Professional Documents
Culture Documents
❏ 2774.018W Whirlpool
• Acrylic with fiberglass reinforcement
• Pre-leveled tub bottom
• Form-fitted backrest
• Molded-in armrests with elbow supports
• Dual accessory deck area
• Single speed pump/motor
• Factory installed power cord with plug
• Eight-jet system featuring:
- Two multi-directional and flow adjustable
Acumax™ high output jets
- Six multi-directional and flow adjustable
Acumax body massage jets including two
in the lumbar area
• Side-mounted air switch On/Off
• Two silent air volume controls
• Quick Connect Safe-T-Heater
connection system
American Standard whirlpools and air baths with * NOTE: the Safe-T-Heater is designed to maintain water
EverClean® incorporate a safe and effective temperature during operation. It will not heat cold water to
silver-ion antimicrobial additive right into the desired bathing temperature.
circulation piping to protect the pipes from mold,
mildew, algae and fungus that could cause ** NOTE: Deep Soak Bath Drain provides an additional 2" of
water depth for a more luxurious bath.
deterioration or staining of the pipes.
H73
© 2011 AS America Inc. Revised 5/11
CADET® 6' x 42"
WHIRLPOOL AND BATHING POOL
HIGH GLOSS
9"(229 mm)
9"(229 mm)
42" 42"
(1067mm) CUTOUT IN FLOOR PUMP (1067mm) CUTOUT IN FLOOR
21" FOR DRAIN 21" FOR DRAIN
(533mm) (533mm)
2-1/4" (2) AIR VALVES OUTLINE OF CUTOUT C/L OF 2-1/4" OUTLINE OF CUTOUT
(57mm) (8) JETS 70-1/2" X 40-1/2" SUPPLIES (57mm) ALT. FITTING 70-1/4" X 40-1/4"
ALT. FITTING (1791 x 1029mm)
C/L OF DRAIN LOCATION #1 LOCATION (1784 x 1022mm)
C/L OF DRAIN C/L OF
C/L OF SHOWER ARM
SHOWER ARM
OPTIONAL TO OPTIONAL TO
FINISHED FLOOR FINISHED FLOOR
USUALLY BETWEEN USUALLY BETWEEN C/L OF
C/L OF VALVES
65 " & 78 " VALVES 65" & 78"
(1651 & 1981mm ) (1651 & 1981mm )
SAFE-T-HEATER C/L OF
REMOVABLE C/L OF
C/L OF C/L OF BLANK OVERFLOW 12"
12" 1-1/2" SPOUT
OVERFLOW SPOUT (305mm)
1-1/2" (305mm) (38mm)
(38mm) 3-1/2" 4" LEVELING STRINGER
4" LEVELING
3-1/2" STRINGER (89mm) (102mm) NOT FOR SUPPORT
(89mm) (102mm) NOT FOR
SUPPORT
19-3/4"
19-3/4" (502mm) 18-1/4"
(502mm) 18-1/4" (464mm)
(464mm) ROUGH
ROUGH FLOOR
FLOOR
NOTES:
BATH CAN BE INSTALLED EITHER ABOVE OR BELOW FLOOR LINE AS PIER, ISLAND, OR PENINSULA TYPE INSTALLATION. SUMP OF
BATH IS SUPPORTED BY INTEGRAL FEET. NO ADDITIONAL SUPPORT REQUIRED. ENCLOSING MATERIAL BY OTHERS.
IMPORTANT: Dimensions of fixtures are nominal and may vary within the range of tolerances established by ANSI Standard Z124.1
These measurements are subject to change or cancellation. No responsibility is assumed for use of superseded or voided leaflet.
H74
© 2011 AS America Inc. Revised 5/11