Professional Documents
Culture Documents
Transient faults can occur during initial set up and discovery or when a server or virtual machine starts
up. You can typically ignore these transient faults, as Cisco UCS Manager clears them automatically.
This chapter includes the following sections:
• Initial Setup and Discovery Faults, page 5-1
• Virtual Machine Startup Faults, page 5-5
Table 5-1 Transient Faults that Occur during Initial Setup and Discovery Process
Cisco UCS Faults and Error Messages Reference Guide, Release 2.2(3)
OL-30570-01 5-1
Chapter 5 Troubleshooting Transient Faults
Initial Setup and Discovery Faults
Table 5-1 Transient Faults that Occur during Initial Setup and Discovery (continued)Process
Cisco UCS Faults and Error Messages Reference Guide, Release 2.2(3)
5-2 OL-30570-01
Chapter 5 Troubleshooting Transient Faults
Initial Setup and Discovery Faults
Table 5-1 Transient Faults that Occur during Initial Setup and Discovery (continued)Process
Cisco UCS Faults and Error Messages Reference Guide, Release 2.2(3)
OL-30570-01 5-3
Chapter 5 Troubleshooting Transient Faults
Initial Setup and Discovery Faults
Table 5-1 Transient Faults that Occur during Initial Setup and Discovery (continued)Process
F77960 [FSM:STAGE:REMOTE-ERROR]: Result: The FSM did not receive a response from
end-point-unavailable Code: unspecified the server during discovery and is waiting
Message: Waiting for BIOS POST
Completion information from
for the BIOS POST completion
IBMC(sam:dme:ComputeBladeDiscover: information.
BiosPostCompletion)
F0320 Server 1/1 (service profile: ) has an The Cisco UCS Manager could not
invalid FRU: identify the FRUs from the servers during
mismatch-identity-unestablishable
initial discovery.
F77959 [FSM:STAGE:REMOTE-ERROR]: Result: The Cisco UCS Manager could not
unidentified-fail Code: identify the FRUs from the servers during
ERR-0505-IBMC-fru-retrieval-error
Message: Could not get Fru from
initial discovery.
7f060101,
dn=fabric/server/chassis-1/slot-1
(sam:dme:FabricComputeSlotEpIdentify:Ex
ecuteLocal)
F16406 [FSM:STAGE:RETRY:]: triggering chassis In a cluster configuration, after the Cisco
discovery via IOM UCS Manager discovers the chassis
1/2(right)(FSM-STAGE:sam:dme:EquipmentI
OCardFeConn:DiscoverChassis)
through the I/O module connected to the
primary fabric interconnect, it raises
discovery through the I/O module
connected to the secondary fabric
interconnect.
Cisco UCS Faults and Error Messages Reference Guide, Release 2.2(3)
5-4 OL-30570-01
Chapter 5 Troubleshooting Transient Faults
Virtual Machine Startup Faults
Cisco UCS Faults and Error Messages Reference Guide, Release 2.2(3)
OL-30570-01 5-5
Chapter 5 Troubleshooting Transient Faults
Virtual Machine Startup Faults
Cisco UCS Faults and Error Messages Reference Guide, Release 2.2(3)
5-6 OL-30570-01