Professional Documents
Culture Documents
Toyota 8FB 的翻譯版本
Toyota 8FB 的翻譯版本
8FBH10
8FB10
8FB10.8FBH10
8FB10-J35
8FBH10
主要車輛規格 (2016 年 9 月)
製造商 TOYOTA
型號 8FB10
負載能力 kg 1000
負載中心 mm 500
動力類型 電池
操作員位置 騎手就座
輪胎類型 前/後 氣動
最大貨叉高度(MFH) mm 3000
0自由升降 mm 140
5 到前叉面的長度 mm 2075
6 總寬度 mm 1060
7 桅杆降低高度 mm 1970
8 桅杆延伸高度 mm 4220
9 護頂板高度 mm 2025
1 轉彎半徑(外側) mm 1750
負載距離 mm 400
(前軸中心線到貨叉正面)
後懸 mm 265
基本直角堆疊通道寬度 mm 2150
(添加負載長度和間隙)
相交通道寬度 mm 1705
提升 滿載 mm/sec 470
空載 mm/sec 650
下降 滿載 mm/sec 500
空載 mm/sec 550
7 牽引桿拉力* 滿載/ 3 分鐘額定 N (kg) 9260/8650 (940/880)
空載
5 分鐘額定 N (kg) 9260/8650(940/880)
2 不帶電池 kg 1940
重量分佈(帶 滿載 前 kg 2950
標準電池)
後 kg 570
空載 前 kg 1310
後 kg 1210
輪胎 編號 前/後 2/2
尺寸 前 6.00-9-10-PR (I)
8 軸距 mm 1410
9 部 mm 885
後部 mm 895
靠背高度 mm 1220
護頂板間隙 mm 1035
配重高度 mm 1105
牽引桿高度 mm 430
台階高度/地板高度 mm 430/615
間隙 (滿載) mm 75
軸距中心(滿載) mm 85
驅動橋(滿載) mm 75
配重(空載) mm 120
最小間隙(滿載) mm 75(桅杆)
坡度間隙 框架 % (tanθ) 27
配重 % (tanθ) 65
制動 服務(腳) 液壓
駐 車手
電動機 驅動 kW 7.6
負載處理 kW 9.5
2414.5/14.5 17.0/17.0/17.0/17.0
33 3090 760
34 1450 1400
352/2 36 6.00-9-10-PR (I) 37 5.00-8-8PR (I) 1410
895
1220
1030
885
430
4
1140/695
4075 41 85 75
125
120
75(桅杆)
27
65
42 液壓 43 手動 4 5 48/545 -
46 845 477.6 48 9.5 3.6
54 Trasistor 逆變器 Trasistor 逆變器
11.8 (1700)
S-FB10 — 8FB10-J35-1 —
8FB10.8FBH10
根據 EN13059 m/s2 -
-
-
注意:* 計算值。
** 60 VDI 工作循環/小時,測試負載為 1000 kg。
8FB10/8FBH10
UNDERCLEARANCE
桅杆(滿載)------------------------------- 75
中心軸距(滿載)--------- 85
驅動橋(滿載)------------------------ 75
轉向橋(空載)------------------------ 125
配重(空載)----------------- -- 120
最小間隙(滿載)-- 75(桅杆)
注:[ ] 用於 8FBH10
S-FB10 — 8FB10-J35-2 —
8FB10.8FBH10
額定 (2016 年 9 月) 8FB10/8FBH10
A:
最大。 Fork Height
B:
Load Center
W:
Capacity
V, FV Mast
Unit: kg (W)
注: > 適用於雙輪胎型號。
特殊胎面 (2016 年 9 月)
型號 8FB10/8FBH10
單/雙 單 單 雙
前輪胎 Dual
Front輪胎尺寸 6.00-9-10PR (I)
總寬度 1435
Tread, Front 1085
V FV
桅杆類型 FSV 性能
H P S E H P S E H P S
提升 滿載 mm/s 470 360 360 325 430 330 330 310 430 330 330
ec
空載 mm/s 650 560 560 535 590 510 510 485 590 510 510
ec
下降 滿載 mm/s 500 500 500 500 480 480 480 480 480 480 480
ec
空載 mm/s 550 550 550 550 420 420 420 420 450 450 450
ec
動力模式 E 310
速度
尺寸 負載距離
485
480
450
mm 400
S-FB10 — 8FB10-J35-3 —
8FB10.8FBH10
桅杆規格和額定容量 (2016 年 9 月) Wide Visible Mast (V), Wide Visible Full-Free Lift 兩級桅杆 (FV), Wide Visible Full-Free Lift 三級桅杆 (FSV)
8FB10/8FBH10
最大 總高度 Free Lift 單輪胎
叉高度
* 降低 擴展 無 無 傾斜範圍 500 毫米 範圍
負載 標準 傾斜
BWD FWD 靠背 負載 FWD BWD mm mm
負載 標準 靠背
靠背 靠背
雙輪胎
米。
500 mm
桅杆
LC
類型
kg
1000
1000
1000
1000
1000
V 1000
1000
1000
1000
1000
1000
1000
FV 1000
1000
950
900
900
900
900
FSV 850
850
800
S- FB440 —
8FB14/8-8FB10-3
8FB14
8FB14/8FBH14
8FBH14
主要車輛規格 (2016 年 9 月)
製造商 TOYOTA
型號 8FB14
負載能力 kg 1350
負載中心 mm 500
動力型 電池
操作員位置 騎手坐式
輪胎類型 前/後 氣動
最大貨叉高度(MFH) mm 3000
0自由提升 mm 145
5 到前叉面的長度 mm 2080
6 總寬度 mm 1060
7 桅杆降低高度 mm 1970
8 桅杆延伸高度 mm 4220
9 護頂板高度 mm 2025
1 轉彎半徑(外側) mm 1760
負載距離 mm 405
(前軸中心線到貨叉正面)
後懸 mm 265
基本直角堆疊通道寬度 mm 2165
(添加負載長度和間隙)
相交通道寬度 mm 1725
提升 滿載 mm/sec 430
空載 mm/sec 650
下降 滿載 mm/sec 500
空載 mm/sec 550
重量分佈(帶 滿載 前 kg 3550
標準電池)
後 kg 410
空載 前 kg 1330
後 kg 1280
輪胎 數量 前/後 2/2
尺寸 前 6.00-9-10-PR (I)
8 軸距 mm 1410
9 部 mm 885
後部 mm 895
靠背高度 mm 1220
護頂板間隙 mm 1035
配重高度 mm 1105
牽引桿高度 430
台階高度/地板高度 mm 430/615
間隙 (滿載) mm 70
中心軸距(滿載) mm 85
驅動橋(滿載) mm 70
轉向橋(無負載) mm 125
配重(空載) mm 120
最小間隙(滿載) mm 70(桅杆)
坡度間隙 框架 % (tanθ) 27
配重 % (tanθ) 65
制動 服務(腳) 液壓
駐 車手
電動機 驅動 kW 7.6
負載處理 kW 9.5
2414.5/14.5 17.0/17.0/17.0/17.0
25 430 650
33 3680 590
34 1460 1460
352/2 36 6.00-9-10-PR (I) 37 5.00-8-8PR (I) 1410
1220
1030
1140
885
430
4
895695
4065 41 85 65
125
120
65(桅杆)
27
65
42 液壓 43 手動 45 48/545 -
46 845 477.6 48 9.5 3.8
54 Trasistor 逆變器 Trasistor 逆變器
11.8 (1700)
S-FB14 — 8FB10-J35-5 —
8FB14/8FBH14
根據 EN13059 m/s2 -
-
-
注意:* 計算值。
** 60 VDI 圈/小時,測試負載為 1350 公斤。
8FB14/8FBH14
UNDERCLEARANCE
桅杆(滿載)------------------------------- 70<65 >
軸距中心(滿載)---------- 85
驅動橋(滿載)------------------------ 70 <65>
轉向橋(空載)------------------------ 125
配重(空載)----------- -------- 120
最小間隙(滿載)-- 70<65>(桅杆)
注意:[ ] 用於 8FBH14
S-FB14 — 8FB10-J35-6 —
8FB14/8FBH14
額定 (2016 年 9 月) 8FB14/8FBH14
A:
最大。叉高
B:
負載中心
W:
容量
V,FV桅杆
:kg(w)
30 33 35 37 40 45
00 00 00 00 00 00
50 13 13 13 13 13 12
0 50 50 50 50 50 50
60 12 12 12 12 12 11
0 10 10 10 10 10 20
70 12 12 12 12 13 13
0 10 10 10 10 50 50
13 13 37 單 10 10 93
50 50 00 位 10 10 0
90 93 93 93 93 93 86
0 0 0 0 0 0 0
93
0
10 86 86 86 86 86 80
00 0 0 0 0 0 0
11 81 81 81 81 81 75
00 0 0 0 0 0 0
76 76 76 76 76 76 70
0 0 0 0 0 0 0
A (mm
860
860
860
860
810
)
760 (mm) 70 10 98 98 94 94 820 650
0 20 0 0 0 0 <900 <900
> >
50 12 12 1 71 68 62 68 65 65 650 650
0 50 00 0 0 0 00 0 0 0 480 1200
60 11 10 1
0 20 80 8
注意:<> 適用於雙輪胎型號。
特殊胎面 (2016 年 9 月)
型號 8FB14/8FBH14
單/雙 單 單 雙
前輪胎 Dual
Front輪胎尺寸 6.00-9-10PR (I)
總寬度 1435
Tread, Front 1085
V FV
桅杆類型 FSV 性能
H P S E H P S E H P S
提升 滿載 mm/s 430 330 330 310 400 310 310 275 400 310 310
ec
空載 mm/s 650 560 560 535 590 510 510 485 590 510 510
ec
下降 滿載 mm/s 500 500 500 500 480 480 480 480 480 480 480
ec
空載 mm/s 550 550 550 550 420 420 420 420 450 450 450
ec
動力模式 E 275
速度 mm 405
尺寸 負載距離
485
480
450
S-FB14 — 8FB10-J35-7 —
8FB14/8FBH14
桅杆規格和額定容量 (2016年9月) Wide Visible Mast (V), Wide Visible Full-Free Lift Two-Stage Mast (FV), Wide Visible Full-Free Lift 三級桅杆
(FSV)
8FB14/8FBH14
最大 總高度 Free Lift 單胎
叉高度
* 降低 擴展 無 無 傾斜範圍 500 傾斜
負載 標準 LC
BWD FWD 靠背 負載 FWD BWD mm mm
負載 標準 靠背
靠背 靠背
雙輪胎
桅杆
類型
500毫米
LC
KG
1350
1350
1350
V
1350
1350
1350
1350
1250
1200
1350
FV 1350
1350
1350
1350
1250
1200 1200
FSV 1200
1150
1150 1150
1100
1100 1100
注意:標準負載靠背的高度為 920 毫米。 * 可選輪胎尺寸; 6.50-10-12PR (I),加 25 毫 1050
米。
S-FB14 - 8FB10-J35-8 -
8FB15/8FB15/8FBH15
8FB15
8FB15/8FBH15
8FBH15
主要車輛規格 (2016 年 9 月)
製造商 TOYOTA
型號 8FB15
負載能力 kg 1500
負載中心 mm 500
動力類型 電池
操作員位置 騎手坐姿
輪胎類型 前/後 氣動
最大貨叉高度(MFH) mm 3000
0自由提升 mm 145
5 到前叉面的長度 mm 2080
6 總寬度 mm 1115
7 桅杆降低高度 mm 1970
8 桅杆延伸高度 mm 4220
9 護頂板高度 mm 2025
1 轉彎半徑(外側) mm 1770
負載距離 mm 405
(前軸中心線到貨叉正面)
後懸 mm 265
基本直角堆疊通道寬度 mm 2175
(添加負載長度和間隙)
相交通道寬度 mm 1760
提升 滿載 mm/sec 420
空載 mm/sec 650
下降 滿載 mm/sec 500
空載 mm/sec 550
重量分佈(帶 滿載 前 kg 3790
標準電池)
後 kg 450
空載 前 kg 1330
後 kg 1410
輪胎 數量 前/後 2/2
尺寸 前 6.00-9-10-PR (I)
8 軸距 mm 1410
9 部 mm 960
後部 mm 895
靠背高度 mm 1220
護頂板間隙 mm 1035
配重高度 mm 1105
牽引桿高度 mm 430
台階高度/地板高度 mm 430/615
間隙 (滿載) mm 65
軸距中心(滿載) mm 85
驅動橋(滿載) mm 65
轉向橋(空載) mm 125
配重 (空載) mm 120
最小間隙(滿載) mm 65(桅杆)
坡度間隙 框架 % (tanθ) 27
配重 % (tanθ) 65
制動 服務(腳) 液壓
駐 車手
電動機 驅動 kW 7.6
負載處理 kW 9.5
2414.5/14.5 17.0/17.0/17.0/17.0/17.0
25 420 650
33 3920 580
34 1460 1540
352/2 36 6.00-9-10-PR (I) 37 5.00-8-8PR (I) 1410
895
1220
1035
1140
4
960
430/695
4065 41 85 65
125
