You are on page 1of 18

NO.

HL-EN-V90N-DP 12/2021 01 /18

V90N-DP SERIES (Original HP3V-D Series)


Swash-plate Type Axial Piston V90N-DP variable axial piston
Variable Displacement Double Pump double pump is designed for the
high pressure open circuit.

Displacement (cc/rev): 180×2 214×2 230×2 252×2


Nominal pressure (bar): 380 350 350 350
Max. pressure (bar): 420 392 392 392

Contents Features
Technical Data 02 • Variable axial piston double pump design for the open circuit.

Type introduction 03-04 • Various controllers available: hydraulic and electrical control
design available, which can combined the different controllers
V90N 180DP type
of flow control, electric proportional control and power control.
• Control principle 05-06 • High efficiency, High working pressure ( 380 bar ) and long lifetime.
• Installation size 07-08 • Compact design with PTO Power port drive for connecting
V90N 212DP/230DP type different auxiliary pumps.

• Control principle 09-10 • Special pump housing structure design meets the low noise
requirements.
• Installation size 11-12
• More suitable for mobile machinery like excavators, cranes,
V90N 252DP type drilling rigs and so on.
• Control principle 13-14
• Installation size 15-16

093
02 /18 Hengli hydraulic Piston Pump | V90N-DP Series

Technical data

Size V90N 180DP V90N 212DP V90N 230DP V90N 252DP

Displacement(cc/rev) 180×2 214×2 230×2 252×2

Rated speed (rpm)*1 2000 1800 1800 1800


Speed
Maximum speed (rpm) *2
2400 2000 2000 2000

Rated pressure (bar) 380 350 350 350


Pressure
Maximum pressure (bar) 420 392 392 392

Maximum torque (N.m) 1200 1500 1800 2100

Case volume (L) 10

Suction port pressure (abs bar) 0.7 ~ 2

Drain pressure (bar) 1

Max. drain pressure (bar) 3


05 Mass (Kg) 262 270 270 320

Temperature range (℃ ) -20 ~ 95


10 ~ 1000*3
Hydraulic fluid viscosity range (mm2/s)
(optimum viscosity range 16 ~ 36)

1 Steady state suction pressure should be 0 bar and above (at normal condition);
2 If suction pressure less than 0 bar, Boost pressure should be required;
3 In case of 200-1000mm2/s, please allow system to warm up before using machine.

094
Piston Pump | V90N-DP Series Hengli hydraulic 03 /18

Type introduction

V90N 230 DP O R E1 / C2 S3 N PA1 M M


① ② ③ ④ ⑤ ⑥ ⑦ ⑧ ⑨ ⑩ ⑪ ⑫

Product series
① Product series V90N

Displacement
② Displacement cc/rev 180 212 230 252

Structure type
180 212 230 252 Code

Parallel construction double pump ● ● ● ● DP

05
Charge pump (impeller)
180 212 230 252 Code
④ with charge pump ● ● ● H
without charge pump ● O

Direction rotation
180 212 230 252 Code
⑤ Clockwise ● ● ● ● R
Counter-clockwise L

Control type
180 212 230 252 Code
Electric
Pilot-operated electro-proportional displacement
proportional ● ● ● ● E1
control, positive displacement control, 24V
displacement
Hydraulic pilot negative flow
⑥ + Proportional increasing power control ● ● ● ● H1
+ (total power control)
Negative
Hydraulic pilot negative flow
displacement
+ Proportional deceasing power control ● ● ● ● H2
control + (total power control)
Hydraulic pilot negative flow
○ ○ ○ ○ H3
+divided power control

Mounting flange
Mounting flange 180 212 230 252 Code
SAE C 127-2 C2
SAE J617 NO.1 flywheel flange ● ● ● ● F1

SAE J617 NO.2 flywheel flange F2
SAE J617 NO.3 flywheel flange F3
Special 4-hole flange G4

