Professional Documents
Culture Documents
Version 00
Molecular weight 298.54
Quality Test / Release Date 02/20/2018
Molecular Formula C20 H42 O
CAS No 629-96-9
Linear Formula CH3(CH2)19OH
Flash Point (°C) 194
Certificate of Analysis
This is to certify that units of the above mentioned lot number were tested and found to comply with the specifications of the grade listed.
Certain data have been supplied by third parties. Acros Organics expressly disclaims all warranties,expressed or implied, including the
implied warranties of merchantability and fitness for a particular purpose. Unless otherwise stated, these products are not intended for
dialysis, parenteral, or injectable use without further processing. The following are the actual analytical results obtained:
BSE/TSE comment
Chemical Comment
Company
Fisher Scientific Acros Organics
One Reagent Lane One Reagent Lane
Fair Lawn, NJ 07410 Fair Lawn, NJ 07410
Tel: (201) 796-7100
Classification
Classification under 2012 OSHA Hazard Communication Standard (29 CFR 1910.1200)
This chemical is not considered hazardous by the 2012 OSHA Hazard Communication Standard (29 CFR 1910.1200)
Label Elements
None required
______________________________________________________________________________________________
Page 1 / 6
1-Eicosanol Revision Date 19-Jan-2018
______________________________________________________________________________________________
Eye Contact Immediate medical attention is required. Rinse immediately with plenty of water, also under
the eyelids, for at least 15 minutes.
Skin Contact Wash off immediately with soap and plenty of water while removing all contaminated
clothes and shoes. Get medical attention. Take off contaminated clothing and shoes
immediately.
Inhalation Remove from exposure, lie down. Remove to fresh air. If not breathing, give artificial
respiration. Immediate medical attention is required.
Ingestion Never give anything by mouth to an unconscious person. Drink plenty of water. Call a
physician immediately. If possible drink milk afterwards.
Suitable Extinguishing Media Use extinguishing measures that are appropriate to local circumstances and the
surrounding environment.
NFPA
Health Flammability Instability Physical hazards
0 1 0 N/A
Personal Precautions Ensure adequate ventilation. Use personal protective equipment as required.
Environmental Precautions See Section 12 for additional Ecological Information.
Methods for Containment and Clean Sweep up and shovel into suitable containers for disposal.
Up
______________________________________________________________________________________________
Page 2 / 6
1-Eicosanol Revision Date 19-Jan-2018
______________________________________________________________________________________________
Handling Avoid contact with skin and eyes. Avoid contact with skin and clothing. Remove and wash
contaminated clothing and gloves, including the inside, before re-use. Avoid breathing
vapors or mists. Do not ingest. If swallowed then seek immediate medical assistance. Wash
thoroughly after handling.
Exposure Guidelines This product does not contain any hazardous materials with occupational exposure
limitsestablished by the region specific regulatory bodies.
Eye/face Protection Wear appropriate protective eyeglasses or chemical safety goggles as described by
OSHA's eye and face protection regulations in 29 CFR 1910.133 or European Standard
EN166.
Skin and body protection Wear appropriate protective gloves and clothing to prevent skin exposure.
Hygiene Measures Handle in accordance with good industrial hygiene and safety practice.
______________________________________________________________________________________________
Page 3 / 6
1-Eicosanol Revision Date 19-Jan-2018
______________________________________________________________________________________________
Acute Toxicity
Carcinogenicity The table below indicates whether each agency has listed any ingredient as a carcinogen.
Other Adverse Effects The toxicological properties have not been fully investigated.
Ecotoxicity
.
______________________________________________________________________________________________
Page 4 / 6
1-Eicosanol Revision Date 19-Jan-2018
______________________________________________________________________________________________
Mobility Is not likely mobile in the environment due its low water solubility.
Waste Disposal Methods Chemical waste generators must determine whether a discarded chemical is classified as a
hazardous waste. Chemical waste generators must also consult local, regional, and
national hazardous waste regulations to ensure complete and accurate classification.
Legend:
TSCA - Toxic Substances Control Act, (40 CFR Part 710)
X - Listed
'-' - Not Listed
International Inventories
Canada (DSL/NDSL), Europe (EINECS/ELINCS/NLP), Philippines (PICCS), Japan (ENCS), Australia (AICS), China (IECSC), Korea (ECL).
Component CAS-No DSL NDSL EINECS PICCS ENCS AICS IECSC KECL
1-Eicosanol 629-96-9 X - 211-119-4 X X X X KE-13066
California Proposition 65 This product does not contain any Proposition 65 chemicals.
______________________________________________________________________________________________
Page 5 / 6
1-Eicosanol Revision Date 19-Jan-2018
______________________________________________________________________________________________
U.S. Department of Homeland This product does not contain any DHS chemicals.
Security
Disclaimer
The information provided in this Safety Data Sheet is correct to the best of our knowledge, information and belief at the
date of its publication. The information given is designed only as a guidance for safe handling, use, processing, storage,
transportation, disposal and release and is not to be considered a warranty or quality specification. The information
relates only to the specific material designated and may not be valid for such material used in combination with any other
materials or in any process, unless specified in the text
End of SDS
______________________________________________________________________________________________
Page 6 / 6