120
65(桅杆)
27
65
42 液壓 43 H和 45 48/545 -
46 845 477.6 48 9.5 4.0
54 Trasistor 逆變器 Trasistor 逆變器
11.8 (1700)
S-FB15 — 8FB10-J35-9 —
8FB15/8FBH15
68
1.5
注意:* 計算值。
** 60 VDI 圈/小時,測試負載為 1500 公斤。
8FB15/8FBH15
UNDERCLEARANCE
桅杆(滿載)------------------------------- 65
中心軸距(滿載)--------- 85
驅動橋(滿載)------------------------ 65
轉向橋(空載)------------------------ 125
配重(空載)----------------- -- 120
最小間隙(滿載)-- 65(桅杆)
注意:[ ] 用於 8FBH15
S-FB15 — 8FB10-J35-10 —
8FB15/8FBH15
額定 (2016 年 9 月) 8FB15/8FBH15
A:
最大。 Fork Height
B:
Load Center
W:
Capacity
V, FV Mast
Unit: kg (W)
30 33 35 37 40 45
00 00 00 00 00 00
50 15 15 15 15 15 14
0 00 00 00 00 00 50
60 13 13 13 13 13 13
0 50 50 50 50 50 00
70 12 12 12 12 12 11
0 20 20 20 20 20 80
80 11 11 11 11 11 10
0 20 20 20 20 20 80
90 10 10 10 10 10 10
0 40 40 40 40 40 00
10 96 96 96 96 96 93
00 0 0 0 0 0 0
11 90 90 90 90 90 87
00 0 0 0 0 0 0
12 84 84 84 84 84 81
00 0 0 0 0 0 0
80 10 10 10 10 10 900 830
0 50 50 50 10 10 <980 <940
> >
60 12 12 1
0 60 60 6
注意:<> 適用於雙輪胎型號。
特殊胎面 (2016 年 9 月)
型號 8FB15/8FBH15
單/雙 單 單 單 雙
V FV
桅杆類型 FSV 性能
H P S E H P S E H P S
提升 滿載 mm/s 420 320 320 300 390 300 300 260 390 300 300
ec
空載 mm/s 650 560 560 535 590 510 510 485 590 510 510
ec
下降 滿載 mm/s 500 500 500 500 480 480 480 480 480 480 480
ec
空載 mm/s 550 550 550 550 420 420 420 420 450 450 450
ec
動力模式 E 260
速度 mm 405
尺寸 負載距離
485
480
450
S-FB15 — 8FB10-J35-11 —
8FB15/8FBH15
桅杆規格和額定容量 (2016年9月) Wide Visible Mast (V), Wide Visible Full-Free Lift 兩級桅杆 (FV), Wide Visible Full-Free Lift 三級桅杆 (FSV)
8FB15/8FBH15
最大 總高度 Free Lift 單胎
叉高度
* 降低 擴展 無 無 傾斜範圍 500 傾斜
負載 標準 LC
靠背 負載
靠背
BWD FWD FWD BWD mm mm
負載 標準
靠背 靠背
雙輪胎
桅杆
類型
V
1500
1500
1500
1500
1500
1500
FV 1500
1450
1400
1500
1500
1500
1500
FSV 1500
1400
1400
1400
1350
注意:標準負載靠背的高度為 920 毫米。 * 可選輪胎尺寸; 6.50-10-12PR (I),加 25 毫 1350
米。 1300
500 mm 1250
LC 1300
kg
40-8FB15
40-8FB15
主要車輛規格 (2016 年 9 月)
製造商
型號
負載能力 kg
負載中心 mm
動力類型
操作員位置
輪胎類型 前/後輪
(x = 從動) 前/後
最大貨叉高度 (MFH) mm
0 自由升力 mm
3 貨叉尺寸 LхWхT mm
叉形傳播(外部) 最大/最小。 mm
傾斜範圍 FWD/BWD 度
5 到前叉面的長度 mm
6 總寬度 mm
7 桅杆降低高度 mm
8 桅杆伸展高度 mm
9 頂置護罩高度 mm
1 轉彎半徑(外側) mm
負載距離 mm
(前軸中心線到前面叉)
後懸 mm
基本直角堆疊通道寬度 mm
(添加負載長度和間隙)
相交通道寬度 mm
速度 * 行程,最大。 滿載 km/h
(FWD/RVS)
空載 km/h
提升 滿載 mm/sec
空載 mm/sec
下降 滿載 mm/sec
空載 mm/sec
60 分鐘額定值 N (kg)
30 分鐘額定值 % ( tanθ)
2 總重量 不含電池 kg
重量分佈 滿載 前 kg
(含 STD 電池)
後 kg
空載 前 kg
後 kg
輪胎 編號 前/後
尺寸 前
8 軸距 mm
胎面 前 mm
後 mm
靠背高度
護頂板間隙
配重高度
牽引桿高度
台階高度/地板高度
桅杆 (滿載) mm
軸距中心 mm
) mm
轉向軸(空載) mm
配重(空載) mm
最小間隙(滿載) mm
坡度 間隙 框架 % (tanθ)
配重 % (tanθ)
制動 服務(腳)
停車
重量(STD Capa城市類型) kg
電動機 驅動 kW
負載處理 kW
能量消耗根據 VDI 循環 ** kW
控制類型 驅動
負載處理
7 附件 Mpa (psi)
2414.0/14.0 16.0/16.0
25 380 600
26 500 500
11330/10640 (1150/1080)
11330/10640 (1150/1080)
)
24/25
24/25
24/24
(
480/500 4710/4900860
34 1650 1770
352/2 36 21X8-9-14PR (I) 37 18X7-8-14PR (I) 1500
940
1220
1035
1135
280
435/700
4075
41 90 75
120
1563
桅杆)
3
970
液壓手動 45 48/600 48/730
46 955 4710.7 48 12.2 4.3
54 晶體管逆變器 晶體管逆變器
14.7 (2100)
-
S-FB15 — 8FB10-J35-13 —
40-8FB15
-
注意:* 計算值。
** 60 VDI 圈/小時,測試負載為 1500 公斤。
40-8FB15
UNDERCLEARANCE
桅杆(滿載)------------------------------- 75
中心軸距(滿載)--------- 90
驅動橋(滿載)------------------------ 75
轉向橋(空載)------------------------ 120
配重(空載)------ -- 115
最小間隙(滿載)-- 75(桅杆)
S-FB15 — 8FB10-J35-14 —
40-8FB15
額定 (2016 年 9 月) 40-8FB15
A:
最大。 Fork Height
B:
Load Center
W:
Capacity
V, FV Mast
Unit: kg (W)
30 33 35 37 40 45
00 00 00 00 00 00
50 15 15 15 15 15 14
0 00 00 00 00 00 50
60 13 13 13 13 13 13
0 50 50 50 50 50 00
70 12 12 12 12 12 11
0 30 30 30 30 30 90
80 11 11 11 11 11 10
0 20 20 20 20 20 90
90 10 10 10 10 10 10
0 40 40 40 40 40 00
10 10
40 00
97 97 97 97 97 97 93
0 0 0 0 0 0 0
11 90 90 90 90 90 85
00 0 0 0 0 0 0
85 85 85 85 85 85 82
0 0 0 0 0 0 0
A (mm)
970
970
970
1000
850
850
850 (mm) 70 11 11 11 11 11 990 900
0 50 50 50 10 10 <107 >
11 0>
50
80 10 10 10 10 10 910 830
0 60 60 60 20 20 <980 >
10 >
60
FSV 桅杆 單位:kg (W)
<1050>
90 10 83 10 10 > 1020 770
930
<970> 0 60 0 20 20 <910 <870
> >
870
<900>
810 10 91 91 91 88 88 780 710
<840> 00 0 0 0 0 0 <840 <810
760 > >
790>
37 40 4 11 85 85 85 82 82 730 670
00 00 0 00 0 0 0 0 0 <790 <760
> >
50 14 14 1
0 00 00 0 12 80 80 80 77 76 7670 7670
00 0 0 00 0 70 < >
60 12 12 1
0 60 60 6
注意:<> 適用於雙輪胎型號。
特殊胎面 (2016 年 9 月)
型號 40-8FB15
單/雙 單 單
mm 1160 1220
mm 970 990
前輪胎 雙
前輪胎尺寸 6.00-9-10PR (I)
整體寬度 1480
胎面,前 1130
V FV
桅杆類型 FSV 性能
H P S E H P S E H P S
提升 滿載 mm/s 380 280 280 255 390 280 280 270 390 280 280
ec
空載 mm/s 600 500 500 465 570 480 480 440 570 480 480
ec
下降 滿載 mm/s 500 500 500 500 480 480 480 480 480 480 480
ec
空載 mm/s 500 500 500 500 420 420 420 420 450 450 450
ec
動力模式 E 270
速度 mm 415
尺寸 負載距離
440
480
450
S-FB15 — 8FB10-J35-15 —
40-8FB15
桅杆規格和額定容量 (2016年9月) Wide Visible Mast (V), Wide Visible Full-Free Lift 兩級桅杆 (FV), Wide Visible Full-Free Lift 三級桅杆 (FSV)
40-8FB15
最大 總高度 Free Lift 單胎
叉高度 * 降低 擴展 無 無 傾斜範圍 500 傾斜
負載 標準 LC
BWD FWD 靠背 負載 FWD BWD mm mm
負載 標準 靠背
靠背 靠背
3605 55000 3075 5670 5920 125 125 7 5 1350 1975 1975
5920
5920
雙輪胎
桅杆
類型
FV
V
1500
1500
1500
1500
8FB18
1400
FSV
1500
1500
1500
1500
1500
注意:標準負載靠背的高度為 920 毫米。 * 可選輪胎尺寸; 23×9-10-16PR (I),加 20 毫 1400
米。
1400
500毫米
1400
LC
1350
1350
KG 1300 1300
1500 1250
1500 1100
1500
S-FB15 - 8FB10-J35-16 -
/8FBH18/8FBH18
8FB18
8FB18/8FBH18
8FBH18
主要車輛規格 (2016 年 9 月)
製造商 TOYOTA
型號 8FB18
負載能力 kg 1750
負載中心 mm 500
動力類型 電池
操作員位置 騎手坐式
輪胎類型 前/後 氣動
最大貨叉高度(MFH) mm 3000
0自由提升 mm 145
4 / deg 7/11
5 到前叉面的長度 mm 2115
6 總寬度 mm 1115
7 桅杆降低高度 mm 1970
8 桅杆延伸高度 mm 4220
9 護頂板高度 mm 2025
1 轉彎半徑(外側) mm 1780
負載距離 mm 405
(前軸中心線到貨叉正面)
後懸 mm 300
基本直角堆疊通道寬度 mm 2185
(添加負載長度和間隙)
相交通道寬度 mm 1775
提升 滿載 mm/sec 370
空載 mm/sec 650
下降 滿載 mm/sec 500
空載 mm/sec 550
重量分佈(帶 滿載 前 kg 4240
標準電池)
後 kg 500
空載 前 kg 1370
後 kg 1620
輪胎 數量 前/後 2/2
尺寸 前 21X8-9-10PR (I)
後 5.00-8-10PR ( I)
8 軸距 mm 1410
9胎 面前部 mm 920
後部 mm 895
靠背高度 mm 1220
護頂板間隙 mm 1035
配重高度 mm 1105
牽引桿高度 430
台階高度/地板高度 mm 430/615
間隙 (滿載) mm 65
軸距中心(Full Load) mm 85
Counterweight % (tanθ) 54
Parking Hand
1 TOYOTA 2 8FBH18 3 1750 4 500 5 Battery 6 Rider Seated 7 Pneumatic 8 2x/2 9 3000 145
1070/100/35
920/200
7/11
2115
1115
1970
4220
2105
1780
22 405 300
23 2185
1775
2414.5/14.5 17.0/17.0
25 370 650
26 500 550
9210/8600(930/870)
9210/8600(930/870)
2750/2940(280/300)
17/23
17/23
11/18
2355
33 4330 620
34 1460 1740
352/2 36 21X8-9-10PR (I) 37 5.00-8-10PR (I) 1410
920
895
1220
1035
1140
430
430/695
4065 41 85 65
125
120
65(Mast)
27
54
42 Hydraulic 43 Hand 45 48/ 545 -
46 845 477.6 48 9.5 4.3
54 Trasistor inverter Trasistor inverter
11.8(1700)
S-FB18 — 8FB10-J35-17 —
8FB18/8FBH18
68
1.5
NOTE: * Computed values.
