-ass Lhru 2-280........... 11/14/80
a-so 11/28/81 a-aol. .11/28/84
a-el thru a-?o............. 11/11180 2-292 thN a-ass II/In/so
a-?1...................... 11/28/84 a-281 11/28/84
2-12 11/14/80 2-288 thru 2-304........... 11/14/80
a-13 11/as/s4 2-sas..................... 11/28/84
2-14 thru a-81............. 11/14/80 2-3(18 thru a-saa........... II/In/so
a-sa thlu a-84............. 11/28/84
a-ss thru a-101............ 11/14/80
2-331.´• 11/28/84
2-tea Il/as/s~
2-328 Lhru a-542........... 11/14/80
a-los 11/14/80 2-sts thlll 2-344´•´• 11/as/sn
2-346 thru 2-951........... 11/14/80
2-104. 11/28/84
a-toe thn, a-118 11/14/80 2-552 II/as/sc
a-11? Ii/as/sc 2-369 thN 2-558 11/14/80
a-lie thlV a-120 11/14/80 a-sso. 11/28/84
a-121..................... 11/28/84 2-351 thru a-388........... 11/14/80
2-1za eru a-lac L1/1c/sO 2-387 11/28/84
2-lzs..................... 11/28/84 2-588 thru a-403
I-UII thru P-l. (L/1~BO 8-MI tblY 1-U16:::::::::::
2-lsl..................... II/as/sc 2-400 thru a-411´• 11/14/80
2-132 thru a-154........... 11/14/80 2-41a.....:............... 11/28/84
2-lsJ..................... II/as/sn a-nls 11/14/80
2-13a th~ a-158 11/14/80 a-414 thru 2-416........... 11/28/84
a-las. Il/as/sn 2-416 BLank 11/14/80
a-Ino th" a-180 ´•´•´•´•´•I´•´•´•
11/14/80 3-1 Lhru 3-45.............. 11/28/84
a-ist ll/ae/s4 3-48 Blanll 11/14/80
INSERT LATEST REVISED PAGES. DESTROY SUPERSEDED PAGES.

The indicates pages re~lssd, added or deleted by the Eurred revision.

aaassnnluLu
A/B
 ILLUSTRATED
ROCKWELL
COMMANDER PARTS CATALOG TABLE OF CONTENTS

690A/B

TABLE OF CONTENTS

IfCTlON PAGE

INTRODUCTION

Enplanation of How to identify a Part 1- 3

Aircraft Assembly Complete. 1- 5
Station Diagram 1- 7
Federal Supply Codes ior Manuiacturers 1- 8

II GROUP ASSEMBLY PARTS LIST

POWER PLANT

Propeller and Propeller Deicing installation 2- 2

Cowling Installation 2- 8
Engine Mounting installation 2-11
Engine Enhaust and Fireshield Installation 2-14
Engine Assembly and Accessories 2-17
Engine Piping Installation 2-25

~UILS *ND OIL SYSTIMS

Fuel and Oil Systems Installation 2-SO

Fuel Equipment Installation a-32
Fuel Yent Installation. 2-58
Fuel Tan~s Installation 2-40

POWER PLANT CONTROLS

Power Plant Controls Installation 2-45

Quadrat Installation 2-49

LANDING GEAR

Main Landing Gear Installation 2-56

Oleo Strut Assembly 2-62
Wheel and BraHe Installation, MLG 2-86
Main Landing Gear Uploelrlnstallation 2-11
Emergency Air Reservoir Installation MUi 2-14
Nose Landing Gear Dears and Actuating Mechanism 2-18
Nose Landing Gear Installation 2-81
Nose Landing Dear Controls Installation 2-81

HYDRIULIC SYSTEM

Hydraulic System Fuselage Nose 2-90

Hydraulic System Center Fuselage and RH Nacelle 2-98
Hydraulic System LH Nacelle 2-101
Hydraulic System Main Landing Gear Doors 2-109

ILICTRICPIL SYSTEM

ElectrlealEquipment Installation 2-114

Overhead Switch Panel Installation. 2-141
BatteryInstallation a-148
Enternal Power Recepta~Le and Access Dear. 2-152
 ILLUSTRATED
ROCKWELL
TABLE OF CONTENTS PARTS CATALOG COMMANDER
880a/s
rrcnon
paoE

II GROUP ASSEMBLY PARTS LIST (CONTD)

INSTRUMIN’IS

Instrument Group LH Instrument Panel 2-154

instrument Group Center Instrument Panel 2-158
Instrument Group RH Instrument Panel 2-158
Instrument Sub-Panel and Circuit Breai~er Panel Installation 2-180
Instrument, Radio, Circuit BreaBer and Sub-Panels Installation a-183
Instrument Equipment Installation 2-188
Nose Instrument Piping 2-178
Fuselage Instrument Piping Installation 2-188

WING

Wing Plating 2-183

Wing Aocess Covers 2-197
Wing Structure 2-200
Truss Installation Main Landing Gear 2-214
Naeelle and Landing Gear Doors Insta~lation 2-ale

5MPINNAOI

Yerttcal Stabilizer and Rudder Insta~Lation 2-244

lIorizontal Stabilizer and Elevator 2-294

PLIGHT CONTROLS

Flap Control System 2-2(0

Aileron ControlSystem 2-248
Elevator Control System 2-258
Control Column Assembly Aileron and Elevator 2-287
Rudder ControlSystem 2-210
Rudder and Elevator Trim Tab Control Systems 2-280

~USIL*OE

Fuselage Plating Complete 2-288

Fuselage Structure Assembly Nose Section 2-282
Fuselage Structure Assembly Forward Section a-300
Fuselage Structure Assembly Aft Section a-308
Cabin and Baggage Compartment Floor installation 2-312
Equipment Dech Installation 2-514
Fuselage Floor Beams and Related Frame Structure a-sri
Fuselage Windshield installation 2-328
CoeBpi~Overhead Windows Installation. 2-328
Fuselage Coclrpit Window Installation a-350
Fuselage Cabin Side Windows installation a-392
Fuselage Emergency ExllWindow Installation 2-335
Main Cabin DoorAssembly and instsillation. 2-558
Main Cabin Door Mechawsm a-543
Step Ins~alllian Cabin Entrance a-353
Fuselage Baggage Door Insta~Lation 2-551

INr~RIOR PURNIOHINOS

Interior Furnishings installation 2-358

 ILLUSTRATED
ROCKWELL
COMMANDER PARTS CATALOG TABLE OF CONTENTS
690A/B

SICrlON PAGE

II GROUP ASSEMBLY PARTS LIST (CONTD)

INYIRONMINrAL

Dual Outf Low Valve Installation 2-387

Pressurization and Air Conditioning Fwd Fuselage 2-168
Pressurization and Air Conditioning Afl Fuselage 2-376
Bleed Air Piping Installation 2-387
Pressurization and Air Conditioning LH MLO Ssitch Installation 2-383

MISCELLP.N$OUS

O~ygen System Installation 2-395

Wing and Empennage Deieer Insf allatlon 2-401
Anti-Icer and Delcer Equipment Installation 2-408
Propeller Synchroniser Controls installation 2-410
Placard and Decal installation 2-412

III NUMERICAL INDEX

Numericallnden 3-1

iii/i~
 SECTION

INTRODUCTION
 ILLUSTRATED
ROCKWELL
COMMANDER PARTS CATALOG SECTION I

BgOA/B INTRODUCTION

Introduction

1~1
 ILLUSTRATED
ROCKWELL
SECTION I PARTS CATALOG COMMANDER
INTRODUCTION BI)OA/B

CATALOG IDENTIFICATION AND PURPOSE ILLUSTRATION8. ALI illustrations throughout the

Illustrated Parts Catalog are numbered and titled to
correspond with their respective parts listings. De-
The purpose of this Illustrated Parts Catalog is to tails faren from illustrations are listed alphabetlc-
assist stockroom, mainten;u~ce, and repair personnel ally. When more than one page of illustrations appear
ill ideotilying alid ordering spare parts for Rockwell in the same figure, eachpage is numbered(Sheet of
Commander Model 690A and 680B aircran;. Thess _) to show relationship to other pages.
aircraft are manufactured by General Aviation
Division, RaBwell International, Bethany, Oklahoma
75008. The Illustrated Parts Catailog is arranged in
three major sections: ATTACHING PARTS. Attaching parts are listed be-
neath the part(s) they attach and are followed by the
separation symbol(---’---) to separate the al~ach-
SECTION I INTRODUCTION ing parts group from subsequent Listings. Attaching
parts such as a series of washers that are similar in
SECTION 1l GROUP ASSEMBLY PARTS LIST appearance but different in application are individually
Indexed to aid in groper installation.
SECTION 1l1 NUMERICAL INDEX

SECTION I-INTRODUCTION
VENDOR PARTS. Parts manufactured by companies
This section contains general information and Ln- other than Aviation Division will bear the
General
structians on how to use theIllustrated Parts Catalog, vendor’s Federal Supply Code Number in parentheses
which 18 sectionalized according to major aircraft Lollawing the part name (see Federal Supply Code for
sections and systems as shown in the Table of Con- Manufacturers, beginning an page 1-8). Vendors hav-
tents. ing no FederaiSupply Code assigned will have the ven-
dor’s name and address listed following thepartname.

AIRCRAFT ASSEMBLY COMPLETE. A visual index,

"Aircraft Assembly Complete", showing the malor
aircraft sections andsystems is provided an page 1-5. PARTS LIST PAGE
An indexed listing showing the titles andpages of these
major groups is shown on page 1-5. The parts list page is divided into five columns which
are explained below.

HOW TO LOCATE PARTS. Instructions on how to

locate and identify parts are contained on page 1-5. FIGURE AND INDEX NUMBERS. This eolumncon-
tains the figure and index numbers of corresponding
illustrations. The figure number is Listed only once
at the head of the column. The index numbers are in
SECTION II GROUP ASSEMBLY PARTS LIST numerical sequence in this column and serve to lo-
cate parts on the illustration.

The Group Assembly Parts List is a breakdown of all

systems, assemblies, and subassemblies which con-

taln replaceable parts. Assemblies or installations PART NUMBER. This column contains the part num-
that are composed of a maJorfy of identical compo- bersassigned to each part. Parts havingnogart
nents are listed together and the components is com- number assigned are listed as "Na Number" in the
mon are listed only once. Even though only the left part number column. No Number parts lather than
assembly or installation may be tllustrated, both left installations and systems)
may be ordered by giving
and right components are Hated. Components not the figure and index number in addltionto the regu-
common to all assemblies or installations will have a lar ordering informntion. General Aviation Division
note such as "(-501 Only)" or "LH Only", etc, part numbers are identical to their blueprint numbers
and are of two types as explained below.

YOll (1) Example:

Installation part numbers are shown in

the illustrated Parts Catalog only for
the purpose of providing a "nent higher
assembly" for assemblies, subassem-
blies, detail parts, etc. Installation
Major Section_´•´•
8ub Section
tf
part numbers are non-proeurable. Drawing Sequence Number_

1-2
 ILLUSTRATED
ROCKWELL
SECTION I
COMMANDER PARTS CATALOG ~TRODUCTION
680A/B

i::E~a:

:r
e~
,R

a~-

4´•1 11 ´•a

1) (3) (1) (2)(E) (1

HOW TO FIND THE PART NUMBER IF THE HOW TO FIND THE ILLUSTRATION FOR A
SECTION OR SYSTEM OF THE AIRCRAFP PART IF THE PART NUMBER IS KNOWN:
IN WHICH THE PART IS USED IS KNOWN:

O Turn to the Table ed Contents, find the page num- O Turn to the Numerical Index. Find the part num-

ber for the major assembly or system in which ber and note the first figure and index number
the part is used, then turn La that page. listed for that part.

O Locate the part and its index number on the illus- IO Find the figure noted in step (4),
Lration.

O Find the index number ´•on the parts list page to O 011 the face of the illustration, find the index num-

determine the part number and complete part ber determined in step (4).
description.

Figuts I-1.Ixpl.n.tion ol Hov to id´•ntify o port

1-3
 ILLUSTRATED
ROCKWELL
SECTION I PARTS CATALOG COMMANDER
hTTRODUCTION BB0A/B

(2) Example: FURN Furnished

FWD Foward
309210 HDWE Hardware
Stoodard (General
Aviation Division)
Drawing Sequence Number ~STL Installation
Size, Length, Etc. INWR blstruction
MLG Main Landing Gear
DESCRIPTION. This column
gives the part title and NLG Nose Landing Gear
modifier as necessary La describe the part, such as NP Non-procurable
LH or RH, upper or lower, Lnboard or outboard, etc. REF Reference
Special instructions necessary far proper placement REP Required
of orders, such as "specify length desired" and STA Fuselage Station
"palnted and engraved" are listed in this column. In- 8TD Standard
dentions of parts titles in this column shaw their re- W/ with
lationshlp La one another within the figure(see Exam- W~ without
pie below). WS WingStation

SECTION III- NUMERICAL INDEX

Example:
The Numerical Index provides an alpha-numerical
12 3 4 5 B 7 Description
Listing of all part numbers contained in Section 1I of
this illustrated Parts Catalog. Instructians for using
Main Assembly LheNumerhal Index are given onPage 1-3, "Explana-
Assembly Lion of How to Identify a Part". The order of prece-
(Attaching Parts) dence in the arrangement of part numbers beginning
parts for assembly at the extreme left-hand’9irst" position is as follows:

Detail parts for assembly Letters A through Z

Subassembly Numerals 0 through 8 (Alphabetlcal 0’8
(Attaching Parts) shall be considered as numerical zeros.)
Attaching parts for subassembly The second and succeeding positions La the right are:

Details far subassembly

8pace (blanlt column)
Diagonal (slant)
UNITS PER ASSEMBLY. This column lists the num-
Point (period)
Dash
ber of companents repuired for a single unit of the
LBLfers A through Z
NHA (Next Higher Assembly). Attaching parts are
Listed in Numbers 0 through 9
quantities re~uired to remove a single unit.
STANDARD PARTS. Standard Parts (AN, MS, NAS,
Requirements that varyon installation(such as shims) etc.)are to be purchased locally.
are indicated "AR", meaning "As Required". Closely
related parts which are not actually included under a THE FOLLOWING INFORMATION SHOULD BE PRO-

given assembly number are usually indicated "REF" VIDED WHEN ORDERING SPARE PARTS FROM AP-
with a note in the description column "see Figure PROVED GENERAL AVIATION DIVISION DLSTRIBU-
to maintain continuity of illustrations. TORS.

i. Aircraft model and factory aerial number.

USABLE ON CODE. Variations in parts usage willbe
2. Part number and description.
alphabetically coded in the "Usable On Code" column 3. 8uantlty desired.
of the parts lists. This variation is to be compared
4. Where and how to ship.
with the e~ulvailent alphabetical symbol following the
parts Listing on each page to determine the Limited WOll
effectivity. A new sequence of code Letters are begun WHEN ORDERING PARTS FOR 8/N 11249, U8E
with each figure, therefore it is important to oheol
SAME "USEABLE ON CODE" AS WHEN ORDERING
each coce of separate figures. Parts used on ALL
aircraft serialnumbers will be coded inthe "Us- FOR S/N 11289 AND SUBS.
able On Code"column and are to be read as unlimited
effectivity parts. RE9UESTIND MANUALS CORRECTIONS/CHANGES
ABBREVIATIONS. The following abbreviations are
used throughout the Illustrated Parts Cata~ag: RBcOmmended changes or corrections to this manual
may be submitted by anyone using the manual. Change/
ALT Alternate correction recommendations shaillbe submitted on
AR As Required the Publications Change Request Form (AC 1452)
ASSI Assembly found in the baoL of all manuals delivered from the
BLKHD Bul~head
factory. All recommended changes will be reviewed
BRKT Braehet
by Customer Service, Engineering, etc., before
CARE Carbueretor
incorporation or relection. Additional forms may be
CYL Cylinder requested from Rockwell International General
EGT Exhaust Gas Transmitter Aviation Mvislon.

1-4
 ILLVSTRATED
ROCKWELL
COMMANDER PARTS CATALOO SECTION I

BgOA/B INTRODUCT(ON

13 1/ II

1( V
I
O i

3 1

ligy181-2. Airrrah Alrembly Complsts

1-5
 ILLUBTRATED
ROCKWELL
SECTION I PART~ CATALOG COMMANDER
INTRODUCTION 680A/B

Figure See Figure

Inden No. Description No.

AIRCRAFT ASSEMBL;Y COMPLETE

1-2- AIRCRAFT ASSEMBLY, Complete

-1 POWER PLANT 2-1 thru 2-8

-2 FUEL AND OIL SYSTEMS 2-1 thru 2-10

-3 POWER PLANT CONTROLS 2-11 thru 2-12

-4 1 LANDING GEAR 1 2-13 thru 2-20

-5 1 HYDRAULIC SYSTEM 1 a-21 thru 2-24

-6 ELECTRICAL SYSTEM 1 2-25 thru 2-28

-7 INSTRUMENT SYSTEM 1 2-28 thru 2-36

-8 WING 1 2-31 thru 2-41

-9 1 EMPENNAGE 1 2-42 Lhru 2-43

-10 FLIGHT CONTROLS 2-44 thru 2-48

-11 FUSELAGE 2-50 thru 2-84

-12 1 INTERIOR FURNISHINGS I 2-65

-1S I PRESSURIZATION AND AIR CONDITIONWG I 2-68 Lhru 2-10

-14 MISCELLANEOUS EQUIPMENT 1 2-11 Lhru 2-15

OXYGEN SYSTEM 1 2-11

WING AND EMPBNNAGE DEICER 1 2-72

ANTI-ICER AND DEICER EQUIPMENT WSTL 2-’15

PROPELLER SYNCHRONIZER CONTROLS WSTL 1 2-74

PLACARD AND DECAL INSTALLATION 2-15

1-B
 s~w
8 L 8 8 8 8 00 X a 8
o~
U~7- gr
N’ 3
,-~rd$_N
N
0~ dlrjd di
i?. zs--~i I I I m

26. 50
95.
45. 00-
6,.
61. 4(1
69. 60

86.
90. 00
9’1.
106. 5(1
116.

LE~T HORIZONTAL STABILIZER

s 111 7 i r
,r
-Ir
r’ I
o~

E! 105.45
34
im
1 ~:e8 oo
D

OX 888XXXXX E P P
diird~rdda’
rmmolNoa

z=´•2´•oo---~ i 1 II ;;T~;
z=o
z=o
z=-lo. oo~

Z=-zs. w~
Z=-40.

2´•-55.

2;-65.

P D DaC
80800 8 o 00~
gg ~a g g g g D ul
g g
Bg
N op a
Dooi~

N ONaV)N O rY)N (d aON dOj i F; 4 i C

Fl 2´•0
NN N N o on o o a 6 O*

*P
8
 ILLUSTRATED ROCKWELL
SECTION I PPIRTS CATALOG COMMANDER
INTRODUCTION 890A/B

FEDERAL SUPPLY CODE FOR MANUFACTURERS

14834 Circle SealCorp.

00303 Shelly Assoclales, Inc. 05824 Barber Colman Co.
E1Segundo, CA 90245 RoeMord, IL 81101 Microporous Filter Dlv.
Anaheim, CA 92805
00613 Molly Co., Mv.of USM, 08239 AUSCO, he.
Temple, PA. 15084 Aerospace Knob Co.
PortWashington, NY 11050
Div. of Dupree, Inc.

GeneralFire ElMonte, CA 91153

00152 Cutler-Hammer,lnc. 08556
Long Island, NY 11128 Extinguisher Corp.
CA 90251 15281 Adlustable Bushing Corp.
Culver City,
00719 Amp, Inc. North Hollywood, CA 91805

Harrisburg, PA 11105 08312 Trans Dynamlc,Inc.

15412 AMF, Inc, AMF Cuno Div.
BUPbBn~, CA 91505
01189 AssociatedCo.,lnc. Merlden, CT 08450

Wtchita, W 67313 08484 Breeae Corp.,Inc.

Union, NJ 07083 15605 Cutler-Hammer,lnc.
01828 VLier Engr. Corp. Milwaultee, WI 53118
BurbanB, CA 81505 08806 General Electric Co.
Miniature Lamp Products 11230 Associated Spring Corp.
01285 Texas Instruments, Inc. Cleveland, OH 44119 Southwest Dlv.
Components Group Dallas, TX 15341
Dallas,TX 16212 09048 Custom Component
Switches,Inc. 21535 The Fafnir Bearing Co.
01358 Fairchlld Indusbies,lnc. Chatsworth, CA 91311 Div. of Telt~ron,Ine.
Stratos Division New Britain, CT 08050
Manhatton Beach, CA 08052 Gulton Industries, Inc.
80268 AUralhe Battery My. 22313 King Radio Corp.
Metuchen, NJ 08840 Olathe, KS 66061
01531 Motorola Communications
Electronics, Inc. 08353 C KComponents, Inc. 24446 General Electric Co.

Chicago, IL 80851 Watertown, MA 02172 Schenectady, NY 13305

01688 RCL Electronics, Inc. 08393 Rochester Gauges, 24522 Humphrey Products Div.
Manchester, NH 03102 inc, of Texas Kalamazoo, MI 48005
Dallas, TX 15220
02013 H E Aircraft Co. 24692 HartaellPrapsller, Inc.
Division of 104[12 Whelen Engr. Co., Inc. Piqua, OX 45358
Weston Hydraulics Deep River, CT 06411
OLrlahoma City, OK 25500 Ooodyear Aerospace Corp.
IOgBe Casco Products Corp. Akron, OH 44135
03211 Puritan-Bep Div. of Bridgeport, CT 08802
Puritan Equip., Inc. 28433 Airborne Mig. Co.
E1Segundo, CA 80245 12145 The Bendix Corp. Elyria, OH 44055
Electrical Components Div.
02681 Parlter Seal Co. Dlv, of Santa Anna Plant 28115 Airborne Mfg.
Pader-Hannifan Corp. Laltewood, CA 80112 OH 44055
Elyria,
Lexington, KY 40509
12324 SLaJ~e Fastener Co. 21181 Cutler-Hammer, Inc.
02728 Electro-Flex Heal, Inc. Div. of Dupree, Inc. Power Distribution
Bloomfleld, CT 08002 EIMonte, CA 91153 &ControlDtv.
Milwau~ee, WI 53218
03038 Longlolt Corp. 12881 Clarostat Mig. Co.,lnc.
Los Angeles, CA 80066 Dover, NH 03820
21193 Cutler-Hammer, Inc.
05481 B. F. Goodrioh Co. Specialty Products Div.
Aerospace Defense 13105 Thermalloy Co. Mllwaultee, WI 53118
Products Dlvielon Dalle, TX 15241
A~ron, OH 44318
27901 United States Plastic Corp.
04838 Controlex Corp. of America 15445 Cole-Hersee Co. Lima, OH 45805
Croton Falls, NY 10519 Boston, MA 02121

05388 Bemco, Inc. 14314 Precision Sensors, Inc. 27998 Geometrical SLructures,Ino.
Centerton, AR 72118 Trumbull, CT 08611 Temecula, CA 82581)

1-8
GULFSTREAM ILLUSTRATED
COMMANDER PARTS CATPIL00 SECTION i
690A/69(JB ~TRODUCTION

FEDERAL SUPPLY CODE FOR MANUFACTURERS (CONTD)

28153 3M Co. Film and 56878 Standard Pressed 71286 Rex Chainbelt, Inc.
ALlied Products Div. Steel Co. Camloc Div.
St. Paul, MN 55101 Jengintown, PA 19046 Paramus, NJ (11652

28985 Tramm Corp. 71400 Bussmann Mig.Dlv. of

TX 76105 51448 SLephens-Adamson Mf g. Co.
Fort Worth, Mccraw-Edison Co.
Aurora, 1L 60501 St. Louis, MO 63107
30327 Imperial-Eastman Corp.
Imperial DLV. 60038 TLmBen Roller 71441 Ametek/Calif.Spring Div.
Chicago, IL 60648 Bearing Co. Pico Rivera, CA 90660
Canton, OH 44706
30467 Aeroflash Signal Corp. 71513 Cleveland Aircraft Products
Chicago, IL 60641 60380 The Torrlngon Co. Avon,OH 44011
Torrlngton, CT 06790
31435 Lear Siegler, Inc. 72386 Felters Co.
Power Equipment Div. 61220 Tyson Bearing Co. MLLLbury, MA 01527
Maple Heights, OH 44131 Masslilon, OH 4(846
72598 Garret Corp.
32992 American Safety 61864 United-Carr Los Angeles, CA 90008
Equipment Corp. Div. of TRW, Inc.
Encino, CA 81318 Boston, MA 02198 72883 Grand Rapids Store
Equipment Co.
Grand Rapids, MI 48502
32531 Joy Mfg. Co. 61951 USM Corp.
PLttsburgh, PA 15222 Boston, MA 02101
72914 Onmes Mig. Co.
32711 YEP 64580 Weldon Tool Co. Urbana, OH 43018
Mslibu, CA 80285 Cleveland, OH 44104
72962 Elastic Stop Nut DLV. of
34163 Aerospace Systems 85301 Pennwab Corp. Amerace Esna Corp.
Componenis, Inc. S. S. White Equip. Div. Union, NJ 07083
Wlchita, ICE 61212 New Yorh, NY 10011
13134 The Helm Universal Div.
33497 Precision Winding,lnc. 68503 Woodward Governor Ca. of Rockwell International

Wichita. KS 61213 Rocldord, IL 61101 Fslrfield, CT 06430

34896 Custom Products Co. 70134 Aero Instrument Co, Inc, 73168 Fenwal, Inc.
Sun Valley, CA 91352 Cleveland, OH 44135 Ashland, MA 01721

38536 Slmmonds Precision 10210 AiResearch Mfg. Co. 13217 E. F. Haughton and Co.
Inc. Los Angeles, CA 80008 Philadelphia, PA 19133
Products,
Long Island City, NY 11101
13433 Re,: Chaihbelt, Inc.
10214 AirpathInstrumsnt Co.
43990 C. A. Bridgeton, MO 63044 Roller Chain Div.
Norgren Co.
Littleton, CO 80120 Sprlngfleld, MA 01101
10255 ALCO Controls Div.
44855 Ohmite Mfg. Co. Emersan Electric Co. 13559 Carlmg Electric, Inc.
Skokle, IL 80018 St. Louis, MO 63141 Hartford, CT 08110

45681 ParLer-Hannifin 70417 Chrysler Corp. 13760 ITT General Controls

Corp.
Cleveland, OH 44112 Amplex DLv. Aerospace Products
Detralt, M1 48231 Burba~, CA 91502
52504 Fenner America Ltd.
70438 Arena Controls Inc. 74083 Hartman Electrical Mfg.
RussellMfg. Div.
DLv.A-T-O ,Inc.
Middletown, CT 06451 EY"stan, IL 60202
Mansfleld, OH 44801

53655 Scott Aviation 10485 Atlantic India Rubber 15237 Kaynar Mfg. Co.
Dtv, of A-T-O, Inc. Worlw, Inc. A Microdot Co.
Lancaster, NY 14088 Chicago, 1L 60607 Fullerton, CA 82634

Revised: 28 November 1984 1-9

 ILLUSTRATED OULFSTREAM
SECTION I PARTS CATALOG COMMANDER
INTRODUCTION 690A/690B

FEDERAL SUPPLY CODE FQR MANUFACTURERS (CONTD)

18005 Lord Mfg.Co. Div. of 82829 Alien Aircraft Products,lnc. 89508 Lear Siegler, Inc.
Lord Corp. Ravenna, OH 44266 Santa Monica, CA 90406
Erie, PA 16512

16581 MiM. Mining Mfg. Co. 82942 Rubaten Corp. 90005 The Benmx Corp.
St. Paul, MN 55101 Bedford, YA 24523 Filter Division
Madison Heights,
H.K. Porter Co. Inc. 83014 Hartwell Corp. MI 48071
77492
Thermoid DLv. Worlts Los Angeles, CA 80054
91511 Auto Valve, Inc.
Philadelphia, PA 18135
83058 Carr Fastener Co. Dayton, OH 45427
A United-Carr
17969 Rubber Craft Corp. of Dtv, of TRW, Inc. 91893 M. S. P., Inc.
California Ltd Cambridge, MA 02142 Marion, IN 46852
Torrance, CA 90607
83086 New Hampshire Ba~U
91929 Honeyweli, Inc.
Bearings, Inc.
Micro Switch Div.
18553 Tinnerman Products, Inc. Peterborough,NH 03458
Freeport, IL 81032
Cleveland, OH 44129

83328 Safe Flight Instrument Corp. 93727 American Aluminum Co.

78138 Waldes Kohlnoor, Inc. White Plains, NY 10602 Mountainside, NJ 1)1092
Long Island City, MY 11101
83584 Wemac Co.
93828 G-Y Controls Div. of
Santa Ana, CA 92104
Sola Basic Ind.,lnc.
80097 American Chain
Llvingstan, NJ 07038
CableCo., Inc. 83835 U. S. Radium Corp.
SotNield, W 48015 Morristown, NJ 01860
94581 National Utilities Corp.
Dlv. of Nuco
80477 Adams Rite Mfg. Co. 84018 American Excelslor Co.
i"dugtries, inc.
OLendale, CA 91204 Norrlstown, PA 18404 CA
Monrovia, 91016

81073 Orayhill, Inc. 84375 Teledyne Battery Products

La Grange, IL 60525 Redlands, CA 82575 95146 ALCO Electronics
Products, Inc.
81312 Winchester Electronics Dlv. 84830 Lee Spring Co., Inc. Lawrence, MA 01843
LittonIndustries, Inc. Brooltlyn, Ny 11201
CT 06779
84911 TA
98625 Aeroquip Corp.
Mfg Corp.
81321 Los Angeles, CA 80098 Ae’Ospace-Marman
Purolator, Inc. Div. Marman Plant
Rahway, NJ 07065 Los Angeles, CA 90064
85832 ELectrofilm, Inc.
81376 Southwest Products Co.
North Hollywood, CA 91605
99193 AiResearch Mfg. Co.
Monrovia, CA 01(116
of Arizona
82211 Componetrol, Inc. 86579 Preci~on Rubber Phoenix, AZ 85010

Chicago, IL 80648 Products Corp.

Dayton, OH 45417 98891 Porter, H.K. Co ´•Inc.
82389 Swltchcraft, he.
88197 Chanute, KS 66702
Chicago, IL 80630 Rogan Bros.,Inc.
IL 60078
82841 Texas Instruments, Inc. 99551 The Bendlx Corp.
Control Products Div. 87(134 Marco-Oai~ Industries,lnc. Fluid Dlrislan
Attleboro, MA 02703 Anaheim, CA 828(13 Utlca. N.Y. 13503

1-10 Rerised: 28 1984

 SECTION

GROUP ASSE NIB LY

PARTS LIST
 ILLUSTRATED
ROCKWELL
COMMANDER PARTS CATALOG SECTION II
690A/B

Group Assembly Parts List

z~l
 ILLUSTRP;TED
ROCKWELL
SECTION n PARTS CATALOG COMMANDER
POWER 690A/B

25
j\

is so
B

n--p18~
3
22
20 15

i
4 ,i A

Figure 2-1. Prop´•ll´•, ~nd P,op´•ll´•r D´•i~ing in~t.ll.ti.n (She´•11 ol 3)

2-2
 ILLUSTRATED
GULE8TREI\M
COII~IANDER PARTS CATALOG SECTION I1

690A1690B POWER PLA~PP

P I T JYITS USII’IY
F I Ii i
7EU CV
i. I.´•~ri
V.J Y Z F i 12 3 i i t i lirl CT)[
h-Riii

b1019L POUES PL LNT I NSTL I LH C PH REF

i. I
PIIOPELLEII PSSI L
L10053.1
IlrTLCHING PLITS)
SDLT 12(6’1)1 B
1 8-31)9
YIIRER 1216121
---t---

IPINIEI 1151 (2)6921 1

836.57P
On*E, SPINYEII 12(~921 I
C~3153
(ITTLCHING PIPTS)
ICPEU 15
3 LI(S16C1032RI

BULYHE 10 1 216921 I
L t-3752
(ITTICHING PIPTII
BOLT 6
5 P*).IOL
1Nl.bl BOLT
´•´•YLIHEI´•´•´•´•´•´•´•´•´•´•´• 1
NUT (152sl~ 9
HLO~)

830-23L STOP LSSI´• 1070 HIGH PITCH 12(692)

PIU´• COTTFP I
7 1152(6~5‘28)
IN9)b110 UL SHE I I
1.30L6 IPSrNG I
9
PIN 1~(6"2) 1
1~883
8-3128-2 IRLCI~ET 121~921 I
´•11
oy STON lsSI 11)692 I I
IITTICBING PLsTSI
.13 1~)01 LINISEIEU (2(6911 ´•´•´•´•´•´•´•´•´•´•´•´•´•.´•´•r´•´•
SLEEVE´• LINISCPEY (1)692) 3
´•1) 1-911
’IN. COTIEI´•´•´•´•´•´•´•´•´•´•´•´•´• 1

..*UT´•FLEXLOCII 29692) 1
-15
---1---

B~L9r)llLI ...LIHX 6911 12)6911 3

.16
IITTbCHING PllT91
1‘1(6) LINX PIU IIII 1)(6921 I
L7
SCIIEY 1
is

G-3021-1lLI PISTON IYITH SODI1 12169)1 L

19
O-I1NG, CILIYOEI( t
20
ii o-alNc, PISTON 1
ii a-IBI3 IE LL (1(692) 1
23 a-alNG, PILOT TUBE 1

r-ono-llor o-alne 1

is e~o-sl Hue SPIOEII bSII (21~921 1

B1B-IIL CL LIIP LNO COUWTEIYEIGHT IISI IZ(b921 3

(PTTIC31NG PLPISI
26 L~11)Z ..30LT. CLLIIP (21~921
NUTI CLI*P 1 2(6921 I
1-1373
ICI(EY´• SOCIET HEIO 12(6921 2
27 6‘292
*I21665-281 PIN, CITTE~ 2
---t---

1-3086.1 PuTE´• 5700 1)9692) I

PB
IPTTbCHIYb ’L~TI)
BOLT 1116921 2
29 I~)OL6 ´•´•´•´•´•´•´•´•´•´•´•´•´•r´•´•´•´•´•

30 L-33L1 YEIGHT 111(19P) 2

IITTLCHING DLPTII
liN1H71 90LT 3
31 ´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•r´•´•´•

---t---

6-3989 UE I GHT (Z16’PI ´•´•´•´•r´•´•´•´•´•´•´•´•´•´•´•. r´•´•

I
IITTLCHIRG PLsTI)
3) ICI(EU´• ZOCXEr nElO CLP 12~6921
---li---

I(e~iied: ioicalbel. 1981 2-3

 ILLVSTRATED
GULFSIREAM
SECTION n PARTS CATALOG COYMANDER
POWEIL PLANT
890A/690B

11----71 211

´•I I,

I~JS--31,

so~ 32

31
23/

L~i

k´• "1
st

~iOur´• 2-1. Prop´•ll´•r ond Plop´•ller Dsirinl lllIlollolion (Sh´•´•1 of 3)

a-4
 ILLUSTRATED
GULESTREAM
PARTS CATALOG SECTION 1l
690A/690B POWER PLANT

P 3 i i UYITI USdbLt
I:´•i)iX C E i C i i r i I L *ti Oh
I_yljii L:U I
i t i I i i i i L
41SY Lji~i

2- L ~3) 1-3039 HEIGHT 121692) I

35 HEIGHT ´•´•.´•´•´•´•´•´•1´•´•´•1´•´•´•´•´• 1
(ITTPCHING PLIITSI
)6 LN)HIII BOLT

37 1-295 ROLL PIN 1

38 8-3091-1 ´•+COUNTEPYEIGUT I
IITT~CHING P1RTS1
39 L-203b~Z2 ~CSEY´• IOCIET HELD CIP 1216911 ´•´•r´•

---I---

IO FITTlNbl LUSRICLTION ´•´•r´•´•´•´•´•´•´•´•´•´•´•

L
G1S~ET, CLI*P 12)6921 2
)2 CLI*P (YITH HOLEI FOR L
COUHTEr(YIIGHTII (1~6911
~3 C-L3D1-10I CLI*P IL(69LI 1
LT10282*) BLIOE´• PROPELLER 3
)5 1-L85) RING. HIRE RETENTION 121~91) ´•´•´•´•´•´•´•1
3
~b 1-L8fiZ It NG GUIDE (2)6911 3
1~1511 ~ING´• BELRING RETENTION 121~91) 3
18 8EII1HGI SPLIT (INCLUDEI BOTH BEIRtNG
HILVEO) 1116911
-)9 1~1889 IPICEl´• BILL I 21692 I
~50 O~1ING ´•r´•´•´•´•´•´•´•´•´•

51 8665))~3 TUBE 15SI´• BETl (FURNISHED YITH ENGINEI 1

(9919))
IITTICHING PLRTII
~5Z *SP)OP-III 50L7 1
*52I01)-3 NUT ´•......´•..´•1´•´•´•´•´•´•´•´•´•.´•.....´•.´•.´•´•.
1
---I---

.53 S50578F220 ´•´•O-IIING 1991911

-5) 580516VIO ´•´•0-RIN6 19919)1 1
-55 ~SLll)eB ´•´•´IH.´•´•´•´•´•´•´•´•´•´•´•´•´• 1
5( 8665)3-1 PLUG, TUBE ESO 1991931 t
-57 S80578FI O-RING 19919)) I
-58 BbbS11-ll r IUIE´• 8E711991931 1
890))) PROPELLER DEICING INITL, ELICTPIC´• LH C REF
SW IIEE Flb´• 1~121
´•59 )E1BIB~Z CL 1IIP 1SS1´• TERIIINLL 103181) I
I)lTTICHING PIRTII
60 1H501~10´•8 ~CREY 2
1N960C1DL UL SHER Z

61 )EL60L-5 DEICER, PROPELLER r03)B11 3

62 nTp alNG. ELECTRIC (03)811 L d

6)0019-1 ILIP RING, DE1CER (IEE FIG´• REF

63 1E1150 TER*INIL 57819 I03)8II
(ITTLCHING PIRTII
-6~ 1W5001D6~1) ´•´•ICREY´•´•´•´•´•´•´•´•´•´•´•´• P
*535338~)1 LOCIYIIHER
---t---

65 3E1271-1 CLIP LISI. LEID (0)(811 3

66 111110(01 CLIWP 3
IITTLCHING PlRTSI
~61 )iNS00108~10 (CI(EU I
1N960C8 YLIHEI( 2
115110)5~08 IIUT I

CODE EFFECTIVE ON SERIIL NUWBERS

6901 11100 THRU 111(9

Revised: 28 Wovember 1981 2-5

 ILLUSTRATED GULFS?REAM
SECTION n PARTS CATALOG COM~ANDER
POWER PLANT BBOA/690B

62

P,,~bZ-11

63

7
figure 2-1. Plopell´•r ~nd Dei.ing inrl.ll.tion iShsel 3 ol 3)
2-6
 ILLUSTRATED
ROCKWELL
COMI~ANDER PARTS CATALOG 8ECTION n
BBOA/B POWER PLANT

FI~URt P 1 R T UNI’S VSP~LE

L- L LNJEX D E S C R i P T I O N PER DPi

IIUMBER N U n B E n I z 1~ r 6 7 nssv CODE

2- L b8 )EZOLL-L BRUSH *SSY 1

IbTTbCHING P*RTSI
-L9 SCREW 2
PN960(S insnir 2
*5210*5-08 NUT

70 PE1i50-10 TI*ER´• OEICER 103’,811 L

I4TTbCHING PIRTSI
HSZ1939-L-08 SCREW 4
PN960-IOL kb~niR I
---I---

II LE1157 SHln, BRUSH BLOCK 10)*811 ´•´•´•´•r´•´•-´•-´• 1

72 3E1397-1 DRPCK~TI MOUNT(NG 103*B11 L
73 ~EiB89-Z lllRE HIR~ESS 103*811 3

2-1
 ILLVSTRATED ROCKWELL
SECTION H PARTS CATALOG COMMANDER
POWER BOOA/B

PI
23

21 1 II
2111
15

,I
s II
i

~i(lur´• 2-2. Co*linp

2-8
 ILLUSTRATED
ROCKWELL
COMMANDER PARTS CATALOG BECTION n
690A~ POWER PLA~P

F16URE P P. R T UNITS USILlLE

C D t I 0 R I P T I O N PER ON
INDEX
LUMBER N U M B E R 1 1 3 I 5 h 7 bSSY COUF

2 t 5000 L CO´•L INt I NST LI COMPLE TEl LH 8 RH PEF

1 650001-11 DOOR ISSY´• COwL, LH UPPik I

650001-12 DOOR nSSY1 COWL´• PH UPPER 1

2 650001-43 LUUYER I

3 65000L-2L SKINI LH 1

650001-22 SKIN, RH 1
i a
I t5000L-3 DOOR, in oUrso
650001-51 DOOR, LH OUTED i B

650001-59 DOOR, Ln OUTED rr´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•

i L
1 d
650001-5 DOORI RH DUTBO ´•1´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•

650001-53 DOOR, RH OUTED L BC

5 650001-1 DUORI Ln INtlO ´•´•´•´•´•´•´•´•´•´•´•´•´•i´•´•´•´•´• 1

650001-55 DOOR 1 LH 1NdO ´•´•´•´•´•-´•´•r´•´•´•´•´•´•´•´•´•´•
1 BC
65000L-9 DDORI RH 1N33 1 4

t5UD01-57 DLORI Rn INaO I S

650001-61 DOOR1 RH iNa3 I´•´•´•r´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´• 1 I

650001-23 0OOR1 O1L LEVEL ~CCESS 1-9´• -7, 1

-53 C -55 DOORS ONLY1
I~TTZCHING PbRTSI
7 NSZOZ53PZ-L82 PIN1 HINGE 1
----1---

8 H5U00-´•051-´•102 ´•´•L*TCH 18301*1 1

g e50001-2r HINGE IITTICHES TD OIL LEVEL PCCESS I

DJORI
LO L5UOOL-L9 HINGE IIITIC~ES TO LOWER LUWL UOOPI

11 650001-25 DOUBLER 1-5´• -7, -53 L -i5 DOORS ´•´•´•r L

ONLYI
IZ 650001-31 FK~MCI Ln OUTDO 1-3 C -5L DCOKS LNLY) 1
L50001-63 FnnuE. LH OUTED 1-59 DOOR GNLII 1
690001-32 FR*Mtl RH OUTED 1-5 6 -lj DOORS ONLYI 1

13 650001-33 FRIIEI LH IhBO 1-7 i. -55 OCORS ONLYI 1

FRb*E, Rn INBD 1-9 C -57 DOORS ONLII 1
650001-65 FR~RE´• RH INBD 1-61 DOOR ONLY~ 1

I~ t50001-)9 LOUYER ´•´•´•´•´•´•´•´•´•´•r´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´• 1

15 650001-L) Si(iN1 LH OUiBO 1-31 -5L L -59 DOORS 1

UNLII
650001-15 IKINI RH OUIBU 1-5 L -53 ODORS DNLII I

Ib 650001-17 SLINI Ln INBU (-7 8 -55 DOORS ONLII 1

650001-19 2*IN´• RH LNBO 1-91 -51 L -61 DOORS 1
OHLYI
650005-1 BEPMI LOWER 1 P

650005-501 BCIN, LOWER 1 EC

18 bS000~-L BE*ni LH DUTBD 1

65000*-2 BEIM´• HH OUTED 1

-19 650006-1 BEI\MI LH 11183 1

650006-2 BiPn, RH 1N90 1
L10~20-5DI NlilE Rlht ii SY1 NPCELL El t H L RH 1
I4TTdCHING PdRTS)
ZO iP9146-09 BOLT (D3D381 6
PlN960DID IITHER
21 1N3-bb BULT ´•´•´•´•´•´•´•´•´•´•-´•´•´•´•´•´•r´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´• 13
W*BHER 13

CODE EFFECTIY~ ON SrRldl NUnBERS

Z9~P 11100 THRU I1ZZb
B 6UUP L1227 THRU 113*9
L 6908 11350 eND SUBS

2-8
 ILLUSTRATED
ROCKWELL
SEC~ION n PARTS CATALOG COMMANDER
POWER PWLNT 680A/B

FLLUR~ P ii R T UNITS US*BLE

L INOLX 0 E S C R I P T I O N PER UN
NUMBCR N U n B E a I 2 i 5 6 7 assv CODE

2- 2 22 610120-107 NUSE RING PSSI1 UPPER 1

I*TTLCHING P(RTSI
nSL169"-119 SCIEW L2

23 890375 UtlCtK INSTLI GEUERP~OR INLET ISEE REF

FIG´• Z- 191
ZI 610120-87 SE4L I
610120-89 ITRIP 1
25 610520-103 NOSE RING LUUFR
1SSY, 1
Ibr~lCnlNG P49TS1
-26 nSZ4691-C19 SCREW 10
27 610420-1 SPLICE, LH ´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•i´•´•´•+´•´• 1
bl0S20-8 SPLICCI Rn I
---s---

r-039P-I STUO ´•´•´•...1´•..´•.´•................... 2

28 610420-33 H4r *SSY ´•´•´•´•´•..´•..l....r.......... L
LC-029t-1SS SPRING 1848301 I
S-0310-ll*HT D-RING L
PLUG, URI\IN L
P9 4N821-b ..´•TLE´•´•´•.´• i
30 L10*2D-9L SEIL ´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•i´•´•´•´•´•´•´•´•´•´•´• L
STRIP I
31 ~L0’108-503 G~SKETI UPPER L
32 6L0108-505 G~SKETI LOWER ´•´•´•´•´•´•i´•´•´•´•´•´•´•+´•´•.´•´•´•´•´•´•´• I
33 b50003-L LI~G´• FID LOWL I
31 650007-1 HPNGERI COWL i
IPITdCHING PIRILI
-3r MS2’lb94-5’t8 SLREW ´•´•1´•.´•.´•´•´•´•´•+´•´•´•´•´•´•´•´•´•+´•´•´•´•´•´•´•´•´•. 2

LIULR) FILLET INSILI LH 8 Rn UJIBD REF

36 110183-3 FILLET
1~SY, Ln OUTBU .´•´•´•´•´•r´•´•´•´•´•´•´•´• I
LLO1B)-* FILLET i\lSI1 RH OUTBO 1
11011~ FILLET INSTLI LH C RH IY8U REF
31 110184-3 FILLET *ISY, LH INBD I
110184-4 FILLET nSSY, Rn INaD I
18 9)005)-L CDYER-DUST, ENGINE INLET

2-10
 ILLUSTRATED
GULFSTREAM
COMMANDER PARTS CATALOG SECTION II
600A/B90B POWER PLAEPI´•

i’
24 PI

20I
~"4P II

II

1.0 ieu in

lI
to

I II 20
la 22

se
~yL--31

i,

~isur´• 2-0. rnlin´• Moun~ins

2-11
 ILLUSTRATED
OULFSTREAM
SECTION n PARTS CATALOG COMMANDER
POWlff PLAlrr ssoi~/saoa

FIGURE
UNITS UII~LI
E INO~Y O E 5 C R i P T I Li N PFI ON
NUFIBLR N M L P I i 5 6 1 niSr Cuil

2- 3 610’)9( POUER PLIINT INSTLI LH S RH REF

620001 .nouhlr 1NSTLI ENGINE, LH t i~H.......... REF
L 6~0091‘505 I SOLITOR llOI´• UPPER I
(*TTICHIHG PLRTS)
2 1N176~1)L BOLT
*NPbOC(116 UISHER
2)52-06) NUr´• BLRREL 11)96)1
Z152~061RET RETIINER, BIRREL NUT (11962)

3 Ln-831-1~ BOLT I1Lf PIRT NLS1)IDH~III 17b0051

ISEE NOTE BELOY)
I Ln‘831~L3 UISHER I1LT PIRT WS1000ZCI) 1760051
IPEE NOTE BELOV)
5 620091~501 BRICIEI, LH I
d ~20091‘503 8RICUET, RH I
I~TTPCHING PIRTSI
I Ln-831-ID BOLT 17b0051 L
B Lll-831-ll UISHE R 116005) I
r.´•

---I---
9 620091-1 ISOL*TOR 1SSI, SIOEI Ln RH P
10 620090-1 RETIINERI ROUNTI BIOE
I*TTICHINb P*RTS)
11 111181~111 BOLT 3
2652-06) NUT, BIRREL r I~P621 1
1)52-O6IRET RETIINER. BIRREL NUT (129621 3

IZ IIOLlTDR 1PSI, UPPER 1

IITTIFHING PIRTII
13 1N116~L31 BOLT ´•.´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•r...........

INP5OCII6 UISHER 9
Z)52~0b) NUT, BIRREL (729)21 I
Z)S2-06)RET RETIINER´• BIRREL NUT 1119621
---I---
-1( BOLT i.......´• I
-15 n920001-C7 U*SHER ´•´•´•.´•´•II´•´•´•´•,´•´•´• I
-16 620091-511 BRLCIET. LH ´•´•´•´•´•´•..´•´•...´•´•´•´•r´• L
-17 620091-513 BRICKET, RH L
(ITTICHINC PLRTSI
18 NbS561-31 BOLT L
19 N520002-7 ..´•YLSHER L
---1---
20 620091-509 ISOLLTOR 1551, SIDE´• Ln C RH 2
21 610099’1 RETL~NER´• I(OUNr. SIDE ´•´•´•´•´•´•.....1´•´•´• 2
I*TTLCHING PIRTSI
22 BOLT 1
Z)SZ~Ob( NUr´• BIRREL (129611 3
2)52-06)887 RETIINER1 BLRREL NUT 1129b2) 3

620089~1 nOUNT, ENGINE, UPPER I

(ITTICWING PLRTS1
26 INLI~-lbl BOLT
IN960CI16 HISHER 8
N6ZIGIINI NUT
---il---

11011

Mounting parts may be replaoed as long as ~ill parts on any

one engine are made by the same vendor. Index numbers
-lihru -11 are made by Lord Mfg. Index -12 thm -22 are
made by Barry Wright Corp. me rear mounts, an engine
firewail, are interchangeable.

LM-831-12 bo~t must be used with LM-831-1S washer and

NAS141DH-14 bolt must be used ~UI MS20002C7 washer.
Do not use MS20002C1 washer with LM-831-12 bolt and
do not use LM-831-13 washer with NAS147DH-14 bolt.

2-12 Revised: 28 November 1984

 ILLUSTRATED
ROCKWELL
COMMANDER PARfS CATALOG 8ECTION n
BgOA/B POWER

FltUkt P 4 R T UNITS USIRLE

L INJEX 0 E I C R I P T I O N PER DN
IUHBER N U n a r
s I 2 3 5 6 I assr CODE

2- 3 25 620138-1 STRUT ~SIY. CDnDLETF. LUTED 1

16 LZOlo~-531 1SIYI CO~PLETEI IHBD 1
IITTICHING PP9TSI
Il 4NL76-204 a3LT 1
I\N96OCdib *ISHER
EIS2Lo*)N6 YUT 1
---t---

28 HFX-6G RDD ENO 1731341 L

I~TTbtHING PIRTZI
NS1656~-Zi PINI ROLLI ROLL L

29 N*5509-6 ´•´•´•CHCtKNUT 1
lO 620117-1 *NCHURI LH OUTID 19LT Pah~ I
o2010T-50l)
620107-2 PNCHO~I Kn OUTBO I1LT Ynir L
bZ010T-50LI
31 LZOIO6-L ..4NCHOR, Ln INBD IdLT P4RT L
bZ0106-5011
620106-2 ..4NtHOR, fiH LNBD li\Li PIRT 1
bZ0iO6-5021
IIITI(HI~G PIITS1
32 *N17*-lb BOLT I
dN960L116 IbjHtR I
MS21DlrN* UT 2

)3 b20088-50L NOUNT. EN61Ntl LH L

31 62IOd8-502 YOJNTI EhjlNEI RH L
I4TTnCHI~G PIRTSI
4NL7l-Zlb BOLT
i\NP60tilb ill\SHER B
~iZIJll-I NUT I

620124 IhSTL´• ENGIYtl *FT REF

620125-503 LIN~ ~SSY1 4FT RDUUT
35 b20125-3 LINK i
3a 620091-519 *OUNT. *F T I STIKED I L
620125-509 .IIYX 4iBYI 1FT YUUNT 1
)I 620125-3 LINL I
js 6ZoOYI-5L4 IOUNI 1
ilFT (STIKEOI 1
I~TTbCHINt P?9TSI
39 dNb-i71 ~OLT I
nN96U-t16 II4SHER
nS2LOI2-b ~Ui

10 b200I2-l FIITING i
41 62012*-3 BRICE L
LNL--~71 JOLT I
13 NIS75-h-005 BUSHING Z
64 4N960-616 *d~*ER 1
15 *5210*~-6 NUT L

2-13
 ILLUSTRATED
ROCKWELL
SECTION n PARTS CATALOO COMMANDER
POWER PLANT 690A/B

~iQ

´•\-r.~

1
L~

~iours 2-4. Ingin´• Elh.urt.nd ~ir´•lhi´•ld

2-14
 ILLUSTRATED
ROCKWELL
COMMANDER PARTS CATALOG SECTION n.
GSOA/B POWER PLANT

FIGURE P R T UNITS USPBLE

r IN~EX D E I C R I P T I O N PER ON
NUMBEL N U M B E K I Z 3 15 6 7 PSSY CODE

6i0II4 POUER PL*NT LNSTLI LH 8 RH REF

1 b104L7-513 T*IL PIPE bSTY, LH i as

bIOIL~-511 TI\IL PIPE *SSY1 RH I nY

610017-1 .IPIL PIPE 1SSY. LH i t
610647-2 TPIL PIPE *SSYI KH I C
I~TT4CHLNG PdRTSI
2 152003~-1 BOLT is
nN960C4LI WISHER ´•´•´•´•´•´•´•´•1´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´• is
WS20500-428 NUT iii
---r---

24 610632-503 RtSTRblNT aSSII T4IL PIPE L

I~TT*CHING P4RISI
NbS5~0nK3-1 SCREW 2
MSZ0503- 103 2 NUT 2
---i´•---

ZB 610111-*9 ELB~W IS SY I LH i PB
610417-,0 eLdOl 455Y´• RH i as
610b*7-5 ELBDW PSSI, LH i C
110647-6 ELdUL eSIY´• RH 1 C
20 610*17-5L tLdU31SIYI LH 6 KH L de
610647-3 ELBOW ISSYt Ln C RH i r

20 610417-55 SE4L ´•´•´•´•´•´•.´•´•´•´•´•r´•r´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´• I PH

610617-15 SE4L i C
3 6~0001 FIREWPLL INITL (itE F16´• Z-4LI REF
660004 StdL INSTLI TdlLPIPE RtF PB
LbD007 SEPL InSTL. TdLL PIPE PIEF C
C 61000*-9 IE4L ´•´•´•´•´•´•´•´•´•´•´•.+r´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´• L na
660007-7 SEnL I c
I~TTPCHING P4liS1
5 U88C-1185-55 CLdnP (9’t58LI i P6
UHLlC-II32-5S CL*RP (9*581) Z C
---t---

6 bI000*-5 COLLPR L dB

COLLPRI iH L C
660007-6 COLLbR. RH L C
7 660004-3 COLLPR 1 bB
COLLIRI LH ´•´•´•´•r´•´•´•´•´•´•´•´•´•-´•´•´•´•´•´•´•´•´•+´• 1 C
6b0007-4 COLL*R´• RH i C
I*TTLLHING P4ITZI
8 ~N3C41 BOLT I
dN960C10 Id~HER 1
1N4C3* BOLT 5
dN960L116 WPSHER 5
---li---

260025 NnCELLE ~SIY bNO INSTLI LOWEP (SEE FIG´• REF

2-il1
10 610418-1 SHROUD iiSSY1 T1ILPIPE´• Lh............. 1 ii
610418-2 SHROUD aSSYI TPILPIPEI Kn i
b10~18-505 SnROUJ bSSY, TPILPIPE. Ln I B
6L0(LB-5D6 SHROUD bZSY1 TIILPIDEI Rh I
610416-)07 SHROUD dSIYI TdIIPIPE, LH L C
610118-508 SHROUD nSSYI TPlLPIPEI KH.´•´•´•´•´•´•´•´•´•+´•´• i C
P~ITS1
II I1N*C41 BOLT 16
dN961L4L1 k*IHER L~
---n---

CODE EF1ECTIYI ON SERIIL NUMBERS

P 6906 L110~ THRU 11132
8 ~90P 11133 THRU 11319
C 6906 11350 bNU SUBS

a-15
 ILLUSTRATED
ROCKWELL
SECTION II PARTS CATALOG COMMANDER
POWER PLANT BOOA/B

F16URt P R T UNIIP USLBLE

C INDtX O E 5 C P I P T I O N PER UN
NUnBEH N U M B t R L Z 3 9 5 b 7 *ZSY CODf

2- 5 FIRESHIELD INITL´• UPPER NPCELLE, LH L RH REF

12 660000-3 FLRESHIELU PSSY, LH ´•´•r´•´•´•.´•´•´•´•´•-´•´•´•´•´•´• L
h6000D-* ~IRElnlELD 1159’(1 RH ´•´•´•´•´•´•´•´•´•´•r´•´•´•´•´•´•´•´•
1
260029 SE4L INITL REF
13 260029-3 PLI\TE L
ii ZLOo29-5 Itdi L
15 MZ)5*89-L GROYMET I
16 660000-5 FIBESHIEL3´• LH L
660000-6 FISESnlELJ, KH 1

a.ls
 Y
i dSj ik

i ~p´• s,

ii

Ip-´•
 ILLVBTRATED ROCKWELL
BECTION n PARTS CATALOG COMMANDER
POWER PLAhP~ Bg0A/B

FIijURE P i\ R UNITS US*BLE

E INDEX D E I C R L P T I O N PER ON
nUMdER N U M B E S L 2 3 C 5 6 T nSSY CCDE

L1019L POWER PLnNT INITLI LH 8 XH REF

640062 DUCT INSTLI GENERPTOR nlk INTIKE REF
L NW2k25-12-1B-6 DUCT loj3P91 L
I*TTLCHING ´4RTS)
Z n535812-14 CLIMP Z

3 L*00bL-1 t JUCT PSSI L

IbTTICHING PIHTSI
n527039-I-07 SCREW 2
*N960-L0L WISHER ´•´•´•´•´•´•´•´•´•´•´•´•rl´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•
2
---t---

5 640063-50L SHROUD ISSY 1 d

t~*0063-503 SHROUD PSSY L BL

(ITTICHING PdRTSI
n5358~Z-lb ´•´•CLIHP 1
---t---

b10’120-501 NOSE RING *IIY´• NICELLE ISLE F1G´• 2- 2) REF

7 610520-rl BOOT ´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•1
I
640060 DUCT INSTLI GENERiPITOR PLR UUT REF
8 640061-L DUCT *Sil.........´•.... .r..´•.´•..´•´•. r I
Y b40055-91I STIRTER GLNER*TORI DC IILi P*IT L
6)0055-11 (RFPLPCEI 640055-LI
I*TTLCHING PIRISI
LO HSZL0IIN6 NUT ´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•-´•´•´•´•r
b
IIN9b3-bl~L WISHER ´•´•´•´•´•´•´•´•.´•´•-´•´•´•´•´•I´•
6

30300-1284 IRUIHI GENER4TOR l)L4351

LI 23(165-12Lo BLOCK, TERMINIL 1~1115) I
12 23065-504 *UUNTINE *DIPTER KIT IP1135) 1
13 ~5913L-01 GbS*ET ´•´•´•´•´•´•´•´•´•´•1´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´• L
14 610194-7 PUnP ISSY1 HIDRbULlt 1WITn FITTLNGSI I
L5 IN8I5-6D UNION 1
16 S-0310-90bR O-RING L
-1T PNB15-10D UNION I
Is I-031o-910R O-RING L
L9 HSPOB22‘40 ELBDW L
20 790332-501 PU*PI HYUR*ULIC (LEES FIrTINGII ´•´•´•´•r 1
I*TTICHING P*RTSI
21 MS2LO~*NS UUT 4
dN96~-5ihL IISH~R I
----I----

22 GPSKtT I
89L25L-2 IUIPTERI TUIPUE PRESSURE 1591931 L
IITTl\CHINC P*RrSI
2* HSZIIT9-08 DOLT 3
nN960C10L WISHER 3
---I---

-25 S9413-ULO D-R ING I991931 Z

26 850287-L TnCHHnEETR-GGGNN*TOO ..´•´•r´•´•´•´•´•......´•r
L
IITTICHLNG PIRTSI
nS21083C4 NUT 4
nN9~0‘l1bL hi SHER 4
---i~---

-2~ NI: NUFIBER NUT ILLUSTRITED i.................. 1 NP

is 610)L7 T*IL PIPE iiSSY IIEE FIG´• Z- 41 REP

CUDE E~FECTIVt ON SERLIL NUnBtRS

6901 11100 THRU 11114
B 6904 1117) THRU LL3~9
C 6908 L1~50 TnRU L1599

2´•18
 lLLUBTRATED
ROCKWELL
COMMANDER PARTB CATALOG SECTION n
BOOA/B POWER PLA~P

i tl /1

k-’

to

t e

B C

1~"’ k
i\ k a

~pg-(l ~Y,, , a

´•´•~´•I

~igure 2-5. Engin´• Alr´•mbly ond AIl´•rrori´•l (Shoet i or 3)

2-is
 ILLUSTRATED
ROCKWELL
SECTION n PARTS CATALOG COMMANDER
POWER PLANT 880A/B

FIGURE P 1 R T UNITS USIBLE

C INDEX O F 5 C R 1 P T I O N PER ON
NUMBER N U M B E R i 2 3 5 b 7 PSSY COOE

2- 29 156265-7-2 Y*IVE bSSY, THERMPL RELIEF 1991931 I

IREPLILEE 1)6161-1-11
I~TTPCnlNG PIRTSI
nS21919HI9 CLIMP L
ICRErl 1
NnS43HTB-52 SPICER I
nN960-10L WISHER L
MS211*4N3 NUT .........r´•´•..´•.................... L
---I---

30 610*95-1 LNGIUE 1SZI. TURBO PROP I D

IStE TPt331-5-Z5iK ILLUSifi*TtD
P4RTI BREPKDOWN FD~ R*L*hCE OF
ENGINE PbRTf)
610495-501 ENGINE PSSY´• TURBO PROD L F
ISEE TPE331-5-2S1K ILLUSTLITEU
PIRTS BRE*KDDUN FOR B*LINCE OF
ENblNE PPRTSI
b10195-50) ENGINE 1SSYI TURBO PROP 1 FG
ISEE TPE331-5-251K ILLUSTRITED
PbRTS BHEnKDOWN FOR dbLnNCE OF
ENGINE P*RTSI
610195-505 ENGINE 1SSYI TURBO PROP I n
ISEE TPE331-5-ZjZ1 ILLUSTRITEO
PIRIS BREIKOOWN FDR BIL*NCt OF
ENGINE PPRTZI
II d93528-3L FUEL CONTROL 15 IY 199 L r3 1 I GJ
893161-1~ FUEL CCNTROL *SSY I991931 I
I4TTICHING PIRTS1
32 521-611-900’t NUT 199 193 I
dN9bOt~LLL WISHER

33 693939 INSULd~OP´• FUEL CONTROL (491931 I

3* S9~12-02R O-RING 199193L 1
35 891196-1 COUPLING 191431 I
36 SP*1Z-OL) O-IING 199 193 I L
37 BUSH INGI O IL F IL TER 199159) L
38 896233-1 CPP *SSYI OIL FILTER IY91Y31 I
-35 59413-519 ~-RING 1991931 1
10 76149 ELEHENT´• O1L FILIER (99L93) 1
*L 5901It21 *I~HER 199I9lI L
12 89*117-2 40nPrtRI 31L FILTER 1991931 L
IPITICHING PIRTSI
13 MSIL0LJ-C NUT 3
II SB191-40C NUT 199 L9 3 I r 1
4N960CllbL WISHER 4

*5 59413-LL5 U-HING 1991931 1

la SYC13-Z31 O-RING (99193) 1
IT 895*Y0-3 GOVERNOR ~JSI, PROPELLER SPEED I GJ
IREPL*CEZ 895490-11 lY91931
lP5490-5 GOVERNOR 455Y1 PROP 1941931 1 H
I~TTbCHING IIRTZI
n521043-5 NUT ......´•´•.´•´•´•r....´•.......´•´•´•r.... 4
*U9bOC516L WISHER r.´•................

CODE EFFECTIVE ON SERIPL NUMBERS

D 6906 L1100 THRU IIZZL
E 6904 L1ZZr THRU 11322
F h9~n 1132) THRU LLS*P
G 6900 11350 THRU ILlt3~
blO8 L1132 THKU 11541
H 6908 11431 THRU 11131
6958 iljlj THRU 11599
j E 6908 11100 THRU illi9

2´•a(l
 ILLUSTRATED
GULFGTREAM
COMMANDER PARTS CATALOG SECTION II
680A/BgOB POWER PLANT

J
I-;
311
~1
bC n

II

J?

1?,

1?
~B
figure 2-5 rngine e~llsmbly and *rrelrorisr(Sheet 3 of 3)
2-21
 ILLUSTRATED OULFSTREAM
SECTION 1I PARTS CATALOG COMMANDER
POWER PLAPFP BllOA/BOOB

FIGURt P n R T UNLTS USLHLE

C INOEX O C 5 C R I P I i ii N PER ON
hUnBtR N U n B t- 1 2 p i i 6 7 assv coot

2- 5-68 869888-1 GISKET 19919)1 ´•´•´•´•´•´•´•r´•l´•´•´•´•..´•´•´• 1

)9 8’)5)81-2 VILVE, PROP PITCH CONTROL II(LPL(CFS 1
895)81-11 1991931
(ITTLCHING PIRTSI
1(521280-09 BOLT 3
IH9bO‘)L6L +´•UIIHER 3
---t---

50 GIIIET 1991131 ´•´•´•´•´•´•´•´•´•´•´•´•1´•´•´•´•´•´• 1

51 919P80~6 .t VILVE´• INLET INTI-ICING 1’)91931 ´•´•´•1´• L
IPTTICHING PIRTII
159500-D) BOLT 1
58L57N2B1-D32 UISHER (991931 3

52 868962-2 IGNITION UNIT (REPLLCES 868962-11 1

199193)
1*ITICHING PLRTSI
W12L119~L1 BOLT
I8157N52-290 YI5HER (99193)
---t---

~53 LE*OI IGNITION (PP1931 1

-51 369816-9 LEIO´• IGNITION I
55 39(210~) vilLVe. FUEL SHVTOFF 199LP31 L
(ITTICHING PIRTII
BOLT 2
LHsbOC)16 Y*5HER
)1121119-1)5 BOLT I
125´•617-9001 NUT 1991931 L

56 IENSOR, INLET TEIIPERITURE 199193) 1 DE

893581-8 IENIOR 6551, INLET TEIIP 1991931 I FG
869169-1 SEH5OR aSSI´• INLET rEnP (9’)193) 1 n
I*TTlCHING PIRTS)
)IPZ1219-ll BOLT GJ
58111HI)I-032 YISHER
L9919)1 GJ
B~IIBP-L ´•´•BUSHrNG´• INIULIT(IR (9919)1 GJ
nS21288-08 BOLT IRH UPPER) 1 H
nSZ1279-LI BOLT (RH LOWER) ´•........1´•.´• 1 H
*521279-OB BOLT (Ln UPPER C LOUERL 2
*521219-06 BOLT (LH CENTER) ´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•1´•´•´• 1 H
59011F23-035 UIJHER (LH CENTERI (991’)31 .´•´•.....1. L H
SB157NII2-03Z ´•´•YLSHER 1991931 9 H
861789-1 BUSHING´• INSULITOI 1991931 H
---1---
51 6*SIET 1991931 L tJ
893307-1 ´•´•INSULITOR (e9L’13) L n
58 8)7935-1 VILVE´• DIL FILTER 81PL55 1991931 I
IL.rTLCHING PIRT91
n52L~79-0) BOLT L
IH960CI0L ´•´•UIIHER I

19(13-016 O-RINb´• I HBD 19919)) I

5’1(13-01~ O-RING´• OUTED (991’13) I
60 869601-) YILYE 15111 OIL PREISUIE REGULITING L
IP’)I9)I
(*Tr*CHINC P*RTSI
NS9)90-0b BOLT L
nH960C)16L ULIHER L
---t---
~61 Ss*Ll~Olb O~RING´• I NBD 1991931 L
P9)L3-01( t PRING. OUTED (9919)1 L

CODE EFFECTIYE ON SER I LL NU*IBERS

D 6901 11100 THRU llZZb
E 6906 11227 THIU 11322
F 6901 11323 THRU 11)~9
G 6908 11350 THRU 11910
6908 11)32 TORO
H 6908 11131 TORO 11)31
6908 11513 THRU 11599
J 6901 C 6908 11130 TORO 11~9P

2-21 ilavisi:li: aH 1984

 ILLUSTRATED
ROCKWELL
COMMANDER PARTS: CAT~LOO SECIION II
BsDA/B POWER PLANT

FIGURt P 4 R T UNITS US*6LE

C INDEX O E 9 C 9 1 P T I O N PER ON
NUMBER N U M B E R L 2 D 9 5 b 7 ISSY

Z- 5 62 319974-1-1 V~IYE OIL YENT 1991 93 1 L

I4TTICHING IbRTSI
MS169*5-i9 SCREW 3
4N96OL6 WISHER 3
13413-628 D-RING 11~1931 3
---I---

63 19413-022 3-11Nj 199L931

64 156120-2-1 COOLER *SSY 1
65 n96417-1 OIL IPNK *ISY 1991931 I
(ITIICHING PbRTSI
YS9490-06 ODLT
IN960CILbL WISHER Z
H521043-4 NUT L
~51490-0h DOLT I GJ
MS9*90-01 HOLT 1
PN960C"16L WISHER
525-617-9053 N UT (991931 1 H

66 39)390-1 Y*LVEI FLOW OIYLDER 1991931 1

IPTTICHING PbRTSI
MZZ1~79-LI HOLT i
---i´•---

~T 369949-1 PLUGI IGNITOR 1991931 2

68 362-509-9002 GISKET 1991931 2
b9 865853-2 WISHER, IGNI’OP PL:IG (491YI) 2
ii) 895380-3 TUIUUE LlnllER ilSSY IV419JI
InlTPCHING PIRISI
HS9489-04 DOLT 3
4N160CloL WISHER 3
---I----

ii 866533-3 TUBE 4SSY1 ENGINE Oil ISEE RtF

Fic. 2- II
IZ 855139-5 FUcl FILTER 1991931 1 GJ
73 865791-* ELE~eNTI STRIINER 199193) L GJ
74 891*36-L VILYE
*SSYI 9NTI-I~F FUEL 1991’)31 L GJ
868558-1 YPLYti INTI-ICE 1991411 1
15 893742-1 PLUG´• N*GNETIL 1991931 L
76 59*12-558 O-RING (991131 1
71 869245-4 VIILYF ISSIt PROP 159193) I
(1TTbCHING P4RTSI
HS9489-09 BOLT Z
*N960C1OL WISHER 2
----t---

260043 ~LL ~DOLtR LNSTLI LOWER NPCELLE REF

18 610423-1 OIL CCOLER L
(blTICHLNG PdRISI
IlS27039-0810 ICREY IFW31 L
4N960C8 WISHER (FWDI P
MZZ703’-I-L3 SCREW (PFT) ´•´•´•´•´•´•´•´•´•´•1´•´•´•´•´•´•´•´•´•´•-´•´•´• Z
4N960D10L WISHER (*FTI
----n-----

79 IN92*-I NUT 2
80 4N832-8 UNION I
-81 5-0310-4081 O-HING Z
IZ 800323-503 SWITCHI BEiI PRFSSUKE (HtPLILtS L
800323-5011

CODE EFFECTIYE ON SEKIIL NUMBEHS

b 6908 11350 THRU 11430
b90B 11’32 THRU
J 6904 L b908 L1100 THRU 113)9

a-as
 ICLUSTRATED
ROCKWELL
8ECTION n PARTS CATAL~OO COMMANDER
POWER BOOA/B

FIGURE P R T UNITS USIBLE

8 INDEX D E 5 C R I P r I O N PER ON
NUMBER N U M B t n I 2 s r 5 a I arsv coot

z- 5 610*9*-5 PUMP diSI´• UNFEbTnER 1 K

P~AP *5SYI UNFELTnER i L
83 IY028*-L PUnPI UNFEITHER 1
79028$-501 PU~P´• UNFEbTnER 1 L
IbTT*CHING PIRTSI
bN503-~16-R SCREW
1N960-416L WPSHER C
---li---

1Nllb‘*D ´•´•NIPPLE i
n620822-1-10 ELBOW 1´•1´•´•+´•´•´•´•´•´•´•´•´•´•´•´•.´•´•.´•........ L K
nNBL6-h0 NIPPLE 1 K
nN853-h ELIOW +´•´•´•´•´•´•r´•´•r´•´•´•´•´•´•´•´•´•´•´•´•´•.´•´•.´•´•. 1 L
S-0311-90b RING, BPCKUP 1 L
f-0310-90LT O-RINC ´•´•´•´•´•´•´•´•.´•´•r´•´•´•´•´•´•´• L L
PNL~89-6 NJi I i
NPSL56~01-’ REDUCER I
11818-60 NUT L i
INB15-~U UNION 1 L
5-0310-9067 U-RING L
8* 610618-)01 ndNIFULU PTSY, IGNITION COULING 2 C
I*TTICHING P4RTSI
85 nS21919H16 CLPMD I C
86 MS21919Hb CLI*P I C
81 PN3-3* BOLT ´•´•´•´•´•´•´•´•´•1´•1´•....´•´•............... I C
*NPbO-LDL WLSHER ILOWEI *TT*CH POINTI I C
nN960-10 I1SntR (UPPZR i\TTl\Cn POINT) 1 C
MSZL042L9 NUT (LOWER PTT*LH POINT ONLII i C
---i~---
88 5*0091-5 SUPPORT PSSI (let FIG´• 2-lil RtF

CODE EFrEcTIVE ON SLRI*I NUMBERS

C b908 11)50 THRU L1599
K 6901 11100 THRU 11104
L 690* G 6908 LL)05 THRU 11199

a-a4
 ILLUSTRATED
ROCKWELL
COMMANDER PARTS CATALOG SECTION II
BOOA/B POWER PLANT

I´•: II
i ii
j.´•
B
1\ 11

e 42
L´•
Y
3

a
21

´•i

L j
i
s~-31
.-i

24 2

i I´•
i´•,

25
3L1~ i:j \i´•

r-

?i 25

Fi.ur´• 2-6. In~in´• Pipinl in~l.ll.tion (Sh´•´•11 o( i)

2-25
 ILLVSTRATED ROCKWELL
SECTION II PARTS CATALOG COMMANDER
POWER PLANT BOOA/B

FIGURE P L R UNITS US*BLE

L INDEX O E i C R I P T I O N PER ON
NUMBER N U M R t R L Z 3 5 6 T nSSY CODE

2- d 610494 POWER FLINT INSTLI iH B~ RH REF

1 610488-69 HOSE ~SSY´• FUEL SUPPLY IFRUII ENG FUEL L
INLET Tn FITTING ON FIRtWbLLI
(Stt FIG. Z-T FOR PIPING
CONTINUITIONI
L *N919-L5 RFDUCEK ...´•´•´•´•´•´•.´•1................... L
I-D3L0-908F O-RING 1
610188-21 HOSE OIL PRESSURE IFKUM OIL L
PLESS´• PORT ON ENG TO FITTING
UN FIREW*LL1
9000*0-4-50 REITRICTOR 1
S-03I0-9047 O-RING 1
5 610198-105 HOSE *ISY´• FUEL ORdIN IF*UM FUEL PU*P L BC
SE*L DRblN PORT TO TEE bT
CONTROLLER DRIINI
b10*88-129 TUBE LISYI FUEL DRIIN IFRUM fULL PUMP 1 LF
DR41N TO TEtl
iZNBII-I UNION r I
S-03LO-Y04T O-RINI i 8C
I-0310-904HT O-RIG ´•´•+´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•...+..´•...i... 1 EF
7 *NBOC~ TtE 1 BC
4N815-C UNION ´•´•´•´•´•-´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•.´•rl´•´• 1 tF
IITTdCnING P1~711
lN6289-1 NUT ´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•r´•´•´•´•´•-´•´•´•´•´•´• 1 BC
1-0310-904F O-RING I BC
1-0310-90*~7 O-RING I EF
1-0911-901 RI~G´• 1 BL
----I----

B 610488-15 HOSE *SSYI FUEL ORllhl (FROM FUEL 1 BC

CONTROLLER OR*IN TO OYEHBO*RO ORIIN)
610*88-123 HOSE bSSY, FUEL DRIIN (FkOM FUEL 1 EF
CONTROL/PUMP TEE TO OYtKBD*RO
DR~INI
BI 6L048E-L3L TUBE *SIY. FUEL DRIIN IFLOM FULL I EF
CONTROL ~R*IN TO TEEI
88 *N82*-I TEE I EF
4 610188-93 HOSE LSIY1 OIL UIPIN IFRON HYO SEIL L
DR41N TO
OYERBOPRO 3R*INI
10 610488-103 HOSE *SIYI OLL VENT (FROM UIL TINK L
VENT PORT TO UYERHOIRU URPIINI
II 610481-87 HOSE ~ISY´• OIL RETURN IFRUM ^tbR CbZt I
OIL OUTLET TO THERMO VPLVE INLETI
1Z 610488-89 HOSE 9iSY, OIL RETURN IFROM THERMO 1
VILYL OUTLET
INLETI TU OIL TINK
13 6i0488-83 TUY’ PISYI nit RETURN (FKCM THERMO 1
YI\LYE OUTLET TO OIL CLOLER INLETI
14 6L0488-85 TUBE n~SYI OIL RFTURN I~RCM OIL COOLER 1
OUTLET TO THERMO Y*1LYB LNLETI
15 i\N919-L5D REDUCER
S-03LO-910T r O-RING I
blOIBB-9L HOSEI OIL UR4IN (FROM OIi SLUPPEI I
TO FYD COUL OR*IN)
IPTT*CHING P*RTSI
1N737TWZZ CLP*P 1
Ndir391-8 CLPHP 1

11 610488-11 TUBE nSSY~ FUEL DRPIN IFROM COLD STnlT L 1

YnLYE DR41N TO DRIIY MINIFDLDI

COOE EFFECTIVE ON SLRI~L NUMBERS

b b9o~ 11100 THRU ilZZb
B 0904 L 6908 LIIUO THKU LI*JO
C b90B 11432 THRU 11542
bPUB Llc~l THRU LLI3L
F ~YOB 1154) THRU 11599

a-as
cULFSTREAM
ILLUSTRATED
COMMANDER PARTS CATALOG
POWER PLANT
680A/BgOB

C~
i~
iC
u:,
i/

CBEI

~1OYr´• 1-6´• sn0in´• Piping inlt.ll.ti~n (5h´•´•11 ~I a)

2-21
 ILLVSTRATED OULFSTREAM
SECTION n PARTS CATPILOG COMMANDER
POIIZR FLANT BBOA/BgOB

FIGURE P n n i Y~ITS UIL?L-

g INJtX E i C 9 1 P T I Y rEi
NUMBER N U M B E i L i 3 1 a a i ~iir cr:e

2- b-18 610188-~3 HOSE IS5I1 FUEL DRII* IFR3* EN6 DI1*IN L

HINIFOLO TO FITTING ONN’REEYLLLI
19 IY8)2-) UNION 1
(ITTICHING PIRTII
lyet~-´• NUT ´•´•´•´•´•´•´•´•´•´•´•´•´•´•r´•´•´•´•´•´•´•´•´•´•´•´•´•´•...... 1
UISHEII
---1---
2(1 6301)3~bll TUBE LSSI, FUEL DRIINt LH (FROM FITTING 1
ON FIREW*LL THRU HOLE bT Sri
Z)B´•00 IN IFT NLtELLE S(IN)
6)D133-618 TUBE 1SSI, FUEL OlllIH1 RH IFROY FITTING 1
ON FIREYILL THRU HOLE lT ST1
218´•00 IN IFT n~CELLE I~INI
-21 850)19~501 HOSE 16511 BLEED II), INSflUIIEII~ rSEE I
FIG´• 2-69 FOI( PIPING COYTIYUITIONI
-22 llS107bI-IZ ELBON 1
23 *SZ0156-12 FLLNGE IITTICHING HDYE FURNISHED YITH I
ENGINE)
~2) *NBL5‘) UNION
25 11815-8 UNION 1
26 610356-1 OUTLET *551´• Oi(llN ´•´•´•´•´•´•´•´•´•´•r´•´•´•´•´•´•´•´• L
IITTICHIHG PIRTSI
)151)6’)(‘5)8 SCIIEY I

11 6)035)-1 IIINIFOLO DRIIN ISSI, LH 1

610051-501 nINIFOLD DI(*IH ISSI, an............... 1
18 156261-1-2 YILVE ISSI, THER*IL RELIEF (9919)1 ISEE REF
FIG´•
19 610188~101 HOSE *Sll, 1IR INLET (Fr(O* i(l* 1111 t
INLET TO DRIIN *INIFOLD PRESSURE
INLETI
30 1*821-6 ELeou I
slo,aa-,~ TUBE 1SSI´• FUEL ORIIN IFRO3 FUEL FLII* 1
DIVIOER DRIIH TO DR*lN *INIFOLD
32 6L0188-19 HOSE 1SSI, OIL PRESSURE IFIDI1 UNFEITHER 1
PUHP OUT TO UNFEITHER P3PT 3N
ENCINEI
33 610)88-113 HOSE lSSI, OIL SUPPLI (FRO9 UNEEITHfR 1
PUNP INLET TO CHECI VILYEI
3) BL)T~(ITTI´•OL(1‘12 CHECI VIL VE (1I8)I1 L
35 610)88-111 TUBE 1SS*. OIL SUPPLI CHECX VLLVE I
TO OIL T*NII
36 865616-3 SNITCH (1LT Pli(T 80271-3 (090)91 L
(9919)1
S~0)10‘PO(T [1~IIHG I
37 800323-503 SYIICH´• 8E1* PRESSURE (SEE FIG. REF
-38 )1120821-)-)0 ELBOY L
~39 1NB16-6D NIPPLE I
I0 610)88-99 TUBE BLEED IIR PRESSURE IFRO*
1SSI, L
ENG BLEED IIR PORT TO INLET
DEICER CONNECTION)
-)1 blO)BB-IOI HOSE ISSI´• HrD SUPPLI (FR3H FIREYILL 1
FITTING TO HID PUIIP INLET)
~2 6L0(88~71 HOSE 1SSI, FUEL PRESSURE I’RO* ENO FUEL t
PRESSURE POST TO FIREYILL FITTINGI
(3 610)88-95 HOSE lSSll OIL PRESSURE IFsOH TORPUE L
BOSS
PRESSURE PORT TO FIIIEYILL
PRESSURE FlTTIHGI
610)88-91 HOSE LSSI´• OIL VENT IFROM TORPUE BOSS L
VENT PORT 73 FIREYILL VENT FITTINGI

CODE EFFEFTIYE OH SEPIIL NU*BERI

I 6906 111)0 THRU 11226

2-28 Reii~rii: P6 Ro~´•ember 198(

AOCKWELL
ILLUSTRP~TED
COMMANDER PARTS CATALOG SECTION U
BOOA/B POWER PLANT

P 4 H T UNITS USlrLt
8 INDEX D E I C R I P T C N PER ON
NUMBER N U H B t R L 2 45 b 7 nSSY CG3E

2- L 45 610488-109 HOIE PSSI, YYD PYEISUDE I FRUM HYD PUMP I

OUTLET TO ~IPFWIIL FITTINGI
*6 610488-LL5 TJBE liSI, FUEL DRPIY IFYLIEI COLD STeiHT 1 BL
YILYt ISPRI DPPIN TO ORIIN CROSS)
610488-121 TUBE 4SSY, FUEL DBPIN IFHUIl IPR 1 EF
OR41h FITTING TO JH*IN LROSSI
*7 610488-117 TUBE 4111, FUEL DRI\IN IFFOn FkD 1 O
CO~BUSTOR OR*1N Tu 09~1N CLLISI
Is TUBE iliSII FUEL DRIIY IFLUN 4FT 1
COMBUSTOR DRIIN Tj J4blh CROSSI
49 610488-121 TUBE *SSYI FUEL DRbll IFLO* OLPI~ L C
CRSSS TO TEE TO OYERSllnRD UR41NI
50 PN827-4U LLOSS 1 3
51 *N82~-40 TEE .r....´•.´•..´•.´•.....................
I
-52 PN815-4 UNION ´•.´•r´•.´•......´•´•r..´• I D
53 900115 RESTLItTOR i
S-03LO-91)r O-R1"IG ´•´•´•´•´•´•´•´•´•´•r´•´• L
54 692545-1 SOLENOID YILYE 199193) 1

CODE EFFECTIYE ON SERlaL NUMBERS

B ~FS6 L 6908 11100 THRU 11490
C 6908 L1~3Z TnRU IIS’tZ
O 6904 8 6908 llZZl THRU 11)19
E 6908 i I*II THRU L L131
F 6908 11)*3 THIU 11599

2-28
 ILLVSTRATED ROCKWELL
SECTION II PARTS CATALOG COMMANDER
FUEL AND OIL SYSTEMS ssoA/e

i,
I

s,

II
fl,;, ´•c~

Pipur´• i-I. PU´•I Ilnd Oil Sv~t´•nl

2-50
ROCKWELL
ILLUSTRATED
COMMANDER PARTS CATALOG SECTION n
680A/B FUEL AND OIL SYSTEMS

FIGURE P L R T UNITS USdBLE

6 INDEX D E 5 C R L P I D N PER ON
NUMBER N U M B E R 1 Z 3 i 5 L 7 nSSY CODE

2- 7 b303L5 FUEL SYSTEM INSTL REF

1 6302L8 FUEL EOUIPMENT INSTLI INBO T~NKS ISEE REE
FIG´• 2- 81
Z 63031* TH*NS31~TER INSTL, OUTED FUEL TINK8 REF
IStE FIG. 2- 81
6B022’t PIPING INSTL´• FUEL PEF
3 630133-753 nOSE ISSY1 FUEL SUPPLY IFPUH FUEL SUMP I
TU LH WING SKIN FITTING)
630133-659 HOSE asSY´• FUEL SUPPLY (FPON FUEL SUMP 1
rO RH WING SKIN FITTINGI
5 610133-313 TUBE ISSYI FUEL SUPPLY IFRCM LH WING i
SKIN FITTING TD LH FIREWILL FITTINGI
6 630133-651 TUBE PSSY. FUEL SUPPLY LFR(I1I Rn WING 1
SKIN FITTING TO RH FIREU*LL FITTINGI
1 610*88-69 HOSE PSSI. FUEL SUPPLY (ZEE FIG+ 2- ~I REF
8 610188-11 HOSE PSSY. FUEL PRE SSUR E I SE E F 16 Z- REF
61
9 eN832-L0 UNION I
nN9Z*-IO NUT 2
10 4N1~3-10D ELBOW 2
I*TTICHING PIRTSI
IN92*-100 NUT L
nN960CL*1~ WISHER 1

ii 610’t88-II .HOSE.ISSY ISEE FIG´• 2- bl REF

12 800’t’i7 TRPNSOUCER INSTL 15EE FIG´• 2-P51 REF
13 L30133-67) TUBE ~SiY´• BOOST PUMP DR*IN 180057 PUMP 1
TO OYERBOIRU)
L* 630133-351 TUBE nSSYI FUEL OR11N IFROM SUMP I
ECLOSURE TU UNION bT STiZ 209´•151
15 630133-611 TUBE *SZI, FUEL ORPIN IFRLIM UNION 1
IT STP 209.1~ TU OYERBObfiD DRLINI
Id *N83Z-8D UNION ´•´•´•´•´•-´•´•´•´•´•´•´•´•´•´•´•r´•´•´•´•´•´•´•´•´•´•´•´•´•´•´• I
I4TTICHLNG PI\RTSl
~N924-80 N~T I
bN960DLZlb WISHER I
---i---

17 INBZI-RD ELBOW ´•´•´•´•´•´•´•.´•´•1´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´• L

is NO NUMBER FUEL TPNKS INSTL ISEE FIG´• Z-iOl REF
19 630081 YENT INSTL´• FUEL T*NKS lift FIG´• 2- 91 REF

2-31
 ILLUSTRATED
ROCKWELL
8ECTRON II PARTS CATALOG COMMANDER
FUEL AND OIL BY8TEM8 BOOA/B

d-

o a

j/
n

*b

"t

Pi

13 ~a3- 9

~ipur´• 2-8. ~u´•l Equipm´•nt inlt~lllltion (Sh´•´•l i~ol 3)

i-38
 ILLUSTRATED
OULFSTREAM
COMMAM)ER PARTS CATALOG n
BllOA/BOOB FITEL AND OIL SYSTEMS

rItUPlE P d ii T UNITI US~BLE

E IhiOEX O E i C I i T I I Y PEI ON
h~*BEl h U H P ’R L 2 9 9 6 7 e~ll Cojt

2~ B 630315 FUEL SISTE* INSTL IEF

6)0P18 FUEL EPUIPIIEYT INSfLI INBD TLY(I REF
(1301(8 FUEL SUnP INSrL t NBD T1N~S REF EJ
63013) ENCLOSURE IUSTL´• FUEL IJ*P t IELIIED REF
EPUIPWENT
i 61013)-39 PLITE, UPPER 1
2 63023)-)9 PLLTE, LONER I
3 63023(-33 COVER 1SSI I
L30L3(-15 PIN 1ND SIDE LSSI 1
5 63013)‘59 COVEII I bJ
IITTLCHING PIRTI)
t StREY 12
PY96006 UISHER 12
---t---

6 63023)-) SIOE 1HD TUBE *SSI 1

I L)OZJ)~LL OECI´•´•´•´•´•´•´•´•´•´•´•´•´•´•´• L
B 63023(-9 FLOOR ´•´•´•´•´•´•´•´•´•´•´•.´•´•+´•´•´•r I
9 6301)(-2) IIDE 1
10 9000)) CLI*IHELL Z
-11 11535)89-11 5RONnET 1
12 1531189´•19 GRONMET i
13 *135(89-1( GRONIET ´•...´•´•´•´•´•.....´•´•r´•´•´•´•´•.....
SCREY 54
11195006 Y*SHER 5)
~IS *521039‘0808 SCREY 8
1YebODB UISHER 8
16 630218-13 TUBE *ISI´•´•´•´•´•´•´•´•´•´•´•´•´•´•´• ´•´•´•r´•´•´•´•´•´•´•´• L
b30)18-3 +´•TUBE19SI´•´•´•´•´•´•´•´•´• L F
630118-17 IUNP I~PI´• CENTER I R
NO NU*BER IUIIP 1561´• CENTER L CJ
II DR*IN VILVE (*LT P*RT ~75C‘)5NY) L
(s15LLI
18 653012 V*LYE ISSI (LLT PLRT 610161) 2
(IT7ICHING PIRTSI
-19 LN(-(II ..´•BOLT´•´•´•´•´•´•´•´•´•.´•
IH9L00llb U*SHER

-20 S-O~IO-LI)F (I-I1ING ...´•´•´•1´•.´•´•´•´•..´•´•´•´• 2

21 6)0016‘511 LDIPTER L
22 630133-673 TUBE ISII´• 50017 PUIIP )R1IN rlEE REF
FIG´• 2- I)
n*ajf-~o UNION I
S-O)lO-eD)F O-RINC I
-2) INBII-IOD ´•´•NIPPLE ´•´•´•´•.´•´•´•I´•.+.....´•´• 2
25 SU*P´• FUEL CENTER TlNli rllEPLICPS I
630)36-5051
(IrTltntNb PIRTSI
26 1N565*)LBHPI SETSCREU 24
WSZ10*1~L) NUT ´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•1´•´•.´•´•´•´•´•´•´•´•´•´•´•´• 2)
1H9LIID(16 YISHER 2(
---I---

21 630109 1 G*IIET
ZB 630235-507 SCREEN, FILTER L

CODE EFFECTIVE ON IEI(IIL WUIIBERI

1 6904 11128 T~IU 113(9
B 6901 111)0 THRU 11138
C 6901 11119 TnRU 113(9
E 6904 112(9 THRU 112(9
6101 11169 THRU 11349
F 6901 11130 THRU 112)8
6901 L12iO T~IV 11263
J 6408 11)10 1HD SUES

ResiEed: 28 Na\-embr,. 198-1 2-53

 ILLVSTRATED OULF8TREAM
8ECTION n PARTS CATALOG COMMANDER
FUEL AND OIL SY8TEM8 680A/BBOB

’I~

i
ki´•

-Ic,
,k4 is

/IS"

Is

1-8. fu´•l iquipm´•nf inlt.llation (5h´•´•11 ol 3)

2-5(
 ILLUSTRP;TED
OULFSTREAM
COMMANDER PARTS CATALOO SECTION II
FUEL AND OIL~ BYSTENS
BsOA/680B

T UNITI UIIBLE
D E I P 1 I O V PEPI ON
L LND~X
Y 3 E I L 2 i I i b 7 bSSI COOt
NYYBE* N U

29 PVIIP´• FUEL 80011 (ILT DbllT

2. 8-
b30309~50111SEE NOTE BCLOYI
I*TTICHINt PIRTSI
30 11521039~)-36 ICI(EU
1N960D)L6 UISHER

630211 CISIET Z
-)L
)2 630182-501 PLITE 1
(ITTICHING PIRTSI
1H)-6L BOLT 13
33
*121250~0(001 BOLT I
IY9)0D)16 YLSHEI( L)

.3) 6)0t10 GIIIET I

b30110~501 TRINSIITTEER´• FUELI LONER CENTER I 8
35
b)02)0~5(15 TR*nSI1ITrER. FUEL, LOUER CENTER L O

b)0339~50) TRINI*1TTER. FUEL, LONER CENTER 1 EJ

(ITTICHIN6 P*RfSI
1H(´•101 BOLT ´•...´•´•´•´•´•´•´•´•´•i´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´• L~
.36 1H(-5L BOLI.´•.´•..´•´•´•´•´•´•´•´•´• II
1H9b00(16 Y*SHER 12
37 STLT~D.IEIL IIHSTLLL UNDER BOLT HEID) 1)
(915111
ns210))H) MUT 12
---~i---

38 630LIL-lJOI SUPPORT *557, FUEL TR(NNS*ITTER I F

6301(2-50) SUPPORT 113’1, FUEL TRINSYITTER L EJ
(I7TICHINC P*RTSL
39 1H(2HLOI EIEBOLT 10

I0 6302)2-5 PLITE 1 F

6)01´•I~L1 PLlrE 1 EJ
I*TTICHING PIRTSL
1153)20(~2)* SCREW 3

6)02*~-) YLSHER 3
---t---

6302(2-9 ..´•SUPPORT 1
-12 610311 GISKEI´•´•´•´•´•´•´•´•...´•´• L
(3 833006 SYITCH´• FUEL LOW LEVEL NL1HINb I F
630)~9 IUlrcn. FUEL LOY LEVEL YII(NINO I EJ
IITTICHIIG PLRTSI
r(N92)‘6D NUT 1
-I5 I-0)10‘906F O-RING 1

1I 630221.501 PLITE 1 F
630211.503 PLITE I EJ
IITT*CIING PIRTSI
.)I )IH)LI 8OLT ´•´•´•´•´•´•´•´•´•´•´•´•1´•´•´•´•´•´• 12
IN9b00)16 WlSHER 12

-IB 630206 blllET 18

b30))1‘)OL SE LL ICE*ENTEO TO FLINGE 3F 1 F
TRIHS*lrTERI
658-055-002 GISIET L EJ
(9 11025L~I DOOR. ICCESSI FUEL TSINP*lrTEP r SEE I(EF
FIG´• 1-381

CODE EFFECTIVE OH SERILL HU*BERS

B 6901 L113D THRU 11133
D 6901 111)9 THRU 11263
E 6901 112(9 THRU 112(9
F 6901 l12S9 THRU 11))9
F 6901 11000 THRU 112)9
6901 112)0 THRU 11268
J 6908 ll)lD IHD SUBS

The electrical wiring on the 850308-505 Pump is as follows:

Red (or Blaob

BLue (or White) NEOATNE

Reiiied: 28 \lurembel´• 1BM 2-35

 ILLUSTRP;TED OULFSTREAM
6ECTION n PARTS CATALOG CO~MANDER
FUEL AND OIL SYSTEMG 680A/680B

a
8 BD~g
8
8
B
8 t3 B
B g

8
8
a
08 a
O 8
Big
C) 8
8e8

t ~4´•-" a
W

,B,B8 a
a
8
Qg 8_
Fl B a
a
8, 8, a
8
8
8 8
O
8 8
8g8

~ipur´• 21. fu´•l iquipn´•nt inn.ll.tion ilh´•´•1 3 of 3)

2-16
 IPBUSTRATED
ROCKWELL
COMMANDER PARTS CATALOG 8ECTION n:
FUEL AND OIL SY8TEMS
BOOA/B

FIGURE P P R T UNITS USIBLE

INDLX D E S C R I P T i O N PER ON

NUNBE~ N U M B t R L 2 15 6 7 PsSY CODE

2- 8 50 6302)9-501 r~nns*lrrtn. FUPL LEYELI INaO TINKS 1 F

630338-)03 IIPNSMITTER, FUEL LEYELI INRD T4NKS i EJ

I*TlbLnlNG P4RTSI
51 MSZ*b94-5132 sCREW 12

52 030082-501 GIIKET 1
53 b~0082-1 GISKET ´•´•´•´•´•´•´•´•´•´•r´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•

54 110096-101 CUYtR´• ILCESSI FUEL TRbNSMITTER IsEE REF

FIG´•2-3111
55 63031L-50L TR/INsMI TT ERI FUEL LEVELI OUTED TPNKSI 2 F
LH C RH
630310-501 TRbNSMI~TER, FUEL LEYFL´• ilUTBU TPNKS´• Z EJ
LH 6 kH
InTT*tHLNG P4RIsI
56 SCREW 16

57 850*98-503 SIGN*L LONUITIONING U~IT1 FUEL FLOW REF

ISEE FIG´• 2-251
58 850198-505 FUEL FLUWI ENGINE MOUNTED I G
850590-505 TR4NSnl~TERI FUEL FLOWI ENGINE MOUNT~U I HK
850590-513 TRPNSMITTER1 FUEL FLOW. ENGINE MOUNIED I L
IPTTILH~RG PIRTSI
IN899C8-~ BUsnlNG ´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•+´•´•´•1.´•´•´•´•´•´•
I
s-0310-908F D-RING I
---I---

CODE EFFECTIVE ON sERIi\L NUnBERS

t 090P 11269 THRU 11)*9
F ~90* 11100 TnRU 11268
G 690P 11100 THRU LLL55
H 690P 11156 THRU 113I9
J 6908 11350 LND sues
6908 11350 IHRU lIIb9
L 4908 11I10 nNU SUBS

2-57
 ILLUBTRATED ROCKWELL
SECTI~n PARTS CATALOG COMMANI)ER
I~UEL AND ODL SYSTEMB BgOA/B

XP
n

2sl

11U

~igur´• 2-9. ~u´•l V´•nt inll.ll.tion

a-SE
 ILLUSTRATED
ROCKWELL
COMMANDER PARTS CATALOG 8ECTION II
680A~ FUEL AND OIL SYSTEMS

FIGURE P n a r UNITS USPBLE

8 LNUEX O E 5 C R I P T L O N PER ON
NUnBER N U B f R 1 i 3 C 5 6 I *SSY CDDE

9 130081 VENT INSTLl FUEL TPNKS REF

1 610258-19 TUBE 1SSY i
2 BKOMME T ´•1 II
9 630248-41 TUBE ISSY, FUEL VENT
630258-39 TUBE *SSII FUEL VENT
5 130085-5L HOSE L

II\TTI\CHING PdRTS)
PN731TW30 tlPnP Z

TUBE PSSYI FUEL VENT 2

7 dN821-8D TEE 2
30298-)3 TUBE ISSYI FULL VENT Z
9 630085-11 HOSE
(PTTbCHING PIRTS1
*N737TW30 CLIIRP

lo 630298-31 TUBE dSSYI FUEL YENTI LH.............. L

630L18-32 TUBE bTSYI FUEL VENT, RH L
LL L30298-29 TUBE dSIYI FUEL VENT 2
12 S-D327-HC GKOMNET
13 MSZL9190GO CL~bT ´•´•´•´•´•´•´•´•´•´•´•´•.´•r´•´•´•´• r´•´•´•´•´•´•´•´•´•´•´•´•´• 2
IPTT*CHING P4RTSI
bN3-I* 83LT L
lN143-19 BRPCKET .......1....................... i
1N96oDLOL WI\SHER 1
nSZlo*~N3 NUT 1
---n----

lr 6303P3-1 Y4LYC bS511 FUEL VENT CHELK I

15 630085-51 HOSE
16 630085-59 HOSE L
IITT*CHLNG PIRTSI
17 IZN737TW30 CLI\RP I,

18 ELBOW ISSY I
19 630085-73 Y~NT n*ST 1
100201J HtnTER 1859)21 1
20 31888 TERMIN91 1007791 1
21 MSZII1PDGB CLIMP .´•.r´•´•´•´•´•´•1´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´• 2
IITTPCHING P~STS1
4NP5n BOLT I

22 M535*89-17 GROHHET I

t OPTION~L INSTI~LLIITIOII i\NO COMPONENTS

2-58
 ILLUSTRP~TED ROCKWELL
8ECTTON II CATALOG COMMANDER
FUEL AND OIL 8Y8TEM8 BOOA/B

fi I Ij

11
10

~I

~bil I a

j,i

i-

6;

rilur´• 1.10. fool Tonkl lnltolllollon (Sh´•´•11 of 2)

2-40
ROCKWELL
ILLUSTRATED
COMMANDER pARts CATALOG SECTION II
asoa/n FUEL AND OIL 8Y8TEM8

FIGURE P 1 R T UNITS USIBLE

L INDEX O E S C R I P T I O N PER ON
NUMBER N U M B E R L 2 3 4 5 6 7 bSSY CODE

2-10 630315 FUEL SYSTEM INITL REF

1 11016)-1 DOOR, dCCESSI LH SM*LL FWU INBO ISEE REF
FIG´• 2-381
i 170162-1 ouun, ncCt Ss, Ln S’I4LL dFT INBD (SEC REF
FIG´• 2-38)
1lOZ56-L .OL3HI bCLESSI LH LIROE FWU INRD (SEE REF
FIG. 2-)81
4 170254-1 OUOR. dCCEISI in Lan;E aFT 1Nau csEF REF
FIG´• 2-381
OUOHI 4CCESSI in IPRGE 4FT iNBD (SEE REF
FIG´• 2-381
5 633C82-50L GPSKET
630221-50) PLITE
I bJOOBZ-L GPSKET ZL
B 610239-501 TRI\NSMI TT ERI FUEL L EYELI IN10 ISEE F LG REF
2- 8I
9 170259-1 UOORI 4LCiSII Rn LdRGE FWO INBD ISEE RE’
FI(i. 2-381
10 630216 C*P bNO LHP14 ISSY, FUEL FILLER 3
Ii S-0310-231F ´•´•O-iilNG 2
I~ 639299-501 GUbRO, FUEL FILLER 3
I4TTdCiilNG PdRTSI
MSZ*61*-S99 SCREW 9

13 170035-43 D~OR1 *CCESSI OUTHD FWD (StE FIG´• 2-381 REF

14 110035-39 DOOR, 4COtSSI UUTBD 4FT 1SEE FIG 2-381 REF
Il 6303LI-L PLPTT 41SY 2
InTTnCHING PIRTII
*524~91-C19 SCREW i

---I---

LL 63005L-L GdIKET ´•1´•.´•-´•´•´•´•´•.´•´•´•´•´•´•´•

P
11 6303L9-503 INTERCONNECT 19 Ed. FOk S/N 11269 E 14
SUBSI
630319-501 INTERCONNECT L 8C
I4TTICHING PdRTSI
18 900129-82 CLdMP 2
19 630075 6ROM*ET L

ZO 6303L9-501 INTERCONNECT Il En´• FOR ilN 11269 8 4

SUBSI
a16319-sos INTERCONNECT I~ Ei\´• DRloR TO S/N 112681 5 Bt
II\ITnCHING P*R1S1
ZI 900129-66 CL*MP 2
22 nS35489-114 GHOMMET L
---I---

630319-1 INTERCONNECT 12
IPTTACHING PPRTSI
24 4N737TH30 CLIHP 2
25 *535189-103 GROMnlET 2

2Ll 630311-1 FUEL INTERCONNECT 4SSYI in I

630311-2 FUEL INTERCONNECT nSIYI Rn I 1
630311-507 FUEL INTERCONNECT 4SSY. in 1 8(
630311-508 FUEL INTERCONNECT 4P5Y1 RH L 80
IdTTPCnING PPRTS)
27 MS21919D32 CL*HP 1
4N3-5d BOLT
IZN96DDID *4SHER 1
*SZLOL*N3 NUT L

COUE EFFECTIVE ON TtHldL NU~BERS

4 6904 LL100 THRU llZbB
B ~90d 11269 THRU 11349
C b908 L1350 aNo SUBS

2-41
 ILLUBTRATED
ROCKWELL
8ECTION n PARTS CATALOG COMMANDER
FUEL AND OIL BYWEYS BOOA/B

~ipur´• 1-10. Pu´•l T~nb inrtollotion (Ih´•´•l? ol 1)

a-42
 ILLUSTRATED
OULFSTREAM
COMMANDER PARTS CATALOG n:
FUEL AND OIL 8Y8TEM8
6s0A/88os

P 4 R T UNITS USIBLE
FlcURl
C INDEX D E Z C R I P r I U N PER ON
N U H B E R L 2 3 I 16 1 d5II CODE
NUMBER

P-LO 28 630311-9 HOSE 1

I*TT*~HING PPRTSI
900129-82 ..CLIHP 2
19 r´•-r´•´•´•´•´•´•´•´•´•+´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•

---I---

TUBE, LH I 4
30 630)L1-3
b3031L-) TUBE Rn ´•´•´•´•´•´•´•r´•´•´•´•´•´•´•´•´•´•´•
1 4
1

304 630311-17 TUBEI Ln 1 BC

630311-18 TUBEI RH I BC

630311-5 TUBE I
31
63D311-L5 TUBE 1 BC

630261-1 YI\LVE ~SIY, FLLP CHECK ..´•........´•r... 2

(ITTICH1NG PIRTSI
32 *N3-3* BOLT Z

*N960t10L YnSHER Z

33 653050-503 1 YILYE1 CHECK L

I4TT*CHING PbRTSI
34 dN3-I* BOLT Z

bN960tlOL i YISHER Z

MSZLD*5L3 NUT ............´•...´•´•´•´•´•´•´•´•´•´•´•´•´•tr´•´•

35 630262-1 BRPCKET 1
36 630316-1 CLIP ´•´•´•´•´•+´•´•´•´•´•.´•´•´•´•´•´•´•´•´•´•´•r´•´•´•´•.´•´•´•´•´• 2

630087 onalr INSTLI INBb i OUTBO FUEL T*NIS REF

V-LOI ..DRIIN IblCOt OIL*HO** CITYI OKI 4
31
IITTICHING PbRrSI
38 IS2469L-IPS SCREH
-39 630080 G~SXET 1´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•
L

40 630308-501 r FUEL CELL *SSY´• LH SHPLL FWD INBD I

630308-502 .FUEL CELL *ISYI RH I~*LL FHD INBD L

11 630307-501 FUEL CELL 4IZY1 LH IMPLL 411 INBD 1

530307-502 FUEL CELL *SSY. Rn SMbLL nFT INBO ´•´•´•´•t I

42 530080-509 FUEL CELL bOlY. LH L*RGE FHD INBD I

530060-510 FUEL CELL 1SPlt RH LIRGE FHD INBD I
43 FUEL CELL IISY´• LH L*RGE *FT INBD 1

630061-510 FUEL CELL *ISY´• Rn LPRGE *FT INBD I

41 63(1063-509 FUEL CELL IIIY, Ln FWD OUT BD I

630063-510 FUEL CELL LIIYI RH FUD OUTED

45 530064-513 FUEL CELL *ISII LH bF~ OUTED 1

510064-514 FUEL CELL 41511 RH IFT OUTED L

46 830062-511 FUEL CELL 4551, UPP ER CENTER 1
630277 FUEL r*NI INSTLI LOWER CENTER REF

47 630204-503 FUEL CELL 4331, LOWER CENTER L

I~TT*CHING P4RTS1
*NICHLO* BOLT LI
48
49 630051 G*IKETl FUEL LEVEL TRINSHLTTER 2
----I---

50 630077 C*ZKET ISEE FIG. 2- 81 REF

170096-501 COVER, ICCESII Ln FWD IStE FIG´• 2-381 REF
51
52 110099-501 COVER, *CCEEI´• LH ~FT (SEE FIG. 2-381 REF
53 110097-501 COVER, LCCESII LH FWD ISEE FIG1 2-381 REF
5* 170098-501 COVER, LCCESS. LH 4FT (SEE FIG´• 2-381 REF
55 630314-501 TR*NIIITTERI FUEL LEVEL´• OUTED TbNKS REF
ISEE Ftb´• 2- si
630340-501 TR*NSHITTER. FUEL LEVEL, OUTED T*NKI REF
ISEE FIG´• Z- 81
PLnTE 1951 2
56 630332-505

CODE EFFECTIVE ON NUMBERS

6 6906 LLLOO THRU 11268
B 6904 11269 THRU 11349
C bPDB 113)0 *ND SUBS

a-h9
 ILLUSTRATED
CIUbFLITREA~
8ECTION n PARTS CATALOG CX)NIMANDER
FURL AND OUI BY8TEM8 aPoA/sooe

FloURE P 4 R T UNITI USbBLE

L INDEX D E I C R I P T I O N PER ON
NUMBER N U H 8 E R I 2 3 ’t 1 6 1 *SSY CODE

2-10 51 6303)2-503 PL*TE *SII´• LH L

PL*TE bPSI´• RH L
(*11LCHING PLRTII
MIL4691-S18 SCREW
---I---

6301(1-503 INTERCONNECT INSTL´• OUTED T~NKS REF 4

630297-507 INTERCONNECT INIT~´• OUTAO T*NIS REF Et
58 610297-1) TUEEI VENT B
I*TTICHINO P4RTSI
-59 1N731THLL ..~L*HP´• I
60 H135~89-L4 ORnHneT L
---t---

61 630297-15 TUBEI INTERCONNECT 6

IITT*~HING PLRTII
62 900129-66 CLIHP 2
63 HS351B9-27 OROI*Er L
---t---

61 630297-11 TUBE. INTERCONNECT I

I*TT*CHINO PPRISI
65 900129-66 CL*RP Z
66 HS35L89-21 OROHHET I

630303 FUEL CELL INITLI FHO IUX REF

61 8303(10-50P r FUEL CELL ~SII, LH FWD INBD L
830304-504 FUEL CELL 455’11 RH FHD INBD 1
68 L3DZ0B-503 FUEL CELL 15SY1 LH FWD OUTED L
830298-504 FUEL CELL 455*1 RH FWO OUTBO L
530300 FUEL CELL INSTL1 451 IUX REF
69 630301-503 FUEL CELL *SSYI LH LF1 INBO I
630301-506 FUEL CELL 4SSI1 RH *F1 1NBO L
10 530502-503 FUEL CELL IPIYI LH 481 OUTED r....... 1
130302-504 FUEL CELL 1551, RH bFT OUTED L

CODE EFFECTIVE ON IERI*L NUMBERS

6901 11100 THRU 11268
B 6904 11269 THRU 11349
t 6908 11350 *ND SUBS

a-44
 ILLUSTRATED SECTION 1l
ROCKWELL
COMMANDER PARTS CATALOG POWER PLANT
BgOA/tl CONTROLS

Is 151
lu
Ir
i

i p.
B

~m, II

\1
/r
I i

~iour´• ?-11. Po.r´•r slont Control. Inltoll.tlon (Shootl of

2-45
 SECTION n ILLUSTRATED
ROCKWELL
POWER PLANT PARTS CATALOG COMMANDER
CONTROLS
8801\/B

tlGURt P I R T UNITS USI8LE

C INOLX D E 5 C R 1 P T O N
I PER ON
NU*BER N U M B t R L 2 3 4 5 6 1 bSSY COOt

2-11- 540095 CONTROLS INSTL, POWER PC4YT ...´•.´•´•.´•r´•´•´• RIF

1 540138-1 IIIPPRT´• UPPER ´•´•´•´•´•r´•´•´•+´•´•´•´•´•´•´•´•...... I
Z 5*013Y-L IIIPP~RTI LO*EH 1
IbTI*CHING PbRTSI
3 bN3-31 BOLT 2
PN460POLO WLZHtR 2

i 540122-521 CIBLE nSSY, LH L RH CONOITION

1 510IPP-505 i49Lt bZSY´• RH EnERGehiCY L
5$0L22-503 CPBLE ~SSY´• LH L
b 510122-519 Cl~it bSSY1 LH C RH POWER 2
I NSZL9190G7 LL~MP 4
IIT7PCHING PbRTSI
8 MS35207-263 SCREW I
nN9bOD10 WISHcR
H52104CN3 NUT ´•´•´•´•´•´•´•´•´•´•´•´•r´•´•´•´•´•´•´•´•´•.´•´•.......... I
---il---
9 MS27975-4 CLFVLS ......´•.´•r.´•.....´•´•...´•´•........

InTTPCHING PIRTSI
1N23-LO BDLT I
4NPI0-L0L 2
*N320-3 NUT 1
NS2*665-I32 PL N1 COTTER
----i---

10 NP5509-L CHECK NUT 12

Il C6152) CINNECTOR (0ib381
12 IIOl~O-L BRnt~ET, LH I
13 540140-2 BR~LKETI RH -´•´•+´•r´•´•´•´•´•´•´•-´•´•´•´•´•´•....... i
Ii 5’10L16-I IUPPO’IT, CONTROL CIDLE 3
15 5*0L12-1 EUPPORTl CONTROL CIBLE 5
154 550119-1 SUPPORT bSSYt CONTROL CIQLE 3
(4TTICHING P49TSi
n53520~-215 ILREW Z
1N960DB h~SHtR 2
RSZI~**NOB NUT r´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•................

16 nS2I266-CN 2
II 51008L a~LDKnNT PSIY dND INSTL 1SEt FIG´• 2-12) REF
LB 4N3-10 BOLT
-19 nN960-19 U4SHER
20 1N970-3 UISnEH 4
Z1 *N320-3 NUT 4
21 MS2466)- L 32 P IN, COTT ER i
23 900118-50L RDJ ENO 8
24 LHECLNUT
1 12
15 HF-3 84LL JOINT (1313*1 2
I4TT*CHING PPRTZI
16 n521039-1-13 SCREII ´•´•´•´•´•´•;´•´•r´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•.´•´•´•´•... I
*N960-10L WISnER I
MS~L042L3 NUT I
27 I\N31)-3R ChECKNUT 1

)B 9001L3-515 .ROOt PUSH, LH ´•r´•´•´•´•´•´•´•´•´• 1 1\8

900113-511 ROUI PUSH, LH I C~

CODE EFFECTIVE ON SERI*L NUnBERI

P 5904 C 6908 L1100 THRU 11430
B 6908 LI*)L THRU 11542
C 6408 11431 TnRU 11131
O 6908 ilS*) iHRU 11599

a-48
 ILLVBTRATED
ROCKWELL SECTION II
COMMANDER PARTS CATALOG POWER PLANT
GBOA/B CONTROLS

I a 23 !2

-´•/L\/ Y~ ~C21

eT 31
UI

!822

21
a \i 29
39 \P~7 1 33
24

34

U~R

Pipur´• ?-11. so.r´•r Plonl Controll inll.ll.tion (Sh´•´•1? of 2)

a-41
 IECTION n ILLUSTRATED
ROCKWELL
POWER PARTS CATALOG COMMANDER
CO~FPROLS BOOA/B

FIGURE P 4 R 1 UNITS USLBLF

6 INDEX D E S C R 1 D T I O N PER DN
NU*BER N U M B E R L Z 9 15 6 I nS5Y COOf

2-11 29 5F77)L-Z071 .CLNrROL 41ZY1 FMEP’EIICY FULL SHUT-OFF Z

1805211
I*TTICHING P4RTS)
30 M121039-1-09 SLREW L
PI INI-LZ BOLT r´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•.......... i
32 4N970-3 kbSHEH I
LISnER IUIE WITH INDEX -291 ´•´•.r´•´•´•´•´•´•´• L
IN9IO-10L WIIHEL IUlt IITH INDEX -301 2
4N9LODL0 UI\SHEI´•´•´•´•´•´•´•´•´•´• Z
~52LOLZL3 NjT IUSE WITH INDEX -291 L
4N320-3 NUT IUlt WITH INDEX -301 ´•´•´•r´•´•´•.´•´•´•-´•´• i
*SZ16b5-L1Z PIN, COTTER IUSE WITH INDEX -301 L
33 NO NUMBER CnECKNIIT (FdHN IS*ED WITH CL~NTKUL iiZ ZY 1 2
8C NU NUMBER CH EC~NUT I FURNISHED WITn CONTfiOL iiSSY1 2
)5 NG NuMaER (~ECIYIIT (FURNISHED *ITli CONTRUL eszrl 2

36 LL3~C7 RUD END IRH DNLII 1665031 LSEE FIG´• REF

2-I~I
31 4N3Lb-7H CHECXNUT (ATTPCHES CUNTIOL RODS TO 26
IUPPORTSI
38 900139-901 .RUD END
39 4N3-ll BOLT 2
dN9h0-LO WISHEK Z
IN9TO-3 LllniK
RSZIU)IL3 NUT 2
MSZ*6(15-13? PINI COTTER P
CO 550112-L ~EbHING 4SSY
I4TTPLHING P4RTSI
NSZ1039-1-09 SCREW
MS11039-1-I3 SCRtn 1
4N9b0010 WISHtR ´•r´•´•´•´•´•´•´•´•´•´•´•´•´•.´•............... 2
nSZLO~IN3 NUT 2

41 550107-501 PLbTt 2
I4TTICHING P4RTSI
42 MS27039~1-09 SCR El 2
r

PN960010 WdSnER
"lSPIo’tCNl NUT
---t-__

13 550102-1 2
950L00-505 Sjpp0RT IRIPLI\CES 55010’1-5031 2
ISEE NOTE BELOYI
45 550103-1 SUPPOKT 2
C6 5)0115-L SUPPO~T 4SIY 2
IPTTICHING "4R1SI
*7 4N3-C* BULT
~NU60-10 WdSnER I

DlSZLo42L3 NUT

CB 550111-501 BELLCRdNK 4SSY. LH L F

550114-L LELLC4dNK 455Y´• RH I E
550120-501 nSSY´• LH 1 EG
550120-1 ~ELLLRINI 45511 An ´•´•´•´•´•´•´•´•r´•´•´•´•´•´•´•´•´•´•´• I FG
’4RTSI
*9 PN)-*d DOLT
4N160-LO I4lntR 3
*S210LZL3 N~T 3

50 5100s5-5 SUPRRT bSSY, LH L Rd................. I

-51 SSLI1OD-l 43PPTER *II

CODE EFFECTIYE UN ~EKIIL NUIBERS

E 6904 L1100 THRU 11208
F 6901 11109 THRU 11319
G bYDB 11350 PND SUBS

WOll
When replacing 5501(10-505 Bupport with 550100-606 support, order Servios Letter No. Sa0 Bit.

2-48
 ILLUSTRATED LIECTION II
OULFSTREAM
COMMANDER PARTS CATALOG POWER PLANT
BOOA/BOOB CONTROLS

!igl

Yi

figure 2-12 Ouadr.nt inltsllstion (Sheel 1 ol 3)

2-48
Revised: 28 November 1984
 ILLUSTRATED
SECTION n OULFSTREAM
POWER PLANT PARTS CATALOG COMMANDER
CONTROLS BSOA/BI)OB

FIGURE P P R T UNITS USbBLE

6 INDEX O t 5 C i I P T I C N PER ON
~UMBtR N U W B E R 1 2 i i i d 7 liSY COOs

2-12 5’10095 CONTROLS INSTL, FOYER FLINT REF

861885 INTERIOR FURNISHINGS INSTL (SEE FIG´• IIEF
1-651
860967 COVER
I NSTLI PUIDRIHT IEF
1 860968-1 PLITE I FLCE L
8)0968-3 ..´•PLLTE´• F*CE I B
810968~501 PLlrE´• FICE L C
I*TT*CHING PIRTSI
2 SCREY II
---I---
71 Bb0968-JI ´•´•´•´•DECLL´•´•´• I C
3 860969-503 COVER. PUIDR*HT 1 D
860969-505 COVER´• PU*OIIINT I E
IITTICHING Plil(TI)
NISP’II-IIOP Y*IHER
S~0)3)110-LOt ICREY

510082-501 PUIDRINT IECHINISI 1 F

5)0081-505 OUIDRIHT *ECHIHISI 1 G
(ITTICHINC PIRTI)
5 112)693-1~0 SCREY I)

b 21-1010-3 INOB 1011691 2

1 21-1010-) IHOB (011691 ´•´•´•´•´•´•´•´•´•´•´•.´•´•r´•´•´•´•..´•´•´• 2
B PI-1010-5 INOB 101169) Z
9 21-1010-6 ~NOB (011691 2
(IITICHIHG PIRTSI
LO nPZ16s~-L3 SCIEY 1
---I--
II ZL´•1010-I I(NOB IOL 1691 2
(*TTICI(ING P*RTSI
-1L IPZ)69)-50 ICI(EY ´•´•´•1´•´•´•´•...´• I
---I---
-13 21-10LO-I ´•´•I(NOB 1011691 2
1( 11-1010-1 I(NOB 10 11(,91 2
IITT*CHINC P*RTS)
15 )1S1169)-18 ICREY 1
---li---
16 21-1019-2 ENO PLITE 1SSI. Rn (011691 1
IITTICHING PIRTS)
~17 WS1(69(~50 ICREV
---I--
LB 21-101)-3 SP*CER I01IL9) I
LLITICHlllb PIRTSI
~19 SCREY I
---1---
PO IN*H(PI BOLT I
21 IH960-~16L V*SHER 1
22 INS-6)I 80LT 2
ULIHER 2
*120361-52~ MIT Z
-13 PLITE, LOCI I0L1b91 1
1~ 11~1020-11 SPICER 1011191 I
25 11~1020-1 SPICER r01II9)
26 PLITE´• LOCI(0lib91 I

CODE EFFECTIVE I1N SEI(IIL NUNBERI

1 6904 11130 THRU 11319
B 6908 11310 THRU 11(30
6908 11(32 ~nRU 115(2
C 6908 11()1 THRU 11)~1
6908 115(3 THRU 11599
D 6901 L1IDO TRRU 11269
E 690* L 6908 THRU 11599
6901 111PO THRU 1I1BP
G 6901 E 6909 111)0 THRU 11)99

2-50 Re~iird: Yd Noiclnilpl´• i sill

 ILLUBTRPITED 8ECTION n
ROCKWELL
PARTS CATALOG POWER PLANT
COMMANDER
CONTROLS
BOOA/B

I
,9

lo iri ~i I sa

35 5:
v
61
O
as

,1
,S
,I
O

I?
sa I ~o

33

51 8
o I i

j
i

t,, r~w a:

"-~Ji/
ia

Figure 2-12. Ouadr.n~ Inll.ll.tion (Shest 2 of 3)

2-51
 SECTION n ILLUBTRATED
ROCKWELL
POWER PARTB :CATALOO COMMANDER
CONTROLS Bg0A/B

FIGURE P R T UNITS USdBLE

8 INUEX D E I C 9 1 P T 1 O N PER ON
NUMBtR N U M 8 E R 1 2 3 i 5 6 I bSSY COOE

2-LZ- 27 2 1-LD21-3 SP~CtR IOL169) 2

28 SUB-PLITE 4101(011691 I
29 21-101)-8 FRICTIU1( ~ISC (011691 2
30 21-1020-2 SPRING IOLL~91 i
3L II-LOll-I FOLLOWER 1011691 It
-32 21-1~1L-b FDLL3WER 1011~91 i
I~ITICHING PPXISI
-33 21-1011-8 SCREW 1011b41 L
´•´•r´•r´•´•´•´•´•´•´•´•´•´•´•.´•

3~ ii-IOli-9 WnlHCR (OLlh91 i

---I---
35 2i-1011-2 RPM LEVER 45SYI RH IOII69I 1
-~O 21-1015-7 PLPIE, iRLCTION (011611 L
31 21-101)-2 ribN)LE. KH 1011b91 1
38 2 L-LOLI-6 rL 418 I FR ICT ION I OLlhl) i
-31 21-101)-~ LEVER *SSYI RH IOL Lh91 1
’tD IN"LO-RL6L IITHER
11 2 1- LD11-) PLITEI 5TOP
LOLIL~I L
ii i L- i OL1-7 HU UI)LE,FR ICT I ON I OL iblil 2
*3 21-1o17-b PLLlTEl tbi lollb9L I
*4 ~L-1OI2-L 1P* LEVER bS5YI LH 1011651 1
*5 2 1-1013- i HI\YDLE, Ln
1011t~9)
16 2L-LOL5-5 TP~CEF IOL L~91 i
17 ~li1011-3 LEVER nlSY´• Ln 101169) 1
2 L-1014-~ SH~FT IOllb91
4Y PM)41415 SP*14G. OISC IOLib91 i
50 21-1020-15 STOP PSSY IOL16YI L
IPTTICHING PPRISI
51 *I2*691-50 SCREW 1
52 M5i469*-55 SCREW
nN960-LO WPSHER I
YSZ1083*3 NUT L
----i----

53 21-1015-9 FRICTION 31SC 1011091 i

5* 21-1020-1 SPRING IOLlb91
-55 i 1-101L-1 FOLLOWER IOiLh9) i
(PTTPCHING PIKIS1
56 MILb9YI-3I SCREW I
51 iI-IOii-Z NUT IOL1691 1

-)B ZI-LOLd~b LtYER´• LIFT 1011691 I

59 ii-LOlb-2 LEVER n5511 RH (Ollb91 1
21-10Lh-L LEVER PSSY, LH 1011691 1
2 L-IOIL)-~ F Pi\CEfi (011b9) 1
61 2 i-10 i 8- I CI11 PLI\TE i\SSY 1(1 11~9) I
bZ nSLb99~-*8 SCREW I
63 MS90’18-097 PLUI ROLL 1
bL JX*5 ~CTUP TOR I O L 169 I i
e5 Llxl-S8H SWITCn I*TTPCHING HOWE FURNISHED WITH 2
I*I~CH1 IOllh9)
66 ZI-IOLa-2 PLI~E, SWITCH 1011691 2
IITTICHING P4RTZ)
67 NI\SL10U-0b-~ SCREW 1
---ii---

60 21-i0L9-1 SWITCH SEGMENT I01IL9) i

I4TTnCHING P9RTSI
-69 N~SL100-oB-10 SCREW 1
I\NPbO-I( VPSHIR Z
MS:IO*LNOB YUT I

70 21-101~-1 PLITE, ENUI LH IOllb91 ´•´•´•.r´•´•´•´•´•´•~.. 1

71 SCREW 3
Ii nSZL694-liZ SCREW I
-71 Z1-1019-3 ´•´•lnlFT (011691 ´•´•´•´•´•´•´•r´•´•´•´•´•´•´•´•´•´•´• i

2-SZ
 ILLVSTRATED SECTION n
ROCKWELL
PARTS POWER PLANT
COMMANDER CATALOG
680A/B CONTROLS

i
’03 85
80

hhj
ki

116 121

161 I

119

’IY

C´•l ‘Ilo

i;\’’"3
too

Figure 2-12. Ouodrant isheet 3 ol 3)

2-55
 ILLUSTRATED
IECTION n ROCKWELL
POWER PLANT PARTS CATALOG COMMANDER
CONTROLS BBOA/B

FIGURt P 1 R T UNITS USI~LE

8 INDEX D E 5 C B I P T I D N PFR ON
NUnBEL N U n B E a i 2 ,4 5 o I assv CODE

Z-IZ- 71 21-1020-16 SP4CER 1011691 L

76 21-1017-5 CIIY *LI\TL 101Lb91 1
510081 PUIOKINT 4iPY INO INSTL REF
Tb 510093-1 BRICXET´• ~EPR CONTROL
77 510092-1 BIPCKLTI FLIP CONTROL 1
I IT7nCH1NG PIIITZ)
78 MSZ7039-1-il SCREW .r.´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•

4NPIODIo WllnER 2
---I---

540118 t COVER INSTLI CONTROL )UPOLNNT REF

830098 ´•-COYCR INITL, CDNTRII IU4DR~NT RLF IJ
79 549150-1 PLITE, ROUNTING 2
I4fTICnlNG PLRTII
-80 M52469~-54 ZCREI. 1´•´•´• 2
---I---

81 540121-503 LUYER ´•´•´•´•´•´•´•´•´•r´•´•´•´•´•´•´•-´•´•´•´•´•´•´•´•´•´•´• L H

830099-511 CUYtR I
830099-517 COVER
(4TTPCHING PIR1SI
-82 nSZLLP3-LZb SCREW 6

83 5*01Zn-50L BRIICKET 455~´• LH 1

830132-1 3RPCKEI. LH i I
d10102-50L d~4CLtTI iH i i
8* 510124-503 aR4Cn ET. Rn r L
830102-2 JRICI(tT. Rn i
830102-503 YR~CK ET. Kn i J
85 540090-1 ~LITEI iPLICt Z
86 540091-1 PNjLEI iUDPOLTI Ln i
87 5*~091-2 bNGLE, SJPPORT´• Rn L
(ITTPCHING PPRTSI
dB MSZT039-L-lo StRE*
15 MSZ7031-I-LL SC~EW 2
dNP6oD10 WUSHEC
NIZ10*IN3 YUT 4

90 510117-1 P44EL
LITTICHING PPRISI
91 MSZ103P-0809 SCREW PR
dN960D4 WPSHER IR
MIZ104~N08 NUT dP

92 540115-1 LNGLE 1
93 51011(1-1 dNiiE ´•..............´•´•r 1
94 540089-1 SUPPORT I
95 51009~-1 CHINNEL
91 540088-L CHbNNEL, LH I
97 5)0088-2 C~PNNEL. Rn i
98 543087-1 IUPPORT´• SIDE, LH 1 K
540087-503 SUPPOfiTI Ln ´•´•´•´•´•´•´•´•´•´•r´•´•´•´•´•´•´•´•´•´•´•´•´•´• I LM
99 5*3081-2 SdPPORTI SIDE´• RH L K
540087-505 SUIP~RT´• SlDti RH i LH

CODE EFFECTIYL ON NUMBERS

n 0704 L1100 mfiu III)I
1 6904 111*2 THPU iiies
J 6904 LIIBY THRU LLZbd
I 69UI lllOu THRU 11266
L 6901 11269 THRU 113~9
M 6908 11350 4ND SUBS´•

2-64
 ILLUSTRATED
GULFSTREAM SECTION II
COMMANDER PARTS CATALOG POWER
690A/BgOB

FIGURE P 4 R T UNITS UIIBLE

INDEX D E 5 C R I P T I O N PER ON

UUHBEC N U H B E R i 2 3 1 5 6 7 I\SSI CODE

~-12 -100 750239 YhLYE INITL1 GEPR 6 FLIZP CONTROL ISEE REF
Fic´• 2-211
5*0106 CONTROL INSTLI FLIP 4NJ -E*R REF

-LOI S*OOBI-SOL CONTROL PSLYI LbNOINj GEIR L

IPITbCnlNG PdRTSI
HS27C3P-9805 SCR Ell I
-102
4N96008 YISHEI 4

-103 5~0083-L LLNTROL 41111 FLdP i

n521039-1805 SCREW
i\N9LOD6 HIIHER
-ios s~allr-i nou I
-LOb 900113-509 ROU L
-101 900113-1 ROJ L
-LOB 900113-507 ROJ ´•´•r´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´• ´•r´•.´•´•´•´•´•´•´•´•´•´•´•´• 1
-109 4N31b-~R CnEC~NUT .´•´•1...´•......´•´•´•.´•.´•..´•´•..... Z
-L10 MSIIP75-L CLEYIS 7
(PTTPCnlNG PdRTZI
-LII INZl-iO i BOLT L
IN9600LO *I\lnER ´•´•´•´•´•´•´•´•´•´•´•1´•´•´•´•´•´•´• 1
4N3L0-3 N~T I
H12)bb5-13( P1N. COTTER ´•´•´•´•´•´•´•r
I

-llZ 540112-501 ROD ENU I N

540112-503 ROD END 1 HO
IITTPCHING PPRTS)
-LIO PNL3-LO BOLT
PN~(IODLO YPIHER 1
4N310-3 NUT 1
n5~4665-134 PIN, COTTER 1

-111 5*0107-501 4Rn 4SIY1 FL~P CONTROLI UPPER I

-115 110108-501 *RU 4ISYI FLnP CONTROLI LOWER 1
I*rTPCHING P*RTI)
-116 HSi71528 PIN´• ROLL 1

-LL7 540113-L *RMI GEIR CONTROL, UPDER 1

-lls 540109-1 4Rn 45111 GEIR CONTRDL´• LOWER 1
IITTPCHING ’4RIS)
n5111528 PIV, ROLL I

-120 5*0049-501 ~LICKETI RH I

-1Zi BI(ICI(ET I LH 1
I~TTPLHING P4PTS)
-122 NSP7039-L-10 SCREW
bN960010 W*I~ER Z
nS21OI*N3 NUT 2

-1L) N4I4)DDL-iZ SP4CtR L

-LP~ 540111-L PIVOT *flY, GEdlR CONTROL I
-iZS 540110-1 ROD, PL YLT 1
860161 .CUYER OUIORINT
LNITL, REF
-Lsb 7LOI-´•IL IWITCH. PROP SING I093531
lb*5-Z BEIEL´• SWITCH (093j1l

COUt EFFECTIYE ON StRiiii NUHLFRI

69DB LIBW THRU 115’9
6904 11100 IHRU 11121
O (1401\ 11116 THRU L13L9

2-55
 ILLUSTRATED GULFSTREAM
SECTION n PARTS CATALOG COMMANDER
LANDING GEAR 890A/B90B

~J 85

B
13

it
90

"a 1~;i
A I., is

,12

ri
I

r
I\ T´•

I ,1 38

J 88

"a

8igu,e 2-11. M.in L.nding Gror in.l.ll.ti.n (Sheel 1 of 2)

Revised: 28 November 1984

2-56
 ILLUSTRATED
ROCKWELL
COMMANDER PARTS CATALOG n

690A~ LANDING GEAR

FIGURE P e a T UNITS US*BLt

INDEX O F S C R I P T L D N PER ON
NUMBER N U n o c a 1 2 3 r 5 a I assv cnoF

2-13 710015 tE*R INSTLI HIIN L*N0146, Ln REF

710015 GEII INSTL´• HbIN LbN31Nji Rn............ REF
L )00-139-18 ULEO STRUT 4~SY (StE FIG´• L-lll RE~
710025 HHEEL 4ND DRPKE INSTL ISEE FIG´• 2-15) REF
310085-505 LLNX4iE LNSTLI nLG DOORS1 Ln.......... REF
330085-506 LINKbGE IYSILI MLG O0ORSI FH REF
Z 330085-3L RUU nSlli OUTED L
333085-33 ROJ d~lY1 INDD 1
(*TTICHING PLRTS)
3 ~NZ3-13P BOLT ´•´•´•´•´•´•r´•-´•´•´•r´•´•´•´•´•´•´•´•´•´•´•-´•´•´•´•´•´•´• L
dNI~O-IOL WUSHER I
MSZ0361-LU32 NUT
~NZ3-1S BOLT (OUTOD SIDE OF L9NUING CCbRI I
iiN96J-1D UISHEK 3
1N3ZO-3 NUT IOUTBU SIDE OF LINUINS GEIR) 1
niZ~b65-lle PINI COTTER 10UTBD SIDE UF LbNDING
iE~R)
M127031)-1-13 SCREII I INBD 5 IDE OF L IND i NC GL PI I
*N960-10L I~ZHER IINST*LL UNUER BOLT HE~DI INBJ I
SIOL UF LINOING GE~R)
~N960-LO WISHEH IINBU SIDE OF L*NUING Gtd~) 3
---I---

5 5-0382-503 400 tND bNO BE*RING ~SSY1 OUTED

1-0382-501 10D END INO
BE*RIN6 iLSSY, INBD 1
IdTTdCHING PIRTI)
4N3L6-~R CHECKNUT L

HS27975-3 CLEVISI ROD ENO 1

330091-505 nar azsv, rLe DOOR OPE*ITINGI LH
OUTED
33009’1-i0a iiR~ liSSY´• OLG ODOR ]PEKI\TING. RH L
OUTED
)30093-)05 IR* 4SSYI RLG DOOR OPER*TINGI Ln INtlD L
330093-50a bRn PISI1 HLG DOOR OPER9TINGI an INBO L
IITT*CHING
B ~Nb-2* aOLi I
PN960-61bL WdSnER 1
1N31o-b NUT i
nS2C665-ZB3 PIR, CUTTtR L
9 nN*CL3b aULT L
~N960-4L6 UPZHER L
MS2O3t 5-~28 4;1r 1

MSZOZU7DPP1 dEIIPLNt IPRESS FITS INTO O´•TO-IN.. 1

HOLE)
6NCC1312YP BEPRING IPRESS FITS INTO 0.75-1*1. 1
HOLEI (a03801
ZZNOIZ-02 NUTI SPLINE (FOR 330093-505 G -5061 I
1729621
lo 330088 SPRING Z
11 330d85-17 RET4INER. SPRING 2
IITTACHING ObRTSI
1N503-ii-6 SCIIEW 1
---I---

LZ 3P0086 YOLE ~SSYI MLG DOOR IPER*rlNG L

(ITTICHING PPRTII
dN4CZZe BOLT ´•´•´•´•´•´•´•´•´•´•´•1´•´•´•´•´•´•´•´•+´•´•´•´•´•´•´•´•´•´•+ 1
nN960-416 W*IHER 1
nS)0365-*L8 NUT L

MSZOZDL~P*P BEPHING ´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•1...

