Professional Documents
Culture Documents
If you are a beginner that wants to build a Mini amplifier with tone
control.
With this, you can share a good sound of music from your cell phone to a
big speaker.
The key to this project following the circuit diagram below is TDA2005. It
is a 20 watts bridge/stereo amplifier for the car radio.
This form, there is a lot of the output power, more than others.
If you use a mono system the output of 10 watts. But in the bridge
system the output of 20-30 watts. At the same are an output speaker and
a power supply.
It is a power amplifier for the car radio, so uses voltage of power supply
is 12 volts 14.4 volts.
Which there are capacitors C2, C3, C6, and potentiometer VR2—Treble
controlling—to adjusts the signal level or the high-frequency sound.
● The gain output, set with resistors R9, R10 and R12.
● Two capacitor C12 and C11 are boost trapping to low frequency.
4
● C14, R8, and C18 and R13 protect a high frequency modulating
oscillator.
We like a great sound so we need to use a proper power supply for this
project.
R1,R2,R6: 8.2K
R3,R11: 1.8K
R4: 1.2M
R5,R9: 33 ohms
R7,R12: 1K
R8,R13: 1 ohms
R10: 10 ohms
Electrolytic Capacitors
Polyester Capacitor
Note: This circuit is mono, If you want in stereo systems, Just create
another set.
7
How to build
First of all, we make the PCB as Fig
The image PCB layout size is 300 dpi per inch. You can use
Components layout
Don't use the soldering iron tip and soak it for too long a device, the
device may be damaged.
9
The heat sink of IC1 should be sized appropriately. (Not too small), the
IC1 screw tightly.
The IC should be mounted to the Heatsink first, then solder the pin to the
IC.
We use the heat sink as Fig. My son drilling holes of the heat sink to
install
the IC1.
10