** 60 VDI circles/h with Tested Load of 1750 kg.
S-FB18 — 8FB10-J35-18 —
8FB18/8FBH18
30 33 35 37 40 4500
00 00 00 00 00
50 17 17 17 17 17 1550
0 50 50 50 50 50 <165
0>
60 15 15 15 15 15 1390
0 70 70 70 70 70 <148
0>
70 14 14 14 14 14 1260
0 30 30 30 30 30 <135
0>
80 13 13 13 13 13 1160
0 10 10 10 10 10 <123
0>
90 12 12 12 12 12 1070
0 10 10 10 10 10 <114
0>
10 11 11 11 11 11 990
00 20 20 20 20 20 <106
0>
11 10 10 10 10 10 930
00 50 50 50 50 50 <990
>
12 98 98 98 98 98 870
00 0 0 0 0 0 <930
>
70 13 13 12 12 12 1020 730
0 10 10 70 30 30 <119 <115
0> 0>
80 12 12 11 11 11 940 670
FSV Mast Unit: kg (W) 0 00 00 70 30 30 <109 <105
<1160> 0> 0>
830
<1070> 90 11 11 10 10 10 870 620
770 0 10 10 80 40 40 <101 <970
<990> 0> >
720
<930> 10 10 10 10 97 97 810 580
670 00 30 30 00 0 0 <940 <900
<870> > >
37 40 4
00 00 0 11 97 97 93 90 90 750 540
00 0 0 0 0 0 <870 <840
50 16 16 1 > >
0 00 00 5
12 91 91 88 85 85 710 510
00 0 0 0 0 0 <820 <790
60 14 14 1 > >
A (mm) 6000 750
<1150>
670
<1030>
610
<940>
560
<860> 520
B (mm)
<800> 480
<740> 450
<690> 420
<650>
SPECIAL MAST (September 2016) Wide Visible Mast (V), Wide Visible Full-Free Lift Two-Stage Mast (FV), Wide Visible Full-Free Lift Three-Stage
Mast (FSV)
Model 8FB18/8FBH18
V FV
H P S E H P S E H P S
Lifting Full Load mm/s 370 300 300 265 350 280 280 250 350 280 280
ec
No Load mm/s 650 560 560 535 590 510 510 485 590 510 510
ec
Lowering Full Load mm/s 500 500 500 500 480 480 480 480 480 480 480
ec
No Load mm/s 550 550 550 550 420 420 420 420 450 450 450
ec
(Centerline of front axle to front face of forks) 425 NOTE: H High power mode / P Power mode / S Standard mode / E Eco mode
S-FB18 — 8FB10-J35-19 —
8FB18/8FBH18
MAST SPECIFICATIONS & RATED CAPACITIES (September 2016) Wide Visible Mast (V), Wide Visible Full-Free
Lift Two-Stage Mast (FV), Wide Visible Full-Free Lift Three-Stage Mast (FSV)
8FB18/8FBH18
Maximu Overall Height Free Lift Single tire
m
Fork
* Lowered Extended Without With Tilt Range Load Tilt Range
Height
Load Stan Capacity at
Without With Backres dard FWD BWD 500 mm FWD BWD
Load Stan t Load LC
Backres dard Backres
t Load t
Backres
t
Dual tire
Mast
Type
FV
FSV
1750
1650
1550
1750
NOTE: Height of standard load backrest is 920 mm. * with optional tire size ; 1750
6.50-10-12PR (I), plus 25mm. 1750
Load Capacity at 500 mm 1750
LC 1750
1600
kg 1600
1750 1550
1750 1500
1750 1500
1750 1450
1750 1400
1750 1150
S-FB18 — 8FB10-J35-20 —
8FB20/8FBH20
8FB20
8FB20/8FBH20
8FBH20
MAIN VEHICLE SPECIFICATIONS (September 2016)
Manufacturer TOYOTA
Model 8FB20
Rear kg 1760
8 Wheelbase mm 1500
Rear mm 940
Counterweight % (tanθ) 56
Parking Hand
1 TOYOTA 2 8FBH20 3 2000 4 500 5 Battery 6 Rider Seated 7 Pneumatic 8 2x/2 9 3000 125
1070/120/36
1020/240
7/11
2240
1160
1975
4220
2105
1980
22 420 320
23 2400
1850
2414.5/14.5 16.5/16.5
25 360 600
26 500 500
11210/10600 (1140/1080)
11210/10600 (1140/1080)
4710/4900 (480/500)
20/23
20/23
15/22
2590
33 4980 770
34 1750 2000
352/2 36 21X8-9-14PR (I) 37 18X7-8-14PR (I) 1500
970
940
1220
1035
1135
425
435/700
4070 41 90 70
120
115
70(Mast)
25
56
42 Hydraulic 43 Hand 45 48/730 -
46 1160 4710.7 48 12.2 4.2
54 Transistor inverter Transistor inverter
14.7(2100)
S-FB20 — 8FB10-J35-21 —
8FB20/8FBH20
67
1.5
NOTE: * Computed values.
** 60 VDI circles/h with Tested Load of 2000 kg.
S-FB20 — 8FB10-J35-22 —
8FB20/8FBH20
30 33 35 37 40 45
00 00 00 00 00 00
50 20 20 20 20 20 19
0 00 00 00 00 00 00
60 18 18 18 18 18 17
0 00 00 00 00 00 10
70 16 16 16 16 16 15
0 40 40 40 40 40 60
80 15 15 15 15 15 14
0 00 00 00 00 00 30
90 13 13 13 13 13 13
0 90 90 90 90 90 20
10 12 12 12 12 12 12
00 90 90 90 90 90 30
11 12 12 12 12 12 11
00 10 10 10 10 10 50
12 11 11 11 11 11 10
00 30 30 30 30 30 70
13 10 10 10 10 10 10
00 70 70 70 70 70 10
80 14 14 14 13 13 1170 910
0 40 40 00 60 60 <132 <129
0> 0>
90 13 13 13 12 12 1090 840
FSV Mast Unit: kg (W) 0 30 30 00 60 60 <123 <119
1150 0> 0>
<1250>
1060 10 12 12 12 11 11 1010 780
<1160> 00 40 40 10 70 70 <114 <1110
990 0> >
<1080>
930 11 11 11 11 11 11 940 730
<1020> 00 60 60 30 00 00 <107 <104
880 0> 0>
<960>
37 40 4 12 10 10 10 10 10 890 690
00 00 0 00 90 90 60 30 30 <100 <970
0> >
50 19 19 1
0 00 00 5 13 10 10 10 97 97 840 650
00 30 30 00 0 0 <940 <920
> >
60 17 17 1
0 10 10 7
A (mm) 6000 900
<1500>
810
<1350>
740
<1230>
680
<1130>
630
B (mm)
<1050> 580
<980> 550
<910> 510
<860> 480
<810>
mm 1160 1220
mm 970 990
SPECIAL MAST (September 2016) Wide Visible Mast (V), Wide Visible Full-Free Lift Two-Stage Mast (FV), Wide Visible Full-Free Lift Three-Stage
Mast (FSV)
Model 8FB20/8FBH20
V FV
H P S E H P S E H P S
Lifting Full Load mm/s 360 270 270 245 330 250 250 245 330 250 250
ec
No Load mm/s 600 500 500 465 570 480 480 440 570 480 480
ec
Lowering Full Load mm/s 500 500 500 500 480 480 480 480 480 480 480
ec
No Load mm/s 500 500 500 500 420 420 420 420 450 450 450
ec
S-FB20 — 8FB10-J35-23 —
8FB20/8FBH20
MAST SPECIFICATIONS & RATED CAPACITIES (September 2016) Wide Visible Mast (V), Wide Visible Full-Free
Lift Two-Stage Mast (FV), Wide Visible Full-Free Lift Three-Stage Mast (FSV)
8FB20/8FBH20
3000 1975 3670 4500 2045 5145 542
FV
5000 3075 5670 Load
Capaci ty at
500
mm
3000 1975 3605
LC
FSV kg
2000
Maximum Overall He 3300 2125 3905 2000
Fork 2000
Height 2000
3500 2225 4105 2000
* Lowered E 2000
2000
1900
Withou 3700 2385 4305
1800
Load
2000
Backres
2000
4000 2575 4605 2000
2000
2000
3700 1775 4345 1900
1900
1850
mm mm mm
1800
4000 1875 4645 1800
2500 1725 3170 1750
1700
4300 1975 4945 1500
2700 1825 3370
40-8FB20
40-8FB20
Model
Load Capacity kg
Load Center mm
Power Type
Operator Position
0 Free Lift mm
6 Overall Width mm
Load Distance mm
(Centerline of front axle to front face of forks)
Rear Overhang mm
No Load mm/sec
No Load mm/sec
No Load Front kg
Rear kg
Size Front
Rear
8 Wheelbase mm
9 Tread Front mm
Rear mm
Backrest Height
Counterweight Height
Drawbar Height
Counterweight % (tanθ)
Parking
Load Handling kW
Load Handling
Sound level at the driver's ear according to EN12053 Uncertainty 4dB(A) dB (A)
1 TOYOTA 2 40-8FB20 3 2000 4 500 5 Battery 6 Rider Seated 7 Pneumatic 8 2x/2 9 3000 150
1070/120/36
1020/240
6/11
2405
1230
1995
4220
2160
2145
22 445 310
23 2590
1910
2414.5/14.5 15.5/15.5
25 360 600
26 500 500
12650/11980 (1290/1220)
12650/11980 (1290/1220)
5300/5390 (540/550)
21/24
21/24
14/21
2890
33 5160 1050
34 2010 2200
352/2 36 7.00-12-12PR (I) 37 6.00-9-10PR (I) 1650
960
965
1220
1035
1195
505
490/755
4085 41 110 125
150
160
85(Mast)
29
96
42 Hydraulic 43 Hand 45 48/845 -
46 1320 4710.7 48 12.2 4.2
54 Transistor inverter Transistor inverter
14.7 (2100)
-
S-FB20 — 8FB10-J35-25 —
40-8FB20
-
NOTE: * Computed values.
