Professional Documents
Culture Documents
1394 Driver Setup W7
1394 Driver Setup W7
FRONTIER WORKFLOW
MANAGEMENT SOFTWARE
1394 Driver Setup & Printer Update
for Windows 7
5 Navigate to the server’s CD drive(X represents the CD drive letter) and open directories to the
following path:
Using an SP2000 film scanner : X¥EZ171¥fmpc W7 drivers¥ez171¥Install¥EZ171
Using an SP3000 film scanner : X¥EZ171¥fmpc W7 drivers¥ez171¥SP3000Install¥EZ171
6 Select the setup.exe file, and click Open.
The filename and path are populated in the Open field of the Run dialog box.
7 Click OK.
8 Click OK.
2
10 The Device Drivers Disk[D-02] dialog box opens.
11 Click OK.
12 Remove the CD from the CD-ROM drive.
The system reboot.
3
Setting the LP5500, LP5700 or LP5900 FireWire Interface IP Address
1 On the Printer Server, select Start > Control Panel
2 Select Network and Internet > View network status and tasks
4
6 Right-click the 「Local Area Connection x IP Over 1394 #2」Connection that is still listed as
connected.(This is the scanner’s FireWire connection.)
7 Select Disabled.
Note: Invalidate both of "Local Area Connection X IP Over 1394#" when you connect
LP1500/2000/2500.
8 Right-click the 「Local Area Connection x IP Over 1394」Connection that is still listed as connected.
A context menu opens.
9 Select Properties.
The 1394 Connection Properties dialog box opens.
5
10 In the Internet Protocol properties section,
select Internet Protocol(TCP/IPv4).
6
Setting Up FireWire Drivers for an LP 1500,2000, or LP 2500 Printer Client Device
Not support
9 Click Regist.
Note:If no error messages appear, the vdentry registration was successful.
10 Click CLOSE.
7
Setting Up FireWire Drivers for an SP1500, SP2000, or SP2500 Film Scanner
Make sure that you follow these procedures exactiy.
1 Ensure that SP1500, SP2000 or SP2500 film scanner is turned off.
2 Complete the scanner installation process.
3 Turn on the SP1500, SP2000 or SP2500 film scanner and wait for it to boot.
8
5 Network Connections window opens.
6 Right-click the [Local Area Connection x IP Over 1394 #2] Connection that is still listed as
connected.(This is the scanner’s FireWire connection.)
9
Printer Firmware Update for an LP5500, LP5700, or LP5900 Printer
6 Navigate to the server’s CD drive(X represents the CD drive letter) and open directories to the
following path:
X¥EZ171¥PrinterUpdateTool¥LP5500-5700-5900¥Firmware downloader
7 Select the install.bat file, and click Open.
The filename and path are populated in the Open field of the Run dialog box.
8 In the Run Dialog, Click the OK button.
•With Cancel button or Close button, cancellation of the update of the firmware is possible.
The “Please wait” message appears and update of the printer firmware stars.
10
10 Click the OK button in the “Printer update finished…” dialog box.
If error message to show as follows is displayed, FMPCIII and Printer restart and then perform Steps
4 to 10.
11
FUJIFILM Corporation
7-3, Akasaka 9-chome, Minato-ku, Tokyo 107-0052, Japan