You are on page 1of 230

第七章 电气配线数据

7 电气配线数据
7.1 Plug/Jack Location List
7.1.1 配线连接器列表 ....................................................... 3
7.1.2 配线连接器的位置 ..................................................... 12

Version 1.0 2014/01


7-1
AP/DC-V C7775G
电气配线数据
电气配线数据 AP/DC-V C7775G
2014/01
7-2 Version 1.0
7.1.1 配线连接器列表 配线连接器列表
配线连接器表的用法
Table 1 配线连接器列表
· 要找到连接器的安装位置,应参照 “配线连接器列表”,找到 Figure No. 和 Item No.,
然后再参照 “配线连接器的位置” 图表。 P/J No. Figure No. Item No. Remarks (where to connect)
· “配线连接器列表” 的 P/J No. 用以下五种方式表示 : P/J1 44 1 Main Low Voltage Power Supply
· J250 表示 Jack 250。 P/J1 17 4 LED Lamp PWB
· P250 表示 Plug 250。 P/J1 18 8 W90 UI I/F PWB
· 无 P 或者 J 的数字表示 Jack 与 Plug 二者。
P/J1 24 4 S104 UI I/F PWB
· CN1 表示连接器 1。
· FS1 表示 Faston Terminal 1。 P/J1 33 18 CIS (DADF-130)
P1 10 30 Motor Driver Main PWB (Connect to J1)
P1 40 5 DARTS3 PWB
J1 30 11 USB HUB PWB (Option)
J1 42 3 MCU-PF PWB (Connect to P1)
P/J2 33 17 CIS (DADF-130)
P2 30 13 USB HUB PWB (Option)(Connect to J350)
J2 30 10 USB HUB PWB (Option)
P/J3 18 2 W90 UI I/F PWB (W90 Touch Panel)
P/J3 24 5 S104 UI I/F PWB (S104 Touch Panel)
P/J3 13 10 AC Power Supply H / LM
P3 40 3 DARTS3 PWB
J3 30 9 USB HUB PWB (Option)
P/J4 18 3 W90 UI I/F PWB
P/J4 13 9 AC Power Supply H / LM
Figure 1 7001 P4 40 4 DARTS3 PWB
J4 30 8 USB HUB PWB (Option)
P/J5 18 5 W90 UI I/F PWB
P/J5 24 9 S104 UI I/F PWB
P/J5 13 11 AC Power Supply H / LM
P5 42 2 MCU-PF PWB
J5 30 12 USB HUB PWB (Option)
P/J6 13 12 AC Power Supply H / LM
P/J7 18 4 W90 UI I/F PWB
P/J7 24 7 S104 UI I/F PWB
P/J7 13 8 AC Power Supply H
P7 42 1 MCU-PF PWB
P/J8 24 2 S104 UI I/F PWB
P/J8 26 4 Sub Low Voltage Power Supply (6675/7775)
P/J8 13 6 AC Power Supply H2 (6675/7775)

Version 1.0 2014/01


7-3
7.1 Plug/Jack Location List
AP/DC-V C7775G
电气配线数据
电气配线数据 AP/DC-V C7775G
2014/01
7.1 Plug/Jack Location List 7-4 Version 1.0

Table 1 配线连接器列表 Table 1 配线连接器列表


P/J No. Figure No. Item No. Remarks (where to connect) P/J No. Figure No. Item No. Remarks (where to connect)
P/J9 13 5 AC Power Supply H2 (6675/7775) P/J91 43 15 Heater Relay PWB (FX Option)
P/J10 18 1 W90 UI FAX KEY PWB P/J92 43 10 Heater Relay PWB (FX Option)
J10 14 7 GFI (IOT)(BLK) J93 14 14 Connector
J11 14 8 GFI (IOT)(WHT) P/J93 43 13 Heater Relay PWB (FX Option)
J12 2 6 Main Power Switch (BLK) P/J94 43 12 Heater Relay PWB (FX Option)
J13 2 3 Main Power Switch (BLK) P95 43 11 Heater Relay PWB (FX Option)
J14 2 5 Main Power Switch (WHT) P/J100 12 6 L/H Cover Interlock Switch
P/J15 18 6 W90 UI 10KEY PWB P/J101 2 1 Front Cover Interlock Switch
J15 2 4 Main Power Switch (WHT) P/J101 21 7 Tray2 Paper Size Sensor (3TM)
P/J16 24 8 S104 UI 10Key PWB P/J101 37 1 Tray2 Paper Size Sensor (TTM)
P/J17 24 6 S104 LCD Module P/J101 38 5 Tray2 Paper Size Sensor (1TM)
P/J19 24 1 S104 UI I/F PWB P/J102 12 7 L/H Cover Interlock Switch
P/J20 24 3 UI LED PWB P/J102 21 6 Tray3 Paper Size Sensor (3TM)
J20 34 14 Tray GFI (BLK)(TTM)(6675/7775) P/J102 37 3 Tray3 Paper Size Sensor (TTM)
J21 34 13 Tray GFI (WHT)(TTM)(6675/7775) P/J103 21 5 Tray4 Paper Size Sensor (3TM)
P/J30 26 7 IH Driver PWB P/J103 37 2 Tray4 Paper Size Sensor (TTM)
J60 26 6 IH Driver PWB P/J104 21 8 TM L/H Cover Inter Lock Switch (3TM)
J61 26 5 IH Driver PWB P/J104 35 3 TM L/H Cover Inter Lock Switch (TTM)
P/J70 43 4 IOT Heater Kit (Option)(IOT32W)(2pin)(2275/ P/J104 38 6 TM L/H Cover Inter Lock Switch (1TM)
3373/3375) P/J105 21 20 Tray2 Pre Feed Sensor (3TM)(6675/7775)
P/J71 43 3 IIT Heater Kit (FX Option) P/J105 36 4 Tray2 Pre Feed Sensor (TTM)(6675/7775)
P71 28 3 Connector P/J106 21 3 Tray2 No Paper Sensor (3TM)
P/J72 43 8 Connector P/J106 36 3 Tray2 No Paper Sensor (TTM)
P/J73 43 7 Tray Heater P/J106 38 3 Tray2 No Paper Sensor (1TM)
J75 43 5 Thermostat P/J107 21 2 Tray2 Nudger Level Sensor (3TM)
J76 43 6 Thermostat P/J107 36 2 Tray2 Nudger Level Sensor (TTM)
J77 43 4 IOT Heater Kit (Option)(IOT63W)(3pin)(4475/ P/J107 38 2 Tray2 Nudger Level Sensor (1TM)
5575/6675/7775) P/J108 21 4 Feed Out Sensor 2 (3TM)
J85 14 6 Finisher Outlet (BLK) P/J108 35 2 Feed Out Sensor 2 (TTM)
J86 14 5 Finisher Outlet (WHT) P/J108 38 4 Feed Out Sensor 2 (1TM)
J87 14 10 Finisher Outlet (G/Y) P/J109 21 20 Tray3 Pre Feed Sensor (3TM)(6675/7775)
J88 14 9 GFI (G/Y) P/J109 36 4 Tray3 Pre Feed Sensor (3TM)(6675/7775)
J90 34 12 Tray GFI (G/Y)(TTM)(6675/7775) P/J110 16 4 Waste Toner Bottle Full Sensor
J90 14 12 Connector P/J110 21 3 Tray3 No Paper Sensor (3TM)
P/J90 43 14 Heater Relay PWB (FX Option) P/J110 36 3 Tray3 No Paper Sensor (TTM)
J91 14 13 Connector P/J111 16 3 Waste Toner Bottle Position Sensor
Table 1 配线连接器列表 Table 1 配线连接器列表
P/J No. Figure No. Item No. Remarks (where to connect) P/J No. Figure No. Item No. Remarks (where to connect)
P/J111 21 2 Tray3 Nudger Level Sensor (3TM) P/J164 6 4 Exit 2 Sensor
P/J111 36 2 Tray3 Nudger Level Sensor (TTM) P/J165 6 3 Exit 2 OCT Home Position Sensor
P/J112 1 10 Dram CRUM PWB (Y) P/J168 6 5 L/H Upper Cover Interlock Switch
P/J112 21 10 Feed Out Sensor 3 (3TM) P/J169 6 6 Face Up Tray Detect Switch
P/J112 35 1 Feed Out Sensor 3 (TTM) P/J170 7 1 DC Heater
P/J113 1 8 Dram CRUM PWB (M) P/J171 8 6 Tray1 Pre Feed Sensor (4475/5575/6675/7775)
P/J113 21 20 Tray4 Pre Feed Sensor (3TM)(6675/7775) P/J172 9 5 MSI No Paper Sensor
P/J113 36 8 Tray4 Pre Feed Sensor (TTM)(6675/7775) P/J173 9 3 MSI Paper Size Sensor
P/J114 1 6 Dram CRUM PWB (C) P/J174 15 8 Tray1 Paper Size Sensor
P/J114 21 3 Tray4 No Paper Sensor (3TM) P/J175 7 3 Duplex Path Sensor
P/J114 36 7 Tray4 No Paper Sensor (TTM) P/J176 7 8 Dup. Cover Switch
P/J115 1 4 Dram CRUM PWB (K) P/J177 8 9 Tray1 Nudger Level Sensor
P/J115 21 2 Tray4 Nudger Level Sensor (3TM) P/J178 8 8 Tray1 No Paper Sensor
P/J115 36 6 Tray4 Nudger Level Sensor (TTM) P/J179 9 4 MSI Feed Out Sensor
P/J116 21 9 Feed Out Sensor 4 (3TM) P/J180 7 2 POB Sensor
P/J116 36 9 Feed Out Sensor 4 (TTM) P/J183 9 6 MSI Nudger Position Sensor
P/J116 36 14 Feed Out Sensor 4 (TTM)(6675/7775) P/J192 5 8 Fusing Unit Exit Sensor
P/J120 3 4 Toner Cartridge CRUM PWB (Y) P/J193 5 5 P/R Latch Sensor
P/J121 3 3 Toner Cartridge CRUM PWB (M) P/J194 5 3 Fusing Unit Belt Speed Sensor
P/J122 3 2 Toner Cartridge CRUM PWB (C) P/J195 5 6 Centere STS/Rear STS (4pin)
P/J123 3 1 Toner Cartridge CRUM PWB (K) J195 16 9 Nohad STS (Connect to J130)
P/J124 1 11 ATC PWB (ATC Sensor(Y)) P/J197 5 7 Thermostat
P/J125 1 14 ATC PWB (ATC Sensor(M)) P/J210 1 9 Erase Lamp (Y)
P/J126 1 15 ATC PWB (ATC Sensor(C)) P/J211 1 7 Erase Lamp (M)
P/J127 1 16 ATC PWB (ATC Sensor(K)) P/J212 1 5 Erase Lamp (C)
J130 16 9 Connector (Connect to J195) P/J213 1 3 Erase Lamp (K)
P/J131 41 2 Human Motion Sensor P/J215 16 5 Agitator Motor
P/J144 12 3 1st BTR Contact/Retract Sensor P/J217 7 12 LH Fan 2 (Option)
P/J150 4 1 TMA Sensor IN P/J218 7 13 LH Fan 3 (Option)
P/J151 4 4 TMA Sensor OUT P/J220 14 1 Toner Dispence Motor (Y)
P/J153 4 3 ADC Sensor / ADC Sensor Open Solenoid P/J221 14 4 Toner Dispence Motor (M)
P/J154 4 2 Temp and Humidity Sensor P/J221 21 1 Tray2 Feed/Lift Up Motor (3TM)
P/J160 8 3 Regi. Sensor P/J221 36 1 Tray2 Feed/Lift Up Motor (TTM)
P/J162 6 9 Exit 1 OCT Home Position Sensor P/J221 38 1 Tray2 Feed/Lift Up Motor (1TM)
P/J163 6 12 Exit 1 Full Stack Sensor P/J222 14 2 Toner Dispence Motor (C)

Version 1.0 2014/01


7-5
7.1 Plug/Jack Location List
AP/DC-V C7775G
电气配线数据
电气配线数据 AP/DC-V C7775G
2014/01
7.1 Plug/Jack Location List 7-6 Version 1.0

Table 1 配线连接器列表 Table 1 配线连接器列表


P/J No. Figure No. Item No. Remarks (where to connect) P/J No. Figure No. Item No. Remarks (where to connect)
P/J222 21 1 Tray3 Feed/Lift Up Motor (3TM) P/J249 12 19 IBT Drive Motor (8pin)
P/J222 36 1 Tray3 Feed/Lift Up Motor (TTM) P/J250 12 2 1st BTR Contact/Retract Clutch
P/J223 14 3 Toner Dispence Motor (K) P/J251 12 17 DEVE Drive Motor (2pin)
P/J223 21 1 Tray4 Feed/Lift Up Motor (3TM) P/J252 12 16 DEVE Drive Motor (8pin)
P/J223 36 5 Tray4 Feed/Lift Up Motor (TTM) P/J253 12 24 Takeaway Motor (4475/5575/6675/7775)
P/J223 36 13 Tray4 Feed/Lift Up Motor (TTM)(6675/7775) P/J254 12 8 P/R Latch Motor
P/J224 22 10 TM Takeaway Motor 1 (3TM) P/J255 12 12 Regi. Motor (6675/7775)
P/J224 34 10 TM Takeaway Motor 1 (TTM) P/J260 8 2 Regi. Clutch (2275/3373/3375/4475/5575)
P/J224 39 10 TM Take Away Motor 1 (1TM) P/J261 13 4 Takeaway Clutch (2275/3373/3375)
P/J225 26 11 IHP Exhaust Fan (6657/7775) P/J262 6 2 Exit Gate Solenoid
P/J226 22 11 TM Takeaway Motor 2 (3TM) P/J263 6 8 Face Up Gate Solenoid
P/J226 26 9 IH Intake Fan P/J265 6 7 Exit 2 Drive Motor
P/J226 34 11 TM Takeaway Motor 2 (TTM) P/J266 6 1 Exit 2 OCT Motor
P/J227 26 10 C Exhaust Fan (4475/5575/6675/7775) P/J268 8 4 Tray1 Feed/Lift Up Motor
P/J228 1 12 Process 1 Fan (4475/5575/6675/7775) P/J269 9 2 MSI Feed / Nudger Motor
P/J230 12 5 Fusing Unit Fan P/J271 6 11 Exit 1 OCT Motor
P/J231 12 11 Suction Fan (4475/5575/6675/7775) P/J272 1 1 IBT Front Cover Switch
J231 13 1 Connector P/J275 7 5 Duplex Motor
P/J233 28 1 ESS Fan P/J277 44 2 LVPS Fan
P/J234 14 11 Rear Bottom Fan (4475/5575/6675/7775) P/J278 16 2 RH Fan (4475/5575/6675/7775)
P/J235 16 6 Making Fan (4475/5575/6675/7775) P300 11 4 ESS PWB (Connect to J300)
P/J235 16 6 HV Fan (2275/3373/3375) J300 28 10 Connector (Connect to P300)
P/J238 1 17 Process 2 Fan (4pin)(6675/7775) P/J301 33 19 CIS (DADF-130)
P/J240 12 14 Drum/Deve Drive Motor (K)(2pin) P/J302 11 6 ESS PWB / HDD
P/J241 12 15 Drum/Deve Drive Motor (K)(8pin) P/J302 33 20 CIS (DADF-130)
P/J242 12 10 Fusing Unit Drive Motor (2pin) P309 11 5 ESS PWB (Connect to J309)
P/J243 12 9 Fusing Unit Drive Motor (8pin) J309 29 2 BP PWB (Connect to P309)
P/J244 12 22 Main Drive Motor (2pin)(2275/3373/3375/4475/ P/J310 11 7 ESS PWB / HDD
5575) P/J313 28 9 BP PWB
P/J244 13 2 Main Drive Motor (2pin)(4475/5575) P322 11 2 ESS PWB (Connect to J322)
P/J245 12 23 Main Drive Motor (8pin)(2275/3373/3375/4475/ J322 40 1 DARTS3 PWB (Connect to P322)
5575) J330 11 9 ESS PWB (Standard RAM)
P/J245 13 3 Main Drive Motor (8pin)(4475/5575) J332 11 10 ESS PWB (Font ROM)
P/J246 12 21 Drum Drive Motor (Y,M,C)(2pin) P335 11 8 ESS PWB (Connect to J335)
P/J247 12 18 Drum Drive Motor (Y,M,C)(8pin) J335 29 9 BP PWB (Connect to P335)
P/J248 12 20 IBT Drive Motor (2pin) P/J336 29 1 BP PWB
Table 1 配线连接器列表 Table 1 配线连接器列表
P/J No. Figure No. Item No. Remarks (where to connect) P/J No. Figure No. Item No. Remarks (where to connect)
J340 11 13 ESS PWB P/J503 44 5 Main Low Voltage Power Supply
J344 11 14 ESS PWB P504 26 3 Sub Low Voltage Power Supply (4475/5575)
P348 11 1 ESS PWB (Connect to J348) P/J505 26 1 Sub Low Voltage Power Supply (6675/7775)
J348 23 1 Riser2 PWB (Connect to P348) P/J506 26 2 Sub Low Voltage Power Supply (6675/7775)
J350 28 2 Connector (Connect to P2) P/J509 44 6 Main Low Voltage Power Supply
J351 11 15 ESS PWB P/J510 44 4 Main Low Voltage Power Supply
P/J352 25 4 FAX mini PWB P/J511 13 7 AC Power Supply H / LM
P/J353 25 5 FAX mini PWB P/J513 16 7 HVPS (BCR)
P/J355 25 3 FAX mini PWB / Riser PWB (Option) P/J514 16 1 HVPS (DEVE)
P/J356 25 6 FAX mini PWB (Speaker) P519 27 10 Motor Driver Main PWB
P/J363 25 2 AG3 PWB (Option) / Riser PWB (Option) P/J520 10 24 Motor Driver Main PWB
J363 25 1 AG3 PWB (Option)(Connect to P364) P/J521 10 22 Motor Driver Main PWB
P364 25 1 Riser PWB (Option)(Connect to J363) P/J522 27 1 Motor Driver Sub PWB
P380 11 12 ESS PWB P/J523 10 27 Motor Driver Main PWB
P/J390 29 3 BP PWB P/J524 27 2 Motor Driver Sub PWB
P/J411 10 1 Motor Driver Main PWB P/J525 10 29 Motor Driver Main PWB
P/J412 10 13 Motor Driver Main PWB P/J526 10 19 Motor Driver Main PWB
P/J414 10 11 Motor Driver Main PWB P/J527 10 17 Motor Driver Main PWB
P/J415 10 3 Motor Driver Main PWB P/J528 10 14 Motor Driver Main PWB
P/J416 10 2 Motor Driver Main PWB P/J529 27 8 Motor Driver Sub PWB
P/J417 10 10 Motor Driver Main PWB P/J530 26 8 IH Driver PWB
P/J431 10 4 Motor Driver Main PWB P/J532 10 20 Motor Driver Main PWB
P/J450 7 9 LH Fan PWB (Option) P/J534 10 21 Motor Driver Main PWB
P451 10 31 Motor Driver Main PWB (Connect to J451) P/J535 10 12 Motor Driver Main PWB
J451 29 8 BP PWB (Connect to P451) P/J536 10 23 Motor Driver Main PWB
P452 10 25 Motor Driver Main PWB (Connect to J452) P/J537 10 15 Motor Driver Main PWB (4475/5575/6675/7775)
J452 27 3 Motor Driver Sub PWB (Connect to P452) P/J538 27 7 Motor Driver Sub PWB (4475/5575/6675/7775)
P/J453 7 11 LH Fan PWB (Option) P/J539 27 9 Motor Driver Sub PWB
P/J454 7 10 LH Fan PWB (Option) P/J540 10 28 Motor Driver Main PWB
P/J460 16 8 HVPS (DEVE/BCR)(2275/3373/3375) P/J541 22 2 Tray Module PWB (3TM)
P/J461 12 1 HVPS (1st/2nd/BTR) P/J541 34 2 Tray Module PWB (TTM)
P/J490 41 1 Human Motion LED P/J541 39 2 Tray Module PWB (1TM)
P/J490 45 1 Human Motion LED P/J542 22 1 Tray Module PWB (3TM)
P/J501 44 7 Main Low Voltage Power Supply P/J542 34 1 Tray Module PWB (TTM)
P/J502 44 3 Main Low Voltage Power Supply P/J542 39 1 Tray Module PWB (1TM)

Version 1.0 2014/01


7-7
7.1 Plug/Jack Location List
AP/DC-V C7775G
电气配线数据
电气配线数据 AP/DC-V C7775G
2014/01
7.1 Plug/Jack Location List 7-8 Version 1.0

Table 1 配线连接器列表 Table 1 配线连接器列表


P/J No. Figure No. Item No. Remarks (where to connect) P/J No. Figure No. Item No. Remarks (where to connect)
P/J545 22 6 Tray Module PWB (3TM) P/J565 15 5 LPH Header PWB (Y)
P/J545 34 6 Tray Module PWB (TTM) P/J566 15 4 LPH Header PWB (K)
P/J545 39 6 Tray Module PWB (1TM) P/J567 15 4 LPH Header PWB (C)
P/J549 22 9 Tray Module PWB (3TM) P/J567 5 4 Fusing Unit Detect Resistance
P/J548 34 9 Tray Module PWB (TTM) P/J568 15 4 LPH Header PWB (M)
P548 39 9 Tray Module PWB (1TM) P/J569 15 4 LPH Header PWB (Y)
P/J549 34 8 Tray Module PWB (TTM) P/J570 15 3 LPH (K)
P/J549 39 8 Tray Module PWB (1TM) P/J571 15 3 Driver PWB (C)
P/J549 22 8 Tray Module PWB (3TM) P/J572 15 3 Driver PWB (M)
P/J550 15 7 LPH Rear PWB (K) P/J573 15 3 Driver PWB (Y)
P/J550 22 3 Tray Module PWB (3TM) P/J574 15 2 Driver PWB (K)
P/J550 34 3 Tray Module PWB (TTM) P/J575 15 2 Driver PWB (C)
P/J550 39 3 Tray Module PWB (1TM) P/J576 15 2 Driver PWB (M)
P/J551 15 7 LPH Rear PWB (C) P/J577 15 2 Driver PWB (Y)
P/J551 22 4 Tray Module PWB (3TM) P/J578 15 1 LPH Rear PWB (K) / LPH Header PWB (K)
P/J551 34 4 Tray Module PWB (TTM) P/J579 15 1 LPH Rear PWB (C) / LPH Header PWB (C)
P/J551 39 4 Tray Module PWB (1TM) P/J580 15 1 LPH Rear PWB (M) / LPH Header PWB (M)
P/J552 15 7 LPH Rear PWB (M) P/J581 15 1 LPH Rear PWB (Y) / LPH Header PWB (Y)
P/J552 22 5 Tray Module PWB (3TM) P590 27 6 Motor Driver Sub PWB (to Option I/F)
P/J552 34 5 Tray Module PWB (TTM) P591 27 5 Motor Driver Sub PWB (to Option I/F)
P552 39 5 Tray Module PWB (1TM) P592 27 4 Motor Driver Sub PWB (to Option I/F)
P/J553 15 7 LPH Rear PWB (Y) J592 22 17 Connector (3TM)
P553 22 7 Tray Module PWB (3TM) J592 34 19 Connector (TTM)
P553 34 7 Tray Module PWB (TTM) J592 39 12 Connector (1TM)
P553 39 7 Tray Module PWB (1TM) P593 10 18 Motor Driver Main PWB
P/J554 10 5 Motor Driver Main PWB P594 10 16 Motor Driver Main PWB
P/J555 10 6 Motor Driver Main PWB P/J595 2 2 Power Switch
P/J556 10 7 Motor Driver Main PWB DP600 5 1 Fusing Unit (Connect to DJ600)
P/J557 10 8 Motor Driver Main PWB DJ600 5 2 Connector (Connect to DP600)
P/J558 15 6 LPH Rear PWB (K) P/J610 1 2 Connector (30pin)
P/J559 15 6 LPH Rear PWB (C) P/J611 8 5 Connector
P/J560 15 6 LPH Rear PWB (M) P/J612 7 6 Connector (24pin)
P/J561 15 6 LPH Rear PWB (Y) P/J616 9 1 Connecter (18pin)
P/J562 15 5 LPH Header PWB (K) P/J617 9 7 Connector
P/J563 15 5 LPH Header PWB (C) P/J618 8 7 Connctor (4475/5575/6675/7775)
P/J564 15 5 LPH Header PWB (M) P/J619 3 5 Cartridge Fan (4475/5575/6675/7775)
Table 1 配线连接器列表 Table 1 配线连接器列表
P/J No. Figure No. Item No. Remarks (where to connect) P/J No. Figure No. Item No. Remarks (where to connect)
P/J624 7 4 Connector P/J676 34 18 Connector (12pin)(TTM)
P/J631 12 4 Connector (30pin) P/J700 17 6 CCD Lens Assembly
P/J632 8 1 Connector (8pin)(2275/3373/3375/4475/5575) P/J700 28 5 Connector
P/J633 1 13 ATC PWB P/J710 30 5 IIT Trans PWB
P/J634 26 12 IH Heating Coil P/J720 30 6 IIT Trans PWB
P/J635 7 7 Connector (5pin) P/J722 30 7 IIT Trans PWB
P/J640 6 10 Connector P/J723 30 4 IIT Trans PWB
P645 34 16 Connector (Connect to J645)(TTM)(6675/7775) J740 32 25 Connector (DADF-130)(Connect to P740)
J645 28 11 Connector (Connect to P645)(6675/7775) P740 40 6 DARTS3 PWB (Connect to J740)
P650 45 4 Connector (Connect to J650) P/J745 33 4 DCDC PWB (DADF-130)
J650 5 10 Connector P/J746 33 6 DCDC PWB (DADF-130)
P/J651 31 6 DC Power Supply (F503)(FAX) P750 19 17 Connector (DADF-110)(Connect to J750)
P/J661 21 19 Connector (4pin)(3TM) J750 30 3 IIT Trans PWB (Connect to P750)
P/J661 35 8 Connector (4pin)(TTM) P750 32 24 Connector (DADF-130)(Connect to J750)
P/J661 38 9 Connector (4pin)(1TM) P/J751 20 12 DADF PWB (DADF-110)
P/J662 21 16 Connector (4pin)(3TM) P/J751 33 15 DADF PWB (DADF-130)
P/J662 35 6 Connector (4pin)(TTM) P/J752 20 11 DADF PWB (DADF-110)
P/J663 21 13 Connector (4pin)(3TM) P/J752 33 14 DADF PWB (DADF-130)
P/J663 36 11 Connector (4pin)(TTM) P/J753 20 10 DADF PWB (DADF-110)
P/J663 36 15 Connector (4pin)(TTM)(6675/7775) P/J753 33 13 DADF PWB (DADF-130)
P/J668 21 11 Connector (2pin)(3TM) P/J754 20 4 DADF PWB (DADF-110)
P/J668 35 4 Connector (2pin)(TTM) P/J754 33 11 DADF PWB (DADF-130)
P/J668 38 7 Connector (2pin)(1TM) P/J755 20 9 DADF PWB (DADF-110)
P/J669 21 18 Connector (9pin)(3TM) P/J755 33 12 DADF PWB (DADF-130)
P/J669 35 9 Connector (9pin)(TTM) P/J756 20 3 DADF PWB (DADF-110)
P/J669 38 8 Connector (9pin)(1TM) P/J756 33 10 DADF PWB (DADF-130)
P/J671 21 15 Connector (9pin)(3TM) P/J757 20 1 DADF PWB (DADF-110)
P/J671 35 5 Connector (9pin)(TTM) P/J757 33 9 DADF PWB (DADF-130)
P/J672 21 17 Connector (3pin)(3TM) P/J758 20 2 DADF PWB (DADF-110)
P/J672 35 7 Connector (3pin)(TTM) P/J758 33 8 DADF PWB (DADF-130)
P/J673 21 12 Connector (9pin)(3TM) P759 20 14 DADF PWB (DADF-110)
P/J673 36 10 Connector (9pin)(TTM) P759 33 7 DADF PWB (DADF-130)
P/J673 36 12 Connector (9pin)(TTM)(6675/7775) P760 20 13 DADF PWB (DADF-110)
P/J674 21 14 Connector (3pin)(3TM) P760 33 16 DADF PWB (DADF-130)
P/J675 34 17 Connector (4pin)(TTM) P/J761 19 19 Doc. Tray Size Sensor 1 (DADF-110)

Version 1.0 2014/01


7-9
7.1 Plug/Jack Location List
AP/DC-V C7775G
电气配线数据
电气配线数据 AP/DC-V C7775G
2014/01
7.1 Plug/Jack Location List 7-10 Version 1.0

Table 1 配线连接器列表 Table 1 配线连接器列表


P/J No. Figure No. Item No. Remarks (where to connect) P/J No. Figure No. Item No. Remarks (where to connect)
P/J762 19 3 Doc. Tray Set Guide Sensor 3 (DADF-110) P/J778 19 15 Exit Nip Release Solenoid (DADF-110)
P/J762 32 2 Doc. Tray Size Sensor1 (DADF-130) P/J778 32 22 DADF Exit Senso (DADF-130)
P/J763 19 2 Doc. Tray Set Guide Sensor 2 (BLU Connector) P/J779 19 14 Document Set Gate Solenoid (BLU
(DADF-110) Connector)(DADF-110)
P/J763 32 1 Doc. Tray Size Sensor2 (DADF-130) P/J779 32 15 Connector (6pin)(DADF-130)
P/J764 19 1 Doc. Tray Size Sensor 2 (DADF-110) P/J780 19 16 Stamp Solenoid (DADF-110)(Option)
P/J764 32 3 Doc.Tray Set Guide Sensor3 (DADF-130) P/J780 32 9 DADF Feed Out Sensor (DADF-130)
P/J765 19 18 Doc. Tray Set Guide Sensor 1 (DADF-110) P/J781 32 11 DADF Feed In Sensor (DADF-130)
P/J765 32 4 Doc.Tray Set Guide Sensor2 (DADF-130)(BLU) P/J782 33 2 DADF Regi. Motor (DADF-130)
P/J766 19 11 Connector (9Pin) (DADF-110) P/J784 33 1 DADF Pre Regi. Motor (DADF-130)
P/J766 32 23 Doc.Tray Set Guide Sensor1 (DADF-130) P/J786 32 19 Connector (DADF-130)
P/J767 19 4 DADF APS Sensor 3 (DADF-110) P/J790 32 21 Stamp Solenoid (Option)(DADF-130)
P/J768 19 5 DADF APS Sensor 2 (DADF-110) P/J791 19 20 DADF Document Set LED (DADF-110)
P/J768 32 6 DADF APS Sensor3 (DADF-130) P/J791 32 26 DADF Document Set LED (DADF-130)
P/J769 19 6 DADF APS Sensor 1 (DADF-110) P/J792 33 21 DADF PWB (DADF-130)
P/J769 32 5 DADF APS Sensor2 (DADF-130) P/J793 33 22 DADF PWB (DADF-130)
P/J770 19 10 Connector (10Pin)(DADF-110) P/J794 33 3 DADF Feed Motor (DADF-130)
P/J770 32 7 DADF APS Sensor1 (DADF-130) P/J795 32 28 DADF Takeaway Clutch (DADF-130)
P/J771 17 8 APS Sensor 1 P/J796 32 27 DADF Pre Regi. Clutch (DADF-130)
P/J771 20 5 DADF Document Set Sensor (DADF-110) DP800 28 7 Connector (to Option I/F)
P/J771 32 13 Connector (9pin)(DADF-130) P900 5 9 Connector
P/J772 20 6 DADF Feed Out Sensor (DADF-110) J900 41 5 Connector (Connect to P900)(Human Motion
P/J772 32 10 DADF Regi. Sensor (DADF-130) Sensor)
P/J773 17 2 IIT Regi. Sensor J900 45 3 Connector (Connect to P900)(SWEA)
P/J773 19 7 DADF Invert Sensor (DADF-110) P/J901 41 3 Human Motion Sensor PWB
P/J773 32 8 DADF Out Sensor (DADF-130) P/J901 45 6 Human Access Detect PWB
P/J774 17 1 Platen Angle Sensor P/J902 45 7 Human Access Detect PWB
P/J774 19 9 DADF Pre Regi. Sensor (DADF-110) J903 43 9 Connector (Option Heater & Accessoly)
P/J774 32 12 DADF Pre Regi. Sensor (DADF-130) P/J904 45 2 Human Access Detect PWB
P/J775 17 9 Platen Interlock Switch P904 22 15 Connector (3TM)
P/J775 19 8 DADF Regi. Sensor (DADF-110) J904 25 11 Connctor
P/J775 32 17 DADF Document Set Sensor (DADF-130) J904 31 17 Connector (FAX)(FX Only)
P/J776 17 5 Carriage Motor P904 34 15 Connector (TTM)
P/J776 20 8 DADF Feed Motor (DADF-110) P904 39 11 Connector (1TM)
P/J777 20 7 DADF Regi. Motor (DADF-110) P/J906 45 8 Human Access Detect PWB
P/J777 32 16 Connector (3pin)(DADF-130) J910 31 4 Connector (Connect to CNP352)
Table 1 配线连接器列表 Table 1 配线连接器列表
P/J No. Figure No. Item No. Remarks (where to connect) P/J No. Figure No. Item No. Remarks (where to connect)
P/J911 41 4 Human Motion Sensor PWB CNP364 31 1 G4 PWB
P/J911 45 5 Human Access Detect PWB CNP364 31 2 G4 PWB
P/J931 43 2 IIT Heater 2 CNP/ 31 16 Riser PWB (FX Only)
P/J932 43 1 IIT Heater 1 CNJ365
P/J1301 29 4 BP PWB CNP/ 31 13 Handset PWB
P/J1311 29 6 BP PWB CNJ366
P/J1312 29 7 BP PWB (to FAX) CNP367 31 12 Handset PWB
P/J1313 29 5 BP PWB CNJ372 31 14 G3 PWB (Line)
J1332 11 11 ESS PWB / SD Card CNJ376 31 8 G4 PWB
P/J1341 29 11 BP PWB CNJ376 31 14 G4 PWB
P/J1343 28 8 BP PWB CN5 45 14 Camera1 PWB
P1395 29 10 BP PWB CN10 45 13 Human Access Detect (GEMINI) PWB
P1397 11 3 ESS PWB F1 19 13 DADF Interlock Switch (DADF-110)
P2701 40 7 DARTS3 PWB F1 32 20 DADF Interlock Switch (DADF-130)
P2702 40 2 DARTS3 PWB F2 19 12 DADF Interlock Switch (DADF-110)
J3480 23 2 Riser2 PWB F2 32 18 DADF Interlock Switch (DADF-130)
P3480 23 4 Image Comp. PWB (Selene2) LCD CN1 18 7 W90 LCD Module
J3481 23 3 Riser2 PWB LINE2 25 7 AG3 PWB (Option)
P/J7191 30 2 IIT Trans PWB LINE3 25 10 AG3 PWB (Option)
P/J7192 30 1 IIT Trans PWB MJ1 25 8 FAX mini PWB (LINE)
P/J7461 33 5 DCDC PWB (DADF-130) MJ2 25 9 FAX mini PWB (TEL)
CNP352 31 4 FAX PWB (Connect to J910)(FX Only) RJ45_CN2 45 12 Camera2 PWB
CNP/ 31 5 FAX PWB (FX Only) RJ45_CN6 45 9 Human Access Detect (GEMINI) PWB
CNJ353 SJ1 28 6 Shouting Juck (2275/3373/3375/4475/5575)
CNP/ 31 3 Fax PWB/Riser PWB (FX Only) USB P2 18 9 USB Connector
CNJ355 USB_Type 45 10 Human Access Detect (GEMINI) PWB
CNP/ 31 7 FAX PWB (Speaker) A
CNJ356 USB_CN2 45 11 USB Connector (Connect to J2)
CNJ359 31 9 FAX PWB (LINE)
CNJ360 31 10 FAX PWB (TEL)
CNP/ 31 15 Extension PWB/FAX PWB (FX Only)
CNJ361
CNP362 31 11 Extension PWB (FX Only)
CNJ363 31 2 Riser PWB (FX Only)
CNJ363 31 1 G3 PWB
CNJ364 31 1 Riser PWB (FX Only)

Version 1.0 2014/01


7-11
7.1 Plug/Jack Location List
AP/DC-V C7775G
电气配线数据
电气配线数据 AP/DC-V C7775G
2014/01
7.1 Plug/Jack Location List 7-12 Version 1.0

7.1.2 配线连接器的位置

Figure 2 Main Power/Front Cover Interlock Switch (j0se71002)


Figure 1 Drum CRUM Coupler / ATC PWB (j0kt71001)
Figure 3 Toner CRUM (j0se71003) Figure 4 MOB ADC Sensor Assembly (j0kt71004)

Version 1.0 2014/01


7-13
7.1 Plug/Jack Location List
AP/DC-V C7775G
电气配线数据
电气配线数据 AP/DC-V C7775G
2014/01
7.1 Plug/Jack Location List 7-14 Version 1.0

Figure 5 Fusing Unit (j0se71005) Figure 6 Exit1/2 (j0se71006)


Figure 7 L/H Cover , Duplex Unit (j0se71007) Figure 8 Regi. Unit , Tray1 Feeder (j0kt71008)

Version 1.0 2014/01


7-15
7.1 Plug/Jack Location List
AP/DC-V C7775G
电气配线数据
电气配线数据 AP/DC-V C7775G
2014/01
7.1 Plug/Jack Location List 7-16 Version 1.0

Figure 9 MSI (j0kt71009) Figure 10 Motor Driver Main PWB (j0se71010)


Figure 11 ESS PWB (j0se71011) Figure 12 IOT Rear Location (Open) 1 of 2 (j0se71012)

Version 1.0 2014/01


7-17
7.1 Plug/Jack Location List
AP/DC-V C7775G
电气配线数据
电气配线数据 AP/DC-V C7775G
2014/01
7.1 Plug/Jack Location List 7-18 Version 1.0

Figure 13 IOT Rear Location (Open) 2 of 2 (j0se71013) Figure 14 Toner Dispence Motor / GFI (j0se71014)
Figure 15 LPH Unit, Tray1 Paper Size Sensor (j0kt71015) Figure 16 HVPS(DEVE/BCR),Agitator Motor (j0se71016)

Version 1.0 2014/01


7-19
7.1 Plug/Jack Location List
AP/DC-V C7775G
电气配线数据
电气配线数据 AP/DC-V C7775G
2014/01
7.1 Plug/Jack Location List 7-20 Version 1.0

Figure 17 IIT Assembly (j0se71017) Figure 18 W90 Control Panel (j0se71018)


Figure 19 DADF 1 of 2 (DADF-110) (j0kt71019) Figure 20 DADF 2 of 2 (DADF-110) (j0kt71020)

Version 1.0 2014/01


7-21
7.1 Plug/Jack Location List
AP/DC-V C7775G
电气配线数据
电气配线数据 AP/DC-V C7775G
2014/01
7.1 Plug/Jack Location List 7-22 Version 1.0

Figure 21 Tray Module (3TM) 1of 2 (j0se71021) Figure 22 Tray Module (3TM) 2of 2 (j0se71022)
Figure 23 ESS Option PWB (j0se71023) Figure 24 S104 UI Assembly (Option) (j0se71024)

Version 1.0 2014/01


7-23
7.1 Plug/Jack Location List
AP/DC-V C7775G
电气配线数据
电气配线数据 AP/DC-V C7775G
2014/01
7.1 Plug/Jack Location List 7-24 Version 1.0

Figure 25 FAX mini (j0se71025) Figure 26 IH PWB / Sub LVPS (j0se71026)


Figure 27 Motor Driver Sub PWB (j0se71027) Figure 28 IOT Rear Location (Closed) (j0se71028)

Version 1.0 2014/01


7-25
7.1 Plug/Jack Location List
AP/DC-V C7775G
电气配线数据
电气配线数据 AP/DC-V C7775G
2014/01
7.1 Plug/Jack Location List 7-26 Version 1.0

Figure 29 BP PWB (j0se71029) Figure 30 IIT Trans PWB / USB HUB PWB (j0se71030)
Figure 31 FAX (Option) (j0se71031) Figure 32 DADF 1 of 2 (DADF-130) (j0se71032)

Version 1.0 2014/01


7-27
7.1 Plug/Jack Location List
AP/DC-V C7775G
电气配线数据
电气配线数据 AP/DC-V C7775G
2014/01
7.1 Plug/Jack Location List 7-28 Version 1.0

Figure 33 DADF 2 of 2 (DADF-130) (j0se71033) Figure 34 Tray Module (TTM) 1 of 4 (j0se71034)


Figure 35 Tray Module (TTM) 2 of 4 (j0kt71035) Figure 36 Tray Module (TTM) 3 of 4 (j0se71036)

Version 1.0 2014/01


7-29
7.1 Plug/Jack Location List
AP/DC-V C7775G
电气配线数据
电气配线数据 AP/DC-V C7775G
2014/01
7.1 Plug/Jack Location List 7-30 Version 1.0

Figure 37 Tray Module (TTM) 4 of 4 (j0kt71037) Figure 38 Tray Module (1T) 1 of 2 (China Only Option) (j0kt71038)
Figure 39 Tray Module (1T) 2 of 2 (China Only Option) (j0se71039) Figure 40 DARTS2 PWB (j0se71040)

Version 1.0 2014/01


7-31
7.1 Plug/Jack Location List
AP/DC-V C7775G
电气配线数据
电气配线数据 AP/DC-V C7775G
2014/01
7.1 Plug/Jack Location List 7-32 Version 1.0

Figure 41 Human Motion Sensor (j0se71041) Figure 42 MCU-PF PWB (j0se71042)


Figure 43 Heater Kit (FX Only Option) (j0kt71043) Figure 44 Main Low Voltage Power Supply (j0se71044)

Version 1.0 2014/01


7-33
7.1 Plug/Jack Location List
AP/DC-V C7775G
电气配线数据
电气配线数据 AP/DC-V C7775G
2014/01
7.1 Plug/Jack Location List 7-34 Version 1.0

Figure 45 Human Access Detect Assembly (j0se71045)


7.2 Wire Network
7.2 Wire Network ...................................................................................................................................... 1
7.2.1 ACH ...................................................................................................................................................................... 1
7.2.2 ACN ...................................................................................................................................................................... 2
7.2.3 IOT 1.8VRTN .................................................................................................................................................... 3
7.2.4 IOT 2.5VRTN .................................................................................................................................................... 4
7.2.5 IOT 3.3VRTN .................................................................................................................................................... 5
7.2.6 IOT AVREF RTN ............................................................................................................................................. 6
7.2.7 +5VDC ................................................................................................................................................................. 7
7.2.8 IOT 5VRTN-1 ................................................................................................................................................... 8
7.2.9 IOT 5VRTN-2 ................................................................................................................................................... 9
7.2.10 IOT 5VRTN-3 ..............................................................................................................................................10
7.2.11 IOT 5VRTN-4 ..............................................................................................................................................11
7.2.12 IOT 5VRTN-5 ..............................................................................................................................................12
7.2.13 IOT 5VRTN-6 ..............................................................................................................................................13
7.2.14 IOT +24VDC-1 ............................................................................................................................................14
7.2.15 IOT +24VDC-2 ............................................................................................................................................15
7.2.16 IOT +24VDC-3 ............................................................................................................................................16
7.2.17 IOT +24VDC-4 ............................................................................................................................................17
7.2.18 IOT 24VRTN-1 ............................................................................................................................................18
7.2.19 IOT 24VRTN-2 ............................................................................................................................................19
7.2.20 IOT 24VRTN-3 ............................................................................................................................................20
7.2.21 IIT 3.3VRTN ..................................................................................................................................................21
7.2.22 IIT ANA3.3VRTN.........................................................................................................................................22
7.2.23 IIT 5VRTN......................................................................................................................................................23
7.2.24 IIT ANA10VRTN..........................................................................................................................................24
7.2.25 IIT 24VRTN ...................................................................................................................................................25
7.2.26 DADF 5VRTN (DADF-110)....................................................................................................................26
7.2.27 DADF 5VRTN (DADF-130(1PASS)) ..................................................................................................27
7.2.28 DADF 24VRTN ............................................................................................................................................28

Contents
i 7.2 Wire Network
7.2.1 ACH
AC POWER SUPPLY H

6675/7775-100~110V Model Only


GFI 1.1
(TRAY)
J20 J645 P645 J7 J6
1 2 2 2
BLK BLK BLK

6675/7775
AC POWER 10.4
SUPPLY H2

J6 J8 J9 J30 10.4
2 BLK
1 3 3 IH DRIVER PWB

J3 J1 MAIN LOW 1.4


1 BLK 5 VOLTAGE POWER
SUPPLY

J5 J85 1.1
5 FINISHER OUTLET
BLK

OPTION
GFI (IOT) 1.1 MAIN POWER 1.1 ACCESSORY/HEATER 1.2
SWITCH RELAY PWB
OPTION
J92 J903 3.13 3.16
J10 J12 J13 J4 1 J91 1 1 ACCESSORY
1 1 1 1 6 3 BLK 3.18
BLK BLK BLK

OPTION

J93 P71 J71 P930 J930 CE30 P931 J931 6.11


1 2 1 1 IIT HEATER 1
BLK BLK BLK BLK

P932 J932 6.11


1 IIT HEATER 2
BLK

NOTE: J94 CE3 J70 P70 9.30


1 2 IOT HEATER (32W)
1 100V machine : 125V/25A BLK BLK BLK
200V machine : 250V/15A
J77 P77 9.30
3 IOT HEATER (63W)
BLK BLK

J72 P72 J73 P73 7.13


2 2 TRAY HEATER
BLK BLK

6675/7775
J8 SUB LOW VOLTAGE 1.10
8 BLK 2 POWER SUPPLY
j0se720001

7.2 Wirenets
7-1 Chapter 7 Wiring Data
7-2 Chapter 7 Wiring Data
7.2 Wirenets
7.2.2 ACN
AC POWER SUPPLY H

6675/7775-100~110V Model Only


GFI 1.1
(TRAY)
J21 J645 P645 J7 J6
1 1 1 1
WHT WHT WHT

6675/7775
AC POWER 10.4
SUPPLY H2

J6 J8 J9 J30 10.4
1 WHT
3 1 WHT
1 IH DRIVER PWB

J3 J1 MAIN LOW 1.4


3 WHT 8 VOLTAGE POWER
SUPPLY

J5 J86 1.1
1 FINISHER OUTLET
WHT

OPTION
GFI (IOT) 1.1 MAIN POWER 1.1 ACCESSORY/HEATER 1.2
SWITCH RELAY PWB
OPTION
J92 J903 3.13 3.16
J11 J14 J15 J4 J91 2 2 ACCESSORY
1 1 1 3 2 1 WHT 3.18
WHT WHT WHT

OPTION

J93 P71 J71 P930 J930 CE31 P931 J931 6.11


2 1 2 2 IIT HEATER 1
WHT WHT WHT WHT

P932 J932 6.11


2 IIT HEATER 2
THERMO- WHT
STAT
J94 CE4 J76 J75 CE5 J70 P70 9.30
2 1 1 1 IOT HEATER (32W)
WHT WHT WHT WHT

J77 P77 9.30


1 IOT HEATER (63W)
WHT WHT

J72 P72 J73 P73 7.13


1 1 TRAY HEATER
WHT WHT

6675/7775
J8 SUB LOW VOLTAGE 1.10
4 WHT 1 POWER SUPPLY
j0se720002
7.2.3 IOT 1.8VRTN

MOTOR DRIVER MAIN PWB

J532 J553 6.6


From 7.2.9 1 4 LPH REAR PWB (Y)
IOT 5VRTN-2 BLU

J552 6.7
5 BLU
4 LPH REAR PWB (M)

J551 6.8
9 BLU
4 LPH REAR PWB (C)

J550 6.9
13 BLU 4 LPH REAR PWB (K)

j0se720003

7.2 Wirenets
7-3 Chapter 7 Wiring Data
7-4 Chapter 7 Wiring Data
7.2 Wirenets
7.2.4 IOT 2.5VRTN

MOTOR DRIVER MAIN PWB


TONER CRUM COUPLER ASSEMBLY (Y)

J411 J120 TONER CARTRIDGE 9.5


From 7.2.9
IOT 5VRTN-2 A1 BLU 4 CRUM PWB (Y)

TONER CRUM COUPLER ASSEMBLY (M)

J121 TONER CARTRIDGE 9.5


A9 BLU 4 CRUM PWB (M)

TONER CRUM COUPLER ASSEMBLY (C)

J122 TONER CARTRIDGE 9.6


B1 GRY 4 CRUM PWB (C)

TONER CRUM COUPLER ASSEMBLY (K)

J123 TONER CARTRIDGE 9.6


B9 GRY 4 CRUM PWB (K)

j0se720004
7.2.5 IOT 3.3VRTN

MOTOR DRIVER MAIN PWB

J417 J130 J195 9.22


From 7.2.9 B2 1 2 NOHAD STS
IOT 5VRTN-2 GRY

J416 J272 IBT FRONT COVER 1.13


2 1 SWITCH
1
NOTE:
FUSING UNIT ASSY
1 2275/3373/3375 : BLU
J431 DJ600 DP600 P195 J195 10.3 4475/5575 : WHT
14 YEL A6 A6 3 2 CENTER STS 6675/7775 : VIO
BLU