** 60 VDI circles/h with Tested Load of 2000 kg.
UNDERCLEARANCE
Mast (Full Load)------------------------------- 85
Center of Wheelbase (Full Load)---------- 110
Drive Axle (Full Load)------------------------ 125
Steer Axle (No Load)------------------------ 150
Counterweight (No Load)------------------- 160
Minimum Underclearance (Full Load)-- 85(Mast)
S-FB20 — 8FB10-J35-26 —
40-8FB20
V, FV Mast
Unit: kg (W)
30 33 35 37 40 45
00 00 00 00 00 00
50 20 20 20 20 20 19
0 00 00 00 00 00 00
60 18 18 18 18 18 17
0 10 10 10 10 10 20
70 16 16 16 16 16 15
0 50 50 50 50 50 70
80 15 15 15 15 15 14
0 20 20 20 20 20 40
90 14 14 14 14 14 13
0 10 10 10 10 10 40
10 13 13 13 13 13 12
00 10 10 10 10 10 50
11 12 12 12 12 12 11
00 30 30 30 30 30 70
12 11 11 11 11 11 10
00 50 50 50 50 50 90
13 10 10 10 10 10 10
00 90 90 90 90 90 30
A (mm) 5000 1650
<1800>
1490
<1630>
1360
<1490>
1250
<1370>
B (mm) 0 70 70 30 90 90 <145 <141
0> 0>
80 14 14 14 13 13 1180 910
0 50 50 10 70 70 <133 <130
0> 0>
90 13 13 13 12 12 1100 850
0 40 40 10 70 70 <124 <120
FSV Mast Unit: kg (W) 0> 0>
1160
<1270> 10 12 12 12 11 11 1020 790
1080 00 50 50 20 90 90 <115 <112
<1180> 0> 0>
1010
<1100> 11 11 11 11 11 11 960 740
950 00 70 70 40 10 10 <108 <105
<1040> 0> 0>
900
<980>
12 11 11 10 10 10 900 690
37 40 4 00 00 00 70 40 40 <102 <990
00 00 0 0> >
50 19 19 1 13 10 10 10 99 99 850 660
0 00 00 5 00 40 40 10 0 0 <960 <930
> >
60 17 17 1
0 20 20 7
70 15 15 1
mm 1230 1455
mm 960 1105
V FV
H P S E H P S E H P S
Lifting Full Load mm/s 360 270 270 245 330 250 250 245 330 250 250
ec
No Load mm/s 600 500 500 465 570 480 480 440 570 480 480
ec
Lowering Full Load mm/s 500 500 500 500 480 480 480 480 480 480 480
ec
No Load mm/s 500 500 500 500 420 420 420 420 450 450 450
ec
DIMENSIONS
S-FB20 — 8FB10-J35-27 —
40-8FB20
mm 445 445
Load Distance
(Centerline of front axle to front face of forks) 480 NOTE: H High power mode / P Power mode / S Standard mode / E Eco mode
MAST SPECIFICATIONS & RATED CAPACITIES (September 2016) Wide Visible Mast (V), Wide Visible Full-Free
Lift Two-Stage Mast (FV), Wide Visible Full-Free Lift Three-Stage Mast (FSV)
40-8FB20
Maximu Overall Height Free Lift Single tire
m
Fork
Lowered Extended Without With Tilt Range Load Tilt Range
Height
Load Stan Capacity at
Without With Backres dard FWD BWD 500 mm FWD BWD
Load Stan t Load LC
Backres dard Backres
t Load t
Backres
t
Dual tire
Load Capacity at 500 mm
LC
Mast
Type
kg
2000
2000
2000
2000
2000
2000
V 2000
1900
1800
2000
2000
2000
2000
FV 2000
1900
1900
1850
1800
1800
1750
FSV 1700
1500
8FB25
8FB25/8FBH25
8FBH25
MAIN VEHICLE SPECIFICATIONS (September 2016)
Manufacturer TOYOTA
Model 8FB25
Rear kg 2270
8 Wheelbase mm 1500
Rear mm 940
Counterweight % (tanθ) 49
Parking Hand
1 TOYOTA 2 8FBH25 3 2500 4 500 5 Battery 6 Rider Seated 7 Pneumatic 8 2x/2 9 3000 130
1070/120/40
1020/240
7/11
2290
1160
1975
4220
2105
2000
22 435 355
23 2430
1875
2414.0/14.0 16.0/16.0
25 340 600
26 500 500
11060/11530 (1120/1170)
11060/11530 (1120/1170)
4510/4810 (460/490)
17/21
17/21
12/20
2960
33 5800 820
34 1740 2380
352/2 36 21X8-9-14PR (I) 37 18X7-8-14PR (I) 1500
970
940
1220
1035
1135
280
435/700
4065 41 85 65
120
115
65(Mast)
25
49
42 Hydraulic 43 Hand 45 48/730 -
46 1160 4710.7 48 12.2 4.6
54 Transistor inverter Transistor inverter
14.7(2100)
S-FB25 — 8FB10-J35-29 —
8FB25/8FBH25
67
1.5
NOTE: * Computed values.
** 60 VDI circles/h with Tested Load of 2500 kg.
UNDERCLEARANCE
Mast (Full Load)------------------------------- 65
Center of Wheelbase (Full Load)---------- 85
Drive Axle (Full Load)------------------------ 65
Steer Axle (No Load)------------------------ 120
Counterweight (No Load)------------------- 115
Minimum Underclearance (Full Load)-- 65(Mast)
NOTE: [ ] for 8FBH25
S-FB25 — 8FB10-J35-30 —
8FB25/8FBH25
V, FV Mast
Unit: kg (W)
30 33 35 37 40 4500
00 00 00 00 00
50 25 25 25 25 25 2300
0 00 00 00 00 00 <245
0>
60 22 22 22 22 22 2070
0 50 50 50 50 50 <221
0>
70 20 20 20 20 20 1890
0 50 50 50 50 50 <201
0>
80 18 18 18 18 18 1730
0 90 90 90 90 90 <185
0>
90 17 17 17 17 17 1600
0 40 40 40 40 40 <171
0>
10 16 16 16 16 16 1490
00 20 20 20 20 20 <159
0>
11 15 15 15 15 15 1390
00 20 20 20 20 20 <149
0>
12 14 14 14 14 14 1310
00 20 20 20 20 20 <139
0>
13 13 13 13 13 13 1230
00 40 40 40 40 40 <131
0>
60 21 21 2080
0 70 70 <217
0>
70 19 19 1900
mm 1160 1220
mm 970 990
SPECIAL MAST (September 2016) Wide Visible Mast (V), Wide Visible Full-Free Lift Two-Stage Mast (FV), Wide Visible Full-Free Lift Three-Stage
Mast (FSV)
Model 8FB25/8FBH25
V FV
H P S E H P S E H P S
Lifting Full Load mm/s 340 260 260 220 320 240 240 220 320 240 240
ec
No Load mm/s 600 500 500 465 570 480 480 440 570 480 480
ec
Lowering Full Load mm/s 500 500 500 500 480 480 480 480 480 480 480
ec
No Load mm/s 500 500 500 500 420 420 420 420 450 450 450
ec
DIMENSIONS
S-FB25 — 8FB10-J35-31 —
8FB25/8FBH25
mm 435 435
Load Distance
(Centerline of front axle to front face of forks) 460 NOTE: H High power mode / P Power mode / S Standard mode / E Eco mode
MAST SPECIFICATIONS & RATED CAPACITIES (September 2016) Wide Visible Mast (V), Wide Visible Full-Free
Lift Two-Stage Mast (FV), Wide Visible Full-Free Lift Three-Stage Mast (FSV)
8FB25/8FBH25
Maximu Overall Height Free Lift Single tire
m
Fork
* Lowered Extended Without With Tilt Range Load Tilt Range
Height
Load Stan Capacity at
Without With Backres dard FWD BWD 500 mm FWD BWD
Load Stan t Load LC
Backres dard Backres
t Load t
Backres
t
Dual tire
23×9-10-16PR (I), plus 20 mm.
Load Capacity at 500 mm
Mast
LC
Type
kg
2500
2500
2500
2500
2500
V 2500
2500
2450
2350
2500
2500
2500
FV 2500
2500
2400
2400
2400
2300
2300
FSV 2200
2000
1550
NOTE: Height of standard load backrest is 920 mm. * with optional tire size ;
S-FB25 — 8FB10-J35-32 —
40-8FB25
40-8FB25
40-8FB25
Model
Load Capacity kg
Load Center mm
Power Type
Operator Position
0 Free Lift mm
6 Overall Width mm
Load Distance mm
(Centerline of front axle to front face of forks)
Rear Overhang mm
No Load mm/sec
No Load mm/sec
No Load Front kg
Rear kg
Size Front
Rear
8 Wheelbase mm
9 Tread Front mm
Rear mm
Backrest Height
Drawbar Height
Counterweight % (tanθ)
Parking
Load Handling kW
Load Handling
Sound level at the driver's ear according to EN12053 Uncertainty 4dB(A) dB(A)
1 TOYOTA 2 40-8FB25 3 2500 4 500 5 Battery 6 Rider Seated 7 Pneumatic 8 2x/2 9 3000 155
1070/120/40
1020/240
6/11
2435
1230
1995
4220
2160
2170
22 475 310
23 2640
1915
2414.5/14.5 15.5/15.5
25 340 600
26 500 500
12890/12010 (1310/1220)
12890/12010 (1310/1220)
5200/5300 (530/540)
20/24
20/24
13/20
3000
33 6020 800
34 2040 2280
352/2 36 7.00-12-12PR (I) 37 6.00-9-10PR (I) 1650
960
965
1220
1035
1195
505
490/755
4075 41 110 115
150
160
75(Mast)
29
96
42 Hydraulic 43 Hand 45 48/845 -
46 1320 4710.7 48 12.2 4.6
54 Transistor inverter Transistor inverter
14.7 (2100)
-
S-FB25 — 8FB10-J35-33 —
40-8FB25
-
NOTE: * Computed values.