Z

2-51
 ILLUGTRATED
ROCKWELL
BECTION n PARTB CATALOG COMMANDER
LANDING GEAR BBOA/B

~s

I~

i,,

~isurs 2-13. Mein Lending Oner In~t.ll.tion Ishae~ i of 2)

2-58
 ILLUSTRATED
CUULFSTREAM
COMMANDER PARTS CATALOG GECTION n
880A/B80B LAM)INO GEAR

FL~URE P i\ R T UNITS USII~LE

L INDEX D E I C R I P T I O N PER ON
NULBEI N U M B E R i 2 3 4 i 6 1 ~551 CODE

l-LI 11 330087 LINK PSII1 MLG DOOR OPIRI1TING 1

(IITICHINi P4liTSl
15 HS21D39-L-27 ICRtW L
bN960-L0L WISHER i
’ISZ03CS-1032 NUT 1

nS2020LKP)I BEILING IPRESI IITS INTO O´•bZ-IN. 2

rlOLEI
Id 330087-5 BUSHINGI NY~ON I
17 N1S71-*-138 BUSHING ´•´•´•´•´•´•´•´•´•1´•´•´•´•´•´•´•´•´•
1
18 330085-*3 EYLBULT 1
IPTTICHING P4ti51
n120365-C28 NUT 1
1N960-*L6 dlTHER

19 110019-501 CYLINDER 1\551, HYDRIULLCI LH GEPRI INBD 1

RETR*CT
710019-502 CILINDEA blSYI HIDAPULltl AH GEI\RI INBO L
RETRI\CT
IITTICHING P4RTS)
10 *Nb-l~i\ BOLT 1
IN960-616 WISHER I
1N9ID-6L6L WISHER 1
HS21083NL NUT I

-11 nS20822-L0 ´•´•eLBOW i

19027L-505 CYLINDER PSSY. HIDRPULIC i
22 HnX-6G ROD END ISS1(7)1s41 ´•´•i´•´•´•´•´•´•´•´•´•´•´• i
IIITTICHING P4RTII
23 nN3L6-IR ´•´•´•CHECKNUT 1
-----I---

2* EO1Z~*l ´•+GLI\NO i
25 5000-187NF INLP RING 1791361 I
-26 S-03L0-116R O-RING L
II S-0311-L16 RINGI BICKUP 2
-28 S-0310-123R U-RING 1
24 ED121~3 ROD´• PISTON I
I4rTICHING P4RTS)
-30 LBO1-080 ´•´•´•NUT172P62) 1

3L S-0310-325R ´•´•´•O-RING I
32 1-0311-325 RING, 8*CKUP 2
33 HE*D. PISTON I
gl I-0310-012R O-RING 1

35 ES1244D 1ND BUSHING nSSY

BODY 1
36 NISIIIb-Oi5 ´•´•BUSHING 1
37 110022-50L CYLINOER 1SSI, nUxlLli\lr AtlRnCT,..... 1
PNEUDR*ULIC
IbTT*CHING PIRTSI
-38 *N5-13* BOLT ´•.´•+´•r´•´•´•´•´•´•´•´•´• I
IN960-516L WISHER 1
NSZ03LI-51~ NUT 1

790269-505 CYLINDER 4511´• *UXILIIRY PETRl\tT 1

19 tDI2526 CLEYIS ISBE FIG´• L-L4I REF
I*TTICHING P4RTSI
40 *N176-L0* BOLT ´•´•´•´•´•´•´•´•´•´•´•r´•´•+´•´•.´•´•´•´•´•´•´•´•´•´•´•´•
I
4L S-I*52-0bl ´•´•´•NUTIBIIRREL (12962)
---i---

42 HnX-5G ROD lND 41SY 173131) L

(bTTICHING PLRTSI
43 1N316-6R CHtEKNUT L

2-58
 ILLUSTRATED OULFITREAM
SECTION 11 PARTS CATALOG COMMANDER
LANDING GEAR 880A/8B08

F16URE P b R T UNITS US4BLE

L INDtX O E S C R I P T I O N PER ON
NUHBEA N U n a E n i z pi s a I assv coot

E01I532 GLLND 1
(LTTICHINb PIRTSI
5008-162IF SN*P RING (l913bl

ib ELB)b-III O-RING (CO*POUND 711-70) (865191 1

-)I S-O)1L-ll) RING. 8801(UP L
-)B EL8)6-ZPO O-RING ICOIIPOUND 111-101 (865191 Z
-~9 ED1ZS)D RO01 PISTON 1
(ITT*CHING PIRTS)
50 1801-070 NUT 112962) I
---I--

-51 EOL253~ ´•´•GUIDE, BICKUP I

-I) ELB3b-OLI O-RING (CO*POUND 111.701 1815)91 1
53 ED12531 HEID. PISTON 1
5) 8012511 SPICER L
55 ESIIIZ9 800* *HD BUSHING LSS*.´•´•´•´•´•´•´•´•´•´•´•. I
56 NLS)b*6-015 BUSHING L
51 IP1OBZP´•(D ELBOY ´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•i´•.´•..i´•´•´•. I
-58 812190701 nBOY ´•´•´•´•´•´•´•´•´•i´•i´•´•´•´•..´• i........, L
rITTICNING P1RTSI
INLIBD) +´•NUT.´•..´•´•´•´•´•´•´•´•´•´• I
I-0310-90)R ´•´•O-I(INb´•´•´•´•´•´•´•´•.´• L
S-031L-901 RINt´• II*CI(UP 1
---I---
800218 SNITCH IHSTL. NLG DOYNLOCX. LH E RH REF
IENl‘bB SWI~Cn´• *LG DOYNLOCI (919291 I
(*LT P*RT Hll-1399)
E11510-501 DR*G BR*CE 1151´• Ln I
E115)0-501 .DR1G BR*CE *SSI´• RH 1
E0Ir,39 PLUNGER
-60 ED1Z131-3 PULLE* ´•´•´•´•´•´•´•´•´•´•´•´•´•il´•´•i´• ´•´•.´•´•´•´•´•´•i´• 2
(ITT*CHING P*RTS)
EIS90)8-076 PIN1 ROLL ´•´•´•´•´•.´•´•´•´•..´•´•´•´•´•I´• 1
62 PIN f
---1---
ESIZ103 IRW *Sr’l. LONER (UPPER 6 LONER 1R*
ISSEWBLIES I(USr BE LSSEIIIILEO
16 NITCnED SETSI
IITTICHINO P*RTS)
-(13 ED12527´•1 ´•+PIN´•´•´•´•´•´•´•´•´•´•´•´•´•´• 1
6) ED11518 COLLIR 1
115203s2-2-31 PIN. FLITHE*D. COLLLR REI*ININb I
LN(LO-IO U*SHER ´•´•´•.´•´•´•,´•´•´•´•´•´•i´•i´•ii´•´•´•.´•´•´•´•´•i L
NS21665-151 PIN1 COTTER 1
---I---
65 90)( ´•´•´•BUNOEE 1521011 ´•´•´•t´•´•´•´•.... iii´•.´•´•´• L
66 NL(538-l(lP-015 BUSHING 1
bl YS1500L~I FITTlNGI LUBRICITIOH L
68 NSL1001-3 ´•´•´•FITTINGILUBRIClr IOH I
ES1Z)O( 1RN 1SS1. UPPER LUPPER I LONER *Rn L
ISSENBLIET NUIT BE ~SSEIIBLED
LS *ITCHED SETS)
-69 NLS5)8-LP-013 8058180
10 8012191-1 PIN LFITTEO PIRT REIHSTILL FRO* L
POSITION REIIOVEDI
EDI1i91-2 PIN (FITTEO PIRT REIHITILL FROn L
POSITION
REnOYED)
71 *N)86-I-lb PIN IFITTEO P*RT REIHSTILL FRO(( Z
POSITION RE*OVED)
~H915-3 NLSWER i
HUT
ISL1665-132 PIN´• COTTER
-12 EOL2)31 BUSHING Z

2-80 Reviaod: 28 November 1981

 ILLUSTRATED
ROCKWELL
COMMANDER PARTS CATALOG SECTION n
680A/B LANDING GEAR

FIGURE P 4 R T UNITS USIHLE

C INDEX D E 5 c 1 1 P T L U N PER ON
NUMBER N U n B E a I i ,s 5 6 7 nssv coot

2-13 73 790330-237 TUBE PSSYI LEFT BRPKC i

710330-251 TUBE PSSY, RIGHT ~RIKE L
1~ 750330-301 HUSE bISYI LEFT BRLKE ...´•....´•´•......r
1
140330-155 HO BE nSIY´• H IGHT 814KE
IITT*CHINt PIRTSI
75 930021-50L CLdnr L
76 930021-503 CLIIII) ´•.´•´•r´•´•´•´•´•´•.r´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•
I
17 NSZi919DGB CL4*P
Is CLINP 1
79 930018 C14nD 2
nN3-4n BOLT 5
dN9~0DIOI WPSHER ´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•-´•´•´•´•´•´•´•´•´•´•´•´•´•r´•´• 5
nSZ0)L5-L032 NUT ´•´•´•´•´•´•1´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•+´•´•´•´•´•
5
---I---

BO bNBZ~-CD Ttt 1
*NBZo-~O CnP 1
BL 790330-L53 TUBE IZLIYI LEFT RRI\KE L
790330-157 TUBE ASSY´• RIGHT BR~KE i
790390-329 TUBE 1S5Y´• LH L RH BRbl(E i BC
130059-503 SUPPORT 1SSI. LPNDING GEenl LH INOU
730059-501 SU"PJ~I *5SY1 LINUING 6EI~, Hh INRD 1
n515302-1 FITTINGI LUBRLLPTIONI nFT i
NI15J01-3 FITTING´• LUBRICPTION, F3D
BZ 730068 BUSHING L
83 RWDBC aEnRING 1813111 L
IPTrlCHING PIRrSI
n516~25-1100 RINGI KET4INING 2
---li----

B1 130070-501 BUSHING I
85 730059-5 SUPPORII LH iN~O ´•´•r´•´•´•´•´•´•.´•´•´•´•´•´•´•´•´•´• L
7j00ZO-6 IUPPORT, KH INBD 1
7300L2-503 SUPPORT nSSY´• L/INUING 3tlR´• Lil OUTED 1
130012-504 SUPPORT bSIY1 LINOING SE*~l RH OUTBU 1
86 n515002-1 FITTING. LUBRltdiilnN1 FIU L
87 RS15001-3 FITTIHGI LUBRICITION´• bii 1
86 7300L8 BUSHING
89 7)0070-50) BUSnl~C ´•´•´•´•..´•´•..l.r..´•´•..´•..´•.1´•´•..
I
40 730062-1 SUPPORT´• LH OUTED 1
IUPPJRT´• RH OUTED 1
91 110041-1 LYLBULT i
PIRTS)
4N9~0-blb kdSHE" ´•´•´•.´•´•´•´•´•´•´•´•´•´•´•´•´•r´•´•´•r´•´•´•´•´•.´•´•´•´• I
MSZLOB)Nb N~T 1
----II---

CDDL EFFECTIYE ON JtRlbL NUnBERS

4 asoa L1100 THRU 1119*
B L90P Li195 TkRU 113*9
C 6908 11350 4"10 SUBS

a-61
 ILLVSTRATED
ROCKWELL
SECTION D PARTS CATALOG COMMANDER
LANDING GEAR BOOA/B

1 p-lo
.i

\I
I 31-j~p I I-fiA

i_fi, II
3

"t

A~L’l;reSI

SE
24

t- T

C
’5
sr

ss i,
II

Xs

~igurs 2-14. Oleo Strut Allembly

a-82
 ILLUSTR~TED
ROCKWELL
COMMANDER PARTS CP;TPILOO 8ECTION II
690A/B LANDING GEAR

FIGUHE P I R i UNITS USbBLt

E INDEX D E 5 C R I P T I O N PER 3N
NUMBER N U M B F R I 2 3 C 5 b I bSSI CODE

2-1I *00-139-iai OLED STRUT IIISYI HnlN LbYING, in....... 1

100-139-Lb?- OLEO STRUT i\SSY, MPIIN II\NJINil RH....... L
L EDIP75R CLEYIS´• RETRPCT CYLINDERI PH I
tULI7Sa CLEYIS´• RETZPCT CYL LYS~9I Lh 1
In7TICHING ~bRTSI
L PN11~-LOP BOLT I
bN46oPOLlb *PSHER 1
3 i-1’SZ-Oh* NUT´• 84RREL 1729621 .r´•´•´•´•´•´•´•´•-´•´•´•´•´•´•´•´• 1
---li----

ESL2112 BOUY PSSY, OUTER C IYNER 1

c5iZ105-L LIN~ ~SIY1 IORBUE 1
EOIZ~OS LINK, Mi\CHINEO 1
InTIPCHING PbsTSI
5 FDIZlOb-l SHPFT´• TOROUE LINK L
BOLT 1

7 ED13)73-L BUSHING 2
8 EDIZIIO PIN´• TORBUB LINK 1
MSlb56Z-36 PiNi ROLL 1
ES1210ZL BOOY dSSY´• OU~ERI LH (StE NOTE aELOUI L
ES124oLR 80jl PSSY´• CUTER, RH (Sti NOTE BELOW) 1
10 t312111 BUSHING Z
II tDiZi96-1 21N1 TRUNNION ISEE NOit BtLnW) L
EJI2)9b-L PIN, TRUNNION ISEE NUTE aELUUI
I~TTICHINi DqRTS1
IP P1N, T*PERED (SEC NOTE BELOWI 1
P1N975-5 WI\IHEK
nN)ZO-l NUT 1
M52*665-132 PIN, COTTER L

13 LDI2I02 BODY´• MICHINEDI OUTER L

Il tDIZISZ HINi, THRUST L
IbrTdCHING ~bRTS)
~012130 STUD´• LOLL*R 2
id N1Sb69-37 RIV;´• RETblNING
---I---

II S-03Lo-1I~R O-9LNt L
Is t012~18 THRE40EO I
I4TTbCnlNG P4RTSI
19 MbOnS42~-12t SCREW 1568781 1
---L----

20 IBNBCZ060YLP Bt~RINGI NEEOLt´• UPPER 1603801 1

EOL2CLI SPICERI B~bRING, UPPER 1
12 60NBtZ074YIP BEIRINGI NEEDLEI LOWER 1603801
23 EUIZILb SPPCER, BB~R INGI LDWES 1
2~ CCML WIPER 172 386 1 13/ 16 I N Y I/~ I N X 1
L~-3/* IN´• LONGI
ES1234C 803Y nND BUSHING nSSY. INNER 1
25 EDILISS SUSHINt 2
ze dOJYI N4CHINtUI INNER 1
27 EOLZIZO PINI JRIG BRnCE I
IPTTPtHING P4RTil
28 EUIZI~L 60LT. PIN L
nNY60PD61b tUIHER I
----1---

WOTI

The following parts must be reinstalled in the

same position from whioh they were removed;

ED 12496´•1& -2 Trunnion Pin

AN 588-4-a8 Taper Pin
ES 13402 L/R SbdyAssy, (Xlter

2-63
 ILLUSTRATED
ROCKWELL
8&CTION n PARTS CATALOG COMMANDER
LANDING GEAR BOOA/B

FIGURE P 1 R T UNITS USIBLE

L INi)tX O E 5 C R L Y T I D N PER ON
NUHBEP N U H R E R 1 2 3 5 L 7 nSSY COOL

2-11 29 EDL~589 HOUK, 000R DPtRITING ir´•´•´•´•´•´•´•´•´•.´•´•´•´•´•´• 1

I4TTICHING "4RTI1
30 nN50018-5 SCREW

31 [012Z3T-L PULLEYI BUNGEL 2

-32 LD12393 SP~CER, PULLEY 2
33 ~012422 SH4FT~ BUNSEE 1
I4TTnCHING PLRTII
34 NnS~70-50 RING, RET*INING ...´•...´•..´•.´•´•r..´•..... 2
4NYhOPU8I6 WISHER Z

35 EDLII1) SPICER, BE*RING L

3~ 5-0310-2351 O-R rHG 1. r I
s7 FOL03LL GL4NOI BEbRING 1
38 S-O310-J35R O-RING ´•´•´•´•r´•.´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•..´•..... L
31 10YTO WIPER 1132171 4R
)O FDL0312 WISHER 1
41 NPS~L9-350 RING, RETIININC .+..´•´•´•.´•´•1............ 1
~Z E3L2~29-i ~ELR INj (DKILLEO TO RE CEIYt LOCKP IN I 1
P4RTSI
r3 tDL3372-3 LOCKPIN ´•´•´•´•r´•´•.´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•.´•´•´•r´•´•´• 2

I~ tUIZ4ZB PLIITE´• URIFICE 1

’t5 1012475 SNUBBER
’t6 EOLIZB5 SPRING ´•´•´•´•rr´•´•´•´•´•´•´•´•´•´•´•´•´•´•.´•´•r´•´•´•´•´•´•´•´• I
17 tD1247L RLTI\INER. SPRING ´•´•´•´•´•´•´•r´•´•´•´•´•´•´•´•´•´•´• I
E1II051-3 SCISSOR *ND BUSHING PISYI UPPER i
CS11051-~ SCISSOR *ND BUSHING PSZY, LOWER L
IPTTILHING PdRTS)
18 NnS*L*-6-~8 BOLT 1
WISHER 2
nN320-a N~T r´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•................ I
HS14665-ZB3 PINI COTTER I
19 nN114-20 BJLT I
IN960-416 WISHER ´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•r´•´•´•´•´•´•´•´•´•´•´•´•´•´•´• Z
4’1310-1 NUT I
n524662-132 PIN1 COTTER L
---I---

50 ED110h0 SU6nING1 FLbNGE IFUI ES11059-)I 2

51 EDllObl BUSHING. FLPNGE IFOR EIIIOSP-~I Z
52 E011359-3 StlSSnR1 UPPER IFO? EI11051-31 L
93 EOiIOSI-) LCISSORI LOWER IFOR ES11059-C) 1
54 EOIZ153 IRICKETI UPLOCK ´•´•´•1´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•.... i
I*TTICHING D9RTSI
51 nN5H5L BOLT 1
*N960-511L WISHER 1
56 INI7)C14I BOLT ´•´•.´•´•´•1´•´•´•´•´•´•´•.´•´•.................
-97 NIS43HT’t-50 SPICER I
dh963-*L6L WISHER ´•1.............................. I
MIZ03L5-12B NUT

ra
59
60
aNalr-soL
IO)LD-905R
YSL~001-I
---L--_

PLUG´•
O-RING
IITTING.
BLEtUERifi´•´•l: jl l ,l l111111111111
LUBRICbTION
2
s
9
bl IDL2~27 PISTINI FLU~TING ´•.´•r..........´•´•´•´•1 1
bZ S-o?LO-3Z911 O-R I´•10 ´•´•´•´•´•´•´•´•´•´•´•´•r.´•´•´•´•+ 1
-83 S-O)LL-318 RING. n.lCKUP 2
OI FUL2426 SPICER L
61 nSZ102)-L5 NJTI CI\STLE 1
’1521258-15 WISHER I
PINI COTTER I

a-84
 ILLUSTRATED
ROCKWELL
COMMANDER PARTS CATALOG SECTION II

sson/e LANDING GEAR

~IGURt P 1 I T UNITS UlbBit

L IN3lX O E S C R I P T I O N PER ON

N~nBFR N U M 8 E R L Z 3 4 5 6 1 nSSY COGL

Z-LI b6 E0I0319 STOP ´•.´•´•´•´•´•´•r´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•

I
b7 MIZ0813-L LIPI dlR YPLYt L
bB nNB09-L CUKEI PIR V4LYE i
69 ~N812-1 BODYI dlR VILVE I

To 4N901-Sn S~SKETI *IK Y4LYE ´•´•´•´•´•´•´•´•´•´•1´•´•´•´•´•´•´•´•+´•

L

71 NIS~5L-51 PLUG BUTTUN ...................r..´•´•´•.. i

ESIZIZ3-L FORn PSSY L
72 tD12495 BUSHING
13 tD13Zb4-L BOLT ´•+´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•r´•´•´•´•´•+´•+
i
IITTPCHING PPRTS)
~N320-b NUT ´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•rt´•´•´•´•´•´•´•´•´•´•´•´•´•´•´• L
152*665-287 PIN, COTTER L
10131t5-L BUSHING, FLLNG~U 1

74 1-03 LO-I LOR O-RING 2

RIV6´• BICKUP ’t
75 M528782-8
16 ED10301 JPCK PLO L
I*TTICHING PIRTZI
71 HS1D*8-IBO PIN, ROLL 1

18 E010300 PXLE L
I4TTbCHING PLRISI
79 52-0~8-250-2500 ROLL PIN 172962) 1

80 tDL3213-L PLUG´• PISTON I

81 S-0310-3Z8R ~-RING I
BZ 5-0311-328 RINGI BnCKUP
83 L011370-L r ROU1 PISTON 1
8~ EDLO~YP-1 FO1~. MbtnlNED i

2-65
 ILLUITRATED
ROCKWELL
SECTION n P~RTS CATAGOG COMMANDER
LANDING GEAR BOOA/B

i B

MODEL BBDI\ 11100 THRU 111*.

o
i

MODEL SBO~IB -11185 FIND SUBSEDUENT.

FiQura ?-15. Wh´•el ~nd Inlt~ll.fion (Ihs´•tl ol 3)

Z-BB
ROCKWELL
ILLUSTRATED
CATALOG SECTION II
COMMANDER PARTS LANDING GEAR
GSOA/B

i´•8,.
i,
5

~s
MODEL 090/\ -11100 THRU 11184.
’-1-iI
,,,i
d

I
i %i-"

MODEL BgOPIIB -11196 P~ND SUBSE~UENT

V´•I
figure 2-1). Wheel end Br.ks In~f.ll.tion. MLOISheet 2 ol 3)
2-81
 ILLVSTRATED
~MCKWELL
8ECTION n PARTB CATALOG COMMANDER
LANDING GEAR BOOA/B

FIGURE P 1 R T UNITS US*BLE

L
INDEX O E S C R 1 P T L O N PER ON
NUNBER N U M 5 L R L 2 P C 5 6 I nZIY COOt

2-15 710029-507 WHEEL INO BRaKE 1SSY´• LH IStE FLG´• 2-131 1 a

110029-508 WHEEL aND BRPKE aSSY, Rn IStt FIC´• 2-131 L P
710029-511 W*EEL nND BRIKE aSSY´• LH IStE FI~. 2-131 1 BC
710029-)12 WHEEL 1NO BR~KE nSSY, RH (SEt FIG. 2-131 1 BC
IllTTICHING PbRTSI
*511025-15 NUT, CISTLE L SEE FL F´• 2- L’t I REF
MSZIPlB-IS WPZntR REF
nS24bb5-357 PINI LOTTtR REF
---li---

2 R´•50 X iD TIRtl TUBELESSI CONYENTI~NIL ID-PLY L

nYLOkl TYPE 111 IP5500I
9543939-1 WHEEL P~SY 1255001 1
9 544155 WnE tL LSSY I 2 5500 L I BC
3 511705-1 RING, HUB CPP RET4LNING 1155001 L
4 9511135 HUd C4P INOT FURNISH~D UNLESS
ORDERED 1255001
5 071~0 CONtl BCaRINGI OUTED 1600381 1
b 13685XL tUNE´• BLPRLNG´• INROIRD 1612201 1
7 9543645 WHEEL HI1LF´• OUTBLIaHD 1255001 I L
50000j6 WHEEL HaLFI OUTED 1255001 L BC
I~rTbCHING PIRTS)
8 ilSZ0~05-30 BOLT
nSL0003C5 WISHER (UNDEI BOLT HELOI 8
MSZOO02-5 WISHER ´•´•´•´•´•´•´•´•´•´•´•´•´•´•1´•´•´•´•´•´•´•´•´•´•´•´•´•´•´• B
22FH-52* NUT 1566781 B
---I---

9 01204 CUP. BE4R1NG 160018) 1

LO 95*)938-L WHEEL HILFI INBOIRD 1?55001 1 a
5000015 WHEEL HaLF. INBD 11550 D I 1 BC
II 13621XL CUP´• BEdRING 1255301 1
12 951*045 L~I´• DiSC DRIYt 1255001 20 d
9544462 KEYI D1SC DRIYE 1255001 7 BL
-13 5002*74 SCREW, KEY 125100) 20 a
HSZD*ZI-*CP RIYET I~ BC
bN9bO-~lbL WISHER 20
14 PNb230-4~ U-RING I
15 ED1D31) STOP LIEE FIGr 2-141 REF
Id 95~4237 BKdKE liSY 125500) I a
IPITPCHING PaRTSI
17 INS-III BOLT 12
nN96D-516 WISHER 12
HSZ03t5-524 NUT 12

18 9513892 YUT´• LOCK (255001 3 a

19 9522159 BUSHING, THR E*OEO 12 55001 3 1
ZD 9522728 GRIP aND PILOT PIN bSSY 1255001 ´•´•´•.r 9 d
21 91340*3 HEID, CYLINDER 1295001 3 1
-22 I-~BLO-OiOii U-RING r..... 3 n
L3 5-03LD-ZL3R O-RING 3
Z* 95353221 RING, THRE*DEO 12 55001 3 ii
28 9535319 3UIOE1 SPRING 1259001 3 a
26 9535318 SPRING, HELICIL tOMPRESSIUN (255001 3 1
21 9515121 SE LF-I\DJUST I hlG
P IN´• 1 2 5500 I 3
L8 9536607 PISTON 1255001 3 a
-29 S-0310-327R J-RINP ´•.´•r´•...... 3 P
30 953t53l LINING, BRPKF 1215001 a a

COOE EFFECTIYE ON SEHIUL NUMBERS

a 69aa 11100 THRU 11194
B 6906 11195 TH*U 113*9
C 6908 11350 *ND SUBS

a-88
 ILLUSTRATED
ROCKWELL
COMMANDER PARTS CATL~LOO 8ECTION II
68(1A/B LANDWO GEAR

28

33

lo 31~
31
,,‘I
\1
35i
22 21

~J ’R(WI\ i is

10
MODEL BBOP~ 11100 THRU 11184. 311 ua,
k 13

11 63

51

63 .J
~--ss
MODEL 680*iB -11185 AND SUBSE~UENT. 61
65
st55 51

~igur. 2-15. Wheel .nd Br.La Inrt.ll.tien. MLO(Shee13 e13)

2-88
 ILLVSTRATED ROCKWELL
BECTION n PARTS CATALOG COMMANDER
LANDING GEAR 880A/B

FILURE P R T UNITS US~BLE

L INDEX 0 E S C R I P T I O N PER DN
NUMBER N U n B E n I z s a I aszr coot

2-15- 31 45)*121 O1SC, BRIIKE 1255001 L ii

31 955013b HOUSINGI DR4KE 125)001 1 n
33 9561D31 RPCKPLITEI BRPKE (255101 L a
IITTICHING YPI(TSI
34 *N7-334 BOLTI MOUNTING
IN960-T16 WISHER 8
2ZFH-720 NUT 15L878)

35 95340*1 RLTIINERI MOUNTING BOLT (25500) 4 4

Pb *N919-lD Rt DUC ER ct r L ii
31 S-0310-906R ..3-KING 1 4
38 M53520~-260 SCREW ´•´•´•´•´•´•´•´•´•1´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´• 1 P
39 5118*6-4 WISHER 125500) L
~O PNIPO*-I V*IVI, BLEEDER L a

rl 4522L3* IOIPTERI BLEEDER VILYF 1l5500I L d

42 S-0310-90bR n-slNG I
43 952628P OUSHINGI WEdK INOICITUR IL55001 L a
~L 952b2C7 PINI HEIR INDICdTUR 1155001
15 Y526289 SPRINGI Wt(R 1N31C4TOR 1255001 I 1
46 5002116 BLPKE PSSY 1255001 1 BC
I4TTICHING PIRTII
41 *N5-lb BOLT LZ
IN960-516 WISHER I)
nSZ10*~N5 NUT IP
---I---

48 5002107 BACKPL*T~ (255001 L RC

IITT4CHING P4RTSI
-19 M520005-43 aOLI
22FH-524 NUT 1568781 ´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•r´•´•´•´•´•´•´•´•

nSs000ZC5 WISHER

50 5002105 PbO´• WtnR 1255001 6 BC

51 5002062 DISKI HOT4TING 1251001 2 BL
)2 95*4476 O I SK, STnT i ONPRY 115 500 1 r L BC
53 5002088 TUBEI TURPUE (255001 I RC
54 FN12-02 NUT 1568781 ´•´•+´•´•´•´•´•´•´•´•´•....1..´•.´•...
5 BC
55 95310*5 GRIP bND TUBE ISSY 14LT PIRT 50032811 5 RC
1255001
56 9535041 PIY~ RETURN 1255001 5 BC
57 5002106 PRESSURE PLITE 1251001 1 BC
58 5002105 PbD1 1255001
HEIR 6 BC
59 NS000-I0aH) RIYGI RtTIINING (791161 5 DC
60 9525909 HOLOtRI SPRING 1255001 5 RL
5002041 SPRINGI RETURN (255011 5 BC
62 1526236 HDUSING´• ZPRING 125500) 5 BC
63 953*915 INSUL*TORI PISTON (225001 a ac
64 5002043 PIITON 1259001 I BC
65 nS28175-22L O-RING 6 BC
66 GY188-7 RIYET 1255001 1Z BL
M13520T-PLO SCREW. BLEEDER I BC
68 511846-1 ~bSHELI BLEEDER 1255001 i BC
69 PNb204-1 YILYE. BLEEDER L 80
10 952ZL3e bD4PTER. BLEEDER YPLYE 1255001 L RC
71 MSZ871R-6 U-RING ´•´•´•´•´•´•´•...r´•´•´•´•´•´•´•´•´•´•.´•´•´•-´•´•´•´• 1 BC
72 5002115 HOUSING (255001 1 bC

CODE EF~ ECT LVE Cli SERLaL NUHDtKS

L b901 lilDO THRU 11194
d 640* 11195 THRU 113*~
C 6908 11350 dNO SUBS

2-10
GULFSTREAM
ILLUSTRATED SECTION II
COMMANDER PARTS CATALOG LANDING GEAR
esoA/ssoB

y- ~1

’J
A
s
II to

211

2JL

1
1 ~tsd
,1, 224

118

1-16. M~in L~ndinp O´•or Uplo~t

Revised: 28 November 1984 2-71

 ILLVSTRATED
GULFSTREAM
BECTION n PPIRTS CAT~LOG COMMANDER
LANDING GEAR ssaA/ssot~

Flsunt P ii R T UNITS USIILF

L LNUEX D t 5 C R 1 P T I O N PEY ON
NUHBtR N U H a t R 1 3 5 d 7 IZISI CC~E

2-16- 7300*5 UPLOCL LNSTLI HYDRPULIC RF~

i SPRING
I~TTICHING PdRTII
-I 1N3-30n BOLT i
3 730015-11 IPICER 2
NnS13HT3-96 SP4CER 1
lN97O-3 **IHER 2
XSZ~os3N3 NUT L
---i---

1 730071 LINK i
5 730015-27 LINK ~IIY1 UPPER Z
(~TTICHING PbRTII
I\NL71CZOP BOLT I
IP4CEI
PN960-416L *bSHER
nS~L083N4 NUT ´•´•´•r´•´•´•´•´•´•´•´•´•´•´•´•...................

1 7300’t5-23 LINK liSYI LOWER

InTTPCHING P9RTSI
B PNll~-30 BOLT I
N1S13HTI-~8 IPICER ´•´•´•I............................

P1N960-L16L WllnER I
LN)IO-I NUTI CI~TLt L
HS2~bt5-L3* PIN´• COTTER L

9 730[1*5-19 *HH PISYI UPLOLK.´•´•...; I

IPTTbCHING PPRISL
10 *N1IIC~LI BOLT
liN960-*1LL wPSHER 1
NUT 1
L1 LN2L-16 BOLT
Hi\S HER I
nN320-C NUT 1
MSZ~Lb5-13C PINI COTTER

IZ 790228-511 .CILINDER 45111 UPLOCII LH..´•.......... 1

190228-111 CILINDER IISIYI UPLOCKI RH I
I*TrbCnlNG PIRTSL
13 1N3-ZOI BOLT, FWO 1
Ni\S*3HT3-ll SP*CEK 2
1N960-LoL U*SHER ´•r´•´•´•´•´•´•´•´•´•´•´•´•´•...´• Z
MSPIO~IN) NUT L
L~ PN)-LO~ BOLT 1
INPIO-LOL *LTHER L
nSZ1083N3 NUT 1
---t---

~NB32-CD UNION 1-513 PSSY ONLYI L

I~B INPIL-ID ELBOW 1-513 1891 ONLI1
1IL *N6Z89-*D NUT 1-513 bSSI ONLII I
5-(1111-901 RING´• BIICKUP 1-513 i\iSY DNLYI
S-03L0-90*R O-RING 1-519 *ZSI ONLYI Z
15 1NB3~-4D ELBOW
16 190303-501 YI\LYE~ *ETE RING
17 *N12890* NUT Z
18 5-031 1-90* RINGI BbCKUP 2
19 I-0310-90’tR O-RING 2
7L3058-503 ..CYLINDEIII HYO-SPRING LO(IDEO 1
20 ,,j eND 1
EDL252L LETPINEH I
22 ~N56501032H1 IETSCREW I

2-12
 ILLUSTR~TED
C´•ULFSTREAM
COM~ANDER pnRTS CATnLOG SECTION n
BOOA/BOOB LANDING GEAR

FIGURt P n R T UNITI US*BLE

I IN~EX O E 5 C R i P T 1 O N PEII DN
NUHBlR N U M B t 8 I i 4 5 6 7 bSSY CODI

23 ED12517 SPIING 1
ED1~SLO ´•´•GLINO 1
25 52-022-091-0875 P1N´• ROLL1729623 1
-16 ..´•PISTON´•´•´•´•´•´•´•´•´•´• 1´•´•´•´•´•´•´•´•.´•..´•´•..´• L
-II EDII5L8 ..´•80DI...´•.´•.´•´•´•´•´• 1
-28 S-0110-010R O-RING 1
281 5-0311~010 RIW6. S*CIUP I
29 O~RING Z
2’)* 5-0311-115 RING, 8*01108 3
-30 1ENL~LI SYITCH, UPLOCY (919291 I
31 730015-9 SUPPORT, UPLI)CI( )YITCH 1
-31 7300)5-~ CHIHNELI BULIHELD SUPPORT I
33 130015´•33 BULXRE*D 1151, LH INBD C RH OUrBD 1
31 7300)5~3) BULXHE*O *557, LH OUTED L ~H 1HBD 1

Revised: 28 November 1984 a.?s

 ILLUSTRATED GULFBTREAM

CATALOO COMMANDER
GEC?1ON n PARTS BgOA/680B
LANDING GEAR

I\

~ea’
a a

21

ii

i/

~4;
.P

~igllr8 2-11. Emergsn~y Air Relervoir in~l.llolion MLO ISh~´•11 ol i)

2-14
 ILLUSTRATED
ROCKWELL
COMMANDER PARTS CATALOG SECTION II
BI)OA/B LANDING GEAR

FIGURE P A R T UNITS UIIBLE

L INOEX O E S C R L P T I O N PER OH

NUMBER N U M B E R 1 2 3 J 6 1 ASSY GOOF

2-17 790331 HYORPULIC SYSTEM INSTL REF

11002~ CYLlhOER 4SSY bND INITLI Gtdl 1IR ..r´•´•

REF
1 710026-19 CYLINOER bSSYI GEAR AIR
I4TT*CHINj PIRTSI
Z MS27039-1-ib SCREW 4

LN960010 WASHER
----li---

zA MSZ1902-D1 UNION I
120037 PDAPTEK ´•´•´•´•´•´•´•´•r´•´•´•´•´•´•´•´•+´•´•´•´•´•+´•´•´•
1
S-J310-90*R I-RING L
5 1N912-50 REUUC ER 1
110o)L-501 CYLINUER 1
1 710026-17 CLAMP
8 710026-15 BLLl(i( Z

9 lN3-26~ BOLT
LN9~30LO WASHER i

MSZ1083N3 NLiT i
lo 7100ZL-3 DRACKET 1SSY 2 n
710026-23 TRAY 1 Bt

11 790310-321 TUBE bSSY ITEE 1N 84GSIGt COWP*YTMENT L A

TJ b1R BOrTLEI
I~ nSZ1905-IC TEE L
"IS2191Z-’t TEE I UL

13 79U330-217 TUBE ASSY ITFt IN BAGGAGE IOIPURT*ENT I

TO UNION)
1* NS21902-’tC UNION I
15 790330-219 TUBE 4SIY IUNION TU BUL*HE*D tLBO* I
AT UPPER Rn WING Sl(IUl
Lb lN533-40 ELBOW ´•´•´•´•´•´•´•´•´•1´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•.´•´•´•´•´•´•
I
PN9L*-4D NUT 1
i\N9LOP07L6 *I\IHEH I

Il 790330-33L HOSE IELBOW IN RH WINL SKIN TD

ASSY L
GEAR CYLLNDER~ IREPLICLS 790)30-1051
L8 790330-235 IU8E bSSY ITEL iN RnCS4Gi COMP~RTMENT I
TS ~ULKHEIO ELBOW iN LU*EH iH WING
SKINI
19 MSZi908-4C ELBOW
bN92*-4C NUT i
dN160P071C IISHEL L
ZO 790330-303 TUBE ASSY IFRU* BULKHEID ELBOH TU TEE I
IN NI\CELLEI
21 OSZL9o5-*C TEE I
LZ 740330-33L HOSE dTSY ITEL IM NICELLE 10 UUTRO i
CYLINOERI
23 790330-L0l TUBE ASSY ITEE IN N*CELLL TLi GAGE 1
INSTL)
7LoO28-501 GAGE INSTLI EMERGENCY blR1 ML6 REF
2* MSL88e9-I VILVE. nin I
25 850186-505 i4Gt. blH PRESSURE L 0

850186-501 GIGEI AiR PRESSURE i Or

Zb MSZ1PZ*O~ UNION 1
(4TTACHING DIRTS1
27 dN9Z*-4D NUT ..´•´•´•.´•1´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•
L
nN960D7i6 *~SHER 2
---I---

28 i-03LO-9o~HT O-RING L

COOE EFFECTIVE ON SERIAL NUMBERS

1 aroe L1100 THRU 11208
B 6901 L1ZOT THRU 113$9
C 6904 L1100 THRU 11160
D b90b 11161 THRU 11319
E b908 il)SO dND SUBS

2-15
 ILLVSTRATED
ROCKWELL
8ECTION n PARTS CATALOG COMMANDER
LANDW(I CIEAR 880A/B

30 1 II,

~llur´• 2-11. Em´•rg´•n~y Air R´•l´•rvoir in.toll.tion MLO (Sh´•.12 ol 2)

1-?8
ROCKWELL ILLUSTRATED
COMMANDER PARTS CATALOG 8ECTION n
BBOA/B LANDING GEAR

FIGUR~ P ei R T UNITS USIBIE

L IN3eX D E S 0 R I P 1 I O N PER ON

NUnBcR N U n a E n 1 z 4 5 a 7 nssv coot

2-17 29 LZ003~ TtEi FILTER YPLYE 1 C

120036-50L TCE´• FILTER VeiLYE L OL
30 190330-323 TUBE ~SSY IFROH UNION TO BULKnt~O TEEI I BE

31 790l3a-325 TUBE nsrr IFnon suL KnEno rtE To uN ton I I aE

32 1903)0-327 TUBE PSSY IFROM UNION TO CYLINDERI t RE

COUE EFIECTIYE ON StRLbL NUMBERS

B b´Ub 11)09 THRU LL3~P
L 690~ lllOU THRU 11160
D b9oP 11161 TnRU 11319
E bYOB 11350 bNO 5UBS

2-17
 ILLVSTRATED
ROCKWELL
BECTION n PARTS CATALOCI COMMANDER
LANDING GEAR BBOA/B

3) 1)

21--e,~
a
z zl
I

ii 2,

i
i i
"B II

lli
let

13 1

1\
P
\j
i

iBe 18

figure 2-11. Nora Lending Oeer Door~ end Alluating Merhonilm

2-18
 ILLVSTRATED
ROCKWELL
COMMANDER P~RTS CAT~LOO SECTION II
BOOA/B LANDING GEAR

FIGURE P b R T UNiTS USIBLF

C INDEX D E I C R 1 P T I O N PER nN

NUMBEK N U n a c n 1 2 3 4 5 a 7 assv cuuE

z-ls NO NUH~FR NOSE L~NDING GE*R DOORS B eCTUI\TING REF

MiCrlnNISM
330169 DUDR INTTLI NOIE GEIRI F*3 REF
L 330169-9 DUOK ISSY, LH FWO L
330169-11 ODOR nSSY, HH FWO i
(~TTLCHING "bPiil
40001~-5´•53 PINI HINGE I

3 330169-21 HINGE H4LFI LH 1

330164-22 HINGE HILFI RH L
’1 310169-13 IE4L, iua BEn IXTRUSI uNI iH i
3301L5-14 IEbi, RUBIER EXTRUSICN1 RH
5 130LL9-15 ItbL t KVJ EER EXTRUSI LN 1 iH ´•..1..
1
330169-17 SEIL´• RUBBER EXTRUZILN, RH L
a 330LL1-19 IEPLI sUdBER iXTRUSION IFOH iH FUD 1
DOOR ONLY1
7 930169-27 It*LI EXTRUZIDNI
RUBBER iH........ L
330169-29 IEILI RUBDER EXTRUSILNI RH.´•...´•.. L
8 330176-1 BRdCXETI LH FWO U~OK 1
330L7b-2 BRICKET´• RH FWO 300R L
I4TTICHING Pdl~jl
r SCREW
iiN96DOIO WPS HER 4
MSLIO)SN) NUT 4

330168 UUOR INSTL. NUSE GF 4R1 4FT ~EF

LO 330168-33 DOOR dSSY, LH IFT I
3301~8-34 JUOR lSSll eH PFT
I~TTLCHING PIRTS)
II 90001b-Z~´•15 PINI HINGE I

LZ 330168-9 HINGE H~LF L

330168-10 HINGE ndLF L
13 330L6P-15 ItlL1 sU98ER EXTRUEIUN IFOK LH IFT i
DOOR ONLYI
1* 130168-11 r BRPCKET, LH PFT DOOR I
IlO1b8-iL BRI\CKtT, RH i\FT JoaR.............. i
IPTTICHLNG "4RTS)
15 MT27039-1-08 SCREW
IINlhOULO II4SHER i

MSZ104*Ns NUT I

16 330168-L3 9I4CER I
161) J3o168-L7 Jb~B ´•´•-´•´•´•´•´•´•´•´•´•´•´•´•´•´•+´•´•-´•´•´•´•´•1´•´•´•´•´• L
17 310186-35 1 HINGE H*LFI LH FWD IS’t ~ic´• 2-511 REF
110185-39 HINGE H*LF, RH FWO ISFE FIG´• 1-5L) RtF
IR 3L018b-Z5 HINGE H4LFI iH 4F7 ISEt FIG´• 2-511 PtF
110185-25 HINGE nbLFI RH I\FT lSE6 F15´• 2-511 REF
330165 LNT~LI NOSE GCbK OUURS REF
9J0009-~5-LL´•80 RUU nSSY 2
20 PN~16-L 84Li JOINT FNO I

I*TTICHING PpRTSI
II i\N316-CR CHICKNUT I
4N960D41bL ´•´•W~SHER ´•´•´•´•´•.´•´•´•´•´•´•´•´•´•´•´•´•r L
nSZ1083N3 NUT IUPPER)
MSZ1OS*N) NUT IL~WERI I
---I---

22 900009-31-1)´•00 ROD dST~ I

23 nS21975-3 CLEVIS I
I*TTnCHINt P4RTSI
24 MI20392-2C19 PINI FLI\T HEnD
I\NPIODID ~dlHtR ´•´•´•´•´•.r´•´•´•´•´•´•´•´•´•´•.´•´•´•´•´•´•´•´•´•´•´•´• 2
YS2Cbl5-13L PINI COTTER L

25 nN316-4R CnECKNUT 1

2-78
 ILLUSTRATED
ROCKWELL
BECTION II PARTS CATALOG COMMANDER
LANDING GEAR 880A/B

FIGURE P b R T UNITS USIBLE

L INDEX U E S C R I P T I O N PEI ON
NUMBER N U M B E R 1 3 4 5 6 1 nSSY COOt

2-18 Zb POOOD9‘25-1*´•IO ROJ bSSY 2

27 RE83N BEI\AING *ND END *TSY IP13351 C
(~ITICnlNG PnRrSI
28 LN3‘l0h BOLT IUPPERI I
29 i\N3-711 BOLT (LOHERI 1
bN96~0LO YISHEH ´•´•´•´•1.´•´•´•´•´•´•.................. Z
n521041N3 NUT 1
l0 dN3lb-IR CHELKNUT L
---I---
31 330036-1 LINK *SSY L
IITTPCHING PIKTSI
32 n520392-2C23 PIN
PN960010L W*SnER 4
HS2*bb)-I)Z 21N, LDITER
---I---

33 3300L7-501 HOUSING *SIY

IPTIICHING PIRTSI
34 nN3-5* BULT i
1N9600L0 r NnSHER Z
HS210~1N) NUT Z
---C---

35 310191-9 BH 4CKtT, LH ISEE FIG´• 2-5 L REF

310191-L BRILXETI Rn ISEE FIG´• 2-511 PEF
330165-5 SH4FT 1TSY 1
-36 iiN9~0-1010L HIIHER 4
37 330037 BLLLCRPNK PT6Y I
38 330038 bR* *SSY
(ITTPCHING P 4R TS I
39 PN3-13n BOLT .´•..´•´•´•r´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´• 1
*NPLODIO W4SHtH 1
NUT I
----li----

I0 330165-L4 SHIFT 1
330165-23 SHIFT ISSY 1
I*ITICHINt PdRTS)
INP6O-1OL6L IIISHER Z
MS24665-136 PIN1 CDTTEK Z

42 330035 BELLCRPNK *55Y 1

IPTTPCHING PIRTS)
$3 1N3-13I BOLT I
nNY60D10 WISHER 1
HS~1044N3 NUT 1
---1---

N*575-3-0OA BUSHING 2
380165-21 ´•´•´•iHPIFT´•´•´•´•´•´•´•+´•. 1
45 330054 IRN ´•´•´•´•´•´•´•´•´•´•´•r´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•r´•´• 1
Lb 33005) BELLCRINK i\STY L
IPTTICHING P4RTS1
47 PN3-22* BOLT I
18 PN3-Z31 BOLT ...´•1´•.´•.´•´•1.................... 1
*N960D10 WISHER 2
M1210LIN3 NUT ´•1´•´•´•´•-´•´•´•´•´•´•´•+´•´•´•...´•´•.......... 2
---L---

NPS15-3-008 BUSHIN~ ´•´•´•´•´•´•r´•´•´•´•´•´•´•´•´•´•´•´• L

*9 330165-15 SPICER´• LDJUITHENT lo.01t THLCKNESSI *P
330165-L3 SP*CER, IDJUSTHENT IO.~ZS THICXNESS) *R
330165-11 SP*CERI *OJUI~MENT 10´•010 THICKNESS) IR
330165-17 IPI\CER´• PDJUST~FNT IO.L25 THICINEZSI IR

a-80
 ILLVSTRATED
rrULFSTREAM
COMMANDER PARTS CATALOG SECTION n
690A/680B LANDING GEAR

´•´•w-~

"P i le
i
.I
‘R~qhP
i
i:
FY d
9 ~´•ul; 12
as
1~1

ss-~
ss
111-

31
‘"I‘" 1
1
ss-~
i
a, p ,,~7;,,
"d
ga

9
Q,

~igule ?-1P. Nora Landing Gsar Inrlollati~n Ilheet I ol 2)

2-81
 ILLVSTRATED
OULFSTRE4M
SECTION II PARTS CAT~LOO COMMANDER
LANDING GEAR asoA/ssoB

Flcunl P R T UNITI UlbRLL

C INDEX D t i C R i P T i O N PER ON
NUMBER N U n a E a i z 1 5 a 7 asiu coil~

1-19 Isoosl GELR INSrL´• STEER*BLE NOSE LLnDIHG REF

1 750055-50) BUNGEE IND BEIRINC 1SS1, NOSE 61*r( 1
(ITTICHING PIRTSI
2 1NP(-13 BOLT 1
1N9bO0116 WISHER 1
3 INZ)-16 BOLT 1
INsbDD)l(,L WISHER I
1N310-) NUT L
*E1(665-132 PIH´• COTTER
---I---

5-301-11 BEIRING (70)11) ´•´•´•´•´•i.....´•´•´•´•´•.´•´• Z

5 750051-31 1R8 ~SSI´•+´•.´•´•´•´•.´•´•.´•´•´• 1
I*TT*CHING PIRTSI
6 IN(-I(,I BOLT 2
1N9bOD116 WISHER
IS1IOIIH) NUT
---1---
1 750011-1 SPICER 1
B 1)0069-501 SHIFT ´•´•´•r´•.´•´•´•´•´•´•..´•´•.´•´•´•´•´•.´•´•´•´•´•1´•´•´•1 1
E1’133 DR1G BRICE *SS* 1
(ITTLCHINt PIRTS)
9 1H1-lb BOLT ´•´•1+´•´•´•´•´•´•´•´•´•´•´• 1
LO NLS(3HT(-2B SPICER 1
750061-13 WISHER 1
IN960Dl16 WISHER ´•´•´•´•´•´•1´•´•´•´•´•´•´•´•´•´•´• I
1N)ZO~I HUT 1
1(P2(6,5-I32 PIN´• COTTER I
L1 EDL0055 BOLT IFURNISHED WITH (00-10L STRUT....
*SS*l
1N96D-PI6L WISHER (FURNTSHED WITH I00-ID1 STRUT 2
*SS*I
ln9~0-516L WISHER (FURNISHED WITH *00-101 STRUT t
1SS*I
)N3LO-’j NUT (FURNISHED WITH (80-101 STRUT 1SSII I
nS2)~C1J-192 PINI COTTER IFURNISHED WITH 400-101 1
STRUT 1SSII
---t---
-12 ES1DL06 Llnx ISr*. LOWER 1
IITTICHING PIRTSI
13 1N11~‘16 BOLT ´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•.´•´•´•´•r. L
INlbOPOlIb WISHER
1N310-I NUT I
1SI)665-183 PINI COTTER 1
---I---

1) LSS9 BELRIIIG (1313)) I

15 ESIO101 LINI LSllt UPPER 1
I*TTICHING PIRTS)
*H117-22 BOLT 1
*Nsb0D116 WISHER 1
IN3I0-I NUT I
11521665-~89 PINI COTTER 1
---L---

LI N1Sll‘l‘bZ ´•´•IUIHIHb ´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•r

P
18 RSISOO1-l FITTING, LUBIIIC*IION ´•´•´•´•´•´•´•´•´•.´•´•´•´•1.
2
19 800029 SWITCH INSTL. NOSE GEIR (SEE FIG1 REF
1´•1’11
10 5-0336-L1lB BELRINC. NOSE GE*R (IEE FIG´• 1-511 REF
750061-27 CILINDER 1SS*l NOSE RETRLCT L
IlrT*CHING P*RTSI
-PZ *NI)-12 BOLT 1
IN9600(16 WISHER I
INebD~)16L WISHER P
IN)LO-I HUT 1
HSZ)(165-132 PIN, COTTER 1
-23 150061~23 BEIRING ´•1´•´•´•´•´•1´•´•´•´•´•´•´•´•´•´•´•

a-82 ileviled: 28 Novsalber 19R4

 ILLUSTRATED
~ULFSTREAM
CONIMANDER PARTS CATALOG BECTION n
680A/BgDB LANDnlG DEAR

L~

Ij-

30T //V 38

b
52 53

51 ~M´•inl

50
B
(8
II

i,,,

,1

II

OigurL 2-19. No.e L.nding Door inrtollolion (Iheet 2 of 2)

a-83
Revised: 28 November 1984
 ILLUSTRATED GULFSTREAM
SECTION n PARTS CATALOG COMMANDER
LANDING GEAR 680A/680B

FIGURE P d R T UNITS USbBLE

G INOtX O E S C R I P r 1 3 N PER ON
NUMBER N U M B E I 1 Z 3 4 i L 7 biiY GOOF

2-L9- P) 9000))-~0-55 RESTRICTOR I

25 )1NB16~(D NIPPLE
190210-505 CILINDCI( *ISI, RETR*tT ILLT PLRT 1
E1931)
EI)IOI*L BRICIET I
I*TTLCHING PLRTS)
21 nSL0391-3C35 PINI FLITHE*D 1....´•´•´•´•´•´•´•..´• I
*HPbO-)16L ´•´•YISHER I
n521661-132 PIN, COTTER 1
---I---
28 5008-150 LOCIRINC L191)6)
19 E0I0II1 END 1
-30 S-0310-ZL8R ´•´•´•O-RING´•´•´•´•´•´•´•´•´•´• 3
31 ES10113 ROD EHO L BUSHING LSSI I
(*TT*CHING PLRTS)
31 LN316-bR CWECINUT I
---1--
33 ED101)6 END 1
-3) 5-0310-1118 O-RING L
-35 ED1D1)) PISTON I
-36 EDLDI)I 800* 1
37 750061-25 .CILINDER ~511i NOSE STEERING L
(ITTICH1NG P1I1~I)
38 EDL1651 BOLT IFURNISHED WITH I0D-I0I STRUT L
lSS*I
1NP10-)L6 ULSHER (FURNISHEO WITH (00-L01 STRUT I
1Sll~
*N310-( NUT IFURNISHED WITH )00~101 STRUT 14511 1
IS1)6~5-13P PIN, COTTER (FURNISHED WITH ~00-IOL 1
STRUT 1SSI)

39 UNION I
S-0310-90(R ..O-RINC 1
-)O 90009)-~0 ELBOW 2
(I S-D310-sO)R O-RINC i
)2 RING, BICIUP
~)3 *Nb289D( NUT 2
*nsl,-~o PLUG Z
111096-503 CILINDER LSSI, NOSE STEERING 1
-(5 291105-1 ´•´•LDt*NUr ´•´•´•1´•´•´•´•´•´•´•+´• I
-16 291101-1 PLUG, END I
RING. 8*CKUP ´•´•´•´•´•´•´•´•´•´•1´•´•´•´•´•´•´•´• i
-)B 5-0)1D-O~Lll O-RING
~)9 I-0311‘L1) RINGI BICKUP i´•´•´•´•´•´•´•´•...´•I´•.
-50 S´•O)LO-LI~R O-RING Z
51 29)10P-3 PISTON *561 I
-5L 291106-1 ´•´•RING´• SELL L
-53 O-RING I
51 295101-3 8001 1
51 750068-1 WHEEL 1NO TIRE *511. HOIE..´•.´•´•´•´•´•´•´•´•. I
6´•(10 16 TIRE, TUBE TIPE, 6 PLI R)iTING, TIPE L
L11
6´• 00 i 6 TUBE 1
95)2186 WHEEL LSSI, NOSE IFOR TUBE TIPE TIREI 1
1255001
-56 952)118 SE*L. BEIRING 1255001 2
~51 1)889 BEIRINCI CONE I´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´• Z

2-84 R.iisud 28 Noucillbel. 19R4

 ILLUSTRATED
ROCKWELL
COMMANDER PARTS CATALOG BECTION n
BgoA/B LANDING GEAR

FIGURE P i\ R T UNITS USIDLE

G INJtX O E S C i) i P T I O N PER UN

NUMBEL N U M 8 E R L Z 3 4 5 6 1 nSSY CODE

2-19 58 YS2~203 WHEEL H~LF bSSYI FFNI1LI 1259001 L

59 r WHEEL HPLl ~TSYI Y4LE 125500L L
I~TIPCHING P4RTSI
~O N*SL*~-Z3 ~OLT 3
*SZOOOZC4 H*SHER (UZt WITH 952’t203 WHEEL 3
H*LFI
nszaooz-~ H4ZHER 1US~ WITH 952*318 WHEEL
HILF)
22FH-528 NUTI FLEXLDC 1168781 3
---t---

61 13830 CUPI BEIRING ILn3381 1

750061-19 STRUT diSSYI NOSE 14NUIN6 GCI\C 1
(~ITICHING PdRTS)
62 PN3-ZZd BOLT 2
6J bk3-23n BOLT 2
*N960010 WIZSHER
MSZ0365-L03Z NUT
6~ 750070-1 PIN 2
65 i\k9600Ll1bL WI~HER 48
---i---

900-101 OLEO STRUTI NOSE LPNDING GE*R L

66 9535 SCISSOR PNO BUSHING bjSI 2
I4TT*CHINS P4RTSI
61 nNL75-32 BOLT 1
I\N960-516L Wn SHL H 2
1N310-5 NUT i
PINI CUTTER 1
68 INII*-L) BOLT 1
PN9LO-4L6 WbSHtR i
nN960-l16L WPSHLR (INST*LLS BEI*EtN SCISSURS) i
l)N3ID-4 NUT L
YlN. COTTER i

bB~bl OUIHING 1
69 EDLOOBO BRIICKtT L
(bTT*CHING P41TSI
10 I\NIHIIII ´•.´•~OLT´•´•´•´•´•´•´•´•´•´•´•´• ´•´•´•´•´•´•´•´•´•´•´•-´•´•r´•´•´• ’t
bN9b0-10L WI\5HER
----(i---

9935 CDLLIR 4ND BUIHINC eiSSY L

II~TICHING P49TSI
II nN3-Llb BOLT Z
nN960-L0L WIISHER
M520365-1032 i NUT Z
12 *N*-LOI\ BOLT 1
WIZSHER 2
Y520365-128 NUT L
-----li---

71 9935-3 CULLIH HILFI FWD IORDER NHIII L

7* 9935-1 HILF´• 4Fr (OnUtR
COLLbR NH*I 1
46189 ´•++´•BUIHIND.´•´•´•´•´•´•´• 2
75 ES10119 SP4CER *SSY L
I~TTbCHING PbRTSI
NUT L
UbSnEK 2
nSZ*615-L32 PIN. GOITER 1

16 *051 SPRING
71 9937 SHOE ´•´•´•´•r´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•
2
78 tDl0lb5 XISnEH 2
19 EO1OLbl SHIN bR

2-85
 ILLUSTRATED
ROCKWELL
BECTION n PARTS CATALOG COMMANDER
LANDING GEAR BOOA/B

FIDURt P d R T UNITS US*BLE

L INJ~X D E 5 C R I P T I O N PER ON
NUMBER N U n B E 9 1 z I 5 a I nssv CODE

2-19 80 EDlOiZO SPICER 2

Al 9565 IXLE 1
81 9566 PLUG 2
I*ITnCH1NG P4fiTSI
83 1Nb-714 dDLT ´•...r´•´•´•´•´•´•´•´•´•´•´•´•´•.´•´•´•´•´•´•´•´•´•´•´• i
NUT I

84 ED10~57 PIN 1
85 5-0310-0121 O-RING L
s~ EOLOOIb SPICER 1
61 11550-’62 RING, REI~INING L
88 9539 WISHER
d9 NO NUMBER WIPER, FELT 13/16 i: L/4 X 7-IN´• i
LONG)
90 9:3* BE*RING i
PL 2-0310-328R O-HING
92 S-OIio-Z28R I-RING i
93 EDIOL59 cnn
94 9531 dEnRING L
95 9661 PIN ´•´•´•´•´•´•´•´•r´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•.
I

96 9530 PLUG L
-97 i-03L0-220R ´•´•´•O-KINC´• L
98 ED1007I PLbTE I
99 ~nS5J-13L RlNci HETIINLNG L
-100 EO1OIZ1 TUBEI ORIFICE
IITTICHING PIRTS)
-101 nNln~d BOLT i
WISHER 1
---li---

-ioZ S-03LO-ZL01 J-KING 1

ESLOOI) i.. FORK ~ND 100 *SSY L
-103 ES10039 FORK INU BUSnlYZ biSY I
nblR9 BUSHING i
-104 tD10D74 ROD, PISTON I
-105 9529 SPICER
InTTLCHLNG PdRISI
-106 PN174-25P DOLT 1
1N960-416L WISHER
MSZ036*-LZB NUT L
---II----

-107 MS268L3-L CPP, nlR YIIYE I

-108 9NA09-L C~REI *IR YILYE 1
-109 MSZ8889-1 VPLVEI *IH .r´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•....t L
-110 *N90L-5d GPSKETI 1IR YILYE 1
-ill 9920 BODY PNO BUSHING 4SSY 1
-llZ EDloaXO BUSHING 2
-113 HIi5~01-1 FITTINGI LUBRIC*TION 2
-114 750003 BEdRLNG *SSY ISEE FIG. 2-511 REF

a-86
 ILLUSTRP;TED
ROCKWELL
COMMANDER PARTS CATALOO SECTION II
690A/B LAND~O GEAR

´•,a

~Y=;’ 12
\y=w

II

II

962
31

6~
r~
4-~:3
,I

~ieure ?-?O. No~s Landing O´•or Controll inrt.ll.fion

2-81
 ILLUSTRATED
ROCKWELL
BECTION n PARTS CATALOG COMMANDER
LANDING; GEAR BBOA/B

FIGURE P P R 1 UNITS USIBLE

C INDEX O E 5 C R I P T i O N PER ON
NUMBER N U M B E I 1 2 3 I 5 6 7 *SSY CODE

2-20 NO NUMBER CONTROLS INSTL, NOSE L?NDING (jEIR ISEE REF

FIG.
1 790330-187 HOSE bSSY´• GE*R DOWN I
790900-189 HOSE nSSYI 6E*R UP L
9NB)I-4D ELBOW i
L pN8jj~*0 ELBOW L
(ITTICHING P4RTII
5 ~N421-*0 NUT I
4N960P071bi WISHER 1

L 190330-191 TUBE ISSlt iE*l DOWN L

7 790330-L93 TUBE eSSYI GEIR UP I
I*TT*CHING 04RTSI
B HSZIPLPDGI CL4MP ´•´•´•´•´•´•´•´•´•´•r´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•.´•´•´•.

9 BOLT ´•´•´•´•´•´•´•´•´•´•´•´•1´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•. L
LO N1543n03-48 SPICER ´•´•´•´•´•+´•´•´•´•´•´•´•´•´•+....r´•´•´•´•´•´•´•´•´•´•´• L
dlN9~00LO WISHER L
RS210)LN) NUT 1..............´• I
---1---

ii 11832-40 UNION Z
I4TTPCHING PPRTSI
nNP2*-4D NUT L
PH961)Pn116L WISHER 2
----li---

13 740310-53 TUBE nSSII iE*s DOWN ´•´•´•´•´•´•-´•´•´•´•´•´•´•´•´•´•r I

1C 190330-51 TUBE PISY´• jEbR UP .´•´•´•´•´•´•´•´•+´•´•´•´•´•r´•´•´•´• I
LS 790330-161 HUSE PSSYI NOSE GEIR STEERING
790330-161 .HuSt 4SSYI NOSE CtPR STEERING r´•´•-´•´•+´•´• I
IITTICHING PdRTS)
17 930017 CLIMP I
18 MSZIP19OGB CLP*P
iS dN3-4~ BOLT 1
PN3-bl .BOLT r´•´•............................... I
Zi NIZL’13DU3-L3 524CER I
PN960PU1OL WISHER 2
MSILU*)N) NUT 2

)2 190330-159 TUBE nSSII LEFT BRIKE (SEE FIG. 2-211 REF

23 190))0-16) r TUBE bSZYI RIGHT BRILE IStE FIG. 2-211 REF
190322 Y4LYE INSTL, NOSE ~HEEL STEERING KEF
24 190922-11 ROD I
15 N527979-4 CLtYLS I
IbTTbtnlNG P4RTS1
26 HSZolPZ-ZCL1 PIN L
27 NIS41HT3-9 SP4CER
1N9~0-10L WISHER I
PIN, CUTTER L
Z8 NUT I

29 RE83N ~EbRING nND ENO IEEY 121335) L

IITTnCHING P4RTSI
30 iNN3I1L4 BOLT I
31 N*543nT3-3Z SPICER I
IN960-10L WISHER 3
MS2101*N3 NUT 1
32 MSZLOBlNI NUT I
---t---

a-88
ROCKWELL ILIUSTRATED
COMMANDER PARTS CAT~LOG SECTION II
BSOA/B LANDING GEAR

FIGUHE P n p r
UNITS US4PLF
L INOEX O t I R 1 P T I O N PFR UY
hUMBtR N U M B E H L 2 3 5 a 7 PSSI cnor

2- no 33 Y-10Z YPLYE nSSY´• NCSE WHEEL STEERING L

I~TT4CHING O1RTSI
3* PN3-Zln BOLT
35 SPltiR i
4N9l0-LOL WbSnEfi C
*SLIOISN~ NUT

3e nSZCR26-)U TEE ´•´•1´•´•´•´•´•´•´•´•´•´•´•´•´•´•’´•´•´•-´•´•’´•´•´•´•´•´• 2

)7 dNP1Z-JU REUUCEK
38 7iC0bi-Z5 LILI~UER PSS’1 NOSE STEELING ISFE FIG´• REF
2-191
~9 7500b1-27 CILINDtK PIIY´• NIISE RETI~LT (PEt FIG´• REF
2-191
~O 330053 BtLLCRINK PSSI ISEt FIS´• l-iBI REF

2-88
 ILLUSTRATED
SECTION n ROCKWELL
HYDRAULIC PARTS CATALOG COMMANDER
SYSTEM 690A/B

GX,

ii
28

121

/i(
20 22

iT-f
IV9 /D
n

~ipur´• 1-21. S*l1´•n No~´• (Sh´•´•11 ot 4)

2.90
 lLLUSTRATED 8ECTION n.
ROCKWELL
COMMANDER PARTS CATALOG HYDRAULIC
690A/B SY8TEM

P n R T UNITS USdrLE
FIGURE
U E S C R 1 P T I O N PER CN
INDEX
N U H B E R 1 Z 3 1 i 6 7 *SSY GOOF
nUnBtR

2-21- T9033L HYDRI\ULIC SYSTEM LNSTLI COMPLETE REF

710330-L59 TUBE 1SSII LEFT BR~KE I

1
790330-ib3 TUBE *5511 RIGHT RRPIKE L

190330-189 no re nssv. ;E 48 up 1

4 190330-181 HOSE bSSY, GEPR DOWN 1

190330-173 TUBE 1SSY1 LEFT 8R4KE 1

5
6 790330-171 .TUBE ISSYI RIGHT BRIKt 1

7 190330-164 TUBE 4SZYI LEFT 8R4KE 1

TUBE iiSSYt RIGHT BK*XE I
n 790330-161
9 190530-175 TUBE PSTYI EMERGENCY PRESSURE 1

790310-179 TUBE IZSSYI RETURN 1

10
II 790930-181 TUBE 4ZSY, RETURN ´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•r
L

790330-L77 TUBE 1SSI´• EMERGENCY PRESSURE 1

12
lj 1~833-40 ELBOW ´•´•´•r´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•

1C 1N837-4D ELBOW ´•´•´•´•´•´•´•´•´•´•´•rt´•´•.´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•

L
IbTT*CHING PdRTS)
4N9Z4-40 NCT 1

4N9b0P0716C WIISHER i

6183~-40 UNION 5
15 ´•´•´•´•r´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•

(4ITICHING PPHTSI
bN924-40 NUT L

I\NPIDPDTIbL HI\SHER

16 1903)0-185 TUBE 1SIY1 RETURN I

17 790330-183 TUBE 455’11 ENERGEN~Y PRESSURE .´•.1..... 1

18 790330-193 TUBE bSSYI GE*H UP L

-19 190330-141 TUBE ~SLYI GEIZR DOWN 1

ZO 790330-5L TUBE *S111 GEIR UP ...´•1´•.......´•......

I

2L 790330-53 TUBE 1\SSY, QE*R DOWN 1

22 790330-b3 .TUBt ISSY1 RIGHT BIIKE

23 790330-61 TUBE PSSYI LEFT BRPKE

21 790330-55 TUBE EMERGENCY PRESSURE I

25 790330-57 TUBE
PSSII RETURN 1

26 T500~L-25 .CYLLUJCR 4SSYI NOSE STEERING ISEE FIG´• REF

2-L91
17 Y-1OZ Y4LYt *SSI. NOSE WHEEL STEERING ISEE REF
FIG. 2-201
18 150061-27 CYLIHOER ~SSY1 NOSE RETRP~T (StE FIG´• REF
2-191
7900L3 VILVE INIT L´• POWER BRI\KE REF
29 790119-501 V*LYE PISJI´• POWER BRi\KE, iH ILNCLUOES I
FITTLNGS)
30 7902)9-511 VILYE ASSY, POWER 8R4Ktl HH IINCLUDES 1
FITTINGSI
P1 4N833-4D ELBOW Z
I*TTICHING P4R1SI
32 bNb289DL NUT 1

33 5-0)11-90* RINGI U*CKUP 1

34 S-0310-901L O-RING I
---I----

35 nN834-*D TEE I
IPTTIC~LNG PPRTSI
36 PN6289D4 t NUT L

37 S-0311-90L RING, BPCKUP 1

38 S-0310-901R O-R1NG I
---I---

39 PNBO~-*D TEE I
InTTICHING PPRTSI
IO *N628901 NUT .......-r´•.................´•´•´•´•
L

ii 5-0311-901 RINGI BPCKUP I

~Z 5-0310-904R O-RING ´•´•´•´•´•´•´•r´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•
L
----1---

a´•81
SECTION n
ILLUSTRATED
ROCKWELL
HYDRAULIC PARTS CATALOG COMMANDER
8YSTEM BOOA/B

c~- II

31

1~ 39
31

32
33

,s
a

,P 63

Si
ic a~

SD

i as--a

~--52

()~I

~lpur´• 2-21. nvdr~ulir lylt´•n -I~ur´•lap´• N.I´• (Sh´•´•1? ol 4)

2-82
 ILLUSTRATED SECTION n
ROCKWELL
COMMANbER PARTS CP~TALOO HYDRAULIC
asOA/n SYSTEM

FIGUHE P 4 R i UNITS USIBLF

L LNOtX O E C R I P T I O N PER ON

NUMBER N U n B t n 1 2 i 5 a I nrsv coot

P-LL 43 790274-505 Y*LYE ISSI´• POWER 3R4Kt. iH 6 RH 1

(LESS FITTINGSI
I*TTPCHING PPRTSI
44 ~N3-7* 30LT IUNLY 3 REaD FOK LH INSTLI
4N960OLO II~HEH IONLI 3 REPO IUR LH INSTLI
MSZIO*4N3 NUT IUNLY 3 REOU FOR in IhT~LI 4

45 EO1ZLIS PLUG, YPLVE 1

4b 5-03 LO-125R 0-LIN6 L

41 i-031(1-017R r O-RING i
IR ES1I)IL-SO1 SPRING i\NO POPPET nSSY 1
19 E0iS013 SPPl~ii RETURN ´•´•1´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•
L
50 H10-3 NUT 1752371 1

51 liN561110~2H12 t SETSCREW 1

5L H1~-l NUT 1751311 1

93 L013179-1 RETblNERI CONNECTOR I

51 EU13451-1 LEYER 4Rn i

55 ELI\ZI-LO ´•.´•´•LIILL´•´•´•´•´•´•´•´•´•´• L
5h 1-0310-21611 O-RING 2
57 S-03L1-216 RINGI BICLUP 2

58 ES12136 PISTON *551 1

59 BOLT
i\N960PD)16 *145 HER 2
~O H10-4 NUT 1752311
bl ESL2714 BOUY bN~ BUSHIVG 4SSY ILH C RH
YILYES)
62 110110 BKI1CKETI POWER BR9KF YnLYE SUPPORT i
IbTTAtHING PPRTJ)
63 bNS-ZZn BOLT 1
~N?60D51b WbZnER i
MS21083Nj NUT I

bl 790013-*5 TUBE I
-65 790013-35 tOLLI1K 2
1102~a YILYE INSILI P*RKING aR4K~ sEF
66 85022~ HI\NDLE 1
P4RK LNG BRPK E 1 n
LITT*CHINO PIRTSI
b7 MlILlbL-17 PIN, RDLL i b

66 85051A-L LN~LE 1 4

69 MSIC16L-15 PIN´• ROLL 3 b

10 790238-L7 IHIFT i
860783-9*9 PLIC*RO ´•´•´•´•´•´•´•r´•´•
1 ii
ii 790238-19 TUBE i 1

IZ 790238-9 UNIVERSIL JUINT 1 P

73 790238-L5 SEIL 1
14 795238-19 PLbTE I

75 7902*7-501 Y4LYE 152Y, PIHKINI BRIKE IINCLUOES L

FITTISCSI
(4TTbCH(Ni P4KTS)
Ia 1N3-lt4 BOLT 3
PN960DIO WLSHER 3

17 900079-40-50 KE STRIC TOR 2

78 *N1289D4 NUT 2
19 5-0311-901 RINGI BPCKUP 2
Bo S-0310-90LR O-RING
dl I\NB1I-IO UNION
81 S-03LO-901R U-KING

CODL EFFECTLYE ON SEKIPL NUMBERS

4 6904 11100 THRU 11349

2-93
BECTION n ILLUSTRATED ROCKWELL
ByDRAULIC PARTS CATALOG COMMANDER
8Y6TEM BBOA/B

,3 .&i"

Irl

."’h
130 I
iiaQ
II?

’i.

Aoulr, 2-21. Hydroulb Sylem fo.olo8e Nets (Shest 3 of 4)

2-84
 ILLUSTRATED SECTION I1
ROCKWELL
COMMANDER PARTS CATALOG HYDRAULIC
880A/D WSTEM

P d a T UNITS USPIL~
FIGVRE
D E i C R I P T I D N PIR UN
C INDtX
U M 8 E R I Z 1 i 5 6 7 i\SSI COOL
NUMIEX N

83 190232-501 Y/ILVE, PPRIING BR4K E ILESS L

2-21
FITTINGSI
8L CCML SETSCREW LII~-ZB X I/i-iN´• LONGI L
85 65151 SPRING
66 ELl\lb-5 BILL I

87 19978 PLUG
~B P5116 SPRING Z

89 ELL-IO ~*LL 2

90 ELb-6 r
BPLL ´•´•´•´•´•´•´•´•´•r´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•
Z

91 l5i2820-1 t
SHIFT 1
D-RING I
92 S-03Lo-010R r´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•

43 E01Z8IS BCDY +´•´•´•´•´•r´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•

1

790239 VI\LVE INSTL, GEPR 8 FL~P CONTROL REF

91 7902SU-50L Y~LYE INU M4NIFOLO ISIY1 bEb~ dNO L

FLIP CONrRDL (CONSLSTS OF YPLVE,
YINIFOLD, ZEIL PLITtS *ND
FITTINGSI
I~TTICHING PIRTS1
95 ~N3-LP BOLT ´•´•´•´•´•´•r´•-.´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´• d

nN960D1O WISHER
---i----

iZN81j-*D UNION
47 dN815-6D UNION Z

98 dN9L9-60 RtUUCER
19 1NIB)D6 TEE Z

-100 PN90101 Tit i

-LOL NUT .r´•´•...............´•.´•´•´•´•´•´•´•´•´•´•

2

ioZ *NbZ69D6 N~T

-103 S-03L1-90* R1Nt´• BICKUP I

-L04 1-0310-904P D-RINj

-iOS S-03LI-90b KING, SICKUP 2

-10b j-0310-906R O-RING

-107 900079-C-63 iltSTRICTOR, EL DOW i

790231-509 YILYE, GEIR FLLP SEL~CTOK IltSS L

FLTTINGSI
-iOB L01005C-I VPLYEI GEPR PNO FLwP CONTROL 1
(13760)
I~TTLCHING P4RTSI
-109 NSL007’ror32 BOLT ´•´•´•´•´•´•´•´•.´•´•´•´•-´•´•´•r´•

WISHER i
IN460C116

-110 L6606~39-115 O-RING IT3Tb~l 2

-111 lIbOLI39-5 O-RING (7B7601
-112 16606~39-2 O-RING 1737601
-113 .....D-RING L7)760L 2

-II~ L065136 G4S*~O-IEbL 1731601 1

-115 58IY5DF2-01 ~LNIFOLO (131b~l 1

-iib 710Z39-L3 CHINNEL 1

-117 790239-9 DOOR 1

IbTT*CHINS PPRTZI
-118 nS27039-L-10 SCREW II
-llS MSL7039-L-09 SCREW Il

-L20 850503-23 HOSE nSSYI nYO PRESSURE LFROM GEIR I

FLIP SELECTOR YPLYE TO HYO PRESSURE
ii\GE)
-121 850110 GPGE´• HYO PRESS. ISEE FIG. 2-301 REF

2.95
 SECTION n
ILLUSTRATED
ROCKWELL
HYDRAULIC PARTS CATALOB COMMANDER
SYSTEM 880A/B

I,,
111

K´•Ii
113 110

Y
IX-/ I I in~i, 1--116

:----S
~I

i
B

~igure 2-21. Syrtem rulel.ge Note (Sheet 4 .f 4)

2-88
 ILLUSTRATED SECTION II
ROCKWELL
COMMANDER PARTS CATALOG HYDRAULIC
BL)OA/B SYSTEM

FliURt P e n r UNITS US~BLE

6 INDEX D E 5 C I P T I O N PtP DN

NUMBcH N U M 8 E R 1 2 3 5 6 1 bSSY CODF

Z-Z1 -LZ2 C*-D32-9(18 CI\8LE i\lSYI PPRKING SR*KE 170’r161 L

IITTPCHING "4RiS)
MSZL9190G3 CLIUP L B

lN142-3 CLIWP 1

-125 *N3-3n 8ULT Z

I(N960-L0L ´•´•HI\II1ER 2 H
MIZLO~*N3 ´•´•IUUT´•.´•´•´•´•´•´•´•´•´•´•´• Z

-126 190238-11 BRPCKET L 8

IPTT*CHING PIRTSI
-iZI MSZ4b9C-~L1 SCREW Z B

-128 NIS*3DD3-Lb SPICER 2 B

i\N460-R ´•´•YI\IHER Z
~SZ114*C08 NUT R

-1)9 190238-23 tSCUTCHEDN S

-L30 140341-1 CDNTROL bRn .....´•....r..............

L B

IPTTICHING PIRTS1
-131 MSI6562-15 PIN. ROLL 1 8
-132 nN3-3 BOLT L e

PN960-LOL W4SneR L 6

MS~IO1Z-3 NUT

CODE EF~ECTIVE ON SERLIL NUnBEPlS

B 6408 11350 *ND SUBS

2.91
 1I
Ee~
n

so _V i. 3

a 1?

U
Ji~
U

~s ns
so

lo
18

p_
,r

ias
81111~ D
rl ,1
15

61 is
L X j,

16 JO
P 28

g
a,,
 ILLUSTRATED ~CTION n
IdOCKWELL
COMMANDER PARTS CATALOG HYDRAULIC

BOOA/B SYBTEM

P I R T UNITS US*BLE
FIGURE
D E I C R I P T 1 O N PER ON
E INDEX
N U M B E R I Z 3 4 5 6 I *SSY CODE
NUMBER

2-22 190329 HYORPULIC PIPING INSTL´• 3LG´• CENTER L

FUSELIGE 5 RH N*CELLE
190330-b5 TUBE *ISI, GEIR UPLOCK L
L ..............r´•

2 190330-2*3 TUBE ~SSY´• GE*R UPLOCK 1

3 190330-91 HOSE *SSY. GEbR UPLOCK 1

4 790330-21L TUBE *ZSY´• GEIR UPLOCK 1

5 790330-233 TUB E *SSI, GEIR UPLOCK ´•.1´• 1

190330-63 TUBE *SSYI RIGHT BRI\KE I
i 1903)0-251 TUBE RIGHT BRIKE I
190330-155 HOSE *ISI. RIGHT BR~I(E ISEE FIG´• 2-13) REE
B
D 790330-41 TUBE bSSY´• GEIR DOWN I

10 7903)0-245 TUBE *SSY, GE*R DOWN .......´•rt.......´•

1

11 110330-91 HOSE i\lSY. GEI\R DOWN 1

it 190330-L2L HOSE *SSY´• GE*R DOWN .´•´•´•i´•´•´•´•´•´•´•´•´•´•´•´•´• I

1’10330-99 HOSE 1SSYI GE~R DOWN L

L3
L4 790330-213 TUBE *IIY, GEI\R DOWN 1

190930-231 TUBE 1SSI´• GEIR DOWN I

15
16 790330-49 TUBE *SJI´• GE*R UP 1

17 190330-247 TUBE PISY´• GE*A UP ´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•1 1

790330-9) HOSE lSSI´• GE*R UP L
Is
19 190330-95 r HOSE 1~SI, GEIR UP ´•...........´•´•´•´•´•´•1´•
I
20 iso3so-rls TUBE nSSY, cEnn UP 1

21 190)30-229 TUBE nSSYI GE*R UP ´•1´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•

1

22 190330-265 TUBE *SSY´• FLIP UP ´•r´•

1
23 790330-251 TUBE 1151´• FLIP UP L

190))0-111 HOSE *SSY. FLIP UP I

2*
790330-119 HOSE *SSY, FLIP DOWN I
25
2a 7903)0-259 TUBE nisr, FLIP DOWN 1

27 190330-b9 TUBE I(SSY. FLIP DOWN L

28 790330-61 TUBE *S IY 1 LE FT BR~KE 1
29 1903)0-237 TUBE *SIY1 LEFT BRLKE I

190330-31 TUBE *III´• PRESSURE 1

30
31 790330-223 TUBE ~ITY´• PRESSURE 1

)2 790330-)9 TUBE *SS~, RETURN ´•´•´•´•´•´•´•´•´•´•´•´•l´•´•´•r´•´•´•´• I

-33 790330-215 TUBE *55’(1 RETURN I

190330-*3 TUBE *SSY´• RETURN 1
35 190330-59 TUBE nSSY1 EMERGENCY PRESSURE 1
3P 190330-221 TUBE *ISYI EMERGENCY PRESSURE 1

37 190))0-2L7 TUBE *SSY I EMER GENCY GE*R DOWN (SEE REF

FIG´• 2-171
31* 190330-321 TUBE PSIY´• EMERGENCY GEaK DOWN ISEE REF
FIG. 2-171
378 190330‘325 TUBE ~SIY1 EMERGENCY GEPR DOWN IStE r´•´• REF
FIG. 2-111
38 79033(1-2*9 TUBE ISSI1 EMERGENCY GEI\H DOWN LSEE REF
FIG´• 2-111
190330-311 HOSE *ISY1 EMERGENCY GEIR DOUN LSEE REF
39
FIG. 2-ii)
48 790330-235 TUBE *ISY. EMERGENCY GELR DOWN IStE REF
F1G. 2-17)
41 190330-321 TUBE 1551. EMERGENCY GEIR OOYN LStE REF
FIG´• 2-111
)2 610488-107 HOSE 1SSYt HYDRbULIC SUPPLY LSEE FIG. REF
2- 01
190330-3 TUBE
*SS1. SUPPLY I
*3 ´•´•´•´•1´•´•´•.´•´•´•´•´•´•´•´•´•´•´•´•

44 190330-241 ISSY,
TUBE SUPPLY ´•-´•´•´•´•´•´•´•´•´•´•´•-´•´•´•´•t 1
45 790330-261 .TUBE *ISYt SUPPLY .....´•...´•.1´•.´•´•´•´•´•´•´• 1

48 1903)0-221 TUBE nSSYI SUPPLY 1

47 LL0488-109 HOSE nSSY. HIDR*ULIC PRESSURE ISEE FIG´• REF
2- b)
48 790330-29 TUBE ~SIY´• PRESSURE 1

7P0330-239 TUBE bSSYI PRESSURE I

49

2-88
 ILLUSTRATED
BECTION n ROCKWELL
HYDRAULIC PARTS CATALOG COM.MANDER
BYSTEM seoA/e

FLGURE P d R T UNITS USPIBLE

I INDEX D E 5 C R 1 P T L O N PER ON
NU*BER N U H B E R 1 2 3 1 5 b I IIIY CODE

2-22 50 790330-203 TUBE nSSI, PRESSURE ´•.´•´•´•´•´•1´•´•´•´•´•´•´•´•´•´•´• L

-51 79033(1-219 TUBE *SSI1 PRESSURE 1
52 790330-33 TUBE 1SSI, PRESSURE L
53 710022-501 CYLINDER *SSY, *UXILI*RI RETR*C’ ISEE REF
FIG. 2-131
5~ 110(119-502 CYLINOER *ITY. HIDRIULIC, RETR*CT I RH REF
GEPR INBO ISEE FIG´• 2-131
15 79022B-5L9 CYLINDER 1SSY1 UPLOCK, RH (SEE FIG´• REF
1-161
5b 510003-3*1 CYLINDER *SSYI FLIP rZCTU*TING ISEE FIG´• REF
Z-I~)
51 790207-505 V*LVE bSSY1 FLIP CONTROL IINCLUDEI 2
FITTINGSI
58 1PbB-*-II´•Lo YILVEI FLOW REGULITDR ILESS FITTINGSI L
1822111
59 71002~ .CYLINDER *SSY dND INSTL, Gt*R *(R 1SEt REF
FIG. 2-171
60 7903)2-501 PUHPI HYDR*ULLC ISEE FIG´• 2- 5) Rt~

2-100
 ILLUSTRP;TED SECTION II
r´•ULFSTREAM
COMMANDER PARTS CATALOG HYDRAULIC
680A/B90B SYSTEM

OL
L)Z:

U~I

,i
D

~ipure 2-20. Hydr.uli. ly.t´•m LH N..´•ll´• (Shss~l ~f 4)

z.dl
GECTION 1l
ILLUSTRATED
OULFSTREAM
HYDRAULIC PARTS CATALOG COMMANDER
SY8TEM 880A/6808

FIGURt P R T UNITS USIBLE

L IN~EX D E I C R I P T I O N PER ON
NUHBtR N U n a E n 1 2 1 r 5 a r nsiv coot

1-23 790328 EOUIPIIENr INSTL, LH N*CELLE REF

1 790330‘Ll TUBE 191*, IUPPLI´•´•´•,.´•. I
2 7903)0´•19 TUBE ~SSI, PRESSURE 1
3 190330-31 .TUBE 1551, PRESSURE 1
790)30-(5 TUBE 1SSI, RETURN 1
´•i 790330-103 TUBE 1SS*´• RETURN I
6 190330-81 TUBE *557, EIIEROENCI PRESSURE .´•´•I´•´•´•´•´• I
1 790330-205 TUBE 1551, RETURN L
8 790330-L9l TUBE 1.551, SVPPLI´•´•´•´•´•.´•.´•..´•´• L
9 TUBE ISS*, EHERGENCI PRESSURE L
-10 790J30~L99 TUBE 155*, EHERbEHCI PRESSURE I L
190310-291 TUBE 6551, EIIEllbEHE* PRESSURE L BC
11 790330-99 HOSE 1551, bE*R oown I
12 790330-103 HOSE LSS1I GEIR UPLOCI 1
13 790130-101 HOSE GE*R UP 1´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´• 1
LI 190330-311 8058 151*´• EIIERCEHCI OELR DOUN (SEE REF
Flb´• 2-ii)
190330~303 TUBE 15171 EIER6EHC* GEIR DOYN ISEE REF
FIb´• 2-17)
16 190330-107 TUBE ~5SI´• EHERBENE* GEIR DOYN ISEE REF
FIG´• 2-111
11 81018(1-105 GLCE´• 618 PRESSURE ISEE Flb´• 2-L7I REF
18 790330-91 HOSE *SI*´• GE*R OOYN 1
19 790330~93 HOSE LSSI´• GELR UP 1
20 790330-301 HOSE LSS*, LEFT BR(1IE 1
-21 790330-11 TUBE *55*´• SUPPL* ´•´•i´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´• 1
-22 190330-17 TUBE *SI*, PRESSURE 1
23 610(88-10’1 HOSE *IS*´• WPPLI´•´•´•´•´•´•´•´•´•´•´•´•´• 1
-2( 610)88-109 HOSE 3551, PRESSURE I
25 (110188~93 HOSE LSSI, OIL OR*IN 1
26 1903)0‘195 TUBE lSS*. HIORLULIC VENT I
710022-501 CILINOER LSSI (SEE Flb´• 2-131 REF
28 710019-101 CIL1HDER *55*i HYOR*ULICI i(ETRLCT (IEE REF
FtG´• 2~13)
19 1902L8-’113 CILINDER 1551, UPLOEI (SEE Ff 6´• 2-16) REI
-)O 790332-501 PU*P´• n*OILUIC (SEE FIb´• 2- 5) REF
´•)L *NB112-LO UNION L
IITTLCHINb P*RTl)
*H9LI-10 NUT I
YISHER 1
---1---

)1 1HB32~L UNION ´•´•´•´•´•´•´•´•i´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´• 1

(ITT*CHlNC PIRTSI
*n9L1~6 NUT I
38960-916 YLSHER ´•´•´•´•´•´•´•´•i.´•.´•´•´•´•.´•´•´•i´•´•´•´•´•´•´•´•´•´•´• 1

.33 1NB11~100 ELBON 1

ELMIY 1
-35 1N831~6D ELIIIY Z
IITTLCHIHb PIRlS)
INP1I‘L HUT ´•´•´•´•´•1´•´•´•´•´•´•´•´•´•´•
1
IH9b0P0s16L U*SHER ´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•i´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´• I

CODE EFFECTIVE ON SERI*L HUI(BERI

690L 11100 THRU 11)09
B 6901 11306 THRU 111)9
C 6908 11350 1ND SUBS

2-102 nevisod: 2R Novombel´• 1P84

 ILLU~TRATED SECTION n
r.ULFGTREAM
COMMANDER PARTS CATALOG HYDRAULIC
880A/680B BYSI~EM

ill,

re,

rs

res
333
131

338

k i
sso

33
EI
13

s~ 13

sl~
II

pi.ur´• 1-23. H*drouli~ Sylt´•. LH (Ihs´•~ 2 of 4)

a-103
 ILLUSTRATED
BECTION n OULFSTREAM
HYDRAULIC PARTS CATALOG COMMANDER
8Y8TEM 680A/680B

IIGURE P iZ R T UNITI USIBLE

L INOLX O E i C R I P T I O N PER ON
LUMBER N U n B F n 12 p r 5 b 7 aszv tOOE

2-23- )b 111833~(0 ELBOY 3

(111108180 P*RTSI
IN921-)D NUT 1
In960POI16L Y*JHER

31 18801-10 TEE 1
II~TICIIINC PLRTII
18921-10 HUT ´•´•´•´•´•1´•´•´•´•´•´•.´•´•´•´•´• 1
IN96OPDII6L U*PHER 1

38 TEE I
I*~T*CHINC PLRTS)
18921-10 NUT 1
W*IHER L

-39 *ILL908-~C ELIOY 1

(*Tr*CHING PIITS)
LN)))~ID HUT 1
IHP60P0116L YISHER 1
---i´•---

-(O 190130 REOULlrOR 1351. H*OR*ULIC 1

(IrTICnlNG PIRTSI
-IL *(13-)L BOLT
LH96DPD10 WLsHER Z
1~1101)H9 HUT Z

*Z 7L3038 YILVE, CHECI (90 DEGREE ELBOY) 1

Il H~L31 VILVE, CHECI ((I DEGREE ELIOYI t
(061391
IN83(-6D ´•´•RE´•´•´•´•´•´•´•´•´•´•´•´•´•´•´• I
INLI3)-~D ´•´•ELBOY´•´•´•´•´•´•´•´•´•´•´•´• 2
(111108180 PIRTE)
-16 lNLLEPDL MIT
1-0111-906 ´•´•RINb´•B*CIUP
S-0310‘eOLR ~Rrnb 1

I) ELIl63 REGVL*TOR 1851 1

IB EDILLB1 CLP, LDJUSTIHG ´•´•´•´•´•´•´•´•.´•.´•..1..´•´•. 1
(*TTLCHING PLRTSI
I9 *52901 NUT ´•´•´•´•´•´•´•´•´•´•.´•i´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´• 1
---I---
50 1‘0310-113R PRI*b 1
51 illlb SPRING I
-52 15106 ´•´•´•bUIDE´•´•´•´•´•´•´•´•~´•´• 1
5) 178II POPPET lND SElT ~511´•´•´•´•´•´•´•´•´•´•´•´•´•´• 1
I-0310-113R O~IINO
5) 8012)91 PLUG, ECREY 1
IITTLCHING P*RTSI
56 16113 LOCKHUI I

-51 S~0310’112R ´•´•´•O-RING´•´•´•´•´•´•´•´•+´• ´•´•´•´•´•r´•´•´•´•´•.´•´•´•´•´•. L

-58 16590 ´•´•SPRING L
59 L8LI0 PLUNGER L
596 s-oslo-olla O~RING
)98 EOI1(P1 TRINIFER fElT 1851 L
-59C EOL~1)7 YISHER ´•´•´•´•´•´•´•´•´•´•´•´•´•´•.´•I´•´• L
590 EOL11~6 SCREEN ´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•i´•´•´•´•´•´•´•´•´•´•. I
60 EOI1LIO ISEE
C*P, UNLDIDING FIG´• 1
6L 5-0310-2138 O-RIHb 1
62 11968 SPRING 1
-63 ED12269 ´•.´•GUIDE, UNLOLDING ´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•t I

a´•104 Rrvised: 28 Novenlbul´• 19X4

 ILLU~TRATED
ROCKWELL 8ECTION II
COMMANDER PARTB CATALOG HYDRAULIC
690A/B SYWEM

8:

ii I

.IP"

b, ii
M

~igure 223. Syllem LH Notelle (Sheet 3 of 4)

2-105
 8ECTION II
ILLV87RAT~eD
ROCKWELL
HYDRAULIC PARTS C~TALOO COMMANDER
8Y8TEM BSOA/B

FIGURE P 4 R T UNITS US*BLE

G INDEX D E I C R I P T I O N PER ON
NUMBER N U M B E R 1 2 3 5 b I I\SSY CODE

1-23- 64 ELn16-18 t BPILL r´•´•.´•´•´•´•´•´•+´•´•´•´•´•´• 1

bl N*E669-93 RINGI RETIINING L
66 tDL22~B IL*TI UNLD*DING ´•´•1´•..´•.´•.......... L
-01 S-0310-ll~R ..´•O-RING´•´•´•´•´•´•´•´•´•´• ´•´•´•1´•´•´•´•´•´•´•´•´•´•´•´•´•´• 1
b8 EDIZZL7 PLUNGER ´•´•r´•´•´•´•´•´•´•´•´•´•´•´•´•´•.. ´•´•´•´•´•´•.1 1
bB* EO12272 FITTINGI PLUG L
688 S-0310-LL6R O-RING 1
69 S-0310-1L2R D-RING L
70 ~6611 CHECKNUT 1
71 *6610 GUIDE I
12 15716 SPRING 1
73 1\6668 POPPET I
74 ES12265 HE*D *ND PLUG *IIY L
15 ED12264 LOCKNUT r.´•.............´•.......... 1
-75i\ 8012262 ´•´•´•BR*CKET. MOUNTING L
16 I-0310-Z~BR ..´•D-RING L
-17 ED12259 ..´•BDDYI *CCU*ULLTDR 1
-78 E012260 PISTON 1
-79 EL836336 O-RING (865191´•´•.´•.....´•.´• I
19* ED12261 RING, BbCKUP 2
80 HSZB889-L V*LVE. blR .´•.´•´•´•...........´•..1... I
8L 1903*0-1 MOUNT PL*T E L
(*Tr*CHING PIRTSI
BI* PN~-5* BOLT ´•´•r......´•´•´•.......´•..1....´•...... 4
Y*THER
*SZ10*4NI NUT
---I---

82 P-1Lb-D i PUMP ISSY 1616101, ERERGENCI BRIKE I

1645601
(*TT*CHING PIRTSI
83 MSZ007*-OI-O~ 8DL1 ´•´•´•´•´•´•´•´•...´•´•t I
*N9600~L6 W*SHER
---F---

84 ELBOW ´•´•´•´•´•´•´•´•´•´•´•´•´•´•r´•´•´•´•´•´•´•´•´•´•´•´•´•´•.´•.. 1
85 INB16-4D NIPPLE I
86 H-L35 V*LYE´• CHECK 190 DEGREE ELBOW) l0L239) 1
81 1NB15-ID UNION 3
88 I-0310-90~R O-RING
89 *N931-40 CROSS I
90 800231 SWITCH 45571 HYDRIULIC PRESSURE I
(INCLUDES FITTINGSI
I~TTICHING PLRTSI
90a nszlp19Dc16 cLlnP 1
PI *N3-13~ BOLT .......´•´•´•r´•´•..´•....´•´•..´•´•.´•...... 1
NI\S43P03-~0 IPI\CER L*LT PIRT N*013DD3-ll)
*N960DIO WPSHER -´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•1.............. I
M5210**N3 NUT 1

92 *NB15-4D UNION 1
9) S-0310-90*R O-RING L
9* 15194 SWITCH PSSY´• HYD PRESS. ILESS I
FITrlNGS) 1020051
PI 790223-507 RESERYOIR *5EY´• nYDRI\ULIC I
(*TT*CHING P*RTSI
-96 *N3-)* BOLT ..´•.........1´•´•´•.´•

LNPIOPDLO WI\IHER 4
HS~104*N) NUT

91 790223-11 COYER *SSY I

PB 790223-7 C*P *ND NECK nill ´•´•´•´•´•r´•´•´•.´•´•´•´•´•´•´• 1
-99 H520822-40 ELBOW 1
-lo0 HS16562-C PIN, ROLL ´•1´•´•.. 2
-101 190223-5 PL*TE ....´•.´•.´•r´•´•´•1.......´•.´•´•´•... 1
-102 2001\0 1/I LOCK SE*L L4568LI i

a-toe
 ILLUSTRATED
ROCKWELL SECTION n
COMMANDER PARTS CATALOG HYDRAULIC
690A/B SYSTEM

P
1
ill

6. i,

ii

911 a

\1
ill

(21--6

IlaQ b
111,
-4?
,1,

Figure 1-23. Lyltem LH Neroll´• Ishest 4 of 4)

2-101
 BECTION n :ILLUSTRAT~ _-) ROCI(WELL
BYDRAULIC PARTB CATALOG COMMANDER
BYSTEM BsOA/B

FIGURE P R T UNITS US*BLE

8 INDEX D E S C R I P r 1 O N PER ON
NU*BEI N U n B E n 1 2 r 5 6 7 arrv CODE

2-23 -103 ~N970-4 UnSHER 2

-10* 16 SPRING I71LI7) ´•.´•´•´•´•.´•1........... I
-105 I\N9600L16 W*SHER I
-106 790223-3 r BOLT ´•´•´•´•´•´•´•´•´•r´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•... L
-107 190081-503 COVER L
-108 T90013 G*SKET I
-109 *N6238-1 G1SIET ´•´•´•´•´•´•´•´•..´•´•´•´•.´•´•.r+´•.´•´•...+.´• 2
-110 *Nb236-2 FlLTER ´•´•´•´•´•´•´•´•´•r´•´•´•´•´•´•´•´•´•´•´•´•´•r´•´•´•´•´•´• L
-111 I\NPI9-60 REOUCER L
-112 I\NB15-6D ´•´•UNION 1
-113 dN823-60 ELBOW 1
P~0310-P06R ´•´•O-RING Z
-115 HS2OB2Z-L0O ELBOW 2
-116 630161 YIIVE 2
(*TTICHING P4R~SI
-LII 1N3-I~* BOLT ´•´•´•´•......´•´•....1...............

*N960D10 U*SHER I
M1210L4N3 NUT I

-Lls 6300*6-505 ..*D9PTER i

-119 S-0310-21bR O-RlhlG IFURNISHED UITH 630161 VILVEI REF
-120 ~N815-4D UNION I
-1ZI S-0310-904R O-RING 2
-122 790214-511 VILYE, RELIEF 1
-123 120037 IDIPTER I
HS2D913-20 PLUG 1
-125 *N917-20 TEE I
-126 *NPII-2D NIPPLE I
-IZI 190088-105 RETERVOIRI NI\CRINED C*ITING I
-Izs narmlcron I
-129 HS)5*89-6 GROnnET 1

a-108
ROCKWELL ILLUBTRATED BECTION II
COMMANDER PARTS CATALOG HYDRAULIC
BOOA/a SYSI~F.M

OL

c /al I B

1-2~. Hydrouli~ londinp Oi~, Doon (Sh´•´•tl ol 3)

2-108
 ILLUOTRATED AOCKWELL
SECTION n
HYDRAULIC P~RT8’:CATALOO COMMANDER
seoA/e
SYSTEM

1 26

a::

Filur´• 2-2~. Sylt´•n-M~in L~ndinl O´•~r Doorl (Sh´•´•1 2 ol 3)

a-llo
 ILLVSTRATED
I~OCKWELL SECTION n
COMMANDER PAATS CATALOG HMRAULIC
asOA/e 8YSTEM

FIGURE P n n r UNITS USnBLE

6 INDEX D E S C R 1 P T I O N PER ON
NUMBER N U H B E R L i 3 15 b 7 *ZSY CODE

2-21 190331 HYDRPUL LC SY STEW INITL r...´•...... REF

790329 HYOR*ULIC PIPING INSTLI MIC REF
L 790330-L01 HOSE assv, cEan up, LH ISEE FIG´• REF
Z-23)
190330-91 HOSE 1\SSY´• GE~R UP´• Rn (SEE FIG´• REF
2-221
Z 790330-331 HO SE i\S IY´• EMERGE hlCY i t~L DOWN, LH REF
IIEE FIG. 2-231
IYU330-33L HOSE ASSY1 EM~RGZ4CY Gtbh DOWN, RH RE~
ISEE F1G. 2-22)
3 790330-93 HOSE bS~YI GL*R UP ISEE F1G´• 2-231 REF
r90330-91 HOSE *5SY´• GL*R DOWN ISEE FLG´• 2-221 RFF
5 790330-121 HOSE *5SY1 GE*R DOWN L
790330-99 HOSE bSTY´• GEPR DOWN L
7 790330-127 TUBE PSSY1 GE*R DOWNI LH L
7P0930-L~1 TUBE I\SSYI Gt*R DDWN. RH I
8 7903)0-12) HOSE I\SSYt GE*R UP L
9 790330-L29 TUBE ~SSY´• DOOR LLOSE L
10 790330-1~3 TUBE PISYI DOOR OPEN 1
LI 790330-131 TUBE nSSY´• DOOR [IPEN
1Z 190330-141 HOSE PSSY´• DOOR OPEN 1
13 790330-145 riOSF *SII, DOOR CLOZE L
LI 790330-133 TUBE asfY, DOOR cLasE 1
1S 790130-L49 t HOSE *S SY I DOOR C LOS E I
16 7903)0-125 TUBE *SSY, GE 4R VPI LH i
190330’L39 TUBE nsrv, ctnfi up, nH I
II TEt i
lnTTncHIre Pnnrsl
18 ~NPZ*-cD NUT ................................t I
*N9bOD7lbl W*IHER ´•´•´•´•´•´•´•´•´•´•´•-´•´•´•´•´•´•´•´•´•1´•´•´•´•.... 1
---I---

IP030I VPLVE LNITL´• PRIORITII LH L HH REF

L9 bNB3Z-*D UNION
20 iiN8S*-ID TEE
2L 1Ne28904 i NUT 2
22 ~-03LO-90"s O-RING 1
23 1-0311-40* H1YU, BLCKUP 2
2’t 790301-505 YLLYE 1~IY´• PRIORITY L
25 2979011-L HETdlNtR I
26 S-0?10-1I2R U-KING 1
27 2179009-1 ´•´•STUD+´•´•´•´•´•´•´•´•´•´•´•´• 1
28 2919008-1 SHIH I\R
29 SPRING IFOR -507 ONLY) 1
30 29790L0-1 SE~T ~SSY 1
31 S-0310-LL3R ´•´•´•J-RING´•´•´•+´•´•´•´•´•´• 1
32 2~79005-1 POPPET ´•r´•.......................´•´• 1
33 1-03 LO-OOLR 3-R1NG I
34 MSL50454 BILL i
35 2919006-1 BUTTON I
)6 2979007-L SPRING I
)7 294030-1 RETPINER *SSY 1
38 2179011-1 BJD11 VLLYE L
190302 Y/LLYE INSTL, DOOR CONTROL REF
39 190302-15 YILVE *SSI. DOOR CONIROLI LH 8 RH 2
IP~T*CHLNG PIRTS)
)O dN3-~1 BOLT 2
*N960P010 WbSHER 2

41 PNB33-*D ELBOW 1
12 nNBB7-’tD ELBOW L

a.lll
LIECTION U. ILLVSTRATED ROCKWELL
HYDRAULIC PARTS CATALOG COMMANOER
SYSTEM 880A/B

~s

9~ i" 1~98--EI
--J

Bi~s..
a

~ilur´• 2-24. Hydrlluli~ L.nd(ng O´•.r D~o.r (Sh´•´•1 3 of 3)

2-111
 ILLVSTRATED
ROCKWELL SECTION n
COMMANDER PARTS CATALOG HYDRAULIC
BOOA/B SYSTEM

FIGURE P 1"T UNIIS USPBLt

L INDEX D t S C R i P T I O N PER ON
NURBER N U M B E I L Z 3 C 5 d I 1SSY CODE

2-24- 13 PINBO’I-LD TEE I

CI ~NB15-*0 UNION L
L5 4NLZ890* NUT 3
46 1-0310-904R O-PINS I
LI 2-03LL-90~ RING, BPCKUP 3
48 790100-535 YPLVE, DOOR CONTROL L
*i 297600 3- L GLI(ND I
IPTTICHI~C PIRTSI
50 PIN Z

-51 S-03LO-010R O-RING I

ill n52877*-10 RING´• 3nLKUP i
-5~ S-03LO-OLZII U-RING
53 291(002-L ..´•´•PLUNGER´•´•´•´•´•´•´•´• L
5~ 2976001-1 SPRING L
55 ND NUMBER SPOOL (PIRT OF Z916100-L HOUIINGI L
56 2976100-L HUUIING
57 2Y6600L-I ORIFltE L
-58 195302-9 ~R4CKET 1
(nTTbCnlNG PIRTSI
59 n527039-1-08 SCREU 3
INPbOPO11 NISn~R 3
NUT 3

bO 2b0048-1 BR4CKET PSSY L

IlTTPlCnING P4RTSI
61 nN3-*1 BOLT ´•´•´•´•´•´•´•´•+´•´•´•´•´•´•1................ i
WPSHER 2

100304 YILYt INSTL, PRIORITYI LH C RH REF

62 1N81)-ID UNION L
e3 *NBOI-4U TEE L
b4 ~N628’04 NUT I
65 I-0310-90LR ´•´•U-HING 2
LI 2-0311-404 RIUS´• 8*CKUP I
67 79D301-50L YILYE´• PRIORITY ISEE OET*IL 4 FOR I
BRCIII(DOWNI
IPTI*tHING P?RTSI
68 nI21031-L-16 SCREW ´•´•´•´•´•...´•´•´•´•´•+´•+´•´•´•´•´•´•´•´•´•´•1.... i
*N9bO-LoL ~*SHER Z
*5210R)N3 NUT 2

69 ZST9012-i SPRING IFOR -501 OYLYL L

10 7L0019-501 CYLINDER bPSI, HYORIULICI hETR(\CT ISEE REF
FIG´• 2-131
II 710022-50L (ILINDER ~ITY´• bUXILIPRY R~TRltT (SEE REF
FIS´• Z-L1)
72 113062-50L CYLINDER ISSY ISEE FIG´• 2-’til REF

2-113
 ILLUSTRATED
SECTION n ROCKWELL
ELECTRICAL PARTS CATALOG COMMANDER
SYSTEM 690A/B

I-
r/
J r

233
l;i 112
111
Ra

E :~-CL/ i

’ici
221

x u
,,o
w

i
c
‘r/
234

A B

ol~
b

a,. 1:´• ´•’p

Figure 2-21. Iquipnenl IShsst I or12)

2-114
 ILLUSTRATED BECTION n
ROCKWELL
COMMANDER PARTS CATALOG ELECTRICAL
690A~ SYP~EM

FIGURE P I R T UNITS USIBLE

L INDEX D E 5 C R I P T i O N PER ON

N U M a E n 1 z 34 5 6 7 nSSv CDDE
NUMBER

800571 EIUIPMENT LNSTL. ELECTRICIL ReE 4

Z-Z5
8006bl EBUIPMENT INSTLI ELECTR1C4L REF a

800029 SWITCH INSTLI NOSE GEPR KEF

800503-L ..4CTUI\TUR ~SSY P

I
2 HIZSZ53-I SWITCH ´•´•´•´•´•´•´•´•´•´•´•´•´•r´•´•´•´•´•
2
L~TT*CHING PIRTSI
3 nS35206-220 SCREW Z

nSZIO*INOI NUT Z

4 800029-LL SPICER 2

5 800029-13 INGLE nSSli LOWER ´•´•´•´•r.´•´•´•´•´•´•´•´•´•´•´•´•´• L

800029-14 INGLE iiSSlt UPPER

I4ITICHING P4RTSI
n535200-230 SCREW 2

4N9L0DL W*SH~R ´•´•´•´•´•´•r´•r´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•

2
---t---

1 800029-7 IRICKET L
I*TTPCHING P4RTSI
8 INI,-aI aoLT 2

IN9600416 WISHER
MS210*INI NUT 2
---I---

800202 HORN INSTLI LINOINC GEPL WIKNING REF C

BOObii HORN INSTLIL4NDING GEI\R nNO STILL REF BL1

WPRNING
9 53534-3 HORNI LdNOLNG GEIR WIRNING I C

284 .HORnl WIKNING I83P26I 1 D

IITT*CHING P4RTSI
-10 MS35206-2*6 ´•´•SCREW 2 C
nN96DDBL i WISHER 2 C
SCREW .´•´•´•´•´•+´•´•´•´•´•´•´•´•´•-´•1´•´•´•´•´•´•´•´•´•´•+´•
O

LNYIODB WISHER I D

L1 800605-1 INSULITOR (FURNISHED WITH HORNI ´•´•1´•´• 1 C

IITTICHING PbRTSI
n535206~211 SCREW I

800213 WINDSHIELD WIPER INSTLI ELECTRIC REF

..12 X*20722-S-90-LZ WIPER *SS1IINCLUDES RLIIOEII (701551 2

IITTICHING P4RTSI
13 MSZ1D*483 NUT IFURNISHEO WITH WIPER BLIDE 45511 1

620143 WISHER IFURNISHED WITH WIPER BL*Ot I

4SSll 1702551
---I---

II XWZC?73-112 ´•´•´•KEFILL 1102551 I

15 XWZ03I5-P00T LINK nSSY 1702551 Z
I4TTLCnlNG PPRTSI
nS2I0II03 NUT IFURNLSHED WITH WIPER BLIDE 4SSY1 1

620743 WISHER IFURNISHED WITH WIPER BL~DE.´• 1

4SSYI (102551
17 nSZ1044NI NUT L
PN960DLOL WISHER ´•´•´•´•´•´•´•´•r´•´• 1
-----I----

Il Y-Z1118 ROD END 1702551 I

19 V-Z0113 CHECKNUT 1702551 L

ZO 800243-13 PIN, PIVOT ´•´•´•´•´•´•´•´•r´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•

2

21 XUL05DO-Z-Z000-1 IIRn’LSSYI DRIVE 1702551 2

(*TTICnlNG PPRTSI
22 BOLT (FURNISHED WITH CIINYLRTEII bSSYI 1

CODE EFIECTLYE ON IEKlnL NUMBERS

6904 L1100 THRU 11319
B 6908 11350 THRU 11599
L 690b L1100 THRU 11268
D b90* 11ZL9 THRU 113~9

2-115
 BECTION n
ILLUSTRATED
ROCKWELL
ELECTRICAL PARTS CATALOG COMMANDER
SYBTEM 680A/B

24

28

26

pS~

,i: -C
h
3’
"i
28

ill

ii(lure 2-15. iquipment inllollation (Sh´•st 2 .111)

2-118
 ILLUSTRATED
CrULF8TREAM SECTION n
COMMANDER PARTS CATALOG ELECTRICAL
SYSTEM
esoA/ssoB

UNITS USnBLE
FLGURE P T
U E 5 C 9 1 N PER DN
L INOEX
R L 2 3 (t 5 6 7 1SS~ tDOE
NUIIBlL N U H B L

Y1036L ´•´•SLEEVE. lDJUSTING 1’10251) I

RIIE. LH L
P) 800213-9
BDOL13-~3 ´•´•PLITE, RH L
IITTlCHING P*RTSI
*51(69(~15L SCREY.´•´•´•´•´•´•´•.´•´•´•.´• 2
25
---1---

m1Fr´• FLE11102551 I
-~6 XY1DD67-I)80
-II IUL0II3-1(2 ´•´•l0rDllllS* (1025~) ´•.´•´•1´•´•´•.....´•´•´•´•´•
IlrT)iCnIHG P11111)
28 LN(~5* DOLT ´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•.I´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•
lNsbDO(I) U*SHER
LN936BII6

CONVERTED 1511(702551 2
29
(*TT*CHINb PIR1I)
.30 1NI-I5* BOLT
1N9bOD10 ´•´•UISHER
MI21OIIHJ NUT i

100Y 3 onn DESISTORI WIIIDSHIELD YIPER 2

31
TIPEI
(ITIICHIHG P1ITI)
~127039-0808 ICREY 2
32
IN96008 V*SHER 2
l1521011HDB MII.´•..´•´•´•´•´•´•´•´•´•+.. L
---I---

800)91 PINEL INITL, YIHDIHIELD COHTLCTOR REF

)3 800~98-1 P*NEL L
IITrlCHINb P1RTII
PlS311Db-219 SCREY 6

LN9)D06 YISHEI´•´•´•´•´•´•´•´•´•´•,´•´• 6
---1---

800591-3 BUS B1R 2

35
-36 *52111101 ´•´•RELL*
IITTICHING P1ITI)
)7 ~NI-31 BOLT
1N96OD(16 UISHER ´•´•´•´•I´•´•´•´•´•´•´•´•´•´•´•´•´•´• ´•´•´•´•i´•´•´•´•´•´•
2

860910 6LIREIHIELD INSTL IIEE FIG. 1-52) REF

BO(llbl-SOL INNUNCI*TOR PLNEL 1551 L

800561-513 INHUNCI*TOD PLNEL 1551 L E
000561-11) LHHUNCI*TOR P*HEL 1II1 1 F
-38 800565-1 ´•´•PLLTEI F*CE 1
IITTLCNINC P1RTSI
-39 ´•´•´•ICREY..´•´•´•´•´•´•´•´•´• 8
NUT
---´•i---

IO 521-1115-11-327 SWITCII (*Tr*CHI*b HDYE 1 *E

YITH IYITCHI (8)0311
521-2115-11-321 rulrcn 1870311 I F
IITT*CHING HDUE FURHISHEO
YlrH IYITCH)
(L 800561-3 LENS ´•´•´•+´•..i´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•1 I
)2 800567-535 t LEGEND I 1

800)61-1)1 LEGEND I E
800)69~569 LEGEND 1 F
.)3 800561-5 DIFFUIER 1
800566-1 DIVIDER *ISI´•´•´•´•´•´•´•´•..´•.´•´•´• 1
)5 BEP62R8L ´•´•´•LIIP*ISI´•´•´•i´•´•´•´• ,.´•´•´•´•´•´•´•I´•´•´•´•´•´•´• 1* IE
BEP~IUQL 16 *E

BEPb2R(IL ´•´•LIIP 1~51´•´•,´•´•´•´•´•´•´•´•´•´•´•´• II F

BEP62*BL ..´•LIIIP 1SSI´•´•´•´•´•´•´•´•´•´•´•´•´•´•´• II F

CODE EFFECTIYE (IN SERI1L NU*DERI

6906 11100 THRU ll))s
E 6908 L1)50 THIU 11399
F 6908 ll(DO THRU 11599

Revised: 28 November 1984 2-117

 ILLUSTRP~TED
SECTION II GULFSTREAM
ELECTRICAL P~RTS CITALOG COMMANDER
SYSTEM asoA/esoB

a
B

Lri

ii
ill I
r

a
D
‘g

51

39--~

~isur´• 2-2). Iquipl´•nt ilhast 3 0112)

2-118
 ILLUSTRATED
ROCKWELL SECTION n
COMMANDER PARTS CATALOG ELECTRICAL
6901\/8 SYSPEM

~IGURE P ei R T UNITS USnhLt

8 INUIX D E 5 C R i P T I O N PER DN
RUW8E* N U H B E R 1 2 P Il d 7 1SSY CODE

2-25 4~ 800562-L COVER 1~SY .r´•´•´•´•.r...´•............ L

I~TTICHING PdRTSI
~7 n521693-125 SCREW 5

48 BOOSb4-501 T-IOIRO dSSY I

IPTTnCHING PIRTSI
19 SCREW 3
nNY6001 WPiSHER 3
MSZLOR3N04 NUT 3
---t---

50 174 CLnMP 1813L21 L

5L 8005~3-1 BKPCKET PSSY L
iR IM INO LC*TOR INSTL´• ELEYIITOK REF
52 NbS~3000-ZO SPIC~R
(~TI*CHING P4RTSI
53 HS35Z06-ZL7 SCREW L
MSZ1383N01 NUT 1

-5~ MS2)566-LB PULLEY ´•´•´•.´•....1..´•´•+ I

I*TTICHING PIRTSI
55 nS27031-1-12 SCREW I
PN960DLo W*SHER 2
MS1i08lN3 NUT I

-56 Y3L-139 SWITCH (9 1929) L

(*TT*CHING PdRTSI
57 H135Z06-Z19 SCREW 2
bN96DD4 Wb~HtR 2
MS2I~B3NOI NUT I
---t---

ie 800*95-L t BRICKET 1
I4TTICHING PPRTSI
59 nS35206-228 SCREW 2
nN960nb WISHtR 2
MSZIOB3NOb NUT 2

60 ND NUMBER WIRE 10´•032 IN+ DI~´• BR1SS´• Pa-U-32L1 nR

bl SUOOIZ-bP CI\8LE *IIY1 ELEY TRIM LSEE FIG´• 2-*91 REF
800593 TERMINIL STRIP INITLI FID REF
62 Tb15n04-IO COVER (8*971) ´•´•r.´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•+´•. 4
63 nS2II26-2% 8US d*R
6) HSZ72LZ-I-LO i-BObRO 4
-65 MS35Z06-216 SCREW ´•´•´•.´•´•i´•´•´•´•´•´•´•´•´•´•´•´• I
66 800594-501 sR*IKET *SSY L n
800691-20) ´•´•BRP~LET /iSSI´•´•´•´•´•´•´•´•´•´•´•´•´•´• I R
-67 ’15)5106-21~ SCREW I

dN960D4 WLSHER C
68 800599-1 CLIP PSSY 2
80D6Z1-i PDTENTIDMETER INSTL, *IL TRIM INDICITUL REF
69 ~58-500 POTENTIDnETER 1il6971 L
70 80062Z-L BHPCKET L
800117 8I\TT ERY TEMP C IIILERON TRIM IND INSTL REF
11 110185-517 PLICIRO L C
110115-519 t PLnCbRD I B
110185-573 PLIC~RU I G
110185-585 PLPCI\RD L HJ

CODE EFFECTIVE UN SERI*L NUMBERS

690P LL100 THRU 113*9
B 6908 11350 TnRU 11599
6901 Llloo THRU 11268
E 6908 11310 THRU 11319
F 6998 1110O THRU 11599
t ~901 LIZ*9 THRU 112*1
690/\ 11269 THRU ilZBb
690P L1287 THIU 11337
J 6901\ 11338 TnRU 11)19

a-118
 SECTION 1l
ILLUBTRATED
ROCKWELL
ELECTRICAL PARTS CATALOG COMMANDER
SYSTEM Bg0A/B

r
a

fs
sil I 1 II\
,I
pi,

I? MODEL BBOPI

II Is

,,1
1-’

e_

MODEL BBOB

ii I u

FiOurs 2-25, Equipnt~nt inltallotion (Shs´•l 4 of 12)

2.110
 ILLUSTR~TED
CIULFSTREAM SECTION n
COMMANDER PARTS CATALOG ELECTRICAL
880A/B80B SYSTEM

FLGURE P 1 fi T UNITS USIBLE

C INDEX O t 5 C R I P I I O N PER DN
NUWBtL N U H B E R 1 Z 3 C i b I bSSY COOE

2-25- 71L LLDIBS-S83 ´•IPL*CIRO. LIGHrEr(´•´•´•´•´•´•.´• 1 O

72 8505)).1 INOICLTDR, IrLERON TRI* ´•1´•´•´•´•´•´•´•´•´•´•´•
(ITrlCHINb PIRTII
13 5(391 CL*IIP (e111931 1
---t---

II nSTL-~06P*-C-Lb SUITCH, BLTTERI SELECT (IEO CIP) 1 8

(951*L)
SU1969 SVITCHI 8677181 SELECT Ir(EO C*PI L C
1016861
XNOB I G
XNOB ´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•.´•´•´•´•1´•
L HJ

75 .PI-221 SUITCH. IILERON rRII( (1119)1 1

(REPL*CEI SC)HXIBL)
811 600~L1 IHDIC*TOR´• BITTER* TEWP (ZBPBI) 1 It
ILTrlCNING PIRTS)
115~80(1)1* CL*WP (UPPER SCREY FURNISREO YITH I K
11
CLINP)
SCREY I K
-Is

POSTLIGHT 11)9111 2 K
IP
20-030)-8-2( POST LlbHT 1119191 I B
´•´•PINEL t C
-BO 800611.3
800617-7 PLI’IE 1 GH
800617.9 ´•´•PL1~E´•´•´•´•´•´•´•´•´•´•´•´• 1 J

800617-11 PtlTE I 8J
100611-13 PLLTE 1 8
IITT*CHIHG PIRTS)
B1 N5S5L06-2L7 ´•´•SCREY
´•´•IC~EY 2 BJ
.S2IL93-56 ´•´•.´•´•....´•r´•´•´•´•´•

NLIODO1-1 ´•´•SP*EER Z I)J

YL SNElI I 8J
LN960D)
´•´•HI~´•´•´•´•´•´•´•´•.´•´•´•´•1 Z 8J
NP210I(HO(
---I---

207685 LlbHTER´• CIGIR (1096~) 1 8K

_811
80018)-903 COHHECTOR PLITE INSTL. PREESUIIE IEF
~ULIHE*O
.82 113119-2)-61 ´•´•COWNECTOI(´• ELECTlllCLL 1.´•´•´•´•´•´•´•´•´•´•´•´•

(*TTICHlNG PIRTS)
-83 llS)510b-211 ICREY
1H96006 Y*SHER
II~IOBIHOL HUI´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•
---I---

800621-1 COYER ´•´•´•´•´•´•´•´•´•´•..i´•´•´•´•´•´•

1
-8(
IIrTlCHINb PLRTSI
.85 *121039-1.08 ´•´•SCIIEY
1N960010 U*IHER .´•´•´•´•´•´•´•´•´•´•´•1´•´•´•´•,´•

800623-1 PLlTE I~I*´•´•´•´•´•.´•´•´•´•´•´•´•´•´• I

.86
PLLTE LSI* ´•.´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•1´•´•´•´•´•´• 1 8
800b23-503
I*lr~CHINb PLRTII
SCREY 1I
.87 nSI10)9-I-08
1H960D10 YIIHER LI

800586-1 ´•´•GLSIET t
-88

CODE EFFECTIYE ON SEIILL NUI(BE1S

1 6901 L1100 THRU 113)9
B 6908 11350 TH~U 13599
C 6906 L1I00 rHPV 11268
D 6901 Lllbs rHRU 113)9
G 6901 112(9 THRU 11269
690* 11169 THRU 1IZBb
n 6906 11287 TnlU 11337
J 6901 11338 THRU 113*9
Y 690* 112(9 THRU 112)9
6901 11269 THRU IIs(s

2-121
Revised: 28 November 1084
 ILLUSTRATED OULFSTREAM
SECTION n
ELECTRICAL PARTS CATALOG COMMANDER

SYSTEM BBOA/B80B

1
’P~s,
´•C~ It I I

7
E la ‘sa

k´•

MODEL BgOP, MODEL 6808

K L
lol

lot

1M
102

103

IDS

G
toe

’C‘ ´•1´•
IDSl
I

MI IN

108
las

’1" C~Y 1-

r"

figure 2-25. Iquipn´•nt Inrt.ll.ti.n ISheet 5 o( 12)

2´•´•111
 ILLUSTRATED
ROCKWELL SECTION n
COMMANDER PARTS CATALOG ELECTRICAL
690A/B SYSTEM

FIGURE P P R T UNITS USbBLE

6 INDEX O E 5 C R I P T I O N PER DN
NUMBER N U M o E a 1 z 1 s b i nssv CODE

2-25 800588 HINDSHIELD CONTROL nNO FUSE BLOCK INSIL REF P

800657 WINDSHIELO CONTROL bNO FUSE BLOCK IhSTL REF a
89 HYL15O3IL .CONTROL BOX 105621) 1
(ITTICHING P4KTSI
90 MS35207-ZbZ SCREW
nN960O10 W*SIIER Z
*SZL08~N3 NUT Z B

91 800188-9 COYER, FUSE BLOCK L 1

800697-3 COYER~ IUSE BLIICK L 5
(4TTbCHING P*HISI
-92 MS35206-228 SCREW I
XS35393-37 ´•´•L OCKWnSnER
53 900D5~-529 SPICERI THRE*DEO 2

9~ PG~-I-1/2 FUSE 111100) L

95 800532-501 FUSE BLOCK (\SSY
IPTTICHING P4RTSI
Sb HIZ~b93-527 ´•´•ICRLW 2

41 800587-1 BRICKET I~SIIWIYDSHIELO CONTROL L 1 4

FUSE MOUNTING
800658-1 BRPCKET dSSY1 WINOSHIELD CCNTROL 6 I 8
FUSE MOUNTING
I~TTICHING PIRTSI
98 MS35201-262 SCREW 4
nN96DD10 WbSHtR

800592 CUNTYDL INSTLI C48IN TEMPERITURE REF LM

99 SYL25~2*Z CONTROL BOX 10562*1 I M
IdTTLCHING PIRTS)
-LOO M535207-263 SCREW 4
1N96DD10 Wd~HtR
----I---

-100(\ HYLI503~o CONTROL BUX ILOC4Tt0 48UYt EMERGENCY L 80

EXIT DO3RI (0562*)
IITTdCnlNG P4RISI
MS27039-1-L5 SCREW 2
bN960D3L WI~HtR

-1008 893038-L RELnY r´•´•´•´•´•´•´•´•´•´•´• 2 L

IPTTICHING PIRTS)
M535ZOb-ZL4 SCREW
1N960D* WIIH~K 2
----t----

-IOL 000591-L OR*CKET ISIY 1 M

800590 RELbY INSrLI DEICER TIMER REF d
800656 .RtLIY LNSTLI OEICER TIIER REF B
3024~5-02 TIMER, OEICCR (0l98I1 L
IPTTICHING PPRTSI
-103 MSsl2Ob-2’ti SCREW 2
PN9bOD8 WPSHER 2
---I----

-104 HSZT212-1-5 T-BObRD 1

III~PCHING PPRTSI
~105 MS3~ZOI-ZI* SCREW 2
-----U----

-1D5b TII’tMOI-l COVER L

CODE EFFECTIVE ON ZER14L NUMBERS

1 6904 LIIUO THRU 113*9
B 6908 11350 THRU 11559
O bY0n LIZLV THRU 113*9
L 690li 11100 THRU 11119
M 6404 L1170 THRU 11268

2-1a3
 ILLUSTRATED
BECTION n ROCKWELL
ELECTRICAL PARTS CATALOG COMMANDER
SYBTEM BBOA/B

g
r
c,
"o o
trio 111

10 O
w.lo o
112
1~1
4,,,
r"" i,
-r 1112 139
ill
,,I
o!

8´•´•? 5130

ill ~iu la

MOOEL 880A--11100 THRU 11248

128 312011 THAU 11288
128

~110

Filur. 2-25. Ilodrir~l Equip.ant inlt~llotion rShee~ 6 of 12)

2-114
 ILLUSTRATED
GUtFSTREAM SECTION n
COMMANDER PARTS CATALOG ELECTRICAL
esoA/ss0B SYSTEM

P 4 R T UNITS US48LE
~IGUHt
5 t R 1 P T I U N PER ON
LNOEX
U n 9 E R L Z 3 4 5 6 7 bSIY CODE
NuHstn N

BR*CIET *Ill. DEICEII TIIIER RELI* 1

2-25 -106 800589-3
I(OUNTIWG
PLITE 1Sll. DEICER TIIER RELLI 1 B
B00b59-L
I*TT*CHING P1I(TII
ICREY 3 1
-IOl 1535206-242
1535106-2)3 SCREN 3 B
YISHEl´•´•.´•.´•´•.´•.´•´•´• 3
INs~OD8
---I´•---

BDO(L1 FLIP SYlTCH INSTL I(EF

JV.~O LEVER (91s191 I
-LOB
-109 *525253-1 IYlrCH I REPLICES V3-L) L
(*TTLCHIHG PLRTI)
W13510~-Z19 ICREY..´•´•´•´•´•´•´•´•´• I 80
4896004 Y*SHER 2 80

800)64-503 IIR*tl(EI´•´•´•´•´•´•.´•´•´• ´•´•´•´•´•´•´•´•´•´•1´•´•´•´•´•´•´•´• L N

~L10
800464.505 BRICKET r´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•
1 80
510003-3(L 488 1SII (SEE FIG´• 2-411 REF
-111 i

800264 LlbHr IHSTL´• BlbG1GE CONPLRTI(ENT REF

83550 DONE LIGnr LSSI 1)291)1 L
-LIZ
303 LLNP 1111(6) 1
-113
JVZOL *CTUITOR, BLOGLGE COI1PIRr*EHT LlbnT L
(P19291
V3-l SWITCH1 B*bOlGE CONFIRTNENT LIGnr L
-115
1’119191
IITTICHING PIRTS)
1535206-219 SCREY
INPIODI UISHER

-LLL 800264-15 BRICIET L

8003’)3 i BOX INSTL, BUS 1HD COWT*CrOR REF

-117 800515-1 BOX 1SSI. BUS *NO CONTICTOR (INCLUDES I P

EPUIPIIENT)
800575-501 BOX ISS1. BUS IND COHTLCrOR (IWCLUDEI L
FPUIPIENTI
800B75-503 BOX lsS*, BUS *NO CONTLCrOR IIHCLUOES I R
EPUIPIEHTI
800575-~0) BOX 1SSI. IIUI 4HD CONTLCTOR I INCLUDE S t I
EPUTPIENT)
800575-501 BOX 4501, BUS 1ND CONTLErOR (INtLUDES 1 D
EPUIPIEHT)
80005-509 BOX ISI*, BUP 1ND COHTICrOl IINCLUDEI 1 BE
EPUIPNEHT)
800175-511 BOI *(51´• BUS L CONTICTOR IINCLUDES 1 CC
EPUIPIIENrl
800575-513 BOX LIII~ BUS L CONTICTDI IINCLUDEI 1 DD
EPUIPIIENTI
IITrICnlHb PIRTS)
-118 1152)039´•1-07 SCREY
LH960010 Y4IHER

CODE EFFECTIVE ON SERI*L NUI(BERS

1 6904 11100 TRRU 113(9
B 6908 1I)TD 1ND SUBS
D 6901 11269 THRU 11349
H 6904 L1IOD THRU 111)1
6904 111)2 THRU 113)9
P 690* 11100 THRU 11155
6901 11156 TnlU 11169
R 6904 111)0 Tn~U 11226
I 6904 11227 TnlU L1168
88 6908 11350 rHRU 11116
CC 6908 11511 T*RU 119(P
DO 6908 TH1U 11199

Revised: 28 Novembel´• 1884 2-125

 ILLUSTRP;TED OULFBTREAM
BECTION 11
ELECT~CAL PARTS CATALOG M)MMANDER
SY8TEM BBOA/BBOB

O
,,,I
las
Is?
Isll 123
Ifl

1 0i 1,1
r i’
llOI 1(11
’8’
llOr L‘V
121
O

In~ o
111

1101
O
o
Ilor lee
1100

ns
na
1 ’5’
131
lae 1311 1161
139
151 111
116
&1 I

1 I
ns
II(
113
111
Ist

O
156 O

Ira-C a
Q

"’i,,,
~ilSO
h

MOOEL 5801\18 -11208. IIZG8ANO SVBSEOUENT

120

Pigurs 2-26. Ils.trtol Iquipmenf inrl.llati.n /5hest 7 of 12)

2-116
 ILLUSTRP;TED
ROCKWELL SECTION n
COMMANDER PARTS C~TALOO ELECTRICAL
ssOA/s SYSTEM

FIGUkE P d R I UNITS USIBLE

C INDEX 0 E S C R i P T i O N PER ON
NUMBER N U n a F a I 2 i i i 6 1 bSSY COOE

2-25-1L9 80051Z-5LL CUYtR 4SSY 1

IblT~CHING PbRTS)
-i2o Zbo0-2* STUB lllZ8L) 5
ZbOO-L WISHER 1112((6) 5

110185-575 OECIL 1 D
LIU115-5V1 OEC;ZL 1 8W
-121 800’.111-503 SUPPORT I1SSYI WIRE BUNL´•LE I
I*TTICHING PPRTSI
-122 RSZIL93-151 SCREW 3
nS3)Z06-L15 SCREW ´•1´•´•´•.´•´•´•´•´•1´•´•´•.´•´•´•´•´•´•´•´•´•´•´•´•´• 1
I\NPbODR WISHER L

600112-503 SPICER B
PIRTSI
n53520L-2*7 SCREW 1
*NP6oOR WISHER L

-125 800394-5~5 BUS B1R 1

-126 BU0391-5Z9 WUS ObR L
-121 BUS UL* I LR
80039"-553 BUS tbR .....´•´•´•.r´•´•´•´•´•r´•´•´•´•´•´•´•´•´•´•´• I I
-128 80039’1-5)5 BUS 64R 1
-iZ9 80~394-5*1 nus ann 1 p
800394-54~ BUS BIR I W
-L30 b00991’527 aus aaK 1 in
BUS PIR I I
-131 800394-525 BUS BdR 1 LR
80339*-519 dUS BnR 1 I
-132 800478-533 2*NFL *Z SI´• REL II 1 LH
PINEL bSSYI REL*Y 1 5
I4TTPCHING PIRTSI
NS3iZOb-ZZ7 SCREW 2
*N96006 WISHER Z
MIZIOB?N06 ’IUT 2
---1---

-1326 IN3Z09 OIUOE L S

-133 GS-5319 HELIYI EXTERNLL POWtK 1939291 L C
(bTTICHING PIRTSI
nS35Zoh-Llb SCREW 2
LN96001 WISHER 2
NSZIOB3No4 NUT

-131 800478-7 PhNtL L LP

800418-3 PPNEL 1 5
-135 800’t7R-501 raiuti nssv. nE Lav 1 Ln
I~TTICHING PPRISI
HS3520h-221 SCREW
1NY1006 WISHER 2
NSZIOB~NDL NUI 2
---t---

COUE EF~ ECT IYE DN 5 EH I Ii NUMBERS

8 6908 11350 THRU 11599
C bYOb 11100 THRU 11268
D a90n 11261 TnRU 11349
I b90* 8 L908 LilZ7 nNO SUBS
i 6901 11100 THRU 11169
P b90P L1100 THRU 11155
R 1901 11170 THRU 11226
S ason llLZ7 TnRU 11268
W 690n 11191 THRU 113*9

2-121
 SECTION n ILLUBTRATED
AOCKWELL
ELECTRICAL PARTS CATALOG COMMANDER
SYSTEM BBOA/B

moo.~ sraa illm mRu 11228

183 i\

i\

las

P/// d~-112 ib~

MODEL BgO*/B --11288 I\ND SUBSE(IUENT

183

-k

o.
C‘.
‘r r
i
las
re?
Ist

i
lio

MODEL BBOP~ 11227 THRU 11288

D"‘O"

Pipurs 2-21. Iquipn´•nl inlt.ll.tion (Sh´•af B o( 1?)

