Professional Documents
Culture Documents
2. Raw Material Bars from which the nuts are made shall be hot-wrought. The material may be further processed by
centerless grinding or by cold drawing.
3. Manufacturing Threading of studs and bolts may be done by machining or rolling. Thread rolling shall be done after heat
treatment.
Threads in nuts shall be machined.
4. Impact Test For ASTM A320 L7 and L7M shall be in accordance with ASTM A320 table 2.
For ASTM A194: Supplementary requirement S3 low temperature requirements shall apply (same
requirements than ASTM A320 L7 and L7M).
5. Chemical For ASTM A320 the chemical requirements shall be in accordance with table 3.
Composition Grade L7M, a minimum carbon content of 0.28 % is permitted provided that the required tensile
properties are met in the section sizes involved; the use of AISI 4130 or 4130H is allowed.
For ASTM A194 the chemical requirements shall be in accordance with table 1.
6. Heat Treatment For ASTM A320 shall comply with item 5.1(Heat Treatment).
The material shall be traceable in accordance with ISO 15156-2/NACE MR0175-2 section 9 and this MDS.
9. NDE All products shall be 100 % visually examined in all areas of threads, shanks and heads. Discontinuities
shall comply with requirements specified in ASTM F788 for bolts/studs and ASTM F812 for nuts.
10. Marking The grade symbol to be marked shall be L7 for Bolt and 7 for nuts.
Each item shall be individually legibly marked.
11. Dimensions Studs and bolts:
− Threading shall be in accordance with ASME B1.1, class 2A fit for diameters 1 in and smaller (UNC series)
and 8 pitch thread series for 1 1/8 in and larger.
MATERIAL DATA SHEET MDS LAS01 Rev.0 v01.
Nuts:
− Nuts shall be ASME heavy HEX-series, double chamfered.
− Nut threads shall be oversized to fit studs/bolts dependent of specified coating.
12. Coating As per specified on section 6.2.8 Bolting of Piping Materials Specification (2500-M380-00S1-0110-001).
13. Certification The material manufacturer shall have a quality system certified in accordance with ISO 9001 and the
system shall have undergone a specific assessment for the relevant materials.
Supplementary requirement S5 shall apply for nuts to A 194.
The material certificate shall be issued in accordance with EN 10204 Type 3.1, and shall include:
• Steel manufacturer of starting material;
• Heat treatment condition and its respective thermal curves.
• Production Testing:
Coating thickness as per ASTM F1137 microscopic exam
Curing Test:
Whitford Test Method 115B (for Xylan 1014)
Whitford Test Method 115C (for Xylar-2)
Adhesion Test:
MATERIAL DATA SHEET MDS LAS01 Rev.0 v01.
Whitford Test Method 132C
Supplier shall provide a certificate of compliance stating that the coated fasteners satisfy the
requirements of this specification as per table 6.3 of 2500-M380-00S1-0110-001.
NOTE: This MDS is derived from ASTM A320-18, ASTM A194-18, NORSOK M-630 MDS X07, IOGP S-563 MDS IX100 and Modec Piping
Materials Specification 2500-M380-00S1-0110-001.