** 60 VDI circles/h with Tested Load of 2500 kg.
UNDERCLEARANCE
Mast (Full Load)------------------------------- 75
Center of Wheelbase (Full Load)---------- 110
Drive Axle (Full Load)------------------------ 115
Steer Axle (No Load)------------------------ 150
Counterweight (No Load)------------------- 160
Minimum Underclearance (Full Load)-- 75(Mast)
S-FB25 — 8FB10-J35-34 —
40-8FB25
V, FV Mast
Unit: kg (W)
30 33 35 37 40 4500
00 00 00 00 00
50 25 25 25 25 25 2300
0 00 00 00 00 00 <245
0>
60 22 22 22 22 22 2080
0 60 60 60 60 60 <222
0>
70 20 20 20 20 20 1900
0 70 70 70 70 70 <203
0>
80 19 19 19 19 19 1750
0 10 10 10 10 10 <187
0>
90 17 17 17 17 17 1620
0 70 70 70 70 70 <173
0>
10 16 16 16 16 16 1510
00 50 50 50 50 50 <161
0>
11 15 15 15 15 15 1420
00 40 40 40 40 40 <151
0>
12 14 14 14 14 14 1330
00 50 50 50 50 50 <142
0>
13 13 13 13 13 13 1260
00 70 70 70 70 70 <134
0>
60 21 21 2080
0 70 70 <217
0>
70 19 19 1910
mm 1230 1455
mm 960 1105
SPECIAL MAST (September 2016) Wide Visible Mast (V), Wide Visible Full-Free Lift Two-Stage Mast (FV), Wide Visible Full-Free Lift Three-Stage
Mast (FSV)
Model 40-8FB25
V FV
H P S E H P S E H P S
Lifting Full Load mm/s 340 260 260 220 320 240 240 220 320 240 240
ec
No Load mm/s 600 500 500 465 570 480 480 440 570 480 480
ec
Lowering Full Load mm/s 500 500 500 500 480 480 480 480 480 480 480
ec
No Load mm/s 500 500 500 500 420 420 420 420 450 450 450
ec
DIMENSIONS
S-FB25 — 8FB10-J35-35 —
40-8FB25
mm 475 475
Load Distance
(Centerline of front axle to front face of forks) 490 NOTE: H High power mode / P Power mode / S Standard mode / E Eco mode
MAST SPECIFICATIONS & RATED CAPACITIES (September 2016) Wide Visible Mast (V), Wide Visible Full-Free
Lift Two-Stage Mast (FV), Wide Visible Full-Free Lift Three-Stage Mast (FSV)
40-8FB25
Maximu Overall Height Free Lift Single tire
m
Fork
Lowered Extended Without With Tilt Range Load Tilt Range
Height
Load Stan Capacity at
Without With Backres dard FWD BWD 500 mm FWD BWD
Load Stan t Load LC
Backres dard Backres
t Load t
Backres
t
Dual tire
Load Capacity at 500 mm
LC
Mast
Type
kg
2500
2500
2500
2500
2500
2500
V 2500
2450
2350
2500
2500
2500
2500
FV 2500
2400
2400
2400
2300
2300
2200
FSV 2000
1550
8FB30
Model
Load Capacity kg
Load Center mm
Power Type
Operator Position
0 Free Lift mm
6 Overall Width mm
Load Distance mm
(Centerline of front axle to front face of forks)
Rear Overhang mm
No Load mm/sec
No Load mm/sec
No Load Front kg
Rear kg
Size Front
Rear
8 Wheelbase mm
9 Tread Front mm
Rear mm
Backrest Height
Drawbar Height
Counterweight % (tanθ)
Parking
Load Handling kW
Load Handling
Sound level at the driver's ear according to EN12053 Uncertainty 4dB(A) dB (A)
1 TOYOTA 2 8FB30 3 3000 4 500 5 Battery 6 Rider Seated 7 Pneumatic 8 2x/2 9 3000 135
1070/120/44
1070/240
6/11
2490
1240
2020
4220
2195
2210
22 485 355
23 2695
2005
2414.0/14.0 15.0/15.0
25 320 550
26 500 500
13060/12630 (1330/1280)
13060/12630 (1330/1280)
5300/5590 (540/570)
17/22
17/22
11/19
3690
33 6880 830
34 2090 2620
352/2 36 28X9-15-14PR (I) 37 6.50-10-10PR (I) 1650
1010
965
1220
1035
1275
340
515/785
40115 41 140 155
180
185
115(Mast)
36
95
42 Hydraulic 43 Hand 45 80/370 80/470
46 1020 4711.9 48 14.4 5.0
54 Transistor inverter Transistor inverter
14.7 (2100)
69
S-FB30 — 8FB10-J35-37 —
8FB30
1.5
NOTE: * Computed values.
** 60 VDI circles/h with Tested Load of 3000 kg.
UNDERCLEARANCE
Mast (Full Load)------------------------------- 115
Center of Wheelbase (Full Load)---------- 140
Drive Axle (Full Load)------------------------ 155
Steer Axle (No Load)------------------------ 180
Counterweight (No Load)------------------- 185
Minimum Underclearance (Full Load)-- 115(Mast)
S-FB30 — 8FB10-J35-38 —
8FB30
V, FV Mast
Unit: kg (W)
30 33 35 37 40 4500
00 00 00 00 00
50 30 30 30 30 30 2850
0 00 00 00 00 00 <300
0>
60 27 27 27 27 27 2580
0 20 20 20 20 20 <272
0>
70 24 24 24 24 24 2360
0 90 90 90 90 90 <249
0>
80 22 22 22 22 22 2180
0 90 90 90 90 90 <229
0>
90 21 21 21 21 21 2020
0 30 30 30 30 30 <213
0>
10 19 19 19 19 19 1880
00 80 80 80 80 80 <198
0>
11 18 18 18 18 18 1770
00 60 60 60 60 60 <186
0>
12 17 17 17 17 17 1660
00 50 50 50 50 50 <175
0>
13 16 16 16 16 16 1570
00 50 50 50 50 50 <165
0>
60 27 27 27
0 20 20 20
70 24 24 24
mm 1240 1475
mm 1010 1105
SPECIAL MAST (September 2016) Wide Visible Mast (V), Wide Visible Full-Free Lift Two-Stage Mast (FV), Wide Visible Full-Free Lift Three-Stage
Mast (FSV)
Model 8FB30
V FV
H P S E H P S E H P S
Lifting Full Load mm/s 320 230 230 210 300 220 220 195 300 220 220
ec
No Load mm/s 550 410 410 355 500 380 380 325 500 380 380
ec
Lowering Full Load mm/s 500 500 500 500 460 460 460 460 460 460 460
ec
No Load mm/s 500 500 500 500 390 390 390 390 420 420 420
ec
DIMENSIONS
S-FB30 — 8FB10-J35-39 —
8FB30
mm 485 485
Load Distance
(Centerline of front axle to front face of forks) 495 NOTE: H High power mode / P Power mode / S Standard mode / E Eco mode
MAST SPECIFICATIONS & RATED CAPACITIES (September 2016) Wide Visible Mast (V), Wide Visible Full-Free
Lift Two-Stage Mast (FV), Wide Visible Full-Free Lift Three-Stage Mast (FSV)
8FB30
Maximu Overall Height Free Lift Single tire
m
Fork
Lowered Extended Without With Tilt Range Load Tilt Range
Height
Load Stan Capacity at
Without With Backres dard FWD BWD 500 mm FWD BWD
Load Stan t Load LC
Backres dard Backres
t Load t
Backres
t
Dual tire
Load Capacity at 500 mm
LC
Mast
Type
kg
3000
3000
3000
3000
3000
3000
V 3000
3000
3000
3000
3000
3000
3000
FV 3000
3000
3000
3000
2900
2650
2050
FSV 2650
2050
8FBJ35
Model
Load Capacity kg
Load Center mm
Power Type
Operator Position
0 Free Lift mm
6 Overall Width mm
Load Distance mm
(Centerline of front axle to front face of forks)
Rear Overhang mm
No Load mm/sec
No Load mm/sec
No Load Front kg
Rear kg
Size Front
Rear
8 Wheelbase mm
9 Tread Front mm
Rear mm
Backrest Height
Drawbar Height
Counterweight % (tanθ)
Parking
Load Handling kW
Load Handling
Sound level at the driver's ear according to EN12053 Uncertainty 4dB(A) dB (A)
1 TOYOTA 2 8FBJ35 3 3500 4 500 5 Battery 6 Rider Seated 7 Pneumatic 8 2x/2 9 3000 140
1070/140/50
1070/240
6/11
2575
1240
2110
4220
2195
2270
22 500 425
23 2770
2045
2413.0/13.0 15.0/15.0
25 270 460
26 500 450
12900/12550 (1310/1280)
12900/12550 (1310/1280)
5100/5490 (520/560)
14/20
14/20
9/17
4290
33 7840 970
34 2220 3090
352/2 36 28X9-15-14PR (I) 37 6.50-10-14PR (I) 1650
1010
965
1220
1035
1275
340
515/785
40115 41 140 155
180
185
115(Mast)
36
66
42 Hydraulic 43 Hand 45 80/370 80/470
46 1020 4711.9 48 14.4 5.5
54 Transistor inverter Transistor inverter
14.7(2100)
69
S-FB35 — 8FB10-J35-41 —
8FBJ35
1.5
NOTE: * Computed values.
** 60 VDI circles/h with Tested Load of 3500 kg.
UNDERCLEARANCE
Mast (Full Load)------------------------------- 115
Center of Wheelbase (Full Load)---------- 140
Drive Axle (Full Load)------------------------ 155
Steer Axle (No Load)------------------------ 180
Counterweight (No Load)------------------- 185
Minimum Underclearance (Full Load)-- 115(Mast)
S-FB35 — 8FB10-J35-42 —
8FBJ35
V, FV Mast
Unit: kg (W)
30 33 35 37 40 4500
00 00 00 00 00
50 35 35 35 35 35 3350
0 00 00 00 00 00 <350
0>
60 31 31 31 31 31 3040
0 80 80 80 80 80 <318
0>
70 29 29 29 29 29 2790
0 10 10 10 10 10 <291
0>
80 26 26 26 26 26 2570
0 90 90 90 90 90 <269
0>
90 24 24 24 24 24 2390
0 90 90 90 90 90 <249
0>
10 23 23 23 23 23 2230
00 30 30 30 30 30 <233
0>
11 21 21 21 21 21 2090
00 80 80 80 80 80 <218
0>
12 20 20 20 20 20 1960
00 50 50 50 50 50 <205
0>
13 19 19 19 19 19 1860
00 40 40 40 40 40 <194
0>
60 31 31 31
0 80 80 80
70 29 29 29
mm 1240 1525
mm 1010 1155
SPECIAL MAST (September 2016) Wide Visible Mast (V), Wide Visible Full-Free Lift Two-Stage Mast (FV), Wide Visible Full-Free Lift Three-Stage
Mast (FSV)
Model 8FBJ35
V FV
H P S E H P S E H P S
Lifting Full Load mm/s 270 190 190 180 270 195 195 180 270 195 195
ec
No Load mm/s 460 340 340 300 430 330 330 285 430 330 330
ec
Lowering Full Load mm/s 500 500 500 500 460 460 460 460 460 460 460
ec
No Load mm/s 450 450 450 450 390 390 390 390 420 420 420
ec
DIMENSIONS
S-FB35 — 8FB10-J35-43 —
8FBJ35
mm 500 500
Load Distance
(Centerline of front axle to front face of forks) 510 NOTE: H High power mode / P Power mode / S Standard mode / E Eco mode
MAST SPECIFICATIONS & RATED CAPACITIES (September 2016) Wide Visible Mast (V), Wide Visible Full-Free
Lift Two-Stage Mast (FV), Wide Visible Full-Free Lift Three-Stage Mast (FSV)
8FBJ35
Maximu Overall Height Free Lift Single tire
m
Fork
Lowered Extended Without With Tilt Range Load Tilt Range
Height
Load Stan Capacity at
Without With Backres dard FWD BWD 500 mm FWD BWD
Load Stan t Load LC
Backres dard Backres
t Load t
Backres
t
Dual tire
Load Capacity at 500 mm