2 2275/3373/3375 : GRY
10.3 4475/5575 : WHT
16 YEL A4 A4 1 4 REAR STS 6675/7775 : VIO
BLU

J523 P612 J612 J176 DUP COVER 1.13


B3 GRY B10 B3 1 SWITCH
2

MOTOR DRIVER SUB PWB

From 7.2.12 J522 P631 J631 J168 L/H UPPER COVER 1.13
IOT 5VRTN-5 B12 B2 B14 1 INTLK SWITCH
1 1
J169 FACE UP TRAY 1.13
A15 BLU A1 A15 BLU 1 DETECT SWITCH

j0se720005

7.2 Wirenets
7-5 Chapter 7 Wiring Data
7-6 Chapter 7 Wiring Data
7.2 Wirenets
7.2.6 IOT AVREF RTN

MOTOR DRIVER MAIN PWB

J412 J174 TRAY PAPER SIZE 7.1


From 7.2.9 A11 BLU 3 SENSOR
IOT 5VRTN-2

J525 P616 J616 P617 J617 J173 MSI PAPER SIZE 7.7
B2 GRY 17 2 BLU 2 2 BLU
2 SENSOR

j0se720006
7.2.7 +5VDC

MOTOR DRIVER HUMAN ACCESS 2.14


MAIN PWB DETECT (GEMINI)
MAIN LOW VOLTAGE POWER SUPPLY PWB

J509 J521 F21 J536 CE7 P651 J651 J650 P650 J904
6 3 6 1 1 1
GRY 3.15A GRY GRY GRY GRY

1 6675/7775
J506 SUB LOW VOLTAGE 1.10
GRY 1 POWER SUPPLY
S104 UI

+5VDC S104 UI I/F


ESS PWB BP PWB PWB

J501 J300 P335 J335 F602 J1311 J1 J5 J16 2.9


9 B3 54 29 29 3 23 S104 UI 10 KEY PWB
GRY 0.75A
P309 J309 1
+5VDC 72 J8 J20 2.11
8 B4 TO 4 1 UI LED PWB
GRY
+2.5VDC
73

+5VDC
TO 79 N.C
+3.3VDC

P335 J335 W90 UI


F1102 48
1 W90 UI I/F
4A PWB
F1104 J1 J5 J15 2.3
1 29 23 6 W90 UI 10 KEY PWB
0.75A
F1201
1
7 B5 N.C
GRY

ON/
OFF 6 B6
GRY

MOTOR DRIVER MAIN UI HUB PWB 3.20


PWB

F1 +5VDC NOTE:
J509 J520 F19 J536 J350
8 1 1 1 TO 1 Chip Fuse
GRY GRY
1 +3.3VDC
1
J1343
3 GRY 1 BP PWB
F22
7 2 N.C
GRY 5.0A
1

j0se720007

7.2 Wirenets
7-7 Chapter 7 Wiring Data
7-8 Chapter 7 Wiring Data
7.2 Wirenets
OPTION
7.2.8 IOT 5VRTN-1 J902 HUMAN ACCESS 2.14
2 DETECT (GEMINI)
BP PWB PWB
HUMAN 2.13
MOTION
SENSOR
PWB
J1301 P900 J900 J911 J901 J131 HUMAN MOTION 2.12
4 BLU
8 4 GRY
3 4 GRY
2 SENSOR
MAIN LOW VOLTAGE POWER
SUPPLY MOTOR DRIVER
MAIN PWB J911 J900 P900 J1301
2 GRY
5 7 5 BP PWB
J451 P451 BLU

To 7.2.9 W90 UI
5VRTN ESS PWB
IOT 5VRTN-2 W90 UI I/F PWB
J1311 J1
P335 J335 8,33,14,11, 8,33,14,11,
J501 J300 40,37,17,10, 40,37,17,10, J5 J15 2.3
4 A3 21,24,46,49, 21,24,46,49, 26,27, 3,2,1, W90 UI 10 KEY PWB
VIO 28,3 26
2,28,4,9,34, 2,28,4,9,34,
7,32 7,32
P309 J309 W90 LCD MODULE 2.4
3 A4 J1341 P900 J900
VIO 5 1 11 GRY
BLU LCD
J7 CN1
12,15,18,23, 12,15,18,23,
26,29,34,37, 26,29,34,37,
2 A5 J906 HUMAN ACCESS 2.14 44,40,42,7 44,40,42,7
VIO 1 DETECT (GEMINI)
PWB
J2 J11 W90 UI FUNCTION 2.2
1 A6 J313 P233 J233 25.1 4 4 PWB
VIO 4 1 4 ESS FAN
BLU

W90 UI FAX PWB 2.7


USB
USB 3.19
J1313 P2 GENERAL USB J4 J10
4 4 PORT 1,3,16,18 1,3,16,18
To 7.2.9
IOT 5VRTN-2

DARTS3 PWB S104 UI


P5 3.20
P322 J322 4 USB HUB PWB S104 LCD 2.10
S104 UI I/F PWB MODULE
J7 J17
1,2,4,5,10, 1,2,4,5,10,
14,18,22,26, 14,18,22,26,
RISER PWB 30,32 30,32
J1
J348 P348 8,33,14,11,
40,37,17,10, J5 J16 2.9
21,24,46,49, 23 3 S104 UI 10 KEY PWB
2,28,4,9,34,
7,32
J8 J20 2.11
J310 3 2 UI LED PWB
1,4,7 25.1
HDD
J302
2,3

J351 3.12 3.14


1,4,7,10,13 ACCESSORY
3.13 j0se720008
7.2.9 IOT 5VRTN-2

From 7.2.8
IOT 5VRTN-1

MAIN LOW VOLTAGE POWER MOTOR DRIVER MAIN PWB MOTOR DRIVER SUB
SUPPLY PWB

P452 J452
From 7.2.8 J509 J520 To 7.2.12
IOT 5VRTN-1 4 VIO 6 IOT 5VRTN-5

3 7
VIO
MCU-PF PWB
J521 J1 P1
2 4
VIO

J536 J350 3.20


2 VIO 3 USB HUB PWB

J1343
4 VIO 2 BP PWB

6675/7775

CE8 J506 SUB LOW VOLTAGE 1.10


5 VIO VIO 2 POWER SUPPLY

To 7.2.3
IOT 1.8VRTN
P651 J651 P650 J650 J904 HUMAN ACCESS 2.14
To 7.2.4 2 2 2 DETECT (GEMINI)
VIO VIO VIO
IOT 2.5VRTN PWB

To 7.2.5
IOT 3.3VRTN

To 7.2.6
IOT AVREF RTN

To 7.2.10
IOT 5VRTN-3

j0se720009

7.2 Wirenets
7-9 Chapter 7 Wiring Data
7-10 Chapter 7 Wiring Data
7.2 Wirenets
7.2.10 IOT 5VRTN-3
MOTOR DRIVER MAIN
MOTOR DRIVER MAIN PWB PWB 2275/3373/3375/4475/5575
J523 P632 J632 J160 8.7
J414 J513 9.7 A1 5 4 GRY 3 REGI. SENSOR
From 7.2.9 BLU
IOT 5VRTN-2 A1 17 HVPS (BCR)
1
6675/7775
J523 P612 J612 P671 J671 J160 8.8
A1 VIO A12 A1 GRY 3 1 GRY 3 REGI. SENSOR

P612 J612 J180 9.23


J417 J461 HVPS 9.20 A9 A3 A10 GRY 3 POB SENSOR
A13 BLU 3 (1ST/2ND BTR) 2
J624 P624 J175 DUPLEX PATH 10.8
J415 P610 J610 J150 6.10 B5 GRY B8 B5 2 2 2 SENSOR
A3 BLU 2 TMA SENSOR IN BLU
B8 B8 3
J525 J243 FUSING UNIT DRIVE 10.1
J151 6.10 A7 2 MOTOR
A9 BLU B2 B14 2 TMA SENSOR OUT 2
J245 4.1
J154 TEMP AND 9.22 A15 BLU 2 MAIN DRIVE MOTOR
B2 GRY A14 A2 3 HUMIDITY SENSOR

P616 J616 J179 MSI FEED OUT 8.3


J153 9.22 B5 GRY 14 5 2 SENSOR
B8 GRY A8 A8 5 ADC SENSOR BLU

J172 MSI NO PAPER 7.12


J412 J144 1ST BTR CONT/RET 9.21 B8 GRY 11 8 2 SENSOR
A1 BLU 3 SENSOR BLU

J183 MSI NUDGER 7.12


J111 WASTE TONER 9.26 B15 GRY 2 17 BLU 2
A4 BLU 3 BOTTLE POSITION POSITION SENSOR
SENSOR
J526 J595 1.1
J110 WASTE TONER 9.26 11 BLU 3 POWER SWITCH
A7 BLU 3 BOTTLE FULL
SENSOR
J527 J241 DRUM/DEVE DRIVE 9.2
J431 DJ600 DP600 J193 P/R LATCH 10.2 A7 2 MOTOR (K)
5 B5 B5 2 SENSOR BLU
YEL BLU

J249 9.19
J194 FUSING UNIT BELT 10.1 B7 2 IBT DRIVE MOTOR
7 B3 B3 3 ROTATION SENSOR GRY
YEL WHT

J247 DRUM DRIVE 9.1


J192 FUSING UNIT EXIT 10.6 A15 2 MOTOR (Y,M,C)
11 YEL A9 A9 2 SENSOR BLU
BLU

J252 DEVE DRIVE MOTOR 9.9


B15 GRY 2 (Y,M,C)

NOTE: 2275/3373/3375 : BLU 2275/3373/3375 : BLU 3 2275/3373/3375 : GRY


1 4475/5575 : WHT 2 4475/5575 : BLU 4475/5575 : WHT To 7.2.11
6675/7775 : VIO 6675/7775 : VIO 6675/7775 : VIO IOT 5VRTN-4 j0se720010
7.2.11 IOT 5VRTN-4

From 7.2.10
IOT 5VRTN-3 MOTOR DRIVER
MAIN PWB

MOTOR DRIVER
MAIN PWB J532 J553 6.6
3 BLU
2 LPH REAR PWB (Y)

J528 P112 DRUM CRUM PWB 9.3


A1 4 (Y) J552 6.7
BLU 7 2 LPH REAR PWB (M)
BLU

P113 DRUM CRUM PWB 9.3


A5 4 (M) J551 6.8
BLU 11 BLU 2 LPH REAR PWB (C)

P114 DRUM CRUM PWB 9.4


A9 4 (C) J550 6.9
BLU 15 BLU 2 LPH REAR PWB (K)

P115 DRUM CRUM PWB 9.4


A13 BLU 4 (K) 4475/5575/6675/7775
J537 P618 J618 J171 TRAY 1 PRE FEED 8.1
1 WHT
3 1 BLU
3 SENSOR
P611 J611 J177 TRAY 1 NUDGER 7.8
B6 GRY
5 6 BLU
2 LEVEL SENSOR

J178 TRAY 1 NO PAPER 7.8 LPH REAR 6.9


B9 GRY
2 9 2 SENSOR PWB (K)
BLU
J554 J558
1,4,23,28 1,6,25,28

J633 J124 9.11


B16 GRY 1 1 ATC SENSOR (Y) LPH REAR 6.8
PWB (C)
J555 J559
J125 9.12 1,4,23,28 1,6,25,28
1 ATC SENSOR (M)

J126 9.13 LPH REAR 6.7


1 ATC SENSOR (C) PWB (Y)
J556 J560
1,4,23,28 1,6,25,28
J127 9.14
1 ATC SENSOR (K)

LPH REAR 6.6


PWB (M)
J557 J561
1,4,23,28 1,6,25,28

J593 DP800 P800


2 2 HCF
VIO

j0se720011

7.2 Wirenets
7-11 Chapter 7 Wiring Data
7-12 Chapter 7 Wiring Data
7.2 Wirenets
7.2.12 IOT 5VRTN-5

MOTOR DRIVER SUB PWB

J522 P631 J631 J165 EXIT 2 OCT HOME 10.9


From 7.2.9
IOT 5VRTN-2 A12 BLU A4 A12 BLU 2 POSITION SENSOR

J164 10.10
B9 B5 B11 2 EXIT 2 SENSOR
1 1
J640 P640 J163 EXIT 1 FULL STACK 10.7
B14 2 2 2 SENSOR
1 2
J524 J162 EXIT 1 OCT HOME 10.7
8 BLU
2 POSITION SENSOR

J590 3.8
11 FINISHER
NOTE:
1 2275/3373/3375 : GRY
TRAY MODULE PWB 4475/5575 : WHT
5575/6675 : VIO
J592 J541 To 7.2.13
B4 11 2 2275/3373/3375 : GRY
VIO IOT 5VRTN-6 4475/5575 : BLU
5575/6675 : BLU

OPTION
DC POWER
SUPPLY
(F503)
P904 J904 J651 J651 J910 34.1
A8 VIO 2 3 4 4 FAX PWB
VIO VIO

To 7.2.5
IOT 3.3VRTN

J904 J352 34.2


2 4 FAX mini PWB
VIO

j0se720012
7.2.13 IOT 5VRTN-6

TRAY MODULE PWB


OPTION
J545 P669 J669 J107 TRAY 2 NUDGER 7.9
From 7.2.12 J904 J352 34.2
IOT 5VRTN-5 2 VIO
8 2 GRY 2 LEVEL SENSOR TRAY MODULE PWB 6 2 FAX mini PWB
VIO

J106 TRAY 2 NO PAPER 7.9


5 VIO
5 5 GRY 2 SENSOR
J542 P904 J904 J910 34.1
4 6 2 FAX PWB
TTM-6675/7775 VIO VIO
J105 TRAY 2 PRE FEED 8.1
7 VIO
3 7 GRY 3 SENSOR
TTM
J549 P676 J676 J116 FEED OUT SENSOR 8.6
3TM A1 12 1 3 4
VIO BRN
J548 P673 J673 J115 TRAY 4 NUDGER 7.11
2 VIO
8 2 GRY 2 LEVEL SENSOR
3TM
J114 TRAY 4 NO PAPER 7.11 J549 P674 J674 J116 FEED OUT SENSOR 8.6
5 VIO
5 5 GRY 2 SENSOR A1 VIO
3 1 BRN 3 4

TTM P672 J672 J112 FEED OUT SENSOR 8.6


A4 VIO
3 1 BRN 3 3
P676 J676 P673 J673 J115 TRAY 4 NUDGER 7.11
2 VIO
8 5 GRY 8 2 GRY 2 LEVEL SENSOR
J108 FEED OUT SENSOR 8.6
A8 VIO
2 2
J114 TRAY 4 NO PAPER 7.11
5 VIO
5 8 GRY 5 5 GRY 2 SENSOR
P668 J668 J104 TM L/H COVER 1.13
A12 VIO 1 2 BRN 1 INTERLOCK SWITCH
J113 TRAY 4 PRE FEED 8.2
7 VIO
3 10 GRY 3 7 GRY 3 SENSOR
J103 TRAY 4 PAPER SIZE 7.5
B2 VIO
3 SENSOR
7.6
P671 J671 J111 TRAY 3 NUDGER 7.10
11 VIO
8 2 GRY 2 LEVEL SENSOR
J102 TRAY 3 PAPER SIZE 7.3
B6 VIO
3 SENSOR
7.4
J110 TRAY 3 NO PAPER 7.10
14 VIO
5 5 GRY 2 SENSOR
J101 TRAY 2 PAPER SIZE 7.2
B10 VIO 3 SENSOR
TTM
J109 TRAY 3 PRE FEED 8.2
16 VIO
3 7 GRY 3 SENSOR

j0se720013

7.2 Wirenets
7-13 Chapter 7 Wiring Data
7-14 Chapter 7 Wiring Data
7.2 Wirenets
7.2.14 IOT +24VDC-1

S104
S104 UI I/F PWB
J1 F1 J19 2.10
3 1,3,5 S104 LCD MODULE
140mA

27

MAIN LOW VOLTAGE POWER SUPPLY


ESS PWB BP PWB
1
1
F1103
A F501 W90
0.75A N.C
1 1A W90 UI I/F PWB W90 LCD 2.4
24 LCD MODULE
J502 J300 F202 P309 J309 F601 J1311 J1 F1 J7 CN1 49-50
3 A8 1 3 3 ↓ 49-50
ORN 0.75A 0.2A 12
1
2 27 27

L/H COVER 1.12 MOTOR FRONT 1.12 MOTOR


INTERLOCK DRIVER MAIN COVER DRIVER MAIN
MOTOR DRIVER MAIN PWB SWITCH PWB INTERLOCK PWB
SWITCH

ON/ +24VDC J510 J520 ON/ J534 J100 J102 J534 J521 J101 J101 J521 J526
OFF SQ 4 ORN
8 OFF 1 ORN
1 1 ORN
2 1 ORN
B2 A2 ORN 2 15 BLU

1
F3 To 7.2.17
5A IOT +24VDC-4

ACCESSORY/ 1.2 MAIN LOW VOLTAGE POWER SUPPLY


HEATER
RELAY PWB MOTOR DRIVER MAIN
J503 J90 PWB
1 ORN
1
J510 J520 To 7.2.16
A 3 ORN
4 IOT +24VDC-3
2275/3373/3375/4475/5575
SHORTING ESS PWB DARTS3 PWB
PLUG
J502 SJ1 SJ1 J300 P322 J322
F201 1-3, 6 ORN
5
4 ORN 2 1 ORN A1 81-83

DC COM
J503
IIT TRANS PWB 5
J700 P700 J720 BLU
3 3 2 NOTE:
ORN ORN

1 Chip Fuse
DC COM
6675/7775
J502
4 N.C
j0se720014
7.2.15 IOT +24VDC-2

6675/7775

SUB LOW VOLTAGE POWER


SUPPLY
IIT TRANS
PWB

+24VDC J505 J700 P700 J720


1 3 2
SQ ORN ORN

NOTE:
J300
2 ORN
A1 ESS PWB 1 Chip Fuse

j0se720015

7.2 Wirenets
7-15 Chapter 7 Wiring Data
7-16 Chapter 7 Wiring Data
7.2 Wirenets
7.2.16 IOT +24VDC-3
MOTOR DRIVER SUB PWB
MOTOR DRIVER MAIN PWB
1
J540 J539 F2 J522 P631 J631 J266 10.9
From 7.2.14
IOT 24VDC-1 3 ORN 3 A3 BLU A13 A3 BLU 4
2A
EXIT 2 OCT MOTOR
1
F11 J414 J513 9.7 A4 BLU A12 A4 3
A17 1 HVPS (BCR) BLU
4A
2 1
F3 P262 J262 EXIT GATE 10.7
J417 J514 9.11 N.C A7 BLU A9 A7 BLU 2 1
B11 GRY 1 HVPS (DEVE) 4A SOLENOID

OPTION
J461 HVPS (1ST/2ND 9.20 J263 P263 FACE UP GATE 10.10
A15 BLU 1 BTR) A9 BLU A7 A9 BLU 2 1 SOLENOID
1
F10
N.C J524 J271 10.7
2A 3 4
BLU

OPTION EXIT 1 OCT MOTOR


1
F13 J523 P635 J635 J450 9.29 4 3
B13 GRY 5 1 5 LH FAN PWB BLU
4A GRY

1
F14 J535 J244 4.1
1 ORN 1 MAIN DRIVE MOTOR
6.3A

J242 FUSING UNIT DRIVE 10.1


3 ORN 1 MOTOR
1 NOTE:
F15 J526 J240 DRUM/DEVE DRIVE 9.2 1 Chip Fuse
1 ORN 1 MOTOR (K)
6.3A
2275/3373/3375 : BLU
2 4475/5575 : WHT
J246 DRUM DRIVE 9.1 6675/7775 : VIO
3 ORN 1 MOTOR (Y,M,C)

J248 9.19
5 ORN 1 IBT DRIVE MOTOR

J251 DEVE DRIVE MOTOR 9.9


7 ORN 1 (Y,M,C)

j0se720016
7.2.17 IOT +24VDC-4
OPTION
J904 J352 34.2
3 5 FAX mini PWB
ORN

TRAY MODULE PWB

J542 P904 J904 J910 34.1


1 3 5 FAX PWB
ORN ORN

MOTOR DRIVER MAIN PWB MOTOR


DRIVER SUB
PWB
1
J540 J539 J592 J541 F4 J551 J224 8.5
From 7.2.14 1 1 B2 ORN 10 5 2
IOT +24VDC-1 ORN 3.15A ORN
TM TAKE AWAY
MOTOR 1
6 ORN 5

1
F8 J552 J226 8.5
5 ORN 2 NOTE:
3.15A TM TAKE AWAY
MOTOR 2 1 Chip Fuse
6 ORN 5
1
F1
N.C
3.15A

j0se720017

7.2 Wirenets
7-17 Chapter 7 Wiring Data
7-18 Chapter 7 Wiring Data
7.2 Wirenets
7.2.18 IOT 24VRTN-1
MAIN LOW VOLTAGE POWER 6675/7775
SUPPLY
ESS PWB
SUB LOW VOLTAGE POWER
SUPPLY
J502 J300
1 VIO
B8

ACCESSORY/ 1.2 IIT TRANS PWB


HEATER RELAY
PWB J505 J700 P700 J720
J503 J90 24VRTN 1 To 7.2.21
3 VIO VIO
1 IIT 3.3VRTN
24VRTN 2 2
VIO

To 7.2.22
MOTOR DRIVER MAIN PWB IIT ANA3.3VRTN

J510 J520 To 7.2.19 To 7.2.23


1 3
VIO IOT 24VRTN-2 IIT 5VRTN

To 7.2.24
2 VIO
9 IIT ANA10VRTN

5 10 To 7.2.25
VIO IIT 24VRTN
6675/7775
J502
2 N.C J300
4 VIO
B1 ESS PWB

2275/3373/3375/4475/5575
SHORTING
PLUG
J502 SJ1 SJ1 J300
2 VIO 6 5 VIO B1 ESS PWB

IIT TRANS PWB


J700 P700 J720 To 7.2.21
7 1 1
VIO VIO IIT 3.3VRTN

To 7.2.22
IIT ANA3.3VRTN

To 7.2.23
IIT 5VRTN

To 7.2.24
IIT ANA10VRTN

To 7.2.25
IIT 24VRTN

j0se720018
7.2.19 IOT 24VRTN-2
MOTOR DRIVER MAIN
MOTOR DRIVER MAIN PWB PWB

J412 J511 AC POWER SUPPLY 1.1


From 7.2.18
IOT 24VRTN-1 B2 1 H
2 J417 J514 9.11
B10 GRY 2 HVPS (DEVE)
J530 10.4
B6 4 IH DRIVER PWB
2 J461 9.20
HVPS
A14 BLU 2 (1ST/2ND BTR)
6675/7775
J225 P225 10.5
B13 VIO 2 4 IH EXHAUST FAN J523 P612 J612 P170 J170 10.8
B12 GRY B1 B12 VIO 2 DC HEATER

OPTION
J414 J513 9.7
A16 2 HVPS (BCR) P635 J635 J450 9.29
1 B17 GRY 1 5 GRY
1 LH FAN PWB

J278 P278 9.15


B3 GRY 1 4 RH FAN

J526 J251 DEVE DRIVE MOTOR 9.9


4475/5575/6675/7775 8 2 (Y,M,C)
VIO
J231 P231 9.10
B13 GRY 1 4 SUCTION FAN
J248 9.19
6 VIO
2 IBT DRIVE MOTOR
J235 P235 9.10
B7 GRY 1 5 MARKING FAN
4 J240 9.2
DRUM/DEVE DRIVE
2 VIO
2 MOTOR (K)
2275/3373/3375
J235 P235 9.10 J246 DRUM DRIVE 9.1
B7 GRY 1 5 HV FAN 4 2 MOTOR (Y,M,C)
VIO

J234 P234 9.28


B10 GRY 1 4 REAR BOTTOM FAN
To 7.2.20 NOTE:
IOT 24VRTN-3 2275/3373/3375 : BLU
4475/5575/6675/7775 1 4475/5575 : WHT
J416 J619 P619 9.18 6675/7775 : VIO
5 1 8 CARTRIDGE FAN
3 2275/3373/3375 : GRY
2 4475/5575 : GRY
J238 P238 9.27 6675/7775 : VIO
9 1 4 PROCESS 2 FAN
VIO
3 4475/5575 : WHT
6675/7775 : VIO

4 6675/7775 : Pin 2/4

j0se720019

7.2 Wirenets
7-19 Chapter 7 Wiring Data
7-20 Chapter 7 Wiring Data
7.2 Wirenets
7.2.20 IOT 24VRTN-3
From 7.2.19
IOT 24VRTN-2

MOTOR DRIVER MAIN


PWB
2575/3373/3375/4475/5575
J535 J244 4.1
2 VIO
2 MAIN DRIVE MOTOR

J242 FUSING UNIT DRIVE 10.1 NOTE:


4 VIO
2 MOTOR
2275/3373/3375 : BLU
1 4475/5575 : WHT
4475/5575/6675/7775
J537 J228 P228 9.27
6 1 4 PROCESS 1 FAN
WHT

MOTOR DRIVER
SUB PWB
J540 J539 J524 J230 P230 10.6
2 2 12 BLU 1 4 FUSING UNIT FAN
VIO

J529 J277 P277 1.11


4 4 B12 GRY 1 4 LVPS FAN
VIO

J226 P226 10.5


6 6 A15 BLU 1 4 IH INTAKE FAN
VIO

4475/5575/6675/7775
J227 P227 4.2
B15 GRY 1 4 C EXHAUST FAN

J591
3 FINISHER

TRAY
MODULE
PWB OPTION
J592 J541 J542 P904 J904 J910 34.1
B1 9 2 4 6 FAX PWB
VIO VIO VIO

J904 J352 34.2


J593 DP800 DJ800 4 6 FAX mini PWB
3 4 HCF VIO
VIO

j0se720020
7.2.21 IIT 3.3VRTN

P710 J700 6.4


From 7.2.18 14 37 CCD PWB
IOT 24VRTN-1

j0se720021

7.2 Wirenets
7-21 Chapter 7 Wiring Data
7-22 Chapter 7 Wiring Data
7.2 Wirenets
7.2.22 IIT ANA3.3VRTN

P710 J700 6.4


From 7.2.18 10 41
IOT 24VRTN-1
CCD PWB

11 40

j0se720022
7.2.23 IIT 5VRTN

IIT TRANS PWB CCD PWB 6.4


P710 J700

From 7.2.18 49,46,43,40, 2,5,8,11,14,


IOT 24VRTN-1 37,34,31,28, 17,20,23,30,
21,19,6,5 32,45,46

J722 J771 6.1


1 VIO
3 APS SENSOR 1

J773 6.3
8 VIO
2 IIT REGI. SENSOR

J774 PLATEN ANGLE 6.1


11 VIO
2 SENSOR

P775 J775 PLATEN INTERLOCK 6.1


14 VIO
1 2 SWITCH

DADF PWB

P750 J752 To 7.2.26


30 A3
DADF 5VRTN (DADF-110)
To 7.2.27
J751 DADF 5VRTN (DADF-130(1PASS))
31 1

BP PWB

J7192 J390
1,7,13,15, 40,34,28,26,
37,39,26, GRY
4,2,15,
24,16,14 17,25,27,

J7191 J336
50,47,44,41, 2,5,8,11,14,
38,35,32,31, 17,20,21,22,
30,29,26,23, 23,26,29,30
22

j0se720023

7.2 Wirenets
7-23 Chapter 7 Wiring Data
7-24 Chapter 7 Wiring Data
7.2 Wirenets
7.2.24 IIT ANA10VRTN

P710 J700 6.4


From 7.2.18 2 49 CCD PWB
IOT 24VRTN-1

j0se720024
7.2.25 IIT 24VRTN

J723 J1 6.2
From 7.2.18 1 1
IOT 24VRTN-1

3 3
LED LAMP PWB

4 4

14 14

To. 7.2.28
DADF 24VRTN

j0se720025

7.2 Wirenets
7-25 Chapter 7 Wiring Data
7-26 Chapter 7 Wiring Data
7.2 Wirenets
7.2.26 DADF 5VRTN (DADF-110)

DADF PWB

J756 J761 5.2


From 7.2.23 1 3 DOC. TRAY SIZE
SENSOR 1
IIT 5VRTN YEL

J764 5.2
4 3 DOC. TRAY SIZE
YEL SENSOR 2

J762 DOC. TRAY SET 5.2


7 3 GUIDE SENSOR 3
YEL

J763 5.2
10 3 DOC. TRAY SET
GUIDE SENSOR 2
YEL

J765 DOC. TRAY SET 5.2


13 3 GUIDE SENSOR 1
YEL

J791 5.1
16 2 DADF DOCUMENT
SET LED
YEL

19 SHORTING
YEL WIRE

J757 J771 5.1


1 3 DADF DOCUMENT
SET SENSOR
YEL

J772 5.3
4 3 DADF FEED OUT
YEL SENSOR

J770 P770 J773 DADF INVERT 5.5


7 9 1 3 SENSOR
YEL YEL

J774 5.3
10 6 4 3 DADF PRE REGI.
YEL YEL SENSOR

J775 DADF REGI. 5.5


13 3 7 3 SENSOR
YEL YEL

J758 SHORTING
1 WIRE
YEL

J766 P766 J767 5.4


3 10 1 3 DADF
3
APS SENSOR
YEL YEL

J768 5.4
6 7 4 3 DADF APS SENSOR
YEL YEL 2

J769 5.4
9 4 7 3 DADF
1
APS SENSOR
YEL YEL
j0se720026
7.2.27 DADF 5VRTN (DADF-130(1PASS))
DADF PWB
DADF PWB
J756 J762 DOC. TRAY SIZE 5.9
From 7.2.23 1
IIT 5VRTN YEL 3 SENSOR 1
J758 P779 J779 J780 DADF FEED OUT 5.10
1 YEL 6 1 YEL 3 SENSOR
J763 DOC. TRAY SIZE 5.9
4 3 SENSOR 2
YEL
J781 DADF FEED IN 5.10
4 3 4 3 SENSOR
J764 5.9 YEL YEL
DOC. TRAY SET
7 3 GUIDE SENSOR 3
YEL
P777 J777 J778 5.16
7 3 1 3 DADF EXIT SENSOR
J765 5.9 YEL YEL
10 DOC. TRAY SET
YEL 3 GUIDE SENSOR 2
J775 DADF DOCUMENT 5.8
13 3 SET SENSOR
J766 5.9 YEL
DOC. TRAY SET
13 3 GUIDE SENSOR 1
YEL

J791 DADF DOCUMENT 5.8


16 2 SET LED
YEL

J757 J768 DADF APS SENSOR 5.11


1 YEL 3 3

J769 DADF APS SENSOR 5.11


4 3 2
YEL

J770 DADF APS SENSOR 5.11


7 3 1
YEL

J772 DADF REGI. 5.13


11 3 SENSOR
YEL

J773 5.16
14 3 DADF OUT SENSOR
YEL

J774 DADF PRE REGI. 5.12


17 YEL 3 SENSOR

j0se720027

7.2 Wirenets
7-27 Chapter 7 Wiring Data
7-28 Chapter 7 Wiring Data
7.2 Wirenets
7.2.28 DADF 24VRTN

IIT TRANS PWB DADF PWB

From 7.2.25 P750 J752


19 A9
IIT 24RTN

20 A8

21 A7

22 A6

23 B5

24 B6

25 B7

26 B8

27 B9

j0se720028
7.3 BSD
7.3 BSD (Block Schematic Diagram) 2.6 W90 FAX Control Panel Switches (1/2) ........................................................................................................... 24
2.7 W90 FAX Control Panel Switches (2/2) ........................................................................................................... 25
Contents
2.8 S104 UI Switches (Option) ..................................................................................................................................... 26
7.3.1 Preface ................................................................................................................................................................ 1
2.9 S104 UI LED (Option) ............................................................................................................................................... 27
7.3.1.1 How to Use the BSDs ..................................................................................................................... 1
2.10 S104 LCD Control (Option) ................................................................................................................................. 28
7.3.1.2 Explanation of Symbols ................................................................................................................. 1 2.11 S104 Touch Panel and UI LED (Option) ......................................................................................................... 29
7.3.1.3 Signal Name ......................................................................................................................................... 2 2.12 Human Motion Detection ...................................................................................................................................... 30
7.3.1.4 DC Voltage ............................................................................................................................................ 2 2.13 Human Motion Detection (Option) (1/2) ........................................................................................................ 31
7.3.1.5 Other Descriptions ............................................................................................................................ 2 2.14 Human Motion Detection (Option) (2/2) ........................................................................................................ 32
7.3.2 BSD (Block Schematic Diagram) ...................................................................................................... 3 Chain 3 Machine Run Control ...................................................................................................................... 33
Chain 1 Standby Power ..................................................................................................................................... 3 3.1 PWBs Communication (ESS-IIT).......................................................................................................................... 33
1.1a Main Power ON (1/2) (for 2275/3373/3375/4475/5575 and 6675/7775-200 to 240V 3.2 PWBs Communication (ESS - DADF-110) ...................................................................................................... 34
Model) ....................................................................................................................................................................................... 3 3.3 PWBs Communication (ESS - DADF-130 (1Pass)) ..................................................................................... 35
1.1b Main Power ON (2/2) (for 6675/7775-100 to 110V Model) ............................................................... 4 3.4 PWBs Communication (ESS-UI)........................................................................................................................... 36
1.2 Main Power ON (2/2) ............................................................................................................................................... 5 3.5 PWBs Communication (ESS - MCU-PF) .......................................................................................................... 37
1.3 M/C Power Control .................................................................................................................................................... 6 3.6 PWBs Communication (MCU-PF - Motor Driver Main PWB) .................................................................. 38
1.4 DC Power Generation (1/7) .................................................................................................................................. 7 3.7 PWBs Communication (MCU-PF - Tray Module PWB).............................................................................. 39
1.5 DC Power Generation (2/7) .................................................................................................................................. 8 3.8 PWBs Communication (MCU-PF - Finisher) .................................................................................................. 40
1.6 DC Power Generation (3/7) .................................................................................................................................. 9 3.9 PWBs Communication (MCU-PF - HCF) ......................................................................................................... 41
1.7 DC Power Generation (4/7) ............................................................................................................................... 10 3.10 Poor Cable Connection.......................................................................................................................................... 42
1.8 DC Power Generation (5/7) ............................................................................................................................... 11 3.11 PWB Detection .......................................................................................................................................................... 43
1.9 DC Power Generation (6/7) ............................................................................................................................... 12 3.12 Accessory (1/9) (FX Only) ................................................................................................................................... 44
1.10 DC Power Generation (7/7) (6675/7775) ................................................................................................ 13 3.13 Accessory (2/9) (FX Only) ................................................................................................................................... 45
1.11 LVPS Cooling .......................................................................................................................................................... 14 3.14 Accessory (3/9) (FX Only) ................................................................................................................................... 46
1.12 Interlock Switching (1/2) ................................................................................................................................... 15 3.15 Accessory (4/9) (FX Only) ................................................................................................................................... 47
1.13 Interlock Switching (2/2) ................................................................................................................................... 16 3.16 Accessory (5/9) (FX Only) ................................................................................................................................... 48
1.14 PWBs Fuse Status ............................................................................................................................................... 17 3.17 Accessory (6/9) (FX Only) ................................................................................................................................... 49
1.15 PWB Location ......................................................................................................................................................... 18 3.18 Accessory (7/9) (FX Only) ................................................................................................................................... 50
Chain 2 Mode Selection ...................................................................................................................................19 3.19 Accessory (8/9) ........................................................................................................................................................ 51
2.1 W90 Control Panel Switches (1/2) ................................................................................................................. 19 3.20 Accessory (9/9) ........................................................................................................................................................ 52
2.2 W90 Control Panel Switches (2/2) ................................................................................................................. 20 3.21 Eslectric Billing ......................................................................................................................................................... 53
2.3 W90 Control Panel LEDs ......................................................................................................................................... 21 Chain 4 Start Print Power ............................................................................................................................. 54
2.4 W90 LCD Control .................................................................................................................................................... 22 4.1 Main Drive Control (2275/3373/3375/4475/5575) ................................................................................. 54
2.5 W90 Touch Panel Control ....................................................................................................................................... 23 4.2 Drive Unit Cooling (4475/5575/6675/7775) ................................................................................................... 55

Contents
i 7.3 BSD
ii 7.3 BSD
Contents
Chain 5 Document Transportation..............................................................................................................56 7.4 Tray 3 Paper Size Sensing (TTM) ....................................................................................................................... 87
5.1 DADF Document Setting (DADF-110) ......................................................................................................... 56 7.5 Tray 4 Paper Size Sensing (3TM) ........................................................................................................................ 88
5.2 DADF Document Size Sensing (DADF-110) .................................................................................................. 57 7.6 Tray 4 Paper Size Sensing (TTM) ....................................................................................................................... 89
5.3 DADF Document Feeding (1/2) (DADF-110) ................................................................................................. 58 7.7 MSI Paper Size Sensing ........................................................................................................................................... 90
5.4 DADF Document Feeding (2/2) (DADF-110) ................................................................................................. 59 7.8 Tray 1 Paper Stacking .............................................................................................................................................. 91
5.5 DADF Document Scan and Invert (DADF-110) ............................................................................................ 60 7.9 Tray 2 Paper Stacking .............................................................................................................................................. 92
5.6 DADF Document Exit Transportation (DADF-110) ..................................................................................... 61 7.10 Tray 3 Paper Stacking............................................................................................................................................ 93
5.7 DADF Document Path and Drive Transmission (DADF-110).................................................................. 62 7.11 Tray 4 Paper Stacking............................................................................................................................................ 94
5.8 DADF Interlock & Document Setting (DADF-130 (1PASS)) ................................................................... 63 7.12 MSI Paper Stacking ................................................................................................................................................. 95
5.9 DADF Document Size Sensing (DADF-130 (1PASS)) ............................................................................... 64 7.13 Tray Heating (Option) (FX Only) ........................................................................................................................ 96
5.10 DADF Document Feeding (1/2) (DADF-130 (1PASS)) ........................................................................... 65 Chain 8 Paper Transportation .................................................................................................................. 97
5.11 DADF Document Feeding (2/2) (DADF-130 (1PASS)) ........................................................................... 66 8.1 Tray 1/2 Paper Pre Feeding............................................................................................................................... 97
5.12 DADF Pre Registration (DADF-130 (1PASS)) ............................................................................................ 67 8.2 Tray 3/4 Paper Pre Feeding .................................................................................................................................. 98
5.13 DADF Registration (DADF-130 (1PASS)) ..................................................................................................... 68 8.3 Tray 1 and MSI Paper Transportation (1/2) ................................................................................................... 99
5.14 DADF Document Scan (1/2) (DADF-130 (1PASS)) ................................................................................. 69 8.4 Tray 1 and MSI Paper Transportation (2/2) ................................................................................................ 100
5.15 DADF Document Scan (2/2) (DADF-130 (1PASS)) ................................................................................. 70 8.5 Tray Module Paper Transportation (1/2) ...................................................................................................... 101
5.16 DADF Document Exit (DADF-130 (1PASS)) ............................................................................................... 71 8.6 Tray Module Paper Transportation (2/2) ...................................................................................................... 102
5.17 Document Path & Drive Transmission (DADF-130 (1PASS)) .............................................................. 72 8.7 Registration (2275/3373/3375/4475/5575) ................................................................................................ 103
Chain 6 Imaging....................................................................................................................................................73 8.8 Registration (6675/7775)...................................................................................................................................... 104
6.1 Platen Document Sensing .................................................................................................................................. 73 8.9 Paper Path (2275/3373/3375-3TM) ............................................................................................................... 105
6.2 Document Illumination .............................................................................................................................................. 74 8.10 Paper Path (2275/3373/3375-TTM) ............................................................................................................ 106
6.3 Carriage Control.......................................................................................................................................................... 75 8.11 Paper Path (4475/5575-3TM) ......................................................................................................................... 107
6.4 Image Input (1/2) (ESS To CCD) ........................................................................................................................ 76 8.12 Paper Path (4475/5575-TTM)......................................................................................................................... 108
6.5 Image Input (2/2) (CCD To ESS) ........................................................................................................................ 77 8.13 Paper Path (6675/7775-TTM)......................................................................................................................... 109
6.6 LPH Control (Y) .......................................................................................................................................................... 78 Chain 9 Marking ................................................................................................................................................ 110
6.7 LPH Control (M) .......................................................................................................................................................... 79 9.1 Drum/Deve Drive Control (Y,M,C) ............................................................................................................... 110
6.8 LPH Control (C) .......................................................................................................................................................... 80 9.2 Drum/Deve Drive Control (K) ............................................................................................................................ 111
6.9 LPH Control (K) .......................................................................................................................................................... 81 9.3 Drum Life Control (Y,M) ........................................................................................................................................ 112
6.10 Image Registration Control .................................................................................................................................. 82 9.4 Drum Life Control (C,K) ........................................................................................................................................ 113
6.11 IIT Heating (Option) (FX Only) ........................................................................................................................... 83 9.5 Toner Cartridge Life Control (Y,M) .................................................................................................................. 114
Chain 7 Paper Supplying .................................................................................................................................84 9.6 Toner Cartridge Life Control (C,K) ................................................................................................................... 115
7.1 Tray 1 Paper Size Sensing ................................................................................................................................ 84 9.7 Charging and Exposure (1/2) .............................................................................................................................. 116
7.2 Tray 2 Paper Size Sensing ..................................................................................................................................... 85 9.8 Charging and Exposure (2/2) .............................................................................................................................. 117
7.3 Tray 3 Paper Size Sensing (3TM) ....................................................................................................................... 86 9.9 Deve Drive Control (Y,M,C) ................................................................................................................................. 118
9.10 Toner Suction Control & Marking Module Cooling................................................................................... 119 25.2 ESS Status LED (1/4) ...................................................................................................................................... 151
9.11 Development Y ........................................................................................................................................................ 120 25.3 ESS Status LED (2/4) ...................................................................................................................................... 152
9.12 Development M ....................................................................................................................................................... 121 25.4 ESS Status LED (3/4) ...................................................................................................................................... 153
9.13 Development C........................................................................................................................................................ 122 25.5 ESS Status LED (4/4) ...................................................................................................................................... 154
9.14 Development K ........................................................................................................................................................ 123 Chain 34 FAX ..................................................................................................................................................... 155
9.15 HVPS (Deve) Cooling (4475/5575/6675/7775) ........................................................................................ 124 34.1FAX (G4) (FX Only) ............................................................................................................................................ 155
9.16 Toner Dispense Control (Y,M) .......................................................................................................................... 125 34.2 FAX mini .................................................................................................................................................................. 156
9.17 Toner Dispense Control (C,K) .......................................................................................................................... 126
9.18 Toner Cartridge Cooling (4475/5575/6675/7775) .................................................................................. 127
9.19 IBT Belt Drive Control ......................................................................................................................................... 128
9.20 1st Transfer .............................................................................................................................................................. 129
9.21 1st BTR Contact Retract Control .................................................................................................................. 130
9.22 ADC Patch and Environment Sensing .......................................................................................................... 131
9.23 2nd Transfer ............................................................................................................................................................. 132
9.24 Drum Cleaning ......................................................................................................................................................... 133
9.25 2nd BTR Cleaning .................................................................................................................................................. 134
9.26 Waste Toner Disposal (1/2) .............................................................................................................................. 135
9.27 Waste Toner Disposal (2/2) .............................................................................................................................. 136
9.28 Rear Bottom Fan Control (4475/5575/6675/7775) ............................................................................... 137
9.29 LH Fan Control ....................................................................................................................................................... 138
9.30 IOT Heater Control (Option) (FX Only) ........................................................................................................ 139
Chain 10 Fusing And Paper Transportation......................................................................................... 140
10.1 Fusing Unit Drive Control (1/2) ................................................................................................................... 140
10.2 Fusing Unit Drive Control (2/2) ................................................................................................................... 141
10.3 Fusing Unit Heat Control (1/3) .................................................................................................................... 142
10.4 Fusing Unit Heat Control (2/3) .................................................................................................................... 143
10.5 Fusing Unit Heat Control (3/3) .................................................................................................................... 144
10.6 Fusing ....................................................................................................................................................................... 145
10.7 Paper Exit 1 ........................................................................................................................................................... 146
10.8 Duplex Transportation ...................................................................................................................................... 147
10.9 Paper Exit 2 (1/2) .................................................................................................................................................. 148
10.10 Paper Exit 2 (2/2) ............................................................................................................................................... 149
Chain 25 ESS..................................................................................................................................................... 150
25.1 ESS ............................................................................................................................................................................ 150

Contents
iii 7.3 BSD
7.3.1 Preface 1.3
Indicates where the input to a function originates. The
example indicates that the input originates from group
7.3.1.1 How to Use the BSDs function 3 of Chain 1 Indicates that a mechanical drive signal goes in the
direction indicated.
1. Enter the Chain specified in the Troubleshooting chapter.
2. Or enter the appropriate Chain, referring to the Contents. Indicates where the output from a function goes. The
6.1 Indicates Control Logic.
example indicates that the output goes to group function
3. Perform failure analysis in the Chain, using test data and
1 of chain 6.
the general procedures in the General chapter.
P11 J11
4. Once you have located the failure, go to the Parts List No.
1 2 Indicates a double plug connector.
2 1
and/or Adjustment No. indicated for reference on the A B Indicates that the signal line continues vertically.
BSD. A B
P11 J11
1 2 Indicates a drawer connector.
2 1
Warning Before installing or removing parts, switch off Indicates that the signal line continues horizontally.
the main power switch and disconnect the
power cord from the outlet to avoid possible
electric shocks or injuries. Indicates that the signal line goes to another zone in J880B
4 3
J880A
Indicates a shorting plug connector.
ZONE the same function. The example refers to zone E3.
E3
7.3.1.2 Explanation of Symbols 1

Indicates that the fasten is used for connection.


Indicates that the signal line goes back to another zone
Refers to the note that is usually on the same page. ZONE in the same function. The example refers to zone A4
1 A4
Indicates that an electrically conductive material such
as a leaf spring and a plate is used for connection.
Refers to test data that is usually on the same page Indicates that the signal line goes to a zone in another
TD when the voltage value shown on the BSD is different
1 CH8.5
ZN A2
sheet. The example refers to zone A2, CH8.5.
from the measured value.
Indicates that the symbol-pointed-to section has been
modified to code 1V.
Indicates that the signal line goes back to a zone in
Refers to the Parts List No. PL stands for Parts List. CH8.5
another sheet. The example refers to zone H4, CH8.5.
ZN H4
7.7 refers to the Plate No. PL No. indicates that the
Indicates the symbol-pointed-to section has not been
PL7.7 part is listed on the specified plate.
modified to code 1V.
PL No. is shown for all the replaceable parts on the Indicates a power line output from Chain 1.
BSDs. +5VDC
(1.2 J2)
Indicates that the whole figure or the framed illustration
Indicates frame ground. has information with 1V installed.
Refers to the adjustment item(s) in the Disassembly,
7.7.1 Assembly, and Adjustment chapter. 7.7.1 indicates that
the adjustment procedure is described under the 7.7.1 Indicates a twisted pair of wires.
section in the Disassembly, Assembly, and Adjustment
chapter.
Indicates that the signal goes from right to left, in the Indicates that the whole figure or the framed illustration
opposite direction to the normal direction. has information without 1V installed.
Indicates a variable register that is adjustable in the field.

TP1 Indicates a feedback signal.


Indicates a signal test point.

Indicates a mechanical connection to a part.

7.3.1 Preface
7-1 7.3 BSD
7-2 7.3 BSD
7.3.1 Preface

Indicates direction the air flows.


