Professional Documents
Culture Documents
Fire Protection Mid Sem
Fire Protection Mid Sem
Question 1
"In a nozzle, the reaction R if dependent on "
Pressure head
Dia of nozzles
Pipeline pressure
Nozzle pressure
Question 2
Volate drop is allowed approximately upto
30%
25%
20%
15%
Question 3
Electrical panel fire can be extinguished by
Water
All
DCP
CO2
Question 4
When the flow of water through a long run of metal pipe is stopped very quickly by the rapid closing of a
tap. The consequent metallic 'clunk' which may be heard is the consequence of
None
Water Hammer
Nozzle effect
Water Jet
Question 5
"For water mist system, which type of pumps are more suitable"
Postive Discplacement Pump
Suction pump
Vertical turbine pump
All
Question 6
A pump shall be appropriate for
for carrying water fluid
work if there is a head differences
None
viscosity of the pump
Question 7
The--------------shall be of the overhung impeller design and the impeller between bearings design
Centrifugal Pump
Check Valve
Negative Displacement Pump
All
Question 8
"Variable speed pumps shall be tested at minimum, rated, and peak loads, with the fire pump operating
at rated speed."
True
False
Question 9
"As the kinetic energy of the water is small, both on entering and leaving the pump, the newly acquired
energy is almost entirely in the form of pressure."
True
False
Question 10
"A pump is required to deliver 2700 l/min at 10 bar. Assuming an efficiency of 65%, calculate the brake
power required to drive it."
65 KW
68 KW
69 KW
60 KW
Question 11
"In a jet flow, flow rate is dependent of diameter of nozzles"
True
False
Question 12
A pump pressure of 5 bar is required to operate a branch when it is working at ground level. If the branch
is raised to a height of 25m above the ground what must be the pump pressure in order to maintain the
same output?
5 Bar
6.5 Bar
7 .5 Bar
6 Bar
Question 13
"In the formula P= Hpg , H is "
None
Depth of the liquid
Head of liquid
10*P
Question 14
Normal source of power required for electrical driven pumps shall be arranged in accordance with
Service connection dedicated to the fire pump installation
On-site power production facility connection dedicated to the fire pump installation
None
Dedicated feeder connection derived directly from the dedicated service to the fire pump
installation
Question 15
"The floor or surface around the pump and engine shall be pitched for adequate drainage of escaping
water away from critical equipment, such as pump, engine, controller, fuel tank, and so forth is the
requirements of "
Pump Room
Pumps
Fire Room
All
Question 16
Water power is dependent of
Head
Pressure
All
flow rate
Question 17
A flow rate in 50mm and 45 mm dia hose is 400 lpm. What is the loss of pressure in the hose if the
frictional factor is 0.005 ?
2 Bar
None
1 Bar
0.5 Bar
Question 18
Atmospheric pressure is equals to 1.013 bar
True
False
Question 19
Each discharge outlet in a multistage multiport pump shall furnish not less than 150 percent of rated
capacity at not less than 65 percent of total rated head
True
False
Question 20
"In a jet flow, velocity of jet (v) is inversely propotional to Pressure (p)"
True
False
Question 21
The------ shall not be used where a static suction lift is required
Negative Displacement Pump
Check Valve
Centrifugal Pump
All
Question 22
Pumps shall furnish not less than 150 percent of rated capacity at not less than 65 percent of total rated
head.
True
False
Question 23
Pressure (P) is directly proportional to a quantity called the friction factor (t) for the hose
True
False
Question 24
Calculate the flowrate from a 15mm type A nozzle when working at a pressure of 4 bar
210 lpm
395 lpm
200 lpm
300 lpm
Question 25
"In a jet flow, velocity of jet (v) is propotional to under root of Pressure (p)"
True
False
Question 26
Pressure losses in a pipe will be inversely propotional to d5
True
False
Question 27
"This type of gauge depends for its operating principle on the movement of a corrugated metal circular
diaphragm, which is secured at its periphery but free to move at its centre."
Gate Valve
Diaphram Gauge
All
Bourdan tube gauge
Question 28
Frictional factor depends on
Distance of relay
None
Internal surface finish
Diameter of hoses
Question 29
Submergence related to
Hose
Hydrant
Nizzle
Pumps
Question 30
A static water pressure of 6 bar is required at a certain point from a supply to be obtained from an
elevated reservoir. At what vertical height above this point must the water surface be?
None
60 m
50 m
68 m
Question 31
The discharge pressure of the pump shall exceed the maximum water pressure under any operating
condition at the point of foam concentrate injection.
True
False
Question 32
Form of energies used in hydraulics are
Potential Energy
Kinetic Energy
Pressure
Heat
Question 33
What is the difference between the reaction of the water leaving a 25mm nozzle as compared with a
12.5mm nozzle if the pressure in both cases is 7 bar?
500 N
510 N
None
515 N
Question 34
When water flows through a hose or pipe there is a gradual loss of pressure resulting from the need to
overcome the frictional resistance which exists between the moving water stream and the internal
surface of the hose or pipe.
True
False
Question 35
"Calculate the water power of a portable pump which, at full power, delivers 1600 l/min when increasing
the pressure by 9 bar."
18 KW
None
20 KW
24 KW
Question 36
The distance between the bottom of the strainer and the bottom of the wet pit shall be at least one-half
of the pump bowl diameter but not less than 12 in.
True
False
Question 37
Pressure of a liquid contained in an open vessel is proportional to the
Depth of the liquid
Density
Amount
All
Question 38
The ---------- is the difference between the true (absolute) pressure being measured and atmospheric
pressure
Net Pressure
Gauge Pressure
Head
All
Question 39
Water hammer is related
All
Nozzles
Water in pipelines
Water Stream
Question 40
"Before a centrifugal pump can be got to work from open water, the air in the suction hose and pump
casing must be expelled so that atmospheric pressure will force the water up into the pump. This process
is called "
Jet
None
Hammer
Priming
Question 41
Alternate power source is required for
All
AC system
Water supply during fire fighting
Pumps
Question 42
The water level of a tank in a sprinkler installation is 40 metres above a pressure gauge. What pressure in
bar should register on the gauge?
5 Bar
6.2 Bar
3 Bar
4 Bar
Question 43
Pressure (P) is inversely proportional to the length (l) of hose through which the water flows
True
False
Question 44
The dump valve shall not operate only for the duration necessary for the positive displacement pump to
achieve operating speed.
True
False
Question 45
Choose the correct statement about pump room ventilation
To store any hazardous vapours
To supply air for engine combustion
To supply and exhaust air as necessary for radiator cooling of the engine when required
To control the maximum temperature to 120°F (49°C) at the combustion air cleaner inlet with
engine running at rated load
Question 46
The ----------pumps shall meet the requirements for foam concentrate pumps
Vertical head pumps
Additive Pumps
All
Postive Discplacement Pump
Question 47
When water passes through a pump its total energy is decreased because energy is supplied from an
external source.
True
False
Question 48
"In case of -------, the total shutoff head shall not exceed 140 percent of the total rated head "
Vertical turbine pump
None
Jockey pump
Centrifugal Pump
Question 49
The fire pump alarm shall actuate whenever any phase at the line terminals of the motor contactor is
lost.
True
False
Question 50
Basics of hyraulics is----
To understand the behaviour of water in relation to the operation of fire service equipment
To make informed decisions concerning the supply and delivery of water in the dynamic arena of
the fireground
None
Can't be an effective arrangements for the provision of water supplies at the pre-planning stage