2. Fixing the units 3. Generate GEOMETRY as per input dimensions by JOINT COORDINATES and MEMBER INCIDENCE command 4. Apply ALL CHECKS from tools command 5. Apply RENUMBERING command 6. Apply REDEFINE INCIDENCE command 7. Specify RELEASES 8. Assign SUPPORTS 9. Assign MEMBER PROPERTY as per codal provision and self judgement of experience 10. Check MEMBERS WITHOUT PROPERTY. 11. EZ CHECKS.(Apply load in different directions in different cases to understand load path etc.) 12. Assign LOADING to floors and other structural components 13. Define LOAD COMBINATIONS 14. Run ANALYSIS after defining Perform Analysis Command 15. Check for ERRORS, NOTES & WARNINGS. 16. Define LOAD LIST for design 17. Assign DESIGN PARAMETERS also Defining design code i.e., IS 456 or IS 13920 18. Provide CHECK CODE command or DESIGN command 19. TRIAL & ERROR for section sizes 20. Define TAKE OFF command 21. FINISH