7.3.1.4 DC Voltage 7.3.1.5 Other Descriptions
Indicates switch and is also used as Interlock Switch. A measurement of DC voltage is made between the particular DC330 Input Component Voltage Level
test point and the frame unless otherwise specified by note
The voltage levels (H/L) shown on the BSDs are the levels that
and test data. The measured DC voltage is in the range
Indicates the Cheater type of Interlock Switch. are measured by the tester. Some of them are therefore
below: different from H/L displayed on the UI panel.
LVPS Voltage Level Range Wiring Color
Indicates the Chip Fuse. +5VDC
(H) +4.87~+5.33VDC Wires are distinguished by color in part of the BSDs for this
Main STBY model. The colors of wires are shown below the signal lines
Low +5VDC in their respective abbreviations listed below:
(H) +4.80~+5.30VDC
Voltage MAIN Abbreviation Color
7.3.1.3 Signal Name Power +24VDC SQ (H)
+23.37~ BRN BROWN
Signal name structure Supply INTLK
(H) +25.63VDC RED RED
・ Input component +24VDC
ORN ORANGE
PAPER SENSED (L) +5VDC YEL YELLOW
Operation state Logical value Voltage with signal (H) <6675/7775> GRN GREEN
The example indicates that when paper is sensed, this LVPS Voltage Level Range BLU BLUE
signal level is (L) and that otherwise, the signal level is (H) VIO VIOLET
with the voltage +5VDC. GRY GRAY
Sub Low
・ Output components Voltage +23.28~ WHT WHITE
+24VDC (H)
ON (L) +24VDC Power +25.73VDC BLK BLACK
Operation state Logical value Voltage with signal (H) Supply GRN/YEL GREEN/YELLOW
PNK PINK
SKY SKY
The example indicates that when the part is ON, the signal
level is (L) and that when it is OFF, the signal level is (H) with
the voltage +24VDC. Figures on the BSDs
The grayed-out portion of the figure shows the path from Motor
or Solenoid to parts to drive.
A B C D E F G H J
1.1a MAIN POWER ON (1/2) (for 2275/3373/3375/4475/5575 and 6675/7775-200 to 240V Model) ELECTRICAL COMPONENTS

AC POWER SUPPLY H
PL18.3
1 MAIN POWER
SWITCH
GFI (IOT) PL18.5
PL18.4 1 POWER ON ACH 1.4 Power Switch
J10 ACH J12 3 4 J13 J4 ACH J3 (MAIN LVPS)
1 BLK
1 1 BLK
1 1 BLK

POWER ON ACN 1.4


J11 ACN J14 1 2 J15 ACN (MAIN LVPS)
1 WHT
1 1 WHT
3 3 WHT

J88 6675/7775
2 1 GN/YL T80
POWER ON ACH 1.10
J5 (SUB LVPS)
8 BLK

POWER ON ACN 1.10


(SUB LVPS)
4 WHT

POWER ON ACH
(FINISHER)
5 BLK J85
J87 GN/YL GFI
3 POWER ON ACN T88
(FINISHER) J86
1 WHT

POWER ON ACH 1.2


(HEATER)
6 BLK

POWER ON ACN 1.2


(HEATER)
2 WHT
4
POWER ON ACH 10.4
J6 (FUSING UNIT)
2 BLK

POWER ON ACN 10.4


MOTOR DRIVER MAIN PWB (FUSING UNIT)
1 WHT
PL18.2
NOTE:
5 1 100V machine : 125V/25A
10.3 FUSING UNIT 200V machine : 250V/15A
RELAY ON(H) +24VDC J412 J511
B1 2
2 2 2275/3373/3375 : GRY
4475/5575: GRY
B2 1 6675/7775 : VIO
2
DC COM
(1.4 D4) POWER
SWITCH
PL18.5
6 POWER SWITCH 1.3
J526 J595 J595 ON(L) +3.3VDC
11 BLU 3 1 BLU
DC COM
(1.4 D4)
j0se730101a

Chain 1 Standby Power


7-3 7.3 BSD
7-4 7.3 BSD
Chain 1 Standby Power
A B C D E F G H J
1.1b MAIN POWER ON (2/2) (for 6675/7775-100 to 110V Model) ELECTRICAL COMPONENTS

AC POWER SUPPLY H
PL18.3
1 MAIN POWER
SWITCH
GFI (IOT) PL18.5
PL18.4 1 POWER ON ACH 1.4 Power Switch
J10 ACH J12 3 4 J13 J4 ACH J3 (MAIN LVPS)
1 BLK
1 1 BLK
1 1 BLK

POWER ON ACN 1.4


J11 ACN J14 1 2 J15 ACN (MAIN LVPS)
1 WHT
1 1 WHT
3 3 WHT

J88
2 1 GN/YL T80
POWER ON ACH 1.10
J5 (SUB LVPS)
8 BLK

POWER ON ACN 1.10


(SUB LVPS)
4 WHT

POWER ON ACH
(FINISHER)
5 BLK J85
J87 GN/YL
3 POWER ON ACN T88 GFI (IOT)
(FINISHER) J86
1 WHT

POWER ON ACH 1.2


(HEATER)
6 BLK

POWER ON ACN 1.2


(HEATER)
2 WHT
4 GFI (TRAY)
PL18.4 POWER ON ACH 10.4
J20 J645 P645 J7 J6 (FUSING UNIT)
1 2 2 2
BLK BLK BLK GFI (Tray)
POWER ON ACN 10.4
J21 (FUSING UNIT)
MOTOR DRIVER MAIN PWB 1 1 1 1
WHT WHT WHT
PL18.2
J90
1 GN/YL T80
5
10.3 FUSING UNIT
RELAY ON(H) +24VDC J412 J511
B1 VIO 2
NOTE:

B2 VIO 1 1 100V machine : 125V/25A


200V machine : 250V/15A
DC COM
(1.4 D4) POWER
SWITCH
PL18.5
6 POWER SWITCH 1.3
J526 J595 J595 ON(L) +3.3VDC
11 BLU 3 1 BLU
DC COM
(1.4 D4)
j0se730101b
A B C D E F G H J
1.2 MAIN POWER ON (2/2)
ELECTRICAL COMPONENTS
OPTION
1 ACCESSORY/HEATER
RELAY PWB OPTION
PL18.12 3.13 3.16 Accessory/
POWER ON ACH
3.18 Heater PWB
1.1 POWER ON ACH J92 (ACCESSORY)
(HEATER) J91 1
BLK
3 3.13 3.16
BLK BLK
POWER ON ACN
POWER ON ACN (ACCESSORY) 3.18
1.1 2
(HEATER) WHT
1
WHT WHT POWER SWITCH OFF ACH 6.11
2 J93 (IIT HEATER)
1
BLK
1.7 HEATER RELAY POWER SWITCH OFF ACN 6.11
(+24VDC SQ) +24VDC SQ J90 (IIT HEATER)
1 2
ORN ORN WHT
1.7 HEATER RELAY POWER SWITCH OFF ACH 7.13
(DC COM) DC COM J94 CE3 (TRAY HEATER)
2 1
VIO VIO BLK BLK
POWER SWITCH OFF ACH 9.30
(IOT HEATER)
BLK
3
POWER SWITCH OFF ACN 7.13
CE4 (TRAY HEATER)
2
WHT WHT
POWER SWITCH OFF ACN 9.30
(IOT HEATER)
WHT

j0se730102

Chain 1 Standby Power


7-5 7.3 BSD
7-6 7.3 BSD
Chain 1 Standby Power
A B C D E F G H J
1.3 M/C POWER CONTROL
MOTOR BP PWB ESS PWB BP PWB MOTOR DRIVER MAIN PWB
1 DRIVER PL18.2 PL35.2 PL18.2 PL18.2
MAIN PWB
PL18.2
+3.3VDC +3.3VDC SLEEP RECOVERY
POWER SWITCH (1.4 F1) ON(H) +3.3VDC
1.1 1.5
ON(L) +3.3VDC J526 P451 J451 J335 P335 P335 J335 J451 P451 J526 (MAIN LVPS)
12 B6 113 44 B5 13 BLU
BLU BLU
SLEEP 2.14
Energy Saver RECOVERY 6675/7775
button ON 1.9 SLEEP RECOVERY
ON(H) +3.3VDC 1.10
(SUB LVPS)
2 Print Job 16 BLU
/Incoming Fax HUMAN SNR BLU
1.9
POWER ON
129
Human Sensor DADF SNR 1.9
POWER ON
128
+3.3VDC
(1.4 F1)
1.6
FAX POWER ON
126 B3
3 +3.3VDC
(1.4 F1)
1.4
FAX STBY 5V ON
43 A6
+3.3VDC
(1.4 F1) IOT POWER ON 1.6
(+5VDC)
56 B4
DC COM IOT POWER ON 1.6
(LPH +5VDC)
4
IOT POWER ON 1.6
(MCU +5VDC)

DC COM IOT POWER ON 1.8


(HCF +24VDC)

IOT POWER ON 1.8


(+24VDC) MCU-PF PWB
PL18.2
5
P1 J1
116

DC COM

j0se730103
A B C D E F G H J
1.4 DC POWER GENERATION (1/7)
ESS PWB BP PWB
MAIN LOW VOLTAGE POWER PL35.2 PL18.2
SUPPLY (1/3) +2.5VDC
1 +5VDC ALL +3.3VDC
PL18.3 TO P309 J309 ALL
2.5VDC 79
DC POWER +5VDC IPS
ALL SDPWR
GENERATOR +3.3VDC +3.3VDC +3.3VDC
1.1 POWER ON ACH +5VDC +3.3VDC
ALL ALL
(MAIN LVPS) J1 J501 STBY J300 +5VDC ALL F1301 139
5 +5VDC 9 B3 TO UI
BLK GRY 3.3VDC RBT IPS +5VDC
S +3.3VDC CR201 +3.3VDC ALL
1.1 POWER ON ACN +5VDC
STBY G D ALL ORN 81,82
(MAIN LVPS) FET
WHT
8 8 GRY
B4 F1102 DC COM
HDD UI
CIE +5VDC ALL
2 4A S +5VDC
ALL S +3.3VDC DC COM 2
G D G D ALL
1 FET FET +5VDC
DC COM DC COM
ALL ALL
DC COM F1104 EPSV IPS 72,73
RETURN 4 A3 +5VDC +3.3VDC CR208
VIO 0.75A S S
G D ALL G D ALL YEL +5VDC P335 J335
1 FET FET 54
DC COM
3 VIO
A4 F1201
UI CR203 DC COM 48 N.C CONT
+5VDC +3.3VDC
S YEL ALL
ALL +3.3VDC
1 G D 51
FET
3
DC COM RBT
+3.3VDC 2
DC COM DC COM

MOTOR DRIVER MAIN PWB


PL18.2 +5VDC 6675/7775
STBY
+5VDC ALL +5VDC STBY 1.10
J509 STBY J521 F21 J536 CE7 (SUB LVPS)
6 GRY
3 6 GRY GRY
3.15A
4 DC COM 1 +5VDC STBY
ALL
2.14
DC COM (HAD PWB)
2 VIO
4 GRY
6675/7775
+5VDC DC COM 1.10
STBY CE8 (SUB LVPS)
5 VIO VIO
DC COM DC COM
DC COM 2.14
(HAD PWB)
5 VIO
FAX MOTOR DRIVER SUB
NOTE: STBY 5V PWB PL18.2 34.1
1.3 FAX STBY S ALL FAX STBY
1 Chip Fuse 5V ON G D F17 P452 J452 J592 +5VDC 34.2
FET 55-57 B8
3.15A GRY
2 For the actual pin numbers, see Wire Net. 34.1
1 35-37, DC COM DC COM
1-8, ALL (STBY 5V RTN) 34.2
52-54, A8 VIO
DC COM
98
6
+3.3VDC
FUSE 17 1.14
FUSE STATUS

j0se730104

Chain 1 Standby Power


7-7 7.3 BSD
7-8 7.3 BSD
Chain 1 Standby Power
A B C D E F G H J
1.5 DC POWER GENERATION (2/7)

1 MAIN LOW VOLTAGE


POWER SUPPLY (2/3) DC COM
PL18.3 1
ESS PWB
+5VDC PL35.2
STBY
OPT
+5VDC
J501 +5VDC MAIN J300 ALL
SLEEP RECOVERY 7 B5
ON(H) +3.3VDC GRY
1.3
(MAIN LVPS) J503 ON/
BLU
3 OFF CR204
+5VDC MAIN ORN
2 6 GRY
B6
ON/OFF 1.7
SIGNAL
DC COM
DC COM
2 VIO
A5

DC COM
1 VIO
A6
DC COM
3

+5VDC MAIN 1.6


J509 (J520-1)
8 GRY GRY

+5VDC MAIN 1.6


(J520-2)
4 7 GRY GRY

DC COM 1.6
(J520-6)
4 VIO VIO

DC COM 1.6
(J520-7)
3 VIO VIO

NOTE:
・Over-voltage Protection: If one of the outputs reaches its over-voltage listed below,
1 ・Short Protection (Over-current Protection) all outputs are cut off. 2 ON : High Speed
OFF : Low Speed
Voltage Output Status at Shorting Recovery Requirements Over Voltage Value
Voltage Recovery Requirements
Detected
+5VDC STBY
All outputs are cut off. +5VDC STBY
+5VDC MAIN To restore them, repair 6~8V
6 the short circuit, power +5VDC MAIN Confirm that no damage has been incurred,
+24VDC SQ off, allow 15 sec, and then power off, allow 15 sec, and then power on.
・+5VDC STBY is normal. +24VDC SQ
・+5VDC MAIN, +24VDC SQ, and +24VDC INTLK are cut power on. 26.7~32V
+24VDC INTLK off. +24VDC INTLK
j0se730105
A B C D E F G H J
1.6 DC POWER GENERATION (3/7)
NOTE:
MOTOR DRIVER MAIN PWB
PL18.2 1 Chip Fuse
1 +5VDC
J536
3.20
MAIN +5VDC MAIN
1 ALL 1
+5VDC MAIN GRY GRY
1.5
(J520-1) J520 F19 +5VDC 3.20
GRY
1 MAIN DC COM
FAX 2 VIO VIO
FAX PWR
1.3 POWER S +5VDC DC COM
ON G D ALL
FET BP PWB
PL18.2
+5VDC USB
2 ALL +5VDC
J1343 ALL
IOT +3.3VDC AVREF 3 1
POWER ON ALL GRY
1.3 S +3.3VDC +3.3VDC
(+5VDC) G D TO ALL +5VDC
FET AVREF MAIN
+5VDC 4 2
ON/ TO +3.3VDC VIO
OFF +3.3VDC DC COM DC COM
MCU
CRUM +3.3VDC
+2.5VDC P451 J451 ALL
MOB ALL A3
+5VDC +5VDC +3.3VDC
3 TO ALL TO +3.3VDC
MOB ON/ CRUM MOTOR DRIVER
+5VDC OFF +2.5VDC SUB PWB
PL18.2 TRAY MODULE PWB
PL10.10/11.17/12.5
+3.3VDC
P452 J452 ALL 1
11,12 +5VDC
FAX PWR F7 ALL 34.1
1 +5VDC +3.3VDC +5VDC +5VDC
1.5 +5VDC MAIN FUSE 22 1.14 ALL J592 +5VDCJ541 1A J542 (FAX) 34.2
(J520-2) F22 FUSE STATUS 9,10 B5 GRY 12 3 GRY
4 GRY
2
5.0A 34.1
FAX PWR +5VDC
+5VDC ALL DC COM
IOT LPH LPH DC COM (5V RTN) 34.2
POWER ON +5VDC LPH +1.8VDC 73,74,75 DC COM ALL 4
1.3 S
+5VDC VIO
(LPH +5VDC) G D ALL ALL B4 VIO 11
FET TO +5VDC DC COM
LPH DC COM
+1.8VDC
MCU-PF PWB MOTOR DRIVER
+5VDC PL18.2 MAIN PWB
STBY
IOT POWER ON PL18.2
1.3
5 DC COM
(MCU +5VDC) MCU +5VDC MCU
1.5 +5VDC ALL +5VDC DCDC +3.3VDC
(J520-6) ALL J1 P1 TO +5VDC P1 J1 ALL
6 57,58,59,60 DCDC TO 120
VIO
+5VDC +3.3VDC
1.5 DC COM
(J520-7)
VIO
7 +5VDC FAX 1,12,21,24,29,92, DC COM
MAIN STBY 5V ALL
DC COM (1.4 F5) 32,38,41,44,47,56,
61,72,81,89,30,95,
37,98,39,40,101,
DC COM 42,43,104,45,46
6

j0se730106

Chain 1 Standby Power


7-9 7.3 BSD
7-10 7.3 BSD
Chain 1 Standby Power
A B C D E F G H J
1.7 DC POWER GENERATION (4/7) NOTE:
1 Chip Fuse
1 MAIN LOW VOLTAGE POWER SUPPLY (3/3) ESS PWB BP PWB
PL18.3 PL35.2 PL18.2
1.12
1 +24VDC
ALL +24VDC
J502 +24VDC SQ J300 F202 F1103 P309 J309 ALL
3 A8 EPSV 1
ORN 0.75A S +24VDC
G D ALL +24VDC
DC COM CR206 FET
1 VIO
B8 ORN
2
DC COM
2 DC COM

DC POWER
GENERATOR
+24VDC SQ 1.8
+24VDC J510 +24VDC SQ (MDM PWB)
SQ 4 ORN ORN
1.5 ON/OFF
SIGNAL
3 DC COM 1.8
DC COM (MDM PWB)
RETURN 1 VIO VIO

HEATER RELAY 1.2


J503 +24VDC SQ (+24VDC SQ)
1 ORN ORN

HEATER RELAY 1.2


DC COM (DC COM)
4 2 VIO VIO

2275/3373/3375/4475/5575
SHORTING
PLUG
ESS PWB 1.9
J502 SJ1 SJ1 (J300-A1)
4 ORN
2 1 ORN
ESS PWB 1.9
(J300-B1)
5 5 VIO
IIT UNIT 1.9
(J700-3)
2 VIO
6 3 ORN
IIT UNIT 1.9
(J700-1)
7 VIO

6675/7775
6 J502
4
N.C
2
j0se730107
A B C D E F G H J
1.8 DC POWER GENERATION (5/7) NOTE:
1 Chip Fuse

1 See the relevant manual separately


2 provided for Finisher.
MOTOR DRIVER MAIN PWB (1/2) MOTOR DRIVER SUB PWB
PL18.2 TM PL18.2 See the relevant manual separately
2 +24VDC 3
LVM ALL +24VDC provided for HCF.
+24VDC F3 +24VDC F1
1.7 +24VDC SQ ALL ALL ALL
(MDM PWB) J520 5A P452 J452 F1
8 FUSE 3 78-81
ORN FUSE 1.14 3.15A FUSE 1
STATUS FUSE 1.14
IOT POWER ON +24VDC +24VDC 1 STATUS
1.3 S ALL
(+24VDC) G D
2 FET
HCF
1.7 DC COM 1.3 IOT POWER ON S +24VDC
(MDM PWB) (HCF +24VDC) G D ALL
3 FET
VIO FINISHER 2
DC COM J540 J539 J591 (+24VDC)
+24VDC 5 ORN
5 1
1 F5
F5 ALL +24VDC F23
FINISHER 2
2A +24VDC (DC COM)
F6 6 6 3
F6 1 ALL VIO
3 4A FUSE 5,6 DC COM
FUSE 1.14 TRAY MODULE PWB
STATUS PL10.10/11.17/12.5
+24VDC
+24VDC F1
ALL F1 ALL 34.1
+24VDC
+24VDC J592 J541 3.15A J542 (FAX) 34.2
F23 1 1 B2 ORN 10 1
F23 1 ALL ORN ORN
TM 34.1
4A +24VDC DC COM
+24VDC
4 F8 (24V RTN) 34.2
F8 1 ALL B1 VIO 9 2
2 VIO
2 VIO
2A +24VDC DC COM
1 F9
F9 ALL
1A FUSE 23,8,9
FUSE 1.14
STATUS

HCF 3
5 J593 DP800 DJ800 (+24VDC)
1 1
ORN
HCF
+24VDC HCF 3
(DC COM)
2 2
VIO
HCF 3
(DC COM)
3 VIO
4
DC COM
6

j0se730108

Chain 1 Standby Power


7-11 7.3 BSD
7-12 7.3 BSD
Chain 1 Standby Power
A B C D E F G H J
1.9 DC POWER GENERATION (6/7) DADF PWB
PL51.2/55.2
3
1 IIT TRANS PWB +5VDC
PL1.6 P750 J752 F1 ALL
+24VDC 18 B10
6.4 ALL 1A
NRESET +5VDC
1 1.10 3 3 36 A5
IIT UNIT +5VDC
2 1.7 J700 P700 J720 +24VDC ALL
(J700-3) F3 F6
3 2 TO 35 A4
ORN ORN 8A +5VDC 4A +24VDC
1 1.10 3 +3.3VDC ALL
IIT UNIT DC COM +5VDC ALL
F5 1 B1
2 1.7 (J700-1) ALL TO
1 1 3 ANA
VIO VIO +24VDC +10VDC +3.3VDC 4A +24VDC
2 F4 ALL 2 B2
TO
4A
ANA ANA
+10VDC +5VDC +3.3VDC 3 B3
TO ALL
ANA 4 B4
3 LED +3.3VDC
+24VDC +24VDC
F7 TO ALL
9 A10
2.5A
LED
+24VDC
8 A11
3
7 A12

6 A13
BP PWB
PL18.2 3 5 A14 3 SLEEP
+5VDC
3 BP J336 J7191 F10 F6 ALL
+5VDC 47 5 17 B11
F901 ALL 1A 1A
STBY
+5VDC 30 A3
4 +5VDC
DC COM
SWE 23 B5
1.3 HUMAN SNR S +5VDC
POWER ON G D ALL
FET 24 B6

STBY 25 B7
1.3 SLEEP S +5VDC
RECOVERY ON G D ALL
FET 26 B8
ESS PWB 1.3 DADF SNR DC COM
5 PL35.2 POER ON 27 B9
1 1.10 IPS
ESS PWB 3 2.12
+24VDC DC COM 22 A6
2 1.7 (J300-A1) J300 F201 ALL PE SENSOR
A1 2.13 IN
ORN ORN 21 A7
1 1.10
ESS PWB CR202 DC COM
2 1.7 (J300-B1) YEL 20 A8
B1 DC COM
VIO VIO ALL
DC COM DC COM 19 A9
6

NOTE:
1 Applicable to 6675/7775. 2 Applicable to 2275/3373/3375/4475/5575. 3 Chip Fuse
j0se730109
A B C D E F G H J
1.10 DC POWER GENERATION (7/7) (6675/7775)

1 SUB LOW VOLTAGE POWER


SUPPLY
PL18.3 1
DC PWR GEN
1.1 POWER ON ACH ESS PWB 1.9
(SUB LVPS) J8 J505 +24VDC (J300-A1)
2 +24VDC 2
BLK 10A ORN

1.1 POWER ON ACN ESS PWB 1.9


(SUB LVPS) DC COM (J300-B1)
1 RETURN 4
WHT VIO

2 IIT UNIT 1.9


SLEEP RECOVERY +24VDC (J700-3)
1.3 ON(H) +3.3VDC 1
(SUB LVPS) J506 ORN
BLU
3
IIT UNIT 1.9
1.4 +5VDC STBY DC COM (J700-1)
(SUB LVPS) 3 VIO
1 ON/OFF
GRY
1.4 DC COM
(SUB LVPS)
VIO
2
3

NOTE: 1 ・Short Protection (Over-current Protection) ・Over-voltage Protection: If one of the outputs reaches its
over-voltage listed below, all outputs are cut off.
+24V Recovery Requirements
+24V Recovery Requirements
Output is Repair the short circuit, power off, allow 15
cutoff. sec, and then power on. 26.7~32V Confirm that no damage has been incurred,
power off, allow 15 sec, and then power on.

j0se730110

Chain 1 Standby Power


7-13 7.3 BSD
7-14 7.3 BSD
Chain 1 Standby Power
A B C D E F G H J
1.11 LVPS COOLING FAIL CODE
043-322
MOTOR MOTOR DRIVER SUB PWB LVPS Fan Fail
1 DRIVER MAIN PL18.2
PWB 1 DC330 042-025
PL18.2 +24VDC F1 MOTOR MOTOR DRIVER MAIN
(1.8 G1)
DRIVER SUB PWB
S DC330 042-018 LVPS FAN PWB PL18.2
P452 J452 G 2275/3373/3375 PL18.3
18 LVPS FAN DC330 042-218 PL18.2
J529 ON(H) +24VDC J277 P277 +3.3VDC
DC COM B9 GRY
4 1 LVPS FAN
D P277 J277 FAIL(H) +3.3VDC J529 J452 P452
MOT 3 2 GRY
B11 16 043-322
2 B12 GRY 1 4
DC COM
(1.4 H6)

ELECTRICAL COMPONENTS

4475/5575/6675/7775 LVPS Fan


J277 P277
3 2
3

1 4

NOTE:
1 DC330[042-025] performs a fault detection after
4 rotating the target fans concurrently for 5 seconds.
If any fan is found to be faulty, a fail code is issued.
Fail codes can be referred to via DC125.
Check the following NVM settings in advance.
(1) NVM741-072: Fan Fail Bypass should be "0".
If you want to prevent any particular fan from raising a fail,
change this value to the fail bypass number for that fan.
(2) NVM741-146: LH FAN CONDITION FLAG should be 1 or 2".
If you want to prevent an LH Fan Fail from being raised,
change this value to "0".
5 The following fans are targeted:
・010-398: Fusing Unit Fan
・042-336: Process 2 Fan
・043-322: LVPS FAN
・042-332: IH Intake Fan
・042-330: IH Exhaust Fan
・042-609: LH Fan 1/2/3 (When NVM742-146 is set to "1 or 2")
・042-342: Suction Fan (4475/5575/6675/7775)
・042-340: Cartridge Fan (4475/5575/6675/7775)
・042-335: Process 1 Fan (4475/5575/6675/7775)
・042-344: C Exhaust Fan (4475/5575/6675/7775)
6 ・042-343: Rear Bottom Fan (4475/5575/6675/7775)
・042-341: HV Fan (4475/5575/6675/7775)
・043-321: RH Fan (4475/5575/6675/7775)
・042-341: Marking Fan (2275/3373/3375)
j0se730111
A B C D E F G H J
1.12 INTERLOCK SWITCHING (1/2)
MOTOR L/H COVER MOTOR DRIVER MAIN PWB FRONT COVER MOTOR DRIVER MAIN PWB
1 DRIVER INTERLOCK PL18.2 INTERLOCK PL18.2
MAIN SWITCH SWITCH
PWB PL14.1 DC330 077-300 PL18.5 DC330 077-303
PL18.2 L/H COVER INTLK SW FRONT COVER INTLK SW
J534 J100 J102 CLOSED(H) +24VDC J534 J521 J101 J101 CLOSED(H) +24VDC J521 J526
1 ORN
1 1 ORN
2 1 ORN B2 A2 ORN 2 15 BLU
+3.3VDC +3.3VDC
+24VDC
(1.8 D2)
077-301 077-300
DC COM DC COM
2 FRONT 10.4
INTLK ON

MOTOR DRIVER MAIN PWB MOTOR DRIVER SUB PWB


PL18.2 PL18.2
INTLK INTLK
+24VDC INTLK +24VDC
ALL J540 +24VDC J539 ALL
3 ORN
3
3 MAIN LOW VOLTAGE POWER SUPPLY
PL18.3 INTLK F2
FUSE 2,3
INTLK 1 +24VDC
1 +24V F10 DC COM ALL FUSE 1.14
ALL 4 VIO
4 F2 STATUS
F10
1.7 +24VDC INTLK DC COM DC COM 2A
SQ J510 +24VDC J520 2A INTLK F3
3 ORN
4 INTLK 1 +24VDC
+24V F11 ALL
1 ALL
FUSE 10,11 F3
INTLK F11
+24VDC FUSE 1.14 4A
6 ORN
5 4A STATUS
4

INTLK ELECTRICAL COMPONENTS


+24V F13 FUSE 13-15
DC COM 1 FUSE
DC COM ALL 1.14
INTLK RELAY 2 9 F13 STATUS
ON(H) +24VDC J503 VIO
BLU
5 4A L/H Cover
INTLK Interlock Switch
DC COM 1 +24V F14
5 VIO
10 ALL
F14
5 DC COM DC COM DC COM 6.3A
INTLK
1 +24V F15
ALL
F15
6.3A
FAIL CODE NOTE:
077-300 1 Chip Fuse
Front Cover Interlock Front Cover
Open Interlock Switch
6 077-301
Left Hand Cover Interlock
Open

j0se730112

Chain 1 Standby Power


7-15 7.3 BSD
7-16 7.3 BSD
Chain 1 Standby Power
A B C D E F G H J
1.13 INTERLOCK SWITCHING (2/2) FAIL CODE
077-305
Tray Module L/H
1 IBT FRONT MOTOR DRIVER MAIN BP PWB ESS PWB Cover Interlock Open
MOTOR COVER PWB PL18.2 PL35.2
DRIVER SWITCH PL18.2 077-307
MAIN PWB PL18.5
DC330 077-307 +3.3VDC
Duplex Cover Open
PL18.2 IBT FRONT COVER SWITCH
J416 J272 J272 CLOSED(L) +3.3VDC J416 P451 J451 J335 P335 077-308
2 1 2 1 A4 114
Left Hand Upper Cover
1 1 Open
094-300
6675/7775 IBT Front Cover Open
2 MCU-PF PWB ELECTRICAL COMPONENTS
J612 P612 PL18.2
B1 B12 Face Up Tray L/H Upper Cover
Detect Switch Interlock Switch
DUP P1 J1
COVER 117 094-300
SWITCH
PL14.6 DC330 077-305 +3.3VDC
DUP COVER SWITCH
J523 P612 J612 J176 J176 J612 P612 CLOSED(L) +3.3VDC J523
B3 GRY B10 B3 1 2 B2 B11 GRY
B2 077-307
2 2
3 DC COM
(1.4 D4)
MOTOR MOTOR DRIVER
DRIVER MAIN PWB
MOTOR FACE UP SUB PWB PL18.2
PL18.2
DRIVER TRAY DETECT DC330 077-201
SUB PWB SWITCH FACE UP TRAY +3.3VDC
PL18.2 PL17.4 DETECT SWITCH
J522 P631 J631 J169 J169 J631 P631 CLOSED(L) +3.3VDC J522 J452 J452
A15 BLU A1 A15 1 2 A14 A2 A14 38
BLU BLU BLU
4
L/H UPPER Dup Cover
COVER INTLK DC330 077-302 Switch
SWITCH L/H UPPER COVER +3.3VDC
PL17.4 INTLK SWITCH
J168 J168 CLOSED(L) +3.3VDC IBT Front Cover
B12 B2 B14 1 2 B13 B3 B11 87 077-308 Switch
1 1 1 1
DC COM
(1.4 H6)
5
TM L/H
TRAY COVER TRAY MODULE PWB
MODULE INTERLOCK PL10.10/11.17/12.5
PWB SWITCH DC330 077-306
PL10.10/ PL12.6 TM L/H COVER +5VDC
11.17/12.5 INTERLOCK SWITCH
J549 P668 J668 J104 J104 J668 P668 CLOSED(L) +5VDC J549
A12 VIO 1 2 BRN
1 2 BRN
1 2 YEL
A11 077-305
DC COM
(1.6 H4)
6
NOTE: 1 Wire Color varies depending on the model. 2 Wire Color varies depending on the model.
2275/3373/3375 : BLU 2275/3373/3375 : GRY TM L/H Cover
4475/5575 : WHT 4475/5575 : WHT Interlock Switch
6675/7775 : VIO 6675/7775 : VIO j0se730113
A B C D E F G H J
1.14 PWBS FUSE STATUS FAIL CODE
041-393
MOTOR DRIVER SUB PWB MOTOR DRIVER MAIN PWB Motor Driver Sub PWB F1 Fuse Fail
1 PL18.2 PL18.2
041-394
Motor Driver Sub PWB F2 Fuse Fail
1.8 FUSE 1
+24VDC FUSE STATUS J452 P452 041-398
76 041-393
Motor Driver Main PWB F5 Fuse Fail
1.12 FUSE 2,3 041-399
INTLK +24VDC FUSE STATUS 041-394
77 Motor Driver Main PWB F6 Fuse Fail
045-345
045-320
2 1.8 FUSE 5,6
+24VDC FUSE STATUS 041-398 Motor Driver Main PWB F8 Fuse Fail

041-399 045-343
Motor Driver Main PWB F9 Fuse Fail
045-320 (2275/3373/3375/4475/5575)
1.8 FUSE 23,8,9
+24VDC FUSE STATUS 045-345
045-343
Motor Driver Sub PWB F3 Fuse Fail
045-358 045-346
3 1.12 FUSE 10,11 Motor Driver Main PWB F3 Fuse Fail
INTLK +24VDC FUSE STATUS 045-347
045-347
045-348 Motor Driver Main PWB F10 Fuse Fail

045-349 045-348
1.12 FUSE 13-15
INTLK +24VDC FUSE STATUS Motor Driver Main PWB F11 Fuse Fail
045-353
045-349
045-354 Motor Driver Main PWB F13 Fuse Fail
4 045-353
Motor Driver Main PWB F14 Fuse Fail
1.4 FUSE 17
FAX STBY 5V FUSE STATUS 045-354
045-356
Motor Driver Main PWB F15 Fuse Fail
1.6 FUSE 22
+5VDC MAIN FUSE STATUS 045-356
045-357
Motor Driver Main PWB F17 Fuse Fail
045-357
5 1.8 FUSE 3 Motor Driver Main PWB F22 Fuse Fail
TM +24VDC FUSE STATUS
045-346 045-358
Motor Driver Main PWB F23 Fuse Fail

j0se730114

Chain 1 Standby Power


7-17 7.3 BSD
7-18 7.3 BSD
Chain 1 Standby Power
A B C D E F G H J
1.15 PWB LOCATION
Sub Low Voltage
Power Supply (6675/7775) DADF PWB
1 IIT Trans PWB

DCDC PWB
IH Driver PWB
(DADF-130(1pass))
Darts3 PWB

2
HVPS (1st/2nd BTR)

BP PWB

HVPS (DEVE)
Motor Driver Main PWB
3
MCU-PF PWB

HVPS (BCR)

4
Motor Driver Sub PWB

ESS PWB
Accessory/Heater
PWB
AC Power Supply H2
Tray Module PWB
5
AC Power Supply H

Main Low Voltage


6 Power Supply

FAX PWB

j0se730115
A B C D E F G H J
ELECTRICAL COMPONENTS
2.1 W90 CONTROL PANEL SWITCHES (1/2)
W90 UI I/F W90 UI 10 KEY PWB
1 PWB PL1.9
PL1.9 SWITCH ENABLE W90 UI 10 Key PWB
J5 PULSE(SCAN 0) J15
8 21

SWITCH ENABLE C # * 0
PULSE(SCAN 1)
9 20

2 SWITCH ENABLE Clear All 7 4 1


PULSE(SCAN 2)
10 19

SWITCH ENABLE 8 5 2
PULSE(SCAN 3)
11 18

SWITCH ENABLE 9 6 3
PULSE(SCAN 4)
3 12 17

SWITCH ENABLE Job Status Interrupt Start


PULSE(SCAN 5)
13 16

SWITCH ENABLE Machine Stop


PULSE(SCAN 6) Status
14 15
4
SWITCH ENABLE Log In / Out W90 UI I/F PWB
PULSE(SCAN 7) PL1.9
15 14
+3.3VDC
SWITCH ON(L)
Speed Dial Dial Pause J15 +3.3VDC J5
25 4
+3.3VDC
SWITCH ON(L)
+3.3VDC
5 24 5
+3.3VDC
SWITCH ON(L)
+3.3VDC
23 6
+3.3VDC
SWITCH ON(L)
+3.3VDC
22 7

j0se730201

Chain 2 Mode Selection


7-19 7.3 BSD
7-20 7.3 BSD
Chain 2 Mode Selection
A B C D E F G H J
2.2 W90 CONTROL PANEL SWITCHES (2/2) ELECTRICAL COMPONENTS

W90 UI I/F W90 UI FUNCTION


1 PWB PWB W90 UI Function PWB
PL1.9 SWITCH ENABLE PL1.9
J2 PULSE(SCAN 4) J11
8 8

SWITCH ENABLE MENU


PULSE(SCAN 5)
7 7

2 SWITCH ENABLE Copy


PULSE(SCAN 6)
6 6
W90 UI I/F PWB
PL1.9
SWITCH ENABLE Fax
PULSE(SCAN 7) +3.3VDC
5 5
SWITCH ON(L)
J11 +3.3VDC J2
9 9
Store to Folder
DC COM
3 4 4
DC COM DC COM
(2.4 D5)

j0se730202
A B C D E F G H J
ELECTRICAL COMPONENTS
2.3 W90 CONTROL PANEL LEDS
W90 UI I/F PWB W90 UI 10 KEY PWB W90 UI 10 Key PWB
1 PL1.9 PL1.9
+24VDC W90 UI I/F PWB
BZ (2.4 C6)
CLK J5 BUZZER + J15
1 28
SP1
BUZZER -
2 27
DC COM
2 DC COM
26 3
DC COM
27 2
DC COM
28 1
DC COM
3 26
DC COM DC COM
(2.4 D5)
3 +3.3VDC
16 13
CR1 CR2
+3.3VDC GRN GRN
(2.4 D4)

Interrupt LED
ON(L) +3.3VDC W90 UI I/F
17 12 PWB
PL1.9
Log In / Out LED
ON(L) +3.3VDC J15 J5 J1
4 18 11 4 25 31
Energy Saver

UI +5VDC
23 6
CR8 CR7 CR5 CR6
+5VDC GRN GRN AMB GRN
(2.4 C5)
ESS PWB BP
PL35.2 PWB BP PWB ESS PWB
Energy Saver PL18.2 PL35.2
PL18.2 LED Energy Saver
5 P309 J309 J1311 J1 ON(L) +3.3VDC DC COM BUTTON
77 6 6 24 5 ON(H) +5VDC J1311 J309 P309
31 78
DC COM Error LED
ON(L) +3.3VDC
76 5 5 21 8 DC COM
DC COM Data LED
ON(L) +3.3VDC
75 30 30 22 7
DC COM

j0se730203

Chain 2 Mode Selection


7-21 7.3 BSD
7-22 7.3 BSD
Chain 2 Mode Selection
A B C D E F G H J
2.4 W90 LCD CONTROL ELECTRICAL COMPONENTS
ESS PWB BP PWB W90 UI I/F PWB
PL35.2 PL18.2 PL1.9
1 W90 LCD MODULE
PL1.9 W90 LCD Module
P335 J335 J1311 LCD G0+ J1 LCD
138 12 12 J7 LCD CLK
41 CN1 41

LCD G0- 8-11,13, LCD R0-R7 8-11,13,


137 13 13
14,16,17 14,16,17
LCD G1+ 19-22,24, LCD G0-G7 19-22,24,
69 38 38
25,27,28 25,27,28
LCD G1- 30-33,35, LCD B0-B7 30-33,35, LCD
2 68 39 39 36,38,39 36,38,39 CONTROL
LCD DE
LCD G2+ 43 43
65 15 15 +3.3VDC +3.3VDC

LCD G2- XSTABY


64 16 16 48 48
LCD G3+ DC COM W90 UI I/F PWB
136 35 35 +3.3VDC +3.3VDC

LCD G3- VBR


3 135 36 36 47 47
CLOCK+ DC COM L/R
140 41 41 6 6
DC COM
CLOCK- U/O
139 42 42 5 5
+3.3VDC
UI +5VDC +3.3VDC
22 22 3 3

UI
UI +5VDC +3.3VDC NOTE:
4 23 23 4 4 1 Chip Fuse
+5VDC
(1.4 J2) UI +5VDC LCD
+3.3VDC
47 47 DC COM
+5VDC +3.3V 1 1
UI +5VDC TO F2 ALL
48 48 +3.3VDC DC COM
0.75A 2 2

8,33,14,11, 8,33,14,11, DC COM


DC COM +12VDC
40,37,17,10, DC COM 19 40,37,17,10, ALL 49 49
21,24,46,49, 21,24,46,49,
2,28,4,9,34, 2,28,4,9,34, +12VDC
5 DC COM 7,32 7,32 24
50 50
(1.4 J2) F1
↓ DC COM
+5VDC 0.2A 12 45 45
F602 +5VDC ALL
29 29 DC COM
0.75A 46 46
+5VDC
(1.4 J2) 1 DC COM
+24VDC
3 3
+24VDC 12,15,18,23, DC COM 12,15,18,23,
F601 +24VDC ALL 26,29,34,37, 26,29,34,37,
27 27 44,40,42,7 44,40,42,7
6 0.75A DC COM
+24VDC
(1.7 G1) 1

j0se730204
A B C D E F G H J
2.5 W90 TOUCH PANEL CONTROL ELECTRICAL COMPONENTS

W90 UI I/F PWB


1 PL1.9 W90 TOUCH PANEL
PL1.9 W90 Touch Panel
+3.3VDC
J3 YV
1

XG
2 ADJ 1.6.6
UI Touch Panel
DC COM Origin Point Correction
YG
3
2
DC COM

+3.3VDC
XV
4

j0se730205

Chain 2 Mode Selection


7-23 7.3 BSD
7-24 7.3 BSD
Chain 2 Mode Selection
A B C D E F G H J
ELECTRICAL COMPONENTS
2.6 W90 FAX CONTROL PANEL SWITCHES (1/2)
W90 UI I/F W90 UI FAX Key PWB
PWB W90 UI FAX KEY PWB
1 PL1.9 PL1.7
SWITCH ENABLE
J4 PULSE(SCAN 0) J10
8 8

SWITCH ENABLE 003 002 001


PULSE(SCAN 1)
9 9

SWITCH ENABLE 006 005 004


2 PULSE(SCAN 2)
10 10

SWITCH ENABLE 009 008 007


PULSE(SCAN 3)
11 11

SWITCH ENABLE 012 011 010


PULSE(SCAN 4)
12 12
3
SWITCH ENABLE 015 014 013
PULSE(SCAN 5)
13 13

SWITCH ENABLE 018 017 016


PULSE(SCAN 6)
14 14

4 SWITCH ENABLE 021 020 019


PULSE(SCAN 7)
15 15

024 023 022 W90 UI I/F PWB


PL1.9
+3.3VDC
SWITCH ON(L)
J10 +3.3VDC J4
5 5 5
+3.3VDC
SWITCH ON(L)
+3.3VDC
6 6
+3.3VDC
SWITCH ON(L)
+3.3VDC
7 7

j0se730206
A B C D E F G H J
ELECTRICAL COMPONENTS
2.7 W90 FAX CONTROL PANEL SWITCHES (2/2)
W90 UI FAX Key PWB
W90 UI I/F W90 UI FAX KEY PWB
1 PWB PL1.7
PL1.9
J4 +3.3VDC J10
4 4 W90 UI I/F PWB
PL1.9
+3.3VDC +3.3VDC +3.3VDC
(2.4 D4) ONE TOUCH PANEL
DC COM J10 SWITCH ON(L) +3.3VDC J4
1 1 17 17
S54
DC COM DC COM
3 3
2 S52
DC COM +3.3VDC
16 16 ONE TOUCH PANEL
SWITCH ON(L) +3.3VDC
2 2
DC COM S53
18 18
DC COM
DC COM
(2.4 D5) S51

FG FG
3

j0se730207

Chain 2 Mode Selection


7-25 7.3 BSD
7-26 7.3 BSD
Chain 2 Mode Selection
A B C D E F G H J
ELECTRICAL COMPONENTS
2.8 S104 UI SWITCHES (OPTION)
S104 UI I/F PWB
1 PL1.13 S104 UI 10 KEY PWB
SWITCH PL1.12
ENABLE
J5 PULSE (SCAN 7) J16
11 15

SWITCH
ENABLE ENTRY1 Speed Dial Dial Pause
PULSE (SCAN 6) Copy
12 14

SWITCH
2 ENABLE ENTRY2 Log In / Out
PULSE (SCAN 5) Not In Use
13 13

SWITCH
ENABLE ENTRY3 Machine Stop
PULSE (SCAN 4) Review Status
14 12

SWITCH
ENABLE Services Job Status Interrupt Start
PULSE (SCAN 3) Home S104 UI 10 Key PWB
3 15 11

SWITCH
ENABLE 9 6 3
PULSE (SCAN 2)
16 10

SWITCH
ENABLE 8 5 2
PULSE (SCAN 1)
17 9
4 SWITCH
ENABLE Clear All 7 4 1 S104 UI I/F PWB
PULSE (SCAN 0) PL1.13
18 8
+3.3VDC
SWITCH
C # * 0 J16 ON (L) +3.3VDC J5
4 22
+3.3VDC
SWITCH
ON (L) +3.3VDC
5 5 21
+3.3VDC
SWITCH
ON (L) +3.3VDC
6 20
+3.3VDC
SWITCH
ON (L) +3.3VDC
7 19

j0se730208
A B C D E F G H J
2.9 S104 UI LED (OPTION)

1 S104 UI I/F PWB S104 UI 10 KEY PWB


PL1.13 PL1.12
J5 +3.3VDC J16
10 16
+3.3VDC Log In
(2.10 D4) Interrupt / Out
Interrupt LED CR1 CR12
ON (L)+3.3VDC GRN GRN
9 17

2 Log In / Out LED


ON (L)+3.3VDC
8 18
S104 UI I/F
PWB
PL1.13
UI+5VDC Energy Saver
3 23
ESS PWB BP PWB BUTTON
PL35.2 PL18.2 +5VDC Energy J16 ON (H)+5VDC J5 J1
(2.10 C5) Saver 25 1 31
Energy Saver
Energy Saver LED Energy Saver LED CR11
3 P309 J309 J1311 ON (L)+3.3VDC J1 ON (L)+5VDC GRN
77 6 6 2 24
DC COM

+24VDC
BUZZER +
ELECTRICAL COMPONENTS 25 1
BP PWB ESS PWB
PL18.2 PL35.2
SP1
BUZZER - Energy Saver
4 24 2
BUTTON
S104 UI I/F PWB ON (H)+5VDC J1311 J309 P309
DC COM
31 78
23 3
DC COM
DC COM DC COM
(2.10 D5)

6
S104 UI 10 Key PWB

j0se730209

Chain 2 Mode Selection


7-27 7.3 BSD
7-28 7.3 BSD
Chain 2 Mode Selection
A B C D E F G H J
ELECTRICAL COMPONENTS
2.10 S104 LCD CONTROL (OPTION)
ESS PWB BP PWB S104 UI I/F PWB S104 LCD MODULE S104 UI I/F PWB
1 PL35.2 PL18.2 PL1.13 PL1.13 S104
P335 J335 J1311 J1
LCD Module
LCD G0+
138 12 12 J7 CLOCK J17
3 3
LCD G0- LCD R0-R2
137 13 13 7-9 7-9
LCD G1+ LCD R3-R5
69 38 38 11-13 11-13
LCD G0-G2
LCD G1- 15-17 15-17
2 68 39 39
LCD G3-G5
LCD G2+ 19-21 19-21
65 15 15
LCD B0-B2
23-25 23-25
LCD G2-
64 16 16 LCD B3-B5
27-29 27-29
LCD G3+
136 35 35 HS
31 31
LCD G3- VS
3 135 36 36 33 33
CLOCK+ REVERSE
140 41 41 34 34
DE
CLOCK- 35 35
139 42 42

UI +5VDC
22 22 +3.3VDC
37-40 37-40
UI +5VDC
4 UI 23 23 +3.3VDC
+5VDC
(1.4 J2) UI +5VDC
47 47
+5VDC +3.3V
UI +5VDC TO ALL
48 48 +3.3VDC
J19 CH1+
8,33,14,11, 1
8,33,14,11, DC COM
40,37,17,10, DC COM 19 ALL CH1-
21,24,46,49, 40,37,17,10, 2
21,24,46,49,
2,28,4,9,34 2,28,4,9,34
5 DC COM 7,32 CH2+
(1.4 J2) 3
CH2-
+5VDC 4
F602 +5VDC ALL
29 29 CH3+
0.75A
1 5
+5VDC
(1.4 J2) CH3-
+24VDC 6
3 3 NOTE:
+24VDC F1
F601 +24VDC ALL 1 Chip Fuse
6 27 27 140mA
0.75A 1 +24VDC
+24VDC
(1.7 G1)

j0se730210
A B C D E F G H J
2.11 S104 TOUCH PANEL AND UI LED (OPTION)
S104 UI I/F PWB UI LED PWB
1 PL1.13 PL1.13
J8 UI +5V J20
4 1
ESS PWB BP PWB
PL35.2 PL18.2 +5VDC
(2.10 C5)
DATA LED DATA LED CR3 CR2 CR1
P309 J309 J1311 ON (L)+5VDC J1 ON (L)+5VDC GRN AMB GRN
75 30 30 2 3
DC COM
ERROR LED ERROR LED
2 ON (L)+5VDC ON (L)+5VDC
76 5 5 1 4
DC COM
POWER LED
ON (L)+5VDC
3 2
DC COM
ELECTRICAL COMPONENTS (2.10 D5)

S104 UI I/F PWB UI LED PWB


3
S104 TOUCH PANEL
+3.3VDC PL1.13
J3 YV
1

XG
2
ADJ 1.6.6
DC COM UI Touch Panel
4 Origin Point Correction
YG
3
DC COM
+3.3VDC
XV
4

6
S104 Touch Panel

j0se730211

Chain 2 Mode Selection


7-29 7.3 BSD
7-30 7.3 BSD
Chain 2 Mode Selection
A B C D E F G H J
2.12 HUMAN MOTION DETECTION ELECTRICAL COMPONENTS
HUMAN MOTION SENSOR PWB
1 BP PWB PL19.4 Human Motion
1 PL18.2 STBY LED
J1301 +5VDC P900 J900 J911
6 BLU
6 6 GRY
1
SWE PYRO-
+5VDC ELECTRIC
(1.9 F4) SENSOR

DC COM
DC COM ALL
2 4 BLU
8 4 GRY
3
ESS PWB DC COM DC COM
PL35.2 (1.4 J2)
ADJ SENSOR Human Motion
P335 J335 RANGE Seneor
38 3 9 3 4
BLU GRY
DC COM

HUMAN MOTION
3 LED HUMAN MOTION LED
PL19.4 J490 ON(H) +3.3VDC J901 Human Motion
1 GRY
1 Seneor PWB
NOTE:
2 GRY
2 1
BLU
Notes on Human Motion Sensor
The pyroelectric sensor on Human Motion Sensor PWB is always turned ON to monitor
the ambient environment of the machine.
When the pyroelectric sensor detects a human, the power from STBY +5VDC is supplied
J131 to Human Sensor (reflective type) and LED.
4 J131 3 3
1 GRY When powered ON, Human Senor (reflective type) functions as a switch to go into or out
of the power saving mode.
This sensor is turned OFF during the power saving mode because its power consumption is high.
2 GRY
4
HUMAN MOTION DC COM
SENSOR BP PWB ESS PWB
PL19.4 PL18.2 PL35.2
HUMAN +5VDC +3.3VDC
SENSED
HUMAN MOTION SENSOR J911 J900 P900 (L) +5VDC J1301 J335 P335
HUMAN SENSED SIGNAL AMP 5 2 10 2 116
5 5 GRY BLU
GRY +5VDC +3.3VDC
DC COM

2 GRY
5 7 BLU
5 46
DC COM
HUMAN +5VDC +3.3VDC
SENSED
(L) +5VDC
6 GRY
1 11 BLU
1 118
DC COM
+5VDC
1.9
6

j0se730212
A B C D E F G H J
2.13 HUMAN MOTION DETECTION (OPTION) (1/2) ELECTRICAL COMPONENTS
HUMAN MOTION SENSOR PWB Camera2 PWB
BP PWB PL19.5
1 PL18.2 STBY
J1301 +5VDC P900 J900 J911
6 BLU
6 6 GRY
1
SWE PYRO- Human Motion LED
+5VDC ELECTRIC
(1.9 F4) SENSOR

Camera1 PWB
DC COM
DC COM ALL
2 4 BLU
8 4 GRY
3
ESS PWB DC COM DC COM Human Access
PL35.2 (1.4 J2)
Detect (Taurus) PWB
ADJ SENSOR
P335 J335 RANGE
38 3 9 3 4
BLU GRY
Human Access
2.14 DC COM Detect (Gemini) PWB

3 HUMAN MOTION
LED HUMAN MOTION LED Human Motion
PL19.5 J490 ON(H) +3.3VDC J901
2 1 Sensor PWB
GRY

1 GRY
2
BLU

4 N.C 3

BP PWB ESS PWB


PL18.2 PL35.2
HUMAN +5VDC +3.3VDC
SENSED
2.14 J911 J900 P900 (L) +5VDC J1301 J335 P335
HUMAN SENSED SIGNAL AMP 5 2 10 2 116
5 5 GRY BLU
GRY +5VDC +3.3VDC
DC COM
2.14
DC COM 2 GRY
5 7 BLU
5 46
GRY
4 HUMAN
DC COM +5VDC +3.3VDC
DC COM SENSED
(L) +5VDC
6 GRY
1 11 BLU
1 118
DC COM 2.14

6 +5VDC
1.9

j0se730213

Chain 2 Mode Selection


7-31 7.3 BSD
7-32 7.3 BSD
Chain 2 Mode Selection
A B C D E F G H J
2.14 HUMAN MOTION DETECTION (OPTION) (2/2)

1 HUMAN ACCESS DETECT (GEMINI) PWB


PL19.5

STBY
+5BDC
1.4 +5VDC STBY ACC
(HAD PWB) P651 J651 J650 P650 J904 +5VDC
1 1 1 CM1
GRY GRY GRY GRY S
G D ALL
DC COM FET
1.4
(HAD PWB)
2 2 2 CAMERA1 PWB
VIO VIO VIO VIO +5VDC
2 S CM2 PL19.5
DC COM G D ALL
FET
HUMAN ACCESS
DETECT (TAURUS) PWB
PL19.5 CN5 CN2
CN10

001-XXXX 200-0000
3 002-XXXX 200-1303 +5VDC +5VDC
CM1 CM1
ESS PWB BP PWB 003-XXXX 200-3102 CAMERA2 PWB
PL35.2 PL18.2 PL1.9
SUB SWITCH 004-XXXX 200-4128
P335 J335 J1341 STATUS P900 J900 J906 RJ45_CN6 RJ45_CN2
131 1 5 B7 5 005-XXXX 200-4129 LAN CABLE
BLU GRY

2.13
006-XXXX 200-4241
ADJ SENSOR RANGE
2 4 B8 4 007-XXXX 200-4242
4 BLU GRY
008-XXXX 200-4243 +5VDC +5VDC
1.3 CM2 CM2
SLEEP RECOVERY ON
3 3 B9 3 010-XXXX 200-4244
BLU GRY
PE SENSOR 020-XXXX 200-4996 SEE USB CABLE
2.13 CH3
HUMAN SENSED (L) +5VDC
4 2 B10 2 100-0101 200-4998
BLU GRY
100-0102 200-4999 USB_CN2
DC COM USB CABLE SEE
5 5 1 B11 1 100-0800 200-XXXX CH3
BLU GRY
DC COM 100-0801
(1.4 J2)
100-0900 2.13
J902 HUMAN SENSED SIGNAL
1
GRY

2.13
DC COM
2
GRY
6 DC COM

j0se730214
A B C D E F G H J
3.1 PWBS COMMUNICATION (ESS-IIT) FAIL CODE
062-311
IIT Software Logic Fail
1 IIT TRANS PWB BP PWB ESS PWB
ESS PWB BP PWB PL1.6 PL18.2 PL35.2 062-329
PL35.2 PL18.2
DARTS Memory
IPS Capacity Fail
P309 J309 J390 EEPROM DI J7192 +3.3VDC +3.3VDC
102 31 GRY 10 062-330
J7192 EEPROM DO J390 J309 P309
6 GRY 35 100 GAPWM/DARTS PWB
EEPROM CS 062-311 Hard Fail
101 33 GRY 8 CIE
+3.3VDC 062-345 062-345
+3.3VDC
EEPROM SCLOCK+ IIT EEPROM Fail (IIT)
2 37 GRY 4 IIT POWER STATUS 062-395
40 GRY 1 91 062-395
33
EEPROM SCLOCK- DC COM Trans PWB Power
39 GRY 2 Cable Connection Fail
065-210
DARTS Memory Fail

