Professional Documents
Culture Documents
Troubleshooting
561N, 572R and 572R Series II Pipelayers and D10R, D11R, D5M, D5N, D6M, D6N, D6R, D6R
Series II, D7R, D7R Series II and D8R Series II Track-Type Tractors Power Train Electronic
Control System
Media Number -SENR8367-17 Publication Date -01/03/2009 Date Updated -13/03/2009
i01786294
Illustration 1 g00630905
This diagnostic code is recorded when the ECM reads the voltage of the solenoid circuit as above normal
(short to +battery).
Note: Ensure that the diagnostic code for the solenoid is on hold and that the diagnostic code indicator shows
"SERV CODE".
1 of 3 8/21/2020, 11:47 AM
B. Disconnect the machine harness from the solenoid.
D. At machine harness connector J2, measure the resistance from the solenoid signal contact to all possible
sources of +battery. The possible sources of positive voltage are contacts J1-1, J1-4, J1-6, J1-8, J1-10,
J1-11, J1-12, J1-17, J1-18, J1-40, J2-1, J2-2, J2-7, J2-8, J2-13, J2-19, and J2-37.
Expected Result:
Results:
Repair: There is a short in the machine harness. The short is between the contact for the solenoid signal
and the circuit with a low resistance measurement. Repair the machine harness or replace the machine
harness.
Stop.
A. Inspect the contacts and clean the contacts of the harness connectors.
D. Enter service mode of the Caterpillar Monitoring System and clear all inactive diagnostic codes.
F. Stop the machine and place the parking brake switch in the OFF position.
Expected Result:
CID 0689 FMI 03 for the solenoid is present. "SERV CODE" is showing.
Results:
YES - CID 0689 FMI 03 for the solenoid is present. "SERV CODE" is showing.
Repair: Exit this procedure and perform the diagnostic code procedure again. If the problem persists,
the ECM may have failed. Prior to replacing an ECM, always contact your dealership's Technical
Communicator for possible consultation with Caterpillar. This consultation may greatly reduce repair
time. See the Testing and Adjusting, "Electronic Control Module (ECM) - Replace".
Stop.
2 of 3 8/21/2020, 11:47 AM
NO - CID 0689 FMI 03 for the solenoid is not present. "SERV CODE" is not showing.
Repair: The problem does not exist at this time. The initial problem was probably caused by a poor
electrical connection or a short at one of the harness connectors that was disconnected and reconnected.
Resume normal machine operation.
Stop.
Copyright 1993 - 2020 Caterpillar Inc. Fri Aug 21 2020 11:47:36 GMT-0700 (Pacific Daylight Time)
All Rights Reserved.
Private Network For SIS Licensees.
3 of 3 8/21/2020, 11:47 AM