Professional Documents
Culture Documents
Indicator Definition
De nition Indicator State Description
Light on Powered
PWR Power Indicator Light off Abnormal
Light on System Normal 1. Standard PoE power supply includes: protocol detection, power pin sequence
SYS System Indicator
Flash System Starting detection, power output, abnormal protection, Link abnormal monitoring.
Light on PoE Powered 2.
PoE PoE Indicator The PoE power supply protocol includes: IEEE802.3af (15.4W ), IEEE802.3at (30W ),
Light off No PoE Powered
IEEE802.3bt (90W ).
Light on Gigabit
1000M Link Rate Light off 3. The standard PoE power pin sequence is 12+/36-, and the passive PoE power pin
10/100M
User Manual
sequence is 45+/78-.
Light on 100M
100M Link Rate Light off 4.
Link Disconnect The standard POE switches can automatically detect and supply power to the PDs
that meet the standard, non-POE devices are not powered and only transmit data.
Light on Link is Normal
Link/ACT Link & Date
Flash Date Transmission 5. Passive PoE switches use mandatory power supply mode, non-PoE powered devices
Light on may be burned out, please use with caution.
Dial Switch VLAN
Mode/SW
Indicator
Flash
Light off
Extend
Default
6. 24V POE switches have both low-voltage power supply and PD detection technology, Commercial Series Switches
which can provide 24V voltage on 45/78 pin, even if it is connected to non-standard
Loop Loop Alarm Light on Port Loop equipment, it will not burn out.
Version: 1.0
9.States of Switch
8.PoE Powered Function
Function De nition State Description
※ This function is applicable to PoE switches, not applicable to non-PoE switches.
Designated port can not
Standard PoE Power Supply VLAN Port Isolation Light on communicate with each
other
Designated port link
Extend Link Extension Flash
extended to 250 meters
Due to regular upgrades of systems and products, ZKTeco could not guarantee exact consistency between
Copyright ® 2021 ZKTECO CO., LTD. All Rights Reserved. 5 6 the actual product and the written information in this manual.
1 2 3 4