2-1.28
 ILLUSTRATED
ROCKWELL SECTION n
COMMANDER PARTS CATALOG ELECTRICAL
680A/B SYSTEM

FIGUkt P e K T UNITS USPBLE

I INOLX D t 5 C 9 1 P T I D N PER ON
NUMBER N U Y B E R L 2 C 5 6 7 PSIY COOE

2-25 -136 GS-5319 .RFLIY´• IXTFRN*L POWE* 1939291 Z LI

I~TTICHING PIRISI
HS35206-216 SCREW Z
bNPbODI WISHER Z
MS21083N0’t NUT ´•´•´•´•´•r´•´•´•´•
2
---I---

800478-3 PINEL I LR
-138 ni2416bD1 HtLnY IZ En´• FOR -501 CNLYI 3
-1384 MSZS1I1OL KELIY IREPLICES 7223-211 1 W
(ITTbCHING PdRTSI
-139 bN3-*b BOLT 2

*NY6001O WISHER ´•´•´•.´•´•´•´•´•r´•´•´•´•´•´•´•´•´•

Z
---I---

-140 MS2*IR7DL KELdY 13 En´• FOR -513 UNLII 1

I~TTPCHING PIRISI
4N3-L31 BOLT 2
I1NPLODLO rl*SHER 2
NbS13003-5B SPICER 2
----il---

61C1HI7Z CIRCUIT BREPKERI RESET 12 En´• FOR 3

-501 G -509 ONLYI 1196051

-1*in 6141HI71 CIRCUIT RIEPKERI RESET 14 EP´• FOR 2
-507 L -509 ONLYI 115b0:I
IPTTICHING PIRTS1
-1418 nN3-4e BOLT ´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•.´•´•1´•´•´•´•´•´•´•´•´•
2
*N4600I0 W4SHER Z

-L~Z 61L1HIIZ CIRCUIT BREbKER´• RESET 1156051 L 80

IPTTPCHING PbRTS1
-L*ZI PN3-lll BOLT Z
N11513003-36 SPICER 2
IN96o010 WISHER Z
----t-__

800524-501 J1ODF bND HEeT S1Nn IiSY 1 C

U00521-503 UIOOE 4NO nEni 51NK 115 SY I ED
IPTTLCHING PIRISI
-113 *lS3SZ0b-ZI5 SCREW
dN9600R ilZHER
500112-5)5 SPICER 4

-114 MRL21S-SL DIODE 1014311

800394-)31 BUS BnR 1 C
800494-551 BUS B1R ´•´•´•´•´•´•r´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´• 1 80
-1*j 04210-1-1 HEIT SINK
119L031
-llb dPLZ CUNT*CIOR 1713631 1
InTTPCHING PbRTSI
-147 bN3-5I BOLT 4

4NVhoC10 WISHER 4

bl*LHlb8 BRE*KER, CIRCUIT 115605) 1

InTTnCnlNG PPRTSI
PNI-12b BOLT 2
419600416 WISHER Z
NnS/1300~-Ch SPICER i
---li---

tDDE EF~ECTIVE ON SERldlL NUMBERS

B 6908 11350 THRU 11599
C B90Pl 1 11100 THRU 11266
6904 1 11269 THRU 11319
L b901 I LILOU THRU 11119
R 6901\ 1 11170 THRU 11220
W 6904 1 11156 THRU 11)*9

2-129
 BECTION n ILLUSTRATED ROCKWELL
ELECTRICAL PARTS CATALOG COMMANDER
BYSTEM BOOA/B

~3

i,

ill
i
103 I i 200

rl lu

X 9*
203
201

´•´•~i- I~o
B
O~ V 204

1 T
toa

vl

218 213

,II

~i(lure 2-25. Equipment (5he.l P of 1?)

ailSO
 ILLUSTRATED SECTION n
CIULFSTREAM
COMMANDER PARTS CATALOG ELECTRICAL
880A/880B SYSTEM

FljUhE P a k T UNIII USnULt

L U i 5 C I Y T 1 Li n PtH O~
INOrX
hunain N ii r R i R I i C i a I ISSI LLjjL

2-25 ‘1)9 llSI(L850L RELII´•´•´•´•´•´•´•´•´•´•.´•´•´•

I*TTICHIN6 PLRTI)
BOLT 2
-150 1N(~31
YISHER 2
---I---
2
-151
(ITTLCH1N6 P*RTSI
SCREW I
n135201-263
´•´•YIIPRC. I
1N960DLo

805 LINITER (111001 L

-1(2 IINLBO
)16) BLMK. IIOUHTINb 111(001 I
-1.I
(*lrlCnINC PLRTS)
SCREW 2
1121691-156
---I---
RELL* LILT P*R’I 170020.1 (1)063) LI(
-15) 170011P
CONTICTOR (IIOb)l 3 5
-15)* 171088
I*ITLCHING P*RTII
BOLI´•´•´•´•~´•´•´•´•´•´•´•´•´•´• LR
-155 *H3-.1
WISNER .´•´•´•´•..´•i´•,´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´• LR
18960010
BOLT ´•´•+´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•I´•´•´•´•´•´•´•´•´• 2 I
188-1)1
Y*IHER 2 5
1Ns6001I6
SPICER 2 5
N1S(30D)-l) ´•´•´•´•.´•´•´•´•´•´•´•´•´•´•´•1´•´•

SHUNT 2
-156
COHT~CTDII1(063) 80
-L.7 *IIORH
(LTTICHIWb PlRlSI
BOLT 2
IN)-LII
Y*SMR i
IH9500)16
´•´•SPLCER 2
N1S(300(-)(

DIOOE (P El´• ON -505 ONL*) 3 C

-L58 IH3209
STRIP (DIOOE I(OUNTINGI (1 EI´• FOR 2 C
-159 800522-1
-105 DNLI)
(nTICHING PIRTS)
SEREY 2
-IbO NS3520L.Zlb
lN9600) YLSHEI´•´•´•´•´•´•´•´•´•´•´•´•´•

(1Lr PIRT L C
-16L 8200~0-501 ´•´•´•SENSOR11SI´• I)*ERVOLTISE
810030-50)1
I BO
8200)0-503 ´•´•´•SENSOR1SS*´• OVERVMTLbE
IITTICNINb P*RTSI
HUI´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´• 1
~162 *S1L083NOI
WISNER 2
1N9600I ´•´•´•´•´•.´•I´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•

---I--

T.BOI.O lSSl L LR
-Ib) 800511-1
*ISI´•´•´•´•´•´•´•.´•´•´•´•´•´•´• 1 5
800511-501 r-IO1RD
IITTICHING P*RTS)
´•´•´•SCIIEY´•´•´•´•´•´•´•´•I´• 2
1135206-015
WISHER 2
1H)bODI
NUT Z
YIZ1083HO(
---I---

CODE EFFECTIVE DN SERI1L NU*BERS

I 6908 11350 fHIU 1158’1
C 690* L1100 THRU 11168
D 6901 11269 rHRU 11319
L 6901 11100 THRV 11169
R 6901. 11110 TRRU 11226
I 6901 11227 rHRV 11268

a-131
Revised: 28 November 1084
 ILLUSTRATED GULFBTREAM
GECTION n
ELECTRICAL PARTS CATALOG ~MMANDER
SYSTEM 880A/B80B

~3
2311
221

222

2JI

ZZO

2313

u-

MODEL 5508 11350 ~ND SUBIE(IUENT.

X’Z

Y
MODEL SBOn/B 11288 IIND SUBSE~UENT.

231
111

238

L?"

2e

a3

241

213
X" ’1’

Pigurs 2-15. iquipment inlt.llati.n (Sheet 10 of 121

2-152
ROCKWELL
ILLUSTRATED
SECTION n
COMMANDER PARTS CATALOG ELECTRICAL
BOOA/B SYSTEM

FIGURE P P P T UNITS USPBLE

L INUEX D E S C R i P T I O N PEK ON
NUMBtl N U M 6 E R 1 Z 3 i 5 6 7 bSSY CODF

2-25 -ibi RH50-50 OHM RES Ii TDRI31 TOL tRbNCE 1 Z LR

IPTT~CHI3G PPRTS1
n5352116-215 ´•´•SCREW 2
4NS60D) *SntR 2
MSZIOB3NOi NUT 2

800518-1 KELIY PbNtL IISY I Pa

800)18-501 l(tLPY PbNEL dSIY I RS
100518-503 RtLdY PINLL IIIY i T
800578-50j RtLdY P4NCL bSSY i U
800518-501 iii4Y PLNEL PSSY i a
I4TT4CHING P4KTSI
-165 n535206-127 SCREW I
-166 SCREW 2
nN960Db *4SHER
---t---

-L6T MS25Z~L-01 RELII IL t~. FOR -507 ~NLII 5

I4TT4CnlNG P4RTSI
MSZ1083NOb NUT
dN960Db WbSnER 4

833038-L RtLIY 113 Ed´• FOR -I ONLYI 10

(bTTdtHING PIRTII
n23~20b-215 SCREW 2
1N9600* WISHER 2
MSZ13e3N04 NUT Z

833018-501 REL4Y 8 t
833038-505 RtLPY 6 30
(~TTbCHING P4*151
MSZ13R3N04 NUT Z
PN963UI WISHER 2
---I---

-170 800518-3 BKPCKET I t

800578-5 SR*CKcT L O
100578-7 UH*CKET 1 e
-1706 800571-509 r i-6O4RO ~SSY I
800577-505 T-BU*RD PSSI i BU
"PKTS)
-L708 nS3520b-215 ´•´•ICREW 2
4N960DI VblHER 2
MSLi483N09 NUT 2

-170C iN3Z09 0103E IZ En´• FDR -501 ONLYI 3 ED

-i7OD 800522-503 STRIP 1 80
IbTTICH(NG PIRTS1
-170E nS3520L-Z15 SCREN ..´•.r..r...................

*h9LOU~ UPS HER 2

---I----

COOE EFFECTIYE ON SERLPL NUMBERS

B 6908 11350 THRU 11599
C 6904 11100 TnfiU LIZ68
0 1904 11269 THRU 113*9
i 6901 11100 THRU iLIbP
P b90* LL100 THRU iii55
P 690* 11156 THRU 11169
R 690Pi L1170 IHRU LiZZb
5 6904 11227 THRU L1218
T 6906 112CY IHRU 112C4
b90* iI2L1 IkRU Li3Zb
U asoa 11327 THRU LL3’t9

a-133
 ILLUSTRATED ROCKWELL
SECTION n
ELECTRICAL PARTS CATALOG COMMANDER
seoa/D
SYSTEM

IHRU 11..I´•

221

2213

2210

231

X"

MODEL BgOA 11(00 THRU 11348.

131 2318

P^

2210 V
2311

v/ ,2213

L
’;:r
231

221 x´•z .la

Figure 2-25. Elerfri~.l Iquipment Inlt.ll.tion IShee~ II of 12)

a-154
 ILLUSTRATED SECTION II
C~ULFSTI(EAM
COMMANDER PARTS CATALOG ELECTRICAL
SYSTEM
680A/BgOB

T UNITS USdBLE
~IGURt
O E I C H I 1 O N PEL ON
C INDLX
R I Z ii) 6 *SSY COOE
NUI(BFP´• N U E R E

PLHEL *ISli PELII 1 80

t-P5 -110F 800(78-501
I*TTLCHINC PLRTSI
SCsEY L
-1700 1S3520L-l15
1H96001 Y*IHER
NUT P
IISZ1OBJHO)

REL** I 80
-1708 615)19
IITTICHING PIRTSI
ICREY Z
-llOJ nP15106-2L~ ´•r´•´•´•.

YISHER 2
~n9600*
.vl
I
HSIIOB)NOI

1 ID
-170K 800178-1
GllOmEr 3
-111 S-O)LI.HI
PINEL *IS*, FUSE nOUNTlHG L LR
-172 800513-101
PI*EL 1.557, FUSE IOUNTIYb I OS
800113-)03
LSP*´• FUSE *OUWTIHG 1 88
800523-505
PINEL LIS*, FUSE WOUNTIHG 1 CC
800523-507
P*NEL 1151, FUSE IIOUNTINb L DD
800523-509
ILT7LCHING P*RTJI
SCIEY 6
W535206-213 1´•´•´•´•´•´•´•.´•

YISHER 6
1N96008
---I---

PLUG BUTTON 183058) 18

81)3152
FUSE (11)00) 6
-115 1GC-I
FUSE 171(001 L 88
-llS1 100-3 ´•´•´•´•´•.´•´•r´•´•´•´•.´•.´•´•´•l

FUSE (11)00) 1 EE
1GC-5
FUSE 1111001 IR
-116 IGC.5
PLUG BUTTOH 183058) L EE
81)8151
FUSE L11(00) I
-LII *GC-I-LI~
FUSE I11I001 1
.LIB *OL~)
HOLDER, FUSE (111001 18
HIP
I
-179 800523-5
IEIIPIOR (T*PE ZIO-L00. 2 011111 1 C
-LBO ObOOD
1166551
(*TTICHING Fl.PTSI
~181 *135106-2(3 ICRE*
..´•V*SHER Z
1HPb0O8
---I--
REL111)0~63) I B
-1811 2(0180
SOCIETITIPE BY1I L 8
-1818 CJB1B
(ITr*tHLHC PIRrS)
230-023-000 POST 2
-1810
*1)5333-)6 LOCIYISHER
W135201-~15 SCREY

CODE EFFECTIVE (1N SERILL NUI(BERS

B 6908 11350 IHRU 11599
E 690* 11100 THIU L1ZbB
O 6901 1116) THRU 11)(9
L 690* 11100 THRU 11169
R 6906 11110 THRU 11226
1 6901 11221 THIU 11268
88 (908 11310 THRU 11516
CC 6908 11511 THRU 115)1
DD 6908 11513 THRU 11599
EE 6903 LISLI TRRU 11’199

a-1S5
Rejissd: 28 Na~omber 1984
 ILLUSTRATED
SECTION n GULFSTLlEAM
ELECTRICAL PARTS CATALOG COMMANDER
SYSTEM 880A/B908

FILURE P n n T UNITS UI4HLE

C INDEX D E I E R I P T I O N PER ON
hUHBER N U n a E n 12 3 r 5 a 7 assv COOE

2-25 -1BZ 800576-1 BOX niSYI CONT*CTOR IWITHOVT 1

EaUIP’IEnT)
800576-501 BOX nisv, rohiracrnn ~*lriiaur I oi
EIUIPnENTI
800576-503 DOX nSSYI CONTICTOR IWIIHOUT 1
EQUIPNENT)
800176-505 aox nssv. cnhiracron iwli*our I 8o
EaUIP*ENTI
880205 SHELF INSTLI ELECTRIC eOUlrnENT REF
-183 tRL795R1054L ..RLGULPTDRI YOLTIGE InLi PIRT LS89-1-F Lli
11P1131 1211~61
)1530-001 RESUL~TORI YDLTP.te 1 99508) 2 I
-181 BbSE, V3ITbcE REGULI~OR Ilii PbRT LR
L7oD-5-I\ 1 121(131 (Z~CIII
I~TT*CHING PIRTS)
-IBS MS17039-1-OB ICREW 4
4N960010 WISMER
HSL1083NP NUT n*

-Issa as~ols-l REL4Y 2 5

IPTTICHING P4RrSI
-IB~B n535206-228 SCREW Z
*N9~0D6 HI\IHER 2
n521083N0l NUT 2
---t---

-1Bb 305138-6 IPEtO SWITCH 1991931 I C

IPTTPCHING PIRTSI
-iBI MS21083N) NUT
---i---

-18111 06000 RESISTOR (TIPI 270-L031 I OHHI L 80

1116551
I*TTILHING PIRTSI
-187B n535206-2~3 SCRE*´•´•´•´•´•...´•´•´•´•´•´• 2
11196008 W*IHIR s
NSZ1083N08 NUT 2
----t----

-187C nS27212-1-* ITR1P´• TERHINI\L 2 1

(bTTdCHING PI9TSI
-iBID nS35206-215 SCRtW 2
*h9LoDC U92HtR 2
MIZ1083N09 NUT 2

-188 880205-13 ´•´•~NGL6 I LR

-L8~ 880205-11 WEB L LR
880205-15 YEE L 5
880205-17 WEB 1 80
-IPO 800595-1 BRLCKET I\SIY I
-191 880205-3 ENU, FWD L
-192 880201-1 ENO. LFT 1
800312 T-8~4RD INSTL´• bFT FUSELbGE REF
Ti\l*llO~-PO CDVER L
-19* HS25Z26-2-Z BUS d*R I
IPTTLCHING PIRTSI
-19) HIPIOBICO~ NUT
1N96DD6 WnSnER

CODE EFFECTIYE ON SEllbL NUMBERI

B 6908 11350 THRU 11599
C 6YOP 11100 THRU LLZhB
O 6901 LIZL9 THRU L13*V
I L90n 8 6908 11ZLI THRU 11599
L L90P iil00 THRU 11169
P a9on illoo rmu illis
o b~aa 1115~ T~RU 11169
6901\ 11170 THRU 11226
5 6901\ L1Z~i THRU LL268

a-1SB
 ILLUSTRATED SECTION n
ROCKWELL
COMMANDER PARTS CATALOG ELECTRICAL
680A/a SYSTEM

I**I

MODEL 8908 --11384 FIND SUBBE~VENT.

227

2211

~isure 2-25. Ila.tri..l Equip.ent in´•l.ll.tion (Sheet )2 of 12)

2-151
 n
ILLUBTRATED
ROCKWELL
ELECTRICAL PARTs CATALOG COMMANDER
8Y8TEM BOOA/B

FIGURE P d R T UNITS USIBLE

G INDEX D E Z C R 1 P T I O N PER ON
NUMBER N U M 8 E R 1 2 a r 5 6 n~rr CODE

2-25 -196 HS27212-1-20 STRIP. TERHIN*L L

(*TTdCnlNG P4RTSI
-191 H23520b~LI SCREW 5
---I---
-198 800312-5 SnEET I
420092 TIP INSTLI YERTIC*L ST*BILIIER ISEE REF
FIG. 2-421
-199 L51~0008 L13P. TE*RDROP IREPL4CtS 504-241 1
IP.TTI\CnING P*RTSI
MS24693-IZ8 SCREW
~N515-6R5 SCREW ´•´•´•´•´•´•1´•i´•´•´•´•´•´•´•´•´•´•´•´•´•..´•...... 2

-200 150-0013 FL*SHER´• ILTERN*TING 1304671 I

I*TTLCHING PIRTS)
MS27039-1808 SCREW
1N960-BL W*SHER 4
---I---

310052 CCNE INSTL´• T*IL ISEE FIG´• 2-501 REF

-201 310052-11 LENS I
I*TT*CHING PIRTSI
-202 MSZ1694-SI SCREW 4
13L15-011-Z~* W*SHER 1785531 4
----I----

-203 1‘500-28 LIGnr *SSY, TIIL POSITION 110*021 1

IITTICHING P*RTSI
-204 HS35206-23L SCREW 2
---L---

*508 L*HP 1
310012-13 DOUBLER 1
800313 RELIY´• BUS bND GROUND WIRE INSTL´• LH C REF
RH
-)06 833019 RELI\Y IFEEOER
PROTECTION1 1 Y
(*TTbCHING PPR~II
-207 1N3-3* ´•´•BDLT´•´•´•´•´•´•´•´•´•´•´•´•´• 2
H*SHER ´•´•´•´•´•´•r´•´•´•´•´•´•´•´•´•´•´• Z
HSZ104*N3 NUT Z

-208 800313-29 CL~MP PISI I y

-209 800613-19 C*BLE *SSY L
I~TT*CHINC P*RTSI
*NI-5* ´•´•BOLr´•´•´•´•´•....´•.´• I
*N9~0P116 ´•+YIZSHER 1
nS2L083N5 NUT ......r´•´•-........´•´•´•............ 1

-210 800313-2) BUS 8*R I

-211 800313-15 ´•´•BUIBnR´•´•´•´•´•´•´•´•+´•. 1
-212 640055-501 STPRTER GENER~TOR, Dr IR~PLICES REF
L4005)-LI (SEE FIG´• 2- 51
800417-1 TR*NIOUCER INITL´• Ln L RH REF
-213 85049)-509 TR~NSDUCER´• FUEL I
r´•.................

890493-501 ..~R*NIDUCER´• OIL ´•r´•´•´•.........´• L

IITT*CHING P*RTS1
-215 *Nb289-* NUT I*LT PbRT *N92e’tl 1
bN960-7L6 Y*SHER I

-216 8l0175-501 TRINIOUCER´• TDRPUE LIMIrlNE I

I*TT*CHING PIRTT~
-217 PN~Z89-I NUT I*LT PnRT *N9ZC41 ´•´•´•11´•´•´•´•´•´•´•´•. 1
lN960-716 W*SHER L
-218 ~N6289-3 NUT I*LT PIRT *N924-31 1
*N960-61b uasHEn ........._
i

COOE EFFECTIVE ON SERlnL NUMBERS

Y 690* lII0D THRU L1113

a-158
 ILLUSTRATED 8ECTION n
CIULFSTREAM
COMMANDER PARTS CATALOO ELECTRICAL
BsOA/B80B SYSTEM

P 1 R T
UNITS US48Lt
rLGURE
O E 5 C R 1 P T I O N PER ON
INDEX
I Z i 4 5 7 dSIY COOE
NunsEn N U M ii E R

~00020-139 LIGHT LSII. L*NOING. Ln IIOUNTING HDYE 1

FURNISHED WITH LIGHT ISIII
200010~131 LIGHT 1SS*, LIHOING. RH IROUIITIHG HDYE L
FURNISHED UITH LIGHT ISS11
890)11-3 LIGHT 1SII, LINOING
LIGHT UNIT 1SSI I1LP10) I
-219 8-3L2)
SCREEH´• I(OTOR 1))914) L
-120 B-3~L9
0-2905.21 nOTOR LSSI 1129111 L
-Iii FILTER IND LIRICXET ~551´• NOISE I
11291))
CINDPY 11511 OUTER I12911) I
-223 8-(198-1
LLWP ´•´•´•´•´•r´•´•´•´•´•´•´•´•´•´•+´•´•´•´•´•´•´•´•´•´•´•´•´•´•´• 1
~LZ(
NUT BIND 1~51..´•´•´•.´•´•.....´•´• L
-215 8-3125
SHUNT INITL´• OEICER EPUIPIIENT REF
800601
SHUNT 2
-126 n5915B6-t0 r

(ITT*CHIHO PIRTII
SCREW L
.59520b2(~
´•´•NUT´•´•1´•´•´•´•´•´•´•´•´•´•´• 2
ISZ108~N08 ´•´•´•´•´•´•1´•´•´•´•´•´•´•´•´•.´•´•

---´•I-

POWER IL~PLI INSIL´• ELECTRO LVI1IHEICEHT REF

800601
FOYER SUPPLI INSTL. ELECTRO LUHINESCEHT REF
Bs0((1
FOYER SUFFL* (REPLLCES OIBBIl (1~550) L
-221 )1111.8
ISEE NOTE BELOW)
(LTTICHlHG PIRTS)
´•´•IC~EY 2
-)274 8521039-)-09
´•´•ULIHER ´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•1´•
2
489600416

t L
-1218 8901*7.5 (USE YITH 71254-81
IYLTE
PLITE L i
-2270 BPOIII-)
BR)ICIET IIS* L i
-2270 800660-1
BRLCIEI *55* L
800660-501
PLNEL INSTL1 OVERHEID SWITCH (SEE rIG´• REF
-218 800383

SWITCH IIPTLI C*BIN DOOR YLRIIINS ISEE REF

-229 800101
FIG´• 2-621
LOCI INSTL. DOOR SLFETI ISLE Flb´• REF
-230 800296
L~611
FUEL FLOW INITL REF P
800501
FLOW IIGH*L CONO´• INSrL REF W
800632 FUEL
FLOY StbNIL CDND´• INSTL REF B
800615 FUEL
It 6NIL COHOITIOHINb UNIT I P
-231 810198-50)
IIbNIL CONDITIONINb UNIT L WI
(150190-503
SlbNIL CONDITIONING UNIT 1 11
810190-51L
(LTrLCHINC PLRTEI
NUT P
*SIIOIIN3
1N96001O WISHER
´•´•PCREY I BY
)1S311207.lbP

LIGHT ISSI (IPel(l ISEE Flb´• REF

-232 1(1.05LI-71)-C-1
SWtTCB IHSTL´• STILL W*RNING IPEE FIG´• REF
-133 850016
2-341

I OPTIONLL INST*LL*TION IHD CO*PONENTS

CODE EFFECTIVE OH IERI*L NUNBERS

L 690* 11100 THIIU 11319
B 6908 11350 THRU 11599
P 6901 11100 THRU 11155
Y 690* 11156 TWRU 11319
i 6908 11310 THRU 11383
1 1908 11381 THRU 11599
1 6908 11)50 THRU 11(69
IL 6908 11470 THRU 11599

WOll

No. 130.
When replacing P/N 0168A with PIN 71154-8 order Custom Kit

2-11(1
Rsviaed: 28 November 1984
SECTION n
ILLUSTRATED GULFBTREAM
ELECTRICAL PARTS CATALOG COMWNDER
SYSTEM BgOA/880B

FIGURE P ii R T UNITS USI\BLE

i INUEX 0 E 5 C I P T I O N PER ON
NUMBER N U n B E n 12 ,e 5 b I assv CODE

2-2) -LPI 23000L T1P INSTL, WING ISEE FIG´• 2-371 REF
880L70 PREISURIL~T Lnh EPU IPnEYT INSTLI REP
COMPLETE IIEE FIGURES 2-e7 i P-bel
80011P PIINEL LIGHTS DIMIE(I INSTL REF
-236 8006~L-1 3IIIMER PSSI 2
IITTPCH1NG PIRTS)
HS35L06-ZI~ SCREW
1N960DB IIIHiR
---1---

861885 INTERIOR FURN LSHINIS INSTL REF C

861026 FURNISHINGS´• INT6RIOR REF K
861997 FURNISHINGSI INTERIOR RFF R
BblPIO INVERTER INITL´• FLUORESCENT LIGHTS REF
-237 Pn-´•28D-13FL-I INYERTER (ELECTRONICS INTL´•
WICHITI´• KS 67213)
I*TTICHING PIRISI
-231P MS1~643-SZB SCREH 2

-2378 861250-3 PLI\TE *ISI IUSE WITH 3L68*1 i d

-237C 861250-4 PLPTE LSSY I B
80063) R~CEPTICLE INSTLI EXTERNIL FOYER REF
-238 800(13*-5 0OOR dSIY ISEE Flt´• P-2BI i TU
8006*9 PINEL INSTL, ELECTRIC4L E~UIP*ENTI LFT REF SD
-239 305538-6 SPEED SWITCH (991931 2 BJ
IdTTbCnlNG PIRTSI
-240 nSZ108)N3 NUT i
bN460DLO WdSnER

-2cl 8330)8-1 IIBLIY 2 ED

I~TTdCnlNG PLRTSI
MS95106-2ZB SCREW D
PN96DD6 WIISHER

-2’,3 T*ISHOCI COVER 2 80

HIZ7Z1Z-L-L SIRIPI TERHIN*L P ED
I11~4CHING PIRTSI
-P** MS35P0(1-215 ICREU 2
-215 800650-1 PINEL *SSY i ED
---L---

800650-1 PINEL liSII´•´•´•.´• L BO

COOE EFlECTIYE ON SERI*L NUnBERS

b90* Li100 THRU L13*9
B 6908 11150 THRU 11599
C 690* L1100 ThRU LIZbB
D 1126P THRU 11)49
K b~01 11249 THRU L1~19
b906 ilPbP T~hU 11319
T b90* 11219 THRU 11249
L901 11269 T~RU 1i326
U bYOI\ LI~ZI TnRU 111’19

a-140
 ILLUSTRATED SECTION n
ROCKWELL
COMMANDER PARTS CATALOG ELECTRICAL
690A/B SYSTEM

a
’?’9\1J\~ 1

’i I’

iO 31

a~:
21
11
10 23
25
31 1 26
1 II
24~

23

o
c~
´•o~
10 II )Y/

2-141
Figure 1-26. Ovsrh´•.d Suitrh P.nsl in´•toll~tion (Sheet 1 of 2)
 8ECTION n ILLUSTRATED ROCXWELL
ELECTRICAL PAATB CATALOG COMMANDER
8Y8TEM BBOA/B

FIGURE P 4 R T UNITS US*BLE

C INDEX D E I C R I P T I O N PER ON
NUMBER N U H B E R 1 2 3 4 5 6 1 *SIY CODE

2-26 800574 EPUIPHENr INSTL, ELECTRICIL REF

800383 P*NEL 1N5TL1 OVERHE*O SWITCH REF
1 800602-1 PINEL´• SWITCH, LH F*LSE r.´•.......... L
800602-501 PINEL. SWITCHl RH FILEE ´•.´•´•.r´•...... 1 4
800102-501 P*NEL, SWITCH, RH FILSt I B
IbTTICHING P~RISI
3 IFSW‘(C-LZ-CP-LOIGY +´•SCREW. STI\KE (123241 5
SFSY-6C-I-CP-LOSGY SCREW, 5T~I(E I 123241 Z
---I---

800583-L PINEL rZISI´• OYERHEI\D SWITCH I t

800583-503 PPNEL *ISI´• OVERnE*O SWITCH ´•´•´•.r´•´•´•´• I D
800583-501 PbNEL *SSYI OVERHE*D SWITCH ..´•.r.´•r. 1 E
800583-509 PLNEL 1~SY´• OVERHE*D SWITCH 1 F
800513-511 PINEL 1SSI´• OVERHEID SHITCH´•´•´•´•´•´•´•´•´• 1 G
800583-513 P*NEL *SSII OVERHE~D SWITCH 1 H
800583~515 P*NEL *STI´• OVERHE*D SWITCH L J
5 20-0307-1-)* PDSr LfGHT 1129 141 3
d 850171-503 YOLTIHMETER .....´•..´•I´•´•´• 2
IlrTdCnING PIRTSI
HS2*b9)-S30 SCREW i
N*S~87-ZI NUT .´•1+´•´•´•´• 2

7 IIGL51-IC-WH-C SWITCH (135591 5

I*I~*CHING PIRTS1
MS21694-530 SCREW ´•r........´•.´•.´•´•.´•´•.......... 2
N*S)9001-13 SP*CER 2
nSZ1D83N06 NUT ´•1..´•´•´•..´• 2
---I----

8 IOrCr9K-35 SWITCHI CIRCUIT BRE*KER 1011951 i

LITT*CHING P*8TSI
HS24693-530 SCREW ´•´•´•r...........t´•´•´•.......... 2
NdS~3DDL-L9 SP*CER
---t---
9 POTCI-/LK-20 SWITCH. CIRCUIT BRE*KER
LO ZOTC~-PK-I SWITCH, CIRCUIT BREI\KER i
IITTICHING P*RrSI
HSZ*L93-530 SCREW t........, 2
N*S~3DDI-19 SP*CER 2

LL 20TCr*K-5 r SYITCHI CIRCUIT 8RE*KtR II E*. FOR 6

-1, -503 L -5071 1O1P951
(*Tr*CHING PdRrSI
HS1*b9eS30 SCREW i
N*843DDL-L9 SP*CER 2

IZ 1205 IJ-I~ SWITCH (093531 I

(*TT*CHINC P*RTS1
N1S662-ZR6 SCREW 2
HSZ10~2L02 NUT 2

COOE EFFECTIVE ON SERI*L NUMBERS

4 6901 11100 THRU 11268
a 6904 E 6908 11269 *ND SUBS
C 6904 11100 THRU 11183
D b901 1118* THRU 11226
E 6904 11221 THRU 112L8
F 6901\ LIZbS THRU 11149
G L908 11150 THRU 11383
H 6908 11384 THRU 11*10
J 6908 11411 *ND SUBS

1-141: 1
ROCKWELL
ILLUSTRATED
BECTION n
COMMANDER PARTS CATALOG ELECTRICAL
BPOA/B SY8TEM

FILUKE P R T UNITS USIBLE

6 INDEX D E 5 C R I P T I O N PER ON
NUMBER N U n B t n 12 1 4 s a 7 assv coot

2-26 13 TIGW~I-LC-WH-C SWITCH 1735591

(4TT*CHINC PbRTSI
MSZ1693-S~O SCREW i
N*S~POU1-L3 SPICER
MSZIOB3NOb NUT Z

il ZOTCS-bK-IO I*ITCH1 CIRCUIT BREIKtR 101295) 5

16 Eb FOR -1´• -i03 P -507 L I
En FOR -5091
IPTTPCHING PPRTS)
nS2*h93-130 SCREW 1
NilS*3on L- LP SPICER Z

15 8D0L56-I PLUG I
InTTdCnlNG P*RTSI
MSZ*b93-S30 SCREW 2
NPS43oDi-13 SPICER Z
MS2I08)N06 NUT Z
---I---

16 Z0TC)-IK-LS SWITCH, CIRCUIT BIIEIIKER II Ei\´• FOR 3

-11 -503´•-501 6 -509) 1012951
I~TT*CHING "bRTSI
NS2’ld53-I30 SCREW
Ndj~3D01-L9 SPICER Z
---li---

17 95.1027 bM*tTtH
I*TT~CHING PIRTS1
SCREW 2
MSZL083NOb NUT Z

LB 800583-5 INIUL4TOR L
19 7208 IJ-ll SWITCH 1093531 I
IITT*CHING PPRTSI
SCREW
*ILLO~ZLOZ NUT 2

20 TIGER)B-LC-IH-C-XPE1 SWITCH 1135591 2

IblTnCHING PIRTS)
SCREW Z
N*S")OD1-13 SPICER 2
~SZLOR3NOb NUT ´•´•´•r´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•..... L
----I----

21 533-051-29 KHOIII50B’tl 2
90-1935-2 ´•+´•SUITCH IREPLICES INo2F~-3X31591 Z
23 TIGM)B-LC-WH-C SWITCH 173 5)9) ’t
2~ TIGMSM-1C-WH-C SWITCH 1735591 L
IITTPCHING P4RTS)
SCREW 2
NdS*)nOl-13 SPICER 2
nS2I0B)N06 N~T 2

15 SYZLCY-173 SWITCHI FUEL C HYD EHERljENCI L C

1271911
800583-11 SWITCHI FUEL PND HYDR*ULIL
EMtR(iENCY
ZO 80C583-7 KNOB Z C
KR-OI-L-SB-Y LNOB K

CODE EFFECTIVE ON StHIIL NUMBERS

C b9~d L1100 THRU 11183
b90d B 6908 L1184 4NO SUBS

a-143
SECTION n
ILLU8TRATED ROCKWELL
ELECTRICAL PARTS CATALOG COMMANDER
SYSTEM BIIOA/B

/r,

Il
r 1 i~ s3‘: II
n

52 50

r
z
is
1
cr
r
I?

~iaure 2-26. Overheod Swl~h Ponel Inltallation ilhest 2 of 2)

a-144
 ILLUSTRATED SECTION n
ROCKWELL
COMMANDER PARTS CATALOG ELECTRICAL

esOA/s SYSTEM

FIGURE P ii R T UNITZ VSIBLE

6 INDtX O E I C I I P T I O N PEK ON

NUMBER N U N n E R I i 5 a 7 nsrr CODE

L-Zh 27 5151 KNOB 111~911 I

Z8 OIZO XHtOSTnT i LM

29 e591 COUPLING ~IT´• TINOE~ 1Lla55) L

)O 0111 RHEDSTbT 12 El. FJR -513 6 -1151

(i~b551
31 3EP62~LP LIOP PSIY I0U3031
32 BtT~ZRLP IlljHT PSSI 100303~ 2

38 BtPbZBLP IIGHT ISIY 100)031 i

31 8005*9-1 KtllY BRILKEI nSSY L CD

800129-1 HELLY GRPCKET dSII L E

I~TTICHING PLKISI
31 nPP’te91-SB SCREW ´•´•´•´•´•´•´•´•´•´•´•´•´•.´•´•r´•´•´•´•´•´•´•.´•´•´•´•
2 CO
´•´•´•ICRE*´•´•´•´•´•´•´•´•´•´•´• 2 t

36 NliS~3000-Z8 SP~CtR Z CO
nli4)DOL-lb SPICtR Z E

WS2LOn3No~ NUT 2 CO
MS21D83hi0h 4UT 2 E

IELIIY I d
-17 833038-531
(PTT*CHING O*RTSI
MSZ10R3N09 NUT Z

nN9LoO* WliiHtR 2

38 800583-3 PPNEL L
I4TlnCHING P4RTSI
39 MSZ~b93-5Zh SCREW

10 B00384-L I~PPCRT nSSY L

*1 833031-535 RELI\Y 3 B
IbTI~CHLNG PdRTS)
(Z nS2(693-53 SCREW 2

MSZio83NO~ NUT
---ii----

13 100583-19 T-80*RU bSSY 12 t~´• FOR -513 L L B

-5151
IITTICHING PIRTSI
41 HSP’ta93-53 SCREW I
nSZ1083NDI NUI 2

800603 ilUS INSTLI OYERHEID SLrlTCH PIINEL REF

9S 8306L9-1 BUS (L E*. FOR -L INSTLI
80061V-50I ´•´•´•´•BUS´•´•´•´•´•´•´•´•´•´•´•´• I N

80061’)-)03 ....BUS IZ E*´• FUR -I INSTLI 1

18 800619-505 8US 1 N

19 I-0370-1 JUNPER 3

50 5-0370-501 JUMPER 1

51 1-0370-50) IUMPER i

52 5-0310-505 JUMPER 1

CODE EFFECTIVE DN SERIPL NUMBERS

L b90b 11100 THRU 1IZbB
b bYO* 6 6908 Il~bY PND SUBS
C 6901 LIIOD THRU LLIIP
O b90n 1118i THRU 11226
E 6901 L1ZZ~ T~RU LLZbB
i h901 LlloO THRU L13~9
M *908 11369 nNO SUBS
N 6908 11380 *ND SUBS

a-145
 SECTION n
ILLUBTRATED
ROCKWELL
ELECTRICAL PARTB CATALOG COMMANDER
SYSTEM
680A/B

1
1

gi
I

´•-F3
IODEL OOOA -11100 THROU(IH llZBB

Pigu.´• 1-17. S.,1´•ry inl,oll.tion (SL´•.L I of 3)

a-148
 ILLUSTRATED
ROCKWELL SECTION n
COMMANDER PARTS CATALOG ELECTRICAL
89oA~ SYSTEM

FIGURE P I R T UNITS US4RLE

INUEY 0 E 5 C R 1 P T I D N PER ON
hUMBEk N U M O t R L 2 3 5 6 7 PSSY CODE

2-27 d0057~ EUU IPRENT INITL´• ELECTRICIL REF ns

800661 EYULP~ENT INSTLI ELECTRIC4I RE~ C
8004LL IbTTERY INSTLI OU4L, LH 6 KH REF n
I N*ZWZS5-80-* DUCT (05)991 2
I*TTICHING PPRTSI
2 liNT37TW58 CL4MP 2

3 240~4 TEt IP79DII L d

It NWZWZS)-Pb-I OUCT ´•´•´•´•´•´•´•´•´•r´•´•´•´•´•´•+´•´• 1 n

IPTTICHING PIRTSI
5 1N731TW46 CLIHP ´•´•+.´•´•´•.´•´•´•r´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•-´•´•´• 2
---I---

d 800125-1 NIPPLE ISSI

7 800609-1 NIPPLE dSSI 1 iZ
a 800’t28-1 SCUOP b
8004LL-3 STRIP L n
IbTTICHING P4RTS)
IU "1S)51OT-261 SCREW 1
INPbODIO WISHER I
------I---

ii 690416-1 NIPPtE aSSY 2 n

Ir 80012)-501 HOL000iiN iS 6Y I BI\TTEIIY r Z ii
13 M527975-4 CLEYLS 2 P
IIITICHING PIRISI
I’t MSLOIPZ-2CI1 ´•+PIN I
35246L5-L5L PINI CUTTER

15 L~990-Z BITTERY 1090521 I

16 800608-501 dNSLEI Ln FWO I P
801)608-501 I\NiLE, Rn FWO 1
17 800608-1 INGLEI iH 9FT I
800608-2 4NGLEI RH 1\FT L n
I~TTdCHING PLRTS1
18 MS~7039-L-08 SCREW 2
4N960DIO WISHER 2

L9 800607-1 FR4nE ~SSY1 LH

800607-2 FR**E i)lSY´• RH L 1
IdTTICHING PIRTSI
ZO nSZ*b91-S51 SCREW I

21 ns25 18 2-2 CONNECTOR 1 BliTT ERY 2

800631 BITTERY INSTL REF 5
22 DUCT 1053491 6 R
I4IT*tHING PPRTSI
23 CLPMP IZ
21 nSZ19L9DG-)I CLIMP 2
nS27039-1-08 SCREW 2
INPLOD10 WISHER Z
MS2108)N) NUT 2

25 2409* TEE 121901) 2 B

ZI NllWWZS4-’18-* DUCT L
(~ITICHING PbRTSI
27 1N13~TY3* CL*MP 2

CODE EFFECTIYE ON SERIlLL NU*BERI

e bsoa L1100 THRU L12~8
B bPO* ilZbP THRU 113~9
6908 11350 *ND iU8I

a-14’1
 BECTION n ILLUSTRATED
ROCKWELL
ELECTRICAL PARTS CATALOG COMMANDER
BYSTEM 89(IA/B

’"ai~

.~r"

25 1 K\ I I/ ii
a,
I i Yh3it~-28

32

22 33

22 B(
80
i3 58

32
?b 23

MODEL BBOP~ 11288 THRU 11118.

~isur´• 2-11. B~lt´•rv ISh´•´•l 2 ol 31

2-148
 ILCVSTRATED SECTION n
ROCKWELL
COMMANDER PARTS CATALOG ELECTRICAL

690A/B SYSTEM

P 4 n r UNITS UsnsLE
FIGURE
0 E I C R 1 P T 1 O N PER ON
r INDEX
M E I 1 2 3 4 5 6 7 nSS~ GOOF
NUNBEH N U B

DUCT L B
2-27 ZB NWZUZSI--90-I
I*TTICH1NG PIHTSI

29 bN737TW3* CLIRP

800609-501 NIPPLE 4SSY 2 B

30
BPO4Lb-1 NIPPLE 4117 4 B
31
SCilOP 3 R
j2
J3 800428-505 ´•´•SlOnP L

650425-1 UIPPLE ilSSY 2 B

311
800L3R-L STRbP B
35
LbTTdCH1NG PPRTS)
36 FIS35207-2bl SCREH 4

iiN961010 H*ZHER
---*i---

B4T1ERY 1090521 Z 8
37 11990-2
900411-501 HOLI1UOWN PISSY 4 B
38
MSZ7975-’1 CitYIS 8
35
IPTTbCHING P4RTSI
40 MS20392-LCll PIN ´•´•´•r´•´•´•´•´•´•´•+´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•

r PIN. COTTER I

800613 BI1TEHY INSTI, LEI\O 4010 REF t

.41 800L53-3 DUCT I C

ti00b53-5 DUCT I C
12
800e53-7 DUCT L C
-43
800E53-Y DUCT I C
I4TTPCHINC PPRTSI
45 4N73/TW34 ~L9nP 2

800053-L1 SLtEYE 4 C
456
ELBUH C C
158 lSI-IOn6N
IbTTPCHING P4RTSI

15L PS700n-BH CLIMP 108’1841 1

ie nSZIP19DG-LS CLIMP 2 C
IdTTbCH1NG PIRTS)

47 HS27039-L-OB S~REU 1
WnSnER +´•+´•´•´•´•´•´•´•´•´•´•´•1´•´•´•´•´•´•´•´•´•´•´•´•´•´•´• i

HZZ10R3N3 NUT I

*8 800654-1 NIPPLE 4SSY 4 C

44 800428-507 SCOOP 3 C

50 800*28-509 SCJOP ´•r´•´•´•´•´•´•´•´•´•+´•´•´•´•´•´•´•

L C

BBb38/T-E 6*TTERYI ii 4HP HOUR 1813751 NP C

51
B86381Tl-E 8II1TiRY I*B 4nP HRI (SEE LIIUTIUN 2 C
BELOWI 18*3751
80066)-1 HINDLING 4lSY, 84TTERI 2 D
52
5i 800b64-3 SIDE 4SSY L 0

800664-5 HbNDLE 4SSY ´•´•´•´•´•´•´•´•´•´•´•´•r´•´•´•´•´•´•´•´•´•´• 2 D

5C
IPTT4CHING P4RTS)
55 nSL7039-L-08 SCREU 2

LN960C1o UbSHtR Z
----I----

800(21-501 HOLDDOWN 4511 C

5L

CODE EFFECTIVE ON SERIIL NUMBERS

8 6904 LIZbP THRU 11319
C 6908 11350 4N0 SUES
O 6908 11385 4N0 SUES

TtT~1
CIUIK)N

When replacing one or both batteries in the same a~rplane,do not mix
41 amp hour and 48 amp hour batteries.

2-148
 SECTION II
ILLUSTRATED
ROCKWELL
ELECTRICAL PARTS CATALOG COMMANDER
SYSTEM BSOA/B

ss

~id
1 1. I
’I‘

cq
ie
c
r"

11 i. 18

IC

MODEL 8808 -11360 P~ND SUBSE(IUENT.

X’21"

Fipure 1-27. B.ttery inltall.tion (Ihset 3 o( 3)

2-150
 ILLUSTRATED
ROCKWELL BECTION II
COMMANDER PARTS CATALOG ELECTIUCAL
69oA/B 8YSTEM

FIGURE P 4 R i UNITS UlbBLE

C INDEX D E I C R L P 1 I O N PER ON

*UMBER N U M B E R 1 2 3 i 5 6 I bSSI COOE

2-21- 11 n527975-4 CLEYIS 0

I4TTICHING PbRTSI
58 nSZ0392-ZC1i PIN I

MSZ16t5-151 PIN´• tOTTEH I

310383 STRUCTURE ~SIY1 FUSELIGE ILEE FIG´• 1-541 REF

320018 DECK INITL. EUUIPnENT REF BC
59 )20OL8-31 CLt*T ´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•1´•´•´•´•
BC
I4TT*CHING PIRTII
60 *1N*Ztl-b~ EYE BOLT L
4N3-6* BOLT ´•´•´•´•´•´•´•´•´•´•´•´•´•r´•´•´•´•´•´•´•´•´•´•´•´•´•´•+´•´•´• 2
BUSHING 3

bN960D10 HIS~ER 3
MS2104*N3 NUT
---I----

62 320018-29 CLEIT BC
I~TTICHING PbffTS)
63 nN3-bn BOLT 2
N1\575-3-008 BUSnlNG 2
4N91U-3 +´•W*SHER 2
nSZ1DI~N3 NUT 2

CODE EFFECTIVE ON SEHIPL NUMRERS

B 6901 LIZ~Y THRU 11349
C 6906 11350 ~NO SUBS

a-151
 SECTION U ILLUBTRATED
ROCKWELL
ELECTRICAL PARTS CATALOG COMMANDER
SYSTEM BOOA/B

´•ia; ,1 a

23

’1´•
1

MODEL 888 PJB lluB. 11288

II P~ND SUBSE(1UENT

il/,\

’P d/ a

MODEL 880A 11100 THRU 11218. 11250 THRU 11288

"6

~ipure 2-28. Ixt´•mol Po.´•r R´•.´•pt..l´• .nd Door

2-162
ROCKWELL
ILLVSTRATED
SECTION n
COMMANDER PARTS CATALOG ELECTRICAL
690A/8 SYSTEM

FIGURE P R T UNITS USIBLE

6 INDtX D E 5 C R I P T I O N PER DN
NUMBER N U n a E R I i 3 4 5 a I nssv CODE

2-28 800514 EQUIPRENT INSTL´• ELECTRIC4L REF *B

800661 EPUIPnENT INSTLI ELEtTR1CPL REF L
8000L3 BnTT ERI INSTLI DUPIL REF
I B000L3-59 CI1ILt IZSSYI BbTT ERI DOOR LITCH L
I*TTPLH1NG P4RTSI
L MS20392-2-9 PIN, FLIIHE*O 2
UIZ’t6LS-LSI PIYI COTTER

3 i\N~ZB*i\ EYEBOLT 2
(PTT*CHING PnRTSI
I nI~ll**N3 NUT I
INPLODIO WISHER Z

5 800013-105 DOOR nSSY, *CCESS 1

(ITTICHING PIRTSI
6 19U001b-5´•TO PIN´• HINGE 2

I n50C3-06*-096 LPTCH LSSY, I\CCESS DOOR 18301~) Z

8000L3-169 SUPPORT L
9 d00O1j-L3L HINGE HPLF 1
10 800013-129 HINLE HILF I
11 80~0Lj-4T BRltKETI CIBLE RETIINING 1
L1 Mr350C-L RECEPTICLE, EXTERN4L POWER I n
lITTICHINB ’IRTSI
lj HS2*693-SZll SCREW 2
nN960010 WISHER 2
NUT

LI 51bb NIPPLE 1779691 Z P

LS 800013-LZ3 BRPCKET 1 EX T PWR REC EPTPCLE 1 I
16 1000L3-127 GROUNOI EXT PWR RtlEPTI\CLE
BUS1 I
11016)* REC EPTICLE INSTLI E XTEPNIL POWER REF BC
17 d00634-5 DOOR bSSY 1 BC
(4ITICHING PIRTZI
LB nSZOZ53-PZ-Z5o PIYI HINGE I

L9 LE-OZ4C-3 SPIING 18I8301 Z BC

20 800136-L GROUND BUS I RC
(PTT*CHING P4RIS)
2L PN*-LI BOLT
IN96101I6 WISHER 2
3SZLDBPN1 NUT Z
---ii---

II MS3500-L RECiPTdtLEl EXT ERNIL POWER L BC

lITTICHING "4RTSI
-23 SCREW 2
1NY600LO WISHER 2
ISZLO8)NS NUT 2

2’, 800635-L IRICKET L BC

I*ITICHING "bRiSI
25 nS27039-1-06 SCREW 2
i\N960DLO WISHER ´•+´•´•´•r´•´•´•´•´•´•´•´•´•´•´•´•. 2
~IZ1SB)NI NUT

Zb MSIDOOIPYZ-I50 HINGE HILF 1 BC

27 800L3’l-3 PL4TE 1 8(
ZB I~Ot3L-7 DOUBLER I Bt

CODE EFFECTIYE ON StRIPL NUMBERS

b 690* lllOU THRU 11268
B 6901 11219 THRU liZ*9
b9oP LIZLY THRU 119*9
C 6908 11350 nND SUBS

2-153
 ILLUSTRATED
ROCKWELL
SECTION n PARTS CATALOG COMMANDER
INSTRUMEhlTS
690A/B

:e

~SK
t´•
PI

2-29. Inrtrumont Group LH In~trumant P.nsl

2-154
 ILLUSTRATED
ROCKWELL
COMMANDER PARTS CATALOG BECTION n

B80AiB IN8TRUMENTS

FIGURE P 1 R T UNITS USnBLE

C INDEX D E T C R 1 P T I O N PER ON
NUMBER N U H B E R L 2 3 4 5 6 7 4SSV CODE

2-29 850l1T INSTRUMENT P*NEL ISIYI LH REF

L 850212-523 IN31C4TDRI 4IRSPEEO L

8505 Bb- L I ND ICbTUR I 4 I RSPEEDI MIIYI*UN nLLLiW48LE I BC

2 850092-901 INDICITORI 4LT1HtTER I D
850092-503 i ND LCI\TOR. 4LT I METE R 1 Ct

3 115(1097 INUICITOR´• DIRECTION4L GYHG L

1 850118 INOIC*TOR, RiiTE OF CLIMB L
5 850091 CLOCn. 8-Unl L
883008 INOICITURI CPBIN R*Tt-OF-CLlnB
7 850221-503 INOICITDRI C4B1N *LT t UIFFERENTI*L L F
PRESS
85022L-50S IN~ICITURI CIBIN bLT L DIFFtRENTIPL 1 G
PRESS
II\TTnCnIND P4RTS)
B nS246$3-53L SCR~I na

N4S487-P1 NUT PR

9 8)0096 INOICITUH´• 4TT1TUDE OYRO I

LU 850095 INDIC*TORI TURN 1ND 84NK
a50202 INDICPTDRI TURN-INO-BIYK 1 t
(4ITnCHING P4KTSI
LL MS3520b-213 SCR Eii t nR
N4SI8I-21 NUT PR

Il 60121-01 EL EEIENT´• LIGHTER Ii 5)12 1 I ii

ao2sa-o~ SOCKET I C i GI\RETTE L I GHr ER 115’t721 1 ii

13 20-0307-G-8-21 POST IIGHT (dLT P4Rr 20-0304-0-8-241 16 H

1728141
20-0301-i-a-ZL POST LIGHT II)LT PI\RT 20-030*-T-8-P’tl LS J
1729111
10-0301-T-8-2* POST LIGHT 1719141 1 It
14 110119-501 DtCbL i P

15 I9301-49 DtCPL RC

CODE EFFECTLVt ON SERI*L NUMBERS

4 6904 11100 THRU 11L4B
B 69041 11249 THRU 113’19
t 6908 L1~50 nND SUBS
O bYOb LLIOO THRU 113~9
E b904 11340 THRU 11349
F 6904 L1100 TnsU 11113
G 6904 B 6908 1I1II nhO SUBS
n 6904 LI100 THRU 11126
J 6904 8 6908 LllL7 bNO SUBS
K 6904 11127 T~RU L1248

2-155
 ILLVSTRATED
ROCKWELL
SECTION U PARTS CATALOG COMMANDER
INSTRUMENTS BOOA/B

10
1

i
r
I,

~i(lur´• 2-30. Inltrum´•nt Group C´•nt´•r Inrtrum´•nt P.nel

a-156
 ILLUSTRATED
ROCKWELL
COMMANDER PARTS CATALOG SECTION n
690A~

FIGURE P K T UNITS US48LE

G INOEX 0 t I C R 1 P T 1 O N PER UN

NUMBER N U M B E R L 2 I J b I *ISY CODE

2-30 850581 INSIRUIENT PINEL nSSY´• CENTtR REF

L 650415-1 INOICPTORI HORSEPDWER 2

2 850508-1 IND1CPTDR´• INTER TUKBINE TEMPEK*TURE 2

3 85(1275-507 I NUICPTORI TI\CHOHET ER 2

850’198-L IND LC*TOR. FUEL FLOW Z
860J9o-1 IND1C4TOR. FUEL FLOW 2 BC
850590-507 INDICPT~RI FUEL FLUV I 0

I4TT*CHING PbRT~I
NSL"b9P-SZ75 SCREW L
6 MSZBO*Z-14 CLPRP, INSTRUMENT 1

7 850~98 LNOICITORI FL*P POZITICN ´•´•´•´•´•´•1´•´•´•´•´•´•´• L

8 890170 GdGE. nro PaEss. I
9 850205-501 IND1CPTOR, TRIM TPB POSITION 1

10 650493-517 S~GEI ENGINE 2 48

G4GEI ENGINE ´•´•´•´•´•´•´•--´•r´•´•´•´•´•´•´•´• 2 CD
IPTTPCHING PIRTS)
ii "152~L43-5)1 SCREW 3
NnS187-LL NUT 3

12 850498-501 TDTI\LILEK´• FUEL FLOW I ii

850590-501 TUTILIIER´• FUEL FLOW L BC
850590-509 TOTPLIIEK´• FUEL FLOW I 0

(bTTdCHING PIRT~I
MSZ4691-S* SCI~W Z

L3 110185-1 DttnL ´•´•´•r´•´•´•´•´•.´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•+´•´•´•´•´•´•´•

L
L1 UEP621LP LlnP niZY 100303)
Id LO-0307-G-Ii-Z* P31T LIGHT IPLT PI\RT 20-0309-6-8-211 L1 4

172814)
20-0307-7-9-24 POST LIGHT I1ILr P4RT 20-030~-T-8-2*1 1I BE
11291~)

COOt EFFECTIVE ON TERI*L NUMBERS

4 ason LLloO THRU 11155
B 6904 11196 THRU L1349
C 6908 11)50 THRU 114~9
0 6908 L1*70 bND IUBI
E b90B 11350 nNo sues

a-157
 ILLUSTRATED
ROCKWELL
SECTION 11 PARTS CATALOG
COMMANDER
M8TRUMENTS
ssoi\le

P~

.o
M

~igure 2-01. Inlbu.´•nt Group RH tnrtrum´•n~ P.nel

2-158
 ILLUSTRATED
ROCKWELL
COMMANDER PARTS CATALOG SECTION n
aoon/e INSTRUMENTS

FIGURt P R r UNITS USIBLE

8 INOtX D E 5 C R I P T I o N PER ON
NUMBER N U M 8 E R 1 2 3 4 5 6 7 bSSY CODE

2-31 850576 INSTRUMENT PINEL 1SSYI RH REF

L 850~7L-509 LNDIC~TORI FUEL PUbNTI~Y I
L3U3~3-5o5 INOIC*TUR, FUEL OUI\NTITI 1 a

2 850169 GPGE, YbCUUn 1

3 85013C50L GIGEI BLeED i\lR PRESSURE 1
IITTbCHING PLRTSI
nS2*bP)-SII S~REI ilR
NPS4a7-ZL NUT PlR

5 Lo-0307-G-9-2* POST LIGHT (Plii PIRT 21)-0304-6-8-2~1 7 C

172814)
L0-0307-T-8-ZI POST LIGHT (1LT PI\RT 20-030I-1-8-2~1 B D
1129Lll

CODE EFEECTIYE ON SERI~I NUMBERS

n 690n 11100 THRU llZbs
8 690P L 6908 L1Za9 bND SUBS
690b L1100 T~RU 11126
C 69oR Lilil ~NO SUBS

2-159
 ILLVSTAATED
ROCKWELL
SECTION n PA RTS; CATALOG COMMANDER
INWRUMENTS BIIOA/B

I:

Pilur´• 1-32. Inltrum´•nt Sub-P~n´•l ~nd Cir~uit Br´•~br P~n´•l

2-180
 ILLUSTRATED
GULFSTREAM
COMMANDER PARTS CATALOG SECTION n
6811A/B80B IN8TRUMENTS

P bi I T UNITS US*BLE
FIGURE
O E 5 C R 1 P T I O N PER ON
L INULX
NURBEI N U H B E R I L 3 5 L 7 nSSY CUOE

1~32 NO NUNBER IHSTRUNENT GROUP IUB~P)NEL L CIRCUIT REF

8I(E*IER 1151
850578-1 SUB~P*NEL 1.551. INSTRUNENT L 1

8505)8-503 SUB-PINEL 1SS*i INSTRU*ENr 1 8

SUB‘PINEL ISSI, INITRUNENT 1 C

850518-501 SUB-PINEL ISSI´• INITRUIENT L O

850518-509 SUQ~PLNEL ILS1´• IWSTRU)EEnr L E

1 TIGERS1- LC-Yn-C-XIEI SVITCH II El. FOR -505. -S07 E -5091 2

(7351P)
I rlSLII-1C-YH-C SNITCH EL. FOR -5051 ~501 6 -5091 I

3 TIG*5*-IC-Yn-C SNITCH (135591 ´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•I´• I

(IrrlCHIH6 PIRTS)
WS2(693-529 SCREY ..´•´•....´•´•´•´•1´•.´•´•´•´• 2
NLS()DDL-IP I r SP*CER ´•..´•.´•´•´•+´•1 Z
I(IZ10B3NOL NUT 2
---t---

3* 810118’)‘1 bUIRD, SNITCH ´•´•´•´•i...´•´•.´•´•´•´•´•´•´•´• L

(*TrlCHIHG PIRTI)
38 5FIY-bC-LZ-CP-L0561 ´•´•ECREY (1212)~
---I;---

900102-1 ~NOB Z
1525002-1 SUITCH´• Rln 618 (1LT PLRr I
*525002-~21
1N960Dbl6 ULSHER 1

d 850518-11 ´•´•(UIICH, TEI(P SELECTOR IREPL*CEI..... 1 1

81L1502651
0151 ´•´•RHEOSTIT ()~b55) I 8F

I 1601-´•)50rLBI-BL SNITCH. GROUND ILOYE11135191 L

(IrT*CHING PLRTI)
111352106-111 SCREY i
N1S(3000-16 SPLCER ´•´•r´•´•´•´•´•´•´•.´•.´•.´•´•´•.

11210Q3n0) NUT
---I---

s 130316-( COHIIOLLERI CIQIN PRESS 1101101 1

(Lrr*CNlHb PIRTS)
ICREY ´•´•´•´•´•i´•´•´•´•r´•

---1---
9 20552 I(NOB I1LT PLRT 013-0056-00 (12~1)) 1
100181)
10 0116 RHEOSTLT 11(6551
LI 3081012 RED ´•´•C*P(810131 L 1

11089‘3 C*P (093531 L BF

-11 )9-1 SNITCHI HORN SILENCER (BL0131 L
13 83)038-501 RELLI´•´•´•´•´•´•´•´•´•´•´•´•´•´• r´•´•´•´•´•´•´•´•´•´•´•´•´•´• L L
833038~1 ´•´•RELII´•´•´•´•´•´•´•´•´•´•´•´• ´•´•´•r´•´•´•´•´•´•´•´•´•´•´•´•´•´•´• I BG
rlTTlCnlNG P*RTSI
1182L083NO) NUT 2

-131 ~SZII1P-l-2 STRIP, rEIIIIIN*L 1 G

IITTLCHING PIRTSI
nS2)693’53 ´•´•SCREY ´•1´•´•´•´•´•´•´•´•´•´• 2
HSt1083 Nmr 2

CODE EFFECTIVE ON SERIIL NUIBEIS

L 6901 11100 THRU 11168
B 6901 11259 THRU 11)*9
C 6908 11310 THRU L13~1
D 6908 1I)LZ Tnau
E 6908 II´•,I 880 suer
F 6908 11)50 LND SUES
G 6908 LL3b2 LND SUES

Reviaed: 28 November 1981 a-let

 ILLUSTRATED CIUbFSTREAM
BECTION n PARTS CATALOG COMMANDER
INSTRIIMENTB BsOA/680B

FIGURE P b R T UNITS USIBLE

E INDEX D t I C R 1 P T I U N PER ON
NUMBER N U H a E n I 2 s I s 6 7 ~ssv cooE

n-3z 850572-1 PPNEL PSSYI CIR~UIT BPFIKEP L H

85051~-503 PINEL iiSSY1 CIRCUIT BREIZI(LK I J
850572-505 PI\NEL I\SSYI CIRCUIT a9EIIKtR L K
850)12-501 P*NEL IIQSYI CIRCUIT BREIII(EH L
850571-509 .PbNtL *55~1 CIRCUIT BREI\KER I
850572-511 PIIILL If SY 1 tl KCUIT IRE~KiR i N
L’t MSZrZ*I-35 CIRCUIT BRE*LER 2
L5 HSZS2*~-ZO CIRCUIT BRIIKER
16 7277-5-5-L2-507-61 CIRCUIT BREI\I(ER 29
I~L E9 FOR -Li 27 t* FOR 5031
-501 1 -5091 28 Eb FOK -5051
-17 SS-5105L PLUGBUTTON Il En´• FOR -1) Lb183~1
Is 7277-5-3-12-501-61 CIRCUIT BRtl\KER I* fit. FUR -L1 -5031
-505 L -5071 1826*71
19 7277-5-1-12-501-61 .~IRLULT BRE*KER (BZb’l71
LO 7271-17-Li-IZ-501-L I CIRCUIT BREPIKER 1 826)71 ´•´•´•´•´•.´•r´•´•´•´•´• 2
LI 7217-5-10-12-101-61 ´•´•CIRCUI~ BREII*ER 182617) 1 10
ZP BDOS15-L T-BU*RO LSSY
I*TTPC~ING PI\RTII
HI3)~0b-Zil SCREW I
PN960D~ WISHER 2
MSZL083N0’1 NUT 2
---e---

2P 833038-505 RELII 13 E*. FOR -LI I

IITTLCHING PIRTSI
H535206-211 SCREW 16 El´• FOR -LI 8
nS21OBIN0* NUT
PN´~ODI WISHER
----I---

-24 110185-591 OECIL

15 850578-9 *NGLE
IITlltHING PIRTS1
26 MS35P06-ZL’1 SCREW ´•´•´•´•´•´•´•1´•´•´•´•´•´•´•´•´•´•´• 2

27 MSPZ05R IWITCn (9)l’r61

CODE EFFECTIYE ON SLRI*L NUMBERS

F 6908 1ND SUBS
H 11100 THRU 11113
J 11I1I THRU LIIPI
K 690n L11ZB TnRU 11169
i 6P011 1L170 THRU 112(18
6901 LIZ*~ THRU 112~9
690P 11169 THRU 1130)
N ~YO* C 6908 11301 dND SUBS
O 690n E 6908 11269 IND SUBS

a-182
 ILLUSTRP;TED
ROCKWELL
COMMANDER PARTS CATALOG SECTION II
BSOA/B IN~RUMENTS

r
38 iqi.

I
i"s
L r L,,,
4,,iK a

r
1 Is
r r
II
II

ii ,I\v
’"d .E

iiour´• 2-33. Inr,rumsnt, R~dio. Cirluit ~nd 6vb-PIlnell

2-163
 ILLUSTRATED
ROCKWELL
IECTION n PARTS CATALOG COMMANDER
W(ITRUMENTS 680A/B

FIGURE P a R r UNITS USIBLE

B INDEX D E I C R I P T I O N PER ON
NUMBER N U M B E R 1 2 3 I 5 6 1 bSSY CODE

2-33 N~ NUMBER INSTRU*ENT. RIOIO. CIRCUrT BREPKER E REF

SUB-PbNELINITL
85(1*31 PaNEL I NSTL REF
1 850582-1 PaNEL. TOP ...........1.............. I
L*TT*CHING PLRTSI
2 HIZ409)-SZIO SCREW
3 nS1*69~-SL SCREW .´•.............´•´•´•..´•´•r........ 1
LN96008 ´•´•´•´•´•´•´•´•´•´•´•´•´•r´•´•´•´•´•´•´•.´•´•´•´•´•´•´•. 2
J698*-110 SnCCKMOUNT 1160051 r..............´•.. L
*N9~0010 W*SHER .´•........´•´•´•´•´•.´•.1...........

HSZ10**N3 NUT 1

850517 INSTRUMENT PINEL *SSI´• Ln 1

5 850517-3 ´•´•´•P*NEL ´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•1´•´• I 1
850511-7 PaNEL 1 B
850517-9 PbNEL 1 CO
(LTT*CHING PPRTSI
b SCREW ´•....+....´•..r.....´•´•1´•...... 5
1196006 ´•´•´•WdPHER 5
I HS27019-OBOI SCREW 1
*N9L008 WPSHER ´•...........´•´•´•´•r.´•.´•....... L
B MIZ1039-1-1O SCREW
*Nl6001O W*lnER 4

850581 INSTRU3ENT PaNEL *SSI´• CENTER I

9 850581-3 P*NEL L EF
´•´•´•´•´•´•r´•´•´•´•.´•´•´•´•´•´•´•´•´•´•´•´•.....

850581-7 ´•´•´•P~NEL...´•´•´•´•.´•´• 1 G
L*TT*CHING PIRTSI
LO MS)S20b-228 SCREW 5
1N960D(I ´•´•´•**SHER 5
L1 HSZIOPP-I-10 SCREW 3
*NPb0010 W*SHER ´•´•´•´•.........´•r´•´•´•.......... 3
-12 HS2469~-55L SCREW ´•r´•.´•´•.´•.....´•´•..´•´•

-13 HIZ7039-1-11 SCREW 1

bN960DL0 YbSHER L
1* HS27039-1-12 SCREW 1
LNe60D10 W*SHER 1
-IS M53S206-230 +´•´•SCREH´•........´• 1
*N960D6 WI\SHER ´•´•´•1´• 1

850516 INSTRUMENT P*NEL dSSY, RH 1

16 850576-1 PL\NEL 1
(*TT*CHING P*RTI1
-17 HE85206ZZB SCREW I
aN96006 W*SnER
18 MSZ7089-080* SCREW I
1N960DB WaSHER I
19 MSZ1039-1-1O SCREW L
*N960010 W*SHER 4

CODE EFFECTIVE ON SERL*L NUMBERS

P 690 11100 THRU 11113
B 690* 1111~ THRU 112*8
C 690* 11249 THRU 11319
O 6908 11350 *ND SUBS
E 690* 11100 THRU 11127
F 6904 11128 THRU LIZbB
G bPOa 112L9 TnRU 11349

a-184
ROCKWELL
ILLUSTRATED
COMMANDER PARTS CATALOG SECTION n
BgOA/B INSTRUMENTS

FIGURt P I R T UNITS USIBLE

6 INDEX D E S C R I P r i O N PER ON
NUMBER N U H B L R I 2 3 i 5 6 I nSSY COOt

2-33 85D578-1 SU8-PI\NEL i\SSY´• INSTRUMENT L EF

850578-503 SUR-PPINEL *PPY´• LNSTRUWENI´•´•´•´•´•´•´•´•´• L G
850578-505 SUd-PIINEL *ISYI I NSTRUIILNT 1 H
850578-507 SUB-P*NEL P~IYI INSTRUMENT L J
850518-509 SUB-PI\NEL nSSY. INSTRUMtNT 1 K
20 850550-1 P*NEL. ELECTROLUMINESCENT L
850580-531 PUNCL, ELECTROLUHINESLtNT ´•´•´•1.´•... 1
855580-505 PPNEL´• ELECIROLUHINESCtNT I D
I4TTICHING PIRTSI
ZI SFSY-bC-L~-CP-L05GI SCREW 1123L~I
----I----

21 850975-1 PPN~L´• ELECTROLURINE~CENT L EF

850579-50L PLNELI tL~CTROLUMIHES(tNT I UG
IPIT*CHING PdR1I)
SFSW-LC-LZ-CP-LO)GY ´•.´•ltREkl 123211
---I---

23 850576-3 PI\NEL I HN
850578-7 PPNtL L JK
IbTTICHING PbRTSI
MSZ1693-525 SCREW II

2’1P 1900051-525 POST P HN

2900054-535 PUST 2 JK
I*TTd~HING PPRTSI
24B M521691-529 SCREW 2 HN
1524691-51 SCREW 2 JK
M135338-11 I(1CKNI1IHER 2 HN
H535338-10 ´•´•´•LOCKk4SHER 2 JK
HS35206-23L ´•´•SCREW 2 HN
nS3jZ00-ZL8 ILR~W Z JL
---s---

850572 PPNEL *iSY´• CIRCUIT BRE*KER I

25 850514-1 PPNEL´• FILSE L F
850574-505 PI\NEL, FI\LSE
85051*-507 PINtLI FnLSt L O
650574-509 P~NELI FPiiSE 1 DP
I~ITICHING PIRTSI
26 SCREW 1 123241 3

27 850585-1 PLITE´• COVER

IITTPCHING PIRISI
n535206-L29 SCREW LO

28 85057)-1 COYtR, CIRCUIT BRE4KER 1 HJ

B30515-50L COVER, CIRCUIT BREPK~R I
I4TTnCHINi PIRTSI
MS3520b-Z19 ´•.´•SCREW´•´•´•´•´•´•´•.´•´•´• I
---I---

CODE EFFECTIYE ON SERldL NUMBERS

U 6908 L1950 IND SUBS
E 690/L 11100 THRU 11127
F 6904 11128 THIU 11168
G b90P IIIb9 THRU 11349
H 6908 113)0 THRU 11361
J b908 11382 THRU I L~3 3
K 6YD~ 11*39 PND SUES
i ~904 11100 T*RU 11120
6906 11121 THRU 111i9
N b90* L1100 IHRU LL3*´
U 690n 1lL69 THRU 11301
P 690* 11305 THRU 11349

2-165
 ILLUSTRATED
ROCKWELL
SECTION n PARTS CATALOG COMMANDER
W8TRUMENTS 680A/B

FIGURE P Pi R T UNITS USABLE

C INDEX D E S C R 1 P T I O N PER ON
NUMBER N U M B E R L i P 4 5 6 I dSSY CODE

2-33 29 850513-)01 PANELI METAL, CIRCUIT BREAKER 1

30 850*62-501 ANGLE 1SSY´• SUPPORT 1 EF
850462-505 ANGLE *SSI´• SUPPDRT´• LH 1 DG
850462-503 ANGLE *SSI, SUPPORTI Rn 1 DG
LATT*CHING PARTSI
31 HSZM93-S5~ r SCREW ....´•´•´•´•´•´•´•...r...............´• i
*N960D8 WASHER b

32 850458-1 SPACER
IATTACHING P*RISI
33 H535206-2)2 SCREW I
AN96008 WASHER ´•´•´•.r.´•...................´•´•.. 2
---~i---

34 J6184-110 SHOCKMOUNT (160051 4

35 850*56-1 SUPPORT, LH L
J(I 850456-2 SUPPORT, KH +´•´•r´•´• L
31 850455-503 t SUPPORT 1
IATTACHING PARTS)
38 nS24693-525 SCREW ´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•.´•´•.r´•´•´•´•´•

---1---

-39 90005*-521 ´•´•SP~CER ´•´•´•´•´•.´•´•´•1´• 2

IATTACHING P*RTSI
10 NS35ZO~-26* SCREW I
nN960D10 WISHER 2

*1 BlO*50-1 ANGLEI LH .´•´•....´•.....´•..´•1´•´•´•´•..... 1

42 850450-2 ANGLEI RH L
43 850108-50) ARM ASSI, LH ´•´•´•´•´•´•´•r´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´• L
44 ARM ASS*l RH L
IATTACHING PARlS1
*5 HSZ1039-1-II SCREW L
nS35333-39 LOCKWASHER (BETWEEN EYEB[IIT C ARM 1
ASSYI
*N960D10 WASHER 1
NSZ1014N3 NUT .1´•´•..´•´•.................´•....... 1
----I---

46 150PLN‘IO SHOCKMOUNT I RH 1760051 1

150PLN-8 SHOCKHDUNT´• RH 176005L .....1´•..´•.... 1
IATTbCHING PIRTSI
41 1~438-131 EIEBOLT ´•´•´•´•´•´•´•´•´•´•´•´•+1..´•´•´•.......... 1
N1S130D~-15 SPACER ...........´•1.´•...´•........... I
19 J-2049-20 WASHER. SNUBBER 11L0051 Z
HSZLOIINI NUT I

50 8)05r1-1 CHANNEL ASSY. LH L

850571-2 CHANNEL *ESY´• RH L
IATTACHING PIRTS~
H535206-~28 SCREW
AN96006 WA SHER 1´• 4
----~i----

51 1S0PLN-LO SHOCKMOUNT 1760051 ...´•.r..´•......... I

IATTACHING PPRTSI
52 *N4-L5* BOLT I
)3 NdS*3DD4-ZS SPACER
54 J-2019-2D WASHER, SNUBBER 1760051 2
NUT L
55 MS35206-228 SCREW ..´•..´•´•´•.´•r..........´•..´•´•..... 4
AN96006 r WASHER ........´•.´•1´•´•................ I
---I----

CODE EFFECTIVE ON SERIAL NUMBERS

D 6908 L1350 AND SUBS
E 690* L1100 THRU 11121
F 690* 11128 rHRU 11268
G 690* 11269 THRU 11349

2-188
 ILLUSTRATED
ROCKWELL
COMMANDER PARTS CATALOG IECTION n
B80A/B INSTRUMENTB

FIGURE P I\ R T UNITS USIBLE

8 INOEY O E 5 C R i P I O N PER DN
hiUnsER N U M B E R L i 3 I 5 6 1 PSSY CODE

2-33 56 850~11-L SUPPORT I

51 850*l8-L *NGLE *ISY Z
IITTICHING PIRTSI
MSZ1039-L-OR SCREW 4
i\N960010 WISHER 4

58 850440-50L 8RICKET, LH L
59 850410-502 BRPCKETI RH I
bO 850’t38-1 i(R’I *SSY
I4TTLCHING PIKTS)
bl nS24699-S26 SCREW 2
b2 nS2469I-553 SCREW i

63 85041C-50L ´•´•SUPPORT IIIGLE´• RI\D\R I

(ITT*CHING PIRTS1
MSZ469*-S)i SCREW 1´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•++´•´•´•´•´•´•´•.´•... Z

b4 85043-503 STRIP ~ISY I

b5 850570-503 BRICKET nSSY, LH
66 850570-501 BK4CKET nssr. RH 1
61 850446-1 BAIICIFT /ISSYI LH FWO 1
68 850C1t-2 RR4CltT IISI, RH FWO
69 810417-1 BR~CKET i~SSY´• LH PFT
10 850197-2 BR9Clt~ *ISYI RH PFT I
-11 8504*5-1 ..4NjLt ..r.´•´•.´•..´• 2
12 1-0305-68-~ JUYPtR i
73 150452-1 STR(IP *SSY 1

2-181
 ILLUSTRATED
ROCKWELL
SECTION n PARTS CATALOG COMMANDER
INSTRUMENTS
880A/B

’n 2
cyu I I, I 1~1 I

3L

’"7~-F D
F
i

16~0 y

´•´•m

, r´•.´•I
3"1
23

Z t
i"
I

li(lY’B 2-34. Inltrumsnl Iquipment inll.llolion (Sheet 1 ol 3)

2-188
 ILLUSTRATED
OULFSTREAM 8ECTION n
COMNUNDER PARTS CPITALOO INSTTITIMENTs
BgOA/680B

FIGURE P 1 R T UNITS USPBLE

8 INOEX 0 E S C R i P T I O N PER ON
NUMBER N U M B i R 12 3 i 5 d I i\SSY CODE

2-31- 850024 EPUIPIIENT INITLI INSTRUMENT REF

850132 FITTING INITLI ST1TIC PREISUKE SOURCE I1EF
i 850L32-3 FITTING 2
850016 SWITCH INSIL´• STILL WIRNING REF
2 191-1 DETECIORI LIFT 1833261 1
IITTICHING PIRISI
M535206-227 SCREW
dN9L0-6 WISHER I

800~CI HORN LNITLILbNUING GEbR IND STILL REF

HIRNING
850195 INDICPTOR INSTLI STILL 1IRNING RtF
3 I-02-000HOD-S INUICPTOKI STILL WIRN LNG 183326) 1
31\ 28* HORN I NIIRNING 1833261 1 B

IITTICnING P4RiS)
4 MS3510(1-ZJ1 ´•´•SCREW
MS3520L-2i3 SCREW i
---I---

5 850195-3 BRICKET L

850418 INOItnTOR INSTL, OUTSIDE PIR REF

TERPER*TURE
1592-2b GdtEl DUTSIOE 1IR TEMPtR*TURE 109)911 1
850561 .CDRP415 LNSTL REF
I C2400-L4T-188 COMP4IS IITTICHING HOWE FURNISHEO 1
WITH CO*PIISI 1702111
8 850563-1 BRIC~ET (LSIY L
(*TT*CHING PIRTSI
HIZ7039CI-10 SCREW
*N960010 WISHER 2
850565-501 P10´• FHD 1
85D565-L P*O´• IFT L

850007 PITOT TUBE INSTL REF

9 850001-7 MOUNT nSSr I
B50015-50L TUBE *5 SY I PITOT. LH (iliT PIIRT I L

PH-SO(I-L IlOl)’tl
850015-503 TUBE bSSY1 PITOTI LH (*LT PIRT L
PHl LOO-L-L 1701 341
8S00L5-502 TUBE LSIII PITOTt RH (*LT P*RT 1
PH-)OL-R I10Il*)
LO dlNSBIZ-L PITOT TUBE I ITTICH ING PI\RT I
FURNISHED WITH TUBtl
850419 PIPING INSTLI NOSE INSTRUMENT REF
11 850503-25 HOSE IS SII YICUUM INLET PIIR IFROH TE t I E
ON YICUUH INLET HI\NIFOLO TO
TURN-*NO-BINK INDICITORI
-12 850503-33 HOSE *SSYI VICUUM INLET IIR (FROM TtE 1
ON V*CUUM INLET NbNIFOLD TO
REGULITED PRESSURE G*Gtl
13 850503-3L PSIYI Y*CUUM INLET *IR IFROM
HOSE TtE REF
ON YIZCUUH INLET nINIFOLD TO
YICUUM G*GFI (SEE FIG- 2-35)
14 850503-29 ´•´•HOSE*SIYI V*CUUH INLET nlR IFRON L
YICUUH INLET MbNIFULO TO
OIRECTIONII GIRO INOICITOR)
15 850503-21 1
HOSE nSSYI VICUUM INLET IIR (FROM
YI\CUUH INLET MINIFOLU TO
HOR12ONTPL GIRD INOLCbTOR)

CODE EFFECTIVE ON IERlbL NUMBERS

6904 11100 THRU 112d8
B 6904 11269 THRU 113*9
C 11100 THRV 11349
D 6908 11150 1NO SUBS
E ~90* lllOU IHRU 11113

2-189
 ILLUSTRATED GULFSTREAM
BECTION n
INSTRUMENTB PARTS CATALOG COMMANDER
BOOA/BOOB

FIGURL P n a i UNITS UlbBLt

L INDEX D E 5 C R i P i I O N PER ON
NUWBER N U H a t R L 2 3 15 6 7 bSIY COOE

31- Ib 1H929-I CIP 1SS* II USED ON SIH 11100 THRV 2

11113)
-17 TEE 2
.18 nSlOBL3-6D ELIIOW Z
19 1S20913-20 PLUG 2
850111 I*PER INSTL. VICUUI FILTERED 1IR REF
-20 850111-21 TUBE I F
850111-23 TUBE 1 G
21 810111-17 NOSE ´•´•´•´•´•´•´•´•´•´•´•~´•´•1´•´•´•´• Z
(IrTLCNlNG P*RTS)
21 1N13~TY18 UIRP ´•´•´•´•´•´•´•´•´•´•.´•´•.´•.......´•´•´•1´•´•´•´•´•
2

~2) nS35)8P~ZO GR()NNET 1

29 850111-15 OOUBLER L
25 1N8)2-I~D ELBOW 2
26 1200(9 BLOCI´• N*NIFOLO 1
(IrTICHINb PIRTI)
21 IN)HI~ BOLT I´•´•´•´•´•´•´•´•´•´•´•´•

LNI6DD1OL U*SHER

28 1N5B22-1 FILTER, *IR I

(*TT*CHING PLRTS)
29 LN)~LI BOLT P
1NeLDO(IL ´•´•H1IHER 2
NSIID(l3NI NUT P
---I---

30 21326 ELENENT, 618 FILTER (8132L) I

-II 850111-11 ´•´•BRICIET I
32 3101)3-71 OOU~LER ISEE Flb´• 2-511 1
850126 PIPING INSTL, INlfRVnENr (SEE Flt´• REF
2-361
33 880276-55 TUBE ISIII BLEED 1IR IIEE Flb´• 2-69 REF
FOR PIPING CONTINUITIOH)
36 850130-3 TUBE *SS*, BLEED 1IR (IEE Flb´• 2-36 REF cn
FOR PIPING COI(TINU*TIONI
-35 NIII)L(OII-) REDUCER I CH
’36 *H(I1B-IPO NUT I CH
-37 1NB~O-llO C*P 2 CH
38 *NB21-IID CROSS 1 CH
8501)0-21 NBE L cn
10 nlllelPHIZ CLII(P L CH
IITTICHIHG P*RTO)
1611039-1-01 ´•´•ICREY´•´•´•´•´•´•´•´•´•´•´•´• I
1N960D1D YISNER 1
NS21D((N3 ’LII 1

(OL 890366-11 LDIPTER 11S* (SEE Ftb´• 1-12) REF CH

850285 EPUIPIEHT INSTLI Y*CUU* EJECTION REF
8901*8 DICER INSTLI PNEUl(lrIC (SEE FIG´• 2-12. REF
FOR S/N IIIIb 6 SUBS)
850285-29 ´•´•EPUIPIENT IS(I´•´•´•´•´•´•´•´•´•´•´•´•´•´•´• 1 cn
-(L 1110)2´•~03 REGULITOR L tH
(LTTICHING PIRTSI
1N’103-10-8 SCREY ´•´•´•´•´•´•´•´•1´•´•´•´•´•´•´•.´•´• P
LN96ODI0 W*SHER 3
´•´•´•UIIHER´•´•´•´•´•´•´•´•´•´• 1´•´•´•...........´•..
3

12 lH833-120 ´•´•´•ELBOY´•´•´•´•´•´•´•´•´•´•´• 1 CH
(3 1N6289D12 HUT CH

CODE EFFECTIVE ON SERIIL NUNBERP

C 6901 11100 THRU 113)9
F 6901 L1IDO rHRU 1118)
G 6901 11181 TnRU
H 6908 11350 THRU 11*15

a-llo Revised: 28 November 1984

ROCKWELL
ILLUSTRATED SECTION 1l
COMMANDER PARTS CATALOG INSTRUMENTS
690A/8

:5

so--~b

43
~_[ 66

46 ;L46

ss r

MODEL 680~18 11100 THRU 11415.

ISEE FIGURE 2-72 FOR SIN´•s 11418 I\ND SUBSI

’i

Piaurs 2-3~. Inrlrumsnl Iquipm.nf Inrt.ll.tion Pheet 2 ~r 3)

2-171
 ILLVSTRATED
IMCKWELL
SECTION n PARTS CATALOG COMNIANDER
W8TRUMENTI BOOA/B

FIGURE P a R T UNITS US*BLE

E INDEX D E S C R I P T O N PER ON
NUnBER N U n B E n I z 3 5 b I assv CODE

2-34- 44 5-0311-912 RING, BaCKUP cn

45 S-0310-91ZHT D-RING 6 CH
46 *N78401Z TEE I En
47 1Ns32-1ZO UNION L cn
48 850278-1 *IR EJECTOR, DE1CER ´•...´•r´•´•´•.....´• I cn
I*TTPCHING PIRTSI
49 MSZ19190GZ9 CL*MP 1
HS27039-L-1I SCREW 1
NI\SIIDD6-2L SPICER I
INPbO-LOL ´•´•WLSHER..´•......´•. 1
HSZ1044N3 NUT L

50 aN929-8 CdP *SSY I CH

51 nN919-15D REDUCER L CH
52 S-0310-910HT ´•..(I-RINC´•´•´•´•´•´•´•´•´• 2 CH
53 810285-5 HOSE 2 CH
I*TT*CHING PIRTSI
54 bN137TW38 CL*UP ´•´•´•´•´•´•´•´•´•´•´•.´•´•´•´•r´•´•´•r´•´•´•´•´•´•´•´• 2

55 13)66 VILYEI RELIEF IZb1131 L CH

56 i\N932-D2 t PLUG L CH
-51 *N838-120 ELBOW I CH
58 aNB9)D1Z-L0 BUSHING ........´•...´•´•´•´•´•´•.´•r...... 2 CH
59 850285-19 JUTLET I CH
bO H135489-20 GRONAET L tH
61 850285-23 BRLCXET 1 tH
62 850430-9 TUBE *SSY ISEE FIG´• L-36 FOR INSTRU REF tJ
PIPING CONTINUITIONI
890348-91 TUBE ISEE FIG. 2-38 FOK INSTRUMENT.´• REF K
PIPING CONTINU*TIONI
850508 INSTRUMENT EPUIPHENT INSTL, ELECTRIC.. REF
63 213650 CONTROL BOX. PROP SING I C
I*TT*CHING PPRTS1
64 M295207-263 SCREW
bN960-10L W*SHER 4

850417-L C*LIBRaTION BOX, FUEL aUINTITY L

I*TTICHING PIRTS)
bb n535206-218 SCREW ´•´•´•´•´•´•t
4

*N960-4L WISHER
nS2LO*~NO* NUT ....´•..´•.´•.´•................1´•...

67 8330)8-501 REL*I 2 I
133038-505 REL*Y B
I*TTbCHING PIRTS)
nS~104*N04 NUT ...+.......´•1´•´•´•´•................ 2
1N960-4L H*SHER 2
---I---

68 r415HDI-10 COVER, TERHIN*L 80*RD 18497Ll 1

69 T-BD*RD ´•´•´•´•´•´•´•´•´•´•´•.´•´•1´•´•´•´•1..´•...... L C
I~TT*CHING P*RTSI
-10 MS3520bZLI SCREW 3
*N9bO-~L WI\SnER .´•..´•´•´•1´•´•

MSZIO4*N04 NUT .....´•.´•.´•1´•1´•´•´•.................

CODE EFFECTIVE ON SERI*L NUMBERS

a 6906 11100 THAU 11268
B 690* 11269 THRU 113~9
C 6901 11100 THRU 113*9
H 6908 11350 THRU LL~15
J 6908 L1350 THRU 11*51
K b908 LI*521ND SUBS

a-172
ROCKWELL
ILLUSTRATED
COMMANDER PARTS CATALOG SECTION II
B(IOA/B INSTRUMENTS

II .OD.L BBO*- IIIODTHROYOH 113´•8´• MX)II 68rB 115.0 iiND SUBS.mTNT

r ,,a
\‘i
3-
w

.k~-lo

a
1 I r
a

I‘--
II,
\v

E F MODEL 8808 -11388 I\ND SUBSE(1UENT

~I

Figure 1-34, in,trum´•nt Fquipmenf Inrl.ll.tion(Shset 3 o( 3)

2-113
 ILLUSTRATED ROCKWELL
BECTION n
INEITRITMENTG PARTS CATALOG COMMANDER
BBOA/B

FIGURE P I R T UNITS US*BLE

E INDEX D E S C R I P r I O N PER ON
NUMBER N U n B E R I z 3 r 5 b I nSSr CODE

1-34 11 810475-503 r
CONTROL BOX. TORPUE LIMITER 2 C
I*TT*CHING PIRTTI
12 nS3520b-1)1 SCREW 4

LN960-BL WISHER
----1---

73 850514-1 PLI’IE dSSI I

85059*-1 BRICKET ´•´•´•´•´•´•´•´•´•´•r´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•+ 1 B

1~ 850522-L INGLE Z
810522-501 INGLE 2
75 106PDL-3 SHOCKMOUNT (*LT P*RT 106-PLW31 4 C
(bTTbCHING PPRTSI
16 nS35206-228 SCREW .´•´•´•´•1´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•
L
dN9L~OD6 WISHER .....´•´•´•´•´•rt´• L
~ZD19-LD WISHER, 5NUBBER 1160051 L C
nS21044NOb NUT .....´•r´•´•´•´•..´•´•´•...........´•.....
I
---t---

11 850516-1 INGLE 4
800646 BOX INSTL. FUEL PU*NTITY MONITOR ISEE 1 ED
FIG.
2-251
TB 630314-503 HONLIORI CONTROL 1 ED
I*TT*CHING PLRTSI
19 H1)5201-Pll SCREW 4
nN960D10 WISHER ´•´•.´•´•1.´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•

80 800633-1 BRI\CKET *SSY ´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•t 1 ED

850599 .tONTROL BOX INSTL, PROPELLER REF D
SYNCHRONIIER ISEE FIG´• 2-Z51
81 213611 CONTROL 801r PROPELLER SYNCHAONIIER 1 D
I*TT*CHING P4RTSI
BZ nS35201-263 SCREW ´•´•´•´•r´•´•´•´•´•´•´•´•´•´•´•´•-´•

*N960D10 WISHER 4

NUT L
~521083N3

83 813018-505 REL*I ´•´•´•´•´•´•´•´•´•´•´•´•r´•´•´•´•´•´•´•´•´•´•.´•´•´•´•´•´•´• 2 D

(*TT*CnlNG PIRTSI
B1 HS3520L-~IS SCREW Z
*N960DI WISHER Z
nSZ1083N04 NUT ´•´•.´•r´•´•´•´•.´•´•...´•´•´•............... 2
---I---

85 rn15n04110 COVER 1849711 I D

86 MS21212-L-tD T-BOIRO 1 D
IITT*CHING PPRTS)
81 H535206-214 SCREW 3
*N96004 WISHER 3
MS21083NO~ NUT 3
----t---
88 850601-501 PLlTE ´•´•´•´•´•´•´•´•´•-´•´•´•´•´•´•´•´•´•´•´•´•´•r´•´•´•´•´•´•´•
I D
IITTICHING PLRTS)
89 n231ZOT-Zb3 SCREW ´•´•´•´•´•´•´•´•´•´•´•´•´•´•1´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•
I
PINP60DL0 WISHER 4
----t---

850600 r BOX INSTL, TORPUE L1MITER (SEE FIG.... REF D

2-2)1

CODE EFFECTIVE ON SERr*L NUMBERS

b00* 11100 THRU 11268
B 690* 11269 THRU L13~9
C 6904 11100 THRU 113*9
D 6908 11350 nND SUBS

2-114
 ILLUSTRATED
ROCKWELL SECTION n
COMMANDER PARTS CATALDO INSTRUMENTS
Bg0A/B

FIGURE P n a r UNITS UsasLE

I INOEX 0 E S C R 1 P i I O N PER ON
NUMBER N V H B E R 1 2 3 15 L I 1~IY CODE

2-31- 90 850475-503 CONTROL BOXI TORPUE LlnLTER 2 D

(ITTICHING PIRTSI
91 n535106-211 ZCREY
W*SHER 4
MS~1583N08 NUT ´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•r´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•

92 8)0602-1 IRILKET 1 n
93 B50604-L PNGLE 2 0
94 850516-1 ~hjLE ´•r´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•
D
95 L06POL-3 .r SHOCKMOUNT D
li\LT PI\RT 106-PLW-3 OR 106-PL-JI
IPT~ICHING P4RTII
96 nS3520L-250 SCKEH 1
i\lY9LOOR WlfHER i
J2049-IO W*SHERI SNUBBER (76005) I
MSZ1OR3NDB NUT ´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•-´•r´•´•´•´•´•´•´•´•´•´•´•´•
I

CODt EFFECTIVE ON SERIIL NUMBERS

U 6908 11350 *NO SUBS

2-116
 SECTION n ILLUSTRATED ROCKWELL
INSTRUMENTS PARTB CATALOG COMMANDER
680A/B

´•ii;i‘

:3
:s
i;
z
7 j
\iL
:o?

ft*

~ilur´• 2-31. Nol´• Inltrum~nt Pipinp Ilh´•´•11 of 6)

2-178
 ILLUSTRATED SECTION n
CIULFSTREAM
COMMANDER PARTS CATALOG INSTRUMENTPI

ssaA/esoB

UNITS US~RLE
FIGURL P P R T
U E S C R 1 P T i U N PEP ON
INDEX
I Z 3 15 L T .IPSY tODE
NUnatn N U n 9 E R

INST L1 NOSE INSIRUULNI REF IB

850419 PIP ING
2-35
IIEDULI\TEO PIIE SIURE L liB
L 850503-21 HOSE P11I1
HOSE I\IZYI YII(UU* INLET ilR ISEE FIG. RLF
Z 850503-13
1-3"1
VICUUN I PR
3 850503-31 .HOSE I\SSYI
IFROII HYO PIIEISULE GIIGE TD
1\551 PB
850503-23 HOSE
FLIP SOLENOID Y*LYFI
IFROI YbCUU* NI*IFOLO TO L dR
5 850503-15 HOSE n65I
aTTITUOE GYROI
HOSE PSSY (FROM VPCUUN MIZNIFOLD T~ 1 i\B
8)0503-13
DLRECTIONdL GYRUI
HOSE ISSY IFROM VICUUN H*NIFOLO 10 1 n
7 850503-11
rvnN-nNo-snNKI
NIPPLE L P.
8 auslb-ro
1 a
u Hriaosa-1 vaLvz
PLUG I
arsls-lo
NLPPLE 4
10 IN9i1-1D
bSSY1 IT*TIC 1 bB
11 850503-9 .HUSE
ITITIC L ns
12 850903-69 TUBE bSSYt
IT*T1C 1 PB
13 850503-07 TUIE I\SSI´•
IT*TIC L P
IL 850503-~5 nTIY.
TUBE
fTPTIC 1 B
850503-81 .TUBE IISIi
HOIE STPTIC I bB
LS 850503-19 1\5111
LO PB
LL dN816-4D NIPPLE
L P6
II dN832-)0 UNION
I*TTbCHING P4RTII
NUT 1
*NbZ89D~
O-R LNG L
I-0310-901R
RING, BiCKUP 1
5-0311-90*
----~i---
1 PR
L8 MS20823-6U LLBOU
L PB
L9 n520826-*0 TEE ´•´•´•´•´•´•f ´•´•´•´•´•´•´•´•1´•´•´•´•´•´•´•´•´•´•´•-’´•´•´•´•´•´•

NIPPLE 18
10 INBL6-bO
MSZOR23-IO tLBOW
TIE 11t568LI 3 bB
-22 *R6X-0
L I\
8-0361-~(1 TCE
I*TTILHING PIRTI)

*NL~8901 NUT
r-nlNG i
r-o,lo-sora
S-(1311-90L HINGI BILIUP
---L---

TtE I B
2) n520826-*0
L "a
25 5-0362-10 UNION
(ITTbCHING PPRTS)
NUT L
i\NBL9-*0
O-RINi I
S-0310-OL1R

I 1
2L 5-0362-10 UiilDN
NIPPLE i b
1-0313
FILTER 1900051 I nr
27 ~0-12*20-315
I PB
28 1N929-IO CPP
CI~SI L PR
29 4N119-L0
PLUG dB
30 *N932D2
NL PPLE L is
3L aNPII-LD
CaP Z 48
32 4N926-L
I *R
39 9000)7-b0-L6 RLZTRICTOR
LaP liSSr B
3L 1.929-1

CODE LFFECTIYE ON StHIPL

i 6904 1ii00 THRU 11113
8 bPOb L 6908 Liiil THRU 11*51

2-111
BECTION n
ILLUSTRATED
GULFBTREAM
PARTS CATALOG CUMMANDER
68DA/B80B

11 5

Ir 111

22 4 L

~cs
i
21

MOOIL BBOlil ´•11100 THRU II1I

aT~,,
21 21

10 I
II

BO
II
II
,Iu:113
i-
II

MOOII)POI ´•1III1 AND SDISIOUINT i

--c;II_-\-"
IOll~ Y

X’?

Pisure 2-35. No~´• Inrtrun´•nt Pipinp (Sh´•~l 2 of 6)

a-its Revised: 28 Novembel´• 1984
 ILLUSTRATED
CIULFSTREAM SECTION n
COMNIANDER PARTS CATALOG IN8TRUMENTS
BOOA/BOOB

FIGURE P b R T UNITS UIPBLE

L INDEX O E S C R 1 P T I D N PER ON
NunBER N U M B E a 1 2 3 i a r bSSI CODE

L-35 810016 PIPING INlrL´• INSTRUI(EHT ´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•1 REF is

-11 1200)~ n*NIFOLO´• YICUU* 1 is
(ITT*CMING P*RTS)
LN92)-120 *UT I´•´•.´•´•´•´•´•..´•´•.´•´•´•.´• I
1N9600I1I6L YIIHER 3
---I---
-36 850(30-19 HOSE L 1B
(ITT*CHINb P1ITSI
1N731TW3B CLLIP ´•´•´•´•´•´•.´•´•´•´•´•I´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•

-31 850*30-15 TUBE I IB

-38 1N833-1P ELBDU I is
(ITI*CHING P*RTSI
IN92)-120 NUT I
LN96ODL116 IIISNER 1
---t---

)9 820130-11 TUBE´• PITOT INOT USEO YHEN SERVICE 1 *B

LETTER HO´• 313 H1S BEEN
ICCOWPLIIHEOI
(LTTICHING PLRTS)
LH3-I1 BOLT ´•´•´•´•+´•´•´•´•´•.´•.´•´•´•1´•´•
~1119LsDb( CLIIIP
ln960-10L IILIMER
*SL1O((N3 HUT

39* LN929-~ C*P LSI* (USEO UHEN SERVICE LETTER Z *B

NO´• 323 H*S BEEN ICCO*PI
~)O 1NIIO*D* TEE I LB
(ITT*CnlNG PLRTSI
IN921-10 NUT 1
1119LOD116 YIIHER ´•´•´•´•´•´•´•1´•´•´•´•´•´•´•´•.´•. I

B10)0B LINE 1NSTL´• ITLTIC SOURCE REF *II

5I LHI)OLDI ´•´•PLUb´•´•´•´•´•´•´•´•´•´•´•´•´• Is
-12 nS2I9I9DGI CLLNP Z *B
(ITT*CHIHG PLRTSI
LN3-I6L BOLT 1
1Ne(00I0L U*S*ER I
N1S13OD(-B8 SPICER I
nSllOI(N3 NUT 1

.13 810169-10(1 TUBE LSII, ITLTIC I *B

810165-1019 TUBE *PS*´• ST*TIC 1 *B
UNION Z IB
(ITTlCHIN6 PIRTS)
1N921-(0 ´•´•NI~´•....´•´•..´•´•´•´•´• L
*NP100116 ULSHER ´•´•´•´•´•´•´•´•´•1´• I

850165-1013 TUBE LSSI´• ST1T1C L *B

-(1 850165-1015 TUBE LSS*, STITIC L *B
-IB 1NB0)0) TEE 2 II
(*TTICMIHG PLlTSI
INL2(I~DI ´•´•Hlr´•´•´•´•´•´•´•´•´•´•´•´•´•´• L
5-0311-901 ´•´•RING, 8*CIUP 1
5-0309-901 O-RING L
---t---
-)P 1N833~)D ´•´•EL)OY 1 is
IlTT*CHIHG P*RTSI
IN6L89D) nUT 1
5-0311-901 RIHC´• BICIUP ´•´•´•´•r L
1-0109-901 ´•´•O~R1NG ´•´•´•´•´•.......´•´•´•r´•´•´•
1

COOE EFFECTIVE ON SERI*L NUMBERS

6901 LLIDO THRU 1111)
B 6901 C 6908 11I1I THRU 11(51

Revised: 28 November 1984 2-119

 ILLUSTRATED OULFSTREAM
GECTION n
PARTS CATALOO´• COMMANDER
INSTRUMENTS
BgOA/680B

MODEL BBOI\/B- 11100 THRU 11161

I~
Is

13

21

LE_I MODEL IBOIVB ´•11100 THRU 1116(

81

e.
P 55

rilu.´• 2-35. N.~´• Inltrun.nt Pipino ISh´•´•r 3 o( 6)

2-180
 ILLUSTRATED
ROCKWELL SECTION n
COMMANDER PARTS CAT~LOO W8TRUMENTG
BSOA/B

FLGURE P 4 R T UNITS US*BLF

INDEX D E 5 C R I P T I D N PER UN

NUMBER N U M B E a 1 2 3 r 5 a 7 4111 CODE

2-35 50 ’tR6X-D TEE 1i568Ll ´•´•´•´•´•´•r´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•

48

5L S 50 Lb5- L 039 TUJE 1\5 5~ 1 STliT IC L ns

52 890165-L0"1 TUBE 45511 iidTIC ´•r´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•

I 4B

53 850530-3 TUBE aSSr1 STITIC ISEF FIG´• 2-36) I 48

54 850221 H9NDLt L 48

I~TTPCHING PIRTSI
MSLb5LZ-17 PIN, ROLL L

15 BSOILZ-l SnbFT 1 bB

56 85043~-L STOP I nn
I4TT*tHING PIRTII
HSIb5a2-I9 PIN, ROLL L

57 RS04oZ-i SPPCER Z 48

)8 850394-1 U-JOINT Z I\B

IITTICHING PIRTSI
MS16S~Z-L5 PI"I´• ROLL 1R

59 850*03-1 SH4FT L 48

60 550111-1 SUPPORT. HINULE I ilii

l4TTnCHING PPRTSI
M527039-1-09 SCREW ´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•1´•´•
2
MS35838-L3 LOCKWI\S HEK 2

LL 85040L-L PLI\TE 1 MOUNTING L 48

I4TTbCHING P4RTSI
62 MSZ7039-i-08 SCREW 2
1N960DLo WPIHER 2

HIZLOI*N) NUT
---t----

63 HE175-I YdLYEI SELECTOR 10201)1 L IR

I~TTPCHING PIRIII
MS35Z06-2-63 SCREW 2
MS35J38-13 LOCKUI\SHER 2

64 853*00-1 BKbCKET. MOUNTING I 48

I4rTPCHING PbHTSI
65 HS27039-1-08 SCREW 2
bN96OD1D Y4SHER
nSalD*IN) NUT ´•´•´•´•´•´•´•1´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•
2

BSO*06-l STOP I 48
I*TTICHING PPKTSI
67 nN3-1ZP BOLT L

bd NUS43D03-35 SPPCER ´•´•.´•´•´•´•´•´•´•´•´•´•´•r´•´•+´•´•r´•´•´•´•´•´•´•´•´•

1
LN960010L W*SHER I
NUT I

850179 PIPING INSTL, NOSE INSTRUMENT REF C

b9 850503-21 HOSE i\SSY I REGUL~T ED PRESSURE L C

70 850503-33 HOSE bSSII Y4CUUM INLET PIR IStE FIG´• REF

2-311
TL 850503-31 HOSE nSIYI Y4CUUM ´•´•´•+´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•t
1 t

12 8505D)-L7 HUSE 4111´• YICUUII L C

13 850501-23 HOSE 4SSY IFRL)H HYD PRESSURE G*BE TO 1 C

FL4P SOLENOIO VILYE)
71 810503-15 HOSE ~SSY IFKOR VLCUUM MINIFOLD TO I C
4TT1TUOE iYROI
75 850503-13 HOSE 451Y IFROM VICUUM *I\NIFOLD 10 I C
D1RECTIONPL tYRO)

CODE EFFEtTIVE ON SER~IL NUMBERS

4 ~PDb 11100 THRU 11113
B 6901 E b908 11111 IHRU 1115t
C 6908 11452 I\ND SUBS

2-181
 SECTION n
ILLVSTRATED ROCKWELL
INSTRUMENTS PARTB CATALOG COMMANDER
BSOA/B

I~ 12 90

02. 83 I 81
102
I! \u 1
M0011 BBOQ ´•11062 600 SUBSI(IUENT

i"l:
8,
7
j

2"
32
33
3P
10
28
1
33 /1 _21 1

2~

610061 6001\i0 11100 TARU 11161

Figure 2-35. No.e Inrlrumenl Piping (Sheet 4 ol 6)

2-182
 ILLUSTRATED SECTION n
C~ULFSTREAM
COMMANDER PARTS CATALOG 1N8TRUMENTB

seoA/esoa

UNITS USPBLE
ricual P 1 R
D E S C R I O N PER ON
C INDtY
L Z i 5 b 7 dSSY CODE
NUMB~R N U H B E R

NOSE 1SII, STlTlC I C

2. 35- 1B 850503-91
TUBE 19111 STlTIC L C
-11 850503~69
TUBE ~55’1. STlTlC L C
-IB 850503-93
TUBE 1SII´• ITlTlC L C
-19 (150503-83
HOSE 1PI*´• PITOT I C
.80 850503-19
NIPPLE 8 C
81 1NBIL-(D
LH832-~0 UNION 1 C
82
IITTLCHINb P*RTS)
1.628901 HUT 1

I-0110-90)R O-RING t
RING, 8*CIUP I

ELBOW 1 C
81 )1520823-60
TEE C
8) nS)OBZb-(O ´•´•´•´•´•´•..´•´•´•,´•´•´•´•´•i´•´•´•´•´•´•´•´•I´•´•´•´•´•´•´•´•
NIPPLE 3 C
85 INBLL~LD
TEE ((56B11 ´•.´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•i´•+´•´•´•´•´•´• 2 C
86 (RLX-0
UNION L t
.81 5-0362-*0
IlrTLCHIWG P*RTS)
nur I
1NB1B‘~D
1-0310-0118 O-RING I
---I---
NIPPLE 1 C
-88 1-0113 ´•´•´•´•´•I´•´•´•´•´•´•´•

LlTTICH(HO PLRTII
NUT L
LHBIB-(O
O-RING I
5-0310-0118

FILTE1 (900051 2 C
89
*N929.~ CIP *II* C
s0
CROSS L C
.91 1NPLB-10
TEE 1)56511 I t
PI ´•´•´•´•´•r´•´•.´•´•´•´•´•´•´•´•´•´•

PLUG 1 C
-93 1H9)2D)
NIPPLE I C
9(
CIP L C
95
RE)TRICTI1R C
-96
PIPING IHSrL, INSTRUI(ENT IIEF C
8’10126
*1NIFDLDI VICUUI´•´•´•´•´•´•´•´•´•´•´•´•´• I C
.9) 120016
(LTTltHIWG Plllrll
NUT ´•´•..´•.´•´•´•´•´•´•´•I´•´•´•´•´• 1
LN92I-12D
IHP60DLllbL YISHER

850(26-13 NOSE I C
.98
(lTTLCHINO P*RTS)
LNl)lTW3B CLMP I

B50~L6-9 LINE, ST1TIC L C

99
lNB))-IID ELBOW L C
-100
(lTTI(.NING PLRTII
1N92)-IID NUI´•´•´•...´•´•´•´•´•´•´•´•´•´• 1
IH9)00II16 Y*SHER I

850126-11 LINE ~SII´• PITOT (NOT USEB WHEN I C

-101
SERVICE LETTER NO´• 3)3 HlS
BEEN *CCO*PLISHED)
(LTTICHING P*RTS)
1H3-)* BOLT
nS2IPIsOG* CLLIIP
Y*SHER i

NSllDI)N3 NUT

11929-1 CLP 1~5’1 (USED WHEN SERVICE LETTER I C

-1011
NO´• )23 HIS BEEN ICCO*PI
-102 188010) TEE I C
IlTTICHIHb PIRTSI
*N9L9-)0 CLP ´•´•´•´•´•´•´•1´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•.´•´•´•´•´•´•´•´•´• 1
1H96DDII6 ULIHER 1

CODE EFFECTIVE ON SERILL NUnBEIZ

C 6908 11´•521ND 5UBS

Revised: 28 Navemher 1984 2-183

SECTION n
ILLUSTRATED
INSTRUMINTS PARTS CATALOG
BgOA/BSOB

;3

1!5193
ta

i;
i,
~a-ii

~-I.B
;1.. II
I’

i
121

TT

~igurs 2-95. Nets Inltrumsnt Piping (5heet 5 of 6)

 OULFSTREAM ILLUSTRATED
SECTION n.
M)MMANDER PARTS CATALOG INSPRUMENTS
BB(1A/B80B

FIGURE P IZ R T UNITS USIBLE

g INUEX O t S t R L P T I O N PER ON
NUMBER N U H O E R I 3 i 5 b 7 d951 GOOF

2-35 -103 85U’12L-13 LINE I\SSII STI\TIC I C

I*TTICHING P4PTSI
104 nN3-LOI BOLT
nSIIP1TOG4 LL*RP .´•....r´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•r´•´•´•´•´•´• L
NnS43003-C8 SPL(ER
i\N?60010L WIZSHEH 1
nSZIOLIN3 I
-105 bN3-be BULT I
NSL191906L CLlnP I
N4513003-16 SP4CER L
dlN9bODLOL Wn5HEK L
nSZ104SN3 NUT
---E---

-IOb PN83)-~D TEE 1 C

PIRTSI
IN92i-4D NUT 1
bN9LODT16 L*IHER L
---i----

-107 850*16-41 LINE 45511 STeiT1C L C

I~TTbCHING PIRTSI
-108 MSZI1IPDGI LL4NP
MS27039-L-16 SCREW I
N11513003-C8 SP~CLR L
INPL~DLOL Wi~ilER 1
1820365-1032 NUT 1

-109 4NB06-IO PLUG L C

-110 R50*26-33 LINE 95511 STI(TIC I D
-lil 1N833-CD ELBOWI BULKHEI\D I O

(ITTbCn1NG PbRTSI
liN9Z4-"U NUT L
PNPI0DI16 il45nER I

-llZ 850426-51 LINE 15511 STbTlC

-113 850416-51 LINE I\SSY1 STI)TI~ 1 0
850426-55 LINE iiSSY´• IZLTERNl\TE STPTIC I 0
-115 150416-47 ~OSt 1 (1

-Ilb INB2*-CD TEE I O

-LLI 810426-3L LINE *ESYI STI\TIC L C

-118 *535C89-L1 GROIIMET 2 C
-119 850424-39 LINE *SSY´• STI)TIC L D
IIITTI\CH ING P4R111
-1ZO nSZ7039-L-LL SCREW
NSZ19190G4 LLIMP
*N9LODL0L **SHER 1

MSZ1O~IN3 NUT L
---(i-----

-121 4N8C6-4D PLUG L

-L22 MSZ0822-9D ELBO* I O
-12) 4NBlb-4D NIPPLE 2 D
ES-X830 Y*LYE LNUT FURNISHEO WITH YILYE) 1 D
1215221
-125 850*2~-53 INGLE´• MOUNT I D
IbTTbCnlNG PIRTI)
-116 dNS-ld BOLT 2
I\NPIO-LOL WI\SnER 2

YS210~*N3 NUT 2

COOE EFFECTIYE ON IERIIL NUMBERS

C 6908 LL~SZ THRU LL599
D 6908 ii*52 THRV 11530

a-185
 ILLUSTRATED OULFSTREAM
SECTION n
INSTRUMENTS PARTS CATALOG CUMMANDER
6801\/6808

M00111108´•11162 TI(AU t,no

WITH SIRVIE~ LITTIR NO. 325
IIEOR~OAITIDIND MODIL 1001-
11131 THHU 11181.

115 :hX- P

132 i

,I
ts~
"*l‘ol

E12´•i

f~igurs 2-35. Note In~trumant Pipinl( Bhe´•t 6 of 6

2-188 Revised: 28 November 1984
 ILLUSTRATED
ROCKWELL 8ECTION n
COMMANDER PARTS CATALOG 1N8TRUMENTB
690A/B

FIYURE P P R T UNITS USdlLt

G INUtX 0 E S C R I P T 1 O N PFR ON
LUMBER N U M 8 t R I i 3 4 5 b I 1\551 CUDE

2-35 -121 R50)26-61 n(lSE I OE

-128 85042L-RE5 TUBE i\III´• ITlilt IIPLIT STI\TIC SYSTEMI 1 O
850426-t5 TUBE 4SSY1 ST*TIC ISPLIT STITIC SYSTFRI I F
-LPS IINBLI-*D Ttt i DE
-130 85042b-Rt9 TUBE 91SYI STnTLt ISPLIT STITII SISIEMI I 0
850426-69 TUBE I5II. STITIC LIPLIT STIITIC SYSTEEI) 1 E
-IPI M121919DGI I:LnMP I Or
I*TTICHING PIRTSI
MSZ7O1I-l-ll StREW ´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•.r´•´•´•.´•´•´•´•´•´• 1
LNILOU1OL ~ISnER r´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•+´•´•.-....

NUT 1
---t---

-192 850926-RE7 TUBE 4SSY´• STITIC (S’LIT ST*IIC SYSTEHI L 0

850426-61 TUBE ~55Y´• STnTIC (SPLIT STITIC SYITEn) 1 F
-133 1N833-ID ELBDW ´•´•´•.´•´•...1..´•´•.´• i D(
I*TTICHING P4RTSI
PN9Z4-4D NUT
nN9600TL6 WPSHER ´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•.´•´•´•r´•´•´•´•´•´•´• I

-L34 bNB15-LD UNION L DF

-L35 85092O-RE3 IUBE I(ISI, ST~TIC ISPLIT ST~TIL SYSTL-*I i
TUdt ~ISYI ST~TIC ISPLIT ST*TIC SYSTtNI L

CODt EFFECTIVt ON S~RI*L NUMBERS

D 6908 11*52 THRU LL130
C 6908 11531 THRU 11599

Z-ls?
 ILLUSTRATED
ROCKWELL
SECTION n PARTS CATILOO COMMANDER
INSTRUMENTS BgOA/B

M0OIL BOOPilB -11100 THRU II1III

~s 2!
1 13

18 !1 II
Is~

8! 88 M ~10
/12
MOOEL 8801´• I11121NO 8UB8EOUINT
81
82

E!~y 88

se

Piluro 2-36. Fur´•l~gs Inltrum´•nt Pipinp inrt.ll.tion (Sheel 1 of

a-188
 ILLUSTRATED
ROCKWELL SECTION n
COMMANDER PARTS CATALOG INSTRUMENTS
BSOA/B

FII´•Ul(t P 4 K T UNITS USIIBLC

IN~LX O E 5 i I 1 P T i O N PLR UN

h 1Miii ii U U M C t H 1 2 i 5 (1 7 45SY CI:LT

FjOlL6 "1P1NG 1NSILI INSIRUYEYT REE

Z-~L
I ’L3ii (Sit FiG. 2-351 liF
150~30-13 T~UE ~iSY1 Y4CUUM IN~TRUMtNT bII 1 4

3 bNJli-1Z3 U~ILN I

’t di’)~JO-LL TJiii 455Y1 Y4CUUU INITUUFIENT I\IU L d

PI*S 9 3- 1 i, t LJ~i i e
IIT~ICHING PhSTSI
nN921-1)3 NJT
bN9COCL116 L45HEK
---s---

6 113’t)0-4 TUJi *IISYI YICUUP INSrXJlltNT 111\ 1 b~

i Y50PB) t)UIPYFN1 IN1ILI VIICIU3 tJtLTliN (iit KtF

Fli´• 2-3’1
qini’l3-)L H(liT i\i511 K~iUL*TFO DLilSULt iStt rlii. KEr
Z-jj)
INd3 1-10 ELIUI 2 4

io IUJF ns iv. RL(IU 411( PqE SSUHL ii

LI PNEZ~-LU Tit 1 n

ii r 11)430-2 i IJBE 11111 IILEEU 41 Il i 1 4

13 rlO~JC-21 iJdt nssr, aicEo blH L

IL Xio(t)ii-~ TIIJi ns sv, jL ii,, nlR 1 ii

avojie-9~ TJdE liSSY I aLFCO 11 R L L
1 ilj~j. i i Nt I U 51L1 5(1\7 Ii SIIIIRC i RLF

dj0540 STIIIC i3UR(F INSTLI 4LIL*NdTE PtF

1) .5)530-3 Tildt 4511, SlililC L O

Bj01J~-9 TJ~L 451~1 STITIC I if

L6 LNIl1I-13 I
TEE (UStO *HEN (EHYILL LLTTEL L
N~´• 123 H~P ~iE"I IL(LMPLISniill
17 95113U-? TJBF 45111 STbilL L I

lli-n-T591-C I1GSL L 4
Ib
IV *520923-LU L
4N’ilL-L:I IUSHINU I n

2~ XBJ053-91L pjRI1 iTbilC 1

IITTI(HING VIRii)
~114691-iLZh SLKFL
Y53529-L j\SKtT L

21 iiS01’15-IOil T U1F 45 SYI SiiZT i C ISEE F I ii 2-35 1 i REF

b~hOl-iU Tti L 4

ZJ d 50105-3 3 i TU;IE 45 SYI S iilTIC L ii

PNeC6C4 PLJG i
i) dj~i65-e51 TUit biiYI Si4TIC L
*kb3L-lO VNICN I 4

IITT*CHING "bRTSI
n~4Zi-4U IUi L
4lYF60U716 W4SHtK i

21 h5n1L5-H91 TUIE 45 SI, STPT IC i

i d

.’U 4NBL5-in VNLON

29 TUBF 4SSYI SIPTIC 1 4

30 1Y833-ID ELIUW i P

IbTTICHI~G P4RTSI
hN921-iD NUT i
dN9bOD716 **SHEK
---L---

II HU1E 41iY´• ST*IIC L d

8~0165-L17 HUSI 455YI IIPTIC 2

COU~ :IFECTIYE ON SCKI~L NU4HtR~

690* L OPO~ L1100 TH~U 11~51
o401 6 6905 11100 THIU il~LI
C brR ilrlh THPU ilSil
0 b904 L1100 THRU IILLO
bPUb L1269 TnkU 11319
ir~b LLJjO TilRU 11151

2-188
 ILLVSTALLTED
ROCKWELL
SECTIDN n PARTS CATALOG COMMANDER
INSTRUMENTS 890A/B

i?-
I ’--12

I II 1: m
ss---~
53

f;
I:

GC1--~o

39

´•~--"I

6
31

x´•1 ir~

~isure 2-36. inrtrument Piping in~t.lloti.n i5heel 1 ~f 21

2-190
 ILLUSTRATED
ROCKWELL SECTION n
COMMANDER PARTS CATALOG INSTRUMENTS
680A/B

FIGUHE P R i UNITS USIBLF

B INOEX 0 E S C R I P T U N PER ON
NUNBEH N U n a E n I z r 5 6 7 aSSr COOE

L-36 33 PN839-90 TEE L d

(ITT*CHING P4RrSI
dN9Z4-~D NUT I
PN9~307Lh WISHER ´•´•´•´•´•´•i´•´•´•´•´•´•´•´•´•´•´•´• 1

3* nN833-120 ELBOW (SFE FIG´• 2-35) REF

35 d50112~-7 LINE 1\SSYI YICUUH 1 G
36 PN815-12D UNION ´•-´•´•´•´•´•´•´•´•´•´•´•r´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´• L G
31 8 LINE II SI1 YI\CUUN i G
38 1NB13-L20 ELBOW 1 G
IITTICHING PLRTSI
PNPLI-IZD NUT 1
nN9600L716 WISHER L

39 8903~8-91 TUBEI YPCUUM i G

IPTT*CHING PPRTS)
’10 YSZ7O)P-I-L1 SCREW
*SZI*L90G1Z CLI\NP 2
MSZ1919US4 CLPMP 3
lN960010 r WISHER
nSZIO*4N3 NUT 3

41 LH3-~ Y*LVEI PELIEE (264331 (SEt ~16´• 1-721 REF

42 810503-21 HOSE *SSY1 REGULITED PRESSURE ISEE FIG´• REF
2-351
4~ bNB)7-)D ELBOW I G
IPTTbiHLNG PPKTSI
bN921-40 NUT L
IN9600716 WISHER I
-----I*---

*I 850426-17 LINE ISSYI PRESSURE 1 G

InTT*CHING P4RTS)
Lg MS27039-0808 SCREW LO
MS2191´UG* LLdnP 10
lN96008 WISHER ID
*SZ1044N08 NUT 10

46 1N829-90 TEE 1 G
~I B 50*16-11 L i NE *SSI I PRF SSUKE i 1 G
(4TTICHING Pb~TS)
)8 MS35ZOL-Z1R SCREW ´•´•´•´•´•r´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•
1
IN3-LOI BOLT I
*SZ14190G~ CLbnP 2
NbS~JDD3-3Z SPICER i
*NPbODB WISHER ´•´•+´•´•´•´•´•´•´•´•´•.´•´•´•´•´•´•..´•´•1´•..´•.... Z
MSZL141N08 NUT 2

19 bNR31-LO ELBOW 1 G
IITTPCHING P4KTSI
*N921-~0 NUT 1
WISHER i
---t---

50 890318-93 r TUBE nSSY, BLEEO blR PRESSURE 1 G

5L 850~26-*9 LINE *SSY. BLEED liR i G
52 8~0426-3 LINE dSSII ILTERNI~E ST*TIC 1StE FIG´• REF
2-35)
53 MSZ0923-’tD ELBOW 1 G
IN’I~-LU BUSHING I G
5~ 88)053-501 PORT, ST*TII, PRESSURE. SINGLE SOURCE 1 G
IITTICHING P*RTSI
55 S52,693-5226 SCREW 6

COOE EFFtCTIYE ON S~HIIL NUMBERS

n a9on 8 6908 liioo rHnu ilssl
c 69UB ll*5L bNO SUBS

2-181
 ILLUBTRATED
BECTION n ROCKWELL
IN8TRUMENTS PARTB CP;TALOO COMMANDER
880A/B

P R T UNITS US48LE
FIGURE
C INDEX D E 5 C R 1 P T I D N PCR ON
U M 8 E R L 2 3 1 5 6 1 *SSI CODE
NUMBER N

56 880528-501 DOUBLER 1 G
2-36
GPIKET 1 G
57 850529-1
LINE PSSY´• ST*TIC L G
58 850426-31
59 MI35489-11 GROHMET LB G
UNION 1 G
bO PNB9Z-LO
I*TT*CHLNG PPRTSI
nN924-b0 NUT ....´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•1´•´•´•´•´•´•´•´•´•
1
*N9L0D916 WISHER .´•r.´•´•´•´•´•´•´•´•´•´•´•´•´•´•´• ´•´•´•´•´•´•´•´•´•´•´•1´•
L

LI 850426-29 LINE ISSY. ST*TIC 1 G

GROHHET G
bZ n535*89-11
850404-1 IP*CER I G
-63
6* 8501(15-1 SP*CER 6 6

INBLS-*O UNION I G

810426-21 LINE *SSY ST1T1C I G

I

I*TTLCHING PIRTS)
67 YSZ1039-1-08 SCREW
HS219L90G6 ELIHP
*N960D10 WISHER 12

HSZIO**N3 NUT 4
---t---

68 *N833-40 ELBOW ´•´•´•´•´•´•´•´•´•´•1´•´•´•´•´•´•´•´•´•´•´•´•´•r-1´•´•´•´•´•´•

I G
I*ITntnlNG P*RTSI
*N924-40 NUT L
bN96007L6 W*SHER I
-----t----

69 850’126-25 LINE ISBY, ST*TIC L 6

InTT*CHlNG P*RTII
70 MS27039-1-08 SCREW 1´•´•´•´•´•´•´•´•´•´•´•´•´•
2

*521919066 CLIMP 3

MSZ1044N3 NJT ´•.´•..´•........´•..´•.´•r..´•........... 2

PNB34-4D TEE L G
II ´•´•´•´•´•´•´•´•´•´•´•´•´•.´•´•´•´•´•´•1´•´•´•´•´•´•´•´•´•´•´•´•´•´•

I*TT*CHING PbRTSI
nNPs~-*O NUT r´•´•..´•´•
I

4\19~00716 Y1IHER r.´•..´•´•..´•...´•.....

L
---I---

72 850426-23 LINE *SSY, ST*TIC 2 G

LITT*CHING PIRTS)
13 1-65 CLI\HP 2

74 850132 FITTIN(i INSTL. STbTIC PRESSURE SI]URCE REF

(SEE FIG. 1-341

COOE EFFECTIVE DN StRI*L NUMBERS

G 6908 11*52 1ND SUBS

2-182
 ILLUSTRATED BECTION 1l
ROCKWELL
COMMANDER PARTS CATALOG WING

Bg(lA/B

31 1~

V
M ~Ci I/ 3s

,o

,I

V
30 ii

~--I-
P
It
’5

‘i;

rie´•´•. 2-31. Wing PIIItins

2-193
 ROCKWELL
SECTION n
ILLUSTRATED
COMMANDER
WING PARTS CATALOG BBOA/B

FIGURE P A R T UNITS USABLE

G INDEX O E Z C R I P T I O N PER ON
NUMBER N U H E E R I 2 3 5 6 1 ASSY CODE

2-31- 160009 WING 1SSI´•´•´•.´•´•´•´•.´•´•´•´•´•´• ´•´•´•´•´•1´•´•´•´•´•´•´•1´•. L

L70119 PANEL dSSYI CENTER WING L
1 LIOLllt--1 SnlN1 LEADING LDGE´• LH INED
1101)1-2 SKIN´• LEADING EDGE, RH 1NBD L
1 170145-501 SI(LN´• LEADING EDGEI LH CENTER L
170145-509 SKIN, LEADING EDGE, RH CENTER I
3 170140-1 i IKIN´• UPPER I
4 110111-1 SKIN, UPPERI LH I
ITD141-50L ´•´•SXIN. UPPER, RH 1
5 L101*3-I SKINI UPPER, Ln ´•................1... I
170113-2 SXLNI UPPER, RH ´•´•1.´•´•´•´•.´•........... 1
L10150-501 SKIN, LONER ´•........´•1...´•´•.´•....... 1
7 110118-1 SKIN. LOWERI LH AFT 1 AB
L1~148-501 SXIN´• LOWER, Rn AFT L *8
110148-503 SKINI LUWERI Ln IFT ......´•.´•..1..... I C
170148-501 SKIN1 LOWER´• Rn bFT I C
8 170298-1 SKIN, LOWER, Ln L RH FWO I
9 170149-501 SKINI LOWERI LH g RH EWO 1
10 170146-1 SKIN, LOWER, LH ´•´•´•´•.........1...´•... 1 18
LIOL~L-501 SKIN´• LOWER, Rn I AB
110146-503 SKIN´• LOWER, LH 1 C
L10116-505 SKIN, LOWERI RH ´•´•´•´•´•´•´•´•+1+´•´•´•´•´•´•´•´•´•´• L C
II 170117-1 TKIN´• LDYERI Ln 1
170147-2 SKIN, LOWER, RH 1´•´•´•´•´•´•´•´•´•´•´•´•+´•´•´•´•´•´•´• I
L10017-50L PAD INSTL, JACK ´•´•´•´•´•´•´•´•´•´•´•´•´•r´•´•´•´•´• REE
12 170011-7 JLCK PAD ´•r´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´• 2
(ATTICHING PLRTS)
HS21039-L-ll SCREW
AN960C10 ´•´•´•U*SHBR´•´•´•´•´•´•´•´•´• 3
----t---

L70D25 8ULKHEAD INSTL´• CENTER WING (YS REF

69´•00)
13 170025-39 PLATE, UPPER L
14 170015-25 PLATE, LOWER 1
ITOOZ6 EULKnE*O INSTL. CENTER WING (YS REF
L13´•001
15 110021-31 ´•´•PLATE´• UPPER L
Lb 170026-33 PLATE, LOWER ´•´•...............r.... 1
11 110197-1 STRAPI UPPERI Ln OUTED .....r........

170197-2 STR*P´• UPPER, Rn OUTED ´•......´•1´•´•... L

18 L10198-1 STRIP, UPPERI LH 1NBO 1
110196-2 STR*P´• UPPERI RH INEO ´•´•´•.r-´•´•´•´•´•´•´•´•´• I
1P 17D199-50L STRAP. LOWERI LH OUTED I
L10199-IiOZ STRIPI LOWERI Rn OUTED L
20 170198-501 STRAP. LDWER´• LH INRD 1
170198-502 STRAP, LOHER´• RH 1NBD 1
170015 TRAILING EDGE INSTL. CENTER WING REF
21 170016-239 SKINI TRAILING EDGEI Ln UPPER 1
170016-240 SKIN, TRAILING EDGE, RH UPPER L
22 L700IL-I93 SKINI TRAILING EOCE´• LH UPPER I
1700L6-194 SKIN´• TRAILING EDGE´• Rn UPPER I
23 110015-69 SKIN. TRAILING LH LOWER EOGE´• 1
110011-11 SI(IN1 TRAILING RH LOWER EOGE´•
2* 170075-85 PANEL, ACCESS, LH 1NBD L
110015-89 PINELI ACCESS, RH INBD
IITTACHING PARTSI
MS2~69*-S*B SCREW AR
HSZ*69*-150 r SCREW IR

CODE EFFECTIVE ON SERIAL NUMBERS

A 6904 11100 THRU 11349
E 6908 11350 THRU L1415
C 6908 11416 AND SUBS

a-194
 ILLVSTRATED SECTION n
IIOCKWELL
COMMANDER PARTS CATPILOO wwo

6801\/8

FIGURE P ii R T UNITS USIRLE

INDEX O E 5 t R 1 P T I O N PFR ON

NUN6~R N U n B E a I 2 3 5 6 7 nssv CODE

2-37 25 L70075-13 SKIN´• IRelLING EOGF, LH LOWER 1

170071-75 SKIN~ TRIILING EUGEI RH LOWER I

26 L70015-87 PINEL. *CCtZZ, L1 OUTED

L7007)-91 PPNEL´• PCCEZS´• R~ OUTED I
IITTICHING PIRTZI
1 SCREW bR
nSZ4~YL-S)O SCREW IR
----I---

27 1101)15-71 SKIN PISSYI CLOS EOUT 1 iH I

170075-79 SKIN nSSY1 CLOSEOUTI R~ 1
28 170015-8L SKIN PSIYI CLDSEOUII LH I
L~U015-B3 SKIN PSSYI CLOStOUTI RH 1
29 17ol73-L SKINI LH UPPER I
170 Il 3-2 SKIN, RH UPPER
30 170LT2-l SKINI LH LOWER 1
LT017Z-Z SKIN, Rn LOWER I

200020 PINEL 452~. OUTER WING I

31 ZO00PO-LSI SKIN, LEPOING EOGEI LH
20ODL0-152 SKIN, LE*OING EOGE. RH I
32 200020-75 SKIN, LH UPPER 1
200020-16 SKINI RH UPPER L
33 LOOOZO-LLI IKLNI LH IOWtR´• FWU 1
200020-112 ´•´•EKIN, RH LOWER 1
FWD L
34 ZDOOZo-17 TKINI LUWER´• *FT
Ln
200020-78 SKINI RH LOWEII IFT i
200008 TRI\ILING EDGE INSILI OUTER WING "EF

35 200008-3 SKINI TR*ILING EJGEI Ln 1

200~38-4 SKIN1 TR*ILING EI)GCI RH 1
96 200008-5 SKIN, TRIILING EJGCI LH.........´•.

