Professional Documents
Culture Documents
Product identifier
Relevant identified uses of the substance or mixture and uses advised against
Relevant identified uses Pharmaceutical Grade Reagent. For Manufacturing and Laboratory Use Only
Use Description Code Not available
Uses advised against Not for consumer use.
Manufacturer/Supplier
24 hour Emergency Response for Hazardous Materials Within the USA + Canada: 1-800-424-9300 and +1
[or Dangerous Goods] Incident. Spill, Leak, Fire, 703-527-3887
Exposure, or Accident. Call CHEMTREC Outside the USA + Canada: +1 703-741-5970
www.thermofisher.com
Classification of the substance or mixture
Physical hazards
Flammable liquids Category 3
Health hazards
Not Hazardous
Environmental hazards
Not Hazardous
Additional information
No information available
Label elements
Hazard pictograms
Signal Word
Warning
Hazard Statements
H226 - Flammable liquid and vapour
Precautionary Statements
Prevention
P210 - Keep away from heat, hot surfaces, sparks, open flames and other ignition sources. No smoking
P280 - Wear protective gloves/protective clothing/eye protection/face protection
P233 - Keep container tightly closed
P242 - Use non-sparking tools
P243 - Take action to prevent static discharges
Response
P370 + P378 - In case of fire: Use dry sand, dry chemical or alcohol-resistant foam for extinction
P303 + P361 + P353 - IF ON SKIN (or hair): Remove/Take off immediately all contaminated clothing. Rinse skin with
water/shower
Storage
P403 + P235 - Store in a well-ventilated place. Keep cool
Disposal
P501 - Dispose of contents/ container to an approved waste disposal plant
Other hazards
______________________________________________________________________________________________________
www.thermofisher.com
Not Applicable
Skin contact Wash off immediately with plenty of water for at least 15 minutes. Remove and
wash contaminated clothing and gloves, including the inside, before re-use.
Immediate medical attention is required.
Eye contact Rinse immediately with plenty of water, also under the eyelids, for at least 15
minutes. Immediate medical attention is required.
Ingestion Never give anything by mouth to an unconscious person. Do not induce vomiting
without medical advice. Get medical attention if symptoms occur.
Inhalation Remove to fresh air. If not breathing, give artificial respiration. If symptoms persist,
call a doctor.
Notes to Physician Treat symptomatically.
Extinguishing media
Suitable extinguishing media Dry chemical. Alcohol resistant foam. Water spray. Carbon
dioxide (CO2).
Unsuitable extinguishing media No information available.
______________________________________________________________________________________________________
www.thermofisher.com
SECTION 6: Accidental release measures
Environmental precautions
No special environmental precautions required.
______________________________________________________________________________________________________
www.thermofisher.com
SECTION 8: Exposure controls/personal protection
Control parameters
Chemical Name Austria Belgium (TWA) Denmark (TWA) Finland OEL (TWA)
Ethyl alcohol 1000 ppm 1000 ppm 1000 ppm 1000 ppm
64-17-5 1900 mg/m3 1907 mg/m3 1900 mg/m3 1900 mg/m³
Chemical Name France OEL (VME) Germany OEL (TWA) Ireland (TWA) Italy OEL (TWA)
Ethyl alcohol 1000 ppm 200 ppm exposure factor 2 None None
64-17-5 1900 mg/m3 380 mg/m3 exposure factor 2
Chemical Name Sweden - Occupational Netherlands OEL (MAC) Spain OEL (TWA) United Kingdom
Exposure Limits - TLVs
(LLVs)
Ethyl alcohol 500 ppm TLV NGV; 1000 260 mg/m3 None 1000 ppm TWA; 1920 mg/m3
64-17-5 mg/m3 TLV NGV TWA
Chemical Name European Union France OEL (VME) Germany OEL (TWA)
Ethyl alcohol None 1000 ppm 200 ppm exposure factor 2
64-17-5 1900 mg/m3 380 mg/m3 exposure factor 2
Chemical Name Italy OEL (TWA) Portugal Netherlands OEL (MAC) Finland OEL (TWA)
Ethyl alcohol None None 260 mg/m3 1000 ppm
64-17-5 1900 mg/m³
Chemical Name Ireland Norway Lithuania OEL (TWA) Spain OEL (TWA)
Ethyl alcohol None None 500 ppm None
64-17-5 1000 mg/m3
Exposure controls
Respiratory protection In case of insufficient ventilation wear respirators and components tested and
approved under appropriate government standards.