DARTS3 PWB
3 PL35.2
RESET
062-329
062-330
DRAM
065-210
U4

j0se730301

Chain 3 Machine Run Control


7-33 7.3 BSD
7-34 7.3 BSD
Chain 3 Machine Run Control
A B C D E F G H J
3.2 PWBS COMMUNICATION (ESS - DADF-110)
ESS PWB BP PWB IIT TRANS PWB DADF PWB IIT TRANS
1 PL35.2 PL18.2 PL1.6 PL51.2 PWB BP PWB ESS PWB
PL1.6 PL18.2 PL35.2
DADF DADF
P309 J309 J390 COMMAND+ J7192 P750 J751 J751 P750 J7192 STATUS+ J390 J309 P309
23 32 GRY 9 11 8 6 10 3 GRY 38 20
DADF DADF
COMMAND- STATUS-
22 30 GRY 11 29 7 5 28 5 GRY 36 19
+3.3VDC +5VDC
PLATEN DC330 005-083 IPS
2 CLOSED (L)+3.3VDC +3.3VDC +3.3VDC
98 8 GRY 33 13 4 DOC. READY
(L)+3.3VDC
DC COM 3 16 23 GRY 18 88
DC330 062-240 IPS
31 1 +3.3VDC +3.3VDC
DADF
DC COM DC COM 005-210 EXIST (L)+3.3VDC
(1.9 C2) 2 34 25 GRY 16 90
+3.3VDC +5VDC 062-277 DC COM
DADF
RESET (H)+3.3VDC J752
3 84 24 GRY 17 12 B12
DC COM IPS
+3.3VDC +3.3VDC
DADF PAGE SYNC
J752 SIGNAL
+3.3VDC +5VDC B14 14 19 GRY 22 85
DADF
START (L)+3.3VDC IPS
86 20 GRY 21 15 B13 +3.3VDC +3.3VDC
DADF CSYNK
RAM 005-275 SIGNAL
A2 33 35 GRY 6 89
4
EEP
U2 ROM 005-280
DC COM
U2
DC330 005-224
Scan Start
DC330 005-088
Image Area ON

5
FAIL CODE
005-210
DADF Download Fail
005-275
DADF RAM Fail
005-280
DADF EEPROM Fail
6
062-277
IPS-DADF
Communication Fail
j0se730302
A B C D E F G H J
3.3 PWBS COMMUNICATION (ESS - DADF-130 (1PASS))
ESS PWB BP PWB IIT TRANS PWB DADF PWB IIT TRANS
1 PL35.2 PL18.2 PL1.6 PL55.2 PWB BP PWB ESS PWB
PL1.6 PL18.2 PL35.2
DADF DADF
P309 J309 J390 COMMAND+ J7192 P750 J751 J751 P750 J7192 STATUS+ J390 J309 P309
23 32 GRY 9 11 8 6 10 3 GRY 38 20
DADF DADF
COMMAND- STATUS-
22 30 GRY 11 29 7 5 28 5 GRY 36 19
+3.3VDC +5VDC
PLATEN DC330 005-083 IPS
2 CLOSED (L)+3.3VDC +3.3VDC +3.3VDC
98 8 GRY 33 13 4 DOC. READY
(L)+3.3VDC
DC COM 3 16 23 GRY 18 88
DC330 062-240 IPS
31 1 +3.3VDC +3.3VDC
DADF
DC COM DC COM 005-210 EXIST (L)+3.3VDC
(1.9 C2) 2 34 25 GRY 16 90
+3.3VDC +5VDC 062-277 DC COM
DADF
RESET (H)+3.3VDC J752
3 84 24 GRY 17 12 B12
DC COM IPS
+3.3VDC +3.3VDC
DADF PAGE SYNC
J752 SIGNAL
+3.3VDC +5VDC B14 14 19 GRY 22 85
DADF
START (L)+3.3VDC IPS
86 20 GRY 21 15 B13 +3.3VDC +3.3VDC
DADF CSYNK
SIGNAL
RAM 005-275 A2 33 35 GRY 6 89
4
EEP ROM 005-280

U2
DC330 005-224
Scan Start
DC330 005-088
Image Area ON
5
FAIL CODE
005-210
DADF Download Fail

005-275
DADF RAM Fail
005-280
6 DADF EEPROM Fail
062-277
IPS-DADF Communication Fail
j0se730303

Chain 3 Machine Run Control


7-35 7.3 BSD
7-36 7.3 BSD
Chain 3 Machine Run Control
A B C D E F G H J
3.4 PWBS COMMUNICATION (ESS-UI)
W90 UI I/F PWB S104 UI I/F PWB
1 PL1.9 PL1.13

ESS PWB BP PWB BP PWB ESS PWB


PL35.2 PL18.2 PL18.2 PL35.2

P309 J309 J1311 COMMAND+ J1 J1 STATUS+ J1311 J309 P309


8 19 19 20 20 5

COMMAND- STATUS-
7 44 44 45 45 4
2
P335 J335 RELEASE+
63 18 18

RELEASE-
62 43 43
CONT
+3.3VDC
(1.4 J3)
CONNECTOR-R
3 DETECT
1 1

CONNECTOR-L
P309 J309 DETECT CONNE-
9 50 50 CTOR
DETECT
DC COM
26 26
DC COM
25 25
4 DC COM DC COM
(1.4 J2)

j0se730304
A B C D E F G H J
3.5 PWBS COMMUNICATION (ESS - MCU-PF) FAIL CODE
024-340~024-343
IOT-ESS
1 Communication Fail 1~4
ESS PWB BP PWB MOTOR DRIVER MCU-PF PWB MOTOR DRIVER BP PWB ESS PWB
PL35.2 PL18.2 MAIN PWB PL18.2 MAIN PWB PL18.2 PL35.2
PL18.2 PL18.2 024-345~024-359
+3.3VDC +3.3VDC IOT-ESS
Communication Fail 5~19
IOT IOT
COMMAND P335 J335 J451 P451 P1 J1 J1 P1 P451 J451 J335 P335 STATUS 024-340~ 041-310
110 B9 53 113 A9 40 024-343
IM Logic Fail
IOT DL DL 024-345~ 042-337
CLOCK ACKNOWLEDGE 024-359
2 111 B8 55 54 A7 42 NOHAD Logic Fail
+3.3VDC 041-310
045-310
IOT DL
START CIE 042-337 Image Ready NG
112 B7 114 +3.3VDC
045-310 045-311
DC COM IOT
POWER STATUS Controller
CIE
121 045-311 Communication Fail
IOT DL +3.3VDC
MCU DC COM
RESET +3.3VDC
41 A8 118 (1.6 F3)
3
DC COM
CIE
POWER UP +3.3VDC
STATUS
115 A5 115

j0se730305

Chain 3 Machine Run Control


7-37 7.3 BSD
7-38 7.3 BSD
Chain 3 Machine Run Control
A B C D E F G H J
3.6 PWBS COMMUNICATION (MCU-PF - MOTOR DRIVER MAIN PWB) FAIL CODE
041-340
MCU NVM (EEPROM)
1 MCU-PF PWB MOTOR DRIVER MAIN PWB MCU-PF PWB Data Fail
PL18.2 PL18.2 PL18.2
+3.3VDC +3.3VDC
041-341
MCU NVM (EEPROM)
Access Fail
+3.3VDC CR32 CR33
GRN GRN 041-368
MASTER READY J1 P1 P1 J1 SLAVE READY MCU-SW Firmware
107 108 Mismatch
041-388
041-340
2 MASTER TO SLAVE 106 96 SLAVE TO MASTER MK Logic Fail
DATA CLK1 041-341 045-312
105 041-368 Drive Logic Fail
97
041-388 045-359
MASTER TO SLAVE 103 90 SLAVE TO MASTER EEPROM Config
CLOCK CLK2 045-312 Mismatch

045-359 045-368
102 +3.3VDC 91
SBM Initialize Fail
3 SBM 045-368
RESERVE 1 045-369
48 99 SLAVE TO MASTER
DATA 1 045-369 SBM Master
Communication Fail
045-377
100 045-377
SPI1 SCLK 045-378 SBM Slave
31 Communication Fail
93 SLAVE TO MASTER 045-378
SPI1 CS0 DATA 2
33 U80 MCU Config Mismatch
4
94 061-398
SPI1 MO SIN 061-398
34 ASIC 1 Initialize Fail
061-399 061-399
SPI1 MIN SO ASIC
35 061-610 ASIC 2 Initialize Fail
061-610
061-611
ASIC 1 CONTIF Fail
061-611
5 ASIC 2 CONTIF Fail

j0se730306
A B C D E F G H J
3.7 PWBS COMMUNICATION (MCU-PF - TRAY MODULE PWB)
TRAY MODULE PWB MOTOR MOTOR DRIVER MCU-PF PWB
PL10.10/11.17/12.5 DRIVER MAIN PWB PL18.2
1 MCU-PF MOTOR DRIVER MAIN PWB MOTOR SUB PWB PL18.2
PWB PL18.2 DRIVER SUB PL18.2
PL18.2 PWB
+3.3VDC PL18.2 MCU-PF TO +5VDC 1 TRAY MODULE TO +3.3VDC +3.3VDC 047-320
TRAY MODULE MCU-PF
J1 P1 P452 J452 J592 COMMUNICATION LINE J541 J541 COMMUNICATION LINE J592 J452 P452 P1 J1 077-211
110 65 A1 YEL 1 2 A2 64 50
YEL
DC COM 3.9
077-212
3.9
DC330 077-032 +3.3VDC 077-214
DC330 077-034 +5VDC DC330 077-120
DC330 077-123 FEED READY ON (L)+3.3VDC 077-215
2
FEED START ON (H)+5VDC 5 YEL
A5 61
62 A4 YEL 4 DC330 077-105 077-314
DC COM DC330 077-033 +5VDC 2 DC330 072-103 +3.3VDC 077-320
DC330 077-121 8.6 FEED OUT SENSOR 2
REGI STOP ON (H)+5VDC PAPER SENSED (L)+3.3VDC
63 A3 YEL 3 6 YEL
A6 60
DC COM
DC330 077-106
2 DC330 073-103 +3.3VDC
8.6 FEED OUT SENSOR 3
3 PAPER SENSED (L)+3.3VDC
7 YEL
A7 59
DC330 077-107
2 DC330 074-103 +3.3VDC

8.6 FEED OUT SENSOR 4


PAPER SENSED (L)+3.3VDC
8 YEL
B7 58

NOTE:
4 FAIL CODE
1 The dip switch settings of the Tray Module PWB are as follows: 047-320
ALL Destination Tray
2275/3373/3375/4475/5575 6675/7775 Broken
077-211
ON
1:ON 1:OFF
2:ON
ON
2:OFF Tray Module Kind
TTM 3:OFF TTM 3:OFF Mismatch
1 2 3 4 4:ON 1 2 3 4 4:ON 077-212
5 1:ON Tray Module Reset Fail
ON
3TM 2:ON 077-214
1 2 3 4 3:ON
4:ON Tray Module Logic Fail

ON
1:ON 077-215
2:OFF Tray Module
1TM 3:ON
1 2 3 4 Communication Fail
4:ON
077-314
P/H Module Logic Fail
6
2 Actual voltage level is opposite to H/L displayed on UI for this 077-320
diag code. On BSD the actual volt level is shown. All Feed Tray Broken
Fail
j0se730307

Chain 3 Machine Run Control


7-39 7.3 BSD
7-40 7.3 BSD
Chain 3 Machine Run Control
A B C D E F G H J
3.8 PWBS COMMUNICATION (MCU-PF - FINISHER)
MCU-PF MOTOR DRIVER MAIN MOTOR DRIVER SUB MOTOR MOTOR DRIVER MCU-PF PWB
1 PWB PWB PWB DRIVER MAIN PWB PL18.2
PL18.2 PL18.2 PL18.2 SUB PWB PL18.2
PL18.2
+3.3VDC +5VDC
IOT TO FINISHER +3.3VDC +3.3VDC
J1 P1 P452 J452 J590 COMMUNICATION LINE FINISHER TO IOT 041-391
112 69 9 COMMUNICATION LINE J590 J452 P452 P1 J1
10 68 52 047-213
DC COM DC COM
047-216
8.7 REGI. CLUTCH SPARE
ON(H) +5VDC 7
2 70 8 +3.3VDC
DC COM FINISHER DETECT
SIGNAL
1 17
10.6 FUSING UNIT EXIT SENSOR
PAPER SENSED (H)+5VDC
72 2 SEE FINISHER
DC COM
PWBS COMMUNICATION
SPARE
4
3
SPARE
5
+5VDC
LVPS SQ
71 3
DC COM
SIGNAL GND
11
4
DC COM
(1.4 H6)

FAIL CODE
041-391
Finisher Module Logic
Fail
5
047-213
Finisher
Kind Mismatch
047-216
Finisher
Communication Fail

j0se730308
A B C D E F G H J
3.9 PWBS COMMUNICATION (MCU-PF - HCF) FAIL CODE
047-217
MOTOR DRIVER MAIN MOTOR DRIVER HCF Communication
1 PWB MCU-PF TO HCF MAIN PWB Fail
PL18.2 COMMUNICATION PL18.2
3.7 078-216
J594 LINE DP800 DJ800
6 B4 B5 HCF TO MCU-PF 3.7 HCF Logic Fail
BLU DJ800 DP800 COMMUNICATION LINE J594
B6 B3 BLU
5 078-219
+5VDC 2000HCF Software
047-217 Download Fail
HCF NO PAPER
SENSED SIGNAL
B8 B1 BLU
3 078-216
2
+5VDC SEE HCF
LVPS SQ PWBS COMMUNICATION 078-219
1 BLU
A3 A4
DC COM
HCF FEED STOP
2 BLU
A4 A3
DC COM

HCF FEED OUT


3 4 BLU
B2 B7
DC COM

j0se730309

Chain 3 Machine Run Control


7-41 7.3 BSD
7-42 7.3 BSD
Chain 3 Machine Run Control
A B C D E F G H J
3.10 POOR CABLE CONNECTION FAIL CODE
062-396
BP PWB ESS PWB CCD Cable Connection
1 PL18.2 PL35.2 Fail
ESS PWB BP PWB IIT TRANS PWB
PL35.2 PL18.2 PL1.6 062-397
IIT-Cont Video Cable
Connection Fail
P309 J309 J336 PING 1 J7191 J7191 TRANS PONG J336 J309 P309
113 1 51 2 50 138 062-397 062-398
IIT-Cont I/O Cable
Connection Fail
CCD LENS IIT TRANS
ASSEMBLY PWB
PL1.3 PL1.6
2
CCD CCD
P710 PING J700 J700 P710 J7191 PONG
50 1 50 1 1 51 137 062-396

J390 PING IO J7192 J7192 PING IO J390


12 GRY 29 12 BLU GRY
29 83 062-398

j0se730310
A B C D E F G H J
FAIL CODE
3.11 PWB DETECTION
041-351
ESS PWB BP PWB ESS PWB BP PWB ESS PWB MS Detect Fail
1 PL35.2 PL18.2 PL35.2 PL18.2 PL35.2
045-379
RBT
+3.3VDC Motor Driver Main/Sub
PWB Type Mismatch
P309 J309 BP DETECT J309 P309 P335 J335 J335 P335
140 71 70 71
DC COM
(1.4 D2)

2 BP PWB MOTOR DRIVER MAIN PWB


PL18.2 PL18.2

+3.3VDC

J451 P451 BP DETECT


B2

DC COM

3 MOTOR MOTOR DRIVER SUB PWB MOTOR DRIVER MAIN PWB


DRIVER MAIN PL18.2 PL18.2
PWB
PL18.2 +3.3VDC

P452 J452 MD DETECT J452 P452 041-351


51 50
045-379
DC COM
(1.4 D4)

j0se730311

Chain 3 Machine Run Control


7-43 7.3 BSD
7-44 7.3 BSD
Chain 3 Machine Run Control
A B C D E F G H J
3.12 ACCESSORY (1/9) (FX ONLY) FAIL CODE
033-715 121-310
Cannot start job EPSV-Accessory Communication Fail
1 ESS PWB
PL35.2 021-360 121-316
339 Adaptor-BOX
type D/type S EP Accessory Fail EP Accessory conflicts with SecureAccess
021-360 021-942 E9100053 021-361 121-320
J351 P2 TX+ P1 EP Accessory Kind Config Error EP Setting information conflict fail
021-361 021-943 6 6 8
021-731 121-321
021-731 021-944
TX- EP Accessory - Function Disabled EP-DX Setting information conflict fail
021-732 021-945 5 5 9
021-732 121-322
2 RX+ EP Accessory Error732 Controller Price Table Error
021-733 021-946 3 3 6

021-750 021-947 021-733 121-333


RX- EP Accessory Error733 EPSV-EP M/C Communication Fail
2 2 7
021-751 021-948
021-750 121-334
021-770 021-949 U Parts Request Fail (EP-SV) EPSV Login Fail
7 7 25
021-771 121-310 CIE 021-751 121-335
+3.3VDC DC COM
Maintenance Request Fail (EP-SV) EPSV Wake Up Answer Fail
3 021-772 121-333 (1.4 D2) ADAPTOR BOX
EXIST(L)+3.3VDC 021-770 121-336
021-941 121-334 12 12 24
U Parts Request Fail (EP-DX) Unknown EP Accessory
121-335 121-338 DC COM
021-771 121-337
+24VDC Maintenance Request Fail (EP-DX) EP Accessory Self Diag Failgh
121-336 121-339 14 14 3

121-337 121-340 EPSV 021-772 121-338


+24VDC DC COM
(1.7 F2) 13 13 5 EPDX Install, Remove Error EPSV Answer Time Out
121-350 121-370
DC COM 021-941 121-339
4 (1.4 D2) +5VDC EP-Scan Service Paused By Disable Changed Price Table Error
8 8 22
EPSV 021-942 121-340
+5VDC 9 9
(1.4 F2) EP-Scan Service Paused By Color Mode EP Accessory Miss Match
DC COM
10 10 23 021-943 121-350
DC COM EP-Print Service Paused By Disable EPSV Logic Fail
(1.4 D2) GND
1,4 FG
GRN
1 021-944 121-370
DC COM EP - Print Service Paused By Color Mode EP-DX - Unexpected Error
5 (1.4 D2) 2
GRN 021-945
EP - Service Paused By Disable
021-946
EP - Service Paused By Color Mode
021-947
Subtract Type Accessory Remaining Rate Short (Scan)
021-948
6
Subtract Type Accessory Remaining Rate Short (Print)
021-949
Subtract Type Accessory Remaining Rate Short
j0se730312
A B C D E F G H J
3.13 ACCESSORY (2/9) (FX ONLY)

1 ESS PWB 300 COIN KIT 334 COPY COIN KIT 8


PL35.2 5/6N DISPENSER 2 342

J351 P2 TX+ P2 TX+ P2 TX+


6 6 4 6 7 6 10

TX- TX- TX-


5 5 5 5 8 5 9
RX+ RX+ RX+
3 3 6 3 5 3 14
2
RX- RX- RX-
2 2 7 2 6 2 15

N.C N.C
DC COM
7 7 7 7 7
CIE
+3.3VDC DC COM
(1.4 D2)
COIN KIT DISPENSER 2 COIN KIT 8
12 EXIST(L)+3.3VDC 12 EXIST(L)+3.3VDC 12 EXIST(L)+3.3VDC
12 10 1 12
3

+24VDC +24VDC +24VDC


14 14 2 14 3 14 3
EPSV
+24VDC DC COM DC COM DC COM
(1.7 F2) 13 13 3 13 4 13 2
DC COM
8 +5VDC N.C 8 +5VDC N.C
8
4 EPSV
+5VDC 9 9 9
(1.4 F2)
10 DC COM 10 DC COM
10 9 10
DC COM
(1.4 D2) T1 FG
1,4 FG FG FG 11
GRN GRN
DC COM
(1.4 D2) OPTION J903 P903 CN2
OPTION J903 P903 OPTION J903 P903 1 1
1 1 1 BLK BLK
5 BLK BLK BLK BLK
POWER ON
POWER ON POWER ON ACH
ACH ACH (1.2 F1)
(1.2 F1) (1.2 F1)
2 2
2 2 3 WHT WHT
WHT WHT WHT WHT
POWER ON
POWER ON POWER ON ACN
ACN ACN (1.2 F2)
(1.2 F2) (1.2 F2)

3 3 5 T89 GN/YL 3 GN/YL


T89 GN/YL GN/YL T89 GN/YL GN/YL
6
F.G.

j0se730313

Chain 3 Machine Run Control


7-45 7.3 BSD
7-46 7.3 BSD
Chain 3 Machine Run Control
A B C D E F G H J
3.14 ACCESSORY (3/9) (FX ONLY)
346 Connection BOX 1 710 EPnet-BOX 335 DocuLyzer/
for EM Type W2/ DocuLyzer
1 ESS PWB EPnet-BOX NW
PL35.2 Type L
P2 TX+ J1
J351 P2 TX+ P1 P2 TX+ P1 6 5
6 6 10 6 10
TX-
TX- TX- 5 6
5 5 9 5 9
RX+
RX+ RX+ 3 7
3 3 14 3 14
2 2
RX-
8
RX- RX-
2 2 15 2 15

7
7 7 7 7 7
CIE
+3.3VDC DC COM
(1.4 D2) CONNECTION
BOX 1 EXIST(L) Epnet BOX
+3.3VDC EXIST(L)+3.3VDC 12
12 12 12 12 12
3
+24VDC
+24VDC +24VDC 14 3
14 14 3 14 3
EPSV DC COM
+24VDC DC COM DC COM 13 4
(1.7 F2) 13 13 2 13 2
DC COM +5VDC
+5VDC +5VDC 8 9
8 8 5 N.C 8 5
4 EPSV 9
+5VDC 9 9 9
(1.4 F2) DC COM
DC COM DC COM 10 10
10 10 4 N.C 10 4
DC COM GND
(1.4 D2) 11 11 FG 1
1,4 FG FG GRN
GRN T1 GRN T1
DC COM 2
GRN GRN GRN
(1.4 D2)

j0se730314
A B C D E F G H J
3.15 ACCESSORY (4/9) (FX ONLY)
Adaptor-BOX type D E9100053 313 KEY SWITCH 304 FOOT SWITCH
1 339 T9100040
OPTION READY
P3 (L)+24VDC J901 P901 P901
11 9 9 9
BLU

J901
15 12 12 12 12 12
VIO
DC COM 1 CL1
22
2 CL2
2
23
2 2
BLU
6
DC COM 3
1
DC COM 1 1
ORN
5
3 DC COM
14 N.C
+24VDC

2
DC COM
3
DC COM
4
4
DC COM
M/C START (L)+24VDC
12 10 10 10 10
BLU

10
DC COM
9 NOTE:
5
DC COM
1 Detection of connection with related product 1
8
DC COM 2 Detection of connection with related product 2
N.C
7
3 When installing Foot Switch, prepare Relay Harness T9100040 in advance.
DC COM
13
+5VDC
6 24
25
26
j0se730315

Chain 3 Machine Run Control


7-47 7.3 BSD
7-48 7.3 BSD
Chain 3 Machine Run Control
A B C D E F G H J
3.16 ACCESSORY (5/9) (FX ONLY)
300 COIN KIT 5
1 339 Adaptor-BOX type D 334 COPY
DISPENSER 2
T9100076 T9100078
J3 P3 TX+ J1 P3 TX+ J50 J2
16 16 7 16 4 GRY
4

TX- TX-
17 17 8 17 5 RED
5
RX+ RX+
18 18 5 18 6 BLK
6
2
RX- RX-
19 19 6 19 7 YEL
7
EXIST EXIST
25 25 10 25
+24VDC DC COM +24VDC
14 14 3 14 2 GRN
2
+24VDC DC COM +24VDC +24VDC
15 15 4 15
1
DC COM 1 A DC COM
3 CL1 CL1
22 22 22
+5VDC IN
+5VDC IN +5VDC IN
3 20 20 2 20 8 8
PNK
+5VDC +5VDC
DC COM DC COM
21 21 1 21 9 VIO
9
2
DC COM 2 DC COM
CL2 CL2
23 23 23 3 BRN
3
4 T1
26 26 GRN GRN
26 GRN GRN
10 WHT
10
KEY 313 KEY
SWITCH A SWITCH 313 DC COM
OPTION READY 304 FOOT
(L)+24VDC J901 SWITCH P901 J901 P901
11 11 9 9 11 9 9
A OPTION
A J903 P903
12 12 12 12 12 1
BLK BLK
5 POWER ON
ACH
(1.2 F1)
M/C START
(L)+24VDC 2
WHT WHT
12 12 10 10 12 10 POWER ON
ACN
(1.2 F2)

3
GN/YL GN/YL
6 T89

NOTE:
1 Detection of connection 2 Detection of connection 3 This +5V is supplied from the related product.
with related product 1 with related product 2 In absence of this +5V, the communication circuit of Adapter Box does not function. j0se730316
A B C D E F G H J
3.17 ACCESSORY (6/9) (FX ONLY)

1 339 Adaptor-BOX type D 346 Connection 344 IC Card 335 DocuLyzer/


BOX 1 for EM Cashier DocuLyzer
T9100081 T9100073 NW

J2 P2 TX+ P1 P2 P1 P2 TX+ J1
16 16 10 16 10 16 5

TX- TX-
17 17 9 17 9 17 6
RX+ RX+
18 18 14 18 14 18 7
2
RX- RX-
19 19 15 19 15 19 8
+24VDC +24VDC J3
14 14 3 14 3 14 1
+24VDC +24VDC +24VDC +24VDC
DC COM DC COM J1
15 15 2 15 2 15 4
3
DC COM
CL3 CL3 DC COM DC COM J3
3 24 24 24 N.C 3
+5VDC IN DC COM
+5VDC IN +5VDC IN
4 20 20 8 20 8 20 6
J1
+5VDC +5VDC 9
DC COM DC COM
21 21 7 21 7 21 10 +5VDC
1
DC COM DC COM DC COM
CL1 CL1 CL1 J3
22 22 22 22 5
4 EXIST EXIST EXIST
25 25 12 25 12 25 4
DC COM DC COM DC COM
FG FG J1
26 26 11 26 11 26 1
2
CL2 GRN
2
23 23 N.C 23 N.C 23 N.C

NOTE:
1 Detection of connection with related product 1

2 Detection of connection with related product 2

3 Detection of connection with related product 3


6
4 This +5V is supplied from the related product.
In absence of this +5V, the communication circuit of Adapter Box does not function.

j0se730317

Chain 3 Machine Run Control


7-49 7.3 BSD
7-50 7.3 BSD
Chain 3 Machine Run Control
A B C D E F G H J
3.18 ACCESSORY (7/9) (FX ONLY)

1 339 Adaptor-BOX type D 300 COIN KIT


334 COPY 5/6N
DISPENSER 2
T9100070 T9100072
J2 P2 TX+ J1 P2 J50 TX+ J2
16 16 7 16 4 4
GRY

TX- TX-
17 17 8 17 5 RED
5
RX+ RX+
18 18 5 18 6 BLK
6
2
RX- RX-
19 19 6 19 7 YEL
7
+24VDC +24VDC
14 14 3 14 2 GRN
2
+24VDC +24VDC +24VDC
DC COM DC COM
15 15 4 15 3 BRN
3
3
DC COM
CL3 DC COM DC COM
3 24 24 N.C 24 N.C A
+5VDC IN
+5VDC IN +5VDC IN
4 20 20 2 20 8 8
PNK
+5VDC +5VDC
DC COM DC COM
21 21 1 21 9 VIO
9
1 A
DC COM DC COM
CL1 CL1 CL2
22 22 22
4
EXIST EXIST EXIST
25 25 10 25
DC COM
T1 FG
26 26 GRN GRN
26 GRN 10 WHT
10
2
OPTION DC COM
CL2 J903 P903 J2
23 23 N.C
BLK
1 1 23 N.C
BLK
POWER ON OPTION
ACH J903 P903
5 (1.2 F1) BLK
1 BLK
POWER ON
2 3 ACH
WHT WHT
NOTE: (1.2 F1)
POWER ON
Detection of connection ACN
1 (1.2 F2) 2
with related product 1 WHT WHT
POWER ON
2 Detection of connection GN/YL
3 5 ACN
GN/YL
with related product 2 T89 (1.2 F2)

6 3 Detection of connection 3
GN/YL GN/YL
with related product 3
T89
4 This +5V is supplied from the related product.
In absence of this +5V, the communication circuit of Adapter Box does not function.
j0se730318
A B C D E F G H J
3.19 ACCESSORY (8/9)
ESS PWB BP PWB
1 PL35.2 PL18.2

USB PWR P309 J309


14
RBT
+3.3VDC
J1313 USB HUB VBUS USB P2
USB OC 1 1
15
F1001

USB 1
2 +5VDC
(1.6 G2)
DATA- DATA- GENERAL USB PORT
16 2 2

DATA+ DATA+
17 3 3

4 4
3 DC COM USB CABLE
(1.4 J2)

NOTE: 1 Chip Fuse

j0se730319

Chain 3 Machine Run Control


7-51 7.3 BSD
7-52 7.3 BSD
Chain 3 Machine Run Control
A B C D E F G H J
3.20 ACCESSORY (9/9)
USB HUB PWB
ESS PWB BP PWB PL1.6 P1
1 PL35.2 PL18.2
VBUS 1: VBUS
Power 2: DATA+
USB PWR P309 J309 Supply 3: DATA- Type A : W85 UI
14 +5VDC 4: GND
RBT Type B CR3 CR2
+3.3VDC GRN ORN
J1313 USB HUB VBUS P5
USB OC 1 1
15
F1001
P2
DC COM DC COM
USB 1 1: VBUS
2 +5VDC DATA 2: DATA+
DATA- (1.6 G2) DATA- 3: DATA- Type A : ACCESSORY
16 2 2 4: GND
CR4 CR5
GRN ORN
DATA+ DATA+
17 3 3

P3
DC COM DC COM
4 4
+3.3VDC 1: VBUS
DC COM USB CABLE DC COM 2: DATA+
(1.4 J2) 3: DATA- Type A : S104 UI
3 4: GND
CR6 CR7
GRN ORN

NOTE: 1 Chip Fuse 1


1.6 +5VDC
+5VDC MAIN J350 P2 F1 P4
1 DC COM DC COM
GRY +3.3VDC 1: VBUS
1.6 +5V 2: DATA+
DC COM TO 3: DATA- Type A : ACCESSORY
3 +3.3V 4: GND
VIO CR9 CR8
4 DC COM CR10 GRN ORN
DC COM

DC COM DC COM

5
J1
J5
USB HUB PWB

J2 P2/J350

6
J3 J4
F1 (+5V Input)
j0se730320
A B C D E F G H J

3.21 ELECTRIC BILLING

1 MOTOR DRIVER MAIN BP PWB ESS PWB


PWB PL18.2 PL35.2
PL18.2
IC SOCKET
SEEP ROM SEEP ROM
BILLING BILLING J335 P335 J1332
53 2
DATA DATA SD CARD
(BACK UP 2) (MASTER) PL35.2
(IOT) (SYS1) 3
1 BILLING
2 1 SDATA DATA
123 4
(BACK
UP1)
U80 U401 (SYS2)
CONT PL18.2
+3.3VDC
(1.4 J3)

NOTE: When replacing Motor Driver Main PWB/BP PWB, In the following cases, manually correct billing data, using DC132.
1 4
3 install the old SEEP ROM on the new Motor Driver Main PWB/BP PWB. ・After replacing Motor Driver Main PWB
SEEP ROM stores Billing, M/C Serial No., etc. ・After replacing ESS PWB
・Fail Code [124-324] (three counts are all different) has occurred.
・Fail Code [124-325] (automatic count correction failed) has occurred.
2 When replacing ESS PWB, install the old SD card on the new ESS PWB.
SD card stores Billing, M/C Serial No., etc.

3 Here are Fail Codes.


024-600 124-314 124-324
4 DC132 01 All Billing Mismatch
024-601
124-315 124-325
024-602 DC132 02 Billing Restoration Fail
124-316
024-603
DC132 03
024-604 124-317
DC132 04
024-605
5 124-318
124-310 DC132 07
DC132 11 124-319
124-311 DC132 08
DC132 09 124-322
124-312 DC132 05
DC132 12 124-323
6 124-313 DC132 06
DC132 10

j0se730321

Chain 3 Machine Run Control


7-53 7.3 BSD
7-54 7.3 BSD
Chain4 Start Print Power
A B C D E F G H J
4.1 MAIN DRIVE CONTROL (2275/3373/3375/4475/5575) FAIL CODE
042-325
MOTOR DRIVER MAIN
MAIN DRIVE MOTOR PWB Main Motor Fail
1 MOTOR DRIVER 1 PL3.2 PL18.2 ELECTRICAL COMPONENTS & DRIVE TRANSMISSION
MAIN PWB
PL18.2 DC330 042-001 TO 042-006 +3.3VDC
+5VDC
MAIN DRIVE MOTOR MAIN DRIVE MOTOR <2275/3373/3375> Main Drive Motor
J525 ON(L) +5VDC J245 J245 FAIL(H) +3.3VDC J525
A11 BLU 6 8 BLU
A9 042-325
+5VDC
DC COM Take Away
CLOCK Clutch Regi. Clutch
A10 BLU 7 (CH8.7)
+5VDC (CH8.3)
DC COM
BRAKE
2 A12 BLU 5
+5VDC
DC COM
GAIN
A14 BLU 3
DC COM
+5VDC
A16 BLU 1
+5VDC
(1.6 D2)
DC COM
A15 BLU 2
3
DC COM
(1.4 D4)
J535 INTLK +24VDC J244
1 ORN
1
INTLK
+24V F14
(1.12 E5) DC COM
2 VIO
2
DC COM
(1.4 D4)
<4475/5575>
4 Main Drive Motor

NOTE: Regi. Clutch


(CH8.7)
1 The operation varies depending on the diag code.

DC330 Process Speed

042-001 79mm/sec
5 042-002 121mm/sec
042-003 175mm/sec
042-004 200mm/sec
042-005 228mm/sec
042-006 255mm/sec

j0se730401
A B C D E F G H J
4.2 DRIVE UNIT COOLING (4475/5575/6675/7775) FAIL CODE
042-344
MOTOR DRIVER MOTOR DRIVER SUB PWB C Exhaust Fan Fail
1 MAIN PWB PL18.2 1 DC330 042-025
PL18.2 +24VDC
F1
(1.8 G1) C EXHAUST MOTOR DRIVER MOTOR DRIVER MAIN
S DC330 042-024 FAN SUB PWB PWB
ON P452 J452 G PL4.3 PL18.2 PL18.2
15 C EXHAUST FAN DC330 042-213
J529 ON(H) +24VDC J227 P227 +3.3VDC
DC COM B13 GRY 4 1 C EXHAUST FAN
D P227 J227 FAIL(H) +3.3VDC J529 J452 P452
MOT 3 2 GRY
B14 13 042-344
2 B15 GRY 1 4
DC COM
(1.4 H6)

ELECTRICAL COMPONENTS NOTE:


1 DC330[042-025] performs a fault detection after
rotating the target fans concurrently for 5 seconds.
3 If any fan is found to be faulty, a fail code is issued.
Fail codes can be referred to via DC125.
Check the following NVM settings in advance.
(1) NVM741-072: Fan Fail Bypass should be "0".
If you want to prevent any particular fan from raising a fail,
change this value to the fail bypass number for that fan.
(2) NVM741-146: LH FAN CONDITION FLAG should be 1 or 2".
If you want to prevent an LH Fan Fail from being raised,
change this value to "0".

4 The following fans are targeted:


・010-398: Fusing Unit Fan
・042-336: Process 2 Fan
・043-322: LVPS FAN
・042-332: IH Intake Fan
・042-330: IH Exhaust Fan
・042-609: LH Fan 1/2/3 (When NVM742-146 is set to "1 or 2")
・042-342: Suction Fan (4475/5575/6675/7775)
・042-340: Cartridge Fan (4475/5575/6675/7775)
・042-335: Process 1 Fan (4475/5575/6675/7775)
・042-344: C Exhaust Fan (4475/5575/6675/7775)
・042-343: Rear Bottom Fan (4475/5575/6675/7775)
5 ・042-341: HV Fan (4475/5575/6675/7775)
・043-321: RH Fan (4475/5575/6675/7775)
C Exhaust Fan ・042-341: Marking Fan (2275/3373/3375)

j0se730402

Chain4 Start Print Power


7-55 7.3 BSD
7-56 7.3 BSD
Chain 5 Document Transportation
A B C D E F G H J

5.1 DADF DOCUMENT SETTING (DADF-110) FAIL CODE


DADF PWB
PL51.2 RT1 005-305
DADF
DADF PWB INTERLOCK DADF Feeder Cover
1 PL51.2 SWITCH
2 DC330 005-212 Interlock Open
3 DADF 5.3
PL51.5 DADF INTLK SWITCH Q1 TP5 INTLK ON 005-940
J753 F1 F2 CLOSED (H)+24VDC J753 S D +24VDC 5.5
1 1 2 2 FET DADF No Original
ORN ORN Fail
G
+24VDC
(1.9 J2) 005-941
+5VDC Doc Number of
Sheets is Insufficient
005-305
2 2 DC330 005-102 SLEEP DC COM IIT TRANS
PWB
DOC. SET SENSOR TD
1
+5VDC
PL1.6
J757 J771 DOC. SENSED
3 1 J771 (L)+5VDC J757 005-940 SLEEP
YEL 2 2
YEL +5VDC
SLEEP 005-941
+5VDC
(1.9 J4) J752 WAKEUP A J750 J7191 WAKEUP A
1 3 A1 32 4
YEL
DC COM DADF DOCUMENT DC COM DC COM
(1.9 J6) SET SENSOR
PL51.6
3 DADF
DOCUMENT BP PWB +3.3VDC ESS PWB +3.3VDC
+5VDC SET LED PL18.2 PL35.2
(1.9 J1) TD DC330 005-084 PL51.7 J309 P309
J756 2 SET LED ON(H)+5VDC J791 87
+3.3VDC
17 YEL 1
DC COM
J336
DC COM 48
16 YEL 2
DC COM
DC COM
(1.9 J6)
4 DOCUMENT
DC330 005-090 SET GATE ELECTRICAL COMPONENTS
DOC. SET GATE SOLENOID
SOLENOID GATE PL51.6 Document Set Sensor
J754 OPEN (L)+24VDC J779 1 DADF Interlock Switch
A2 BLU 1 2
DC COM
F2
A1 ORN 2 1 Document Set Gate Solenoid
1.25A
+24VDC 4 +24VDC (BLU)
(1.9 J2) F2 5.6
5 GRN
(PWB SIDE) T2 T3 (MOTOR BRACKET)
F.G F.G

NOTE:
TD Test Point: DADF PWB J757-2 (+) to GND (-)
1 The coil resistance of the solenoid is 40Ω±10%. (coil temp 20℃) 1 Diag ON: approx. +2.64VDC
2 Actual voltage level is opposite to H/L displayed on UI for this TD Test Point: DADF PWB J756-17 (+) to GND (-)
diag code. On BSD the actual volt level is shown. 2 Diag ON: approx. +1.97VDC
3 Inrush Current Protection Element (RT1) is installed to prevent a problem from occurring in
6 a surrounding circuit due to a great inrush current that generates at the opening/closing of
Interlock Switch. When Interlock Switch is closed, causing an inrush current to flow in RT1,
the internal resistance of RT1 protects the circuit. When 50ms has passed since Interlock was closed, DADF Document Set LED
FET (Q1) turns ON, leading to a stable power supply to the motors.
4 Chip Fuse j0se730501
A B C D E F G H J
ELECTRICAL COMPONENTS
5.2 DADF DOCUMENT SIZE SENSING (DADF-110) DADF PWB
PL51.2
DADF PWB DC330 005-221 1 +5VDC Doc. Tray Size Sensor 1
1 PL51.2
J756 J761 DOC. TRAY SIZE SNR 1 Doc. Tray Size Sensor 2
3 1 J761 DOC. SENSED (L)+5VDC J756
YEL 2 2
YEL

1 3 1
YEL DC330 005-222
DOC. TRAY SIZE +5VDC
SENSOR 1 PL51.10 DOC. TRAY SIZE
+5VDC J764 SNR 2 DOC.
6 1 J764 SENSED (L)+5VDC Doc. Tray Set
YEL 2 5 Guide Sensor 1
YEL
2 DC COM
4 3 Doc. Tray Set
YEL
Guide Sensor 2
DOC. TRAY SIZE
SENSOR 2 PL51.10 DC330 005-215 1 2
Doc. Tray Set
DOC. TRAY SET GUIDE +5VDC
005-194 Guide Sensor 3
J765 SNR 1 BLOCKED
15 YEL 1 J765 (H)+5VDC
2 YEL
14 005-946
005-948
3 13 YEL 3 2 The following shows the relation between paper size and
1 005-921 combination of ON/OFF outputs from the Size Sensors.
DOC. TRAY SET DC330 005-216
GUIDE SENSOR 1 (BLU) +5VDC
PL51.10 DOC. TRAY SET GUIDE DOC.
(BLU) SNR 2 BLOCKED DOC. Tray Set Tray Size DADF
+5VDC J763 Guide Sensor
12 YEL 1 J763 (H)+5VDC Document Size Sensor APS
2 YEL
11 Sensor 1
1 2 3 1 2
DC COM A5 S/5.5"×8.5"S OFF OFF ON ON OFF -
10 YEL 3
1 B5S OFF OFF OFF ON OFF ON
DOC. TRAY SET DC330 005-217
4 GUIDE SENSOR 2 +5VDC 16K
PL51.10 DOC. TRAY SET GUIDE OFF OFF OFF ON OFF OFF
J762 SNR 3 BLOCKED S/8"×10"(10.5")S
9 1 J762 (H)+5VDC
YEL 2 8 A5 L OFF OFF
YEL OFF ON OFF
+5VDC A4 S ON OFF
(1.9 J1)
7 3 5.5"×8.5"L OFF OFF
YEL
DOC. TRAY SET 8.5"×11"S OFF ON ON ON OFF
GUIDE SENSOR 3
PL51.10 SHORTING 8.5"×13"(14")S ON ON
WIRE DC330 005-227 +5VDC
5 8"×10"L ON OFF
DADF TYPE DETECT
(L)+5VDC B5 L ON OFF ON OFF OFF
19 YEL YEL
18
B4 S ON ON -
DC COM 8.5"×10.5"L ON OFF
(1.9 J6)
16K L/ExecutiveL ON OFF OFF OFF OFF
NOTE: FAIL CODE 8K S ON ON
1 Actual voltage level is opposite to 8.5"×11"L ON OFF
H/L displayed on UI for this diag code. 005-194 Size Mismatch Jam on SS Mix-size ON ON OFF
6 On BSD the actual volt level is shown. 11"×15"(17")L ON ON
005-946 SS-Size Mismatch Jam on No Mix-Size (Cont)
A4 L ON OFF
005-948 SS-Size Mismatch Jam on No Mix-Size ON ON ON
A3 S ON ON
005-921 Let SEF Detect Error
j0se730502

Chain 5 Document Transportation


7-57 7.3 BSD
7-58 7.3 BSD
Chain 5 Document Transportation
A B C D E F G H J
5.3 DADF DOCUMENT FEEDING (1/2) (DADF-110) ELECTRICAL COMPONENTS & DRIVE TRANSMISSION FAIL CODE
005-121
DADF Feed Motor
DADF PWB 4 5 DADF Feed Out Sensor On Jam
1 PL51.2 DADF FEED DADF Feed Out Sensor
DC330 005-001 TO 005-021 MOTOR 005-122
DADF FEED MOTOR ON PL51.5 DADF Simplex/Side 1 Pre Regi.
J754 +24V CLOCK A J776 Sensor On Jam
B6 BLU 1
1 005-135
DC COM
CLOCK /A DADF Side 2 Pre Regi. Sensor
B5 BLU 3 DADF Pre Regi Sensor On Jam
DC COM 005-146
CLOCK B
B4 BLU 4 DADF Pre Regi. Sensor Off Jam
2
DC COM MOT 005-147
CLOCK /B
B3 BLU 6 DADF Pre Regi. Sensor Off Jam
on Inverting
DC COM INTLK ON
F4 +24VDC (ACOM) 005-197
B2 ORN 2
4A Prohibit Combine Size Jam
2 INTLK ON
DADF
+24VDC (BCOM) 005-198
INTLK ON
B1 ORN 5
Too Short Size Jam
+24VDC
(5.1 F1) 005-199
3
Too Long Size Jam
005-906
DADF PWB DADF Feed Out Sensor Static
PL51.2 Jam
005-907
DC330 005-205 3 +5VDC 005-121
DADF Pre Regi. Sensor Static Jam
J757 J772 DADF FEED OUT SNR
6 1 J772 DOC. SENSED (L)+5VDC J757 005-906
4 YEL 2 5
YEL 5 The operation varies depending on the diag code.
The operation lasts for 50 sec, and then ends
automatically.
4 YEL
3 005-197
DC330 Rotation
Process Speed Direction
DADF FEED OUT
SENSOR PL51.6 005-198
005-001 41.3mm/sec
005-199 005-002 55.0mm/sec
005-003 73.3mm/sec
DC330 005-206 005-122
5 +5VDC 005-004 82.5mm/sec
DADF PRE REGI SNR
J770 P770 J774 DOC. SENSED 005-135 005-005 110.0mm/sec
12 YEL 4 6 1 J774 P770 J770 (H)+5VDC
YEL 2 5 5 11 005-007 146.7mm/sec CW
YEL YEL 005-146
+5VDC 005-008 165mm/sec
(1.9 J1)
005-147 005-010 220mm/sec
10 YEL 6 4 YEL
3
DADF PRE REGI 005-907 005-014 293.3mm/sec
DC COM SENSOR PL51.17
(1.9 J6) 005-015 330mm/sec
6 005-017 440mm/sec
NOTE:
Actual voltage level is opposite to H/L displayed on UI for this diag code. 005-019 400mm/sec
1 The winding resistance of DADF Feed Motor is 1.15Ω±0.12Ω 3 On BSD the actual volt level is shown. 005-020 300mm/sec CCW
2 Chip Fuse 4 DC330[005-093] performs initialization of Nudger Roll. 005-021 240mm/sec j0se730503
A B C D E F G H J
5.4 DADF DOCUMENT FEEDING (2/2) (DADF-110) FAIL CODE
DADF PWB 005-196
PL51.2
DADF PWB Size Mismatch Jam on No Mix-Size
1 PL51.2 DC330 005-218 +5VDC
005-915
J758 J766 P766 J769 DADF APS SNR 1
11 YEL 2 9 1 J769 P766 J766 DOC. SENSED (H)+5VDC J758 DADF APS Sensor 1 Static Jam
YEL 2 8 3 10 005-915
YEL YEL 005-916
005-196 DADF APS Sensor 2 Static Jam
9 YEL
4 7 YEL
3
005-917
DADF APS SENSOR
1 PL51.17 DADF APS Sensor 3 Static Jam
005-945
2 1 DC330 005-219 +5VDC
FS-Size Mismatch Jam on No
J768 DADF APS SNR 2 Mix-Size or SS Mix-Size (Cont)
8 5 6 1 J768 DOC. SENSED (L)+5VDC
YEL YEL 2 5 6 7 005-916 005-947
YEL YEL
FS-Size Mismatch Jam on No
005-945 Mix-Size or SS Mix-Size
6 YEL
7 4 YEL
3
005-947
DADF APS SENSOR
2 PL51.17

3 DC330 005-220 +5VDC


J767 DADF APS SNR 3
5 8 3 1 J767 DOC. SENSED (H)+5VDC
YEL YEL 2 2 9 4 005-917
YEL YEL
+5VDC
(1.9 J1)
3 YEL
10 1 YEL
3
DADF APS SENSOR
3 PL51.17
SHORTING
4 WIRE +5VDC
DC330 005-228
APS EXIST (L) +5VDC
1 YEL YEL
2

DC COM
(1.9 J6)

NOTE: ELECTRICAL COMPONENTS


5 Actual voltage level is opposite to H/L displayed on UI for this diag code.
1 On BSD the actual volt level is shown.

Front

6 DADF APS Sensor 1


DADF APS Sensor 3
DADF APS Sensor 2
j0se730504

Chain 5 Document Transportation


7-59 7.3 BSD
7-60 7.3 BSD
Chain 5 Document Transportation
A B C D E F G H J
5.5 DADF DOCUMENT SCAN AND INVERT (DADF-110) FAIL CODE
DADF PWB
PL51.2 005-123
DC330 005-110
DADF PWB +5VDC DADF Simplex/Side 1 Regi. Sensor
PL51.2 DADF REGI. SNR On Jam
1 J757 J770 P770 J775 DOC. SENSED (H)
15 YEL 1 9 YEL
1 J775 P770 J770 +5VDC J757 005-123 005-145 005-125
2 8 2 14
YEL YEL DADF Regi. Sensor Off Jam
005-125 005-908
005-131
13 YEL 3 7 YEL
3 005-136 DADF Invert Sensor On Jam on
DADF REGI. Inverting
SENSOR PL51.17
005-132
DC330 005-211
+5VDC DADF Invert Sensor On Jam
DADF INVERT SNR
2 DOC. SENSED (H)
J773 005-134
9 7 3 1 J773 +5VDC
YEL YEL 2 2 8 8 DADF Invert Sensor Off Jam on
YEL YEL 005-131 005-139 Inverting
+5VDC
(1.9 J1) 005-132 005-913 005-136
7 YEL
9 1 YEL
3
DADF Side 2 Regi. Sensor On Jam
DADF INVERT 005-134
DC COM
SENSOR PL51.9 005-139
(1.9 J6) DADF Invert Sensor Off Jam
3 005-145
ELECTRICAL COMPONENTS & DRIVE TRANSMISSION
DADF Regi. Sensor Off Jam on Inverting
DADF
3 REGI. 005-908
MOTOR DADF Regi. Sensor Static Jam
DC330 005-026 TO 005-041 PL51.5 DADF Regi Motor
J754 MOT ON +24V CLOCK A J777 005-913
A4 BLU 4 1
DADF Invert Sensor Static Jam
DC COM
CLOCK /A
A5 BLU 6
4
DC COM 3 The operation varies depending on the diag code.
CLOCK B The operation lasts for 50 sec, and then ends
A6 BLU 3
automatically.
DC COM MOT
CLOCK /B DC330 Process Speed Rotation
A7 BLU 1 Direction
DC COM 005-026 41.3mm/sec
INTLK ON +24VDC (ACOM)
A8 ORN 5 005-027 55mm/sec
005-028 73.3mm/sec
5 F5 INTLK ON +24VDC (BCOM)
A9 ORN 2 005-029 82.5mm/sec
4A
DADF 2 005-030 110mm/sec
INTLK ON DADF Regi Sensor
+24VDC 005-032 146.7mm/sec CCW
(5.1 F1)
005-033 165mm/sec
005-035 220mm/sec
DADF Invert Sensor
005-037 293.3mm/sec
NOTE:
005-038 330mm/sec
6 1 The winding resistance of DADF Regi Motor is 2.7Ω±0.27Ω
005-041 440mm/sec
2 Chip Fuse

j0se730505
A B C D E F G H J
5.6 DADF DOCUMENT EXIT TRANSPORTATION (DADF-110) ELECTRICAL COMPONENTS

DADF PWB EXIT NIP


1 PL51.2 RELEASE
DC330 005-072 SOLENOID
EXIT NIP RELEASE PL51.6
SOLENOID
J754 ON (L) +24VDC J778 P778 1
B9 BLU 1 2
DC COM
B8 ORN 2 1
+24VDC
F2
2 (5.1 B5) Stamp Solenoid
(Option)
DC330 005-226
+5VDC STAMP SET
SIGNAL OPTION Exit Nip Release Solenoid
STAMP
SOLENOID
DC330 005-073 PL51.8
DC COM
STAMP SOLENOID 2
J755 ON (L) +24VDC P780 J780
2 BLU
1 2
3
DC COM
1 ORN
2 1
+24VDC
F2
(5.1 B5)

NOTE:
4 1 The coil resistance of Exit Nip Release Solenoid is 50Ω±10% (coil temp 20℃)

2 The coil resistance of Stamp Solenoid is 60Ω±10% (coil temp 20℃)

j0se730506

Chain 5 Document Transportation


7-61 7.3 BSD
7-62 7.3 BSD
Chain 5 Document Transportation
A B C D E F G H J
5.7 DADF DOCUMENT PATH AND DRIVE TRANSMISSION (DADF-110)

1
DADF Feed Motor

Nudger Roll

Feed Roll 3
2 9
Takeaway Roll 2
4 8
567
1

13 14
10 11 12
Exit Roll
3

Registration
Roll

Out Roll M
No. Parts Name CH No. Parts Name CH
DADF Regi Motor
1 DADF Pre Regi Sensor 5.3 11 DADF APS Sensor 2 5.4
2 DADF Feed Out Sensor 5.3 12 DADF APS Sensor 3 5.4
4
3 DADF Interlock Switch 5.1 13 DADF Regi Sensor 5.5
4 DADF Document Set Sensor 5.1 14 DADF Invert Sensor 5.5
5 Doc. Tray Set Guide Sensor 1 5.2
6 Doc. Tray Set Guide Sensor 2 5.2
7 Doc. Tray Set Guide Sensor 3 5.2
8 Doc. Tray Size Sensor 1 5.2
9 Doc. Tray Size Sensor 2 5.2
5
10 DADF APS Sensor 1 5.4

The meaning of symbols: M Stepping Motor Sensor NOTE: The position of motors and sensors on the figure is different from the actual one.

j0se730507
A B C D E F G H J

5.8 DADF INTERLOCK & DOCUMENT SETTING (DADF-130 (1PASS)) FAIL CODE
005-305
DADF PWB
DADF PL55.2 RT1 DADF Feeder Cover
1 DADF PWB INTERLOCK 5.10 Interlock Open
PL55.2 SWITCH 1 DC330 005-212 DADF
2 5.12 005-940
PL55.6 DADF INTLK SWITCH Q1 TP5 INTLK ON
J753 F1 F2 CLOSED (H)+24VDC J753 S D +24VDC 5.13 DADF No Original
1 ORN 2 FET Fail
ORN
G 005-941
+24VDC
(1.9 J2)
+5VDC Doc Number of
Sheets is Insufficient

005-305
2
1 DC330 005-102 SLEEP DC COM IIT TRANS PWB
DOC. SET SENSOR TD +5VDC PL1.6
DOC. SENSED 1
J758 J775
15 YEL 1 J775 (L)+5VDC J758 005-940 SLEEP
2 14 +5VDC
YEL
SLEEP 005-941
+5VDC
(1.9 J4) J752 WAKEUP A J750 J7191 WAKEUP A
13 YEL 3 A1 32 4
DC COM DADF DOCUMENT DC COM DC COM
(1.9 J6) SET SENSOR
3 PL55.5
BP PWB +3.3VDC ESS PWB +3.3VDC
PL18.2 PL35.2
DADF J309 P309
87
DOCUMENT +3.3VDC
+5VDC SET LED DC COM
(1.9 J1) TD DC330 005-084 PL55.7 J336
J756 2 SET LED ON(H)+5VDC J791 48
17 YEL 1
DC COM
4 DC COM
16 YEL 2 ELECTRICAL COMPONENTS
DC COM DADF Document DADF
(1.9 J6) Set LED Document Set Sensor

NOTE:
1 Actual voltage level is opposite to H/L displayed on UI for this
diag code. On BSD the actual volt level is shown.
5
2 Inrush Current Protection Element (RT1) is installed to prevent a problem
from occurring in a surrounding circuit due to a great inrush current that
generates at the opening/closing of Interlock Switch.
When Interlock Switch is closed, causing an inrush current to flow in RT1,
the internal resistance of RT1 protects the circuit.
When 50ms has passed since Interlock was closed, FET (Q1) turns ON,
leading to a stable power supply to the motors.

