Professional Documents
Culture Documents
2390A Series
Spectrum Analyzers
A range of RF and
Microwave Spectrum
Analyzers that offer value
and performance to both
field and bench users.
Fully synthesized Spectrum sweeps. This gives excellent sensitivity and bandwidth filters. These give the best
Analyzers to 26.5 GHz accuracy right up to 26.5 GHz. available characterization of wideband
signals and have an impulse bandwidth
3 Hz to 30 MHz resolution Narrow Resolution >5 MHz. In zero span mode a minimum
The 2390A series all have resolution sweep time of 200 ns/div makes displaying
bandwidth filters bandwidths down to 3 Hz. Narrow radar pulses precise and straightforward.
Excellent intermodulation resolution bandwidths provide the ability to
resolve closely spaced signals or
performance sidebands.
+30 to -135 dBm measurement
range
Measurements to 300 GHz with
external mixers
Optional built-in tracking generator
Receiver mode with AM and FM
demodulators
Optional quasi-peak detector and
EMC filters 200 ns sweep clearly shows ringing on
demodulated radar pulse
FM spectrum
The 2390A series of spectrum analyzers AM and FM Receiver Modes
from IFR combine exceptional performance The 3 Hz filter is also used for close in The 2390A series features built-in
with excellent value for money. There are signal analysis, for example it can be used receivers for both AM and FM signals.
three instruments in the range:- to identify 50 or 60 Hz power line Modulation detection can be set to
sidebands on oscillators. The average narrowband or wideband mode.
2392A 9 kHz to 2.9 GHz displayed noise level when using a 3 Hz For an FM transmission a modulation
2390A 9 kHz to 22 GHz filter is less than -135 dBm at 2.9 GHz and scale of 1 kHz to 5 MHz per division allows
2393A 9 kHz to 26.5 GHz below -125 dBm at 26.5 GHz. This makes direct measurement of the modulation
2390A series suitable for locating and component of carrier signals up to
Frequency Accuracy identifying low level spurious and harmonic
All three instruments are fully ±20 MHz deviation. Frequency
signals. synthesizer settling time can be measured
synthesized to give accurate frequency
measurements. Even on wide spans the Wideband Filters for Spread Spectrum using the DC coupled output from the FM
2390A series gives precise frequency and Pulsed Signals detector.
measurements and an integral frequency When analyzing signals with wide A high quality audio output through
counter enables the measurement of spectrum bandwidths such as digitally either a built-in speaker or headphone
individual signals to 1 Hz resolution. modulated carriers or pulsed radar, the connector allows audible detection of noise
Fundamental mixing to 12 GHz enables resolution bandwidth of the spectrum or distortion. It can also be used to identify
the microwave versions to reach their analyzer can limit the measurement. The the source of interfering transmissions.
maximum frequency in only two harmonic 2390A series have 10 MHz and 30 MHz
Spectrum Analyzers
<-65 dBm with 5 MHz RBW 3 Hz RBW 300 Hz RBW SPURIOUS RESPONSES
FREQUENCY STANDARD 9 kHz to 100 kHz <-115 dBm <-95 dBm
100 kHz to 2.9 GHz <-135 dBm <-115 dBm Harmonic Distortion
