Professional Documents
Culture Documents
The Load Break Switch is 3 & 4 Pole manually operated, consisting two
sets of terminals for connecting to incoming supply & load. It ensures safe isolation and
is suitable for use in individual enclosures, switch boards, lighting and power panels etc.
with following features :
• Suitable for incoming and outgoing feeders.
• 2 stable positions (I - O).
• Fully visualized breaking.
• Pre equipped terminal cover, phase barrier with all ratings.
• Quick Make & Break type irrespective of human torque.
• Resistant to Tropical conditions & polluted environment.
• High thermal & dynamic withstand capacity.
• Self extinguishing fiberglass re-inforced insulating body.
• Available in Open execution, Steel sheet enclosure & Direct Mounted type.
• AC 23A Category.
• Bounce free contacts.
• Any pole can be used as Neutral pole... true 4 pole switch.
• Unique Safety Handle with built in door padlock facility.
• Padlockable in “OFF” position
• Castle lock, interlocking two isolators.
• High Electrical & Mechanical life.
Handle up to 630A Handle for 800A and above Auxiliary Contact Extended Shaft
Door Interlock Inter-Phase Barriers Terminal Shroud 8.8 Bolts & Nuts
1
On Load Changeover Switch
Door Interlock Inter-Phase Barriers Terminal Shroud 8.8 Bolts & Nuts Bridging Bar
2
Automatic Transfer Switch
brings to you, ATS range of True 4Pole motor operated changeover switches
with positive break indication. They enable the on load transfer of two three-phase supplies
via remote volt-free contacts, from either external automatic controllers, using pulse logic
or Push Button Station. They are intended for use in low voltage power systems where
interruption of the load supply is acceptable during transfer.
Handle with
padlock lever
• Automatic transfer switch controller ATL series use to control the automatic
load switching from the MAIN LINE to SECONDARY LINE.
• Programmable automatic or manual control for contactors, motorised
circuit breakers and changeover switch.
• Measurement inputs for three phase + neutral voltage, also suitable for
1 and 2 phase lines.
• Display LED for ATL 10, LCD Graphic Display 128x80 pixel LCD for ATL 600.
• Event log and alarms.
• 6 programmable digital inputs, 7 programmable relay outputs.
• Viewing of L-L and L-N voltage values of the controlled lines.
• Compatible with Synergy software.
ATL DPS1 ATL 500 ATL 600
CONTROL FUNCTIONS OF THE LINES
• Phase sequence and phase loss.
• Minimum and maximum voltage.
• Voltage asymmetry.
• Minimum and maximum frequency.