TD Test Point: DADF PWB J758-14 (+) to GND (-)


6 1 Diag ON: approx. +2.58VDC

TD Test Point: DADF PWB J756-17 (+) to GND (-)


2 Diag ON: approx. +1.96VDC
DADF Interlock switch j0se730508

Chain 5 Document Transportation


7-63 7.3 BSD
7-64 7.3 BSD
Chain 5 Document Transportation
A B C D E F G H J
ELECTRICAL COMPONENTS
5.9 DADF DOCUMENT SIZE SENSING (DADF-130 (1PASS)) Doc. Tray
DADF PWB
PL55.2 Size Sensor 2
DADF PWB DC330 005-221 1 +5VDC
Doc. Tray
1 PL55.2 Doc. Tray Size Sensor 1
J756 J762 DOC. TRAY SIZE SNR 1
3 YEL
1 J762 DOC. SENSED (L)+5VDC J756 Set Guide Sensor 1
2 2
YEL

1 YEL
3
DC330 005-222 1
DOC. TRAY SIZE +5VDC
SENSOR 1 PL55.11 DOC. TRAY SIZE
+5VDC J763 SNR 2 DOC.
6 1 J763 SENSED (L)+5VDC
YEL 2 5
YEL
2 DC COM
4 YEL
3
DOC. TRAY SIZE Doc. Tray
SENSOR 2 PL55.11 1 2 Set Guide Sensor 2
DC330 005-215
DOC. TRAY SET GUIDE +5VDC
J766 SNR 1 BLOCKED 005-194
15 YEL 1 J766 (H)+5VDC
2 YEL
14 005-946 Doc. Tray
005-948 Set Guide Sensor 3
3 13 YEL 3
1 005-921
DOC. TRAY SET DC330 005-216 2 The following shows the relation between paper size and
GUIDE SENSOR 1 (BLU) +5VDC
PL55.11 DOC. TRAY SET GUIDE combination of ON/OFF outputs from the Size Sensors.
+5VDC J765 (BLU) SNR 2 BLOCKED
12 YEL 1 J765 (H)+5VDC DOC.
DOC. Tray Set Tray Size DADF
2 YEL
11 Guide Sensor
Document Size Sensor APS
Sensor 1
DC COM 1 2 3 1 2
10 YEL 3
1 A5 S/5.5"×8.5"S OFF OFF ON ON OFF -
DOC. TRAY SET DC330 005-217
4 GUIDE SENSOR 2 +5VDC B5S OFF OFF OFF ON OFF ON
PL55.11 DOC. TRAY SET GUIDE
J764 SNR 3 BLOCKED 16K
9 1 J764 (H)+5VDC OFF OFF OFF ON OFF OFF
YEL 2 8 S/8"×10"(10.5")S
YEL
+5VDC A5 L OFF OFF
(1.9 J1) OFF ON OFF
7 3 A4 S ON OFF
YEL
DOC. TRAY SET 5.5"×8.5"L OFF OFF
DC COM GUIDE SENSOR 3
(1.9 J6) PL55.11 8.5"×11"S OFF ON ON ON OFF
5 8.5"×13"(14")S ON ON
NOTE: FAIL CODE 8"×10"L ON OFF
1 Actual voltage level is opposite to H/L displayed on UI for this 005-194 Size Mismatch Jam on SS Mix-size B5 L ON OFF ON OFF OFF
diag code. On BSD the actual volt level is shown.
B4 S ON ON -
005-946 SS-Size Mismatch Jam on No Mix-Size (Cont)
8.5"×10.5"L ON OFF
005-948 SS-Size Mismatch Jam on No Mix-Size 16K L/ExecutiveL ON OFF OFF OFF OFF
8K S ON ON
005-921 Let SEF Detect Error
6 8.5"×11"L ON OFF
ON ON OFF
11"×15"(17")L ON ON
A4 L ON OFF
ON ON ON
A3 S ON ON j0se730509
A B C D E F G H J
5.10 DADF DOCUMENT FEEDING (1/2) (DADF-130 (1PASS)) ELECTRICAL COMPONENTS & DRIVE TRANSMISSION FAIL CODE
005-121
DADF PWB DADF FEED DADF Feed Motor DADF Feed Out
1 PL55.2 1 3 MOTOR Sensor On Jam
DADF FEED MOTOR ON PL55.5
005-141
J792 +24V DIR J794
1 4 DADF Feed Out Sensor
BLU Off Jam
DC COM
CLOCK 005-197
2 BLU
5
Prohibit Combine Size
DC COM Jam
BLAKE
3 BLU
6 005-198
J794
2 DC COM MOT 1 Too Short Size Jam
+5VDC BLU
4 GRY
3 005-199
+5VDC INTLK ON Too Long Size Jam
(1.9 J1) +24VDC (ACOM)
F4
6 ORN
8 005-905
3.15A 2 DADF Feed Out Sensor
5VDC RTN Static Jam
DADF 5 7
INTLK ON VIO DADF Feed In Sensor 005-906
+24VDC
(5.8 F1) DC COM DADF Feed In Sensor
(1.9 J6) DADF ENCODER SIGNAL
3 Static Jam
(F-MOT_CHA) DADF Feed Out Sensor
DADF PWB
PL55.2
+5VDC The operation varies depending on the diag code. The operation lasts
3
for 50 sec, and then ends automatically.
J792 DADF PWB When using the Diag to rotate the Feed Motor of DADF-130 (1 Pass),
BLU
7 PL55.2 open the Top cover and use a driver to cheat the DADF Interlock
DC330 005-204 Switch before performing the rotation. If you attempt to rotate the
DADF FEED IN SNR +5VDC
Feed Motor in the normal state, it might cause the generation of
4 J758 P779 J779 J781 DOC. SENSED abnormal noise. (This abnormal noise is due to friction between the
6 1 6 1 J781 J779 P779 (H)+5VDC J758 005-906 Nudger Roll and the Bottom Pad (a Cork Pad below the Nudger))
YEL YEL 2 5 2 5
YEL YEL
005-121 DC330 Process Speed Rotation
Direction
4 3 4 3 005-141 005-045 440.0mm/sec
YEL YEL
DADF FEED IN 005-197 005-046 550.0mm/sec
SENSOR PL55.8
DC330 005-205 005-198 005-047 400.0mm/sec
DADF FEED OUT SNR +5VDC
J780 DOC. SENSED 005-048 300.0mm/sec
J780
005-199
5 3 YEL
4 3 YEL
1 (H)+5VDC 005-049 240.0mm/sec
2 2 5 2 CW
+5VDC
YEL YEL 005-905 005-050 150.0mm/sec (Feed)
(1.9 J1)
005-051 460.0mm/sec
1 YEL
6 1 YEL
3
DADF FEED OUT 005-052 100.0mm/sec
DC COM
(1.9 J6) SENSOR PL55.8 005-053 350.0mm/sec
005-054 220.0mm/sec
005-094 440.0mm/sec
NOTE:
6 005-095 165.0mm/sec
1 DC330[005-093] performs initialization of Nudger Roll. 2 Chip Fuse CCW
005-096 100.0mm/sec
005-097 220.0mm/sec
j0se730510

Chain 5 Document Transportation


7-65 7.3 BSD
7-66 7.3 BSD
Chain 5 Document Transportation
A B C D E F G H J
5.11 DADF DOCUMENT FEEDING (2/2) (DADF-130 (1PASS)) FAIL CODE
DADF PWB 005-196
PL55.2
DADF PWB Size Mismatch Jam on No Mix-Size
1 PL55.2 DC330 005-218 1 +5VDC
005-915
J757 J770 DADF APS SNR 1
9 1 J770 DOC. SENSED (L)+5VDC J757 DADF APS Sensor 1 Static Jam
YEL 2 8 005-915
YEL 005-916
005-196 DADF APS Sensor 2 Static Jam
7 YEL
3
005-917
DADF APS SENSOR
1 PL55.17 DADF APS Sensor 3 Static Jam
005-945
2 DC330 005-219 1 +5VDC
FS-Size Mismatch Jam on No
J769 DADF APS SNR 2 005-916 Mix-Size or SS Mix-Size (Cont)
6 1 J769 DOC. SENSED (L)+5VDC
YEL 2 5 005-945 005-947
YEL
FS-Size Mismatch Jam on No
005-947 Mix-Size or SS Mix-Size
4 YEL
3
DADF APS SENSOR
2 PL55.17

3 DC330 005-220 1 +5VDC


J768 DADF APS SNR 3
3 1 J768 DOC. SENSED (L)+5VDC
YEL 2 2 005-917
YEL
+5VDC
(1.9 J1)
1 YEL
3
DADF APS SENSOR
DC COM 3 PL55.17
(1.9 J6)

4
ELECTRICAL COMPONENTS
NOTE:
1 Actual voltage level is opposite to H/L displayed on UI for this
diag code. On BSD the actual volt level is shown.

DADF APS Sensor 2


5

6
DADF APS Sensor 1 DADF APS Sensor 3

j0se730511
A B C D E F G H J
5.12 DADF PRE REGISTRATION (DADF-130 (1PASS)) FAIL CODE
DADF PWB
PL55.2 005-122
DADF PWB DC330 005-206 +5VDC DADF Simplex/Side 1
1 PL55.2 005-122 Pre Regi. Sensor On
J757 J774 DADF PRE REGI. SNR Jam
19 YEL 1 J774 DOC. SENSED (H) +5VDC J757
2 YEL
18 005-146 005-146
+5VDC
(1.9 J1) DADF Pre Regi. Sensor
005-907 Off Jam
17 YEL 3
005-907
DC COM DADF PRE REGI.
(1.9 J6) SENSOR PL55.17 DADF Pre Regi. Sensor
Static Jam
DC330 005-098 DADF T/A
2 CLUTCH NOTE:
DADF T/A CLUTCH PL55.6 The winding resistance of DADF
J793 ON (L) +24VDC P795 J795 4 1
Pre Regi Motor is 2.7Ω±0.27Ω.
2 BLU 1 2
3 The operation varies depending on
DC COM 2 the diag code. The operation lasts
F2
1 ORN 2 1 for 50 sec, and then ends automatically.
1A +24VDC
+24VDC F2 5.16 DC330 Process Speed Rotation
(1.9 J2) DADF PRE Direction
DC330 005-099 REGI. CLUTCH
PL55.6 005-057 41.3mm/sec
DADF PRE REGI. CLUTCH
3 ON (L) +24VDC P796 J796 5 005-058 55.0mm/sec
4 BLU 1 2
005-059 73.3mm/sec
DC COM
005-060 82.5mm/sec
3 ORN 2 1
005-061 110.0mm/sec
+24VDC
F2 005-064 146.7mm/sec
(5.12 B3) 2 DADF PRE
REGI. ELECTRICAL COMPONENTS & DRIVE TRANSMISSION 005-065 165.0mm/sec
DC330 005-057 TO [ 005-080] MOTOR
PL55.5
DADF Pre Regi. Motor 005-067 220.0mm/sec
DADF PRE REGI. MOTOR DADF T/A Clutch CW
4 J754 ON +24V CLOCK A J784 005-069 293.3mm/sec
A1 4 1
BLU 005-070 330.0mm/sec
DC COM
CLOCK /A 005-072 500.0mm/sec
A2 BLU
6
005-074 150.0mm/sec
DC COM
CLOCK B 005-076 440.0mm/sec
A3 3
BLU 005-078 350.0mm/sec
DC COM MOT
CLOCK /B 005-079 460.0mm/sec
A4 1
5 BLU 005-080 100.0mm/sec
DC COM
INTLK ON +24VDC (ACOM)
A5 ORN
5 3 Chip Fuse
3 DADF
INTLK ON +24VDC (BCOM) Pre Regi. Clutch The coil resistance of DADF T/A Clutch
F7 4 is 240Ω±10% (coil temp 20℃)
A6 ORN
2
4A
DADF The coil resistance of DADF Pre Regi.
5 Clutch is 240Ω±10% (coil temp 20℃)
INTLK ON
+24VDC
(5.8 F1) DADF
Pre Regi. Sensor
6

j0se730512

Chain 5 Document Transportation


7-67 7.3 BSD
7-68 7.3 BSD
Chain 5 Document Transportation
A B C D E F G H J
5.13 DADF REGISTRATION (DADF-130 (1PASS)) FAIL CODE
DADF PWB 005-123
PL55.2
DADF PWB DADF Simplex/Side 1
1 PL55.2 DC330 005-110 +5VDC Regi. Sensor On Jam
J757 J772 DADF REGI. SNR 005-123 005-125
13 YEL 1 J772 DOC. SENSED (H) +5VDC J757
2 12 005-125 DADF Regi. Sensor
YEL Off Jam
+5VDC
(1.9 J1) 005-908 005-908
11 YEL 3
DADF Regi. Sensor
DC COM DADF REGI. Static Jam
(1.9 J6) SENSOR PL55.17

2 1 DADF
REGI. ELECTRICAL COMPONENTS & DRIVE TRANSMISSION
DC330 005-026 TO [ 005-044 ] MOTOR
DADF REGI. MOTOR ON PL55.5
J754 +24V CLOCK A J782 DADF Regi. Motor
B8 BLU 4 2
DC COM
CLOCK /A
B7 BLU 6
DC COM
CLOCK B
3 B6 BLU 3
DC COM MOT
CLOCK /B
B5 BLU 1
DC COM
INTLK ON +24VDC (ACOM)
B4 ORN 2
3
F5 INTLK ON +24VDC (BCOM)
B3 ORN 5
4A
4 DADF
INTLK ON
+24VDC
(5.8 F1)

NOTE:
The operation varies depending on the diag code. DADF Regi. Sensor
1 The operation lasts for 50 sec, and then ends automatically.
DC330 Process Speed Rotation DC330 Process Speed Rotation
Direction Direction
5
005-026 41.3mm/sec 005-035 220.0mm/sec
005-027 55.0mm/sec 005-037 293.3mm/sec
005-028 73.3mm/sec 005-038 330.0mm/sec
CCW
005-029 82.5mm/sec CCW 005-041 440.0mm/sec
005-030 110.0mm/sec 005-043 350.0mm/sec
005-032 146.7mm/sec 005-044 460.0mm/sec
005-033 165.0mm/sec
6
2 The winding resistance of DADF Regi Motor is 2.7Ω±0.27Ω.

3 Chip Fuse
j0se730513
A B C D E F G H J
5.14 DADF DOCUMENT SCAN (1/2) (DADF-130 (1PASS)) ADJ 1.6.7
IIT Calibration
ESS PWB DARTS3 PWB
PL35.2 PL35.2 DCDC PWB CIS(1/2)
1 PL55.2 PL55.10
GBUS_A01-20 P322 11-15,17-21, J322
J740 SELBUS J745 J746 SELBUS J1
91-95,97-101 44 44 21 11
VDL 0-7 32-35 DC330 005-089
112-115 LGATE LSYNC
VDA 0-7 37-40 46 46 26 6
+3.3VDC
117-120
VDB 0-7 42-44,46 nNVMSEL SPI-CS
122-124,126 30 30 28 4
+3.3VDC
2 VD 0-7 48-51
128-131 nGASEL SPI-SI
26 26 29 3
GBUS_DA00-15 +3.3VDC
22-25,27-30,
102-105,107-110 nSDSEL SPI-SCK
GBUS_CE0-1 28 28 30 2
5,85 +3.3VDC

GBUS_DACK SEN
8 42 42
GBUS_RE
9 SCLK
3 36 36
GBUS WE
10
SIN DC COM
IN1_LS 40 40
47 J7461 LED1-A J2
7 BLU
7
IN2_LS LED PWM DC COM
52 48 48
LED2-A
EXT_RST_X 9 BLU
9
73 PD DC COM
34 34
6.4 IIT LVPS SQ 1
4 74
F2601 +24VDC DC COM +24VDC F201 J7461 +5VDC J2
DADF CSYNC 25 25 TO 1 1
80 3.15A BLU
+5VDC
CIS +24VDC +5VDC
IN1_PS +24VDC 45 45 1 3 3 NOTE:
127 BLU
+24VDC +5VDC 1 Chip Fuse
IN2_PS 47 47 5 BLU
5
132
+24VDC +5VDC
VCLK 49 49 DC COM
134 2 BLU
2
EXT +24VDC
5 DADF PS IPS +3.3VDC 50 50 DC COM
160 +24VDC F2603 ALL 4 BLU
4
TO +3.3VDC
EXT 8A 29 29 DC COM
154 6 BLU
6
+3.3VDC EXT +3.3VDC
+3.3VDC
88-89 J746 J1
1 1 CIS 31,33,35, DC COM 31,33,35,
CIE+3.3VDC +24VDC +24VDC 1,4,7,10, DC COM 31,28,25,
(1.4 G2) F1781 ALL 37,39,41 37,39,41 13,16,19, 22,19,16,
1-3, F1771 TO
81-83 IPS DC COM DC COM 22,25,31 13,10,7,1
1.6A 1.6A
IPS +24VDC +24VDC DC COM DC COM
6 +24VDC
(1.9 C5) 6,16,26,31,36,41,45,53,55,
65,72,75,86,96,106,111,116,
121,125,133,135,145,152,155
DC COM DC COM
(1.4 D2)
j0se730514

Chain 5 Document Transportation


7-69 7.3 BSD
7-70 7.3 BSD
Chain 5 Document Transportation
A B C D E F G H J
5.15 DADF DOCUMENT SCAN (2/2) (DADF-130 (1PASS)) FAIL CODE
063-210
CIS(2/2) ADJ 1.6.7 DCDC PWB DARTS3 PWB ESS PWB Extension EEPROM Fail
PL55.10 IIT Calibration PL55.2 PL35.2 PL35.2
1
065-221
J1 VA+ J746 J745 J740
30 2 24 24 CIS AGC Fail
J322 P322 VDB0-7_R
56-59 065-222
VA- 136-139
29 3 23 23 CIS AOC Fail
60-63 VDA0-7_R
140-143 065-223
VB+
27 5 22 22 CIS Connection Fail
64,66-68 VDL0-7_R
144, 065-224
2 VB- 146-148
26 6 21 21 CIS Device Fail
69-70 TAG4-7_R
149-150
065-225
VC+
24 8 20 20 CIS Fail
LS_R
71
VC-
23 9 19 19
PS
76
VCLK+
21 11 18 18 063-210
3 CFG1
77 065-221 ELECTRICAL COMPONENTS
VCLK-
20 12 17 17
C2_INT3 065-222
78 CIS
VD+ 065-223
18 14 16 16
LSCNT_INT_R
79 065-224
VD-
17 15 15 15 065-225
PS_R
151
4 VE+
15 17 14 14
RST_STS_X
153
VE-
14 18 13 13
CFG0
+3.3VDC 156
PD
12 20 PU
27 27 CFG2
157
LED CONT2 DC COM PD
9 23 32 32
5 INT
158
LED CONT0 DC COM DC COM
8 24 PD
43 43 PS_R
159
DC COM DC COM
DC COM
SPI-SO
5 27

J2 LED1-C J7461 SOUT


8 BLU
8 38 38
6
LED2-C DC COM
10 BLU 10

j0se730515
A B C D E F G H J
5.16 DADF DOCUMENT EXIT (DADF-130 (1PASS)) FAIL CODE
005-126
DADF PWB DADF Out Sensor On
1 PL55.2 Jam
DADF OUT SENSOR DADF PWB
PL55.17 PL55.2 005-127
J757 J773 DC330 005-208 DADF Out Sensor Off
14 YEL 3 +5VDC Jam
DADF OUT SNR
DOC. SENSED 005-126 005-128
J773 (H)+5VDC J757
2 15 005-127 DADF Simplex Exit
16 YEL 1 YEL YEL Sensor On Jam
005-910 005-129
2 DADF Simplex Exit
Sensor Off Jam
005-910
DADF EXIT SENSOR DADF Out Sensor
PL55.8 Static Jam
J758 P777 J777 J778 2 DC330 005-209 005-911
7 3 1 3 +5VDC
YEL YEL DADF EXIT SNR DADF Exit Sensor
DOC. SENSED 005-128 Static Jam
DC COM J778 J777 P777 J758
(1.9 J6) (L)+5VDC
2 YEL
2 2 YEL
8 005-129
3 9 YEL
1 3 YEL
1
005-911
+5VDC
(1.9 J1)

ELECTRICAL COMPONENTS
DC330 005-226
+5VDC STAMP SET
SIGNAL OPTION
STAMP
4 SOLENOID
DC330 005-073 PL55.8
DC COM
STAMP SOLENOID 1
J755 ON (L) +24VDC J786 P786 P790 J790 DADF Exit Sensor
2 1 2 1 2
BLU BLU
Stamp Solenoid
DC COM
1 ORN
2 1 ORN
2 1
1
+24VDC F2
(5.12 B3)
5

NOTE:
1 The coil resistance of Stamp Solenoid is 60Ω±10% (coil temp 20℃)

2 Actual voltage level is opposite to H/L displayed on UI for this


diag code. On BSD the actual volt level is shown.

DADF Out Sensor


j0se730516

Chain 5 Document Transportation


7-71 7.3 BSD
7-72 7.3 BSD
Chain 5 Document Transportation
A B C D E F G H J
5.17 DOCUMENT PATH & DRIVE TRANSMISSION (DADF-130 (1PASS))

1
DADF Feed Motor

DADF Pre Regi Motor M DADF T/A


Clutch Nudger Roll
DADF Pre
Regi. Clutch
Feed Roll

2 9 3/4/5
1

13 6 2
8 7
10/11/12
Takeaway Roll Retard Roll

Pre Regi. Roll 16


CIS
3
15 Exit Roll
14

Regi. Roll Out Roll CIS Roll


No. Parts Name CH No. Parts Name CH
1 Doc. Tray Size Sensor 2 5.9 10 DADF APS Sensor 1 5.11
4
2 Doc. Tray Size Sensor 1 5.9 11 DADF APS Sensor 2 5.11
M 3 Doc. Tray Set Guide Sensor 1 5.9 12 DADF APS Sensor 3 5.11
DADF Regi Motor 4 Doc. Tray Set Guide Sensor 2 5.9 13 DADF Pre Regi Sensor 5.12
5 Doc. Tray Set Guide Sensor 3 5.9 14 DADF Regi Sensor 5.13
6 DADF Document Set Sensor 5.8 15 DADF Out Sensor 5.16
7 DADF Feed In Sensor 5.10 16 DADF Exit Sensor 5.16
8 DADF Feed Out Sensor 5.10
5
9 DADF Interlock Switch 5.8

The meaning of symbols: M Stepping Motor M DC Motor Clutch Sensor NOTE: The position of motors and sensors on the figure is different from the actual one.

j0se730517
A B C D E F G H J
6.1 PLATEN DOCUMENT SENSING
IIT TRANS PWB BP PWB ESS PWB
PL1.6 PL18.2 PL35.2
IIT TRANS IPS
1 PWB 1 DC330 062-251 +5VDC 1 DC330 062-251 +3.3VDC
PL1.6 J722 APS SENSOR 1 APS SENSOR 1
+5VDC J771
3 1 J771 DOC. SENSED(L) +5VDC J722 J7192 DOC. SENSED(L) +3.3VDC J390 J309 P309
GRY 2 2 34 7 95
BLU GRY
+5VDC
(1.9 F1) DC COM
1 VIO
3
DC COM APS SENSOR 1
(1.9 C2) PL1.3 IPS
1 DC330 062-301 +5VDC 1 DC330 062-301 +3.3VDC
TD
1 +5VDC J774 PLATEN ANGLE SENSOR PLATEN ANGLE SENSOR
2 10 GRY 3 J774 PLATEN CLOSED(L) +5VDC PLATEN CLOSED(L) +3.3VDC
1 BLU
12 36 GRY
5 93
+5VDC
(1.9 F1)
DC COM
11 VIO
2
DC COM
PLATEN ANGLE
(1.9 C2) SENSOR
PL1.3

PLATEN
INTERLOCK
3 SWITCH
PL1.3
DC330 005-213
MAGNET 1 DC330 062-300 1 DC330 062-300 +3.3VDC
PLATEN INTERLOCK SWITCH PLATEN INTERLOCK SWITCH
DC COM P775 J775 J775 P775 PLATEN CLOSED (L)+3.3VDC PLATEN CLOSED(L) +3.3VDC
14 VIO
1 2 1 2
BLU
13 30 GRY
11 97 062-300
DC COM
(1.9 C2)

4
NOTE: ELECTRICAL COMPONENTS FAIL CODE
1 Actual voltage level is opposite to H/L displayed on UI for this diag code.
On BSD the actual volt level is shown. 062-300
Platen Interlock Open
TD Test Point: IIT TRANS PWB J722-10 (+) to GND (-) APS Sensor 1
1 With sensor connected, approx. +1.21VDC

Platen Angle Sensor


6

Platen Interlock Switch


j0se730601

Chain 6 Imaging
7-73 7.3 BSD
7-74 7.3 BSD
Chain 6 Imaging
A B C D E F G H J
6.2 DOCUMENT ILLUMINATION
IIT TRANS PWB ADJ 1.6.7 LED LAMP PWB
PL1.6 IIT Calibration PL1.5
1

ESS PWB BP PWB CR1-6


PL35.2 PL18.2 J723 LASER 1 J1
13 13
1 DC330 062-002 +3.3VDC

P309 J309 J336 LAMP ON J7191 CR7-12


107 46 6 LASER 2
12 12
DC COM
2 6.5 LED
SELB CR13-18
LASER 3
11 11
ELECTRICAL COMPONENTS & DRIVE TRANSMISSION
CR19-24
LASER 4
10 10
LED Lamp PWB
CR25-30
LASER 5
9 9
3
CR31-36
LASER 6
8 8

CR37-42
LASER 7
7 7

CR43-48
LASER 8
4 6 6

DC COM
5 5
DC COM
+24VDC
2 2

+24VDC
15 15
5 LED
+24VDC
NOTE: (1.9 E3) 1 1
1 Turning ON DC330[062-002] makes the lamp ON for 180 sec,
and it automatically turns OFF.
14 14
DC COM
3 3
NOT USED

6 4 4
DC COM
(1.9 C2)

j0se730602
A B C D E F G H J
6.3 CARRIAGE CONTROL ADJ 1.6.1 FAIL CODE
Full/Half Rate Carriage Position Adjustment
062-360
IIT TRANS PWB CARRIAGE
ESS PWB BP PWB PL1.6 2
DC330 062-005 SCAN MOTOR Carriage Position Fail
1 PL35.2 PL18.2 CARRIAGE +3.3VDC DC330 062-006 RETURN PL1.4
062-389
MOTOR CARRIAGE MOTOR 3
P309 J309 J336 ON(L) +3.3VDC J7191 J722 ON CLOCK A P776 J776 Carriage Over Run Fail
30 42 10 20 BLU 6
+3.3VDC
DC COM DC COM
CLOCK /A
FWD 19 BLU 5
29 41 11
DC COM
CLOCK B
CLOCK + 18 BLU 4
27 25
2 DC COM MOT
26 CLOCK /B
CLOCK - 17 BLU 3
28 24
DC COM
6.4
NRESET 15 BLU 1
+3.3VDC +3.3VDC +3.3VDC
F8
1 PWR 1 16 BLU 2
4A
35 45 7 +24VDC
(1.9 E1)
3 +3.3VDC +3.3VDC DC COM TD
J722 1 J773
1 PWR 2 7 3 J773
GRY 1 BLU
36 44 8 +5VDC
(1.9 F1)
+3.3VDC +3.3VDC DC COM
8 VIO
2
1 PWR 3 IIT REGI. SENSOR
DC COM
37 43 9 (1.9 C2) PL1.4
DC COM
4
ELECTRICAL COMPONENTS & DRIVE TRANSMISSION IIT TRANS PWB BP PWB ESS PWB
PL1.6 PL18.2 PL35.2
IPS
DC330 062-212 +5VDC DC330 062-212 +3.3VDC
IIT Regi. Sensor Carriage Motor IIT REGI. SENSOR IIT REGI. SENSOR
BLOCKED(H) +5VDC J722 J7192 BLOCKED(H) +3.3VDC J390 J309 P309 062-360
9 38 3 92
BLU GRY
062-389
5
NOTE:
The signals PWR 1 to PWR 3 switch the value of the current supplied to Carriage Motor. TD Test Point: IIT TRANS PWB J722-7 (+) to GND (-)
1 1 With sensor connected, approx. +1.20VDC
2 Turning ON DC330[062-005] makes the Carriage move 50mm in the
Scan direction, and it automatically stops.
The M/C does not accept the Stop instruction before the Carriage automatically stops.
Turning ON DC330[062-006] makes the Carriage move 50mm in the
Return direction, and it automatically stops.
6 The M/C does not accept the Stop instruction before the Carriage automatically stops.

3 The winding resistance of Carriage Motor is 1.0Ω±15% (25℃)

j0se730603

Chain 6 Imaging
7-75 7.3 BSD
7-76 7.3 BSD
Chain 6 Imaging
A B C D E F G H J
6.4 IMAGE INPUT (1/2) (ESS TO CCD) FAIL CODE
IIT TRANS PWB ADJ 1.6.7 CCD PWB 062-393
ESS PWB BP PWB PL1.6 1.9 IIT Calibration PL1.3
PL35.2 PL18.2 CCD PWB Sync Signal
1 #RESET 6.3 Fail
P309 J309 J336 (IIT LVPS SQ) J7191 P710 IPS_NRST J700
115 36 16 27 24
5.14
CIE
+3.3VDC CR11
RED
+3.3VDC

#ACS1 DC COM
133 34 18 IPS_NCS
+3.3VDC 23 28
2 #ACS0
127 35 17

AFE SCK +
24 28
IPS_SCLK
129 20 31
AFE SCK -
25 27
+3.3VDC +3.3VDC

#AFE SDO IPS_SDO


131 33 19 22 29
3 +3.3VDC

#CL LS CCD_LS
135 31 21 25 26
+3.3VDC

#CCD PWDN
121 39 13
+3.3VDC NOT USED
J390 SMODE0 J7192 CLK+
25 14 GRY 27 47 4

DC COM
+3.3VDC 062-393
4 CLK-
SMODE1 48 3
32 10 GRY 31
ANA+10VDC
DC COM 4-3 47-48
ANA ANA+
+10VDC 10VDC
(1.9 E2) ANA+5VDC
9-7 42-44
ADJ 1.6.2 +5VDC ANA
IIT Lead Edge Registration (1.9 F1) +5VDC
ADJ 1.6.3
+3.3VDC
5 IIT Side Edge Registration
17-15 34-36

ADJ 1.6.4 +3.3VDC +3.3VDC


(1.9 F2)
IIT Vertical/Horizontal Reduce/Enlarge ANA+3.3VDC
13-12 38-39
ANA ANA
+3.3VDC +3.3VDC
(1.9 F2)
2,5,6, DC COM 49,46,45,
14,11,10 37,40,41
6 19,21,28, DC COM 32,30,23,
31,34,37, 20,17,14,
40,43,46,49 11,8,5,2
DC COM DC COM
(1.9 C2)
j0se730604
A B C D E F G H J
6.5 IMAGE INPUT (2/2) (CCD TO ESS)
BP PWB ESS PWB
CCD PWB IIT TRANS PWB PL18.2 PL35.2
PL1.3 PL1.6
1 J700 RE_P P710 J7191 TE1+ J336 J309 P309
22 29 33 19 70 BP PWB ESS PWB
PL18.2 PL35.2
RE_N TE1-
21 30 34 18 69
J309 P309 AFE BW TE +
RD_P TD1+ 52
19 32 36 16 67
AFE BW TE -
RD_N TD1- 51
18 33 37 15 66
2
AFE BW TD +
RC_P TC1+ 49
13 38 42 10 61
AFE BW TD -
RC_N TC1- 48
12 39 43 9 60
AFE BW TCLK +
RB_P TB1+ 46
10 41 45 7 58
AFE BW TCLK -
3 RB_N TB1- 062-362 45
9 42 46 6 57
062-371 AFE BW TC +
RA_P TA1+ 43
7 44 48 4 55 062-380
062-386 AFE BW TC -
RA_N TA1- 42
6 45 49 3 54
062-790
AFE BW TB +
RCLK_P VCLK1+ 40
16 35 39 13 64
4
AFE BW TB -
RCLK_N VCLK1- 39
15 36 40 12 63
+3.3VDC +3.3VDC IPS +3.3VDC

IPS_SDI #AFE SDI


33 18 20 32 132
IPS +3.3VDC

IIT_SNS0 IIT_SNS0
27 24 14 38 118
+3.3VDC FAIL CODE
LED 6.2 IPS +3.3VDC
5 LED SEL SELB 062-362
25 26 IIT_SNS1
15 37 117 X Hard Fail
IPS +3.3VDC
062-371
DC COM IIT_SNS2
ADJ 1.6.7 12 40 116 Lamp Illumination Fail
IIT Calibration
062-380
DC COM
AGC Fail
50,47,44,41,38,35,32, 2,5,8,11,14,17,20,
31,30,29,26,23,22 21,22,23,26,29,30 062-386
J7192 J390 AOC Fail
6 1,7,13,15,37, 40,34,28,26,4,
39,26,24,16,14 GRY 2,15,17,25,27 062-790
DC COM DC COM
(1.9 C2) PreIPS X Recognition
Fail
j0se730605

Chain 6 Imaging
7-77 7.3 BSD
7-78 7.3 BSD
Chain 6 Imaging
A B C D E F G H J

6.6 LPH CONTROL (Y) FAIL CODE


045-370
ADJ 18.2.6 LPH Unit
ESS PWB BP PWB MOTOR DRIVER MAIN PWB LPH Exposure Amount Fine Adjustment PL2.1 LPH Power On Fail
1 PL35.2 PL18.2 PL18.2 Multi
1 LPH LPH DRIVER PWB (Y) 045-371
REAR HEADER SLED PWB
DC330 061-001 PWB (Y) PWB (Y) (Y) LPH Download Data
PL2.2 Fail Multi
To J569 J577
DC330 061-004 045-372
P335 J335 J451 P451 J557 CONTROL J561 P581 J581 CONTROL CONTROL LPH Mismatch Fail
061-350 SIGNAL AND SIGNAL AND SIGNAL AND Multi
VIDEO DATA VIDEO DATA VIDEO DATA
061-354 045-373
+3.3VDC
2 LPH Read Fail Multi
061-358 Y_LREQ SD_L2B_Y SD_B2L
045-374
061-362
LPH Write Fail Multi
061-366 Y_PREQ DC COM DC COM
045-375
061-370 LPH Act Fail Multi
DC COM DC COM
061-374 (1.4 D4)
045-376
061-378 DC COM DC COM LPH PLL Lock Fail
Multi
3 061-386 J532 +5VDC J553 J565 +5VDC J573 +5VDC +3.3VDC
4 BLU
1 4 1 TO 061-350
061-390 MCU-PF
+3.3VDC
LPH Power On Fail Y
LPH +3.3VDC
061-394 PWB +5VDC
PL18.2 (1.6 D4) +1.8VDC +1.8VDC DC COM 061-354
2 3 2 3
045-370 J1 P1 BLU LPH Download Data
LPH +1.8VDC DC COM DC COM Fail Y
045-371 DATA +1.8VDC
(1.6 E4) DC COM DC COM 061-358
045-372 1 BLU
4 3 2
LPH Mismatch Fail Y
4 045-373 DC COM DC COM 061-362
3 2 1 4
045-374 BLU LPH Read Fail Y
DC COM DC COM
045-375 (1.4 D4) 061-366
045-376 LPH Write Fail Y
061-370
ELECTRICAL COMPONENTS LPH Act Fail Y
LPH Rear PWB
NOTE: 061-374
5 1 The operation varies depending on the diag code. LPH Chip Fail Y
Y
LPH Operation 061-378
DC330[061-001] Forcedly turns ON LPH. (Solid pattern) LPH Ltrg Fail Y
LPH Header
DC330[061-002] Forcedly turns ON LPH. (Cin 50%) PWB (Y) 061-386
DC330[061-003] Forcedly turns ON LPH. (Streak Evaluation pattern) LPH PLL Lock Fail Y
DC330[061-004] Performs only thyristor transfer. 061-390
Drum (Y) LPH FFC Connect
Posi Fail Y
6
061-394
LPH (Y) LPH FFC Connect
Nega Fail Y
LPH (Y)
j0se730606
A B C D E F G H J

6.7 LPH CONTROL (M) FAIL CODE


ADJ 18.2.6
045-370
LPH Unit
ESS PWB BP PWB MOTOR DRIVER MAIN PWB LPH Exposure Amount Fine Adjustment PL2.1 LPH Power On Fail
1 PL35.2 PL18.2 PL18.2 Multi
1 LPH LPH 045-371
REAR HEADER DRIVER PWB (M) SLED PWB
DC330 061-001 PWB (M) PWB (M) (M) LPH Download Data
PL2.2 Fail Multi
To J568 J576
DC330 061-004 045-372
P335 J335 J451 P451 J556 CONTROL J560 P580 J580 CONTROL CONTROL LPH Mismatch Fail
061-351 SIGNAL AND SIGNAL AND SIGNAL AND Multi
VIDEO DATA VIDEO DATA VIDEO DATA
061-355 045-373
+3.3VDC
2 LPH Read Fail Multi
061-359 M_LREQ SD_L2B_M SD_B2L
045-374
061-363
LPH Write Fail Multi
061-367 M_PREQ DC COM DC COM
045-375
061-371 LPH Act Fail Multi
DC COM DC COM
061-375 (1.4 D4)
045-376
061-379 DC COM DC COM LPH PLL Lock Fail
Multi
3 061-387 J532 +5VDC J552 J564 +5VDC J572 +5VDC +3.3VDC
8 BLU
1 4 1 TO 061-351
061-391 MCU-PF
+3.3VDC
LPH Power On Fail M
LPH +3.3VDC
061-395 PWB +5VDC
PL18.2 (1.6 D4) +1.8VDC +1.8VDC DC COM 061-355
6 3 2 3
045-370 J1 P1 BLU LPH Download Data
LPH +1.8VDC DC COM DC COM Fail M
045-371 DATA +1.8VDC
(1.6 E4) DC COM DC COM 061-359
045-372 5 BLU
4 3 2
LPH Mismatch Fail M
4 045-373 DC COM DC COM 061-363
7 2 1 4
045-374 BLU LPH Read Fail M
DC COM DC COM
045-375 (1.4 D4) 061-367
045-376 LPH Write Fail M
061-371
ELECTRICAL COMPONENTS LPH Act Fail M
LPH Rear PWB
NOTE: 061-375
M
5 1 The operation varies depending on the diag code. LPH Chip Fail M
LPH Operation 061-379
DC330[061-001] Forcedly turns ON LPH. (Solid pattern) LPH Ltrg Fail M
DC330[061-002] Forcedly turns ON LPH. (Cin 50%) LPH Header PWB (M) 061-387
DC330[061-003] Forcedly turns ON LPH. (Streak Evaluation pattern) LPH PLL Lock Fail M
DC330[061-004] Performs only thyristor transfer. 061-391
Drum (M) LPH FFC Connect
Posi Fail M
6
061-395
LPH (M) LPH FFC Connect
LPH (M) Nega Fail M
j0se730607

Chain 6 Imaging
7-79 7.3 BSD
7-80 7.3 BSD
Chain 6 Imaging
A B C D E F G H J

6.8 LPH CONTROL (C) FAIL CODE


ADJ 18.2.6
045-370
LPH Unit
ESS PWB BP PWB MOTOR DRIVER MAIN PWB LPH Exposure Amount Fine Adjustment PL2.1 LPH Power On Fail
1 PL35.2 PL18.2 PL18.2 Multi
1 LPH LPH 045-371
REAR HEADER DRIVER PWB (C) SLED PWB
DC330 061-001 PWB (C) PWB (C) (C) LPH Download Data
PL2.2 Fail Multi
To J567 J575
DC330 061-004 045-372
P335 J335 J451 P451 J555 CONTROL J559 P579 J579 CONTROL CONTROL LPH Mismatch Fail
061-352 SIGNAL AND SIGNAL AND SIGNAL AND Multi
VIDEO DATA VIDEO DATA VIDEO DATA
061-356 045-373
+3.3VDC
2 LPH Read Fail Multi
061-360 C_LREQ SD_L2B_C SD_B2L
045-374
061-364
LPH Write Fail Multi
061-368 C_PREQ DC COM DC COM
045-375
061-372 LPH Act Fail Multi
DC COM DC COM
061-376 (1.4 D4)
045-376
061-384 DC COM DC COM LPH PLL Lock Fail
Multi
3 061-388 J532 +5VDC J551 J563 +5VDC J571 +5VDC +3.3VDC
12 BLU 1 4 1 TO 061-352
061-392 MCU-PF
+3.3VDC
LPH Power On Fail C
LPH +3.3VDC
061-396 PWB +5VDC
PL18.2 (1.6 D4) +1.8VDC +1.8VDC DC COM 061-356
10 3 2 3
045-370 J1 P1 BLU LPH Download Data
LPH +1.8VDC DC COM DC COM Fail C
045-371 DATA +1.8VDC
(1.6 E4) DC COM DC COM 061-360
045-372 9 BLU
4 3 2
LPH Mismatch Fail C
4 045-373 DC COM DC COM 061-364
11 2 1 4
045-374 BLU LPH Read Fail C
DC COM DC COM
045-375 (1.4 D4) 061-368
045-376 LPH Write Fail C
061-372
ELECTRICAL COMPONENTS LPH Act Fail C
LPH Rear PWB
NOTE: C 061-376
5 1 The operation varies depending on the diag code. LPH Chip Fail C
LPH Operation 061-384
DC330[061-001] Forcedly turns ON LPH. (Solid pattern) LPH Ltrg Fail C
LPH Header PWB (C)
DC330[061-002] Forcedly turns ON LPH. (Cin 50%) 061-388
DC330[061-003] Forcedly turns ON LPH. (Streak Evaluation pattern) LPH PLL Lock Fail C
DC330[061-004] Performs only thyristor transfer. 061-392
Drum (C)
LPH FFC Connect
Posi Fail C
6
061-396
LPH (C) LPH FFC Connect
LPH (C) Nega Fail C
j0se730608
A B C D E F G H J

6.9 LPH CONTROL (K) FAIL CODE


ADJ 18.2.6
045-370
LPH Unit
ESS PWB BP PWB MOTOR DRIVER MAIN PWB LPH Exposure Amount Fine Adjustment PL2.1 LPH Power On Fail
1 PL35.2 PL18.2 PL18.2 Multi
1 LPH LPH 045-371
REAR HEADER DRIVER PWB (K) SLED PWB
DC330 061-001 PWB (K) PWB (K) (K) LPH Download Data
PL2.2 Fail Multi
To J566 J574
DC330 061-004 045-372
P335 J335 J451 P451 J554 CONTROL J558 P578 J578 CONTROL CONTROL LPH Mismatch Fail
061-353 SIGNAL AND SIGNAL AND SIGNAL AND Multi
VIDEO DATA VIDEO DATA VIDEO DATA
061-357 045-373
+3.3VDC
2 LPH Read Fail Multi
061-361 K_LREQ SD_L2B_K SD_B2L
045-374
061-365
LPH Write Fail Multi
061-369 K_PREQ DC COM DC COM
045-375
061-373 LPH Act Fail Multi
DC COM DC COM
061-377 (1.4 D4)
045-376
061-385 DC COM DC COM LPH PLL Lock Fail
Multi
3 061-389 J532 +5VDC J550 J562 +5VDC J570 +5VDC +3.3VDC
16 BLU 1 4 1 TO 061-353
061-393 MCU-PF
+3.3VDC
LPH Power On Fail K
LPH +3.3VDC
061-397 PWB +5VDC
PL18.2 (1.6 D4) +1.8VDC +1.8VDC DC COM 061-357
14 3 2 3
045-370 J1 P1 BLU LPH Download Data
LPH +1.8VDC DC COM DC COM Fail K
045-371 DATA +1.8VDC
(1.6 E4) DC COM DC COM 061-361
045-372 13 BLU
4 3 2
LPH Mismatch Fail K
4 045-373 DC COM DC COM 061-365
15 2 1 4
045-374 BLU LPH Read Fail K
DC COM DC COM
045-375 (1.4 D4) 061-369
045-376 LPH Write Fail K
061-373
ELECTRICAL COMPONENTS LPH Act Fail K
LPH Rear PWB
NOTE: 061-377
5 1 The operation varies depending on the diag code. K LPH Chip Fail K
LPH Operation 061-385
DC330[061-001] Forcedly turns ON LPH. (Solid pattern) LPH Ltrg Fail K
DC330[061-002] Forcedly turns ON LPH. (Cin 50%) LPH Header PWB (K) 061-389
DC330[061-003] Forcedly turns ON LPH. (Streak Evaluation pattern) LPH PLL Lock Fail K
DC330[061-004] Performs only thyristor transfer. 061-393
Drum (K) LPH FFC Connect
Posi Fail K
6
061-397
LPH (K) LPH FFC Connect
LPH (K) Nega Fail K
j0se730609

Chain 6 Imaging
7-81 7.3 BSD
7-82 7.3 BSD
Chain 6 Imaging
A B C D E F G H J

6.10 IMAGE REGISTRATION CONTROL FAIL CODE


MOTOR DRIVER MAIN PWB 089-600
PL18.2
MOTOR DRIVER MOB ADC SENSOR ASSEMBLY RC Sample Lateral Fail-A1
1 MAIN PWB PL18.5
PL18.2 089-601
DC330 089-001 (LOW POWER) 089-601
DC330 089-002 (HIGH POWER) TMA SENSOR IN RC Sample Block Fail-A1-In
TMA SENSOR 089-604
089-603
J415 IN LED PWM P610 J610 J150 089-607
A2 B9 B7 3 +3.3VDC RC Sample Block Fail-A1-Out
BLU TMA SENSOR IN
DC COM J150 J610 P610 SENSED SIGNAL J415 089-610 089-604
LED PD AMP 4 B6 B10 A1 AMP
+5VDC BLU 089-613 RC Sample Block Fail-B-#1-In
A4 BLU
B7 B9 1
089-623 089-606
2 MOB
RC Sample Block Fail-B-#1-Out
+5VDC 089-666
(1.6 D3) DC COM
A3 B8 B8 2 089-607
BLU 089-668
DC COM RC Sample Block Fail-B-#2-In
(1.4 D4) 089-600
089-609
089-616 RC Sample Block Fail-B-#2-Out
089-617 089-610
TMA SENSOR OUT 089-625 RC Sample Block Fail-B-#3-In
3 TMA SENSOR 089-626 089-612
OUT LED PWM J151
A8 B3 B13 3 +3.3VDC 089-627 RC Sample Block Fail-B-#3-Out
BLU TMA SENSOR OUT
DC COM LED PD AMP J151 SENSED SIGNAL 089-628 089-613
4 B12 B4 A7 AMP
+5VDC BLU RC Sample Block Fail-B-#4-In
A10 BLU B1 B15 1 089-603
089-615
MOB 089-606
+5VDC RC Sample Block Fail-B-#4-Out
(1.6 D3) DC COM 089-609
A9 BLU
B2 B14 2 089-616
4 089-612 RC Data Over Flow Fail
DC COM
(1.4 D4)
089-615 089-617
089-629 RC Data Over Range Fail
ELECTRICAL COMPONENTS
089-667 089-623
Vsout Stability Fail-In
089-669
089-625
RC Data Linearity Fail Y
5 TMA Sensor In
089-626
RC Data Linearity Fail M
089-627
MOB ADC SENSOR RC Data Linearity Fail C
ASSEMBLY
089-628
089-667
RC Data Linearity Fail K
TMA LED Fail-Out
089-629
6 089-668
Vsout Stability Fail-Out
TMA Thresh Hold Fail-In
089-669 089-666
TMA Sensor Out TMA Thresh Hold Fail-Out TMA LED Fail-In
j0se730610
A B C D E F G H J

6.11 IIT HEATING (OPTION) (FX ONLY)


IIT HEATER 1
1 1.2 POWER SWITCH OFF ACH PL1.14
(IIT HEATER) P71 J71 P930 J930 CE30 P931 J931
2 1 1
BLK BLK BLK BLK

1.2 POWER SWITCH OFF ACN


(IIT HEATER) CE31
1 2 2
WHT WHT WHT WHT

IIT HEATER 2
2 P932 J932
PL1.14
1
BLK

2
WHT

j0se730611

Chain 6 Imaging
7-83 7.3 BSD
7-84 7.3 BSD
Chain7 Paper Supplying
A B C D E F G H J
FAIL CODE
7.1 TRAY 1 PAPER SIZE SENSING
071-212
MOTOR DRIVER TRAY 1 PAPER SIZE SENSOR MOTOR DRIVER MAIN
MAIN PWB PL9.1 1 PWB Tray 1 Paper Size
1 PL18.2 J412 +3.3VDC J174 PL18.2 Sensor Broken
A13 1
BLU
2 DC140 071-200 AVREF
AVREF +3.3VDC
+3.3VDC TRAY 1 PAPER SIZE
(1.6 E2) SENSOR
DC COM J174 SENSED SIGNAL J412
A11
BLU
3 2
BLU
A12 071-212
DC COM
(1.4 D4)

SW4 SW3 SW2 SW1


2

DC330 071-104
TRAY 1 PAPER SIZE SENSOR +3.3VDC
SW5 SIZE SELECT SWITCH
ON (L)+3.3VDC
4 A10
BLU

3
NOTE:
2 DC140[071-200] displays AD Value from
1 Paper size is sensed by voltage corresponding to combined resistance of Paper Size Sensor and Tray 1 Paper Size Sensor.
SW5 On/Off. Normally, the value is in the following output range:
The table below shows the relation between paper size and combination of Switch ON/OFF pattern, ・Normal output range : 0-989
・Abnormal range : Other than the above.
voltage and AD value. (Any combination other than the ones below results in an undetermined size.)

