Professional Documents
Culture Documents
ZB634KL EE Trouble Shooting Guide
ZB634KL EE Trouble Shooting Guide
1.33 Sub board top vieww:
2, System block diagram:
4lanes
display
4lanes
Front_camera
4lanes
Rear_camera
2lanes 4lanes
Slvecamera 5
Mipi SW SMP SPK
Slvecamera 8
4lanes LDO Audio Jack
2xSIM
SIM1&SIM2 MIC
WIFI/BT
LPDDR3 32bit
Usb 2.0
eMMC
Audio PA
Sensor IC I2C
MB/LB PRX
MB/LB DRX
TP WCN3680
HB PRX
HB DRX
Camera WIFI/BT/FM
GPS
SPI
SPK Audio PA
SPI
Finger
SD Card
WAN RF
3, Main Functions and Characteristics:
Processor QSP 690 (Octacore 1.8GHz)
GSM/GPRS/EDGE; WCDMA/HSPA+/DC‐HSPA+;
Modem
FDD‐LTE/TDD‐LTE(3G,4G Diversity include)
Peak Data Rate DC‐HSPA+ (DL/UL): 42/5.76 Mbps; LTE Others: CAT 6
RF Band Pls see RF band sheet
6.26" FHD IPS notch Panel LED Backlight
Display
Battery Pack & Life 4000 mAh
Memory 32GB+3GB, 64G+4G
Storage Micro SD Card (SD, SDHC) Support (Up to 2TB)
Accelerator
E‐Compass
Proximity
Sensor Fingerprint
Gyroscope (G+G)
Ambient light sensor
Face unlock
WLAN Integrated 802.11 ac/b/g/n; WiFi‐Direct
Bluetooth V 4.2 Dual mode; Bluetooth Profile: V2.1+
Bluetooth
EDR;V3.0+HS;V4.0
FM Radio Support, 87.5‐108MHz with 50KHz step
GPS AGPS, GPS, Glonass.
Micro USB 2.0
Interface
Audio jack: Head phone 3.5mm
Front Camera 8M FF
1.12M AF + 5M(bokeh)+8M(120 degree wide angle) FF
Main Camera
2.12M AF +5M(bokeh) FF
Front Flash: Softlight LED flash
Flash LED
Rear Flash: Single Flash
Microphone Microphone*2
DSDS, Nano SIM, Nano SIM, Micro SD, 3 choose 3 SIM/SD card tray,
SIM
Single SIM for Operator(WW All sku)
OTG Yes
10W adapter(w/Adapter ID), 50/60HZ universal
Charger
With USB thermal
4, PCBA Main IC:
5, Commmon failure analysis:
5.1 Power on prrinciplee and timing:
As shown in
i the figure
f below, as
s long as
a the bbattery is
it is the side
s FPCC and thee side bu
utton fuunction FFail.
4 groups of Mipi Data Lanes and 1 group of Clock Lanes are used
are used to power LCD and TP. LED CABC signal is used to regulate
DOVDD (1.8V) are used to power Camera. SDA, SCL, RESET and
5.4.2 Back 5M
2 groups of Mipi Data Lanes and 1 group of Clock Lanes are used
(1.8V) are used to power Camera. SDA, SCL, RESET, MCLK, SYNC
4 groups of Mipi Data Lanes and 1 group of Clock Lanes are used
(1.8V), VCM (2.8V) are used to power Camera. SDA, SCL, RESET,
5.4.4 Back 8M
4 groups of Mipi Data Lanes and 1 group of Clock Lanes are used
(1.8V) are used to power Camera. SDA, SCL, RESET and MCLK are
abnormal or not.
Note: The SPK spring is on the subboard, please check the main
FPC
5.5.3 Mic is output directly from the module and can measure
main FPC, the mainboard to reach the PMU inside the module,
checking whether the subboard D5, the main board D45, and the
check whether CN10 G12 PIN is abnormal, G12 is low level when
not plugged in, and high level after plugging in. If the phone
is abnormal first.