Professional Documents
Culture Documents
Arbeitergasse 25
CYBERITH SDK + HTC Vive Setup
3130 Herzogenburg 1
Holger Hager
Austria
CEO
h.hager@cyberith.com
FN 410899p
Table of Contents
Prerequisites ........................................................................................................................................................... 3
Calibrating the Virtualizer ....................................................................................................................................... 4
Calibrate the Virtualizer with the HTC Vive ............................................................................................................. 4
Steps to follow very carefully .............................................................................................................................. 6
• SteamVR
http://store.steampowered.com/
1. First, install Steam from this website, have a Steam account with an activated HTC Vive serial key.
2. Now, go to the Library, in the “Tools” subsection and install SteamVR from it.
• An HTC Vive
• A Virtualizer
Figure 2 - The Virtualizer surrounded by the two HTC Vive Base Stations
Then, you need to put the HTC Vive HMD at the center of the Virtualizer, directly on the base plate if
you can.
The Vive should be aimed towards the same pillar you calibrate the Virtualizer with (please check
the previous part of this document).
Now, measure the height (in cm) your HTC Vive is above the floor of the Virtualizer.
In my case, the height is approx. 116 cm. It is totally fine if the height is
different in your case.
➢ Use this value for the “Locate the Floor” SteamVR calibration step.
Congratulations!
You’re done with this setup, have fun!