095
04 /18 Hengli hydraulic Piston Pump | V90N-DP Series

Type introduction

Input shaft
Input shaft size 180 212 230 252 Code
SAE J744-32-4 14T 12/24DP S3
JIS D2001 34.5×12×2.5 J3

JIS D2001 40×14×2.5 J4
JIS B1603 18×3×20 J6
ANSI B92.1-1996 17T 8/16DP ● ● ● ● S7
JIS D2001 60×18×3 ● S8

Through drive
180 212 230 252 Code
None ● ● ● ● N
SAE A 82-2 SAE J744-16-4 9T 16/32DP ○ ○ ○ A1

05 SAE A 82-2 SAE J744-19-4 11T 16/32DP ○ ○ ○ A2
SAE B 101-2 SAE J744-22-4 13T 16/32DP ● ● ● ● B1
SAE B 101-2 SAE J744-25-4 15T 16/32DP ● ● ● ● B2

PTO Power port drive


180 212 230 252 Code
None ● ● ● N
⑩ SAE A 82-2 SAE J744-16-4 9T 16/32DP PA1
SAE B 101-2 SAE J744 15T 16/32DP PB1
SAE C 127-2 SAE J744-J744-32-4 14T 12/24DP ● ● ● ● PC1

Connection type (except inlet and outlet port)


180 212 230 252 Code
UNC port, ISO11926 ○ ○ ○ A

Metric port, ISO 6149 ○ ○ ○ M
BSPP G thread, JIS B2351 ● ● ● ● G

Thread type of Flange Port


180 212 230 252 Code
⑫ UNC threads (only for UNC port) A
Metric thread ● ● ● ● M

Note: Marked with " ○ " means under development.

096
Piston Pump | V90N-DP Series Hengli hydraulic 05 /18

V90N 180DP Control principle

·E1 Electro-proportional displacement control principle

Electro-proportional displacement control: With pilot-pressure-related control, the pump displacement


is adjusted in proportion to the pilot pressure. Basic position without pilot signal is Vg min, which
includes the mechanically depressurized basic position Vgmin. With increasing pilot pressure the pump
swivels to a larger displacement. The necessary control power is taken from the operating pressure or
the external control pressure applied to port P. If the pump is to be adjusted from the zero basic setting
or from a low operating pressure, port P must be supplied with an external control pressure of at least 30
bar, maximum 50 bar.
A1 A2

a4 a5
Pi1 a1 a2 Pi2

a7 a6

05

Ps2
D1
Dr1
B1
Ps1 D0 Dr2

A3 a3

Note:
·H1 Negative flow control schematic When ordering, please provide
the information as below:
A1 Psv a3 A2 ·Working pressure
·Maximum flow
·Minimum flow

a1 a2

Pi1 Pi2
D1

Dr1
B1
D0 Dr3

A3 a3

097
06 /18 Hengli hydraulic Piston Pump | V90N-DP Series

V90N 180DP Control principle

·H2 Negative flow control schematic

A1 Psv a3 A2

a1 a2

05 Pi1 Pi2
D1

Dr1
B1
D0 Dr3

A3 a3
Note:
·H3 Negative flow control schematic When ordering, please provide
the information as below:
·Working pressure
A1 A2 ·Maximum flow
·Minimum flow
a4 a5
a1 a2

PA1 G1 G2 PA2

Pi1 Pi2

Ps2
D1
Dr1
B1
Ps1 D0 Dr2

A3 a6

098
Piston Pump | V90N-DP Series Hengli hydraulic 07 /18

Installation size

V90N 180DP type

143
532(A3) 113(D1) 10×Ø13.5 through
401(A1、A2) 73.5(Dr1) 3)
(Dr Recommend
41.5 3)
233(D1) (a Tighting Torque:98N.m
10.5
3) 15° For M12 Of Strength
49 138(Dr1) M12 37(A 12
×
30 Class 10.9 Of JIS
°
eye bolt 2
0.

