Professional Documents
Culture Documents
elements
HAZARD OF ELECTRIC SHOCK, EXPLOSION, OR
ARC FLASH
SpaceLogic KNX Switch actuator A Voltage may be present at the outputs when the mains
REG-K/4x230/16 with manual mode voltage is connected to the system.
F
L L 1 L L 2 L L 3 L 4
16 A 16 A 16 A
3
4
3 4
7 Connect the mains voltage.
Now you can check the functionality of the actuator and
The device may be damaged! the connected loads without having to load the
- Only operate the device according to the specifica- application from the ETS. (See the "Operating the
tions stated in the Technical data. actuator" section.)
- All devices that are installed next to the actuator must
be equipped with at least basic insulation
Failure to follow these instruction can result in Putting the actuator into operation
equipment damage.
¼
WARNING 1 Press the programming button.
Getting to know the switch actuator Risk of fatal injury from electrical current. The The programming LED lights up.
device could become damaged. 2 Load the physical address and application into the
The switch actuator REG-K/4x230/16 with manual mode Safety clearance must be guaranteed in device from the ETS.
(referred to below as the actuator) can switch four accordance with IEC 60664-1. There must be at
The programming LED goes out.
loads via separate, floating make contacts. least 4 mm between the individual cores of the
230 V supply cable and the KNX line. The operating LED lights up: The application was loaded
You can also manually switch the connected loads with successfully, the device is ready for operation.
manual switches on the actuator without bus voltage. 230 V
The actuator has a bus coupler. It is installed on a DIN
rail, with the bus connection made via a bus connecting 4 mm
KNX
Operating the actuator
terminal. It is supplied with power from the bus voltage.
A data rail is not required. Normally, you control connected devices using push-
buttons or by remote control. However, you can
manually switch each of the actuator's channels on and
V6475-563-01 02/22
V6475-563-01 02/22