Professional Documents
Culture Documents
SOFTWARE MANUAL
-1-
Application Software Manual
INDEX:
1. SYSTEM REQUIREMENTS ………………………………………………………………………….. 3
3. INSTALLATION …………………………………………………………………………. 10
4. TROUBLESHOOTING …………………………………………………………………………... 15
-2-
Application Software Manual
1. SYSTEM REQUIREMENTS:
-3-
Application Software Manual
2. SOFTWARE SCREENS
• MAIN WINDOW
-4-
Application Software Manual
[NOTE : To enter in the HEALTH mode user has to select proper HEALTH MODE from
CRT UNIT By pressing “W” Key]
• This is the main screen for INJECTOR HEALTH MODE while ON condition
in software.
• This window shows warning of the Injector Health parameters if User enters
into another health mode then following window appears. This is the main
screen warning for INJECTORHEALTH MODE in Application software.
-5-
Application Software Manual
• This is the main screen for PUMP HEALTH MODE in Application software.
[NOTE : To enter in the HEALTH mode user has to select proper HEALTH MODE from
CRT UNIT By pressing “PR1” Key]
-6-
Application Software Manual
This is the main screen for PUMP HEALTH MODE while OFF condition in Application software.
This window shows warning of the pump Health parameters if User enters
into another health mode then following window appears. This is the main
screen warning for PUMP HEALTH MODE IN Application software.
[NOTE : To enter the parameters into unit user has to reset the LOAD button from the
main screen to re-enter the parameters user has to again set/push the LOAD button ]
-7-
Application Software Manual
• LOAD MODE
Once user enters into LOAD mode then the user has to select proper pump. In pump mode
user has to select the PR1 OrPR2 at a time only one is select to avoid unnecessary
misbehave of the software (in siemens pump).
• As shown in figure user is only able to change the pump selection and the
parameters respectively.
-8-
Application Software Manual
• DATA MODE
• Device communication
-9-
Application Software Manual
When user is using USB to serial then user cannot get the COM1 then user has
to change the COM name to COM1 following screens are used for change the
communication portname.
• Help window
- 10 -
Application Software Manual
3. INSTALLATION
- 11 -
• Above window is shown select next.
- 11 -
• PRESS INSTALL
- 12 -
Application Software Manual
- 13 -
Application Software Manual
4. TROUBLESHOOTING
SOLUTION:-
• If any .netframework error rises while install due to late updated system ,
DEPENDENCIES folder is equipped with .netframework offline installer
which will update the system to the required .netframework after install
user should restart the system and try again for install.
- 14 -
Application Software Manual
SOLUTION:-
While usb connected for the first time if device manager has an error of
unidentified port shown in figure below then DEPENDENCIES folder has
silicon labs usb to uart driver which will solve this error
User should open the folder and install the required version dependent on
which windows version is installed on user system.
- 15 -
Application Software Manual
SOLUTION:-
• After successful install if the visual parameters of the application are overlapping on each
other then follow following steps to solve the problem
• Set the resolution and size of text to recommended settings and again restart the application to verify the
change.
- 16 -