Professional Documents
Culture Documents
Question
Answer - 1
Likes - 0 | Dislikes - 0
Answer
As we know that these given products are known as the aluminum frames and the annular fins and
also that they are made up of extrusion process which is the main process and apart from that there
are some process which can be used and being explained below
https://chegg.machine.gq/ans?id=bc78a96c-8591-496e-a74c-46096ad87d78 1/2
5/30/22, 4:04 PM Always rext ;(
i) Apart from the extrusion process there is a manual process which is being used for making these
products and the step wise process is as given below
First of all the required profile parts are obtained from cutting machine and moved to the
assembly areas
After this appropriate angle selection is being done for the profiles selected
All other necessary requirements are checked if required
Small small drill holes are made in the profiles and the angle ate maker as per the hole made
and also the holes provided & number the profile & angle are checked
After this the holes in angles are also being made and this is done as per the marking
Identification number is provided for better assembly
After it the angles to the profile as per the identification number is being done
After that the assemblly of the aluminium frame is being carried out
Corners are being inspected if the gap or mismatch is found, if it is there , correction is being
done
The gasket is fitted as per the cutting requirements and list made that time
Fitting the accessories
Checking the dimensions
Even though we can produce these parts with manual processes but these process are not that
much attractive beacuse
https://chegg.machine.gq/ans?id=bc78a96c-8591-496e-a74c-46096ad87d78 2/2