Professional Documents
Culture Documents
INSTRUCTION MANUAL
Warranty Details
REGISTER YOUR PURCHASE AT www.aldi.com.au/en/about-aldi/product-registration/ TO KEEP UP-TO-DATE WITH IMPORTANT PRODUCT INFORMATION
3
YEAR WARRANTY
4 5
8
9
6
10
11
12
13
14
essential; failure to keep that distance can result in the unit malfunctioning
or causing injury.
NOTE: D o not install this appliance at a dry cleaner’s premises.
Fig. 1 Fig. 2
Vertically opening window (Fig. 7)
• Adjust the window slider to the height of a vertically opening window.
• Fit the slider to the side of the window, then close the window.
• Fit the oval exhaust hose connector through the opening to the outside.
Fig. 7
POWER
9 10 10 11 12 13 14
1 3
IMPORTANT!
• Allow 30 seconds for cool airflow through the louvres. When turned
on, the cooling compressor requires up to 30 seconds to complete its
startup procedure, after which cool air will be produced (check for cool air
by placing your hand near the louvres).
• Avoid starting the air conditioner soon after switching off, and avoid
switching it off immediately after switching on. Allow at least five
minutes in between switching the unit on and then off, or vice versa.
This allows the compressor time to prepare for the next cycle. If the air
conditioner is turned off and then back on soon after (not recommended),
the compressor will require a few extra minutes before producing cool air.
• When using functions in Cooling and Dehumidifying mode, keep an
interval of at least three minutes between each ON and OFF.
Cooling mode
IMPORTANT: W hen using the portable air conditioner in cooling mode, the
flexible exhaust hose must be vented through an open window
to exhaust warm air from the room.
• Press the MODE button until the cooling mode indicator illuminates.
• Press the TEMP- ( ) or TEMP+ ( ) button repeatedly to set the desired
room temperature between 16°C and 31°C.
• Press the SPEED button to select the fan speed: high or low.
NOTE: For best cooling efficiency, make sure that:
* Curtains/blinds are closed if your room is directly exposed to the sun.
* The air conditioner is located away from any heat source.
Fan mode
• Press the MODE button until the dehumidifying mode indicator illuminates.
• Press the SPEED button to select the fan speed.
Timer operation
The air conditioner has a 24 hour timer, which you can set to start the unit at
a later time, or to switch off the unit automatically.
On-Timer setting
• With the unit switched off (but power supplied), press the TIMER button
once to activate the timer: the timer indicator will illuminate and “01” will
be flashing on the display screen.
• Press the ( ) or ( ) button repeatedly to set the number of hours after
which you want the unit to start operation. For example, to start the unit
in three hours, select ( 3 ).
• Press the TIMER button again to confirm the set time.
• To cancel the set time, press the TIMER button a third time.
Off-Timer setting
Use the same procedure as above, but while the unit is switched on, to set
an auto-off time.
Airflow adjustment
• Move the louvres at the cold air outlet Fig. 8
manually up or down to adjust the airflow
in these directions (Fig. 8).
• Move the lever underneath the louvres
to the right or left to direct the airflow to
either side (Fig. 8).
The ground is not level or not Make sure to place the unit
flat enough. on a flat, level ground.
Noisy The sound comes from the
This is normal and no cause
refrigerant flowing inside the
for concern.
air conditioner.
Call for service to replace
The room temperature sensor the room temperature
E0 Code
failed. sensor (the unit can also
work without replacement).
E2 Code Water full. Drain the water manually.
If the housing surface needs cleaning, wipe it with a damp cloth, then dry with
a soft, dry cloth.
CAUTION: Do not wash the unit directly. Do not use any solvent or alcohol-
based cleaning agent on any surface. Using such harsh cleansers will scratch
or damage the surface, or can even lead to deformation of the housing.
Fig. 10 Fig. 11
Responsible disposal
At the end of its working life, do not throw this appliance out with your
household rubbish. Electrical and electronic products contain substances
that can have a detrimental effect on the environment and human health
if disposed of inappropriately. Observe any local regulations regarding the
disposal of electrical consumer goods and dispose of it appropriately for
recycling and recovery of the refrigerant. Contact your local authorities for
advice on recycling facilities in your area.
3
Email: info@tempo.org
YEAR WARRANTY