Professional Documents
Culture Documents
TMS370 ICP Users Manual Rev1 3
TMS370 ICP Users Manual Rev1 3
Users Manual
Rev. 1.3
2005.05.11
© 2004 TMT
P/C: 3-001-0002
Revision History
1.1 2004.11.23 Added TMS374 with Am29F010A PLCC ROM target connection
Added TMS374 with M28F256 and M27C256B PLCC ROM target
1.2 2004.11.26
connection
1.3 2005.05.11 Added Magneti Marelli IAW 1AP.80 target connection
1. INTRODUCTION…………………………………….. 4
2. REQUIREMENTS......................................................... 4
3. TARGET CONNECTION............................................ 5
3.1. ICP Interface……….……………………………………. 5
3.2. TMS374 with DIP ROM …………………………………6
3.3. TMS374 with PLCC ROM ……………………………… 7
3.4. TMS374 with Am29F010A PLCC ROM………………... 8
3.5. TMS374 with M28F256 and M27C256 PLCC ROM…… 9
3.6. Magneti Marelli IAW 1AP.80…………………………… 10
2. REQUIREMENTS
The following describes what items are required for TMS374 in-circuit
programming.
• XPROG-m programmer board (P/C: 1-001-0002)
• TMS374 family in-circuit programming adapter (P/C: 1-002-0008)
• Power supply 15Vdc/300mA
• Device Programmer Desktop V4.2 or higher (P/C: 2-001-0001)
• TMS370/TMS374 family authorization (P/C: 2-002-0005)
PC
XPROG-m programmer
(PLCC or DIP)
MCU
TMS374 ICP (TMS374Cxxxx)
ROM
adapter
Power Supply
board
15Vdc/300mA
AD0
AD2
AD4
AD6
Vcc
AD1
AD3
AD5
AD7
GND
Vcc
+5V/100mA
RESET
VppR
SYNC
TMS374
CLK
Oscilator
1 28 Vcc
Vcc
2 27
3 26
4 25
5 24 Connect this pin to Vcc
ROM/EPROM DIP28
6 23
7 22
If this pin connected
OE
8 21 to GND disconnect it !
9 20
10 19 AD7
D7
AD0 11 18 AD6
D0 D6
12 17 AD5
AD1 13
D1 D5
16
AD2 14
D2 D4
15
AD4
GND D3 AD3
GND
RESET
VppR
SYNC
TMS374
CLK
Oscilator
Vcc
to GND disconnect it !
AD7
AD0
AD6
AD1 AD5
AD2 AD4
GND AD3
RESET
VppR
SYNC
TMS374
CLK
Oscilator
Vcc
AD0 AD7
AD1
AD6
AD2
AD5
GND
AD4
AD3
RESET
VppR
SYNC
TMS374
CLK
Oscilator
Vcc
M27C256B
M28F256
AD0 AD7
AD1
AD6
AD2
AD5
GND
AD4
AD3
RESET
VppR
SYNC
TMS374CD13APQQ
CLK
VCC
VCC
M28F512
AD0 AD7
HERMESPLUS
AD1
M
AD6
AD2
AD5
GND AD4
AD3