Professional Documents
Culture Documents
Krystaline 1 reacts with un-hydrated cement ensuring that the structure’s waterproofing
particles to grow millions of needle-like barrier is maintained and protected.
crystals deep into the concrete mass. Over a
period of weeks and months, these crystals The concrete itself becomes the waterproof
grow, filling the naturally occurring pores and layer and the surface treatment is not
voids in concrete, and permanently blocking required to remain intact for the system to be
the pathways for water and waterborne effective. Krystaline 1 consists of Portland
contaminants. Later, if cracks form due to cement, specially treated quartz sand and a
settling or shrinkage, incoming water triggers compound of active chemicals. Krystaline 1
the crystallization process and additional is supplied in powder form and needs only to
crystals begin to grow, filling cracks and be mixed with water prior to application.
Typical Applications
KRYSTALINE TECHNOLOGY, S.A. - C/ Alfred Nobel 18, 03203, Elche (Alicante) Spain
TEL: (+34) 966 443 062 - krystalinewaterproofconcrete.com - info@krystaline.co
KRYSTALINE 1
CRYSTALLINE WATERPROOFING MORTAR
Application Guidelines
All concrete to be treated with Krystaline 1 powder to 1 parts water by volume for slurry
must be clean and have an “open” capillary consistency over wet surfaces.
system. Remove laitance, dirt, grease, etc.
by means of high pressure water jetting, wet Slurry Consistency
sandblasting or wire brushing. Apply one or two coats (according to
specification) of Krystaline 1 using a
Surfaces must be carefully pre-watered prior masonry brush or appropriate power spray
to the Krystaline 1 application. Saturate equipment. When two coats are specified,
(remove any free standing water) the apply the second coat whilst the first coat is
concrete surface with clean water prior to still “green”.
application.
Post Treatment - Once the Krystaline 1
Pour water into a clean suitable mixing treatment has reached initial set, moist cure
vessel, then gradually add the Krystaline 1 with a fine mist spray of water 2 - 3 times per
powder into the water while mixing with a low day for three days. In hot or windy conditions
speed paddle mixer until a consistency of it should be cured more frequently.
thick oil paint is obtained. Only mix suitable Alternative methods can be employed such
quantities that can be applied within 20 as covering the application with wet burlap.
minutes and stir mixture frequently. If the During the curing period the Krystaline 1
mixture starts to set, do not remix with treatment must be protected from rainfall,
additional liquid, simply re-stir to restore frost and water puddles.
workability.
Krystaline 1 is an effective waterproofing
Mixing Ratio: Use 5 parts of Krystaline 1 system for rigid concrete structures only and
powder to 2 parts water by volume for slurry may not reliably seal cracks and joints that
consistency. Use 3 parts of Krystaline 1 experience constant or repeated movement.
Coverage Storage
KRYSTALINE TECHNOLOGY, S.A. - C/ Alfred Nobel 18, 03203, Elche (Alicante) Spain
TEL: (+34) 966 443 062 - krystalinewaterproofconcrete.com - info@krystaline.co
KRYSTALINE 1
CRYSTALLINE WATERPROOFING MORTAR
Technical Data
Color Grey
Appearance Powder
Density 1.2 g/cm³
pH (Mixed with water) 13
Crystalline penetration 2.5 cm/month
Compressive strength 34.5 N/mm² (Class R3: ≥25 MPa)
Adhesion strength by pull-off 2,82 MPa (Class R4: ≥2,0 MPa)
Initial set time at 25°C 60 minutes
Depth of penetration (impregnation) ≥5 mm
5:2 (By volume)
Mix ratio (Slurry)
3:1 (Over wet surfaces)
Mix ratio (Dry pack) 4:1 (By volume)
2 0,5
Capillary absorption and permeability to water W < 0,1 kg/(m x h )
Solids content 100%
Disclaimer
Whilst any information and/or specification contained herein is to the best of our knowledge,
true and accurate, we always recommend that a trial be carried out to confirm suitability of
the product, as no warranty is given or implied in connection with any recommendations or
suggestions made by us or our representatives, agents or distributors. The information in this
data sheet is effective from the date shown and supersedes all previous. Please check with
your office to confirm that this is current issue: (January of 2018).
KRYSTALINE TECHNOLOGY, S.A. - C/ Alfred Nobel 18, 03203, Elche (Alicante) Spain
TEL: (+34) 966 443 062 - krystalinewaterproofconcrete.com - info@krystaline.co
KRYSTALINE 1
CRYSTALLINE WATERPROOFING MORTAR
17
1170/CPR/ER.03608
KRYSTALINE 1
Principle 1 (Pl): Protection against ingress
Method 1.2 Impregnation (I)
EN 1504-2
PRODUCTS FOR PROTECTION AND REPAIR OF CONCRETE STRUCTURES.
SURFACE PROTECTION SYSTEMS FOR CONCRETE.
Tables 1 & 4 Impregnation
KRYSTALINE TECHNOLOGY, S.A. - C/ Alfred Nobel 18, 03203, Elche (Alicante) Spain
TEL: (+34) 966 443 062 - krystalinewaterproofconcrete.com - info@krystaline.co