Voltage Value (V) AD Value


Paper Size SW1 SW2 SW3 SW4 SW5
(J412-A12) DC140[071-200]
4 No Tray OFF OFF OFF OFF OFF 3.085±0.066 922-989
A5S/5.5"X8.5"S (*1) OFF OFF ON OFF OFF 2.671±0.066 797-857
B5S OFF OFF ON ON ON 2.468±0.066 735-796 ELECTRICAL COMPONENTS
8.5"X13"S OFF ON OFF ON OFF Tray 1 Paper Size Sensor
2.064±0.066 610-671
8.5"X14"S OFF ON OFF ON ON
A4S OFF ON ON OFF OFF
1.864±0.066 548-609
8.5"X11"S OFF ON ON OFF ON
5 SRA3 S/
ON OFF OFF ON ON 1.278±0.066 366-427
13"X18"S/12"X18"S(*1)
A4L ON OFF ON OFF OFF 1.079±0.066 304-365
A3S ON OFF ON ON OFF 0.881±0.066 244-303
B5L/7.25"X10.5"L(*1) ON ON OFF OFF ON 0.691±0.066 184-243
8KS(*2) ON ON OFF ON OFF
0.493±0.066 124-183
B4S ON ON OFF ON ON
8.5"X11"L ON ON ON OFF OFF
6 0.300±0.066 64-123
16KL(*2)/7.25"X10.5"L(*1) ON ON ON OFF ON
11"X17"S ON ON ON ON ON 0.106±0.066 0-63
*1:Paper size is changed in diag.
*2:System Setting enables switching between GCO and TFX sizes. j0se730701
A B C D E F G H J
FAIL CODE
7.2 TRAY 2 PAPER SIZE SENSING
TRAY MODULE PWB 072-212
PL10.10/11.17/12.5
TRAY MODULE PWB TRAY 2 PAPER SIZE SENSOR Tray 2 Paper Size
1 PL10.10/11.17/12.5 PL10.1/11.15/12.1 1 Sensor Broken
2 DC140 072-200
J549 +5VDC TRAY 2 PAPER SIZE +5VDC
J101
B12 1 SENSOR
GRY J101 J549
SENSED SIGNAL
+5VDC 2
YEL
B11 072-212
(1.6 H4) DC COM
B10 3
VIO
DC COM
(1.6 H4)

SW4 SW3 SW2 SW1


2

3 DC330 072-104
TRAY 2 PAPER SIZE SENSOR +5VDC
SW5 SIZE SELECT SWITCH
ON (L)+5VDC
4 B9
YEL

3 NOTE: 1 Paper size is sensed by voltage corresponding to combined resistance of Paper Size Sensor and 2 DC140[072-200] displays AD Value from
SW5 On/Off. Tray 2 Paper Size Sensor.
Normally, the value is in the following output range:
The table below shows the relation between paper size and combination of Switch ON/OFF pattern, ・Normal output range : 0-247
voltage and AD value. ・Abnormal range : Other than the above.
(Any combination other than the ones below results in an undetermined size.)
Actual voltage level is opposite to H/L displayed on UI for this diag code.
3 On BSD the actual volt level is shown.
Voltage Value (V) AD Value
Paper Size SW1 SW2 SW3 SW4 SW5
(J549-B11) DC140[072-200]
No Tray OFF OFF OFF OFF OFF 4.66±0.05 231-247 ELECTRICAL COMPONENTS
4 A5S/5.5"X8.5"S (*1) OFF OFF ON OFF OFF 4.01±0.05 199-214 Tray 2 Paper Size Sensor
B5S OFF OFF ON ON ON 3.69±0.05 184-198
8.5"X13"S OFF ON OFF ON OFF
3.07±0.05 153-167
8.5"X14"S OFF ON OFF ON ON
A4S OFF ON ON OFF OFF
2.75±0.05 137-152
8.5"X11"S OFF ON ON OFF ON
8"X10"S OFF ON ON ON ON 2.44±0.05 122-136
5 SRA3 S/12"X18"S(*1) ON OFF OFF ON ON 1.83±0.05 92-106
A4L ON OFF ON OFF OFF 1.52±0.05 77-91
A3S ON OFF ON ON OFF 1.21±0.05 61-76
B5L/7.25"X10.5"L(*1) ON ON OFF OFF ON 0.91±0.05 46-60
8KS(*2) ON ON OFF ON OFF
0.60±0.05 31-45
B4S ON ON OFF ON ON
8.5"X11"L ON ON ON OFF OFF
0.30±0.05 16-30
6 16KL(*2)/7.25"X10.5"L(*1) ON ON ON OFF ON
11"X17"S ON ON ON ON ON 0.00±0.05 0-15
*1:Paper size is changed in diag.
*2:System Setting enables switching between GCO and TFX sizes. j0se730702

Chain7 Paper Supplying


7-85 7.3 BSD
7-86 7.3 BSD
Chain7 Paper Supplying
A B C D E F G H J
FAIL CODE
7.3 TRAY 3 PAPER SIZE SENSING (3TM)
073-212
TRAY MODULE TRAY 3 PAPER SIZE SENSOR (5Bit)
PWB PL10.1 1 TRAY MODULE PWB Tray 3 Paper Size
1 PL10.10/11.17/ PL10.10/11.17/12.5 Sensor Broken
12.5 073-200
2 DC140
J549 +5VDC J102 +5VDC
B8 1 TRAY 3 PAPER SIZE
GRY SENSOR
+5VDC J102 SENSED SIGNAL J549
(1.6 H4) 2
YEL
B7 073-212
DC COM
B6 3
VIO
DC COM
(1.6 H4)
2 SW4 SW3 SW2 SW1

3 DC330 073-104
TRAY 3 PAPER SIZE SENSOR +5VDC
SW5 SIZE SELECT SWITCH
ON (L)+5VDC
4 B5
YEL

3 DC140[073-200] displays AD Value from


NOTE: 1 Paper size is sensed by voltage corresponding to combined resistance of Paper Size Sensor and SW5 On/Off. 2
Tray 3 Paper Size Sensor.
The table below shows the relation between paper size and combination of Switch ON/OFF pattern, Normally, the value is in the following output range:
voltage and AD value. ・Normal output range : 0-247
(Any combination other than the ones below results in an undetermined size.) ・Abnormal range : Other than the above.

Voltage Value (V) AD Value Actual voltage level is opposite to H/L displayed on UI for this diag code.
Paper Size SW1 SW2 SW3 SW4 SW5 3 On BSD the actual volt level is shown.
(J549-B7) DC140[073-200]
No Tray OFF OFF OFF OFF OFF 4.66±0.05 231-247
ELECTRICAL COMPONENTS
4 A5S/5.5"X8.5"S (*1) OFF OFF ON OFF OFF 4.01±0.05 199-214
Tray 3 Paper Size Sensor (5Bit)
B5S OFF OFF ON ON ON 3.69±0.05 184-198
8.5"X13"S OFF ON OFF ON OFF
3.07±0.05 153-167
8.5"X14"S OFF ON OFF ON ON
A4S OFF ON ON OFF OFF
2.75±0.05 137-152
8.5"X11"S OFF ON ON OFF ON
8"X10"S OFF ON ON ON ON 2.44±0.05 122-136
5 SRA3 S/12"X18"S(*1) ON OFF OFF ON ON 1.83±0.05 92-106
A4L ON OFF ON OFF OFF 1.52±0.05 77-91
A3S ON OFF ON ON OFF 1.21±0.05 61-76
B5L/7.25"X10.5"L(*1) ON ON OFF OFF ON 0.91±0.05 46-60
8KS(*2) ON ON OFF ON OFF
0.60±0.05 31-45
B4S ON ON OFF ON ON
8.5"X11"L ON ON ON OFF OFF
0.30±0.05 16-30
6 16KL(*2)/7.25"X10.5"L(*1) ON ON ON OFF ON
11"X17"S ON ON ON ON ON 0.00±0.05 0-15
*1:Paper size is changed in diag.
*2:System Setting enables switching between GCO and TFX sizes. j0se730703
A B C D E F G H J
FAIL CODE
7.4 TRAY 3 PAPER SIZE SENSING (TTM)
073-212
TRAY
MODULE TRAY 3 PAPER SIZE SENSOR (2Bit) TRAY MODULE PWB Tray 3 Paper Size
1 PWB PL11.15 1 PL10.10/11.17/12.5 Sensor Broken
PL10.10/
11.17/12.5 J549 +5VDC J102
B8 GRY
1
2 DC140 073-200 +5VDC
+5VDC
(1.6 H4) TRAY 3 PAPER SIZE SENSOR
DC COM J102 SENSED SIGNAL J549
B6 VIO
3 2 YEL
B7 073-212
DC COM
(1.6 H4)
2 SW3 SW1

NOTE: 1 Paper size is sensed by voltage corresponding to combined resistance of Paper Size Sensor. ELECTRICAL COMPONENTS
3 The table below shows the relation between paper size and combination of Switch ON/OFF pattern,
voltage and AD value.(Any combination other than the ones below results in an undetermined size.) Tray 3 Paper Size Sensor (2Bit)

Voltage (V) AD Value


Paper Size SW1 SW2
(J549-B7) DC140[073-200]
No Tray OFF OFF 4.66±0.05 231-247
B5L/7.25"X10.5"L(*1) OFF ON 4.01±0.05 168-230
8.5"X11"L ON OFF 2.15±0.05 92-167
4 A4L ON ON 1.52±0.05 0-91
*1:Paper size is changed in diag.

2 DC140[073-200] displays AD Value from Tray 3 Paper Size Sensor.


Normally, the value is in the following output range:
・Normal output range : 0-247
・Abnormal range : Other than the above.

j0se730704

Chain7 Paper Supplying


7-87 7.3 BSD
7-88 7.3 BSD
Chain7 Paper Supplying
A B C D E F G H J
FAIL CODE
7.5 TRAY 4 PAPER SIZE SENSING (3TM)
074-212
TRAY MODULE TRAY 4 PAPER SIZE SENSOR (5Bit)
PWB PL10.1 1 Tray 4 Paper Size
1 PL10.10/11.17/ TRAY MODULE PWB Sensor Broken
12.5 PL10.10/11.17/12.5
2 DC140 074-200
J549 +5VDC J103 +5VDC
B4 1 TRAY 4 PAPER SIZE
GRY SENSOR
+5VDC J103 SENSED SIGNAL J549 074-212
(1.6 H4) 2 B3
YEL
DC COM
B2 3
VIO
DC COM
(1.6 H4)
2 SW4 SW3 SW2 SW1

3 DC330 074-104
TRAY 4 PAPER SIZE SENSOR +5VDC
SW5 SIZE SELECT SWITCH
ON (L)+5VDC
4 B1
YEL

3 DC140[074-200] displays AD Value from


NOTE: 1 Paper size is sensed by voltage corresponding to combined resistance of Paper Size Sensor and SW5 On/Off. 2
The table below shows the relation between paper size and combination of Switch ON/OFF pattern, Tray 4 Paper Size Sensor.
Normally, the value is in the following output range:
voltage and AD value. ・Normal output range : 0-247
(Any combination other than the ones below results in an undetermined size.) ・Abnormal range : Other than the above.

Voltage Value (V) AD Value Actual voltage level is opposite to H/L displayed on UI for this diag code.
Paper Size SW1 SW2 SW3 SW4 SW5 3 On BSD the actual volt level is shown.
(J549-B11) DC140[072-200]
No Tray OFF OFF OFF OFF OFF 4.66±0.05 231-247
4 A5S/5.5"X8.5"S (*1) OFF OFF ON OFF OFF 4.01±0.05 199-214 ELECTRICAL COMPONENTS
Tray 4 Paper Size Sensor (5Bit)
B5S OFF OFF ON ON ON 3.69±0.05 184-198
8.5"X13"S OFF ON OFF ON OFF
3.07±0.05 153-167
8.5"X14"S OFF ON OFF ON ON
A4S OFF ON ON OFF OFF
2.75±0.05 137-152
8.5"X11"S OFF ON ON OFF ON
8"X10"S OFF ON ON ON ON 2.44±0.05 122-136
5 SRA3 S/12"X18"S(*1) ON OFF OFF ON ON 1.83±0.05 92-106
A4L ON OFF ON OFF OFF 1.52±0.05 77-91
A3S ON OFF ON ON OFF 1.21±0.05 61-76
B5L/7.25"X10.5"L(*1) ON ON OFF OFF ON 0.91±0.05 46-60
8KS(*2) ON ON OFF ON OFF
0.60±0.05 31-45
B4S ON ON OFF ON ON
8.5"X11"L ON ON ON OFF OFF
0.30±0.05 16-30
6 16KL(*2)/7.25"X10.5"L(*1) ON ON ON OFF ON
11"X17"S ON ON ON ON ON 0.00±0.05 0-15
*1:Paper size is changed in diag.
*2:System Setting enables switching between GCO and TFX sizes. j0se730705
A B C D E F G H J
FAIL CODE
7.6 TRAY 4 PAPER SIZE SENSING (TTM)
074-212
TRAY MODULE TRAY 4 PAPER SIZE SENSOR (2Bit) TRAY MODULE PWB Tray 4 Paper Size
1 PWB PL11.15 1 PL10.10/11.17/12.5 Sensor Broken
PL10.10/11.17/
12.5 J549 J103
+5VDC
B4 GRY 1
2 DC140 074-200 +5VDC
+5VDC
(1.6 H4) TRAY 4 PAPER SIZE SENSOR
DC COM J103 SENSED SIGNAL J549
B2 VIO
3 2 YEL
B3 074-212
DC COM
(1.6 H4)
2 SW3 SW1

NOTE: 1 Paper size is sensed by voltage corresponding to combined resistance of Paper Size Sensor. ELECTRICAL COMPONENTS
3 The table below shows the relation between paper size and combination of Switch ON/OFF pattern, Tray 4 Paper Size Sensor (2Bit)
voltage and AD value.(Any combination other than the ones below results in an undetermined size.)

Voltage (V) AD Value


Paper Size SW1 SW2
(J549-B7) DC140[073-200]
No Tray OFF OFF 4.66±0.05 231-247
B5L/7.25"X10.5"L(*1) OFF ON 4.01±0.05 168-230
8.5"X11"L ON OFF 2.15±0.05 92-167
4 A4L ON ON 1.52±0.05 0-91
*1:Paper size is changed in diag.

2 DC140[074-200] displays AD Value from Tray 4 Paper Size Sensor.


Normally, the value is in the following output range:
・Normal output range : 0-247
・Abnormal range : Other than the above.

j0se730706

Chain7 Paper Supplying


7-89 7.3 BSD
7-90 7.3 BSD
Chain7 Paper Supplying
A B C D E F G H J

7.7 MSI PAPER SIZE SENSING


MOTOR MSI PAPER MOTOR DRIVER MAIN
1 DRIVER SIZE SENSOR PWB
MAIN PWB PL13.5 PL18.2
PL18.2 J525 J616 J617
AVREF P616 P617 J173 1 DC140 075-200 2
B3 16 3 BLU
1 3 BLU
1
GRY MSI PAPER SIZE SENSOR
AVREF J173 J617 P617 J616 P616 SENSED SIGNAL J525 AMP
+3.3VDC 3 BLU
1 3 BLU
1 18 B1
(1.6 E2) GRY

DC COM DC COM
B2 17 2 BLU
2 2 BLU
2
GRY
DC COM
2 (1.4 D4)

NOTE: 1 Paper width (size in fast scan direction) is sensed by voltage corresponding 2 DC140[075-200] displays AD Value from
to MSI Paper Size Sensor resistance. MSI Paper Size Sensor.
Normally, the value is in the following output range:
As to MSI, AD values corresponding to paper sizes (widths) vary depending ・Normal output range : 86-966 (Nominal)
on the machine because when MSI is installed on IOT before shipment, 51-1023 (NVM range)
MSI Size Sensing is adjusted in the diag. The values below are for reference. ・Abnormal range : Constant and within the NVN range above.

3 Voltage Value (V) AD Value


Paper Size
(J525-B1) DC140[075-200]
Post Card S 2.945-3.004 908.374-935.445
ELECTRICAL COMPONENTS
5.5"X8.5"S 2.472-2.531 762.064-788.741
A5S 2.373-2.432 731.393-758.070
B5S 1.968-2.026 605.752-632.429
8"X10"S 1.801-1.860 554.018-580.694 MSI Paper Size Sensor
4 8.5"X11"S(Letter)&X13"&X14" 1.564-1.622 480.481-507.157
A4S 1.634-1.693 502.283-528.959
7.25"X10.5"L 0.958-1.017 292.758-319.434
B5L
1.074-1.132 328.603-355.279
B4S
16KL(Taiwan)
0.954-1.013 291.649-318.326
8KS(Taiwan)
5 16KL(Mainland China)
0.919-0.977 280.563-307.240
8KS(Mainland China)
11"X17"S
0.807-0.865 245.827-272.504
8.5"X11"L(Letter)
A4L
0.597-0.656 180.790-207.466
A3S
12.6"X19.2"S 0.457-0.516 137.554-164.231
6 13"X19"(X18") 0.341-0.399 101.340-128.016
SRA3 0.323-0.381 95.797-122.474

Ref. Paper length (size in slow scan direction) is sensed by timing how long
paper takes to pass Regi. Sensor. j0se730707
A B C D E F G H J
FAIL CODE
7.8 TRAY 1 PAPER STACKING
071-210
TRAY 1 NUDGER MOTOR DRIVER MAIN
MOTOR DRIVER MAIN LEVEL SENSOR PWB Tray 1 Lift Up Fail
1 PWB PL9.4 PL18.2
PL18.2 J528 J611 J177
DC COM P611
B6 5 6 BLU
2 DC330 071-102 +3.3VDC
GRY
DC COM TRAY 1 NUDGER LEVEL SENSOR
(1.4 D4) TD J177 J611 P611 LIFT UP (H)+3.3VDC J528
1 +5VDC 1 7 4 B7 071-210
B5 6 5 3 BLU GRY
GRY BLU
+5VDC
(1.6 D2)
TRAY 1 NO PAPER
2 SENSOR
PL9.4
DC COM J178
B9 2 9 BLU
2 DC330 071-101 +3.3VDC
GRY
DC COM TRAY 1 NO PAPER SENSOR
(1.4 D4) TD J178 PAPER SENSED (L)+3.3VDC
2 +5VDC 1 10 1 B10
B8 3 8 3 BLU GRY
GRY BLU
+5VDC
(1.6 D2)
TRAY 1
3 +24VDC F8 FEED/LIFT ELECTRICAL COMPONENTS & DRIVE TRANSMISSION
(1.8 D4) 1 DC330 071-001 to 003 UP MOTOR
TRAY 1 FEED/LIFT UP MOTOR PL9.4 Tray 1 Feed/Lift Up Motor
ON +24VDC CLOCK A J268
B4 7 4 BLU
1 2
GRY
DC COM

CLOCK /A
B3 8 3 BLU
2
GRY
DC COM
4 MOT

CLOCK B
B1 10 1 BLU
4
GRY
DC COM

CLOCK /B
B2 9 2 BLU
3
GRY
DC COM

5
NOTE:
1
Tray 1 Nudger Level Sensor
The operation varies depending on the diag code.
Tray 1 Feed/ Target Machine Tray 1 No Paper Sensor
Lift Up Motor Operation

DC330 [071-001] 4475/5575/6675/7775 Rotates the Motor in the Feed direction. (2-phase excitation)
TD Test Point: Motor Driver Main PWB J528-B5 (+) to GND (-)
DC330 [071-002] ALL Rotates the Motor in the Lift-up direction. (2-phase excitation) 1 With sensor connected, approx. +1.23VDC
The motor makes the tray lift up, and after Level Sensor turns ON it steps down
6 and finishes the operation. TD Test Point: Motor Driver Main PWB J528-B8 (+) to GND (-)
However, if Level Sensor is ON when the motor starts driving, it does not operate. 2 With sensor connected, approx. +1.22VDC
DC330 [071-003] 2275/3373/3375 Rotates the Motor in the Feed direction. (1-2-phase excitation)

2 Tray 1 Feed/Lift Up Motor winding resistance is 4±0.4Ω. (25℃) j0se730708

Chain7 Paper Supplying


7-91 7.3 BSD
7-92 7.3 BSD
Chain7 Paper Supplying
A B C D E F G H J
FAIL CODE
7.9 TRAY 2 PAPER STACKING
TRAY 2 NUDGER LEVEL 072-210
TRAY MODULE PWB SENSOR TRAY MODULE PWB
PL10.10/11.17/12.5 PL10.3/11.7/12.3 PL10.10/11.17/12.5 Tray 2 Lift Up Fail
1
J545 DC COM P669 J669 J107
2 8 2 2 DC330 072-102 +5VDC
VIO GRY
DC COM TRAY 2 NUDGER LEVEL SENSOR
(1.6 H4) TD J107 J669 P669 LIFT UP (H)+5VDC J545
1 +5VDC 1 3 7 3 072-210
1 9 1 3 GRY YEL
GRY GRY
+5VDC
(1.6 H4)
TRAY 2 NO PAPER
SENSOR
2 PL10.3/11.7/12.3

DC COM J106
5 5 5 2 DC330 072-101 +5VDC
VIO GRY
DC COM TRAY 2 NO PAPER SENSOR
(1.6 H4) TD J106 PAPER SENSED (L)+5VDC
2 +5VDC 1 6 4 6
4 6 4 3 GRY YEL
GRY GRY
+5VDC
(1.6 H4)
TRAY 2 FEED/LIFT UP
3 MOTOR ELECTRICAL COMPONENTS & DRIVE TRANSMISSION
+24VDC
F1 1 DC330 072-001 to 003 PL10.3/11.7/12.3
(1.8 H3) TRAY 2 FEED/LIFT Tray 2 Feed/Lift Up Motor
UP MOTOR
J550 ON +24VDC CLOCK A P661 J661 J221
4 BLU
1 4 1
GRY
DC COM
2
CLOCK /A
3 BLU
2 3 2
GRY
4 DC COM MOT

CLOCK B
1 BLU
4 1 4
GRY
DC COM

CLOCK /B
2 BLU
3 2 3
GRY
DC COM
5
NOTE:
1 The operation varies depending on the diag code.
Tray 2 Feed/
Lift Up Motor Operation
Tray 2 No Paper Sensor
DC330 [072-001] Rotates the Motor in the Feed direction. (2-phase excitation) Tray 2 Nudger Level Sensor
DC330 [072-002] Rotates the Motor in the Lift-up direction. (2-phase excitation)
The motor makes the tray lift up, and after Level Sensor turns ON it steps down TD Test Point: TRAY MODULE PWB J545-1 (+) to GND (-)
1 With sensor connected, approx. +1.18VDC
and finishes the operation.
6 However, if Level Sensor is ON when the motor starts driving, it does not operate.
TD Test Point: TRAY MODULE PWB J545-4 (+) to GND (-)
DC330 [072-003] Rotates the Motor in the Feed direction. (1-2-phase excitation) 2 With sensor connected, approx. +1.18VDC

2 Tray 2 Feed/Lift Up Motor winding resistance is 4±0.4Ω. (25℃)


j0se730709
A B C D E F G H J
FAIL CODE
7.10 TRAY 3 PAPER STACKING
TRAY 3 NUDGER 073-210
TRAY MODULE PWB TRAY MODULE PWB
PL10.10/11.17/12.5 LEVEL SENSOR PL10.10/11.17/12.5 Tray 3 Lift Up Fail
1 PL10.5/11.9
J548 DC COM P671 J671 J111
11 VIO
8 2 GRY
2 DC330 073-102 +5VDC
DC COM TRAY 3 NUDGER LEVEL SENSOR
(1.6 H4) TD J111 J671 P671 LIFT UP (H)+5VDC J548
1 +5VDC 1 GRY 3 7 12 073-210
10 9 1 3 YEL
GRY GRY
+5VDC
(1.6 H4) TRAY 3 NO PAPER
SENSOR
2 PL10.5/11.9
DC COM J110
14 5 5 2 +5VDC
VIO GRY DC330 073-101
DC COM TRAY 3 NO PAPER SENSOR
(1.6 H4) TD J110 PAPER SENSED (L)+5VDC
2 +5VDC 1 GRY 6 4 15
13 6 4 3 YEL
GRY GRY
+5VDC
(1.6 H4)
TRAY 3
FEED/LIFT UP ELECTRICAL COMPONENTS & DRIVE TRANSMISSION
3 +24VDC MOTOR Tray 3 Feed/Lift Up Motor Tray 3 Nudger Level Sensor
F1 1 DC330 073-001 to 003 PL10.5/11.9
(1.8 H3)
TRAY 3 FEED/LIFT
UP MOTOR <3TM>
J550 ON +24VDC CLOCK A P662 J662 J222
8 BLU
1 4 GRY
1
2
DC COM
CLOCK /A
7 BLU
2 3 GRY
2
DC COM
4 MOT
CLOCK B
5 BLU
4 1 GRY
4
DC COM
CLOCK /B
6 BLU
3 2 GRY
3 Tray 3 Feed/Lift Up Motor
DC COM

NOTE: 1 The operation varies depending on the diag code.


5 Tray 3 No Paper Sensor
Tray 3 Feed/
Lift Up Motor Operation

DC330 [073-001] Rotates the Motor in the Feed direction. (2-phase excitation)
DC330 [073-002] Rotates the Motor in the Lift-up direction. (2-phase excitation)
The motor makes the tray lift up, and after Level Sensor turns ON it steps down
and finishes the operation.
However, if Level Sensor is ON when the motor starts driving, it does not operate.
DC330 [073-003] Rotates the Motor in the Feed direction. (1-2-phase excitation)
6 2 Tray 3 Feed/Lift Up Motor winding resistance is 4±0.4Ω. (25℃)

TD Test Point: TRAY MODULE PWB J548-10 (+) to GND (-) TD Test Point: TRAY MODULE PWB J548-13 (+) to GND (-) <TTM>
1 With sensor connected, approx. +1.18VDC 2 With sensor connected, approx. +1.18VDC
j0se730710

Chain7 Paper Supplying


7-93 7.3 BSD
7-94 7.3 BSD
Chain7 Paper Supplying
A B C D E F G H J
FAIL CODE
7.11 TRAY 4 PAPER STACKING TRAY MODULE PWB
TRAY 4 NUDGER PL10.10/11.17/12.5 074-210
TRAY MODULE PWB TTM Only LEVEL SENSOR
PL10.10/11.17/12.5 PL10.7/11.11 Tray 4 Lift Up Fail
1 J548 DC COM P676 J676 P673 J673 J115 DC330 074-102
2 VIO
8 5 GRY
8 2 GRY
2 +5VDC
TTM Only TRAY 4 NUDGER
DC COM LEVEL SENSOR
(1.6 H4) TD J115 J673 P673 J676 P676 LIFT UP (H)+5VDC J548
1 +5VDC 1 3 7 6 7 3 074-210
1 9 4 9 1 3 GRY GRY YEL
GRY GRY GRY
+5VDC
(1.6 H4)
TRAY 4 NO PAPER
SENSOR
PL10.7/11.11
2
DC COM J114 DC330 074-101
5 VIO
5 8 GRY
5 5 GRY
2 +5VDC
TRAY 4 NO PAPER
DC COM SENSOR PAPER
(1.6 H4) TD J114 SENSED (L)+5VDC
2 +5VDC 1 6 4 9 4 6
4 6 7 6 4 3 GRY GRY YEL
GRY GRY GRY
+5VDC
(1.6 H4)
TRAY 4
+24VDC FEED/LIFT UP ELECTRICAL COMPONENTS & DRIVE TRANSMISSION
F1 1 DC330 074-001 to 003 MOTOR
3 (1.8 H3)
TRAY 4 FEED/LIFT TTM Only PL10.7/11.11 <3TM> Tray 4 Feed/Lift Up Motor
UP MOTOR Tray 4 No Paper Sensor
J550 ON +24VDC CLOCK A P675 J675 P663 J663 J223
12 BLU 1 4 GRY 1 4 GRY
1 2
Tray 4 Nudger
DC COM Level Sensor
CLOCK /A
11 BLU 2 3 GRY
2 3 GRY
2
DC COM MOT
CLOCK B
4 9 BLU
4 1 GRY
4 1 GRY
4
DC COM
CLOCK /B
10 BLU 3 2 GRY
3 2 GRY
3
Tray 4 Nudger
DC COM Level Sensor

Tray 4 Feed/
NOTE: 1 The operation varies depending on the diag code. Lift Up Motor
5 Tray 4 Feed/ Tray 4 No Paper Sensor
Lift Up Motor Operation

DC330 [074-001] Rotates the Motor in the Feed direction. (2-phase excitation)
DC330 [074-002] Rotates the Motor in the Lift-up direction. (2-phase excitation)
The motor makes the tray lift up, and after Level Sensor turns ON it steps down
and finishes the operation.
However, if Level Sensor is ON when the motor starts driving, it does not operate.
DC330 [074-003] Rotates the Motor in the Feed direction. (1-2-phase excitation)

Tray 4 Feed/Lift Up Motor winding resistance is 4±0.4Ω. (25℃)


6 2
<TTM>
TD Test Point: TRAY MODULE PWB J548-1 (+) to GND (-) TD Test Point: TRAY MODULE PWB J548-4 (+) to GND (-)
1 With sensor connected, approx. +1.18VDC 2 With sensor connected, approx. +1.18VDC
j0se730711
A B C D E F G H J
FAIL CODE
7.12 MSI PAPER STACKING
MSI NUDGER 075-212
POSITION SENSOR MOTOR DRIVER MAIN
MOTOR DRIVER MAIN PL13.2 PWB MSI Nudger Up Down
1 PWB PL18.2 Fail
PL18.2 J525 DC COM P616 J616 J183 DC330 075-102
B15 2 17 2 +3.3VDC
GRY BLU MSI NUDGER
DC COM POSITION SENSOR
(1.4 D4) TD J183 J616 P616 LIFT UP (H)+3.3VDC J525
1 +5VDC 1 18 1 B16 075-212
B14 3 16 3 BLU GRY
GRY BLU
+5VDC
(1.6 D2)
MSI NO PAPER
SENSOR
2 PL13.4
DC COM J172 DC330 075-101
B8 11 8 2 +3.3VDC
GRY BLU MSI NO PAPER
DC COM SENSOR PAPER
(1.4 D4) TD J172 SENSED (L)+3.3VDC
2 +5VDC 1 9 10 B9
B7 12 7 3 BLU GRY
GRY BLU
+5VDC
(1.6 D2)
MSI
3 DC330 075-001 Feed FEED/NUDGER ELECTRICAL COMPONENTS & DRIVE TRANSMISSION
INTLK
+24VDC F11 1
DC330 075-003 Feed MOTOR
(1.12 E4) DC330 075-004 Nudger Up/Down PL13.2 MSI Feed/Nudger Motor
MSI FEED/NUDGER MOTOR 2
ON +24VDC CLOCK A J269 MSI Nudger Position Sensor
B13 6 13 BLU
1
GRY
DC COM
MSI No Paper Sensor
CLOCK /A
B12 7 12 BLU
2
GRY
4 DC COM MOT

CLOCK B
B10 9 10 BLU
4
GRY
DC COM

CLOCK /B
B11 8 11 BLU
3
GRY
DC COM
5
NOTE:
1 The operation varies depending on the diag code.
MSI Feed/ Target Machine Operation
Nudger Motor
DC330 [075-001] 4475/5575/6675/7775 Rotates the Motor in the Feed direction. (2-phase excitation)
DC330 [075-003] 2275/3373/3375 Rotates the Motor in the Feed direction. (1-2-phase excitation) TD Test Point: Motor Driver Main PWB J525-B14 (+) to GND (-)
1 With sensor connected, approx. +1.24VDC
6 DC330 [075-004] ALL Rotates the Motor in the Nudger Up/Down direction. (1-2-phase excitation)

2 MSI Feed/Nudger Motor winding resistance is 4±0.4Ω. (25℃) TD Test Point: Motor Driver Main PWB J525-B7 (+) to GND (-)
2 With sensor connected, approx. +1.24VDC
j0se730712

Chain7 Paper Supplying


7-95 7.3 BSD
7-96 7.3 BSD
Chain7 Paper Supplying
A B C D E F G H J

7.13 TRAY HEATING (OPTION) (FX ONLY)


TRAY HEATER
1 PL18.12
1.2 POWER SWITCH OFF ACH
(TRAY HEATER) J72 P72 J73 P73
2 2
BLK BLK

1.2 POWER SWITCH OFF ACN


(TRAY HEATER)
1 1
WHT WHT

j0se730713
A B C D E F G H J
8.1 TRAY 1/2 PAPER PRE FEEDING
MOTOR DRIVER MAIN
MOTOR 4475/5575/6675/7775 PWB
DRIVER TRAY 1 PRE FEED PL18.2
1 MAIN PWB SENSOR
PL18.2 PL9.4 DC330 071-105 +5VDC
J537 P618 J618 J171
1 WHT 3 1 3 TRAY 1 PRE FEED SENSOR
BLU J171 J618 P618 PAPER SENSED(L) +5VDC J537
DC COM 2 BLU 2 2 2
(1.4 D4) WHT
3 WHT 1 3 BLU
1
+5VDC
(1.6 D2)

TRAY TRAY MODULE PWB


2 MODULE TTM-6675/7775 Only PL10.10/11.17/12.5
PWB TRAY 2 PRE FEED
PL10.10/ SENSOR
PL11.7 1 DC330 072-105 +5VDC
11.17/12.5 J545 P669 J669 J105
7 3 7 3 TRAY 2 PRE FEED SENSOR
VIO GRY J105 J669 P669 PAPER SENSED(L) +5VDC J545
DC COM 2 GRY 8 2 8
(1.6 H4) YEL
9 GRY 1 9 GRY
1
+5VDC
(1.6 H4)
3

ELECTRICAL COMPONENTS
NOTE:
Tray 1/2 Pre Feed Sensor 1 Actual voltage level is opposite to H/L displayed on UI for this
diag code. On BSD the actual volt level is shown.

j0se730801

Chain 8 Paper Transportation


7-97 7.3 BSD
7-98 7.3 BSD
Chain 8 Paper Transportation
A B C D E F G H J
8.2 TRAY 3/4 PAPER PRE FEEDING
TRAY TRAY MODULE PWB
MODULE TTM Only PL10.10/11.17/12.5
1 PWB TRAY 3 PRE FEED
PL10.10/ SENSOR
PL11.9 1 DC330 073-105 +5VDC
11.17/12.5 J548 P671 J671 J109
16 3 7 3 TRAY 3 PRE FEED SENSOR
VIO GRY J109 J671 P671 PAPER SENSED(L) +5VDC J548
DC COM 2 8 2 17
(1.6 H4) GRY YEL
18 GRY 1 9 GRY
1
+5VDC
(1.6 H4)
TRAY 4 PRE FEED
2 SENSOR
PL11.11 1 DC330 074-105 +5VDC
P676 J676 P673 J673 J113
7 3 10 3 7 3 TRAY 4 PRE FEED SENSOR
VIO GRY GRY J113 J673 P673 J676 P676 PAPER SENSED(L) +5VDC
DC COM 2 8 2 11 2 8
(1.6 H4) GRY GRY YEL
9 GRY
1 12 GRY 1 9 GRY
1
+5VDC
(1.6 H4)

3
NOTE:
ELECTRICAL COMPONENTS Actual voltage level is opposite to H/L displayed on UI for this
1
diag code. On BSD the actual volt level is shown.
Tray 3 Pre Feed Sensor Tray 4 Pre Feed Sensor

j0se730802
A B C D E F G H J
8.3 TRAY 1 AND MSI PAPER TRANSPORTATION (1/2) FAIL CODE
075-100
MOTOR DRIVER MAIN PWB MOTOR DRIVER SUB PWB MSI Miss Feed Jam
1 PL18.2 PL18.2 +24VDC
4475/5575/6675/7775
F1
TAKE AWAY 075-103
(1.8 G1) DC330 077-050 MOTOR
PL15.1a MSI Feed Out Sensor
T/A MOTOR TAKE AWAY MOTOR Off Jam
ON P452 J452 J538 ON +24VDC CLOCK A J253
83 4 1 2
4
DC COM
DC COM
T/A MOTOR CLOCK /A
CURRENT 3 3
82 4
2 DC COM MOT
T/A MOTOR
CLOCK
85 CLOCK B
2 4
4
DC COM DC COM

CLOCK /B
1 6
4
DC COM
3

2275/3373/3375
TAKE AWAY
DC330 077-001 1 CLUTCH
TAKE AWAY CLUTCH PL15.1a
J414 ON(L) +24VDC P261 J261 3
B17 GRY 1 2
DC COM
4
B16 GRY 2 1
+24VDC
F5
(1.8 D3)

MSI FEED OUT MOTOR DRIVER MAIN


SENSOR PWB
J525 J616 PL13.4 PL18.2
P616 J179
B5 GRY 14 5 2 DC330 077-104 +3.3VDC
5 BLU
DC COM MSI FEED OUT SENSOR
(1.4 D4) TD J179 J616 P616 PAPER SENSED(L) +3.3VDC J525 075-100
1 1 6 13 B6
B4 GRY 15 4 3 BLU GRY
BLU 075-103
+5VDC
(1.6 D2)

6 NOTE: 1 DC330[077-001], if combined with DC330[042-001 to 006],


allows you to drive Take Away Roll 1 and MSI Take Away Roll.
4 Wire Color varies depending on the model. TD Test Point: Motor Driver Main PWB J525-B4 (+) to GND (-)
1 With sensor connected, approx. +1.24VDC
4475/5575 : WHT
2 The winding resistance of Take Away Motor is 1.2±0.14Ω (25℃). 6675/7775 : VIO

3 The coil resistance of Take Away Clutch is 115±10% (at coil temp of 20℃). j0se730803

Chain 8 Paper Transportation


7-99 7.3 BSD
7-100 7.3 BSD
Chain 8 Paper Transportation
A B C D E F G H J
8.4 TRAY 1 AND MSI PAPER TRANSPORTATION (2/2)
<2275/3373/3375> <4475/5575> <6675/7775>
1
Take Away Motor
Take Away Motor
Main Drive Motor
(CH4.1)

Take Away Clutch

MSI Feed Out Sensor


MSI Feed Out Sensor MSI Feed Out Sensor
4

j0se730804
A B C D E F G H J
8.5 TRAY MODULE PAPER TRANSPORTATION (1/2) ELECTRICAL COMPONENTS & DRIVE TRANSMISSION
<1TM (2275/3373/3375)> <TTM>
1 Feed Out Feed Out
TRAY MODULE TM TAKE AWAY Sensor 2 (CH8.6)
PWB Full speed, MOTOR 1 Sensor 2 (CH8.6)
PL10.10/11.17/ DC330 077-035 2-phase excitation PL10.9/11.16
12.5 /12.5 Feed Out
Half speed,
2 DC330 077-036 1-2-phase excitation Sensor 4 (CH8.6)
TM Take
TM TAKE AWAY MOTOR 1 3 Away Motor1
J551 ON CLOCK A J224 TM Take
4 BLU 4 Away Motor1
DC COM
CLOCK /A
2 3 BLU
6
DC COM
TM Take
CLOCK B Away Motor2
2 BLU
3
DC COM MOT
CLOCK /B
1 BLU
1
DC COM Feed Out Sensor 3
5 2 (CH8.6)
ORN
3 <3TM>
F4
6 5
3.15A ORN TM Take
1 Away Motor1
+24VDC
(1.8 H3)
TM Take
Away Motor2 Feed Out
Sensor 2 (CH8.6)
TM TAKE AWAY
DC330 077-037 Full speed,
2-phase excitation
MOTOR 2
PL10.9/11.16
4
DC330 077-038 Half speed,
1-2-phase excitation
TM TAKE AWAY MOTOR 2 3 Feed Out
J552 ON CLOCK A J226 Sensor 3 (CH8.6)
4 4
BLU
DC COM Feed Out
CLOCK /A
3 BLU
6 Sensor 4 (CH8.6)
DC COM
CLOCK B
5 2 BLU
3
DC COM MOT
CLOCK /B
1 BLU
1
DC COM
5 ORN
2
NOTE:
F8
6 ORN
5 1 Chip Fuse
3.15A
6 +24VDC 1
(1.8 H3) 2 DC [077-036] is available for 2275/3373/3375/4475/5575 only.

3 TM Take Away Motor 1/2 winding resistance is 2.4±0.24Ω (25℃)


[1TM] TM Take Away Motor 1 winding resistance is 3.4±0.34Ω (25℃) j0se730805

Chain 8 Paper Transportation


7-101 7.3 BSD
7-102 7.3 BSD
Chain 8 Paper Transportation
A B C D E F G H J
8.6 TRAY MODULE PAPER TRANSPORTATION (2/2) FAIL CODE
072-101
TRAY MODULE Tray 2 Miss Feed Jam
1 PWB
PL10.10/11.17/ TRAY MODULE PWB 072-102
FEED OUT SENSOR 2 PL12.5
12.5 PL10.11/11.5/12.6 Feed Out Sensor 2
On Jam (Tray 3/4)
J549 J108 DC330 077-105
A8 VIO 2 DC330 072-103 1 +5VDC 072-900
DC COM FEED OUT SENSOR 2 072-101 Feed Out Sensor 2
(1.6 H4) TD J108 PAPER SENSED(L) +5VDC J549 Static Jam
1 1 YEL
A9 072-102
A7 GRY 3 073-101
+5VDC
072-900 Tray 3 Miss Feed Jam
2 (1.6 H4)
073-102
FEED OUT SENSOR 3 3.7
PL10.11/11.5 Feed Out Sensor 3
On Jam (Tray 4)
P672 J672 J112 DC330 077-106
A4 VIO 3 1 BRN
3 DC330 073-103 1 +5VDC 073-900
DC COM FEED OUT SENSOR 3 073-101 Feed Out Sensor 3
(1.6 H4) J112 J672 P672 PAPER SENSED(L) +5VDC Static Jam
2 BRN
2 2 YEL
A5 073-102
A6 GRY 1 3 BRN
1 074-101
+5VDC
073-900 Tray 4 Miss Feed Jam
3 (1.6 H4)
074-900
FEED OUT SENSOR 4 3.7
TTM PL10.11/11.6a/11.6b Feed Out Sensor 4
Static Jam
P676 J676 J116 DC330 077-107
A1 VIO 12 1 3 TTM DC330 074-103 1 +5VDC
BRN
DC COM FEED OUT SENSOR 4
(1.6 H4) J116 J676 P676 PAPER SENSED(L) +5VDC 074-101
2 2 11 A2
A3 GRY 10 3 1 BRN YEL
BRN 074-900
+5VDC
4 (1.6 H4)
3.7

3TM
3TM
P674 J674 J674 P674
3 1 2 2
BRN

5 1 3 BRN

NOTE:
1 Actual voltage level is opposite to H/L displayed on UI for this diag code. TD Test Point: TRAY MODULE PWB J549-A7 (+) to GND (-)
On BSD the actual volt level is shown. 1 With sensor connected, approx. +1.19VDC

j0se730806
A B C D E F G H J
8.7 REGISTRATION (2275/3373/3375/4475/5575) FAIL CODE
071-105
MOTOR DRIVER MAIN Regi. Sensor On Jam
1 PWB (Tray 1/2/3/4)
PL18.2 REGI.
3.8 075-135
2 DC330 077-002 CLUTCH
PL15.2a Regi. Sensor On Jam
REGI. CLUTCH (MSI)
J523 ON(L) +24VDC P632 J632 P260 J260 1
A8 BLU 1 8 GRY
1 2 077-101
DC COM Regi. Sensor Off Jam
A7 BLU 2 7 GRY
2 1 077-130
+24VDC Regi. Sensor On Jam
2 F9 (Duplex Direct)
(1.8 D4) MOTOR DRIVER MAIN
PWB 077-900
REGI. SENSOR PL18.2
PL15.2a Regi. Sensor Static Jam
J160 071-105
A1 5 4 3 DC330 077-103 +5VDC
BLU GRY
DC COM REGI. SENSOR 075-135
(1.4 D4) J160 J632 P632 PAPER SENSED(L) +5VDC J523
2 GRY
5 4 BLU
A2 077-101
A3 BLU 3 6 GRY
1
3 +5VDC
077-130
(1.6 D2)
077-900

NOTE:
ELECTRICAL COMPONENTS & DRIVE TRANSMISSION
1 The coil resistance of Regi. Clutch is 165Ω±10% (at coil temp of 20℃).
<2275/3373/3375> <4475/5575>
2 DC330[077-002], if combined with DC330[042-001 to 006], allows you to drive Regi. Roll.
Regi. Clutch Regi. Clutch
4 Main Drive Motor
(CH4.1)
Main Drive Motor
(CH4.1)

6 Le
Le ft Front
ft Front

Regi. Sensor Regi. Sensor


j0se730807

Chain 8 Paper Transportation


7-103 7.3 BSD
7-104 7.3 BSD
Chain 8 Paper Transportation
A B C D E F G H J
8.8 REGISTRATION (6675/7775) FAIL CODE
REGI. SENSOR MOTOR DRIVER
PL14.5b MAIN PWB 071-105
MOTOR DRIVER PL18.2
MAIN PWB J523 P612 J612 P671 J671 J160 DC330 077-103 Regi. Sensor On Jam
1 PL18.2 A1 VIO A12 A1 3 1 3 REGI. SENSOR +5VDC (Tray 1/2/3/4)
GRY GRY 071-105
DC COM PAPER SENSED(L) 075-135
(1.4 D4) J160 J671 P671 J612 P612 +5VDC J523 075-135
2 GRY 2 2 GRY A2 A11 A2 Regi. Sensor On Jam
A3 VIO A10 A3 GRY 1 3 1 VIO (MSI)
GRY 077-101
+5VDC 077-101
(1.6 D2) 077-130 Regi. Sensor Off Jam
077-900 077-130
MOTOR DRIVER MAIN MOTOR DRIVER SUB PWB
PWB PL18.2 Regi. Sensor On Jam
2 PL18.2 +24VDC F1 REGI. (Duplex Direct)
REGI. (1.8 G1) DC330 077-055 MOTOR
REGI. MOTOR PL15.1b 077-900
MOTOR 1
ON P452 J452 J538 CLOCK A J255 P255 Regi. Sensor Static Jam
33 8 1
VIO
REGI. DC COM
MOTOR
CLOCK CLOCK /A
34 7 VIO
3
REGI. DC COM MOT
MOTOR
3 CORRENT CLOCK B
84 6 VIO
4
DC COM
CLOCK /B
5 VIO
5
DC COM ELECTRICAL COMPONENTS & DRIVE TRANSMISSION

Regi. Motor
4 NOTE: Regi. Sensor
1 The winding resistance of Regi. Motor is 0.45±0.09Ω (25℃).