LC
Mast
Type
kg
3500
3500
3500
3500
3500
3500
V 3500
3500
3400
3500
3500
3500
3500
FV 3500
3500
3500
3500
3400
3400
3300
FSV 2900
2200
10.14.15.18.20.25 8FB30,
8FBJ35
STANDARD EQUIPMENT (August 2016)
8FB10.14.15.18.20.25.30, 8FBJ35
● Drive AC motor ● Load Handling AC motor ● Wide Visible Mast (V) [MFH: 3000 mm] ● Backrest (Angled Lower Stay, V and FSV masts) ● Operator Presence Sensing
System (OPS) ● Easy-down system (V masts) ● Multi-function display (with Power Meter) ● Power select function ● Power keep function ● Hour meter ● Headlights ● ORS
seat ● Memory tilt steering column ● Emergency Power Shut-Down Button ● Dual-action parking brake ● Full hydraulic power steering ● Electric horn ● Floor mat ● Storage
area ● Assist grip ● Battery Connector Handle ● Overhead guard ● Overhead guard cap ● Drawbar pin ● Document clip
Code M
o
Item d
el
LOAD HANDLING
0 4 5 8 0 5 0
1 1 1 1 2 2 3
✳
) ) ) ) ) )
B
H H H H H H
( ( ( ( ( (
F
8
★ M20N ● ● ●
B B B B B B
F F F F F F
8 8 8 8 8 8
2) M29A ● ● ●
) ) )
- - -
0 0 0
✰★ M30A ● ● ●
✳
4 4 4
( ( (
3) ✰★ M40A ● ● ●
✳
5
3 4) ✰★ M33A ● ● ●
J
F 5) ★ M41B ● ● ●
8
w. Backrest ★ ★ M40N ● ● ●
6) ★ M67A ● ● ●
w. Backrest 1) ★
★ M82A ● ● ●
w/o Backrest ★
K11A ● ● ●
w. Backrest ★ N14A ● ● ●
●
Wide Visible Mast (V) ● Full-free Lift 2-stage Mast (FV) ● Full-free Lift 3-stage Mast (FSV) ● Fully Oil Charged Lift Cylinder ● Long Forks ●
w/o Fork Set ● Additional Forks ● Long Forkbar ● High Load Backrest (Angle Shape Type) ● High Load Backrest (Flat Steel Type) ● High Load
Backrest When Ordering FV Mast ● w/o Backrest ● Laser Marker
Fork Vibration Damper ● Tilt Cylinder Boots ● Mast Tilt Indicator ● BATTERY AND CONTROLLER
7) ✰★ D00C/ ● ● ● ● ● ● ●
D✳
★ D80B ● ● ● ● ● ● ●
★ D46A ● ● ● ● ● ● ●
8) ✰★ D03C/ ● ● ● ● ● ● ●
D
9) ★ D20A ● ● ● ● ● ● ●
★ D30A ● ● ● ● ● ● ●
★ D30B ● ● ● ● ● ● ●
10) ★ D42B ● ● ● ● ● ● ●
11) ★ D44B ● ● ● ● ● ● ●
★ D58A ● ● ● ● ● ● ●
D59B ● ● ● ● ● ● ●
★ D61B ● ● ● ● ● ● ●
★ D40A ● ● ● ● ● ● ●
Battery (Wet Cell) ● Battery Case ● Battery Hanger ● Local Battery ● Spare Battery (Wet Cell) ● Battery Brand (GS Yuasa) ● Battery Brand
●
(HITACHI) ● Battery Charger ● Battery Protecting Function ● Battery Fluid Top-up System with Reserver Tank ● Battery Code Adapter ● 12V
Power Supply ● Wire Harness For Accessories ● Battery Side-out
Single Overall Electrolyte Filler Ports ● LIGHT AND INDICATORS
E09D ● ● ● ● ● ● ●
J19A ● ● ● ● ● ● ●
J19E ● ● ● ● ● ● ●
J19S ● ● ● ● ● ● ●
J19U ● ● ● ● ● ● ●
J20B ● ● ● ● ● ● ●
J21D ● ● ● ● ● ● ●
J24L ● ● ● ● ● ● ●
J26A ● ● ● ● ● ● ●
J26C ● ● ● ● ● ● ●
J44C ● ● ● ● ● ● ●
J08B ● ● ● ● ● ● ●
Slope Sensing Auto-Power Mode Selector 14) ● Yellow Beacon On The Overhead Guard ★ ● Yellow Beacon On The Overhead Guard
(Key-on Position) ★ ● LED Yellow Beacon On The Overhead Guard ★ ● LED Yellow Beacon On The Overhead Guard (Key-on Position) ★ ●
Front Combination Lights ★ ● LED Rear Combination LIGHTS ★ ● LED Head Light & Front Combination Lights ★ ● LED Rear Working Light
★ ● LED Rear Working Light (Selective Lighting Condition) ★ ● LED Blue Light (Selective Lighting Condition) ★ ● License-plate Light and
Bracket ●
S-FB30 — 8FB10-J35-45 —
8FB10.14.15.18.20.25.30, 8FBJ35
Code M
o
d
el
0 4 5 8 0 5 0
1 1 1 1 2 2 3
) ) ) ) ) )
B
H H H H H H
F
( ( ( ( ( (
8
B B B B B B
F F F F F F
8 8 8 8 8 8
) ) )
- - -
0 0 0
4 4 4
( ( (
K03A ● ● ● ● ● ● ●
K21D ● ● ● ● ● ● ●
K21H ● ● ● ● ● ● ●
K22A ● ● ● ● ● ● ●
K21C ● ● ● ● ● ● ●
K21A ● ● ● ● ● ● ●
K36B ● ● ● ● ● ● ●
L26B ● ● ● ● ● ● ●
L38B ● ● ● ● ● ● ●
L39B ● ● ● ● ● ● ●
L39C ● ● ● ● ● ● ●
L39D ● ● ● ● ● ● ●
Item
5
3
Headlight Guards 15) ★ ● Back-up Buzzer ★ ● Adjustable-volume Back-up Buzzer ★ ● Forward Chime ★ ● Back-up Chime ★ ● Forward &
Back-up Chime ★ ● Seat Belt Interlock System ★ ● Deluxe Multifunction Display 16) ● PIN Code Entry System ★ ● Shock Sensor ★ ● CAN
System for Telematics ★ ● Telematics ★ ● BODY
E11B ● ● ● ● ● ● ●
G40E ● ● ● ● ● ● ●
G43C ● ● ● ● ● ● ●
H01N ● ● ● ● ● ● ●
H02B ● ● ● ● ● ● ●
H02D ● ● ● ● ● ● ●
J10B ● ● ● ● ● ● ●
J10J ● ● ● ● ● ● ●
L37A ● ● ● ● ● ● ●
P10A ● ● ● ● ●
Q15A ● ● ● ● ● ● ●
Q15B ● ● ● ● ● ● ●
Q15D ● ● ● ● ● ● ●
R30A ● ● ● ● ● ● ●
R30B ● ● ● ● ● ● ●
R30C ● ● ● ● ● ● ●
R30D ● ● ● ● ● ● ●
R40A ● ● ● ● ● ● ●
S00B ● ● ● ● ● ● ●
S00C ● ● ● ● ● ● ●
S02A ● ● ● ● ● ● ●
S20C ● ● ● ● ● ● ●
S28A ● ● ● ● ● ● ●
S31✳ ● ● ● ● ● ● ●
S35A ● ● ● ● ● ● ●
Right Hand Shift Lever 17) ★ ● Suspension Seat w/ Damper ★ ● Orange Seat Belt ★ ● w/o Overhead Guard Caps ★ ● Canvas Cabin w/
Wiper ★ ● Front Windshield w/Wiper and Washer ★ ● Rear-view Mirror, Right and Left Sides ★ ● Panoramic Mirror ★ ● Rear-pillar Assist
Grip ★ ● Sleeved Forks ★ ● Clamp Release Interlock 3rd Lever 41) ★ ● Clamp Release Interlock 4th Lever 42) ★ ● Clamp Release Interlock
3rd/4th Lever 43) ★ ● Body & Forks In One Color (Mast, B/R & ATT In STD Color) 18) ● Body & Forks In Two Color (Mast, B/R & ATT In STD
Color) 18) ● Body & Forks In Three Color (Mast, B/R & ATT In STD Color) 18) ● Body & Forks In Four Color (Mast, B/R & ATT In STD Color)
18) ● Mast, B/R & ATT In Specified Color 19) ● Tool, Standard Set (A Set) ★ ● Tool, Standard Set (B Set) ★ ● TOYOTA Symbol Mark ●
Certificated Label ● SAS Equipped Decal 20) ● Name Plate 21) ★ ● OPS Decal ★ ● CHASSIS
E32A ● ● ● ● ● ● ●
K14A ● ● ● ● ● ● ●
Dual Brake Pedal ● Power Steering Cylinder Boots ★ ● WHEELS AND TIRES
● ● ● ● ● ● ●
● ● ● ● ● ● ●
A10R ● ● ● ● ● ● ●
A20T ● ●
A10A ● ● ● ● ●
A13A ● ● ● ● ●
A19A ● ● ● ● ●
A41A ● ● ● ● ● ● ●
B30E ● ● ● ● ● ● ●
B30F ● ● ● ● ● ● ●
B30G ● ● ● ● ● ● ●
B30H ● ● ● ● ● ● ●
D29A ● ● ● ● ● ● ●
H35A ● ● ● ● ● ●
A95B ● ● ● ● ● ● ●
R00V ● ● ● ● ● ● ●
R05B ● ● ● ● ● ● ●
R05C ● ● ● ● ● ● ●
R08A ● ● ● ● ● ● ●
R50A ● ● ● ● ● ● ●
R51A ● ● ● ● ● ● ●
China Certification Spec. 22) ★ ● Australian Spec. 23) ★ ● EEC Spec. 24) ★ ● E Mark (for EC) 24)25) ★ ● Europe Spec 24)44) ★ ● System
of Active Stability ● Cold-storage Model (Type 45S) 26) ★ ● Rust-proof Model (Fisherman Special) 26) ★ ● Cold-storage Model (Fisherman
Special) 26) ★ ● Rust-proof Model ★ ● Key-less Ignition Switch 27) ● Low Height Headguard (2200) 12) ★
Unit Indication, mm/kg 28) ● Body Color (501 Beige) ★ ● Urethane Resin Paint 29) ● Lacquer Paint 29) ● Wheel in Specified Color ● Mast
Rust-proof Painting ● Backrest Rust-proof Painting ● PACKING
S52B ● ● ● ● ● ● ●
S52G ● ● ● ● ● ● ●
S52H ● ● ● ● ● ● ●
T00B ● ● ● ● ● ● ●
T01A ● ● ● ● ● ● ●
Parts Catalog(General)2set ● Parts Catalog(Specified User)1set ● Parts Catalog(Specified User)2set ● Export Packing(Standard) ● Export
Packing(Wooden Box) ●
S-FB30 — 8FB10-J35-46 —
8FB10.14.15.18.20.25.30, 8FBJ35
Code M
o
d
el
0 4 5 8 0 5 0
1 1 1 1 2 2 3
) ) ) ) ) )
B
H H H H H H
F
( ( ( ( ( (
8
B B B B B B
F F F F F F
8 8 8 8 8 8
) ) )
- - -
0 0 0
4 4 4
( ( (
T03N ● ● ● ● ● ● ●
T06A ● ● ● ● ● ● ●
T07A ● ● ● ● ● ● ●
T10A ● ● ● ● ● ● ●
T11B ● ● ● ● ● ● ●
T11C ● ● ● ● ● ● ●
T11E ● ● ● ● ● ● ●
T13B ● ● ● ● ● ● ●
T18A ● ● ● ● ● ● ●
T30A ● ● ● ● ● ● ●
T44N ● ● ● ● ● ● ●
T45B ● ● ● ● ● ● ●
T45M ● ● ● ● ● ● ●
T45O ● ● ● ● ● ● ●
T49N ● ● ● ● ● ● ●
T90A ● ● ● ● ● ● ●
T91A ● ● ● ● ● ● ●
T92A ● ● ● ● ● ● ●
T92B ● ● ● ● ● ● ●
T93A ● ● ● ● ● ● ●
Item
5
W/o Fork Packing For Container ● Spare Battery Case Packing(Crate) 30) ● Charger Packing(Crate) 31) ● Attachment Packing(Pallet) ● Mast
Packing(Wooden Case) 32) ● Mast Packing(w/o Case) 32) ● Mast Packing(Pallet) 32) ● Collective Water-Supply Tank Packing ● Attachment
Packing(On truck) ● TOYOTA Mark & Plate Packing ● w/o Touch-Up Paint ● Operator's Manual 2set ● Operator's Manual(Special)1set ●
Operator's Manual(Special)2set ● W/o Washer Fluid 33) ● Original Forks Packing(Separate) ● Additional Forks Packing(Separate) ● Sleeved
Forks Packing(Separate) 34)35) ● Sleeved Forks Packing(On truck) 34) ● Backrest Packing(Separate) 36) ●
NOTE:
15) Must enter together with J20B
1) Must specify M41B or M45A when backrest is required.
16) Must specify A41A.
2) Length of the forks can be selected from the size range set for [M20A].
17) Only available when A41A is required.
3) Must enter together with M41B or M45A when FV Mast is required. 4)
18) Must specify R05B or R05C.
For NZ model, must be specified.
19) Must specify both R30A/B/C/D and R05B/C.
5) Available only FV Mast.
20) Must specify A41A.
6) Must specify A41A.
21)
Not available on models with "40-8FB20/25. 8FB30/J35". Must specify S31✳.
7) Not necessary to specify when selecting local battery. ( English[S31A],Spanish[S31B],Chinese[S31C],French[S31E],
8) Must enter together with D80B. Russian[S31F], Taiwanese[S31G] and Portuguese[S31K])
9) Only available with the same capacity, brand and spec of the battery. 22) Not available on models "8FBH10/14/15/18/20/25, 40-8FB15/20/25".
