Professional Documents
Culture Documents
Topology Diagram
Addressing Table
Page 1 of 3
Basic Frame Relay
Bước 1: Thực hiện kết nối mạng như sơ đồ trên (Cable a network that is similar to the one in the
topology diagram. )
You can use any current router in your lab as long as it has the required interfaces shown in the
topology.
Note: If you use 1700, 2500, or 2600 routers, the router output and interface descriptions appear
differently.
Bước 2: Điền địa chỉ IP của các interface vào bảng Addressing Table trên
Bước 3: Tiến hành cấu hình địa chỉ cho các interface
Nhiệm vụ 2: Thực hiện các cấu hình Router cơ bản (Perform Basic Router configuration)
Sử dụng OSPF
R2:
R2#show frame-relay pvc
Page 2 of 3
Basic Frame Relay
LMI is a keepalive mechanism that provides status information about Frame Relay connections
between the router (DTE) and the Frame Relay switch (DCE)
What are the three different types of LMI?
Cisco, ANSI Annex D, and Q933-A Annex A and that the default LMI type for Cisco routers is
cisco.
What DLCI does the Cisco LMI operate on?
Issue the debug frame-relay lmi command. The output gives detailed information on all LMI
data. Keepalives are sent every 10 seconds, so you may have to wait until you see any output.
The debug output shows two LMI packets: the first outgoing, the second incoming.
R1#debug frame-relay lmi
R1#undebug all
Page 3 of 3