Le
ft Front
j0se730808
A B C D E F G H J

8.9 PAPER PATH (2275/3373/3375-3TM) Paper Path Sensor


No. Sensor Name CH
Interlock Switch
1 1 Tray 1 Nudger Level Sensor 7.8
No. Switch Name CH
2 Tray 1 No Paper Sensor 7.8
I-1 Front Cover Interlock Switch 1.12
Face Up Roll 3 Tray 2 Nudger Level Sensor 7.9
Exit Roll 2
I-2 L/H Cover Interlock Switch 1.12
4 Tray 2 No Paper Sensor 7.9
I-3 TM L/H Cover Interlock Switch 1.13
EXIT 2 5 Tray 3 Nudger Level Sensor 7.10
M 6 Tray 3 No Paper Sensor 7.10
Exit Roll 1
7 Tray 4 Nudger Level Sensor 7.11
The roll name of feeder unit in each tray 18
2 EXIT 1 8 Tray 4 No Paper Sensor 7.11
Tray 1/2/3/4 Feed Roll Invert Roll 9 MSI Nudger Position Sensor 7.12
Duplex Roll 1
Tray 1/2/3/4 Nudger Roll IOT I-1 10 MSI No Paper Sensor 7.12
M
DUPLEX 17 11 MSI Feed Out Sensor 8.3
Duplex Roll 2 12 Feed Out Sensor 2 8.6
Tray 1/2/3/4 Retard Roll
I-2 13 Feed Out Sensor 3 8.6
16 14 Feed Out Sensor 4 8.6
M
3 19 Regi. Roll 15 Regi. Sensor 8.7
Take Away Roll 1 16 POB Sensor 9.23
Regi. Clutch
Duplex Roll 3 17 Fusing Unit Exit Sensor 10.6
M
18 Exit 2 Sensor 10.10
15 M
M 19 Duplex Path Sensor 10.8
MSI 9 1/2 Take Away Clutch
A-1 Motor
A-5 10 TRAY 1
4 11 M No. Motor Name CH
12
MSI Take Away Roll M 7.8
M Tray 1/2/3/4 Feed Lift Up Motor 7.9
3/4 7.10
Take Away Roll 2 A-2 7.11
Take Away Roll 3 13 TRAY 2
M M MSI Feed/Nudger Motor 7.12

Analog Sensor 5/6 M TM Take Away Motor 1 8.5


No. Sensor Name CH M
A-3
5 TRAY 3 M TM Take Away Motor 2 8.5
A-1 Tray 1 Paper Size Sensor 7.1 14 M
A-2 Tray 2 Paper Size Sensor 7.2 M Duplex Motor 10.8
7/8
A-3 Tray 3 Paper Size Sensor (5Bit) 7.3
Take Away Roll 4
A-4 M Exit 2 Drive Motor 10.10
A-4 Tray 4 Paper Size Sensor (5Bit) 7.5 TRAY 4
A-5 MSI Paper Size Sensor 7.7 M Fusing Unit Drive Motor 10.1
I-3
M Main Drive Motor 4.1
6

M Stepping Motor M DC Motor Clutch Oneway Clutch Torque Limitter Sensor Analog Sensor Interlock NOTE: The motor positions shown in the illustration
Legend: A I
differ from those of the actual machine. j0se730809

Chain 8 Paper Transportation


7-105 7.3 BSD
7-106 7.3 BSD
Chain 8 Paper Transportation
A B C D E F G H J

8.10 PAPER PATH (2275/3373/3375-TTM)


Paper Path Sensor
Interlock Switch No. Sensor Name CH
1
No. Switch Name CH 1 Tray 1 Nudger Level Sensor 7.8
I-1 Front Cover Interlock Switch 1.12 Face Up Roll Exit Roll 2
2 Tray 1 No Paper Sensor 7.8
I-2 L/H Cover Interlock Switch 1.12 3 Tray 2 Nudger Level Sensor 7.9
I-3 TM L/H Cover Interlock Switch 1.13 EXIT 2 4 Tray 2 No Paper Sensor 7.9
M 5 Tray 3 Nudger Level Sensor 7.10
Invert Roll Exit Roll 1 6 Tray 3 No Paper Sensor 7.10
The roll name of feeder unit in each tray 18 EXIT 1 7 Tray 4 Nudger Level Sensor 7.11
2
Tray 1/2/3/4 Feed Roll 8 Tray 4 No Paper Sensor 7.11
Duplex Roll 1 DUPLEX
Tray 1/2/3/4 Nudger Roll I-1 9 MSI Nudger Position Sensor 7.12
M IOT
17 10 MSI No Paper Sensor 7.12
Duplex Roll 2
11 MSI Feed Out Sensor 8.3
Take Away Roll 1
Tray 1/2/3/4 Retard Roll I-2 12 Feed Out Sensor 2 8.6
Regi. Roll
13 Feed Out Sensor 3 8.6
M 16
3 14 Feed Out Sensor 4 8.6
19
Regi. Clutch 15 Regi. Sensor 8.7
Duplex Roll 3 M 16 POB Sensor 9.23
17 Fusing Unit Exit Sensor 10.6
15 M
Take Away Clutch 18 Exit 2 Sensor 10.10
M
9 1/2 19 Duplex Path Sensor 10.8
MSI
Motor A-1 TRAY 1 20 - -
A-5 10 11
4 No. Motor Name CH 21 - -
12 M
M 22 Tray 3 Pre Feed Sensor 8.2
7.8
M Tray 1/2/3/4 Feed Lift Motor
7.9 MSI Take Away Roll 23 Tray 4 Pre Feed Sensor 8.2
7.10 3/4
7.11 Take Away Roll 2 A-2 TRAY 2 Analog Sensor
13
M MSI Feed/Nudger Motor 7.12 Take Away Roll 4 M No. Sensor Name CH
M A-1 Tray 1 Paper Size Sensor 7.1
M TM Take Away Motor 1 8.5 14 23 7/8
A-2 Tray 2 Paper Size Sensor 7.2
5 M
M TM Take Away Motor 2 8.5 22 A-3 Tray 3 Paper Size Sensor (2Bit) 7.4
Take Away Roll 3
5/6 A-4 Tray 4 Paper Size Sensor (2Bit) 7.6
M Duplex Motor 10.8
A-5 MSI Paper Size Sensor 7.7
M Exit 2 Drive Motor 10.10

M Fusing Unit Drive Motor 10.1 A-3 TRAY 3 A-4 TRAY 4


I-3
M Main Drive Motor 4.1
6

M Stepping Motor M DC Motor Clutch Oneway Clutch Torque Limitter Sensor Analog Sensor Interlock NOTE: The motor positions shown in the illustration
Legend: A I
differ from those of the actual machine. j0se730810
A B C D E F G H J
8.11 PAPER PATH (4475/5575-3TM) Paper Path Sensor
Interlock Switch No. Sensor Name CH
No. Switch Name CH 1 Tray 1 Nudger Level Sensor 7.8
1
I-1 Front Cover Interlock Switch 1.12 2 Tray 1 No Paper Sensor 7.8

I-2 L/H Cover Interlock Switch 1.12 3 Tray 2 Nudger Level Sensor 7.9
Face Up Roll Exit Roll 2
I-3 TM L/H Cover Interlock Switch 1.13 4 Tray 2 No Paper Sensor 7.9
EXIT 2 5 Tray 3 Nudger Level Sensor 7.10
M 6 Tray 3 No Paper Sensor 7.10
Exit Roll 1 7 Tray 4 Nudger Level Sensor 7.11
The roll name of feeder unit in each tray 18 8 Tray 4 No Paper Sensor 7.11
2 EXIT 1
Tray 1/2/3/4 Feed Roll Invert Roll 9 MSI Nudger Position Sensor 7.12
Duplex Roll 1
Tray 1/2/3/4 Nudger Roll I-1 10 MSI No Paper Sensor 7.12
M IOT
DUPLEX 11 MSI Feed Out Sensor 8.3
17
Duplex Roll 2 12 Feed Out Sensor 2 8.6
I-2 13 Feed Out Sensor 3 8.6
Tray 1/2/3/4 Retard Roll
16 14 Feed Out Sensor 4 8.7
M 15 Regi. Sensor 8.8
3 19 Regi. Roll
Take Away Roll 1 16 POB Sensor 9.23
Regi. Clutch 17 Fusing Unit Exit Sensor 10.6
Duplex Roll 3 M
18 Exit 2 Sensor 10.10
15 M
19 Duplex Path Sensor 10.8
M 20
MSI 9 1/2 20 Tray 1 Pre Feed Sensor 8.1
Motor A-1
M TRAY 1
No. Motor Name CH A-5 10
4 11 M
7.8 12
7.9 MSI Take Away Roll M
M Tray 1/2/3/4 Feed Lift Up Motor
7.10
7.11 3/4
Analog Sensor
Take Away Roll 2 A-2
M MSI Feed/Nudger Motor 7.12 Take Away Roll 3 13 TRAY 2 No. Sensor Name CH
M
A-1 Tray 1 Paper Size Sensor 7.1
M TM Take Away Motor 1 8.5 A-2 Tray 2 Paper Size Sensor 7.2
5/6
M A-3 Tray 3 Paper Size Sensor (5Bit) 7.3
M TM Take Away Motor 2 8.5 A-3
5 TRAY 3
14 M A-4 Tray 4 Paper Size Sensor (5Bit) 7.5
M Duplex Motor 10.8 A-5 MSI Paper Size Sensor 7.7
7/8
M Exit 2 Drive Motor 10.10 A-4
Take Away Roll 4 TRAY 4
M Fusing Unit Drive Motor 10.1
I-3
M Main Drive Motor 4.1

6 M Take Away Motor 8.3

M Stepping Motor M DC Motor Clutch Oneway Clutch Torque Limitter Sensor Analog Sensor Interlock NOTE: The motor positions shown in the illustration
Legend: A I
differ from those of the actual machine. j0se730811

Chain 8 Paper Transportation


7-107 7.3 BSD
7-108 7.3 BSD
Chain 8 Paper Transportation
A B C D E F G H J

8.12 PAPER PATH (4475/5575-TTM)


Interlock Switch Paper Path Sensor
1 No. Switch Name CH No. Sensor Name CH
I-1 Front Cover Interlock Switch 1.10 Face Up Roll Exit Roll 2 1 Tray 1 Nudger Level Sensor 7.8
I-2 L/H Cover Interlock Switch 1.10 2 Tray 1 No Paper Sensor 7.8
I-3 TM L/H Cover Interlock Switch 1.11 EXIT 2 3 Tray 2 Nudger Level Sensor 7.9
M 4 Tray 2 No Paper Sensor 7.9

Invert Roll Exit Roll 1 5 Tray 3 Nudger Level Sensor 7.10


18 6 Tray 3 No Paper Sensor 7.10
The roll name of feeder unit in each tray EXIT 1
2 7 Tray 4 Nudger Level Sensor 7.11
Tray 1/2/3/4 Feed Roll Duplex Roll 1 DUPLEX
8 Tray 4 No Paper Sensor 7.11
Tray 1/2/3/4 Nudger Roll I-1
M IOT 9 MSI Nudger Position Sensor 7.12
17
Duplex Roll 2 10 MSI No Paper Sensor 7.12
Take Away Roll 1 11 MSI Feed Out Sensor 8.3
I-2
Tray 1/2/3/4 Retard Roll
Regi. Roll 12 Feed Out Sensor 2 8.6
M 16 13 Feed Out Sensor 3 8.6
3 19 14 Feed Out Sensor 4 8.6
Duplex Roll 3 Regi. Clutch 15 Regi. Sensor 8.7
M 16 POB Sensor 9.24
15 M 17 Fusing Unit Exit Sensor 10.6
M
9 18 Exit 2 Sensor 10.10
1/2
MSI 20 19 Duplex Path Sensor 10.8
Motor M A-1 TRAY 1
A-5 10 11 20 Tray 1 Pre Feed Sensor 8.1
4 No. Motor Name CH
12 M 21 - -
7.8 M
7.9 MSI Take Away Roll
22 Tray 3 Pre Feed Sensor 8.2
M Tray 1/2/3/4 Feed Lift Up Motor
7.10 3/4 23 Tray 4 Pre Feed Sensor 8.2
7.11
Take Away Roll 2 A-2 TRAY 2
M MSI Feed/Nudger Motor 7.12 13 Take Away Roll 4 M Analog Sensor
M TM Take Away Motor 1 8.5 M
14 23 No. Sensor Name CH
7/8
A-1 Tray 1 Paper Size Sensor 7.1
5 M TM Take Away Motor 2 8.5 M
22 A-2 Tray 2 Paper Size Sensor 7.2
Take Away Roll 3
M 5/6 A-3 Tray 3 Paper Size Sensor (2Bit) 7.4
Duplex Motor 10.8
A-4 Tray 4 Paper Size Sensor (2Bit) 7.6
M Exit 2 Drive Motor 10.10 A-5 MSI Paper Size Sensor 7.7

M Fusing Unit Drive Motor 10.1 A-3 TRAY 3 A-4 TRAY 4


I-3
M Main Drive Motor 4.1
6
M Take Away Motor 8.3

M Stepping Motor M DC Motor Clutch Oneway Clutch Torque Limitter Sensor Analog Sensor Interlock NOTE: The motor positions shown in the illustration
Legend: A I
differ from those of the actual machine. j0se730812
A B C D E F G H J

8.13 PAPER PATH (6675/7775-TTM)


Paper Path Sensor
Interlock Switch No. Sensor Name CH
1
No. Switch Name CH 1 Tray 1 Nudger Level Sensor 7.8
Face Up Roll Exit Roll 2
I-1 Front Cover Interlock Switch 1.12 2 Tray 1 No Paper Sensor 7.8
I-2 L/H Cover Interlock Switch 1.12 3 Tray 2 Nudger Level Sensor 7.9
I-3 TM L/H Cover Interlock Switch 1.13 EXIT 2
4 Tray 2 No Paper Sensor 7.9
M
5 Tray 3 Nudger Level Sensor 7.10
Exit Roll 1
Invert Roll 6 Tray 3 No Paper Sensor 7.10
The roll name of feeder unit in each tray 18 EXIT 1
2 7 Tray 4 Nudger Level Sensor 7.11
Tray 1/2/3/4 Feed Roll Duplex Roll 1 DUPLEX 8 Tray 4 No Paper Sensor 7.11
Tray 1/2/3/4 Nudger Roll I-1 9 MSI Nudger Position Sensor 7.12
M IOT
17 10 MSI No Paper Sensor 7.12
Duplex Roll 2
11 MSI Feed Out Sensor 8.3
Take Away Roll 1
I-2 12 Feed Out Sensor 2 8.6
Tray 1/2/3/4 Retard Roll Regi. Roll
13 Feed Out Sensor 3 8.6
M 16
3 19 14 Feed Out Sensor 4 8.6
15 Regi. Sensor 8.8
Duplex Roll 3
M 16 POB Sensor 9.23
15
17 Fusing Unit Exit Sensor 10.6
M
M 20 18 Exit 2 Sensor 10.10
9 1/2 19 Duplex Path Sensor 10.8
MSI
Motor M A-1 TRAY 1 20 Tray 1 Pre Feed Sensor 8.1
A-5 10 11
4 No. Motor Name CH 21 Tray 2 Pre Feed Sensor 8.1
12 M
7.8 M 22 Tray 3 Pre Feed Sensor 8.2
7.9 MSI Take Away Roll 21
M Tray 1/2/3/4 Feed Lift Motor 23 Tray 4 Pre Feed Sensor 8.2
7.10 3/4 Take Away Roll 5
7.11 Take Away Roll 2
M Take Away Roll 4 A-2 TRAY 2 Analog Sensor
M 7.12 13
MSI Feed/Nudger Motor M No. Sensor Name CH
M TM Take Away Motor 1 8.5 A-1 Tray 1 Paper Size Sensor 7.1
14 23 7/8
Take Away Roll 3 A-2 Tray 2 Paper Size Sensor 7.2
5 M TM Take Away Motor 2 8.5 M
22 A-3 Tray 3 Paper Size Sensor (2Bit) 7.4
M 5/6 A-4 Tray 4 Paper Size Sensor (2Bit) 7.6
Duplex Motor 10.8
A-5 MSI Paper Size Sensor 7.7
M Exit 2 Drive Motor 10.10

M Fusing Unit Drive Motor 10.1 A-3 TRAY 3 A-4 TRAY 4


I-3
M Regi. Motor 8.8
6
M Take Away Motor 8.3

M Stepping Motor M DC Motor Clutch Oneway Clutch Torque Limitter Sensor Analog Sensor Interlock NOTE: The motor positions shown in the illustration
Legend: A I
differ from those of the actual machine. j0se730814

Chain 8 Paper Transportation


7-109 7.3 BSD
7-110 7.3 BSD
Chain9 Marking
A B C D E F G H J
9.1 DRUM/DEVE DRIVE CONTROL (Y,M,C) FAIL CODE
3 DC330 091-044 042-320
DC330 091-045 Drum Y,M,C Motor Fail
1
MOTOR DRUM DRIVE
DRIVER MAIN 1 DC330 091-026 TO 091-031/048 MOTOR (Y,M,C)
PWB PL3.4 MOTOR DRIVER MAIN
PL18.2 2 DC330 091-014 TO 091-019/046 PWB
+5VDC
DRUM DRIVE MOTOR (Y,M,C) PL18.2
J527 ON(L) +5VDC J247
A11 BLU 6 +3.3VDC
+5VDC
DC COM DRUM DRIVE MOTOR (Y,M,C)
CLOCK J247 FAIL(H) +3.3VDC J527
2 A10 BLU 7 8 BLU
A9 042-320
+5VDC
DC COM
BRAKE(L) +5VDC
A12 BLU 5
+5VDC
DC COM
GAIN(L) +5VDC ELECTRICAL COMPONENTS & DRIVE TRANSMISSION
A14 BLU 3
+5VDC <4475/5575> <2275/3373/3375>
DC COM
CW/CCW(L) +5VDC
A13 BLU 4
Drum Drive Motor
3 DC COM (Y,M,C)
+5VDC
A16 BLU 1
+5VDC
(1.6 D2)
DC COM
A15 BLU 2
DC COM
(1.4 D4) Drum/Deve Drive
J526 INTLK +24VDC J246
3 1 Motor (Y,M,C)
4 ORN
INTLK
+24V F15
(1.12 E5) DC COM
4 VIO
2
DC COM
(1.4 D4)

NOTE:
5 1 The operation varies depending on the diag code. 2 The diag codes below drive Drum Drive Motor (Y,M,C), 3 <Multiple-Component Control>
Drum/Deve Drive Motor (K) and IBT Drive Motor simultaneously. Outputs the following at the same time:
・Drum Drive Motor (Y, M, C)
DC330 Process Speed ・Drum/Deve Drive Motor (Y, M, C)
DC330 Process Speed ・Drum/Deve Drive Motor (K)
091-026 79mm/sec ・Deve Drive Motor (Y, M, C)
091-014 79mm/sec ・IBT Drive Motor
091-027 121mm/sec ・Erase Lamp Y, M, C, K
091-015 121mm/sec
091-028 175mm/sec ・Agitator Motor
091-016 175mm/sec ・BCR AC Y, M, C, K
091-029 200mm/sec
091-017 200mm/sec
6 091-030 225mm/sec
091-018 225mm/sec
091-031 REVERSE
091-019 Reverse
091-048 308mm/sec
091-046 308mm/sec
j0se730901
A B C D E F G H J
9.2 DRUM/DEVE DRIVE CONTROL (K) FAIL CODE
042-323
Drum K Motor Fail
1 1 DC330 091-032 TO 091-037/049
DRUM/DEVE DRIVE MOTOR DRIVER MAIN
MOTOR 2 DC330 091-014 TO 091-019/046 MOTOR (K) PWB
DRIVER MAIN PL3.4 PL18.2
PWB 3 DC330 091-020 TO 091-025/047
PL18.2 DRUM/DEVE DRIVE +3.3VDC
+5VDC
DRUM/DEVE DRIVE MOTOR (K) MOTOR (K)
J527 ON(L) +5VDC J241 J241 FAIL(H) +3.3VDC J527
A3 BLU
6 8 BLU
A1 042-323 ELECTRICAL COMPONENTS & DRIVE TRANSMISSION
+5VDC
DC COM
CLOCK
A2 BLU
7
2 +5VDC
DC COM
BRAKE(L) +5VDC
A4 BLU
5
+5VDC
Drum/Deve
DC COM
GAIN(L) +5VDC Drive Motor (K)
A6 BLU
3
+5VDC DC330 091-044
DC COM 4
CW/CCW(L) +5VDC DC330 091-045
A5 BLU
4
DC COM
3
+5VDC
A8 BLU
1
+5VDC
(1.6 D2)
DC COM
A7 BLU
2
DC COM
(1.4 D4)
J526 INTLK +24VDC J240
1 1
ORN
4 INTLK
+24V F15
(1.12 E5) DC COM
2 VIO
2
DC COM
(1.4 D4)

NOTE:
1 The operation varies depending on the diag code. 2 The diag codes below drive Drum Drive Motor (Y,M,C), 3 The diag codes below drive 4 <Multiple-Component Control>
Drum/Deve Drive Motor (K) and IBT Drive Motor simultaneously. Drum/Deve Drive Motor (K) and Outputs the following at the same time:
5 IBT Drive Motor simultaneously. ・Drum Drive Motor (Y, M, C)
DC330 Process Speed ・Drum/Deve Drive Motor (Y, M, C)
DC330 Process Speed ・Drum/Deve Drive Motor (K)
091-032 79mm/sec DC330 Process Speed ・Deve Drive Motor (Y, M, C)
091-014 79mm/sec ・IBT Drive Motor
091-033 121mm/sec 091-020 79mm/sec ・Erase Lamp Y, M, C, K
091-015 121mm/sec
091-034 175mm/sec 091-021 121mm/sec ・Agitator Motor
091-016 175mm/sec ・BCR AC Y, M, C, K
091-035 200mm/sec 091-022 175mm/sec
091-017 200mm/sec
091-036 255mm/sec 091-023 200mm/sec
091-018 225mm/sec
6 091-037 Reverse 091-024 255mm/sec
091-019 Reverse
091-049 308mm/sec 091-025 Reverse
091-046 308mm/sec
091-047 308mm/sec
j0se730902

Chain9 Marking
7-111 7.3 BSD
7-112 7.3 BSD
Chain9 Marking
A B C D E F G H J
9.3 DRUM LIFE CONTROL (Y,M) FAIL CODE
ELECTRICAL COMPONENTS
024-933
MOTOR DRIVER MAIN PWB Drum Cartridge Y Life End
1 PL18.2
024-940
DRUM CRUM COUPLER ASSEMBLY (Y) Drum Cartridge M Life End
PL8.1
024-933 DRUM UNIT 091-313
DRUM CRUM PWB (Y) CRUM
+3.3VDC CRUM ASIC Communication
091-411 Fail
J528 DATA P112 4 DATA
091-417 A4 BLU
1 091-411
Drum Cartridge Y Near Life
091-480 CRUM +2.5VDC 3 VCC
2 A3 BLU
2 091-417
091-917
CRUM Drum Y CRUM Trouble Info
091-927 +2.5VDC 2 CLOCK
(1.6 E3) CLOCK 091-421
A2 BLU
3
091-940 Drum Crum Unit (Y) Drum Cartridge M Near Life
DC COM 1 GND 091-427
091-943 A1 4 Drum Crum Unit (M)
BLU Drum M CRUM Trouble Info
DC COM
091-313 (1.4 D4) 091-480
3 DRUM CRUM COUPLER ASSEMBLY (M) Drum Cartridge Y Life Over
PL8.1
024-940 DRUM UNIT 091-481
DRUM CRUM PWB (M) CRUM
+3.3VDC Drum Cartridge M Life Over
091-421
DATA P113 4 DATA 091-917
091-427 A8 BLU
1
Drum CRUM Y
091-481 Communication Fail
CRUM +2.5VDC 3 VCC
A7 BLU
2 091-918
091-918
CRUM Drum CRUM M
4 091-928 +2.5VDC 2 CLOCK Communication Fail
(1.6 E3) CLOCK
A6 BLU
3 091-927
091-941
Drum CRUM Y Not In
DC COM 1 GND Position
091-944 A5 4
BLU 091-928
DC COM
(1.4 D4) Drum CRUM M Not In
Position
091-940
5 Drum CRUM Y Data Broken
091-941
Drum CRUM M Data Broken
091-943
Drum CRUM Y Data
Mismatch
091-944
Drum CRUM M Data
6 Mismatch

j0se730903
A B C D E F G H J
9.4 DRUM LIFE CONTROL (C,K) FAIL CODE
ELECTRICAL COMPONENTS
024-941
MOTOR DRIVER MAIN PWB Drum Cartridge C Life End
1 PL18.2
091-313
DRUM CRUM COUPLER ASSEMBLY (C) CRUM ASIC Communication
PL8.1 Fail
024-941 DRUM UNIT
DRUM CRUM PWB (C) CRUM 091-401
+3.3VDC
091-431 Drum Cartridge K Near Life
J528 DATA P114 4 DATA
091-437 A12 BLU 1 091-402
Drum Cartridge K Life Over
091-482 CRUM +2.5VDC 3 VCC
2 A11 BLU 2 091-407
091-919
CRUM Drum K CRUM Trouble Info
091-929 +2.5VDC 2 CLOCK
(1.6 E3) CLOCK 091-431
A10 BLU 3
091-942 Drum Cartridge C Near Life
DC COM 1 GND Drum Crum Unit (C) 091-437
091-945 A9 4
BLU Drum C CRUM Trouble Info
DC COM
(1.4 D4) 091-482
091-313 Drum Crum Unit (K)
3 DRUM CRUM COUPLER ASSEMBLY (K) Drum Cartridge C Life Over
PL8.1
091-401 DRUM UNIT 091-913
DRUM CRUM PWB (K) CRUM
+3.3VDC Drum Cartridge K Life End
091-402
DATA P115 4 DATA 091-914
091-407 A16 BLU 1
Drum CRUM K
Communication Fail
091-913 CRUM +2.5VDC 3 VCC
A15 BLU 2 091-915
091-914 Drum CRUM K Data
CRUM
4 +2.5VDC 2 CLOCK Broken
091-915 (1.6 E3) CLOCK
A14 BLU 3 091-916
091-916 Drum CRUM K Data
DC COM 1 GND Mismatch
091-921 A13 BLU 4
091-919
DC COM
(1.4 D4) Drum CRUM C
Communication Fail
091-921
5 Drum CRUM K Not In
Position
091-929
Drum CRUM C Not In
Position
091-942
Drum CRUM C Data
Broken
091-945
6
Drum CRUM C Data
Mismatch

j0se730904

Chain9 Marking
7-113 7.3 BSD
7-114 7.3 BSD
Chain9 Marking
A B C D E F G H J
9.5 TONER CARTRIDGE LIFE CONTROL (Y,M) ELECTRICAL COMPONENTS FAIL CODE
093-314
Y Dispense Motor Fail
1
093-315
MOTOR DRIVER MAIN PWB TONER CRUM COUPLER ASSEMBLY (Y) M Dispense Motor Fail
PL18.2 PL5.1
093-427
TONER CARTRIDGE
+3.3VDC CRUM PWB (Y) Toner Y CRUM
4 DATA Trouble Info
J411 DATA J120
093-314 A4 BLU
1 093-428
Toner M CRUM
093-427 CRUM +2.5VDC 3 VCC Trouble Info
2 A3 BLU
2
093-943 093-941
CRUM
+2.5VDC Toner M CRUM
093-950 (1.6 E3) CLOCK 2 CLOCK Communication Fail
A2 BLU
3 Toner Cartridge
093-960 Crum (Y) 093-943
DC COM 1 GND Toner Cartridge Toner Y CRUM
093-970 A1 4 Communication Fail
BLU Crum (M)
DC COM 093-950
(1.4 D4)
Toner Y CRUM Data
3 TONER CRUM COUPLER ASSEMBLY (M) Broken Fail
PL5.1
TONER 093-951
TONER CARTRIDGE CARTRIDGE
+3.3VDC CRUM PWB (M) CRUM (M) Toner M CRUM Data
093-315 Broken Fail
DATA J121 4 DATA
093-428 A12 BLU 1 093-960
Toner Y CRUM Data
093-941 CRUM +2.5VDC 3 VCC Mismatch Fail
A11 BLU 2
093-951 093-961
CRUM
4 +2.5VDC Toner M CRUM Data
093-961 (1.6 E3) CLOCK 2 CLOCK Mismatch Fail
A10 BLU 3
093-971 093-970
DC COM 1 GND Toner Y CRUM Not
A9 BLU
4 In Position
DC COM 093-971
(1.4 D4)
Toner M CRUM Not
In Position

j0se730905
A B C D E F G H J
9.6 TONER CARTRIDGE LIFE CONTROL (C,K) ELECTRICAL COMPONENTS FAIL CODE
093-316
MOTOR DRIVER MAIN PWB TONER CRUM COUPLER ASSEMBLY (C) C Dispense Motor Fail
1 PL18.2 PL5.1
093-317
TONER CARTRIDGE
+3.3VDC CRUM PWB (C) K Dispense Motor Fail
J411 DATA J122 4 DATA 093-426
093-316 1
B4 GRY Toner K CRUM
093-429 Trouble Info
CRUM +2.5VDC 3 VCC
093-942 B3 GRY
2 093-429
CRUM Toner C CRUM
093-952 +2.5VDC Trouble Info
2 (1.6 E3) CLOCK 2 CLOCK Toner Cartridge
093-962 B2 GRY
3 Crum (C) 093-912
K Toner Cartridge
093-972 DC COM 1 GND Empty
B1 GRY
4
093-916
DC COM
(1.4 D4) Toner Cartridge Toner K CRUM Not
Crum (K) In Position
TONER CRUM COUPLER ASSEMBLY (K)
PL5.1 093-924
093-317 TONER CARTRIDGE Toner K CRUM
3 +3.3VDC CRUM PWB (K) Communication Fail
093-426 DATA J123 4 DATA 093-925
B12 GRY 1
093-912 Toner K CRUM Data
Broken Fail
CRUM +2.5VDC 3 VCC
093-916 B11 GRY 2 093-926
093-924 CRUM Toner K CRUM Data
+2.5VDC 2 CLOCK Mismatch Fail
093-925 (1.6 E3) CLOCK
B10 GRY 3 093-942
4 093-926 Toner C CRUM
DC COM 1 GND Communication Fail
B9 GRY
4
093-952
DC COM
(1.4 D4) Toner C CRUM Data
Broken Fail
093-962
Toner C CRUM Data
Mismatch Fail
093-972
5 Toner C CRUM Not In
Position

j0se730906

Chain9 Marking
7-115 7.3 BSD
7-116 7.3 BSD
Chain9 Marking
A B C D E F G H J
9.7 CHARGING AND EXPOSURE (1/2) NOTE:
1 Operates the components below
MOTOR DRIVER MAIN PWB HVPS (BCR) simultaneously.
1 PL18.2 PL18.6 2275/3373/3375: DC330 [091-028]
DC330 091-009 3 J414 J513 4475/5575: DC330 [091-030]
BCR AC CLK 6675/7775: DC330 [091-048]
A15 3 CAUTION HIGH
Output AC VOLTAGE
DC330 091-010 1 4 Component
BCR AC CLK SEL Freq. Control 2 Operates the components below
A14 4 simultaneously.
DC330 091-011 1 4 2275/3373/3375: DC330 [091-034]
1 DC330 091-005 4475/5575: DC330 [091-036]
BCR Y AC PWM BCR BIAS Y 6675/7775: DC330 [091-048]
DC330 091-012 1 A13 5
DC330 091-001 4
DC330 091-013 2 1 3 Operates the components below
2 BCR Y DC PWM
simultaneously.
A12 6
4 2275/3373/3375: DC330 [091-028/034]
1 DC330 091-006 4475/5575: DC330 [091-030/036]
BCR M AC PWM BCR BIAS M 6675/7775: DC330 [091-048/049]
A10 8
DC330 091-002 4
1 4 Wire Color varies depending on the model.
BCR M DC PWM
A9 9 2275/3373/3375/ : BLU
DC330 091-007 4 4475/5575 : WHT
J414 1
BCR C AC PWM BCR BIAS C 6675/7775 : VIO
A11 A7 11
3 4 4
1 DC330 091-003
DC COM BCR C DC PWM
A8 A6 12
4 DC330 091-008 4
DC COM 2
BCR K AC PWM BCR BIAS K
A5 A4 14
4 DC330 091-004 4
DC COM 1
BCR K DC PWM
A2 A3 15
4 4 Idc Monitor J513
4 DC COM INTLK +24VDC Y 7
A17 1 4
4
INTLK Idc Monitor
+24V F11 M 10
(1.12 E4) SIGNAL GND 4
A1 17
4 Idc Monitor
C 13
DC COM 4
A16 2
4 Idc Monitor
DC COM K 16
(1.4 D4) 4
5
DC140 091-203
BCR K DC Io Mon
DC140 091-202
BCR C DC Io Mon
DC140 091-201
BCR M DC Io Mon

6 DC140 091-200
BCR Y DC Io Mon

j0se730907
A B C D E F G H J
9.8 CHARGING AND EXPOSURE (2/2)

<Charging And Exposure Y> BCR Y <Charging And Exposure M>


1
BCR M

HVPS (BCR)
HVPS (BCR)

<Charging And Exposure C> <Charging And Exposure K>

BCR C BCR K
4

6 HVPS (BCR) HVPS (BCR)

j0se730908

Chain9 Marking
7-117 7.3 BSD
7-118 7.3 BSD
Chain9 Marking
A B C D E F G H J
9.9 DEVE DRIVE CONTROL (Y,M,C) FAIL CODE
093-324
MOTOR DRIVER MAIN
DEVE DRIVE MOTOR PWB Deve Y,M,C Motor Fail
1 MOTOR (Y,M,C) PL18.2
DRIVER MAIN 1 PL3.4
PWB
PL18.2 DC330 093-022 TO 093-026/040 +3.3VDC
+5VDC
DEVE DRIVE MOTOR (Y,M,C) DEVE DRIVE MOTOR (Y,M,C)
J527 ON(L) +5VDC J252 J252 FAIL(H) +3.3VDC J527
B11 GRY 6 8 GRY
B9 093-324
+5VDC ELECTRICAL COMPONENTS & DRIVE TRANSMISSION
DC COM
CLOCK
B10 GRY 7
+5VDC
DC COM
2 BRAKE(L) +5VDC
B12 GRY 5
+5VDC
DC COM
GAIN(L) +5VDC
B14 GRY 3 2 DC330 091-044
DC COM DC330 091-045

Deve Drive Motor


+5VDC (Y,M,C)
B16 GRY 1
3
+5VDC
(1.6 D2)
DC COM
B15 GRY 2
DC COM
(1.4 D4)
J526 INTLK +24VDC J251
7 1
ORN
INTLK
+24V F15
(1.12 E5) DC COM
4 8 VIO
2
DC COM
(1.4 D4)

NOTE:
1 The operation varies depending on the diag code. 2 <Multiple-Component Control>
Outputs the following at the same time:
・Drum Drive Motor (Y, M, C)
DC330 Process Speed ・Drum/Deve Drive Motor (Y, M, C)
5 ・Drum/Deve Drive Motor (K)
093-022 121mm/sec ・Deve Drive Motor (Y, M, C)
・IBT Drive Motor
093-023 175mm/sec ・Erase Lamp Y, M, C, K
093-024 200mm/sec ・Agitator Motor
・BCR AC Y, M, C, K
093-025 225mm/sec
093-026 255mm/sec
093-040 308mm/sec

j0se730909
A B C D E F G H J
9.10 TONER SUCTION CONTROL & MARKING MODULE COOLING FAIL CODE
1 DC330 042-025 042-341
MHVPS Fan Fail
1 MOTOR DRIVER MAIN
PWB 4475/5575/6675/7775 MOTOR DRIVER MAIN 042-342
PL18.2 SUCTION PWB
FAN PL18.2 Suction Fan Fail
+24VDC F5 DC330 042-020 PL18.2 (4475/5575/6675/7775)
(1.8 D3)
SUCTION FAN
J414 ON(H) +24VDC J231 P231 DC330 042-211 +3.3VDC NOTE:
B11 GRY 4 1 SUCTION FAN
P231 J231 FAIL(H) +3.3VDC J414 1 DC330[042-025] performs a fault detection after
DC COM MOT 3 2 B12 042-342
GRY rotating the target fans concurrently for 5 seconds.
DC COM If any fan is found to be faulty, a fail code is issued.
B13 GRY 1 4 Fail codes can be referred to via DC125.
2 DC COM
Check the following NVM settings in advance.
(1.4 D4)
(1) NVM741-072: Fan Fail Bypass should be "0".
4475/5575/6675/ 2275/3373/3375 If you want to prevent any particular fan from raising a fail,
7775 change this value to the fail bypass number for that fan.
HV FAN (2) NVM741-146: LH FAN CONDITION FLAG should be 1 or 2".
+24VDC F5 DC330 042-012 MARKING PL4.3 If you want to prevent an LH Fan Fail from being raised,
(1.8 D3) FAN change this value to "0".
MARKING/HV FAN PL4.3
ON(H) +24VDC J235 P235
B4 5 1 The following fans are targeted:
GRY ・010-398: Fusing Unit Fan
DC COM
DC330 042-206 +3.3VDC ・042-336: Process 2 Fan
3 MARKING/HV FAN ・043-322: LVPS FAN
P235 J235 FAIL(H) +3.3VDC
MOT 3 3 B6 042-341 ・042-332: IH Intake Fan
GRY ・042-330: IH Exhaust Fan
・042-609: LH Fan 1/2/3 (When NVM742-146 is set to "1 or 2")
・042-342: Suction Fan (4475/5575/6675/7775)
DC COM ・042-340: Cartridge Fan (4475/5575/6675/7775)
B7 GRY
1 5
・042-335: Process 1 Fan (4475/5575/6675/7775)
DC COM ・042-344: C Exhaust Fan (4475/5575/6675/7775)
(1.4 D4) 2 ・042-343: Rear Bottom Fan (4475/5575/6675/7775)
・042-341: HV Fan (4475/5575/6675/7775)
・043-321: RH Fan (4475/5575/6675/7775)
4 ・042-341: Marking Fan (2275/3373/3375)
ELECTRICAL COMPONENTS
1
<4475/5575> <2275/3373/3375> The Pin No. depends on the model.
2 ・ Pin 1/5 : 2275/3373/3375/4475/5575
・ Pin 2/4 : 6675/7775
Suction Fan

HV Fan
Marking Fan
j0se730910

Chain9 Marking
7-119 7.3 BSD
7-120 7.3 BSD
Chain9 Marking
A B C D E F G H J
9.11 DEVELOPMENT Y FAIL CODE
092-312
MOTOR ATC MOTOR DRIVER MAIN ATC Fail Y
1 DRIVER MAIN ATC PWB SENSOR (Y) PWB
PWB PL5.2 PL5.2 ATC PWB PL18.2 092-657
PL18.2 PL5.2
J528 +5VDC J633 J124 DC140 092-203 ATC Amplitude Fail Y
B11 GRY 6 3 ATC SENSOR (Y) 092-312
J124 J633 J528 092-665
+5VDC 9.12 9.13 9.14 SENSED SIGNAL
(1.6 D2)
2 5 GRY
B12 092-657 ATC Average Fail Y
DC COM
B16 GRY 1 1 DC COM 092-665
DC COM 9.12 9.13 9.14
(1.4 D4)
2
ELECTRICAL COMPONENTS
HVPS (DEVE) (1/4)
PL18.5 ATC PWB
Output AC 9.12 9.13 9.14
J417 DEVE AC CLK J514 Component
B9 3 Freq./Duty
GRY
Control
DC330 093-027
DEVE Y DC PWM DEVE BIAS Y
3 B6 GRY
6
DC330 093-031
DEVE YMC AC PWM Magnet Roll (Y)
B8 4 Vdc Monitor Y
GRY

INTLK +24VDC DC COM


B11 GRY 1 9.12 9.13
INTLK
+24V F11
(1.12 E4) DC COM
B10 GRY 2 CAUTION HIGH
4 VOLTAGE
DC COM
(1.4 D4)

HVPS (DEVE)

ATC Sensor (Y)

j0se730911
A B C D E F G H J
9.12 DEVELOPMENT M FAIL CODE
092-313
ATC PWB ATC Fail M
1 PL5.2 ATC MOTOR DRIVER MAIN
SENSOR (M) PWB 092-658
PL5.2 ATC PWB PL18.2
9.11 PL5.2 ATC Amplitude Fail M
J125 +5VDC
DC140 092-204
3 ATC SENSOR (M) 092-313 092-666
J125 J633 SENSED SIGNAL J528 ATC Average Fail M
9.11
2 4 GRY
B13 092-658
DC COM 092-666
1 DC COM

2
ELECTRICAL COMPONENTS
HVPS (DEVE) (2/4)
PL18.5 ATC PWB
MOTOR
DRIVER MAIN
PWB 9.11 Output AC Component CAUTION HIGH
PL18.2 Freq./Duty Control VOLTAGE

DC330 093-028 Magnet Roll (M)


J417 DEVE M DC PWM J514 DEVE BIAS M
3 B5 7
GRY
9.11 DEVE YMC
AC PWM Vdc Monitor M

DC COM

4
HVPS (DEVE)

5 ATC Sensor (M)

j0se730912

Chain9 Marking
7-121 7.3 BSD
7-122 7.3 BSD
Chain9 Marking
A B C D E F G H J
9.13 DEVELOPMENT C FAIL CODE
092-314
ATC PWB ATC Fail C
1 PL5.2 ATC MOTOR DRIVER MAIN
SENSOR (C) PWB 092-659
PL5.2 ATC PWB PL18.2
9.11 PL5.2 ATC Amplitude Fail C
J126 +5VDC DC140 092-205
3 ATC SENSOR (C) 092-314 092-667
J126 J633 SENSED SIGNAL J528 ATC Average Fail C
9.11
2 3 GRY
B14 092-659
DC COM
1 DC COM 092-667

2
ELECTRICAL COMPONENTS

HVPS (DEVE) (3/4) ATC PWB


PL18.5
MOTOR
DRIVER MAIN
PWB 9.11 Output AC Component CAUTION HIGH
PL18.2 Freq./Duty Control VOLTAGE Magnet Roll (C)
DC330 093-029
J417 DEVE C DC PWM J514 DEVE BIAS C
3 B4 8
GRY
9.11 DEVE YMC
AC PWM Vdc Monitor C

DC COM

4
HVPS (DEVE)

ATC Sensor (C)

j0se730913
A B C D E F G H J
9.14 DEVELOPMENT K FAIL CODE
092-315
ATC PWB ATC Fail K
1 PL5.2 ATC MOTOR DRIVER MAIN
SENSOR (K) PWB 092-660
PL5.2 ATC PWB PL18.2
9.11 PL5.2 ATC Amplitude Fail K
J127 +5VDC DC140 092-206
3 ATC SENSOR (K) 092-315 092-668
J127 J633 SENSED SIGNAL J528 ATC Average Fail K
9.11
2 2 GRY
B15 092-660
DC COM
1 DC COM 092-668

2
ELECTRICAL COMPONENTS

ATC PWB

HVPS (DEVE) (4/4) Magnet Roll (K)


MOTOR PL18.5
DRIVER MAIN
PWB
PL18.2 9.11 Output AC Component CAUTION HIGH
Freq./Duty Control VOLTAGE
3 DC330 093-032
J417 DEVE K AC PWM J514
B7 5 DEVE BIAS K
GRY
DC330 093-030
DEVE K DC PWM
B3 GRY
9
Vdc Monitor K

DC COM

4
HVPS (DEVE)

ATC Sensor (K)

j0se730914

Chain9 Marking
7-123 7.3 BSD
7-124 7.3 BSD
Chain9 Marking
A B C D E F G H J
9.15 HVPS (DEVE) COOLING (4475/5575/6675/7775) FAIL CODE
1 DC330 042-025 043-321
RH Fan Fail
1 MOTOR DRIVER MAIN
PWB RH FAN
PL18.2 PL4.4 MOTOR DRIVER MAIN
+24VDC F5 DC330 042-027 PWB
(1.8 D3) PL18.2
RH FAN
J414 ON(H) +24VDC J278 P278 DC330 042-217 +3.3VDC
B1 GRY 4 1 RH FAN
P278 J278 FAIL(H) +3.3VDC J414
DC COM MOT 3 2 B2 043-321
GRY
DC COM
B3 GRY 1 4
2 DC COM
(1.4 D4)

NOTE: ELECTRICAL COMPONENTS

1 DC330[042-025] performs a fault detection after


rotating the target fans concurrently for 5 seconds. RH Fan
If any fan is found to be faulty, a fail code is issued.
3 Fail codes can be referred to via DC125.
Check the following NVM settings in advance.
(1) NVM741-072: Fan Fail Bypass should be "0".
If you want to prevent any particular fan from raising a fail,
change this value to the fail bypass number for that fan.
(2) NVM741-146: LH FAN CONDITION FLAG should be 1 or 2".
If you want to prevent an LH Fan Fail from being raised,
change this value to "0".
The following fans are targeted:
4 ・010-398: Fusing Unit Fan
・042-336: Process 2 Fan
・043-322: LVPS FAN
・042-332: IH Intake Fan
・042-330: IH Exhaust Fan
・042-609: LH Fan 1/2/3 (When NVM742-146 is set to "1 or 2")
・042-342: Suction Fan (4475/5575/6675/7775)
・042-340: Cartridge Fan (4475/5575/6675/7775)
・042-335: Process 1 Fan (4475/5575/6675/7775)
・042-344: C Exhaust Fan (4475/5575/6675/7775)
・042-343: Rear Bottom Fan (4475/5575/6675/7775)
・042-341: HV Fan (4475/5575/6675/7775)
5 ・043-321: RH Fan (4475/5575/6675/7775)
・042-341: Marking Fan (2275/3373/3375)

j0se730915
A B C D E F G H J
9.16 TONER DISPENSE CONTROL (Y,M) ELECTRICAL COMPONENTS & DRIVE TRANSMISSION

DC330 093-00179mm/s
1 DC330 093-002121mm/s
DC330 093-003175mm/s
DC330 093-004200mm/s
MOTOR DRIVER MAIN PWB MOTOR DRIVER SUB PWB DC330 093-005225mm/s
PL18.2 PL18.2 INTLK
TONER Toner Dispense
F3 +24VDC
DC330 093-033255mm/s DISPENSE
(1.12 H4) DC330 093-034308mm/s MOTOR (Y) Motor (M)
MOTOR TONER DISPENSE MOTOR (Y) PL5.1
ON P452 J452 J529 ON +24VDC CLOCK A J220
31 A4 1 1
BLU Toner Dispense
2 DC COM Motor (Y)
MOTOR DC COM
CLOCK
32 CLOCK /A
A3 2
BLU
DC COM DC COM MOT

CLOCK B
A1 4
BLU
DC COM
3
CLOCK /B
A2 3
BLU
DC COM

DC330 093-00679mm/s
DC330 093-007121mm/s
DC330 093-008175mm/s
DC330 093-009200mm/s
DC330 093-010225mm/s TONER
INTLK
4 F3 +24VDC DC330 093-035255mm/s DISPENSE
(1.12 H4) DC330 093-036308mm/s MOTOR (M)
MOTOR TONER DISPENSE MOTOR (M) PL5.1
ON ON +24VDC CLOCK A J221
29 A8 1 1
BLU
DC COM
MOTOR DC COM
CLOCK
30 CLOCK /A
A7 2
BLU
DC COM DC COM
5 MOT

CLOCK B
A5 4
BLU
DC COM

CLOCK /B
A6 3
BLU
DC COM

NOTE:
1 Toner Dispense Motor (Y/M) winding resistance is 5.3Ω±10%.
j0se730916

Chain9 Marking
7-125 7.3 BSD
7-126 7.3 BSD
Chain9 Marking
A B C D E F G H J
9.17 TONER DISPENSE CONTROL (C,K) ELECTRICAL COMPONENTS & DRIVE TRANSMISSION

DC330 79mm/s
093-011
1 DC330 121mm/s
093-012
DC330 175mm/s
093-013
DC330 200mm/s
093-014
MOTOR DRIVER MAIN PWB MOTOR DRIVER SUB PWB DC330 093-015
PL18.2 PL18.2 225mm/s TONER
INTLK DC330 093-037
255mm/s
F3 +24VDC DISPENSE
(1.12 H4) DC330 093-038
308mm/s MOTOR (C)
MOTOR TONER DISPENSE MOTOR (C) PL5.1
ON P452 J452 J529 ON +24VDC CLOCK A J222
27 A12 1 1 Toner Dispense
BLU
2 DC COM Motor (C)
MOTOR DC COM
CLOCK
28 CLOCK /A
A11 2
BLU
DC COM DC COM MOT

CLOCK B
A9 4
BLU
DC COM
3
CLOCK /B
A10 3
BLU
DC COM DC330 093-01679mm/s
DC330 093-017121mm/s
DC330 093-018175mm/s Toner Dispense
DC330 093-019200mm/s Motor (K)
DC330 093-020225mm/s TONER
INTLK
F3 +24VDC DC330 093-021255mm/s DISPENSE
(1.12 H4) DC330 093-039308mm/s MOTOR (K)
4 PL5.1
MOTOR TONER DISPENSE MOTOR (K)
ON ON +24VDC CLOCK A J223
22 B4 1 1
GRY
DC COM
MOTOR DC COM
CLOCK
23 CLOCK /A
B3 2
GRY
DC COM DC COM MOT

5 CLOCK B
B1 4
GRY
DC COM

CLOCK /B
B2 3
GRY
DC COM

6
NOTE:
1 Toner Dispense Motor (C/K) winding resistance is 5.3Ω±10%.
j0se730917
A B C D E F G H J
9.18 TONER CARTRIDGE COOLING (4475/5575/6675/7775) FAIL CODE
2 DC330 042-025 042-340
MOTOR DRIVER MAIN Cartridge Fan Fail
1 PWB
PL18.2
INTLK
+24V F10 MOTOR DRIVER MAIN
(1.12 E3) CARTRIDGE PWB
S DC330 042-021 FAN PL18.2
G PL4.2
CARTRIDGE FAN
D J416 ON(H) +24VDC J619 P619 DC330 042-209 +3.3VDC
DC COM 3 4 5 CARTRIDGE FAN
1 P619 J619 FAIL(H) +3.3VDC J416
MOT 7 2 4 042-340
2 DC COM 1
5 1 8
1
DC COM
(1.4 D4)

ELECTRICAL COMPONENTS NOTE:


1 Wire Color varies depending on the model.
6675/7775 : VIO
3
4475/5575 : WHT

2 DC330[042-025] performs a fault detection after


rotating the target fans concurrently for 5 seconds.
If any fan is found to be faulty, a fail code is issued.
Fail codes can be referred to via DC125.
Check the following NVM settings in advance.
(1) NVM741-072: Fan Fail Bypass should be "0".
If you want to prevent any particular fan from raising a fail,
4 change this value to the fail bypass number for that fan.
(2) NVM741-146: LH FAN CONDITION FLAG should be 1 or 2".
If you want to prevent an LH Fan Fail from being raised,
change this value to "0".