200008-6 illNI TRIILING EJGEi Rh L

37 200008-P3 ODDR1 INSPECTION 2

(PTTICHING PbRTII
MS2~b91-550 SCREW 3

230006 TIP INITL~ WING, LH G RH REF

38 230006-9 TIP nSSY´• LH

2l0006-L0 TIP nSSYI RH 1

(I\TTIICHING PIRTS)
MSZlbP~-iiCl SCREW ´•´•1´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•
18
NISL1OPOO1OL WISHtR I
---t---

39 130006-5 LENS, LH I
23UDOL-L LENSI RH L
I~TTLCHING PbRTII
UZLlb43-C21 SCREW B

NLS11~9006L *~SHER 8
----I---

ZIOD09 FLLP diSY *NO LNSTL´• INRU RLF

2~0005-93 FL4P IS SY I I NBD, iH I
2~0009-9" FL*P bSSII INBDI RH i
40 IKLN´• LH UPPER
210309-84 SKIN. RH UPPER I
11 210009-05 SKINt LH LOWER r´•´•´•´•´•´•´•´•´•´•´•´•´•´•+´•´•´• I
240009-86 SK INI Rn LOWE R L
12 210009-7 SKLN´• LE~DING EDGEt LH 1
2*000’1-8 t SKINI Ltl\DING FD‘EI RH....´•´•´•´•´•´•++ 1
210005 FL*P INSTL. OUTBO*RD REF
2~0005-17 FL~P ASSY´• OUTED, LH 1
210001-78 FLnP ~SSY´• OUTED, 9H L

43 Z~0005-7L IKIN1 LH UPPER G RH LOWER i

44 29000)-72 SKIN, LH LOWER L R~ UPPER I
’t5 2~0005-bl SKIN, LEIOING EDGEI iH 1

210005-62 SKIN, LE~DING EDGEI RH I

2-185
 ILLV8TRAT~eb
8ECTION n ROCKWELL
WING PARTS CATALOG COMMANDER
BOOAIB

FIGURE P n R 1 UNITS US*BLE

L INDEX D E I C R I P 1 I O N PER ON
NUOBER N U H B e R 1 2 5 6 1 6ssv CODE

2-31 250000 *ILERON INSTL, WING +´•´•+.´•1´•´•´•´•´•´•´•´•´•´•´•´• RFF

*6 250000-285 SKINI LH UPPER .´•.´•´•´•´•r.´•r´•.......... I
250000-246 SKIN, RH UPPER .´•´•1´•´•´•.r´•.´•´•´•´•´•...... I
11 150000-281 SKIN, Ln LOWER ´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•1´• 1
250000-251 r i SKINI RH LOWER I
48 250000-2’11 SKINI LE*OING EOGEI LH .´•.´•´•.r´•´•..... L
250000-225 i SKIN, LE*DING EDGEI Rn L
2500o0-3LL TRIH 1*8 LSSY´• *ILERON I
19 250000-323 SKIN, UPPER I
-10 290000-325 IKINt LOWER L

a-1BB
 ILLUSTRATED
ROCKWELL
COMMANDEII PARTS CATALOG SECTION n

680A/B WING

1,

/Y~ /C
22

21 YC

\o~ls

a"

Figure 2-98. Wing Al~elr Covert

2´•´•181
 ILLVSTRATED
ROCKWELL
IECTION II PP,RTG CP;TALOO COMMANDER
WING BBOA/B

FIGURE P a n i UNITS USIBLE

C IN3EX D E S C R I P i L D N PER DN
hUnBtR N U H B E H 12 3 5 6 1 *SSY CDDF

2-38 160o09 WING ASSY1 LOHPLETE 1

170L39 PANEL PSIYI CENTER WING L
L 170165-1 DUOK. PCCESII INBD FUEL T*NKI LH FWD 1
170165-2 300R1 ACCEESI INBD FUEL rbNKI RH FWD L
170Lb2-1 OUI]RI ACCESS, INBD FUEL TnNi(, LH nFT L
JOOR´• ~CCESS´• LNBD FUEL T*NK´• Kn IFT i
3 10163-1 DUUR´• aCtESSI LH L
L70163-2 UOO~´• bCtEES1 Rn I
170256-1 30081 PCCEIS´• INBD FUEL rANK5. LH FWO 1
173259-1 0008, aCCESSI INBO FUEL TANKS. RH FVD I
5 LIJZZ4-I DOOR1 LCCESSI IN83 FUEL TbNKSI LH aFT I a
170254-50L DOUH. *CCtSSI iNBD FUEL r*NnS´• LH AFT L B
LI~Z54-2 OUOR´• ACCESS, INBD FUEL TANKS, RH aFT 1
110254-502 OUURI ACCESS, 1NBO FUEL iANi(I, RH AFT I 8
113253-1 OOdH1 ~LCEST´• Ln i
170253-2 3008, ACCESSt RH i
(*TTICnlNG ’bRTI)
MSZCb91-1~8 SCREW AR
nS246YI-S51 SCREW AR
---ii---

I LIOLlb-I OLIURl ACCESS

IATTACHING PIRTSI
ANI-ii\ 8DLT LO
aN3-5(\ UOLT ´•´•´•rl´•´•´•´•´•´•´•´•´•´•+´•´•´•.´•´•´•´•´•´•´•.´•´•.. is
4N96DDLO WASHER ZR
930 116-537 CHINNEL I GANG I tONii\ INS 5 NUT SI 2
9U0LiI-509 CnPNNILI GANG ICONiAIVS 9 NUTS) s
---1---

8 170177-1 DUUR. ACCESS Z

IATTACHING PARTSI
i\Ns-Ll\ r 80LT 5
AN)-5e BOLT ´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•+´•´•´•r´•´•´•´•´•´•´•´•´•´•´• LI
AN960DLo WASHER 16
900116-503 CIII\NNELI GANG I~ONT4INS NUISI i
900116-505 i CHANNEL, GANG ICUNiAINS I NUTSI Z
---li----

L7U0)5 PCCFSS DUDRS. DUTSBO FUEL CELLS REF

9 171015-43 DUOR, ACCESS Z
IATTACHING PIRTSI
MS2Id9l-SIIi SCREW ´•´•´•´•´•´•´•1´•´•+´•1................ 92
MSZllb94-Ss~ SCREW L2
900116-511 CHANNEL, GANG ICONTAINS 8 NUTSI I

10 111)03)-99 UOOR~ ACCESSI LH I

1100P5-11 UUURI ACCESS, RH r................. I
IbTTaCHING PARTSI
M5Z’tb91-I18 SCREW IP
n521(9’t-153 SCREW r´•´•´•´•.´•´•´•´•´•´•´•´•´•´•´•´•´• lb
400L16-101 GANG CHANNEL ICONTAINI 8 NUTS) Z
---I---

LI l7COYb-50L CUYER´• ACCESS, LH ´•.r..´•´•.´•.........´• L

170096-502 CUYER I 4CCE SS, RH 1........... 1
12 llCOP7-501 COVERI ICCEIS´• Ln 1
L10~9T-502 COVCH, *CttSS´• RH I
1) 17C099-501 tOVER´• ACCESSI LH I
IlOC19-502 COVER, aCCESSI RH i
1lC098-501 COYEKI ~CCEIS´• Ln I
170098-502 CDYFRI 4CCESTI RH i
I4TTPCHING PdRTSI
MI24b94-S48 SCREW AR

CDDE EFFECTIVE DN SERIAL NU*BERS

A 6901 L1100 THRU
B h4DI C 6908 11211 aNO SUBS

2-188
 ILLUSTRATED
ROCKWELL
COMMANDER PARTS CATALOG SECTION n
BOOA/B WING

IIliURE P I( R T UNITS UlnBLE

8 LNUtY D F 5 C I i P T O N PER ON
NUH8tH N U M 8 E R i Z 3 ’t 5 6 7 1SSI CODE

2-38 i) L70075-R~ ZI\NELI *CCESS (IEE FIG´• 2-871 RtF

-10 170075-81 P9NLLI I1CCESS (ZfE FIG. 2-971 RE~

17 200008-2) UOORI INSPtCTION ISEE FL6. 2-371 REF

LB 110038-511 DOOR, ICCEIS I
-19 170169-1 U001(´• /ICCESS C
L101~9-51L DDOHI 4CCESS i D
I*TT*CHING ’4RTSI
4N3-*P BOLT 18 C
nN9600LO *PIHER Is C
2ZNRGI-OZ-7-19-9 CH*NNtLI G4NG IC~NTPINS 9 NUTSI 2 C
llP9621
~N*-54 BDLi 10 D
dNBb0Olih r W(\5HER LO O
MIZ1059L1 NUTPLPTL LO 0

20 110166-1 JOUR t ICCESS 2

LL 10002i-1 DOOR 1 I\LCESS 2
IITTPtHING P4RTSI
YSZ*~9*-S18 SCREW ´•´•r´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´• 48

200020 PPNEL 4SSY1 OUTER WING I

22 200028-509 COVER, ICCESS 3
23 200028-513 COYER´• nCCESS
Z~ 200028-515 CUVER´• LCCESS 1
IPTTICHING PPRTZI
SCREW bR

25 ZO0010-63 UOOR 1 *CCE SS I LH i

200020-b~ UOOR I PLCE SSI RH L
IITTdLHING P4RTSI
nPZ169*-SCB SCREW ’12
LUU020-6l CH4NNEL, GdNG 1
POOOLO-1~9 CH4NHIL 1 G~NG I

CODE EFFECTIYL ON StRI*L NUnBtRS

C b90* 6 b90B L1100 THRU 11~15
D bPOB II~Lb *ND SOBS

a-189
 ILLUTRATED
ROCKWELL
BECTION n PARTS~ CA7ALOO COMMANDER
WING BBOA/B

/12

i D
24. 00~ 8\
se. 00

as. F
21
r~
?8. 48 C
los.
a
II

142. 00

lee. oo~

-r,:
181. 33

216. 00\
.lo
234. BE
\52
253. 31‘´•

212. 00

Wing Statlans

’2"

A B

21 _
1´• 1 31
31 26
26 36

12

6i.ur´• 1-39. Win. Slrurturs IBhe.f 1.f 6)

2-200
 ILLVSTRATED
ROCKWELL
COMMANDER PART8 CATALOG SECTION II
BLI(IA/B WING

FICUKE P d 8 r UNITS US*BLE

C INDEX D E S C I P r I D N PEU DN

HUM~ER N U nis E R z r 5 a 7 asiv coot

2-~9 lb000Fi WING PSSI´• CONpLETE I

ilal,si´•1 PINEL ~5SY1 CENTER WING 1

Irollscl 1
STRUCTURE PISYI CENTER WING I

170217/ IUL KHEI\O INSTL, CENT t* W LNB RE~

I
I I lot L’i 1 BUL KHtIDI LH
L7OZ17iZ 6ULLHEbDI RH i
L70D37 DULLHEb~ INSTLI CENTtH WING REF

2 170091-) BEeiY, LH INBD 1

173037-6 BE*H, Rn INBD I
1700~7i3 BE*HI in Durgo
ITno utlnl RH OUTED 1
17 BUL KHEIIO INSILI CENTER WING 1 *5 REP
2*.011
C 17 *tB~ iH 1
Il WEBI Rn 1
5 LIOLO LH I

LIOIO WEUI Rn 1
LIOLZO: BULKHEnD I NSTL I CENT EH k ING (WS REP
39´•001
L70LZLr50L WEB, in I
1l0i~i-502 WtB, KH L
7 17012211 WEB, LH 1 1

LIUIZZLSOL WEB1 Ln 1 8

170L2ZTZ HEB1 RH 1 I)
L701ZZi502 WEbl Rn 1 B

LNSTL1 CENTER WING IWS REF

LIOOZ5/
a 170rozii Wto nssv, LH I
1i0232i2 ....WCB nSSY1 Rn I
s 110025157 RIBI RH
170025158 KLBI Rn 1
170031- BULKH~PU INSTL, CENTER WING IWS REF
85´•011
10 1100~1+35 ...´•RIB, LH 1

L700~1136 RIB, r HH I
1700)2 iULKHEIJ INITLI CENTER WING IUS REF
Y8´•36)
1100 Rie. LH L

IliTi
L1
1700
L700 RIE1 RH I d

17oasztsz RIB, Rn B

17DO~bi BULKHEID INITL, CENTER WING IWS REP

L13´•001
It 170026135 RIBI LH 1
170026-36 RID´• RH
13 170026rb5 KIBI LH
Iioozaibs ....Rlsl RH 1
110028: RIB INSTLI CENTER WING IWS 1iZ´•0ol REF

I ili i 21
LI 1 25 WEB, Ln 1
17001 26 WEB, RH 1
15 WEE, LH ´•´•´•´•´•´•´•´•´•´•´•´•.´•´•´•´•´•´•t´•´•´•´•´•
L
L700 28 r ~EB´• RH L
i RIB INSTtl CENTER WING (WS l~o´•DOI REF
Lb L L RIB, LH I
L70029t4Z RIB, Hn 1
17 L10029-39 RiB, Ln 1´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´• I
L70029i~0 RIBI HH I

CODE EFFECTIVC DN SEHL*L NUnBERS

690b C. 6908 L1100 THRU ll~1j
B 6908 L141b 1ND SUBS

a-201
 ILLVBTRATED
ROCKWELL
SECTION n PARTG CATALOG COMMANDER
WING BI)OA/B

FIGURE P 4 H r UNITS US*PLE

L INU~X D E I C R L P T L O N PFR ON
NUMBER N U M B t R L 2 I 5 6 7 PSSY CODE

2-39 110213 RULKHEPO INSTL, CENTER WING IWS REP

19´•~bl
LB llOZL3-5 BULIHE*D, LH L
170213-6 BULXHE4D. RH 1
LTOZL4 UULKHEIU INSTL, CENTER hlNG IWS Rtr
L03´•l~l
19 17021)-3 r BULKHE 40, LH I
110214-* BUL*HE*DI RH ´•´•´•.´•...r´•´•´•´•´•´•´•´•´•´•´• 1
LOU031 FIREW*LL INITL RFF
LD 660001-3 FIREWPLL 1SIYI LH .r´•´•´•´•´•´•´•´•´•´•´•´•´• 1
b6000L-5 FIREW4LL *SIY1 Kn 1
21 620087 MOUNT IkSTL. ENGINE ISEE FIG´• Z- 31 REF
L70015 TR41L1NG EDGE 1NSTL1 CENTER *ING REF
22 L7D081-3 bNtLEl Ln
HH ´•´•´•´•´•´•´•´•r´•´•´•´•´•´•´•´•´•´•´•´•´•+´•- L
23 L7DD15-L01 IIB 451I, LH L
170015-102 Ila assr. nn I
2~ 1r00l6-141 CHPNNEL, UPPER´• rNBO PULLEY BKKT I
i\lSY
L7DDib-113 CHINNEL, LH LOWERI INUD PULLEY BRKT 1
LSSY
CH4NNELI RH LOWER, INbC PULLEY BRKT L
1SSY
26 l7DDI6-01 r *NGLE C
L7 170DLb-151 SUPPORTI LH INBD PULLEY aRKT nSSY 1
170016-149 SUPPURTI RH, INBD PULLEY BRKT ISSY
28 170075-101 HIE *SSI´• Ln INED PULLEY BRLT PSSY, I
INBD IIDE
170075-L05 RIB *SSYI RH INBn PIILLLY IIRKI eSS~. I
LNBD SIDE
29 170075-bl RIB *ISY1 LH INED PULLEY BHKT dSSY, L
OUTED SIDE
L70075-bl RIB nSSYI RH iNBO PULLEY BRKT nssr, 1
OUTED SIDE
30 170016-171 PNGLEI Ln INBD PULLEY BRLT PISI´• L
UPPER
170016-161 *NGLEI RH INBD PULLEY BKKT *SSY1
UPPER
31 170010-119 4NGLE1 LH 1NBO PULLEY BRKT *BSY,.´• L
LOWER
LT001b-L65 PNGLE, RH INBD PULLEY BRKT PSSYI L
LOWER
32 110016-73 STIFFENER, LH INBO PULLEY BRKT I C
1SSY´• INED SIDE
170016-121 STIFFENER, LH INBD PULLEY BRKT 1 O
nSSYI LNED SIDE
LIOOL6-117 STIFFENERI RH INBO PULLEY 8RKT L C
ITTY´• INED SIDE
L10016-117 STIFFENER, HH INEO PULLEY BRKT L D
4SIY1 INEO SIDE
33 1700L6-71 IT(FFENERI LH INBD PULLEY BIKT L
*SS11 OUTED SIDE
LIOOLe-175 STIFFENERI Kn INBD PULLEY BRKT I
*ISY, OUTBO SIDE
14 L700L6-IZ9 CH*NNEL. UPPER, OUTED .´•.´•.1´•...... 2
PULLEY
ERKT nBSY
31 11001~-135 CH~NNEL. LOWER LH~ OUTED PULLEY
BRlf LSSY
L70D1b-131 CH*NNELI LOWER Rn, OUTED PULLEY L
BRKT *SIY

CODE EFFECTIVE ON StRI*L NUMBERS

C 6906 11100 THRU 11208
D 6901 G 6908 11209 *ND SUES

2-20a
 ILLUSTRATED
ROCKWELL
COMMANDER PARTS CATALOG SECTION n
6801\/8 WING

~IGURE P 1 H T UNITS USIBLE

6 INUEY D E 5 C R 1 P r I o N PER DN
LUMBIH N U H B E R I 2 3 5 6 7 ISSY IOUE

1-39 36 SUPPORT, Ln´• OUTED PULLEY BRKT PISI I

170016i359 SUPPORTI RHI OUTRL) PULLEY t)Rl(T nSIY L
37 RiB1 LH OUTED PULLEY dlKT bSIY1 1
INBU SIDE
IlccsolsoI Rlbl RH OUTED PULLEY ~KKT 1SSII I
IN8J SiDt
38 l70C8911 RIBI LH OUTBU PULLEY BRKT ISSY1 L
OUTED SIDE
ilcaaail RIB. R~ OUTED PULLEY BRKT 1SSY1 i
OUTED SIDE
19 17301ai189 *NilE. LH OUTED PULLEY BRKT aSSY1 L
UPPER
I~oolbiles 4NGLt, RH OUTED PULLEY BKKT *SSY1 I
UPPER
ro L7001bi141 *NOLE´• LH OUTED PULLEY BRKT 45SY1
LOWER
auiLt, nH OUTED PULLEY ~RKT nSSY1 L
LOWER
41 17O0161355 ST i FF tNtR, LH OUTED PULLEY BRKT L
4551, INBO SIDE
170~161356 STIFFENERI RH OUTED PULLEY BKIT L
4iSY1 INBO SIDE
12 17001(1153 STI~FENERI LH L)UTBD PULLEY BRLT L
LISI1 OUTED SIDE
110016135~ STIFFENERI LH OUTED PULLEY BR~T L
nSSY1 OUTED SIDE
13 260026 NICELLE PSSI nND INSTL´• UPPER IltE.. REF
Fic´• Z-~LI
200020 P*NEL ISSY1 OUTER WING L
200002 RIE INSIL, UUTER WING IWS L7B.ba~ REF
2oo002i9z KIEI LH L
20u0o2i,3 R1B, RH L
~5 20003213L ~IB, LH L
zooaozi~r Kla, nH
20uoos H IB INS TL I OUTER WING IHS 197 321 REF
46 20o00silo Hia. LH I
200009111 ~Is. Rn ´•..´•...´•´•´•´•.r.´•´•´•´•´•´•´•´•´•´•´•´•´•
L
)7 ro000,i) Ria, LH
RIBI RH I
2000041 .R1B INITLI OUTER WING IWS 21b´•0o~ REF
~s zoaoo*iie nia, LH
19 RIU, RH L
rs za00a4iia nie, Ln I
Il nis, nH
zoooos RIU INSTLI OUTER WING 1WS 234´•6~1 REF
so zoooasis His, CH I
.Hlnl RH 1
ii nia. LH L
RIB1 RH L
200006 RIB INSIL´• OUTER WING IWI 253´•321 RLF
52 200006ib RIBI LH L
KiB1 Rn r´•´•´•´•´•.´•´•´•´•´•´•´•´•´•´•´•´•´•´•-´•´•´•´•- 1
s, zoooosir nia. LH L
RiBt RH I
200001 Rlii INITL, OUTER WING IWS ZIZ´•OOI REF
5, 20o0o7ia RlE. LH L
zo0007i7 R18´• RH 1
200008 TRIILLNG EDGE INSTLI OUTER WIND REF
ZS 20000s17 FORIIER IWS L78´•bbl ´•´•1´•´•´•´•´•´•´•´•´•´•´•´•´• L
56 20000s19 FOK~ER IUI 197.321 1
57 200008~11 FORHtR 1WS 234´•6~1 1
is ZoDOOE-il) FORMER IWS 253.321

a~205
 ILLUSTRATED ROCKWELL
SECTION n PARTS CATALOG COMMANDER
WING BSOA/B

CZI

’9 ii

66

160

Ir 13

""’"6

Pilur´• 2-39. Wins St~urlure ~Shaet 2 6)

2-204
 ILLUSTRATED
ROCKWELL
COMMANDER PARTS CATALOG SECTION n
BOOA/B WING

FIGURE P R T UNITS USIBLE

6 IN~EX O E 5 C R i P T I O N PtR ON
LUHBEB N U M E E R 1 2 3 4 5 6 I nSSY COOE

2-39 240009 FLIP bSSY *ND INSTLI INBO REF

59 2IJ009-93 FLIP bSSY, iH iNED I
2$0009-9C FLIP ISSYI RH INBO L
IPTTICHING PPRTS)
bO 4N4-LLn BOLT IOUTBO) L
MS27039-C-2h SCREW LINBOI
PNPIOCII~L WISHER IINBOI
NPS~)HT’t-)O SPICER I LNEOI I
1NPbo04L6 WISHER
MS21044hi4 NUT 2

61 210001-520 PLbrE nSSYI LH INBO FLIP i

bL 2’t0O0I-52I PL*TI IISSY´• RH INBO FLIP i
63 240001-522 PLPTt PSSYI LH INRD FLIP L
64 2*000L-5Z3 PLITE *SIY1 RH INBn FLIP I
I~TTICHING PbRISI
bS US24L9*-551 SCREW
---I---

66 100013-4-0´•LB BUSHING ´•1´•´•´•´•...´•.......´• I

61 PLPTE ISSYI LH 8 RH INEU FLIPS I
68 210001-514 PL*TC *SSI, LH C RH IN65 FLIPS
IITTICHING PIRTS)
69 MSZ’1~4*-S5C -´•´•ECREW´•´•´•´•´•´•´•´•´•.´• 4
---L---

10 OUOOL3-~-0.ls BUSHING I
II REE3N i dE~RING bND ENO *SIY 12I3351 L
ILTTbCHlNG PIRTZI
72 1N3-13* BOLT L
1N960DL0 WISHER I
MSZ104~N3 NUT L

73 240009-11 RIB ISSY I

7* 210009-12 RIB *SSY
75 210001 BUSHING 1
Id 240009-81 R1E´• LH OUTED ´•´•´•´•´•´•´•..r´•´•´•´•r´•´•´•´•´•´• I
2)0009-82 RL8I RH OUTED i
rT 240009-97 Rlai Ln INBD I
240909-98 r Rli)l RH INED 1
Is 240004-79 STR LP I TRI\I LING EDGE I
-19 210009-89 SPPR I
BO 240009-99 IP*RI LH i
240009-100 IPPRI RH I
81 2*0001-506 HINGE ns rv. LH 1
240001-507 HINGE PSSY. RH 1
82 210001-504 ´•´•H1NGE *SSY1 LH L
240001-505 HINGE *SSY1 RH I
IPTTPCHING P4RTSI
83 HIL*b94-551 SCREW 3
4N960DLO WISHER 3
MSZ1044N3 NUT ´•´•´•.r.´•´•..´•...´•.....´•............ 1
---I---

-84 nSZLIZOLKP’tl IIEPRING L

240005 FLIP INSTLI OUTBOIRD REF
85 240005-71 FLIP *SSI1 LH DUTBD L
2)0035-78 FLIP IS5Y, RH OUTED I
(ITTICHING PbR7S)
86 PNI-111 BOLT
INP60D4LI WISHER 2
nS2L044N* NUT ´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•1´•´• 2

2-a05
 ILLUBTRATED
ROCKWELL
SECTION n PART~ CATALOG COMMANDER
W~NO BOOA/B

111
c

~53

i,,

II? B

los

lot

los

’C
Y

I at

~isur´• ?-)9. Wing St~u.ture Ishe´•1 3 16)

2-108
 ILLUSTR~TED
ROCKWELL
COMMANDER P~RTS GAT~LOO SECTION n

BOOA/B WING

P d R i UNITS USIBLC
FIGURE
6 0 E I C R L P T I O N PFR ON
LN~tX
N U M B E R I 2 J 5 6 1 ~ISY CODE
NUMBER

2-39 87 240001-5LO t HINGE ISSY. Ln OUTED CLPP L

245001-511 HINGE LISYI RH DUTBO FLIP I

BE L4U001-ILZ HINGL i\lSI1 LH OUTED FLI\P I

t HINGE LSSI1 RH OJTBU FLIP 1

IITTPCHING PIRTS)
89 MSZ169~-55L SCR EY 3

~O 900013-4-0-18 BUSHlNG L

91 2*0001-508 HINGE nSSY1 LH C RH OUTBU FLIPS L

92 210001-509 HINGE ~SSY´• LH C PH OUTUO FLIPS I

I*TIPCHING PbRTSI
93 MS1~69)-BS1 ICR EW 4
----li----

99 l000L3-4-018 BUSHING 1

95 RE83N i aEnRIN6 IND PSSY 1213351

END L
IITTPCHING P4RTSI
96 *N3-l)n aOL T 1

PN960010 r
WISHER ´•´•´•´•´•´•-´•´•r´•´•´•.+´•´•´•´•´•´•+´•´•´•´•´•´•
I

HSZ104~N3 NUT L

97 2*0005-)5 RiB *SSY 1

98 240005-36 RIB bSIY I

99 L)OnOL BUSHIN6 1

Z10005-L5 RLB, LH I
-100
Rla´• HH ´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•.´•1´•´•.´•´•´•´•´•´•
i

-101 2*0015-1 Rldt LH 1

2)0005-8 RIB1 an i

-LOL 240005-59 R1BI LH L

240005-60 RIB1 RH L

-103 210005-83 ZTRIPI TRIILING EDGE L

-10* 240005-53 SPbR ´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•r--´•-´•´•
I

240005-45 RIB1 LH ´•´•-´•´•´•´•´•´•r´•´•´•´•´•´•´•´•´• 1

210005-46 ...1IG1KH 1

-IOb 240005-51 SP4KI LH 1

210005-58 SPIR. R3 L

-107 L40091-90P HINGE *ZSY1 LH

210001-503 nlNGt *SSY´• RH L
IdTTbCHING P4R~SI

-108 SCREW 3

LNP6OD10 WISHER 3

MS21o*4N3 NUT ´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•r´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•

3

-LO1 NSZOZO1KP~b BE~HING 1

-110 2*0001-500 ..HINGE ~ZSYt LH i

2*D0OL-50l HINGE PSSI1 RH I
IPTTPCHING PIRTS)
N521694-554 SCREW I
-lil
i
*N9~0D10 WISHER
MI2I0*CN3 NUT I

-llZ nS20201KPlb ´•´•´•HtbRINt´•´•´•´•´•´•´•´•´• 1

250000 IILERON INSTL1 WING REF

NO NUMBER *1LERON PSIY´• LH E

-L13
250000-258 I\ILERON nSSY´• RH 1 E

250000-313 PILERON PISY. LH IREPL*CES 1 F

250000-3651
250000-361 IILERON 1SSI, RH
I4TTPCHING PPRTSI
BOLT 3
-114
bN9~00116L WISHER 3

1SZ108)N4 NUT

COOE EFFECTIVE ON SERLbL NUMBERS

E 6901 LL100 THRU IIIOZ
r b90n 6 6908 IIZo) dND SUBS

2´•´•201
 ILLV[ITRATBD
ROCKWELL
SECTION n PAR~ CATALOG COMMANDER
WING 680A/B

ill

ill

~n ~u, 113 ’15

1
ill
ill

I,,

’I’
131
111

135
i. la

~,;"a
132

la 1~1

lie

,j, 123

141

L
a

120
II(
"B lil

(11(1

~isur´• 1-39. Winl itrurtura (Shee1 of 6)

2-208
 ILLVBTRATED
ROCKWELL
COMMANDER MRTS CAT~LDO SECTION n
880A/B WING

FIGURE P 1 fi T UNITI US*BLE

INDEX D E I C R 1 P T 1 O N PER ON
NUMBER N U M B t R i Z 3 I 5 6 7 1SSY CUUE

2-39 -III 2500~0-172 HINGE *SSY´• LH L RH I1LIRON L

-Llb 250o30-L68 HINGE PSIYI LH 8 RH *ILERUN 1
IbTTPCHING P4RTSI
-117 dN3-1* BOLT I

6N960010 HPSHER
NSL1041N) NUT 2

-LIO 9Uo013-*-0´•17 RUSHING 2

-119 ZSDOOU-170 HlNGt nND BUSHING 4SSY, in........ I G
250000-171 r(lNGE *ND IIUSHING IS SY RH 1
250000-351 HINGE 4P SYI LH i H
210000-359 HINGL I~SSYI in i
IITT*CHING P4RTSI
-IZO nN3-54 BOLT 4
dN960010 *bSHtR I

P00013-4-0´•17 BUSHING ´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•..r´•´•´•´•´•

2
-ILL Y001113-3-0´•17 ..´•´•BUSHINS 2
Ni\S15-3-008 L1UIHING I H
-123 ZS0000-bZ RIBI in I
250000-6) ~IBI Kn I
-124 25U000-Z89 STRIP´• TR*IL1NG EDGE´• LH I
250000-200 STRIPI TR41LING EDGE, KH L
-125 250000-291 Rid, in I
290000-9 RIB1 Rn
-126 250000-10 RIB. LH 1
2)0000-CL RIB~ RH I
-127 IP4K, LH L
250000-157 SPPH, RH ´•´•´•´•´•.´•.´•´•´•1´•+..´•......... 1
-128 250000-2 RIOI LH 1
250000-3 RIB, KH 1
-LZ9 250000-18 RIB. LH ´•´•´•´•´•´•´•´•´•´•1´•´•´•.´•´•´•..´•...... L
ZiOOUO-i9 RIBI Rn i
-L30 250000-201 RIBI LH i
2S0DDO-ZOS RIB, RH i
250010-206 RIBI LH I
250000-207 Rid, Rn I
-132 250000-50 RLBI in I
250000-51 RIB, RH 1
210000-18 RIB, LH
250000-79 RIB´• RH I
250000-L38 SPIR LISI, LH.....´•´•..´• 1
250000-L39 SPIR nSSY´• RH I
-131 250000-375 WtB´• in IREPLPCES 250000-281) 1
2)0000-163 WEB, RH L
-135 ZS0000-Lbb W~8´• in L
250000-161 HEB, RH 1
-136 250000-Lbl WEB´• Ln i
250000-L65 WtB, RH ´•.´•´•´•´•´•´•´•´•....´•..´•´•´•´•´•r´•- L
-137 250000-232 TP~RI Ln 1
250000~233 SP*R t Rn L
-138 250000-240 ´•+´•RIB. LH I
25~030-24L Rn L
-139 P50000-242 RIB, LH ........´•´•´•.1´•´•..´•´•´•´•´•´•´•´•.. L
Z~o000-243 ~Is´• RH i
25~000-148 HINGE bi~Y1 in 1
L50000-149 nlNGE 1SSY, RH L
I*TT*CHING PIRTS)
MIZ*L9r85) SCREW r´•´•.´•....1.´•´•´•´•´•´•..

4N960DLO ´•´•W~SHBR C

NSZLO~*N) NUT 2

MIZOZ~LKP)P BEIRLNG L

CODE EFrlCTIYE DN SERIIL NUMBERS

G b901 L1100 THRU IIIPT
H 690* 8 6908 L1IZB *ND IUBI

2-208
 ILLUOTRATED
ROCKWELL
SECTION n PARTS ´•CATP~LO% COMMANDER
WING BO(IA/B

[T~3

~"d

ol I

la

~ilur´• 2-39. Winp Strudur´• (Sh´•´•15 ol 6)

2.210
 ILLUSTR~TED
GULFSTREAM
P~RTS SECTION n
COMMANDER
WhlO
680A/B90B

UNITS UIIBLE
FIGURF T
D t 5 C R L P T I O N PER ON
L INDEX
2 3 i 5 6 1 ISSY COUE
NUMBER N U M B E R L

Bs~CIET, LH I
2-39 -L)Z 250000-80
BRICIET´• RH L
L50000-BL
250000-86 BRICI(ET´• LH
BR*CXET´• RH 1
150000‘85
HINGE ISSII LH~RHIILEIOII L
-1)) 2501)00-150
HINGE 1SII´• LH t RH IILERON 1
150000~211
LITTICHING P1RTSI
1N3~bl BOLT
UISHER II
INPLDDIO
NUT 2
*SII0)1N3
---I---

BE*RING I
IISZOID1KP)I .´•It´•....´•´•´•´•´•´•´•´•+´•

BRICIET, LH 1
-L(I 250000~190
BRICIETI RH
210000~1(1
L E
-1)8 BR*CIET, LH
LH I FG
250000-369 BR*CIET´•
RH 1 E
P)0000~219 BRICIET, ´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•,´•1

BRICIET´• RH L Ft
150000-310
TRII T18 IlS11 LILERON I
2)0000-311
Till T1B (REPLLCES I
.150 L092TRL00~18 ICTUITORI
L092rR1(10~5)
IITTICHIN6 PIRTSI
BOLT, FYD (I)19II 1
-IS1 1BCbOB~
BOLT1 LFT 11)2911 I
18C6088

BUSHING E
~15) NLlll~(-015
P F
NLSIS-)-OI( BUIHING
F
I-03be-1 YIIHER
ROD EHD LREPLICEI HN-)) L
-IS) 250036-1
(ITTICHIN6 P*RTS)
´•´•CHECINUI´•´•´•´•´•´•´•,´• ´•´•´•i´•´•´•´•´•´•´•´•´•´•.´•´•´•´•
1
~155 LH3lb~)R
---I---

BR*CIET IPPII INBD 1

-Il6 250000-359
8RICI(ET *ISI. OUTED I
-157 250000-3~0
IlTrlCHING PLRTS)
-LSB BOLT
UISHER 2
1N9(10010 ´•´•´•´•´•´•´•I´•´•´•´•´•´•´•´•´•´•´•

COVER INSTL. FLIP MINCE REF

Lb0011
COVER, LH INBD L
-159 L60D2~-1
COVER RH INBD L
I

IITTICHIHG PIRTS)
SCREU 3
WSZ(b93~5)9 1 ´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•.´•r´•

SCREY 1
*SLlb9~-56
1)135-OL)-P(* Y*IIER (78S53I
SCREY L
1(12(69(-111
Y*SHER I7BB))) L
13235.020-261 ´•´•´•´•+´•´•´•´•´•r´•´•´•....´•´•~´•

---t---
COVER´• LH OUTED ´•´•´•´•´•.´•i´•´•´•´•´•´•´•´•´•´•´•´•´• 1
-IbO 160023-503
COVER, RH OUTED 1
160023-50)
STRUCTURE LIII´• CENTER UIH6 REF
L1OI1B-l
IIRIHGER. LH (ND´• L INBO) L
-LL1 110118-3
STRINGER, RH I*0´• I rNBD I L
LIO11B-~
STRINGERI LH INO´• L OUTBDI 1
-162
STRINGEIII RH (HO´• L OUTBO) L
170118.16
STRINGER, LH (HO´• P INBD) I
-163 IlOILB-5
STRINGER, RH (NO. I INBO) L
170118-6
STRINGER. LH IND1 2 OUrBOI L
-16( 170118-39
SRRNNEER, RH LNO. 1 OUTBDI L
llOL18-)0
INITL´•
STRINGER 10 PERCENT CHDRD REF
110219
..+SrR1H6ER. LH L
-L65 1)0219~3
STIIHGER´• RH L
tlOllP-~

CODE EFFECTIVE ON SERIILNU*BERS

E 6906 L1100 11202
THRU
F 690* L 6908 11203180 SUBS

2.%11
Revised: 28 November 1984
 ILLUSTRATED GULFSTREAM

SECTION II PARTS CATALOG COMMANDER

WING ssaA/esaB

Its
Ist
161

:;´•S
-;re
in

its
its

In

1a3

la~

ist

f~
111 i,,

I,,

i,,

111 /152
111 lso lit I rr

~V

Apure 1-39. Win(l Qru~ture (Shaet 6 of 6)

2-212
 ILLUSTRATED
ROCKWELL
COMMANDER PARTS CATALOG SECTION n
690A/B WING

FIGURE P b R T UNITS USIBLE

C INDEX 0 t S 0 R I P T I O N PER ON

LURBER NUna~R I z 1~5bl assv caoE

2-34 -Lbb L7OLLB-I STRINGERI En (NO´• zn,............... I

170118-8 ST’. INGLRI RH INO´• 21)1 I

LIOlls-9 STRINGER 1~0´• 311

-168 170118-11 STRINGER 1NO´• 3) L

-IL9 110118-L3 STRINGER (NU´• *I I

-110 170118-11 ~NGLEI LH

170118-L8 PNGL~´• RH 1

-111 171118-L9 PNOLEI EH I

170118-20 PNGLEI RH
-172 170118-29 STRINGER, LH (NO. 5 OUTEDI L
170118-30 STRINGERI RH (NO´• 5 OUTdOl L

-173 170118-2L STRINGER, LH (NO´• L INBUI I

17ollti-~2 STR~NGER´• RH INO´• b INBOI I

-L7* 170i1B-3L IT~INGtRI LH ING. 6 OUTBDI 1

170118-32 STRINGtR~ RH INO´• b OUTOUI I

-175 170118-23 ´•´•STRINGER, LH INU´• ~i\ INdDI 1

110118-24 STRLNGER´• KH (NO´• bb INBO) L

-176 I701i8-33 STRINGERI LH (NO´• bl OUTBDI 1

I701iB-3i STRINGER, RH INO´• 64 OUTBU) L

-LII 110118-25 STRINGER INO´• 71 1

-178 110118-27 STRINGER ING. B) L

-174 LI0LL8-35 ..STRINGtR LNO´• 8i\l L

110297 FITTING INSTL IHS ZI´•0~1 REF

-180 17O2UI-1 BR~CKET. LH L

170296-2 dRLCrETI RH I

-181 170295-L BRPCKET 1 LH L

170295-1 BRPCI(ET1 Rk .....´•r´•´•´•´•´•´•´•´•´•´•´•´• I
-Is? 170160-1 BRICIET´• LH L
L70L60-2 BR*CKEII HH I
.’00020 DINEI ISSI´• OUTER WING REF
-183 200020-89 ITRINGEI~ LH INO´• II L
200020-90 STRINGERI RH (NO´• LI 1
Zo0020-93 STRINCtR´• LH (NO´• 21 I
2OO020-9’t STRINGtRI KH INO´• 2) L
-185 ZOOoZD-L*L ´•-STKINGER. LH INO´• Z1\) i
200020-1*2 STRINGtR, RH (NO´• 2111 I
-IBb 200020-83 STRINGERI LH ING. 31 i
100020-81 STRINGLI~ RH INO´• 31 1

-181 200020-19 ..STRINGER´• LH IND´• ii I

200020-80 STRINGEH´• RH INU´• *I L

-188 200020-91 STRINGERI LH (NO´• 5) 1

200020-92 STRINGER´• RH INO´• 51 L
-IdY 200020-103 STRINGtR, LH (ND´• 6) 1
200020-104 ITRINGER´• RH (ND´• b~ L
-IPO 200020-109 STRINGEH´• LH (ND- bbl L
200010-110 STRINGERI RH INU´• bdl L

-1?1 200020-85 STRINGER, LH (ND´• I) I

200020-86 STRINGtRI Rn ING. 71 1
200020-81 STRINGER´• LH (ND+ 81 L
200020-62 STRINGER. Rn I ND. 8) 1

2-213
 ILLVSTRATED
ROCKWELL
SECTION n PART8 CATALOG COMMANDER
WING
680A/B

C.

i~
.r;--

1-40. rrull M.in L.ndinl O´•.r

2.a14
 ILLUSTRATED
ROCKWELL
COMMANDER PARTS CATALOG BECTION n
68(IA/B WING

FIGURE P 4 R T UNITS USbBLE

L INDEX O t I C R i P T I O N PER DN
hUNBER N U M 8 E R L 2 3 9 5 6 I bSSY COOE

2-10 160019 WING *ZSY. COnPLETE i

730058 TRUSS PNO SIDE BRICE INS1LI nL6
1 730019-503 SUPPORT nSSI1 L4NOING GEIR, LH LNBU REF
IStE ~IG´• 2-13 FOR BREP~UUWNI
730059-501 SUPPORT PSSYI LPNOING GEPRI RH INBO REE
ISEE FIG´• 2-13 FOR BRflKUDWN)
Z 7311062-503 SUPPORT i\SSYI L4NDING iit*Rt LH OUTED REF
IIEt. FIG´• 1-19 FOR BHtl\l(DOWN)
730062-504 SUPPORT ~S111 LdlNOING GtbR1 RH OUTED REF
(SEI Fli´• 2-13 FOR BKEIKDOYN)
3 730076-1 8R4CEI flOE 2
IITT*CH1NG P*RTSI
4 i\N6-12ii POLT L
*NO-L3P BOLT I
PN96DDblL WISHER 2
MS21044N6 NUT 2

930005-20 .LLIP, PIPING SUPPORT

7 730077-1 EYEBOLT Z
(IITICHiNG P4RTSI
8 MSZ104*N7 NUT I
*N900DT16 WISHER 2

9 130058-3 TEEI LH INBO 1

730058-4 TEE, Rn INBD L
10 730058-11 *N~LEI LH INBO L
T300l8-LB PNBLE´• RH iNBO L
LI 730058-19 INGLEI IH OUTBO
130058-20 4NGLE´• RH OUTBO
12 730058-2L ~NGLEI LH INBO L
7J0058-22 4NGLEI Rn INBD i
13 730058-23 I\NGLE´• LH OUT80 1
730058-21 PNGL El RH OUTED L
11 170059-3 STR*PI LH 8 RH 1
N*575-b-008 BUSHING´• STRbP I

2-215
 ILLVSTRATED ROCKWELL
SECTION II PARTS CATALOG COMMANDER
WING 690A/B

53 61 J-
SE

J L ,-i´•I 51

16 se
as
i, n

g--BI t/
,3

12
Jr
1 31 37 3.3 116
ii 3(
13
(15

i~t kB
j,

cs I~ \e I Y‘I

I_

B
~2SB 21

T C2I
17 i~p

31C,
´•II

lillurs ’2-41. ond Londinp O´•or D~on inrt.ll.lion (Sh´•st 1 of ’2)

2-216
 ILLUSTRATED
ROCKWELL
COMMANDER PARTS CATALOG SECTION n
BgOA/B WING

FIGURE P I R T UNITS US48LE

C INDEX D E I C R I P T I D N PER ON

NUMBER N U M B t R I 2 3 C 5 6 T PSSY CODE

I-*1 NO NUMBER NPCELL E t LPNDING GEI\R DOORS INlrL REF

260025-511 NICELLE IS SY 4NO I NSTL LH LOWER I ii

260025-514 N*CELLt *SIY *ND INSTL. Kn LOWER ´•1´•´•´•´• L n

200025-515 NICELL~ nSSY INO INSTLI LH LO*tR I

L60025-5Lb N*CELLE *SIY 1ND LNSTL. Hn LOWER 1 B

260025-511 NIC ELLL nPSY 1NO I NSTL i

LH LOWER 1 C

260025-518 nnCEiLt nSSv nNo INSTLI RH LOWER 1 C

ZL0025-5L9 NiZCELLE bTSY bND INSTLI LH LOWER 1 F

260015-520 NIC ELLE ISSY i\NO I N lit Rn LOWER t

1 F
I4TTbCnlNG PbRTSI
L NS21039-L-o8 SCREW 8

7 YSLTOJP-L-LO SCREW
PNP6O-1OL W*S n6R Il
MIZIn)ZL3 NUT 12

3 EIS27039-L-09 SCREW t

MSZ1039-1-3 L SCREW I

nSZLn44N3 NUT .....´•´•´•r

L

26Oo2T DOOR bSSY *ND INSTLI ~LG REF

260027-3 DOOR PSSYI STRUTI LH OUTED I
260027-) DOOR *SSY. STRUT1 RH OUTED
b 260027-5 DOOR nssr, smur. LH INBU I

260027-6 ...DDDR biSY´• STRUTI RH INBD 1

I4IT*CHING PdRTSI
1 900016-33´•ls PINI HINGE I
---I---

8 330095-502 BRPCKCT 45SY IDUTRD DOORS LH L

FWD G RH *FTI
31C095-50L BR*CKET nSIY (OUTBO DOORS LH L
i\FT L RH FWDI
LO 33CC95-503 BR*CIET 4ZSY IINBD DOORS LH FWO I
L RH ilFTI
11 330095-50* aRnCKEr *SIY IINED DOORS LH bFi 1
G RH
FWDI
I*TTICHING P4RTSI
MS27039-L-LD SCREW 2
n521694-553 SCR FW 2

dN960PDIOL WISHER
YSZLO~ZL3 NUT Z
---I---

1(54* BEIIRING 12L 3351 L

Il 260028 LINI4SIY1 ULG DOOR OPERPTLNG

NSZO 20 LKP ii BEPR ING i

13 330(185 LINKIGE INSTL´• 3LG DOORS 1StE REF

FIG+ 2-131
19 160027-19 HINGE nnLF´• LH OUTBO DOOR I

260027-20 HINGE HPLF´• RH OUTBO DOOR I

260027-23 HINGE HPLF´• LH INBO DOOR 1

Zb0027-2~ HINGE Hnlr, RH INBU DOOR 1

19 260027-25 HINGE H*LFI LH INBO DOOR (*TTICHED 1

IO NICEILEI
260027-26 HINGE HILF1 RH INBD DOOR I*TTICHEO L
NPCELLEI
TO
260027-11 HINGE n*LFI LH OUTID DOOR 1
TO NntELLEI
260027-12 HINGE H*LFI RH OUTED DOOR IPTT*CH~O
rO NntELLEI

CODE EFFECTIVE ON SEKI*L NUMBERS

I a90n L1100 THRU LLIIZ
E 6904 1113) THRU 11ZZb
L 690* 11221 THRU 113C1
F 6908 11350 *ND SUBS

2-217
 ILLUSTRATED
RDCMYELL
BECTION n PARTS CATALOG COMMANDER
WhlO BI)OA/B

FIGURE P 4 R T UNITS US48LE

INDEX D E S C R I P T I O N PER DN
HUIIBER N U M R E R I 2 I 1 5 O 7 i\SSY CODE

2-41 660002 FIREW*LL INSTL (ST* L61´•001 REP

´•´•´•´•´•´•1´•.

660002-3 FIREWILL ~SSY, LH L D

660002-9 FIREW*LL *SSY´• Rn ´•´•´•´•´•´•´•.´•´•´•´•´•´•´•1´• L D
6b0002-31 FIREU*LL *SSY1 LH I C
L60002-33 FIREWILL *551. RH L 0
66O0O2-31 FIREWILL *56Y1 LH I F
660002-39 FIREUPLL *SSI, Rn I F
16 660002-7 BULKHEID. Ln I O
...............1....

bbD002-8 dULKHE4D´• RH i 8
660002-35 BULKHE*O´• LH L t
660002-36 BULKHE*D. RH 1 C
660002-41 r BULKHEIDI LH I F
660002-42 BULKHEIDI Rn I F
(*TT*CHING P*RTS1
II nNIC4 BOLT 1´•.´•´•.´•...........´•.´•´•´•..... 16
1N960t4L6 W*SHER 16
---L---

18 17343-61-’t50 INDIC*TORI THERH*L 113LbB) 3

(~TTICnlNG PbRTS)
bNBC5A BOLT 3
1N960D10L **SHER ´•´•´•´•´•1.................... 1

19 660004 SE*L INSTL. T*ILPIPE (5EE FIG´• 2- RZF

Il
660001 SEI\L INSTL, T41L PIPE IStt FIG´• 2- REF
II
20 610418 SHRDUD *SSYI TIILPIPE ISEE fit. Z- 41 REF
2600’12 EJECTOR *ND FI\IRINB nssr nNu INSTL REF
260012-55 F*IRING *ESY´• LH
2600)2-56 F*IRING 41IY1 RH L
20d S-0390-1 STUD ......´•´•.´•r´•..........´•.´•´•´•... 2
21 260012-51 F4IRING, LH FWD L
260042-55 FIIRING´• RH FWD I
22 260012-59 F~IRING´• Ln nFT 1
Z6o0*2-60 FP1RING, An *FT L
23 F*LKING n5lY. LH
260042-26 F*IHING *SIY1 RH I
IITTPCHING PIRTS)
21 HS2469*-SSD SCREW 73

25 260012-53 EJECTOR 4551 L

254 610498-1 assv,
158 210025-153 Ea~K;rpao T4LLPIPC
´•´•´•´•´•´•´•´•´•´•´•´•´•´•1´•´•´•´•´•´•´•´•´•´•´•´•.´•.
4
L F
26 260025-113 SKINI LH DUTBO L E
260025-145 SKIN, LH DUTBO L F
210025-11* SKIN, RH OUTED L E
260025-1)6 SKINI RH OUTBO 1 F
27 260025-125 SKIN, LH ´•´•´•r´•´•´•´•´•´•´•´•´•´•´•´•´•´•.......... I B
260025-133 SKIN´• LH I C
2b0025-L4J SKIN, LH 1 F
260025-126 SKIN´• RH I B
260025-L)4 SKIN, AH ´•´•´•r´•´•´•´•´•´•´•´•´•´•´•´•.´•´•......... 1 C
260025-114 SKIN, Rn I F
ZB SIIN´•
UPPER´• LH 487 I E
210025-1)9 SKIN, Ln UPPER1 *FT L F
260025-12 SKIN, Rn UPPERI nFT 1 E
260025-110 SKINI Rn UPPER, *FT I
29 260025-7 ..CDNE PISSY, TAIL 1
......´•+.r........´• 1´• E
260025-117 CONE *SSY´• T*IL I F

CODE EFFEtTIVE ON SERI*L NUMBERS

B 4904 11133 THRU 11226
C L90* IIPZ7 TnRU 11349
D 690* 11100 THRU llZZ~
E 690* 11100 IHRU 11149
F 6908 11350 LND SUBS

2-218
 CrULFSTREAM ILLUSTRPITED
COMMANDER
BOOA/BOOB
PARTS CATALOG SECTION n
WING

FIGU*E Y ii a UNITS UIIIBLE

L INDEX D E 5 C 9 1 P T I O N PER ON
hU36En N U H a E a I z 9 i a 7 asiv coat

2-ii -31 26C025-LL5 iKINI LH i E

~bOoP)-lli i~iN1 ~n i*IRo

260025-116 il(lN´• RH I E

LB0025-iiZ il(lN, KH I*180 i

2600*3 01L tUOLER INSILI IOUtY h~CELLE ReF

31 010413-1 OLL COOLER ISEE FIG´• 2- i) Rti

~b0013-3P STIFFENER 1
3L
SEIL i
33
-3~ i6C0*3-21 EEI\L I
2600)3-31 LOUVEII L
)5
SULLHEI\O I
36 Zb0025-9
37 ZLCOL)-BL ..(100R1 bCCEIS L
I~TTICHING PIR1II
NS27039-1-06 ICREH 8

2bo025-117 CH4NNEL ILH i]UTBO 8 i(H INaDI 1

38
39 260025-128 CH4NNEL ILH INBO g RIU I)UTBDI 1

160025-15 BULI(HE~D, LH i
CO
260025-16 BULI(H~IID I RH 1

*I 260021-105 Eil4NNELl LH I

260025-106 CH4NNLL´• RH I
CH4NNFLI LH I
12 P60025-107
CH*NN~LI 9~ 1
1600L5-L38
CHINNELI iH I
)3
CH*NNEL. Ri~ 1
260025-50
CH*NNELI LH I
14 260025-51
CHIINNEL´• RH L
260025-52
260025-79 IL4L1 RUBBER EXTRUSION I
IS
FRPHE´• Ln OUTBO ISTb ZLI´•OO) 1
16 260031-1
FRP*E´• Rn OUTED IS~L 211´•001 L
260037-2
II 260036-1 FRIHE´• LH UUTBD ISTb 206´•00)
FRIZNE Ril OUTBO ISTII ZOb´•OOl i
200036-2 I

260035-1 FR*HEI LH L)UTBD (ITb L91´•001 i

*B
rR**EI RH OUTBO 1574192´•001 L
260035-2
26002)-57 RIil´• LH 1
19
RIB´• RH I
260025-58
RL3´• LH I
50 260035-501
R1B´• RH I
260035-502
R18´• LH 1
51 260025-L09
RI~. R~ L
260025-110
LN^LE L
52 260043-3
53 16(1025-75 INGLE t LH
INGLEI RII I
260025-76
INGLEI LH I
5* 260025-71
*NGLEI RH ´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•-´•´•´•´•´•r´•´•´•´•´• L
260025-72
BRICIETI HLG IIR G1GE NOUNTING 1
55 710028-7
N*CELLE 1SSY PNO INITL´• LH 6 Rn UPPEK REP
ZLDOLL
DOOR, (ICCESS L
56 260026-93
ICREY 8
51 HSP*694-Sl8
DOOR´• 4CCESS, LH L
58 260026-17
DOOR, bCCESSI Rn i
260026-48
HIZ*L9~-IiB ´•´•ICREY II
59
DI)UR, IIICEZS L
-60 260026-131
ICREU 15
..61 H121~41-I*8
DOOR *SII´•´•´•´•´•´•´•´•´•´•´•´•´•´•´• L
62 260026-121
-63 2e0026-121 DOUBLER
IIIN. LH i
LL 260026-117
SI(LN, RH L
2b0026-8(
LOFIGCRON, LH 1
65 26002L-L3
LOIIGERON RH 1
260026-L1 1

CODE ON SLR14L NURBERS

E 6904 11100 THRU LL349

6908 11350 i\NO SUES

2-219
 ILLUSTRATED
OULFSTREAM
SECTION n PARTS CATALOG COMMANDER
WING 680A/680B

,,g
f
a

1. ,´•1

2-41. ~nd Londinp O´•.r Dborl in.t.ll.tion (Ih´•´•l 2 ol 2)

2-220 Revised: ZB Nauemlier 1984

 ILLVSTRATED
r.ULFSTREAM
COMMANDER
PARTS CATALOG SECTION n
WING
B(IOA/BOOB

FIGUKt P II RT UNIfZ UIP´•BLE

8 INDEX D t I C I I P T I U N PE~ ON
hUH8eR N U n o E a I 2)4 s 6 7 assv COOE

2-41 -66 260026-L5 LONGERONI Ln I

~beOL1-lb LOIIGERLN´• KH 1
67 260075-1 ~NGLt´• LH 1
260015-1 ..*NBLEI Rn i
bB 2L007*-L bNGLt. LH 1
ZL0071-2 bNGLt´• RH I
69 Z60026-Ll1 4NGLEI L~ L
Pb00Z6-L’12 bNGLt´• RH i
70 26002b-L’t3 4 NGLE LH 1
Z60oPL-L’~ 4NGLE1 RH i

7L 260026-75 ´•´•FRIUt´• LH...´•......´• i

210026-76 FRIIIEI RH i
72 2 60026-1 I FRInE1 LH i
260021-is FRIREI RH I
73 26002L-79 FOIHERI LH
2b0026-80 ´•´•F O~*ER 1 RH
II Z6O0Z6-77 ´•+CH~NNELI LH I
260026-78 CHINNFL´• RH L
15 2LO(IZ6-BL FRllnEI LH I
260026-82 FRIIEI~. RH 1
la 260026-111 CH~NNEL´• LH L
2L0026-LL2 CH4NNELI RH d´•´•´•´•´•´•´•´•´•´•´•´•´•+´•´•´•´• I
IT 260026-103 RIB. LH L
RIB´•
78 260026-10L *NGLE1 RHL;I:::::::::::::::::::::::::::
260026-102 *NGLEI RH L
14 260026-95 8RI\CKET. LH I
260026-46 ´•´•BRICI(ET´• RH I
80 260026-6L IPICERI LH I
260026-62 SPICER, RH L
I*TT*CH1NG P4RTII
BL ll~Z1039-L-3L SCREY I
MSZlo~4N3 NUT L

82 2(10072-L R18´• LH I
260072-2 R181 RH I
83 160026-91 4NOLE 1
Ln I
260026-95 *NGLEI RH L
BI 260OZ6-L07 BRICKETI LH 1
260021-108 8R4CI(ET I RH
85 260026-109 8KPCKET´• LH I
P6OD26-LLO BRICLET´• RH I
26006L 000R INITLI MLG´• LH L RH 4FT REF
86 5132 TIRE I*LT P*RT 5*91 (281531 1R
87 260051-505 DPOR nill, HLGI bFT ILH OUTBO) L
IREPLICEI 260051-501)
260051-1 DOOR 4SIY1 YLGI PFT IRH INBDI 1
88 260051-2 OUDR rlSIY´• YLG´• 4FT ILH 1EIBOI L
)60051-506 DODR *111I HLGI dFT (IH OUTBOI i
IRePLbCtS 26005 L- 501)
I4TT4LHINt P4RISI
89 M1Z~b41-13 SLR Eli IZ
~N960C8L WIBntR LZ
MIZLOIZLo8 NUT L2

-90 2e0D6I-) INGLLI LH L

260061-4 ~NGLEI RH 1
I1 210061-5 INGLEI iH
lb0061-L IINGLtl RH
92 Pb0C61-7 *NCLEI LH i
260061-8 INGLEI RH L

a-221
 ILLUSTRATED GULFSTREAM
PARTS CATALOG COMMANDER
SECTION n
WIN(I 890A/B908

FIGUKE P i\ R T UNIIP USIBLF

L INDLX D 5 C I I P T I U N PtX Ur
NUMBIH N U M B E R I Z 3 i Z L 7 i\SSY COOE

1-)1- 93 260061-9 ING~E, LH 1

260D6L-LO INGLE´• RH I
IITTICHIN6 PIRTSI
-9~ 11521039-1-10 SCREW 2

LNP)OCLOL WISHER Z
*S)LO)LL3 NUT 2
---I---
99 260069-1 TUBE LSSI. TORPUE, LH I
260069-2 TUBE 1SSI, TORPUEI RH L
(ITrlCHING P1ITS)
96 NSZIOIIN) HUT I
NLS(3HT)-3 SPICER 1
-97 IH3B6-I-(, PIN1 TIPER 1
*N915´•3 WISHER 1
LN320-3 HUT I
162)bL5-13Z PIN, COTTER I

-98 IN960CBI6 YLSHEII´•´•´•´•´•´•´•´•´•´•´•´• LR

IW960CB16L WISHER 1R
-99 260068-1 LEVER *RN. LH ´•1´•´•´•´• I
260068-2 LEVER 1RII, RH L
-100 26006)-1 NOUHT lSSll IIEIRINS, LH FYO I
26006)-2 HOUHT 1SSl, 8EIR1NG, RH FWO L
(ITTICHING PLRTS)
-1D1 LNIE(I BOLT 3
)IN~(IOCIOL WISHER 3
*IIIOB3H3 NUT i

BE*RING ´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•I´•´•´• 1
260059-1 MOUNT 1SSI, BEIRIHG, LW L RH )iFr
I*TTICHIN6 PLRIS)
-103 IN3C)I BOLT +´•´•´•´•´•´•´•´•.´•´•´•´•´•´•´•i´•´•´•.´•´•.,~´•´•´•´•´•´•´• 3
*NPbDCLOL WISHER 3
HS2L083H9 NUT 3

0)-5b~-0) BE*RII(G (083121 L

PIRTS YR~) 113L)()´•
IliLT
-LO( 7L30~L-IOI C*L1HDER *SS* IO‘RIHG IIT *0´• 183-01 1
-105 1Ne19-IO REDUCER ´•´•´•´•´•´•r´•´•´•

-IOb 5-0310-90211 O-RIHG .´•´•´•´•´•´•´•I´•´•

-LOI 713092-501 CILIHOER *SS* (LESS FlTTlNGS) L

IlTTItHING PIRTSI
-IOB *HIC12* +´•BOLT´•´•´•´•´•l´•´•´•´•´•´•´• ´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•i´•´• I
-109 IH)CL1* ´•´•BOLT I
-110 HLSIIHT(~L SPICER I
INsbOC)L6L WISHER ´•´•´•´•´•´•´•´•´•.´•´•.I´•´•´•´•

~111083H) 1´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•

---I---

11311*-501 ´•´•´•C*LINOEIIIISII DOOR IICTUITING I

-L11 L DREIIS~) ROD END I*LT P*RI HIIX~(G (1313~) L

(BL116)
-tlt HUT ´•´•´•´•´•.´•..´•´•..´•´•..´•´•´•´•´•´•´•´•´•II´• 1
-113 260061-11 SPICER ´•´•´•´•´•´•´•´•´•´•´•I´•´•´•´•.´•.´•´•.´•´•.. 1
-III IN9b0-5I6L WISHER 1R
-115 S.O)LI-L13 ´•´•´•´•RINGIB*tl(UP.´•. 3
~116 O~RIHG
-117 713111-1 ´•´•~*LINDER I
-llB )1)11)-1 ´•´•´•´•PISTON´•´•´•´•´•´•.´•´• 1
-119 S-0)I1-lL3 RING, 8ICIUP 1

2-239 itovixsd: 28 November 1984

 WLFSTI1EAM ILLUSTRATED
CUMMANDER PARTS CATALOG SECTION n
680A/B80B WING

FL~UYE P P X T UNITI USPIBLE

t INDtX O t c R I P T I O N PE9 ON
NII*BER N U n a E a 1 z I c 5 a r nszv coot

S-0310-L13R O-RINB L
-111 111i12-1 LOCIHUT I
-112 )1)110-1 END CIP 1
0)-10(-0( BELRING 10831~) 1
-113 260011-1 SUPPORT FITTIHb, C*LINDEI NP
260011-901 SUPPORT FITTING. CILINOER IREPLLCES
t
N1Sll-(~001 BUSHING (USED HITH 260011-1) i F
N1111-*-00) BUSHING(USED YITH 2
-12) 930036-1 COVEII-OUSTI ENGINE OUTLET L

COOE EFFECTIYE ON SERIIL NUI(BERS

E 690* 11100 mRU I1~)P
F 6908 11)10 INO SUES

Revised: 28 November 1981 2-%23

 ILLUSTRATED
OULFSTREAM
SECTION n PARTS CATALOG COMMANDER
EMPENNAOE
BgOA/6908

51
5
~EJ

Is~ o ~i ,iil 13

Isi~

I
t 3
;ca~

~S;
’t ´•n~
Sr I,

~isur´• 2-42. \lellil~l SBbili´•´•r ~nd Rudd´•r In~tollotion IOh´•´•11 ol 4)

2-224
ROCKWELL ILLUSTAATED
COMMANDER PnRfs cnTnlOo SECTION II
680A/B EMPENNAOE

FIGURE P 4 R i UNITS USbBLE

6 INDEX a i I C R I P T O N PEH ON
NUMDtr N U n a c a 12 5 7 4ssr coat

z-Iz NU NUMBER YERTIC~L S14dILIIEH 6 HUDDtK INSIL REF

ILOJod IT*alLILER liS111 YFRTICI\L SWEPT I
I 410012-1 TIP 4SSYI YEKTICPL IIABILILEH I
IdTTbCHING PdRTSI
I’ nSL~b91-I’t9 ZCI(EW 27
ii-3L~5-020-ZI* rlPSHtR IIJi531 PI
---~i---

110015-11 CLOSEUUI 1
InTTICHING P4RIS1
nSLr6r~-549 TC*LW
11-3235-020-5*9 I4I(1CR 1189531 4

i 9 L0D15-9 TIP ´•´•r´•´•´•l´•´•´•´•´•´•´•´•´•´•´•´•´•........... L

Ci000R-71 ODJH I 4
I4TTdCHING P4RTSI
I nSZ*blCS1B TcREW
---I---

410005-151 ~UJBLtR L 4
410008-1~9 SKIN, LEADING IDGE L 4
~1000R-245 SKIN, LCIJING EJGE L BC
~10008-161 HIB L
LO 410008-101 Rid
900120 NIPPLE, FL*NGtO (RIYtTCD iO -107 RIRI L 4
193~21)
II LiOUOB-105 Rid i
13 ’110008-103 RID ´•´•´•´•+´•´•´•.´•rr´•´•´•´•´•´•´•´•´•´•´•.´•´•´•´•´•´•´•´•. 1
13 SLC008-101 RIB I
L1 110008-91 RId L
Ii ’tiooOR-97 Rid L
L1 110008-95 RLJ 1
17 RIU 1
18 (LOOOR-5 RIB L
19 410008-91 1113 I
ZO 410008-199 Rid I n8
~10008-269 RiJ 1
21 410008-73 ~NGLEI LH I
’tiOoo8-I~ IIN^LE1 Kri r´•´•´•´•´•´•´•´•´•´•´•´•.´•.´• 1
iZ 110008-171 SklNI LH t 1 4
)10008-213 SKIN, LH L 80
110008-113 SKIN, RH 1 4
1100DR-2~7 SKINI Rn I RC
~10005-201 DOUILEK Z
21 110009-105 r SP91(ns sv, ~noNT I
zr si00os-zp spnn. LENTER i
L5 ~LU009-)09 TPIR 4SSY´• REIY L
410008-195 D03R nSSY L a
JOOR *SSY I CE
~100UB-iT1 STIFIFNEP I
410018-191 DOOR I D
410008-213 DOOR L Ct
21 CL0008-1Bo STIFFtNER 1
Ze ~L000b-R5 CHINNEL L
29 4 Lboo 8- I Rla L
3L ii000C-115 GUSSET ´•´•´•´•´•´•´•..1.................... 2
II *L0008-109 RIR
31* 11i95189-145 GHOMHET 1 R
)2 4NCLE ´•..´•.´•.1´•...................... L
3J nNjLE 2
3* 1100UB-17 Rid ´•´•´•´•´•´•1´•......................... L

CDOE EFFEcTIYE DN S~RI*L NUMBERS

690P 11100 TnRU 11268
B b90n 11269 THRU LL31P
L 6906 LL35~ bNO SUBI
5~0* LiloO THRU 111L2
6904 LII~) T~RU 113~9

1-215
 ILLUBTRATED ROCKWELL
SECTION II PARTS CATALOG COMMANDER
EMPENNAOE 680A/B

8"5

"a

)ipur´• 2-42. Vartil~l ~nd Rudd~r Ph´•et 2 ~f 4)

a-228
ROCKWELL ILLUSTRATED
COMMANDER PARTS CATALOG SECTION n
890A/B EMPENNAOE

FIGUHE P i\ R T UNITS USnBLE

C INOtX D E 5 C R I P T 1 O N PEP UN
NUWBti N U M 8 E R L i 9 9 5 I dSSY COOE

)-~2 I’t* ~1000 8-2 31 000R 1 8C

IbTTPCHING PdRTSI
340 MSL7039-1-06 SCREW 20
---I---
35 *1(1008-197 KIR I
36 110008-153 RIti ´•-´•´•´•´•´•-´•´•´•´•´•´•´•´•´•´•´•..r´•´•´•´•´•´•´•´•´•´•. I D
110008-223 91Y I Ct
37 ii00UB-161 FITTING ~ISY ´•´•´•´•r´•´•´•´•´•´•´•´•´•-´•´•´•´•´•´•´•´•´• I
nlZOZO1KPI* BEnKIN6 1
~B CIOOJR-LS7 RIR ´•´•´•´•´•´•´•´•´•r´•´•-´•´•´•´•´•´•´•´•´•´•´•´•-´•´•´•´•´•´•´• L O
I1UOOB-LZT Rid L Ct
39 RiJ I O
410008-229 RIB L CE
10 410008-155 RIJ ´•´•1´•´•´•´•´•´•´•´•´•´•´•´•´•1´•............... L D
~LoOOB-ZZS Rid I CL
)I IlOoOR-lbP FITTING bSSI
*ZLOZOIKpnb BtbRING 1
42 *IOoJ6-L63 RiB L F
13 ilJOJB-207 r K13 i G
~LOOOH-233 RL~ L CF
41 110008-ZOY RIJ I (i
~LU008-Z39 Rid L CE
19 410o08-ILS Rla 1 D
~L0008-Z3L Ris I Ct
~b 110108-55 R1~ ´•´•´•´•´•´•´•´•...r´•´•´•´•´•´•´•´•´•´•´•´•´•........ I
110008-57 JOUBLER I
410048-117 GUISET Z
~B ilo~08-L81 STIFFENFRI LH 1
110008-182 ST I FF ENER. RH 1
19 410008-183 STIFF~NtHI Ln 1
110008-181 STIFFENERI HH L
4 LOO)C-107 DOUBL ER 1
’t2o030-505 RUO~EK nSSY L
iL~O)O-jOT KUUOtR 45SY I LJ
InlTIICHING P4RTSI
51 4NZL-166 BOLT i
nN9C9D416 Y*SHER i
XSZLOB~NI NUT 2

5L $20092-503 TIP liSY

IbTI*CHING PIRTSI
YSLlb91-~49 SCREW II
WnSHER 1785531 *1
---L---

jj L51-0oo8 LPMPI TE4RDROP IREPL*CEZ 50*-211 REF

ISEE FIG. 2-251
54 120092-7 TIP I
’t2O1O1-L SIIFFFNER. FWO 1
120113-1 STIFFtNERI CENTER 1
420102-1 SIIFFENERI rLFT .r´•´•´•´•´•´•´•´•´•´•´•....... i
-5~ ’110129-501 CUYER
I4ITltHING PIRTSI
NSZ7039-0d05 SCREW Z
bN9~0PDB YISHER 2
SCREH ´•´•´•rl´•´•´•´•´•-´•´•´•´•´•´•´•´•´•´•.......... Lo
4N9~0POb il~niR 10
---li---

COOE EF~tCTIYE ON SELlbL NUROtRS

(908 L1350 *ND SUBS
D b906 11100 THRU LIILZ
h906 11163 THLU 11349
690b LI100 THRU 11119
G 6901 LL111 THRU 1l1hZ
H bVO* LLlOo THRU 11304
J 69011 11305 THRU 11349

2-227
 ILLUSTRATED
ROCKWELL
SECTION II PARTS CATALOG COMMANDER
EMPENNAOE
esoA/e

pr O

-4

I: ~-u’3; I
~;og 11,

,,,P?
PI i
o

~r b~´•
1
C

2-42. Stebili~´•r .nd Rudd´•r Inlt.ll.,ion ISh´•´•l 3 ol 4)

2-228
ROCKWELL
ItLUSTRATED
COMMANDER PARTS CATALOG IECTION U
890A/B EMPENNAOE

FI~UHE P a R T UNITS USIBLE

L INJIX D E 5 C R 1 P T I O N PER UN
NUMBER N U N B t R L Z 3 5 6 7 PSSI LUOt

2-12 56 420i00-L DOOR bSSI L

(~TTLCHING PPRTSI
nS27039-1-05 SCREW ´•´•´•.1´•..´•.... r´•´•´•´•´•´•´•´•.´•´•.´•.... Zb
*NYbOPUIOL HASHER 26
T531206-221 SCREW i 2
LN960P16 WISHER Z
~527031-0805 SCREW
dN960Y08 WISHER i

57 420110-501 SKIN *SS1. iH r´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•...... L H

120154-1 SKIN ISSY1 LH 1 CJ
58 L~OL4L-501 SKIN *SiY1 KH 1 H
120L55-1 SKIN dSSII RH ´•´•´•´•1´•´•.´•.............. 1 CJ
59 4L0109-L RIU ~ISY
bO IZD10B-L Rla PSSY 1
420128-501 SPIR LSSY, FWO 1
6i 410027-1 RIB ´•´•+´•´•´•´•´•´•´•´•´•´•.´•.....i.......... 1
62 *ZOOZb-L RIB i
63 4L0058-L PiB i
64 420057-1 RIB L
IPTTaCHING P4RISI
HS27O39-0806 SCREH ´•´•´•´•´•´•´•´•´•´•´•´•´•´•1´•´•´•´•.......... 2
*N960-8L WISHER Z
---~i---

tS 420029-1 t RIB 1
420028-1 RiB 1
67 420056-1 RIB I
IdTTICHING P4RTSI
MS27039-0806 SCREW ´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•t 2
iiN960-8L WISHER 2

61 420036-L DOUBLER L
65 120031-1 HINGE HaLF, UPPER i
10 423025-1 HINGE HaLF, LOWER 1
lnTTl\CHING P4RTSI
IN~-5ei BOLT
hN16O-10L WIIHE R I

7L 420128-5 IP4R´• FWD ´•´•´•1´•.................... 1

2 120042-1 FRdnE I
7~ ~ZOo*l-L FRINE 1
14 4.’0053-501 FR*HE I
75 420039-1 ´•´•FR*IIE 1
76 420018-1 FRaNi I
71 420094-1 FRIHE I
IU )POOIO-i FRIME 1
79 420013-1 RIB 41SI .´•.´•´•1...................... I
80 420055-513 SP*R bSSY L
81 I20152-L STIFFENER I
d2 420091-L R1B 1
83 420089-1 Rla 1
84 420142-1 FRIAE I
85 *20059-L SrRIPI TRnlLING EDGE i
86 4LO086-50B HINGE HPLF L
si sue span 1
aa 4 PO 119- L RIB I
39 1201lb-L Kla I
90 420133-L RIB I
91 12013*-1 RIB I
92 1201)5-1 RIB L

CODE EFFECTIVE ON SERIAL NUnBERS

C 6908 L1350 *ND SUBS
H 690* iI1O0 THRU 11304
J 6904 L13O5 THRU 113*4

2-228
 ILLUBTRATED
ROCKWELL
SECTION n PARTS CATALOG COMMANDER
EMPENNAGE BIIOA/B

137

~1´• ´•r
2. 130

~V i
i

d 1
ib;

J131
~f
~--136

ji 4

~ipur´• 2-42. ilabilil´•r .nd Rudd´•r In~lall.lion ISh´•s, 4.1 q

2-290
ROCKWELL
ILLUSTRATED
COMMANDER PARTS CATALOO SECTION II
68(IA/B EMPENNAOE

FIGIIYE P n I T
UhllTZ USIIBLF
i IhJLX O E 5 C R I P T I O N PFK I1N
h U M B F R I 2 5 b I bSSY (nOL

2-12 93 12006~-705 HINGE nbiF I

91 42:130-501 iUB SPIR I
gq ~ZOL)I-TOI THIH T10 liiY1 KUDOFK

423010-1 ~INI HINGE 2

190016-20.20 PIUI nlHjt ´•´•´•´•´•.r´•´•´•´•´•´•.............
---I---

it IIRR 1
InlTbLHING PIKISI
dSL7139-L-IS SLR~k
RSL733Y-I-~0 TC~IW i
1N16~010 WISHtR Z
15!114*N3 iiUT 2

YJ27IC1nSP3L BEbRING I
’51 42006L-53i HIN~E H4L~1 UPPER
98 423061-50) HINGL HPLFI LUIEH 1
420125-501 SKIN 1
´•iUO 420150-1 IKlh! i
420077-503 HORN *iSY1 fiUDDE" 1
P4RTII
-101 nN3H56 BOLT
1~UC001oL *PSHtR i
-13L 4N3-5* oOLT j
~UVblDIO W42HE~
NUT 3
LOJ ~NS-OI BOLT i
nN461C416 WIIHEK 2
li21DS"NI NUT i
---li---
-104 5302?-1 IU"PO’T 4SSY I
PdRIS1
YS?IC83N4 UVT 1
1N960C4L~ WPSHEP I

-iOo aEIKING
-101 9100L3-1 EN~ 1
Idll9CHING PIRISI
-IJU iN?-lln 53Li 2
~NULODIO iiiSHER 2
"lS21O44N3 YU’ Z

-109 100016-1 LINK bSSY i

I4TTICHING "IYTSI
-110 dNI-in
L
i;sa,n~la wnsHta I
NUT 1

111 ’IPIOLOII(P)I ?liii( i Vlj L

-ili 50jOLb-3 LINX
-113 ’1230~1-1 PLITL I
-II* 4L007Y-1 ODUBLCI, fWU 1
-115 ´•tZOiBU-l OOU6LEn. IF T 1
-Ilt 4ZIOIR-L
Z
I~TTbCHING rbRi~l
-117 LN3-4b UOLT
*N561DLO WISHEE
liZlol~N3 rui
6

-lls 110015-501 iUPPOfiT *5SY 1

-llr HJZ3%32KP253 UEIRINS I
IPTTICHING PbRIS1
1000-2?1 RINGI SN*P 1791361 I

2-251
 ILLUSTRATED
ROCKWELL
BECTION II PARTS CATALOG COMMANDER
EMPENNAGE BgOA/B

FIGUHE P 4 R i UNIrS USIBLE

E INDLX O E I C 9 1 P O N PER ON
hUMBEY N U M B E P L 2 5 6 1 4117 CODE

2-12 -120 120082-1 F(TTING L

-1Zi 425013-1 SLE EYI 1
-1.’2 920085-501 COLLIR
-123 420111-1 TUBE 1
)20013-509 dCTUPTOR INSTLI RUOOER THIR TnB REF
-124 490022-501 TUBE aSSY L
I4TTICHING PIRTII
-L~S 4N173C7 dDLr ´•´•´•´•´•´•´•´•´•´•+´•´•.´•.´•´•r´•´•´•´•´•´•´•´•´•´•´•
L
aN960010 W4IHER 1
MSllR2~-3 YUT L
*52*bL5-Z83 Plri´• COTTER L
-LL6 V45509-1 CHECK NUT I
---t---

~ZOOL3’23 PCTUnTOR 1SSI I

IITT*CnlNG P4RTSI
-127 4N3-L3n BOLT Z
-1ZU nN3H134 ..´•DULT´•´•´•´•´•´•´•´•´•´•´• 2
nN960D1O W45 nE H r r r ´•1´•

MSL1014N3 NUT
MS35206-ZLS SCREW
3~SHER I
HSZ104SNO4 NUT ´•´•´•´•-´•´•.´•´•´•r.´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´• I

-130 4Z0012-50L I\O~PTtR L

-131 420013-2’) 4RH L
420013-31 OOUULER i
PIITS)
-132 *E35201-IZO ´•´•StKtW
dh960UIL WbSHtR 2
MS2IO49N0C NUT ´•r´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•

-133 410016 BR*CLET 1SZY´• illln rail acTunron

BKPCKET I
-135 n52L383N3 NUT ´•´•´•.´•´•.´•...1....´•...´•...... 2
-L~L 2835Y6 *CrUITOH I*LT P*RT 2835YC 1653011 i
(613011
-137 910013-35 IRM ´•´•1´•´•´•´•´•.´•´•´•´•´•´•r´•´•´•´•´•´•´•´•´•´•´•´•´•´•´• I
I*TTICHING PPRTSI
-138 MSZSb93-S9 SCREW
i\N’ibOD’tL WaSHER L
YIZL04*N04 NUT L
---L---

420011-25 *An ´•´•.´•´•´•´•´•´•.´•´•´•´•´•´•´•´•´•;r´•´•´•´•´•´•´•´•´•´• i

I~TTPCHING P4RTSI
-ICO E11217 SCR~H 1365361 1
En1238 WbSntR 1365361 L
4N960DI I*SHER IUNDER SCREW HtPU) L
Ea1Z39 NUT 1365361 L

-141 440012-507 TRINSMITTtff 4SSY1 TRln TLU I

IUTTICnlNG PIRTSI
N135106246 SCREU ´•´•r´•´•´•´•´•´•´• Z
nN96008 WISHtR ....´•.´•´•.´•.´•r´•.´•´•..........´• 2

-I)P 420114-501 SHIN ´•´•.rl´•1´•1..´•´•.´•..´•.............. i

-114 420119-1 SHIM

2-232
ROCKWELL ILLUSTRATED
COMMANDER PARTS CATALOG SECTION II
BBOA/B EMPENNAOE

~IGURF P 4 R T
UNITS US*BLE
C INOtX 0 t S 0 R I P T I O N PER ON
NUn8tR N U M B E R I 2 3 5 6 LISY COOt

1-12 ~10071-1 DORIIL FIN 9SSY 1

IUOI 1-50 L Jox rnL F IN liSSI i
(ITTPCHING PPRTS)
-1)5 LISL7o31-i-01 SCREW r 69
iiN960-LOL WliS nER gg

~13071-1 OURSIL *SSY, rYO 1

410071-35 DURS*L ~SIY, FHD I
110071-15 ´•´•RIB ´•´•´•´•´•I......................... L
~i00li-17 RiB ....´•1......................... i
)10071-27 SHELL I
110071-65 SHE LL I
-191 I1001i-5 OORSLL bTTY1 MIDDLE I
~1007L-29 ~URSPL bSSY´• MIODLt I
41~071-9 nis i
rioo71-11 nie 1
IIooll-zs SHELL I
~10071-39 SHELL I
-118 ’t10071-3 DURI*L dSSI, *FT .´•......i........... I
)1UOlI-J3 OORSPL *SSY´• IFT 1
RiB I
’1i001I-13 SHELL I
*10011-31 SHELL I
"1U073-1 DOR59L FIN PTSY I M
41~013-101 DORSPL FIil I551IREPLICES *10073-503) I C
InTTbtHING PIRTSI
-L’t9 MSZ~69*-SI SCR EH t qj
1\-3235-OZO-P~P UIISHER 1785131 93

-L50 110073-3 SHELL I DORSI\L 1 n

I10073-9 SHELL´• OORSdL I C
-151 930054-1 GUST L3CK ~SSY1 RUDUER I

CODt tFFLCTIVE ON SERI*L NUMBERS

C 6908 11)90 dNO SUBS
690P 11100 TnRU 11121
L b901 11128 THRU I1i9l
690* 11195 THPU 11~*8
bYOb 11250 THRU 11268
M 690d 1119C THRU 1119~
6904 LLZ1P THRU 112*9
6901 L1269 THRU 11319

2-1)1
 ILLU87RP;TED ROCKWELL
BECTION 21 PARTI CATALOG COMMANDER
EMPENNAOE BBOA/B

D.":, i" II E

2
C

21 II I %X!1

BS
A BI 1 53
52 51

600

31)

c o E

e~
a;

,,=4~, 1:

~ilur´• 2-42. Stobili.´•r .nd il´•v.l~r inlt.ll.lion (Sh´•.11 ol 2)

2-234
 ILLUSTRATED
ROCKWELL
COMMANDER PARTS CP;TALOO SECTION n
BgOA/B EMPENNAOE

FIGUKE P 1 Y T UNITI USdBLE

C INOtX D E 5 C R I P T I U N PtR ON
NUnBEH N U M B E R L 2 3 15 d I bSSI CODE

Z-4)- *1(1 NUMBER HORI1OUTbl ST1\BIL12ER L ELtYPTOR INITL REF

SI~JILIIER 4151 *NO INITLI nORIIONTbl L
1 11300L0-223 TI" 1SSYI HOR I LDNTI\L 2
1 430010-147 SKIN1 LEIDING EDGE 2
3 410010-209 SKINI LH UPPER L
1)0010-210 SLIH, RH UPPER 1
41110LO-213 SI(IN´• LH IUUER I
430010-214 SKIN, RH LOWER 1
I~OOLO-95 SKIN´• UPPER 1
5 110010-91 IKINI LOWER 2
b 430010-153 RIB Z
7 410010-151 RlD 2
’t30010-155 R18 i
430010-151 RiD 2
10 430010-1)9 RID 2
ii s~001D-161 ZId 2
iZ 430010-164 RIB1 LH L
430010-110 KiBI RH 1
13 ’J0010-171 r RIB 2
14 ’r30010-89 RIB 2
IS 430010-$9 RID 2
16 430010-87 Kin ´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•r´•´•´•´•´•+´•´• Z
ii $30010-85 RIR i
is 430010-83 RIJ Z
19 430010-81 HII I
20 430010-79 RIs Z
LL RIR 2
430010-77 RIB
L30010-71 RiO 2
24 430010-19 RII 2
25 430010-131 HID i
Z~ *30010-1P5 HIB 2
27 130010-71 RID
LI 410010-137 HiD 2
29 410010-7 FITTING ~551´• OUTSOIRU 2
30 MSZo2olKPlb BEIRINj L
31 130010-43 GUSStT ´•´•´•´•+-.r´•´•´•´•´•´•´•´•´•´•+´•´•´•´•´•´•´•´•´•.. 4

435010-L13 BRILKET 2
33 1~0010-*L CLIP 2
31 130010-31 RIB Z
35 430010-29 JDV8LERI LH 1
430010-30 00~8LER1 HH L
4J00LO-Z19 GROIIIIET 2
3~ *30010-63 RL?´• Ln ´•´•´•´•´•´•´•´•´•´•´•´•´•1..´•............ I
430010-64 Klai RH 1
)7 430OL0-57 FOR*EH L
38 430010-51 FORMtR 1
34 L~o010-107 FORMER i
40 Lj0OIO-5L FORMER ´•´•´•´•´•´•´•´•´•´•´•´•r´•´•´•+´•´•´•´•´•´•´•´•´•´•´•´•

41 430010-139 F OR ni a I
rz 130010-119 iRUMME T L
43 430010-11 FLTIING IfEIi INBO 2
14 NIZ020LKP’II IEPRINi r´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´• L
45 430010-221 GUISET, LH 7
130010-222 GUIIET, RH Z
16 *30010-39 CLIP i
s7 430010-17 BKPCKET 2
rB L330LO-L~9 ITR1P P
49 4300L0-Zll DOJK´• In 1
430(110-212 DOOR. RH
I~TT*CHING P4HTII
NIZ1039-L-05 SCREW 10
---I---

2-235
 ILLWSTRATED
ROCKWELL
BECTION n PART~ CATALOG COMMANDER
EMPENNAOE
BgOA/B

ss
"i9p91

103
[I"
d
,,1
lor

lot

O Ire

In

111

c~"

;BTk~
113 a

u~-C
Iir In

filur´• 2-43. Horilont.l it.bili´•´•r ond Elov.f.r inlt.ll.,ion (Ih´•´•12 or

2-258
ROCKWELL ILLUSTAATED
COMMANDER PARTS CATALOG SECTION n
BgOA/B EMPENNAOE

FLLUKE P 4 R T
UNITS USnHLt
INOtX O E S C R i P T O N
i PEK ON
hCMBtX N U W B t R 1 Z 3 i 5 7 bSSY COOE

2-43 10 ~30010-L93 IPIRI 4FT

51 13000Z-~L1 SPbR 4SIY´• CENTEK i
52 430010-65 SP4K r´•´•´•´•´•´•´•´•....................... Z
13 430012-5L5 IP4R 4SSYI FWO
ELFY4TOR 4111 4ND INITLI LH 1 4
"’00~0-529 ELEYITUR 4SiY PNO LNSTLI KH........... I
410000-53L ELEYiiTOR assu 4Nu INSILI Lh i B
440000-533 EL~Y*TOR 4SIY 4NO INSTL, aH L B
I4TT4CHING P4RTI)
54 INI-LII BOLT i
4N9bO0116 W~SHEK 2
MTZL083N3 NUT 2
---I---

55 140000-254 SKIN, LEIOING EOGE I

56 iC0000-289 SLINI LH UYPER 8 RH LOWER I
440000-191 SKINI Rn JPPER 6 Ln LOhcR 1
57
SKIN1 LH LOWER E RH LIPPLR
58 1*0000-1*2 K1BI LH i
59 *40000-224 KIB. RH I
60 1*0000-2L R1B. LH I
hi C1001o-24 KIR´• RH I
eL 440000-22 RLB
as r4aooo-16r nra i
bi 440000-Lbb RIB I
b5 I~Ooo0-IZL RIB ´•´•´•´•1............................ i
CIOooO-ZIZ RIB L
b7 ZEE I
4~P014 HINGE II~LF 1
ea iioooo-Izs spnn i
b4 ~10000-192 F4\IRING I
I*TT4CHING DdRTSI
SCREW 8
MS35206-Z2R SLKt* Z
NUI

TO OUOR

IPITdCHING PIHTSI
nSZ*b9~-149 SCREW 10
´•--t---

IiUo00-lrZ HINGE HdlF, INBD

IPTIICHING PIRTS)
IZ PN)-~* DOLT 4
4hi960DIO WIIHtR 4
dNP60U10L W4SHtR 4
----i---

VOOOL3-4-.ll BUSHING 2
73 **00L7-I HINGE i\SSY1 OUTDO I
(4TTbCHINt PIRTSI
ii 4N3-54 BOLT 4
4N46o010L UISH~R I
-75 N227039-0806 SCREW I
4N960DO W4SHER I
nLZi083-No8 NUT

90O113-L-1.17 BUSHING 2
Ib 140000-279 Rid
77 440000-281 RIB 1
78 i)0000-283 Rid L
19 140000-232 STRIP ´•´•´•´•r´•´•´•´•´•´•´•´•´•´• I
80 C10000-36 RIB
81 *40000-98 FITTING i
COOE EFFECTIYE ON SERI*L NUnBtHS
6904 11100 THRU 11202
D 6904 4 6908 11203 *ND SUBS

2-251
 ILLUITRATED
ROCKWELL
SECTION II PARTB CATALOG COMDNLNDER
LrMPENNAOE ssoA/e

FICUKt P 1 K T UNITS UI*BLF

C INDtX 0 E S C R i P T I D N PER ON
NUMBER N U n B t R i 2 3 9 5 6 1 4SSY LODE

2-43 CI00O1-50L r T*R 4551 9YD ~NSTLI ELEYPTUR I

-82 PPOOLL-~* ~1NI HINGt 1
I’tUOi3 HINGE H4LF i
83 940001-33 8K4LKET 45SY ´•´•´•´•´•´•´•´•´•´•.´•´•+rl´•.-´•´•´• 1
’120010 SUPPORT 45SY I
85 HS272blnSP3L BE4RING i
86 1’,0001-3) *NGLE, DUTBD i
67 r 4NGLE´• INBD i
IITTdCHING P4RTS1
58 nS~7039-L-09 SCREW ´•´•´•´•´•´•´•´•´•´•´•1´•1.............

4NYL0PD1OL H4SnER ´•´•´•´•r´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•

84 i4000L-27 SKIN, UPPER ´•´•´•´•´•´•.r´•´•´•´•´•´•´•´•´•´•´•´•´• i

110001-29 SKIN, LOWER
C10~15 INSTL, ELEV TRIM TbB FEF
nECHeNIC*L
ICTUITOH 4ISY1 LH i
iC0015-29 ´•´•I\CTIIIITUR *551, Rn L
90 1400)7-501 TUBE 4ISY i
IITTPCHING P4RTSI
91 i\NZ3-131 BOLT i
ISi1083N) NUT i
92 4NJlb-LR CHECnl)UT L

93 4RM ILH ONLY) I

410015-LI DOUBLER ILH ONLYI L
"4R7SI
9~ MS)IIO~-210 SCREW i
bh96004L W4SHtR Z
NUT 2

95 410011 4D4PTER .t..r´•´•´•´•´•´•´•´•´•´•´•´•´•´•...... i

Yb 2835YC r ~CTU*TOR lb53011 i
**UOLL dRnCKET 41511 TRIM T*B 4CTU*TGR i
I~ITPCHING P4RTSI
57 nN3-lol BOLT ´•´•rl´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•.´•1... 2
58 PN~HLOP JOLT 2
4~9h00LO N4SHIL B
NUT

Y9 *40016-3 BR*CKET i
-LOO N121083NI NUT
-li)l I430I5-23 r\Rn ILH ONLYI L
I~TTICHING OIRTZ1
-LO~ SCREW i
PNPL)O*I I*IHER ´•´•´•´•r´•´•´•´•´•´•´•´•´•´•.´•...´•´•´•´•´•... Z
VUI´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´• Z
---I---

-L03 410Pi5-3L 4RN liH UNLYI L

-L31 )40012-591 TRPNSMITTER bSIY1 TRIM 748 ILn L
ONLII
IPTTPCHING P9PTII
-105 SCREW r´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´• 2
I\N96O010 W4SHER i
---L---

-L06 LOL4 ~DJUIT48Lt l~’h551 1

IPITICHING PI\RTSI
-107 MS)52o6-229 SCREW I
4N9b006 H*SHEfi Z
MIZ1OI*NOb NUT i

a-a38
ROCKWELL ItLVSTRATED
COMMANDER PARTS CATALOG BECTION II
BSOA/B EMPENNAOE

FIGUKE P R T
UNITS US*BLE
INULX
U E I C R I P T I O N PER ON
NUnetC N U M B F R 1 2 3 C 5 d 7 PIIY COOE

Z-i) -108 2 765’1- ]P SHPFT, FLEX 130 1 NONES 1 1653011 1 SEE REF
FIG´• 2-*91
4’0000-261 COLLIR PSSII LH ´•´•1.................. 1
410050-262 CULLIR bSSII RN I
IITTICHING PIYTSI
-109 nSi1083N1 YUT ´•´•´•´•1´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´• L
YISHtR ’´•´•´•´•1’´•´•´•´•´•’´•´•´•´•´•’´•´•´•´•´•´•´•´•´•´•´• I
-110 1N~-5n BOLT ´•´•´•´•´•´•1´•´•´•´•´•´•´•´•´•’´•´•´•´•´•´•´•´•´•´•´•´•´•+´•
1N561C10 ~ainEn

-lil ENO ’´•´•´•´•´•´•´•´•´•f L

IITTPCHING PIKTSI
-112 ~N3-L7b BOLT ´•´•´•´•´•´•´•´•´•´•´•f

ilN160DID II\SHLR ´•´•´•1´•´•´•´•´•´•´•´•’´•´•´•´•1 2

MSZ09~5-L031 NUT 2

-113 L~OOLI-50L ~HINNFL

IITIICHING PIRTSI
-119 *1~7039-L-10 ICREW 3
bh960~10 *~Sntl 3
UIZL3’l~h13 NUT r´•´•´•´•
j
----~i---

-115 iC000~ COLLbH I

-ilL COLL*R I
-117 li0000-96 TUOE I
-lls *30007 BRltKtT PSSY (SEE PIG´• 2-53 FOY REF
JREbl(DCIINI

2-238
 lLLVSTRATED
ROCKWELL
SECTION n PARTS CATALOG
COMMANDER
FLIGHT COPITROLS
asoA/e

-6

d
I/

/r ,a if 33 1
lo

v n
II

~ipur´• 2-44. Control Sy´•1´•n (Sh´•´•t I o( 3)

2-240
 ILLUSTRATED
CIULFSTREAM
PARTS CATALOG SECTION n
COMMANDER
FLIGHT CONTROLS
890A/B80B

P i\ R T UNITS USILILE
FIGURE
C INOEY D E I C R i P T i 0 N PFR DN

N U M B E R 12 ’i 5 L 7 dZSY CODl
NuMaIn

510015 COHrr(OL IHSTL, YING FLIGHT REF

5000L1~511 CIBLE *SI*´• COIPLETE ´•´•´•´•1´•´•´•´•´•´•´•´•´•´•´•´•´• 1

L 500012-LPI CIBLE LIS*, LH 1

Z 500012-129 ´•´•CIBLE 1SS*´• OH 1

500012-121 C~BLE IISI. LH I

3 r

500012-231 e~BLE ISSII RH ´•´•.....´•´•.´•´•´•r´•´•´•´•´• 1

500012-101 CIBLE LISI, LH L
600011-99 CIBLE 1151´• RH 1
5 500012-103 CIBLE161*. LH 1
500011-91 ~IBLEllS*. RH I
6 1(5112~LBSS TURNBUCILE BOOT 8
IECIIHIS~ INSTL. FLIP CONTROL REF

7 510003-3)1 CILINOER LSIII FLIP ICTUITII(G I

(INC~LUDES FlTTIHGSI
IO-RINb II~ NO. IBb-O)
IITTICHINC PIRTSI
8 *H2)-22 BOLT I
liN960011b Y*5HER
9 N1113HT)-8 IPICER I
WS1l826-l NI~´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´• L
HIE(665-136 PIN, COTTER 1
-10 INP(-I3 BOLT L
UIIHER L
)ISIIBZb-( NUT ´•´•´•´•´•´•´•´•i.´•´•´•´•´•´•´•´•´• I
I52(665-13l ´•´•PINICOI~ER 1
---I---

-II IHBIS-)O ..´•UNIOH´•´•´•´•´•.´•.´•´•´• 2

Il S-O)lO-eOlR O-RING 2
-13 1’10119-1 ´•´•´•C*LIHDER*SS*, FLIP ICrUITING (LEIS L
FITTINCS)
IDIL‘16n ROO EHD (1313(1 1

IS *N316.bR CHECINUI 1
16 ICREY LBLB291 ´•´•´•´•´•´•´•´•´•´•i´•´•´•´•´•´•´•´•

-II ´•´•´•´•RIHb, RETIINING 1

-Is 1112111bWI-1 ´•´•´•´•Rlnbl ICRLPER L
-19 n52B932-01-5 ´•´•´•´•FELT´•YIPER´•´•´•´•´•
20 1-0)11-112 ´•´•´•´•RINOIBICIUP´•´•´•´• I
PI I-0)10~112R ´•´•O-RfNG 1
-)P )IILICL CLP, CILINDER (818291 I
-23 I-0310-13LR ´•´•´•O~RING´•´•´•´•´•´•´•´•´•´• I
It 5-0311-131 R1NG´• BICIUP L
PI III26t3 Rm´• PIITON 182829) I
-26 S-O)ll-~1R ´•´•´•IINO, BICKUP
5-0)10-2188 O-RING 1
LI 1III6C) BUIHING L 81819) I
28 III26CI H~USING, CILINOER 18)819) I
-29 510003-351 LIHI: 1551 1
ILTTI(:HING P*RTPI
30 BOLT 1
-31 NIS)3HT)-b SPLCEO 1
1Hs60O(16 UIIRER 2
)1H)600116L UISHER 3
1111816-( HlT 1
n511665-13) ´•´•P1NICDITER L

-32 510003-3~1 ´•´•*RI*III.´•´•´•´•´•´•´•´•´• L

I*TT*CHlNb PIRTSI
-33 tZ-11 SEIICREY ´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•ii´•´• ´•´•´•i,´•~´•´• L
---I---
3~ BTJ9PIV TI*HSnl~TER´• POIITIOH INDIC*TOR 1
126666)
(IrTICHING PLRTSI
-35 1931206-218 ´•´•ICI(EU ´•1´•I´•´•´•´•´•´•´•´•´•.´•´•´•´•´•
---t---

36 IP3L0681)52S PLUb. ELECTRICIL CONNECTION 1

Revibed: 2R Navemb.r 1084 2-241

 ILLUSTRATED GULFSTREAM
COMMANDER
SECTI(IN n PARTS CATALOG
FLIGHT CONTAOLG
090A/690B

i
n~
ir
bit
,I ss
’B
10

19 s-.

1´•
14 L´•-

"2,,

c o

r s~

7j~S3 93

~--511 59
J
415

~s
I

lipura Control lyrl.n ISha´•1? ol 3)

a-a42
ROCKWELL
ILLVFTRATED
COMMANDER PARTS CATALOG SECTION n.
680A/B FLIGHT CONTROLS

FIGURE P L T UNITS USbBLE

C INOEX O E 5 C R I P T I O N PER ON
hUn6EH N U M B E R 1 2 3 19 6 7 ISSY CODE

Z-II 37 "lS3OS7-64 tL4nPI ELECTRICI\L tnNNtLTICN L

510033 BK*CKLT INSTL, FLIP REF
38 5100s3-1l CLIP 2
510033-5 CLIP 1
-~tO 510013-7 CLIP 1
-41 510033-9 IdiH I
12 510033-3 BRICKET 1
1~ 510003-317 ROD 45511 CUnPLETE
IPTTICHING PPRTI)
’t4 lL24-17 BOLT
i\N9600416 WPSHEX 2
bN3Z0-C NUT 2
Y524605-132 PIN´• COTTER 2
---li---

15 HE~FS RUO END (L133~1 2

Il dN316-5e CHtCKNUT 2
Il No NUIRER ROD *5SY ILEZS ROD ENDS G CHECK I
NUTS)
48 510003-327 PULLEY nSSYI LH 1
49 5i0024-L PULLEY 4ifYI RH
I~TTICHING PPRTSI
50 BOLT ´•´•´•´•´•´•´•´•´•´•r´•´•´•´•´•´•´•´•´•´•´•-´•´•´•´•´•´•´•´•´• I
51 N1S4ZOOLZ-ZB SPICER ´•´•´•´•´•´•´•´•´•´•´•´•........i´•´•´•´•´•.... 1
5Z SPICER I
PN9600616 WISHER I
MSZ10R3N6 NUT I
----t---

53 510010 H~TIINER, CIRLE L

IbTI4CHING PIRTS)
51 MS27039-i-13 SCREW ILH PULLEY 1SSYI I
55 n527039-1-11 SCREW IRH PULLEY PISY) i
bN96nD10 WASHER L
*iZiO~lN1 NUT i
----1----

56 510071-1 FITTING (LH PULLEY LSSYI I

57 5L0033-359 CHANNEL, UPPER L
510003-173 CHlNNELI LOWER I
58 510003-301 BRACE
510003-36L BRICE i
59 510001-957 BR*CKETI iH UPPER i
110003-93 BR*CKETI RH UPPER L
ID 510003-123 BRACKET liSI´• LH LOWER 1
513003-324 HRPCKET dSSY, RH LOWER ´•´•´•1´•´•´•´•´•´•´•´•´•´• i
61 510003-355 CLIP, LH 1
510003-330 CLLP´• RH I
61b )10003-36) 4NCLE
618 513003-365 ANGLE i
61C 510003-367 PLATE 1
bI 4521566-38 PULLEY 2
I*ITACHING PIRTSI
63 IN’t-IDA BOLT I
WISHER .....r´•´•..........´•........... i
MS:IOBINI NUT 2

64 NbS427Kll PIN, CIULE GU*RO 2

´•´•´•´•´•r´•´•´•´•´•´•´•´•´•´•´•´•..

65 510003-303 DRICKET´• PULLEY 2

66 510003-307 CLIP, UPPEa 2
a7 siooa,-2s7 tLIP´• LOWER ´•r.´•´•´•´•´•´•´•´•´•´•.´•.......... I
68 RE83N BEARING *NO ENO 1SSY 121335) I
I4TT*CHING P1RTI)
69 510003-207 BOLT 1
bN96001n WASHER ´•..´•..........´•r I
M517826-3 NUT 1
MI246L5-L3Z PIN, COTTER t i

1-%41
 ILLUOTRATED
ROCKWELL
BECTTON II PARTS CATALOG
COMMANDER
FLIOWT CONTROLB
BOOA/B

II

%*e II

1IJ

´•7 ii

II~ n
,o

I~ I
;a ~ti-

~iour´• ~l.p Control i*.l´•n (Sh´•´•t 3 ol 9)

2-a44
ROCKWELL
ILLUSTRATED
COMMANDER PARTS CATALOG SECTION II
BSOA/B FLIOA~ CONTROLS

FIGURE P 1 K T UNITS USPBLE

L INDEX D E 5 C R 1 P T L O N PER UN
NUMBER N U R E R L 2 9 i 5 b 7 *SSY CODE

2-41 70 bN3L6-4R CHECKNUT

7L 900009-2~-6´•L5 ROO 4SiY ILEIZ ROD ENDS L CHECK NUTSI 2
72 510025-501 PULLEY nSSY (LH US 19´•0I L RH WS 2 n
sa.7oi
110025-505 PULLEY bSSY´• FLIP ILH WS 49´•~4 C RH BC
US 56´•701
(*TTPCHING PIRTSI
73 NISlb~P4nll BOLT I
4N9L0-416L WISHER Z
4N9600116L WISHER i
MSZ1O"IN1 NUT L

71 910025-5 FITTING ´•´•´•´•´•r´•´•´•´•´•´•´•´•´•´•r´•´•´•´•´•´•´•... 1

IITTICHING PLRTSI
75 INI-lld BOLT 2
WISHER 2
nS:10*4NI NUT ´•´•+´•´•´•..´•´•..........i.......... 2
---t---
16 r10030 RETLLNER~ C48LE Z
IPTTLCHING PLHTSI
17 MS27039-L-LI SCREW 1
IN9600I0 WISHER I
MS2IO44Nl NUT 1

nSL02070PPI BE~RING .r´•´•´•´•´•´•´•´•´•´•............... L BC

MDPPI BEIRING (113351 L
18 900023 FPIRLEIO 10
IITTICHING PIRTSL
-79 MS35206-~*6 SCREW 2
4hl96008 WISHER 2
MS21D4’tNOB NUT 2
---t---
BO REB1N ’It4RING *NO END i\SSY 1213351
I4TT*CHING P4RTSI
81 INZ3-17 BOLT 1
bN960D10 WISHER ´•.......´•..´•1................. 1
n517826-3 NUT
nSZ*~L5-1)2 YIN1 COTTER I

82 4N316-4R CHECINUI L

8~ V00009-23-5.00 ROD niSY ILESS ROD ENDS L CHECK NUTSI 2

84 510026-501 PULLEY ~ZSY´• LH IWS L27´•00) I
51002650J PULLEY iiSsY, FL4PI LH (WS 127´•001 1 BC
81 510027-501 PULLEY 1SSY´• RH 1WI 1
510027-503 PULLEY PISI´• FLIP, RH IYS 1~2´•851 1 BC
IITT~EHING PIRTSI
B6 YnS~64P1115 BOLT
WISHER 2
USZIO*’tN’1 NUT ´•´•´•´•´•.1 I

*SZOZOIDPP~ BEIRING 1 gC
MDPP’1 BEi\R1N6 121)351 I
87 510016 FITTINi .......´•r.´•´•......´•..´•..... i
(*TT*LHlNG PLRTSI
88 nN4-76 BOLT Z
WISHER 2
NUT Z

84 510026-3 CLIP ILH PULLEY (INLYI 1

CODE EFFCCTIYE ON SERIIL NUMBERS

6904 LlloO THRU 11226
B 6901 11221 THRU 113)9
C 6908 11350 PND SUBS

2-245
 ILLUSTRATED
ROCKWELL
8ECnON n PARTS CATALOG COMMANDER
FLIGHT COhPPROL8 BOOA/B

F3

O
,E u
10~

Q
’02
R ~i
K i

"1’

A B

~Li"
20

"4,,

figure 2-41. Piilsron Control lyrlsm (Sheet 1 ol 6)

a-248
ROCKWELL
ILLUITRATED
COMMANDER PARTS CATALOG SECTION II
BOOA/B CONTROLS

FIGURE P 4 R T UNITS USIOLE

INDEX D E S C R i P T I O N PER DN
NURBCR N U H O E R I 2 3 C 5 6 T *SSY CODE

2-’t5 530161 CONTROL INSTLI FUSELPGE FLIGHT REF

500012-535 C*BLE 1ZSYI tUNPLETE I
1 500012-273 C~BLE 4SSY 1
2 500012-215 ClnLt *SSI I
500012-2)3 CblLE *SSI
C 530162 CULU’lN PILERUN
INSTLI IND tLtYbTUH IStE REF
FIG´• 2-*11
30168 BR*C~ET INSILI IILERON DRUM liT* 28´•301 REF
i 130Lb9 DKUn 4SSY1 *ILERON L
IITT*C~ING P4RTSI
6 4NS-IIb BOLT I
i\N960-51bi WISHER diR
MSZ03C5-5Z’t NUT 1
----i----

1 530169-5 STOP I
B 530169-13 RtT4INER, CLBLE I
I4TTbCHING P4RTSI
9 *N)-ZOP BOLT L
nSL03L5-428 ...3UT I
---I---
LD 53o1b9-LL RtTIINERI tdBLE I
IPTT*CHING P4KTSI
ii MSZ7039-i-L7 SCREW ........................i.... I
bhPbODiO WISHER 1
n520365-1032 NUT 1

Il S~Olb9-9 DRUH, IILERON I

L3 513050 HOUSING iiSIY´• BEIRING 2
n120201KP51 AEPRINlj I
L’t NiiS*3003-130 SPICER 2
IITTPCHING PIRTSI
15 n527039-1-31 SCREW I
HSZi083Nl NUT

Id 530061 STOP BOLTI CONTROL Z

IITTICHING PIKTS)
L7 bN316-LR CHECKNVT 2
---L---

Is HSIB155 PLUG BUTTON 1618611 I

IY 530168-15 4NGLEI LH I
20 530168-16 I bNGLEI KH 1
21 530168-11 ~NjLE´• LH
ZZ 530 168- L B *NGLE Rn 1
23 530168-19 GUPRDI CIOLt ´•...1 Z
IITTnCHING PIRT1I
ZI MS27039-1-OT SCREW 2
1N960DLO WISHER i
25 530168-3 CH4NNEL I
InlTlCHING PbRTSI
26 MS27039-1-09 SCREW
IN960D10 WISHER
nSZOlb5-L032 NUT ´•1´•´•´•´•´•´•´•´•.´•´•´•.1.................

27 53016B-) HPT I
IIOlb7-501 BRIZCKET INSTL, *ILERON CUNTHOLI LH ISTI( REF
21´•001
81*~KEI INSTLI *ILERON CUNTRDL´• RH ISTb REF
21´•001
ZB MS20220-2 PULLEY 1
IITTICHING PIRTSI
24 MSZ7039-5-20 SCREW I
WISHER I
MSLLOB)N9 NUT I
---I---

2-241
 ILLU8TRATED
ROCKWELL
SECTION n PARTB CATALOG COMMANDER
FLIGHT CONTROLS
888A/B

0-" b31
3,call>,,

P’ 1 X-
"’7.
n I "-LiPi~

~igurs 2-45. *ileron Conlrol Syrfsm (Sheet 2 of 6)

2-248
ROCKWELL ILLUSTRATED
COMMANDER PARTS CAT~LOG SECTION n
BOOA/B FLIGHT

FIGUKE P 1 H
UNITS USIBLE
INDEX D E 5 C R I P T i O N PER ON
NUHBEH N U M B E R L 2 3 1 6 7 bSSY CCOF

2-*5 30 NnS*Z7K13 PINI C(\RLL GU4LD

31 110167-L5 BR9CKFI´• LH FVD I
5J0167-17 BH4CKETI RH FWO i
930L67-19 BRPCKETI Ln *FT L
530167-21 BR9CXETI RH i\~T 1
930118 BRI1CI(ET INSTL, I\ILERUN CUNIROL REF
530’tib-I BRI\CKLT PSSYI LH IST4 18´•001 1
NO NUMBER BR*CKET *SSY´• RH IZTb 78´•001 1
33 n52*566-38 PULLEI I
I~TTPCHINt PIRTSI
3’t PNI-23b BOLT lLH PULLEYI 1
35 dN4-~5P BOLT (KH PULLEY) 1
36 NPSI30JI-LI~ SPICEH I
nNObOCIL6L ´•I~LHER ILH PULLEYI 1
4NP600916 WI\SHL R (RH PULLEYI i
NI21083NI NUT 1
----I---
31 N11513003-3) SP4CEH 1
IITT*CHING PIRTS)
38 nS27~39-1-LI SCREW I
RS/L081N3 NUT i
39 530417-L BRIC*ET, LH PULLEY
*0 530116-502 ~NGLt´• RH PULLEY I
11 130178 CHPNNtL, RH PULLEY i
)2 530117 INGLEI Rn PULLEY i
530*1b-I IIRICKEI i\SIYI *1LERON ISTI\ 12L.001 L
43 R52~566-38 PULLEY 1
IITT*CHING P4RTSI
~4 ~NI-231 BOLT ´•´•´•´•r´•´•´•´•´•´•´•´•´•................ I
*5 NPS43DDI-100 IP4CER 1
~N9bOCllbL 14SntR 1
MZZ1083N1 NUT
----t___

$6 Y*513003-34 IPdLEH 1
IITlnCnlN6 P4K1SI
41 N527039-1-13 SCREW i
HSZ10B3N3 NUT I
---li---
$8 5)04L7-Z SRICKET I
530182 BR4CIET INSTLI I\ILERON PULLEY IST* REF
LI*.DOI
45 M524566-38 PULLEY ´•......................1...... I
IdTTICnlNG P4ITS1
50 4NI-254 BOLT I
tl NbS43DDI-LOI IP~CER 1
I\N960D116 34SHER 1
NSLO~L 5-*28 IUUT 1

NPS130D3-31 IPbCEL 1
IdTTISHING P4RTSI
53 n527339-L-1~ SCREW 1
RS~LS83N3 NUT I

1* 4NGLE
55 930177 I\N^LE
56 539182-3 Cd4NNtL 1
530181 BRntlET INSTLI *IIERDN PULLEY 1571 REF
15~´•50)
51 n52~266-38 PULLEY 1
I4ITnCHINt PPRTSI
58 MSZ1031-*-38 SCRtH I
59 NI\S’13DO)-80 SYbCER I
4N960Dllb W~SIIER 1
MS203L5-*28 NUT I
---II---

2-248
 ILLUISTRATED ROCKWELL
BEOTION H PARTB CATALOG COMMANDER
FLIGHT CONTROLB BI)OA/B

.r

H J

ra i

a? a3

K L

sa a~
85

ar
~Y

i/, P
Qo,
93

as .~Y

Figure 2-45. Aileron Control Syrtem (Iheet 3 of 6)

2-250
ROCKWELL ILLUITRP;TED
COMMANDER PARfs CATALOG SECTION n
BgOA/B FLIGHT CONTROLS

FIGURE P a H T
UNITS USbRLE
L INOtX
D E 5 C R I P i I O N PER ON
NUMBER N U M R E R i 2 I C 5 6 7
bSSY CODE

1-~5 sD NnS43003-3L SPICER ´•´•´•´•´•´•´•´•´•´•´•´•´•1´•´•´•´•´•´•´•´•´•´•´•´•-´•´•´• i

IaTT*CHING PIRTSI
6L *SZ1039-1-L3 SCREW I
RSZLoBIN3 NUT
i

bZ 530L8L-3 PNGLE
I
63 530111 4NGLE ´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•-´•´•1´•´•´• 1
53038’t aILERON CCNTROL INITLI LH REF
61
PULLEY j
(IITaCHING PPKTSI
65 bN~-L19 BULT ILOWER CENTER PULLtll i
66 eNI-l*~ BOLT ILH LOWER PULLEYI
67 liN~-lOil BOLT ILH UPPER PULLEII
bB N*54100C-~8 SPICER ILn LOWER PULLEII i
bU410-LI6 WITHER an
HnSnER ´•´•´•´•´•´•´•´•’´•´•´•´•´•´•´•´•´•´•f nR
MS21o44N4 NUT
i
---t----
69 Ndi4~7KIZ PI*, CaBLE GU4RD 2
-70 530388-509 IIR~CKET
I
71 530393-1 SUPPOHT
L
72 530389-1 SUPPURT 1
73 NnS~27nZL CbBLE GU*RD 2
111 530~L’t-1 INGLE
IITTICHING P9RTSI
15 CN3-5* BOLT ´•´•´•-´•’1´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•’´•’´•´•´•’
nNY60-loL WPIHER
2
llS2LO’t4N3 IUT
2
----I---
76 530390-503 BHP~KET ´•´•´•´•´•´•´•´•f L
IbTTdCHING PaRTS)
17 9N3-51 BOLT nR
PNI60-LOL WIIHER bR
nSZLOIIN3 NUT
~R
---L---
78 NP5427~19 PIN Z
19 530385-1 BRICKLI 1 a
5303es-sa1 anac*~r ´•´•f
I BC
I*TT*CHING PbRTII
so nRr-5n saLi
nN960-~L6 W*SHER ’´•´•´•´•´•´•´•´•´•´•´•’´•-´•´•´•´•´•´•´•´•´•f 2
nSL104*N4 NUT
---~L---

81 530341-501 INilEI UPPER I

sZ 530392-53L *NGLtl iO*tR 1
83 5~0415-50L BRPCKET ´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•’´•f L
530395 PILERUN CONTROL INSTL´• RH
IEF
84 MSZ*56b-48 PULLEY
I9TTICHING PIRISI
85 dN~-lO* BOLT ´•´•´•´•´•´•’´•´•´•´•´•´•´•´•´•´•´•’´•´•´•´•´•´•"1~"´• I
*N960-416L W*SHER
I
NUT
I

86 NPS4Z7KIZ P1N
5
87 530521-1 t 8KaCKEII PFT I
88 530391-505 RR*CKtTI FWD I
(bTTltnlNG PIRTII
89 PN3-~1 BOLT an
bN9LOC10 wasnen an

CODt EFFECTIVE ON StKIaL NUMBERS

690b 11100 IHRU L1169
B 690P 1116L THRU L13~9
C 6908 11350 aNU SUBS

2-251
 ILLUFTRAT6D
PARTS CATALOG
FLIGHT

OC1

1L´•’~
i.
~Zu-

~ipure ?.ii~ Ailsron Control (Shset 4 of 6)

ROCKWELL ILLVSTRP~TED
COMMANDER PARTS CATALOO IECTION II
680A/B FLIGHT CONTROLS

FIGUKE P a H T
UNITS UlbRLE
6 INDEX O E I C R i r I O N PER ON
NURRFR h U n 1 2 )4 5 b 7
PIlY COUE

2-45 90 53J39C-5)L BR4CKET 4fSY´• UPPER I

91 530399-531 6R4CKET bSSI´• LOHEK 1
92 590’101-533 BRPC*ET. PFT 1
93 530io2-503 BRIZCKLT. FWD I
IC SJO~Z7-l GUPRJ I
95 530405-505 INTERCOSriiL, UPPER I
96 530101-505 INTERtOSlnLI LOWER
97 535403-L dR4CKEI I
98 YSZIZ51-51 TURNBUCKLE RO01 Z
5150*5 CONTROL i NITL, WING F LIGHT liEF
j0C012-5Z7 CbaLE dSSI´• COnPLETE 1
99 5U0012-2)5 (Pdit bSSY, LY 4ILERON i
-LOO 5030i2-239 CI1RLE 4\5 SY 1 Lil PI LEION
50001L-Lll C*BLE aSiY1 R~ IIIEROI L
-iU: 500012-245 (dai E a
siv. nh at LeRnN i
-103 MTLIZSI-5S TURNBUCKLE 3001 I
110058 CUNTK(IL IUSTLI aILEROPI, Ln I IIL’t.oOl RFF
-101
PlN, CdBLE GU*HO 2
-105 PULLEY I
IPTTPCHING PPRTSI
-L06 *N*-lOd BOLT 1
4U960-416L YPSHER
M520365-428 NUT i
-LOi 51006L-S05 BRICLET. 4FT I
-LOd 5100bZ-505 BR*CltTI FWU L
510048 INITL´• RH IILER~N IWS 24.001 REF
-i09 Y45’127niZ P Ihl´• CaBL E GUIIRD I
-110 *SZ45bb-iB PULLEY I
I4TTICHING P~ITS1
-111 4NS-IOb BOLT
4N?CO-4L6L unsHEn i
M221J44N1 NUT 1

-112 5L0049-5n) 8*ICKETI 9FT I

-113 510050-503 al4CKFTI FWD I
51C053 CONTROL I~ITii IILERUNI CENTEK fiEF
-114 NPS127Kll PINI CPBLE GUPRD ´•r´•´•´•´•´•´•´•´•´•´•........ L
-115 PULLEY I
(I~IPCHING PPRTSI
-Lib ahl4-1LI\ BOLT 1
4NPb0-4L6 WPSHER I
MS21OI*NI NUT .....................i..........~

-117 ~527039-1-18 SCREW Z

aN960-10 i4lntR 2
MS110*4NI NUT Z
-Ils ~6113CD)-38 SPOCER Z
-ile 510054-501 aR4CkET I
-IZO 5L0055-50L BR4CIFT
-iL1 510056-531 BR~CKET I
51003*-1 BRP CIET 41 SY´• LH 1
510034-2 6HICIET 1TSY´• RH 1
"S14566-38 PULLEY ........._ I
I4TTPCHING PIRTS)
-113 434-106 BOLT ´•´•´•´•´•1.......................... 1
i\N960-)L6L WPIHER I
MS2L044N) NUT 1

-iLI N91421K1U PIN, CIBLE GUaRD I

-125 110034-3 bNjlEI LH FWD ´•´•´•1´•.................. I
510034-4 PNGLEI ~n FWD i
-IZo 5100~1-5 PNGLEI LH bFT I
510034-6 PNljLE, RH nFT i

2-253
 ILLUBTRATED ROCKWELL
SECTION n PART~ CATALOG COMhlANDER
FLICIHT BOOA/B

120 I ~a

6
1211
c
´•J
115
121 100
’t
I; _.
ss

s r

loo
130 I :1 138

133 1

I) la
131

130

X \i
se

~ieure 1-45. Aileron Conlr~l Syrlem isheet 5 ol 6)

2-264
 CIULFSTREAM ILLUSTRATED
COMNIANDER PARTS CATALOG SECTION n
8OOA/BOOB FLIGHT CONTROLB

IIG~RE P 1 R T UNITS USPBLE

P INDLX D I 5 C R I P r O N PLR ON
hUMBiR N U M B F R I Z i i 5 L I LSIY CODr

2~)5 -121 530(L)~1 FPIRLEIO

(*TTICH1NG P*RTSI
´•128 n521039-L-11 SCIIEY Z
IN960DL0 Y*SHER I

15210(~-3 NUT Z

SLOOLI-L BRLCIET INSTL. IILERON PULLEI´• Ln REF

510012-2 BRICIET InBrL´• IILEROH PULLEI. I(H REF

-129 NLS(2I~1B PIN, CLBLE GUIRD ´•´•´•´•´•´•´•´•´•´•´•´•.´•.1.´•´•´• L
*SL)~66-38 PULLEI´•´•´•´•´•.´•´•´•´•´•´•´• 2
-1)0
(*TTICHING PIRTSI
1HI-151 BOLT I
UIIHER ...´•1.´•´•´•´•´•+´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•

~N310-) NUT 1
PIN, COTTER ´•´•´•´•´•´•´•´•1´•´•´•´•´•´•´•´•´•´•
1
---t---

-132 110012-5 I)R*CIEr

510012-3 INUE. UPPER L
-133
510012-6 IGLE. LONER I

510012-9 CLIP, LH 1
-13)
510012-10 CLIPI RH ´•´•´•r´•´•´•1´• 1

-135 510011-1 BUIHIHG i

1100)b-1 ROLLEI´•´•´•´•´•´•´•´•´•´•´•´•´• i
(ITTlCHIN6 P*RTS)
-131 1N3-L61 BOLT 1
1N960-I0L YLOHER i
18960010 Y*IHER ´•1´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•
I

852108383 i NUT L
---t---

-138 5)019~-1 8810881

510011-501 BELLCRINK I NlTL, I1LERON. Ln REF
510011-502 BELLCR*NIINSIL, *ILERON´• RH REF
510006 ROD *65’1. COI(PLEIE .´•´•..+´•´•´•´•´•1´•´•´•´•´•´• 1
-139
I*TTLCHII(C PIRTI)
BOLT L
-L)O 18)-131
UISHER L
189600)16
NUT 1
IP)IO))NI
BOLT L
-111 183-101
´•´•Y*SHER L
LN960010L
RI20365-1032 NUT 1
---1---

-LIZ RE)F5 ROD END (113351 ´•.´•´•´•´•´•´•´•´•i´•´•´•´•´•´•´•´•

CHECINUT I
-1)3 LN316-5R ´•´•´•´•´•´•+´•´•´•´•´•´•´•´•´•.,´•´•´•´•´•1,´•

510008 ENO ~SI*

NIPTL6IRBP3L 8218188 L
-L1´•i
500006 iljl llS*´•´•.´•´•´•´•´•I´•´•´•´•´•´• 2
L*rT~CHING P*RTSI
182(-116 BOLT 1
-1)7
´•´•YLIHER ´•´•iil´•´•´•´•´•´•

*lL1083n3 NUT ´•´•´•´•i´•´•´•´•.´•´•´•´• i

-I)B LH2I´•L3 BOLT
189600116 NLSHER L
´•´•NUI.´•.´•´•´•´•´•´•´•´•´•´•´• L
18320-(
PIN, COTTER 1
*51)6~5-13(
---1---

-1)9 ISZO1DLIP)I ´•´•´•BE*IINC L

-150 110001-501 BELLCRLNI 1SS*´• *ILERON´• LH I
BELLCRLNI 655*, IILE8ON. an L
51000)-502 r

(LTTICHIIG P*RTS)
BOLT I
-151 1N)-(5L
LN9~0D)16 NLSHER I
NUT 1
WsZIO*)NI
---t---

Reviaed: 28 November 1884 2-255

 ILLUITRATED
OULFSTREAM
BECTION n PARTB CATALOG COMMANDER
FLIGHT CONT~MLS 680A/6908

118

.´•1 ’i
i;a

re
Q~"’
d
~-RI

lu re

113

2-~5. Aileron Control Syltem (Ihesl 6 of 6)

a-a58
 ILLUSTRATED
ROCKWELL
COMMANDER PARTS CATALOG SECTION n
690A/B FLIGW CONTROLB

FIGURE P R T UNITS UIIBIE

L INDEX U E 5 t R I P T I D N PER DN
hUNBCR N U H 0 E R L 2 1 1 16 T PSSI CODE

Z-~5 200020 P*NEL nSIY, OUTER WING REF

510010 SUPPORT INSTL´• PILERDN BtLLCRbNKI iH RtF
C RH
-152 8550126 PLUG BUTTON I
-153 510010-13 CHbNNEL 4SSY´• LH LOWER L
510010-14 CH~NNEL ~SSI1 Rn LOWER 1
510010-9 CH*NNEL dSSYI LH VPPLK 1
510010-10 C~4NNEL 9SSYI Rn UPPER
5L0009 BEIIRlNG bSSY 1
-155 nSZOZolKP4P BFIRING i

2-a57
 IILV8TRATBD
ROCKWELL
SECTION n PARTG CATALOG COMMANDER
FLIGHT CON~ROLB
eson/e

Aaure 2-~6.Ilev.br Co~rol Sy~ten (Ihaet 1 of 5)

2-a58
ROCKWELL
IUUSTRATED
COMMANDER PART8 CATALOG SECTION II
680A/B FLIOBP CONTROLS

FIGUHE P 4 9 T UNITS USABLE

L INDEX D E I C R L P T i O N PER ON
*UHBEK N U M B E 9 1 Z 3 C 5 6 7 ASSY CODE

2-ltb 130161 CONTROL INSTL. FU SELAGE FLIGHT REF

50001P-535 CAJLE dSIY, COMPLETE I
I 500012-15L CABLE bSSY1 ELEVATOR ii-RUM TOLOUE I
TUBE 41 ST1 61.00 TL TURNBARREL
AT iTd 3Zb´•DOI
500012-L55 CPBLE ELEVATOR IEKCH TURPUE 1
TUBE 41 srn bl.oo ra PULLEY *T
STA 6 AFT 10 IURNBAKREL
AT STb 336.001
3 500012-L*3 CABLE ASSY1 ELEVATOR IFROH TURNBIRREL I
dT STA 326.00 TO PULLEY lr 574
127´•00 C FORWARD TO ELEVATOR
HORN iii STA ’tZ1.001
I 5000LZ-L17 CABLE ASSY. ELEVATOR I~ROM TURNBARRtL I
AT STA Ilb.oo TD ELEVATOR HORN
bT ITI 127´•001
5 MSZ1Z5185S TURNBUCKLE BODY
530161-501 CL NTKOL L STOP I NIT L´• ELEVATOR REF
6 530166-501 TUBE n~SYI ELEVATOR (INCLUDtS ROO Z
tNDS´• LOCKS C CHECKNUTSI
IATTACHING PARTS)
7 1\N5-LZP BOLT 2
bN96n-511L WASHER
NAS75-5-008 BUSHING 2
nSZ1OIIN5 NUT 2

9 5-0307-55 KOD tNO 2

LO NA5539-6 CHECi(NUT Z
II NnSS59-Z LOC KI ROD END Z
12 500005 LINK ASSI. ELEVATOR 1
IITTdCHING PARTSI
13 bNI-ld BOLT
4N900D116 WASHER I
HSZ10I*NL r NUT I
ii ANZ*-13 BOLT 2
nN9600116 WASHER
PN320-* r NUT 2
MSZ4~65-L3* PIN. COTTER 2

Il nSZ~Zoll(PIP BEARING L
530165-501 TUBE INS1LI ELEVATOR TOKUUt
L6 533014 4RH
(PTTn~HING PPRTSI
11 4N386-2-14 PINI TAPER 2
PIrr75-3 ´•´•´•WASHER 2
AN)ZD-) NUT 2
n5246~1-132 PIN´• GOITER 2

iB )30165-17 SLEEVE ´•´•.´•´•´•´•´•i................... 2

L9 530165-7 -´•´•I*SHER´•´•´•´•´•´•´•´•´•´• 2
20 5304)b-1 COLLAR ASSY 2
I4TT*CHING PARTII
ii n527039-L-11 SCREW 2
HSZ7039-1-L0 SCREW 2
AN9(0010 WASHER
ISZlo~*N3 lYUT ´•´•´•1´•´•´•´•´•´•´•´•´•´•-´•´•´•´•+´•´•.´•´•´•.....

MSL50UL-3 FITTINGI LUBRICATION ´•´•´•´•tr´•´•´•´•´•´• L

829LI BEARING 1601801 I
23 5301L5-19 TUBE ASSYI ELEVATOR TORUUE i
~4 530067 STOP BDLT1 ELEVATOR 2
IPTTACHING P4RTS)
nSZL083N4 NUT ´•´•´•´•´•´•.´•.´•.r´•´•´•´•´•´•´•+´•´•´•´•´•´•´•´•´•´•´•.´• 2
IN910Dlll WASHER ´•´•´•´•´•´•´•.1´•.´•.´•................ i

2-258
 ILLU~7RATED
PARTS CATALOG

IC~

ila~

"r:8

Pigurs 2-46.EI´•v.lor Control Syllen (Sheet i of 5)

 ILLUSTRATED
ROCKWELL
COMMANDER PARTS CPITALOO SECT~ON 71
BgOA/B FLIGHT CONTROLS

FIGUKE P d R T UNITS USIBLE

6 INOEX 0 E 5 C R I Y T I U N PER DN
hUnBEK N U W 8 E R L Z 3 19 6 7 bSSI CODt

2-I6- LS 530164-11 BR4CKtT ´•´•t 2

Z~ 530164-9 tni\NNtL1 LH 1
530164-LD innNNELI K~
ZX MSZ~566-ls PULLEY
IITTICHING PIRTSI
29 BOLT 1
i(N9600l16 WbSHEK i
*i21J*4NI NUT i
-----~i---

30 530161-3 BRICKET 2
31 530164-5 SUPPORT´• UPPER 1
32 590164-7 ´•´•IUPPORT, LOWER I
33 NnS4Z7K10 PIN1 C*BLE GU4RD Z
34 5j01bZ CDLUIN INITLI IILERO~ PNO CLEY*TON ISLE REF
FIG. L-*l)
5301PL 8R4CnET INSTL, ELFY*TOR PULLEY ISTd PEF
69´•001
31 nSL4566-3a PULLEY 1
I4TTPLHING PnRTSI
36 1N4-~76 BOLT 1
17 530L1L-5 SPICER 1
Y*SlltR 1
MSZIO~CNI NUT I

38 *N3-711 BOLT I
39 530191-3 CH4NNEL I
530418-1 BR~CKCT INSTL. ELEV PULLEYI LH ISil REF
111´•00 L ST1 154.101
53D~16-L 8RICKET nSSY 1
40 h152’1566-3B PULLEY 1
1~TTbtHING "4RTS)
4L bNI-231 BOLT i
$Z NnS’t3UOI-IOO SPICER
nN960C~16L Wi\S HER
*IZ10R3N1 NUT
---i~---
1*5*3003-3~ SPICER I
IPTTltHING PIRTSI
~4 N527039-1-13 SCREW 1
´•´•´•´•´•´•+´•´•´•´•.´•r´•-´•´•´•´•.´•´•´•.....