77(a
±
12 30
.2

3)
71(D
Ø5

49.5
301(a2)
280.5(Dr1)

r3)
243.5(D1)

(A3)

20°
28.5
48

114(Pi2、a4)
141(a1)121.5(A2)

46(Pi1)60.3(Pi1sv)
38.5(A1)

160
Ø511.2 -0.135
-0.232

2×M12 depth 22
Ø555-0.2
0

0.2
Ø116

Ø146±

79±0.5
05
(Length of spline)
17T-8/16DP
DEUTSCH CON.DT04-2P
ANSI B92.1b

R6.7
5
2×13.5
M12
5 17 eye bolt 146.5(Psv) 145
149(a4)
272(Pi1、Pi2)

189(Pi1、Pi2)
Qmax.
adjusting screw Qmin.
adjusting screw
206(A1、A2)
Ø24.981 -0.127
0

Ø31.9

+0.05
+0.03

+0.1
Ø101.6

0
Ø110

135(B1)

2.4±0.05
137.5(D0)

35(a1、a2)

9
13
273(D0)
378(a1、a2)
422(B1)
553

099
08 /18 Hengli hydraulic Piston Pump | V90N-DP Series

Installation size
油口说明
·V90N 180DP Description of oil port

(422)
from front casing
Φ32 Φ32

B1
Φ102

77.77±0.2
A1 A2
66.7

66.7

31.8 31.8 4-M16 depth 24

130.18±0.2
05

Port Details

Tighting
Port Name Port Size and Description
Torque(N.m)
A1, A2 Delivery Port SAE 6000psi 1 1/4" 98
B1 Suction Port SAE 500psi 4" 240
Dr1 Drain Port G 3/4 depth 20 170
Psv Serve Assist Port G 1/4 depth 15 36
Pi1, Pi2 Pilot Port G 1/4 depth 15 36
a1, a2, a3 Gauge Port G 1/4 depth 15 36
D1 Oil Filling Port G 3/4 depth 20 170
D0 Outlet Port G 3/4 depth 20 170
A3 Gear Pump Delivery Port G 1/2 depth 19 53
Dr3 Gear Pump Drain Port G 3/8 depth 15 34
a3 Gear Pump Gauge Port G 1/4 depth 15 16

100
Piston Pump | V90N-DP Series Hengli hydraulic 09 /18

V90N 212DP/230DP Control principle

·E1 Electro-proportional displacement control principle

Electro-proportional displacement control: With pilot-pressure-related control, the pump displacement


is adjusted in proportion to the pilot pressure. Basic position without pilot signal is Vg min, which
includes the mechanically depressurized basic position Vgmin. With increasing pilot pressure the pump
swivels to a larger displacement. The necessary control power is taken from the operating pressure or
the external control pressure applied to port P. If the pump is to be adjusted from the zero basic setting
or from a low operating pressure, port P must be supplied with an external control pressure of at least 30
bar, maximum 50 bar.
A1 A2

a4 a5
Pi1 a1 a2 Pi2

a7 a6

05

Ps2
D1
Dr1
B1
Ps1 D0 Dr2

A3 a3

Note:
·H1 Negative flow control schematic When ordering, please provide
the information as below:
A1 Psv a3 A2 ·Working pressure
·Maximum flow
·Minimum flow

a4 a5
a1 a2

Pi1 Pi2
Ps2
D1
Dr1
B1
Ps1 D0 Dr2

A3 a6

101
10 /18 Hengli hydraulic Piston Pump | V90N-DP Series

V90N 212DP/230DP Control principle

·H2 Negative flow control schematic

A1 Psv a3 A2

a4 a5
a1 a2

05 Pi1 Pi2
Ps2
D1
Dr1
B1
Ps1 D0 Dr2

A3 a6
Note:
·H3 Negative flow control schematic When ordering, please provide
the information as below:
·Working pressure
·Maximum flow
A1 A2
·Minimum flow

a4 a5
a1 a2

PA1 G1 G2 PA2

Pi1 Pi2

Ps2
D1
Dr1
B1
Ps1 D0 Dr2

A3 a6

102
Piston Pump | V90N-DP Series Hengli hydraulic 11 /18

Installation size

V90N 212DP/230DP type

672
582.5(A3,a6,Dr2)
401(A1,A2,Ps1,Ps2)
68.5 28.5±5
272
12±5 a5 a2 Ps2
Dr1 Ps2 a2 a5 a6 Dr2
Dr1 D1 eye bolt
a6 Dr2 D1
(m12)
A3
P

