MYCRETE WPA Acrylic Polymer for Cementitious Waterproofing
PRODUCT DATA SHEET
Introduction Surface preparation: The surface of application must be myCrete WPA is a water-borne styrene acrylic clean, smooth and sound. Concrete surface should be free copolymer based waterproofing product which can be from dust, laitance, oil, debris, loose concrete etc. presence used for durable waterproofing of terrace, balcony, of which results in poor bonding between concrete surface bathroom, podium, chajja, basement, retaining wall, and waterproofing membrane. water tanks etc. The time tested chemistry of the Grind the concrete surface to obtain a smooth and sound polymer, ease of application and cost-effectiveness surface. Surface dust must be removed using vacuum/ air makes myCrete WPA a go-to product for the blower followed by washing/ moping. Steel surface (if any) waterproofing of commercial and residential projects. should be free from rust and oil. Perform patch work using polymer modified cement mortar (CM 1:1) admixed with Application area MYCRETE DexTR 5-10 % of the cement content. ● Terrace, balcony, chhaja etc Priming: Prepare primer by mixing volumetrically ● Podium level slab MYCRETE WPA, water and OPC 53 Grade in the ratio 1:1:2 ● Basement from positive side respectively. Apply the primer coat using a short, stiff ● Wet area like bathroom, toilet etc bristle brush. Allow it to dry for 24 hours before ● Potable water tank proceeding further. Waterproofing membrane application: Prepare Key features membrane mix by mixing volumetrically MYCRETE WPA ● Water based system. No harmful volatile content. and OPC 53 Grade in the ratio 1:1. Use a hand held low RPM Safe to apply in confined places stirrer to obtain lump free consistent slurry. Do not mix ● Optimum workable time. Easy to apply with good more material than which can be used within the pot life. workmanship Do not retemper the mix with water. Occasionally stir the ● Excellent bonding with concrete and common entire mix to avoid settling of solids at the bottom of the masonry surfaces container. Apply the mix using brush/ roller and gently ● Long term crack bridging ability of 2 mm place reinforcing non woven fabric 45-100 GSM. Saturate ● Resistant to ingress of water even under 7 bar the fabric using a serrated roller, brush/ roller and hydrostatic pressure additional mix such that it is well-placed onto the substrate, leaving no air pocket or loose part. Allow the membrane to cure for 24 hours before Properties proceeding further. Pond test should be done after at least Solid Content 44-46 % three days of air curing under normal sunny environment. o Pot life at 30 C 30 minutes Touch to dry time 2-3 hours Coverage: 1-1.2 Kg/ Sq.m. Recoat time 24 hours Practical consumption will vary depending upon the
Full cure time 7 days surface condition
Application Methodology Packaging: 10 Kg and 20 Kg HDPE container
Health and Safety
Preparatory steps: Make sure plumbing line, pipe Wear safety goggle and hand gloves while handling. fittings, core-cut pipe penetrations, sanitary fitting, brick work etc are done before proceeding for MYCRETE WPA is a non-toxic and non-flammable product. waterproofing. Once a waterproofing job is completed, breaking or damaging the waterproofing layer, Storage protective screed/ plaster layer generally leads to poor Store in the original container with lid closed under normal performance. warehouse condition. Shelf life is 12 months from date of
manufacture.
Mistry Construction Chemistry
Office No.1-2, Sneha Niwas, S N 119, M N 572A/P, Bhukum, Paud Road, Pune, Maharashta - 412115