MS11381N3 NUT i

’15 930’117-1 BRI\CKtT 1

510190 URICKET INSTL, ELEYIITUR PULLEY ISTb REF
L17´•001
46 152*j66-38 PULLEY I
InTT*~HING PPRISI
Il HS270)9-I-LI SCREW I
nNS60D416 Y4IHER L
MS21044NI IUUT 1

~B NIS~ZTK10 PIN, CbDLE GUIRO i

’9 530190-3 4NGLEI UPPEP I
50 530190-5 INGLE, LOWER
530221 PULLEY INSIL ISTb 223´•961 REF
51 N5245~6-38 PULLEY I
(*TT*CHING P4RTS3
BOLT ´•´•´•´•´•´•´•´•-´•´•´•1´• i
53 NISIBUD’t-53 SPICER 1
dN96o-~L61 W4lnER (INITbLLS BENEPTn BOLT HEPDI 1
4N960-*1b WISnEH (INST*LLT BENEn~h NUT) 1
NSZi044N4 NUT 1´•´•´•´•´•´•´•´•´•´•´•´•.................... I
---I---

54 PIN, CIBLE GU4RO L

55 530221-9 CHINNEL. LH 1

2´•281
 ILLUFTRATED
ROCKWELL
BECTION n P~RTS CPi7A100 COMMANDER
FLIGHT
BOOA/B

[I~3 E F

dl I s6
ri
,A
a

:5

o H

Reure?-46.Ilavalar Control Syrt.m ilhset 3 of 51

a-a82
ROCKWELL ILLVSTRATED
COMMANDER PARTS
B)OA/B
CATALOG SECTION n
FLIGHT CONTROLB

FIGURE P d R T
UNITZ US*BLE
L INDEX D E S C 9 1 P T I O N PER ON
NLMBEH N U M R E R L 2 j i I dSSY CODE

L-’tb- 56 5)0221-11 CH4NNEL RH

1

57 530221-7 BH4CKtT i
530187 BR~CKET INSTL´• ELEV*TOR ISii\ 251.00).. RBF
98 MSZC56b-38 PULLEY 2
IUTT~CHING P4R1SI
59 bNI-Z*n BOLT ........._ I
bO SPICEH i
dN960D~L6 WI\IHER 1
MIZ1J14N4 NUT 1
----t___

61 hiPZ)27Klo PIN1 CI\BL E GUbRO 2

62 530187-7 BRbCKET I
t3 530187-11 ARPCKCT I
6’t 530187-9 BRdCKET I
65 530187-13 BRi\CktT 1
530112 BRbC*ET INSILI ELEYPTUR LST1 308001 OEE
66 nSZ1566-*R PULLEY 1STP 290.00) Z
IU~TICHING P4RTSI
bl dN4-ll~ BOLT I
WlZSHLR 1
MSZ10I)N9 NUT i
68 PI~1 CIBLE LUbRD
69 530112-11 BRPCK ET I LH UPPER
530112-22 BKdCKtT´• Rn UPPER I
IPTT*CnlNG P4RISI
70 MS27039-1-1O SCREW i
IhPbODLO WblnCR 1
nSZLO*rN3 nUT
---t---
II ~3011P-19 RRIZCKET. L1 LOWER I
5)0112-20 BRICIE~I RH LOWER I
I*TTdCHING P4RTSI
72 Y5ZL69CS5Z SCRtH 1
1N96oD10 W~SHER I
YSZIO*INI hlUT 1

73 M524566-48 PULLEY (STb 308´•001 2

(~TTPCHING P*RTSI
7) ~NCLOI\ BOLT ´•´•´•´•r´•´•´•´•´•´•´•´•´•´•´•´• I
PN960Dll~ ~ISnER
HSZ104*N4 NUT I

75 NdSLZ7KII PIN, C*BLE GU*RU I

76 530112-2) BRI~I(ET´• LH UPPER
530112-21 BHICIETI RH UPPER 1
17 530112-41 BRnCKET, LH LOWER I
530112-42 BRPCX~T. R~ LOWER i
(4TTnCnlNG P4RTSI
18 bN3-Cd 80L7 1
*N960DLD W~SHER ......´•r.´•.................... L
3521044N3 NUT
---i´•---
79 MS2456b-38 PULLEY IS~d 109´•lbl 2
(*TTICHING PIRTS)
80 ~N4-L1P BOLT 1
I*SHER i
nSZ104LN4 NUT I
---li---
81 NIS127Kll PIhl, CIBLE GU~RO 2
BZ 530112-27 BHICKtT i
83 530112-29 BRP(KET I
84 530112-31 BR4CKEl 1

2´•285
 ILLUSiRATED
ROCKWELL
SECTION n PARTS CATALOG COMMANOER
FLIOWT CONTROLS 880A/8

r;l J

-~i
r

gU b
;I-
i

:s,h I
i B

rilo,e 1-46.Ilevonor Co,rol Sy~f.m (Shaet 4 of 51

2´•284
ROCKWELL
ILLUSTRATED
COMMANDER
PARTS CATALOG BECTION n.
BOOA/B FLIGHT CONTROLS

II1

i,,

102
103

lg U"~-
w

U 3

02
’I
T,

1
’P
iw

rigure 2-46.11evlltor Control Syrlem (Iheot 5 ol 5)

2-285
 ILLUSTRATED
ROCKWELL
8ECTION n PARTS CATALOG COMMANDER
FLIORT
BOOA/B

FIGUKL P 1 R i UNITS USIBLE

C INDEX D E 5 C I 1 P T I O N PFR DN
NUHBtk N U n n E n 1 2 I 4 s 6 I nSsu CODE

2-16 85 )10112-33 dKdCKtT L

IPTT1CHING PIRTSI
Bb dN3-4~ BOLT Z
PN960D10 WISHER 2
n52101~N3 NUT Z

1(7 REHIN HEI\HINli PNU ENU 1SIY (LL3151

IITTICnlNG PPRTSI
IN3-7i DOLT, nFT END INOT ILLVSTCdTEUI 1
bN960DLOL WISHER, *FT END INOT ILLUITRITtOL 1
NUT, bFT END 1NOT ILLUSTRITEDI
88 RDLT L
89 41543~73--6 SPICER I
90 SPICER
*N96UD1O WISHER I
MSZIO~CNI NUT L
---1---

91 nN316-IR CHECi(NUT ´•´•´•´•´•´•´•´•´•´•´•´•´•´•.´•´•r´•´•.´•´•´•´•´•´•´•´•. 2

92 iC0009-3L-10.~0 ROD 41ZY (LESS ROD ENDS C CHECKNUTSI L
93 53o141-5OL SPRING
9~ 5901*9 LINK Z
91 130161;3 LINK 2
I4TTPCHINC P4RTSI
96 PN3-5n BOLT ´•´•´•´•´•´•´•´•´•´•r´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•.r.´•´•´• L
51 Ni\S43HT)-b SPICER
INY600IO WISHER 1
M12LOIIN3 NUT L
---I---

530026-50L TUBE I\SSYI ELEY~TOR IDLER............. I

93 500005 LINK PISY ´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•1´•..´•.1.... L
IITT*CHING PIRTI)
99 BOLT ´•´•´•´•´•r´•´•´•´•´•´•´•´•´•´•´•´•´•..´•´•´•´•´•´•´•.... L
MSZLOB)N* ~UT L
-1DO LN2L-13 BOLT I
eN9600116 WISHER ´•´•´•´•´•r´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•.´•.... 4
PN3ZO-I NUI 2
*iZ)b61-13’1 PIN, CUTTER I
----1---

-101 MSZO~OLKP41 BEIRLNG 1

-IDL 530029 BEIAINLi biiY1 ELEYITUR IDLER i
(PTTPCHING P4R1S)
-103 I\NI~LII\ BOLT L
4N96o0116L WISHER
NUT L

L(SPOZO1KPII BE~RlhlG 1
-LO~ 530026-9 CH4NNEL´• OUTED I
-105 530026-5 CH1Nhti, INDD Z
-10(1 53002b~7 COLLI1K 4
-i01 5)0026-3 TUBE
-108 110078 SUPPORT *SSYI ELEYI\TOR IDLER ISEE FIG´• RE~
2-531
-iOY 310028 FR**E ISSY, FUSel*CE. FUSEL*Gt 1E~
IINCLUOES IILERON izrn *31.001
Fli´• 2-53)
PULLEY aK4tKtTI

a-286
ROCKWELL
ILLVSTR~TED
COMMANDER PART8 CAT~LOO BECTION iI
690A/B FLIGHT CONTROLB

´•I~B
,f
v7
t52
II ii
1
12

-I:
"ph~"/
p-
211 4~ ri3

´•´•I e

2-47. Conlrol Column *rl´•.bly Ail´•ron .nd Il´•v.tor

a-aar
 ILLU~57RATED
ROCKWELL
BECTION n PARTS CATALOG COMMANDER
FLI(IHT CONTROLB
BOOA/B

FIGURE P d R T UNITS UZIBLE

C INUFX D E I C R I P T I O N PtR ON
NUNBEH N U M D E R L 2 1 1 5 6 7 nSSY CODE

2-47 ~30Lbl CLNTR OL L NITL, FUS ELdGE FL IGHT RFT

9J0162-505 r CDLU*N INSTLI ~ILEROhl t ELLYI\iOR REF
CONTROL, LH
530LbZ-506 CULU’(N INIIL. IILERUN E LLFVI\TOR PEI
COVTKOLI RH
I 530162-31 COLUNN *59Y. IILFRON ~NO tLEYbTURI iH L
COLUAN ~SIY1 PiILERON 1ND ~LEYITORI RH L
2 5)0435-L WHEEL nSTY1 IILERON ~NU cltY4TOH I
CONTPDLI LH
530435-2 *HFEL PSSY´• I\LLERON i\ND CLtYbTDR L
CONTROLI RH
I~TT*CHING PPRTSI
(S:LORIRLZ NUT L
1N960-LZi~ *PSnER

130453-1 MEOI\LLION I
5 55-~OR14L17L1 PLUG BUTTON 1830581
530L35-L1 PI*TE, LH
530435-12 PLI\TC, RH ´•´•1´•´•´•´•´•´•´•´•´•´•´•-´•´• L
I4TT*CHING PnRTSI
7 NIISL 102-02-1 SCREW Z

b SL~CXN191-96-* SWITCHI nPP LIGHT 1156051 1

9 530135-7 LENS 1
I4TT*LHING PIHTZI
10 NbSL102-04-4 SCREW Z

LI L195-GE LnHP 1088061 L

12 2506 SOCKETI L*HP HOLDER 1134451
i) 530435-5 BRICKET dSSI ´•´•r´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´• 1
(~TT*CHING PIRTSI
SCREW 2

15 530135‘3 HHEELI IIILERON PND eLEVIITDR 1

CONTRDLI LH
530135-4 WHEEL, *ILERON i\Ni) LLtYI\TOR
CDNTROLI RH
16 MS35C84-b GRO~MET
17 nSZLORNN1Z NUT L
18 dN960-IZlb HPSnER L
19 933062 IEPRING PSSY
IPTT*CHING P4RTSI
PO MI27039-1-0b SCREW Z
ii ~SL7039-I-il SCREW I
---li---

MS1?0101KPL21\ aLI\RING I
*N960ULZlli Il\lnER liH
-23 9h900-LZLbL W~SHER
II MSZOOOZ-L2C W*SHER I
2~ 530111 IPROCKET 1
26 MSZU066-183 KEY
-21 533022 EHIFT i
28 590162-2~ COVER 1
PIRTSI
29 1N530-BR6 SCREW 4

30 530432 CHPIN 4SSY

31 TURNBUCKLE BODY 2
32 500012 C~BLE I~IYI IILERON IStE FIG´• 2-iii REF
33 533063 COVER 1
(bTTICHING PIRTSI
31 bNj-32n DOLT
MSZ1~R)NS NUT I
---li---

2´•a88
 ILLVSTRATED
r´•ULFSTREAM P~RTS C~TALOO SECTION 1l
COMMANDER FLIGHT CONTROLS
(180A/BOOQ

P d R T UNITS USIBLE
FIGUHE
L INOEX O E I C R i P T I O N PER ON

N U 8 a E a 1 2 a I 5 6 7 assv CODE
*UMBII

)5 533032 PULLEI ~III´•´•´•´•´•´•´•+´•´•´•´•´•´•´• 1

P05X BE*RIWG (2133~) 1
36 5)0195 *NGLE´• SUPPO~T 1
(~rTICHIWG PLRTII
-31 NLIL)S-LL BOLI´•..´•´•.´•´•´•´•.´•´•´•´• i
IH9600516L ´•´•YLSHER 1R
IS2L0IIN5 NUT L
38 1NI-5* BOLT
1N9(OD1L6 YIIHER Z
---I---

.39 533032 PULLEI *SII.´•´•´•...´•.´•´•´•´•´•´• ´•´•´•´•´•´•1´•

1
(ITT*CR1NG P*ITS1
)0 **5-IS1 BOLT I
-)1 NLSI’I-I-O11 ´•´•´•BUSHIHb 1
IPZIO)~N) NUf I
---1---

PD5r BE*R1HG (213351 L

)Z 533010 SUPPORT IISI ´•´•´•´•´•´•´•´•´•´•´•´•´•´•I´•.´•.´•.´• L
n120101XP12L BELIING L

)3 530162.35 TUBE 1S5* L

1)8008‘~01 ~RI *IS1, LH
533008-502 *)I *III, Rn I

-)5 llS202001(PI ´•´•´•~EIRIH6 2

)6 NII)IIXI1 PIN I
630162-25 BOOT I
II~TICIIING PLRTII
-)B IH5)0‘6-l ICREY LB
---t---

)9 530161-27 PLlrE´• BOOT RETIINER 1

-50 )IHIII~ULOI CLINP 1
51 530162-1 (IEE Flb´•
OOUBLER 2-51) REF
090105 ELEYITOR rR111HITL. ELECTRIC REF
ii 1C610-1 IYITCH. ELEV*rOR TRI*. PILOT YHEEL I
IIL111)
(LTI*CHIN6 P*RTl)
1535206-205 SCREY I
---t---

53 llOLJS01P)1190-1 RELEIIE SYITCH r09)53) 1

Hevised: 28 November 1981 2´•289

 ILLUGTRPITED OULFSTREAM
COMMANdER
sr:cTroN n PPIRTS CP;TPILOO
PLIGHT CONTROLB
BgOA/GBOB

B /_

"1"’

~ipurs 2-4(. RYddsr Control Syrtal (She´•11 of 5)

2.270
 GULFSTREAM ILLUSTRATED
00NIMANDER PARTS CATALOG SECTION n
888A/BBOB FLIGHT COEPI~ROLS

~iGUlt P I R r UNITS UIPBLE

L INUtX O E S t R 1 P T I O N PER ON
~UMBER N U M i E R L 2 3 I 5 d I bSSI COUE

2-)6 53016L CONTIOL INSTL, FUIELLGE FLIGHT IEF

500012-535 C*BLE IIll, COIIPLETe L
1 500012-217 CIBLE 1SS1, LH I

2 500011-2)9 CIBLE 1II*´• RH I

s 500012.263 CI8LE *SS1, LH (FROH RUDDER PEOIL 1FT 1

TO TURNBIRREL LT IT1 33~´•001
500012-265 CIBLE 1SI*, RH (FRON RUDDER PED*L IFI L
TO TURNBIRREL 1T )’13´•001
IT*
5 500012-251 CIBLE LII*, LH lT
(FRON TURHBIRREL 1
lTI ~35´•00 1FT TO RUBBER 1(ORWI
6 500012-253 CI8LE 151*, RH (FRON TURHBIRREL *T 1
5T* 353´•00 *FT TO RUODEr( HOIIWI
1 1111251-61 TURNBUCILE 8001´•+´•´•´•´•´•´•´•´•´•´•´•´•´• 3

530065 8RLCKET I HITL. RUDOER CIBLE REF

B PULLE* Z
I*TTLCHIWC PIITI1
9 1H(-IO* BOLT 1
1N96DDll6 ´•´•UIIHER L

*I1LOIIH) NUT I

L~ NLP(27112 PIN, CIBLE 6UIRD

11 530065-16 Bs*CIET (LH OUTED L RH IHBO) 2

ii 530061‘11i BRICIET LLH INBD I RH OUTBOI 2

ii 530065-1 ´•´•IP*CER. LH I
ii 530065-8 PPLCER~ Rn L
(ITTICHING PLRTI)
.15 ~511019-0811 ´•´•ICREY´•.´•´•´•´•´•´•´•´•´•´• 9

IIS1IOIINOB N)T 3
---I---

530065-13 ´•´•IEE. LH I
-16
530065.11 TCE. RH I
530090 ~R*CIET INlTL. RUDDER CI5LE REF

II PULLE* ´•´•´•´•´•´•´•´•´•´•´•´•i´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•
(*lT*CnlNb P*RT51
is *N)-IDl BOLT ´•´•´•´•´•´•´•´•´•´•´•´•I´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•
I
INPLODII(I YISHER I
NsILDIIN) ´•´•MI~´•´•´•´•´•´•´•´•´•´•´•´•´•´• 1
---t---

19 PIN, C*BLE 6UIRD

20 530090-5 ~RICIEI´• LH LFT I
21 530090.6 BR*CIET´• LH FYD
530090-3 ´•´•BR*CIEr´• RH 1FT L
23 530090~) BR*CIEr´• RH FYD ´•´•´•´•´•I´•...´•´•´•´•´•´•´•´•´• I
(IrTICHINC PIRTS)
~2) IN3-I* ´•´•BOLT´•´•´•´•´•´•´•´•´•´•´•´•´•
*N960DID YISHER t
N1110(IN3 HUT 1´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•
L

51001)1 PEOIL INITL, RUDOER tUNTROL REF

25 *N3-5* 80Lr I)
*NPLODIOL YISHER 12

NSL101LL3 NUT ´•´•´•´•´•´•´•´•i´•´•+´•´• II

-26 5(0L23-1 PED*L ISSI´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•
(LTTICHIN6 PLRIII
27 BOLT (PEDIL ITTLCHNENT TO Lf HI: *IS*1 I
U*SHER I

za BOLT (PEDIL *TTICHNENT r0 HORN 1SS1I

Y*SHER ´•´•´•´•´•´•1´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´• 1
NUT
1)2 PIH, COTTER ´•´•´•´•´•´•I´•1´•´•´•´•´•´•´•´•,´•I´•´•´•´•´• 2
---I---

-29 BUIHING 2

-ao ´•´•´•BUSHIHG 2

Revised: 28 Nauember 19sl 2-211

 ILLUSTRATED
OULFGTREAM
BECTION II PARTS CATALOG COMMANDER
FLIGHT CONTROLI B(IOA/BgOg

:~4
n
d ,I
I C11

to

-I
a
i jL
J
ai 6

P,
Jl~il 35

ii
~r

~igurs 2-41. Rudder Control Sy~(en (Sheet of 5)

2.2121
 ILLUSTRATED
CIULFSTREAM
PARTS CATALOG SECTION II
COMMANDER
FLIGHT CO~PPROLB
ssaA/esoB

P IRT UNITS UII\BLE

~ltURt
0 E I C R I P T I O N PLII ON
INOtX
N U N B E R 1 2 i i 6 1 ~551 GOOF
NunsE n

IRN ISS11 BRLIE 1

2-)8 31 5)0010
(ITTlCHING PIRTI)
BOLT L
.32 *N3~L51
*H9b00L0L UISHER ´•...+´•.´•r´•´•.´•...´•´•I´•´•´•´•´•´•´•´•´•´•´•
L
N)T I
.5210((N3

´•´•´•BUIHLNC´•´•´•´•´•´•´•´•´• 2
3) .1511)-3~001
5)00LI 1RN ~Ill´• TORPUE TUBE, BI~IE I
(ITTICHIHG PLRTSI
BOLT 1
.35 1.3-151
W*SHER 1
IN96DD1OL
NUT L
---I---

.36 NL5l5-3-0D( BUSHING

Lr(n 1PII´• BRLIE IUBe´• CURVED 1
31 560012
(ITTLCHIY6 P1RTSI
LN3-IS1 BOLT L
.38
VllnEI´•´•+´•´•´•´•´•´•´•´•´•´• L
*NP60DIOL +´•´•´•´•´•´•´•´•1´•´•´•´•´•´•´•

WSI1O)~H) HUT .+´•.´•´•´•´•r´•´•´•´•..´•´•´•´•

1
---i~---

BUSHING L
~39
560013 LINI 1SS11 BSIKE WECHINISI
(ITTICnlNb PIRTS)
BOLT 1
1N~)‘15
INZ3-LP BOLT L
UISHER I
1H9600L0L
*H110.3 MIT 1
.S2)665-L32 PIW, COTTER I
---I---

NLS15-3-010 BUSHING
)ioOL*~50L r
1RN 1SS1, BRIIE *ECH*NIS*, RH 1

560026-501 1RH 1SSI, BRLIE NECRINISH, LH I

)5
(ITTICHINb PIRTS)
´•´•BOLT I
.16 LH2)-LS
II~IHEII I
1N9600I0
YLIHER L
LN~LODIOL
HUT 1
IU3Z0~3
PIN, COTTER 1

H1115~).00) ´•´•BUSHING ´•´•´•´•´•´•´•´•´•´•´•´•r´•´•´•´•´•´• 3

´•)I
-(B 79011’) V*LVEI POUER BRIIE (IEE Fld´• 2-111 REF
IN9600L)16L ´•´•U*IIIER 1
-(9
50 1(0001 HOUSING 6SS1, RUDDER BELRING 2
8108 BEIRING (60)801 I
51
.52 5(0005-1 BEIRING
5(0005-5 TUBE i
-53 ´•´•´•´•......´•I´•´•´•´•´•´•´• ´•´•´•´•´•´•´•r´•´•´•´•

5~ 5)000)-503 HORN lrSll RUDDER PEDIL

BUSHING Z
BELRING Z
5‘0302.191
55 5)000( HORN ~551´• RUDDER PEDIL
56 BELRINb ´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•1´•
1

~)0001-9 SPICER Z
.51
HOUSING 1651 Z
58 5)0006
B)DB I)EIPING (b03BD1 1
.59 5)000´•1-3 TUBE ´•...´•´•´•´•´•´•´•r.......

bO 8708 BELRINb 160380)

-)I LH1)-1L BOLT 1

1119600(16 II)ISHER L
NUT L
1N)20-)
PINI COTTER L

Revised: 28 November 1084 2-215

 ILLUSTRATED
OULFSTREAM
BECTION n PARTS CATALOD
COMMANDER
F1´•IGRT CONTROLS
BsDA/BOOB

I~

0\ I, 1 13

o?

"20’ 1 (1 lil

F O

I´• 113 1 33

’Y~
II:

rieurs 2-~8. Rudder Control Sy~tem ilheet 3 of 5)

1-3?4
ROCKWELL ILLUSTRP~TED
COMMANDER PARTS CATALOG SECTION 1l
BSOA/B FLIGHT CONTROLS

FIGUH~ P Y T
UNIT~ UIPBLE
L INUEY O E 5 C R I P i N PER ON
hUM8tH N U n E a 1 z 3 5 a 7 assu CODE

2-*8 530451 BRICIET INSTL´• RUDOER PEDPL. L~ C RH PET

IST1 99´•00)
02 ~52L5L6-3b PULLEY
t
1
IITTICHING P~RTS1
63 4NI-loii BOLT
nN960D~16 U*SHEK i
~SZLo*iN4 NUT I
---I---
tC N*S~Z7K10 PIN L
e5 530154-9 RRPCKET (LH UPPER L Hn LOWELI
~b 5)015~-4 snncrtr ILH LOWER B RH UPPER)
530’tiB-I BRICKET INSTL´• RUDDER PCOnL ISTII REF

~3011t-L BRICXET PSIY, LH i

530~L6-2 BRICntl *ISYI RH I
67 *521566-38 PULLEY 1
(*ITICHING PIRTSI
bA nN~-23n DOLT I
bY NbE4)DUI-lOo IP4CER I
4N960C)16L W*SHER I
)lP210B3NI NUT I

70 N1\541003-3) IPPCER 1
(ITTdCHING P4KTSI
71 nsZ7039-L-13 SCREk I
MSZ1083N3 NUT 1

IZ 530)17-L BR4CKETI LH I
73 530~17-2 BRPCKtTI KH I
5302L1 PULLEY LNZTLI KUDOER IST* 21)´•58) REF
ii j30211-1s STLIP IRH ONLY) I
IdTT*CHING P4RTSI
-71 "112109)-1-11 SCREW p
In9bD-LOL **SHER 2
nSZ10*~NI NUT i
---1---
It ASL~Sbb-38 PULLEY LRH INSTL1 i
IITT*CHING P9RTS)
7~ ~N4-Lbb BOLT I
76 NIS13DO*-~3 SPPCER I
INYIODSI~ WISHtR i
*SZLOI~NI NUT

7~ NS2’t)66-)8 PULLEY ILH INSTL) I

IPTTICHING P*RTSI
80 4N~-IOn BOLT
nN960-41~L WbZHtR 1
PN960D)1~ rl*IHEP I
MSL10~*N4 NUT 1

8L N~S427K10 PINI CdBLE GU*RO ILH INSTLI 1

82 PINI CIBLE SUIRD (Rn INSIL) I
83 530221-3 Ln I
8) )30221-~ 9NGLE, RH I
85 530221-9 CHPNNtL, LH (SEE FIG´• Z-iel REF
86 530221-11 CHPNNELI RH ISEE FIG´• REF
))0lR7 ~R*tKET INSILI RUI)OER PULLEY, LH L Rn REF
ISTP 211.001
87 n5245L6-38 PULLEY I
I~TT*CHING PPRTSI
88 1N4-10P BOLT I
I\NP6ODIL6 WIIIHEH 1
NUT

2-215
 ILLUFTRATED
PARTB CATALOG COMMANDER
FLICIHT esoA/e

1I~

:’B
B
as´•
g

_P
i101

P
101

~igure 2´•48. Rudder Control Syrtam (Shset 4 of 5)

a-218
ROCKWELL
ItLVSTRATED
COMMANDER PARTS CATALOG SECTION II
6801\/8 FLIGHT CONTROLS

FIGUKF P b R T UNITI US*RLE

L INDEX O E 5 C R 1 P T I O N PER ON
NUnaEK N U M B E R L 2 3 11 6 I bSSY CODE

I-~B 89 Plhl. CaaLt GU~RD 2

’10 530187-3 BRI\CKET, LY OUTED I
530167-’1 aRICKET, KH OUTED 1
PL 5301R7-L5 BRICKEII Ln INBO I
510187-6 DKPCKETI RH INBD 1
)30132 BR4CIE~ INZTLI RUOOtK, LH 6 R* ISTP RtF
272´•001
TZ MS2*5hi-38 PULLEY
IbTTICHING P4RTSI
43 *N*-LIII BOLT I
4N9~00116 W4IHER
YSLL04*NI iUUT 1

94 NPSI2TKII PINI CIBLE GU*RO 1

95 53D1ZU-i GUISET, LH
530120-2 GUIStTI Rl i
96 530132-3 WRIPOERI LH I
530132-4 URITPEHI R~ 1
17 530132-5 BRICLtll LH
530132-6 dR4CLEII Kn I
TB 530132-1 GUISETI CH 1
j33132-8 jUSSET´• RH 1
530131 LRbCKET INSTL´• RUDDERI LH L RH ISTb REF
290001
99 YS2~56h-IB PULLEY I
I4TTICHING "ilPTSI
-100 dN4- LLI\ BOLT 1
4N9~00416 *liHEfi 2
NUT L

-LOI N*SIZI~LL PINI C*BLE GU*RO 1

-LO~ )30137-5 RRICKETI LH I
530137-h BK*CLLT, RH
-103 530137-3 8R4CKt~i LH I
RRICKLT. KH i
I*TTICHING ’~RTi)
-iUS nSZ7039-1-1n SC*EW I
dNPLODLO WblHER
"1i2104IN9 ´•+NUT´•´•´•´•´•´•´•´•´•´•´•´•´•´• L

430112 BRI\CKET LN ITL, RUDDER t LH C RH ISTI\ RFF

JBb´•BZI
-105 NSL1566-3U PULLEY L
IbTT4CHING PPRTSI
-LOb ilN*-ILn BOLT 1
4N9L00~16 *ISHER 2
MSLLOILN4 NUT 1
---I---
-107 NIS~ZIK11 PINI CI\BLE GUIRD L
-LOB 5d0112-31 *NGLE, LH OUTED L
530L12-36 *NGLE, RH OUTED i
-101 530112-37 ´•´•~NGLEI LH INBD L
130112-3(1 *NGLEI RH INBO I
530102 BR4CKET INSTL, RUDDER PULLEY, LH C RH RFF
(STb 109. OUI
-110 MiZ1566-3R PULLEY 1
I~TIPCHING PIRTSL
-LLI BOLT I
*N4L00116 WIISHtH 1
)1521053NI HUT 1
----I----

a-211
 ILLUBTRATED
ROCKWELL
SECTION n PARTS CATALOG COMMANDER
FLIQHT CONTROLS
BO(IA/B

~ur

113

II~

Pigura 1-~B. Rudder Control Sytfs. (Sheet 5 of 5)

a-a18
 ILLUSTRATED
GULFSTREAM
PARTS CATALOG SECTION n
COMMANDER
FLIGHT CONTROLS
BOOA/BO(IB

FIGURE PIR T UNITS USIBLE

L INDEX D E I C II P r i O N PER OH
NUnsER N U II B E R 12 3 5 b 7 *SSI CODE

i-60 -112 NISIZI~L2 PIN´• CIBLE GU*RD 1

-LI) ~)OLOL-I BILCIET´• LH 1
530102-8 BR*CXEr, Rn L
530101-5 BRICXET, LH ´•´•´•´•´•´•´•´•´•I´•´•´•´•´•´•´•´•´•´•´•´•´•.. L
130102-6 BIICIET, RH L
-L15 530L02-3 BRICIET. LH ´•´•´•´•´•´•´•´•´•´•i´•´•´•´•´•´•´•´•´•´•´•´•.´• 1
5)0102~* BRICIET´• RH 1
11007)-503 HORN IlSl, RUDDER (SEE FIC´• )-621 REF
530103 ST~P INITL, RUDDER ´•´•´•´•´•,´•´•´•´•´•´•´•´•´•r´•´•´•´• IEF
-LII NO NUNBER STOP 1SS* ´•´•´•´•.´•´•´•1´•´•´•´•´•´•´•´•´•´• 1
-L1B 530067 STOP BOLT ´•´•´•´•´•´•´•´•I´•´•´•´•.´•´•´•´•´•´•.´•...´•´• Z
IN)lb´•~R CHECIH)I´•´•...´•..´•´•
LN9600)16 YISHER 2
-119 i BOLT i
1Hs6~D51L V*IHER
NUT
PIN, CLITTER Z

Rsvised: 28 November 1984 a~218

 ILLUBTRATED
SECTION n OULFBTREAM
FLIGHT CONTROLS PARTS CATALOG COMMANDER
BgOA/BOOB

M
i
L
i
IBr L

6. \-~Y K

O
F
C1
B D

rieu~s 1-49. Rudder end ilevs,or Trim T~b Syllemr (Sheef 1 or 51

a-aso
CIULFSTREAM ILLUSTRATED SECTION II
COMMANDER PARTS CATALOG FLIGIFI~ CONTROLS
BOOA/BgOB

,,~I,I
"ii
i1
9

II~

2 of
ligure 2-49. Rudder ond IIev.tor Trim T.b Control Sytleml(lhasf 5/
2-281
 ILLUSTRATED
OULFBTREAM
SECTION n PARTS CATALOG
COMMANDER
FLIOAT CONTROLI
BOOA/BOOB

FIGURE P b R T UNITS UZIIHLE

L INOtX D E 5 C R I P 1 I O N PER UN
NUMBER N U 8 B E R 2 3 C I d I ~ISY COUE

1-I9- 530L89 CONTROLS INITL. RUDDER C ELEV TRI~ T*BS. REF

500011´•101 CIBLE *SSI, COnPLETE ´•´•.´•´•,,´•.1´•´•´•.´•´•´•´• L 1
CLBLE )ISSI, CO*PLETE L BE
1 ’500011-71 CIBLE IISI. RUDDER TRln IFRIII CHIIN 1 I
ISII *T ST1 39)´•00 FYD TO ORUII
lr ITI (9´•00 C *FT TO CHIIN
ISII
*T STI 39)´•001
1* 500012-283 ~*BLE 1PII, RUDDER TRIW IfROII I BE
TURNBIRREL lT Sri 231´•b5 FWD
TO ORUI 6 *FT TO TURNBIRREL *r
511 131´•65)
is 500011-)85 CLBLE LSI*l RUDDER TRln (FRO* L BE
TURNB*RREL IT ST1 ~31´•65 1FT
rO Cn*IN ISI* *T 516 391´•00)
LC ´•10001P-ZBI CIBLE *IS*1 RUDDER TRI* IFR[I* ´•´•´•1´•´•. L BE
IURNB*RREL IT ITI 231´•Lr LFT
TO CHIIN *SS* IT STL 39)´•001
1 100011-69 C*BLE LSI*. ELEVlrOR TRII IPROIl L
TURNBIRREL IT ST1 293´•00 FYD
TO DRUI( *T STI )8´•00 L *FT TO
TURNBIRREL IT ST1 291´•00)
3 500012-73 CIBLE 1111. ELEVLrOR TRlN IDUILI I
IFRON TURNBIRREL *T ITL 291´•00
IFT TO CHIIH ISI* CLBLE 1SS1
1LSD DIVIDES L EXTENDS TO
TVRHB*RREL *T ITI 13b´•D01
50DOL2-ll CIBLE LSSI, ELEVITOR TRII( (FRO* L
TURNBIRREL *T IT* 316´•00 *FT
rO CH*LH
*S1*I
5 500012-75 CIBLEIISI, ELEYITOR TRI~ IDUILI L
IFROW TURNB*RREL lT 111293´•00
LFT TO LH Rn cn*IN ISS*Sl
6 WSZ1151-B25 TURNBVCILE 8001 (SEE NOTE BELOW) IR
’130L89~3 CONTROL IISI. RUDDER I ELEY Tr(ll( T1BI 1
530071 CONTROL ISS*, RUDDER TRII TliB L
7 530077-505 UHEEL, RUDDER rllIl 718 I
B NS1LB62-223 ´•´•´•PIN. ROLL
9 NS16161-11( PIN´• ROLL L
10 530081 GELR Z
11 530011 DRUN 1´•+´•´•´•´•´•´•´•´•.´•´•...´•..´•´•´•´•´•´•´•´•´•´• L
12 130011-1 SHIFT (~´•Sb-INCHES LONGI 1
13 530011-5 SHIFT (3´•30-INEHES LDNGI 1
1( 530013 HOUSING *SSI´• RUDDER TII* TIE 1
-15 NSL0201KP6* ´•´•´•BE*RIHG
5)0012-503 CONTROL *551´• ELEY*TOR TRln TLBS I
(ITTICHINb PIRTII
16 INS-II BOLT Z
1HPb0D10 ´•´•ULIHER 2
NSlI()IINs I NUT L
---t---
17 530077-50L YHEEL. CONTROL, ELEV T)I)I T*BS I
176 nSL6562-Li9 PIN, ROLL
-ls WIlb)62-223 ´•´•´•PlnlRDLL´•´•´•´•1´•´•´•
-19 530088-501 OE*R 1´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´• L
ZO 530089-501 ´•.6EIR...´•´•´•.´•´•´•´•´•´• I
-21 5)0015 ´•´•´•DRUI´•´•´•´•´•+1´•´•´•´•´• ´•´•´•´•I.´•´•´•´•´•´•´•´•´•´•´•´• L
22 530072-L5 SHIFT, LE*R I)´•13-INCHES LONG) 1
23 530072-5 SHIFT, DRUn (L´•BB-INCHES LONG) L
Z) NLJIIHTL~B SPICER 5
53007) R(IUIING IS~*, ELEVITOR TRIH T1B I

CODE EFFECTIVE ON SERIIL NUIBERS

1 6906 lllDO THRU LLIBI
B 6901 llZBZ THRU 113)9
E 6908 11)50 1ND SUBI

11011

Part Number 510038-507 may be installed in lieu

ol MSa1251-BIS to properly rig cables.

2.281 Reuisecl: 28 November 1984

ROCKWELL ILLUSTRATED
COMMANDER CATALOG
BSOA/B
PARTS sECTIDN n
FLIGHT

~3 c

31
C3
i. ~-ii

nf~,32
"´•I´•
34

21

´•21" 1 I, II,

1:
d a

li1 gBa
/n .I?

"I o

´•~´•I

FI lo

i z
v ‘g

r
Is

i
Y
y

rieure ?-XP. Rudder.nd ~(ev.lor Trim Tob Control Syrteml (Sheet 3 of 5)

2-a83
 ItLUSTAATED
ROCKWELL
SECTION n PARTB CATALOG COMMANDER
FLMjHT CONTROLS B8OA/B

FIGUHF P 4 2 T UNITS USIRLE

L INU~Y D t 5 C R P T I O N PEU UN
NUE(BLY N U W B C R 1 2 1* 5 6 1 1SII COOL

2-49- 26 MIZ(IIOIKPLII UE~RLNi

13;)080 SP~OL nSSY ISTI\ 59´•001
11 539080-5 SPUOL 2
I~TTbCnlNG PIRTSI
15 SCREW L
NnS43U33-95 1P4LEK i
IIN96011ILbL
INYb0DL0L
HSZLOIIN1 NVT

30 NnS427K26 PIN I
51 530CDO-I BKICKEI
530113 PULLEY i)SSYI CIBLE CONTRUL IIT* 01.001 2
UZ21560-iB PULLEY 2
IITTnCHING PIRT)I
33 ~N3-LSd BOLT 1
3’* ~PS43D33-37 SP4CEK L
bhY60DLO WdZHCK 1
MSZIOI~N) NUT I
---I---

35 N1S4Z11ZO PIN
~6 510193-3 BHICKET I
130192-103 PULLcl rlSSY ISTb IZb.001 1711.0~
20~´•1101
31 MS2~5Lb-LB PULLEY
IIITLCHING PIRTSI
3C nN3-114 llOLT ´•1´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•.´•......... L
1N1~001D WPSHER i
MS2Ln41N9 NUI 1
---I---

39 NIS417KII PIN L
)0 130192-5 B~LCKET ´•´•´•.r..........´•............. L
C1 533LD9-Z1 SE*L´• TEFLON 15iP 1711. 001 2
C1 530159-19 SHln, PHENULIC ISrl LI~´•001 2
43 510109-31 CLI D ISTP L 711´•001 I
IITTI\CHINO PIHTS1
MS35207-2L~ SCRLW 2
*N960-LOL WIISHEK

530192-501 PULLEY dSSY IST* L35´•ool

~5 M124566-1U PULLEY r´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•...... 2
I~TTIICHING PORTSI
~L I\N3-IIP ’iOLT 1
nNPbODIO *PSHEI L
MS2i044N3 NUI
---I---

17 NnS4L7Kll PIN i
’IR 5 30 192-3 52 nCKET
530117 BR*CKLT INSILI TRI* Tna PULLEY 1STb PFF
2S’1´•0~1
ly n224j66-1R PULLEY
I4ITICHING PIHTSI
50 bN~-llb BOLT L
1N9600LO WbSHER 1
M12LO’tIN3 HUT I

51 N1S427Kll PIN ´•´•I´•.´•´•´•´•´•´•´•´•´•´•´•´•´•.´•.´•...........

52 510117-3 BKLC~ETI LH L
530LL7-4 nR4CKtT, RH
130118 BRPCKET INSTL~ LH L Kn I~T1 2721001 i
53 NSZ41hb-IB PULLEY 2
IITTPCHING PIRTS)
51 i\N3-iiP BOLT i
4N960D1o W4SHER 1
nl2L044N) NUT

P.284
ROCKWELL rLLVSTRATED
COMMANDER PARTS
BgOA/B
CATALOG SECTION n
FLIGHT CONTROLEI

:8~ J

so

~e
1;(1 ’r.´•1
a
i:
i~´• a

K L

L´•8
B?

Lpd
Q

BJ 81
’2 "1
21’

~11

figure 2-49. Rudder ond ilevolor Trim T.b Conlrol Sylteml(lheet 4 of 5)

a-a85
 ILLUGTRATED
ROCKWELL
SECTION n PARfS CATALOG COMMANDER
FLIGHT CONTROLS BBOA/B

FIOUHE P 4 n r UNITS US4BLC

L INDEX D E S K I P T I U N PLR ON
NUIIIIER N U M B L R L i 3 1 5 6 1 *ISY CODE

2-49 55 N4I427l(11 PIN I

56 5)0118-3 BRbt~ET1 LH L
530118-* BH4CKETI aH r..... L
530259 BKICKET 4TSY 4NU INSTLI TKIM CONTROL 1
ISTb 308´•00)
5302)9-13 ORdCIET nSSY1 Ln 1
57 PULLEY Z
58 4N3-L14 BOLT ´•´•´•´•´•´•´•´•´•´•´•r´•´•´•´•´•´•´• Z
4h960-LOL WdSnER 2
YSZL04CN3 NUT ´•´•´•´•.1´•´•´•1´•´•´•´•´•´•´•´•´•´•´•´•-+´•.´•.... i
59 5l0259-9 jU4RDI C48LE L
I*TT4CHING P*HTSI
60 MSZ1019-08o5 ICRE* L
4N960-L0L ...~*IHER
NSZL012-08 IUT L
---i(---

bl 530259-5 BR~CKETI LH
530259-11 BR*tKET 4SSY1 RH I
bP nS2~56b-18 PULLEY r i 2
IblTICHING PIRTSI
63 *~3-14P BOLT
-64 Nlif130D3-LI IPI\CLR 1
nN9b0-1DL W*SHEH L
YSZLO*4N3 NUT L
---t---

0~ 530259-7 GUIADI C4BLE I

I4TT4CHING P4RT51
66 n127039-0805 SCREW 1
4NP6O-L0L W4BHER
MSZIO)I-08 NUT ´•......´•.´•..´•.´•´•r´•.....´•....... I
---I---

61 530259-9 BRbtKEI PSIY´• RH

310021 FR~NE 1\6 SI ISTP 326.00 1 RtF
68 530083 BKICKET
b9 MSZ15LL-LB PULLtY ´•´•´•´•´•´•´•´•´•´•´•......1.............. 3
IPTT*CHING P4RTSI
70 *N3-106 BOLT ´•´•´•´•´•´•´•´•´•´•r´•´•´•´•´•´•+´•´•+´•´•-´•´•´•´•-´•´•´•´•´• L
71 NI\E13DD3-19 IPI\CER IHH INSTL ONLII L
4N960-10 W4IHER ILH INI‘TL ONLYI I
4NPO0-LOL W4SHER I
MSZ10I*NI NUT

12 N4SSZ7KII PLN Z
310022 FH4NE 4SSY IST* 3*61001 REF
13 590003 8R4CKET ´•´•r´•´•´•´•´•+´•´•´•´•´•´•´•´•´•´•.´•........ 1
1* n214566-18 PULLEY I
I*TTICHINO PdRTSI
75 4N9-IOP BOLT L C
nN)-i*b BOLT L DE
76 NnS4~DD3-19 IPICEP L C
SPI~ER 1 Dr
nN960-10L WISHEH 1 C
4N960-10 Y*SH~R 3 DE
H12LO*eN3 NUT i

17 NPS4ZIK11 PIN I C
hlliS~Z7T20 PIN L Or

CODE EFFECTIYE ON SEHI*L NUHEERS

C 6001 L1100 THRU 11286
O 6904 11287 THRU LL319
F 6908 11)50 4ND SUBS

2-288
ROCKWELL
ILLVSTRATED
COMMANDER PARTS CATALOG SECTION n
690A/B FLIGHT CONTROLS

ol 91 ~ol ii
103

?-ia~

´•r

figure 2-~9. Rudder ond Elsvolor Trim Tob Control Syltemr (Iheet 5 ol 5)

2-a87
 ILLUSTRATED
ROCKWELL
SECTION II PARTS CATALOG COMMANDER
FLIGHT 6901\/8

FIGUKE P (I H T UNITS USIBLE

E INOEX D E 5 C 4 1 P T I O N PFK DN
NUMBER N U M B E R i Z 1 1 6 7 liSY CODE

2-49 7t 130189-23 F*IRLE*D ´•´•´•´•´•´•´•´•.´•..........1......... 1

I*TTdCHINC ’PRISI
79 XIZ7039~1-09 SIREW ...1............................. 1
1N~b0010 k*SHiP I
NUT 1

’10023 FllnnE I5SY1 FUSELIIGE (ZTn REF

80 530083 BRICKET 3
81 HSZI5L6-LO PULLEY
(~TT*CnlNG P4RTZI
82 1N)-lOb BULT I
a3 n1513003-19 SP4CER IrOR IINGLE PULLEY INSTL)
nNV60-LO Wb~nER (FOH OUIL PULLEY IN~TLI
1N96D-LOL WbPntl (FOa JUI\L PULLEY INSTL) i
nSZ1011N3 NUT ´•´•´•r´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•.´•´•´•´•.´•´•.... L

81 YIS~27Kll PIN .´•.´•r......r...........´•1..´•´•´•..... Z

31COZ~ FHII*IE I\Z SY (STI\ 386.00 I REF
85 53008* BRICKET 2
d6 nZZ)5~b-LB PULLEY
IITTICHING PIRTII
87 PN3~13n BOLT I
d8 NPS~3003-21 IPICER
IN’~OPLOL HnSHER I
ni~1014N9 NUT 1

89 N45427KL1 PIN ´•´•´•´•´•´•´•´•´•´•..1...................... 2

ZjlSn LHdlNI RULLER, RUDOER TRIM 116l i
PITCHESI 17313P)
91 ilNjl s-rRA SCRE W´• RUOOEI TRIM srnp i
PNPLO-IL WIPHtR
MSZ1OIINOI NUT 2
PZ 2765Y-01 1HLFT´• FLEXI RUDDER TRIM I~1-INCHEII I
1693011
43 2759 H*SHER (653311 PP
9~ 3616Y TPROCKET niSY 1693011 L
95 530189‘29 BRICKET L
96 n~2115LBZS TURNBUCKLE BUOY ´•´•´•´•´•´•´•´•´•r´•´•´•´•´•´•´•´•´•´•´•´•´•

57 MSZ1~54-ZLS EYE´• TURNBUCKLE 2

98 2515ei CH*INI ROLLER~ ELEY TRIM (LC7 PITtHtSI Z
173*331
L)9 Z165Y-oP THPFT, FLEXI ELCYITOR TRIM I)O-INCHESI P
1653011
-100 2789 wnsnEn (6sjaii an
-101 csssv SPROCKEI *SSY 16~3011 2
-102 530189-21 (HINNEL, Ln
-103 5)3189-28 CHbN~ti, RH 1
IITT*CHING PIRTSI
-104 PN3-** BOLT 2
nN9600LOL IPIHER 2
NUT Z
---I---

-LO~ *135~0b-ZLI TRIM STDP

IN960~*L klSHER
M5ZLJ~4N01 NUT ´•´•´•.´•´•.1´•´•.´•.´•.´•´•´•´•.´•´•............. 4
-IOb 530189-)1 BR4CKETI LH 1
-101 530189-32 BK~CKETI RH ´•´•´•´•´•r´•.....´•..´•....´•...... 1
-108 530189-25 GUIHD. CH*IN 2

2-288
ROCKWELL
ILLUSTRATED
COMMANDER PARTS CATALOG SECTION n
680A/B FUSELAGE

it 5
69 10
32
II
12
1J

3 15

II
a

2521

,a

30o‘
,,J’ F
‘1-~o’P
s~
i

I% 31 31

X,B
21
-1, 12

52
80

15;

figure 2-50. Pl~ting Complsts

2´•288
 ILLUSTRATED
ROCKWELL
8ECTION II PARTS CATALDO COMMANDER
BUSELAOE 880AjB

FIGUHE P R i UNITS US*RLE

L INDEY O E r C R 1 P T I O k PFR UN
LUMBER N UM B E R L 2 i 5 6 1 nSSY COOL

)-50 300001 FUS6LIGE bESI, COMPLETE L

3LO~’t’t RbDO’IE INSTL REF
i 3L0)**-15 NOSE CI\P L
(~TTPCHING PPRTII
MSP007~-D3-06 BOLT
nN960Cll6 **SHER 3

2 3L0414-5 CUYEH 3
IPTTdCH13G PIRTSI
151-10 STUD 1112661 1
513-1 WbSHER 1712861
5RZ-L R~CEPTPCLE 17LZBb~ L

3104LB PLITIN- LNITL. FUIELPGE REr

)10173 PLITING INSTLI EXTENDEU NUSt´• RLF
FUIELIOE
3 3LOL73-3 SKIN L
3LOL73-5 SKINI LH L
311113-27 SKINI RH i
B )L0L73-1l DOOR I Lil I
7 310113-18 J0DR1 Rn L
InTT*CHING PIRTII
MS2469)-I49 SCREW II
---I---

8 310L84-3 OUOHI LH
310181-’1 0001(1 KH L
IPTTbCHING PPRISI
MSZ469~-C*8 SCREH 22
---I----

LO 3101L8-139 SKIN ´•´•´•´•´•´•´•´•´•´•´•´•r´•´•´•´•´•´•´•´•´•´•.´•....... 1

11 310$18-151 SKIN I
1Z 3L041B-117 SKIN 1
13 310418-161 SKIN ´•´•1´•´•´•´•´•´•´•...................... I
-li 310)16-93 SKIN
15 J1073b-L09 SKIN 1
Id 3L04L8-L)9 SKIN I
17 310518-L73 SKIN IREPLICES 31041l-’t5I
18 3 IOliR-175 SKIN (RLPLI\C~S 31041 8-95 L L n
310118-L77 SKIN 1 BC
19 310118-11 SKIN 1
-ZO 3L0118~65 ´•´•IIINILH´•´•´•´•´•´•´• L
3LO418-L6 SKIN, Rn 1
21 110000‘*2 FILLET. LH .´•´•´•1´•.................... I
LL0000-43 FlLLET. RH I
21 110000-65 FILLEII Ln 1
L10000-bb FILLETI RH I
23 310418-63 SKIN I
-24 310416-117 ZK~N 1
25 310*18-159 SKIN I
ZL 310*L8-119 SKIN 1
-P~ 310’118-57 SKIN I
28 310418-157 SKIN I
29 310418-25 SKIN I
30 l10418-39 SKIN ´•´•r´•´•´•´•´•´•´•´•´•´•..´•................ I
31 110418-23 SKIN 1
52 110’118-85 DOOR. Ln I
33 310418-86 DOOR, RH i
IPTTPCHING P~RTII
SCREW 10
---I---

CUOE EFFECTIVE ON StRIIL NUMBERS

6901 11iO0 THRU 11268
B h90* 112bY THRU 11349
L 6908 11350 *NO SUBS

2´•a80
 ILLUBTRATED
oULFSTREAM
PPIRTS CL~TALOO sECTION n
OOMMANDER
FUSELAGE
680A/B80B

FIGUHE P 1 R T UNITS USbBLF

C INDEX D E 5 C R I D T I O N PER ON
NUnBEk hi U M B t 8 1 2 3 i 5 L 7 bSIY COO~

SKIN I
L~5(1-
310)18~103 ´•´•II(IH´•´•r´•´•´•´•´•´•´•´•´• 1
35
36 310(18-113 SKIN L
)IDILB~LI’I ´•´•IIIN´•´•´•´•´•´•´•´•.´•´•´•´• L
37
3L0(18-L79 t II(IH 1 BC
SI(IN 1 I
-38 310117.13 1´•´•´•´•´•´•´•´•´•´•´•´•

310(11-2~ ´•ISI(IN´•´•´•´•´•´•´•´•´•´•´•´• 1 BC
´•+51(1N´•´•´•´•´•´•´•´•´•´•´•´• I 1
-)9 3L0)17-23
310117-27 ´•+II(IN.´•´•´•´•´•´•´•´•´•´•´• L BC

310(18-1)5 SKIN 1
)0
-)1 310(18-1)3 IIIN 1
3L0(18-131 II(IN ´•´•´•´•´•´•´•´•´•´•1´•´• 1
.*2
110151 FILLET lllSrl1 YIN6 aEF

´•3 1IP1SL-)1 FILLETI LH I

110151-)2 FILLET, RH 1
FILLETI LH ´•..´•´•´•´•´•´•´•,´•i´•´•´•´•´•´• I
110151-33
FILLET, an 1
FILLET, LH 1
i5
FILLET, RH 1

-)b II0ISI-ZI FILLET. LH 1

110151-28 FILLET´• an I
-)7 LLOlll-7 FILLET, LH r´•´•´•´•.´•..´•´•´•´•´•´•´•´•´•´•
I
llOL51-8 FILLET, RH 1
310111)-1)0 SKIN 1
~B
SKIN 1
-~9 )10118.151
50 310)18-153 SK rn I
310118-163 SKIN I
-51
´•´•II(IN..´•´•´•´•´•´•´•´•.. 1
.SL 310)18-150
-53 31073L´•LIO IKIH
310(18-11) IIIN (REPLLCES 310618-)6) ´•´•´•1´•´•...´•´• L
5.
310(18-171 SIIN IREPL*CES 31(I~L11-Lll t
IS
310118-)1: 91(IN I
.56
SIIN L
-57 310)18.1~ ´•´•´•´•´•´•´•1´•´•´•´•´•´•´•´•´•´•´•

SI(IN L
-58 310)18-(0 ´•´•´•´•r´•´•´•´•´•.´•´•´•.´•´•´•´• ´•´•´•´•´•´•´•´•I´•´•´•´•

310(18-26 SKIN 1
310)18-115 SKIN 1
60
61 jioiis-sa S~IN I
310159-11 DIIUBLER ´•´•´•´•´•´•r´•´•´•´•.´•.´•´•´•´•´• L
-611
DOOR INITL´• FUIELL6E ICCESI´•´•´•´•´•´•I´•´• REF
330001
)30001-1) DOOR´• LH L
62
jjooo~-l, DOOR´• RH L
IITTICHING PIRTSI
´•´•SCREU 9
.63

CONE INOTL, T*tL aEF

3100)2
310052-15 CONE LSS* IREPL*CES 3101)6-3) 1
6)
(IrTICHING P1ITII
1127039.0808 ICREY 22
-6~

66 FILLET´• Rn
FILLET, LH L
110000-62
SCOOP INSTL. RLI IIR FLUSH (SEE Flb´• REF
67 88021)
2-681
DOOR 1ND DOUBLER ISSI, UPPER 1
310183-1
310183-5 0008 1
68
STUD (’llL86) 30
(ODZ-J
GROI1(ET 111186) r´• 30
RECEPTICLE (11PBb) )O
ZI).L.CD
(EIL I
310183-1

CODE EFFECTIVE ON SERIIL NUNBERS

1 690* 11100 TMRU 11168
B 6901 11259 TnlU 11)~9
C 6908 11310 IHD SUBS

Hevissd: 28 November 1984 2-281

 ILLUSTRP;TED OULFS’I~EAM
COMMANDER
BECTION n PARTS CATALOG
680A/B808
FUSELAGE

C
A

-c,s
i’
to

i I1IIII I:l´•U- I

41
a,
20 33,´•
ci

i 3179
21 29

i I
11 23

C
is u

42 L~PII I ii II I II i1

Y~nrI I i i ii I I I i II I o

I,
~ieurs 2-51. Pu~eloge Slrurture Alrembly Note isheel 1 ol 4)

a-asa
ROCKWELL ILLUSTRATED
COMMANDER PARTS CATALOG 8ECTION II
890A/B FU8ELAOE

FIGURE 9 R T UNITS USIBLE

C INDLX O E S C R i P T I O N PER UN
LUHBEH N Vi M 8 E R 12 3 i 5 6 7 *SSI CODE

z-51 3oop01 FUSELIGE *ISY, COMPLETE L

3L0)83 STRUCTURE IZSSIt FUSELIGE L
310112-511 STRUCTURE bSSYI EXTENOEO NOSE L
310111-1 FRIME 4SSY, FUSELIGE NUSE IST1\
-0’19´•151
i ,1olsz-s INGLE t
31018Z-L3 FRIME I
3 3ialR2-’ DOUBLER, LH L
,ioUsr-s DOUBLER. nH 1
310482-9 DOUBLER, UPPER CENTEe 1
IloU"s-l NOSE BEIM nSSI´• FUSELIGEI RH L
310485-39 HINGE H*LF, FWU
5 310485-25 HINGE HaiF, aFT
PIU485-7 4NGLE, LOWER I
r )I04J5-5 *NGLEI UPPER i
8 31oqe5-9 4NGLE 1
310485-11 *NGLE L
io 31oqa5-I3 4NGLE I
11 3101/84-33 PNGLE I
Il 3L0485-L5 CHINNEL ´•´•´•´•´•´•r´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•... I
IPTTICHlNG PIRTLI
BOLT 10
Lb WISHER 10
NSZLOILN* NUT lo

1, 31011115-21 CHPNNEL I
II 3LO185-19 INGLE I
15 31P1~5-31 STIFFENER 1
ia 3101~5-35 STIFFENER I
17 310185-31 INGLE
18 310185-11 CH*NNEL 1
iY 110185-3 WtB 1
20 15UOP3 BEnPING bSSI. NOSE GEIR STRUT 2
(ITT*CHING P*RTSI
BOLT 4
WISHER I
*lSilP83NI NUT

9 loop*-so, SUPPORT INITLI NOSE GEIIR ORI\G LINK REF

zi ,100a4-3, UOUBLER 2
I4TTbCHING P*RTI)
22 nszlpsa-o4oos BOLT
Yszopozce WISHER IUNDER BOLT HEIIO)
lid WISHER j
r NUT 3

23 S-olaa-1z1s ....8EanINe 2
ze 31a0p*-4i CH*NNEL. UPPER 1
25 3ioo)i-iz CHnNNELI LOWER I
IPTTnCnlNi PPKTi~
za bN3-F* BOLT 2
OL WISHER 2
IS21(*~N3 NUT 2

21 ,ioo~? FITTING 1
(ITTbC~ING P4RTS)
28 nNr-6n BOLT 6
Id WISHER 6
MS2L(’t*Ni NUT

zs ,iaol*-*? COYtK I

a-285
 ILLUSTRATED
ROCKWELL
SECTION U PARTS CATALOO COMMANDER
FU~WLOE 888A/B

Lhl

j
R;

1" ~5

I´•iaure 2-51. ilrurlure *rtembly Nora Se.lion (Shee~ of 4)

2-a84
ROCKWELL ILLUSTRATED
COMMANDER PARTS CATALOG SECTICh(n
BOOA/B
FUSELAGE

FIGURE Ph T
UNITS US48LE
L IN~rX
D E S C R 1 P U N rEH ON
NUMBEL N U M B E R i 2 j 1 5 b r ~SSY CODE

2-5L JO 31005L-25 Cn~NNEL I

IdTT*CHING P~RTS)
31 nNr-5* BOLT 2
4N96o-*16 W*IHFR ´•´•´•´•´•´•´•´•´•´•"´•f ´•´•"´•´•´•´•"1´•
MIZIO*~N4 NUT 2

32 3100i’t-37 CLIP
1
IPTT*CHINS PbRTS)
J3 *NI-~P BOLT g
HdSHER
NSZIO~IN9 NUT i

J’t 31005’1-39 SUPPORT ´•´•´•´•´•´•´•´•1´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•t 1

IITTeCHING PPRTSI
35 1N3-64 BOLT
IN?LODL0 W~SHER L
NSi13~1N3 NUT i
----li---
310186-1 NOSE BE4N bSSY´• FUSELIGEI iH I
id 310L8L-35 HINGE HILF´• PW~ L
)7 310186-25 HINGE H4LFI bFT I
38 ~iOLBb-7
INGLEI LO*ER ´•´•~´•´•´•´•´•´•1´•´•´•´•´•´•´•´•´•+ I
31 310186-53 *NGLC´• UPPER i
I0 3LO1B1-31 *NGLE ´•´•~´•´•´•´•´•´•1´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´• L
II 3101R6-L5 CHINNtL 1
I4ITdCHING P*RTS)
dNI-5n BOLT LO
4h9600116 WISHER LO
nS2L014NC NUT 10
---I---
42 310186-21 PNGLE ´•´•-´•´•f I
13 510186-13 ITIFFENFK
310186-19 PNGLE ´•´•´•´•´•´•´•´•1´•´•´•´•´•´•´•´•+´•´•´•´•´•´•´•´•´• i
15 310L86-33 ITIFFtNER L
’6 3Lo1s6-29 INGLE I
17 310186-51 CnANNEL 1
is 31U18L-1l ~NGLt i
19 3 10186-9 ~NGLE I
50 310186-9 *tB
51 BIOITP-L FRbML, UPPER IST4 -029.001 1
52 310178-501 FR*nEI UPPER ISTI -OL6.5ol L
3LOITI-L FRIHE nSSYI UPPER IST* -0oL.001
53 310114-3 FR*nE, UPPER I
)C 310661-L ITIFFENER i
310181-505 UECK PSSY. UPPER L d
310181-507 JECK bSSY´• UPPER 1 E
3LOL91-501 SUPPORT nSSY´• BELLCLdNK i
55 310191-13 COYER
IITTICHING P4RIS)
56 ~521039-1-09 SCREW I)
nN9600LO HISnER IS
---I---
57 310191-1l 1 COYER I
58 310191-3 BRICK~T, LH 1
310191-~ OR*CKETI RH L
59 3101RL-45 4NGLE L
bO 3L0181-*9 bNGLEI LH i
61 310181-50 ~NGLEI Rn L
62 310181-31 SEIL
I
I*TTPCHIN~ PPRTS)
63 nN530-6-6 SCREW
---il---

CODE EF~ECTIYE ON SERI*I NUHBEIIS

6904 L1100 THRU 1IZbS
t ~90* G 6908 L126Y 4NO SUBS

a-a85
 ILLUBTRATED ROCKWELL
SECTION n PARTS CATALOG COMMANDER
FU~LAOE aaoA/s

?1 103

o il’ar RI iii M

~igur. 1-51. fulalo(ls i\.lembly Nora Se~tion (Sheet 3 ~f 4)

1-388
(IULFB~REAM I ILLUSTRATED
COMMANDER I I
PARTS CATALOG BECTI(W n.
sQOA/sooe 1 FUSELAGE

fltURl P:*RT UNITS USIBLE

C INDEX i D E 5 E R I P T I O N PER ON

N U n a E a I a, s 6 1 ISSr cool
NUI1BER

6~ 31 -35 BR*CIETI LH L
2~)L-
-65 31 -)6 BRICIET, RH L
66 31 ~21 CH*NNEL 1

.67 31 -33 CH*NNEL ´•´•´•I´•´•.......´•´•´•´•´•´• 1

68 )L -39 CH*HNEL I
69 1e BR*CIEr ´•I´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•
1
´•LI BUSHING (INETLLLI 1N -19 BRlrl 2

70 1‘89 Cn*NNEL´• LH I
)I CHINNEL. RH I
II cWER 1
(*TTICHI*G PIRTS)
1-08 SCREY 5
O YIIHER I

-72 3LOd~PI OoUBLER L

I, Ilodsi-91 DEER ´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•r´•
1 1
OECX 1 E
3101jai-sol BRIEl(ET ISSr, LONER OECI (RH ONLI) 1
(~TTICHING PIRTSI
BOLT I
WISHER I

31018)-9 BRLCIET 1
-75 310480-1 ´•´•FRLIE, LONER, LH 1
16 FRINEI LONER, RH ´•´•´•1´•´•´•´•´•´•´•´•´•´•´•´•´•.
I

-71 FRIWE, LOYER´• LH L

Bii l72-~
-78 FRI*E. LONER, RH L
19 FR*~EI LONER, iH L
.80 FR*I(E, LOYERI RH 1
81 FRI~E´• LONER, LH I
FR*I(E´• LONER, RH 1

-82 LNGLE´• LH ´•.´•+´•r 1

-83 INGLE I RH L
IITTl,ENING P*RISI
SEREY L
NLSIER ´•´•´•´•´•´•I´•´•´•´•´•....´•´•´•´•´•´•´•´•´•´•´•´• 1
NUT 1
---li---

3L01~3-50) BULIHEID 1SS*´• FYD PRESSURE ISTL L B

I´•5D)
310161-501 BULNHEID ISSI, FND PRESSURE (ST1 L F
5´•50)
BULKHE*o 1SPI, FYD PRESSURE LSII 1 0
ll´•~DI
BULIHELD ISll, FYD PRESSURE (Srl t E
1.501
8~ 310((3-67 IEE´• LH i´•´•....´•.´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´• I B
CHLNNEL, LH L
ss 3101~3‘69 IEE, RH I B
CHLNNEL´• RH I
-8~ )10(113-~1 TEE L
BI 110(~3-13 CHLNHEL 1
as DOUBLER I ii
3 OOUBLER 1 E
se ,lotQ-ss TEE 1
90 310(13~51 RING L
-91 DOUBLER 1 I
)´•111 I DOUBLER I E
-92 110(1)-11 DOUBLER I BE
3-97 DOUBLER ´•.´•.´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•r´•´•´•´•´• I DE
s, 3101)3-13 ..´•´•LNGLE´•´•´•´•´•´•.´•´•. ´•´•´•´•´•´•´•´•´•´•´•´•I´•´•´•´• 1
P~ ...´•*NGLE´•.´•.´• 1

CODE EFFEcTIYE ON SERI1L HU*BERS

L 6901 L1100 THRU 11268
B 6901 11100 TnlU 11113
C 6906 1111( THRU 11183
D 6906 11186 THRU 11268
E 6901 C 6908 11159 1ND SUBS

Revised: 2t( November 2.281

r""
BECTION II
ILLUBTRP~TED
GULFSTREAM
FU8ELAOE PARTS CATALOG
CDMIUZANDER
ssoA/staa

On
~o=

~l.ur´• 2-51. ~ul´•l..´• Itru.tu.´• *Il´•.bly Nor´• I´•l,lon (Ih´•´•1 4 ol

8-888
ROCKWELL
ILLUSTRATED
COMMANDER PARTS CATALOG SECTION n
680A/B FUSELAGE

FIGUKE P n R r UNITS USIBLE

L INDtX 0 E 5 C R P T I N PER ON
NU*BEH N U M B E A 1 2 3 4 5 L 7 ~ISI GOOF

2-5L 95 3L0443-79 4NGLE I

96 310443-L1 bhCitl LH t
97 310113-12 IINGLC´• Ln I
98 310443-17 ~NGLEI LH I
’)P 310*43-19 4NGLEI RH I
´•´•´•´•´•´•´•r´•´•´•´•´•´•´•´•´•´•.....

-100 310443-33 NIPPLE ´•´•´•´•´•´•´•´•´•.1...............

-101 310443-)1 r UOOR ´•´•´•.1´•...................... I

IPTTICHING P4KTSI
nSI103P-L-OB SCREW 23
bNVbODLoL WnSHER 23

-1DZ 3L0443-3 FRPME, LH 1 g

310443-89 FR(\Ml, RH L F
-103 )10443-65 FKP*E´• UPPER 1
310443-87 FRIMEI UPPER I F
315443-83 FRI\HEI RH L B
310443-11 FI*RE, BH I F
-105 410443-61 WEBI in I
)10113-99 WiB1 L~ 1 E
-iOb 510413-73 WEB. RH I RC
310513-95 WED, RH 1 3
310443-109 WEBI RH I
-101 310750-1 IN6Lt 1
-108 310719-L SOUBLER
-109 P4NEL i
-110 310112-3 SCREEN I
lnTTPlCHlNG PIRTS)
-111 HSZ7039-o806 ICREY 4

1N960-10 U~SHER
nSZ10)2-08 NUT 4

-llZ 3L0173-5 IKIN´• RH ISEE FIG. 2-501 REF

8800L8-503 YCNT´• LPBIN illfi LXH*UIT I

COOt EFFEtTIVE DN StKlnL NUNBERS

b 69DP 11100 THRU L1ZhR
B b9Dn 11100 TnRU L1113
C bYO* 11114 IHRU LilB)
D b90L 11184 THRU 11268
E b40b C 6908 L1269 bND SUBS
F P90b L B908 1111* I\ND SUBS

a-288
 ILLVSTRATID
ROCKWELL
SECTION II PARTS CATALOG COMMANDER
FU8ELAGE 880A/B

o,

u 130
131
1311 128
128

162
120
111 10
21 30 82

lls
110

s~

2! 13
2Pll
Itll U 16
1? 21 sc
31 13 85

23 L
9 is

!1813

IOE
133

(51
’59
Ilo :31 ’"2

aa 81 128 121

5 B
98
In
Its
to 1~1

toe
In 133
j35 113
1(2

’11"

~isur´• 2-52. Arl´•nbly 18hsat 1 of 2)

a-soo
ROCKWELL ILLUSTRATED
COMMANDER PARTS CATAALOO SECTION n.
BBOA/B FU8ELAOE

FlcUnE P ii K T UNITS UIPBLE

IN~tX O E S C R I P T I O N P~R ON
hUnBtR N U M B E R 1 i 5 6 7 bSSY CODE

I-SZ sU0001 FUltL bGE 1SSY. CUHPLE TE i

)11)83 ST~ UCTURE
~SSYI FUS ELI6E i
I ~LU3J3-ZL9 ~NjLEI LH
310]83-251 4~GLt, RW i
311383-247 dNiit´• iri 1
310]83-1’t1l ..*NjLEI RH I
3 ~10303-h5 PNGLt´• LH 1
~19383-21b bNSLEI KH ´•....1..................... I
110383-3 CHINNEL 1
5 360015-37 CHnNNCL, WINUSHIELU IStE Fi(i. 2-561 i IIEF
310055-503 FRIIE nSSYI FUSELdjF IST~ 38´•001 i
b J10055-19 FR4ME, LH I
310055-20 FRIIMtl RH i
310439-511 FRIME INSTLI FUSEL4GE ILbNT ~tf
7 1L4439-~9 FRPMEI LH 1
8 110109-3L FRIRLI R~ i
)10L69-503 FRPNE *SSYI rUSELncC IST(I 51.75) i
9 JLOl6O-1I FRIUEI LH 1
)10169-13 ER4Hti RH 1
310164-17 IUPPUHT 1
9d 310383-329 PNGLE
310391-505 FR4ME ~ZSYI FUStLIGt IETI 60.501
10 )10311-11 IEGnENT´• iH
310391-19 IEGNtNTI RH ´•´•´•´•r´•´•´•´•-´•´•´•´•´•´•....... i
j1O)P1-27 ITR*P 2
ii 310085-2 CHPNNEL, LH
310085-I CH~NNtLI RH L
310388 FR4Mt INETL, UPPER ReE
LZ 3L0388-3 SEG’IENI. LH I
31038I-I S(G~iNTI RH L
13 310335-5 Ilc~tNTI CENTER 1
111 310170-501 INTERCDSTIL. Li~ I
310170-502 INTZ~CUST4LI RH 1
3101,00-523 FR4ME LSSYI FUStL*GE (Sid b9´•001 L
I) 310’tO0-8O FRIMtl LOWER LH I
310400-82 iRIHEI UPPER LH ´•.r´•´•´•´•´•+´•´•´•....... I
310100-88 TPLICEl FRbH~
16 310400-51 FHP3t´• UPPER CENTER
IT 310400-85 FRPMEI UPPER RH i
)10*U0-71 FRPnEI LOWER HH
310400-91 SPLICEI FRdNt I
LR 310’tZ4-5 CH4NNtL 3
LS 3101LS-6 CH4NN~L
ill 310421-1 CH~NNtl I
21 310’t2’t-9 CHINNEL I
22 31012*-11 Cn4NNEL I
310~03 1 FR4h:E dSSYI FUIEL~GF ISTll 07h´•0o L Z
STb 087´•001
31D’t03-13 FRdnEI UPPER LH I
24 3L0403-LI FR4Ntl UPPER RH I
25 ~10433-39 FL4ME I *1IDDLE I STn Ib.OUI
26 310403-4L FA4Htl H100tE ISTI 57´•001 I
310400-52L FRLHE 1SSY. F~EELbCE ISTb O9t.50 G Z
iTi\ 099.301
27 310*00-81 FR*HE, UPPER LH ISTd YL´•501 L
28 )10~00-79 FRPMEI UPPER RH IST4 96´•501 i
310’t00-87 r SPLICEI FRIWE ISTP 96´•501 I
Z8P 310383-327 SP~CER 3 C
(bTT4CHINO "bRTS)
iiN)-27P BOLT 1
6N960010 W1SHEfi i
MSZ104~N3 NUT 1
---I---

CODE EFF ECT IYE ON 5 ER I*i NUMB ERS

C 6908 11350 dND SURS

2-501
 ILLUSTRP~TED
ROCKWELL
SECTION n PARTS CATALOG COMMANDER
FUSELAGE BOOA/B

FIGUKE P I\ R T UNITS USPBLE

C INOtX O E S C R i P T L U N PER ON
NUHBEY N U M 8 E R 1 2 I 1 5 O 7 *551 CODE

2-52 29 310400-89 FR**EI UPPER RH 1579 46.501 1

30 310100-80 FRIRE. LOWER RH (STI i
310400-89 SP~ICt I PR~ME´• RH IITi\ ~h´•501
31 310100-53 FRI\HE, CENT ER ITdi lb´•10) L
32 110*30-82 FKIMEI UPPER LH ISTb 99´•00) 1
33 3L0~00‘80 FRIMEI LOWER LH ISTP 9Y+001
310400-88 IPLICEI FfibMEl LH ISTI UY´•oOl i
34 31o4OD-L3L FRLME. UPPER RH ISTP P9´•o01 I
35 310400-79 FHIMCI LOWER HH ISTII 99.001 1
310400-87 SPLICE, FHINE. RH i4Til Y9´•00) L
3b 310400-54 FRPMEI CENTER IBTb 99.001 I
~losna-515 FnnME nssv, FUSELIGE ISTb 108´•001
P1 310386-11 FH4HEI UPPER LH
3U )10381-18 FHPHEI UPPER Rn 1
39 310386-43 FRAMEI LOWER LH ´•´•´•´•´•´•´•´•´•.r´•´•´•´•´•´•´•´• 1
CD 110386-37 FRIMEI LOWER RH ´•´•r´•´•-´•´•-´•´•´•´•´•´•´•´•´•.

310985-535 FR*NE ~STY1 FUSELPGE ISTP 117´•001 i 1

310385-515 FK4NE *SSI, FUSELb6E (STb 117´•001 I B
310385-549 FR~nE t\TSY I FUSEL 4GE ISin I 17.00 I L L
ii 310385-85 FRINE, LH L 4
310385-95 FHIHE, iH 1 B
310385-99 F~PME, Ln 1 C
-)Z 3L0385-87 ´•´•´•F~nnLIRH 1 4
310385-97 FRIMtl RH
310385-101 FR4NL, RH 1 C
FR4nE 4111, FUSELIGE I~Tb LZ~´•OO) I
43 310385-87 FRiZnE, LH 1
3L03R5-89 Fll4ME, Rn i
310385-525 FRI*E ASSY, FUSELPGE ISTI L4~.001 1 4
3103R5-5/t7 FK~E ISSY, FUZTL~^E I iTa II~.ODJ L 6
310185-551 FR4nE *SSY, FUIELPGE ISTb LC4.DDI
45 310107-1 iRbMEl LOWER LH
i1)707-50I FRIME´• LOWER LH L 8
310701-503 FHPHEI LOWER LH i C
’tb j10706- i i FRl\ne I UPP EH LH
CT 310707-2 FHIM~. LOWER RH 1 4
3L0707-5DZ FR4nEI LOWER Rn 1 A
310711-504 FKPHII LOWER Rn I C
)8 310706-2 FKP*tl UPPER Rn
310386-517 FR*MI1\SSY1 FUSELI\GE ISTn LIS´•OOL
*Y 3LDl8b-17 FRdlEI UPPER LH i
5C 310386-18 FR*IL, UPPER RH
51 liOjBh-C3 FR~ME, LOWER LH I
)i 310386-44 FRIMFI LOWER R~
310102-509 FR4nE nTSYI FUSELIGC 15~1154.501 I
53 310115-1 FRIME, LH i
54 310705-2 1 FKIMEI RH L
310395-109 SPLICE INSTLI FUSELIGE ISTP L55´•~*1 REF
55 jiOjgg-25 FR4ME1 LH L
5b 310319-26 FHIMEI HH
57 310399-3 FIIHEI CENTER ´•´•´•´•r´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´• L
310398 SPLICE INSTL´• FUIELIGL 1574 It~´•BZ) Rtr
58 31042(-3 SPLICE
310398-21 GUSSET, LH ....´•..´•´•..1............ I
311398-22 GUSSCTI RH L
3101)0-501 TRIME INSTL, FUSEL*GE 1STn 1~3´•50) REF
59 310140-27 FRINE. LH L
60 110110-28 FR*MEI UH I

CODE EFFECTIVE ON PERI(iL NUMBERS

4 690* LL100 THRU 11324
t 6904 11325 THRU 113*9
C 6908 11350 IND SURS

2-303
ROCKWELL
ILLVSTRATED
COMMANDER PAATS SECTION II
6901\/8 FUS~LAGE

FIGULt P a a T UNITS USPRLE

6 INUEX n t I C a I P r L n N Prn ON
hUMBFL N U R R E R L 2 3 4 6 1 ~5SY COUt

2-52 3L039:-501 5 PL ItE INST i FUS EL4GE I STI II L .36 1 REF

61 310427 SPLLCE
310312-23 GUISETI Ln L
310392-24 GUSSETI RH I
310~01-501 FR9ME bSSYI FUSEL 4GE (STI\ L 12 ´•50)
62 1L071!-1 FRPMEI LOWER LH I
310711-2 FL~HL, LOWER RH I
e3 3107L0-1 FR4HEI UPPER In
310710-2 TRlini´• UPPER RH L
64 31038*-5L7 FR**E ISSYI IRONT SPUR 1STn 178.811 1
310404-503 FRIRE *SSII IUStLdGE ISTb 1Br.00i L
65 110404-5 FRINE, iH L
310101-6 FKdME´• aH
310435-501 FRIYE 4SSY, FUSELIGE Isin irs.aol
66 310405-19 FHIMC. Ln L
310401-6 FRII"EI RL(
bi 310*11-507 FR~3E nSSY, RE*R SPIR ISTP 209.151 I
3L0407-501 FHIME ~SSYI FUSELPGE I)T* ZL1.00) I
68 3L0407-L9 FRINE´• LH
3L040(1-501 FRIYE bSIYI FUSELIGF ISTii Z34´•00L L
69 310106-15 FK4MEI in L
310396-)01 r FRI*IE IISSYI FUSELbLE ISTii 223.98) I
70 310396-25 FRIMEI LH i
11 )10396-15 FRPnE, iH 1
310397-503 FRIME UISY1 FUSELIGE (STn 234+151 1
310397-505 FRIUE bSSYI FUSELPCE (STP L39.L5) 1 t
IZ 310397-21 FRnMti in I
73 310397-23 FR4MEI RH I
31O0CO-5LL FR4ME aSSYI FULELbGE (STn 251.001 1
1~ 310010-37 IEG*IENT, UPPER LH 1
15 310010-39 IEGnENTI UPPER R~ I
76 310090-53 iE6RENTI LOWER LH................. L
11 310040-55 SEGNENTI LOWER RH................. 1
78 3L0*15-501 LONGE KCN UP SY 2
IPTTICHING P9RTS)
NnZ146-25 BOLT I
NI200O2C6 W4SntR ´•´•´•´•´•´•.1.I.................... L
YSZOIOZ-h W4SHER I
EB-OL4 NUT 1729621 1

510417 HOnO INSTLI FUSELbjE RE~

79 310121 FI~TINO
IbTT*CHING PIRISI
NbSl~b-ZI BOLT InFT ENDI 1
YSZOOOZC1 WPSHER (bFT ENDI 1
MSLOOOZ-b IISHER IUFT EhiO) I
EB-O6" UT-O InFT LNDI 1729621 i

80 310422-501 FITTLNG, LH
310422-502 FITTING, KH 1
I*ITntHING PPRTS)
NbSICb-23 BOLT I1FT ENDI
MS?OOOZCb HI\SnER IbFT ENDI I
n520002-6 Y~IHER ibFT FNDI L
EB-Ub’t NUT IbFT ENDI llZ9621

8L 3109L7-Z1 INTLHCCSTIL, in 1
82 3 10*17-22 INT EfiCOSTliL I RH I
31?420 CH**NEL 1~STL´• DRPGI LH L Rh RE~
63 310420-9 CHINNEL, LH FWD 1
310*20-11 CH~hlNEL. Ln 4FT L

COOE EFFECTIYE DN IERI~I NUMBERS

O b9od L1100 THIU 11268
E 6904 B 6908 L1269 bND SUBS

2-503
 ILLUSTRATED ROCKWELL
SECTION n PARTS CATALOG COMMANDER
FUSELAGE
BOOA/B

FIGURL P 4 P T UNITS USIRLE

E INDEX O t 5 C R I P T i O N PLR ON
LUMGLR N U M B E R L 2 5 6 I eS9Y CDOt

2-52- 84 3LO42O-1O tH*NNELI RH FWD

310120-12 tHd~NELI RH 4FT L
310412 Cn4NYiL INITL REF
85 310412-)9 ;H4NNEL, LH L
310412-6L Cu9NNEL´• RH i
Lt 310412-53 CHI~NELI LH L
3101L2-51 CH*VN EL I RH r I
H7 )10112-~5 CH4NNELI LH I
88 313*12-56 CH4UNtl´• RH ´•´•´•´•´•´•´•r´•´•´•´•´•´•´•´•´•´•´•´•´•´•´• L
BS 3L07D*-i CHb~NEL´• iH IFR03 Iii 126.00 TO ITn
178.811
90 310704-2 CHINNELI RH (FROI ST/i 126.00 TO ITP L
1IR´•BLI
330153 JI\M8 INSTL´• CPIBIN UCOR REI
-91 33011)-53 CH4NNEL, FHD
’,2 330L53-L9 CHP~NEL´• nFT I I
93 330L53-47 CHINNEL, CENTER 1
91 3)0153-L9 SILL
3L0~10 SH*NNEL INSTL IEF
45 3Lo410-81 CHbNNELI LU L
3LO~LO-83 CHPNIIEL 1
RH L
96 CHINNELI LH I
310410-57 CHP~NELI RH L
57 210110-85 CH4NNELI LH L
98 310410-86 .CHIVNell RH 1
95 310410-87 CHINNELI LH 1
310910-89 CH*NNELI RH I
310136 STIUC TORE INSTL, P1CTUfit W INDO* RtF
-100 3L073b-32 cHnNNEL, ~H 1
310131-31 CHPYNELI LH ..r´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•r´•´•´•´• L
-IOL 310736-33 CHIYNEL´• LH C RH
-132 313736-40 CIII\~YEL I RH ´•.+r..............´• L
310716-19 CHI\"INE L, LH I
-IOj CH4NNELI RH 2
310736-35 Cn9"lNELI LH
-104 310136-35 Cnn~NELI Rn I
3L0136-37 CHLNYELI LH 1
)L0T03-503 Cn4NNILI LH IFROn 5Tb 1Zb´•DO TO ST1 L
L7~´•81)
310713-50* CH*NNELI RH (FROR STI\ 1Zb.00 TG ilii I
178.811
-LOt 110383-213 LOUGERiONI LH LFWO OF BI\GGPG~ DOGRI I
310)R3-Z11 LU~GEION´• Ln I*FT OE R*~L*SE OCCRI 1
-101 1103J3-Z3L LDUGEHehll RH I
310190-505 FRIHE PSSYI FUSELIGE IST1 37´•001 L
~108 310390-63 FRIHEI LH I
310390-45 ´•´•´•FRI\HEI RH I
310393 rR4hlE *TSY, FUSELI\OE IST/I ’t9.3*) 1
-109 310393-9 FRl\nt. LH
)10393-7 FRPHE, RH L
310387-509 FRIYE *5SY1 FUSEL*GE ISTP 5Z´•~71 I
-110 319381-hi FRbHL´• Ln I
310387-69 FRPME, RH 1
310172 STRUCTURE 42SY1 CYTENDEO NOSE ISEt REF
FIG´• 2-511
-L11 310181-*9 .4NGLEI LH ISEE FIG´• L-511 REF
310395-509 INGLE INSTL´• FLOOR SUPPURT RFF
-LIZ 310SP5-27 4hlClLE, iH I
310395-28 INGLEI IH I
-LLP 310395-29 *NGLEI LH ..´•´•´•´•r´•´•.......´•.´• I
110395-30 4NGLEI Rn 1

CODE EFFECTIVE ON ZERI*L NURBEIS

r 6904 L1100 TnRU 11113

a-504
 ILLUSTRWED
CIULFBTRE*M PARTS CATALOG
COMhIANDBR
soOA/EDOe

FIGURE P R 1 UNITf US*BLE

L INDEX D E I C R I P T I O N PER ON
NU38ER N U N a E a I 2 ,,5 6 7 irsr CODE

2-52 -III 3l0395i)I .*N6LE´• LH r´•´•´•´•´•´•´•´•´•´•´•´•i´•´•´•´•´•´•´•´•´•´•´• L

310395132 LNGLE, RH 1
‘115 310395i33 LNGLE. LH L
31039513) ´•..~NOLE´• RH ´•´•´•´•´•´•´•´•1´•´•´•´•´•´•´•´•´•´•
I
-116 31039511 LNGLE IRH SIDE ONLI) ´•´•´•´•´•´•r´•´•´•´•´•´•´•
1
-111 31039515P LNGLE, LH L
-lls 310395160 INCLE´• RH 1
-119 slo,slin INGLE´• LH
3i0395i38 *NGLE´• RH 1
-121 )10395139 LH ...´•~r´• L
-122 310395j10 IHGLE´• RH 1
-LZ3 310391111 ´•´•´•INGLE1Ln´•´•´•´•´•´•´•´• 1
,lo,s5i,2 ...*NOLE, RH 1
~1Z5 310395193 ´•´•´•IH6LE. LH ´•´•´•´•´•´•´•.´•´•´•´•´•´•´•1´•´•´• 1
-126 3103911)) *NGLE, RH +´•´•.´•´•´•´•´•+´•´•´•´•´•r´•´•´• 1
3103951)5 ~YbLE´• LH 1
-I2B 3103951(6 INGLE. RH 1
~L29 )L01951)1 LHGLE, LH 1
3l0395i,a ...~NGLE´•RH´•´•´•´•´•´•´•´• L

,lo19si~s INGLE, LH L
-132 310395150 LHGLE. RH ..´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•1´•´•´•´•´•´• I
-133 310395i9 LNGLE1 LH ´•..´•....´•.´•´•´•´•´•´•1.´•´•´•´•´•´•´• 1
310391111 LNbLE´• RH 1
FRLNE 1SS*´• FUIELLGE (STL LI´•501 I
~135 31039~113 FRI*E, LH L
..´•FRIIIE, RH I G
310l9lirI FRLNE. Rn L n
31038’)-1509 FI(IWE *551´• FUSELLGE´•FUIELIGE (IT1´•´• I
13.501
.136 31071111 ´•.´•FRLIIE´• LH ´•´•´•´•´•1 1
slol,s-ll FRLNE´• RH ´•´•´•´•´•´•´•´•I´•´•i.´•´•´•´•´•´• I
-137 )10)8)183 CH*NNEL Z
330108i509 IHSTL, EWERGENCI EXIT
J*IIB REF
-Ila 33010s17 ..´•CH*M(EL, UPPER L
-Is~ a3010si5 ..´•CHINNEL´• LONER L
330153 JlNs INSTL, CLBIN DOOR ´•´•r´•´•´•´•´•´•´•´•´•´•´• REF
-1*o 330153ilD, J*ns, FWD I
-I*I 330153ili3 J*ne. LFT 1
-I*2 ,30153ilos Jln8, UPPER FYD i
~1)3 3301531111 JI~B´• UPPER LFT 1
,sols,ilos JLas. LONER 1
-1)5 330153195 DRIP CLP, UPPER I
-116 33015317P ..´•IHTERCOSTIL .´•´•´•´•´•.´•´•´•r´•+I´•´•´•´•´• 1
)30113~135 ´•´•1NTERCOIT*L ´•´•i´•´•i´•´•´•i´•´•´•´•´•.´•´•´• I
-I)B 3301131131 1NrERCOST*L 2
330153ili3 INTERCOST*L i´•´•i´• I
330108i509 ´•´•JlnelNlrL, ENER6ENC* EXIT I´•´•.. REF
-lso ,30108i53 INTERCUST*L ´•´•´•i

330L52 JII(B IHSTL. 8*G6LGE DOOR REF

-151 330152ils J*NBI SCUFF PLLTE ´•´•´•´•´•´•´•~´•´•´•´•I´•´•´•´• I

330L5211 J1*B´• CORNER, LONER ´•.´•´•´•´•´•,´•r´•´•´•´•´• I
-Irl ,,ol´•izi~l SEIL~ SIDE, FYD 1
-Is, 33015219 J*WBI CORHER´• UPPER 1
~155 33015113 ´•´•´•CH*NNEL ´•´•´•´•´•´•´•´•´•´•I´•´•´•´•´•´•~´• ´•I´•´•´•´•´•´• L
-156 330112111 r J*IB´• CORNER. UPPER L
-157 330152115 ´•´•SELL. *FT IIOE´• L
-Iss 33015215 ´•´•´•JIYBICDRHER, LONER I
-Iss 330151121 ´•´•SELL1 LONER 1
31076L YIIRLrlDH DLI(PER INSTL (Sr*ll)´•OD L REF C
STL 1)~´•001
-I60 310)6~11 WEIGHT 16 C

,CDDE EFFECTIVE ON IE911L NU*BERI

C 6908 11310180 5085
G 6901 C 6908 11100 TIRU 11))0
H 6908 11531 TnlU 11999

2-505
 ILLUSTRATED GULFSTREAM
COMMANDER
SECTION n PARTS CATALOG
FUSELAGE
ssaa/eson

111

n3

i~il

I:

?--J 1

t
M001111P1- 11111 THAU 11311
Ey:
Ire
a

P:" MODII 1108 -11160 ~no sussroursr

Pipurs 2-)2. Itrudur~ Aa~.bly ~orword Seni~n ilhaat 2 ol 2)

2-908
 ItLVSTRP;TED
ROCKWELL
COMMANDER PARTS CATALOG 8ECTION II
BI(OA/B BU8ELADE

FILURE P e n r uNiTr usnnLt

G INOLY D t I C R I P i I U N PE* ON
NUn8ER N U M R E R I 2 3 i 5 d 7 PS~Y CODE

1-52 -161 j1075LI-LI *IE L liHT LL

(~TTPCHING P4RTII
-1b) nN3- Llii BOL T IUS:O W ITH 310761-5 YL IGHT I 1
1N~-Zbh BOLT (UZEO WITH 310159-13 UEIGHTI I
PH96~-10 WIIHEK L
MSZL044N3 NUT I

-L63 313761-L1 BnR nSSY 4 C

310761-5 r
BPR nSSY ISTn 2 C
3117bl-13 UIR 1IIY IST* 111´•051 i C
(bTTLCHING PIRTS)
dN4-13b BOLT 2
nN1~0-116 WbSHER 2
MI~IOI4N* NUT 2
-166 *Ilh5hZ-30 PIN1 ROLL 1
----II---

-167 3176P-501 MOUNT C

I~IIPCHING P~RTSI
4N4-211 BOLT Z
WIIHER
MSZloliN4 NUT 2

-169 110762-501 FR4MEI Ln i C

310762-)02 FRbMLI RU 2 C
86L685 INTEHLOR FVSNISHINGS INSTL, RH ISFF REF
FIG´• 2-L´•5)
dbOQ10 -LIRESHIELO
INSTL REF
-170 860911-1 GLPHESHIFLD I
310383 STRUCTURC I\SSY, FUSBLIZGE REF
)1)761 YIJRITION DlnPER INSTL 1STb 117´•00 L REF 8
Ll’t´•OOl
-171 110759-5 WEIGHT 16 H
(ITTICHING PIRTSI
-172 *N3-ZSI BOLT
bN960-10 U4IHFI L
~51101LN3 NUT L

310761-9 BIR nssY ISTn 117.001 2 D

319761-1 B1R PPIY IZTn 141´•001 2 e
I~TI*CHING PIRT~)
~N4-13* BOLT Z
1N9L0-416 W4SHLR Z
MSZL044NI NUT
-175 N5I6562-30 YINI ROLL L

-L71 310760-1 YOUNT i D

I~TTPCHING PPRIS)
-111 PNS-ZI* BOLT Z
4N960-4L6 WPIHLR
MIPL044N" NUT 2

-178 310762-1 FRI*EI LH 2 B

3107L2-2 FRIW~´• KH 2 R

CODE EFFECTIYL ON SERI*L NUMBERS

6 L90n 11925 THRU 11349
t 6908 11350 LND IURS

a´•301
 ILLUSfRATID ROCKWELt
SECTION n PARTS
FULLAOE
CATALOG COMMANDER
880A/B

437.19
429. 48

409. 56

388. 85

FUSELADE 366. 60
STATIONS

346. 60

326.00

308. 00

A
zsa, 00

212. 00
lit

254. 00 hhaii( ~p a

131
1’ ~13149
11
to
SE
r

to

i
437.19

´•_~ ’I
39~

429. 48
31 1 ~i 111 51

FUSELAGE
STATIONS
FUSELAGE
STATION
386. 85 ;I~e 32 1 V 409. 56
´•17~1 11"’

ri~ure 2-53. Pi.lembly Alt Ss~fion

2-508
ROCKWELL
ItLUBTRATED
COMMANDER pnRfs cnTnLoc SECTION n
asOA/8 FUSELAGE

FIGURE P 4 R T UNITS US*RLF

C INDEX O E 5 C P 1 P T I O N PER ON
NUMBER N U M B E R i Z 3 C 5 6 7 PSSY CODE

2-53 300001 FUStLncE bSSI´• COMPLETE 1

311383-5*1 STRUCTURE 4151. FUSEL4GE L
B iCO*i-ST7 5 II(IICTUR E 451Y1 FUSFL4GE I iirT
10034-5~3 FR~HE 4SSY, FUSEL4GF 1STd iSI´•001 1 4
110039-515 FR*ME FVSELPGE liTb 251.001 1 B
110039-21 FRIZE(E SEGMENTI UPPER LH ´•.r´•´•´•´•´•´• 1
)10039-35 FRP*E SEGHENTI ~’PtR RH L
1 110039-*3 FRPWE StGMENTI LOn’ER Ln I 4
310039-17 rRnnE IEGMENT´• LOWER LH.´•....... i R
310039-’ti FRIME SEGUENTI LOWER RH 1
110039-~5 FR**E SEGMENTI LOWER RH......... L
)10011 FR4ME b~II´• FUSELIGE (Sib 172.001
3L3071-9 FRPME IEGMEYTI UPOtK LH
FRlnE SEGMENTI V’PER RH I
C 3LOd71-ll FRdRE SEGHENT´• LOWER LH I
3Lo07L-12 FKIRE IEGMENTI LOWER RH I
5 310071-3 ´•´•´•FRIME, UPPER 1
313071-1 FRdntl LOWER 1
310071-5 FRblYCI LH
310071-C FRIME, ilH
j100LS FR4HE nSSYI FUSELbGE IZTI 290.001 I
6 310019-17 PNGLE´• UPPER LH................. 1
310019-18 *NGLE, UPPER RH L
7 310014-23 *NGLE´• UPPER LH L
~IOC19-21 *NGLEI UPPER CH L
R 310019-11 r WEB1 UPPER LH I
310019-4L WEBI U"PFR RH I
310019-31 WEBI LO*ER LH L
310019-39 WEB´• LOWER RH L
3100L9-LS 4NGLEI LOWER LH 1
310019-L6 4NGLEI LOWER RH
ii 310019-25 PNGLEI LOWER LH i
310011-26 ~NGLEI LOWER R~
3LOo19-ZI INGLEI LH L
31001"-19 I\NGLE I SPL ICE I INNER IINGL ES I
LOo19-Z9 LNGLCI SPLICE ILOWER) 1
310C19-3L I\NGLLI SPLICE IT"PI 1
3 L0019-27 PINGLE, SP LI LE (5 IOtI 2
3LP020-501 FRIMt 1SSY. FUSEL~GE (ST* 308.001 L
13 310020-17 bNGLEI UPPER LH L
3L~CZO-18 nNGLE1 UPPER RH................. 1
I* 31o120-ZL *NGLFI UPPER LH
310020-22 ~NGLFI UPPER RH................. L
15 310020-37 WtB, UPPER LH 1
310020-33 WEei UPPER RH I
310020-19 PNGLtl SPLICE IINUtR nNGL~SI
310020-29 bNGLEI SPLICE IT"P1 1
310120-29 *NGLEI SPLICE InIntl 2
Id 110020-15 4NGLEI LOWER Ln i
310020-16 bNGLt´• LOWER RH................. 1
17 310020-23 4NGLEI LOWER LU................. 1
310020-21 INGLE, LOWER RH L
Is 310020-31 r WEBI LOWER Ln 1
310020-35 r IEBI LOWER RH 1
310020-17 4NGLEI SDLICEI LOWER L

CODE EFFECTIYE ON SLRI~L NUMBERS

n 6904 L1100 THRU Ll~bB
B ason G bs0s ilzos aNo SUES

2-508
 ILLU57RATED
ROCMVELL
BECTION II PARTS CATALOG COMMANDER
FU8ELAGE 690A/B

FIGURE P 4 R i UNITS UIIBLE

C ino~x 0 F I C R I P i I O N PER OH
NUMBER N U M B F R 1 2 3 i 6 7 bSSY COOE

P-13 3 LO I i 8- 501 FRIME PSSY. FUSELIGE IST/I 326´•00) 1

11 j10118-19 FR~HL, UPPER LH L
31C11B-2L FLI*E´• UPPER RH I
31011P-ZS r FR*MEI UPPER RI) 1 3
lO ]LOL1B-I FRLMEI LUWER´• iH .1´•.............

31DLL8-1O FR*NEI LOHERI KH 1

II ~IOLLB-L5 IR9WEI LONER
IEYTtNUS OYER LOWER L
8 STRINGERZI
SIO1IR-L7 FR~MEI LONER IEXTENDS OYEI LOWER 1
4 STRINGERSI
ZZ 3L0118-I I NTERtOST dL 1 LH L
310118-8 INTELCDSIILI RH L
3LO!lr r FRIIME i\iSYI FUSILI\GE 1STli )lb.001 L
3101t9-3 F9*nti iH I
310L19-5 FKIME, RH I
24 )10119-9 FRIME, Ln I
310115-11 FRIMEI RR i
310023 r FRdlE ~ISYI FUSELPGE ISii\ 366.001 1
-25 310023-3 FRIREI Ln
IIOOP3-II FRI\El RH I
id 310023-5 INTERCOSTIL. UPPER .........1.... 2
27 310023-7 INTLRCOSTIL, LOWER 2
3iO014-501 FRPIIE i\lSI1 FUIFLIGE ISTP 386´•A51 L
28 3iooz*-s3 FnanE. UPPER
29 310024-41 LONER I
30 310021-IL CLIPI LH ´•´•´•´•..r´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´• I
91002*-52 CLIP, LH ´•´•.1.................... L
31 311024-7 CLIP, LH
310024-8 CLIP, RH
32 31002"-L1 CLIPI LH 1
310024-12 ....CLIPI RH 1.........´•r.´•´•...´• I
)3 3LOOZ’t-27 ooUn LEn, LOWER I
3’t 310021-L) CLIPI LH 1
31POP~-L4 CLIPI RH L
J5 3 IOOZ’t- 53 8R9t E
36 310024-L5 INGLEI Ln I
3iOD1I-lb 4NGLEI RH r´•´•´•´•´•+´•´•´•´•´•´•´•´•.... L
I~TTICnlNG P*RIZI
37 MZZ1039-L-LO SCREW 3
dNP~ODLO W*SnER 3
1N9LOOLOL WLSHER L
nSZ1041N3 NUT

38 WEB .´•I.´•´•´•´•´•´•´•´•´•.´•´•............. L
39 3La02L-55 OOUBLER I
CO 530LL2 BRPCKET INSTL ISEE ~1G. 2-461 REF
)I 310024-97 CLIP, TDP ..´•.1.................. I
310029 r.. FR~HE INSTLI FUSEL1\6F ISTe 109.561 Rtr
12 310025-L7 NEB
13 311025-3 *NGLE
-44 310015-7 ´•´•´•´•WEB I
*5 310025-9 STIFFENER 1
16 310025-11 4NGLE
*7 310019-13 CLIP1 LH 1
310025-Ll CLIPI RH i
-*e 310025-L5 ´•´•´•´•ODUBLER 1
310060 SUPPORT lNSTLI LOWER HUODER HINGE r I
*9 310060-13 CHINNEL 1

CODE EFFECTIYE ON SLRIIL NUMBERS

C 6904 LLlOo THRU 11317
D ason B asos il~*a nNo sues

2.510
ROCKWELL
ILLUSTRP;TED
COMMANDER P~RTS CAT~LOO SECTION n:
B(IOA/B FUGELAGE

FIGURE P e n r UNl’II USdRLE

C INOtX O E S C R i P T I U N PFR ON
NUMBEI N U M 8 E R 1 2 3 15 6 7 bSSY CO~E

2-53 310319 FR~RE nSZYI FUSELIGE ISTP 429.181

50 310319-3 FRbML 1 E
d10379-7 FRPME L F
-51 313319-1 FfiPME L
52 3L30r8-i FITTI~G1 LH I
313078-2 FITTI~G´• RH I
(1TTbCHING PIRTII
ilN3-5/1 ´•+´•´•BOLT´•´•´•´•´•.´•´•´•´•+ 1

nYii60010 WIISI1EI(
NUT

3iOOZR FR4ME bSSY, FUSELPGE ISTb ~37.191 1

5) 310028-9 F~bni 1
ii INGLE 2
55 ~iU028-23 LHINNEL iH L
;10028-2* CH4NNEL. RH
56 310028-35 GUISCT Z
57 310028-LS PNGLtl iH
310028-16 bNGLEI RH 1
58 310028-25 UUMPER 1
59 310028-27 *NtLt, LH L
310018-28 *NGLEI HH
b0 3L3028-29 CLI´ Z
bl JioDZ´-)1 4NGLE 1
62 310028-L9 CHPANEL i
63 310028-9 CH*YNEL 1
6* 310028-39 CHP~NEL i
65 NSZ*SLb-~8 PULLEY 1
I*rT*CHLNG PPRTSI
bN2~-L9P BOLT 1
nN9600’tid *ISnER ´•´•´•´•´•´•´•´•´•´•´•´•´•.r´•´•´•´•´•´•´•´•´•´•´•

NSZLOB?N* NUI i
NISIZIK1Z PIN, GUIRD 2
3LOOPB-ll i\llM1 PIN GUIRD SIIPPORT I
---t---

66 310028-*5 nNtLE. LH 1
310OP8-’t6 LNGLEI KH
67 311128-11 INGLEI LH I
31~028-48 PNGLFI RH L
68 311028-11 CH*NNEL I
br C)OUOT BRPCKET nSSY1 ELEYIT~R CENTEP I
nlNiE
IdTThCHING On97S1
IN*-bn BULT Z
iiNPboDIII W*IHER
RSLLOB~NC NUT 2
---I---

MSZOZOLKPI* RLIRING
70 GRDMnET ´•´•´•´•´•´•´•´•´•´•´•.´•´•1´•.........

71 91006b LDNGERDNI EXTRUOEO (SP1CIrY LENGTH bl

DESIREDI

CODE EFrECTIYt ON StKlli NUMBERS

E 690(\ 11100 THRU Lllji
F b90P C 6908 11156 dNO SUBS

a.sll
 ILLUWRATED
ROCKWELL
LIECTION n PARTS CATALOG COMMANDER
FUBELA(IE BBOA/B

i r
Q II
]iII CT

i",,I CF3 S
11

´•r
Is II

I ca
II

/I

/TP i
11

3f

li~
-F

’i-
.i´•$
Ct
II 21

11
-,y
~igure 2-54. Cabin and Bage.ge Comparlment Iloor inlt.ll.tion
a´•512
ROCKWELL
ILLUBTRATED
COMMANDER PARTS CATALOG BECTION n
690A/B FUSELAGE

FIGURE P 4 1 T UNITS USdBLF

C INOEX 0 E 5 C R ilp T I 0 N PFP nN
NUMBER N U M B F R L 2 3 1 5 b T PSFY C[IDE

2-54 30000L PUSELlPji i\SSYt COMPLETE Rt~

313383 SIRUC TURE 4SIY I F JS EL~C E REF
320005 FLJ09 INITL´• C48IN REF
1 320005-3 SKIN1 FLDOR 2
2 3L0095-L37 ZKINI LH
320005-139 SKINI RH L
IITTdCHING PbPTSI
YSZr039-L-08 SCREW bl
YSZ103’-I-C9 SCREW 4R
---li----

4 32D005-L5 ~OOR L
I4TTPCHING P4RTSI
N527034-1-08 SCREW 4p
---1_-_

i 790219-9 i100R ISEE ~iG´• 2-2 Ii REF

320005-127 iKlh. LH L
1 320005-129 SKIN, L~ I
B 320005-L7 OUOI i
530162 CDLUEI* i"lSTL. dlLLR´•)lr PNU ELEY~TOR REF
ISEE Fic´• 2-471
9 510162-7 OOUBL"R ..........1.......´•´•´•´• 2
LO j30lL2-15 CovEn .............1............. 2
11 320005-23 COVER ´•´•´•´•´•.´•........i´•´•´•´•´•´•.´•´•´•´•´•´• L9
320005-1.1 S4 SKtT 14
IITTPCnlNG P4RTSI
NIZ7039-L-09 SCREW 4R

Ii 920005-41 ´•´•´•003RliiY L
13 120005-21 SKINI LH 1
1~ 320005-133 SKIN nssr, iH .......1 I
Is 320005-151 IKINI RH 1
16 320031-21 000R i
17 920005-111 SKINI iH
re 32a005-142 SKIN, n~ ::::::::::::f I
19 120005-29 JOOR L
´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•1´•´•´•´•´•´•´•´•´•~´•´•´•
20 320095-25 SKIN 1 4
szooos-153 SKIN ´•´•´•´•´•´•+´•´•´•´•´•.´•´•._´•............ I B
320006 F L(IOR INITLI B~GGI\GE COIIPPR TMENT REF
LI 320006-3L COYER 4
IbTT4CHING P4RISI
MS27039-1-08 SCREW 3
---li---
L2 320906-51 ODOi I D
larrncHINe PnnrEl
MSZ7039-L-OR SCREW
----I---

23 32030~-3 SKIN, Ln 1
24 320046-49 SKIN, RH 1 0
321001-4 SKIN´• RH I C
25 320006-31 SKIN L
26 320006-39 0008
27 320096-5 SKIN I
28 320006-6 SKIN .......´•r´•r.´•.........+..r.... 1
29 320006-9 r 300R ´•´•´•´•´•´•´•´•.1.................... I
30 320006-43 SKIN. LH I
3L 320006-47 ZKINI R$ 1
32 )20006-*L OODR I

CODE EFFEtTIYE ON SERLIL NUMBERS

691d L1~00 THRU 11268
B LIOP r 6908 LLZLP dnD SUBS
C L904 11100 THRU 11113
D 6914 C 6908 1111* nND SUBS

2-S1S
 IECTION n ILLU~TAATED
FUSELAGE PARTS CATALOG BBOA/B

20 3

i
4
i
21

at,
5
~225

r
i 2
11

Pi~ure ?-5~A. Iquipn´•nt D´•.lr

2´•514
 ILLUSTRATED
ROCKWELL
COMMANDER PARTS CATALOG SECTION n
680A/B FUSELAGE

FIGURE P a a T UNITS USbBLt

8 INDtX D E S C R I P T I i] N PEP CN
NUMBER N U M B E R 2 3 I 5 6 7 bSSY CODE

2-514- 300001 FUSELIGE aZSYI COMPLETE REF

310383 STRUCTURE ISSI. FUS EL4GE REE
3200L8 OECK INSTLI EPUIPnENT REE

1 320018-29 CLEbT ISEE FIG´• 2-271 REF

2 320018-31 (IEE FIG´• 2-211 REF
32001e-L9 PdNEL b~SY1 1FT1 LH

3 320021-1 FbCtl IFT´• LH I

320018-2L PINEL 118" X 23" X 0.25’ MIRINE 1
PLYWnOO)
IbTTbtHING PIRTSI
N1\175-3-00R BUSHING 25
N4S75-3-00S BUSHING 4

ISZT039-L-12 SCREW 2)
SCREW
4N9ho010 WISHER 25
---I---

IZ001P-)3 PINEL PSSI, FWD1 LH

5 3LOo2o-L FPCE´• FWD´• LH 1 1

320018-27 PdNEL (16’ X 25" X 0.25" M4h1Nt 1 I

PLYW0O01
IITT*CHING PIRTSI
hiiii7S-~--008 ..´•´•BUIHING 20
N1575-3-03j BUSHING 9
~iLlo39-L-LZ SCREW 20
MI24bPIS5) SCREW 4

nN9C0OL0 WISHER ZO

3200L8-s5 rPNEL aSSI. FUD, RH I b

1 320020-501 FbCEI FWOI RH 1 a

e ,zoola-ll PINtL 116" X 25" X 0´•25" MIRINE 1

PLYWO001
(4TT4CHING P4RTSI
UdZIS-3-OL6 BUSHING 34
MSZ1039-15 SCREW 3)
PN969D10 WISHER 3*

j2nOLR-37 PI\NEL i\S SY I *FTI RH I

9 320021-501 F*CEI bFTI RH I a
to ,zools-ss "I\NtL (18" X 23" X 0´•25" *I1RINL i d
PLYWG001
IITTICHLNG PlsTSI
NdS75-s-008 BUSHINS 29
1521039-L-12 SCREW 29

IN"L0CIO WISHER 29

L1 320012-1 SUPPORT 1 n
12 320011-509 SUPPORT 4SSY 1 4

L3 320011-5L1 SUPPORT dSIY ´•1´•´•´•´•´•´•´•´•´•´•´•´•´•.´•´•´•´•´•´• 1

14 3200L1-507 SUPPORT aS5Y .´•.´•...´•............r. L a
II 3P0011-L CHINNEL 1 4
LL 9200L1-503 SUPPORT LSSY
17 ’20019-1 IVPPDRTI LH 1 4

LB 320019-501 SU’PORTI RH 1
19 320019-503 ´•´•.~NGLLI FWO. LH 1
23 320019-504 *NtLE´•FUO, RH i
Zi 320011-501 4NGLEI 9FT. LH 1 1

22 9?0019-506 4NtLEI nFTI RH 1 d

23 )20018-1i SUPPORI, FWD1 LH I a

325018-18 SUPPORTI FWU´• RH

L5 320018-15 SUPPORT. 4FTI LH I n

COOE EFFECTIYF DN StRIPL NUMBERS

a bson c as0s ilzas aNo sues

2-515
 ILLUSTRATED ROCKWELL
GECT1ON n PARTS CATALOG COMMANDER
FUSEWLOE BOOA/B

~1GUfiE P P R T UNITS USPBLE

E INDEX O E I C R I P T I O N PER ON
NUMBER N U n a E n i 2 9 r 5 a I arsv CODF

2-S(1- Zb 520018-15 IUPPOITI lirTI RH L d

IITT~CHING PIRTII
17 BOLT ´•´•´•´•´•´•.´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•.´•´•´•´•r 4
nN960010 WISHEI 4
n92L0’14N1 NUT
----I----

28 880223-)9 CH4NNEL I b
29 880223-4L .......´•..............1´•.´•´•..
I

COOE ETFECTIYE ON SERIIL NUMRERS

1 6901 L 6qPl 11269 dND SUBS

2´•518
 ILLVSTRATED
ROCKWELL
COMMANDER PARTS CATALOG BECTION n

690A/B FUSELAGE

Sta
52. 61
sta
C
sta
23. 50
B
A

~L I

sta
3 Js
144. (10
33 31
sta M
Iza. ao
K is i
1So~oo
Sta s
87. 00
sta
F
69. 00
Sta
154. 50

sLa
135. 00

a"~-I Sta
G 117. 00
sta
E
O sta
78. 00
31
15 31 sta
239. 15
sta
X
223. 08
st. V 30
toe. 15 cn Ta
T
sta 238

sta
st~
112. 50
188. 00
R B
163. 50 w
O g Sta
U 234.00

214. 00

5
ia,
198. 00
o
31 Sta
118. 81

’2

Fi(lur´• 2-55. floor 8´•.ml.nd R.lot´•d ~r..´• Stru.turs (She´•tl of 4)

2-311
 ILLUSTRATED ROCKWELL
SECTION II PARTS CATALOG COMMANDER
FUSELAGE BBOA/B

FIGURE P 4 R T UNITS UI*BLE

L INDEX O L 5 C R 1 P T I O N PER ON
NUHBEI N U M B E R 1 2 3 5 6 1 *SZY CODF

2-55 300001 FUSCL*OE *SIY1 COMPLETE ´•´•1´•´•-´•´•´•´•´•´•´•´•-´•´• L

310383 STRUCTURE 19SY1 FUSELIGE 1
310382-5L1 BE*M INSTLI FLOOR´• LH REF
3L1382-513 BEIW INSTL´• FLDDRI PH REF
i 310382-6L DOUBLERI LH .´•.´•´•´•´•´•´•´•´•´•´•1´•´•....... L
3L0382-62 OOUBLER´• RH 1
310382-61 b~CLti Ln ´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•.r I
3L03A2-64 I~GLEI Rn I
3 311382-123 dEB, iH FWO I
s10382-125 XEBI RH FHO I
3L03R2-135 WEB, iH CENTER IRFPL*LtS I
3L0382-11
310382-136 UEB´• RH CENTER IREPLPCEI
310382-6)
313382-31 WEB, LH CENTER 1
3L3382-38 WEB´• RH CENTER ´•´•´•´•´•´•ri´•´•´•´•´•´•´•´•´•´•´•´• I
6 310382-95 WEBI Ln 4FT L
310382-L39 WEB´• Rn 4~T IR~PL4CES 310382-L3L1 L
)10382-L33 30UBLER 1
7 310382-59 STLFFENERI LH L
313382-60 STIFFENERI RH 1
31o38~-BP DOUBLER, Ln I
110382-90 J~UBLERI RH I
9 )L0382-b~ i STLFFENER, Ln I
310382-70 STIFFENER~ Rn L
910382-55 0OUBLtRI Ln 1
3L0382-56 r JOUBLER, Rn I
11 310382-61 ITIFFENER 1
iZ )10382-65 T~IFFENER´• LH I
310382-66 ETIFFENERI RH I
i) 310382-19 DOUBLER, LH 1
310382-20 OOUBLER´• RH L
310382-*9 ..´•BR~CKET L
15 310382~11 ´•´•´•UOUBLER ´•´•t r´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´• 3
16 310382-11 STIFFENER II
II 310382-L2B DOUBLERI Ln .´•..............r...... 1
?l01BZ-iZT UOUBLER, Rn
18 310382-35 PNGLE ´•´•.´•´•.´•.´•1´•.................. I
19 3IO3BP-ST i 4NGLEI LH I
510382-58 9NGLE´• RH 1
-PO 311)82-1~ DOUBLER 3
21 310382-21 OOUBLER´• LH i
313382-22 DOVBLER. RH ..´•´•´•´•´•.rr.´•........... 1
22 310382-85 STIFFENER i
23 310382-29 4NGLE I
21 310382-31 4NGLE 1
25 310381-33 4NGLE, LH I
310382-3’ PNGLEI RU ´•.´•..´•................1.. I
Zb 310382-107 30UBLER´• Ln 1
310382-115 30UBLER´• RH i
27 3L0382-113 SUPPORT ILH ONLYI L
28 110382-19 4NGLE I
29 310382-11 *NGLE ILH 6NLYI 1
30 4NGLE I
310382-*4 INGLE I
11 110182-1 I\NGLEI LH (ST4 6´•10 TO ST1\ ZI~.DO) I
310382-8 ~NGLEI RH ISTb b.10 TO ITI\ 254.00) 1
32 j13382-9 INGLEI LH IFROM ST1 OLB´•OO TO STb I
013´•001
310382-10 4NGLh~ RH IFROR STI 018´•00 TO STP 1
078´•00L
33 110382-17 CIPI LH IFR(IH STP 013´•00 TO 574 L
L82´•001
3L0382-IR CIP, RH IFROM ST* 073´•00 TD ST* 1
1RI´•OOl

a.sls
ROCKWELL
ILLUSTRATED
COMMANDER PARTS CATALOG SECTION n
680A/B FUSELAGE

Rotated 1800 1 J’-M n r;t Rotated 1800

35 (E

d d ,,sl Sbjs 15

I I, I 91---fia Rotated 180D

QO 9: Rotated 1800

95

15

’1
II

d ,,11

"’a Rotated 1800

d
G H
Rotated 1800

113

121

I,,
O 111

d d
122
r
I

~ipur´• 2-55. ~ul´•l.0´• ~loor Ba.ml.nd R´•lo,´•d F..n´• Stru.lurs (Sh´•e1 2 of 4)

2-318
 ILLUSTRATED ROCKWELL
SECTION n PARTS CATALOG COMMANDER
FUBELAOE esoa/e

FlcuRE P n R T UNITS US*BLE

L INDEX O E 5 C R I P T I O N PER ON
NU*BER N U H B E R L 2 3 L 5 6 I *SSY COOE

2-55 3* 3L0382-45 PNGLEI LH (FROn STP Lls´•00 TO ITII I

209´•001
31038P-46 INGLE´• RH IFROM STd L18´•00 TO STP L
ZOY´•DOI
32000) FLOOR INSrL, CPBIN IEEE FIG´• 2-541 REF
39 320005-53 BUL KHEP~ 1
310423-503 SUPPORT INSTL´• RUOOER TURUUE TUBE, LH REF
SUPPORT INSTLI RUODER TOfiOUE TUOEI Rn REF
36 31042)‘15 GUSSETI Ln L
310423-16 GUSSETI RH 1
31 310423-5 r BRILKET, LH 1
3 L0423-6 r BR~CKET RH L
s8 310*23-1) CHbNNEL´• LH I
)10423-14 CHI\NNEL´• RH 1
310389-509 FRP*E nPSI1 FUSELPGE ISTn 23.501 I
39 310389-L3 INGLE 1
40 310739-L SPLICE, LH 1
ii J1o7)4-1 SPLICEI Rn 1
42 313389-9 I\NGLE, LH ´•....´•´•´•.r´•´•..´•.r´•´•...... I
13 110389-10 4NGLEI RH L
94 310389-11 *NGLE, LH 1
310389-12 ~NGLE, RH L
)6 )10389-1) CLIP 1
17 310389-5 WEB´• LH L
*8 3L0399-L WEB´• RH ´•´•´•´•´•´•´•´•´•´•´•´•´•´•.´•´•r´•´•´•´•´•´•´•´•´• i
49 3107*0-t FRIHE, Ln L
IO 1i0710-2 FR4nEI RH I
51 313389~31 FRPnE´• CENTER L
910990-505 FK~HE 1~SI, FUSELnct IST1 3~´•001 I
52 )10340-61 GUSZET. LH L
53 310190-71 GUSSETI RH L
5* 3L0390-7 ~NGLE ...´•´•.´•..´•.´•..1.......´•...... 2
j5 3L0390-1l nNGLE´• LH 1
56 310390-12 PNGLE. Xn L
57 310390-13 4NOLE´• LH L
58 310390-LI 4NCLEI RH ´•´•´•´•´•´•1´•´•-´•´•´•-´•´•´•.´•´•´•´•´•´•´• I
59 310390-11 ~NGLE´• LH 1´•´•...................... 1
60 310390-Lb INGLFI Rn I
~L 310390-L7 PNGLE 2
-bL 310390-25 INGLE L
63 310390-2L PNGLEI iH I
64 310390-22 PNGLE, KH ..´•1.´•´•.....´•............ I
LS 3L0390-57 PNGLE .´•....................i...´•.. L
310390-11 ~RCH L
67 310390-29 CLIP I
68 310390-39 UOUBL ER .´•1´•..´•.´• i
69 310390-19 nEB L
-70 310390-9 HEBI Ln I
11 3L0390-10 r WEB, RH L
IZ 3L0390-59 FRIMFI LH I
73 310390-60 FR*M~I RH
74 310390-95 FRIME, CENTER ....´•´•´•´•´•.´•´•11´•...... I
31038I-509 FRIME *SSY1 FUSELPGE ISTd 52´•6r) I
TS 910387-65 SUSSETI iH 1
18 310381-43 GUSSET1 RH I
77 310387-1 bNGLE, LH I
IB 310)87-8 INGLE´• RH ........´•´•1´•´•....´•.´•..... L
19 3L0387-9 ´•.´•STIFFENER~ LH ´•´•´•.´•´•.......1 L
RO 310387-10 STIFFENER~ RH ´•´•´•´•.´•´•.............r L
81 310381-13 ITIFFENER~ LH I
8I 310381-1* STlFFENERI RH ´•´•´•´•´•´•´•´•´•r´•´•´•´•´•´•´•´•´•´•´• L
83 3L3387-15 OOUBLER, Ln 1

3-310
 ILLVSTRATED
ROCKWELL
COMMANDER PARTS CATALOG SECTION II

680A/B FUSELAGE

O Rala~ed 18.0 L~
132
MLaied iB00

159

s~
131ji;

d 130
~lal 1
d’" 139
1

113
131
’2111

L M
Rotated 1800
121 138
116

115

""-Fi
i,
,,I

C~"’:Y’ 132

N
Rotated 1800 L~

i
7
,,I

151152
155 118 I‘
151

la
P
"21’
(I ill

P Q
Rotated 1800 Rotated 1800

110 118,,, i
Ilola,
Its
las1,,

1\88 1118

11111 1 12 211

~igur. 2-55. ~u.el.ga ~loor 8´•.mr .nd Rel.tsd ~r... Stru.tur. Isheet 3 of ~I
2-921
 ILLUSTRATED ROCKWELL
SECTION n PARTS CATALOB COMMANDER
FUIELAOE 880A/B

FIGURE P R T UNITS US*BLE

B INDEX 0 E 5 C R L P T I D N PER UN
NUMBER N U M B E R L Z 4 5 6 7 *ISY CODE

2-55- 84 3L~381-16 OOUBLER´• RH L

8) 310387-17 INGLEI LH 1
8L 310387-18 bNGLEI Rn I
87 319317-2I 4NGLt ´•´•´•´•´•´•´•´•´•´•´•´•´•.´•´•´•´•1...´•...... I
BE 110387-23 CLIP ´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•..´•.r´•´•´•´•´•´•´•´•´•. L
89 310387-14 PR~H I
90 910387-51 r INGLE I
91 310387-3 r WEB. LH L
92 310397-4 HE9, RH ´•1´•+..´•.................´•.. I
43 3L0387-L1 WEB, CENTER
94 310387-55 FR*WE. LH 1
91 3L0387-56 FRIYE´• 9H 1
56 910187-49 FRI*E´• CENTER L
310400-51) FRP3E *SIYI FUSEL*GE ISTI b9.001 I
310400-511 FRIHE *SSY, FUSELISE 1ST* 96´•501 I
47 310400-80 FRIHE ILn ST1 06~´•00 C RH ITd
09L´•5ol
98 P10400-79 FR*HC 19H ZTe 069.00 C 1
LH ST* 096.901
19 3Lo400-1l TT I FF ENER i L
-100 3L0100-13 STIFFENER L
-101 310400-14 IrlFFENER L
-102 310100-1) ´•-´•STIFFENER L
-103 310400-lb STIFFENER ´•´•´•´•´•.r´•´•´•´•-´•´•´•´•´•´•´•´•´•+´•´•´• L
310400-19 4RCH
-105 310)00-21 HEB .´•´•´•r´•´•´•....................... L
310*00-25 CLIP I
-107 310100-L23 WEB´• LH (STPI b9´•001 I
-108 310*00-121 WEB´• RH IST* 69´•001
-109 310100-117 WEBI LH ISTb 96.501 L
WEBI Rn IST1 96´•50) I
-IIL 310100-1~7 FRIHE I
-112 310400-18 INGLE 1STI 69´•001 L
-113 310400-77 INGLE (STI 9~.10) 1
-LLI 3L0400-LOI *NGLE
(ZTI 9L´•501 I
-L15 310400-99 CHINNEL ISTn b9´•001 L
310103 FRIHE ~SIY´• FUSEL*GE 1STb 078.00 8 1
IT~ 081´•001
310403-21 INGLE 1
-117 310403-35 FRlnE 1
-118 310403-23 NGLE I
-119 310*03-97 FRP*E 1
310386-515 FRI4E *IIYI FUIEL*GE ISTd 108.00) 1
310386-517 ..FRIME *SSYt FUSEt*GE ISTII 135´•001 L
-12D )10727-1 GUSSETI L~ I
-IZI 310727-2 GUSSET. RH L
-1Z2 310381-23 ´•.´•CLIP....´•...´•´•´• L
-123 )10386-3 INTERCOSTILI Ln L
-LZ~ 3L0386-’t INTBRCUIT4L, RH I
-129 310386-39 FRLMEI LH 1
-126 11038h-’t0 ..´•FR*HE, Rn L
-IZI 3t0386-13 FRIME, CENTER L
310385 FR4HE *SIY´• FUSELI\GE (ST* 117.00, ST* 3
12b´•00 L S7b 14*´•00)
-1LB 31012~-503 GUSIETI LH 1
-L29 310727-504 GUISET´• RH ´•1´•´•´•´•´•´•´•............... I
-130 310185-7 UEB 1
-131 3L0385-8 WE8 ´•´•´•´•´•.´•.....´•..1.´•´•´•´•.r´•´•.....´• I
-132 910385-9 STIFFENER L
-133 310385-10 STIFFENER 1
310385-15 STIFFENER i
-135 310385-16 STIFFENER I
-136 ?10385-L7 WeB 1
-137 )10385-19 STIFFENER L

2-112
ROCKWELL ILLVSTRATED
COMMANDER PART~ CATALOG SECTION n
BSOA/B FUSELAGE

L~ r

Rotated 1800

218

I
las

209

201
Isa

´•o, ,B 22(1

229

"’b’ I

W Rotated 1800 X
Rotated 1800

230 236

231
zJs

~iour´• 2-55. lloor ond I´•loRd ~rams S,rudur~ ()haet 4 of 4)

2-325
 ILLUSTRATED ROCKWELL
SECT~ON n PARTS CATALOG COMMANDER
FUBELAGIE 880A/B

FIGURE P 4 R T UNITS U9PBLE

L INDEX D E I C R I P T I O N PER ON

NUMBERi N U M B E R i 2 3 I 5 6 1 bSSY CODE

2-55 -138 3L0385-2L bNGLE ´•´•´•´•1´•´•´•´•´•´•´•´•´•´•´•´•´•+r´•´•´•´•´•´•´•´•´•

I
-139 3L0395-23 IRCH L

-140 310385-25 CLIP .r...´•...............´•.´•´•.r...

L

310385-35 CLIP L
-LIZ 3L0385-1~ FR*HE ´•´•´•´•´•´•´•´•1´•´•´•´•´•´•1´•´•´•
1
3L0385-46 FRI\ME I

310315-*1 FRI\HE I
B10402-509 FRIME *ISY´• FUIEL*GE (ST1 15*´•501 I

-L*5 310727-L GUSIET. LH 1

-Llb 310727-2 GUIZETI Rn
-L47 910402-5 UEB. iH 1
-148 WEB, RH i
-1*9 310102-1 dEB 1´•+´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•t
L

-150 310*02-9 bNGLE

-L51 310402-LL 1Rtn L

-L12 3L0402-1I r STIFFENER ......´•.+.....´•´•rl´•r.....

1

-L13 31D402-LS STIFFENER, Ln ´•1´•´•´•´•´•´•´•´•´•´•´•´•+´•´•´•´•´•´•

L

)1D*02-Lb STIFFENER, Rn 1´•´•´•´•´•´•´•+´•´•´•´•´•´•´•´•´•´•´•´•

I
-155 310402-11 CL IP ´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•r´•´•´•

-150 310’102-L9 STIFFENEIII LH L

-157 310402-20 STIFFENEI´• RH I

-158 310102-51 FR*NE, LH 1

-155 FRbnE´• RH i

-160 liD*02-3I r FRIHE´• CENTER ...........1.´•.´•.´•.´•.

I
INITLI FUZELPGE IST* 1~3´•501 REF
3101*0
3L0727-1
F~RIHE
GUSSET. LH 1
-Lbl ´•´•´•´•´•´•´•.´•´•´•´•´•´•´•1´•´•´•´•´•´•+-

-162 310121-2 GUSSET, Rn L

310LIO-8 INTERCOIT*L, LH I
3L0110-9 INTERCOSTILI RH
310140-L3 CLIP I
310140-25 FRIME. LH 1
-Ibd 3101*0-21 FRPHEI RH .´•´•´•´•´•´•´•´•´•´•´•´•r´•´•´•´•´•´•´•´•´•´•´•
L

-167 310110-29 FRPME´• CENTER ´•´•´•´•r´•´•´•´•-´•´•´•´•´•´•´•´•.´•´• 1

310401-501 FRI~E ISSYI FUSELIGE IST* 172.501 L
310401-3 UEB, Ln ´•´•´•´•´•r´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•
1

-169 310401-) WEQ´• RH 1

-170 310401-5 FRaME 1
-111 310401-7 4NGLEI LH 1

-112 3 LO*O 1-8 4NG LE t RH I

-113 31040L-4 *NGLE ´•´•´•´•´•´•´•´•´•´•1´•+´•r´•´•´•´•´•´•´•´•´•´•´•´•´•´•
L
310401-LL ~RCH 1
-175 310401-13 CLIP 1
-116 310401-16 PNGLE´• RH 1
310401-15 *NGLE, LH t
-171 310411-LT STIFFENERI Ln 1
-L7A 310401-18 STIFFENER, RH 1
-119 910401-19 ´•´•WEB..´•´•´•´•´•´•´•´•´•´•´•´• I
-180 310401-ZL STIFFENER .´•.´•´•....´•´•1.´•.´•´•´•´•....´•. 1
31038) .FR*YE ~SII, FRONT SPPR 1ST1 L7B´•81) L

-lsl 310384-9 CH*NNELI LH 1

-182 310384-10 CH~NNEL, RH i.. 1´•´•´•´•´•.. r...........
1
-183 310384-13 CHI\NNEL 1
-IUI 310384-19 DOUBLER ´•´•r´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•+´•´•´•´•´•´•´•´•
Z

-185 310384-37 *NGLE ......´•.´•´•´•.´•..´•´•´•rr´•´•.´•...´•´•

1
-180 310381-39 *NGLE 2

-187 310384-79 t*P ´•..´•.´•.´•´•´•.r..´•................ 1

-LBR 310384-R3 WEB 1
-189 310381-85 CI\F
-110 310381-139 nNGLE ´•´•´•´•.´•´•´•´•´•1´•..´•´•....´•........ 2
310)04 FRPHE *IIY´• FUSEL*GE 1STP 188.00) L
-191 310’10r3 ´•´•´•FRI\EIE´•´•´•´•´•´•´•´•´• 1
-19Z CLIPI LH 1
3L0404-8 tLIP~ RH 1

2-814
ROCKWELL ILLUSTRATED
COMMANDER PARTS
690A/B
CATALOG SECTION n
FUSELAGE

FICUPF P R T
UNITS USIBLt
G INDEX O E 5 C 9 1 P T I O N PER ON
GUHRtl N V M e E a 1 z 9 t 7 nrsv CODE

2-55 -193 310434-9 CLLP´• LH 1

310404-10 tLIPI ~H I
-191 310404-11 JUIPOHT I
-195 310134-13 ~I*CC L
310405 FRPME nSSY1 FUSELPSE ISTn L58´•o01 L
-191 P13415-3 FRdME 1
-Li7 i10135-7 CLIPI L~
311*05-8 tLIP. PH I
-196 310415-a CLIPI i~ I
310415-10 CLIPI H* I
-19( 310435-11 SUPPORT I
-LOO llo*05-L3 8R4CL i
FHIYE I NS TLI FUSFLPIGE I ST~ 209 L 5 1 LtF
-201 310411-99 WEBI LH I
-201 3iOL11-1I7 WE 3, Lil 1
-203 310’111-13 ´•´•´•iiE. I
-201 310411-19 ...?NGLE I
-205 310411-113 ZUPPOHTI LH I
-lob 3LOIil-~6 SUPPORTI PH I
-217 3L04LL-31 LH I
-ZOR 310~11-32 STIFFEYE~I 9U I
310411-33 STI~FEYE$I Lu 1
-2LO 310411-34 ITlFFElUER) PY
-Zll 310411-35 iUPPllFT
)IU*LL-C) SUPPCT T I
-213 310411-101 ITIFFENER I
3L041I-2I STIFFEYE~I LH I
-211 ITIFFEIERI RH I
-216 310411-21 *NGLEI LH I
-Zi7 310411-22 INGLEI 1H 1
-Pls 310411-85 SPLI(EI LH I
-219 310411-87 IPLICEI RH I
310411-39 IOtlCEI LH 1
-221 )L1IIL-II SPLltE´• RH I
310407 FRIME ISSY1 IUSEL4GE irin 214.001
-222 310’07-3 UEB L
-223 310’131-5 -´•´•INiLtl iH I
310437-6 r\NGLEI RH
-22* )10101-19 FRPnE 1
-L25 310"07-13 bNGLt 1
-126 310’117-15 ~NGLE I
)10396 FRPME dSSY1 FUSELdGE (ST1 223.981 1
-217 310396-13 4NGLt 1
-228 310396-L7 FR4HE I
310396-19 ~NGLE I
PLDll)b FRI\HE liSSY1 FUSELI\GE I Sii\ 23~´•00) I
-230 310*06-15 ´•.´•FRIME I
-231 310436-7 HEB L
-232 310406-9 9NG LE I
-233 310406-11 INGLC I
-L3$ 310406-13 CHPNNEL I
310397 FRIME nSIY1 rUSEL4GE ISTn 234´•151
-235 ]10397-3 FRPME I
-236 310397-7 PNGLt I
-237 310397-11 ´•´•I1NGLE I
-238 310040 FRIIME ns sv isTa 251. oil I i re F Ic. nEF
2-521

2-325
 ILLVSTRATED ROCKWELL
SECTION n PARTS CATALOG COMMANDER
FUSELAGE 680A/B

_Ii,

B C

X 30
~´•=1 j~
-i, x´•
t i,

I i I k

2-)6. Pulel~gs Windlhield inrlallotion

2´•326
CIULFSTREAM ILLUSTRATED
COMMANDER PARTS CATALOG SECTION n
ssaA/ssoB FUSELAGE

F16URE P ii R T UNITS USIBLE

C InoEx D t 5 C R i P T I O N PER ON

NUHBIR N U H B E R i 1 9 5 6 T PSZY CODE

)11000L FUIELIGE 1II*~ CDNPLETE REF

2-56-
OODR L YINOOY IIISTL. FUSELLCE IEF
330112
3600)5 UINOSHIELD INSTL REF
3600)5-7 ...~T1LP......´•´•´•´•´• I
1
I*TT*CRIND Pllr5)
NSLlbe(-52 SCREY ´•´•´•´•..1´•´•´•.´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´• 2
2
*N960DIO ..´•YIS~R´•´•´•´•´•´•´•´•´•.´• 2
NUT 2
*S2101(N3 r

3 n51(69)-*8 SCREU 28
---I---

360015-9 STRIP´• YIHOEHIELO CENTER I

(*Tr*CHIN6 91.815)
5 SLREY ´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•1´•´•´•´•´•´•´•

i(ll(be)-~8 IC8EY (2
6 ´•t´•´•´•´•´•´•´•´•..´•´•´•´•I´•´•´•´•´•´•
360015.11 61NG CRINNEL 2
*51)69(~5) SCIEY ´•´•´•´•´•´•´•´•r´•´•´•´•´•´•´•.´•´•´•´•´•.´•´•´•´•´•´• 1
7

360015-33 51869, LH OUTER L

8
9 3L0015-)( ITR~´• RH OUTeR L
LO 960015.5 518181 LH INNER I
ii ITR~P, RH INNER ´•´•´•´•´•´•.1´•.´•´•´•~´•´•´•´•´• L
360015-6
(ITTlCHIHG PIRTSI
-12 *52)69~-)8 ´•´•´•SCREY´•´•´•´•´•´•´•´•´•´•´• II
n52169(-)1 ICIEY 2
-13
´•´•ICREW 1
.11

.15 350013-1 ´•´•IIINDIIIIELD, LH (REPL*CEI 3600)3-3) 1

16 360013-8 YINDSHIELD´• RH IREPLICLS 360013-(1 L

(ITTLCNING PIRTI)
´•´•´•SCREY´•´•´•´•´•´•´•´•´•´•´• 11
11
DING CHIHNEL L
360011-39 ´•´•´•´•´•,i´•´•´•.´•´•´•´•´•´•´•´•

---I---

900106-803 GROWNET lR
18
is 360015-29 G*II(Er 2
20 GIBKEr ´•´•´•i´•´•´•´•´•´•´•´•´•´•´•´•´•´•´• 2

ii jsools-1~ blllE T 2

ii 360015-19 GISXEr I

-23 360015-31 8151.87 2

360015-17 ..´•GLSXET ´•´•~´•´•´•´•´•t I

25 815111
26 360015-53 ´•´•GIIIET 2
ii 360015-37 CH*HHEL´• LH 1
-28 360015-38 ..´•CHINHEL, RH ´•´•´•...´•´•´•´•´•r´•´•´•´•´•´•´•

29 360015.11 CNlNNEL. LH
-30 360015-13 ´•´•CH~NNEL´• RH ´•I´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•

.31 360015-3 ´•´•*NGLE´• RETLIHER, Ln I

INGLE1 RETIIHER, RH L
360015-1
I*TTLCHING PIRTS)
-32 .521039-1-08 SCREY ´•.´•´•´•´•´•,´•´•´•1´•.´•´•´•´•´• 12
350015-39 blNb CH*HNEL I

33 31D1L8-161 II(IH (IEE FIG´• 2-501 REF

Revised: 2X Novembsl´• 1984

a-Ra7
SECTION n ILLUSTRP;TED
OULFSTREAM
FUIELAGE PARTS CATALOG
COMMANDER
880A/698B

a’
-fiI~
I

16

i´•-

~isure 2-5~. Co~Lpil Ovsrhe~d Windovr in.tollation

a-528
ROCKWELL
ILLVSTRATED
COMMANDER PARTS CATALOG SECTION n:
BBOA/B FUSELAGE

FIGURt P ii R T UNITS USIBLE

G INDEX D E 5 t R I P T i O N PER ON
NUMBER N U M B t R 2 C i 6 7 PSSI CODE

2-57 300001 FUS~L*GE PISYI COMPLETE ´•1.´•´•´•´•´•´•´•´•´•´•´•´•´•´•

i
390112 DOOR 9ND WIhi00Y INSTLI FUSELI\GE I

3600LI-i iIn00W INSTLI COCKPIT OYtRHtdOl iH I

36001$-2 WINDOW INITLI COCKPIT LYEKHtnDI RH L
360015-1 WINOOW, Ln I
360015-2 r iI~OOW1 RH L
I4TTICHING P9RTI)
2 MSZ1~9C56 SCREU ~O
900106-501 jROMnt T r CO
---´•L---

360016-L GISKET I
5 560017-1 RINS I\SSYI LH 1
3~0017‘2 RING ISSY´• RH ´•´•´•´•I.´•.´•............ I

2-528
 ILLUSTRAT~D
ROCKWELL
SECT1ON n PART8 CATALOG COMMANDER
FUSELAGE
BBOA~

i
lo

1;
´•i´•

~ilur´• 1-58. Co.kpit Wind~r in.,.ll.tion

2-530
 ILLVTR~TED
ROCKWELL
COMMANDER PART~ CATALOG SECTION n
69oA/B FU8ELAOE

FIGURE P d R T UNITS US(\BLE

L INDLX D E S t R I P T I O N PER ON
NUMBtL N U M B E R 12 3 15 6 7 bSIY GOOF

1-58 300001 FUStL*Gt nSSY1 COMPLETE REF

330112 DOnR i\ND WINDOW INSTLI FUSELIIGE REF

R6LBR5 INTERLUR FURNISHINGS INSTL I~tE FIG´• REF

2-651
BIL901 WI~OOU FR(\nE INSrLI COCKPIT PE~
L 86100L-1 .Ffinnt dSSY´• WINOOWI PLLUT L
PBIO0L-501 FRdnE *SSY1 WIYOOW´• COPIL~T I
8~L901-5 BUMPER Z
160106-522 r COCKPIT WINDOW INSTL´• LH REF
360006-521 CDCKPIT WINOOW LNSIL´• RH RtF
3aLDLZ-501 ..´•WINDOH´•´•´•´•.´•´•´•´•´• 1
IPTTPCHI~G P9RI~I
M52~694-551 SCREW "R
5 90C106-519 ´•´•)ROMMET 16
36D0O6-9 GPNG CH*NNEL´• FWD L
36900L-7 G14G CH4YNELI UPPER L
8 360006-5 G*NG CnPNNEL. IFT I
9 360006-11 G*~G CHINN~LI L01E9 L

LO R4I1N G*SKET IO´•0b3* SHEET, CLOSED CELL dR

RUBITEYI 1829621
11 310118-161 SKIN ISEE FIG´• 2-50) PFr

2-351
 ILLU8TRATED ROCKWELL
SECTION n PARTS CATALOG COMMANDER
FUSELAGE BgOA/B

´•r

3 J~ 18 llB L

IS B
is,
r: it

,k;r

t ii

21 22

Pipure 2-59. ~ur´•l... C.bin Side Windowl Inrt.ll.ti~n

2-552
 ILLUSTRATED
ROCKWELL
COMMANDER PARTS CATALOG SECTION n
B80A/B FU8ELAolE

FIGURE P 4 R T UNITS USIBLE

L INDEX D E 5 C R I P T O N PER ON
NUMBER N U M R E R L 2 1 5 6 1 1551 CODE

2-59 300001 FUSELICE ~SSY1 COMPLETE REF

P3oi12 DOOR nND WINDOW INSTLI FUStL*GE REF
861885 INTERIOR FURNISHINGS INITL ISEE FIG. REF
2-651
861889 i r WINDOW FRIME INSTLI C*BIN, LH L RH REF
1 861953-1 PdNELI LH I
861953-2 i PINEL. RH
I4TTdCnlNG P4RTSI
NPSZZ~-ZB WP~HCR (12)211 5
YS2Lh9$-558 SCREW ´•´•´•r´•´•´•l.´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´• 3
63235-1)20-2112 W*SH~R 1785531 3
SFSYBC-LOSRS SCREW 1123211
M52469)-550 SCREW I) El\ REOD ON LH SIDEI L
MI2’1693-553 SCREW 3
---I---

2 861912-501 REVEnL, WINDOW IS~PLL IINDOHI 1

3 8b1952-Z ´•´•´•REY:~L, *INDDW´• LH IPL CTURe L
WINDUWI
Rb1952-1 ...´•RLYE~L. WINDOWI I(H IPICTURE
UINOOWI
L tblBBS-LL t BUMPEII FWD L
5 bbl889-13 BUMPERI PFT I
iL*SS INSTLI INTERIOR CbBINI LH C REF
RH
6 8b1R87-9 SLnSS, TINTED L
861887-19 GLb~S´• CLEIR
IITTICHING PPRTS)
7 nP35LOb-2*7 SCREW 3
8-532 ´•´•´•´•NUT(619)71 3

8 661887-5 CLIP 5
9 861887-11 CLIP 2
lo 86L987-15 BUMPER I
11 861881-3 tL*SS1 TINTED 1
861887-17 GLISSI CLEIR ´•´•´•´•´•´•´•´•´•´•´•´•.´•...r´•´• I
I*TTICHING PIRTS1
12 NS35206-297 SCREW ´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•1´•´•´•´•´•´•´•´•´• 8
8-R31 NUT I 619571
----Ii----

13 861887-27 CLIP ´•´•´•´•´•´•r´•´•´•´•´•´•´•´•´•´•´•´•´•´•-´•´•´•´•´•´• I

L) P~1BR7-PI CLIP, LH 2
861881-27 CLIPI 9H 2
15 811887-27 CLIP, LH 1
861587-21 CLIPI RH 1
II 861887-13 BUMPER
lbl 861987-29 CLIP, LH 8 RH FWD 2
861887-29 tLIPI LH 8 RH 4FT 2 4
IbTTbCHING PPRTSI
108 n535206-241 SCREW ´•´•´•´•´•r´•´•´•´•´•´•´•´•´•´•´•´•´•-´•´•´•+´•´•´• I
8-832 NUT 1~19511 1

130367-1 WINDOW INSTL´• PltTUREI Ln REr

333367-2 WINDOW INSTL´• PICTUREI RH REF
17 330367-’9 GLPISS, OUTSIDE IIM1LL nlNooul I

DPTION*L INSTI\LL*TION i\NO COMPONENTS

COOE EFFECTIYE ON IEHIIL NUMBERS

4 69as iIsso nNo SUBS

2-533
 ILLUSTRATED ROCKWELL
SECTION n PARTS CATALOG COMMANDER
BUBELAOE BSOA/B

FIGURE P I\ R T UNITS US98LE

6 INDEX O E 5 C R I P T I O N PER ON
NUMBER N U M B E R i 2 3 1 5 b I PISI CODE

2-59 L8 330367-11 GL4SS, INSIDE ISMILL klNOOW) I R

330367-55 GLLSS´• INSIDE I9ILL WINDOWI 1
I4TTbCHING PIRTII
19 SCREW 36
20 900106-513 GROMMET 36
Zi 330367-3L GPNG CHPNNEL, UPPER L LOWER Z
22 330)I7-29 r jnNG CH4NNELI FHU L nFT 2

23 330367-L7 RET*INER I
2) 330367-L5 SPICERI FHD E *FT 2
330367-51 SPICER, FWD L 4FT 2
25 330367-41 SPICER, UPPER E LOWER 2 R
)30361-53 IPICERI UPPER C LOWER .....´•....r´•´•
2 d
ILi 330387-9 GL*SI´• OUTSIOEI LH IPICTURE WINDOW) I
330367-10 SLlilSI OUTSIDE, RH IPILTURE WLNDOWI I
27 3303b7-7 GL*IS, INSIDEI LH IPICTURE YINDONI I
~303LI-B GL*SSI 1NIIDE´• RH (PICIURE WINOOWI I
IdTT*CHING PIRTS)
28 MS2lb91-560 SCREW .´•r.´•´•.´•.´•´•.´•´•....´•....r..... 115
29 900L0b-513 iROHWET LLS
30 330367-21 64NG CHINNEL´• FWD L
31 330)67-25 G4NG CHINNELI UPPER FWD I
32 330361-23 GPYG CHIYNEL, UPPER IFT I
35 330367-19 GING LHbNNELI bFT 1
1L 330361-21 C*NG CHINNELI LOWER L

31 330)61-15 RETIINER, LH L
330367-16 ..´•RETIINER~ RH i
36 SP*CERI FHO 1
31 33n367-4L IPICERI UPPER FWD i
38 330367-35 r r SPICER, UPPER 4FT I
39 330367-33 SPICER, *FT I
*0 390367-37 SPICER1 LOWER *FT
11 330367-39 IPICER´• LOWER FWD L
12 P*~314 r4PE (L/B" X 1´•0"1 176381) i\R C
R-~tl L-N T*P E I L/ 8" X I o") bR 3
R-’111-N ´•´•´•T4PE11/8"XI´•0") 48

CODE EFFECTIVE ON SERIIL NUMBERS

d 6908 11310 nND SUBS
a ~90d L1100 THRU 113*9
C bPO1 L110o THRU 11293
O 6904 1 6908 1129’, *ND SUBS

2-594
ROCKWELL
ILLUSTRATED
COMMANDER PARTS CATALOG BECTION n
Bg0A/B FUBELAOE

II
II

1
Tr~-ll

O
O t
sr

19"c~

~9s--2

1’*

Figure 2-60. rurel.8´• El´•rgen.y Exit Windo~ Inlt~llefion (Sheet 1 o( 2)

a´•355
 ILLUSTRATED
ROCKWELL
SECTION II PARTS CATALOG COMMANDER
FUSELAGE BOOA/B

FIGURE P P R T UNITS UI1Bit

I INDEX D E 5 C R I P T I O N PER ON
NUMBER N U M B E R L Z 3 1 5 6 I bSIY CODE

1-60 300001 FUStL PCE PSSY1 COMPLETE REF

330L12 DOOR *ND WINDOW INSTL. FUSELI\GE .´•´•.1.´• REF
BblBBS INTERIOR FURhlSHI~OS INSrL (SEE EIG´• REF
2-651
861955 *INDOH FRI\ME lNITLI EMERGENCY EXIT REF
I R61957‘L PINEL
I~TTI(HINC P*RTSI
2 NPiS388-6-9 SCREW
NI\S391PLP W*IHCR
HZ27130-8 RIYNUT

3 861157-50L PLNIL ´•´•´•´•´•´•´•i´•´•´•´•´•´•´•´•´•´•´• L d

861957-503 PINEL ´•´•´•´•r´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´• 1 e
5 R61956-1 R~VEILI WINDOW 1
d 861955-13 IE*L 1
861880 GLe.SS INITL. INTERIOR REF
7 86L880-11 GLPIS´• TINTED L
B61880-L9 GL*SSI CLE*R I
IbTTACHING P*RTSI
B M131206-P17 SCREW ´•´•´•´•´•´•´•´•´•´•1´•´•+´•´•´•´•´•´•´•´•´•´•´•´•´• 4
6-832 NUT 1~19571
---I---
9 861RR0-2L CLIP 1,
Lo 8L1.B80-15 BUMPER 1
333L09 EMERGENCY EXIT INSTL RtF
330113 t WINDOW INSTL ´•´•´•´•´•´•´•´•´•´•r´•´•´•´•´•´•´•´•´•´•´• REF
ii 330113-23 GLLSII OUTSIDE
12 330113-17 GL1SS´• INSIDE L C
630113-29 GL*ISI INSIDE L D
I*TTPtHING P*RTSI
13 USZ~b?4-ShO SCREW *4
II 900LO~-5L3 r GROMMET 4*
1) 330113-11 G*NG CH*NNEL

L~ 330113-1 TPICER C
330113-21 SPntER 4 D
17 330113-19 RETI\INER +´•´•´•´•´•´•´•´•rl´•´•r´•´•´•´•´•´•´•´•´•´• L
18 R-4I1-N TPPE ´•.1´•1.´•.´•´•.................. IR
330LOB 1 J*HB INSTL, EMERGENCY EXIT (StE RtF
FIG´• 2-521
L9 130108-’,5 SEPL
330109-11 H*NOLE nSIY 1
IPTTPCHINt PPRTS)
20 n52469~-156 i SCREW Z
---1---

21 330109-73 H*NDLE I
22 Li\8758-ISI-8-1 PL4CnHO (838311 +...´•..´•´•´•r.´•..´•.. L
I*TTPCnlNG PPRTSI
23 nSZ1039-L-LZ SCREW 2
----I---

2~ 330109-15 t LnTCn Z
25 330104-59 8118 *SIY. LH 1
)30109-60 i 8bR ~ETY´• RH L
IITT*CHING P4RTSI
2L PNZ3-18* BDLT´• CLEYIS 2
dN960-I~L WPSHER 2
M521014N3 NUT ´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•.1......... i

OPTIDN~L INIT*LL*TION IINO C(IMPONENTS

CODE EFFE~TIYE ON 6eR1*L NUMBERS

6901 L1100 THRU 11268
8 6906 C 6908 11269 *ND SUBS
C 690L LL100 THRU 11)19
D 6908 11350 *NO SUBS

21S18
 ILLUSTRATED
ROCKWELL
COMMANDER PARTB CATALOG SECTION n
BSOA/B FUSELAGE

32P
j-"
x’,-"7
--r-~

11´•4s*r
B

.n

i~ a

260. ~ureloge imsrgen~y 6xil Window inlfollolion (Sheet 2 of

2´•SS1
 ILLU8TRATED ROGKWELL
8ECTION n
P~RTO C~TALOO COMMANDER
FUSELACIE BOOA/B

FIGURt P 1 R T UNITS US*BLE

i.INOEX D E 5 C R 1 P T 1 O N PEI ON
NUMBER N U 3 8 E R L Z I 1 5 L 7 PSZY CODE

~-bO 21 330109-11 B*R´• LH ´•..´•´•´•´•´•.´•´•r´•´•´•´•......... L

)31109-78 B1R1 R~ L
28 330109-61 SPRINB L
29 330109-L9 LUPPURT 2
30 330109-71 SUPPORT ´•´•´•´•´•1´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•.´•. Z
3L 330109-85 WELD I\SSY I
~30LOR JI\N8 INSTL. EHERGENCI EYII ISLE FIG´• REF
2~5ZI
32 310108-35 STRIKER PLITE Z
IITT*CHING PPRTII
P3 MS27339-L-D8 SLREH ´•´•´•r´•.´•´•´•´•´•´•´•´•´•´•´•´•´• Z
---r)___

a´•538
ROCKWELL ILLU~TRATED
COMMANDER PARTI CATALOG sECTrONn
BgOA/B FUSELAGE

Y
1 "31
r~
12
’I
I~ I ´•I Y’ ~o

~i.ur´• 2-61. Moin Cobin Door Arl´•nbly ond inltollotion (Ih~´•t 1 o12)
2´•´•558
 ILLUSTRATED ROCKWELL
BECTTON II PARTS CATALOG COMMANDER
FUSELAGIE BO(IA/B

FIGURE P 4 R T UNITS USPBLE

c INDEX D E S C R L P T i O N PER ON
LUMBER N U M B F K L 2 3 4 5 6 T PSSY CODE

2-61- 300001 FUSEL13E PISSY, COMPLETE REF

330112 DOOR 1\NO n INDOW 1NZ TL 1 FUSEL*GE REF
861885 INTERIOR FURNISHINGS LhSTL (SEE PIG´• REF
1-651
86L909 WINDOW PRIME
INSTLI CIBIN DOOR REF
L 861959-1 PINFL PSSY´• CIDIN DOOR
2 861960-1 REYE*LI C*DIN DOOR I
86LBd0 GI.ISS INSrLI INTERIOR ´•+.´•...1.´•... REF
3 BhlBR0~3 GLISS´• TINTED L
861080-17 GLnSI´• CLF4R I
I*TT*CHING PbRTS)
nS35Z06-247 SCREW
8-032 NUT 1619571

5 BblBBO-~ CLIP, UPPER i

861880-5 CCIPI LOWER I
T 861880-9 BUMPER I
~302*1-103 DOOR ISSY, CIBIN I
330113-503 WINDOW INSTL´• Ci\BIN 00011 REF
8 330L13-11 SLPSS1 I NSIDE 1 i\
330113-29 GLllS. INSIDE I D
9 330L13-23 GLISS t OUTS IDE ...´•.....t I
(ITTICHING PIRTSI
10 SCREW 1*
L1 9UDL06-5L3 GROMMET ’t4
IZ I)~1L3-LL Gi\Ni CHI\NNEL

13 j90113-19 RETPINER L
T*PE IO´•0b2" SHEET, CLOSED CELL IR
RUB~TEXL
LS 330113-21 SPICER
330159-50L HINGE IYSTL, CdiBIN DOOR REF
L~ 310119-15 PIN 2
IPTT*CHING PIRTSI
nSIC5bZ-Z09 PIN I

Il 330368-1 HINGE n*LF IUPPER L LOWERI Z

InrTbtHING P?RTZI
IB MSP*b94-ILB3 SCREW L
19 VSZ*LT’r6)1 t SCREW 3
*N960D10L WISHER 3
nS2LO44N) NUT 3

20 330159-5 HINGE HILF IUPPER L LOWEI) 1

LI\TTICHING PIRTS)
ZL MI2469)-151 SCREW 4
---I---

21 3l0228-I 4RM1 C4D1N ENTRINCE STEP ICTUPTLNG I

23 330261-501 BRICLET *SSI, C*BIY OOCR I
850514 PRESSURE SEnL INSTL´• C4BIN DOOR REl
24 850134-7 TUBE
I*TT*CHING PIRTSI
MS2L919DG4 CL*E(P L
YS27039-L-OR SCREW 1
nN9hnDL0L WISHER I
*SZ10~4N3 NUT I

25 850534-5 TUBE rl´•´•´•.´•´•´•´•.´•´•+´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•.. 1

I OPTILNIL INSTbLL*TICN *ND COMPONENTS

CODE EFF ECTIYE ON SER I PL NUMBERS

b ~90* L1100 TnRU 11349
D 6908 L1350 INO SUDS

2´•540
ROCKWELL
ILLUITRATBD
COMMANDER PARTB CATALOG SECTION n
BSOA/B FUSELAGE

A B

4
,r;

~igure 2-61. Moin Cabin Door Pl.remblv and inrtallation IShest 2 of

2-341
 ILLUSTRATED ROCKWELL
8ECTION n: PARTS CATALOG COMMANDER
FUBELAGE 880A/B

FIGURE P ii R T UNITS US*BLE

L INDEX O E I C R 1 P I I O N PER ON
NUMBER N U M a t R L 2 3 I 5 6 T PZSY CODE

2-61 26 2628-1/4 UNICN 1303211

21 R50134-9 TUBE .´•´•..´•..´•+´•.´•´•´•´•´•´•.r..´•´•´•.......´•. L
LA nr35C89-6 GRO*MET 9
19 90-935 SEI\L, DOOR (0)4811 L
30 269-P-I/B-l/l ELBOW L30321) 1
31 Kl04-02HR COUPLING 1303271 L
32 CONNECTOR 1333271 ´•´•´•´•´•´•..´•´•r´•´•´•´•´•´•´•´•´•´• L
3) 51.5-201-4 YPLYE, 418 LIMIT I*LT P*RT 515-201-01 1
1439901
I*TTICHING PnRTS)
P4 MS31Z06-P19 ICI1EU 2
MSZLOA3Nos NUI I
---I---

35 850’130-25 TURE 45611 BLEEO ~IR IZEE FIG´• 2-36) REF

-36 MZZOBZ2-L-40 ELBOW ´•1´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´• 1
37 269-P-11)-L/4 ELBOW 130321) I
38 1106-L59-RNni\ PEGUL*TOR 1 439901 L
(~TTbCHING PIRTSI
39 nN92~-8 NUT ´•´•´•´•r´•r´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´• L
PINPI0-LZ16L kl\SHER ´•´•´•´•´•´•´•r´•´•´•´•´•´•´•´•´•´•´• I

)O 330241 ~ECHPNISH INSTL´• C*BIN ODOR (IEE FIG REF

2-621

2-543
 ILLVSTRP;TED
CIULFSTREAM PARTS CATALOG SECTEEU n
COMMANDER FUSELAGE
BOOA/BOOB

~g A

n B

5 1

kt 3
j.-- 1
I
´•r
‘P

2-61. Moin Cobin Door IShsst 1 of 6)

Revised: 28 November 1984 2´•549

 ILLUSTRATED OULFSTREAM
COMMANDER
SECTIONII PARTS CAT~LOO
esaA/esoB
FUSELAGE

FIGW(E P 1 R T UNITS USLILE

6 INDEX D E S C R I P T I O N PER ON
NUIII)ER N U N a E a I I I 56 I LEI* CODE

2-62 300001 FUEELIGE LSS*, CONPLETE REF

330112 DOOR C YINDOU INSTL. FUIELLbE REF
3~0111-503 DOOR EL8IH
L4111 L
80017~ ´•´•´•EPUIPI(ENT lNSTL. ELECTIIC)L (SEE REF
FIG´• 2-ii)
800501 SWITCN INSTLI CLBIN DOOR YLRNINb REF
1 JV-l ..´•´•.*CTU~TOR. IYITCH 1919291 1
800501-3 ~CTUITOR. SWIICH ´•´•´•´•´•´•´•´•´•r´•´•´•´• I B
V1-1 SYITCH´• C*8IN DOOR W*RHINt I
191929)
(*Tr*CnlHb PIR’ISI
3 N83)206-219 ICREY ILOCIUISHER L NUT ´•..1.´•´• 2
FUINISHED YITH S*ITCH)
1N9b0D1 i YISHER 18878168 SNITCH L ´•´•´•´•1´•
I
8RLCXETI

800572-1 BRICIET L
(*ITICHIHG P*RTI)
-I *IJIIOL´•LII ´•´•´•´•´•ECREY´•´•´•´•´•´•´•´• Z
1196008 VISHER
---I---

1161909 YINDOY FR*IIE IHSTLI CIBIN DOOR REF

(IEE Flb´• 2´•L11
6 86190e-31 DOOR LISI. E*ERGENC* DOOR I
RELIIIE
IITrlCHIHO PLRrSI
7 8121039-1-11 SCREY 2
8 IIGLIB-LC-YH-F IWITCH~ ENERGENC* DOOR RELEIIE L
17JllPI
---´•I-

80029(1 ´•´•´•LOCIINlfL, DOOR I*Fer* REF

9 8)3038~1 RELI* (REPLICES 833038-5051 L E
rLTrlCnING PLRTS)
SCREY 2
NUT
1N9L0D( YISNER 2

W10-06)9(1-00 SOLENOID 1
I*TIICHINO PIRTI)
-II LNIO~-8-( ´•´•ICREU

12 800Z9b~) 8810881 I
1J 800298 IPRIHC L
´•´•´•´•´•LIN~´•+´•´•´•´•´•´•´•´• I
(*TT*CHINC PLRTSI
800290-17 PIN ´•´•´•´•´•´•´•´•´•´•..´•´•1...´•..´•..´•´•´• L
*IZ(Lbl-l ´•..´•PIN. COTTER i
II nS10J92-1CI Pln´• FLITnE*D 1
1Hs60-10L i UISHER ´•´•´•1´•´•´•´•´•´•´•+´•´•´•´•´•´•´•..´•.´• L
8121665-132 r ´•´•´•´•PIW´•COTTER´•´•´•´•´• L

-II ´•´•´•´•´•WLSHER´•´•´•´•´•´•´•´• 1
18 800296-(1 LINK

CODE EFFECTIVE ON IERIIL NU*BERS

1 6906 L1I00 THRU 113)9
B 6908 11)50 *ND SUBS
E 6908 11350 THRU 11516

a-944 Roviasri: 28 Navon~ber 19RI

ROCKWELL
ILLUBTRATED
COMMANDER PARTS CATALOG SECTION n
680A/B FUSELAGE

A.