(for attaching bracket)


301(Ps2,a2,a5)
A3
Pi2 B1

209.5(A3)

265
A2
37 41.5
a3 a3

225
A1 A2 Psv

121.5(A2)
Psv D0
Φ511.2 -0.135
-0.232

A1
Φ555 -0.2

30°
Φ116
0

38.5(A1)

101

105
79
Pi1
Length of spline
Deutsch conn.
05
a4 a1 Ps1 2×4-M14 Ps1 a1 a4
Dt04-2p
141(Ps1,a1,a4)

depth 20 Φ530.2±0.2
M10 depth 16 eye bolt
5 17 (for attaching bracket) (m12) 200 145

C-C

M10 depth 16 Qmin.


(for attaching bracket) Pi1 Pi2 A1(A2)
adjusting screw

Qmax. 1.6
adjusting screw a3
272(Pi1,Pi2)

Psv
137.5(D0) 206(A1,A2)
128

15
256

112
56

(70)

8-M12 depth 19 D0 B1 Ps1(Ps2)


a4(a5) a1(a2)

2×1-M10 depth 16
59.5 52
(for attaching bracket)
47.5 76

103
12 /18 Hengli hydraulic Piston Pump | V90N-DP Series

Installation size
油口说明

·V90N 212DP/230DP Description of oil port


(403)
from front casing
Φ32 Φ32

B1
Φ76

69.9±0.2
A1 A2
66.7

66.7

31.8 31.8
4-M16
depth 24
57.35±0.2

05 120.7±0.2

Port Details

Port Name Port Size and Description


A1, A2 Output Port 1 1/4" SAE J518C Code 62 (6000psi)
B1 Suction Port 3-1/2" SAE J518C Code 61 (2500psi)
Dr1 Drain Port G 3/4 depth 20mm
Psv Servo Assist Port G 1/4 depth 15mm
Pi1, Pi2 Pilot Port G 1/4 depth 15mm
D1 Oil Filling Port G 3/4 depth 20mm
D0 Outlet Port G 3/4 depth 20mm
A3 Gear Pump Output Port G 1/2 depth 19mm
Dr2 Gear Pump Drain Port G 3/8 depth 15mm

104
Piston Pump | V90N-DP Series Hengli hydraulic 13 /18

V90N 252DP Control principle

·E1 Electro-proportional displacement control principle

Electro-proportional displacement control: With pilot-pressure-related control, the pump displacement


is adjusted in proportion to the pilot pressure. Basic position without pilot signal is Vg min, which
includes the mechanically depressurized basic position Vgmin. With increasing pilot pressure the pump
swivels to a larger displacement. The necessary control power is taken from the operating pressure or
the external control pressure applied to port P. If the pump is to be adjusted from the zero basic setting
or from a low operating pressure, port P must be supplied with an external control pressure of at least 30
bar, maximum 50 bar.
A1 A2

a4 a5
Pi1 a1 a2 Pi2

a7 a6

05

Ps2
D1
Dr1
B1
Ps1 D0 Dr2

A3 a3

Note:
·H1 Negative flow control schematic When ordering, please provide
the information as below:
A1 Psv a3 A2 ·Working pressure
·Maximum flow
·Minimum flow

a4 a5
a1 a2

Pi1 Pi2
Ps2
D1
Dr1
B1
Ps1 D0 Dr2

A3 a6

105
14 /18 Hengli hydraulic Piston Pump | V90N-DP Series

V90N 252DP Control principle

·H2 Negative flow control schematic

A1 Psv a3 A2

a4 a5
a1 a2

05 Pi1 Pi2
Ps2
D1
Dr1
B1
Ps1 D0 Dr2

A3 a6
Note:
·H3 Negative flow control schematic When ordering, please provide
the information as below:
·Working pressure
·Maximum flow
A1 A2
·Minimum flow

