You are on page 1of 6

1)Which of the following statements best describe TTL?

TTL is defined inside the header of the frame

TTL represents the amount of time allowed for a packet to survive.

TTL value is decremented by 1 each time the packet traverses a layer 3


device.

TTL value is incremented by 1 each time the packet traverses a layer 3


device.

2)The segment is formed in which layer of the OSI reference model?

Datalink layer

Transport layer

Network layer

Physical layer

3)According to OSI reference model, which layer is responsible for end to end
connection?

Transport layer

Physical layer

Network layer

Data link layer

4)A network administrator has captured a data frame in the network with the
destination MAC address of 01-00-5E-A0-B1-C3. The correct statement about
this MAC address is

It is a broadcast MAC address

It is an illegal MAC address

It is a multicast MAC address

It is a unicast MAC address


5)Host A and host C are in the same network. Host A wishes to send data to
host C, and generates an ARP request to obtain the destinaton MAC address.
Which statement is true?

The destinaton IP address of the ARP request is Host C

The destinaton MAC address of this frame is the MAC address of the
router.

The destinaton IP address for the ARP request is a broadcast IP


address.

The destinaton MAC address of this ARP request is Host C

6)The default subnet mask for a class A address is .......

255.255.0.0

255.255.255.0

0.0.0.255

255.0.0.0

7)A network administrator uses the ping command to check for points of
failure in the network. Which protocol will be used during this process?

TCP

STP

UDP

ICMP

8)As shown in the figure below; Host A and Host B can communicate.
True

False

9)In the full duplex mode, the transmission of data is in both sides
simultaneously.

False

True

10)Which of the following is a broadcast address?

200.0.0.100/30

192.168.1.1/24

192.168.1.15/24

100.0.0.15/28

11)In which layer of the OSI model the frame is created?

Data Link Layer

Transport Layer
Physical Layer

Network Layer

12)Which of the following IP addresses is the broadcast address for the


network 10.1.1.0/30 ?

10.1.1.1

10.1.1.2

10.1.1.0

10.1.1.3

13)Every packet has a trailer to check the validity of data.

False

True

14)According to TCP/IP reference model, the fourth layer from the bottom is
…........

Transport layer

Session layer

Network layer

Application layer

15)Which layer of OSI model is responsible for routing of packets from one
local network to the next?

Layer 2

Layer 4
Layer 1

Layer 3

16)Which of the following statements regarding ARP is TRUE?

ARP discovers the destination port number.

ARP discovers the destination IP address.

ARP discovers the destination MAC address.

ARP discovers the source MAC address.

17)Which of the following applications can be used to detect the path along
which the data packets are transmitted from the source to the destinaton?

Route

Tracert

Send

Ping

18)A coaxial cable supports higher transmission speed than a fiber optic
cable.

True

False

19)In which of the following transmission media can collision occur?

Coaxial Cable

Twisted pair Cable

Serial Cable
Fiber Optic

20)If a data frame has a type field value = 0x806, this frame is an Ethernet
II frame.

False

True

You might also like