23 1 I\A Il Yi~--20

w ii

´•J 12

ol

figure 2-62. Main Cabin DaDI ishest 2 af 61

2-545
 ILLUITRATED ROCKWELL
SECTION n PARTG CATALOG COMMANDER
FUSELAGE B(OA/B

O
,B I ;n,,
T,.,,,,

13

’:i n
´•u

35 38 11

31

31

II

figure 2-62. Main C~bin Door M8lh~niln (Iheet 3 of 6)

2-348
ROCKWELL
ILLUSTRATED
COMMANDER PaRfs CATALOG BECTION n
BBOA/B FUSELAGE

IIGURF P 1 R T UNITS UZIRLE

E INDEY D E I C R I P T I O N PER ON
NUMBEP N U Il B F R I 2 i S 6 7 4SIY CODE

2-62- 19 800290-13 ´•..´•´•*RM´•´•´•´•´•´•´•´•´•´•´• 1

IITI*CHINF PIRTSI
ZO 4N3-bd BOLT 1
21 NbZ13nT3-lb IPICER 1
4NP60-IOL W4SHER ´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•r.´•
1
MSL~083N3 NUI´•´•.´•´•´•´•´•´•´•´•´•´•´•´•´• 1
22 1N3-ll~ BOLT
SPI\CiR L
24 Nb543HT5-lb SPICER I
4N960-516 W4SHER
----I---

25 800296-51 S PH LNG I ELE CTRL C4L W LLE HGU Si NG 1

800296-35 rUBEI SPRING GUIDE
26 130208-1 ..´•BIYONET
I4TTICHING PbRTSI
27 *521031-OBLI SCREW ii i
-026´•611 L
YSZ1039-0821 SCREW 1
4N9LO-BL WLSHER 1
*SZ10~2-08 N~T I
---1---

28 330204-501 GUIDC´• BIYONET 1

29 bN3-71 BOLT LR
30 MSZ*b94-55T SCREW 2

31 4N3-IIb BOLT 2
-32 PN)-LSn BOLT L
33 4"13-L94 BOLT I
34 Ni\S75-3-O~P BUSHING 23
4N’60010 WISHER 23
NIZIOL~N) YUT 23
35 330231-503 SIYONET d
36 330243-501 GUIDLI BbYONCT
31 330243-)03 GUIDEI 84YONET 1
~B F35-1C 9DD LND 113L)ll 3
(nTTnCHING PPRTS)
bN3L6-9R CHtCKNUT

39 FL34-14 KOD END (13L34)

I4TT4CHLNG P4RTS)
4N31h-4L CntC~NUT i

10 900009-*9-9´•70 RUD nSSY ILESS ROO ENDS L 2

CHICKNUTS)
ii 90001U-49-7´•ZZ ROD *SSY ILESS ROD ENDS 6 L
CHECKNUTSI
42 330221-1 STRnP 1
43 330212-L LINK
330205-1 SELLCRP~K ´•´•´•´•´•´•r´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•
L
15 )30333-1 8tL LCRI"IK 1
16 330201-1 dELLLRnNK i
"7 330230-1 BELLCHINU 2
Is MSZIZ52-5RS CLtV1SI RDD END
P4RTSI
49 PN*-IPI BDLT 1
50 NnS75-~-001 BUSHLNG 1
~N960-41b WISHER I
nSZ1~4*N* NUT I

a-341
 ILLUSTRATED
ROCKWELL
SECTION n PARTS CATALOG COMMANDER
FUBELAGE 880A/B

~T1

38 li~t_28

II

~Udg-::

~iQurs 2-62. Main Cobin Door (Sho´•t 4 of 6)

2-948
 ILLUBTRP;TED
PARTS CATALOG
680A/B
 ILLUGTRATED ROCKWELL
BECTION n PARTB CATALOG COMMANDER
FUBELAOE BBOA/B

FIGURE P b R T UNITS USABLE

C INDEX D E I C R L P T 1 U N PLR ON
NUMBER N U n a E R 1 i 5 6 7 aSSu CODE

2-62 ii 330209-1 ROD IALT PART 330318-1) i C

330318-L ROD ´•´•.´•´•r´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•

L D
I*TTICHING PIRTSI
52 *N3-lA BOLT I
53 N1\S71-P-005 BUSHING L

Ll*175-3-003 ´•´•´•BUSHl"lii´•´•´•´•´•´•´• 2
IN960-10 WASHER 1

MSZi04~N3 NUT L
---t---

ji 33011~-1 CLEVISI ROD END 2

IATT*CHING PARTS)
55 nN3Lh-CR CHECKNUT 1

56 900013-)´•)6 ROD i
H52791~-3 tLEVISI ROD END 2
I*rTIIHLNG P4RTSI
58 4N316-IR CHECXNUT L
---I---

15 900009-23-16.91 ROO *SSY ILEIS ROD ENDS t I

CHEC~NUTSI
b0 3)0365-L ROD ISSY L
6L 330206-1 lELLCRINK I
62 330234-501 GUIDEI 841ONET Z

63 LE-034t-10 SPRING 1848301 ´•´•´•´•´•´•´•´•´•r´•r´•´•´•´•´•´•´•´• I

b’t 330328-1 r ROD 1
IbTTICHING PARTSI
C5 *N9L6-~R CHECI(NUT 3
---I---

b~ MS21P71-3 ~LEVIS, ROD END .r.´•....´•.´•......´•.

L
IbTTltnlNG PPRTS1
67 PN3-lb BOLT L
MSZ1083N3 NUT L

bB 330)22-1 BELLLRANK L
I*rTACHING PIRISI
as aNa-an BOLT ´•´•´•´•´•´•´•´•´•´•´•-´•´•´•´•´•´•r´•´•´•-´•´•´•´•´•´•´• L
10 NPiSll-3-009 BUSHING 2
liN460-IOL WISHER 2
---1---

71 330325-1 SUPPORT. TIE PLPTE 1

Tl 33032~-1 PL4TE ASIYI BACKUP L
73 330323-1 CLIP L
I~ 330236-1 EYEBOLT 1
IlTTACnlNG PIATSJ
75 AN3-5A BOLT I
l(i NPlll-9-0~5 ..´•BUSHING 1
YSZIOB)N9 YUT I
---~i---

II SWI958 SPRING (172301 L

78 330133-1 ROCKER .´•´•´•´•´•r´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´• 1
19 HS51966-54 SETSCREW 2
2385-7 LATCH HANDLE nSSY 1801111 1
80 LFIZ6 LEVER HANDLE (80117) L
IATTACH(NG PPRTSI
81 LP585 PIN 180*771 I

-82 LE)28 ETCUTCHEDN I BOlt711 I

83 LJ470 WISHER. TEFLDN 180*171 a

CODE EFFFCTIYL ON SERIAL NUMBERS

C 6901\ LL1D0 THRU 11226
D 690b E 6908 11221 AND SUBS

a-SSO
QVLFSTREAM ILLUSTRATED
COMMANDER PARTS CATALOG SECTION n
st0A/asoa FU8ELAOE

"1

1~
L

,g
83
"I~a 52

jil~
9’ 33 ~1( lo I id
st

I II" Cso i~"

~i.ure 2-61. Main Cabin D~or Methanilm (Ihest 6 a1 61

a-951
 ILLUSTRATED OULFSTREAM
8ECT~Chln PARTS CATALOG COMMANDER
FUBELAOE eeoA/e8oB

FIGURE P L II T UNITS USIB~F

C INDEX D E S C R I P T I O H PER OH
NU)lsER N U n a E a I i 5 b I ~ssr cOoc

2-~2 81 L11I79 HUB CR*H* *151 (801111 1

(ITTltHINb PLRTSI
85 HSL0391-ZC29 Pin L
XUII Y1SHER 180*11) I
*SZ)L65~1)0 PIN, COTTER 1

-86 LI1(1L H*NOLE *111, FLUSH I BD(III 1

L286~ ..´•´•´•RDLLER´•UPPER 1801111 L
L2Bb~-l ROLLER, LONER 1801111 I
15111)98 PINI ROLI.ER .´•´•´•´•´•´•.´•´•´•´•´•´•´•´•´•i. 2
81 NO HUIBER PIN L
BE LS)50 ZPRINb 180(11) 1
~89 LLSbr) SPINDLE 180(111 L
EECUTCHEON CISE *551 180)11) I
90 LV388 COVER 180(11) L
(ITr*CHIHC PLRTEI
91 ICREY
---1---
92 LtBb3 ´•´•´•´•GIII(Er180(111 1
93 ClIsl CILINOIR 1551 (80)771 I
9~ 1RI)-T(bi9 XEl (SPECIFI LIRPLIHE SERIIL
NO´•1
95 *2292 NUT (801111 1
96 LE129-500 ´•´•´•´•´•ESCUTCHEON´• HIHDLE IBLI))I)
33011) JLIIB INSTL´• CIBIW DOOR REF
-91 33015)-1)5 BLOCI( RECEPTLCLE´• FUD
98 330L53‘1)9 BLLOCK RECEPT*CLEI UPPER
-99 330113-!51 BLOCI RECEPTICLE, IFT I

2-552 Revised: aB Novembtir 1984

 ILLU~TRATED
ROCKWELL
COMMANDER P~RTS IECTION n

690A/B FU8ELADE

a g,
Ib

1-63. Step inltollolion Cobin Entr~nre (Iheet 1 of 2)

a-553
 ILLUBTRATED ROCXWELL
SECTION n PARTI CATALOG COMMANDER
FU8ELAOE BOOA/B

FIGURE P P R T UNITS US*BLF

C INDEY D E S C R 1 P T I U N PER ON
hUHBER N U M B E R I i 3 1 5 6 7 *SSY CODE

2-69 300001 FUStLniE *SSY´• COMPLETE ISEE FIG´• 2-501 REF

340000 .STEP LNSTL. CIBIN REF
1 3*0010-19 TUBE *SZY1 INNER I n
340000-39 TUBE ISIY´• INNER 1..´•.´•´•.´•.´•..´•...... 2 B
I4TTICnlNG PLRTSI
2 P.N’1-14I1 ´•´•BOLT´•´•´•´•´•´•lr´•´•´•´•´• ´•´•´•´•´•´•´•´•´•´•´•´•r´•-´•´•´•´• I
3 N1\576-1-I -0 L BUSHING ´•.r 1
WISHER ´•´•´•´•´•´•´•r´•´•´•´•´•´•´•´•´•´•´• I
---I----

4 nS90*8-041 PIN, ROLL Z

I)U090-P7 KEI 2
InTT*CHINC P4RTSI
O nN21-ll BOLT I
nN9~0-l.lbL WISHER I
nslraza-l NUT L
MS24665-L3~ PINI COTTER 1
---t---

7 1~0000-33 TUBE LZSYI OUTER i

I4T~ICHING PIRTSI
B 1N4-lb BOLT L
INI60-4L6L I WISHER 1
---II----

340000-3L THE*D´• SbFETY H*LK 1

10 )~000L-1 STEP *S5Y´• C*BLN 1
3)0001-501 STEP
nSSY. CPBIN 1 B
II MS-50721 PLUG BUTTON IL1Bb~) 1
560000 CONTROL INSTL. CIBIN STEP REF
12 56-3615-221 9 C48LE i\ZSI ILESS CL EYISES L LHCCINUTS I L
(800971
IILT P*RT CSNL1Z~PIZ (800911
13 MS27975-Z CLEYIS ´•..1............´•´•´•............. 2
IPTT*CHING PIRTSI
L4 INZ4-1O BOLT L
PNYbO-4LbL WISHER 2
MS17026-~ NUT I
MSZ~665-LI* PIN1 COTTER 1
MS20392-3til PIIVI CLEVIS ´•´•´•´•´•´•´•´•´•´•´•´•1´•´•´•´•´• I
nS2)665-L32 P1N I COTTER r L
---I_--

15 nN31~-4R tHECKNUT Z
16 560000-11 TUBE ISSY IINCLUOES ROD ENDS L 1
CHECKNUTI
IITT*CnING P*RTSI
17 INI-lI BOLT 1
dN960-4L6L WISHER I
MSZ1042L* NUT I
iB bN4-Lld r BOLT L
*N960-*16 WISHER I
19 NnS17-*-19 BUSHING I

20 HM-* ROO END 113134) I

21 1N316-4R CHECKNUT
PL 56(1000-11 TUBE ILESS RDD ENDS G CHECKNUTS) I
23 560000-9 BELLCRINK ISSY L
21 bNI-20* BOLT
25 N1\575L-115 BUlnlNG I
bN96~-416L WISHER 1
26 560000-55 LINK 1SSY (INCLUDES ROO ENDS L I
CHECKNUTSI
27 nY316-4R ´•.~nECKNUT 1
28 *N3Lb-5R CHECKNUT I

CODE EFFECTIVE ON StRLnL NUMBERS

690* 1L100 THRU 1130)
B a~on E 6908 11305 nND SUBS

a-364
 ILLUSTRATED
ROCKWELL
COMMANDER PARTS CATALOG SECTION n.
68(IA/B FUSELAGE

13
25--C4
I~
22~ 19

r´•,

Is

31~ ZE 21 26 ~30
38--~ j
l.i

B
o

36

Figure 2-63. Step inlt.llation C.bin 6ntr.nre 15heel 2 of

2-555
 ILLU8TRATED ROCKWELL
8ECTnrr n PARTS CATALOQ COMMANDER
I~U8ELAOE 880A/B

FIGURE P P. R T UNITS USIBLE

C INDEX D E r 0 R I P T I D N PER ON
NUMBER N U n B t n I z 5 b I nnsv caoE

2-63 29 nRE-P-ZD ROO END 151)C81 L

(4TTPCHING PdRTSI
-30 n5)7039-L-11 SCREY L
bN9bO-I~L WLS~ER ´•´•´•´•´•+´•r´•.´•´•´•´•r´•.´•...´•........
1
nSZL0’12L3 t NUT 1

31 8853100 ROO END islllbl L

IPTT*CHINO PIRTSI
32 HI27039-L-Lb SCREH
4N9~0-10L ´•´•WPSHER L
YUT L

33 )60000-57 LINK ILESS ROD ENDS G CHECKNUrSI 1

34 160000-59 BELLCRINK bEIY ´•´•´•.´•´•´•.´•´•´•´•´•´•1´•´•´•´•´•´•1´•´• 1
I~TTICnlNG PbRTII
35 IN*-L)P BULT ..´•.r´•..´•´•´•....´•.....´•..´•´•´•....... 1
36 N151~-*-028 BUSHING ´•´•´•´•´•1´•1´•.´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´• L
i\NP60-~16L k*S HER I
---L---

560000-13 STOP PSSY L

I~TTICHING P4RTI)
31 HSZ1039-1-10 SCREH Z
i\N960DLo Ui\S HER i,
2
HSZIOIIN3 NUT 2

,a iias RUYPER. RUBBER 1704851 I

39 PLUNGER 1012261 1
~D )60000-65 STOP L
*1 330228-1 nRH, CIBIN ENTRINCE STEP bCTUn~lNG ISEE REr
FIG´• 2~611

a-888
ROCKWELL
COMMANDER
ILLUSTRATED
SECTMIN n
69DA/B PARTS CATALOG FUSELAGE

"j:

i´•
A

C= s

Figure 2-64. ~ulelogs Bogeoge DDDI

2-351
 ILLUBTRATED ROCKWELL
8ECTION II PART~ CATALOG COMMANDER
FU~LAOE BOOAIB

FIGURE P R T UNITS USLBLE

L INOEX O E S C R P T I O N PER ON
NUMBER N U n a E n 1 z 4 z a I aSSY COOE

2--61 300001 FUZeLnGt bSSI, COnPLETE 1

330112 ODOR nND WINDOW INSTLI FUSELIGt I
330118-501 3O0R INSTLI BIGGPGE L
I IsDIIS-bl L(IC K 127998L
bSSI L
(4TT*CHING PIRISI
2 NS20392-2CZ) ´•-PIN´•HINGE P

dN9bO-IOL WISHER B

NS2*b65- i 32 PIN1 CUTTER 2

---1---

3301L8-53 .nlNGE bSSY, 8*GG*GE DOOR 2

-4 Nn57L-3-OLP ´•´•´•BUSHING L
5 330118‘39 ..´•´•COY~R......´•´•.. ´•.....´•´•´•´•´•´•r.´•.. I
I*TT*CHING P~RTSI
6 4N530-PRd SCREW 4
---L---

7 3029-1 LOCK ISSY 1219981 ´•´•´•´•r´•´•´•´•´•.´•´•´•´•

1
8 IRIS-TYPE 2 LOCK 1804771 ´•´•´•´•´•r´•´•´•´•.´•´•-1-´•´•
L
9 1)0160-501 ´•´•´•STRIKER 1
I*TT*CHING PPRTSI
LO M9270)9-0801 SCR tW i L
1N96008 WISHER
NUT ´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•r´•´•´•´•´•´• I

ii 130118-37 CLIP ´•+´•´•´•´•´•´•r.´•.´•.................

L
12 330L1R-3l CPBLE PSSY L
I*TTbCnlNG PIRTS)
13 NS21039-L-LO SCREW 1.´•.. I
bN9bO01O WISHER I
HSZIOIIN3 NUT ´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•1´•´•´•´•´•´•´• I
---~i---

3)0118-51 SE*L ´•´•.´•´•´•´•´•´•´•´•´•´•.´•´•´•´•´•1´•´•´•+´•´•´•´•´•´• I

2-968
aULFSTREAM ILLUSTRATED
COMMANDER PARTS CATALOG
seon/aooe

~i’3

risur´• 1-65. In~arior ~urnilhinp. In.t.ll.fion IShs.t

1 of 5)
 sECTICDU II ILLUSTRATED GULFSTREAM
ITERIOR PARTS CP;TALOO COMMANDER
FURNLSHINOS 880A/BB08

FIGURE P I R T UNITS UIIBLE

6 INDEX D E 5 C R I P T I O N PIR ON
MMBER NU WE E R 1 2 3 56 1 LISI CODE

2-65- 861885 INTERIOR FURNISHINbl INSTL REF

861026 FURNISHINCP´• INTERIOR REF B
861009 OXIGEN S*STE* INSTL´• PRII(IRI.´•´•.´•..´•´•´• REF
1 2120580 1SH TRI’I´• PILOT P COPILOT (128821 ´•.1 Z
IITT*CnlHG PIRTI)
1 111(693-5)1 ICREW

C´•ll JLCI(8I3Bs) Z
ILB ~1CI(, PHOIE (82)891 Z
860211 BOOT INITL, RUDDER PED*LS REF
5 860227-7 8007. PILOT PEDILS (INCLUDEI COVER L
FOR BRIIE Y*LYE LEVER)
6 860227-9 BOOT´• COPILOT PEDILI
(ITT*CHING P*RTS)
I 1Nl)lTYB2 CLInP rlNSTLLLI 88688 YLLVE LEVER L
COVER 10 8Ll(n0 I1N PILOT 510E1
B INI)ITY)D CL**P..´•..´•...´•´•´•´•´• L
9 LNIIITWSB r CLI*P L

-10 860121-11 ´•´•PLUG´•´•´•´•´•´•´•´•´•´•´•´•´•

‘11 8b0127~L3 ´•´•PLUC´•´•´•´•´•´•´•´•´•´•´•´•´•
12 860227-17 I(ETIINER, Ln OUTED I an rwso
I, 860227-19 RET*INER´• LH INBD r RH OUTED Z
860618 GUST LOCK INI’IL REF
Il NLI NU*BER CLBLE rlll* ICOIISISTS OF CLI)LE, I
SLEEVES L PINI
15 860625-1 TUBE
16 860627-1 ´•´•TURNII*RREL 1
LI (1~0621´•L UELD *SSI´•´•´•´•´•´•´•´•´•´•´•´•´•´•´• 1
-18 860629-1 BR*CIET 1LI* L
(*TTlCHING P*RTII
SCREY ´•´•´•i´•´•´•ti,.l,´•´•´•´•´•´•´•´•´•,´•.´•´•´•´•´•´•
IN9LO-IO WISHEI´•´•´•´•. i.´•´•il..´•´•´•´•´•.,´•´•´•´•
152108313 NUT

B~Lsll FIRE EITINGUISHER INSTL REF

IP FRP 112 FIRE EXTINGUISHER INO BRLCXEr IOL)561 1
(*TTICHING PIRTS)
*HI-121 BOLT
*N960-l16L U*SHER
*I210I)N) NUT

161893 OVERHE*D PINEL IHSTL, tOtlPIT REF

20 RB´•b7‘1-8 KNOB(8619)) ´•..´•´•..´•1´•´•´•´•´•´•.´•....... Z
)1 1102 RHEOSTIT. LH (1)655L L
SE-L)010 RHEOSTIT. RH I((bl41 L I
JIIH0961I02)1 POTENrlO~ETER Z B
-23 LlbHT 1129111 (1291)1 2
860783-559 PLICIRD r PILOT INSTR´• L I bnTS I L C
860783-607 PL*CII(O I PILOT INITR´• LIGHTSI L O
P~ 8(0183~1113 PLICIRD IELEVITOR TRI* 118) I C
860783-603 PLIC*1D IELEVIT(I(I TRln TIE,....., I o
Pb 86018)~)57 PLICLRD IRUOOER IRln T1B1 I C
860783-605 PL LCLRD IRUDDER TRIW T*II) I D
27 860783-561 PLICIRD (COPILOT INSTR´• LIGHTSI I C
860783-609 PL*CLRD ICOPILOT IHlrR´• LI6HTSI 1 D

CODE EFFECTIVE ON SER I1L NUNBF((S

P 6901 l1lDD THRU LLZbB
B 690* 6908 11169 INO SUBS
C 6901 11100 THRU
D 6908 113501ND SUBS

a´•380 ilcvialli aR Novclob~l 19RI

 ILLUSTRATED SECTION n
ROCKWELL
COMMANDER PPIRTS C/LTALOO INTERIOR
FURNISHWOS
690A/B

rff~

22
,Y a

5~’

s~
211 i. i h. j S

lilure 2-65. Interior ~urnilhin(ll ISh´•´•, 2 of 5)

2-361
 BECTION n ILLUBTRATED
ROCKWELL
~NTERIOR PARTI CATALOG COMMANDER
FURNISHINGS 880A/B

F o

’1
13 ill

MODEL BBOA
11100 THRU 11Yg.

131

MODEL BgOB

11310 AND SUB3EOUENT.

12 le~ I xll~ll

Eilur´• 2-65. Inbrior iumilhingl inlt.ll.tion ISh´•´•1 1 of 5)

2´•183
AOCKWELL
ILLUSTAATED
SECTION n
COMMANDER PARTS CATALOG INTERIOR
BgOA/B FURNLSBI08

F IGURE P i\ R T UNITS USIRLE

i. INDEX D E 5 C R I P T I D N PER ON

NURBER h U B E 1 12 3 5 6 7 1SSY CODE

2-65 28 8L1033-505 ESCUTCHEON1 Ln 1

e61033-507 EICUTLHEUNI RH
IITTPCHING P4RTSI
30 S-0395P1-B SCREW ´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•r´•´•´•´•´•´•´•´•´•´•´•´•
i
NdSI~*-l NUI i

8(11892 OVtRnEdD PLNEL INSTL´• C481N REF

31 SCZCXNI-P6 SWITCHI RE40LNt LIGHT (IZ9Lll

SU534P11-E BELEII SWITCH 11241*)
32 L[I-0549-38-C ´•´•OUTLETI blR (7291)1 3
i\lR 183)6’11 i n
2533 OUTLET.
16LB92-3 GbLKET i b
33 ´•´•´•I´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•

861892-25 GnSKtT
3" 10-0121-78-C-2 LIC´•HT nSsI 1129141
25L0 LIGHT 1SSYI REbDING (R3J6*I 4 D

jj B11521-5L3 LSCUTCHEON 3
PL15Z1-SZ1 ESCUTCHEON 3 8

861521-51) ESCUTCHEDU 1 RH 4F T 1

861521-523 RH *FT I B

36 861521-50L BOX dSZY IStE FIG´• 2-7LI REF

861001 ~RESH 418 INSTL´• COCKPIT REF

.37 LO-o519-38-C OUTLET, bIR I129141 2

38 DCLO~C-IOI DUCT CSSY~ LH

861008-502 DUCT bSSY´• RH .´•´•1´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•
i

39 860*7*-903 OUCT´• FRESH PIR 2

40 86L951-l1 HEIDLINER nSSY´• LH FWD 1

T61951-7) HEPDLINER nSSY. RH FWO I

41 00195L-P5 HEPOLl~tR *SSYI LH IFT L

LbI951-67 .HEbOLINLR ISSY´• RH bFi L

861041 SWITCH LNSTLI C*BIN LIGHT REF

’12 516-7015-51-927 r SWITLH´• CbBIN LIGHT (R103’h

SC5DFP59-1-9-Pb SWITCH (007521 L

43 86101L-3 FSCUTC HtOY L C

861011-5 ESCUTtHEOY 1 D
ibTTltHlNG PbR7S)
M124693-527 SCREW Z
dN960-516L WISHER 2

4-SJN I~CK NUT ´•´•´•.´•´•´•´•´•´•´•´•´•´•´•-´•´•´•´•1´•´•´•´•´•´•´•

2

131 R6L04L-T OECIL I D

5~1035 *SH TR41 INSTL ´•´•´•´•´•´•´•´•r´•´•´•´•´•´•´•´•´•´•´•´•´•´•´• REF

112~-4 *IH TR/I (346961 9P

15 861035-3 POCKET -´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•1´•´•´•´•+´•´•´•´•´•´• bP

16 A61035-5 CLIP ´•´•´•´•´•´•´•´•´•´•´•´•´•1´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•

bR

8L19LB-L LU*T HINGER INSTL REF

L7 86109L-501 ESCUTCHEON 2

IPTTICHING P4RTSI
18 SCREW ...............1.´•.............
2

*9 8619iR-5 CLIP Z
50 8L039L-50L PIYOT PSSYI CO1T HINGER
I~TTPCHING PLRTS)
51 YS27039-1-08 SCREW I
dN9I0D1OL WISHER 1
MSZ104~N3 r NUT I
52 4N4CLn BOLT
dN9600*16L WISHER L
---(i---

tODE tFFECTIYE ~N SERIPL NURBERS

n ason 11100 THRU 11268
B 690* L 6908 11269 *ND SUBS
C 690* 11100 THRU 11349
D 6908 11350 1ND SUBS

a-363
 BECTION n
ILLUSTRATED
ROCKWELL

FURNI8Hrm08
EASTS CATALOG COMMANDER
BOOA/B

se A

se 82

I I se

C
9,,

Ea--8
B’

’0’

~ipure 2-65. Int´•rior ~urnilhingr )n~toll.tion (Sh´•´•1 4 .f 5)

a-984
 ILLUSTRATED
ROCKWELL SECTION n
COMMANDER PARTS CATALOG INTERIOR
BgOA/B FURNISHINGS

~I

Pi.ure ?-65. Int´•rior ~urnilhinsr inltollotion irheet 5 of 5)

a-365
SECTION n
ILLVSTRATED
ROCKWELL
INTERIOR PART8 CATALOG COMMANDER
rURNL4HIN08 BBOA/B

FIGURE P P R T UNITS USLBLE

8 INDEX D E S C R I P r I O N PER ON
NUnBER N U H B E R I 2 3 4 1 6 I bSSY CODE

2-65 13 860510-551 SPRING, RETURN, PFT .´•´•´•´•´•´•r´•´•´•´•´•´•´•´•´•

L
51 Rb~110-502 SPRIYG´• RETURN´• FORWI\RD I
55 NSI6lhd-PLl PINI ROLL ´•´•´•´•´•´•´•´•´•´•´•´•´•1´•´•´•.´•´•´•´•´•´•´•´•´•
-46 9110099-´•032-.50- .80 WISHER
57 861090-1 HP~GER *SSY ´•´•´•´•´•´•´•´•´•´•´•´•´•´•r´•´•.´•´•´•´•´•´•´• Z
IPrTPCHING PPRTS1
)8 MS161bZ-15 PI"I´• ROLL I
---li---

64 861090-7 KNOB I
IITTICHING P4RTS)
60 MSLb56Z-1~ PINI ROLL ´•..´•..´•....1........´•..´•. 1
---I---

61 810386-501 SHPFTI PIYOT I

62 RIIPLO-3 r BICKING L
63 CS9b00-3 SEPT BELT (IPECIFY COLOR DEIIREDI PR
1323921
tl B~L899-L SLIT PSEYI PILOT IWITH UPnOLSTERYI I
861899-5LL SEPT dSSY, PILOT IWITH UPHOLSTERY) 1 F
861819-513 SEPT PSSY. PILOT IWITH UPnOLZTERII L 6
861899-2 SEPT *SSY1 COPILOT IWITn UPHOLSTERYI L t
861899-512 SE*T *TSI´• COPILOT (WITH UPHOLSTERY) L F
861899-514 SEPT *SSY, COPILOT IWITn UPHOLSTERY1 L G
61 5840-5 S EPT Il ZY IWITHOUT UPHOLSTERY I
134888)
BbOD05 TRICK INSTLI PILOT PNO COPILOT SEPT REF
16 nSI6561-IZ PIN, ROLL I
67 860005-21 TRPCKI PILOT StPr. OUTBO
(160005-28 TR~CK´• COPILOT SEPT1 INBD 1
860(108-29 TRPC~, PILOT EEIT´• INBD .´•-´•r´•.´•´•.´•´•´• 1
Bb0005-30 TRICK, COP LLOT IE1\T, OUTED L
IITTICHING P9ITSI
L9 MSZ7039-L-Ln SCREW
-70 1152703~-L-09 SCREW 2

71 B61P00-L SEPT *ISY´• PbSSENGERI LH IWITH dR E

UPHOLSTERYI
861900-513 SE*T PISI´• P*SSENGERI LH IWLTH dR FG
UPHOLSTERY)
861900-2 SEPT I1SSI, PPSSENGERI RH 1 WITH PR E
UPIIOLZTERII
861900-51) SEPT 4SSYI P*SSENGERI RH I WITH na Ft
UPHOLSTERYI
72 5810-1 SEPT ISSY, LH (UITHOUT UPHOLSTERYI I
13*b9~)
5810-2 IE4T PSIY. RH (WIT*OUT UPHOLSTERYI i
1316961
13 5816 nEIO REST *SSY (346961 I i\
7* 861902-1 COUCH PSSY IWITH UPHOLSTERYI 1
75 5520 COUCH nSsr iw/o uPHOLSTtRv, 1346961 I
860210 TK4CK INSIL´• PPSSENGE9 IEnT REF
lb 860212 STOP PSTY. SE*T TRICK B
77 R60238-505 TRPCK, P*SSENGER SEPT .´•...´•.´•´•.´•.´•r´•
I

IPTTICHING PdRTII
IB MSZ4694-597 SCREW *R

861886 INTERIOR STRUCTURE LNSTL...........´•´•. REF

SblOo( LIGHT i\SSY´• 51DE REF
79 FIlT5/WN/RS/C BULB ISYLYPNIP´• WICHITdl KS1 R

CODE EFFE~TIVE ON SERlbL NUMBERS

b901 11100 THRU LLZbB
E 690* 11100 THRU 1lZIB
6904 LIZSO TnRU 11268
F 6904 11249 THRU 11219
6904 B 6908 11269 THRU 1I)8*
G 6908 11485 dND SUBS

2-588
 ILLUSTRP;TED
ROCKWELL
COMMANDER PARTS CATALOG SECTION n
690A/B ENVIRONMENTAL

St

Y~ j~hRY jV ZI\ II

r la 12

r i
9 ~Y -.‘O
/r
L II

Fieur´• 2-66. Duel Outflov Indollati~n

2-)61
 ILLUOTR~TED
ROCKWELL
SECTION n PARTS CATALOG COMMANDER
ENVIRONMENTAL BOOA/B

FLGURE P R T UNITS USPBLE

C INDEX O E Z C R I P T I O N PER ON
NUHBEH N U n B E R 1 2 9 4 5 6 7 assv CODE

P-Lb 880170 PREISURIII\T ION E9U IPMENT INSTLI COMPL tTL REF
880583-503 DUI\L OUTFLOW
YI\LYE INSTL, REF
PRESSUR114TION
880583-3 TUBE nSSI. YICUUM INITRUMENT PIR L
120046 HPNIFOLOI YLCUUM ISEE FIG´• 2-35) REF
3 080583-33 HOSE 4SIYI CONTROL blR L
885683-31 HOSE ~SIYI ITPTIC I
890533-37 HOSE PSSV. CONTROL *IR L
88’)583-39 HOSE diSIYt CONTROL LIR
IITTP~HING PIRTI)
NPS)II-8 CLIHP 1

I 880)B3-~L HOSE, CONTROL IIR 1

e B8o,s,-*I HOSE, CONTROL nlR L
PPRTS1
NdS357-8 CLIHP i

9 nSZ0822-ID ELBOW ´•´•1´•´•´•´•´•´•´•´•´•´•´•´•..´•.............

10 nSZCRZ6-*O TLE ´•´•´•´•´•´•´•´•´•´•´•´•r´•´•´•´•´•´•´•´•´•´•´•´•´•r´•´•´•´•´•´• L

LL PNDlb-LO NIPPLE
iZ 117 Y9LVEI SHUT OFF 1321111 1
IITTI~HING P4RTSI
II nN9L5-b-5 SCREW 2
lN960-6 UISHER 2

14 nN8L5-40 ´•´•UNION
5-0309-904 O-RING 2
15 PCI)O CHECK YILYE I*LCD CDRP´•I OKLIHO*P L
CITYI Dll
5-0309-901 O-RING ´•´•r´•´•´•´•´•´•´•´•´•´•´•´•..´•............ L
Id L303C6-4 CONTRDLLER. C*BIN PRESS 1702101 (SEE REF
FIO´• 2-)21
Il 61838-40 ELBOW 1
Le 880583-21 ELBOW I
I*TTICHI~G P*ATSI
19 NUI 1´• L
nN960-116 WISHER L

)D 880583-21 ´•´•CONNECTOR i
I9TTICnlNC PIRTSI
ZL iiNP24-40 NUT ....r´•.......´•´•.................. I

22 L03510-5 YI\LVE´• OUTFLOW 1102101 Z

´•r´•´•´•´•´•´•´•´•´•´•´•´•

I4TT*CHING PPRTII
MIZ10~*NOB NUT 1...´•.......... 6
PN9~0-8 WISHER 6

23 880583-28 GPSKET

2-368
 ILLUSTRATED
ROCKWELL
COMMANDER PART8 CATALOG SECTION II
690A/n

i,

?1
i",
~I

MODEL 090P1- 11100 THROUGH 11288´•

k~
i

~J I
i

MODEL 890~ 11100 THROUGH 11268.

1
Pa
it 211

Figure 2-67. Prar~urildion .nd Air Cendilioning Fwd (Shsat 1 ol 4)

2-569
 ILLUSTRATED ROCKWELL
SECTION n PARTS CATALOG COMMANDER
ENVIRONMENTAL 680A/B

121 j

~53;C’
I
"71"
/Y
o

M80I1 )101/8 -1I28(A110 SUBSIIIUENT

228

221
)i’r
b 2’" 21"

M88EL 1801- 11611 PINO SUQIE(IUINT

i,

Is 22

2’
62

23 11
k 60

MODEL 08OP,I8 11288 ~ND SUBSE(IUENT

n.opla

~isuta 2-61. ond Air Conditionin(l inlt.ll.~ion Fwd IShe~t 2 of 4)

a.s?o
 ILLUSTRATED
ROCKWELL
COMMANDER PARTS CATALOG SECTION n
690A/B ENVIRONMENTAL

IlliUsF P 4 1 T UNITS USI1HL’

INDEX O E 5 C i P T I O N oFP Oh
NU’IP.IC N U M R F R I 14 5 L 7 4iSY TOUi

2-e7 8"110 7UI iiUil Il IOP: F UIPMEYT I NST L I CCYPL LIE KEL
ELLPI~ INIEiIOL FJlYISHINGI IVITL ISLE ilS´• 9Er
2-651
II6L""L-~ HF40LINFK dSSY ISLE Fli. 2-651 REI

YILVI INSTLI YE NT I Li\T lylj 4 ii RLI

11-310119 FLCXIBL" LUITROL I I

InlTnCHING ~PRTSI
*ii1114UG9 LL*MP
UIL~o29-L-OR ILHEI 3

nNOb3rlU WISHER i I

NUI 4
IN?-Lb ~DLi i h

nNChJDLO *d-HLL 1 4

YI2L~P3N3 NUT i

3 "83166-iU1 YIIIYt 4 i II´• YE NTIL*T INe ii i H 1 a

Gj)Oli-il5 bXR
IbTTPCHING ’ORTSI
~ilC562-6 PIYI RDLL 1
---d---

4a3Lhi-I SHd Fi 1 4

I ’80165-9 PLITE L d

JDliOS-li Y?IYC
X(i19)9 SIIYPJ*I STUJCrUPt I"IITLI UiiT RULklll~O liF
Nn2llZLb-LLB-6 1ULTI LH 135~191 i
lo UWZLZSh-308-h nUiT. L* 115399) i
-104 NVZWZS8-90-6 OUCT 105149) i R
IbTTICHING P4RTSI
II bz17j7Tk5R CLPUP ilP

iin cLnnp i
LZ RSi19140GZ9 CLIMP I
~Nf-in BULT i
ONPCOD10 WIIHEY
YUT i

980195 DUCT INSTL CaR I"I PRES SUH i 2lll(iN REE 4

880608 DUCT INSTL. C1Blhl PKES(UhlL*TIDI.´•.´•´• REF I.

880230-505 OEFROSTLR I PISTL IEr

ij 880206-29 OEFRUSICR bSII L
-li nk’LUZSb-13~-’1 OUCTI FIH 1013991 L h
15 4WZXISb-’2-~ OUCT. LH 105399) L
I4TTbCHING PIRTSI
ia ~E17371W98 CLIMD 2
---Y---

17 Ni*ZiZSC-A8-b UUCT i iii 1053 911 I

Ld Nn2W2I4-224-6 JUCTI Dn 1051991 L h

irn NIZ1211-L61-6 JUCI I

R~i I 05 399 1 1
(b~TbiHING PIRTSI
ib 4NI37IWIO LL~nP
---t---

20 MS21919Dj18 CL4MP L
(*TTPCHING
MS27038-1-Li IC9EY L

bN961010 WIS~FH L
YSLLO*IN3 YUI L

21 N733-~-27 IlUSE 1O 5399) i C

214 NT33-~-Li HOSF ´•´•´•´•´•´•´•´•´•´•´•´•1´•.´•´•´•´•´•´•.´•´•´•´•´•´•´•´•´•´•
4

IITTICHING PPRTS)
h~1377*46 CLIMP 2

tnOE EFFELTIY~ DN SERIIL NU*OERS

ii bson 11100 THXU 11268
3 b904 C 6POR 11269 h~D ZURS
L b904 L 6908 11100 THIU 11516
b908 LL517 IHRU 11599

2-511
 ILLUSTRATED ROCKWELL
SECTION n PARTS CATALOG COMMANDER
ENVIRONMENTAL BOOA/B

u a

B
111
11 13

~3
i Il

IB

I/ 1/ (J

MODEL 8801\/8 --11288 FIND IUBSE~UENT

Il II

37I

Figure 2-87. Plerrurildion ~nd Air inll.llotion Pwd ~urelag. (Ih´•´•1 3 of 4)

2-512
 ILLUSTRATED
ROCKWELL
COMMANDER PARTS CATALOG SECTION II
BgOA/B ENVIRONMENTAL

IIGUnE P ii 8 i UN iTS USPBLt

L illiltX 3 i 5 t R I P T I L ir "Fli ll)i

N U M 3 i P L 2 3 Is b I *SSY C~OC

L-61- ~Zil 6’10911~-1 ..)UCT Z C

LIR 880662-1 HE4TEF I5SY1 SiDt WINnLW OtFOG 2

Ud0577-501 jOJHLCC 41111 LH IREPL11115805r7-1)

bd3571-502 J~UBLE9 45SYI kH IREOLICES 880577-2)
24 Sd1~75-i nLtYUH LSSYI LH I
08?575-2 rLt~Un *iiY1 KH L
P4RTS)
M1Z73?9-i-09 SCK[V
hN960VLO Y4SH~P ´•´•´•´•-´•´•r´•´•´•´•´•.+´•´•´•´•´•´•´•´•´•.´•´•...
4P

PN76~rloL WISHEL iiP

NUT 2
----I---

Pb RBOL51-41 WELI 4SSY

27 Y*ZWZSLI-3’-T nUiT 1053991 I
I4TTbCHING ’41~51
28 II’II)7TWIOI CLPMP 2

ZLCO11R-L IL~WFP IjSY 131163) L n

I~TTdCHING Pblli)
j0 BOLT Z
~NRhODIO WI~HER

880115-~3 CL*"P dSi*

RRICKII I 4
32 830155-41
nl?3-ls-la C;I;JPLING 1O 5349 1 L d
IbTT"CHING Y4~TSI
3~ YI~SB(L-LI CLI(*IP
---i~---

35 160518-1 FLilOW nsir I

16 88U15L-501 )UCTI Ln 1 I

37 81U151-L7 TU3t 3

371 8(iJ~38-3 TU~E ´•´•´•´•´•´•´•´•´•´•r´•´•´•´•´•´•´•´•´•´•´•´•´•.´•´•´•´•´•´•´•

i ii

38 SBO158-507 OUtT I Li~ 1 n

~s aaolsa insN,lrIuN, LH
8l0bL6-1 TR4NSITION1 LH L 3
R10046-) THbNII~IONI RH L

40 880199-511 dOX ~iSY´• LH L

H80193-502 9OX bSSY1 RH
ii R9315R OUCTI RH 1
12 Ce411P-5Li CUCTI iH 1
TR4NSITION i
43 BdObl)-L
ii ]80158-515 DUCT´• RW
ii 880158-517 DUC T1 LH 6 RH 2
4L 380158-51) IUCT´• LH C RH
17 i*2k2liZ-1ZR-b DUCT, LH e Rii 2
auT37TWL07 CL~YP IZ/N LILDO TH9;1 ilLhs RFR 171 Lt
i1 MS~19LODG52 C14YP 4
10 91Cn*n-L17-~00-3 CL~YP L d

51 1111-3 41~ YILVE 183)h41 2

(bTTbCHING P4RTSI
"121643-5~1 ZCRth 4

BULKntdD I n
52
524 861)45-7 Yb~lFULS ´•´•r´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•
L 3

9d0511 LIUT LET Ih ZT L1 Ci\O I*I 41R CFF

COOt CI~ELT1YE ON IELIIL kUYRERS

bBOP 11100 THPU 11268
e bsna E hsoR 112tP iiNO IURS

C b906 L 6903 L1100 THRU 11516

h90D 11111 THRU 11599

2-373
 ILLUB’TRATED ROCKWELL
SECTION It PART8 CATALOG COMMANOER
ENYIRONMENTAL BBOA/B

II Il

13

i o

,o

630

13
38 YI*:21 I II

MODEL 800P1- 11100 THROU(IH 11288.

Il

(1 ill

EiOuro 2-6~. Prelrurilolion ond Plir Conditioning ~vd Pur´•I.8´• (5h´•´•t 4 of 4)

2-514
ROCKWELL
ILLUSTRATED
COMMANDER PARTS CATALOG BECTION n
BL)OA/B ENVIRONMENTAL

FIGURE O
T UNITS UZIULE
L INlEX 0 E I t R I P T I C N PEn nN
NU~6EP h U M 9 r 9 i 2 i 1 5 t 7 ~SSY CnOF

2-67 53 880531-3 UUTLE T 41 SYI C4dlN 4 IR 5

I ITTICHINj Pn9rSI
MS17o30-i-08 SCRLW i
4U161J1l Y4SHER
NUT

660115 SWITCH iNSTL1 CIRIN PRESSURE, RH PF~

51 *’15(-63 SlilT~HI C~ZIIN PRESSURE´• KH 1113 LI I L
(4TTPCHING P4ilTSI
NSj5206-ZLI SCREW
W~SHET Z
NUT 2

55 1303’16-~ CJ*ITROLLtlll CIBIN PRESI IloZLOI IStt REF 4

Fi^´• 2-321
51 dilOSR3 YIILVE INSILI OU41 OUTFLOW iSEt FIC,´• REF
2-hhl
I B0638 DUCT I NST L. Cne i N PRES SUr I Lnr ri N KFF 3
5’ LRO~LZ-L BLUWER INPTL RE~
I~TTI(HING 041751
4N900-1O W4SHE’ .....´•.r´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•.... 3
II~1OLIY3 NUT
---(i---

58 71ZhZ-I BLDWtK IILY IKEICOI INC´•I NUENSTETI I B

TX I
59 RRJe12-3 AOUNT 4SSI L e
60 nboELZ-9 DUCT *SSY I 8
11 e93LII-2I TRINSITION I B
(dTTnCHING P4RTSI
iiN530-h-6 ZCRCX

bZ N~ZIZSLO-SB-b JUCT 10)359) i 1

63 1N137TW98 il~NP 2
bl NnZk2Sh-’tO-h OUCTI DEFROSTER (053991 2 H
1,5 dN7371*bb ..´•CLPMP L

n9)587 SENSOR INSrL, CIRIN TtYP

66 BYLF-7$64 tLENENTl CPUIN TFnP L
IPTTnLHING PILTSI
nS35ZOL-Z2P SCREW 1
L1N9630t~ LI4SHtH
NUT C
---I---

CODL E FFBLT I V L ON ItP I1L NUN HERS

4 6901 11100 THRU ilibE
e ason E 1903 11209 n"10 lllBS

2-5’16
 ILLVSTRATED ROCKWELL
SECTION n PAATB CATALOG COMMANDER
ENVIRONMENTAL B80A/B

Ui

B E
co

I
1 a a

is is
f

i I,

L/

se’

Rpun 2-66. .nd Air Condifioninp inr)l Ah ~ur´•l.p´• (Sh..ll of 6)

a-S16
 ILLUSTRATED
ROCKWELL
COMMANDER PARTB CATALOG BECTION n
Bg0A/B ENVIRONME~AL

P 4 r UNITS USIBLE
~IGURL
D t 5 C P 1 Y i I U h PtR OM
C intX
N U M O E R I 2 3 C 5 a r 1SIY cn:i
NUMBCP

2-68 rucI7o PRC SSURI IliT IOY EBU IPnthlT I I*ST L, CCMPLEI E LE~

880223 PKIIIURI~*TION blln illR CONCITIUNIMGI IIFF

hFT FUSELbG~
660232 BLEEU PIPING IYSTL IStF ~IG´• ´•´•+I
RCI

2-691
UUCTI ULtEO IIR (771921 liii ~IG. 9Ei d
L iCEtTS-9-88-b
2-691
OUCT (oi1991
I4ITPCHING PIRISI
nE17)7TW7~ CL~MP 2

nSZL91"3GZB CL4*’ 1
CLIIP
9~3-5P BOLT 2

bYg60Ulo WPSHEL 2

YUT 2
MS~104CN3
---li---

3 Y*ZW2SII-LZ8-4 DUCT 1053111 L

IhTThCHING PPRTSI
n~i37T11P7 CLIUP i

"IT3?-LP-II COJPL IN(i 1353 99 I 1 P

4
IRTTIC~LNG PIPTSI
*N7~7TW107 CL~MP 2

5 B305BI-L UIYFRTF9 PSSY, EYEIIILL blX L

I~tPL*CES BRoFS1-50L)
ik~W2-5-12-L36-L OUCT 105)991 1
IITTIIHING PIRTS1
INT3’TWi07 CL4NP 2

7 d8O62’t-I TUI~I BLEED ~IR i

lb iT3’-L1-16 SLEEYE. COUPLING 1053991

IITIIC*ING P4RTSI

bN737TWPB CLIM*

8 SkZU 25 L~-VI-6 iIUCT 1053 99) 1

(4TTICHING ’bRTSI
*N731~W7’t CLIMP 2

lh731Tii107 CL4’IP C

9 T*ZlrZILZ-1T 8-6 OUCI 1013*91 ISEE FIS´• 2-671 RF~

LO n*ZLZSib-7h-ii O(1CT 1053991 L

IilTTnCniNt PIRTSI
CLI*P 2

---r;___

880224 StlOP INSTLI Rbn nlR FLUSH Rtf

180224-11 SLDOP iijiY L

ii
IITTICHIYG PLPIII
NS27039-3807 ICREW 20

6N960DR VPSHER 20

BR0Z25-505 OUCT bSSYI DISTRIRUT1ON I O

LZ
88G225-507 DUCT ilS SY I DI STIII BUT ICN I i

13 15C4 P*ITCH 1321711 I

I1TT4CHING PIRIS)
MSZ1083N7 NUT L

880225-31 WnSHE R L

CDDt EFFECTIVE nN itklPL NUMLTRiS

1 6901 11100 THRU 11319
690n LLLOO TP~U 11208
C 6901 6 6908 11209 bND SURl
O 690P LL1CO THIU 1120R
C b901 C 690B 11269 nNO SUAS

2-511
 ILLVITRATED
ROCKWELL
SECTION n PART~ CATALOG COMMANDER
ENVIRONMEhPI~AL BBOA/B

20 /J~-21

Filur´• 2-68. PI´•lluril~lon ~nd Air Condilionin. Inrtl Ah ~ur´•l..´• Ph´•´•1 .r 6)

a´•578
 ILLUBTRATED
ROCKWELL
COMMANDER MRTS SECTION II
BSOA/B ENVIRONMENTAL

ad
~i rl-

(5

1 i´•1

I
d

r
"Pj,
t 33
33

33
32
13

"1’3

~i(lun 2-68. Pr´•rluri..fion.nd Air Conditioninp in~tl Ah (Sh´•sl 3 ~f 6)

a-578
 ILLVBTRP;TED
ROCKWELL
BECTION n
PARTS CATALOG COMhGANDER
ENYIRONMENTAL BBoA/B

~IGURE P n n 1 UNITS UILBLE

L INDEX O t 5 C 9 P U N PER ON
hUMBLh N U M 8 F R I 2 3 5 d I ~SSY L~Ot

2-bU ~RO)L1 SICWER INSTLI HEIT EXtHbNGtk RE~

L’t t5~-7 SU I TLII´• PHFSIIIR E 1 1-’17 i I 1
IdTTbCHI~G P4DTSI
MSZLOe3NI NUI L
bN100-7LOL *4SHEK 1

15 X-70Z-79 8LOWEH IhCT PbRT~ 2103e01-1 L

ZLn36017Z Il’tIhlI
16 880211-47 IrRPP 1
17 800211-13 ~TRIP
PIRTSI
?25-02-950-1 CL4MP 1*8625) P

18 880211-4~ )OOL i
I4TTn(HING P*RTZI
IN3-36 UULT 5
4"17L3-10L Whinta

10 dOoZL1-C5 lilCT liiiY L

I~TTPCHLNG PIRT1I
nN3-5P iDLT 24
d4~L0010 WI\SHER Zi

380321-501 PLFNUM ISSYI L481N 419 PL~

ZU 881571-1 Y4LYEI SLFCO 418 L
InTTaCnl~G PIRTSI
~I bN3H17P dOLT 4

nheh4DLO IIIIH[-R 4

22 8eOZPD-50L PDIPTtl L
880325-503 jhSKET 2
24 *YLF-)I~ZR tLEYtNTI TtMPERPTURE SENSITIYE
I0SbZil
25 IIIF-PLO bO*PTEP 1056211 I
I4TTnCHING PIRTS1
MSZ*643-SZR SCLEW 4
ni2713q-L-06 SCREW
3535330-43 IOCKW4SnER
----I---

980322-505 DLENUM 45511 CaB1N 418 i

I4ITPCHING PIRTSI
17 18271-400 C~UPLING 19Bb251 L
~R MS2703)-L-01 SC9 Ek
~NCLIDIO W4SH[R ´•´•´•´•´•´•´•´•r´•´•´•´•´•´•´•´•´•´• ´•1´•´•´•´•´•´•´• 48
YSZ1141N) NUI I

29 Y*LYFI R~U nlR CHECK

880275 JET PUHP INSTL REF
30 980217-603 JET I1SIY 1 1

880217-)01 JET YUIP nSSY 1

InTlnCHING P4RTII
31 bN~-56 BOLT
iiN960DIOL WPlnEH ´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•..1
4

nSZlll~N9 NIiT 4

32 513 2 3- 8- L 8 SLEEYE 1 01399 1 P

I4rTPCHING P*RTS)
33 dN731iW7C CLIMP Z

CODE EFFECTIYE ~N ILRIIL hUM8ERS

P bYOn LLLOO TH*U 11349
P 6908 11350 eND SuaS

2-380
 ILLVSTRATED
ROCKWELL
COMMANDER PPIRTS CL~TALOO SECTION II
ENVIRONMENTAL
BBOA/B

~--53

,I--
8
.B

"-t~r
MODEL 880* -1(IO(ITHRU 11348.
I"p

~ipure 1-68. Pr.1,uril.tion ond Air Conditioninl in.tl Ah Pul.l.ge (Ihsa~’l of 6)

a-581
 ILLUSTRATEP ROCKWELL
SECTION n PART~jCATALOB COMMANDER
ENVIRONMENTAL BOOA/B

ilbUiL P P a T UNITS USIBLt

IN:IEX 0 e I. C a I P T I m y pen oN
hiMnii N U M n t a 1 i 4 5 6 7 bSSY GOOF

L-6A HB02L7-S~ INLET dSZY

YSJ217-2L PLEVUH COYtR 4511, INLtT I
IITTILHING PIRTSI
IS ’1527039-1-09 SCfiEW LO
hhl9bODLO WISIIER 1C

3b 880211-1 JLT PUHP 3

IITT*CHING P4RTSI
~1 M527031-1-12 SCREH ´•1´•.´•´•´•´•.´•´•..............
1N960010L W~SIIEP
6521n42-3 NUT
---li---
3Li "80259-501 NU2ILE. JET PUUP.............. 3
CJOZ17-18 PLENUY n5SYI INLET I
*L MSJS*HY-26 GR[IUUET
LI 580217-37 GPSKET I
d30217-~1 PLL NU’I nSSY I
i 802 L 7-0 5 PLEIIUM COYER EXHIIUSI
1\51Y1
(IITT*CHING P4RTS)
~3 527039-1-09 SCR’W IZ
hN9600L0 WPIHtR 12

il 980217-57 Y4LYE IILT PPRT 3ZL11Z-P 3

1828291
I~TT*CHING PPRIS)
Lg *1831206-291 ICR EW r

lN46n011 WPSHER 2
NUT 2
---1---
I~ 580217-15 PLLNUM PSSII EXH*UIT
41 UBOZL7-4L GISKEI I
9R 580275-5 InUNTI LH I
14 880275-3 YOU4TI KH
50 n80275-9 IYTELCOSTIL, LH
Si 880115-7 IYIERCUZTILI Rn I
12 ngcos~-l *U*PTEH´• FLINGE i
IITT*CHING P4RTSI
~NL-61 OULT
IINVblD’1I~L W4IHEF ~t
MSZLOI4NL NUI 4

YR0052 CUilLINlj PICXIGE INSTL R~F

51 171000-2 toniiYG UNIT 1013S91
IITTPCHING P1BTSI
jg nH3-bP aOLi B
---*i---

Jb 13140 ;ISKET 1
;180055 OUCT INSILI LDOLI~G 41K rXIT PEF
r n
17 880066 FLEX JUINT
I*TTICHING P9RTS)
58 nN1-Zb aULT 18
LVPLOPLO WPS~ER )I

59 680055-75 DUCT ISPY EXH~UIT i\lR

I 1
IITT*CHING P4RT5I
60 YSZ1695-55n SCRLW 35
---t----

tOOE EFFECT1YE ON SERI*L NUMUERS

B 6904 LLIOO TH4U 1IZOR

2-582
 I:/

i‘ i I
ii i

,(i
 ILLU8TRATED
ROCKWELL
IECTION P PARTB CATALG)O COMMANDER
ENVIRONMENTAL BgoA/B

FIGURF D 4 R T UNITS USPBLF

L IND~X O E 5 C R i P T I U N PEk ON
hiUNPtk N U M B t 9 L 2 3 I 5 L 7 b5SY CODE

2-68 (ii b80LoC-511 DUCT II´•ISTLI ~L EXI RLEI L06L IN~ 4 1 R

:XIT
(4TTdCHING PdRTSI
(2 4iY3-bb 3OLT i
b) *1~7019-1-01 I~REU P
*NP~OniO WIIHCR
2~lbnOLOL W*IHCR
---I---

61 UtS~i-l IUCTI FLEXIBLF 1053491 1 C

LS J~OLDT-L DUCT IFSY, RFLIEF YILVt tXIT I C
46 9do6Lp-I CONNECTOH n5SY, COLD 418 DUCT I D
L 863223-2) HOSE, ORPIY L
I4TT4CHING P4RTS1
.a PN737TWZb CLPMP i
ti MS2111906LO CL~MP ´•´•´•´•´•1....´•....................

nN3-jn BOLT 2
1NlbODlo WIPHLR ´•´•´•´•´•´•´•´•´•´•´•´•.´•.´•r´•´•´•´•´•´•´•´•´•´•´•´•´• 2
~SZLOLIN) NUT 2

70 680223-9 TU~i
71 1)5489-11 GROMUFT i
72 LLIPI ILtiYE 198’)911 FI
IITTICHING "4875)
/3 ?N737IW107 CL4MP ´•´•.´•´•.´•´•´•´•´•r´•´•´•´•´•´•´• L

71 rin9628-L TURE I i*
LITTdCHING P4RTSI
rS IINIPTTWOI CLII’IY ´•+´•´•´•1´•´•´•´•´•.................... 2
---I---

Ib SUPPORT, TUDE i FI
77 MIZI919n3IZ LLIYP 1 it
I*TT4CHING PPRTZI
16 BOLT i
i\N"hO-L0 W~IIIER L
YS21044N1 ~UT
---L---

19 Si39-LD-L3 5L FEVE I F’
InTTllCHINt P4RTSI
ao rNT37TUPR CLPNO 1

81 950)1-L WbTCR SEPPRPTOR 1725911 1 Pt

I4TTnCHING DIRiS1
81 MS35942-1b CL4*P L
----1~---

U3 360625-1 MOUNT SUPPORT L Pt

(4TTntHING PIRTSI
84 dN3-5n BOLT i
nN9bO-LO H*SnEH 5

85 29n0379-*U-50 RESTRICTOH 1 F"

I~TTICHING P191SI
nNbL80-4D NUT i
i-0310-9olR C-R i NG L
5-0311-104 RIYG1 BICKUP

OPTIIINI\L INSII\LL4TlnY ~NO LOMPOEltNTI

COUE EFFEtTIYI. nN S tH LI\L NU*RERS

L 199* G 6900 11209 *ND SU95
D 6901 L 1908 11264 4ND iUBI
F b90B 11)50 4ND SUBS

2-584
 ILLUSTRATED
ROCKWELL
COMMANDEA PARTS CATALOG SECTION n
690A/B ENVIRONMENTAL

2 12

1~111 1~

t~\i 12
I,:

"d

MODEL 5901\ -11100 THRU 11319 1 OPTIONAL)

MODEL 5905 11350 ANO SUBSEOUENT. ISTP~NDARDI

X11"’

Figure 2-68. Prer.urilotion end Air Conditioning Inltl Ah Furel~ge Pheef 6 of bJ

2-586
 ILLV8TRATED ROCKWELL
BECSION n PnRfs CATALOG COMMANDER
ENYIRONMENTAL BBOA/B

FIGURL P n n i UNIIS UIIDLE

C INDFY 0 E I C R I P T I U N PEK ON
hJMB~R N U M R i 9 L Z 3 C 5 7 n~5Y CUOt

2-08 6~ LisOLZ3-51 nOSE PSIY 1 ii

ill n527~0*-C0 FITIING L Fn

PR ~80223-*4 HUSt i r´•
hS d802%3-ls TUBE i\SII L rn

(bTTbLnlNG P4RIII
90 1N737TWZ~ CL9HP 1

O*TIONni INITILLbTIUN nND

CUUt EFr(CIIYF UN IthII\I NUMUFRS

(1906 11350 ~NO IURI

2-586
 ILLUSTRATED
ROCKWELL
COMMANDER PARTS CATALOG SECTION II
ENVIRONMENTAL
Bg0A/B

~t=’
113
O /A

i
,I
se

os I s~
oi or A

Figure 2-69. Bleed Air Piping in~t.ll.lion (Ihset I ol 2)

2-581
 ILLVSTRATED
ROCKWELL
SECTION n PARTS CATALOG COMMANDER
ENVIRONMENTAL 880A/B

FlbURt P d K T UNITS USLOLF

L IN)tX U E 5 C R P T D h
i I PER ON
UUHBEI N U M R E R L i I i i 6 T bSSI COOL

2-69 881LIO PRESSUKILITlOn EOUIP4EYT INSTLI LDNPLETE REF

IICO2J2 bLtE3 4 iR P I L~ i hlG INSTL PCF
I PIII 18"E ilt´• Z- 6) REI
2 890315-10I H(ISF I\SIY´• BLEEO blY IIFE FIT.´• 2- ol DEF
J INEIS-Lb UNION
dNR?L-lh UNION 2
P*RTSL
PNRZ~-Lh NUT L
n*9bO-ZLL6L k4IHER .r´•´•´•´•´•´•´•´•´•.´•................. I
---I---
5 d80)74-39 TUBE 4iSI. LH ´•´•´•´•´•r´•r´•´•´•´•´•´•´•´•.´•..... L
di1027b-23 TUBE IfiY1 RH 1´•´• I 45
481270-83 IUEE aiZY1 RH 1 C
IiTTICHINC PIRTSI
CL hMP
YS~1919H8 CL4MP I
iiN3-bn ROLT ILn UNLII I
n~3-5b BOLT liH ONLII I
HIS131iT3-lt PP4CFH ILH (INLYI
NnS13~T3-8 SPICER (R* DNLYI i
nNStlO-1OL W4SHER I
NUT

7 BB0~16-4L TUBE PSIYI LH I

8 TUBE ISSYI KH 1
IITTi\(HING 24RiSI
YS11914H)Z CLIMP
"527939-1-11 SCREW I
bN96nD10 WISHER I
18211*~43 NUT t

4NRI1-I6 FLBOW Z
L~ JU3276-21 TUBE PSSY, LH I
ii 950276-25 TUBE niSYI hH I
I4TT*LHING PIATSI
MSZL919H32 CLbNP 2
ns27039-1-na SCREW 2
I)NO(ISULO WISHER ´•´•´•´•´•´•´•´•´•1´• 2
111?10’1~*11 MUT 2

II a80Z7t-II TUBE iiS SY I iiB

IITTICHING P4RTSI
USZL919H32 CLPMP I
Y521039-1-25 SCREI ´•´•+´•´•´•.r´•´•´•+´•.´•................ 1
NI\I’1PHTI-OI SPICER I
dN9bnUIO WISHER I
NUT L
---I---
13 4NR~I-lb TEE 1051Y9) I
H8027~-45 TUBE dSSY I pR
15 dS0Zlh-*9 TUBE 1SiY I
LiR021h-59 ruaF as Sv I B
Lb UBO~lt-55 TUI(C *91Y I iiR
I9TTnCHING PPRTSI
MZ2L919n)Z CL4MP 1
MIZI919DG22 CL4nP
"527039-1-10 SCREW I
IN9L0D10 WISHER I
MILi04~N3 YUT L
---li___

CODE EFFrCTIYE ON SLKIIL NUMRERS

b90P LlloO TnRU IIZoB
690* 1IZoY THRU 113~4
6"08 11350 nND SUBS

2-988
 ILLUSTRATED
ROCKWELL
COMMANDER PARTS CATALOG SECTION n
688A/B ENVIRONMEIUTAL

Ficuni P 4 R T UNITS USIBLE

C IY~IX 0 t I t R I P T i O N PER CN
NU*UER N U n o E n I r s a 7 nrsv CnlF

2-69 L i ilNe i 5- LL UNION I

18 181276-R7 TUdE diiY I hH

I4TT4CHINC PIRTSI
MSLI914DG1) CL~RP i
MS27039-1-09 ICKtx’
bN160DLO WPSHER 1
MS2LOiCN3 nui I
---r---

II 4N9L9-L3 RE~ULER L I~

20 R~0586-L TU~t nSSY L an

s~o2la-´•t7 T?ldt iiSSY I L
ii
180Z7h-57 IUOE ~SIY I B
I4TI4tHING P4RTSI
NSZ1917H’) CL4MP 2
1127039-1-~R SCREV i
hlnS’tlDD)-LZ~ SP4CER i
*N4h1~10 IISHLR 1
MTL1OICN3 NUT i
---i~---

EBOZ7O-5L TUBE iiS SY r i 1 iiB

-13 IN815-10 UNION ´•´•´•´•´•´•´•.´•´•1´•´•´•´•+´•´•´•
I h’l

24 3-016 O-R i NG I OLb97 I I hR

25 IYBOS-LL TEE L bR

IllTTi\CHIlUG DdRTSI
26 bN92*-1L NUi L 4

nNLZ84-2J YUT 1
Lr 3-916 n-R ING (02691) I
S-0310-420HT O-HI~G 1 B
---I----

28 PC0508 CHECK Y4LVE IaLCO CORP., UnLaHO’la 2 a

CITYI OKI
HTC-7010 CHECK YbLYE IILCD COPD.. OKLdHOH4 2 B
CITYI 01(1
I4ITbCHINO P4RISI
24 iBnh-ZoO COUYIING 19Rh25)

30 Z~o46-200C tPSKiT 198bZSI i

HAO~I)-L TUSE nSSY
58:3585-501 TUBE dS SY 1 R
II~TPCHING "4Riil
32 MI2LPI?HSO CLaMP 1
33 X527019-1-09 StREW L
*~SHER 1

nSZLI*~N3 NUT .r´•´•´•´•´•´•´•´•´•´•´•´•r´•´•´•´•´•´•´•´•´•.´•´•´•´•´•´•´•´• I

34 UR057*-L YILVE, aLLED alR 1 eP

IaTTPCHING PbRTS)
35 4N3-lh4 BOLT 4

4N900D10 WbiHtk -´•´•´•´•´•´•´•.´•´•r´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•

9

*P21012-3 I1UT 4

3~ liBn325-503 li~lKET ´•´•´•´•´•´•´•-´•1´•´•´•´•´•´•´•´•´• 2 liP

37 BP)591-i TURE PSSI L bB

I4TT*CHING P4RTSI
38 MS11919H32 CLbMP 1
lr US27339-1-3R ZCREY
in H*543003-L29 SPIICER 1
4N960010 V42HER L
ISZ1I~IN) NUT I

COOt EFFELTIYE ON StRIPL NU~DtRS

6904 11100 THIU 11201
D 690n 11209 IHRU 11)19

2-588
 ILLUBTRATED ROCKWELL
SECTION n PARTG CATALOG COMMANDER
ENVIRONMENPAL Bg0A/B

MODEL BB(I~ -11IO(ITHRU 11319.

23
32 1

101

II

13

p
MODEL 6908 11350 ~ND SUBSE(1UENT.

511

80, 59
U
13
55 50

~k
II
i
"1-7~r
e/ a?
9

Figure 2-69. Bleed Air Pipin. Inrt.ll.tion 1911991 i of 2)

2´•980
 ILLUITRATED
ROCKWELL
COMMANDER PARTS CATALOG SECTION 1l
680A/B ENVIRONMENTAL

FIG~kE P K T UNITS US48LE

C I~OtX O E S C R 1 P T I U N Pt~ Uh
LUMBER N U H 0 E R L 2 3 4 5 d 7 dSSY COlt

680216-53 TUBE ISSY F101 UNIDN T1 CnE(K YILYE) I P

COB TUBE *521 EKOY TEE TO CHECK YPLVF) I L

-*1 SLL~TS-O-III-L 1)UiT I77II2) I iiU

I4TIPCHING PIRIS)
12 PN737T171 5L4MP Z

13 iboZ19-503 Y4LYt, RLEEO nlR 3

I4TIICHING P4PTSI
32$0 44 CLIRP
Z-ZL* ..3-RInG 102~811 2
---I---

II bB1276-65 TU~C diSY1 LH 1 i

I: IIEOZ7C-b7 TUBE PISY, RH I C
(dTTPCHING YbRTSI
4L riZL119HJ2 CLnMP
1SL70)R-I-09 SCREW 1
d~hl"hJDLO uii\SHEK L
lliL041E13 NUT L
17 "SLIP1OHI~ CLPnP
YIZT039-I-e9 SCREU L
nN9L0010 14in’R I
iliillilN9 NUT i
---I----

4b aSOh*l-L BIICKETI FWD ~OUYT L r

49 bN824-ib TEt 1053791 2 C
50 b80276-69 TUBE LSSY 1 C
I4TTPCHINS P4RTS)
SL HSZL9L4H32 CLIMP
~127039-1-09 SC~EW 1
ilN4t3D10 *dSHER t I
HSZLoS4N) NUT I

:2 RBOLIO-I RRICITTI 4FT MCUYT L

53 810276-75 TUJF 4SSY L C
5’1 Y8027~-79 TU3C PSSY I r

Sr PBOZT6-8L TUBE *55~ 1 C

50 DB027h-~7 TUJZ PSSY 1 C
I4TTICHING 04RT51
51 ~52L919H3Z CL4MP L
YS27039-i-09 SCREW 1
bN981DLO W4SnER 1
MIZIOI4N3 NUT 1

58 dNP15-Lh UNION L C
iT d*3h3B-L Y*NLFOLO~ CHECK Y4LYI I C
oD HTC-1000 CHtCI( YILYC i 4LCO C09P.1 GXLIIHUM4 2
CITYI OKI
IbTTbCHING 04RTSI
i-0~10-920HT O-KING
dY1ZB"-ZO NUT 1

61 i\Nb L 5- L 2 UNION 1 r
lZ 88927~-n9 TUBE PSSY 1 C
I*TTLCHING P4RTSI
63 NiLI9I9HZI CLPAP 2
"SZ1039-L-09 SCR~I 2
INNPODIO WISIIER
MI210IIN3 NUT Z
---(i---

CODE tFFFLTIYt ON StRIAL NUMBERS

1 b90n 11100 THIU L11~8
B 6904 11209 THUU LL3CV
C 6908 11150 dND SURS

2-581
 ILLU8tRATED
ROCKWELL
SECTION n PART~ CATALOG COMMANDER
ENYIRONMENTAL 880A/B

FICURL P P S i UNITS UP48LF

1 INOLX C 1 i C R I P T I O M PFR ON
hUMBCn N U M D L 11 I i I 5 7 eSSY CCDC

2-69 890~)2 BLEE3 PIR SHUIOFF SYSTFU LNSTL PE’

L1 10-0301-R-2) PRST I- IGHT1129 L ’t I i L
61 aEPC2elP LIijnT ISSY 1003031
hb M~CZ"9-418’ i(hlJB I L~ORII L
117 1NOLT-~-3X3"59 SI(ITCH i nlr pnn i so- 12719)1 1
oc IVD41~-3 ~RICIFT L
IbTT*CHING "bRiSI
YS352ob-Z~% ZCReW 1
1N1(1008 -´•1XI\SHEH 2
---LI---

10 Rl0l*)-7 INEULI)TOK
II 190**2-5 PLPC4RO r.´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´• i
IZ 190LIP-9 I\Y^LE 1
dBD232 OL EtD i\ Ih PIP L NG INSTL REF
13 IZl~bo YbLYE, OLEEO PIR ITUNOST~IND CO1P.I 2
ICCKFOROI IL)lffEPL4CLJ
1115-00-31
~S?IZhElO-bS .CINNECTORI tLECTRICPL IUSi hlTH 2
127L1b3 VPL VE)
ii dbSt~2-l TUBE ISIYI LH
B8327L-hi TUIE *Sil, PH L

OPIIDNIL INSrPLL4TIIN ~NO CUMPnNFNTS

2´•582
ROCKWELL
ILLUSTRATED
COMMANDER PARTS CATALOG SECTION n
690A/B ENVIRONMENTAL

-ta
~d
i,

ligure 2-10. Pr~rlurilation ond Air Conditioning LH MLO Swif~h in~,allafion

2-383
 ILLUSTRATED
ROCKWELL
SECTION II PARTS CATALOG COMMANDER
ENVIRONMENTAL GBOA/B

I16URt P 4 E T UNIIS UI4HLE

i INI~X D E S C R I P T I O N PER DN
NU*Rt 2 N U P O E R 1 2 P 5 d 7 *SIY CODF

2-10 ’R~LIO PRESSURILITION EOUIPMENT IhSTL. COMPLETil RC~

iH YLG IWIlCH INSTL
3C1P11 IWIICH INITLI GROUNO CPIIIICT RE~
I 5:i?L17-li´• iW i TCII 4Ni) *Iln as rr I
2 i\h1(105-21R TFR’lhlhL
IbTTICHING PIRTII
n127531-1-12 SCltX L
IN9t3-LOL W*EHEK 1
HSZln4SN) NUT
---s---

L:O0217-1) BRICKETI IWITCH ZUPPORT L

P001’lr-3 BRIZCKtT i
IbTTICHING PaKISI
6 MS27031-L-IZ SCKEW Z
bN96~-L3 WISHEP ´•´•´•´•´•´•´•.´•.´•..1................ 2
r NUI´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´• 2

SIILT ´•´•r´•r´•´•´•´•´•´•´•´•´•´•´•´•´•´• I
8 ~dS13Hrb-6 SP4CEH ´•´•´•´•´•r´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´• 1
nN’ibO-(ii(i wniHEfi ISti )IG´• 2-111 RE(
*b1320-h ;´•1Ur (IIF F16´• 2-141 R(F
ili?*b( 5-2 83 I~lhl COTTLR IIEC Fli.´• 2-i ’t I Ht~

2-384
 ILLUSTRATED
ROCKWELL
COMMANDER PARTS CATALOG SECTION n

BLIOA/B MISCELLANEOUS

MODEL 880P, --11100 THAU 11288

at
C
ss ct
91 wl Y~ _162 SI

53 51 1
,2

U’
1
i

1~ii i
i,

A B

"r I
3 luiali4i I

"g I
123 32

~1

~II

~iour´• 2-71. Oxyp.n Sy.t.a in.t.ll.ti.n (Sh´•´•11 ol

2-585
 ILLUGTRATED
ROCKWELL
SECTION n PARTS CATALOG COMMANDER
MISCELLANEOUS BLI(IA/B

123

-a.

~Y 8
’O

2-71. Oxylt,n Syd´•m in~l.llation (Sh´•.1 2 ol 4)

%-988
r,ULFSTREAM ILLUSTRATED
COMMANDER PARTS CATALOG SECTION II
890A/880B MISCELLANEOUS

FIGURE P 1 II I UNITS USIBLE

C INDtl 0 E Z C R I P T I O N PER ON
NUIIBER NUnsEa 1 2 3 1567 *551 CODE

1-71. 861009 OX*GEN I*ITEll

INlTL. PRIII*RI´•´•´•´•.´•´•´•´•´•´• REF
In625 ~srr. OX*GEN 101117)
nllr D
1 C)51-1000 ´•+n*sn. OXlbEN (DIPLII 1 D
2 1)50 FLOU INDIC*TOR 1022111 1 O

3 210550 PIN lIP*, LINIIRO 1022Lll L O

3)101 TER*INIL (022LI) L D
5 CIO)OR3 ´•+CO~O(OZP11) L D
860951 nlSK1557. OI~GEN, D1SPOSIBLE REF
6 28302-10 ´•´•lllSlI OXIGEN (53655) 2 BE
1 11019 CORD 102ZL71 I BE

B 860951-3 CL*NP .´•´•´•´•´•´•´•´•.......´•.....´•.´•´•´•r´•´•´• I BE

(ITTlCHINt PIRTS)
9 IS)SIOL~PLI SCREW 1 BE
1N96O-) ´•´•U1SHER ´•´•´•´•´•´•´•r.´•´• 1 BE
WI~LOIIH) NUT 1 BE

I*RLS1-)(-)O-I-~D-I-3 WLI, OX*GEN 2 t

10 8883 REbULITOR 1SS1 I53(55l L
IITTLCHIHL P*RTII
-II WSL1039-L-01 PCREY
---li---

Il 161)58-2) PO~I LlbHT ´•´•+I´•´•´•.´•´•..´• 2 F

´•13 ELBOW ´•´•´•´•´•´•´•r´•´•´•´•´•´•´•´•´•´•´• 1
300-2-2 ELBOW IB3L15I I
I~ 2638 YILVE´•LH (OLIIII I is
16 2628 YLLVEI RH 1022111 L 18
Il UNION .´•´•..´•.~´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•1´• 2 *8
5-0309-906 O-RINb ´•1,´•..´•..´•´•.´•´•.´•´•´•´• 2 15
LB 861009-7 TUBE 1557 (COPILOTS n*SK r3 REGULITDR 1 is
TEE)
re 161009~31 TUBE 1551 (COPILOrP OI*bEN OUTLET TO 1 C
REGULlrOl TEEI
-20 861009-33 TUBE lSSI ICOPILI1TI OXIBEN REGULLTOR Ti) I C
TEE)
18821-10 TEE
)Z ~s08 O UTLET OXIGEH, LH I RH i I C
ELBOY´• LH ´•.´•´•´•l´•´•l´•´•´•l´•´•´•´•´•i´•´•.´•´•´•i´•´•´• 1 C
NIPPLEI RH L t
1N9)L-ZO PLUG 1 C
23 86L009~9 TUBE 1557 IREbULITOR ELBOY TO REGULITOR 1 68
TEEI
sbi009-5 TUBE *Sll IREGULITOR rEr To ovsans*o 1 18
TEE RH IIDel
21 Bb1009~2s TUBE *5I* ILH TEE OYERIIEID TO UNIOWI I G
861009-(5 TUBE 151* (LH IEE OYERHEID TO UNION) L H
26 8611)09-39 TUBE *IS* r COPILOTS OXI6EH REGULITI)R TO L G
UHION)
861009-69 TUBE 1551 (COPILOTS OXI6EN REGULlTOR TO I H
UNION)
21 lHBI5-)D UNION L
28 861009-11 TUBE 1551 IOYERHEID TEE TO OVERHEIO L
TEEI
29 86100P-L3 TUBE LSBI (PILOTI I(SII TO OVERHEID TEE´• 1 *8
Lnl

CODE EFFECTIVE I)N SERIIL NU*BERS

1 6901 LI1DO THRU 11108
B 6901 11209 THRU tllbB
C 6901 C 6901 11269 THRU 11519
D 6901 11100 THRU 1116)
E 6901 THRU 11208
F 6908 11350 THRU II)PP
G 6901 E 6908 11159 rHRU 11115
H 6908 tl)lb THRU 11599

Reviard: 28 Novembel´• 1984

2-581
 ILLUSTRATED GULFSTREAM
COMMANDER
BECTION n PARTS CATALOO
BBOA/BBOB
MIICELLANEOUS

MODEL 880n/8 11?88 ~ND SUBSEOUENT,

tF
88

se
?DF;~
i
,2

C~
sli
:131
21

D E

’P1-.
3 22

i\ 1
L0-
i
Piours 2-71. Oxy(l´•n Syrtsm (Ih´•a~ 3 o(

a-588
 ILLUSTRATED
ROCKWELL
COMMANDER P~RTB CAWLOO SECTION n
BOOA/B MISCELLANEOU8

~i;´•´•e

13 L~--38

X/

Qhr~3- ~32

Llslli´•

~i(lure 2-11. Oxyean Syrtem inltall.tion (Shsel 4 ~f

a-398
 ILLUSTRATED
ROCKWELL
SECTION n PARTS CATALO(I COMMANDER
MISCELLANEOUS BgOA/B

IIIUH~ P 4 R r UNITS UI4RLE

i INO[X O t 5 C R I P T I O N PER ON
~UMHIL n u M o E n 1 2 i 5 6 7 nsrv CODE

2-71 30 dh1009-*L TUBE PJSY IPILOTI N45~ ~USL OUTLET I

VILYE TO DVFRHE4D TEF. LHI
Y(IICOI-17 TUsF 1\SSY IPILUTS *4SK HOSE OUTLET L H
YI\IYE Til OYERHEPU TCEI Lnl
31 6b1004-~ TUBE ~SSY IOXYGEN sOTTLF TO REGULITOH1 L 4
32 801009-19 TUsE 1SIY IDXYGEN SOTTLE TU HEGULITOP) L D
1161009-29 TU3L SSYL (~XYGEN sOTTLF TO RLGUL*TOR1 1 L
34 BL1009-Lj HOSE, sHIEL3 *li ilR
Lb1009-31 HU~E, SnllLD dR C
R6OZYI-5I1 BOTTLE INSTL´• OXYGEN RFF 4
101241-1 eorr~a INS rL CXYGQ"I, *iT RFF B
Ub121Z-50L SOTTLE 14STL, OXYGFNI 4Fi LEF C
35 J01-9-Z ELi)OW 1536551
P6 6530 COUPLING, CYLINDER 15~C551 I bL
J7 P0~281-7 TUBE bSTY, VENT I 4
86L~)Z-5 TUBE LSSY, VENT I R
39 ehl)*2-13 TUBE ISSYI VENT 1
141~4CnING ’4RTSI
10 YIZ19190G5 tLIMP 2
MIJ5206-7bl SCREW Z
dN960ULP W4SHEn 2 4
NUT 2 4

ii anri,-so UNION I d

i2 NILDOZ1-SD ELIOW i R
ii RIIORZZ-5n ELJOW I C
~4 r~n297-5 FITTING 1 4
*5 L612IP-P VENT L RC
~6 63406*-do BDITL~I OXYGEN 1536511 1
i’ ’IZZLP10-~)II CLINP 2
CR C6U2RI-3 BI4CKFT 2
"4 9612L2-3 B14C~tT Z BC
P(IIR9h OXYGE N SY STEn INSTL. CPBIN ......i....... P.LF
50 LM625 MPSK PSSYI OXYGEN IStE INDEX -I FOR 6
RRL4KDUWNI IOZPIII
51 1618 Y*LVE 1022111
~L IbZR Y*LYE 1022171
53 eoLR96-15 TUBE bSSY 1
51 861896-1 TUBE 45IY
55 R61896-7 TUBE nSSY I
Id li61R9L-11 TUBt i\ISI L
57 r61816-9 TUBE nssv I
se nainsa-13 rust nisv
59 salele-3 TUUE ISIY
60 aNR3~-4O ELBOW ´•´•r´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´• 6
(ITTICHING P4RTSI
4N92)-90 NUT
5-0)~9-404 O-RING ´•+´•´•´•´•´•´•´•´•.´•´•.r´•´•´•´•´•´•´•´•´•´•´•´•.´•´•´•´• L
----li---

bi IN821-~D TEF I

6.’ BOX 911Y, LH ´•´•´•´•´•´•´•´•´•.r´•´•´•´•´•´•´•´•´•´•´•´•´•´•´• 2

63 601521-501 BOY nSSY1 Rn 2
e* R6152I-505 Doon aSsv r aR
P61521-521 DUOR 1551 4 C
a5 H61521-1 BOX 1SIYI Rn (\FT L
C6 11615)1-501 DOOR ~ISY I 43
861521-531 OOOR I\SSY L C

CODE EFFECTIYE ON SEKIPL NUnBERS

690b LL100 THRU L1LOB
B ~90* 11209 THRU IlPbB
6904 L b)OB IlIt9 dND SUBS
6914 L h91R 11269 THRU 11I1~
6900 Ll~lb THRU 11599

2-400
 ILLUBTRATED
ROCKWELL
COMMANDER P~RTS SECTION n:
ason/8 MLSCELLANEOUB

is

E ~fa$o
or ~s n ii ’B

ill is

a
-Is

Pi.ur. 2-12. Wine.nd Imp´•nnol. D´•i.´•r inlt.lldi.n (Sheo11 of 4)

2.401
 ILLU8fRP;TED
ROCKWELL
SECTION II
MISCELLANEOUB
PARTB CAT~LOCI COMMANDER
880A/B

~IGUCt P 4 R T UNITS USIBLE

INOLY 0 E S C a 1 p T I c r PER ON
NUMBEU N U M 0 t R L 2 3 Ii b 7 455’ CEDE

L-72 8901$8 DEIC ING SYSTEM, COHPL ETE REF

8903Id WIN) ~NO EMPENNIGE DEICEK INSTL, REF
CUMPLETE
IYULld OICEK INSTi, PNEUMnTIC ktF
L Z5I-IC5015-01 ROOTI WIUG OtlCERI LH
2 i55-705015-02 ROnii HING OEICER, HH I
HYo316-503 30URLER1 in i aH 2
ssolrs-zl HOSE I PRE SSURE t YICULIE( 2
IPTT4CHING PbRTI)
nH7 371W30 CLdHP r

LL nS3SCR9-IL (‘RUMIIF T i
i BYOj18-1] TUBE, PRESSURE 8 YPC~UM 2
56 MS’S*R9-2OS GRJ*MET 8
i 890)18-10 TUBE, PRESSURE C V4LUI)M
ea 1Si17L9DG9 CLIMP 8
IITTPCnlNC PPRTSI
4hi3-54 BOLT 1
bN?tO-LDL 3bSHER ´•´•´•´•´•´•´•´•.´•r´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´• L
YS21044N3 hlUT .´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•.+r´•´•´•´•´•´•´•´•

---i----
7 r90318~29 HOIE
PbRTS1
dN131TW30 CL4HP Z

8 R403)8-15 TURE´• LH PRESSURE L YLCUUN i 4

n90318-R3 IUdEI LH PRESSURE 8 YPC~UM 1 B
190319-17 TUBE, RH P9ESSUIE C Y4CUUM I
e90318-8L IVBE. RH PRESSURE i Y*CUUM L 8
Lo 1NV1~-193 HEOULER
LI O-KING 6 4
i? 8903(8-77 TUBE ISSI´•´•´•´•´•´•´•´•´•´•´• L
13 81U348-63 HUsE L 4
IPTTACnlNG P4RTSI
L* ~N1)7TU39 CL4MP 2

15 R4U3CR-ZL TUREI PRESSURE C YPCUUN I 6

Ii 4NBD7-L20 IIOI\PTER L
-17 ?NI!?2-LZn UNICN L 1
LB e4921-12 NUT 2 4
L9 S-C3~9-908 O-PING 1 1
dN93ROL2 TFE 1 4
2L R903~8-ZT HOSE 2 6
I4TT*CHING PIRTSI
22 i\iU131~ri30 CL9MP 2

23 BY03(e-ll PDIPT~R nSSY 1 4

zr nNB27-12o CROIS ISEE EIG. 2-341 RtF
25 050130-1 r TUBE 45 SY ISCE F IG. 2-3* 1 ´•..r PCF
26 I~EPI-1I\ Y~IYE 1
0 15 TR I BUTOR I r 955 L I 1
IITTntHIYG PbRISI
21 nNI-j0 UOLT 2
4N9e0-416L UPIHFP I
MSZi144NI NUT ´•´•+´•´•´•´•´•´•´•´•´•r´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•...´•´• 2
---I---

28 R90346-ll ORPCKET ´•..´•´•.r.´•´•................... i 6

29 R903*R-85 TUBE *SSY, PRESSURE L V*LUUM 1 B

CnDt EFrECTIYE ON IERlbL NUBERS

P 6904 8 6908 11100 THRU 11415
B 6908 11416 ~ND SUBS

2-402
CIULFSTREAM ILLUSTRP;TED
COMMANDER SECTION H
PARTS CATALOG
B80AJBBOB MISCELLANEOUI

MODEL 6801VB -11100 TnROUOH 11411´•

i
~i-ll
20
1
o

Tj

~ilur´• 2-12. Winp.nd I.p´•nn.l´• D´•i.´•r Inlt.ll.lion ISh;´•l 2 of 4)

2-409
 ILLVSTRATED OULFSTREAM

PARTS CATALOG COMMANDER

SECTION II
MLSCELLANEOUB esoa/esoB

FIGURE PIR r UNITS US*BLE

L INDEX D E S C R I r T I O H PER ON
MINBER N U B E R 1L 315 6 I 151* CODE

2~71- 30 1N83)-BD ELBOU 1 B

(ITTICNIHb PIRTSI
-31 IN92)-BD MIT I
-32 S-0310-908HT O-RING I
---li--r
33 1Ne31-BD CROSS 1 8
I)ITTICHING PIRTSI
31 1NBIS-8D UNION 2
-35 5-0310-90887 PRING 2
---1---

8903)8´•19 ´•´•TUBE1SS*l PRESSURE I 91CUU8 L II

-37 890318-81 ´•´•rUBEIISII PRESSURE I 910008 ´•´•´•i´•´•´•´• I I
38 1N9L9-L90 REDUCER L B
5-0310-91281 ´•´•O-RING I B
-*O BsDI(B-II ´•´•HOSE 1´•´•´•´•´•´•´•´•´•´•1´• B
IITTLCH1NG PIRTSI
-)1 LN131TU3(1 CL*nP 2

38E91-L1 VILVEI DIITRIBUTOR 1991)11 1 B

(ITT~CHING P*l(rl)
-~3 *N)-3D BOLT
1N9(10-)16L ´•´•YLIHER
nS11D)INI NUT 1
---I---
890)(8-13 BRICKET, ~UNT I 8
-IS 8’)008-25 ´•´•WU~LER L B
1(131189-1* 6ROINET 1 B
17 n531189-20 CRONIET ´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•i´•´•´•´•´•,´•´•´•´•´• I B
)B ~BOZlb-Be TUBE *SSY ISEE FIG, I-bs) REF
-19 LN8)3‘L1D ELBOY. BULI(WE*D ´•´•´•´•´•,´•´•I.......´•.. I B
(*TT*CHIHG P*RTS)
-50 INP2I-IID NUT 1
O~R1Nb ´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•1´• 1

-501 BUSHrNG 1
S-O~LO-)IOHT O-RING
51 71)0)2-503 REGULITOR. RELIEF YILVE´• DEICER 1 B
(LTT*CUING P1RTSI
-52 I(S2001~-03-03 ´•´•BOLT´•´•´•´•´•´•,´•´•´•´•´•´•
LN960-10t V*SHER

890)18-93 TUBE 1PII´•´•´•´•´•´•´•´•.´•l´•´•.´• REF

-51 1N9L9-16D ´•´•I(EDUCER I 8
~55 REDUCER I B
-56 O-RING B
-57 *H937D12 CROSS 1 8
18 IHBSL-1LD UNION 2 B
(ITTICHING Plr(TSI
-59 IN91I-I2D ´•´•NUr´•´•´•´•´•.´•´•´•´•´•´•´•´• .´•´•´•1´•´•´•´•´•´•´•´•´•´•´•´•´•´• I
6´•0110-9LZHT ITRING 2

-60 890318-89 ´•´•TUIEIIS* 1 B

6l 890)(8-25 ´•´•HOIE 2 B
ILTTICRING PLRTS)
62 INI)ITW)B CL**P
---I---

63 ,n,-, VILVE, RELIEF 126133) ´•´•´•´•´•´•r´•´•´•´•´•´•.´• I II

61 1N8I)-D10 PLUG ´•´•´•´•´•´•´•I´•´•´•´•´•´•´•´•´•´•´•.´•´•´•.´•´•´•´•´•.´•´• L B
65 1N919‘20D REDUCER I B
~66 I-0)10~910HT ´•´•O~RIHG I B

CODE EFFECTIYE ON SERIIL HUI(BERS

B 6908 111I( ln0 SUDS

a-401 Revircd: ail Navenibel´• l!)ti4

GULFSTREAM ILLVFTRATED
COMMANDER PARTS CATALOG SECTION n
6801\/6808 MIGCELLANEOUS

MODELgBOB 11I1 nND SUBSE(IUENT.

1"
3\ 33-~i
,,~i,

r
L
j

,9,,,,
1f~ ~I" II
y II

,I

13-
r
‘L;d!
1,,

X11 I~a

I´•igvre 2-12. Wing .nd Impenn..e Dei.sr inrt.ll.lion (Sh´•´•l 3 d 4)

Reuised: 28 Novemb.r 1984 2-405

 ILLUSTRATED OULFSTREAM
COMMANDER
BECTION n PARTS CATALOG
880A/B90B
MISCPLLANEOUEI

IZI

a~

~a e

,3 ii

18

q 12

~isUI´• 2-72. Win..nd I.p´•nn~p´• D´•i~´•r in.l.ll.~ion (Shee~ 4 d 4)

2´•408
 ILLUBTRATED
ROCKWELL
COMMANDER PARTB CP;TALOO SECTION II
MI8CELLANEOUB
BOOA/B

FIGULE P 4 ii T UNITS USbRLE

E IND~X O E S C R i P T I O N DER ON
NUMBER N U M B E H Z 5 6 7 1ZSY CUDE

2-12 b7 850278-1 i~lR EJtCTOK. DEICER 1 B

(ITTb(HI~G PbKTS)
bB ~iZ1919DG24 CL4MP 1
69 SCREW 1
NIS42UO6-21 SPICER 1
HIIWEH 1
NUI

10 890~48-15 OUTLET 1 R

11 830158-3 SUPPORT ´•´•´•´•´•´•´•´•r´•´•´•´•´•r´•´•´•´•´•´•´•´•´•´•´•´•´•.

1
I~TTPCHIYG PIPTSI
12 MS27039-i-0’1 SC*FI I

PN"L0-10L WISHER

13 R90~1e-* CLIP ~SSY i R

7( CLIP ISZY I

15 890318-25 HUIF
IPTTPCHING PPRTSI
nN7)I~Y3R CLLMP

16 6903)8-9 TUREI PRESSURE G YlCCUI*I i

77 8r03"8-11 TUBEI PLESIJRE E YltUUM i
78 ":ZL9L9D612 CLIXP 8

(*TTdtHING ~4RTSI
MI~T039-L-01 SCREW i
LN4eO-IOL WISHER 1
MIZ1OICNI NUT

79 ~00T. HOHIIDNT*L ZTdBILILLRI LH 1

CO 252-7950L5-0* BOOT, HOXI2UNT*L STnRIL12tfil RH 1

PL 251-7050L5-05 UOJTI YERTIC4L STnSIIIIEC I
82 899356-)01 DOUBLER 3
83 890348-33 HOSE
(*TTICHING P4KTS)
8’t LNT37TW22 ilIMP 2

as Ns,sres-lr canMnET p
ad 390357-1 *I~IFOLD 45fY
PIRTSI
bN3-5~ BOLT i
LN960DL0L WISHER ´•´•r´•´•´•´•´•´•´•´•´•´•´•.´•´•´•´•´•´•´•´•´•´•´•´•´•´•´• L
NUT 2
WS219L90G16 CLLIP ´•´•r´•´•´•´•´•´•´•´•´•´•´•´•´•´•.´•´•´•´•.´•´•´•´•´•´•´•´• 2

e7 8903~4 PRDPELLER DEICING INSTLI ELECTRIC ISEE REF

FIG´• 2- Il

CODE EFrtCTIVE DN SE*ILL NUMBERS

C 6900 I1410 *NO SUBS

2.401
 ILLVITRATBD
ROCKWELL
SECTION II PARTS CATA100 COMMANDER
MISCELLANEOUS BBOA/B

1711

2
9~L

23
a
A
12
,r
2

U I

B is

sil

~isur´• 2-13. *nli-i~´•r .nd D´•i~´•r Equipn´•nt in.l.ll.lion

2-(08
ROCKWELL ILLUSTRATED
COMMANDER PARTS CATALQO SECTION a
B(IOA/B MI8CELLANEOUS

~IGULE P Ii R T UNITS USIBLE

L INOCY O E 5 C P 1 P T I O N Pth Oh
NUM~ER N U M a E i I i 3 i 9 a 7 nssv CODE

2-13 890338 DEICLNG SYITENI COMPLtTF REF

UOUL92 LIGHT INITLI ICE INS~ECTIDNI iH C RH RtF
L 8001R5-L REIPINtK 1
(4TTICHLNG P4PlTIi
2 n521693~5C SCREW I

*I3Z1OA~No* NUT i

---I---

dUJ1Bs-l LENS
i 10)4aL-1 i
ICI’1JO-L R ET4i Nt s 1
IdTT4CHING PnRTII
6 USj5ZOL-227 r SCREW ´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•´•I´•´•......... Z
Y555333-37 2
----li---

i d1~79R-2* LLIP 11291i) 1

8 31-0618-1 IOCYET i7Llil) 1
100190-1 RLTIIN~R L
(~TTdCHING P4RTS)
10 Y535206-)27 SCREW 8
Y535333-37 LOCK*~IHER 2

II MS3:489-i GROMIT
it R00L8’t-I COYER
I4TTPCHING Pn9TSI
13 MS2*b93-S27 SCREW
---I---

a90310 RUDDER HURN INTI-ICEL IYSTL RFF

I* MS27LIZ-2-I STRIPI TEBRI1IL 1574 )Ob.BZI I
I4TTICHING P4RTSI
NS2’td93-526 SCREW 2
USZ1OSI~OL NUT 2
----li---

L5 iBTL-2-37-Bb THERYUSTPT L
16 5Ei4B7-Z 4~TI-ICERI RUDDER HORN (03i8i1 1
I4TT4CnlNG 04RTS1
17 YS27099-0806 SCREW

LR 120030-505 RUDDER liSSY (StE FIG. 2-*21 REF

19 5E1407-1 4NTI-ICER. RUDDER ~ORN 1031BL)
IIIT4CHINS P~ITSI
20 1452703P-3806 SCREW 7

21 *1OODR-515 ST481LLltR 655Y1 VCRTICi\L SWEPT (StE RFF

FIG. 2-’tZ I
R903ds RUDDER TRIM 748 DEICE9 INSTL REF
890389-1 DEICEK´• RUDDER TRIM Tnb I
890371 Otl(ER INSTLI GENtfinTOR INLET REF
23 372-i00-L HEI\TER (OL7281 2
IATLZ-37-86 THERMUSTIT 2
)5 533038-1 RELPY 2
IdTTbCHIMG PIRTS)
MS35L06-23L SCREW Z
4N96006 WISH~R 2
MS21083N06 YUT
---I---

2-408
 ILLU~RP;TED IMCKWELL
BECTION n PARTI CATP~LOO COMMANDER
MlsCELLANEOUS BBOA/B

G´•

r-
B

4; r

ri(lur´• 2-74. Plop´•ll´•r Synlhronil´•r Conlroll

2-410
 CIULFSTREAM ILLUSTRATED
COMhdANDER PARTS CATALOG SECTION n:
ssoA/ssoB MLSCELLANEOUS

FIGURE P 4 4 T UNITS UIIBLE

C INDEX O E i i 1 I P i I O N ON
LU*B~R N U n B E a I 2 3 15 6 7 nssv CODE

2-71- 5600L0 tOhiTROLI INZTL, PROPELLER S*NC (RH CNLII ReF

I 710L-JL S*ITCH1 PROP SING 109)531 IIEt FIG´• REF
s-LZI
9D0LL3-5L3 ROD. PUIH´• RH (leE FIG´• 2-1LI REF
3 550114-1 BELLCRPNK liSSYI RH ISE E FIG´• 2-11 REF
4 213447 llOD ENO II65D)I L
IITTICHING PbRTS)
5 INI-1(IP BOLT 1
PiN910-3 WI\IHEfi L
i\NPLO-IOL VIZSHER I
PN320-3 NUT 1
nSI)b65-132 PIN, COTTER ´•´•´•´•´•-´•´•´•´•1´•´•´•´•´•´•´•´• 1

213450 Sn4FTI PLEX 16L5031 I

1 1185-021 ICTU*T0R I 66503 I +1´•´•.´•.´•´•´•´•´•´•1´•´•´•+. L
I*TTICHING PPITI1
8 *N3~3* BOLT
UbIHER 4
PN960CLO

9 560011-1 BRICKET *I~YI FWD L

-10 560012-1 BRLCUET bSSY1 b~T 1

LI 640019-1 SLIP RING, DEICER 2 4

12 3362-02* I*RGET, IINCHROPHbSE 16(150)1 6 4

13 1680-646 PICKUP 1 b65031 P

I*TT*CHING PIR1S1
1133-817 NUT 1665031 L
----I---

1316-082 BR*CKET 4111 IREPLLCEI 2938-0221 2 4

15
1~610)1
I*TT*CHINt P4R1SI

LL HIILPSI--5) SCREW IOPTION*L fIl UIE H551957-5*1 2

ii 352042-1 BRUSn 4SII ISEE FLG´• P- 1) RtF

COOE E~FECTIVE ON IERlbL NUHBlRI

4 6908 11350 LND SUBS

2.411
 ILLUSTRATED GULFSTREAM
SECTION n PARTS CATALOG COMMANDER
MISCELLANEOUS ssoA/ssoB

c \K

E
0~ \9

A
%Bb "T S
U

A B C

TOW iNFlAls ro

LIMITS 30 LBS.
~1;1-1 EMERGENCY EXIT

DI IE F

FUEL TANK
ATTACH-JACK PAD TIRE PRESSURE
SUMP DRAIN
70 PSI

JET FUEL ONLY HYDR*ULIC RESERVOIR

SEE AFM FOR APPROVED FUELS I 1 ~11110 M*)l( ON DIPIIICK

FILL FROM EITHER SIDE

FILL INBD TANK FIRST HYORAULIC RESERVOIR
1111 TO M*IIK ON DIPITICK
Tlsl M(L-H-83181 RID IIUID

Figu,´• 2-11. Plo..rd ond Da..l InrIIlIIIllien ISh´•´•l I er 3)

2-412 Revised: 28 November 1984
 ILLUSTRATED
CULFSTREAM
COMMANDER PARTS CATALOG SECTION II
690A/690B MISCELLANEOUS

I~ ,I I,

I *CCUMULe~rORI]
1N~LPITI TO 600 PII
8*001GI C*PI\CITI
600 is M*X.
IVINLI DIITIIBUTID
Lsmne SOURCE
KEEP CLEAN

"bo’ I ’U1

M N

BALLAST CAPACITY
38 LBS MAX

I
8*TTIRY CART RICEPTPICLI24 VOLT
IiT7 WHEN PDDINO OR RLMOYING
BALLAST THE A/C WI~BAL.
LOADING SUB-TOTAL MUST BE
13 AD~USTED ACCORDINGC(

O P O

nocxwa inle,nnaonal

O i I r~
ii~ i~
i~
Ti I
p~i

Ij~ Rockwell Turbo Fommander

Ei.ure 2-15. Pl.~.rd .nd De..l inlt.llolon ISh´•et ot 3)
2-413
 ILLUSTRATED
OULFSTREAM
SECTION If PARTS CATALOG CUMMANDER
MIBCELLANEOUS 680A/8908

Turbo Commarlder
1I_J

I~
Lul

TL~rbo Cor~hander

CAUTION
""’"Y’

"*U’ME1L’´•*U"’r’

CAU-III

~isure 2-75. PI..erd end Ind~llotion Isha´•1 3 of 3)

2-414 nevised: 28 November 1984

 ILLUSTRATED
OULFSTREAM
COMMANDER PARTS CATALOG 6ECTION II
690A/890B MLSCELLANEOUS

FIGURE PIRT UnITS USIBLE

L INDEX O E I C R I P I I O N PER on
NU*BER H U B E R i Z I I 56 1 ISSI CODE

~-75- 1101)( PLICIRO (DECLL I NSTL REF

1 110136-225 OECIL. TOY LI*IT (RED LETTERI) 2
Z 11013(.1 DECIL´• NOSE TIRE PRESSURE 1110 LETTERS) Z
3 110098~503 OECIL, E*ERGENCI EXIT 1
1101)(-11 DECLLI FUEL (RED LETTERSI
SU*P
5 11013*~LL OECLL. JICK PID (1(ED LETTERII Z
llOL)(-97 DECIL,JLC~ PLD IBL*CI LETTERSL Z
6 11013)-2(9 DECIL, n~lN TIRE PRESSURE (RED LETTERS)
I 110L3).L9L DECLL. FUEL FILL IBLICI LErTERS)
11013)-193 DEC*L. FUEL FILL (1IEO LETTERSI
B L101)1´•99 DEC*L´• FUEL IU*P I BL*CI LEITERII 3

9 110139.29 DEC*L, HIORLULIC RESERVOIR (RED 1

LETTERSI
11013(-LOI OECLL. HIDI*ULIC RESERVOIR IBL*CI I
LETIERSI
11013(-233 DECLL1 H*DRIULIC RESERVOIR (REO I G
LETTERS)
110136-235 OECIL´• H*DR*ULIC RESERVOIR IELLCX I G
LETTERS
10 11013)-~ DECILI HIDRIULIC *CCUWULLrOR IIELLDY L
LETTERS)
11 110131-179 PLICIRD. E*bGlbE C*PICITI L
ii DEC*L. SILTIC SOURCE IELICl( LtrTERSI
11013).231 DE(*L. STITIC SOURCE (YHIrE LETrERS)
13 110131.9 DEC*L, DLTTER* RECEPTICLE (RED LETIERII L C
IlDI3I-s3 OECIL´• ELTTERl REEEPTICLE (ILIEI´•´•´•´•´•´• 1 C
LETTERS)
11013).219 OECLLI 8*TIER* RECEPT*CLE 1 D
110136.221 OEC*L. NO´•1IIITrERI´•´•´•.´•I´• 3 D

110136.223 DECLL´• HO´• 2 ELTIER* Z O

LI 11011(-111 PLLEIRDI BILLIST CIPICITI ´•´•´•´•i´•´•´•´•i´•´•´• 1

15 110136-31 DECILIM S’IEP L
-16 PLLTE, HI*E
110136-19 PLITE´• COUNTR* IE0111RLT1OH (EXPORT I
OHLII
110136.63 PLLCIRO´• YEICHI IEXPORr ONLI) 1
is
-is bbi4II-5oI DECIL, EXTERIOR C

Bb0E1I-)03 DECIL, EXTERIOR Z C

20
-li ablrsp-l OECIL, EXTERIOR 2 E

BL11I0-l DECIL. EXTERIOR t D

22
162012.1 DEC*L. EXTERIOR ´•´•i´•´•´•´•´•´•.´•´•´•´•´•´•´•~´•´•´•´•´• B

CLU.III OECLL I PROPELLER L116sPl Z

PI
PLIC*RO, BlbGlGE LIGHT I G
.23 061L2~-l)e

CODE EFFECTIVE ON SERI*L NUWDERS

6903 L110D THRU
113)9
B 6905 11310 THRU 11599
C 6901 11100 THRU 11268
O 690* 6 6903 112(9 IIRU llses
E 6901 lilts TRRU 113(9
F 6901 r 6903 L1I00 rnRU 11516
G 6903 111LI TnRu 11599

Heviaod: 28 Nuvrmber 1984 2-415/2-(18

 SECTION

NUMERICAL IND EX
 ILLUSTRATED
OULFSTREAM
PARTS CATALOG SECTION m
COMMANDER
NUMERICAL rmDEX
ssoi\lss0B

19~1[clBIIII

Num erical ind ex

3-1
Revised: 28 November 1984
 ILLUSTRATED
OULFSTREAM
Seotian In PARTS CATALOG COMMANDER
Numedel hdex 880A/690B

P Pi R T FIGURE P 1 R T FIGURE P L R T FIGURE

L INDEX E INDEX I INOEX
N U 8 E R NU*BER N U It B E II NUI(BER N U n B E R NUIIBER

I-L30b 2- L -)t *H23-111 91 ~N)-15L 2~(8

1-1311 2~1´•ZL *N)3~LI LN)´•ISL 1~)8- 15
1-1)13 1- 1-26 *N23´•15 1‘LI- IN)~1S1 L~IB- )B
2~ L L7 *NP3-L5 L‘)B~)1 1N)-19L 1‘)9 ´•33
*-1851-7 2- L -(8 *N23-l5 IN)-I~L 2-62 ‘32
~-1852 2- L -(6 *N23-17 81 LN)´•l~b 76
*~L85( L -15 ~N23‘LB1 ~2(1 1N3~1611 1~35 (2
1-LB17 2- L -(7 *N23´•12 2-)8 -18 IN3-16L 2-~I -117
*-1889 2~ I (9 IN~(-10 30 LN1-161 IS
*~ZOL1 2- L 29 2-6) I) LN)-17L -108
*-20)6´•2~ 1-1~39 *N1)-ll ~-63 6 1N3-llL
*-2018-IL 2- 1-33 *N2~´•lll 2-P5 -1)1 IN)-l 711 2~52 -lbZ
1~20( 8~2 2- L L *NI(-ll* 2-~6 -99 1N1-ZOI Z‘L6 -1)
I-PBP 2- 1-27 INZI´•13 2-L9~ 2 ~)I
1-285 2-1-31 LN2(-13 P-)(- 10 1N3-ILI 2-LB -~I
1~)099 1‘ L ~3) *NZ*~13 2~(5 -1)8 IN3´•ZLI
~-)0) 2- 1 13 IN2)-IP L) ~N)´•Z)L I~LB (B
Z-1- 9 *NZI-13 ~100 *N1‘231 2~19 ´•63
*-3086-2 L 28 1NI(-l)~ 1NI-251 1-52 -112
1-3089 2- 1 32 2-L6 11 LN3-261 9
~-32)5-020-1)9 *NL)-16 P *N3-2~1 Z~51 -I~)
*-)~35-820-Pll L-IZ 2 1NI)-161 L~39 ~N3-17)1 -281
1-3135-020-1(1 1NI(-161 2-)2-51 1N1-3 i-PI -L32
1NL)-17 9) 1N3~3L
P-)3II 2- L -30 1NZI-1B* 2-53- 65 *N3-I~ 2-10- (Z
L-((IIl 1~)1- 8 *N3-31 2-LI- 3
P-500-28 1NII-I2 2-)8-61 *N)-3I
L~36 ~IP 1NI(-(2 L-1P -22 *N)-31 2~15 ‘101
1-880-2 2- L -15 LN21´•lb 2-)8 -119 *N)~31 L-SL -II
L~BB) I-l-LO *Nllb-6 2-LB- 20 LN)-)I 1~68 -Is
1-890-6 )-1-35 *N3‘1(1 )-II- 18 1NI-91 2-I~- 8
2~ I 1( *N3-IO* 1‘L6 I) INP‘301 Z~Lb
LBCIOBB 2-39-152 1N3-101 2-18-25 Z- 9 -13
Pac6089 PII3-l01 2-35 -10( LN9´•~1 2-LL (7
~EC-L 2-2~ -115 1H3-ID1 1-16 18 1N1-~l P~LL (9
IGC~3 2~LS ~LISL IN3~1D1 ~91 1N)‘~1 P~1)- 19
*dC-5 I-L5 ~L151 1N3-101 2~(5 ~1’LI 1-10- L9
1GC-5 2-25 -17~ LN3-I0I 2-(9 10 IN)-~l 1-2) II
*GC-l´•ll~ 91 1N)-10* 2‘~9- IS 1N)-(l I0
2-25 ~LII ~N3‘1D1 2~19’ 82 LNI-)I 6l
LI))1)1~ 1-12 (9 1H3-IO* 5 1N3’)1 2-25 -1)9
*NLBO *N3-L1 2~11 39 L~15 -1)LB
*N113CI LN3-ll* 2-35 )9
LNII*-1) 2-19 68 1H3‘11* 2-19 -38 *N3-(l 1-35 -10L
2- 3 2) 1N3-Lll 1N3-(1 2-35 -1)L
*NIII-IO t‘l)- (9 *N3~L1* 2-69- 50 1Nf-(l I
IHII(‘P)* 3 -3( LNI‘L1* 5) 2-38 8
1NI76-2ll LH)-L1L 2´•)9- 58 2´•38- 19
1NLI)-3o 2-l6 8 LN)~L1* 2‘b~ 22 1N)-~l ~111
3 32 LN3-ll* 2~62 3L *N3-)1 ~´•)5 89
INII)CII* 2-16- 56 ~N3‘12 L-LI- 31 1N3-~L 2-(6 -78
INIIICIOI L-16- 6 ~N3-IZ1 61 86
1Nll*C211 2~16-10 LN)-L)I 2-L8- 39 LN)-)L ~9)
LNlll-32 2-19 67 IN3-L3L 1N3~)1 Id
1NII6-I0L 2-L3 -10 LN3-13L 1-)3- 91 IN)-(L 2-)9 -LD’L
1N116~101 L *N)~13L 2~25 ~1)0 )INI-~L Z~ll- Ib
*Nllb-13P 2- 3 Z 1N3-I31 2-)9 II 1N3-~L
INLlb-1)1 3 -13 LN)-L)L 2-39- 96
*N1)6-L31 2- 3 22 LN3-L)I 1N)-~* 2-61 LI
1N176-101 1~ 3 17 Z~)b- 88 LNI-)* I-LI~ )O
2-19 Ib *N3-131 2-69 81 I-2) -LL7
1Nltl-Zb 1-19 L3 1N)-l)* 2-62- 33 PN)-IL 2- 9 ZI
INLB1~1)L 2~3-11 2-19- 11 1N)~91 ~21
~N23-10 2-LL- 9 LN3-l)l 2-20- P 1N3-IL I- LO
1N23- LO L-1L-II1 LN3-I)* L-LO- 30 LN~-5r( LB ~3)
1N23-LO 2-LZ -113 1N3-l~l 63 LN3~51 I~Z)- 96
IN13- LZ 2-)8 -(2 LN3-LII 2-(9- 15 1N3-5L
llN23~ Is* Z~L3 3 1N3-L51 2~25 ~10 1N3~51 2-15 ~155

s-a Revised: 28 NovembsF 1984

 ILLUSTRATED
GULFSTREAM
PARTS CATALOG Section IIl
COMMANDER
Numerioitl Inden
asoA/esoB

P 4 R T FIGURE P 1 R T FIGURt P 1 I T FIGURE

E INDEX r INDEX 8 INDEX

N U n B E n NuN5En N u n a E a NU*aER N U n a E n au*sra

2~38 7 LN311-3R 1-11- 17 bN)´•1OI I-Il ~IP3

auj-sn a LN316~(L 1-62- )9 1N)~IO1 ~‘)6- 29
2-39 ~117 *N3lb-(R *N)~101 2~16 I~
2-39 -120 Z-12 -109 1N(-IOl 9
*N3-51
IN3~51 2‘39 -L5a 1N3I6-IR 2-13- 5 IHI´•LOL 2~)8‘ is
IN3~51 2-12 -70 lN3I6-IR Z-IB- 21 *NI-I 01 L-(B 63
-101 INSLL~IR 2-18 I) 1N)~101 ED
1N)-51
2-13 -7) 2~18- 30 IN)~1OL 2~(8 ~88
1N3-51
1N)~5* 1N)lb-lff 1-)9 -155 liN(-lll 2-39~ 60
IN316-)R ~-(3- 92 *NI-ll* L‘39 ‘86
LN3.5)
2-*5 71 *N316-(R I-ii 10 INI-LII 2-)3 5)
IN1-51
2-(6 96 *N316-)R 2-(1 82 ~N)-lll 2-I* 75
2~(8‘ 25 17 1NI-LII Z~(5 65
LN3~5*
LN)~51 1-53- 52 *N3lb-(R I-I6‘ 91 LNI-III 2-)5 -Llb

1NI-5I 2-62 IS *N)1~-)R 2-(8-118 *N)-lll 2-16 LI

2-68- 1 LN316-(R 38 ~80
LN3~51
1N3-51 2-65- 19 lN)II-IR 1-62 -55 *N)-lll 2-(6 -10)
2-68 -31 INsIb-IR 2~62 ~58 2~)8 93

iNj-51 1.68- Is LN)iL-1R 2-62- 65 *N)-lll 2-)8 -100

1N3-11 -69 LN3I6-IR 2-63- 15 2-18 -106
2-68 18 IN~LL-(R 2-b3- )I *N)-LLL 2-63 L8
*N)~51
*H3.51 1-68 BI *N)Lb.~s 2-63 Il *NI-1Z1 2-25 -118
2-69 6 ~N31L-´•IR L-O-(~ *N(-IZL I-b5 -19
1N)~I1
2-71- 611 2-)5-1)3 *N)-I31 2-15 -I)O
*N3-5L
2-12 86 *N316-5R I-a) 28 ~N)‘131 1-52 -IbS
LN3-S1
~N9-bl 2- 2 21 *N316-6R *N)-13~
*N3L6~bR 2-L9 ~3P 1NI´•13L 2‘~3 ~35

2-21- 95 *N31b-bR I-II- 15 LNI-III I-2S -155

LN3-6*
2-11 61 *N3I6-IR L-IL 31 1N)-l(l I-25 -157
L-21- 63 LN3L6-IR 2-L3~ 23 LH)~I’LI
2.)5 -105 *N32D-3 2-LI- 9 *NI-lll I

2-39-1)6 ~N110-3 2~11‘ 11 1NI~1S1 52

*N3-6*
2~)3 ii P~I1 32 1NI-1S1 ~-O

1-51 )5 1N32D-3 2-L3 1 1N1-16 2-19 9

*N1-61
*N3-6* 2-62 .IO 1N320-) 2-L)-7l LNI-ILI
69 ~N32(1-3 97 *N(-IS* I~(B ~77
*n3-61
1-68-55 1N)I0-3 *HI-IOL 2´•)I- 9

*N3-6I 2-68- 62 *N32D-) 1-(8- )B 1NI-20* 2-63 ZI

2-69- b *N310-3 2-(8- 12 LN(‘ZII ~-J2 -168

LN)-61
*N3-ll I-ID-IS 111320-3 1-58- 16 2-52 -L71
1N320-3 5 1N)-231 2-55 -3)
*N)-I1
*N3~1* ~)B *N320~) I-L6~ 11 IH)-131
LNBLO-I P-I9-L0 IN)-I3L 2-16- (1
*N3~11
29 *H3ZO-) L-19- 38 IN)-2)1 68
liN3~7*
52 1-19 75 1H)´•ZI1 I-I1 59

67 1H32D‘I 2.*( II *N)~2(1 I-IS 52

*N~‘I* 1-61
8 *N320-( ~!)B 59
LN3C(1
~N320-( I) 2-15 35
IN~C)I 2-1L -101
P-(1.103 1H110-) L-(~ -100 *H)-)ll 2-15 ~50
LN3C))
IN)ID-I 2-)8- 61 IN(-L7L 2-16 -36
LN3C51
LN3HI 01 1~13‘ 98 *N320~5 ~-19 -12 1W(-ll 2-25
1-19 lo LN)20-5 ~-L9- L1 liNI-31 2-25-L50
LN)NIIL
LN320-5 2.)8-119 *N*-30 21
1H3H13L 2-)2 -118
2-68 -21 IN)LO-b 2-11- )8 *H(-30 -)3
ln3H171
Il 1N110-6 ~N)-)L 1-28 -21
*N3H31 2-3)-
1N320-~ 1~10 8 1N)~)I1 8 19
1N)HS1
I-1) -111 1N386-I-L6 2-13-ii LNI-I51 2-)1 ~191
1N)LO-3
L.1Z -113 LN38L-L-L 97 Ln)-ll 2- 5 36
~N)L0.3
*e ~N,eb-2-l, 2-23 aII
1N3l0-) 2-1,
1-16 8 I-I*- 11 *N1.51 2-25 28
1N)10-~
Z-L9- 3 LNI-IOL 2-1- 5 INI-l* 2-38 19
IN31(1‘(
2~19 LZ IN)-IOL Z- 8 35 1NI-51 2-)~ 80
LN310-~
68 1N)-I0* 1-19 12 *N(.5L 2-)1 38
LN)IO-I )-IP
1N)-101 63 *N(-51 2-51 II
*N)LO-(
1-19 67 1NI-lOl 2-)5 61 1N(15~ 2-5L 10
1N3I0-S
8 ~N)-lOl 85 1NI‘I1 L~II- )1
2-13
I-L9 13 1NI-I01 2-(5 -IOb 1N)~51 )-5L 33
1N310-1
16 1NI~ID* ~LL1 1N1.51 2~51 II
1N310‘1

Revised: 28 November 1984 3-3

 ILLUSTRATED
OULFSTREAM
Seotlon III PARTS CATALOG COMMANDER
Numerlca~ Index 680A/BgOB

