Trim limit switch lead bullet connectors Clean and/or tighten connections 14, 15, loose or corroded. 16 and 17 as necessary. Disconnect trim limit switch leads from trim harness. Connect a continuity meter between leads 16 and 17. Continuity Faulty trim limit switch or leads. should be indicated with drive unit in full IN/DOWN position. If not, check for damaged leads or poor connections. If this is not the cause, replace limit switch. Check for a loose or corroded OUT/UP circuit connection, damaged OUT/UP Open trim control OUT/UP circuit. circuit lead or faulty OUT/UP trim switch. Repair or replace as necessary.
Trim Control Trailer Switch Inoperative
TRIM OUT/UP SWITCH FUNCTIONS
Cause Special Instructions
Check for a faulty trailer switch, loose or Open trim control trailer circuit. corroded connections or damaged trailer circuit lead.
Trim System Functions While Unattended
Cause Special Instructions Faulty trim or trailer switch. Replace switch. Shorted trim pump harness or trim control Repair or replace as required. harness.