10) Must specify D00C or D00D. 23) Available on models with "8FB18/25/J35".
11) Must specify D40A. Must specify A41A and either G40E or H35A.
12) Available on models with “8FB10/14/15/18/20/25". 24) Not available on models with "8FB(H)10/14, 40-8FB15/20/25".
13) Must specify either "D00C0485/0600, D03C0485/0600" or D80B. 25) For EC model , must be specified.
14) Must specify A41A. 26) Not available on models with "40-8FB15/20/25".
27) Must specify L38B or L39D. 38) Must enter inspection code.
28) All models must be specified. 39) Must enter required numbers of the sheet.
29) Must specify R30A/B/C/D. 40) For Malaysia model, must be specified.
30) Must enter flag "B". 41) Must specify either A410/A411 or Load Stabilizer[L1]. 42)
31) Must enter flag "C". Must specify either A450/A451 or Full Rotating Paper Roll
32) Must enter flag "M". Clamp[U61C671/681].
33) Must specify H02B/D. 43) Must specify either A420/A421 or Bale Clamp[C242].
The countries which are applied methanol control must be 44) Must specify A10A and A41A.
specified. 34) Must specify P10A.
35) Must enter flag "S". ★ Please see the “Matching Options”.
36) Must enter flag "X". ✰ Please see the chart below for the item.
37) Must enter together TSDR-No.
S-FB30 — 8FB10-J35-47 —
8FB10.14.15.18.20.25.30, 8FBJ35
FULLY OIL CHARGED LIFT CYLINDER (August 2016) Model Mast Type
8FB/8FBH10.14
15.18.20.25 F
40-8FB15.20.25
8FB30, 8FBJ35 F
●❍●
INDEX:
❍ Standard / ● Available, *Equipped automatically when B30E/F/G/H is selected.
8FB10.14.15.18 ● ●
Wide Visible
Full-Free Lift Three-Stage Mast
(FSV)
8FBH10.14.15.18 ●
40-8FB15 ●
8FB/8FBH20 ●
40-8FB20 ●
8F/8FBH25 ●
40-8FB25 ●
8FB30 ●
8FBJ35 ●
NOTE:
● Mast may be interchanged with models within the same group.
MAST WEIGHT (August 2016)
Maximum Model
Fork
Height
8FB/8FBH 8FB/8FBH2 40-8FB20 40-8FB25 8FB30
10.14.15.18 0.25
40-8FB15
mm kg kg kg kg kg
Mast Type8FBJ35
kg
640
655
680
715
V
CAUTION:
The figures are without load backrest and forks.
The figures presented in this chart have been rounded off to the nearest
number. Use caution when applying them to specific products.
FV
730 750 830 900 940 730 765 780 805 860 890 920 955 970 985 1070
1125 1200
FSV
S-FB30 — 8FB10-J35-48 —
8FB10.14.15.18.20.25.30, 8FBJ35
Maximum FW B FW B FW B FW B FW B FW B FW B FW B FW B FW
Fork D W D W D W D W D W D W D W D W D W D
Height D D D D D D D D D
mm de de de de de de de de de de de de de de de de de de de
g g g g g g g g g g g g g g g g g g g
2500 7 5 6 6 7 5 6 6 7 5 6 6 7 5 7 5 6 6 6
2700 7 5 6 6 7 5 6 6 7 5 6 6 7 5 7 5 6 6 6
3000 7 9 6 10 7 9 6 10 7 9 6 10 7 9 7 9 6 10 6
3300 7 9 6 10 7 9 6 10 7 9 6 10 7 9 7 9 6 10 6
3500 7 9 6 10 7 9 6 10 7 9 6 10 7 9 7 9 6 10 6
3700 7 9 6 10 7 9 6 10 7 9 6 10 7 9 7 9 6 10 6
4000 7 9 6 10 7 9 6 10 7 5 6 6 7 9 7 9 6 10 6
4500 7 5 6 6 7 5 6 6 7 5 6 6 7 5 7 5 6 6 6
5000 7 5 6 6 7 5 6 6 7 5 6 6 7 5 7 5 6 6 6
Maximum FW B FW B FW B FW B FW B FW B
Fork D W D W D W D W D W D W
Height D D D D D D
mm de de de de de de de de de de de de
g g g g g g g g g g g g
2500 7 5 6 6 7 5 6 6 6 6 6 5
2700 7 5 6 6 7 5 6 6 6 6 6 5
3000 7 9 6 10 7 9 6 9 6 9 6 9
3300 7 9 6 10 7 9 6 9 6 9 6 9
3500 7 9 6 10 7 9 6 9 6 9 6 9
3700 7 9 6 10 7 9 6 9 6 9 6 9
4000 7 5 6 6 7 9 6 6 6 9 6 9
4500 7 5 6 6 7 5 6 6 6 6 6 5
5000 7 5 6 6 7 5 6 6 6 6 6 5
40-8FB20
All
Mast FV
Type
V BWD
FV
deg
6
6
9
9
9
9
Mast 9
Type 6
6
mm de de de de de de de de de de de de de de de de de de de
g g g g g g g g g g g g g g g g g g g
2500 7 5 6 6 7 5 6 6 7 5 6 6 7 5 7 5 6 6 6
2700 7 5 6 6 7 5 6 6 7 5 6 6 7 5 7 5 6 6 6
3000 7 7 6 8 7 7 6 8 7 7 6 8 7 7 7 7 6 8 6
3300 7 7 6 8 7 7 6 8 7 7 6 8 7 7 7 7 6 8 6
3500 7 7 6 8 7 7 6 8 7 7 6 8 7 7 7 7 6 8 6
3700 7 7 6 8 7 7 6 8 7 7 6 8 7 7 7 7 6 8 6
4000 7 7 6 8 7 7 6 8 7 5 6 6 7 7 7 7 6 8 6
4500 7 5 6 6 7 5 6 6 7 5 6 6 7 5 7 5 6 6 6
5000 7 5 6 6 7 5 6 6 7 5 6 6 7 5 7 5 6 6 6
Maximum FW B FW B FW B FW B FW B FW B
Fork D W D W D W D W D W D W
Height D D D D D D
mm de de de de de de de de de de de de
g g g g g g g g g g g g
2500 7 5 6 6 7 5 6 6 6 6 6 5
2700 7 5 6 6 7 5 6 6 6 6 6 5
3000 7 7 6 8 7 7 6 9 6 9 6 9
3300 7 7 6 8 7 7 6 9 6 9 6 9
3500 7 7 6 8 7 7 6 9 6 9 6 9
3700 7 7 6 8 7 7 6 9 6 9 6 9
4000 7 5 6 6 7 7 6 6 6 9 6 9
4500 7 5 6 6 7 5 6 6 6 6 6 5
5000 7 5 6 6 7 5 6 6 6 6 6 5
40-8FB20
All
Mast Type
Mast Type
V
deg
6
6
9
9
9
V 9
9
All
6
6
BWD
S-FB30 — 8FB10-J35-49 —
8FB10.14.15.18.20.25.30, 8FBJ35
Maximum FW B FW B FW B FW B FW B FW B FW B FW B FW B FW
Fork D W D W D W D W D W D W D W D W D W D
Height D D D D D D D D D
mm de de de de de de de de de de de de de de de de de de de
g g g g g g g g g g g g g g g g g g g
3000 7 5 6 6 7 5 6 6 7 5 6 6 7 5 7 5 6 6 6
3300 7 5 6 6 7 5 6 6 7 5 6 6 7 5 7 5 6 6 6
3500 7 5 6 6 7 5 6 6 7 5 6 6 7 5 7 5 6 6 6
3700 7 5 6 6 7 5 6 6 7 5 6 6 7 5 7 5 6 6 6
4000 7 5 6 6 7 5 6 6 7 5 6 6 7 5 7 5 6 6 6
Maximum FW B FW B FW B FW B FW B FW B
Fork D W D W D W D W D W D W
Height D D D D D D
mm de de de de de de de de de de de de
g g g g g g g g g g g g
3000 7 5 6 6 7 5 6 6 6 6 6 5
3300 7 5 6 6 7 5 6 6 6 6 6 5
3500 7 5 6 6 7 5 6 6 6 6 6 5
3700 7 5 6 6 7 5 6 6 6 6 6 5
4000 7 5 6 6 7 5 6 6 6 6 6 5
40-8FB20
All
Mast Type All
BWD
deg
6
FV 6
6
6
6
Mast Type
FV
S-FB30 — 8FB10-J35-50 —
8FB10.14.15.18.20.25.30, 8FBJ35
770 100 30
850
920
1070
1220 35
850 100 35
920
1070
1220
920 100 35
1070
1220
1370
1520
920 120 36
1070
1220
1370
1520
920 120 40
1070
1220
1370
1520
1670
1820
1070 120 44
1220
1370
1520
1670
1820
1970
920 140 50
1070
1220
1370
1520
1670
Model Availability
●
●
8FB10
●
8FBH10
❍
●
●
●
8FB14
8FBH14
❍
●
●
❍
8FB15.18
8FBH15.18
●
40-8FB15
●
●
●
❍
8FB20
8FBH20
●
40-8FB20
●
●
●
❍
●
8FB25
8FBH25
●
40-8FB25
●
●
●
❍
●
●
8FB30
●
●
●
●
●
❍
●
8FBJ35
●
●
●
INDEX:
❍ Standard / ● Available
S-FB30 — 8FB10-J35-51 —
8FB10.14.15.18.20.25.30, 8FBJ35
Unit: mm
920 ● ● ● ●
1070 ● ● ● ●
1220 ❍ ● ● ●
1370 ●
1520 ●
1670 ●
1820 ●
920 ● ● ●
1070 ● ● ●
1220 ❍ ● ●
1370 ●
1520 ●
1670 ●
1820 ●
920 ● ● ●
1070 ● ● ●
1220 ❍ ● ●
1370 ●
1520 ●
1670 ●
1820 ●
●
●
●
8FB20.25
8FBH20.25
40-8FB20.25
●
●
●
8FB30
8FBJ35
INDEX:
❍ Standard / ● Available
NOTE: *Dimentions are 60mm shorter when High Load Backrest (Flat Steel Type) [M33A] is selected.
Code
D00D D03D 80
(Wet Cell)
D00C
D00C
Availability
D00C ●
D00C
●
●
● ●
8FB15.18 ● 8FBH10.14.15.18 ● 40-8FB15 ● ●
8FB20
●●
●
8FB25 ● 8FBH20.25 ● 40-8FB20.25 ●
●
8FB30
8FBJ35
●
INDEX:
● Available
8FB10.14.15.18 ● 8FB20.25 ●
INDEX:
● Available
S-FB30 — 8FB10-J35-52 —
8FB10.14.15.18.20.25.30, 8FBJ35
600 400 20
●
80 ●
INDEX:
● Available / ▲Only available for 40-8FB15
NOTE: 1. The indicated input voltage means the available range of three-phase AC input voltages applied to the battery charger: 200V denotes the range of 200 to 230V
and 400V the range of 340 to 460V, respectively.
2. In AC power sources where there is appreciable variance between the rated and the measured line voltage values, be sure to measure actual input voltage to a
battery charger and then order it with correct power requirements for operation. Usually re-charging is done at night when incoming voltage is relatively high
without line voltage drops, and it is a good practice, therefore, to measure the line voltage at night.
80 ●
INDEX:
● Available
NOTE: The indicated input voltage means the available range of three-phase AC input voltages applied to the battery charger: 200V denotes the range of 200 to 230V.