P 1 R T FIGURE P 1 R T FIGURE P L r FIGURE

L IHDEX (INDEX E INDEX
N U n a a NUW8ER N U B E I NUnBER N U H B E R NUWBER

1N1~6* I-1- d 1N6-1’L1 20 bNI3LTY38 1-35 -36

1Nl~bl 8 33 Z‘ 19 IN1l7TY38 I-i) 98
INI-bl I-25 8 INI‘P( 2-13 8 1N13)rY98
1NI-b~ 2-1)- IP LN6-211 2~ IN1)7TY)B 2-12 ~62
INI-bl L-IL -103 2-19- 83 INI1ITYIB 2~12 15
2‘51~ ZB 2-19 -LOL *NI37TY(I 2-27- 23
1N)-6I 69 1N12DI-1 2-L5 )O LNIP7rY)6 5
IN)-61 I-68 59 1NbtO(‘l I-I5 69 INIPIrY)L P-bl 19
1N(~I* ~-LS L) LN131rW16 22
LNI~II 88 LN6236~2 Z~Z) ~110 *H131rWSB L~ZI- P
1N1-ll 13 IN6Z38-1 2-21 -109 1N117TYIB 2-65
IN)~IL -19 lN1289~20 Z~b9‘ 26 IHI3IrY58 L‘bl- II
1NI-71 2-63 8 *N6L89-20 ~-69- 60 1111i1i58 2.67- 16
1NI~I1 2~63 II 1HIILTHbb 65
IN)CRIOI 2-10 18 1N6Z89-) 2- L 7 INIILTUI)
LNICL L1 I-(1-LOP 116289~( ~115 1N131TU7) Z
IN)CIPI 9-(1-108 1116289-1 1-21 -217 1N7317Y7) 2-~B 8
IN)CL31 2-13 9 1Nb2Be-*D 2-L6 1)C INI31TYI) I-bB 33
1N1C221 Z-I) 13 *N1289-ID I-68 81 INI11TYI( 2-69 )2
IN(CII 9 116189-6 2- 5-83 1N7111YBZ 2-65 I
IN(C) 2~11 II INLI89012 Il 111111i91 2~68 15
IN(CII 2~ 11 1N62890) Z~IJ 58 )lNI)ITY98 2~61 63
IN)C)L 2-65 -52 11(62890) I-IL- 17 IH737TY98 1-68 II
IN)H1)1 Z~ 1 36 IN6I89D( 13 LN131TY18 80
IN)H)I L-L(- 6 1N62890) 2-ZL- 32 INI(Z-3 2-21 -II)
IN(H)Z* 2~12 IO IN6I89D) 2-21 36 1NI(Znlb
IN(HII *N62890I 1~21‘ (O LH~(3‘13 P- 9-13
1N128)* 1-28 3 IN628904 2-ZL 18 1NIBIDb 2-21- 99
IN)2H101 2- 8 -39 1N62890) Z~LI -101 111i81-10 2-2)- 38
1N)L8-61 60 IN62890) 1NIB~-(O 2~21- 11
1N)38~1)1 I16I890I I-2(~ 15 INIBIDLZ L~3´•-
1N161 2- 8 )7 11618901 2-2( 6( 1N8D1‘16 2-69 25
*N5-lll Z-15 17 INIZBPO( 2-35 11 1NBO(~) 2~ 6 I
1N5-IZ* 2-(6 1162890) 2-35 29 INBD(-)D 2-21 39
L-13 38 1N1Z890) 1~)5 )B *NBD1~(D 37
1N5-15L 2-(7 )O 1N6189D) 2-)5 ~9 1N8DI‘)D 2-2) 13
~N9-121 L‘ZI~ 63 1N6Z89I)( 2~35 82 *N80)-)0 2~2)- 63
*N5-321 2-)7 3) LN6Z8906 I-2I LNBD(~)D Z~3b 22
INI-I 11 6 INbZ890b Z~Z)‘ )6 1NBDIDI 2‘LL -100
LNS-51 2-25 -109 1N66l-2I1 1-10 Z INBOID) 2-35 )O
22 LNI-331 39 INBDIO) 18
1N5~11 2-15 -II *NI)ITY101 2-*7- 5D INLIDID) 2-35 -102
I-II 55 INl3IrYI0I 2-61 28 INBOb-)O 2-35 -109
1N50D LDb- I) L 6* LH737TW107 2-67 18 LNBDL-(O L-35 -121
*NS00108´•10 2~ 1~61 *N131TW107 P‘68 3 liNBDbO) 2~35
~N50018-I 2-1(- )O 1N137TU107 2-bB- LNBD60) 2-16 L)
~NS011110´•6 1~18 IN131TY1(17 L~68 6 INBDI~LIO 2-72- 16
I- L -60 1NI37TUI07 2-68- 3 INB09-I 2-1)- 68
11(503-10-8 2-3(- 41 IN717TY1(17 1-68- 13 r(NBD9-L ~108
11503~)16-8 2- 5 -83 1N137TY22 *N811-1 69
*N503-8-( 2-62 -II IN131TYZ1 1-68 -90 INBII-DID 2-11- 6)
*N(OI-8-6 INIIITUZI 2-12 -89 2~19
1N515-(RB 2´•~9 91 1N131TY26 I-I0 19 IN81)-50L 58
llN515-I-Z 2´•66-13 ln731rU16 2.68- 68 *H815~100 5 L7
IN511-6PS 2-25-19’) LN737TY30 5 LNB15-IZ Z~b9 -II
*H52(C103LRI 3 1N731TU30 2~ 9 9 LNBII~L1 Z~b9 -61
L~(7-LB L~ 9‘17 1HB1~-1ZD 2~36 3
IH530-6-6 2~51- 61 INIILTYIO 2-10 ZI INBI5-II0 1~36 -36
Z~bl- 61 1N131TU30 8 INBI1-IL 2~69. 3
~usPo.aaa 2-(7-29 LNlb7TY30 ’I *NBIS~11
IW930~8Sb Z~b)- 6 1NlllIY30 2-72- 1 *H815~16 2-69 -)B
51 )1H731~Y)O IZ IN8I5-( 2‘ 6 6
*N5651)28H2( 1~ 8 26 INI37TY3P z- 6 I
IN56501012H3 2’16 ~11 1N73ITY3) ZI 1NB15-)
LD *N7371U3) 24 IN815-) 2- 6 52
*N581L~1 28 2-27- )5 INRIS~)D 1-19 ´•39
IN6~1PI 2~)0 1W7)7TW38 22 In8I5-L0 BI
1N6~131 1N)3LTU38 Z-)I 51 INSI5-ID I-II 96

5-4 Revised: a8 Navomber 19R4

 ILLUSTRATED
GULFSTREAM
PARTS C~TALOG section In
COMMANDER
Numerical Inden
BSOA/BIIOB

FIGURE F L R I FIGURE P 1 R I FIGURE

P I T
I INDEX L INDEX E INDEX
N U B E R NUIIBER N U B E R NUIIBER
N U 8 E R NU*BER

LNB3P-L20 2-12 -58 PINPIZ-)D 2-20 -37

2-23- 87
*N832-L6 1‘69- lNP12-50 2-17 5
INBLr-IO 2-is -92
2-23 -1ZO 1N831-I I‘ b 19 119L3-ID 9
LNBIZ-)D 2- 8-23 1N91)-LO 2-23 -8(
LN81~-(D
2-I’L -62 LN832-60 2-16- L(1 *N~II-20 2-23-115
LH815‘)0
2-35 -L31 1NB)1-)D 2-20- II LN918-IO 29
IN815-(0
11832-(0 2-21- 15 1N918-1D 2-35~ 9L
1NBI~-lO 2-36- 16
Z~)b- 65 LN832-*D 2-2)- Is LNPI’)-ID
1NB15~(0
11 1N832-(D II 5 2
1NB15~)0 2~((-
1NB3Z-)O 15 1Ns19~150 2~ 6 Il
*NB15-)D It
LN832-I0 P~3’1‘ 81 LN919~L5D 5L
LN815-.D )-II- LI
LN832-)0 2-P6- 16 LH919-l60 2-12 ~5(
LNB1S-)O 2-11- 17
1-)6 -28 LN832-6 2-13- 32 *N91P-19D 2-72 ~10
1NBll-5D
~-II I1 IN832-60 *N(IP-L9D 2-12 ~)B
LN8L5-50
2- 5 -15 111132-8 2-5-80 *N91~-19D 2-12- 55
1NB11~6D
2- 5 -83 *NL))2-80 2- I-lb 1N9L9-POD 2-72 ~65
IN815-60
2-21- PI 111833-100 2- I-ID ~Nel 9~23 2-69 L9
1N8L4-6D
2-23 -112 1N833-11 I-)5- 38 1NPLP-bD 2-15- )6
i~NBL5-b0
1N833-L2D 1N919‘bD 2-21- 98
INBLr-8 2- 6-25
2-12- 31 *N8)3-L20 1-31 -100 P-I3 -111
1NB15-BD
2- 8-2* IHB33-120 2-36- 1 *H92)-ID 2- 7-9
1NBI(1-I0D
2- 5 -83 *N833-l20 I 1Nsl~-lO 2-23- 31
1NBI6-)D
2-19- 15 1N83)-1)D L-36- 3’1 IN92)-!OD L~ 7-10
IHB16~)D
2-23 85 1N833-L20 2-36- 38 ln9Ll-IZ 2-12 -18
1.35 8 1N833~LID 1~12 ‘~s LNIP(~ILD 2‘3´•1~ 35
1NB16~)0
2-35- 16 LNB33-)D 2-17-16 1N92)-12D 2-35 -38
1NB16-40
81 *N833~)D LNIII‘I1D 2~35 PI
1NBI(~)D
2.35 -123 LN833-I0 2-21- 13 1N92(-LID 2~35 -1D0
INBL6-10
2-66- LI 1N833-(D 1HPI(-I2D 2-36 5
1N8I6-)D
2-11 22 IN833-(0 2-23 36 IHPLI-IID 2-36 38
IN8L6-)0
2- 5-83 *N831-~D *H92)-120 50
IH8l6-60
)iHB16-60 2- 6-39 2.35- 19 1~12 ~59
1NBlb.6D 2-35 -20 1NB33-IO 2-35-LII IN9LI-16 2-69-
2-3)- 85 *N133~1D IHP~(-IPI 26
LHBL(~6D
IN(IIB-LZO 2-3~- 36 ~N(133-)0 30 1N91(-~ I‘ 6-19
Z-)I- 25 *N833-ID 68 1~17 -19
1HB1B~)D
INBIB-)O 2-)5 -87 *N833-10 2-11~ 60 1N91(-)D 2-11- L6
LN818´•10 2-35 88 1NB3)-~ 2‘ 4-83 *1192)~(0 L~11- 2)
*H8L8-60 2. 5 8) 1Y13)-6D 2-23 )5 IN91)-(D
31 2-23- *5 1N92)~)0 2~10 ~IZ
1NBIO-IZD
1NB20-)0 2-13 80 2-12 30 INsPI-)O 2-2L 1)

1NBlt‘l(lD 33 1H83(~)D P5 l-ZL ~15

1NB2I-I6 2-69 9 1NR31-ID 2-2(- 20 ~NI)))-)O 2-1)- 36
1N8L1-~ 2- 6-30 1N83)-(D ~106 31

IN82I-60 2-23- 3) 1H83(-60 2´•1(1- 33 *N9P(-)D 2-23- 38

1H8P1-80 1H83(.)D 2-)b ~II IN1)P(~(D 39

INBL)-LO 2-23 -L13 1N83(-6D 2-23 I) 1NP2(-)D 2-2) is

1HBL)-16 2-69 13 1N831-(D 2-16 15 *N921-)D 2-35 )O
1N82)-1~ 2-69 -(P *NB3I-I0 2-10- 9 1N92)-IO 2-35- 15
LHBLI-) 88 *N831-I0 1-21-1~ INPZI-)D I-15 -106
*NBLI-)D lN837-10 2-21 I2 1HP1)-)0 2-95 -111

1NBZ)-)O i-I)- 80 1NB)I-ID 2-36- ’1 IN92)-(0 2-36 -13)

2.35 .116 1N831-~0 2-36- (3 IHP2)-~D 2-36 Lb
INBP)~)O *9 1N91(~(0 1‘)6 -30
1NBZ)~IO 2-)L- II *H838-1ZD LNIP)~(D Z‘P~- 33
LNBI)-´•O 1~ 11 *NPZ)~IO 2~16
~-36 16 INI)L-L2D 2-)I 25 2~36 (9
1NB1)-)0 2-11- ~I *N89)CB-( 2- 8-58 IN~LI-)D 2-36 68
1N82)-)0 )-11- 61 *N8P)DLL-IO 2-))- 58 1~)6 -11
I~ Z ~19 LN89)D1)~10 501 1~66 L9
7 LNP01-)1 2‘ II-ID LN92(~110 2‘b6 21
IN82I-II0 2-3)- 38 *N9D1-5* 2-19 -L10 1NP2*-I0 2-7L- 00
i-I)- 2( 1N911~1D 2-35 ~10 LNl))~b 2-23 -32
LNBI~-(D 2- 6-50 1N91L-1D 2-35- 31 LN91)-6 2-23 -35
LN832-I0 9 1N911~10 2-s5- 9) 1N91)~LO 8-*1
11832~10 2-23 31 1N911-ZO 2~23 -116 LN92(~bD 2~36 60
IN832.LID *NPIZ-10 11192)~8 2- 5 19
LN812-L20 2-72 ~11 *NPI)-ID L~16- 53 2-61- 39

Revised: 28 November 1984 S-S

 ILLUSTRATED
SeCtian m PARTS CATALOG COMMANDER
MlmsrlOSllndex 680A/B80B

P L R T FIGURE P R I FIGURE P 1 R T FIGURE

INDEX INDEX C INDEX
N U 8 E R NUIIBER N U W 8 E R NUEIBER N U )I I E s NU.BER

LN9L(-80 *N960~LOL C)(. 19 P-62. )D

1NP2)-80 L-)2 3L *N960-10L 2-31 6) LN96D-)L6 Z-b) Is
*NP16-6 2-35 -32 1N960~10L 39 1N~bD-llbL 2‘ 1-6
~NsZb‘b 2~)5 95 *H9L0-I0L 2-35 -L01 1N960-llbL Z~ 5 t6
1N929~( 16 )´•35 ~1L6 1N9L0‘(16L 2~ 5 -19
1-35- *N960-10L Z INsbO-II6L 2- 5 -83
*N929-) 2-35 391 1N960´•10L 2-)2 70 I89bD-II(,L 2-12 PI
1N929-) 2-35 -90 XH960-10L L-O ~1(5 1NPb0-)16L Z. II-II
LN92e-) 1~35 ~1011 1N9(10~10L L‘)I. IS IN96D‘~lbL 1~15 L3
*N92e-(D 2-35 -28 1H960‘10L 2-15- 11 IN960.I16L P-lb- 6
1*1929-(0 2-35 -LOI ~H960-10L 2-)5 ~131 1Hs)D-(16L 8
LN929-8 2-3(- 50 *H96(1-IOL 15 2-16 -10
1N931-I)I *N9~0-IOL 2-69 O INsbD-)16L 1-19 -22
1N9)2-ZD P-ll- 22 IN96G-IGI. 2-)9- 58 2-19 -II
1193202 2‘35 ~30 bO LN9b0~)16L
1193202 1-35 93 LWPL(I-1OL 2-(9- 6)
LN936110 2-1- 8 IN960~10L ~-)9- 66 P~19 ~IOb
119361)11~ 2-25 -PB LN960-IOL 1-~9- 11 1-(*- 13
1N931~)D 89 *n960‘10L 1~(9 16 1~(5 68
1N931-80 2-72 -33 IN960-LOL L-~9- 83 1N9LO~)LbL 2-(5- 81
LN937012 51 *N960-10L I~bO 26 .LOb
IN9380L2 -20 *N960-10L 2~62- 16 1Nsb0-)L6L P.)I-111
*N9)1-)D P-I6- I)B 1H960-10L E-62- 21 1N9bO~)lbL 2-~5-129
*N9(1D-IO L-I-87 *NP60-LOL L-LL 10 *N))O-(1~L 2-(b- 53
*N960-IO I´•ll-L9 *N960-I0L 2-63- 30 1N9L0-)L6L P-I8 -80
*N960~LO I-L1- 39 INsLO-IDL 2-63- 32 2-63 3
*N960-L0 2-11-)7 IN960-LOL 2-6)- 1-63- b
LN960-IO 2-LL-~e IN960-IOL LB *N9b0-116L 8
*N960~10 2-12- 52 IN9LO-IOL 2-69- 6 *H’IIO-)LLL 1-63- II
1N960-10 2-1) *NILO~IOL 2-70 3 P-b3 17
1H960-I0 2-1)- ~W960-10L 2-72 61 *N960-9l6L 2.63- 15
6~ L~IP- 52 *HPLO~)LLL L-~)´• 36
*N960-IO 2-11-111 *H960-10L 2-72- T1 *N9LO-)L6L 2-65- 19
1H960-10 11 LN96O-10L 2-12 -78 *NII,D-IILL I-IP- LI
1N9)0-10 Z‘)9~ 76 LN96O-1OL *Ns)0-*16L 2~12
1N96(1-IO Z‘(9 -83 LN960-I0I6L P-IB- 36 XNPb0-516 2-12- IP
1N9LO´•IO 2-51- 83 1N9~0-IOL6L 2-18- )1 *ns60-5L6 2´•L5 -II
2-11-111 ~N960-1216 Z-(I- 3 1N9LO-)16 1~15 ~(1
*N960~10 1-52 -161 *N960-1216 2~)1 18 11960-516 2-62
1N9LO-10 2-5L -llZ 2-(I 23 1H96D-516L L- 5 21
LNe60-LO 2-62 -53 *N960-l2l6L 2-61~ 39 1NP60-516L 2-13- 38
*N960‘10 l~b5 -Is *N960-lIl6 2-23- 31 1N96D-516L 2-1)- 55
2~(11- 57 1W960~P116L 2-69- 1H9bO‘IIbL 2~1s- II
*H960-L0 2-68 Is IN960-) )-11- 9 LNsb0-516L 67
*N960-10 1-68 -8) 1N960~)L (-3´•´• 66 1N9)0-516L 2-)1 -111
*N960-10 2‘10 1Ns6D-(L INPbD-516L 2-)1- 6
IN96O-IOL 2-1- 10 ~N’lbO-IL IN9b0-516L 2´•)6- 1
LNSbO-IOL P- 5 1N9~(1-(L P-)9~ 91 1N950-116L 1-65~ Il
IN9LO-IOL 1~1-29 ~N960‘)L 1-(9 -LOI *N9b0-b 1-3~- 2
L‘ 5 ‘87 P LWP)O~( L3
LN960-IOL 9 I) *N960~616
*N960~1DL 2-11- 26 1N9M0-916 2~´•1)-18 IN9)0´•Llb 2- 3 O
~NP(IO-IOL 2-11- 32 LHPLO-(1(1 L-l*~ 19 1N960´•L16 20
LN960-10L L-IP- I *N960-616 2~16-11 LNP(O-blL 2-13-91
*N960~10L 2‘13 2~19- 38 ln9LO-b16 )B
1N960-10L 1-13-15 *N960-116 2-19- 68 LNs(0-616 1-19 ~218
*N960~10L 1O 1~19- 15 LN963~b16 1~10- B
*N960‘10L 2-L6 -II LN960-I1L 2-)5- 68 1H9(0-616L 2- 5-10
LN960~10L 2-L9 10 LN960-)16 2-~’1- 80 1H960-(15L 2-13 B
IN96O-IOL 2-~4 -116 *H960-b16L 2-13 -20
Z~LO ~27 ~53
LN960-1OL 2-20 -31 LN960-)16 2-5L ZZ 1N9(0-116
1N960-I0L 2-20 -35 LN960-)lb 2-51- 3L 1N960-llb 2-25 -211
IN960-I0L 2-21 -LZli *N960-)16 33 1N9bD-II(, 2-62- 11
1N960~10L 1~ZL ~132 L~IP -1~5 INP60~llb I~b6‘ 19
68 Z~52 ~lbB 1N96D~116L
1N9I0-I0L 2-25-207 2-52 -LI~ IN9bO-llbL 1)
IN~(IO-IOL 1-31~ 11 2-52 -III 11960-8 2-12 69

S-B Hevised: 28 November 1984

 ILLUSTRATED
GULFSTREAM
COMMANDER PARTS CATALOG Seotlon 1l1

680A/BgOg Numerical index

P P I D 1 R
d R T FIGURE R FIGURE T FIGURE
IYDEX 6 INOEX E INDEX
N U n B E a NU~BER N U n B E R NUnBER N U 8 E R NUIBER

IN96L1-B IN960DIO 1HPboOlD 2-38 -IP

111960~8 2-66 ZL 1N960010 ~-12 -LIZ INPLODLO P-39 -12
nN960~8L -100 18060010 2 INPLDO10 2~IP ~8)
1N960-8L 2~31L 12 *N960010 2-17- 9 LH9f,00I0 2-39 -9(
LN9bO~BL 2~(2 1Ns60D10 2-LB- 9 1N9bDD10 ~108
1N960-8L 2-)2 -67 *N960010 2-L8-15 (N960010 2-39 -111
1N960-8L 2-62 PI *N9b0010 2-18- 1~ *NPbDO10 -111
1N960-816L L-L2 -10 *N96OOLO 2-18- 29 1N9b0010 2-39 -IZO
11O60-916 2-23 32 1N9600LO 2-18 3) INP)ODL D 2-39 -III
LN9(G-9I6L 2-19 If *N960010 2-18 PO 1NlbOD10 1~39
*N9I0CIO B LN960010 ~-LB 13 18950010 1~3e ~158
~N960C10 Z~LI 55 LN9L0010 19 L*OLOOIO 96
1N960C10 *NPLDOI0 1-L9- 63 2-)2 -102
LNO60C10 2-(5 -89 ~H960010 t-2O- 10 1N9)00LO 2-)1 -108
1N960C10 8 *NPL0010 2-2L *HelDOIO
1N960~10L L- 1-60 *Ne60D10 2-21- 16 INPbODIO 1-~2 -125
*N960C10L I-I- 2) 1N960010 1-21- 95 IN)LDDLO 2-(2 -118
INOIOC1OL 2- 5 -58 *N96OD10 I-I3- PI LLI~)DDIO 2-*3- II
1N960C10L 2-5- 1O LN960010 2-L3-Lll Ill9bD0Io 2-(3 -98
IH960C10L 2- 5 17 IN960010 2-25- 30 ln9bDOll)
1N960C10L 2-18 -32 *N960D10 2-15- 55 *N91DOIO 2-~3 -110
*N960C10L )‘10 -3~ 1N960010 2-25- 8) LNP)ODIO
*N960CIOL 2-*L sl IN96OD10 L-15- 81 lNP)0010 2-(3 ~11)
1N960C10L Z-)L-LO1 LN9600LO 2-25- P0 1N96DDID
1N960C10L 2-(1 -103 1N9600LO 2-25- 98 ~N960D1D 2-0 -69
1N96oC1)16 I-I-In IN96O0LO 2-24-100 InPbDOID
1N960(3)16 2- 3 2) LH960DIO 2-L5 -LIB LN~LDOID 81
2-3-32 IH9M)DIO 2-25 -I3P *NPbODIO
1N960C)16 18960010 1-25-110 LN9)ODI0 -2)
*N960C)L6 Z IN96ODIO I-25 -l)ls LN9)DOIO 2-)5 26
llH9bOC)16 9 1Ne60DI0 2-~5 -L(L* LNPbDDID 2-(5 -LIB
1N960Cllb I-I-II 1N96001n LN96001D
2- 5-55 LN96)D10 2-~5-151 Ln9bDD10 22
*NSbOC)Lt, 2-21 -109 1H960D10 1-25 -155 INL)~ODID 2-)6 -70
l,N960tilb 2-(!- LI 1N9M)OIO 2-P5 -185 *N960DID I-I6 ~7)
IN9bOC(L6 L 1N9~0DIO LNP)OD10 )~(b -78
INP60C*IIL 2- 5 -32 1N9600IO 2-25-110 LN9)ODIO I-~L -86
*N96OCII)L 2‘ 5 -(1 *N9600LO 2-21- 10 LN960010 2-)6- 90
1Ns60C116L 2- 5-60 IN960010 2-27- 18 LNP)OD1D 2-16- 07
INO6nClILL 5 65 *H960010 LNO60D1D 1-18 2)
*NPbOC*lbL 2- 5 -65 LN9bOD10 I-II- 36 *NPbOD1D 2-*8- 2)
llNP60C(16L 2-39 -60 LHOMInIO 2-27- II 1H96D0ID
*N96oCllbL 1N960DIO 2-17- 61 1N960nLD 2~(8 ~10)
*NsbOC(lbL 2-~5 36 *N96ODLO 2-28 INOLODLD 1-19 16
*H9bOC116L 2-(5 -)5 LN96(IDLO 13 1N9~001D -3(
*N960C1I6L 2-46 II *N960D10 P-ZB 21 LH96ODLO ~-19 38
1N960C)lbL 69 IN960DLo I-In 25 1N9L001D 2~19 )6
bN960C51bL Z~ 1Ns~OD10 1~31‘ 1N9LOOLD P-*P- 50
*N96OC6 2- 5-62 IH~(IODLO 2-33- 8 )IN~SODLO 2-(9- 54
LN9bOC116 Z *N96OOlQ 2-)3- 11 *H9L001(1 I-~e- 79
IW96nC6IL 2~ 3 ~13 IN960DIO ~-31- 13 1N9600L(I 1~51- 35
~N9bOC616 2- 3-27 LN9LOO10 2-33- 1) *N9600LO I~I1- 56
1N9bOC8 2-I-67 *N96001n 2-33- 19 *Ns~OD1D 2-51- 11
*N9bOC8 2-1-59 *NP60010 1-)3 -In LH960D10 1-51- 11
INP~OC8 2~ 4 -Is *N960010 2~33 -14 LN~LOD10 Z-~1- 2811
1N960C8L 2-)1- 89 *N9600I0 1-33 -57 2-53- 1)
~N960C816 *N960D10 1-3~- 8 1N9)00LO 1-53 ~51
IN960C816L 2-)1- 98 LN960010 2-3)- In 2-5)*- 1
*N9b0010 2-1-20 *N9M)Ol(l 1H9600IO 2-51*- 6
*N960010 L- Z -)I IN960DIO 19 LN9L0niO 8
INObn010 I-In 27 *N960nLO BZ IN960010 I-5IL- LO
LNPLOnIO I-II- 8 1NO(0nnIn 1-3)- 89 1N9bO010 2-5)1- 21
1N960010 32 IN96n01n 1~35‘ 62 ln9L0010 2~56 Z
LN9600IO *N960010 )~)S -65 ~HPLOOLO 3(
~N960DIO 2-L1- )2 *N9600LO )O INP600LO 31
IN9b(1010 L‘L2 Is *N960010 61 *NPbnDIO 13
LNOI0DI0 I-II 89 *H96nnIn 7 *NP~ODIO 2
IN960010 2-12 -111 *N960010 2-38 4 1NPbnnIO 2-67 2

Revised: 28 November 1984 3-1

 ILLUSTRATED
GULFSTREAM
Section m PARTS CATALOG COMMANDER
NumericalInden 880A/BBOB

P b R T FIGURE P i R T FIGURE P i R T FIGURE

L INDEX L INDEX INDEX

N U n 8 E a NUNBER N U 8 E R NUNBER H U B E R NUIBER

1N9b0010 2-61 IP 1N960D10L 2-88 Af IN9)DD)IL 2-25 -227*

1N9b0010 2-61 PO b9 lN9bOD)16 Pt
LN960010 Z~b7. 25 1N960010L 86 1NsbDDILb 29
1N160010 1~67 30 1N960012L1 2~ 1 Ib *N960D)16 2-35 -111
*N96a010 2‘61 .53 1N9600111~L L‘19- 55 1N9600116 1-38 -19
LN960010 2-65 2 1N960D1Z16L 2-(7 22 1N9L0811b 2-39 LO
1N960D10 2-48-19 IH96001)L~L 2-44- )9 INPbDD(L6 2-39 ~81
LN960010 2-~8 2L 1N96DD1116 2-39 38 119600)16 2~)1 51

1N~bOD10 2-68- 28 1196001116 2-31 -100 1N9)011)16 2-)2 -103

IN960810 2-68 -35 1N960D1716 1 1H90011)16 Z~)L ‘LO~
IH9bD0tO 2-68 )3 LN960D1716 2-36 )8 -It0
~N9601)10 P´•68 -58 *N960Dl7lbL )5 *N940D)16 5*
1N9L0010 2~68- 63 1N96DD17L6L ~91 1Nsb00)16 1~(3 ~L09
INIL(ID10 2-bB -69 LNP6DD3L 2-25-LDOl 1N96DD(16 8
lN960DIP 2-69 8 *N96DDI 2-25- )9 LN9bO8116
IN960010 2-69 -11 LN960D1 2-I)- 51 1NebOD)1~ 2-4)-
lNP60010 2-69 12 *NlbDDI 2-25 61 1N9b00)16 63
1NP~0010 2-69 16 LN’)LODI 2-25- 8L ~N’))DD)L(, 2-))- 74
111960010 2-69 ~18 1N96OD) 2-28 ~1008 *N9b00116 86
1N960010 2-69 21 LN9LODI ~LOP *N9bD0)16 Z‘)) 88
LN960D10 2‘69 -33 1Ns60D( 2-25 ´•115 1N9b00116 36
2-~9 -35 lN96O8I L~LS -1)3 1WsbDD(16 Z-~5 -4L
1N960010 2-~9-)0 1N960D( 2-25-L3b 1Ns(DD)16 2-)5- 49
1N9LOD1O 2-59 16 1N9608I ~´•LI ~L60 1NP60D116 ‘L31
1N960010 P-69 ii *N9IDD) 2-21 -IbL 1H96OD)16 2-15 -110
1N9608IO 2-69 51 *Ns~OD) 1N960D)L1
XN9600LO 2-(9 -51 LNs60D) 1-25 -16( liH9600116
LN900010 2-69 -63 LN960D) 2-25 -1(18 *89)88416 2-15 -151
LN960010 2-71 )O 1N96DD) 2-24 -LLP *Nsb0D116
*N960810L 5~ 18 *N960D) ~1108 1N96DD)11 Z‘~L -I)
INP60D1OL 9-Is LN96001 2-25 ~170E lHPL0D)Ib 2-46 2)
IN960810L 2-LI- 31 1N960DI 2-15 -LIOG 1NPL00116 29
1N960010K 2-L3 19 lN960DI 2-25 ~llOJ LNsbOD)16 37
1N9~0010L L~IB ~32 IHSMIDI P~21-181D *Net~OD)lb 2~(6 -)7
IN960DLDL 2-25 LI 1Ne60D( 2-L6‘ 31 1N9bD0)16 i~)b -68
INP6ODIOL 2-34- 27 LN96884 2-32- 21 LN9)OD116 2-46 67
IN)(IOD1OL 2-35 Ln9WOI 2-32- 23 Z-)L- I)
1N96DOLOL 2-35- bB LN96081 2-3)- 8) 2-16 88
IN960010L 2‘35 -10( LN960DI lN9b00116 2-*6 -LOO
~N960010L 1H’lbODI lNs6DD)16 2-)7 -38
lN9l,DDIOL 2~35 ~LL)B lNsbOD( 3 *N9b00)16 I-)8 9
1N960010L 1-39 -110 LN960D( Z~6L 9 lN9L0D1t6 P~*8 ~18
LN96001DL 2-35 -131 1N960DI L-bl 5( INsbOD(16 I‘)B 61
LN9600LOL Is 1N960D)L ~129 119600116 ~-(B 63
INP6ODIOL P-)2-LOI 1N960D)L 2~(2 ~L32 LNPbOD)lb P~(B 78
1N9b0010L 2~)3. 72 IN96ODIL L~)2-138 LN9600116 ~80
1NP60010L 2-)3 -1) liN9600)L 2-)3- 9) 1H96DD11b L-I8 -88
1N960010L 1~(5 -1(L 1N960D)L 2-(3 ‘LOZ 1N9)OD(16 ‘9)
1N960D10L -87 ~N960DILb 2- 8-19 1N9600(lb 2-)8 -100
1N960010L 24 1N960D(16 2~ 8-26 PN960D)16 I~(B -106
1N960010L Z~)B ‘28 1NsbDD(16 2~ 8´•30 LN96DD116 I~)B -111
1N960810L ~31 1N960D)16 8~33 *n95DDllL ~lls
1NP6001OL 2~18 -34 1N960D116 2- 8-3b 1N9b00)16 1~51‘ II
liN960D10L 2-(8- 38 rlNs60011~ 8 -(I IN960D)16 2~51- 28
1N960010L 2-18 -(2 1N9600(16 2-L9 1N9bD8)L6 2~51- 18
1N960010L Z-IB -(6 *N960D(I6 2-L9- 6 1N90DO)I6 I~SL -It
1N960010L 1~L9 -29 *N9608116 L-L9 LO LN9L08)lb 2~53 -65
IINS(IOOLOL 2-19 -88 *N960D116 I~L9 ´•IZ PN9b00116 2-53 49
1N960010L 2-~9 ~LO) *N960D116 All *H9b00)16L 2-L8 -II
IN960010L *N~600116 83 ln9L00)16L 3
LN960010L Z~51 -101 *N9600)lb ~105 *NPL00110L L~39 ~11)
1N960n10L Z~5P ~31 119600116 2~25 8 *N9L0D116L 2~11´• 10
IN96o010L ~‘bl. 19 IN9b0D1tb 2~25- 29 LN9600116L 3L
1N9600LOL 2-81- 2( 31 IN96D0(16L I)
1N96001~L 2-65- 5L *N960D)LL ~1(8 PN950D116L 2~(6 -103
lN9688L8L LN960D116 2-25-150 nV960D)16L 2-65 -42
IN9608IOL 2-68 -3L I‘LI~L55 lNPbDD)LIL 1-68 -53
1N960tllOL 2-b8 -31 LN9b00116 INP60D516 2~11- 03

3-8 Revixrd: 28 November 1984

 ILLUSTRATED
OULFSTREAM
PARTS CATALOG Section III
COMMANDER
Numerical Index
e8oA/seas

FIGURE P I T FIGURE P L R T FIGURE

p d R T
8 IHOEX t inorx
C IHDEX
NU*BER H U n 8 E n NU*BER N U 8 E R HUIBEI
N U Il B E R

2-))~ 33 1510) ~51

IN96005LI ~109 LN960DB
2-)5 29 1196008 2-3)- 9L LSL59 2-21- 85
11(9600116
2-(8 -119 1N9LODB 2-3(- 96 152’)01 2-23- 19
IN9b00516
2-)7- 31 IH96OD8 2-36- )5 1511~ 88
IN96005l6L
1N~60DB *B 15116 1)
INP(lO0Ii(L 29
LN960D8 *58-500 2-25 69
IN960Db 2- 8 5
2~ B II IN960DB 15 16189 2-L9- I´•
~N160D6
L‘I1- 6 *N96008 2-))- 19 16189 1-19 -L03
39 L-b2 5 16´•)) 56
1N9600L
-49 *N96008 2-6)- 10 16590 2-23 -58
*N9b006 2-25
83 *N96ODB 11 Ib((B I)
IH9bOD6 L-PI-
~I)Z 1N9bO08 Z~bs 69 16610 1~23 II
LHP6006
IN960D8L 2-24 10 2-23 10
1N9600b 2-25 -135
*HPLOD9lb 2-36- 60 167(58-24 II
IN960D5
2-25 -161 *N96OP0IO 2-11 3 LIO~L*P 2-)5 -15*
1H960D6
)-24 -1858 IN960P010 )1 110198‘2( 2-13 I
1NIbODG
LN96OPOI0 2-23~ 96 11089-3 2-32 -11
IN96006 2-25 ~195
2-25 -2)2 IN960P0I0 2-2* 10 L71D8H 2-25 -1511
1N96006
2-33 6 *H960PO10 59 1110RH 2-25 -157
1NP600b
2-33 -10 IINP60POIO (11 11126 2-23- 5L
LN9b006
2.33 -15 *Ne60P0LOL 2-20- 21 178)I 2-13 -53
11196006
2-33 -II *N960P010L 2-(L-ll 17968 2-23- bI
1N96006
L~)Z- 56 181)0 59
IINP(IOD(I 2~)3 ~50 *HI(IOPOIOL
*N960PD1OL 2-)3- 88 *8161 2-L9- b8
11’)6(106 1-33- 95
1NP6006 2-34-76 *H960P0llb 2-21- 59 1922
I-I3 -I01 IHILOPDI 2-(2 55 19978 2-21 81
1Ns6006
2~b7 66 INBLOPDL 2~´•P 56 2~ 1 12
*N9600b
1-13 -25 *N96OP06!6 2-1)- 2 8-is)) 2-i-IF
LNPbOOb
~)5 IH960P0616 2-14- 28 8~1901(11 2- L L6
LN96006L 2-68
2-32 5 *N960P07L6 1-11- 16 8-3028-2 2- L -11
LNe~OD616
5 LNP6OP0716 2-LI- 19 8-)091-1 2- L -38
1.9600616
IN9~0Db16 2-))- 52 1Ns60P01L6 2-19- 1) 8-312) 2-25 ~219
*N9bOI)116 2-17- 21 IN9bDPD116L 2-20- 5 8-llZS 2-25 -225
2-L9 Lb *N960P0716L 2-20- 12 8-3339 Z-1- I
LN9b00)16
LN9bOD7L6 2-35 -10 *H96DP0716L 2-2L-1) 8-)(29 2-25 -220
2~)5 ~)5 1N960PD7I6L 2-21~ 11 8~)(98-1 P-15 ~2P3

2-35 -102 1N960PD716L 2-23- 36 8-832 2-59 I

LN960011b
1~35-LOL *N960P0116L 37 8-832 Z~59 ~IZ
119600716
-133 1Ne60PD71~L L‘Z3~ 38 2~19 LbB
1N960D71b
1-36- 26 IN960P0II6L 2-23- 3’) 8-)12 2-60- 8
1N96OD716
1N96007L6 2-)6- 30 IH960PDB 2-)2- 55 8-832 ~-61-
INPLO07I6 IN960PO8 2-(2- 56 886381r-E 2-27 ~5L
ines007l6 2-36 -13 1N960P0816 3) B8b381TI-E 5L
LN9600716 2-36 -19 LN960P0sl6L 2-23 -35 BEP)1ILP
L-3b- 68 *N970-3 Z-L1- 20 8EPL2ILP 2~30 L9
119600716
2-36- II 1N970-3 L-ll- 32 8EP628LP 2-26 ~)3
LN9(0Dllb
IN9600716 2‘)0 8 INP10-3 2-11- 39 BEPL1BLP 2-69 65

1-24- 18 IN910-3 2-L6- I 8EP62R8L 2-25 -(5

1N9600116L
1NP60DB I- 8 LS IN970-3 2-27 63 BEPLZRBL 2-25 (5
1196008 1-II 151 *N970-3 4 BEP~ZRLP 2-26 32
IH9b008 2~11 91 IN970~) 1~23 ~103 8EP62YBL 2-25 45

IH9(1008 *N975-3 2-L3- II BEP112*BL 2-25 -)5

1196008 2‘12 -101 1N915‘) 2-(L -97 8E5P5-L 2-68 -61
*N950DB 2-25 10 11975-3 2-)6 L1 8RE)70D 2-6) 3L
11196008 Z.LS~ 32 1N911-) 2-1(~ 1Z BII~LOPb* P~ZI- ~58

IN96008 2-25‘L03 1RE-´•3-20 2-63- 29 85)8152

1NPb(108 ~R13-T(619 2-62- 9( BSIBLSI 1~25 ~1761
IN96008 1-15 -113 IRIS‘TIPE Z 2-6)- B 8150126 2-0 -152
1196008 2.2) ‘12( LR292 95 BII bOO-ll 2‘25 ~lb

IN960D8 2~25 ~1*3 LILF~50)28 I-bB~ 2) 81LF-T(69 ~‘61- 66

1N96908 2-15 ~111 I*LF~BLO 2~68 25 8208 2-(8 51
1N960D8 2~25 -181 2-25 -LOZ 8208 2~)8 58
LN96008 2-25 ‘1878 2-39 ~159 8208 Z~)B ~60
PN96008 2~25 ~236 13235-020~P(li 1~99 -159 BZ)LI 2-)6 ~22
INsb008 2-3)- 3 13235-020-2~1 2-59- I R355D 2-15 -L12:
PN96008 ~‘33 1 1)20-0619*)-00 2~62‘ 10 C-ll Z~05 3

1196008 1-91 Il 1)5L-LO 2-61 4) C-LPDL-IOI 2- L )2

IN96008 1508 2-25-201 C-LIOL~LOI

Keuised: 28 Nauemher 1984 8-9

 ILLUSTRATED
OULFSTREAM
Lisotlon III PARTS CATALOG COMMANDER
NumerlcalInden 880A/6808

P L R T FIGURE P L R T FIGURE P I R T FIGURE

E INDEX L INDEX L INDEX
N U H 8 E R NUIBER N U W 8 E R YUIBER N U n a E a nunera

2- L -19 E0I22bI Z‘L)~ LR ELL~IO

t-3152 P~ L ED1P2b8 ~‘2)- 66 EL1´•6 90
C-)1S3 2- 1 EDII269 2-11 6) ELLlb-1B 1-23 6)
CLU~III 2-15 P) ED1Z210 L‘~) 60 ELLlb~l 86
CJBIB 2-~5 -1818 EOI1LIZ Z~L3 681 ELLPI-LD L~Z1 55
CIOIPSBLO’III 2-25 -183 EO1Z)PI )2 EL83~-01L .52
CRZ1911(lo3FI-LLI 2-25 -ls( EDLZ39) L-L)~ 26 EL836-L1~ 2-13 -(6
EI-ll ED121o2 2-1) 13 EL83b-lZo 2-13 IB
C19b00-3 1-65 ~(13 ED1IIO’I i-I)- ELB)b-336 2-23 -19
C*39) 2-6L -93 EO1I)OI-L 1-1)- 5 E5-XB)O L~35 -I2)
CZ)0o-L(T-188 2-3(- 1 EDII1ID ~-L*- 8 E110039 1-19 -LO)
C)’11~2000 1 ED11(1) Z~L)- 10 ES100)) 1~19 ~L02
C61SL3 2‘11 II ED1211b 2-I~ 23 EllD1D6 2-19 II
C70)OR3 1-)1- 5 ED11(11 1-1~- 21 EI1D1D1 2-19 -15
0ls31-1-10 2-~5 -151 EO1I(1B 2-I)- LB ESIDII9 1-19- IS
EL1237 2-(2-L(O ED1Z(IO 21 E61D113 )1
E*1238 2-)2-L)O EDI2IPI L-l)- 28 ES110’J9-3 I-1)- )I
811239 ED11~P1 i-I)- 33 1-1(- )I
E*I1b3 2-2)-)1 EOll*I~ P-LI- 6) E111L3b 1-ZI- 58
E115)0-501 2-L3 59 EDIII17 P~LI bl ES11265 1~2) I)
E*I))O-501 1-13 -59 EO1I)LB ESIZ19~
E193) I-L9 8 ED1)(19´•I 2-LI- (1 ES12)DZL 1-1)- 9
2-52 -78 ED12I30 Is EIIIlO~ll 9
EQ~Ob) 2-52 19 E012~3´•i 2-L3- I) EIIZ)O) b2
EB-Ob* )-SI- 80 EDI)(1I 2-L3- bZ ESIIIDI 2-I)- bB
EDLOOIO 2-L9 -III ED12(39 2-L)- 59L EIIL(OS-I 3
EO1OOS) 2-19 -11 Eolz~,l ESIZ(12
E01001~ 2-L9 -86 ED1102 1-11- 13 ESt2)1)-1 2-1)- 11
ED10057 L´•19 8( EDIZI)) 2-L3 29 EILZ((O I-Is )5
ED10D7L ~-L9 98 EDIII1Z E112)9L 598
ED10o1( ~-L9-LOI EDIP1S3 2-LI~ 5) E112S29 1-1)- 51
EO1DOBO 9-L9 be ED1111D 2-LI- 15 ES1117s
ED10120 P~L9 80 8012(71 Z~L(-)l E113)12-501 2~11- )8
ED10121 I-Ls-L00 EO1ZIB1 2-23- )8 2-62- )9
EDIDI() P‘L9 26 ED1Z(~( s~13 55 FNII~O1 2~15
ED1OL 2´•Le -36 EDIZ(eS 2´•1~- 25 FR~ Il) Is
EDIDII1 2-L9 -35 ED1219S L-l(- IZ FL1TIIYYIRIIC 1~65 ‘79
EOIOL)b 2~L9 -33 EDI1I9b-I 2-L1- L1 F3)’ Il 2-62- )8
ED1010 2-L9 -29 E0III96-2 2-l(-L1 6-2905-21 2-25 -))1
E0IDL59 l-LP -93 E011(97-1 )-I3- 10 61-531’) 2-25 -133
EDIDIb) ~19 EDL2)91~P 10 bS-131P 2~15 ~136
EDI0Ibs 2-L9 -78 EDI2fSI7 2~16- 19 615319 2-25-1708
ED102LI I-LP -101 EOIZSIB 2~1)- 21 b*IBB-I 2-15- 56
E011)299-1 2-L)- 86 ED11)L9 2-L6- 26 H-1)5 86
EO1OI0D 78 8012520 L1 H-131 2-23- )3
EDL03D1 E012SP1 2-L6‘ II HE715‘L 2~35 63
ED10311 1-1*- 31 E011121 P-16- 20 nF-) 25
8010312 Z-L( IO EDIZ5Zb 2~1) 39 HFX~6G 2~ 3 28
ED1O)L( 66
Z´•LI- 8012521-1 Z-1)- 63 HI(P 2-25-LI8
ED1011) L-L)-LI E012528 m-~ ~-s, -20
ED1106P~3 E011)30 H*X-IIC 2-13 -)L
1011059-) 2-LI-53 ED12531 L-1I- 53 nNX-(G 2-13- 22
EDL1060 2-1)-50 ED12132 2-13- ns-2072b I-b3 ~It
EDII0bI 2-L)- 51 ED1153) L-L3~ )1 HS(B15)
EO11ZBS 2-LI-)6 ED115(5 HTC-1000 Z‘bP -28
5011370-1 2-LI- 83 ED12S89 Z-LI- 29 HrC- 1000 1-69 b0
EDI1)I) 2-1)- )5 ED1215b I HIL1SD3(D 2-25 -IOOL
ED1161P 2-19 -38 ED12118 2-L)- 1 HIL1501~1 2-25 -89
EDI1II5 2-2t -)S EDIZ819 I-LI- 9) nlo-, ,-,t- so
ED111S6 2-23 590 EDIIOI(1-l H10-) d
8012157 2-23 590 E01)Ib3~1 I-II 80 HLO-) 1-21- bO
E012237-1 2-1(- )1 EDI3Ib)‘I 13 HID-I L-PI- 52
8012231-3 2-LI- 60 ED13Lbl-L 2-1(- 13 HIODO-´•051-´•102 B
ED12119 2.23 17 ED13)IZ-3 ).I) )3 H50DO-06~-09L 2..28
ED11160 1-13 -78 ED13373-1 2~1)- I INOLF)-)X)~59 2-69 bl
ED12211 L~)3 19* 5) lN3209 L~15 -I)LI
EDlllbt 2-23 151 EDI3I79-I 2-21- 5) INIPo9
EOIZ)LI L-L3 IS ED15o13 2-LI- (9 IH)109 1~15 -llOC

S-10 Revised: 28 Nouembsr 19R4

 ILLUSTRATED
GULFSTREAM
COMMANDER PARTS CATALOG Seetlon In

BSOA/BgOB Numerical Inden

P I R T FIGURE P 1 R T FIGURE P 1 R T FIGURE

C INDEX L INDEX P INDEX
N U H B E R NU*BER N U n B E a nUasER N u 8 E a NU*BER

5-20)9-2~ 2-))-)9 W516162-20~ Z-6L -16 I(I)DZDIIPIL 31

J-20)9-ZD )-3)- 5) n516562-223 2-)9 B ~IPD2OLIPII I-ii -~L
JLLND56S102)li 2-65- IL US1656L~P09 1~(9-L8 HIZDPOLIP)I ~L06
JY-20 2-25-108 nPl65b2-22) L~(9- 9 *S2DZ0LIP*L
JV-l Z~bl 1 *11~562‘L25 1-(4- L71 WIIDIOLIP(I 30
JVZOI 2-25 -11( WI1MLI-21 I- 3 -28 *SIDIOIKP(L
JX)) 2~12 -6( 1.65‘ )´•i IIBIDPO1IP(* L~(5 ~1(9
J1019-10 1113(1562~30 2.51 .IOb 115102(111P*1 ~15)
~120(9-10 2-3)- 96 )lS1L´•162-30 1-52 -119 nSZD1O1I(PI)I 2-16- 15
J698~-110 2~3)- W516162~31 1~65- 58 IlslOPOLIP)I 2~)6 ‘101
Jb98)‘110 Z~))- 3) 1-1~- 9 *IIOZO1I(P(L 2~)6 ~103
I(lO(-OZHB 1-61- 3L llP16162-~ 2-13 -100 *SLD1O1I(PI* )-S3 bs
IS(1 2-(1- LL nS1LSbZ-)2 2-65- 66 nPZDZOll(P51 2-)5 -13
L18158-IS)-8-1 1-60 -IZ NILllb2-b 5 WIZOZO1IP~I 1-)9 L5
LC-029C-ISS 2- 2 -28 R516625-1100 83 ~12DZDLIP61 26
LE-019C-3 ~‘LB 19 RIILLPI-)OII Il WIZ02021(PZSB 2-~1-119
I~bZ 181W95´•~9 I- 5~62 *52020)DPP) P‘13 9
LE328 I-LI 82 *516997-31 1-12 56 *SZOZO)DPPI 2-(( 17
LE)Ie-500 nBLL991-)) 61 WIZDI0IOPP( 2-11- 86
LF526 1-62 80 WSL7L)98 L- L 55 U523220-~ I-*S IB
LJ)7D Z-~1 83 nSL71)98 2~1( 50 IS20L53-PL-250 Z~LB 18
LLSbO Z-bL -89 n5171)98 2-62- 86 *S2D153P2-L82 2- 1 7
LW-B31-10 7 115111518 2-I2 -116 ISL036)-1032 1-13- 3
Lll-831-IZ 2-1- 3 11111528 2-12-119 WS1036)-)Z8 1-19 -106
Ln-831-13 n117825-3 2-*2 -125 H1103b(-52* 2-12 ZZ
LI(-83 1-II Z- 3-88511826-3 69 2-13- Is
LORI I-bB 72 111781~-3 81 RSL03~)-Ll( 1-19 83
LP585 2-62- 81 l5L7816-( 2-*)- 9 n520365-Lr)32 2-13- 15
LP9L16-09 2- 2 -)O *ILIBlb-* W120365-1031 2-13 -79
LSS9 2-19 -1I n517826-) 31 *1101~1-103) L-19~ 63
LS(50 L-~l- 88 lls1781~-( 2~63 6 1520361-3(131 11
LTL0282t) I-I-0 1511826-( 2-63 -1I 1~)5 -I08
LY388 90 2~28 Z1 1~(3 -112
89 IS20001-C) 2-3-15
L*l)76 2-62 -86 nII0001-I2C L-(l- 2( n22036’1-1031 2-)5- 16
L11)19 8) bO nP103L1~103Z -1(1
LZ8S3 2-62 92 2~15 8 nSt0)65~)28 1~11 9
L286( 2-61. 86 *SL0D02-6 I-1P -78 n120365~128 1‘13~ 1)
L1866-I 2-62 86 *S)OOOZ-L 2-52- 19 n510)65-(~8 2-13 -18
IDL-) 2-)r -L18 NBIDDDI-6 2-52- 80 nSZD365-*28 I-L)- 5)
WDPP) *510002-1 Z- 3-19 111203Ll-)58 2-19 ~IZ
*OPP) Z-)I- 86 llSIOOOLCI 1520~(16-)28 2-*5 9
llD)~- 168 WSZ0002C* llSZD16)-~28 1~(5 ~51
lrL-H-5593-) L~)6 -ls nS20002C5 2-15-(9 llSLD)65-))8 2-(5 -59
~PI-121 2‘~1 75 I520002C6 18 2~15 ~101
WR1Z11-SL *52000LC~ P-52 19 1~13
nPCL85-*1BZ 1-69 -66 *SIOOOZCL 2-52- 80 llSLD)L5-5)~ I-LS- II
IIIPZOSR 2-32 LI NS20003CS 2-15- 8 nSZ03L1~52) 6
Z~Z5 7) N520005-30 )~15- 8 *SPO)P2~2-31 1~13 bI
USI5O0I-1 I-I-ID 11220005.L3 1-15.I9 WSI0392-2-9 2-28 P
nlll00l-1 I-I) 67 ~1200013-03-) 2-L) LI *520)92-1CL1 L-PO 16
llSL50(11-I 2-1(- LO n52DD))-1 Z I(SZD392-2Ell 2-27- 1I
I(IL50(11-L I-Is -Is RIZ006~-IB3 2-~7- 26 llS10392-Ltll 2-27- I0
1131003-3 2-19 -Lt) H520073-03-(16 I-50- 1 nSZD)92-1Cll L-L)- 58
I(IL’1001-3 Z-I)- 68 *I20016-03-03 2-12- 52 n120392-2CI9 2-L8- 2)
*ILS001‘3 81 L‘L3- 83 *B2D392~)CL) L~18‘ 32
n1150(11-3 81 I-2I-L09 *113)P1~2C23 2-66- Z
n5I500I-3 2-16-12 WSPD2D01PS )-1I- *5 HSZ3392-2C29 2-62 -55
2-13 -81 ~5202011iP111 nS10391-IEI L-Sl- 16
n5150D2-1 2-13- 86 *S2O201IP111 2-)1- (Z nS10392-3Cll 2-63- 1(1
*S1´•S0I5I llS101011(P3)1 2-13~15 Z~19 ~21
n516562-13 Z-~5 -60 IP201011P31 1) 111DIOI~)C9 I-15 -13
1(51b561-LS 19 ~1101011P(* P~I1- 13 111)0100~1092 21
WSLbS61-I5 L~L1 ~L31 *5102011(Pll BI 11113500~)28 1
n516562-15 1~35 -58 IPZOIOIXPII ,-,e -los 311[1156‘ 12 6-23
11516562~L1 -61 ns2D2011(PII 2~)9 -11) n520162~12 1~ 6~22
1~1(156PL1 nIIDI0I1(Pll 1-39 -1*1 n110162-12 2-69- L
2~35 ~5L, nB)OZOl~iPI1 2-39 *110813-1 61

Kevised: 28 NovemLler 1984 9-11

 ILLUSTRP~TED GULFSTREAM
Seetlon III PARTS CPITALOO COMMANDER
Numerical Inde. BsOA/B80B

P P R T FIGURE P L R r FIGURE P 1 R T FIGURE

L INDEX G INDEX 5 INDEX

U n a E 8 NUWBER N U n a E a NUI8ER N U n 8 E a NunsEn

N

1-19-107 n1210083 I-15- 16 ne21D1)N3 2-31- (9

nS10a13-L
11120812-100 Z-L3-IIS WSllD)´•83 1-51- 8) WP)LD~IN3 2-35 -39
2- 5-83 HSI10)*COLI -I28 IIPZ1O((NI 2-35 -62
W5Z08L2-0-10
.SLOB1Z-~-(O 1- 6-38 n5Z1OIINO) 2~15- WSIIOI)NI 2-35- 62
36 W5ZL0))NOI 8L *~11D))N3 2‘35 65
1(520822-)~)0
.12DQZZ-)D I.. 5 19 n5110)9NOI 2-3)- 66 NS1LDI(N) I-s5 -68
*r~0822-)0 2-1) PI *5210)INOI 61 *S11O(~NI 1-15 -LOL

nE2D822-)D 2-13 -57 NSZIDI)NO) 2-)~- )O WSZ10))N3 2-35 -IOI

*520822-10 2-13 -99 I(I~1OI(No( P-~L -IIP nP)1O1(H) 1-35 -105
2-35-122 *521011NO) .132 nSZIOI~H) )-)1 -120
n52082Z-)D
2‘66 9 1(12LOIINOI -138 *52LO)IN3 ~-35 -IZb

Z-ll~ L3 WIPIO)~NO* 9~ *SZLOI)H3 2-35 -131

ISZOB22-(0 I.II- 12 1-(9- 91 n51101)113 2-36 -)O
1820822-50 NS2IO)INO1 2-(9 -105 *12101(N) 2-36 67
1(S11O1INOI P~62 9 I(S~101)H3 P~PL -70
n510823-)0
*120813~(0 2~3b ~19 NB1101(H06 2‘)~- 16 R5L1OI)N) 2‘19- IZ
)(100823-(0 P-)6 -53 11(210(~N06 2-)3- 69 1152101113 2-39- 83

n120823-50 nP210)INOb 1-)3 -1D1 N52I0))N) 2-39 96

WS1Da13-bD 2~31- LB IP2I1D)~NOI 2-61- 66 nSZLO)~N3 2-19 -108
2.)5 LB n52101)N06 2-73- 1) *12101(N3 2-19 -111
*IlO~Lr6D
n510821-60 L-35 -83 WSZ10IIN08 2~LL -151*52101)N3 2~39 -1II
11520825-)0 1-3)- 17 N52101)N08 2-12- 69 NlZ10))N3
n520826-(0 2-20 -36 IIS)1OI(NOB 1-12- 91 W1)100N3 1-39 -1I6
-19 IS210*(N08 I-L5 -32 IPLID))N) Z-~I-
nP1OBZ~-lO
H5P0BZ6-*O 2-31- 2~ N52I011N(18 I5ll0)1N3 L-’L1 81
1-35 BI nSZ101INOB )8 *IZIO)~N3 96
N520816-)D
1(520826-)0 Z-L6 -10 nPZ1P(INOB NSPID))N3 I-IZ -101
2-13 -III W11100NOQ 2-18- L5 HIZ1O)6N3 2-)2 -108
*SP0913-2D
*SZO~1)-LD 1-3)- 19 NPZIO)INOB 10 115110))N3 I-ii ~111
1(52100N08 2-b6~ 1Z 2-11 -IPB
1(121021-L5
.52LO25.LS 2-19~ 1 nSPIOI)N3 *S110*1LN3 2~(3 ~98
HSZLOI1-LI I- 8 -16 l52)0OONJ 2~ 9-13 ns2io)’iN3 1-(3 -11)
2-68 *S11011N3 2-10 ~21 ISZ10)~n3 2-0 ~15
H1)10)1-06
11~1011-08 2-*9 60 ~IZIOIINP 1-11 a nSZlO))H3 II
2~*9 ~66 n5ZL0llN3 IO nS210)~N3 L~19 ~II
~621012-08 2-SL -111 n5II011N3 1152101)83 I-)9 II
2-62-27 I5Z10IIHI I-IL -89 nZ1101)N3 2-95 -L17
*521012-08
.5210)2-3 2-21 -132 N5PI0IIN3 2’11-1L2 NSZ101(N3 2-)6 ZI
2-)5~128 nS210)6N3 2-16-13 NSllO)(N3 Z~)b- 10
nSII012-3
n921D(2.1 2-68 -37 n52101)n3 Z-1B- 9 nSZ1O))N1 2-)6-II
nsZIOIL‘I Z~b9 ~35 IPZLD)(NI 1~LB- 15 *5ZLD))H3 P~lb~78
n(~lOIB-I P- 3 -3* nSZ10))N3 L-Ia- 29 ns2lo,~n, 2-66 as
nszio~z-6 z-I-,9 W12101(N~ P-LB- 3~ *SL1O)~H3 P-*~- 87

n521012-~ P- 3 -)5 nS21D11N3 2-18- 39 *IZLO)(H3 2-~6 -90

nSZL0(2L02 2~25 ~)9 n1210(~N3 )3 *SIIO(~N3 Z~)b ~9)
~SIIOIIL02 2-Z~- 12 1112101)N3 2-L8 -)B IIILLOI(N) 2-18
nS110)2L02 2-26 -19 n521G11N3 Z-ZD- 10 IISZIO((NI 2-)8 -32
89 P1S210I(N3 I-20 -21 *5210))N3 2-)8 -35
ISZLO)PL08
2~ 5 81 nS210((N) 2-20 31 IP~LOON3 38
2-2~ 35 n5ZLO))N3 9~)8 IS
n521012L3
IS21OI2L1 Z.L1. 32 lsZIOON3 2-21- WIZID((LI) 2-68 -IDI
NSLIOIZL3 NI2I011N3 2-ZL‘L25 llSZ101)N3 L-~9 -16
n111D12LI *521OI)N3 2-23- 9I W5P1DIIN3 1-)9- 19
11~1012L3 W1)101~N3 2-L3~ 91 n(Z1OI)N) 2-)9 -3)
~11P1012L3 P-)L- I I(IZ10((N9 2-23- 96 *SZL00n3 -18
ISLL0(2LI 1-)1- L1 15210)113 L-I)~LII 18110)1N3 2-19 -)6
9* nPllO)~N3 59 N52L0)’lHs 2‘)9 ~50

IISPLO)ZL) -25 nSPLOI)N3 L-15~ LI 1-)9 -5)

1-63 -30 nPZ1011N3 2-25 -)O PISPIO))HI 2-)9 -58
HSLlO)n)
llSIi0)2L3 I-L3 -32 llllO))N3 P-)5 -101 *5210)’1N3 D~)9 ‘6)

*5210(2L) 1-63 II nSZ1011N3 I-2S -231 nSP1O)~N3 L~19 II

llS1101)N3 1‘21- 61 nrzlo,1N, I-~s -16

1-b9 6 WSII0)IN3 2-27 ~63 nSZ1D))N3 1-)9 -19

n5210)3-3
HPZ1013-( 1-5-)3 IIILIO)~N) 2-18- nSZl(l)~N3 ~83
1~ 5 ´•65 ~SZLOIIN3 nSllO()N3 1-19 ~88
nS2L0(3~)
nSL1P)3.5 9.5-~1 W52IO))N) nSIIO(~N3
*SZIOI)BOI 1-61~ 5~ WSL10))NI L~)3- ~5 n521011n3 2~5L -26

1-L5 ~13 nlZIO))N) ~O nSZ101)H3 -35

3-12 Rsviaed: aR Novemhor 1Y114

 ILLUSTRATED
GULFSTREAM
PARTS CATALOG Section III
COMMANDER
Numerical Indes
890A/890B

P I I T FIGURE P L R T FI6URE P L I I FIGURE

L INDEX L INDEX E INDEX
8 E R NUN8ER H U n a E a NU*BER N U )I B E R NUWBER
N U

.SZ10)~N3 2-52. 281 nSZIO))N1 1-19-111 ~121083*0( 2~25 -L TOJ

WI1LO)1LN3 2-52-L62 WS2L0IIN) 1-)5 -116 n511083n0) 2-15 ~L87D

*121011NI 2-52 -171 nSll0l)NI 2-)5 -123 IS1L083HOI 2-26 -36
1~53 ~)7 ~‘(5 ´•LOO 1112L083HOI ~)I
*SL1DIIN)
*SIIO~)N) 52 nsZ100H) 2-(5 ~151 IISZIOBINOI L-ZL

.5110))N3 21 WSILOI)N( 2-)6- L1 NIIIOB)NO)

Z~lb- Z W52IO((NI 29 *l2lD83N0I 1-31~ 1
.S2l0)1N3
2-60 26 nS2tlll)NI n92L083NO) 13
nZllO))N3
ns2LOI(N3 2-61 -19 IISZIO))NI 2-I6- )1 Ns2Ios,aoI 2-,n- 22

nr210I(N) 2-bl~ 26 *52101)NI 5) n121083NO) 2-32 -23

llS~1011N3 2~62 ~3( *12LO)*NI 1-(6 .60 llSZ1083NO( 2-3(~ 8(
53 *IZ10(*N1 61 nSZL083HO( 2~3)- 87
nS21011N)
2-b)~ 31 Ils2L0I)N) 1~(6. 1( nrZL003HO( 2~13 2
.12I0IIN3
2-61- L) nS2100N( 2-(6 ~80 NSZIOB3H06 ~59
llS210))N3
IIS1IOI)N) 2~65 -51 ~52104)Nl 2-(B~ 9 n5110831106 1~25‘83
nI2I0I)N) 2~61 2 NSZ10*)NI 2~(B-1B 11121083106
.S2LOI(N3 2-61~ 12 llS210)(N( 2-)8- 6) 15I1083106 2-25 -115
nS210IIN3 I-bl -20 *SZ10(INI 2-(8- 78 ISZ10B3N06 I~ZS ~161
WSIIOIIN) 2~61 25 *IZLOIIN) 80 nS2I1O(I~HOb 1‘~5 ‘1858
N521O(6NI .88 HS211183N06 I-Zb~ I
nSZ100N)
IIS11O)IN) 2-61- 57 IS11O)~N) 2-(8- 93 nSI1O83H06
*SZ1OI(N) 2 I52I0))N) I~)B ~10(1 nr2l oa,*os 2~26 LS
*I~LOIIN3 2-68 -28 IPI10(IN( 1-18-106 2-26 -17
2-68 -31 RII1OI)N) 2-51- 12 *521083n0( 2-26 -20
*S21DIIN3
WSP1O)~N) 2‘68- 69 WIL1O))N) ~‘51‘22 WS1108)1106 2~
2-68 -Is *ILlOlInI 2-51- 28 nnll oa,nos 2-26 -36
2~b9 8 NS2101)N* )~51- 31 nI11083Ho6 2~32 3
WSPIOIIN)
2-69 -IL nT2IOIIH( 2-51- 1) nr2lo83No6 2-73 -25
IISZLO))N3
.S2L0))N) 2-69. LI *5210IINI Ns2L083808 P~25 -1BIB
16 *52L0)*N) 1121083108 2-25 ~226
n12LO))N) 2-69 -18 nsPIIlIINI 1-’iI-168 nPllOB3Wo8 )-3)- 91
2-69 -21 nS210)6NI 2-92 ~111 *IZIOB)N08 96
nS2I0(6N)
*SLLOON) L-~9 -3) WSIIO))N) 2-5L .177 llS21083N08 I-bl~ 36

2-19 W521011N( 2’62- 50 nlZL083H12 3

*IZ101)n)
*11101)N3 NSZLO)IHI 1~65- 19 *52L08)HL2 -17
nS~1011N3 2~69 ‘)7 I(IZ101*n~ 53 *S)LOL13H3 1-12- 52

35210013 2-69 -51 nS2IO1)NI 2-71- 9 11~108313 3

WIZ1011N3 2-69. 51 WS21OIIH( 2-12- 27 nSZL083N3 1(
llSZLO))N3 1~(9. 63 I(21LO)NNO O nSZLO89N3 9

W52LO)INP Z‘IO 3 nI2L0))n5 1~ 5 21 *5Z1083N3 2-18 21

*IL10)~H3 1-70 6 *S)101)N5 1~15-)7 nSZLD83NI 1-2)~ 68
31~1011H3 2-ii-(0 IISZlo))N~ 1-)6- B NSIl083N3 2-25 ~55
nS1101)N3 2~12 61 *5210)6H5 2-)I~ 37 *S2L083N) Z‘~5 -90
*1ZloON3 2.11~ 69 *IZIOI)N5 Z~(I-(I ~5ZL08)N3 2~25
*IZLOI(N3 NS210)(W6 nS1L083H3 Z~Z5 ‘187
*IIIOON) 86 W5210((NI 2- 5~10 nSZ108)N) ~I)O
*5210))N) 3 -2) *IP1O(9NL 5 NSP1D83N3 2~11 -2(
*I2LO))NI 3 -32 *S110´•)N7 B 1(2108313 2-21‘ (1
nS210)(N( 2‘ 8‘31 WIZ1OIS-08 1-61 IS)1O83N) 2~28 2)
*IZIO))WI Z~lb ~10 WSI1O)I~OB 2- 1-69 nSZ108)N3 Z~ZB 25
HIIIOI)NI 2-18 -21 IS210*5L) 2-10- nszl oa,N, 2-31- er
n9110)~NI 2-19. nS21059L(
6 2~38- L~ HS2LOB)N3 2~(1-10L
*IZL0(1NI 2-23 -81111521083 2-32- L31 *11L083N) 2~11 -109
ns2l0(lNI 2-25- 8 IISIIOB)~NLIB 75 HS21083H) Z‘IZ ~L35
*S210)~NI 2-33 -)P RSILoB3C06 ISZID83H3 5)
*121011NI 1.)3 ~5) *52108)CI 2- 5~16 *111D~3N) ~‘O ~91
nSZIOI)N) 2~39 ~60 *1210831(0) 19 HS~1083N3 2-(5
IISZLOI)*) 2~39 ~86 llSL1083NO( 5) *111D83N3 L-(5 -38
*III(LI)NI 2-)1 -96 1152108310) 2-25- 57 IS21083N3 2-)5 -11
nOllOl(HI 2-(1~103 nSZL083NO) 1-15 nS2L083N3 2-)5 ~53

*S1LOI)N) 2~(2-L10 IS11083NO) ~1)6 nrllo8sul ~61

*SLIO))NI 73 *S2L083NO) 2-25 -161 nr21081N) 1‘15 ~1)1
II(ZLOI)N) Ns2L083N0) nS21083N3
1152101)111 2~0 ~86 WSZ10B3NOI Z~15 -Lbl *111083N) 2-16 -II
WSZI0))N) 88 llSZL083NO) 1-25 ~168 nIZL083H3 Z-P8 ~II
HIZLO)(NI 68 *51L083NOI ~lb9 *P1LD81N3 2-62 -21
80 *52LOB)NO) 2-25 ~1708 nllLDB)N3 2~62 67
~85 *52108)HOI 2-25 -LIDG llSZ1083N3 2-(2 -7~

Revised: 28 NavL~mher 1984 5-13

 ILLUSTRATED
GULFSTREAM
seotlonln PARTS CATALDO COMMANDER
Numerical Indsa
BgOA/B8oB

P L R T FIGURE P II T FIGURE P 1 R I FIGURE

L INOEX 6. INOEX C InDEl
N U 8 B E R NU*BER N U W 8 E R NUnBER N U 8 B E R NUIBER

1152108313 2-65 -IB 1(521908-~C 1-11-19 H17)18)01 2-25 -119

111108313 2~61 L 2~21- 39 (152)15701 2.15 -L(O
nS7I083NI 2-lb 6 *SL1912-~ Z‘LI- 11 1111(566. Is 1-25 -5(
nS21083N) I-20 -18 1(111’)1900-11 2-77- )6 *121166-1A 1-~9 -32
*52L083N) L-lo -32 1(111919DC-PI 2-21- L) n51))66-18 L-~P- 11
*IP1083N) i~ZB ~21 n121e19DClo Z‘L8‘ 69 ~)5
nPL1083N) 2-31- L~ 1(1219190612 1-)6-)0 n5215G6-18 P-~9 -~P
*521083N) P-39-111 1(1219190611 1‘69- 18 111)566~38 L~)9 -13
nS11OBIN) P-)I-LIO 85219190612 2-11-111 Z-(P- 57
*S11OBIN) 5L 85219190616 L-2~- 901 817)568-18 7-)9 -62
182L083N( 2-~2 -105 n52191906 16 2-12 86 1(1i1568-13 I-)s 69
nS21G83N( 2-))´•100 1-67- 10 112)5(1)-18 2-)9 I)
IILIOB1H( 16219L9DGPL 2-69- I~ WS1))6b-18 1-)9- 81
*51LD83N) 2-)(~ 63 152191906)8 2-67- II ISZ)16b~ls 2-~9- 86
nSL1083NI 2-)5 -36 111219L90GP8 I-68- 1 R12)56b-38
~121083N) 1-)5 -(5 ISZ1919062P 2-31-~9 857(566-38 2-)5 -33
)II2L083N) 2-)6 -II WIZ19190b29 L-´•5 -)3
*111083N) 2-)6 -)2 11511919063 1~2L -IL) 1-(5 -)9
IISLIOBINI 2~)6 -99 11219190636 P-bB- L nSL)5~b-38 2-(5 -17
IPIL083N( 2-)6 -103 *12191906) 1-13- I~ nS2)566-38 L-)l -122
nrPL083NI 2-)8 -69 11521’)1906) 2~10- 8 812)56)-38 P-O -130
IS2L083NI Z-~8 -L11 ~121e19DCI 2-35- 39 WII(’ibb-38 2-)0 -15
RILL083N) 1-51-20 *IllsleDCI 2-35- (L *52))6(-38 2~)6- (O
nS21083N) 1-13 65 152191sDdl 2-35 -LOI 852)566-38 P´•(b (L
nl2L083NI 2~53- 69 1(121919061 W1II)6b-38 I-(b -IL
nS2L083N5 I-PI- 63 ~521919001 ~101 P-(b -58
nr21083N5 2-25-209 I(12tPI9DG) 2-)5-108 ~S1(56)-)LI i-(b -79
WSL1G83N5 P´•)L-L12 1(121919006 l-)I-LLO IIGI(IGb-)G 2-)8- 62
n1110113NS 1-)5 29 *121919DC( 2-)5-13L 1152(566-38 I-(8 bl
WS21083N5 1-0 -31 1112191906( 2-36-)0 15I(566-38 2-(8- 76
IS2l0B3Nb 2-13 -20 llSL1P19Dbl 1-16-(5 nfI(lbb-38 I-18 -79
nlZ1O8)N) 2~13 9l 1(52191906) 2-36-68 WSP(56b-3B 2-)8- 87
n521D83Nb 152191906) 2-61- 1( 112(56)-38 2-)8- 92
IIS2LOB)N1 I-bB ~1) *S219190bl I-67- Z 852(566-38 )-)B -105
II~P1OBINI 2-68 -1( 1(11111900(1 L-LB-II n1I(5Eb-38
35211~)0) 2-1-66 8511919005 2-11-~0 1152)568-68 I~(I- 6(
1(121210-0(001 P- 8-33 15219190651 I-LI -)9 a)
nP11210-0)00~ 2-51-12 *1)191’)066 2-36 -67 2-15 -1P)
8521211-825 2-(9 6 *I1IPL’IDbl 1-36-10 *SP))bb-~8
n621)5L-51 1-~5 -98 1152191906) 1-11- 7 WSP(56)-*8 L~IS -1LI
~511151-51 ~SZIP190GB 2- 9-13 n52))6)-18 1‘)6- 18
1(521211-65 2-~8- 9-2L nSP1166-*8 2-)6- 66
8521251825 2-)9- 96 *IZIPL9DGB 852(566-)8 2-)6- 1)
II)L25L855 6 ~52LPL90GB 2~20- 18 Rllll6b-(8 B
n591I51851 5 11S2iPI90G8 I-IZ~ 61 nSP156b-68
~SZ125LB´•iP 2-)7- 31 nSZL919032 L-10- 27 99
2-62 -)8 I(IZls19HL2 2-31- )O 852(166-)8 1-53- 65
*SL12SC~LS 2-)9- sl nS219L9H16 2- 5 -85 *S1~61L-ll 5
n521258-15 2-L(- 65 llSlle19H19 I- 5-29 llSI(b21-ll 2- 8 -1I
*511158-15 2´•11- 1 nSZ1919H2) 1-69~ 2L llrZ(b~5-1)0 2-62 -85
nP211(16-~N 2-11- 16 1(5219L9H2) 2-69- 63 nSZIb61-132 2-11~ 9
nsZIZIP~05 L~ 5 ~15 ~SZL919nII L~69 8 112)6bl-13~ 12
nPZLllleOS 2- 9 -58 W52I9I9H3i 2-69- L1 nsZlb65-132 2-11~ )Z
*1112le06 5 ~16 1621919H3P 1Z *12)b65-132 )~11- 39
*511219-08 1- i ZI n~L1919HIZ 2-69- 16 1112)LbS-132 11
2- 5 -56 llSlle19H3P 38 2~1)- Il
n521119-11 2- 5-52 llBL1919H32 2´•69- ~b 1521665-112
WI2IL79-ll L- 5 -56 WIZLe19H32 L-b9- )7 152)(61-131 1-II -32
1511~19-1L 2- 5 -56 IS2LP19n)2 2-69- 5L nSi)b6J-132 1-19- 3
n511179-11 2-1-~6 nSLIP1Pn~2 2-~9- 5) n11)661-L3Z LO
n12l280-06 2- 5 -55 152L919HIO 2-69- 32 2-19 ~11
nSZ1280-09 2- 5-)9 1(52191986 2~ 5-86 *PZ16~5-L)P 2-19 ZZ
1(21288-08 Z- 5 -56 852191988 6 *621~65-132
nSP1902-0) 2-17- )1 11~119PO-ISR )-II~ )I RIl)bIS-~3L 2-19 -)8
nOZ1901-)C 1~11- 1( n5119210( 1151)065-112
*SZ1905-(C 1~LI- II ls2116bD1 2~25 -138 n52)~65-132 2-)1- 97
nPZL905)C 2-17- 21 *52117101 1-25- 16 n5)~661-L32 10
nS219070) 2-13 -´•iB *22)11101 2-L5 -1IRL 1151)605-L1Z

5-14 Rsuised: 2R November 108~1

 ILLUSTRATED
OULFSTREAM
PARTS CATALOG Section In
COMMANDER
Numericail Indeu
680A/B80B

P IIT FIGURE P 1 R T FIGURE P L R T FIGURE

C IHOEX E INOEX C INOEX
N U Il B C R NUWBER N U 1 8 E R NUIBER N U n a E a NUIBER

*SL)e65-132 2-))- 69 11116’)3-528 2‘68- 25 2~(3 10

)152)665-132 2.*)~ 81 IILIb93-IZ9 L-)2 3 nS1169)-S19 2-)0 7

n22166S-L32 L~´•6 -II 2´•)3~ 218 1151(69)-5)9 2-50 -33

IPIId65-l32 2-(8 -28 llP1)69(~S19 1-50~ b3

1(521665-132 1-18 -)Z I(IZlb9P-53 2-16- )L ISE)(,91-I5 I-2S -202

nsil665-L32 2-62- 16 I12IL93-53 2-26- II 151)691-510 1-37 -)1
I52I661-132 2-63 -1(*111)693-53 L-)Z L)1 510 2~31 -Ib

1(52)6(1´•1-132 Z I12Ib93-130 6 2-31 -37

2-1)~ 5 1(521693‘530 2-16- 8 II
*SL(6(15-13( 2-12 -LI1 1528693-530 10 I(2)b9I-150 2‘68 -60
n511665-13~ 2-12.113 *ILlb93-I30 2-26- L3 nIl)b~*-511 L-PI- )O
n52(66’1-13) 2-13 L-I6- I) WS2(69)-151 2-33 -II
1111665-131 Z~lb. 8 1111)693~130 2-26- IS 152(191-551 P-33 -6)

n52)665-13( 11511193~530 1-16- L~ 152)691-551 2-38 6

2-18 -28 11i1(,43-530 1-26-20 n11(69)-151 2-39 -159
ISZIb4SI)I 61 152(693‘530 ii n12)69~´•151 1-15 ‘15
IPP)665-L)) L-LP~ 68 151(693-530 2´•16- 35 nSP169(-5S2 2-)6- IZ
USZ1~65-13) Z-LO 27 I12i693-131 2-19- B *SL119)-55) P-sl- 62
1111169-131 9 2-30- LI 111119)-553 I-38- 10
1(52(b6S-13) 31 II2ile3-1)1 2-31- 191)~9)-153
1521(165-1311 1111193-5’1 21‘12 -80 1(12169(~15) 1-39 -65

152(665-134 2-)6 LI 1111693-5) 1-30- II 152169)-55) 2-39- (19

asi,665-la~ I12I691-5) L~(L ~138 HSZlb9(~15* L‘39 -83
)~)B -Ib 1-73- Z *IZ(~S(-S5L I-)9- 89

nS2(665-L3~ 2-)8 -61 ~52M93-5)1 2-65- 2 nSLlbsl-SS~ 2-)9 -93

IIzis93-519 I-Se -lss Irr,bsI-sSI 2-39 -loe
llS2*6bl-L3( 1-61 6 I52IL93-5S0 2-))~ 31 nIZIb9(-SS1 2~39 ~LI1
115~)66513) 2-6)~ 11 I12Ib9)-ISO 1-59- L
R12(6L5136 2-18- (1 IIII(L93-151 I-25 -IPL nS2)b9~´•551 2-6L -ls
2~(5 5L )(SL)(9)-551 21
IS2)66S-151 2-11- 61 I52I693-153 2-59- L nSP(L9)~155 2-28 ~13
1521665151 I-LI .11 1(11693-16 Z-LS´• 81 n52(b9)-156 I-LS -153
~S21L93‘51 L~33 2)8 L(51(69)-556 IO

115~(665151 2-PI-is 1(12I693-18 ISl(b9)~551 2-58- I

lsZ)L(15-LSL 2-28 1: n52169)-119 ll~l(b9)-551 2-62 -30

*si~sss-zal z-l-al 2-21-1~1 nP1(69I’5S8 5

.52)665.283 2‘ 1-1 llr2)69~.C48 L-50- 9 L-59~ I

2-1-11 *S2)691-´•C)9 L~ 1:-26 152)69)-56 (~39 ~159
lS2I665-283 2-L3 B llS2169~-C19 2-59 -19

152)661-183 2-1(-(8 IS2iL91-C5L I-IB- 9 II)IbeI-GbG 2-59- 28

1152)6(9.283 L~19‘13 1(121i91-51 2-33- llSZlb9~-160 L3
11521661-283 2-12 ~12´•i *1Z(L9´•-S102 2- 8-51 III(b9I-I60 L-6I LO
ISI~b65-28) 2-70 8 IlilL91-661 L~ 5 ~29
1(51(661-L85 2-19 -16 *51´•69~‘53 89 ISI((,9I-II Z~(I ~1(
11II66S-28I *51IL9I-530 2-26 1 n51)69)-59~ I-38- 9

1(1116(15-357 65 )‘Pb- 11 n52((19)-59~ 2- 8~16

*12(~65-111 2-11- 1 2-*2 -1*9 nSL(69)-597 2-65 -18
*52)6L55 L~62 ~11 nSZlb9)-S(B 2 ~35 *IE(b9(‘S~B Is
IISZlt~eTC21 1.37- 39 1151)69)-5(8 1121(9)-599 L-LO- IZ
IP1)6e~S2Z6 2-36~ 20 1-10~51 nlZ(b9)~L)2 ~72

1111091-4126 1-36- 55 11i1691-518 2~31- *SP)bP(-(l 13

n~2)69EI217 I-L~- 5 n52(69~-5)8 2-31 -)b 1(12)L9)-18 P-12
ISi)693-52?i 1(21691-5)8 2-38 b lls1)6s(-~8 2-56 3
152)693-125 1-13 -1( *SL)Lsl-SIB 1-38- 9 Is2(b91-I8 I-S6 -11:
nPL)~93-SZS 2-33-38 1152169)-518 2-38- 10 II))b’)I-5G 2-12 ~12
1111)693-526 2-12 -82 *121(191- 518 I-)8- L( 1162)~9(-10 2‘12 ~II
~Il)be3-IZI 2-16 -1) 2-38- )1 *92(b9)-50 I-L1- 19
1611611-011 )-25.19 1(11~69)-5)8 2-38- L) 1(11)69)-50 2-12 -51

152)693-526 2-31- 61 IS1I(9I-SIB 2-38- 15 nS~)Le)-50 71

1(SL)b9rS16 2-73 -II 1121(91-118 P-)L -II llII(~P)-52 2-56
nS2IbSTSiI I-Il ~96 IIIlb9*-SIB 2~)1-59 111(1,9)-52 2-56- 1
1111693-027 I-bE *52)69*-5)8 2~(L ~61 *SZ(b9)~5) 2~5b -II

nBZI~P)-517 2-71- 13 I-(I 1 *II(b9)-SS Z~1P ~52

882)693-1170 1 11SP()9´•-´•iS 2~56

WP11693-521) L.LB‘L3 2-92- 8 nS2)bs)-16 2-57- Z

1152(69)´•5211 1-30 S Z b

1111693-128 I-15 -199 152(696-119 2-~Z- IPI)bil-(,9 2-L2 LO

1121693-118 L-2S -2371 I51(69(-519 ~-(2- SZ I-5(L-

Revieed: 28 Novembe~ 19811 9-15

 ILLUSTRATED
OULFBTREAM
Sedlon III PARTS CATALOG COMMANDER
Numericallndeu 680A/680B

a R T FIGURE P 1 R T FIGURE P R T FIGURE

L INDEX C IHDE~ C INDEI
N U n 8 E R NUMBER N U n B E a NUMBER H U 8 B E R NUMBER

MS1IL91S5) 6 M1II039-1-08 2-41 -101 1152103s-1-11 1-36 -)O

1~32 5 3 L~37 II
llBIIIRI-I 1-21 1I W121039-1-08 2-41 WS21039-1-ll 2-(4 55
n224I26-2-2 I-Il 63 nIII039-I-08 2-4(-21 WSZ10)9-1-LI 2-(5~1ZB
n525I26-2-I 2-25-L9* W111039-1-08 Z-5(- Il n511039-1-11 ZI
n525211-~553 I-II-III M52103P-1-08 1-16 -32 n5~1039-1-11 P-II- 21
n52JL4)-20 -15 ISL1039-~-08 I-bO- s3 Wlt1039-I-ll 2-62
*5i5I11-1’1 1-)2 LI M52703P-I-08 WIZ’1(139-1-11 2-24 -55
n52525)-1 1-21-1(19 3521039-1-08 2-65- 5L 2-)3 L)
n52525)-) 2~21- *117039-1-08 2-61 n521039-1-1~ 2-I8 -75
n515211-01 P-25~161 2~61 ~53 I(S210)s~l-L1
)1527039~080) 1 L‘69~ II WSLIOI)‘I~II 6
~527039-080( L~33 -18 M8II039-I-08 -IZ IP11039~1-II 10
n1li039-0804 2-12-101 2-LL JO MIII03P-I-II P-LO 23
n521039-0805 2-12-10) ~521039-1-09 Z´•LL -)O WSZ1039-1-1P 2-68 -37
n517039-0805 2-)2 -55 11521039-1-09 P-Il~ )2 115210)9-1~L2 2-IO 3
1521039~0805 2‘21-lls Z~IO 6
351101e0805 I-I9- 60 1~2)039-1-09 2-35- 60 W521039-1~13 I-II- 26
1(121039‘0805 1-)9 -66 n527039-1-09 2-(L- 1(121039-1-13 2-13
118170)9-0806 2‘~2 64 MPI7039-l-89 2-42 -1(1 M1il0)9-I-I3 I-33- )5
*527039-0806 67 P‘(3- 88 54
n5i)099´•0806 2-)3 ~75 *111039-1-09 1-)5- Z~ n511039-1-13 I-)5 -38
2‘51-L1L 1-19- 19 L‘)5‘ 17
llSZ1039-080b Z-I)- 11 n52703e-1-0’1 1(12103s-1-13 Z~)5 ~)3
*11I039-0806 1-7)- 20 11527019-1-09 2-51- 83 1-~5 61
1511039~0801 10 1527039~1-09 3 115110)9-1-13
R517039-0807 I(IZ70)P-1-09 2-54- 11 n5)1039~1-13 2-48 -11
1(5110)9-0808 I- B -I5 n5II039-I-09 18 PISZID39-1-13 1-63- 30
1(521039~0808 1-25 -31 ~‘b5 70 )9
llPZ1039-OBOB 2-25 -200 n521019-1-09 P‘67- )5 ME1103P-I-1) Z-II- 17
11521039-0808 2-36 -)5 1(521039-1-0’) 1-68 IB 1(121039-1-1( 1-72 -69
ns2lols-oaos z-so -64 *SZ1019-1-OP Z-~8- 35 n627(1)9-1-1) 2~25 ~1001
l(P21039-0809 P~LZ PI Z~bB I(I210)P~L-lb Z
HIZ1039-0810 P- 5-78 MS27039-L-09 1-68- 63 HIZ’10)9-1-1~ 2-21- 68
*521039-0817 I-Il -1S nS2170J9-L-09 2-69- 18 M111039‘1-lb 2-35 -108
1(521039-082( 2-bP -27 llSZ103s~L-09 Z-bP- 3) MILI[1)9-I-Ib I-Il -32
115210)9-0817 2-62 -17 MP2)039-I-0P 2-69- (6 *1210)9-1-11 2-(4 -II
161103s-1-01 2-3)-)0 MS210)9-L-09 2-69-11 *IL1039-1-1B I-)Z -96
llSZ103P-L-05 2~0 ~16 1-~9- 51 1(121039-1-18
L1SIIOJ9-I-05 2-(3 -19 16110)9-1-09 2-69- 91 M52)019-I-20 l-(P -96
18L1039-1‘06 2-28 -IS 152103’)-1-013 2-69‘ 63 *121019-1-21 2-69- 12
n121039-L-06 MSZ1039-I-LO L-)-I8 nS11039-1-L) I-I3- 15
11521039-1-(16 I-II 348 ns21039´•1-10 2-11 -)O M12I0)P- I-sc 2~)9 28
llSZ1039-1.0b )’(I- 20 MS1703P-L-LO 2-12- 88 WIZ1039-I-31 2-41-
1(52)039-1-06 I-bB -15 WS27039-I-10 RIL10)9~1-31 1~)1- 81
HSZ)0~9-L-07 *527039-1-10 2-21-118 1152103~-1-31 2-14- 11
1(521039-1-07 1-25-L18 3521039-1-10 2-33- 8 1(521039-1-38 2-69 -2L
WS27039-L-01 ZI n511039-1-10 L-3)-ll 115210)9-1-38 1~69 ~39
W521034-1-07 1-71- 11 WSllo39-1-LO H111099~15 I-I(P- 8
n621039-1-07 2-72 18 MSZI(L)P-I-IO Z-(L- Z 1-15 -2211
1(SZ1039-L-08 2- L -70 MlilOl9-I-Io I-II-II 2-)6 -I1
11521039-1-08 1-18- 11 MS2ID3P-I-IO l-II PI M1II039-4-26 2-39 ~60
*S210)F1-08 2-2) -59 1527039-1-10 *521039-(-3(1 Z- 8-30
nS21099-L~OB ´•85 I-)b~ 22 )~)1- 58
*52103P.I-08 I-I9 -87 MS270P9-I-LO 2-(6 ~)O nSZID)9-9-ZO
*127039-1-08 RSP703P-I-10 L-)8 -LD) nSL1039L1~10 8
*1210)9-L-08 L-PI- 18 1(117039-1-10 1-53 -)1 *SZll 3(1-8 2-bO Z
2-b3 ~)1 ~5)1112´•1-10 2~15 -6)
MP27039-1-oB 2-21- 17 MSI7039-I-I0 2-bl- 13 *SZIZLP-I-10 2-31- 69
2~27 -55 2-65 b9 WSZIZ1P-1-IO 86
*E27039-1-08 2-33 -41 I-bl- )D nSIII1Z-l-P 2-32 -1)1
2-31- 62 *527039.1~10 9 2~21 ~19(1
2-)5 -65 1(527039-1~10 L‘69 ~16 1‘21 ´•1BIC
WS2103P-I-08 2-36 -67 W521039-1-11 2-11- Is n5172I2-1-I 1-21 -1)3
1127039-1-08 2´•36 10 1151~039-1-11 ~.12 -89 *SP7112~1-5 2-25 -LO1
Z~)L- 1 *P27039-I-LI 2-73 LI
nSL1039~1.08 2-~3. 69 11121039-1-11 1.)1 .IZO IIS2IZ(1KSPIL Z~)Z -96
~SZ1039´•L-08 2~)1 .71 nS270)9‘L-ll Z~15 .131 *SZ1161XIP3L 2~(3 ~85

S-18 Rsvixcd: 28 Nousmbar 1884

 ILLUSTRATED
GULFSTREAM
PARTS CATALOG secuan In
COMMANDER
Numerical Index
890A/B90B

P d R T FIGURE P I I T FIGURE P L R T FIGURE

INDEX C IND~I INDEX
H B E R NU*BER N U n 8 a NUUBER N U i E R NUIBER
U U

~SIIZLII(SPIL 1-33- Z(C 8P3l206-2)7 1~ZS ‘IZ)

)-68 -87 IP)5206-P18 2-)1- 66 1(53510(1-1)7 2-59 I
.517)0)-(0
11 n535206-219 51 nS)52(lb-21) 1~59 Il
n~27975.2
)-1) b n83SPOb-P Ls I-Z5 -109 WS35106-l(l 2-59 lb8
n521915-3
1~18 -23 *135206~1L9 ~115 HI)520b-2(1 Z-bO 8
.I11.~5-1
n1219)5-) t~6L -51 2~62 1153520b~2)1 ~-L1-
2-62 -66 U535206-220 Z‘L5- 3 YS3520b-PIB Is
*S27915‘)
W12~971-1 2-11- 9 n535200-~20 Z-(Z-1)2 *53520b-2)9 2-61-3)
2-11~110 nS35206-2P0 9) n53)20b-250 96
l1lL1975~)
2-20 -25 W535206-227 2-25- 8) WS3520b-26) 2-33 -)O
8917975-(
2-27- 13 nI35206-127 2-25 -1)~ 15351D6-161 2-63 -101
11i)1911-1
n521971-~ 2-21- )9 nS3520b-PII 2-25 -1)5 11131206-26) 2-7L -)(I
I.I1 -57 11535206~221 I‘15 -I65 n1)5201-Ib0 2-15 -38

ns180)1-ll P-15 -)1 8535206-227 2 *1)1201-l60 ~-15 -67

nS2801Z~L1 I-)0 11535206~227 55 15)5L(ll-Ibl 10

2~35 9 WS35206~2ZI 56 *S31201‘Ibl -36
*ILB05bl
nIP871~-10 I-Z)- )II WS35106-22I 2-73- 6 IS31201-Ib2 1-15 90

*11871’1-ZZL W535206~221 I-13- 10 W535201~262 98

HS18116WZ-L 2-((-18 WS)5206-lZB )-25- IP W135201-262 1-15 -131
llSIBllB-6 2-15 -7L 1535206-228 2-25- 92 WS35201-~62 19
71 2~L5 ‘L858 llS31P01~2b3 2~11- 8
n528182~8
nSPBB89-I 2-17- PI 1(5)5201-LZB 2-15 -212 *53)201-261 -LOO
.SZBB89-L 2-19 ~L09 n13S20L-11B 1-13 n5)SI0I-263 -IS1
H128889~L 80 1113520b~228 LO *531107~P63 )~3(- 6)

3118932-01-5 19 IIP)IPOL~LZB 2-33- 1) nS)120I-2b3 2-36- 82

31 WS3520b~tPB )O n531101~163 89

nIIIObBI)SZI 2~0 ~16 59 WS)I1OI~Zb) )1

IO3L19-2)-6L 2-29 82 n535206-(28 2-3)- 16 nS)S2II-I) )-I5- 18
813I26EIo-65 2-69- 13 N535206-128 1-I3- 69 W535)33-36 2-25 -LBIC
*SJ~O(-L 2-28- 12 1-(3 -101 P(1)5))3-37 1~25 ~9Z
Pls3106-L P-t8- PL HI35206-22B P-((- 15 n51~333-31 2-73 6
H1~920L-2-bI 1~)5 ~61 1535206-I29 2~73 ~1O
8131206-105 2-25 -39 L-)l- 27 n1)53)3-39 P-33 -(S

*535206205 2-(7- 52 11535206-229 2-33- P8 nPI)IlB-ID 2-33- 218

11535206-21) 2-25 P113r20L-219 1-67- 66 1(535338-11 Z-l-b)
*51520L-Z1~ 2~25 ~1008 *13)106~230 1-25 3535338-11 L~33 -2´•8

*5192 I-25 ~L05 *53510b‘230 2~33 IS 1´•´•35 60

113~106-21( 1‘)2 ~13 L‘LL~ 91 *5353)8~´•3 2-35 -63
1531106-2II 2-31- 26 *53S206-P3L 2-25 -LO) *5353~8-13 2-68 -25
2-3(~ 10 llS35L06-Z3L ~IC 11531)89~1
~135206´•111 2-3)- 81 *585201-2)1 Z~I)- 1(531(89~L 2~13 -11
nI35106-ZL1 2-62 9 WP3S206-231 2-68- )5 IP)r(89-I03 P-IO- 21
R135106-211 ~5( llS3510b-Z)L 1-13~ 25 n531189´•11 2~35 ~118
*1)5206-21) 9 n5)5)89-L1 P‘36 ~5’)
1(53520~-2L5 2-25-163 1~14-11 n531189~11
1(5)5LObZll 2-25 -Lb( n5)5206-2)1 2-25 -11 *535189-11 P-bB -II
3135206-211 2-25-168 n5)5206-2)1 P-))- 12 *935189-~Ll 1-10 ZP
*l)lP06-215 Z~Z5‘L708 2-)~ 91 L~ B ~13
11535206-215 2´•25 -LIOE 2~25 -101 2- 9 L
nS35L06-ZL5 2~25 -1706 W535206~1(2 I~L5 ~116 2-LO 60
11135206-~15 2-25 -1810 n135206-2)2 P-3(- 3) *135189-Ll ii
*S15206~2L5 2-25 -L 870 2~15 10 1(135(89~19
HS3510b‘lL5 2‘21-197 2~15 ~1DI n53’1(89~1)5 -311
1(515206-1L1, *5352Pb‘Z)) Z~L5 ~1’1) 1(535(89~11 8-11
8* *131206-2(3 2~25 -1RI *135)89~17 1~ 9
lls~5201.215 *135206.2)) 2-25 -1RIB *535189~11 BlI
1535)06~111 L~)3 -101 *535206~213 nP35(89~19 Z- B~IZ
8)15206-216 2~15 ~65 1135206~2)1 Z~bl- 69 IS3118P~ZO I)
2-25 ‘~1 ’1135206~71( 2~ 8~)0 n5)1(89~20 2-3)~ 60
LIP)5106-116 ~138 HS35ZDL-2(’1 Z~LS‘ID) llS)I)Bs~ZO t‘lZ -(7
HS35206Zlb 2-25-1)6 1~61- 5 n231)8P-20S 511
n13910bZlb 1-2)-160 1(535206-2(5 Z. 2~68 ~(O
2-15 -II0J P-~5-L23 n53))89-27 Z~10
HS1S206-2L7 2-PS ~53 H135206-215 *535~89-21 -66
Z-L5~ 10 2~23‘119
11835206-ZL7 1
HI3120bIn 2-32 -~Z Z‘(Z ~L(Z n535189-6 ~70
WS35Z(i6-211 L.19 ´•105 *53510b-216 19 *5)5I89-6 Z~bl- 28

Revised: ZH Nsvember 1981 3-17

 ILLUSTRATED
GULFSTREAM
seotlon 111 PARTS CATALOG COMMANDER
Numerioa~ Indsr esoa/sson

P 1 I T FIGURE P 1 R T FIGURE P L R r FIGURF

C INDEX B INDEX L INDEX
N 0 I B E R HUIIBER N U W B E 8 NUIIBER N U n a E R NU*BEI(

NIS)l1KII Z~)P 55 N1S13003~85 2~)9 29

1-61- 3) HISII)I(LL 2-)5- 69 NlII)DO)-IDD 2-~5 -(5
n61)812~15 )-58 -10 HLIIZIXII 86 NLI(IDO)~lOo 2-)6 -(2
U1)1811-L6 L- i b N1S)Z1112 -LO( N1I()DDI-lOo
nS3581P-lb Z~bB 82 NIP)ZIXLZ 2-(5-LD9 N1S( 3001-10( L-~5 -)6
*151957-52 2-1-69 NLS)27K1L 10 NIP()DO)-IOI 2-(5 -5L
N*112111~ 2-*8- 19 Nlr(3DDI-15 2-33 -(7
IS6I966-5) 2-62- 19 NII)ZIXI1 2~18‘111 N11130D(-ZS 2-33 -13
)111)018-0(7 2-63- N*S)LIXI~ 2-43- 65 N15()DD(-28 2-)5 b8
WSPD(8~016 2~13 -61 N111211(1) 2-(5- 30 N*SI)DD)~´•l 2~)8 ~78
~SPOIB-O’ll 1-11- 63 N1B)t7K13 2-(9 Is N1P)300)~)b
~590)8-180 )-1(- II NISIZ~I(L) 1‘(9~ IZ N11~)300)‘53 -5)
1(59135-01 Z -22 N*S)LIIII 2-*9- II N*1)3DD)-13 2-)6- 60
1(9L36-01 2- 5 Il N1S)27Xll P-~9- 8) N11)100)-1( 2-21-1)5
1(9158(1~10 N15)11116 L-)9~ 89 N*S(3DD)-7’L 2‘25 -157
2~25-15b N1P(27111 15 N1((3001~80 2~(5 -5s
*19~89-0( 5 -10 N*5)11~18 N*1(30DI-BB 1~)5 12
llS9)B9~09 2~ 5 ~71 N1/12II(LO ~)I N1S(30D6-1Z 1‘ LP -LP3
I89689-18 2-1-52 NLSIIII(ZI 2-)5- 13 NII()HT)-II
319(90-06 2- 5 -60 NLIII)K1I 2-)8~ 82 2-61- 21
159)90-06 2- 5 -63 NIIILIXL~ 2-)9- 30 NIlLPNTs-I(, 11-69-
1(19)90-06 2- 5 -65 N*111113I P-16 -5) NIS()HT)-P3 ~90
159)90-08 2- 5 (5 1111~21720 2-(9- 11 N11)3HT)-)2 2-20 -31
119500-01 2- 5 -5L NLIIIDDD-Ib 7 N*1)3HrI-37 1-62 -13
II)OHI)IO-1IC 19 NL113D00-10 2-25 -52 N1S(3HT3-52 2- 529
NL11100-0b-3 l~lt -67 N11(1000-18 2-26- 36 HII()Hr3-b l-~b- 89
NLB1100-08-IO 2-12 -69 N1SI1DDI~II 2-32 3 N*SI3HTI-b Z-~b -91
NLS1I02-L)Z-( I N*113D01-13 I NIS()nr~-61 )-bP -12
NLB1102~0)-( 2-67-10 N1S13D01-L3 Z-lb~ 13 N*I()Hr3-8 l-b9 b
WLS11690010L NIII)DOL-I) 15 L~IO -27
NlSll~e001L 2-37- 39 H1S)3DDI-l) N1S)3HT)-96 3
NLS1*´•~2) 2-19 60 N15*3DDI-13 L) N1S)3HT(‘ZB 2-16- 6
N1LL)5-22 2-)1- 37 N*BI)DDI-I(, 2-26- )b NIS(3HTI-PB 2-19 LO
N111)6~23 2-52 80 N1S)30D1~19 L~26 8 N1S(3HT1~3 96
N*sil6-26 2-52 19 NIS)30D1~19 2-26 10 NIP(3HI~-)O 2-)9 6o
N1S1((1~21 2-52- 18 N1SI3001-l9 2-26- LI 8
N)SL(IDH~11 N*S))OD1-le 1( N1S1IHr´•-50 2-1(- 51
L-3)- 35 N1S(30DI-19 L-L6- 16 N11)3Hr1-6
Nlgl)~)Ob-) L- 9 -83 N*(*3001~7 2-25- 81 N*II)HTI-L
HISZLO-LB 2-59 L N1S1300)-10 Z1 Nlr(3Hrl-8 L~I)- 9
HLS38D-b9 2-60- N*11300)-128 1~69‘ 21 N11(3HT5-lb 2-62
N18~91-ILOP 2-L2 N*S))OD3-lls 2-69 )O N*5)3Hrb‘6 2-70 8
N11)91S6P 2-60- i N1513003-130 N*1)3Hlb-8 2-(9 -1)
N)S39~-8 2-~-16 N1113003-16 NIS(((~L 2-65 -)O
N18397-8 2-66- 6 N15630D3-16 2-35 -10’1 NLS)51’5L
NL13ebB 2-66 8 N1SI)DD3-19 11 NLS(b~-6-)8 18
N1P(ZOD12~ZB N1S13DD3~19 1~70- 7
N1512DDLZ-91 2-((-52 H*5)3DD3-19 2-)9- 83 NIIII)P(I1~
N11(PDD6-21 NLS)3DD3~21 2-)9 88 N16)b~P(*15 L-)~- 86
HII)2DDL-21 2-72- 69 HIS13003-2( N16)6)Pb1I3 2-6) -50
NLI(Z)~IO 2-)5-126 N1S)3003-I2 2-36- I8 N1S)87-LL 2-26 6
HL5)211(1D 2-16 -33 H1513003-3) 2-15- 37 NL1(87-21 2-29 8
NIZ)~1K10 2-~6 18 N*S))DD3-3) NII(87.PI II
HIFIZ)I(10 N1S130D3-)( 2-)5- 52 N*1(81-2 L 2-)0 LL
N18127K10 2-(8 6( WL113DD3-3( 60 NII(BI-21
NLS*ZII(LO 2-18 81 N*5)3D03-)0 2-)6- )3 N1SIO-131
N111211(10 2-)8 89 N*1)30D3-3) L´•(B- IO -81
NLS)I1I(LO -96 N1513003~35 2~35 bB I‘LI~ LO
NLS)LLKII 2-1)- 66 N11)300)‘36 1~25 -LIZI Nlr539-~ 2-)2 -1Zb
NISIZII(L1 N*513003~31 1-(9 PI N*IID~’b 2-3-29
NL8)271(L1 2-)6 -68 N1SOD03-38 2-(5-L18 N1P)o9-6 2-)6 LO
N*S1171(11 i~)b ~15 NLS13D03‘~0 )-LO~ 35 P~L3- 66
N1S127Xll 2-)6 81 NLS130D3-~0 2-23 9L Nlg)38~6P-OZ3 2-13 69
N1SIZII(II L-(B-lOl N11)3D03-)2 N11559-Z LL
N11)271(11 2-)8-101 H1E13003-~8 2-LO- 10 N*l)bOH13.L ZP
N11(27111 I-)9 )9 N*S13DD3-ls N*15LI-31 3 18

NIP)ZIIII 2-)9 )I N*S*3DD1-)8 2-35 -10~ N116LZ-2Rb 2-26 LZ

Hll)L71(11 -5L NL113DD3-18 L~15 ~1)0 N11)62-ZR1 2‘16 -19

3-18 Revised: 2R November 1984

 ILLUSTRATED
OULFSTREAM
PARTS CATALOG Seotion III
COMMANDER
Nume~ical Inden
680A/680B

P I R T FIGURE P 1 R T FIGURE P R T FIGURE

L INDEX P INDEX E INDEX
N U n B E a HUneER N U N 5 E a NU*BER N U 8 a E a NUIBER

N1Sbb9-350 Z-L(~ II NW1YIS8-50)-6 2-68- Z S-03I0-IIIR 2-19- 50

NLSb69~)) Ib 101 )~16 ~29
2-23 65 N5000~106*D 2‘15 59 1~0)10‘1161 26
N*1669~93
2-23 ~82 5-0310~1Lbl 2-23 67
N1(670-50
I~IZ ~5) PL135) 1-Z9~ Il S-O3LO-116R ~688

N1515-3-001 2-)8 ~)3 PCb508 LB

N1S75-3-00) P-I8- 36 PC750 1-66- 15 S-0)10-125R 1-21- II
NISI5-3‘00I P-IB- 39 PDII 2-(7- 36 S-O3l0-131R 2-0 ~2)
N1515‘3-001 PDSI. 2-17~ )L P-l(~ 17

NLS15-3-005 1.5)1. PW-ZBD-L )FL-I 2~15 -237 S-O)IO-ZLOR 1-19 -1DP

2-5)1- 6 PS100*-BH 2-27- 95C S-0)10-Z1)R 1~15 2)
Nllll-)-005
N1111-r005 Z.bP -53 R-III-N 2-59 -I) I-0110-ZL~R )-23- 50
P-62 16 R-I1I-N 2-59 -13 5-0)10-21)1 P-I3 bl
HL115-3-005
N*S15-3-00(1 2-~B -30 R-III-N 2-60- 18 S-0)10-~13R 2-*1 -120
N*SI5-I‘008 1-18 -I3 R-III-N 2-6L-1) S-0310-ZL5R P-L9- 13

NL115-)-008 2-is -(B RB-67-0-DC.*-D 2-215~ 71 S-03L0~216R 2-2L ~56

61 1) S~0310-116R 2-23 ~119
63 Z‘f~5- 20 S~03L0‘218s 1~19 ~30
NL175~3.00B
N117’1-3-008 2-39-122 R8-67-1-I8-PI P-~6- 16 S-O)LO-~1BR
NIS11‘3-008 1-5)1- REB)N 2-18-21 1-D310-219F 2-8-20
Nlsl~-3-008 6 IE83N 2-20- 29 5-0310-2208 2-19 -97
2-5~1- 10 RE83H 2.39- 71 2-13- 28
NLS19-3-008
2-(8- 29 RE83N 2-39 -95 S-0310-ZPBll 2-L9 -92
H*SIS-)-D09
HLSI5-3-009 2-62- )I RE83N Z-0. 68 1-0)10-1307
N*5)5-3-009 IEB)H 2-)I- 80 5-0310-2327
2-)8 -13 RE83N 2-)6- 111 I-0310-231F 2-LO L1
N*SIS-3-OLO
2-5)1- 8 REIF5 *5 5-03L0~2351( IL
N*119.3-016
2.*1~121 RE)FS 2-(5-L(2 5-0310-2357 L- L ~20
NIPlS-I-DDI
2-)1 -123 RHIO-50 OH* 2-25 -Lbl 5~0110-P38R 2-23- 76
N1S15.)-00)
‘50 RYBBC L-13~ 83 5-0310.3258 ~81
N1S15-)-007
~5) R06-259-RNII L-bl- 38 5-0310-3271 1-15 -29
N11~5-I-0(ls 2‘~8
2~39 -15~ R)IIN 1~68 ~10 S~O)IO-)LLII( 62
Nlr15~C(ll*
1-39 -I53 2-(8- 5~ I-0310-3PBR Z-I)~ BL
N15I5-I-0I5
2~63 ~36 5~0302‘19* 56 9L
L7 IZ 38
N1SIS~)-1OB 2~13
2-(13 -25 5-0301‘55 2-)6- 9 5-0310-3~77 1-1 21
N*S15-~-115
i‘(b 8 5-0309-90) 2-35- )B 1-0)10-9021 2-(1 -106
NLS15-~-008
N*515-5-011 1-0309-901 2-35- )9 S-0)10~903F 2- 6 ~53
L-)~(3 5-0309-901 L-bb- II 5-0310-9D*F 2~ 6~ 7
N*175-6-005
Z-~D- 1) 5-0309-901 s-0)10-901F 8-23
N*115.6-008
S-0)09-POI 2-ll-L7 5-0110-90687 b
NIIIL-TOII 2-6)-
L~63- 1 1-0309-901 1-11- 60 S-0)10-901HT I
N1116-~-I-01
1‘13- 36 5‘0309~908 2~IP ~I’) PB
NLS1616~015
2-13- 56 1-0309-912 1-71- LI S-0310-90(R 2-L3- 58
NI1161L-0I5
2-63 -19 S-0310-006R II S-D3I0-90IR 2-16 L)C
NISII-)-ls
2.19 ~17 S.0310~0LOR S-D3LO-9D(R 2-16 -19
NLS)I-7-62
I-03L0~010R 28 S~0310-90)PI I
NT33~ L1‘LI
1-0310-0108 2-21 -92 S-03LO-90)R i-re 19
1733-15.~3 2-67- 33
2-61- )L1 5-0310-0108 2-2~- 5L 2-19- )1
2-67- 2L 5-0310-0118 2-~)- 19* I-0)1D-9DIR 2-11~ 3(
NT3)-~-Z)
1-)5 25 I-O)L0~90)11 2~11‘ 38
NYZYP 1
61 I-0310-011R BI 5-0)10-9011 1~21‘ 12
nWZYZP10-58-6
3 (-0310.D11R 2-35- 88 I-D)10-90)R 80
NW2Y2I12- L1B-) 2-68
2-67 27 5-0310-0128 2-13- 3) 2-21- 82
NYZUP 511-3P-I
I‘bB -10 5~0310‘0121 85 L~11 ~10)
NYZWZ116.26-~
2-61 LB1 I-031o~OL2R 2.26- 52 5-O)LO-sOIR 2-23 88
NYIHZS)-L61-6
S-0310-OL7R 2-21. )1 5-0310-90*8 2-13- 93
NU1YZSI-LZ)-L 2~61 -18
2-27- 26 5-0310-0268 2-19-(8 I~D3LO-901R 2-23 -III
NWLWLI)‘IB-)
I‘O)LO~IIOR 1~ 5-0)10~90)11 22
NW~YLS)-B8‘6 1)
2-19- 3) (6
2-11-
)~21- 28 P~L3. 51 65
L 2~13- 69 1-0)10-9011( 2~35‘ 11
NHZWIS´•I-BO-~
-22 1-0310.1128 Z-L)- Lb S-D110-90)R 2-35 PI
NUZY1IS-BO-) 2-21
S-OslO-L1ZR 2-II- 21 I-D310-901R 2-35 -81
NW1YI16-I 3)-~ 2-67- L(
NYZYP 56-168-~ 1-61 S-03L0.113R L-I3 5(
P~61 LO )1 P‘bB ~85
P-bl 6~ S-o3LO-113R 5-0)10-9011 2- 6
NULWP 56-(0-b
2-(7 LS S-03LO-11)HT 2- 2-218 5-0310-9017 2- 6-6
NYZWI 56-1~‘)

Revised: 28 November 1984 S-18

 ILLUSTRATED OULFS’I~EAM
Sedlan In PARTS CATALOG COMMANDER
Numericz~ Indea BgaA/680B

P L R T FIGURE P I R T FIGURE P I R T FIGURE

IHDEX P IHDEX INDEI
N U 8 E R NU~BEs N U H a E R NUnsER H U 8 a E a NU~BER

5-0310-90)7 I- 6 36 5-031516-8 ~‘65 30 59~1)-01( 2- 5 bl

2- 8 )1 5-0336-L218 2-19 20 59)13-OL~ Z- 5 59
S~0110‘90bR 2~ 5 ‘1~ 1~5L‘ 23 P9)13-016 1~ 5~61
L-15 -37 2´•35- 25 4-63
S-~)lO-eDbR 2-15 S-03b2-I0 1~)5 26 59)L3-ll4 I- 5 I5
S-o3LO-906R 2-2L-106 S-03bZ-I0 P-~5- 87 5911)-1)1 I- 5 -16
1-0310.9068 2-23- I6 f-036S~)O 2-34’ Il 59(L)-579 2- 4-39
1-0310-9068 2-23 -111 5-03L9-1 1-19 -153 59113-628 Z- 5-62
5 83 1‘26~ (9 TLl(nOl~lO 2~25 ´•L 93
S-031O.9O67 2- 4-83 1-0310-501 )-Zb- 50 711)*0)-5 2-25 -105*
S-0310-908F 2- 6 P 1-03I0-503 I~Zb 51 TIl~l0)-10 Z‘1~ 62
1~031(1-908F 2‘ 8´•58 1~0)10-505 1~20‘ 52 T*15*O)‘LO 2~3)- 68
B.O)10-eOBHT 2-72 -32 5-0313 2-34- 16 TLII*O)-10 2-36- 85
S-0310-908HT 1~72 -35 5-03~3 1~35 88 r115n0)~) L‘25 -263
1-0110-9087 5 -81 1-0382-503 2-L3- 5 TIGERIB~1C-YH-C-X*E 2-26-20
5-0)10-91DHT 2-3(- 52 5-0381-501 2-13- 5 TIGERSI-IC-YI(-C-X*E 1-32- 1
S-0)10-910HT 2-72 501 5-0390’1 L- 2- TlbLII-1C-W~-C
211 Z~Lb I
S-03I0-910H7 I-IZ -66 S-(1390´•I L-)l- 20* TIGLS1-IC-Yn-C L‘)L 2
S-0310-9LOR 2- 5-18 5-L)52-(16~ 2-L3-~1 TIGI)B-1C~YH-C 2-16 -23
1-0310-9107 2- 6 ~15 S-II52-0bI 3 T16311-lt-Yn-C L-Zb -2)
I-031(1-91ZHT 1~3(-)5 S-30L-11 2-L9- I rIb115n-IC-YH-C 2-32 3
5-0310.91281 L-IP- 39 5-)02‘~31 2-(1-101 TIGIIII-IC-UH~C 1-)6 -13
S-0310-9LIHT I‘IZ -50 5CEEIS-B~BB-6 (-bB‘ L TLGL5)-1C-YH~F 8
S-0)10-9L2HT I-Il -56 )~69- )L U88C-L2(15-SI 5
S-03L0~91LHT 2-71- 49 SC2CINI-9L )1 UllBC-1132-IS 1-9- 5
S.0310-9LOHT 2-69 -II ICICXH191-96~* 2-*1- 8 V-I02 2-20 sI
S-0310-9)DHr 2-69 60 SC’IDFP59-I-9~16 Z~L5- )2 V-IO2 I-ZL -II
S.D3L1~010 1-16 ZB* SE-15010 2-65- 22 V-1D) 1-10- sl
5.03L I-0L6 -)7 SFIY-)C-Il-CP~LOLGI 2-26- 3 V-2DLI)
I.0)L1-112 P-)(- 20 IFIW-6t-I2-CFLOSGI 1~3L 38 V-21118 1´•25 is
5-031L.113 2-)1 .11I IFIY-(C-IL-CP-LOSGI 2-)1- OL V3-L 2-25 -115
2-13 -)1 IFSW~LC-LZ-CP-LOSGI 2-33- )Z V)-1 1~62
2-19 -)s IFSY-6C-IP-CP-LOICI 2-33- IL V3L-L39 56
5-0311-114 2-16- 196 EFSU-bC-I-eP-LOIbl 2-26- Y10)62 1-15 -23
5-0)1 L~116 2-13 -27 IFSYBC-LOIQb L X-102-19 2~68 -15
5-0)1 1-131 55-5083)1(1711 1-(1- 5 XYII 2-62 -85
S-D)11-LI) 1-11-119 55-51051 ~-)1- II IYIODbl- 1180 2-24 Z(
1-03I1-2I6 2-21- 51 OIBH-LZN ~´•L3 -39 IU10173~Hl 2-21~ 21
1-0311-118 2-0 -Ib 57323-8-18 2~LB -32 XY)o3I)-3i5-)6 2-24- 29
5.0311-32) 2-13 -31 ST3EIO-13 L-68 -IP XY210)15-IOOT L~ZS ‘15
r-03ll-3z8 1-1, -63 2~bB- II XY10100-~‘P000‘1 2‘)5 ‘2L
5-0311-328 t-II- 82 IY195B 17 XULD122-I-90-12 L~Z5 -II
7 111969 2-25 -7) XYP0973-612 1-15 -11
5-0311~90( 2~13 58 IWZYI-5-L Z~ 136-6 6 9
1-031 1-901 i-IL -1)C 58282112-128-6 I-~I- )1 21115 P-)L
S.OSLL.90( 2-L6 is 58282111-128-6 2‘bB 9 18625 2~11 50
I-03L I-eo, ~-19 -In suruzrl2-9,-6 ,-bs- a 1i039 7
5~0311-90) 2-21- 33 IY531111-E ~‘65- 3L ~(80 Z
5-0111-90) IIL15020 )-IS~ 99 It~PB 2-71- 16
5-03 L 1´•90) 2-21 II I*2LCl.ltP I-P6 ZI 2LIB 2-ii 52
S-0)L1-90) 2-21- IP 50310-9058 1638
1-0311~901 2-21-103 5033)L6-6C L-~Z- 18 2638 2-71- 51
5-0311-90( I-L)- 23 E601‘´•2507181-8L 1-32 1 1908 2-71- PI
S~03L 1‘90) S80571YLO L- 1-M 0111 2-26- 30
5-0)11-90) 2-2)- 66 L80578FLLO 2-1-53 0116 1-32 -10
5-0311~90( P-31- 11 S8057sF) )-I-II 0128 2-26 ZB
I-03111POI 2-15 23 S8197N2)2-032 2- 4-56 01)1 I-)2 6
5-0)11-90( 2-)5 -)B SBL51Nl)P~O)I 1-4-46 03-161-01
E-031 1-981 P-)5 -19 2- 5-11 03-10)-0) -I22
I-)5 -81 IB157N52~21D 2~ 5 ~5L 06000 L-ZS ‘180
8-031 1-90) 1-68 -85 2´• S -)’t 06000
5-0311~P06 2- 5 -83 59011F23-01) I- 4 -56 07100 2-15- 5
6-0111~P06 1-21 -105 1901)E21 1~ S~)1 0113( 9
1-031 L-P06 2-13. 16 59112-013 2-5-36 1-01-000n0D-1 2-3~- 3
5-031 L-911 2-3)- O 19112-028 L- 5-3) 1C~70-I 2-)7- 52
1.0321~Hn 2-24 -111 29112~158 L- S -16 LEHL-68 P-I3 -59
S~OPII‘HC P- 9 -1) 19)13~010 1‘ 5‘25 1EH1~68 2~16 -30
2~12- 59)13~01) 1~59 IEL150

3-20 Hevisrd: 28 Nauember 1984

 ILLUSTRATED
OULFSTREAM
PARTS CATALOG Section III
COYMANDER
Numerical IndeK
ssoA/ssos

R T FIGURE P L R r FIGURE P I R T FIGURE

p I
t INDEX B INDEX C INDEX
B E P NU*BER N U B E R NURBER N U B E R NUMBER
N U H

11 11018~-) 2- 2~37 170016-113 2-39 ~25

1E1151
2-LZ -65 110185-L Z-)0~ 13 1711016~1)5 25
1SXI-58H
Z-65 -23 It0I85-S0I L) LlllD16-1)9 2~39 ~21

2~25 .2)2 110185.SLl 2~25 -71 L103L6~151 2~39 ~21

10-OSPI-IB~C-l
~3) Lt0L85-S19 71 110016~1b5 2~39 ~31

2-65 -32 11 11031 b~lbl 2~39 ~10

37 ll0L85~575 2~25 -120 170016~1 69 2-39 3L
2-1~- 39 llOLB5-58~ 2-15 111110016-171 2-39 ~30
fOVIO
2-15 ~31 LIOIB5~58) 11 110016‘115 )3
lol)Y )W*
1´• 9 19 L1018S-S91 2~25 ~120 111)~3 6~177 1-39 32
L00~01´•I
110185-5’)3 1-32- 2) 1-)9 -)9
L01)
2-6b ZZ L1OZ tl 1)0316~181 2-39 ‘(O
L01510.5
IS 1125~( Z-01- )1 111)016-189 1~39 ~)9
LObPOL-I
2-3(- 95 1133-811 L-l(- L) IID0IL-I91 2-39 -10
IO(POL-)
2-21 -11) 1165 2-63 38 L1001~-193 2-31 22
LOb5731
2.21 -1D8 128 2-65- L7D016-19) 2-37 -22
L01005(-I
2-19 .150 II0036 110316-2)9 1~31 2L
109~711100-18
1~10 2-17- Is 110016~1(0 1~31 ~21
110000~)L
2-50 -21 110037 l-LI- 1110016-)53 2-39 -)2
110000-13
t-5D -66 1200)1 2-23-123 11(1016‘35( 1‘39 -12
110000-62
11000(1-63 P~)(L- 66 IlOO)b )5 1100L6-)SS 2~39 -)1
2-50 -22 1200)6 2-)5 -97 LIDOL6-)S6 2-39 (1
111)000~65
2-50 -22 II00)b 1 110016-359 1-39 ~36
11D000-6b
2~75 3 1100*9 26 2‘3’)- 36
L1D098-503
L1013) P-)5 1303~L-) 2~)2 8 2~39‘ 16
9 1303)L-) ~-66 -16 110016-11 2-39 -33
11013)-LOI
L1013)-ll Z~15 55 110016~13 2~39
1-75- 13LIO 2-68- 56 171)P17-S01 2-37 LI
LLD1)(-II
2~15 ~!L 133*L 55 110011-7 P~31 12
2-75 1( I36I1XL 2-L5 II llODZS 2-37 1L
Llo13)-lBl
2-75 I 13LBSXL 6 tlODZS 2-3e I
II0I3I-I9I
2~15 7 13830 I-L9- 6L 1)(LDLS-15 2-37- LI
IIOLP)~LP)
L10L3)~219 2~15 -13 13889 1‘19- 51 110025´•39 L3
L1013~-121 2-15 L3 1)95-GE I-)I- L1 170025-11 2-39 9

2-75 -1) 11990-2 I-II -15 I1002S-58 2-39 9

110131-223
L1013)-21´•j 1-75- 1 1*990-2 2-27- 31 L790Zb
11013(-119 2-75- IZ t10-00I3 2-15 -200 110026 2-39 -It
L~15 ~12 LIOPLH~10 )6 170026~3) L~II ~16
2~15 9 LSOPLN‘10 L~))‘ 5L 2~)9 ~12
2-75 9 LS0PLN-8 2-13- 16 1100~L-36 2-39 -12
I1OI))~P)9 2~15 6 151~0008 1-25 ~199 110010-31 )~31- 15
1.15 9 151~0008 2‘(~- 53 170026~65 L3
L~15 LS ISI99 9( 110026~b6 2~39 L3
LLOL)L~99 P‘15 ~17 156110-2-1 2- 5~6) 170828 2~39 -19

lIOI31-5 LS~Zb)‘7-2 170(118-25 L~39

LL01))-63 2-75- 18 2-6-28 II00I8-I6 2-39 -1I
llOL3~-I 2 1592~26 L~11- 6 170018~17 L~39 ~15
2~15 -13 16 )-1) -101 L7DDZB-ZB ~‘39 ~15
L1013)-95 2-15 L3 160009 1-91 110029 1-39 -IS
LIOI))-PI 5 160009 170029~)9 2‘39 LI

LIDL3)-99 2-75- 8 160009 1-99 L10029-)0 2-39 LI

110151 2-50 1600P9 2-)0 170029-)1 2-39 Lb
110151~P7 160022 2´•19 -L58 170029~12 2~39 Lb
LIOLSI.ZR L~50 16(1013.1 Z~s9 ~159 LID331 2-39 9

110151-29 2~50 -15 160013‘1 Z~19 ~159 L1D0)1-3S 2-39 LO

110151-3~ 2‘50 -~5 160023~503 2~19 ~160 110031~36 2-39- LO
L1OL)1-)L 2~10 ~)3 P~39 ~160 17003L L~39 LO

110111-31 2~50 -)3 1660(1119~115 2´•LL ~110 170D)P~(I ~‘39 -11

L10LSL-33 1I L6bOb139~2 I-I1.11I 170031-)) L~)9 ‘II
2-21-111 L10032‘51 LI
Llo15L-7 2-50 )I L6bOb*39~7 2-21 ~11) llOD3L-52 2~39 II
L1D151-8 1-50 -~1 1680-6*6 I-I(- 13 II0035 L-)8 B

LlOlsl~l 2-75 ~11 1)001b‘117 1~19- 32 1700)5´•39 2-IO~ L)

110183 110016-121 2-)9- 32 L 10035-39 2-38 -10
110183-3 2~ Z -36 1 7OQ16-L29 31 110035‘11 2´•18 -10
1101B3-) Z -36 11(1016-131 1-)9- 35 LIOD)S-13 Z~IO 19
I10I8I L .)b 1 35 110035‘)) L~38 9

I10I8I-3 2- 2 -37 II0DI6-1)I 1-19- 1) 1100)1 1-19 1

Keviacd: 2R Nsvember 1981 3-21

 ILLUGTRATED
OULFSTREAM
Bectlon m PARTB CATALOG COMMANDER
Numeriesl Index
880A/6808

P I R T FIGURE P 1 R T FL6URE P L R r FIGURE

L INDEX E INDEX C INDEX
N U n 8 E R NUMBER N U It B E R NUMBER N U n B E n NUMBER

110017-3 3 170118~29 ~LII 17DL9)´•1 1-37- 11

IIOD1I-I 2-)9 3 170118-3 1-)9 -1CI1 170191-2 2-31- 1)
110031~5 2-39 2 L70LlB-10 2-19 -LIZ 1101’)8-101 2-37 -)D
1100)l~b 2-99 LIOL18-3L 1-19 -11) llDL9B-501 2~31 PO
1)DD38-5Ll )-)B -18 110118-32 2-39 -III 1l0L99-501 1-37- 19
110059‘3 P~)O 1) 170118~33 1~)9 -176 170L99~502 1~37 19
LIOlll~ 1‘37 -)O L 10118~3( ~llb LIOZOZ~I 1~39 8
L70015 P´•39 -2! L 10L38-35 2-39 -119 IIOLOZ-Z L~(9- 8
1)D015-LOI L-)P 23 110118-39 2-14 110213
II00I5-I0I 1-)9 -23 IIOIIB-I 1IOZL)-l
L10015-Lo3 2-39 28 170118~)0 2~19 ‘L6~ 110213-6 Z~IP ~Is
L10075-101 2-)9 -)B 110118-5 2-39 -163 II02II 2-39 -18
110015´•bl P~)9 19 110118-6 1-~9 -163 L1011)-3 1~)9- 19
L10015-(I L‘19 -19 110118-7 1-19 -166 II0PII-) I-is 19
L10011-69 2-37 -I) LIOLLB-B 1~19 ~Lb6 llOL17
110015-71 2-37- 23 170118-9 -L61 110111-1 1-)9 1
L1DD15-13 2-31 L) 11(1120 2-39- 5 llOP17-Z 2-39 -I
L10015-15 2~)1 ~15 110111~501 b ll(lt19
1)0015-7) 1-31- 21 llOLZ1-501 2-3´•)- 6 llDL19-3 1~19 ~Lb5
11001´•1-19 I)OLLP-I 2-)9- 7 110219-) 2-39 -lb5
n00ll´•81 )-)1- LB 110121-2 2~)9 1 110253~1 P~3B- 6
170015-8) ~-31- IB 110122~50L 2-19- 1 170s13-2 2~)8 6
110015-85 LIO1ZZ-102 2-)9 1 II025I-I 2-10
11001~-R5 2-38 L5 L)D1)9 Z-91 11DPI)-l L~38 5
L10075~BI 1‘11- 16 17DL39 I-38 11015(-2 2-38 5
L10015-RI 2~38- 1~ 170139-1 L~39 Z~IO
1-37 -2( 1701(0-1 3 L1015(~501 1~38 I
110015~P1 2-37 -26 1)01(1-L I-)I- 1702))-502 1-38 5
170081-3 2-39- LL L70L(I-501 1~37- 1 1IDZlb-L 2- B
-)9
110081-~ L-39 -11 II0II3-I 5 110156-1 L-10- 1

nOOBB-L 2-39 -38 L7D113-Z 5 110256-L ~´•38

n(1089-1 2‘)9- 38 2-)7- 1 110259-1 2-10- 9
110oPO-501 2-39- 31 1101~)-2 1 L10259-1
110(1’11-501 2-39 -37 1 IOL)5-~01 2-37 Z 110195-1 2-39 -181
L100~L-501 2´•´• B -54 I1D1i1-509 2-37- 1 II0295-2
110096-101 2-LO- 51 I7DII6-I 10 110296´•1 L~39 -LBO
110096-~01 1~38 -11 170116-501 I-3I-I0 1102)6-1 2-)9 -180
110096-502 I-38 -11 1-31- 10 110201 2~39 -119
110091-101 L~LO -)3 2-31 -10 170298-1 P-31- B
170091-101 P~38- 1) 1)01(1-1 11 173)3-bl-150 1-11- 18
L70091-5D2: 1~38 -12 170L(I-2 2-37- 11 1801-010 2~1)- 10
L7(109LI-5D1 1701(8~1 I IBO1~OBP 30
170098-101 1-38 -1) 1701(8~501 2-37- 1BIl~-200 2-69 29
IID09B-50P 2-38 -11 1101(8-~03 2-37- 1 IsPIL-I00 L~68 -~I
L10Ds9-501 I-ID 52 1701~8-501 1~)) I 1P000 L6-I´•10 2-28 b
L10D99-5OI 170119-’1(11 P IPODI6-20´•2D 2-12 -95
LID099-502 2-38 -13 1)0110-501 2-37- 6 191-1 2-3)- 1
110105 3 L-19 -182 19bB-)-0´•10 -58
LIOIO(-1 1-39 1701b0-2 2-)9 -187 2 OREIIS-) ~III
)´•)9 1701b2‘1 2~10- 2 2~b9 -)3
170107-1 1-)9 5 1IDLbZ-l 2 2625580 2-65 I
170L07-2 2~39 5 1101b2~2 L Ln3-l 2-36 ~(1
170118-1 1-39 1101b3-I I-)B- 3 IH)-I 2-72 -63
170118-1 2-)9 -LLO 110163’2 I-P8~ 3 20‘0)0)´•8´•~1 Z~b9 64
L1011B-ll 1-19 -I~B 110165-1 ~-10- 1 20-D)O)-T-8-P( 1-29 -13
L10118-13 2~39 -169 1)0165-1 2-)8- 1 2~15 ~79
L70L18~L5 1-)9 -1~Z I 2‘25 19
170L18-1~ 2-)9 -162 llDLb6-I L´•38- 90 20-0307-6-8-21 2~)9 L3
LIOL18~11 L~)9 ‘L10 LIOI~P‘1 1~38- 19 P~30 Il
110118-18 2-39-L70 1 IOIL9-IOI 2-38- 19 20-0301-6-8-2) 2-31- 5

L10118´•19 2-39 -111 11011L-1 -30 20-0)01-T-8-2( 2-29 ~13

170118-10 2-39-L71 110172-L 2-31 -38 IO-0301-T-8-P) 1-)0~ 15
170118-ZL 1-)9 -173 170113-1 2-)1~ 29 20´•0107~7-8-)) 5
L70118-12 .173 n0113-2 1-97- 1P ~0-0301-7-2( 5
-175 1101)6~1 7 ZOIC)-LI(~IO 2-26 LI
LIO111-LI 110117-1 I-)8 B 20TCI-LK-15 2-26 Lb
L70L18~25 1-39 -111 11D196-I L‘~I‘ 18 20TC(-LI(-20 9
170LL 8-21 2-39 -178 110196-2 2-)1- 18 L~tO LO

5-a2 Ravisod: Z~i Novcmbar 1984

 ILLUSTRATED
GULFSTREAM
PARTS CATALOG section I11
COMIWLNDER
Numerica~ Index
BBOA/BBOB

P b R T FIGURE P 1 R r FIGURE P R r FIGURE

L INDEX E INDEX t INDEX
N U n B E a NUnaER N u n a E n nUnsER N u 8 a E a NUI8ER

2-Ib B 2000L0~19 ~L81 2´•I~- 30

I~Zb 11 2~39 ~L81 27

ZDO1C 111 2-23 -LOI 2O8828-8L 2-39 -192 1-12- 25

10000~ 2~39 ~)3 200020-82 2‘39 Z100108~P 1-67 ~19
100001-32 2-)9 -II 298829-83 L-)9 -116 110650 1-71- 3

200001-33 2-39 200020-8) 2-39 -L86 213(17

IDDDOL-36 1-39 -15 PD00sO-BS 1-)9-L91 213((7 1

20000L-31 I-39 (5 200010-81 1-39 -191 ZL3)lD 2-76 6

200003 2-39 (S 200020-89 2-39 -I8I 2L3b50 2-3) 63

L00003-10 2~39 )6 1~0020-90 2-99 -181 P1365L i-II 8L

200003-LI 1-3’)-*6 100010-91 L-~9 -LRB 11~1-) 2-61 -51

200003-) 1-)9 (I lOOOZO-PI 2-39 ‘LBB LLFH-52( 2-15 8

200001-5 1-39 17 200010-93 2-39 -LB( ZLFH-51) 2-15 19

L0000( 2-39 Il 200020-9) 2-39 -LBI 22F1-528 1-19 60

100001-16 2-3’)~(9 1000)8-509 2-38 -21 22FH-7ZD 2-15 -3)

L00001-ll 2-39 -19 288828-513 2-38- 23 228812-81 Z-1)- 9
1~0001-18 2-39 18 200028-515 1-ID 2( 2~38 19
~00001-19 2-39 -)B 100829-1 I-)8- ZL 230-021)-000 2-25 -1BIC
200005 t-39 19 10562 2-3L 9 238886 Z~P5

20D005-1 2´•´•39 -51 107685 2-25- 811 230006 2-37- 31

2~39 51 i 230006~10 Z~)I IB

200005~6 1-19 -50 21-1010-1 23000(-5 1-37 ~39

200005-7 P-39 -50 11~1010-2 L-IP -1) 2)0006-6 2~31‘ 39
200006 1-39 -51 ll-L010~3 Z-LZ- 6 23DOD6-9 2-37- 38
200006-1 2-39 -53 21-1010.) 2-LI- 1 230)5-1110 2- 5-LL
200006-5 2-)9 -53 11-1(110-11 8 23565-10)
200006-6 1´•19 -52 21‘1010-6 Z-LI- 9 1385´•1 2-62 -79
200006-7 2-39 -51 21-1010-1 I-Ii-II 2)8081-500 2-39 -110
200001 2-39 51 21-1011-1 P~LL 55 Z)ODDL-5Ol 2-39 ~110
200007-6 2-39 5) 21-1O1L-2 2-12 57 ~)00DL-502 -101
200007-7 2-39 5( 2-12 32 1)0001-503 2-3e -101
288808 2-37 36 21-1011-7 L‘L~ 3L 1(0001-50( 2-39 82
200008 2-39- 56 21-1011-8 2-12- 33 2)DDOL-105 2-39 81
200008-11 2-39- 51 Z1-lOll-P 2)0001-506 2-39 81
280008-13 2-39 58 Z1-IOIP-l 1-II (1 2(0001-107 2-39 81
2(10008-~) 2-37 -)1 ~L-1(11Z-1 35 ~)0001-1118 )~39 ~91
200008-23 2-38 -17 11-1013-1 )-12 -*5 P(0D0I-109 2-39- 92
200008.3 2-37 35 P-L2 11 2(0001-510 2-39 81
200008-( 2-)1 35 L1-1013-3 210001-511 1-39 81
200008-5 2-31 36 21-1013-) Z-LL 39 IIDDOI-r,I2 2-39 88
200DD8-6 2-31 36 21-1016-1 I-L2 10 2(OD01-5L3 1-39 88
2-39 -55 LI-101~-P 2-t2-16 2(0001-51( 1-39 ~68
200008-7
1~39 ~56 LI-1OLI~) Is 1*0001-515 1‘39 67
200(108~9
POOOLO 1.17 -)D 11.101(-* 28 2(0001-520 2-39 ~61
POOOZO 2-38 -II 21-L01)-9 I-L2- 23 210001-~21 2-39 -61

