Professional Documents
Culture Documents
20.12.2020
1. In the current mirror circuit of fig1, both the transistors are matched.
Determine R and the lowest possible Vo. Find the output resistance of the
current source. Also find the change in the output current for a change of
0.5V in the output voltage.
2. Q1 and Q2 are matched transistors in the circuit of fig2. Find the required
value of R and the device dimensions so that the nominal output current,
Io = 200µA, when Vo = VGS. Further it is required that the current source
should operate for Vo in the range of 0.25V to VDD and the change in Io over
this range should be limited to 5% of the nominal Io. Find also the output
impedance of the current source.
3. In the current steering circuit of fig3, determine the widths of all devices,
value of R and the output resistances of current source Q2 and current sink
Q5 for obtaining I2 = 100µA, I3 = I4 = 40µA and I5= 75µA. Further the
current source Q2 should operate properly for voltages at its drain as high as
+1.3V and current sink Q5 for its drain voltage as low as – 1.2V.
RV COLLEGE OF ENGINEERING®, Bengaluru - 59
Department of Electronics & Communication Engineering
3rd Semester- Analog Microelectronic Circuits (18EC33)
Tutorial-3
5. In the circuit of fig5, determine V1, V2, V3, V4, V5 and I for R=30K.
9. In the mirror circuit of fig8, assume BJTs with very high β and VBE = 0.7V
at 1mA. Find the value of R that will result in Io = 1µA. For the above
design, find Ro assuming β = 200 and VA = 50V.
**************