a4 a5
a1 a2

PA1 G1 G2 PA2

Pi1 Pi2

Ps2
D1
Dr1
B1
Ps1 D0 Dr2

A3 a6

106
Piston Pump | V90N-DP Series Hengli hydraulic 15 /18

Installation size

V90N 252DP type

684.5

595(A3, Dr2, a3) 202.5

68.5 411.5(A1, A2, Ps1, Ps2) D1 Dr1 Ps2 a2 a3 Dr2


Eye bolt
28.5 (M12)
P 12
Dr1 D1 a2 Ps2

(for attaching bracket)


Deutsch conn.
A3
a3 Dr2 A3 Dt04-2p

280.5
316.5(Ps2,a2,a5)
37 41.5 B1

229
A2
294.5(Dr1)

A1
D0
260(D1)

30°
247(a6)
219.5(A3)
∅116

Psv2
a7 A1 A2
125(A2)

101.5
05

Deutsch conn.
Φ511.2 -0.135
-0.232

45(A1)

79
Φ555 -0.2

Ps1
Dt04-2p a1
0

Length of spline R6.7


5 10-∅13.5
2-13.5 through
2X4-M14 Eye bolt
Psv1 a6 a1 Ps1 Φ530.2±0.2
146.5(Ps1,a1)

12.5
(M12)

12.5
depth 20 132.5 70

5 17 M10 depth 16 202.5 148


(for attaching bracket)
B-B

M10 depth 16
(for attaching bracket)
Psv1,Psv2
Qmax. adjusting screw
a6,a7 A1(A2) Qmin. adjusting screw
277.2(Psv1,Psv2)

206(A1,A2)
128

15
256

112
56

147(D0)
(70)

2-M10 depth 16
(for attaching bracket) D0 a1(a2) B1 Ps1(Ps2)

8-M12 59.5 52
depth 19 47.5 76

107
16 /18 Hengli hydraulic Piston Pump | V90N-DP Series

Installation size

·V90N 252DP Description


油口说明 of oil port

(413.5)
from front casing
∅32 Φ32

B1 ∅89

69.9±0.2
A1 A2
66.7

66.7

31.8 31.8
4-M16
05
60.35±0.2 depth 24

120.7±0.2

Port Details

Port Name Port Size and Description


A1, A2 Output Port 1 1/4" SAE J518C Code 62 (6000psi)
B1 Suction Port 3-1/2" SAE J518C Code 61 (2500psi)
Dr1 Drain Port G 3/4 depth 20mm
Ps1,s2 Gauge Port G 1 1/4 depth 24mm
Psv1,sv2 Pilot Port G 1/4 depth 13mm
a1,a2 Gauge Port G 1/4 depth 15mm
a4,a5 Gauge Port G 3/8 depth 15mm
a6,a7 Gauge Port G 1/4 depth 13mm
D1 Oil Filling Port G 3/4 depth 20mm
D0 Outlet Port G 3/4 depth 20mm
A3 Gear Pump Output Port G 1/2 depth 19mm
Dr2 Gear Pump Drain Port G 3/8 depth 15mm
a3 Gear Pump Gauge Port G 1/4 depth 14mm

108
Piston Pump | V90N-DP Series Hengli hydraulic 17 /18

05

109
18 /18 Hengli hydraulic Piston Pump | V90N-DP Series

05

China America © This brochure can be reproduced, edited, reproduced or


transmitted electronically without the authorization of Hengli
+86 400 101 8889 +01 630 995 3674 Hydraulic Company. Due to the continuous development of
the product, the information in this brochure is not specific to
Germany Japan the specific conditions or applicability of the industry, thus,
Hengli does not take any responsibility for any incomplete or
+49(30)72088-0 +81 03 6809 1696 inaccurate description.

110

You might also like