Professional Documents
Culture Documents
MS 1314 4 2004 Amd 1 2012 Fullpdf
MS 1314 4 2004 Amd 1 2012 Fullpdf
MALAYSIAN STANDARD
MS 1314-4: 2004
The attached amendment on MS 1314-4: 2004 has been approved by Technical Committee on
Concrete and concrete products.
1.2) Add Note 2 below the table and should read as follow:
Other pile driving methods may be used subject to agreement between purchaser and supplier.
1.3) Add Note 3 below the table and should read as follow:
Concrete strengths higher than 60 N/mm2 may be used subject to agreement between
purchaser and supplier.
2.1 Add new class of piles of Class C for diameter 250 mm, 300 mm and 350 mm in Table 2.
2.2) Add Note 1 below the Table 2 and should read as follow:
Pile lengths exceeding 18m are subject to agreement between purchaser and supplier.
MS 1314-4: 2004
Amd. 1
Page 1 of 2
(3) Clause 6 (b), page 4
Replace the existing permissible tolerances in pile cross sectional dimensions of wall thickness
of hollow section with the following:
wall thickness of hollow section -3, +15 mm for all types of piles.
(4) Table 3. Cracking bending moment (Mc) and factor 'f ' for prestress levels of 4.0,
5.0 and 7.0 N/mm² for spun piles, page 9.
Add new class of piles of Class C for diameter 250 mm, 300 mm and 350 mm in Table 3.
Nominal
Minimum concrete Cracking bending
diameter Class of Factor Effective prestress
strength moment (Mc)
(mm) Pile 'f ' (N/mm²)
(N/mm2) (KNm)
MS 1314-4: 2004
Amd. 1
Page 2 of 2