Professional Documents
Culture Documents
Appliance(s) are racked, stacked and • The Rubrik cluster network connections must be plugged into access port(s) or native VLAN port(s). Connect to a node
have power Rubrik does not support bootstrap on trunk link port(s). Example: Ansible to Bootstrap Cluster
Validate all nodes are discoverable
Appliance(s) are cabled correctly • The network switch must have Link Layer Discovery Protocol (LLDP) enabled.
Run Bootstrap on node
Complete Pre-Installation Worksheet • Rubrik uses multicast DNS (mDNS) for node-to-node discovery and to initiate system set up as
well as node adds
Obtain a Support Portal login by
• IPv6 support enabled
registering for access
AC Power Supplies
Node D Node B
NODE LOCATIONS NODE DISCOVERY CLUSTER BOOTSTRAP
The following figure shows the rear of To set up all of the Rubrik nodes in a Rubrik 1. SSH to a node using mDNS hostname
an r6000 series appliance. cluster, connect to any Rubrik node.
• Login as admin user: ssh -6
1. Connect laptop to a node’s admin@node_serial_number.local
bond1 interface
• Alternatively, connect using Google Chrome:
2. On laptop, launch Bonjour Browser https://node_serial_number.local
Node C Node A
Power Supply Latches • Note: mDNS hostname is
3. Find .rubrik
node_serial_number.local where
node_serial_number is the serial number of the Rubrik node
4. Make note of each node name’s and
NETWORK IPv6 address
Node Ejector Handle
2. At the Rubrik CLI prompt, type bootstrap. Use information in Pre-Installation Worksheet
INTERFACE LOCATIONS Push down and pull to complete configuration.
to remove node.
The following figure shows the network
3. Once bootstrap has completed, access the Rubrik cluster using any configured node
interfaces locations on a node. IP address.
Pull Handle Two Two VGA Dedicated IPMI
10GBaseT 10Gb/25Gb Connector 1GbE port
Management Data ports
ports (bond0) Two
(bond1) USB ports
20201025_v1