Professional Documents
Culture Documents
ASSEMBLIES
3 4 1
Ref. Description
1 Frame
2 Countershaft housing
3 Bearing seal
4 O-ring seal
2. A bearing seal must be fitted in the If there is no glue, maintain the bearing seal
groove of the countershaft housing, on with the aid of metal wire twisted at the ends.
the pinion side. This seal suppresses any Cover the seal with grease and proceed as
vibrations between the countershaft explained in paragraph 3. If metal wire is used,
housing and the frame. remove it when the seal is in place in the bore
This seal is split. Fit the seal into the groove of of the frame, see Figure 9-4 (Step 1).
the countershaft housing, on the pinion side,
and glue the two ends together. There should
be no gap between the two ends of the seal.