Temperature Stability (0°°C - 50°°C) 2.9 to 12.0 GHz <-130 dBm <-110 dBm <-70 dBc, 9 kHz to 2.9 GHz
±0.2 ppm 12.0 to 26.5 GHz <-125 dBm <-105 dBm (-30 dBm input and 10 dB attenuation)
±0.02 ppm (Option 09) <-100 dBc, 2.9 GHz and 26.5 GHz
GAIN COMPRESSION (-10 dBm input and 10 dB attenuation)
Ageing <1.0 dB with -5 dBm (0 dB attenuation)
First year Third Order Intermodulation Distortion
±2 ppm/year AMPLITUDE UNITS <-80 dBc (-30 dBm input and 10 dB attenuation)
±1 ppm/year (Option 09) Logarithmic display <-75 dBc ( 9 - 12 GHz only)
Thereafter dBm, dBµW, dBmV, dBmV
Linear display Residual Response
±1 ppm/year (input terminated with 50 Ω)
±0.5 ppm/year (Option 09) mW, µW, mV, µV
<-90 dBm, 9 to 100 kHz;
RESIDUAL FM DISPLAY LINEARITY <-100 dBm, 100 kHz to 26.5 GHz
(peak to peak in 20 ms, spans <1 MHz/div, Log Other Input Related Spurious
100 Hz video filter) 5 or 10 dB/div (-30 dBm input and -10 dB attenuation)
<10 Hz, below 6 GHz ±0.15 dB/dB, ≤1.5 dB over 8 divisions <-70 dBc below 18 GHz
<20 Hz, 6 GHz to 12 GHz 1 or 2 dB/div <-60 dBc 18 GHz to 26.5 GHz
<40 Hz, 12 GHz to 26.5 GHz ±0.5 dB over 8 divisions
DISPLAY BANDWIDTH
NOISE SIDEBANDS Linear
(Span <100 kHz/div) Linear mode
10 kHz offset 30 kHz offset <10 MHz RBW >5 MHz (-3 dB), 30 MHz RBW;
0.1 to 1.0 GHz -97 dBc/Hz -101 dBc/Hz ±2% of Reference Level over 8 divisions >2.5 MHz (-3 dB), 5 MHz RBW;
1.0 to 2.8 GHz -92 dBc/Hz -95 dBc/Hz 10 MHz and 30 MHz RBW at <5 µs/div Sweep Time
2.8 to 6.0 GHz -93 dBc/Hz -100 dBc/Hz ±10% of Reference Level over 8 divisions
6.0 to 12.0 GHz -88 dBc/Hz -95 dBc/Hz (<10 dB IF Gain) Log mode
12.0 to 26.5 GHz -81 dBc/Hz -88 dBc/Hz >1 MHz (-3 dB), 5 MHz RBW;
FREQUENCY RESPONSE at <20 µs/div Sweep Time
SYSTEM RELATED SIDEBANDS (with 10 dB attenuation, relative to REF OUT)
(at 300 Hz RBW) ±1.5 dB, 9 kHz to 2.9 GHz Receiver
<-65 dBc below 12 GHz ±2.0 dB, 2.9 GHz to 12 GHz FREQUENCY RANGE
<-60 dBc 12 GHz to 26.5 GHz ±3.0 dB, 12 GHz to 18 GHz 2392A 9 kHz to 2.9 GHz
±4.0 dB, 18 GHz to 26.5 GHz 2390A 9 kHz to 22 GHz
Sweep 2393A 9 kHz to 26.5 GHz
RESOLUTION BANDWIDTH
TIME
Range SENSITIVITY
Span >200 Hz/div 3 Hz, 10 Hz, 30 Hz, 100 Hz (Digital Resolution); 5µV at 100 MHz (30 kHz RBW, 3 kHz Video
1 ms to 10 s/div in 1-2-5 sequence 300 Hz, 3 kHz, 30 kHz, 300 kHz and 5 MHz (at Bandwidth, 5 kHz FM deviation at 1 kHz rate,
3 dB); 10 dB SINAD with 10 dB IF Gain)
Zero Span
200 ns/div to 10s/div in 1-2-5 sequence 10 MHz and 30 MHz (at 3 dB) (Linear display and SELECTIVITY
(Resolution reduced <2 µs/div) FM modes) Available analyzer RBW between 200 Hz and
Option 08 300 MHz
ACCURACY
±1% >1 µs/div Additional 1 kHz and 1 MHz (at 3 dB); DEMODULATION
200 Hz, 9 kHz and 120 kHz (at 6 dB)
TRIGGER SOURCE AM Scales
Internal (Video), External (front panel), External (rear Accuracy 10%, 20 %, 50 %/div
panel) or line (AC input) ±20%, 300 Hz to 30 kHz;
±30%, 300 kHz to 30 MHz; FM Scales
TRIGGER MODE ±10%, 200 Hz, 9 kHz and 120 kHz (in 1-2-5 sequence)
Free Run, Auto Normal or Single 1 kHz to 100 kHz, <10 MHz RBW;
Selectivity 200 kHz to 5 MHz, 10 MHz, 30 MHz RBW
TRIGGER COUPLING 60 dB/3 dB ratio
AC, DC, High-Pass Filter, Low-Pass Filter, TV line, <5:1, 3 kHz, 30 kHz, 300 kHz, 1 MHz, 5 MHz; Memory
