Professional Documents
Culture Documents
protocol?
UDP
TCP
ICMP
OSPF
Which EAPS Shared Port node is responsible for preventing a super loop, should the
common link fail?
Controller node
Master node
Partner node
Transit node
Which of the following EXOS commands shows whether OSPF is enabled on a VLAN?
Which of the following statements is true regarding the EAPS domain priority?
Domains with the highest priority are serviced first during link failure &
recovery
Domains with similar priority are treated equally as soon as an event comes
in
Domains with the lowest priority are serviced first during link failure &
recovery
Domains with similar priority are serviced in control VLAN ID order during link
failure & recovery
Which of the following identifies the address range reserved by the Internet Assigned
Numbers Authority (IANA) for IP Multicast?
224.0.0.0 to 239.255.255.255
224.0.0.0 to 255.255.255.255
239.0.0.0 to 239.255.255.255
255.0.0.0 to 255.255.255.255
Which of the following is true in regards to ELRP? (Select all that apply)
Select the correct EAPS Shared Port configuration steps from the list below. (Select all
that apply)
Which of the following OSPF technologies is used when a new area is created in the AS
that does not have a direct physical interface connected to area 0.0.0.0?
Hello Packets
Link State Advertisements (LSAs)
Virtual Link
Database Overflow
One
Two
Eight
Four
What is the ESP state if the ESP neighbor can be reached through segment health-
checks, and the common link is up?
Idle
Ready
Blocking
Pre-forwarding
display eaps
in order to configure a stacked units slot number, which piece of information is required?
The EXOS command 'use image primary' does which of the following?
Causes the switch to load the primary image file into memory and
immediately execute without a reboot
Causes the switch to load the primary image after next reboot
Causes the switch to clear the current configuration in memory and the
immediately load the primary image
Causes the switch to immediately load the primary image file into memory
and execute on the next reboot
True
False
Which load sharing algorithms can be assigned to a LAG? (Select all that apply)
Address based L1
Address based L2
Address based L4
Port based
Which of the following commands correctly configures the link aggregation feature?
ISC blocking filters are removed when which conditions are true? (Select all that apply)
A switch does not receive three MLAG successive hello packets from its peer
ACLs that are created from a policy file separate from the configuration file
ACLs that are created from a script file separate from the configuration file
ACLs that are configured in the configuration file but not saved
The EXOS port mirroring feature can copy ingress and exgress traffic to which of the
following destinations for network analaysis?
Physical port
VLAN
Remote IP address
All answers apply
In an EXOS switch, in which slice are the default system rules allocated?
Slice 0
Slice 16
Slice 15
The default system rules are allocated randomly
The VRRP router that has the VR's IP address as the real interface address
The VRRP router that has the VR's IP address as the real interface address
What is the EXOS command to only display switch configurations that are different from
the factory defaults?
Which Multiple Spanning Instance is configured on the default STP domain s0?
CIST 0
CIST
MSTI 0
EMISTP
Which of the following stack topologies is recommended for continuous operation?
Bus
Daisy Chain
Ring
Star
Match any
Match all
Match first
Match last
In latest version of ExtremeXOS, how many ECMP gateways can be configured for
OSPF?
4
16
32
64
A broadcast storm
Out-of-sequence packet delivery
ACLs apply to all traffic; both user traffic and control traffic
All of the above
From which port does the Master node transmit EAPS “hello” packets?
o Carry a set of new LSAs one hop further away from their point of origination
Which of the following statements is true regarding the EAPS secondary port on the
Master node?
When an EAPS domain is complete, the master disables the secondary port
in order to prevent a loop
When an EAPS domain is complete, the master blocks the secondary port in
all VLANs in order to prevent a loop
When an EAPS domain is complete, the master blocks the secondary port in
all the Protected VLANs in order to prevent a loop
When an EAPS domain is complete, the master blocks the secondary port in
all the Protected VLANs for that domain in order to prevent a loop