Professional Documents
Culture Documents
1. Generate a data color map that displays areas within +/- 0.06 using green/red for pass/fail.
As it can be seen at the figures above one side of the part failed the inspection. It can result
in the misalignment, while the part is situated at the top of the other one.
As a second method for the linear distances between two points, it was convenient to use
callipers.
3.Define datums and inspect the shown parameters.
Three datum systems were created to fulfil the requirements for controls, for example if a
parameter depended only on A, the Datum A was used and so on.
Flatness of surface A
The value stays within the tolerance zone.