TV field <12:1, 1 kHz; TRACE STORAGE CAPACITY
60 dB/6 dB ratio <5:1, 9 kHz and 120 kHz; 99 traces (including user defined traces and test
TRIGGER BANDWIDTH 50 dB/3 dB ratio <10:1, 300 Hz; limits)
>5 MHz @ -3 dB (at EXTERNAL INPUT connector) 50 dB/6 dB ratio <10:1, 200 Hz
RECALL TO DISPLAY AT ONE TIME
TRIGGER LEVEL RANGE Switching Error 4 traces
Video (referenced to 30 kHz RBW)
±0.5 dB, 1 kHz to 5 MHz; SET-UP STORAGE CAPACITY
Adjustable over 8 divisions, positive or negative 99 set-ups
polarity ±1.0 dB, <1 kHz;
±2.0 dB, 10 MHz, 30 MHz; MACRO PROGRAM CAPACITY
Front Panel BNC 64 kbytes
User settable threhold: -2.5 V, -1.0 V, -0.5 V, 0 V, VIDEO BANDWIDTH
+0.5 V, +1.0 V, +2.5 V; nominal Range Oscilloscope
Rear Panel BNC 10 Hz to 1 MHz in decade steps plus NONE INPUT
+2.5 V nominal (no Video Filter activated) Type
TRIGGER SENSITIVITY INPUT ATTENUATOR BNC (f)
Spectrum Analyzers
VAC operation
2393A-220-C 9 kHz to 26.5 GHz Spectrum Analyzer, 220
VAC operation with certificate of calibration
2393AT-110 9 kHz to 26.5 GHz Spectrum Analyzer,
Tracking generator, 110 VAC
2393AT-110-C 9 kHz to 26.5 GHz Spectrum Analyzer,
Tracking generator, 110 VAC, with
certificate of calibration
2393AT-220 9 kHz to 26.5 GHz Spectrum Analyzer,
Tracking generator, 220 VAC
2393AT-220-C 9 kHz to 26.5 GHz Spectrum Analyzer,
Tracking generator, 220 VAC, with
certificate of calibration
2393AP-110 2393A Premium (Tracking generator;
200 Hz, 1, 9, 120 kHz filters; Quasi-peak
Detector, 0.02 ppm high stability time
base) 110 VAC
2393AP-110-C 2393AP-110, Cert. Cal
2393AP-220 2393A Premium (Tracking generator;
200 Hz, 1, 9, 120 kHz filters; Quasi-peak
Detector, 0.02 ppm high stability time
base), 220 VAC
2393AP-220-C 2393AP-220. Cert. Cal
Accessories
AC0100M Near Field Probe Set
AC0410 Maintenance Manual
AC1009M EasySpan (Waveform Transfer Software)
AC 1047 Applications library
AC1600M TMAC Programming Manual
AC2388 1 GHz Active Probe supplied with accessory
power supply
AC4101T Return Loss Bridge (5 MHz to 1 GHz)
AC4103T Return Loss Bridge (5 MHz to 2 GHz)
AC4250 75 Ω Adapter BNC/N
AC4700 Rack Mount Adapter
AC5007 Soft Padded Carrying Case
AC5009 Type SMA PLANAR CROWN Adapter (2393A
only)
AC5010 Type N PLANAR CROWN Adapter (2393A
only)
AC7800 75 Ω Adapter F/N
AC8700 UHF Antenna
5900/327 MI Plot Measurement Presentation
Software.
IFR Americas, Inc., 10200 West York Street, Wichita, Kansas IFR Ltd, Longacres House, Norton Green Road, Stevenage, Herts
67215-8999, USA. E-mail: info@ifrsys.com SG1 2BA, United Kingdom. E-mail: info@ifrinternational.co.uk
Tel: +1 316 522 4981 Toll Free USA: 1 800 835 2352 Fax: +1 316 522 1360 Tel: +44 (0) 1438 742200 Freephone UK: 0800 282 388 Fax: +44 (0) 1438 727601
As we are always seeking to improve our products, the information in this document gives only a general indication of the product capacity, performance and suitability, none of which shall form part of any
contract. We reserve the right to make design changes without notice. All trademarks are acknowledged. Parent Company IFR Systems, Inc. © IFR Ltd. 1998.
http://www.ifrinternational.com
Part no. 46891063
6 2390A Series Revision A