200010 P-3~-)3 2L.10L5-5 2-12- Ib 2)0001-522 2-39- 63

1-39 -182 21-LOl5-6 2-12- 38 P(0301-523 2-39 61
200020
100020 L~(5 -L5L 36 2)000) 1-39 ~75

200028-103 2-39 -IBO 21-L015-8 I-1I 29 2)000( 2-39 99

Z~)9 ~L89 2-11~ 53 P10005 1~31 ~)1
200020~10)
200020-109 1.39 -198 21~LOLb-1 i-Il 59 260005 2-39 81
200020-LLO 2-)9-190 )1-101I-1 1-11- 59 2(0005-15 2-39 -100
~(10010´•111 1-3I- )3 1-11- 58 2(0005-L6 2-39 -100
200020-112 1-37 -33 P1-1017-I 210[1(15~31 2-39- 97
2000ZO-L31 2-25 -218 L1-1017-5 1-11- 15 210005-36 )-)P -98

100020-119 1-25-218 11-1011-6 2-LL- 13 210005-)5 1~39 ~105

200010-11)1 2-)9 -185 P1-lOn-l (Z 210005-I6 1-39 -105
2~39-185 )1-1018~1 2~11- 6L 2~0005´•53 1~39 ~10(

ZOOOPO-L)P 2-38 -15 21-1018-1 1-12- Ib 268885-57 2-39 -106

2‘37 ~31 21~1019-1 P~LL ~68 21000~-58 ~106

2(loOPO-L52 2-31- )1 21.1019-1 L-ll~ 66 210305-19 2~39 -101

288028-63 2-38 -25 11-1019-3 L-1Z- 13 1)ODOS-LO 1-39 -102
200020-6) 1-Il -25 L-1I- (B 210005-61 2-37- 15
2-)8 15 2L-IOL9-5 2-12- 60 2)0005-62 1-37- (5
200020-65
2-31‘ 32 2-I~- 51 P10005-I 2-39 ~101
~00020-15
~‘37. 32 50 2(0001-11 1~31 ~(3

20002(1-17 1-31- 3~ 2L-1010~L6 2-12 -7~ ~)ODDI-IZ 2-37-

1-31 -IP PI-1020~11 P-1Z- ZI 2-31 -II
200oLO-18

Revised: 28 November 1984 5-25

 ILLUSTRATEO
OULFSTREAM
Seobon In PARTS CATP1L00 COMMANDER
Numerlea~ Inden
eeoA/ssos

P L R T FIGURE P R r FIGURE P 1 R r FIGURE

E INDEX g INDEX P INDEX
N U n a E a HUUBER N U M B E R NUMBER N U B E R NUI(BER

1(0005~71 2~)9 -85 150000~100 2‘39 ~12) 260025´•115 2-(I- 30

2100(15‘78 210000~201 1‘39 -L30 26DDZ5-116 2~(1- 30
1)0005-18 1-39 -85 250000-205 1-19 -1)0 P6L13Z5-IZ 2-)1- 28
2)0005-8 2-39 -101 250000-I06 260815-125
Z)0005-8P 2-99 -LO1 250000-101 2-39-13L 260)15-126 -21
2)0009 ~‘)1 39 ‘1*~ 2b03LS‘IZI
2)0009 2-39 -58 150000-218 2-39-1(8 260011-128 l-II -39
210009-100 2-39- 80 250000-219 1-39 -lls 260025-133 I-I1- II
1(0009~L1 2-39 ~73 Il L~(L L)
2)0009-12 1-39 -71 25000(1-1)2 2-)9 -137 1)0025-139 2-)I- ZB
2(0009-1 I-37 )I 250000-233 1-)9 ~1)1 260025-113 2-)L 28
II0009-I9 2-39 -78 250000-2~0 L-)9 -1BB ZL03L5-l~l I-)1- PO
I)0D09-8 1-91 IL 290000-211 1-)9 -138 ZbO325-IIZ 2-(L 30
1)OO09-8L 1-39 -lb 25(1699-1)2 I-)s -I)9 Ib0025~1(3 2-11- 27
1)0009-82 2-39 -76 250000-263 2b03L5-I~) I-(1- 27
2)0009~83 2~31- (O 16 1611311´•L)5 )-I1- 26
2)0009-8) 2-37 -(O 1500O0-If,l Z-)I~ ~1 2-)1- 16
110009-85 IIO0O0-PSB I-P9 -113 260321-1*1 1-)1 29
P50000~28) 1~)9 -117 ID
240009-89 I-Is 19 250000-285 L-ll- (6 2bD025-1 53 Z‘(I- I58
210009-9) 2-31 -39 2500(10-287 L-))- )1 )6002´•1-16 L-~l- (O
1-39 59 250000-289 2630)5-19 2-61 )3
L1O009-96 1-37 -39 250000-291 I-)s -L15 260015-50 L-ll- ~3
I-39 -59 250000-197 I-)I- (B 260325-51
210009-97 2-39 -77 250000-3 2-39 -ILB 2600)5-113 L-(I
2)0009-98 2-39- 11 250000-311 1-37 -18 160325’51(
1)0009-99 2-39 80 250000-311 2~)9 -1IP 260325-5L5 r-(1
2109( 3 )10000~323 2~31 )9
1109) 2~11- 11 250000~125 50 ZbOD25~511 2~*1
1(0s6-200C 2-69 -30 250O00-357 L-)9 -119 260025~518 1-~1
2~(-11CO 2~50- 68 250000~)58 2-19~119
2)52-06) 2)0000-359 2~)9 ~156 260025-52
2)52-06) Z- 3 11 2I000D-3b0 1-)9 -151
2)52-0Ll I-)-L3 Z500DD-36) 2-19 -113 260025-5I 1-11- 19
2)52-06) 1~ 3 12 Z)OODD~3L9 2‘39 ~I)B 260011-58 2-~L- 19
1))Z-O(IRET 1 250000-370 2- 39 -1)8 260025‘1 2-11- 29
2~3‘L1 )50000~373 21001)~71
2(52-06)RET 2-3-13 250000-)11 2-39 -L3( 2b0025-72 2-)1- 5)
IISL-ObiRET 1- 3 22 25(1668-*9 -L26 2600P5-75 L-(L 53
25*51 1-19 99 250000-~1 260025-76 I-Il 9)
25111 2-19 -98 150000´•50 2-39 -132 ~b(1025-19 l-~L -I5
155-705015-OL 2-12 L 250900-51 1~39 ~132 Ib00P1-81 L~)I- 31
211-105015~01 2-12 250000-62 2-39 -123 268025-9 2-11- )6
19 2~19 ~123 26001~ I-39 -1)
251´•)0101)-0) 2-IL -80 IIOP00-18 2-39 .133 260026 ´•IS
155-705015-05 1-72 8L 210000~79 1-39 -13) ILODI(,-lOf 1~(1- 78
250000 2~31´• )5 150000~80 2-39 ´•L)L LOZ 2-*1- 18
110000 2-39-112 P’iO0OO-BL L~)9’L(P 260026- 103 P-)l- 77
250000-138 P-39-L33 210000-8) 1-39 -1)) 260026-10) 11
tS0000-1)9 2-39 -133 250000-85 1-39 -L)) l60D2b-IOI BI
210000~1)8 2-39-1)0 2~0000-9 2~39 -L25 260026-108 2-)1- 8)
2588O8-LI9 L-39-1)0 150036-1 260021-109 2-)1- 85
ZS000a‘LSO 2106 26002I-110 2‘11 85
210000-191 L~39 ~121 2510 L-65~ 31 2~0)26‘Lll
250DD0-lb3 1-3’) -L 3* 1533 2-61- 3Z 160026-112
250D00-L6) L -39 -L)6 ZbC1BO 2-25 -LBLI 110326-117
Zr00o0-lbS 2600-LY I-Il -IZO 160026-LZI Z-)1~ 63
PIODOO-lb6 P-)9 -115 L600-2Y 1~15 ~1LO 2600)6´•1)7 62
Z50000-L67 2-39 -135 260025 9 Z60026-L3 1-)1- 65
2-39 -116 2b002L-13) 68
150000~112 2-39 ~115 )L 160021.1~ -65
P50000~L16 2~39 ~119 Lb00P5~101 2~(1- I2 260026´•111 t~ll- 69
260025-108 IZ 260326-112 69
I50O00-18 1-39 -129 I60021-109 L-)I 5L 2-(1 lo
250000-19 1-39 -129 260025-it 2-(L -18 2bOD26-l~’i 2-)1- 70
~50000-190 1-39 -L’II L~0015-110 Z-II -IL Z60326-15
250000‘L91 )´•3~ ´•1~7 P60011´•113 2-~I´• 26 ZboDZ*.16
210000-2 2~39 -128 260025-111 L~)1 Zb 160326-L7 Z~91 IZ

5´•24 Revitiod: 2H Novambor 1084

 ILLUSTRATED
OULFSTREAM Section III
COMMANDER PARTS CATALOG
Numerioal Indel
ssoA/aeoa

d R T FltURE P d R r FIGURE P L R r FIGURE

P
C INDEX L INDEX 4 INDEX

E R HU*8ER N U B E R NU*BER N U W R E R NU*8ER

N U B

.71 210059~1 3ELR18-2 L´•1~59

P‘II- 58 26006L L-ll- 85 3123I2-1 1-1-68
ZbOo26~)1
2160026-~8 )-II- 58 260D61-LO 93 3EL0)1-1
80 lb006L‘11 2´•(I~LLP 308LOI2 RED 2~32 L1
26002b~bl
2-11- 80 L‘OL -90 300-1-2 Z-ll- LI
Ib00P6-62
11 Z-IL -90 300- 8-2 2-71- 35
260026-71
P.(L -II 260061-5 2-11‘ 91 300001 P-SD
~b001.-76
2-)I- 7( 260061-6 91 300001 2-51
268026-11
Z100bl~l Z~9L 92 308DDI
160026-78
260026-1’1 2-(L 260061~8 92 30DDOL
260026~80 Z-II .73 2600(1~9 I~*L ~93 )00001

260026-81 L-(l- 75 260064-L P-)I-L00 30POOL

P-It -75 t~0(16)-1 2-)1-100 300001 2-45
260016-82
260026-86 64 260068-1 2-41- 99 300001
260016‘93 56 99 3OODOL
P-)I- 19 260069-1 2-(1- 95 )00001 2-58
160DL6-91
2~00L6-9b PL0069-P 1-1- 95 )0000L 2-99
260026-97 2-)L -83 160012-1 BZ 30o00L 2-b0
8) Z~)L ~8Z )00001
Zb00PI 2-11- 260074-1 Z-II -68 300001 2-61
Lb0011-L1 2-~L 15 260074-2 1~)L ~68 300001 1~63
Zb0DPI-IZ 2-41. 11 260075-1 I-(L -67 300001 2-6(
)-II- 1) 260015-2 ~-(L -67 3029-5 2-6(- 1
260027-19
260027-20 )-II- I) 2-61- 26 303 I-IS -113
2-41- II Z-bl- 32 30)00-128( 2- 5 -1O
2‘)1~ L( Z69-P-ll)~ll) 37 301538-6 2-25 -1Bb
260027-2)
260017.15 2-41- L5 2‘(1- 30 305538´•6 L~25 ~139
260027-16 2-41- 15 27)26 2-34- 30 )I-OLIB-l 8
260027-3 2-)L- n651-01 2-(3-108 310019 1-53-
1-(1- 5 21651-0* 2~)9 ~9L )10019~11 8
2600L)-)
260027-5 6 27651-01 2-49- 99 31ODL9-15 2-53 -10
260027-6 2-(1- 6 2789 2-49- 9) 310D19-16 2-53 LO
1Z 2789 l-(P~LOD 1~63 6
260028
~-(-LZ 28302-10 2-71- 6 310019-18 P-91- 6
260029
260029-3 1-1-13 2835’18 2-*1 -136 3100L9-19 2-53 LZ
2b00P9-5 P835IC 2-)3~ 96 1IODIP‘ZI 1-53 -12
2-(L‘*8 281 2-25- 9 310019-13 P-53 I
Z6OO3J‘1
ZL00)5~P I-)L ~)B PBI )1 2-53 7

2600)5~501 I~)L ~50 2900051-525 2~)3 Zlb 3100L9-25 2~53 LI

260035~501 50 1(1 310(119´•PL 2-53- II

2L0036~1 2-68~ 85 3LOL)19-27 2-53 ~11

260036~2 )I 3LD019´•29 ~IZ

26001)-1 29510L-3 2-L9 5) 310019-31 LI

260037-2 )-IL -46 295102-3 2-19- 51 310019-37 2-53 9

160011 2-4L ~10 295L0)-1 2-L9- (b 310019-19 2-53- 9

260842-25 -23 195105~L )10019‘)1
Ib00)Z-26 2-41- 23 295106-1 1-19- 52 310120-15 2-53 Lb
2600(1-53 s~)l .25 51 3L0020~16 2~53 -1~
260042-55 2-)1- PO 2916002-1 2-24- 53 )1OO2O-LI 1-53 -13
1600)2-56 L-~l- PO P976001~1 P‘~)- )9 110020~18 1~53 ~13

260011-57 2-)1- PI 1976009-1 2-LI- 9~ 310020-19 2-43- 15

160042-58 PI 1976100. 1 3LDOZ0~21 P-SP
2L00(1-59 22 L~I(’ )P 3LD020~22 2~1)- 14
2´•~L 22 297900L~I 35 310020~29 2-53 17
2690)3 2- S 71 L1~9001-1 310010-21 2-5) 17
2600() )´•)t ~)O 1919008~1 Z8 L~53 -15

~600( 3-19 3) 1979009~1 2~2)‘ 17 310020~17 2~53 ~18

3) 30 310010-29 1-53 -11

260013-) 2-)1- 52 2979011-1 2-2)- 25 310320-31 2-53 18

260013-33 I~)L ~1) 2919012~1 69 3L0020-33 2~5)‘ 15
26001 3-35 Z-)L -35 IPlsOl)~L 38 310020-35 P-S3 -Is
140018‘1 L-ZI~ 60 297901)-1 310020´•31 L5
26005 L-L Z-~I 81 3-916 P-b9 PI 3L0020-5OI 1-53 LZ
260051-2 2-(1- 88 2-69- 27 )IDDP1 2-)9 -67
260051-505 2-11 -87 301495-02 2-25 310012 2-(9- IZ
260051-506 2-)L -88 3E1150-10 2- t -70 310023 1-~9 -79
Z~)I .123 3E1271~1 P- I 65 310023 ~‘53 21
160057-501 )E1397-1 2´•1- 12 )IOOL3-ll 2-13 -25

HaviJed: 2X November 1984 S-25

 IILUSTRATED
Section III PARTS CATALOG COMMANDER
Numerical Inden
680A/BgOg

P L 8 T FIGURE P L R T FIGURE P e a r FIGURE

E INDEX L INDEX E INDEX
N U II B E R NUIIBER N U n a E a HUNBER N U n R E R NUIIBER

)101)23-~ ~‘1)- 25 3100(1-511 1~53 310112-5 Z-5L 81

1100~3-5 1-11- 16 310012 310112-51) 1-51
11002 )-1 P-5)- 17 )10052 2-10~ 6) 11DLll~b 2-51- 83
31001) P-IP 8) 310052-11 I-Il -IOI 110173 L-50 1
31O0ZI-LI 2-53 -)Z 31(1052-1) 2-25-105 )10173-11 1-40 b
31002(-L2 2-53-)2 310012-15 2-50- 64 )10113-18 7
31002(-13 2-53 31 31005) 2) )ID113-L1 2-59 5
31002)-L) 2-5)- 3) 3100)(-15 )-11- 30 310113-3 )~)O 3
3L0024-l5 1-53- 36 3100)~-)3 ~-51- 11 3L0113’5 1-10.
310024-16 I-53- 36 3100)1-31 2-11- 12 310L73-5 L-5L -L11
3L0021-21 1-53 -33 31001)-39 2-51- 3) 310114-1 2´•51- 52
)10021-(1 1~53- 29 3100)1-(1 Z-)I- P) )LD11~-3 53
310024-43 18 31005)-*2 )~11- 25 310175-4 1-51- 81
31001)-501 310051-13 2-51- LP 310176-1 2-91- IP
3L001)-51 )-1)- 30 31005)-403 1-5I‘ PO 31017b´•2 2-51- 80
3L002)-52 2-53- 30 1100)5-19 1-52 6 )10118-50L 1-5L -12
31002)-43 1-53 -35 310055-20 2-52 6 310179-3 2-51- )1
310024-55 1-5~- )9 3L0055-503 I-11- 5 310L8O-1 1-11- 15
110024-51 3L0060 I-Is-ID 3IDI80-2 2-51- Ib
~L(1021-59 2-53 -38 )L00b0-13 Z-5)- )9 3L0181-19 L-5I- 119
1~13‘ 31 )10011 Z )LOIBt‘ll 66
)1002~-8 2-13 -)1 310011-10 1-53- 3 310181´•3 2~51- 71
310025 L~)3- )1 310071-11 2-53- 3L01B1‘J3 L~51- 67
310025-11 310011-12 2-53- 310L8L-35 2-51- 64
)100~5-LP t-51- )1 110011-3 5 310LBl~)t, 65
IIO025-14 I-53- 11 3L0071-5 5 3LOLBI-31
31(10L~-15 2-53 -~B 310071-6 2~53‘ 5 310181~39 1-51~ 68
310015´•11 2-53 -42 310011‘1 2´•13- 5 3L0181-)5 2-)L -59
310025-1 2´•53 I3 3L0011-9 I-Is 3 )1DLll-)9 L-5I b0
310011‘1 1~53 31007~ 1‘)~ ~10B 1-11 ~111
110011-9 2-53- 1I 310018-1 2-13- 52 3L0181-50 I-51- 61
)10018 1-16 -109 910018-2 2-51 IZ 310181-505
110028 2~13 ~5Z 3L0081~1 II 3LOLB1~507 I)
3LOOZ8-L1 2-53 -68 310085-2 2-52- 11 )10181-8’)
1~13‘ 51 310118~10 LO 2-5L -10
310028-16 2-53 -57 3I0II8-I5 2-53-21 310181-91
110018-19 L-ll- 62 310118-11 2-)3- 21 310181-97 2-51- 13
310028-11 2-53- 61 310118-19 1-53- Le 3LOL82-I 1´•51
3L0028-23 I-53- 55 3~0118-21 2-53- 19 110182-1) I-II- I
110018-21 2-13 -51 3IOIIB-2I 2-51- 19 310182-1 2-5L- L
3L0028-25 2-53- 58 310118-50L 1-53- LB 3LD182-7 2-51- 3
310028-21 2-13- 59 3L0LI8-7 2-53~ 21 310L82~8 2-51- 3
)10018~28 2-51- 59 319118-8 L-53- 22 310182-9 2-5L
310018-29 2-53 -(O 310118-9 L-I)- LO 3L0181-1 L~)O- bl
310018~3 2-5)- 53 1101113 2-53- II 310183-5 2-50 -68
31POZB-31 2-53- 5( llOLL9-ll 1-53- 2) 310L83-1 1~50- 68
310020-)5 1-53- 56 310119-3 13 11018*-3 1-10 8
310028-39 2-53- 64 310119-1 1-19- 23 3LOL8)-* 2-50 9
310018-)1 2-53 -65 310119-9 1~53- L) 310185-1 Z-5L 3
I-1) 66 310140 2-85 ~160 slOlBS~L1 9
310D28~)b 3LOL10~1) 2~)5 -16* 310185-13 L‘I1~ 10
310018-’L7 L~5) 67 3101(0~15 31DL 85~15 1‘5L IL
310928-)8 P‘53 -67 s101(0-)(1 2-55 -L66 3LOLBS-l7 L-)L ~Is
310028-~ 2~5)- 63 310140’27 1~52 ~59 310185-19 L)
3~0039-19 1~53 1 310110-28 2-52- 60 310181-21
3100~9‘15 2-53- 1 310L10~29 2~15 -167 310185-2) 18
31001’)-11 2-53 2 3101(0-5(11 2-51- 58 )1DLBI-Z’j 5
310039-)3 2-53- f 310140-8 1-55 -Ib) 310L85-3 19
310019-45 2-53 Z 3101)0-9 2´•55 ~Lb3 3L0185-3L 2-51 LI
310039-)7 1 310159-11 2-10 bit 3LOLB5-)3 2-51- 11
310039-513 1-53 3LOl69-ll 1-52 9 31O181-31 )~11- Lb
310039~515 2-53 )10169-13 9 310185~37 ~15
3100)0 Z~55 -238 310169-L7 2~12 9 310185~91 )~18 II
3100(0-31 2-12 -71 3L0L69-503 2-52- 8 3I0I85-39 2-51-
3100)0-39 2-52 11 )10110-’101 2-52- L( 310L85.) 2-51- 1
310010~511 1-51 ~13 310110~502 1I 310LD5-7 1‘11
)IOOI0-5l 2-52 16 310112 2-52 -LLO 310185-9 2-5L 8
9100)0-55 I-ii 11 3I0IIL-3 2-5 L -1LD 110186- 1 2-)1 )5

3-28 nevised: 28 November 1984

 ILLUSTRATED
OULFSTREAM
Seotion I11
COMMANDER PARTS CATALOG
Numerical Index
880A/B808

b T FIGURE P I R T FIGURE P L R T FIGURE

P R
L INDEX E INDEX L INDEX

a NUnBER N U n B E a NunaEn N u n a E a NURBER

N U n a E

310)82-55 .1D 310385‘~5 ~‘´•15 -IIZ

)LO1RI-L1
310382-)6 2~55- 10 L~55 -I’L3
L~51- )1 3I0382-5I 2-95~ 19 1~52
310186-11
2-51- )1 310182~58 2-55- L9 310)85-5)5 2-52 )O
310186-19
t~51- 12 310382~59 )L0385~))7 2~5Z
31018~‘21
Z~LB-1B 2~55‘ 1 310385~))’1 L~52 )O
3L0186-25
3L0382-61 1 310385~5)1 2~52 II
-)1
2-51- )b )10382-62 2-45- L 310)85-5)9 2-52 -*O
310186-29
P101B6-3 3L0382-6) 2-55 2 910s84-451
)O 310382-6) 1-55~ 1 310)85-7 2-5~´•130
910186‘3) I-ii )9 )30382-65 2-45 12 31038)-8
2-18 LI 310382-66 2-55 Il )10185-85 2-52 (1
310186-35
36 31038)-6) 2-54 -11 310385-81 2-52-
)10186-35 2-11-
2-51-47 3L0381-b9 2-55 310184-87 2-42 -13
.10186-41
2-41 39 )10382-1 2-55 31 310185-89 2-52 I)
3LOL86-5)
38 3L0382~10 9 3L0)85-9 2-55 -111
31018~-1
310382-11 1‘5~- 29 310)85.95 II
)10186-9 L‘51-)9
II 3I0382-8 2-45- )1 310385-91 2-52- O
310L87-501 I~SL
II 1~15 -~Z 3L0385-99 II
~11)191-9
2-5L 11 310382-89 2-41 B 310386-Ll 1-51 -37
3L0189-1
IB 310382-9 32 )10)86~11 2-52 I9
PI0I89-2 2-51
1~55- )10)86-18 1-S2- 38
31019L-ll 2-51- 57 310382-90
310381-95 2-55- 6 110386-18 2-12- 50
3L019L-ll 1-51 -55
~-LB- 35 31038) 2-21- 58 310)8t~-t3 2-5’1 -122
)L019L-3
)10)8) Z-51 31038~-3 2-55
310191-3 2-41- 58
2-18 -)5 310383 II0)86-)) 2-54 -IZI
3I0I9I-I
3LO)Bb-17 2-42 -IO
3101P1-I 2-51- 58 )10383
3L0383 Z~SI 3LO)Bb~39 2~55 ‘1P5
31019 L-501
2-53 (9 310)89 2-5(1 310386~) 2-55 -12(
310319
2-53 50 310383 2-55 )L0381~(0 2-51 -126
310319-3
)L0183-211 2-52 -LOb )10986-I3 2-52 39
310)19-5
)L0383~11) 2~52 ~L06 P‘52 ~51
310)19~1 2‘53 ‘50
2~5)- 32 310383-P)1 2.52 -L07 310)81-Ll 52
310182-10
)I 310383-2)5 L.SZ~ 3 310)86~)L5 2~12
)10981~101
2-55 -16 310383-246 2-52 3 3L038~-5L5 2-55-119
310382-11
1-42- Z 310386~517 2~51 18
310382~113 I-IS 27 31038)~L)l
P~55 16 31038)-218 2~52 2 31038L-511 ~L19
310382-115
3~0383-119 2-52- 1 3L0)81-IO ~80
310382-123 2-45 3
1 310)~F11 )-55 93
310)BL-L25 2-54 3 11031)3~25L
2-15 11 31038)-3 L-IL 1 310)87-13 2-55 BL
)10382-127
2-55 Il 310383-327 2-52- 281 310)81-1) 1-55 BZ
310382-128
1~52 91 3101111~1) L~55 83
310)82~13 1-55 15
P5) 310)BI´•L6 L~51 84
3L0382-1)3 2~55 6 310383-5*1
2~51-131 310)81´•11 2-55- 85
110382-135 1 310383-83
2-55- 31038) 2-55 -180 310)87-18 2-55 86
)10382-1)6
31038(~10 1.54 ~iBZ 31038)~19 89
310~82‘1)9
2-54- 20 3103Ll~-13 2-55 -181 310)81-11 2-55 81
)10382-1*
)1038(~139 11038)~23 De
310)82~17 2-55 ~33
~-52. )3 31038)-19 P-5’1-18) )10381-3
)10381-LB
2~55 ~185 310381~1 L~55 PZ
310381.19 13
3L0)81-39 Z-51 -LBb 3L0381-~1 2-55 16
)L0381-20 2-95 -13
3L0)81-517 2-5Z 3L0381~)9 L~)S 96
310382-21 2~55‘ 21
2-45. 21 310384-)9 2-55 -181 310)87-509 2-51 -109
3LD)82-21
2-55 ~LBB 310)87‘509 2~55 I)
310382-~9 2~55 310381-8)
31038)~85 .189 310)81~11 1-55~9(1
310381~31 2-55- Z(
2.5) 24 3L0381-9 P-55 -L81 310381-15 PI
310381-13
3L0385 L~55 -121 31038)~56 P-55- 95
310382-3( 2.55
18 3L0385~10 L~55 ‘133 310381~61 2~51 ~110
310382-)5 1-51
5 310381-L01 2-52- ~Z 3I038I-b3 2-42 -110
310382-31 2-15
4 3L0185~L5 L~45‘L3) L~55
28 3L0385-16 2-54 -135 )10381-1 2~15 ~11
)LO)BZ-39 2-51-
2-55 30 310384-17 2-55 -136 310381-8 2-55 78
310382-~3
310385~19 1.55 ~137 310)81~9 1~55 19
)10381-II 2-55.)0
2-55 -3( 310385-21 3LD)BB 2-52 II
310381-15
2-55 ~3) 310381~21 2~55 ~139 )L03BB~3
310382~)6
2-55 -II 310385-25 1-55 -II0 3I0)88-I 2-52 12
310)82-19
2-55 3L~385-35 2-54 -1II 3I0388-l 2-52 1)
110352-5L1
2-55 310385-)3 2~55 ~111 310)89~10 1~55
)10382-113

Revised: 28 November 1984 3-27

 ILLUSTRATED
OULFS’I~EAM
Oectian In PARTS CATALOG COMMANDER
Numerioal index
880A/B80B

P d R r FIGURE P 1 R r FIGURE P L R r FIGURE

6 INDEX i INDEI C IHDEX
N U n B E a NUIBER N U B E R NUWBER N U B E R NU*BER

)1038’)-11 2-55 310395-~5 2-IL -1~7 310)00-8) 1-51~ 29

310389-12 2-15 -1~ 110395-)6 2-52-128 310100-81 2-52 -17
310)89~13 39 ~129 3LO(00-87 ~‘5L LB
310389´•´•15 2-55 -’16 310395´•~8 -L3D 310(40-87 1~52 -31
3L0189-37 1-55 -51 3L0395-)9 2-52 ~111 3LOIDO-BB 2-51- 11
)I038P-5 2-55 -41 310395-50 2-52-132 310100-88 2-42 -93
1-52 -1)5 310395-509 1-92 -LI1 3L0(00-89 2-52 -30
3L0389-409 2-54 38 310394-49 2-52 -Lt1 310(00-9L 2-52 1)
310)84-6 2-55 -)B 310395-60 1-52 -118 )10100-99 2-15 -115
3LD389-9 2-15 )2 3L0394-7 2-42 -Ilb 3L0(01-ll 2-55 -111
11039(1-10 2-55 -11 )103’)5-9 2-42 -L33 310((11-13 2-55 -115
310390~11 P‘55 55 310196 ~‘55 3IO(OL-19 2-15
)1(119(1-12 2-54 -56 310396-13 1-55 -LZI 310(01-16
310)90~L3 2~55 ´•)7 )L0)9(1‘15 11 2~54 ~171
)103’10~1´• 2~55 ~58 310196~11 2~55 ~128 310)01~18 2-54 ~I)B
)10390-15 2-14 -59 310396-19 1-55 -229 31010L~L9 2~51 -119
310)90~1b 2~)5 ~60 1~52- 10 3LO)Dl‘ll 1~55 ~IBO
310390-11 2-55 -61 310396-503 2-42 -69 310101-3 2-55 -168
)10390-19 2-45 -69 110391 2-55 ~13’L 318)01-4 2-54 -II9
310)90-21 2-55 -63 310391-11 2-55 -137 3L0)01-’i 2-55 -110
1‘55 )L0391~21 1) 3LD(01~101 61
310390-L5 2-55 -62 )L0397-P3 2-52- 73 3L0(01-101 2-59 -161
310390~29 2-55 -67 310397-3 2-55 -215 310101-7 2-55 -171
3L0390-39 2-55 68 310397-503 2-92 )1 3L0)01-8 ~‘55 -112
110390-41 2-15 -66 3L0391-5D5 2-52- 11 310)01-9 2-45 -113
310390-15 2-51 -108 310191-7 2-55 -236 3L0)02-L L
310)90~)05 310398 3L0)01~L3 2-55 -15)
310)90-101 1-55 -51 310398-21 Z‘1IZ- 58 3L0)02-15 2-55 -153
310390~55 2~15 7( 310398-12 P~91‘ 58 310)02~16 2~55 ~15)
310390-57 2-51- 65 310399-25 2-52 -55 311)(02-11 2-55 -155
3L0390-59 2-45 -72 310399-26 2-52- 46 310101-19
310390-60 2-55- 13 310399-3 2-52 -57 310(02-20 2-54 -151
310390-63 2-52-108 310399-509 2-52- 1) )10)02-31 2-55 -160
310390-65 2-55 -52 310100-101 1-55 -111 31D(DP-5 2´•~5 -III
310390-7 2-55 5* 3L0(00~11 2-55 99 310)02-509 2-52 IZ
3L0390-11 P~51- 53 310)00-117 2-44-109 3L0)0I-509 1~55 -1II
310390‘9 2-55 10 3L0100-119 2-51-110 3L0(02-51 2-55 -158
110391-17 Z-5L -ID 310100-121 )-51-107 310102-52 L-95 -159
31039t-L9 2-42 -10 2-15 -108 310(01-6 2-55-1)8
310391-11 LD 310)00~13 2-15 -100 310)02-1 2~51-L)9
310391~505 2~5P 91 3L0~00‘13L 3) 3L0(02~P 1´•´•55 ´•150
3L0)92-ZJ 2-52 -6L 3L0)00-I) 2-5) -10I )10103 2~52 -22
310392-21 2-52 -61 310)00-111 2-55 -111 310(0) 2-45-115
310)s2‘’101 2-51 -60 310)00‘15 Z~)) ~L02 310(01‘11 2~52 ´•2´•
310393 2~5Z -108 310)00~1b 1~15 -103 310)03´•´•13 P~5L ~13
31039)-1 3L0)00~19 Z-5’1´•LOI 310)03~23 1~55 ~L1B
310393~9 2-52 -109 310)00-21 2-95 -105 310)0)-27 2‘55 -116
31039) 310(00-21 P‘SS -LO~ 110(01-)5 -LII
31099(~11 P~5Z ~131 310100~521 2-52~ Lb 310)03‘17 2‘~9 ‘119
2-51-135 310)00´•521 2~95- 96 310)01´•)’) 1~)2 -25
3L039(-ZI 2-51-L35 3L0)00-423 2-52- 1) 310)03-~1 26
310391´•11 1~52 -131 )10*00~523 96 310101 1-55 ‘190
310391-~1 2-52 -111 310)00-53 31 310)0)-10 1~55 -L93
310395-18 2~5L ~ILL 310100~1) 2~52 ~16 31010(~11 2‘55 ´•191
310)95-29 2-52 -113 310)00-5( 2-52 -96 310(01-13 2-51-195
310395-30 2-52 -113 )10100-71 2‘51-L13 1ID)DI-) 2~55 -191
P~52 ~LI) )10100‘18 1~55 310)L)(-~ L‘5Z
)10191~12 310)D0~79 2~52-17 310)01~503 2-51 b)
)10395-33 P-52 -LL5 310)00-79 2-52 28 31D1DI-b 2-52 65
1-51-115 310100~79 -35 310101.1 2~55 -192
310111-31 2~52 -119 310)00-79 Z-5~ PR 310101-8 2~55 -191
)10395-38 2~5Z ~1PO 310100~80 2-IZ -15 )1D(OI-P 2.55 ~193
3103P1-P9 2-52 -I2L 310)00-80 2-52 -30 310(05 2-55 -195
310)95-~0 1-52-11) 310)00-80 ~-52- )3 )10)~5-10 2-55 -198
31D3P 5~)1 -113 )10100~80 2~11- 97 310105~11 -1PP
2~52 -L20 310)00~81 21 310105-13 1~55 ~200
2~52 -121 3L0)00-82 2~52 15 310~09-19 2~51 66
2~52 -126 310)00~81 ~‘52. 32 310105-3 ~196

3-28 Hsviscri: 28 Navnmbrr 1084

 ILLUSTRATED
GULFSTREAM Section III
COMMANDER PARTS CATALOG
Numerical Inden
680A/B90B

FIGURE P d R T FIGURE P 1 R T FIGURE

p I R T
INDEX C INDEX INDEX
N u a E a Nu~asR N u n a E a NunsEn
n u n 8 E a nun8la

310111~22 2-52 ~82 3L0)2).5 )~51- LB

)-52. 65
2-50 39 )IDIP(-~ 2-52 L9
2-52 66 310117-2)
2~41)‘ 38 310)2)-1 1-5L 20
310(01-1 1-55 -IPI 310)17-25
)10117-27 I-I0- 19 310(1)-e 2-52 ZL
310(05-8
2 310)26-3 2-52 ~58
)LO(OI.P 2~55 ~L98 310118
-229 310*LB-103 L-IO )5 )10)21 L-IL -61
)10)06 L-5I
L-15-233 110)18~113 36 )10((3-10P 2-51
3L0106-ll
3L0)18-115 L-IO -37 )1[1(13-11 2-51 96
3L0(0b-L3 L-55 -13)
310*18-111 1-50- 26 310()3-LL1 2-51- 91
3L0106-15 I-Il -69
2.55-230 3L0)18-ll9 2-50- 26 31003-11 1-51- 97
310106-L5
310(18-119 2-50- 36 31003-13 ~-51- 81
310)06-´•j01 2-52 -68
1~)O ~(Z 3LO)()~LI ~98
310(06-7 P~55. 231 )10118-131
LO P~51 ´•99
31010b~9 2-55 -231 3L0)18~L39
310)18-L)O l-50 -(8 310(0-P3 93
)10107 1-55 -Z11
310118-1)3 1-50 ~(1 2~51 ‘102
310)01-L)
1-55 -226 3L0)1B-I(I L-IO- )O 3101)3-31 2-51 -101
110107-LS
2-50- L2 31003-)3 L-51 -LOO
310607-L9 2-52 -68
-22) )LOllll-1~9 ~16 310)~3-19 2-51- 89
310*01-19
2-)5 -222 3L0118-150 L-I0- 52 310((3-)1 1-51 86
)10101-3
2-55 -223 )LO(II.1SI )-)O 11 310(13-)3 P-51 88
310)07-5
)LOIIB‘L´•II IP 310))3~503 L-5I ~8)
310(07~50L ~61
310118´•153 1~50 ~10 310)(3~505 -83
)10)07-6 2-15~213
2-’12 7 )10)18~155 L~IO- 60 310)(3-101 1-5L -83
)L0109-1P
l-5Z 8 310118-L57 L-~O- 18 310)))-)09 1-51- 83
110(09-31
310,18-159 L-I0- zs PO
310,09-511 6

1-52- 9( )10118-161 2-50- L) 3LDO)-5) 2-5L -101

3LO)LO
3IOtl8-L61 33 )‘11 ~105
3101LO~’IS L‘51 .96
1~5L ~96 310118~1bl 1~)8‘ LI )10113~LI L-51 ~103
3L0110~51
L-)Z -95 310)18-163 Z-50- )1 3101)3~61 2-51- 86
110(10-BL
3L0)18~171 55 31003~b9 2-11~ 85
110)10-83 1~52. 9´•1
Il 3L0))3-7l 2~3)- 32
)10110~85 2-12 ~91 )10(18~113
310118-17) 1-50- 1) 3L003-ll Z-ll- sZ
llO(LO-8b 2-51- 98
1-52- 99 3101L8-175 1-50- 18 )1011)-13 2-51 -LDb
3LOILO-87
99 )L(IIIB-lll 2-50- LB 3LO)I)-75 91
)10110-89 2-52
L-50- 31 3LDO)-19 1-51 95
)10IL1 1-15-200 310118-119
310)18~13 2~50 )L 310))3-11 9)
)10)11~101 2~15 -213
2-55-205 31011~-1) 2~50 -57 )10)1)-83 2-51- 88
)LO)11-lOl
2-55 -201 310118-15 2-50- 29 3101()-87 2-51 -103
)LO*LI~L1)
2-55 ~10) 3LOllB~L6 2‘10- 59 )10(~)´•89 2-51 ~lol
310(11-13
)LO(1 L-19 I.)5 -20) 310~L8-)9 2-50- )O 310)))-91 L-51 ~LO)
2-55 -216 310118-60 1-40 58 310))3-93 Z-5L B)
)10(11-21
L-I5 -211 310118~)1 19 85
310(11-21
31D)ll-lb 21-55-206 310)LB-)Z L-)o’5b 310141~95
1-55 -)11 )10(18-51 L-IO~ 27 310)))-91 ~9)
)10(1
‘215 310(L8~58 6L 310)(3-9s 1~51 ~IO’i
)IO)LL~ZB
2-55-101 310)18-63 I-’10~ 23 3!0)6( L~50
)10(L1-31
310)L1-)2 1-51-1011 310118-65 20 310)16-15 2-50 t
Z-IS -109 )tO(lB-~b 20 310111~5 2-50 L
310)1L-3~
310( L 1-3. 2.55 -210 )10)18~85 1-1O~ 32 IlOb)l~L 2-51~ 5)
310(LL-35 ~.55 -211 310)18-86 2-50- 33 )10103-503 2-52 -105
310)11~39 2-55.220 310(18~93 C50- It 3L0101~50) Z~’iP ~L05
310)L1-(0 1-5´•1 .PZ1 3L0120 Z-52- 82 310)0(-1 2-52 -89
310(L1-0 2-55-PL2 310)L0-1O L-52- 80 3LOIO)-2 2-52 -90
310)11-501 1.5L -67 310910-11 1-52- 83 310105-1 1-52 -53
2-55-2L8 310120-12 1-52~ 8) 310105-1 2‘52
310(L1-8)
310(L1-87 2-55-119 3101L0-9 1-12.8) ~107I)6-1 1-52 -16
310(L1-99 2-55 -P01 310)21 Is 3L0106-2 2-51- (8
)10(12 1-52 -8) 3L0122-501 2-51- 80 )10107-1 Z-SZ -)5
-86 310))P-502 80 310707-1 2-52 ~)1

3L0(12-5) 2-12 86 3L0123-L3 )B 310107-501 )~51 -)5

310*LL-IS P~52 -87 3LO(L3‘1( ~IOlo7-lIOL )-)Z ~)I

310)12-56 2-52 -88 310113-15 2-55- 36 PLO7OI-5D3 I-ii -15

310(12~59 2~5Z ~85 310)23~16 36 310101.501 )1
1-52 -85 3L0)1)-5 Z-55~ 37 310110~1 1~52
310)15-50L ~‘51- )B )101)3~503 35 110110~2 ~61
310(11 1-52 78 310123-50) 2-55- )5 )10111~L 62

310(11‘13 1-50 ~38 11(1)23-6 2-55~ )1 ~10111-1 62

3LO(II-ZI 2-52 -81 31012)-LO 2-52- IL )10123-1 I-5L -8L

ReviRed: 28 November 1884 5-28

 ILLUSTRATED
GULFS’I~EAM
Section IU PARTS CATALOG COMMANDER
Numerlcsil index
apoA/asoe

P I R T F1GURE P R T FIGURE P L II T FIGURE

E INDEX L INDEX E INDEX
N U Il 8 E R NU*BER H U n a E a NU*BER N U n a E R NUNBER

3L0717-1 320001~)1 1) 3)DORS-~3 1-19 18

310127-1 2-51-L*5 320001-53 Z~ll- 3) 330086-505 2.11. 1
)10717-L 1-55 -161 )20005-61 P-5(- 11 330085-506 2-L3
319121-2 320006 Z-51~ 10 3s008b Z~L3 -1)
)1D1ZI-~ ~I)L ~2000b´•3 L‘5)~ 2) 330081 1-13 ~19
)LDI1PZ )-IS -lb2 ~LO(IOb-31 ZL 3)0081-5 2~1). II
31DILI-50) 1-55-118 32(10(1~-11 L~I)- L) )10088 10
)1D1PI-SD) 2~55 -11P 320006- )9 2-54- 16 330093-105 ~-13- 7
3L0136 2-52 -99 310006-4 2´•5)- 2) 130093-10(1 2-13- 1
310)96-109 2-50 LS )2000b-)I 2-5)- 32 330016.505 l-L1. I
)10~36-110 2-50 -53 )20006-(3 2-51- 10 33O0P(-SOL 2- Il 7
)10136-31 2-52-100 3L0006-~I 2-55- 3L 3)0095-101 2-41- 9
310736-32 Z~5L -100 11000b-)9 2~)1- LI 330395-501 L~(1 8
110136-33 2~51 -101 110006-5 2‘4)- 11 33001)5-503 LO
310716-35 Z-II -L03 320006-51 2-5(- LI 130095-10)
)1013b-)b 2-52 -103 )20006-6 L-5)- 18 330108 2‘60 ~ls
318716-37 L-SI -10) 320006-9 2-5)- 29 130108 2-60 -91
310136-38 2-51 -1O1 320011-503 L-5(I- 16 330L08-35 2-60 -)Z
)1013~´•39 2-12 -101 310011-501 2-5)*- II 330L08-(S 1-60 -19
31013(1~)0 2-11-102 320011~509 Z-5)1- LI )5OLO8-5 ~-52 -139
3101)9~1 2~15 -1O )10011~111 13 33DL08~509 1-SI -131
)LOI)O-L 1-55 -)9 II(IOL2-1 11 s30108~109 ~‘)2 ´•1~9
1107’)0´•2 2-55 -50 3200L3-L 2-54*- IS 3)0188-51 2-51 -150
3LDlll-1 ~L0018 58 13010(1´•7 2-)1-138
3LO7)4-1 2-55 -)L 310018 2-))1 318159 2-60- 10
~L01)5-I 2-52-136 320018~15 2-5)1- 25 330109-59 -29
(I07I7-I ~-IL -IZ 310018-17 I-S)*- 21 3301 09-60 1-60 PS
3101)8-1 2-51 -L09 3~00L8-18 )1DI 09-67 2-6D -28
310119-L 2-51-LO8 310018-19 2-5)6- Z 3)01D9-b9 1-60 -19
2~)1-101 310018~21 L‘5)1~ )30109-70 Z~bO ~)O
310759-13 2-52 -161 320018-~3 P´•5(~- 330109-11 2-60- 1P
11075’1-5 1-52 -nl ,zoola-2S a lIalos-7, ,-60 -21
,lalaO-l 2-51‘1)6 2-5)6- 6 330101)-15
318761 2-52 -lls 320018‘19 2-27- 62 330109-17 L-bO -27
310761 2~52: -110 12001s~P9 ~‘5)L- L 3)01 09-is 2-60 -27
31(1761-11 1~52 ‘161 320018~31 L~L1- 59 33010~-85 2~(0 ~)1
110761-L3 2-12 -161 3)0018~31 i 3)0112 2~´•ib
3LOIbi-’) 328818-33 2-5)6- 10 310112 2-57
)10)(11-5 L-)2 -113 JPr)018-37 P-5)~- 8 ~)011Z 2‘58
310161-7 2-52 -II3 320018-45 L-S´•L- 26 )IO1I2 1-59
310762-L 2-52 -LIB 320018-)7 8 130112 2-68
310162-2 2-52 -lls )IOD19-1 330112 2-6L
310162‘501 I~IP ~L69 )2001P‘50L 18 330112 i~b2
318)62-582 2‘12 -119 310019-103 130111 2-6)
310163-~01 320019-101 l-5*L- PO s30113 2~60- 10
31076)-5 2-52-160 320019‘501 P-5~*- 11 330113‘11 1-60- 15
31888 1- 9 -20 )1001P‘506 21 330113-11 2-61- 1P
3L991~‘1-1 2- 5 62 )LOOIO-l )-111~ 5 13011)-17 I-bO -12
31998O-6 I- 5 -5L )10020~501 1 330113-L7 2-6L 8
)20001 1-5( 320(12L-1 330113-L9 2-60- 1)
32000’1 2-)5 -31 )IOOZL-S01 2-1(1- 9 )30113-L9 2-61- 1)
)10001‘121 6 r68- 17 33(1113~21 2-61~ 15
)20001-129 1-5(- 1 3290 1* 2-69- Ij ))011~-23 l-LO- II
320005-133 2-54- 1( 33000) 2´•j0- bll 330113-13 2-61- 9
11001)5-1)~ 2 )IOOO)-I3 L~50- 62 330111-21 I~bO- 16
J20005-139 2-54- J3009)-1) 2-50- 62 )30111-19 2-60- 12
320005~1(1 11 )30011~501 33 330113~19 8
)L0001-1(L 2-8(- 18 )30035 2-18~ (Z 33011)~)03 1
310001-15 330036-1 )~LB- 3L 330113~1 2-60 ’16
320005-151 2-I)- 11 330031 L~L8’ 37 330118-33
320005-153 1-1’1- In )IDDJB 38 330118~sl 11
320005-17 8 )30053 L-LII- (b 330L 111-)9 1-64- 1
320005-21 2-1)- 13 3100)) 10 330L1B~)DI
320001-23 2-5)- 11 33005) Z-IB- )5 330118-51
320005-25 2-54- 20 330085 2-4L-13 1)OLl8-83 3
320005-21 2-54- 16 330085-!1 2-13 -It 33DLls‘~) 1
320(105-29 19 2 2-61- Is
2-5)~ 1 130085‘33 Z 330152 1-12 ~110

S-SO ReviJed: ZB November 1984

 ILLVSTRATED
OULFSTREAM
MMMANDER PARTS CATALOG Gection III

680A/BBOB Numerioal inder

P R T FIGURL a I It T FIGURE a 1 R T FIGURE

L INDEX E INDEX L INDEX
N U ii B E 8 NUIIBER N U n B E a NUWBER N U II B E R NU*BER

9)0112-11 P~52´•15b )30207-1 L~6L -(b 368)06-1 2~58 8

)3015Z-LI L-52 -151 330208-1 L-LZ- Lb 360006-521 2-58 2
130152-11 2-51 -Ills 330109~1 51 )60001~521 I
2~52 ‘193 330212~1 1-62 ~3 )~000b´•7 7
330L51~15 2~52 -151 3)0227~1 lb0006-9 1~58 6
3)0151-3 2-52 -155 310228-1 2-61- LZ 360812-581 2-58 3
3)0152-5 2-51 -158 330228-1 2-63 I1 )6ODI)-I
330152-1 2-52 ~152 330230-1 2-~2 -)7 36001)-2 2~57
330152-9 2-52 -15* )3023I-503 35 2-57 1

330113 2-51- 90 31013~-501 1-62- 62 )60[115-2 2-57- L

330113 2-52 -139 330236-1 L-bl~ 7~ 168916-1 2-57-
330153 1-61- 96 3)02))-501 2-62 -36 360011-1 2-57- 5
L~52 ~L(’I 3)02)3-503 2-(12
-31 3b0311-2 2~57
330113-101 L-51 -1(O 3302)1 2-61- ~O 1600))-7 P~5b ~15
310313-109 2-52 -L)L 330217-503 L-~L- I 360893-8 2-56- 16
330L53-Lll L´•52 -1~3 330211-50) 2-62 )600(5 2-56
3)015)-111 2-52 -1)1 330265-501 L~61- I) 3600(1-11 2-56- 29
330153-1)3 -1)9 3)0322-L 68 2~56 30
330113-131 2-52 -111 330323-1 1-62- 73 3600)1-15 2-56 ~)I
310LS3-131 1-52 ~I(B 33031)-L 2-62- II 3(100)5-17 PO
33011)~L(5 ~91 330325~L L~62‘ )1 3600))-213 19
330L53-1~9 2-62 -98 3)(1318-1 2-62- 6) 36011(5-3 2-56 -31
330153~151 2-62 99 310333‘~ 3600(5-3L 2-5O 19
)3015)~19 9) 3303))~1 5) 360015-33 B

)30153-)5 -115 330160-501 2-6)- 9 360011-3) 2-56- 9

330153.*1 L-SL 93 350365-1 ~´•bl LO 360015-37 5
3)0111-(9 Z-S1- 9) 330367-1 2-59 LbB 360315-)1 2-56 PI
3301’13-53 2-51- 91 )30367-10 ,-le- nb ,soo~s-)s 2~5b PB
3301~3-19 3)0)67-L1 2-59- 18 1L00(´•i-39 2-56- 17
330159‘15 Ib 330361~L5 1‘59- 35 3600(1~39 2‘5b ~32

3)0159-5 2-61- 20 330367-16 L-59- 35 3600)5-(

330119-)01 2-6L- LS 3)03(11-11 2~59 ~13 3100)1-~1 b
33016) 1.18 LB 3)036)-19 2-59 360015-17 2-56 21
330Lb5-L1 L.I8 -)9 330361-2 2-59 LbB 3601)(5-)9 1-56 2L
2-18 -I9 330367-21 2-59 -3) 3(10015-5 2-56- 10
)301~1-LI I-18 -*9 2-19~ ii 3600)1~11
330165-17 2-18 -)9 330367-15 2-59- )1 960))5-53 P~5b Zb
3)OI6S-19 2-18 -(O 330367‘27 2-59- 10 36001)´•) 2-56- II
330L65-2I Z-IB- O 330~6)-29 2-59- 2L )~OD15-I 2-56- 1
P-18- )O 3303bl-)1 I-)s- 11 )~0011-9
~30L61-5 2-18- 35 3)0367-33 2~59- 39 )6161 9)
130168 1~18 9 38 2- 9-68
)30168-10 2-L8 -12 3)0387-)7 10 369876-12 5-5)
330L(8-11 2-18 -1) 330)67-)9 1~9s ~(L 36981~-9 2- 5 ~5*
330168-12 1-18 -1* ))O)L1-)l 2-59- 31 3699)9-1 2- 5~67
330168-13 2-18 -Ib 330367-93 )-S9 -36 31L-L0D-1 L-l~- 23
)30168-15 2-18 -13 330367-)5 1-S9- 2( 311E91-ll 1-12 -26
Lbl 2‘59~ IS 38E97~111 (Z
330168-33 2.18 -10 330367-19 1-59’LI )9-1 2-32 L)
LO 33(13L7~61 2~19
3)0L68-9 2-18- LL 330361-53 2-19~ ZS 39~390-L L- 5-66
)30L69 )-ls 3)0361-55 2-59- 18 )-IJN L-~l- )3
I‘I8- L 330367-7 I-SO-PI LL1ZIC1 LB
330169´•.13 2-59~ LI )LIZICL IL
33DI(’I-I) 2-18- 330167-9 2-59- 16 )IIPIC) 2-))- 25
330L69.15 l-LB- 5 )30)68-1 2-61- 17 )III6C( L-() -27
330169-17 2-18- 5 330318-1 P-bZ~ )I lllZ6CB 16

3)0169-19 1-18- 6 3362-02) )DrL-I-)I-Llb 2-73 LS

3)0169-21 P-LB 3)0000 1-63 (BrL2~)1-Bb 2-13- ZI
330169-22 2-18- 3 3(0000-15 2-6)- I )E1601-I I- f bl
310L69-21 2-18- 1 3)0000-3L 2-63- 9 IEl86S-I 2-1-62
330169-29 I-I8- 1 3(0000-J3 2-63- 7 )EIB89-P P- L -73
330169-9 P-IB- L 3)0000-31 2-61- 5 )RLX-D 1-35 -22
)30116-1 2-18 B 1-6) 1 (161-0 2-35 SO
33011~-2 2~18- 8 3)0001~1 2-6) ~10 )RII~D 1~35 ~86
)3011)1)-10I i-bP- 28 2-b)~ 10 2-35 -92
)90205-L Z‘b2 3)101 2~)5 ~17
)3OL0(1-I 2-61- 61 360006-11 P-58- 9 ~0-1P120-375 2-35 -89

Rsuised: 28 November 1984 i-81

 ILLUBTRATED OULFSTREAM
Section III PARTS CATALOG COMMANDER
Numerical Inden 680A/680B

P R T FIGURE P 1 R T FIGURE P L I r FIGURE

C INDEX 6 INDEX C INDEX
N U W 8 E R NUWBER N U n a E R HUNBER N U B E R NUNBER

100-101 1-19 65 410008-85 ZB 91

)00~1 39~18 L 110008-91 19 2-42 ~LOO

)00-13~-1BL 2-L) (L0008-93 I~(Z -11 )20071-103
100-139-138 2-1) 2-92 16 )20078-L 2-42 -Ilb
)ODZ-N 2-58- 68 110008-97 2-)2 LS )20019-1
4002-3 2.50 -68 110008~99 2-)I~ L) ’120DBO-L 2-12 ~1L5
2-19 -76 )10009-509 2-)2 -23 (10081-1 2-)2 -113
(L0008 2-42 (10009-509 2-(2 25 428382-1 I-(Z -IZO
I1OOOB-LOI ~-(2 -13 (10(115-LI 3 )PD083-I 2-(2 -111
(1001)8-1(13 2-42 -IZ 410015-9 1~(2 I )ZDD8S-50L 1-42 -122
110008-105 I-(Z Lt )PDD86-1(13 1-)2: -86
~10008-101 2-41 LO )10011-11 1~)2 ~93
(L0008-109 2-42 -31 410011-15 )20D89-1 L-)P- 83
1-42 B )LOO)f-n 2-42-146 410391-1 2-42 -82

110008-151 1 *10071-13 2-42 ‘1)8 (20392 2-25 -198

(10008-163 2-)2 -36 410071-15 120092-503 L-)2 -52
)L00(18-155 2-)2-40 )1(1(171-27 (20DPP-I
410008-L51 2-12- 38 ~10011-29 2-)2 )~0098-L 2-(2 16
)10008-159 Z-)Z -39 )10011-3 420099-1 2-42 -71
)LoODlB-LLI 2-42 -37 ~10011-3) 2-0 -I)B IZOI DO-I ~‘)Z -56
)L0008.163 (Z (10011-35 P-I1-I)6 )LOIOL-1 2-42- 51
110008-L61 2-)~ *1 (10011-37 2-(2 -118 42OL Dl~l 5)
11OD08-I6I 2-42 9 )10011~39 )10101-501 2-42 -95

(10008-L69 Z-(L -)1 410071-5 2-’LZ-L)7 )ZOLDI-l

)10008-111 2-42- 21 )10011.101 1~12-1)( )1010P-I 2-42- 59
410008-173 P.´•I -22 410071-65 2-42 -1)6 0011)-1 2-)2 -54
410008-175 ~-(P -30 410071-1 2-0 -146 )ZOII’L-l L~)L -I)(
410008-111 1-)2- )1 410071-9 1-12 -L)I (1011)-501
)10008-119 2-)2- 15 410071-9 (10125-501 2-42- 99
)L~OOB‘LBO 2-*1 LI 410072-1 I-I)- L )ZDL1B-l I-)2 -II

)10001.181 410073-1 2-)2 -118 )20L28´•501 2-12 60

*10005-L82 2-)2 -)B )ID0I3-) 2-(2 -150 12011’)-501 2-42 -55
~1000B-LB) 2-)2 -)9 )L0073-507 L-)2-1)8 ~10L30-501 ‘9~

)10008.184 L-~P 19 )LOD73-9 2-*) -150 )L0130-503 ~‘)Z 87

I1ODOB.LB1 L-~2 -50 1164 2-25 -LS3 00L33-I 90
110008-19L Z‘(P. 2’) 420018 2-43- 8) )21)13~-1 2-12 -9L
)10008.195 2-12 -25 420012 2-))- 95 (P0131-1 91

)10008-191 Z-~1- 35 (~0012-1(11 2-IP-I)0 )10110-901 2-)2- 57

110008-199 2-)2-10 420013-23 4201)1’50L 2-42 -58
(LOOO8-2O1 2-42- PI (20013-25 2-(2 -119 4101)2-1 8)
*10008-107 420013-29 1-11 -123
410008-109 2-42- II 410013-31 I-*L -I3I )tDI)S-I 2-(2 -88
)10008-211 2-(2 -25 )20013.35 110116-1 2-(2 -89
)10008~213 L-(I- IS Z~12 ~II) )101)8~1 96

)10008-213 2-(2- 36 (10015-5OL 1‘12 -118 )ZOL~O-1 2-11 -100

(10008-121 2-42-40 ~ZOOII-L 1-)2 -)O )lDL52-1 2-12 -81
)L0008-227 Z-IZ -38 420026.L L-)L -62 423154-! 1-(1- 51
)10008-P29 P-))-~9 420027.1 l-)P- 61 ~58
110008-23 Z~)Z 24 ))0028-1 66 )30001‘513 1~)3 ‘51
410008-231 l-(P )5 )10029-1 2-(2 65 ~30002-515 P-~3 13
110008-131 420030-1 P-I2 95 )30007
410008‘235 L~)Z -II IP0030~501 Z~’L2- 50 130907 1~53 -69
)1D008-L39 341 420030-505 2-13- !B 13DOL0~1(11 2-)3 -39
)10008~2)3 1‘)2 PZ 10 I300I 0-1 09 2‘0 -)L
)10008-1)5 B )20031-L 69 (30010-11 2-43 -)3
(10008~2’LI 22 ~210036‘L 68 130010~113 2-~1- )P
110008-269 Z-IZ 20 420039-1 2-)2- 15 000LO´•L19
)10008-)3 2-42 -)3 )P0O10-I 1-IZ- Is (300LO-133 1-)3 -25
410008..35 32 ~100)1‘1 Z~(P ~73 ~10010. L35 Zb

(10008~1 2-)~- 18 )L(ID)i?-l Z-)2- 12 1)O0LO-L31 1-)3 -18

(10008~515 2~73. sl IP )30010-111 2´•´•13 P

)10008-55 )2005)-501 2-)Z -7) )30010-1)9 7-)3 -I8

)20055~503 80 )39010~161 2~)3 7
)L0008.7 Z.(Z -19 120056-1 Z-~)´• 67 130010-153 2-43- 6

)10008-11 2-41- b 420051-1 Z-OI~ 64 43ODIO-I55 B

(ID008-I3 Z-~L 21 110058-1 2-42 -63 )303LO-L57 2-)3 9
(10008~7) )200)9~L ~´•(Z ~85 I30DI0-I19 ~-)3 -10
Z-)Z ))OOLL-50) 98 ´•30DLO´•lbl ‘11

5-52 nevised: 28 Novembel´• 1984

 ILLUSTRP~TED
GULFSTREAM Section m
COMMANDER PARTS CATALOG
Numerical Inden
690A/680B

r FIGURE P 1 I I FIGURE
p R r FIGURE P I R
6 INDEX INDEX
L INOEX
N U 8 E R NU.BER N U 8 E R NU*BER
U BEll NUWBER
.1...

2~)3 -56 500012.1’)3 3

I300L0-169 2-(3 12
L~)) 51 500011~P15 ~102
(30010~11 ~(1 (100OO-P93
2~13‘ 80 5(103L1-l~l 2‘)8 1
)300LO-170 2‘~3- LZ 1(000O-3b
5) 500011-LIP 2-)8 7
)30010-111 L3 1)0000~521
53 500DLZ~15L L‘(B- 5
)300L0~19) 50
2-13 ´•13 500012’~53 I~)B b
(30010~109 3 ´•)00O0-531
13 600011~163 2-*8 3
(300LO-ZIO P-13 3 ((0000-533
1.O0O0-96 2-)3-LLI Z-)B
(3001 0-21L 2-~3 )9
81 500012~11) L
)3001 0-212 ~)9 1(0000~98
2-)3. 89 500012-175 2-(5 2
1)10010-213 3 ))000L-27
2-(3- 89 5000L1-18) II
130010-21~ s 110001-19
83 500011~185 )-19 Is
P-I3 ~35 110001-33
86 500011~187 Z~(P II
130010~211 *1 110001~)9
1.)3~ 87 500011-507 2-*9
()0010-222 2~’3- )5 )~0001‘36
BL 50001)~127 2~)(
0001 0-223 L
L~)3 -111 500011‘927 Z~)5 98
)30010-29 2~0 35 110002
L~(3 ~115 500012~535 L~)5
)3001(1~)0 35 0000)
2-~3- 90 500012-~35 2-)6
(30010-31 2-13- 38 ))0001-105
)I (I001L-50) 500012-535
1300LO-31
(10()12-501 L~)3 -10) 500D1L-~39 2-19
(30010-39 2-(3 ~)6
2-(3- 81 500012-69 2-L5- bl
2-(3 -31 ((001~
I3O0I0-9I 2-)9~ P
2-)3 -)1 )1O0II 2-)3- 61 500012-be
)3001 0-0 2-)9 1
L1 110015 L-()- 89 5003L2-ll
(30010-(1 2-)3-
93 500012~73 3
130010-)9 2.(3~ 15 160015-17
1~(3 ~101 )0001P~IS L‘~9 5
)10010~51 1~0 ~)O
2-)3- BP 400011-11 1-)9-
~300LO-511 2-13
2-(3- 89 500012-91 2-~I- 9
)3O0LO-51 t-))- 31 )10015-19
36 500011~99
2-)3 93 10001~-1 I~)Z ~109
))OD10~6) 1~)3. 36 ))0015~1
2-~L-133 50001b-3 1‘O -112
11001()-65 52
2-)3~ 96 500L013 2~15 6)
2-(3~ 29 I)00Ib
2-)2 -13( 500LOI( 2~15 61
~30010-11 2-93-27
L-()- 99 500ZObZ 2-15 ~51
1)3001 0-13 2-(9- 2( ´•)001b-3
500)088 2‘15 -53
(10010-15 2)
2-(3-L13 5002105 50
1)0010-)1 P-)P- 22 ))0021-501
2-)3- PO 2-)2-L2( 5002105
1)001 0-19
OPo23~1 Z-)I ~101 500)LOb 1~15
2-)3 -19
2- 8-LI 5002101 2-15 18
(3001 0-83 P-I3 -18
L-L(- 28 1002115 2-11~ 72
13881 0-85 2-13-11 (8N8C2O6OILP
)9301‘19 1-29- 15 5002116 2-11
I)OOIO-BI 2-(3 -16
2-13 -19 500217) 13
))O01 0-89 2-(3 LI 511)87‘1
5E1(87-2 2-73- 16 5888-159 2-19 28
130010-95
Z~Lt- I) 5888- L(Z*F 15
)30010-91 L~(3 5 5LS‘101.1
Z~ZO Z 510301 1-II 6
(116‘08L 1-1)~11 SRL~L
I-ZO~ L 51
(3.51 153-1
2 5LOD03‘)01 2~)) 69
1~)3 65 .57‘10
2-26 22 110003-297 2-))- 01
))00O0-111 67
25 51000)-301 58
))o000-LIR 2-)3 68 )001~18111F
5LOD01-303 65
110000-112 2~(3 ~58 )000-211
2-)6- 1) 510003-301 2-11- 66
00000-L61 2-(3 63 500001
l-lb. 98 51030)-311 -(3
))0000-lb6 2~)3 500001
2-15- 10 510003~)23 68
II00O0-I10 Z-))- 10 5000055
50000’16 P~15- I 2-96- 60
I)0000-1IP 2-)3 -71
((00O0-192 69 500006 2-)5 ~L16. 510303-317
P-(7- IZ 510003-330 P-))~ 61
II0O(10-22 6~ 500012
.59 )00012~101 510003-3(1 L~25 ~111
))0000~22) 1~(3
-79 5 5Lo00)-3ll P-))~ sZ
)(0000-~32 1-)3
I-)b~ 3 51000)~3)1 56
~.13 bl 500012-1)3
1 7
~(0000‘2)2 66 100011~1)7
500011-111 2-~6- L 518383-351 29
~)0000-216 2-(3 -116
500012~1)?i 1~16 5L0003-315 61
51
1 110003‘351 ~59
2~)3 ‘60
5000L2.227 3 510001~)59 5)
)10000~26L
I(0OO0-PI2 2-)3-108 500011-~P9 P ~10303-361
100012-)31 3 510303-)L3 2-~1- bl*
(10000-21’) 2-)3
11 l000L2~235 P-15 ~9’) 510003~365 618
))OD00~15L L~’L)
)00012-2)9 2.~5 ‘100 510303.367 2‘)(~ 61C
2.(3 -78
500012-1)1 2-(5 -101 510003-93 2‘(( )9
2~)3 -56

Revised: 28 November 1884 9´•S9

 ILLUSTRATED
section III PARTS CATALOG COMMANDER
NumerloalInder
680A/B80B

L R T FIGURE P 1 R T FIGURE P I R T FIGURE

E IHDEX i INOEX r INOEX
n U 8 E a NunsER N v 8 E a ~unsER N U 8 a E n NUWBER

2~ 5-51 530111-)1 -108

~150 L~ 5 65 53PIIZ.36 Z~)B -loB
510006 2‘)5~139 525~b11‘9001 5~32 533112-91 2-)8 ´•LOP
110008 530023-L 2-(2 .10) 530L11-38 2-~8 -109
510009 530026-3 2-~6 -LOI 530111-(1
5100LO P~(S ´•1SL 530026~5 2-(b ‘10) 5)0112-)2 1~)6 -11
5L001 0-10 530011-503 5)OLll ´•)B
1100LO-13 2-(5-153 530016-1 2-16 -106 539111-) 2-~9 -1)
510010~11 2-,5-153 530026-9 1‘(L ~LO( 531)111-~ z-~e -52
´•iloola-9 2-)5-15( 530029 530118 -92
510011-IOL 2-1) -138 580065 2-)8 1 530118‘3 2-)9 -5b
510011-102 2-)5-1)8 530061-19 I-(8- Ib 530118-, 2-~9 a6
5L0012-1 2-~I-1ZB 53(1065-1) 2-(8- 16 530111 91
5L0011-IO 530065-L5 2-(B- 1) 530131-s 1´•)8 -96
’110012-2 I-)9-L1B 530065-16 P~*8-II P‘~8.96
510PL2-1 2-15-133 1-)8‘13 5)0131-1 I-)8 -97
510012-) 2-)5 -133 5300~5-8 53D13)-6 -97
510012-5 2-~5..132 530067 L-*5- 1~ 5)0112-1 2~(8‘ 98
510012-9 I-)5-I3I 530061 I-)6- 2( 530131-8 2-)8- 98
51001(1 L-l)- 81 530067 2~(8 ~118 13DL)I 2‘)8~ Is
51001~-1 2-~(-)s 530071 2-)9- 6 130131-3 2-)8 -103
51002´•1~9 110011-3 L-~9-12 530131-( P~(8 -103
’110025‘501 IZ 530011~5 2‘)9~ 13 130131´•9 ~.)B ~L02
5100P5~505 530071-15 5)0131-6 2-(8 -102
5100t6-) 530012~5 Is 5301(L.501 -91
91002(1-501 530072-503 2-(9- 15 53011´•) I‘)b ~91
510016-503 510073 53016l
510027-SOL 85 53007( 1~)9‘ 25 530161
510027-503 2-~)- 85 530015 I-(9´• L1 5301bl L~(7
5100)0 Z-0- 53 530075 2-(9- 11 530161 1~(8
110030 16 130011-501 11 5301)L.3 2~)6. 95
510033 130011-505 Z-)9 I 530Lb2 2-)5
110033-LI 2-)I- 38 530080 1-(9 .26 5301bZ 3(
51003)-3 530080‘5 2-*9- II 5)OLbZ a
5L00)3-5 2-0 39 130080-1 )L 530162-L5 2~5) LP
510033~1 2-4(-)0 53008L L‘(9- 10 530162-23 2-)7 28
’11(1033-9 (1 530083 1‘(9~ 68 ´•130L6Z.ZS (I
11003)-1 ~111 430083 2~)9 ~13 530162~21 (9
-L~1 53008) 80 530~62.33 L~() 1
510036-3 -I1I 530081 2-(9 85 530162-3( 1
51003)-1 530088-501 2-)9. 19 530162-35 L-)l -)3
5100))-5 P-~I‘L26 530089-501 2-)9- LO 530162-505 2-)1
5100~)-L 2-*5´•L2b 130090 1~)8-16 530L62-506
5L0015 530090-3 L-~8- 21 53DL62.7 51
5100)5 2-(5 -98 830090-) 2-*8 -21 530162-1 2-I)- 9
5L0016-1 Z-*5-13b ’130090-5 P~(B 20 13016)-18 2.)6 -27
5100) I-L 130090-6 2-18 LI 530L)(-ll l-Ib -25
510018 I-)5 -LOB 530102 2-(8 -loe I-Is ,o
510019´•503 2-)5 -111 530102-3 53016)-5 2-(6 -)1
510050-503 2-45 -113 530102-( 2-)8 -115 53016).501 1-)6- I

5L0053 2-45 -113 530LD2-5 2.)8 -IL( 5301 6)’7 )-)b -31
51005)-501 530102-6 130164-9 Il-(b Zb
510055~501 530102-1 2.(8‘113 ´•1301bl~ll Z~)b ~Is
5L0056-50L 2-)5 -LZL 530102’8 530165-19 2-~6 -2)
5L0058 L~15 -LO) 530103 530161~501 2~)6 Il
~L0061-505 2-(5 -LOI I~OL1Z 53DL65´•7 i‘(b -19
110061-505 ~-)5-108 530112 530166.501 L‘)b. b
5L0071-L 5)0112 2-53- (O 530L61-15 2-65 -)1
5LI7OS-I 3 530111-is 53DIbi-II 2-(5 31
511816-) 1-15 -39 530112-20 5)OL6l-l9 2~)5 -)1
68 69 530IIl-21 L~(5 12
5151 2-16 27 530111-22 2-)6- 69 530167-501 2-)5 -27
11530~0(11 530111-1) 130111´•102 27
2-65 (2 530112-21 1-´•6 16 5301b8 2-)5
12~012-09)-0871 ~-lb -25 530112-2~ ~-16 .82 510168.11 19
52´•018-250-1500 2-1*- )9 510312-2’) 2-46- B) ´•I)Olbs-16 1-(5 28
I21-L L14- LI-321 I-Il (D 5)0111‘)1 L-lb 8~ 130168-17 2-)5 II
511~1115-11-321 -~O 530112~33 85 5301)8~18 )´•)5. 22

5´•54 Revised: 2R November 1984

 ILLVSTRATED
OULFSTREAM
seetlan nI
COMMANDER PARTS CATALOG
Numerical Inder
880A/B80B

P b R T FIGURE P L R r FIGURE P I R r FIGURE

i INOEI C INOEX L IHDEX
8 F R NUWBEI N U Ii 9 E R NUW8ER N U I 8 E R NUI8ER
N U

530219~) 1‘(9- 65 540003-50) ~-(B ~5)

5)OL(B-LP
25 530259-9 2-)9 19 59000) 2-18 55
530168-3 L-~5
ZI 510384 2~)5 540005 E)B~ ii
5)0168~5
2.~5. 4 530385‘1 2-15 -19 5*0005-3 Z-I8- 59
530169
Z~)S ~10 19 5)0005-1 2-(8 ~1)
510169-11
2~)5 8 530381)~503 2‘(5~ 10 540DD4-I 5)
530169-L3
1 530)89~1 12 510005~9 2-48 57
LZ 530390‘503 5~0006 Z‘*8‘ 58
530169-9
2-(1~(0 2‘(5- 8L 5)0001 L‘)B -50

530392-501 I-)5 82 440010 2-18 31

53()176-502
2-15 11 530393-1 440011 1-18 3)
530117
L-)5~ 55 53039*-1 2-)5-L)B 5(0011 2~(8 ~37
530177
I-I5 -63 530)95 I-I5- 83 440013 2-(8- 10
5301)1
)1 530397-505 P~(5 88 ))001)~501 2-)8
530118
2-)4- 56 430398-501 2-(5~ 90 5)002(-501 P-(B- 15
530181
2-9)- 62 5303’19-503 2-(5 -91 5)80(9-501 1-12 -LLO
530181-3
~)B 5)(1(01~903 1~)5 ~92 2‘12 ~LI1
530182
1-I5 -56 510102-403 L-I5- 93 5)0881 I-II- Il
530)03-1 2-45- 97 560081 2-12 -15
5)0181
530L87 86 5)010(~505 2~*) 96 5*0081-501
Z~)b 63 530105-505 99 2~12-
530187-11
2-)6 65 5)0113-1 I-15 -121 5*0083-L 2-L2 -103
530187-L3
5)0)11-1 Z~)I- 11 5(008)´•501 -101
530187~15 ~91
4304L5-401 2-)5- 83 5)0087-1 I-II- 98
530187-3 2-)8 -90
-90 430(16-1 1-Il 32 51008)-7 2-12 99
530181-~ I-(B
91 5)0(16-1 2-(6 39 1)0087-503 2-12 -98
530L87-6 2-)8
430(l6-L 1-I)- 66 5~DDBI-105 2~11 99
530187-7 I-Ib -62
430IL6-2 5)ODBB-1 2-L2 9(1
530187-9 I-Ib 61
~)Ollb-2 L1 5*0888-2 91
530189 P-~s
1-19- (Z 530411-1 I-I5- 39 5)008s´•1 Z-1Z -9(
530189-19
L-(b (5 510090-1 L-IL- 85
530189-~1 2-49 *f 530111~1
2-)9 Is 530)11-1 L-*8~ I~ 510091-L 2-12 86
)30L89-23
~.)9-108 530117-2 2-)9 )B 59009L-2 2-11 81
530189-25
-101 130117-2 Z-(B- 7) 510092-1 2-IL -II
530L89-21 2-)9
530)38 4)0093-1 1~1L
530189‘28 2-)9 -103
Z‘(b -39 4)OD9)‘L 95
5)018’)-29 Z‘´•9 -95 510118-1
(1 530118-1 2-*8- 6( 9103’15 2-ii
130189-3
430189-31 l-(P -106 5306)0-1 2-)8- 95 540095
2-)8~ 91 5)0095-4 Z-~ 88
5)OL89~3Z 530120-2
2-69- )3 530421-1 2-´•5~ 87 5)0094-4 2-LI- 50
5)0189-31
2-(6 -)5 530)27-1 2-(5- 9) 548106 2-IL -100
530190
5)0131 2-47- 25 ’1(010)´•501 L-IZ -11(
530L90-3
530131 Z~(I- 3(1 5(0L08‘5111 2-12 ~L11
530190-5 2-46 50
5)0)31-1 Z-*)- Z I~OL09-1 ~118
5)0191 2-(b
2-)6 39 430134-11 2-(7 6 510110-1 1-12 -125
130L91-3
430631.12 6 ))0111-1 2-12 -12(
530191-5 2-46 31
-18 ’130136-2 2-12 -1IL
530192-3 Z-)P
5’L0111~503 1-II ~112
2-~9 -(O ~30135-)
1-99 2-11- 15 5)0113-1 2-11-117
530192-50L
1-49 )6 530435-5 1) 5(0111-1 2-12 -105
530192-50)
9 4(0115-1 2-L1 92
53019) 1-19 31 530635-7
530(36-1 1-´•6- 10 5)OL16-1 1-II- 93
430193-) 2-49
’130)53-1 2-)7- ’L 5)0117-1 2-12 -90
530195 2-(7- )6
53015) Z-IB- 61 5)0118 2-12- Il
530121 2-46 ~50
53011(~) 64 5(0120~501 2~11 ~83
))0221 2~)8. 13
43015)-) 2-(8- 66 510121-503 P-IL -81
531)221-11 2-)6.46
533-051-29 1(0122-503 I-L1- 4
510221-11 2-)8 -86
.33008~50L 5)P112~505 1-11- 5
53022 L~L3 2~)8 16
513008-502 5)0111~519 2-l1- b
130221~3 ~83
2-)1. ’LZ 5(0122-51L 2-11‘ 1
)30221-) 2-18 8) 533010
I~ 5)0113~L 2‘18 ~26
530P21-7 2-)6 -)1 53301)
133012 2-(7- 27 5*0121-50) 2-IL -81
530LI1-9 2.)6. 55
56DL3B-L )-11- L
530221-9 2-98 -85 513032
-46 533(132 2-(7- 39 560139-L 111- 2
530259 1-19
2-19 -61 5)3050 2-(5 L~ 5)01)0-1 2-11- 12
530259-11
533061 2~)1 .Is Z‘LL ~13
530259~13 ~56
2-)9 67 5)3013 2-)I~ 33 5(D1~L-1
53I1t59~3
430259‘5 2-1(9 61 5353)-3 1-25- 9 5(0116-1

Revised: 28 November 1984 3-55

 ILLUSTRATED GULFSTREAM
Section In PARTS CATALOG COMMANDER
Numeriea~ Inden esoa/esoB

P I R T FIGURE P I R T FIGURE P 1 PI r FIGURE

L IHDEX L INDEI E INDEI
N U It B E R NUWBER N U 8 B E R NUII1ER H U W 8 E R NUWBER

5)OL50~1 2-12 19 6LDLll´•6 PB

5(31 P-)L -86 610)20-8 610648-501 2~ 5 84
5())1 2-LS -73 610)20-87 2-~-2) 61(1HL68 2~15 ~11LB
5466 2-28 11 b10)20~89 2- 2 L( LI)1HL7I L-LS -1)11
5(85-012 7 610)20-91 2- 2 )O bl)lnllZ 2-25 -III
550100-505 (I b10)20~s3 2- I 30 6l(tnilZ I-2S -1)2
55010L-1 2-11- (3 6L0)2D-97 2- 5- 7 610042-1 2- 3 -(D
550103-1 2-11 (5 610)23-1 L- 5 Is 620087 2- 3
550L07-501 L-ll- )L 610)13-1 Z-ll- )L 620081 2-39 -21
550L08-L I-II-II 610488-101 L- b -29 620088-501 2- 3 -33
’150112-1 L-ll- 10 610(88-103 L- b-10 620888-502 L- 3 -3)
550114-1 2-11-48 610488-105 1 LZ0089-L 2-1-13
2-I(- 3 blO(BB-101 I- b-)L bL0090-I 1~ 3 ~ID
550LL)-501 1-11-48 610188-107 2-22~(1 620090-1 I- 3 -21
15011’1-1 2-11-)6 610(88´•107 L-23- 23 620D9L-1 9
5’10LL9-1 L-11- LI1 L10188-109 2- 6-)5 62DD9L-501 2- 3 -1
558120-1 2~11-18 610488-109 2-22 -)1 620091-)03 2- 3-
55(1120-501 2-11-)8 610(88-109 2-23 ZI 6IOD9L-505 2- 3 I
5(-163E1213 2-63- I) 6lO)88-L11 2~ 6-35 620091-’109 2- 3 -20
160000 2-63 -1L 61OI88-L13 2- 6-3) 620891-511 2- 3 -16
)b0000-ll 2-63 -16 610(88-111 1- 6-)6 62OD9L-513 1- 3-11
16000LTI) 2-63 -36 610488-117 P~ 6-1) 620091-515 2~ 3-LZ
560000-41 2~b3 -22 610(88´•119 L- 6-48 620091-5!9 2~ 3-36
560000-55 2-(3 L(I 6LO(88-IZ1 I- b-(P bZ0091~5L9
5b0000-57 2-b3 -33 blO(BB-123 1- L- 8 OPO1OL-L 2~ 3‘31
5b0000~59 2‘6)~ 3) 610(88-127 2- 6-(6 6)010(1-2 2- 3 -31
56~(100-65 )~b3 -~O 610((18-IPP 2~ 6- S ~LOLOI-I 3~30
’160000-9 P-63 -I) 6LO)BB-13L 2- 6-BL~20107-2 P-)~30
560010 1-7( (110(88-21 2- 6~ LZOIOB-L 2~ 3 ~15
560011‘1 9 610((IB~P1 Z~I-II e~0108‘501 L~
560012-1 2-1(- 10 610(88-63 I- 6-18 bZOIZ)
57-17(1-2015 1-11- 29 bi0(OB-69 2- 6- 1 620L2)‘3
5810-1 2-65 -)P 610*88-69 1 620125-3 1- 3-15
5810-2 2-6) )I 61OI88-7L 2- 6 )Z 620115-3 2- 3 37
5816 1-65 -73 610(88-71 1~ 1- 8 62012’1-103 2- 3-34
IBZD 2-65 -75 610)88-73 P- 6-3L 620115-10) I- 3 -36
58)0-5 2-65 65 610188-75 2- 6 8 620113 2-25 13
5B(9~0FL-OL I-ii -115 blO)BB~ II L- 6-L7 (201113 2-25 Lb
6´•00 X6 2-19 II 6lOl88-79 I- 6-32 638946-581 2-23 -lls
6´• 00 16 2-L9 5’1 blO)BB-83 L- b- 11 6300(6-’111 P~ 8 21
6NCCI 3111P 2-13 9 610(88-85 L- 6-1) 630051 (9
60880207)’(29 L-L(- 22 610(88-81 2- b-Il 630051-1 2-LO- 16
8-37 610)88-89 2- 6-12 630060-501 2-10 -)Z
b00L1Z~503 P~15 -12( b10188-91 6300)0~508 Z~1D. )Z
b0111~01 2~19 ‘12 )10188~9) Z~ 6~ 9 63001L~501 I~ID -(3
bOISB-OI I-IP 12 610188-9) 2-2) 25 blDDbl-508 2-10 )3
610108~503 b10188~91 Z~LO ~)6
610)08~505 2~ Z -32 610188-91 2~
610)17 2‘ S LB 610188~99 2~ b-)D 630063-508 L~10
610)17-)9 IB 610194 L- 1 b3DD64-509 1~10 IS
LIO)L 7-50 28 610194 3 630Dbl´•510 1-10 )5
b10)11-91 PC 610(94 6)0319 Z~10 ~19
610)17-51) 1 610(9) 2- 5 630017 8-(2
6lO)L 1-51) 2-)- 1 610194 2´• 6 6)0011 2-10 -50
blOllP´•il PD 610(’)(-5 4 82 630080 P-10 39
6IO)L8 2~)L 10 61019(-1 1- 5-11 630D82-L 2- 8 -53
610(18-1 2-~-10 ~1019(-9 2- 5-81 610082-1 P~LO-
2-)-10 610)91-1 1- 5-10 b3DD82-501 2‘ B -52
610118´•905 L- L -10 6L0)95-501 2‘ 9-30 6)0082-S01 2-10 5
610(L8-506 2~(-10 (110)91-10) Z- 5 ´•30 630085 2- 1-19
610118‘~07 )´•)´•10 b10195~505 2‘ 5 -39 L1DOBS 1~ 9
b10(18~508 10 610(98~1 15L 6)ODB)‘ll 2~ 9 9
blOllO~LO) 2- P -25 61(1632~503 ~1 9~LB
610)20-101 2- L -21 6106~1‘1 1 630085.51 P~ 9~5
6L0)10-I) 2- 2 28 6106)1-15 2-’1 20 6)0085-51 Z- 9 IS
blO(L0‘39 2- Z -)B ~106)F2 L 630085-53 Z~ 9 ´•16
610120-501 2~ 2 19 6L04)1~3 ZC Z~ 9 -19
b10)10~507 2-5- 6 61(16~1‘5 28 630381 I´•I0 36

S´•SB Rauiaed: 2R November iBR4

 ILLUSTRATED
OULFSTREANI Section m
COMMANDER PARTS CATPILOO
Numerical Indeu
680A/690B

P 1 T FIGURE P I R T FIGURE
p L Il r FIGURE
L LNDEX C INOEX
L INOEX
N U H 8 E R NUn.ER N U B E R NU*IIER N U I 8 E R
YUIIGEI

2.10‘ bP 650001-t1 1
610313-333 5 630301~2
b3030Z~1 2-10~ 10 I
6)0133-357 2‘ 1~1*
2~10.10 650001’L3 LI
1. b ZO
.1O 63030) 2-LO 66 650001-15 2- L LS
630133-618 2~ 6
630301-1 2-LO- 67 bSOOO1-ll 2- Z Ib
6301)3-651 6
2.LO~ bl 650001~19 2~ 2 16
630133~659 2-7 b)030)~2
b500D1~21 3
630133~611 2~7 15 6)0307~1
2-10- )I L5000L-22 3
630133-613 7 ~13 630)01~2
1´•´•10~ (O 2- 2~ 6
b301)3~L13 630308~1
630308-2 1-10- (0 ~50001-25 II
630133~75)
b30309~505 8~L9 650001-27 9
b10161 2-23 -116
I~LO‘ 26 650001-19 LO
630182.501 2- 8-32 630311-1
630311-15 31 650001-) 2- 2-
63010)-101 2-10 -67
6)031L-11 2-LO- 31)1650DOL-11 12
6P02D6 8 is
6)0311‘18 1~10 301 650001-32 Z ~II
630209 2‘ 8 Z1
2-10- 26 b)ODDI-)3 I)
630210 2- 8-3~ 630311-2
2-10- 30 650001-3~ 2- I- 13
630111 P- 8-31 630311-3
630311-1 1-10- 30 650001-39 I- 2 L)
630216 2.10 -10
L 6)0311-~ 2-10 31 650001-(3 2
630218
630311-507 2-10- 26 650001-5 2- Z
b30218 P- B
L-IO~ 26 2- 2 9
630218-13 2- 8 16 610311-508
8 16 610111-9 ZB 650001~53 2- 2
630218-17 I-
2-7- 2 650001-55 5
630221-501 8.66 630311
2- 8-55 650001-(7 5
630221-503 2- 8 -~6 630311-501
2~ LO-55 650001-~9 P- 2
630211-5(15 2-10 6
650001~61 L~ 2 5
63021) 2- 7- Z 630315
2- 8 650001-63 2- 2 LZ
2- 8 630315
P~L(I 610001-65 2- 2 13
630131-11 2- B I 630315
2-10 96 650001-7 L- 2 5
61023)-15 2- 8 630316-1
2-10-15 bS0001-9 5
2- B 9 630317-1
Z´•10- 23 650003-1 L- L- 33
6)0231-3 2- 8 6 630319-1
b30319-50L 2-10- 20 bS000)~1 18
b3013~-33 2- 8- 3
630319-503 2-10- n ssooo*-, 2 18
63023)-39 2- 8 1
630119~505 L~10 2D 2 ~17
2~ 8 L
5 630319~507 I-Ill-II ~50001-101 2~ 2 -II
b302P)-59 2- B
630332-503 2-10- 51 65000(~L 19
63013)-9 B
6)0235-507 2~ 8‘ 28 L~10.51 b5000b~Z
56 ~50001‘1 2 ~3)
bPOZ)9~501 Z- 8~50
653012 8 18
2‘LO 8 630333.1
L~ 8-25 653050‘501 33
Z‘ 8-35
2- i 35 630338-503 2- 8-50 651´•1 2-68 -1(
6302)0-505
2~ 8 ~(O 630339-50) 8-35 2-(8 -13
6302(2-11
I- 8~55 658.05~‘(101 2~ B~)BL
630212‘5 8 .)L1
8‘38 61(13)0~501 15 6591 29
0102(2~501
b)0III-50) 8-.. 6303)1-501 2- 8-)81660800
630II2-I 2- 8 ~O 6803)3-505 2-31- 1 660000-)
2- 8 -)1 2-3) Is 660000-( 2-(-12
630))2-9
sl 6303(8 B 2‘ )-16
6)0261-1 I~LO
610261~1 L-LO .35 6103)8-3 1- 8-L6 660000.6
2-10 )6 630)(9 8 63 660001 2-39 19
6)0217
2-IP- 68 6350*(-*8 2-11- 16 b6r)001-3 2-39 ~20
630296~L
~)-032-3)8 2-21 -1P) 6b00DL-5 P~)s ZO
630296-2 2-IO -68
18 bi0053-I )-1 660002 2-) 3
(30297-18 I-I0-
6)0191-11 I-I0- 61 6)001)-1 660002
6)005).501 2- b~ZI 660002-3 15
6)0297-17 Z~LO ~6)
I-LO -57 b10055~5Lll 2~ 9~ 9 600002-)1 15
630291-103
2´•13. 57 610055.501 660002-33 15
630297-507
b30P98~1P 2~ 9 L b(OOSb~L P- 6 26 660002~35 1-(1- 16
2- 9-11 660060 L- 9- 1 660002-36 I~)L‘16
6P0298-29
b3029631 2- 9~10 2- 5~ 8 660002-37 15
I- 9-10 610062 2~ 5 L6000P´•39 15
6301’)8-32
630298~33 8 6)006)~’101 5 bbDOOI~(L Z~)1- 16

L)0198~39 P~ 9 6(0063~503 Z- 5~5 6bDOOI-(2

P´• 3 2- 5~ 3 6bODD2~5 2~´•1- 15
2.
63(1298-)3 2- 9- 6 6)0079-1 ~-1-62 660002-7

1~10 ~12 6)0019~1 660001-8 1-11~ 16

63PZP9~501
b)~)OO 2-10 68 i-IS -1(5 66000)
Z-LI)~ 69 650001 2- Z 66000) 1~)1- 19
630301-1

Rovisod: 2R Novombel´• 1981 3´•31

 ILLUSTRATED
GULFSTREAM
Beotion In
PARTS CATALOG COMMANDER
s8oA/ssos

P L 8 T FIGURE P R I FIGURE P I R T FIGURE

P ´•~NDEX C IHOEX (INOEX
N U 8 8 E a NUWBER N U H B E 8 YUHBER N U 8 8 E R NUIIBER

660001-3 1 7300)5-17 2-lb 1 Z~P) -10b

66000)-5 6 1300)1-33 ~-L6- 3) 19022)-5 2-2) -101
bb000)~9 1300(5‘3~ 2~L6 1) 790223.501 1-23 95
660007 3 1300)5-5 2-lb- 32 190123-1 1-13 -98
660007 730015-9 2-16- 31 190228-5L3 1-16 L2
6b0007~) 1 73(1058 2-)0 190128~513 L~13 -19
660007-6 2- L 1 )30058-11 2-(0- LO 190228-51)
66000)-5 6 130058-18 2-*0 -ID 190221-11~ )~)Z -55
661)007-~ 6 130058-19 1’)0130 IO
bb0001-7 150058~P0 1~)O‘ L1 190211~109 1´•´•11 ~101
6915(5-L 2- 6-5) 130058-21 Z-)0~ 12 798131-581 1.21- 83
693939 Z- 5 -33 1)0058~P2 I‘(O~ L~ 7’)0238 l-ZL bS
110015 2-13 130058-23 I-(0- 11 190238-13 I.P1- It
7100L5 2-13 736858-)) 1-(0- 13 190238-L5 2-21- 1)
710019-501 2-1)-19 1301358-3 2-(0- 9 790238-L7 2-~1- IQ
110019-501 2~23 28 7300~8‘) 2.´•0 9 I-ii II
710019-50L I-2)- 10 130059-5 2-13 -85 1)0238-21 2-11.126
110019-502 2-13-19 130019-503 2-L3. 81 790238-23 2-11 -129
11001 9-502 130059-503 2-)0- 1 790138-9 2-21- 72
110021-501 2-11- 31 130059-50) I-I3-BI 1902)9 I-12 -100
1100P1-lol 2-22 -53 130059-50) I-(0- 1 790219 L-2L 93
110022-501 -27 130059-6 I-L3- 85 790239-13 1-21-116
710021-)01 130062-5 2~13- 90 190219-9 P-PI -1LI
710026 1-11 736662-593 1- I)-85 190139-9 2-5)- 5
710016 1-22 -59 I300b2-503 L-)O- 1’102(1-501
710026-13 2‘11- 1 730062-58) 2-13- 85 7902*8.501 I-PI -91
110016-15 ~-11- 8 130062-501 L 1901)s-5(19 29
11002(1~LI 2-11- 7 130062-´•~ so 1902(9‘511 Z‘Z1- 30
710016-13 2-L7 10 130068 2-L3 82 1902 69-505 1-13 18
710026-) ~-11- 10 IlOObB 1-13- 88 790110-505 1-19 -25
)10028~501 23 130010-501 8) 1.I) ~21
110028-7 130010-503 )-11- 89 19027(-511
710029 1 110071 790279 2-)8 )8
716829-587 2-L5 13001* 2~16- 1 79027’)-505 2-21- )3
710029-508 2-L5 130016-1 2-(0- 3 19028(.1 2- 5 -83
716829-511 2-15 11001)-1 2-(0- 1 19028)-501 2- 5 -83
110019-512 2-L5 150003 1-19 -11( 190100-205 2-I)- 18
110031-501 2-LI- 6 110003 1-51~ )D 790301.501
710011-L P~13- sl 15005)~503 1 19030L~505 P)
1101‘JI 1-12 ~126 750061 ,-le 190302 I-i)- 38
1101-J1 1 11006L~13 LO 190801-L5 2~2(. 39
1101J’IOL037890-t L-(l -53 ISOOE~L-19 2-19 -~1 19010L-9 1~1(. 58
1111)-8 2-25-111 110061~21 I-le- 23 190)03´•501 1-16 ‘16
71262-1 ~‘61 58 150061-25 ~‘L9 37 )9030)
113038 2-23 -)L )500b1~21 2.20- )8 19030) 2-2)- 61
11)058-503 2-16 -19 1’10061-15 26 190322 11-.10~ P3
713062-501 )-1I- 72 750061-27 21 790322-L7 I-PO- ZI
713862-501 7)00(1-27 2-28- 39 190128
713092-50L 2-(L -101 IS00bl-II I-II-Pi 790329
713096-503 2-19 -)I ISO0(1I-)I 2-L9- 5 190)19 2-2(
11)110-1 2-11 -L22 1500bB´•1 2-19- 55 7’)0130-103 1-23 -13
113111-1 2-(1 -111 758869-561 1-19- 8 798336-161 2-2(- 1
11)11P-l 1~(1 ~L21 150070-1 6) 12
113113-1 I-)L-LIB 150071’1 1-19- 1 190)30-107 1-11-23
)11111~50L 1)30)2~)03 1~3)- *1 190330-101 2‘2)- Lb
111 2-66 LZ 153012-503 2-72 51 I~D330-LL7 P-2P ZI
1205 (J-ll 2-Zb -1~ IblIP 790330~11’) L~22
1208 rJ-ll Z-2(‘L9 16~1-) I9D1)0-LL1
2-32 LO II) ~‘IS- 50 190))0-111 Z.I(- 5
121*60 13 790813 2-21 28 190)30-123 2~1( 8
1211~5-1-12-101-61 I-3P -19 790013-)5 Z-P1- 65 190)30’125 2-2(- 16
21 1900L3‘(~ 61 1)0330~121 L~t(- I
1211-5-)-1~-501-bl 2‘)2 -Is 190013 I-l)-LOB 790330-L19 2-I~- 9
7217-5-5-12-587-61 2-)2 -16 790087-503 2-23 -101 IP0))0-I3 1-):3 1
1300)1 I-lb 798888-505 2-23 -IZI 7P0330-L31
1300)5-11 3 190130 P-Il- 61 790330-L33 L)
1)00)5~19 P~lb 9 190201‘105 L~22 51 790330-139 2-II 16
1300)1-23 2-16 19022)-11 790)30-1(! 1~1)- I

S´•3B Revised: 28 Novcmbsr 1984

 ILLUSTRATED
CULFSTREAM
section 1II
COMMANDER PARTS
MlmeriCal index
69(IA/B90B

P 1 R T FIGURE P I T FIGURE P R T FIGUIE

C INDEX L INDEX E INDEX

n B E R NUIBE~ N U W B E R NU*8ER N U n a E a NU*BER

N U

10 190339~259 8´•53 X 10 2
1903)0-1)3
2-2)- 13 790330-261 L-I1- I5 8TJPPIV P-)I- 3)
190330-1~5
190330-1)1 2-2(- IP 190330-263 Z-ZP- 511 800013 1-28
2-2) II 190330-265 I-PZ 12 800013-105 2-28 5

~11 190330-29 1-21 -I8 800D13-L23 2-28- 1~

7e0330-L5
Z~L3 ~81 190330~L91 2~13- 10 800013~127 I-ZB 16
790)30~113
790))0-L55 2-13 -1~ 190330.3 P-ZZ- )3 800D13-1P9 2-28 -10
8 190)30-101 7´• 800013~131 Z‘LB 9
IP0)30~115
190330-)01 2-23-20 800019-169 2-28 8
190)30-157 2-1)- 81
2~20‘ 22 190330~303 2-LI‘ 21) LL
L 190330-303 15 80001)-59 I-P8 1
1~03)0-L54
Z~PO ~15 190330~31 2-1)- 3 800029 19
19013(1~1bl
2-20 2) 790330-321 800DI9 2-15
790)30-163
2-Lt Z 1903)0-311 2-22 -II 800019-LI 2-25-
190330-L6)
2-20- 16 190330-313 2-17- )O 800019-13 L~Z5 5
190330-165
8 190330-325 2-L7 31 800019-1~ 2-25 5
790330.161 2-21
1-21- 1 190330-321 2-ZP 318 800019-1 2-25 I
190330-169
ZL 7903)0-327 2-L7- 31 800102 2-15- 8
7903)0-11
6 190330-321 311 8OOZL8 1-13- 58
190330-111 L-LI-
5 790330-329 1-13- 81 800231 2-23 90
190))0-173 1-21-
790330-115 P-LL 9 7’)0330-33 2-21- 52 8002)1 2-18
)-2I 12 790330-331 2-L7 II 8OD2)I-L3 2-78 I
190330-111
790330~331 2-11‘L2 800237~L5 1~)0‘ L
790330-L79 Z~L1- 10
2-11-tL 190330-331 2-22- 19 8082)7-) 2-78- 5
7903)0-L81
P.PI-II 190330-331 2-2)- 1( 8001(3 2-25 Il
1903)0-L83
l-ZL~ 16 790330~)31 Z 8002(3~13 2~25 28
IP0130~1B5
P-P0 L 790330-33L Z 8002)3-13 2-25 ZI
790330-187
2~21 Ie0330-37 P-22 30 8001~3-9 2-25 2)
190330-187
I-P0 2 790330-39 2-21 32 8002b~ 1-25 -111
190330-189
2-21 790330-13 P-II 31 L-LS -L16
190330-189
1 190330-(5 800296 2-25 -130
190330-19 P-23
2-10 6 7903)0-(1 9 800296 I-~P B
IP0)30-l9l
790330.)9 2-22 -16 800296-11 L5
190330-19L P-2I- is
1-20- 1 790330-51 2-28- LI 800196-3 2-62 Il
1(10330-193
LB 190330-51 2-21- PO 888296-35 25
190130-193 P-LI.
190330-53 2~20-13 18
190330~195 1‘23
L-23- 8 190130-53 2-11- L1 800296-)) 1-61- 19
790330-191
790330-55 P‘21 2~ 800296~5L 25
I~P)30-L99 Z~L3 LO
9 Z~ll. 25 800296~55 ~1(
190330~L0l 1~23
5 790330~59 808198 1~LI 13
790550..28) 2~23
1 790330~61 2~21- 23 800)11 2~25 ~191
790330-205 L~13
190)30-61 I-PP 28 800312-5 2-25 -IPB
190)30-~11
22 800)13 1‘25 ~1D5
798159..21) ~1)
7901)0-63 i-II b 800313-15 -211
190)10-~15 2-22 20
1903)0-65 2-22 1 800313-19 2-25 -209
790)10-217 2-11 13
I-LZ- 31 790330-69 2-22 -11 80031)-23 2-25 -P1O
790330-117
51 190330-81 P-I3 800313-29 2-25 -208
790330-219 2-11
2-22- 16 190330-91 2-22- L1 800323-503 2- 5-82
790330-121
790330-91 EIl-18 800)23-501 P- 6-31
190530-223 1-11- 31
2-22 )3 7903)0-91 2-2(- O 800)83 2-25 ~228
190110-)21
190330-121 2-22 ~36 7’)0330‘93 L-ZI- Il 8(10)83
790339‘93 IP 80038)~1 ~)O
1130330~229 2~12 ~21
1-12 -15 790330-93 L-LI 800193 P-P5 -116
790)30-231
5 790330-95 P-I2 19 800)9)-525 2-25 -131
190(30-L33 2-22
11)0330-95 Z‘LI~ 1 80039´•~521 2-)5 -130
790330-135 2..11 LB
Z~ZZ 9 800)9)‘)29 l~)’i ~116
790130~235
790330-99 I-LP- 13 80039)-131 2-II -LI)
790)30-237 2-11- 7)
ZP 190350-99 P-P3 11 8003s1~535 2-25 -IP5
190330-2)7
19(1330-99 1-2)- L 80039)-5)1 1~25 -1PI
790330-P39
2-22 790331 L-ll 80039)-5)s 2-25 -129
2 79033L L~LI 2~25 ~128
190P30-1*I
I-11- 10 190331 L.Z1 80019~-511 1-25 -119
I~P2 17 isol,l-sol 800)9(~5)9 2‘25 ~130
1-11- L5 19(1)31-501 Z-L2- 68 800)PI-1(9 2-21 -131
1903)(1-2~9
P-22 38 7POJ32-501 2-23- 30 80039~-15L 2-25 -1)(
)90)30-2(9
1903)9-L Z‘~I 13 2-P5
190))0-~51 P-13 13
2-22- 7 7983)8-1 2-23- 81 800111 P-1I
190))0-25L
1903)1~1 800(11~) 2~11 9
190330-257 23

Revised: 28 November 1984 9-10

 ILLUSTRATED OULFSTREAM
Section ID PARTS CATALOG COMMANDER
Numeric~il inden 890A/B808

P 1 R r FIGURE P R T FIGURE P b R T FIGURE

L IHOEX 8 INOEX L INOEX
N U n a E a NvnsEn N U n 3 E a NunsEn N u a E a Nu*sEn

800)1(~501 12 80051) 800LOB-501 Z~27 ~16

800111~101 38 80057) L~L7 800bOB~502 IL
800)26-501 2-27- 96 80051) 1-28 BOO~D9-1 1-27 7
8001Z5~1 Z-ZI 6 800111´• Z‘bP 800b(lP‘501 -30
BOP)II-l L-21- 3) 800575-1 2-L9 -111 8(10617 I~ZI‘ 10
800128-1 2-21 B 800515-501 2-25 -III B006L7-11 2-25 80
800128-1 2-27- 32 8005~15´•503 2-25 -111 80Dbl7-13 2-25 -80
800)28-505 2-27- 33 88D575-5O5 2-25 -LII 800)11~3 ~-ZS -80
800128-501 1-11- 19 800575-501 800111-1 1-25 ED
80D128-509 2-21 -50 800515-509 1-25 -111 BOD~11-9 L~15 BO
800)10-50) 1-25 -LII 2-25 -111 80Db19-1 2-26 -15
800((6~1 15 800515‘513 BODb19~501 ~‘16 -~d
800)61 2-25 -101 800576-L 2-25 ~181 80DSL9-503 1-26 -(1
800)69-501 1-15-110 800116-501 )-24 -182 800b19-)0’1 )-26 -13
800666-505 2-15 -110 800576-50) 2-25 -LBZ Br)0(21-L 1-25 -68
800)78-3 80051b~505 2~15 -Is~ BOOb~l-L L~25 10
800118-3 808577-1 2-11 -lb3 809623-1 2-25 -86
800)78-501 -L35 800577-501 2~15 -lb) 800123-503 L~25 86
800)78-~03 -132 800~11-503 Z~15 8)
800178~50) 1~15 ~IIOF 800511~505 L-Z5 -LID1 BOOL19~1
100)18~5I15 1‘~5 -L32 800578-L )-II ~Lb) 800)32 2~25 ~230
800)78-7 1-25 -L~I 8005)8-3 2-15 -110 809631-1 2-3)- 80
800(18-1 2-25 -1701 8005I8-5 2-25 -110 80063) -237E
800)82 )-25 -L6) 80063) 2-28 16
BOO)B)-L 800518-503 2-25 -Ib~ 80DL3(-3 1~28 -27
800)85´•´•1 2-13 1 800118-505 2-21 80063~‘5 ~-25 -138
800)86-1 2-13 800518~)01 2-25 -161 80063)-5 2-28 -11
800)88-1 2-73 3 80(1578-7 2-25 -LIO 80063(-7 2-28 LB
8001119-1 5 800’183-1 2-26 8001)5-1 2-28 -21
800*90-L 2-11 9 800583-17 Z-L6 -25 800636-1 2-28 ZO
800)9) 2-25- 51 800583-19 2-26- )3 800637 2-27- ZL
800195-1 2‘25 -58 800583-3 2-26- 38 800638-1 )-27- 35
BDOI97 2- LPI 800183-5 2-26 18 800661-1 2-25 -136
800197-L 2-25 -212 800583-103 2-Zb GGDG*) 2-21 -2)5
800501 2-)1-229 800583-507 L‘Z6- 800(1) 2-25 B
800501 ~-bZ 800183-509 1’26 8(1001~ 1-36- 2
800101-) 2-62 1 800183-511 2-26- B000lI, 1~3(- n
aoaso~-1 2-25 1 800583-113 2-26 6 8001*9 2-25 -238
800501 800583~515 I~Zb BOObSO~I P~ZS ~2(5
800511~51L 2-15-119 800583~1 2-Lb- 16 800650-1
8001~L-I 2~25- 811800)~3 L~21- )O
80051P-50) 1-15 -L70D 800186-1 L-26 88 80065)‘11 -(5*
580523-5 2-25 -1)9 B(IO5B7-L 2-15 -97 800653-3 2-27- )1
808523-501 2-L5-L7P 800588 2-25- 88 BOO663-5 2-27 -~Z
80012)-503 2-25 -IIZ 800588-3 1-25~ 91 800653-1 2-2)- (3
800511-105 P~25 -112 800589-1 2-25 -LOb 800611‘9 2-27
800513~507 Z~P5 -112 800590 L~1I ~101 800b5(~1 2~2)- )B
80011)-509 1-P5 -II1: 80059L-1 2‘21 -101 80061) 2-15 -2)0
80052*-501 2-25 -1I21 800592 L~ZE 98 800656 1-25 -101
80012)~501 Z~25 1100593 61 80DL51 2~PI- BE
800531‘501 95 1)0019(‘501 2-15~ 66 800651´•) 2-24 -9L
8005~5‘1 2-32 22 80019)~509 66 800658-1 )~)5 PI
8005)9-1 2-26 36 800595-1 2-25 -190 800659-1 2-2~ -LOb
800)61-3 2~25 ~1 800197 2-25 32 BOOL60-I 2-25 -2210
800561-5 2-15 -63 800591-3 )5 8DDb60-l(ll L~25 ´•PZ)D
800561-501 2-25 -31 8005’)8-1 ~33 BOOl6l 2~25
800561’513 2-15 31 800599-1 2-21 bB 8006bl 2-27
800161~523 ´•31 800601 2-11 -226 80D6bl L~ZB
8005~2-1 800602-1 1 1-21- 52
)001(,9-1 2-25 5L 8006P2-501 2-26 2 800bb(‘3 2-21 53
8005b1~40L 2-25 ~)B 800602~107 2 B00bbl-5 1-27 -5~
800565~1 P-25 -38 800603 2- 6-3I
800566-1 2-15 800601 1~25 ~215 BP003o-501 2‘15 -L61
800567~535 2-25 )2 800605-1 2-25 11 )-25 -L~I
800567-5(1 2~25 ~´•L 800601‘1 P~PI- 19 R30-2)L 2~ L L
8005b9~561 )-21 -~Z 800601-2 2-21- 19 830098 2‘12 Is
800512-1 2-61 800L08~1 1~11-17 8)00’)9´•511 Z~1P -81
80017* 800608´•2 2-21- 11 830399-517 2~12 81

9-40 lievised: 211 Naurmbsr 1984

 ILLUSTRATED
GULFSTREAM Section 11I
COMMANDER PARTS CATALOG
Numerical Index
BSOA/BgOB

FIGURE P 1 R T FIGURE P L R T FIGURE

p L T
G INDEX 8 INDEX G INDEX
NU*BER N U B E I NU~BER N U B E R NU*BER
N U a E R

2~LZ ~83 8.0110 2-)0- 8 850116-)1 2-35 ~llZ

830101~1
P-LI- 84 850174-503 2-26. 6 85006-)1 2-31 -121
8301(12-2
8) 850L86~505 )-11 21 85012L-63 2-35 ~115
830L01~501
2-12. 81 810186.505 2-23- 11 850(26-64 2-35 -128
830102-503
2~ 8 ~(3 85(11sb~109 1~L7 26 850(26~61 2~35 ~131
833006
8501’)5 Z D50126-69 2~35 ~1)O
8))019
1-21 ~LOOB 850191-3 Z~1*. 5 850)26‘1 2-36 35
8)1038-1
1.15 -168 85010-~ 2-68- 81 850126-9 L~35 ~99
833038-1
850(30~11 1
2-PS -LBSL 850202 1-29 LO
833038-1
1~25 ´•2)1 850)05~5(11 2-la~ 9 850130-13 2
8)3038~L
2-32 -13 85022L-503 1-19- 7 850))0-15 2-35- 37
8))0)8-1
9 850221.505 1 850()0‘11 2~35 -39
8)~0)8-1
2-73 -25 810221 2-21. 66 1~35 ~3L
83)038~1
2-25 -169 850224 2-)5- 54 850(30-~1 I-3(- 39
833038-)01
31 2-29‘ 1 B10)30-I) 13
8330)8~501
2-32 13 3 2~36 12
2‘3)‘61 850218-1 1-3*-)8 850130-25 35
83)(1)8-~01
2-25 -169 8~0178-1 61 850()0-21 2~36 10
8330)8-501
2-26- 11 8)0285 2-3~- (01 850)30-) 3*
8310)8-905
2-32- 2) 850285 1-36 1 2~36 -1I
831018-505
2-)(- 61 85D285-L9 59 850130-3 2-72 -25
833038-505
83)018.505 2-14- 83 850285-23 2-34- 6L B5O)P0-9 1-3)- 62
1 850285-29 2-3)- )01 850(30-9 1-36 6
8)6.57P
2- 1 25 850285-5 2-34 53 850)36-1 2-)5 56
838-lit
810-81 2- L 25 BSOPBI-l 850)31 I-33
2-3)- B 8503L9-’IOL 2- 6-21 810)38-1 2-33 -60
850001
850QOFI 1-)´•. 9 850)L9~501 1~69. 2 850)(0-501 1-33 ~58
9 850399-1 2-)5 -58 850((0-101 2-31- 59
810011-501
850015-102 9 850100-L L‘35- 61 85r)))l-L 2~33 ~56
850015-503 L‘f~‘ 9 850)01‘1 2-39~ 61 850(45-L 1´•31~ 71
asoola 2-25 -23) 850102-1 2-35- 51 8501(6-1 2-33- 67
810016 2-3(- 1 850*03-1 2-35- 99 850(46-1 2-33- bB
2-3( 850)0*-1 1-16~ 63 85D()7-L 2-33- (19
850024
85009L 1-19 5 810(05-1 1-3~ 6) 850))7-2 I-Il 70
850099-501 2 850106 2-35- (O 850(46-1 2-33- 51
8)0091~)0) 2~29 110(06 1( 810)50~1 1~)3 ~)L
2-29 -10 850)06-3 1-35- 66 850150-2 2~))- )Z
810091
850096 2-29- 9 850111-1 1-35- 60 810(12-1

850091 2.29- 810)11-1 2´•35- 55 810)5´•1-503 1-33- )I

L-30 .7850426 32 BSO()b-l 35
850098
850108~503 850426 1) 8)0)5b‘~ 2~33 -)6

850108-50) 1.33- O 850126 )-)’1´• 96 8~0158´•1 2-33 -)2

850111 2-3( 19 850´•26 2-36 2-93 30
850111‘11 810116~RE3 L~39 30
85O111-L5 850)26-885 850)62-105 2-)3 -30
81011b-RE7 810171-503 1~)3 -6)
850111~LI
85011L~L1 P-)(~10 850126.819 1~35 ~130 810)1)~501 2~33 ~13

810111-13 2.3)-10 850426-11 2-35 -10L 850)75-1 2-30- 1

850Lls 2-29 I 8501L6-L3 1‘35- 98 850)11-501 P-L´•I~Plb

810L32 2-31 810)16-15 II 810)1´•1-503 1-3)~ 11
850132 2-36 -7) 85(1)16-17 2-36- 850115-503 1-3*- 90
850I32-3 1 850)26-23 850)1(1-509 ~-3L‘ 1

850131-50L 2~3L 850126~P5 2~16. 6’) 810(11~1 65

840165-L039 I-)1´• 51 850416-27 2-36- 66 850(18 2-31- 5

850165‘10)1 ´•52 2-16~ 61 810)79 LO
850161-111)1 1-36- )1 8´•10126-3 850(19 2-35
85016~j-10)) 7-11-~6 810)26-31 2-35 ´•LLI 850(19 2~35 ~68
I~)S -)I 58 810(93~101
850165~1011 1-)5- )3 85012~‘33 1~35 -110 850)s3~109 2~15 -213
1~)5 1-15~119 850(93~911 P~30 ~10
850L65~1)5 2-36 -31 BSOILb‘)l )1.35 ~101 8501’)3´•519 ~‘30 ‘10
850165-1)7 2-36 -32 850)26-)3 2-35 -103 810)98-1 2-30
850165~3)5 2~36 23 37 850(98-503 2‘ 8~57
L~3b -29 ~115 81D)98~fi0) ~13L
810165-611 2-36 Il 850116-19 2-36- 51 850)98-505 2- 8-)8
850165-893 )~3b PI 2~35 ~113 2~30 LZ
850169 P-31 2 850126-)3 850103-11 2-35 I
850110 2-2L -LZL 850)26-55 2-35 -11I 850503-13 2-35 6

Ileuised: 28 November 1984 3-41

 ILLUBTRATED
Beotlon III
PARTS COMMANDER
Numerlosil Inden
BB(NL/BOOB

P I I T FIGURE P 1 R r FIGURE 1 T FIGURE

E INDEX C INDEX ~IHOEX
N U PI B E R NU*BER N U n a E a NUMBER N U n a E n NUMBER

850503~13 2-)9 15 25 BbDI)O I.65 -15

850103-15 1-35 5 81017)-501 L-~)- 25 8602)2 2~65 16
850103-15 P-35 1) 850514-509 2-3P 25 860287-3 2-71 (B
850)0 3~11 2~35 IZ 850515~1 1~)3 PR 8~0287.5
8)0501-19 2-35 -15 850515-101 2-)1- 28 8)0281-501
85(1’103-L9 2-35 -80 850576 i-II 66818)-7 2-71- 31
810503-21 2-35 1 810176 19 P-bS 61
850501-21 1-35 -69 8’10576-) Ib 869391.501 2-65 ~50
850503-11 2-36 B 850511 L~Z9 860)1).503 2‘65 -19
850103~P1 2~36 LIIIII1I 1-33- 860510´•50L 1~65 ~5)
850503-13 850511-3 5 860111)´•50~ 2~65 -5)
850503‘23 2~35 850511-1 L-)3~ 5 8(10118 1~65 L)
850503-21 2-31 -73 850511-9 2-33- 5 860L2)-L 2-65- LI
850103-25 1-34- 11 850518-1 I-)2 B60b25-I 2-65 -15
850503~27 11 1-)3- 19 BbOLZI.1 2.65- Lb
850503‘29 II 850578‘11 6 B6DLZP-L -Is
8)050)-31 2-3)- 1) 850518-3 2-33- 23 860)8)-519 2-21- 10
81(1503-31 2-35 3 850578-503 2-92 86018)-113 25
850503-31 1-)5-11 810178-50) 2-3)‘ 19 860183-511 2-65- Pb
850’10)-33 2-31- 12 810118-501 2~)2 860)83.519 L-bl- I(
8)0503-)3 2-35 2 850178-105 2-33- 19 860’183-561 2-65 -)1
810503-13 1-)5-10 850578-507 860183-603 I-b5 -II
810503´•61 2-35 LI 850578-507 2-33- 19 Bb0183´•b05 P-(5- Z1
850503-61 2-)5 L) 850118-109 2-32 860183-607 1-65- 2)
85~503´•b9 2-35- 11 850578-10’) 2-33- 19 860189-609 2-65 LI
850103~69 2~35 ‘11 850918-1 23 Bb0875´•103 2~15 LO
850503-83 810’178-9 2-81- 25 860910
850103-83 2-)5 -79 850579-1 22 860910 2-51 -119
850503-9 2-35 -11 850119-501 2-)3~ 22 860911-1 2-52 -LIO
B105P3-91 2-31- 76 8~0580-1 20 860951 1~11‘ 5
810603-93 L-35 18 850580-503 L-33- 20 8~0951-3 )~11‘ 8
850508 2-3( 62 2-33 IO 860967
8)0511-1 2-3)-13 810’181 )-)O 860967
850516-1 810581 1~)3 B 860968-51 P*
850516-1 2-3,- 94 esossl-, 9 esosba-1 1
slasl8~1 2-21- 68 850581-7 2-33- 9 860968-3 2-12- 1
BIOIPE1 2-3)- 1) 850182-1 2-13~ i 860968-501 1
850)22-501 850~85-1 PI 860969-503 I-12-
850529-1 2-36 L(I 850581-1 2-29- 1 860969-505 2-LZ 3
8)0129-1 2-36- 1) 850589-1 2-32- II 86L001’1 2-58 L
850530-3 P-)5 -53 850590-L 861901-101 2-18- 1
8)0130-3 2-36 -15 850590-101 1-30- IP 861006 2-65 ~18
850530-7 1-36 LI 8501130~103 2-25 -231 861001 2-65- 36
850530-9 2-36 15 850590-101 2- 8-58 1-65 -)B
810534 2-61- 23 850590-501 86L408-502 1-65 -)8
850534-5 2-6L PI 850590-509 2~30 LZ 86L009 2-65
850’13)-1 2-61- Z( 850590-511 2-25 -211 861009 2-71
2-61- 27 850190-111 2- 8-58 861D09‘L1 2-7l- PB
810590 1-)6 L) 85059(-1 811009-13 2-11 LP
850511~1 2-15-72 850599 1-3(‘ 80 861009-15 2~11- 3)
85056J-L 2-34- B 85(1600 861009-19 P-I1- 32
890561 6 810601~501 L~)(- 88 861309-23
8105(16-1 a 850602~L 2-3(- 92 861309-)9 25
850565-501 B 85060)’1 2-3)- 93 B6lD09-) 2-11- ~L
2~30 1 8580 2‘11- 36 B6lD09-31
BIOII~IOL 2-31-66 860005 2-65- 65 861009-33 P-II- )O
2~3) 65 860005-21 61 86LD09~)7 2~11 19
850)7L-I 2-3)- 50 Bb00D5‘IB bl 861009~39 L~II‘ 26
850571-2 1-)3 -50 8(10001-29 2-65- 63 861509-)1 )-11- 30
850572 2-33 2)C 8(10001-)0 2-65 68 861009-45 2~11- 21
850512-1 131 860227 2~65- 861009-(7 )O
850512~503 I3I BbOZ27~L 1 LO 861309~´•9 L~II- 26
850572-505 2-32 L)L 2-65 II Bb13D9-5
8’10’172-101 2-31 131 810L21-17 ~-65- IP 861009-7 I-II- is
8505)1-509 1-32- 111 2-65- Il 86LOD9-9 2‘11~ 23
85051P´•511 I-3P -13*BbOZZI‘I 2-65- 5 861026 1-29 -136
850513-501 2~31- 29 860121-9 2-65 b 861026
85057)-1 1-)1- 25 860238-505 1-65- 11 8610)3-505 P-b5 -)B

5-42 Revised: 28 Novsmher 1984

 ILLUSTRATED
OULFSTREAM
PARTS CATALOG Section m
COMMANDER
Numerical Indeu
as0A/asoe

P d R T FIGURE P R T FIGURE P I R r FIGURE

C INDEX t INDEX C INOEX

W B E R NU*BER N U 8 E R NU*BER H U B E R NUIIBEI

N U

2~65 )9 Bbl8s7-19 Ibl 86b133~) 2~ L ~51

8111)33~507
2-65 -131 861887-3 2-59 -1L 866533-3 2- 5 -11
861035
2~65. O 81188)-5 L~SP´• B 86L5)0‘2 2‘ 5-31
8b1035-3
~-b5 -16 861887~9 2-59- b 8611119´•L 2- 5 -56
8b10)5~5
2-65 11 861889 2-99 867)89-1 2- 5 Sb
8610)L
2-6~- I) 8(1889-11 Z-59- 8(11935-1
86L0)1-5 0bl8s9-L3 2-59- 5 BLBIIIB-l 2- 5-71
2-65- 30 B(IBlbZ-I 2- 5-52
8610(1-7 2-65 -)31 861892
11 L~65 )3 8M169~1 5 Sb
Bb1090~L
2-69 -59 861892-3 2-65- )3 869215-4 2- 5 -17
861090-7
86189) ~‘65 19 B69bOL~I 2~ 5 60
BLL091~5D1
2~15 25 8b1896 2-71 (9 869888~1 2~ 5 (B
86L22)-219
861896-11 2-71- 56 880018-)0) 2-51-113
8612)2-1
86L212-13 39 861896-1) 2-11- 58 8800)3-1(15
8612)1-3 2-11-)9 861896-15 1-11~ 5) BB00´•il )-68‘53
2-71- 38 861896-3 2-71- 59 880055 2-68- 16
861896-5 2-71- 5( 880055-15 P-LB- 19
R6LZ12-501 1-II. 3)
1-11-45 861896-7 2-11- )5 880Db6 2-68 -51
861211-9
Bb1896-9 2-71 51 88009)-1 2-68 52
861210 2-22 -236
2-25 -2378 861899-L 2-65 b( 880155 2-67 -12
8b1250-3
Z-25 -L37C 86L899-2 880115-11 2-67- )7
861250-9
2-15 -22 861899-511 2-b5‘ 61 B80155-(L 2-67- Ib
861270-1
2L 861899~112 2~65 6) BBOL52~)3 L~LI 3L
861289-1
)-11~ 69 861899.513 L~65- 6~ 880155‘)5 )2
861521~1
L-65- 61 BBOlls (L
L161511~501 Z-ll~ 66 861899-5L*
861900~1 11 880118-501 Z~bl ~38
861121~503 2~71. (12
~-65- 11 880L58-509 1-61~ 36
061521-.01 Z‘~5 ‘36 861900-2
b) 861900-113 2-65- 71 880118-111 (I
861921-50( 2-7l-
Z~ll- LI 861900-51) 880158-51) 2-67 -)6
861)L1-505
2-65- 35 BL19DZ~I 2-65.14 BB015L1~5L5 2-67- O
861)11~513
2-65 35 861901 2-56 880150-517 2-61 15
86142 I-SIS
2-65- 35 86190(-5 2 880160 2~67 ~39
BLL511-5ZI
2-65- 35 861909 2-61 880165-15 2~61 B

2-71. 6) 861909 2-62- S 880165-501 2-67- 3

861521-519
6 880L65-7 6
86152 I-43L 2.71- 66 861909-37
I)BOL~´•I-P 7
011880 2-611~ 6 861915~.(13
2 86L918-L 2-65- )6 880167 )~6)- L
BLLBBO 2-6L-
1 861918-3 1-65- 62 8110110 2-25 -1)5
P-b0-
-10 861918-5 Z-b~- 19 880110 Z~b6
BblBB0~15
BLLBBO-LI 3 66L921 L-65 Il 880110
0619)9 2.67- B 880110 2~68
86188(1‘19
2-60 86L919-7 2-61. 1121 BB0L70 2-69
86L880-11
3 861951-~ L-67 1 880110 P~IO
BLIBB0-3 2-61-
1-61 6 861911-65 2-65 11 880179 2-67 53
BLLBBO-5
5 861e51-61 II 8801’)3-101 2-bl~ IO
861880-1
2-61- 1 861951-11 2-6~- ID 2-67 -*D
BblBBO-9
1-I) 861951-73 1-65- IO BBOLO’I 1-25 -182
861885
86L9)2-L 2-59 880205-11 2-25 -189
861885 I-PI -236
2-51 -169 861952-2 1-)9- 3 880205-13 2-25 -IBB
86L885
1-58 2-59 2 880205‘1) 1-25 -189
861885
2-59 8619)3-1 2-59 1 88020~´•11 2-25 -189
861881
861953-2 2-59 1 880105-3 2-25 -191
861885 2-60
L-61 861955 I~bO 080205-7 2-25 -192
861185
2-65 861955-13 l-bO 6 880206-29 2-67 13
861885
2-60 5 880201~105 P~6) IZ
861885
2-65 -78 861951-1 2-60- 1 880211 2-68 L3
861886
2-59 5 ~61951‘101 2-b0 1 880111~23 L~bB II
81188)
2~59 9 861957~503 L~6(1- Is
861887‘11
2-’19 -Ib 861959.1 2-6L- L 880211-)) 2-68- 19
BLIBB1-l)
~10 880211-)7 l-68- 16
861887-15 1~59
861997 I-1S -236 880)17-15 2-68 -Ib
811887-11 2-59 ~11
6 862011~1 1~15 ~23 BBOZ17~L9 39
BL1BB)-IP 2-59‘
86161b-3 2- b )6 880P17-21 1~68 3(
861887-Ll 2.59 19
P-5D- LI 86566)-3 2- 5-50 880217´•3) 2-60 II
861887-21
2-59 LI 86579!-4 2- 5-73 880211-11 2-68 -´•7
8~L881-21
1~1-69 BBOZ1F50L 2~68 30
811881~21 1~59 ~15 865853.2
2-59- LS 2-1-5) 880217-503 2-68 -30
86L887-17
2-59 -Ibl 866533-17 2-1-58 880211-11 2-68 )1
861887-29

Revised: 28 November 1984 3-45

 ILLVSTRATED OULFSTREAM
Section In PARTS CATALOG COMMANDER
NumericaLIndeu 880A/680B

P 1 R r FIGURE P 1 R r FIGURE P L R T FIGURE

6 INDEX L INDEX L INDEX
N U n a E a NUWBER N U W B E R NU*BER N V n a E a NunsEn

88021 1~59 2-68- 33 880575-2 1-67- Pt 8903)8-21 2-71- 21

880111-65 2-bB -)2 BBDSlb-l IZI 890318‘21 2-72 -(O
~)L 880511~501 23 890)(B~Z9 1~72 I
88(1219~503 2~6P ´•*3 23 8903(8-)P 2~7P -83
880223 I-bB 880518~1 2-61~ 35 L‘IZ -13
880213~23 I-bB -67 880580~1 51 890)(8-11 Z~IP-12
880123-39 Z-5IL- 28 880581-1 1-68- 5 89L13)8-19 2-72- 36
BBOZ13-~L 2-5)1- 29 880583 2~LI )6 2~12 9
BB01I 3-13 2-68 69 880583-25 2-66- 23 890))8-83 2-12 8
2~68 86 1~66 18 29
880213-)9 2-68 BE 880583-29 2-66- ZO 8903(8-87 2~1L -31
880223-53 )I-bB -76 88(1181-3 2~66- 1 890148-89 2~12 LO
880223-9 2-68 10 880513-33 1-66 3 1-IZ -16
BB02II 1-50 67 L~bb 62
BLIOZt( 2-68 -10 880183-37 2-66- 5 8903~8-P1 1-3(- 39
880224-11 2-68 -11 880581-)9 L-LL 6 BP03)8-P3 2-36 -1I
880125-31 1-68 -13 880583-)1 2-66 1 8903L8-93 1~36- 50
880225-505 2-68 -11 880583-)3 1-06- B 8903(8-93 I-Il -53
880221-10’1 2-68 -IZ 880183-103 2-66 890356~101 2-12 BP
880130-501 I-bB -22 680584-1 Z-b9- 31 890)56´•)0) 2-12 3
880232 880585-1 Z´•b9- 31 890)51-1 2~72. 86
880232 2-69 810585-501 2-69 31 890110 2-73 13
880231 2-69 12 88058L~1 L~69 ZD 890375
88015I-I 2-68 -36 880581 1-67- 65 890375 2-13 -22
880253-501 Z-bB -38 880591 2-67- )21 890)88 2-73 -11
880162-1 2-68 -19 880591-3 890381)‘1 2-13 -)P
880115 2~68 29 880606-501 1-68 61 890(05 2-47 51
880215-3 2-68- )9 880608 2~61- 1) 89D(L6-1 2-27- II
880275-5 2-68 -)8 BIIDLDB 2-67- Sb 89011CL 2-27 -31
880175-7 1-68 II B~Ob08‘3 I-(lI sil 890((1-3
880211-9 1~68- 50 880609-1 1~(18 65 890((2 2-69- 63
P~b9 6 880612-1 L-~l- 57 2´•~e‘ 68
880276-25 I-f,9 LL 880112-21 2-67 6L 890(*2-5 2-69 II
880276-19 2-69 ´•10 880612-3 2-67- 59 8)0((2-1 2-69 -70
880176-31 ~11 2-67 -60 890)*2-9 1~69 -IZ
880216~39 2-69 5 BBOblB~L 2-68 -66 890((7 1-25 -226
880276~11 2-69 1 88061)‘1 2-68- 8901)1-3 1-25 -2270
88021(1-13 2-69- 8 880)15-1 Z-~8- 83 89001-5 I-Is -2118
saozlb-~5 2-69 ~1’1 880628-1 2-68- 1I 890))8 1-3)- 1O1
BBOZIb-II 2-69 ZL BBOLIB-l 1-69- 59 890(I8 I-IZ
8BOPl6-)9 2-69 -15 2-69- 52 890((8-13
BBOZlb-´•il 2-69 22 BBOb~L-l 2-69- IB 8’)0))8-31 2-72 -)D
8802)6-53 2-69 -)01 880662.1 2-69- 11 R90(ls-15 )5
880216-55 21-69 I08 880Lll-1 2-67 890))8-3 2-12 II
880276-57 2-69 -21 BBDbIL-I L~67- )9 2-12 -73
880276-59 ,-se- Is seosIs-n 2~-al-,P 890))8-1
BRO))L~bl 7) ZPB 893101~1 5 51
880216-65 Z~b9 -)1 883008 2~29 6 893128~3L 1- 5-31
2-69 -)5 8830)3-501 2-36- 20 8935)1-33 2- 5 -31
88021b~69 50 BBJ013~501 2-~6- 5) 893)87~’1 I~l-Sb
880276-75 1~69- 53 8883 2~11- 10 893587~8 I- 5 Sb
880116-11 89033) 1- 1-58 8937)2-L 2- 5-15
BBOZib-I9 2-69 -5( 89033( 89)117-2 2- 5 -)Z
880216-81 2-69 -55 890318 891)36-1 2- 6 -I)
88021(1-81 2-69 6 890338 89513’(-5 2-I-11
2-))- 33 890s)6 2- 5 ‘57
880116-85 2-(19 16 8903(6-11 2-3)- )O1 891)80-3 2- 5 -lo
BB021b-R7 2-69 Il 890L16-11 L-72 -~3 895(8L-2 2~)‘)9
880216-89 2-69 62 8903(6-L7 2-12 28 89)990-3
880276-89 I-Ii-ID 8903~8-11 R95)9P-I
880)21-105 2-68 -19 8901)8-13 5 89b233-1 I- 5 -Is
880)12-50´•1 1-68 -26 8903)8-L5 2-IL B 89(1256-2 Z- 5 ZP
880)11~503 1-68 -21 8901)8~17 2~12. 9 Z‘ 1~61
880~2)-503 2-69 -36 8903)8-19 1-12- 6 8’)719(1-1 1‘ 5 ~35
880528-501 ~-)b 56 L-12 15 90-9)5 2~61 19
BBO’il)~l 2-68 -10 8903)8-23 900009-13-16´•9) 2~62 59
880571-1 1-69 -3~ 8903)8-25 bl 900009-23-5´•00 83
880575-1 2-LI Z) 8903)8-25 2-12. 15 9001109.23-6.15 1-1)- 71

5-44 loviborl: a8 November 1884

 ILLUSTRATED
C~ULFSTREAM
leetion UI
COMMANDER PARTS CATALOG
Mlmerical inden
esoi\/ssoe

FIGURE P 1 S T FIGURE P L I r FIGURE

P I R T
L INDEX E INDEI L INDEX

N U B E R NUnsER N U B E R NU*BEI( N U 8 E R
NU*BER

Z.P5 -1)3 952b136 1~15 52

1~LB‘19 900112~505
26 90(1113-L -101 9526287 Z~15- (’L
9P0009-PS~1´•´•10 2~18
PI 900113-507 2-12-108 952)288 1~15-()
9o0009~3L-LO´•2D
900LL3~109 )5
Z~LB -22
i~bl- II 900113-513 2 9529 2-19 -105
900009-)9~1´•PZ
1-62 *O P00II3-515 2-11 28 P530
90000s-)9-9´•10
25 1531 I-I9 9~
9000L 3-3-0.17 2-39 -112 900119-511
12 900115 9532186 Z~L9 ~55
2-(3
900116-501 2-38- 10 953( 2-19 -90
2-39-118
8 9)3(013 Z~l’i 2L
900013~)‘0´•11 ´•LPI 900116-503
900116-505 2-38- 9 953)0*) 2‘15 ~35
900011-)~0´•17 P~O IS
69 908116-507 2.38- 1 953(0)5 2-15- LZ
90001 1-)-0´•17 2-51-
e0011b~109 1 953))2( L~lr- 3I
90001 )~)-0´•18 2-39 ~66
10 90011b~511 2-38 9 P5))9L5 2-15 ~6)
900013-)-0´•18 2-39
2-39 -90 900118-501 ~.II-L3 9535 2-19 -66
900013-(-0´•18
2-,1- Io 95350(* ,-15- 56
PI Poalpo
900129-66 2-L0- 21 95)10(5 2-15 5)
2-)3 -82
2-10~ 62 95353L8 1~15 16
900016~2)´•75 )~Is LI
2-)1 1 900129-66 61 95)5319 2-15 -25
90DOLL-)3´•)2:
900129~82 IB 9531321 2-LI~ II
900016~1´•50
2-LO 19 91)1311 L1
900023 2~)1 78 90012e~81
2~13 65 PSlb591 2-15- 30
900036 8 10 900
9100)8-107- )00-3 2-bl~ 1(1 9336601 2-15 28
P000)1-)0-55
2-53- 11 9539 1~L9 ~88
900031~60.1(1 )3
6 2-15 I
900837.60-16 2-35- 96 9)0003-10
2-20- LI L-LS- 10
e000)0.)-~0 930017
910018 Z-L) IP 95(3939-1 2
9000)0-)0-15 2‘23 -LPB
2-I5- 16
L~3) )9 930021-501
1-13 16 1-15 2
900051-529 2-25- 93 930021-503
93005)-1 95)3162 2-19- Il
90001)-3´•56 2-62 -56
9300’15~1 1~ 2~18 12
900079-)-80 2-21 -LOI
95)1 2-19- 81
900019-(0-50 2-21 -71 930056.1
95´•1021 CZb~ 11 95~6 1-19 BZ
2-19.(0
95111)1 95531)b Z~L5
s0009e-.03~-´•10-´•80 2-65 56
952213( 2-15-)1 e56LOll 1-15 -33
90010rL 1-)2 I
2~L5 10 911000~) 51
900106503 ~‘5L ~Is ´•)52213)
9522159 2-L5- 19 9861 2-19
900106-503 2-57- 3
9522728 2-15- 20 99ZO 2-L9 -111
900101-513 )-SP- 10
9931 2-L9- 10
900106-51) 2-59 -29 9523892
952(203 2-19- 58 9935-1 L-19- II
90010(‘51) 2-60- 1(
L‘le- 56 99)5-3 2’19- 73
90(1100-113 2-61- 11.9521LLB~
952)318 2-19-is 9~11 2-19 -II
900106-519 2-58- 5
2.Lt -)B 9525909 I-L5- 60
9DOL09-501

Revised: 28 November 1984 5-45/3-48