Professional Documents
Culture Documents
1. Introduction ....................................................................................................................................................... 2
2. Firmware Update ............................................................................................................................................... 3
3. Bluetooth Firmware Update .............................................................................................................................. 8
1
1. Introduction
This manual aims to help you get the latest software programs for your keyboards.
1. GO:PIANO88
2
2. Firmware Update
2.1 Launch the Roland Comm Firmware updater.
Note: If you cannot launch this application, please allow apps downloaded from identified developers on
your Mac.
⚫ Click the “Open” button showed by red box in the picture above.
3
2.3 Preparation of GO:PIANO88
⚫ Connect your instrument to a PC with a standard USB cable.
Note: Never connect the PC with more than one instrument for each update.
⚫ Make sure the power supply is reliable for the update, and please don’t execute by battery power.
4
⚫ Boot up your GO:PIANO88 by Update Mode.
Take the keyboard GO:PIANO88, press and hold “#1+#2+#3+#4”([A0] + [A#0] + [B0] + [C1]) keys together and
⚫ When update mode, LEDs turn on of the instruments as below picture shows.
5
2.5 Click “Refresh” to prepare the connection.
Please confirm that the textbox shows “Device connected.”
Note: The progress bar may repeat several times (7 minutes) before the update is finished.
6
2.7 Finish the update.
⚫ Click “OK” to finish the update if you get the message below.
Note: If you fail to get the above message, please try again:
⚫ Check the selected update file is correct.
⚫ Check the USB connection or try with another USB cable.
⚫ Connect with another USB port on your Mac.
7
3. Bluetooth Firmware Update
3.1 Preparation
⚫ When online update is finished, disconnect the USB cable. Turn off the power.
⚫ The panel LEDs will flash (The update process will take about 50 seconds).
Note:
⚫ Close the update tool and restart your instrument, it will operate with the latest programs.