Professional Documents
Culture Documents
Forma 049 - Tarjetas Inspección Semanal Aw119
Forma 049 - Tarjetas Inspección Semanal Aw119
22
ESCUADRÓN DE MANTENIMIENTO
SISTEMAS AERONÁUTICOS No. 2222
WHEEKLY INSPECTION
HELICOPTER WASHING
CPCP CAP 20 SECTION 20-90-00
WO……………………..……………….
INSPECCIÓN SEMANAL
2-5.Cleaning procedure – General
A. Preparing helicopter for cleaning.
1) Cover static vents, pitot tubes, air ducts, heater ducts, etc., to prevent
entrance of cleaning solution.
3) Mask as necessary.
B. Cleaning.
4) Wipe off spilled oil, grease, hydraulic fluid, etc., with a solvent.
5) Apply the cleaning solution by hand or spray. Use sponges, soft brushes, or
cloths to loosen soils.
CAUTION: DO NOT USE HIGH PRESSURE SPRAYS. DO NOT FLUSH LUBRICANTS FROM BEARINGS
NOTE: Work small areas to prevent the cleaning solution from drying on the surface. It is usually advanta geous to
start at the lower surfaces and work outward and upward.
6) Rinse away loosened soil and cleaner residue with a stream of water. Check
for residue by lightly wiping with a cloth. Reclean and rinse as needed to
eliminate residue.
7) Follow the cleaning with an overall rinse.
8) Dry.
WHEEKLY INSPECTION
HELICOPTER WASHING
CPCP CAP 20 SECTION 20-90-00
D. Baggage compartment.
20) Wipe with a solvent to remove oily soils.
24) When known spills have occurred, local clean-up procedures include wiping
up spills with swabs. The affected area should be scrubbed with soap and
water and wiped dry with swabs. Use scrub water sparingly to avoid
WHEEKLY INSPECTION
HELICOPTER WASHING
CPCP CAP 20 SECTION 20-90-00
29) Remove debris (salt, sand, etc.) from seats and floor by brushing or with a
vacuum cleaner.
NOTE:Pay special attention to the area around fastener heads, along bulkheads, and in corners.
30) Wash seats, floor, and adjacent areas with detergent and water. Areas
covered with permanently installed interior covering should be cleaned with
a soft brush and damp cloth. Do not wet areas that cannot be completely
dried.
31) Rinse. Check for residue, reclean, and rinse as needed.
32) Dry
33) When known spills have occurred, local clean-up procedures include wiping
up spills with swabs. The affected area should be scrubbed with soap and
water and wiped dry with swabs. Use scrub water sparingly to avoid
spreading the spilled fluids or soaking through the floors.
34) Carpets soaked with spills should be removed for cleaning.
35) Clean spills on seat tracks per step (7).
WHEEKLY INSPECTION
HELICOPTER WASHING
CPCP CAP 20 SECTION 20-90-00
—Behind cowlings.
37) Clean the area to be treated with a solvent to remove oil and grease residue.
38) Remove debris, soil, and other contaminants by washing with detergent and
water (MIL-C-43616).
39) Allow to dry or wipe dry.
CAUTION: ISOPROPYL ALCOHOL (99%) IS FLAMMABLE. ISOPROPYL ALCOHOL (99%) SHOULD NOT BE
INGESTED AND INHALATION OF LARGE QUANTITIES OF VAPOR SHOULD BE AVOIDED. (THIS
IS RUBBING ALCOHOL AND INCIDENTAL SKIN CONTACTIS NOT A PROBLEM.)
40) Treat the fungus by wiping or spraying with isopropyl alcohol (99%).
NOTE: 99% isopropyl alcohol may soften some plastics. (70% may be used on plastics but the 99% should not be
used on polycarbonateor acrylic plastics.) Alcohols may remove lubricants and preservatives.
44) Dry.
WHEEKLY INSPECTION
HELICOPTER WASHING
CPCP CAP 20 SECTION 20-90-00
FIRMA: _______________________________