Professional Documents
Culture Documents
1.2. Relevant identified uses of the substance or mixture and uses advised against
1.2.1. Relevant identified uses
Use of the substance/mixture : Lubricants, greases, release products
GHS08
Signal word (CLP) : Danger
Hazard statements (CLP) : H304 - May be fatal if swallowed and enters airways
H413 - May cause long lasting harmful effects to aquatic life
Precautionary statements (CLP) : P273 - Avoid release to the environment
P301+P310 - IF SWALLOWED: Immediately call a POISON CENTER/doctor/…
P331 - Do NOT induce vomiting
P405 - Store locked up
P501 - Dispose of contents/container to ...
3.2. Mixture
pH : Not applicable
Relative evaporation rate (butyl acetate=1) : No data available
Melting point : No data available
Freezing point : Not applicable
Boiling point : 315 °C
Flash point : 260 °C Cleveland Open Cup
Auto-ignition temperature : No data available
Decomposition temperature : No data available
Flammability (solid, gas) : No data available
Vapour pressure : < 0,01 mm Hg
Relative vapour density at 20 °C : > 5 (Air =1)
Relative density : 0,94 - 0,95 g/cm³
Density : 0,9 @15.6°C
Solubility : Soluble in: hydrocarbons.
Water: Insoluble
Log Pow : No data available
Viscosity, kinematic : 11,8 mm²/s @100°C
Viscosity, dynamic : No data available
Explosive properties : not explosive.
Oxidising properties : not oxidizing.
Explosive limits : 0,9 vol %
7 vol %
9.2. Other information
No additional information available
IMDG
Transport hazard class(es) (IMDG) : Not applicable
IATA
Transport hazard class(es) (IATA) : Not applicable
ADN
Transport hazard class(es) (ADN) : Not applicable
RID
- Overland transport
No data available
- Transport by sea
No data available
- Air transport
No data available
- Rail transport
No data available
14.7. Transport in bulk according to Annex II of MARPOL 73/78 and the IBC Code
Not applicable
Germany
VwVwS Annex reference : Water hazard class (WGK) 1, low hazard to waters (Classification according to VwVwS, Annex
4)
12th Ordinance Implementing the Federal : Is not subject of the 12. BlmSchV (Hazardous Incident Ordinance)
Immission Control Act - 12.BImSchV
Netherlands
SZW-lijst van kankerverwekkende stoffen : None of the components are listed
SZW-lijst van mutagene stoffen : None of the components are listed
NIET-limitatieve lijst van voor de voortplanting : None of the components are listed
giftige stoffen – Borstvoeding
NIET-limitatieve lijst van voor de voortplanting : None of the components are listed
giftige stoffen – Vruchtbaarheid
NIET-limitatieve lijst van voor de voortplanting : None of the components are listed
giftige stoffen – Ontwikkeling
Denmark
Classification remarks : Emergency management guidelines for the storage of flammable liquids must be followed
Recommendations Danish Regulation : Young people below the age of 18 years are not allowed to use the product
Other information : This information is based on our current knowledge and is intended to describe the product for
the purposes of health, safety and environmental requirements only. It should not therefore be
construed as guaranteeing any specific property of the product. It is the user's responsibility to
take the mentioned precautionary measures and to ensure that this information is complete and
sufficient for the use of this product. This SDS was prepared by Intertek. However, the
information is provided without any warranty, expressed or implied regarding its correctness.
Some information presented and conclusions drawn herein are from sources other than direct
test data on the substance itself. This SDS was prepared and is to be used only for this
product. If the product is used as a component in another product, this SDS information may
not be applicable. Users should make their own investigations to determine the suitability of the
information or products for their particular purpose. The conditions or methods of handling,
storage, use, and disposal of the product are beyond our control and may be beyond our
knowledge. For this and other reasons, Intertek does not assume responsibility and expressly
disclaim liability for loss, damage or expense arising out of or in any way connected with
handling, storage, use or disposal of the product.
Full text of H- and EUH-statements:
Aquatic Chronic 3 Hazardous to the aquatic environment — Chronic Hazard, Category 3
Eye Irrit. 2 Serious eye damage/eye irritation, Category 2
Flam. Liq. 3 Flammable liquids, Category 3
Repr. 2 Reproductive toxicity, Category 2
Skin Irrit. 2 Skin corrosion/irritation Category 2
H226 Flammable liquid and vapour
H304 May be fatal if swallowed and enters airways
H315 Causes skin irritation
H319 Causes serious eye irritation
H361 Suspected of damaging fertility or the unborn child
H412 Harmful to aquatic life with long lasting effects
H413 May cause long lasting harmful effects to aquatic life
This information is based on our current knowledge and is intended to describe the product for the purposes of health, safety and environmental requirements only. It should not therefore be
construed as guaranteeing any specific property of the product