S-FB30 — 8FB10-J35-53 —
8FB10.14.15.18.20.25.30, 8FBJ35
8x3.00 TB (Side-Ring) ● ●
8x3.00 TB (Side-Ring) ● ●
8x4.33R TB (Side-Ring) ●
9x4.00E TB (Side-Ring) ● ●
10x5.00F TB (Side-Ring) ● ● ●
●
●
8FB10.14
●
8FBH10.14
●
●
●
8FB15
8FBH15
●
8FB18
●
8FBH18
●
40-8FB15
8FB20
8FBH20
●
8FB25
8FBH25
40-8FB20.25
●
●
8FB30
●
●
●
8FBJ35
●
INDEX:
❍ Standard / ● Available
S-FB30 — 8FB10-J35-54 —
8FB10.14.15.18.20.25.30, 8FBJ35
8x3.00D TB (Side-Ring) ● ● ● ●
8x3.00D TB (Side-Ring) ● ● ● ●
8x4.33R TB (Side-Ring) ● ● ● ●
9x4.00E TB (Side-Ring) ●
10x5.00F TB (Side-Ring) ● ● ●
●
●
8FB10.14
8FBH10.14
8FBJ35
INDEX:
● Available
8FB15 ●
8FBH15
●●●
●
8FB18
8FBH18
●●
40-8FB15
8FB20
8FBH20 ●●
8FB25
8FBH25
40-8FB20.25
●●●
8FB30 ●●●
S-FB30 — 8FB10-J35-55 —
8FB10.14.15.18.20.25.30, 8FBJ35
MATCHING OPTIONS (August 2016) (Column figures refer to matching with to the items listed at left)
Item
EEC Spec.
China Certification Spec.
E Mark (for EC)
Europe Spec.
Australian Spec.
Cold-storage Model (Type 45S)
Rust-proof Model (Fisherman Special) Cold-storage Model (Fisherman Special) Rust-proof Model
Battery Charger (On-truck Type)
Battery Charger 200V/3P (Off-truck Type) Battery Charger 400V/3P (Off-truck Type) Battery 48V(Wet Cell)
Battery 80V (Wet Cell)
Local Battery 48V
Local Battery 80V
Spare Battery (Wet Cell)
Battery Brand (GS Yuasa)
Battery Brand (HITACHI)
Single Overall Electrolyte Filler Ports
Battery Protecting Function
Battery Fluid Top-up System with Reserver Tank Battery Hanger
Battery Code Adapter
Wire Harness For Accessories
Battery Case
Right Hand Shift Lever
Battery Side-out
Suspension Seat w/ Damper
Orange Seat Belt
w/o Overhead Guard Caps
Canvas Cabin w/ Wiper
Front Windshield w/Wiper and Washer Low Height Headguard (2200)
Rear-view Mirror, Right and Left Sides Panoramic Mirror
Code 1 2 1 1 1 1 1 1 1 1 1 1 2 2 2 2 2 2
0 1 2 3 4 5 6 7 8 9 0 1 2 3 4 5
A10A 1
A10R 2 X
A13A 3 X
A19A 4 X
A20T 5 X
B30E 6
B30F 7 X X
B30G 8 X X
X
B30H 9 1 1 1
C30E 1 X X
0 X
X
C30L 1 X X
1
C30 1 X X
M 2
D00C 1
3
X
D00D 1 X
4
X
D03C 1 X X
5 X
D03D 1 X X
6 X
X
D20A 1 X
7 X
X
D30A 1 X
8 X
X
D30B 1 X X
9 X
X
D40A 2 X X
0 X X
X X X
D42B 2 X X
1 X
D44B 2 X X
2
D46A 2
3
D58A 2
4
X
D61B 2
5
D80B 2 X X X
6 X X
X
E11B 2 X
7 X
X X
G25B 2 X X
8 X
X
G40E 2 X
9
X
G43C 3 X
0
X
H01N 3
1
H02B 3 X X
2
X
H02D 3
3
H35A 3
4
X
J10B 3
5
J10J 3
6
J19A 3 1
7 0
J19E 3 1
8 0
J19S 3 1
9 0
J19U 4 1
0 0
J20B 4
1
J21D 4 X
2
J24L 4
3
J26A 4 1
4 0
J26C 4 1
5 0
J44C 4 1
6 0
K03A 4
7
K11A 4 3
8
K14A 4 3
9
K21A 5
0
K21C 5
1
K21D 5
2
K21H 5 X X
3 X
X
K22A 5
4
K36B 5 X
5 4
X
L37A 5 2
6
L38B 5
7
L39B 5
8
L39C 5 X X
9
L39D 6 X X
0
M00B 6
1
M00 6
D 2
M00F 6
3
1
1
2
S-FB30 — 8FB10-J35-56 —
8FB10.14.15.18.20.25.30, 8FBJ35
Code 1 2 1 1 1 1 1 1 1 1 1 1 2 2 2 2 2 2 2 2 2 2 3 3 3 3 3 3 3 3 3
0 1 2 3 4 5 6 7 8 9 0 1 2 3 4 5 6 7 8 9 0 1 2 3 4 5 6 7 8
M09A 6 3 3 3 3
4
M20A 6
5
M20 6
N 6
M30A 6
7
M33A 6 1 3 3 3 3
8 1
M40A 6
9
M40 7
N 0
M41B 7
1
M67A 7 X X
2 X
X
M82A 7
3
N14A 7
4
P10A 7
5
D601 7 X
6
D602 7 X
7
D604 7 X
8
D605 7 X
9
D612 8 X
0
D613 8 X
1
D627 8 X
2
D628 8 X
3
D629 8 X
4
D630 8 X
5
C006 8 X
6
X
D096 8 X
7
D104 8 X
8 X
X X
X
X
D217 8 X
9 X
X X
X
X
D219 9 X
0 X
X X
X
X
D220 9 X X
1 X
X
X
X
D221 9 X
2 X
X X
X
X
D271 9 X
3 X
X X
X
X
D272 9 X
4 X
X X
X
X
D280 9 X
5 X
X X
X
X
D360 9 X
6 X
X X
X
X
D773 9 X
7 X
X X
X
X
Q15A 9
8
Q15B 9
9
Q15D 1
0
0
R00V 1 X
0 X
1
S00B 1
0
2
S00C 1
0
3
S28A 1 X
0 X
4
S31A 1
0
5
S31B 10 X X
6
X
S31C 10 X X
7
X
S31E 10 X X
8
X
S31F 10 X X
9
X
S31G 11 X X
0
X
S31K 11 X X
1
X
S35A 1 X
1 X
2
1
Item
1
2
Fully Oil Charged Lift Cylinder
Long Forks
w/o Fork Set
Long Forkbar
S-FB30 — 8FB10-J35-57 —
8FB10.14.15.18.20.25.30, 8FBJ35
SPECIFICATIONS OF BATTERY AND BATTERY CASE (August 2016) The “minimum weight of battery with
case” indicated in the table is the lightest weight of the battery required to satisfy stability requirements of the vehicle.
V 48 48 48
pcs 24 24 24
Weight of Filled Cell Approx. 20.0 24.0 27.5 30.5 20.0 24.0 27.5
kg
Quantity of Electrolyte Approx. 5.5 4.8 5.1 4.8 5.5 4.8 5.1
liter
Case kg 90 90 90 105 90 90 90
Specifications (HITACHI)
8FB10 8FBH10 8FB14
V 48 48 48
pcs 24 24 24
Weight of Filled Cell Approx. 22.2 24.0 26.0 31.9 22.2 24.0 26.0
kg
Quantity of Electrolyte Approx. 5.5 5.2 5.1 5.9 5.5 5.2 5.1
liter
Case kg 90 90 90 105 90 90 90
Model 8FB10.14
kg
kg
mm
mm
mm
Width 821
Length 747
Height 460 [540]
NOTE: [ ] for Battery Side-out [G25B].
8FBH10.14
kg
kg
S-FB30 — 8FB10-J35-59 —
8FB10.14.15.18.20.25.30, 8FBJ35
mm
mm
mm
SPECIFICATIONS OF BATTERY AND BATTERY CASE (August 2016) The “minimum weight of battery with
case” indicated in the table is the lightest weight of the battery required to satisfy stability requirements of the vehicle.
V 48 48 48
pcs 24 24 24
Case kg 90 90 105 90 90
Specifications (HITACHI)
8FB15 8FBH15 8FB18
V 48 48 48
pcs 24 24 24
Case kg 90 90 105 90 90
S-FB30 — 8FB10-J35-61 —
8FB10.14.15.18.20.25.30, 8FBJ35
kg
kg
mm
mm
mm
Width 821
Length 747
Height 460 [540]
NOTE: [ ] for Battery Side-out [G25B].
8FBH15.18
kg
kg
S-FB30 — 8FB10-J35-62 —
8FB10.14.15.18.20.25.30, 8FBJ35
mm
mm
mm
SPECIFICATIONS OF BATTERY AND BATTERY CASE (August 2016) The “minimum weight of battery with
case” indicated in the table is the lightest weight of the battery required to satisfy stability requirements of the vehicle.
V 48 48 48
pcs 24 24 24
Weight of Filled Cell Approx. 26.5 32.0 33.5 42.0 32.0 33.5
kg
Specifications (HITACHI)
8FB20 8FBH20 8FB25
V 48 48 48
pcs 24 24 24
Weight of Filled Cell Approx. 26.9 30.5 32.2 39.5 30.5 32.2
kg
S-FB30 — 8FB10-J35-64 —
8FB10.14.15.18.20.25.30, 8FBJ35
kg 730
kg 965
Model 8FB25
Minimum Battery Weight (with Case) 820
Maximum Battery Weight (with Case) 965
mm
mm
mm
Width 911
Length 822
Height 460 [540]
NOTE: [ ] for Battery Side-out [G25B].
8FBH20.25
kg
kg
S-FB30 — 8FB10-J35-65 —
8FB10.14.15.18.20.25.30, 8FBJ35
mm
mm
SPECIFICATIONS OF BATTERY AND BATTERY CASE (August 2016) The “minimum weight of battery with
case” indicated in the table is the lightest weight of the battery required to satisfy stability requirements of the vehicle.
kg 2465 2890
SB350 SB350
mm 350 350
V 48 48
pcs 24 24
Model 40-8FB25
Vehicle Weight without Battery 3000
1155
Battery Connector Type SB350
Minimum Connector Length * 350
Truck Voltage 48
Number of Cells 24
Ampere-Hour Capacity 845/5
550
519
186 158 48.0 8.4
Specs. of Cell
Specifications (HITACHI)
40-8FB15 40-8FB2
0
kg 2465 2890
SB350 SB350
mm 350 350
V 48 48
pcs 24 24
S-FB30 — 8FB10-J35-67 —
8FB10.14.15.18.20.25.30, 8FBJ35
kg
kg
mm
mm
mm
Width 911
Length 822
Height 540
40-8FB20.25
BATTERY CAPACITY : 845AH/5HR, 48V
Model 40-8FB20.25
kg
kg
S-FB30 — 8FB10-J35-68 —
8FB10.14.15.18.20.25.30, 8FBJ35
mm
mm
mm
kg
kg
mm
mm
mm
Width 821
Length 747
Height 540
8FB20.25
kg
mm
mm
mm
Width 911
Length 822
Height 540
S-FB30 — 8FB10-J35-70 —
8FB10.14.15.18.20.25.30, 8FBJ35
SPECIFICATIONS OF BATTERY AND BATTERY CASE (August 2016) The “minimum weight of battery with
case” indicated in the table is the lightest weight of the battery required to satisfy stability requirements of the vehicle.
kg 3690
ht of Battery kg 920
SBX350
mm 350
V 80
pcs 40
Length mm 90 109 90
Model 8FBJ35
Vehicle Weight without Battery 4290
920
Battery Connector Type SBX350
Minimum Connector Length * 350
Truck Voltage 80
Number of Cells 40
Ampere-Hour Capacity 470/5
550
519
109 158 27.5 5.0
Specs. of Cell
Specifications (HITACHI)
8FB30
kg 3690
ht of Battery kg 920
SBX350
mm 350
V 80
pcs 40
Length mm 90 109 90
kg
kg
mm
mm
mm
Width 954
Length 822
Height 570
S-FB30 — 8FB10-J35-72 —