Hand protection Wear suitable gloves. Glove material: Compatible chemical-resistant gloves.
Skin and Body Protection Wear laboratory coat for body protection.
Hygiene Measures Handle in accordance with good industrial hygiene and safety practice.
______________________________________________________________________________________________________
www.thermofisher.com
SECTION 9: Physical and chemical properties
Appearance suspension
Odour Mixture has not been tested
Odour Threshold Mixture has not been tested
pH 6-8
Melting point / melting range °C Mixture has not been tested °F Mixture has not been tested
Boiling point / boiling range °C Mixture has not been tested °F Mixture has not been tested
Flash point °C 37.7 °F 100
Autoignition Temperature °C Mixture has not been tested °F Mixture has not been tested
Decomposition temperature °C Mixture has not been tested °F Mixture has not been tested
Evaporation rate No data
Flammability (solid, gas) Not Applicable
Upper explosion limit Mixture has not been tested
Lower explosion limit Mixture has not been tested
Vapour Pressure Mixture has not been tested
Relative density Mixture has not been tested
Specific gravity No data
Solubility Completely miscible with water
Partition coefficient: No data
n-octanol/water
Viscosity Mixture has not been tested
Explosive properties Mixture has not been tested
Oxidising properties Mixture has not been tested
Other information
No data.
______________________________________________________________________________________________________
www.thermofisher.com
SECTION 11: Toxicological information
Specific target organ toxicity Conclusive but not sufficient for classification
(STOT)–si ngleexposur e
Specific target organ toxicity Conclusive but not sufficient for classification
(STOT)–r epeatedexposur e
Reproductive Toxicity May cause adverse reproductive effects - such as birth defect, miscarriages, or
infertility
Toxicity
The environmental impact of this product has not been fully investigated.
Chemical Name Freshwater Algae Water Flea Data Freshwater Fish Microtox Data log Pow
Data Species Data
Ethyl alcohol No data available Daphnia magna No data available No data available logPow-0.32
EC50=10800 mg/L (24
h) Daphnia magna
EC50=2 mg/L (48 h)
Daphnia magna
LC509268 - 14221
mg/L (48 h)
______________________________________________________________________________________________________
www.thermofisher.com
SECTION 13: Disposal considerations
UN number 1170
UN proper shipping name Ethanol solution
Transport hazard class(es) 3
Packing group III
Environmental hazards
Not Hazardous
Safety, health and environmental regulations/legislation specific for the substance or mixture
Substances under Regulation (EC) No 850/2004 of the European Parliament and of the Council of 29 April
2004 on persistent organic pollutants and amending Directive 79/117/EEC
______________________________________________________________________________________________________
www.thermofisher.com
None.
Chemical Name EINECS (European ELINCS (European ENCS (Japan) PICCS (Philippines)
Union) List of Notified
Chemical
Substances)
Ethyl alcohol Listed - Listed Listed
References
•ECHA:ht t
p: /
/echa.europa.eu/
•TOXNET:ht t
p://
toxnet.nl
m. ni
h.gov/
•eChemPor t
al:htt
p://
www. echempor t
al.or
g/
•LOLIdatabase:ht tps:
//www. chemadvisor.
com/
l
oli
-dat
abase
Classification and procedure used to derive the classification for mixtures according to Regulation (EC)
1272/2008 [CLP]:
"The above information was acquired by diligent search and/or investigation and the recommendations are based on
prudent application of professional judgment. The information shall not be taken as being all inclusive and is to be
used only as a guide. All materials and mixtures may present unknown hazards and should be used with caution.
Since the Company cannot control the actual methods, volumes, or conditions of use, the Company shall not be held
liable for any damages or losses resulting from the handling or from contact with the product as described herein.
THE INFORMATION IN THIS SDS DOES NOT CONSTITUTE A WARRANTY, EXPRESSED OR
IMPLIED,INCLUDING ANY IMPLIED WARRANTY OF MERCHANTABILITY OR FITNESS FOR ANY PARTICULAR
PURPOSE"
______________________________________________________________________________________________________
www.thermofisher.com