Professional Documents
Culture Documents
Fsaesef
Fsaesef
Is proof of equivalency for your design required for any of the rules?
__Yes. Alternative material was used to that specified in B.3.3.1
__No. Chassis did not deviate from baseline requirements
Baseline Alternative
Design Description and/or
Material Material Rule No. Rule Description
Material Used
Used Used
B3.10 Main Roll Hoop Tubing
B3.11 Front Roll Hoop Tubing
B3.12 Main Roll Hoop Bracing Tubing
B3.13 Front Hoop Bracing – Tube Frames
B3.18 Front Bulkhead – Tube Frames
B3.19 Front Bulkhead Support – Tube Frames
B3.20.6 Impact Attenuator Anti-intrusion Plate
B3.24 Side Impact Systems – Tube Frames
B3.32 Main Hoop Attachment – Monocoque
B3.33 Front Hoop – Monocoque
B3.34 Main Hoop Bracing Attach – Monocoque
B3.33 Front Hoop Bracing – Monocoque
B3.29 Front Bulkhead – Monocoque
B3.30 Front Bulkhead Support – Monocoque
B3.31 Side Impact System – Monocoque
B3.20.3 Impact Attenuator Attach – Monocoque
B5.2.4 Safety Harness Attach – Monocoque
B5.4.1 Shoulder Harness Bar
NOTE: THIS FORM AND THE APPROVED COPY OF THE SUBMISSION MUST BE PRESENTED
AT TECHNICAL INSPECTION AT EVERY FORMULA SAE EVENT ENTERED
© 2010 SAE International. All Rights Reserved. Printed in USA. 2011 Formula SAE Rules
APPENDIX B-1
2011 FSAE™ STRUCTURAL EQUIVALENCY FORM Page 2 of 2
University Name_____________________________Car Number(s) & Event(s)_______________________
Please attach pictures of the frame and/or monocoque below for review during the SEF process. Please label all
tubes to show outer diameter and wall thickness. Three view drawings and isometric views of the structure (CAD,
FEA models, etc) are acceptable. Note: The final decision about all designs will be made at technical inspection.
Approval of an SEF does not guarantee passing Technical Inspection.
© 2010 SAE International. All Rights Reserved. Printed in USA. 2011 Formula SAE Rules