The following fans are targeted:


・010-398: Fusing Unit Fan
・042-336: Process 2 Fan
・043-322: LVPS FAN
・042-332: IH Intake Fan
・042-330: IH Exhaust Fan
Cartridge Fan ・042-609: LH Fan 1/2/3 (When NVM742-146 is set to "1 or 2")
5 ・042-342: Suction Fan (4475/5575/6675/7775)
・042-340: Cartridge Fan (4475/5575/6675/7775)
・042-335: Process 1 Fan (4475/5575/6675/7775)
・042-344: C Exhaust Fan (4475/5575/6675/7775)
・042-343: Rear Bottom Fan (4475/5575/6675/7775)
・042-341: HV Fan (4475/5575/6675/7775)
・043-321: RH Fan (4475/5575/6675/7775)
・042-341: Marking Fan (2275/3373/3375)

j0se730918

Chain9 Marking
7-127 7.3 BSD
7-128 7.3 BSD
Chain9 Marking
A B C D E F G H J
9.19 IBT BELT DRIVE CONTROL FAIL CODE
042-324
1 DC330 094-005 TO 094-011/014 IBT DRIVE MOTOR MOTOR DRIVER MAIN IBT Motor Fail
1 MOTOR PL3.4 PWB
DRIVER MAIN 2 DC330 091-014 TO 091-019/046
PL18.2
PWB
PL18.2 3 DC330 091-020 TO 091-025/047 +3.3VDC
+5VDC
IBT DRIVE MOTOR IBT DRIVE MOTOR ELECTRICAL COMPONENTS & DRIVE TRANSMISSION
J527 ON(L) +5VDC J249 J249 FAIL(H) +3.3VDC J527
B3 GRY 6 8 GRY
B1 042-324
+5VDC IBT Drive Motor
DC COM
CLOCK
B2 GRY 7
+5VDC
DC COM
2 BRAKE(L) +5VDC
B4 GRY 5
+5VDC
DC COM
GAIN(L) +5VDC
B6 GRY 3
+5VDC
DC COM
CW/CCW(L) +5VDC
B5 GRY 4
DC COM
+5VDC
B8 GRY 1
3
+5VDC
(1.6 D2)
DC COM
B7 GRY 2
DC COM
(1.4 D4)
J526 INTLK +24VDC J248
5 ORN 1
INTLK
+24V F15
(1.12 E5) DC COM
4 6 VIO
2
DC COM
(1.4 D4)

NOTE:
1 The operation varies depending on the diag code. 2 The diag codes below drive Drum Drive Motor (Y,M,C), 3 The diag codes below drive Drum/Deve Drive Motor (K) and
Drum/Deve Drive Motor (K) and IBT Drive Motor simultaneously. IBT Drive Motor simultaneously.
DC330 Process Speed
DC330 Process Speed DC330 Process Speed
5 094-005 79mm/sec
091-014 79mm/sec 091-020 79mm/sec
094-006 121mm/sec
091-015 121mm/sec 091-021 121mm/sec
094-007 175mm/sec
091-016 175mm/sec 091-022 175mm/sec
094-008 200mm/sec
091-017 200mm/sec 091-023 200mm/sec
094-009 225mm/sec
091-018 225mm/sec 091-024 255mm/sec
094-010 255mm/sec
091-019 Reverse 091-025 Reverse
094-011 Reverse
091-046 308mm/sec 091-047 308mm/sec
6 094-014 308mm/sec

j0se730919
A B C D E F G H J
ELECTRICAL COMPONENTS
9.20 1ST TRANSFER
MOTOR DRIVER
1 MAIN PWB HVPS (1ST/2ND BTR) (1/3)
PL18.2 PL6.2 HVPS (1st/2nd BTR)

J417 1BTR Y PWM J461 1ST BTR VOLTAGE Y


A8 8
BLU

1BTR M PWM 1ST BTR VOLTAGE M


A7 BLU
9

1BTR C PWM 1ST BTR VOLTAGE C


A6 BLU
10
2
1BTR K PWM 1ST BTR VOLTAGE K
A5 BLU
11

INTLK +24VDC
A15 BLU 1
INTLK
+24V F11
(1.12 E4)
SIGNAL GND
A13 BLU 3
3
DC COM CAUTION HIGH
A14 BLU 2 VOLTAGE
DC COM 1st BTR (Y)
(1.4 D4)

1st BTR (M)

1st BTR (C)


4 1st BTR (K)

j0se730920

Chain9 Marking
7-129 7.3 BSD
7-130 7.3 BSD
Chain9 Marking
A B C D E F G H J
9.21 1ST BTR CONTACT RETRACT CONTROL NOTE: FAIL CODE
1 The table shows the relation between diag code and operation. 094-320
1st BTR
1 1ST BTR CONTACT Operation Contact/Retract Fail
MOTOR DRIVER 1ST BTR RETRACT
MAIN PWB CONT/RET
PL18.2
DC330 094-012 Contact CLUTCH The Contact operation of 1st BTR.
1
DC330 094-013 Retract PL3.2 Turns ON Fusing Unit Drive Motor at a
1ST BTR CONT/RET CLUTCH speed of 121mm/s to turn ON 1st BTR
J414 ON (L) +24VDC J250 P250 2
1 DC330[094-012] Contact Retract Clutch.
B15 GRY 2
Detects the Contact position with 1st
DC COM BTR Contact Retract Sensor and then
B14 2 1 stops Fusing Unit Drive Motor.
GRY
2 +24VDC F5 The Retract operation of 1st BTR.
(1.8 D3) Turns ON Fusing Unit Drive Motor at a
speed of 121mm/s to turn ON 1st BTR
3 DC330[094-013] Contact Retract Clutch.
1ST BTR CONT/RET MOTOR DRIVER MAIN Detects the Retract position with 1st
SENSOR PWB BTR Contact Retract Sensor and then
DC PL3.2 PL18.2
J412 COM J144 DC330 094-200 stops Fusing Unit Drive Motor.
A1 3 1ST BTR CONT/RET +5VDC
BLU
DC COM SENSOR CONTACT 2 The coil resistance of 1st BTR Cont/Ret Clutch is 240Ω±10% (20℃)
(1.4 D4) J144 SENSED(H) +5VDC J412
3 +5VDC 2 BLU
A2 094-320 3 The following shows the actuator position with the 1st BTR
A3 BLU
1 contacted/retracted.
+5VDC
(1.6 D2) Contact Retract

ELECTRICAL COMPONENTS & DRIVE TRANSMISSION


1ST BTR
Cont/Ret Clutch
4

1ST BTR
Cont/Ret Sensor
5

j0se730921
A B C D E F G H J
9.22 ADC PATCH AND ENVIRONMENT SENSING ELECTRICAL COMPONENTS FAIL CODE
042-604
MOB ADC SENSOR ASSEMBLY Temp And Humidity NOHAD Temperature
1 PL18.5 Sensor Sensor Fail
MOTOR DRIVER NOHAD STS 092-649
MAIN PWB ADC SENSOR
PL18.2 DC330 092-001 (SPECULAR) ADC Shutter Open
Fail
ADC SENSOR LED2
J415 ON (L)+5VDC P610 J610 J153 092-650
B9 A7 A9 4
GRY ADC Shutter Close
DC COM LED2 Fail
DC330 092-002 (DIFFUSE) (SPEC) ADC Sensor/ 092-651
ADC SENSOR LED1 ADC Solenoid
2 ON (L)+5VDC ADC Sensor Fail
B10 GRY A6 A10 3
092-661
DC COM LED1 MOTOR DRIVER MAIN
PWB Temperature Sensor
+5VDC
(DIFF) DC140 092-200 PL18.2 Fail
B12 GRY A4 A12 1 ADC SENSOR
AMP J153 J610 P610 SENSED SIGNAL J415 092-670 092-662
+5VDC 2 A11 A5 B11
(1.6 D2) GRY Humidity Sensor Fail
DC COM
B8 GRY
A8 A8 5 092-671
DC COM 092-670
DC COM 1 DC330 092-003 092-672
(1.4 D4) ADC Patch Fail Y
3 ADC SENSOR OPEN SOLENOID ADC SENSOR OPEN SOLENOID
OPEN (L)+24VDC 092-673 092-671
B5 GRY
A11 A5 8
ADC Patch Fail M
DC COM
092-675
092-672
+24VDC 092-676
B6 A10 A6 7 ADC Patch Fail C
GRY
+24VDC F6
DC330 092-004 092-677 092-673
(1.8 D3) ADC SENSOR OPEN SOLENOID
CLOSED (L)+24VDC 092-678 ADC Patch Fail K
B7 GRY
A9 A7 6
092-649 092-675
4 DC COM
ADC Mini Setup Fail Y
092-650
TEMP AND HUMIDITY 092-676
SENSOR AVREF
DC140 092-201 +3.3VDC 092-651 ADC Mini Setup Fail M
TEMP. AND HUMI. SNR
+5VDC J154 J154 TEMP. SIGNAL 092-677
B4 GRY
A12 A4 1 Temp. 4 A1 A15 GRY
B1 092-661
ADC Mini Setup Fail C
DC140 092-202
+5VDC
(1.6 D2) TEMP. AND HUMI. SNR 092-678
DC COM HUMIDITY SIGNAL ADC Mini Setup Fail K
B2 GRY
A14 A2 3 Humidity 2 A3 A13 GRY
B3 092-662
5
DC COM
(1.4 D4) DC COM

NOHAD STS AVREF


PL4.2 DC140 042-200 +3.3VDC
NOHAD STS
J417 J130 J195 J195 J130 TEMP. SIGNAL J417
B2 GRY
1 2 1 2 GRY
B1 042-604

DC COM
(1.4 D4)
6
NOTE:
1 After performing this diag, make sure to perform DC330[092-004] to close the shutter.
Unless the shutter is closed, the sensor within it may become contaminated.
(Note that the shutter automatically closes when you perform printing.) j0se730922

Chain9 Marking
7-131 7.3 BSD
7-132 7.3 BSD
Chain9 Marking
A B C D E F G H J
9.23 2ND TRANSFER FAIL CODE
HVPS (1ST/2ND BTR) (2/3) 077-110
PL6.2
MOTOR DRIVER MAIN POB Sensor On Jam
1 PWB
PL18.2 DC330 094-001 (-) CAUTION HIGH 077-903
VOLTAGE
DC330 094-002 (+) POB Sensor Static
J417 2ND BTR PWM J461 2ND BTR VOLTAGE Jam
A2 BLU 14

9.25 CLN BIAS


PWM

2
Iout
J417 Monitor J461
BLU
A1 15 BLU

DC COM

2ND BTR Io Mon


3
MOTOR MOTOR DRIVER MAIN
DRIVER MAIN PWB
PWB POB SENSOR PL18.2
PL14.3 DC330 077-102
PL18.2 DC330 094-202 +5VDC
J523 P612 J612 J180
A9 A3 A10 3 POB SENSOR
1
GRY J180 J612 P612 PAPER SENSED(L) +5VDC J523 077-110
DC COM 2 A11 A2 A10
GRY
(1.4 D4) 1 077-903
A11 A1 A12 GRY 1
1
4 +5VDC
(1.6 D2)

NOTE: ELECTRICAL COMPONENTS

1 Wire Color varies depending on the model.


6675/7775 : VIO HVPS (1st/2nd BTR)
2275/3373/3375/4475/5575 : BLU

2nd BTR
j0se730923
A B C D E F G H J
9.24 DRUM CLEANING ELECTRICAL COMPONENTS
DC330 091-042
Erase Lamp (Y)
MOTOR DRIVER Makes Erase Lamp (Y/M/C/K) emit light.
1 MAIN PWB
TD
Erase Lamp (M)
PL18.2 1
DC330 091-038
ERASE LAMP (Y)
ERASE LAMP (Y) PL8.1 Erase Lamp (C)
J411 ON (L)+24VDC J210 P210
A6 1 2
BLU Erase Lamp (K)
DC COM

2
A5 BLU
2 1
+24VDC F6
(1.8 D3) DC330 091-039 ERASE LAMP (M)
TD ERASE LAMP (M) PL8.1
1 ON (L)+24VDC J211 P211
A8 1 2
BLU
DC COM

A7 BLU
2 1
+24VDC F6
(1.8 D3) DC330 091-040 ERASE LAMP (C)
TD ERASE LAMP (C) PL8.1
1 ON (L)+24VDC J212 P212
B6 1 2
GRY
DC COM Erasure
4 Lamp
Drum

B5 GRY
2 1
+24VDC F6 TD When diag is turned ON, +12VDC changes to 0VDC.
(1.8 D3) 1
DC330 091-041 ERASE LAMP (K)
TD ERASE LAMP (K) PL8.1
1 ON (L)+24VDC J213 P213
5 B8 GRY
1 2
DC COM

B7 GRY
2 1
+24VDC F6
(1.8 D3)
6

j0se730924

Chain9 Marking
7-133 7.3 BSD
7-134 7.3 BSD
Chain9 Marking
A B C D E F G H J
9.25 2ND BTR CLEANING
MOTOR DRIVER HVPS (1ST/2ND BTR) (3/3)
1 MAIN PWB PL6.2
PL18.2

J417 CLN BIAS PWM J461 CLN BIAS


A4 BLU 12

9.23
CAUTION HIGH
VOLTAGE

2
ELECTRICAL COMPONENTS

HVPS (1st/2nd BTR)

4
2nd BTR

j0se730925
A B C D E F G H J
FAIL CODE
9.26 WASTE TONER DISPOSAL (1/2)
091-400
MOTOR DRIVER MAIN PWB Waste Toner Bottle
1 PL18.2 Near Full
091-910
WASTE TONER BOTTLE MOTOR DRIVER MAIN
FULL SENSOR PWB Waste Toner Bottle
PL8.2 PL18.2 Not In Position
J412 DC COM J110 DC330 091-201 091-911
A7 3 +5VDC
BLU WASTE TONER BOTTLE Waste Toner Bottle
DC COM FULL SENSOR Full
(1.4 D4) J110 BOTTLE EMPTY (L)+5VDC J412 091-400
+5VDC 2 A8
A9 1 BLU
BLU 091-911
2
+5VDC
(1.6 D2)
WASTE TONER BOTTLE
POSITION SENSOR
PL8.2
DC COM J111 DC330 091-200
A4 3 +5VDC
BLU WASTE TONER BOTTLE
DC COM POSITION SENSOR
(1.4 D4) J111 BOTTLE SET (L)+5VDC
+5VDC 2
BLU
A5 091-910
3 A6 1
BLU
+5VDC
(1.6 D2)

MOTOR DRIVER SUB PWB ELECTRICAL COMPONENTS & DRIVE TRANSMISSION


PL18.2 AGITATOR
+24VDC F1 MOTOR
(1.8 G1) DC330 091-043 PL8.2
AGITATOR MOTOR
J529 ON +24VDC CLOCK A J215 1
4 B8 1
MOTOR GRY
ON P452 J452 DC COM
Agitator Motor
19
CLOCK /A
MOTOR DC COM B7 2
GRY
DIR
20 DC COM MOT

MOTOR DC COM CLOCK B


CLOCK B5 4
21 GRY
5 DC COM
DC COM
CLOCK /B Waste Toner Bottle
B6 3 Position Sensor
GRY
DC COM

NOTE: Agitator Motor winding resistance is 16±1.6Ω. (25℃)


Waste Toner Bottle
1
Full Sensor
6

j0se730926

Chain9 Marking
7-135 7.3 BSD
7-136 7.3 BSD
Chain9 Marking
A B C D E F G H J
9.27 WASTE TONER DISPOSAL (2/2) FAIL CODE
1 DC330 042-025 042-335
MOTOR DRIVER MAIN PWB Process 1 Fan Fail
1 PL18.2 +24VDC F8
(4475/5575/6675/7775)
4475/5575/6675/7775
(1.8 D3) MOTOR DRIVER MAIN 042-336
S DC330 042-022 PROCESS 1 PWB
G FAN PL18.2 Process 2 Fan Fail
PROCESS 1 FAN PL4.1 (6675/7775)
D J537 ON(H) +24VDC J228 P228 DC330 042-210 +3.3VDC
DC COM 4 4 1 PROCESS 1 FAN
WHT
P228 J228 FAIL(H) +3.3VDC J537
MOT 3 2 WHT
5 042-335
DC COM
6 WHT
1 4
2 DC COM
(1.4 D4)

6675/7775
DC330 042-013 PROCESS 2
+24VDC F6
(1.8 D3) FAN
PROCESS 2 FAN PL4.1
HIGH J416 ON(H) +24VDC J238 P238 DC330 042-207 +3.3VDC
6 4 1 PROCESS 2 FAN
VIO
P238 J238 FAIL(H) +3.3VDC J416
DC COM MOT 3 2 8 042-336
VIO
3 9 VIO
1 4
DC COM
(1.4 D4)

NOTE:
ELECTRICAL COMPONENTS 1 DC330[042-025] performs a fault detection after
4 rotating the target fans concurrently for 5 seconds.
If any fan is found to be faulty, a fail code is issued.
Fail codes can be referred to via DC125.
Check the following NVM settings in advance.
Process 2 Fan (1) NVM741-072: Fan Fail Bypass should be "0".
If you want to prevent any particular fan from raising a fail,
Process 1 Fan change this value to the fail bypass number for that fan.
(2) NVM741-146: LH FAN CONDITION FLAG should be 1 or 2".
If you want to prevent an LH Fan Fail from being raised,
change this value to "0".
5 The following fans are targeted:
・010-398: Fusing Unit Fan
・042-336: Process 2 Fan
・043-322: LVPS FAN
・042-332: IH Intake Fan
・042-330: IH Exhaust Fan
・042-609: LH Fan 1/2/3 (When NVM742-146 is set to "1 or 2")
・042-342: Suction Fan (4475/5575/6675/7775)
・042-340: Cartridge Fan (4475/5575/6675/7775)
・042-335: Process 1 Fan (4475/5575/6675/7775)
・042-344: C Exhaust Fan (4475/5575/6675/7775)
6 ・042-343: Rear Bottom Fan (4475/5575/6675/7775)
・042-341: HV Fan (4475/5575/6675/7775)
・043-321: RH Fan (4475/5575/6675/7775)
・042-341: Marking Fan (2275/3373/3375)
j0se730927
A B C D E F G H J
9.28 REAR BOTTOM FAN CONTROL (4475/5575/6675/7775) FAIL CODE
1 DC330 042-025 042-343
Rear Bottom Fan Fail
1 MOTOR DRIVER MAIN
PWB REAR
PL18.2 BOTTOM MOTOR DRIVER MAIN
+24VDC F5 DC330 042-015 FAN PWB
(1.8 D3) PL4.3 PL18.2
REAR BOTTOM FAN
J414 ON(H) +24VDC J234 P234 DC330 042-204 +3.3VDC
B8 GRY 4 1 REAR BOTTOM FAN
P234 J234 FAIL(H) +3.3VDC J414
DC COM MOT 3 2 B9 042-343
GRY
DC COM
B10 GRY 1 4
2 DC COM
(1.4 D4)

NOTE:
ELECTRICAL COMPONENTS
1 DC330[042-025] performs a fault detection after
rotating the target fans concurrently for 5 seconds.
If any fan is found to be faulty, a fail code is issued.
Fail codes can be referred to via DC125.
3
Check the following NVM settings in advance.
(1) NVM741-072: Fan Fail Bypass should be "0".
If you want to prevent any particular fan from raising a fail,
change this value to the fail bypass number for that fan.
(2) NVM741-146: LH FAN CONDITION FLAG should be 1 or 2".
If you want to prevent an LH Fan Fail from being raised,
change this value to "0".
The following fans are targeted:
・010-398: Fusing Unit Fan
4 ・042-336: Process 2 Fan
・043-322: LVPS FAN
・042-332: IH Intake Fan
・042-330: IH Exhaust Fan
・042-609: LH Fan 1/2/3 (When NVM742-146 is set to "1 or 2")
・042-342: Suction Fan (4475/5575/6675/7775)
・042-340: Cartridge Fan (4475/5575/6675/7775)
・042-335: Process 1 Fan (4475/5575/6675/7775)
・042-344: C Exhaust Fan (4475/5575/6675/7775)
・042-343: Rear Bottom Fan (4475/5575/6675/7775)
・042-341: HV Fan (4475/5575/6675/7775)
・043-321: RH Fan (4475/5575/6675/7775)
5 ・042-341: Marking Fan (2275/3373/3375)

Rear Bottom Fan

j0se730928

Chain9 Marking
7-137 7.3 BSD
7-138 7.3 BSD
Chain9 Marking
A B C D E F G H J
FAIL CODE
9.29 LH FAN CONTROL
2275/3373/3375/4475/5575 : Option, 6675/7775 : Standard 042-609
MOTOR DRIVER LH FAN PWB 1 DC330 042-025 LH FAN PWB LH Fan Fail
1 MAIN PWB DC330 042-026 PL14.4 PL14.4
PL18.2 LH FAN +24VDC LH FAN 1 +5VDC
ON (L) PL14.4
J523 +24VDC P635 J635 J450 J453 LH FAN ON (H) +24VDC LH FAN 1 FAIL J453
B14 4 2 4 1 3
GRY GRY GRY GRY
DC COM +24VDC
PWM PWM
B15 3 3 3 2 MOT
GRY GRY GRY
DC COM
DC COM
4
GRY
2
DC COM +5VDC
(9.46 E6) LH FAN 2 LH
PL14.4 FAN 2
J454 J217 P217 P217 J217 FAIL J454
1 5 1 3 3 3
GRY GRY
+24VDC
J450
2 4 2 MOT 2
GRY GRY
DC COM
4 2 4
GRY
3
DC COM +5VDC
(9.46 E6) LH FAN 3 LH
PL14.4 FAN 3
J218 P218 P218 J218 FAIL
5 5 1 3 3 7
GRY GRY
+24VDC
6 4 2
GRY MOT

8 2 4
4 GRY
DC COM
(9.46 E6)
+5VDC
+24VDC +24VDC +5VDC ALL ELECTRICAL COMPONENTS
B13 5 1 5 TO LH Fan 1
GRY GRY +5VDC
INTLK LH Fan 2
+24VDC F13
(1.12 E4) F1 +24VDC
MOTOR DRIVER MAIN LH Fan 3
2.5A ALL PWB
+24VDC PL18.2
5 DC COM DC330 042-216 +3.3VDC
DC COM DC COM
ALL LH FAN
B17 1 5 1 J635 P635 FAIL (H)+3.3VDC J523
GRY GRY 4 2 B16 042-609
GRY GRY
DC COM LH Fan PWB
(1.4 D4)

NOTE: 1 DC330[042-025] performs a fault detection after rotating the target fans concurrently for 5 seconds. If any fan is found to be faulty, a fail code is issued.
Fail codes can be referred to via DC125. Check the following NVM settings in advance.
(1) NVM741-072: Fan Fail Bypass should be "0". If you want to prevent any particular fan from raising a fail, change this value to the fail bypass number for that fan.
6 (2) NVM741-146: LH FAN CONDITION FLAG should be 1 or 2". If you want to prevent an LH Fan Fail from being raised, change this value to "0".
The following fans are targeted:
・010-398: Fusing Unit Fan, 042-336: Process 2 Fan, 043-322: LVPS FAN, 042-332: IH Intake Fan, 042-330: IH Exhaust Fan, 042-609: LH Fan 1/2/3 (When NVM742-146 is set to "1 or 2")
・042-342: Suction Fan (4475/5575/6675/7775), 042-340: Cartridge Fan (4475/5575/6675/7775), 042-335: Process 1 Fan (4475/5575/6675/7775), 042-344: C Exhaust Fan (4475/5575/6675/7775)
・042-343: Rear Bottom Fan (4475/5575/6675/7775), 042-341: HV Fan (4475/5575/6675/7775), 043-321: RH Fan (4475/5575/6675/7775), 042-341: Marking Fan (2275/3373/3375) j0se730929
A B C D E F G H J

9.30 IOT HEATER CONTROL (OPTION) (FX ONLY)


2275/3375/3375
1 IOT HEATER (32W)
PL18.12
1.2 POWER SWITCH OFF ACH
(IOT HEATER) CE3 J70 P70
2
BLK BLK
THERMOSTAT
PL18.12
1.2 POWER SWITCH OFF ACN
(IOT HEATER) J76 J75 CE5
1 1 1
WHT WHT WHT
2

4475/5575/6675/7775
IOT HEATER (63W)
PL18.12

J77 P77
3
BLK
3

1
WHT

j0se730930

Chain9 Marking
7-139 7.3 BSD
7-140 7.3 BSD
Chain 10 Fusing and Paper Transportation
A B C D E F G H J
10.1 FUSING UNIT DRIVE CONTROL (1/2) FAIL CODE
010-330
MOTOR DRIVER Fusing Unit Motor Fail
1 MOTOR FUSING UNIT DRIVE MAIN PWB
DRIVER MAIN MOTOR PL18.2 010-368
PWB PL3.1 Encoder Pulse Fail
PL18.2 1 DC330 010-001 TO 010-008/013 FUSING UNIT +3.3VDC
+5VDC
FUSING UNIT DRIVE MOTOR DRIVE MOTOR 010-378
J525 ON(L) +5VDC J243 J243 FAIL(H) +3.3VDC J525
A3 6 8 A1 010-330 Heat Belt Rotation Fail
+5VDC ELECTRICAL COMPONENTS & DRIVE TRANSMISSION
2 2
DC COM
CLOCK
A2 7 Fusing Unit
+5VDC Fusing Unit
2 Belt Rotation Sensor
DC COM Drive Motor
2 BRAKE
A4 5
+5VDC
2
DC COM
GAIN
A6 3
2
DC COM
+5VDC
A8 1
2
+5VDC
(1.6 D2)
DC COM
3 A7 2
2
DC COM
(1.4 D4)
J535 INTLK +24VDC J242
3 ORN 1
INTLK
+24V F14
(1.12 E5) DC COM
4 VIO
2
MOTOR DRIVER MAIN PWB
DC COM PL18.2
(1.4 D4)
4 DC330 010-203
FUSING UNIT BELT +5VDC
J431 DJ600 DP600 J194 ROTATION SENSOR 010-368
9 B1 B1 1 J194 DP600 DJ600 ACTUATED (H)+5VDC J431
YEL WHT 2 B2 B2 8 010-378
WHT YEL
+5VDC
(1.6 D2)
7 B3 B3 WHT 3 BELT ROTATION 10.4
YEL SNR SIGNAL
DC COM FUSING UNIT BELT
(1.4 D4) ROTATION SENSOR
PL7.1
5

NOTE:
1 The operation varies depending on the diag code. 2 Wire Color varies depending on the model.
DC330 Process Speed DC330 Process Speed 2275/3373/3375/4475/5575 : BLU
6675/7775 : VIO
010-001 255mm/sec 121mm/sec
010-005 (4475/5575)
010-002 225mm/sec
010-006 175mm/sec
010-003 200mm/sec (2275/3373/3375)
6
175mm/sec 121mm/sec
010-004 (4475/5575/6675/7775) 010-007 (2275/3373/3375)
010-008 79mm/sec
010-013 308mm/sec j0se731001
A B C D E F G H J
10.2 FUSING UNIT DRIVE CONTROL (2/2) ELECTRICAL COMPONENTS & DRIVE TRANSMISSION
FAIL CODE
P/R Latch Motor 010-380
MOTOR DRIVER MAIN PWB MOTOR DRIVER SUB PWB P/Roll Latch Motor
1 PL18.2 PL18.2 Fail
+24VDC F1
P/R LATCH
(1.8 G1) 1 DC330 010-009 TO 010-012 MOTOR
PL7.1
P/L LATCH P/R LATCH MOTOR
MOTOR ON P452 J452 J524 ON +24VDC CLOCK A J254
95 13 6 2
BLU
DC COM
DC COM
CLOCK /A
P/L LATCH 15 2
BLU
MOTOR CLOCK
2 96 DC COM MOT
P/R Latch Sensor
DC COM CLOCK B
14 5
BLU
DC COM

CLOCK /B
16 1
BLU
DC COM
3

P/R LATCH SENSOR MOTOR DRIVER MAIN


PL7.1 PWB
J431 DP600 3 DC330 010-202 PL18.2
DJ600 J193
5 B5 B5 2 P/R LATCH SENSOR +3.3VDC
YEL BLU
DC COM LATCH SENSED(H)
(1.4 D4) TD J193 DP600 DJ600 +3.3VDC J431
1 1 BLU B4 B4 YEL
6 010-380
4 YEL
B6 B6 BLU 3
4
+5VDC
(1.6 D2)

NOTE:
1 The operation varies depending on the diag code. TD Test Point: Motor Driver Main PWB J431-4 (+) to GND (-)
1 With sensor connected, approx. +1.19VDC
DC330 Operation
5 010-009 Latch Motor automatically stops at the P/Roll Latch ON position.
010-010 Latch Motor automatically stops at the P/Roll Latch OFF position.
010-011 Latch Motor automatically stops at the P/Roll Half-Latch position.
010-012 Latch Motor automatically stops at the P/Roll Latch ON position.
(Envelope)

2 The winding resistance of P/R Latch Motor is 5.7Ω±10%

3 H : P/Roll Latch On Position


6 L : P/Roll Latch Off Position

j0se731002

Chain 10 Fusing and Paper Transportation


7-141 7.3 BSD
7-142 7.3 BSD
Chain 10 Fusing and Paper Transportation
A B C D E F G H J
10.3 FUSING UNIT HEAT CONTROL (1/3) FAIL CODE
MOTOR DRIVER MAIN PWB
PL18.2 AVREF
010-371
+3.3VDC Heat Belt STS Center
(1.5 E2) Disconnection Fail
1 STS
CHK 010-377 010-372
MOTOR DRIVER MAIN FUSING UNIT ASSY
PWB PL7.1 010-376 Heat Roll STS Center
1 DC140 010-201 Over Temperature Fail
PL18.2 REAR STS
REAR STS 010-373
J431 DJ600 DP600 P195 J195 J195 P195 DP600 DJ600 SENSED SIGNAL J431 010-373
16 YEL A4 A4 BLU 1 4 3 2 BLU A5 A5 15
T° YEL 010-374 Heat Belt STS Rear
DC COM 1 Disconnection Fail
(1.4 D4) DC140 010-200
CENTER STS
CENTER STS 010-379 010-374
SENSED SIGNAL Heat Belt STS Rear
2 14 YEL A6 A6 BLU 3 2 1 4 BLU A7 A7 YEL
13 010-371
T° Over Temperature Fail
DC COM 010-372
(1.4 D4) 2 FUSING UNIT 010-375
RELAY ON(H) 1.1
+24VDC F6 3 DC330 010-201 +24VDC 010-375 Heat Belt STS Center
(1.8 D3) +3.3VDC Warm Up Time Fail
THERMO- THERMOSTAT STATUS/
S STAT FUSING UNIT RELAY 010-376
G D P197 J197 J197 P197 ON(H) +24VDC STATUS
FET 17 YEL A3 A3 2 1 2 1 BLU A1 A1 18 010-382 Heat Belt STS Rear
BLU YEL Warm Up Time Fail
010-377
3 FUSE
FUSING UNIT CUT Fusing Unit On Time
DETECT Fail
RESISTANCE
FUSE DC COM 010-379
J567 J567 STATUS (NOT USED) STATUS
1 B9 B9 1 N.C 2 B8 B8 2 Fusing Unit Hot Not
YEL BLU BLU YEL Ready Return Time
+3.3VDC FUSING UNIT Fail
(1.6 D2) DETECT(H) +3.3VDC DC COM
3 BLU
B7 B7 YEL
3 010-381 010-381
TD Fusing Unit Assy
1 DC COM Illegal Fail
4
010-382
Fusing Unit
NOTE: ELECTRICAL COMPONENTS Thermostat Fail
1 DC140[010-200,201] displays AD Value from H/R STS.
Normally, the value is in the following output range:
・Normal output range : 1018(low temperature end) -120(high temperature end) Fusing Unit
Detect Resistance
2 Displays the current status of Thermostat.
H : Thermostat OFF
L : Thermostat ON
5
Actual voltage level is opposite to H/L displayed on UI for this
3 diag code. On BSD the actual volt level is shown.

TD Test Point: Motor Driver Main PWB J431-3 (+) to GND (-) Rear STS
1 With sensor connected, approx. +1.65VDC

Center STS
6
Thermostat

j0se731003
A B C D E F G H J
10.4 FUSING UNIT HEAT CONTROL (2/3) FAIL CODE
MOTOR DRIVER MAIN MCU-PF 010-360
PWB PWB
MCU-PF MOTOR DRIVER MAIN PWB IH DRIVER PWB PL18.2 PL18.2 IH Driver Input High
1 PWB PL18.2 +3.3VDC PL18.3 Voltage Fail
PL18.2
010-361
J1 P1 J412 TXD J530 J530 RXD J412 P1 J1
111 B3 7 6 B4 51 IH Driver Input Low
1 1 Voltage Fail
10.1 BELT ROTATION ENCODER
SNR SIGNAL SIGNAL IH FREEZE SIGNAL 010-362
B8 2 5 B5 010-360 IH Driver Surge Fail
1 1
+3.3VDC SAFETY GND 010-361 010-363
B9 1 4 B6
IGBT Temperature
1 1 010-362 High Fail
2 +3.3VDC +3.3VDC DC COM
(1.6 D2) DC COM
010-363 010-364
1.12 FRONT
INTLK ON IGBT Temperature
010-364 Sensor Disconnection,
IH IH SAFETY Abnormal Action,
010-367 Short Fail
FREEZE SIGNAL
B7 3 010-369 010-367
IH 1 Input Low Current Fail
ENABLE 010-370
010-369
3 041-316 IH Driver
Communication Fail
041-317
6675/7775 010-370
AC POWER IH Driver Freeze Fail
SUPPLY H2
PL18.3 041-316
1.1 POWER ON ACH IH Heating Coil
(FUSING UNIT) J8 J9 J30 J60 P634 J634 IH Driver Interface Fail
1 3 BLK 3 1 1
BLK BLK BLK 041-317
1.1 POWER ON ACH
4 (FUSING UNIT) J61 MCU IH Interface Fail
3 1 WHT 1 1 2
WHT WHT BLK

NOTE:
1 Wire Color varies depending on the model.
5 2275/3373/3375/4475/5575 : GRY
6675/7775 : VIO

j0se731004

Chain 10 Fusing and Paper Transportation


7-143 7.3 BSD
7-144 7.3 BSD
Chain 10 Fusing and Paper Transportation
A B C D E F G H J
10.5 FUSING UNIT HEAT CONTROL (3/3) FAIL CODE
042-330
1 DC330 042-025
MOTOR DRIVER MAIN MOTOR DRIVER SUB PWB IH Exhaust Fan Fail
1 PWB PL18.2 (6675/7775)
PL18.2 +24VDC F1 DC330 042-016 IH INTAKE
(1.8 G1) FAN MOTOR MOTOR DRIVER MAIN 042-332
IH INTAKE PL4.3 DRIVER SUB PWB
S FAN ON(H) PWB PL18.2 IH Intake Fan Fail
HIGH P452 J452 J529 +24VDC J226 P226
26 G
FET D A13 BLU 4 1 PL18.2
DC330 042-214
DC COM +24VDC F1 IH INTAKE +3.3VDC
LOW FAN FAIL (H)
25 P226 J226 +3.3VDC J529 J452 P452
MOT 3 2 BLU
A14 24 042-332
DC COM
2

DC COM
A15 BLU 1 4
DC COM
(1.4 H6)

6675/7775
PL IH EXHAUST
+24VDC F6 DC330 042-017 FAN
3 (1.8 D3)
IH EXHAUST FAN PL4.3
J412 ON(H) +24VDC J225 P225 DC330 042-215 +3.3VDC
B10 VIO 5 1 IH EXHAUST FAN
P225 J225 FAIL (H) +3.3VDC J412
DC COM MOT 3 3 B12 042-330
VIO
DC COM
B13 VIO 2 4
DC COM
(1.4 D4)

4
ELECTRICAL COMPONENTS NOTE: 1 DC330[042-025] performs a fault detection after rotating the target fans concurrently for 5 seconds.
If any fan is found to be faulty, a fail code is issued. Fail codes can be referred to via DC125.

<6675/7775> <2275/3373/3375/4475/5575> Check the following NVM settings in advance.


(1) NVM741-072: Fan Fail Bypass should be "0".
IH Intake Fan If you want to prevent any particular fan from raising a fail,
IH Driver PWB change this value to the fail bypass number for that fan.
(2) NVM741-146: LH FAN CONDITION FLAG should be 1 or 2".
IH Exhaust Fan If you want to prevent an LH Fan Fail from being raised,
5 change this value to "0".
IH Intake Fan
The following fans are targeted:
・010-398: Fusing Unit Fan
・042-336: Process 2 Fan
・043-322: LVPS FAN
・042-332: IH Intake Fan
・042-330: IH Exhaust Fan
・042-609: LH Fan 1/2/3 (When NVM742-146 is set to "1 or 2")
・042-342: Suction Fan (4475/5575/6675/7775)
・042-340: Cartridge Fan (4475/5575/6675/7775)
6 ・042-335: Process 1 Fan (4475/5575/6675/7775)
Sub Low Voltage Power Supply IH Driver PWB ・042-344: C Exhaust Fan (4475/5575/6675/7775)
・042-343: Rear Bottom Fan (4475/5575/6675/7775)
・042-341: HV Fan (4475/5575/6675/7775)
・043-321: RH Fan (4475/5575/6675/7775)
・042-341: Marking Fan (2275/3373/3375) j0se731005
A B C D E F G H J
10.6 FUSING FAIL CODE
010-398
MOTOR DRIVER MAIN PWB MOTOR DRIVER SUB PWB Fusing Unit Fan Fail
1 PL18.2 PL18.2
+24VDC F1 FUSING 1 DC330 042-025 MOTOR MOTOR DRIVER MAIN 010-420
(1.8 G1) DC330 042-011 UNIT FAN DRIVER PWB
PL4.3 SUB PWB PL18.2 Fusing Unit Assembly
FUSING UNIT S FUSING UNIT FAN Near Life Warning
P452 J452 J524 ON(H) +24VDC J230 P230 PL18.2
FAN ON G D
99 FET 10 BLU 4 1 DC330 042-202 +3.3VDC 010-421
DC COM FUSING UNIT FAN Fusing Unit Assembly
P230 J230 FAIL (H) +3.3VDC J524 J452 P452 Life Over Warning
MOT 3 2 BLU
11 97 010-398
077-103
DC COM Fusing Unit Exit Sensor
12 BLU 1 4 010-420 Off Jam
2
DC COM 010-421 077-104
(1.4 H6)
Fusing Unit Exit Sensor
077-103 Off Jam (Too Short)
FUSING UNIT EXIT 077-104 077-106
SENSOR PL7.1
Fusing Unit Exit Sensor
J431 DJ600 DP600 J192 077-106 On Jam
11 YEL A9 A9 BLU
2 DC330 077-101 +3.3VDC
077-901 077-901
DC COM FUSING UNIT EXIT SENSOR
3 (1.4 D4) TD J192 DP600 DJ600 PAPER SENSED(L) +3.3VDC J431 Fusing Unit Exit Sensor
1 1 A8 A8 12 094-417 Static Jam
10 YEL A10 A10 BLU 3 BLU YEL
094-418 094-417
+5VDC
(1.6 D2) IBT Unit Near End
094-419 Warning
094-420 094-418
ELECTRICAL COMPONENTS IBT Cleaner Unit Near
NOTE: 094-421 End Warning
1 DC330[042-025] performs a fault detection after Fusing Unit Fan 094-422 094-419
4 rotating the target fans concurrently for 5 seconds.
If any fan is found to be faulty, a fail code is issued. 2nd BTR Unit Near
099-373 End Warning
Fail codes can be referred to via DC125.
094-420
Check the following NVM settings in advance. Fusing Unit
(1) NVM741-072: Fan Fail Bypass should be "0". IBT Unit End Warning
If you want to prevent any particular fan from raising a fail, Exit Sensor 3.8
change this value to the fail bypass number for that fan. 094-421
(2) NVM741-146: LH FAN CONDITION FLAG should be 1 or 2". IBT Cleaner Unit End
If you want to prevent an LH Fan Fail from being raised, Warning
change this value to "0".
094-422
5 The following fans are targeted: 2nd BTR Unit End
・010-398: Fusing Unit Fan Warning
・042-336: Process 2 Fan
・043-322: LVPS FAN 099-373
・042-332: IH Intake Fan Wind around P/Roll Fail
・042-330: IH Exhaust Fan
・042-609: LH Fan 1/2/3 (When NVM742-146 is set to "1 or 2")
・042-342: Suction Fan (4475/5575/6675/7775)
・042-340: Cartridge Fan (4475/5575/6675/7775) TD Test Point: Motor Driver Main PWB J431-16 (+) to GND (-)
・042-335: Process 1 Fan (4475/5575/6675/7775) 1 With sensor connected, approx. +1.19VDC
・042-344: C Exhaust Fan (4475/5575/6675/7775)
6 ・042-343: Rear Bottom Fan (4475/5575/6675/7775)
・042-341: HV Fan (4475/5575/6675/7775)
・043-321: RH Fan (4475/5575/6675/7775)
・042-341: Marking Fan (2275/3373/3375)
j0se731006

Chain 10 Fusing and Paper Transportation


7-145 7.3 BSD
7-146 7.3 BSD
Chain 10 Fusing and Paper Transportation
A B C D E F G H J
10.7 PAPER EXIT 1 ELECTRICAL COMPONENTS & DRIVE TRANSMISSION FAIL CODE
DC330 077-040 (CW, 1-2 phase excitation) Exit 1 OCT Motor Exit 1 Full Stack Sensor 047-211
DC330 077-041 (CCW, 1-2 phase excitation)
MOTOR DRIVER MOTOR DRIVER SUB PWB Exit 1 OCT Home Fail
MAIN PWB PL18.2 DC330 077-042 (CW, 2 phase excitation) EXIT 1 OCT
1
PL18.2 DC330 077-043 (CCW, 2 phase excitation) MOTOR
EXIT 1 OCT MOTOR PL17.2
A P452 J452 J524 ON +24V CLOCK A J271
49 1 BLU 6 Left t
Fron
DC COM 1
/A CLOCK /A Exit 1 OCT
47 5 BLU 2
Home Sensor
DC COM
B CLOCK B
48 2 BLU 5
2 MOT
/B
DC COM
CLOCK /B
Exit Gate Solenoid
46 6 BLU 1
Exit 1 Full Stack Sensor
DC COM
+24VDC
3 BLU 4 Exit 2 Gate Fusing Unit
+24VDC
Drive Motor (CH10.1)
INTLK F2 4 BLU 3
+24VDC
(1.12 H3)
3 EXIT GATE
DC330 077-003 5 SOLENOID
EXIT GATE SOLENOID PL17.5
ON J522 ON (L) +24VDC P631 J631 P262 J262 2
41 A8 BLU A8 A8 1 2
BLU

MOTOR MOTOR DRIVER MAIN


A7 BLU A9 A7 2 1 DRIVER SUB PWB
BLU PWB PL18.2
INTLK F2 PL18.2
+24VDC DC330 077-109
4 (1.12 H3)
TD EXIT 1 OCT HOME +3.3VDC
J524 1 +5VDC J162 POSITION SENSOR
7 BLU 3 J162 BLOCKED (L) +3.3VDC J524 J452 P452
1 BLU
9 100 047-211
+5VDC
(1.6 F4)
DC COM
8 BLU 2
DC COM EXIT 1 OCT HOME
(1.4 H6) POSITION SENSOR
EXIT 1 FULL STACK PL17.1
SENSOR
5 PL17.2
J522 J640 P640 J163
B14 2 2 2 DC330 077-124 +3.3VDC
3 4 EXIT 1 FULL STACK SENSOR
DC COM
(1.4 H6) J163 P640 J640 FULL SENSED(L) +3.3VDC J522
1 3 1 B15 86
B13 3 1 3 4 3
3 4
+5VDC
(1.6 F4)

6 NOTE: 3 Wire Color varies depending on the model. 4 Wire Color varies depending on the model. TD Test Point: MOTOR DRIVER MAIN PWB J524-7 (+) to GND (-)
1 The Exit 1 OCT Motor winding resistance is 1 With sensor connected, approx. +1.22VDC
2275/3373/3375 : GRY 2275/3373/3375 : GRY
100Ω±10%. 4475/5575 : WHT 4475/5575/6675/7775 : BLU
2 The coil resistance of the Exit Gate Solenoid is 6675/7775 : VIO Off : Exit 1 on the exit side
60Ω±10%. (Coil Tem. 20 ℃) 5
On : Exit 2 on the unit side j0se731007
A B C D E F G H J
10.8 DUPLEX TRANSPORTATION FAIL CODE
077-131
MOTOR DRIVER Duplex Path Sensor
1 MAIN PWB INTLK On Jam
+24V F13
PL18.2 DC HEATER
(1.2 E4) 077-907
PL14.5a/14.5b
S DC HEATER Duplex Path Sensor
G D J523 ON(H) +24VDC P612 J612 P170 J170 Static Jam
FET B11 GRY B2 B11 1
ORN
DC COM ELECTRICAL COMPONENTS & DRIVE TRANSMISSION

B12 GRY B1 B12 2


VIO
2 DC COM Duplex
(1.4 D4)
2275/3373/3375 4475/5575/6675/7775 Path Sensor

INTLK DC330 077-071 DUPLEX DUPLEX


+24V F11 2 MOTOR MOTOR
(1.12 E4) DC330 077-073 PL14.6 PL14.6

イラスト
DUPLEX MOTOR
ON +24VDC CLOCK A J275 J275 <2275/3373/3375>
B7 GRY B6 B7 6 3 4 3
1 Duplex Motor
DC COM
3
CLOCK /A
B9 GRY B4 B9 2 6 <4475/5575>
1 Duplex Motor DC Heater
DC COM MOT MOT

CLOCK B
B8 GRY B5 B8 5 3
1
DC COM

CLOCK /B
4 B10 GRY B3 B10 1 1
1
DC COM

DUPLEX PATH MOTOR DRIVER MAIN


SENSOR PWB
P624 J175 PL14.6 PL18.2
DC COM J624
B5 GRY B8 B5 2 2 2 +3.3VDC
BLU DC330 077-108
5 1 DUPLEX PATH SENSOR
DC COM TD
(1.4 D4) J175 P624 J624 J612 P612 PAPER SENSED (L)+3.3VDC J523 077-131
1 1 3 1 B6 B7 B6
+5VDC BLU GRY
B4 GRY B9 B4 3 1 3 1 077-907
BLU
1
+5VDC
(1.6 D2)

NOTE:
1 Wire Color varies depending on the model. 2 The operation varies depending on the diag code. 3 2275/3373/3375:The Duplex Motor winding resistance is 5.7Ω±10%
2275/3373/3375 : GRY 4475/5575/6675/7775:The Duplex Motor winding resistance is 1.5±15%Ω(25℃)
6 DUPLEX MOTOR Operation
4475/5575 : WHT
DC330[077-071] Rotates the Motor reverse.
6675/7775 : VIO (in the Pull-in Duplex direction. 1-2-phase excitation) TD Test Point: Motor Driver Main PWB J523-B5 (+) to GND (-)
1 With sensor connected, approx. +1.21VDC
Rotates the Motor reverse.
DC330[077-073] (in the Pull-in Duplex direction. 2-phase excitation) j0se731008

Chain 10 Fusing and Paper Transportation


7-147 7.3 BSD
7-148 7.3 BSD
Chain 10 Fusing and Paper Transportation
A B C D E F G H J
10.9 PAPER EXIT 2 (1/2) ELECTRICAL COMPONENTS & DRIVE TRANSMISSION FAIL CODE
DC330 077-045 (CW, 1-2 phase excitation) Exit 2 OCT Motor 047-212
DC330 077-046 (CCW, 1-2 phase excitation)
Exit 2 OCT Home Fail
MOTOR DRIVER MOTOR DRIVER SUB PWB
1 MAIN PWB PL18.2 DC330 077-047 (CW, 2 phase excitation) EXIT 2 OCT
PL18.2 DC330 077-048 (CCW, 2 phase excitation) MOTOR
EXIT 2 OCT MOTOR PL17.5
A P452 J452 J522 ON +24V CLOCK A P631 J631 J266
45 A1 BLU A15 A1 6
BLU
DC COM 1
/A CLOCK /A
43 A5 BLU A11 A5 BLU
2
DC COM
B CLOCK B
44 A2 BLU A14 A2 BLU
5
2 MOT
DC COM
/B CLOCK /B
42 A6 BLU A10 A6 BLU
1
DC COM
INTLK +24VDC
A3 BLU A13 A3 BLU
4
Exit 2 OCT
INTLK +24VDC Home Position Sensor
INTLK F2 A4 BLU A12 A4 3
+24VDC BLU
(1.12 H3)
3
MOTOR MOTOR DRIVER MAIN
DRIVER SUB PWB
PWB PL18.2
PL18.2
TD
DC330 077-110 +3.3VDC
1 +5VDC J165 EXIT 2 OCT HP SENSOR
A11 BLU A5 A11 3 J165 J631 P631 BLOCKED (L) +3.3VDC J522 J452 P452
BLU 1 BLU A13 A3 A13 39 047-212
BLU
+5VDC
(1.6 F4)
4 DC COM
A12 BLU A4 A12 BLU
2
DC COM EXIT 2 OCT HOME
(1.4 H6) POSITION SENSOR
PL17.4

NOTE:
1 The Exit 2 OCT Motor winding resistance is 100Ω±10% TD Test Point: Motor Driver Main PWB J522-A11 (+) to GND (-)
1 With sensor connected, approx. +1.23VDC
5

j0se731009
A B C D E F G H J
10.10 PAPER EXIT 2 (2/2) FAIL CODE
077-105
DC330 077-060 (CW, 1-2 phase excitation)
MOTOR DRIVER MAIN MOTOR DRIVER SUB PWB DC330 077-061 (CCW, 1-2 phase excitation) 4475/5575/6675/7775 Exit Sensor 2 Off Jam
1 PWB PL18.2
PL18.2 INTLK F3
DC330 077-062 (CW, 2 phase excitation) 077-109
+24VDC DC330 077-063 (CCW, 2 phase excitation)EXIT 2 DRIVE EXIT 2 DRIVE
(1.12 H4) MOTOR MOTOR Exit Sensor 2 On Jam
EXIT 2 DRIVE PL17.4 PL17.4
MOT MOTOR ON +24VDC 2275/3373/3375 077-902
ON P452 J452 J522 CLOCK A P631 J631 J265 P631 J631 J265
90 B4 B12 B4 GRY 6 2 B12 B4 4 2 Exit Sensor 2 Static
1 5 Jam
DC COM
DC COM

CURRENT CLOCK /A 6 The Pin No. depending on the model.


89 B6 B10 B6 GRY 2 6 6 6
2 1 5 <4475/5575> <6675/7775 >
DC COM MOT MOT
B8 B8 B9 B7
CLOCK
93 CLOCK B
B5 B11 B5 GRY 5 6 6 3
DC COM 1 5
DC COM
B11 B5 B10 B6
DIR
92 CLOCK /B
B7 B9 B7 GRY 1 B7 B9 1
DC COM 1 5
DC COM
3
MODE 0
91
MOTOR MOTOR DRIVER MAIN
EXIT 2 SENSOR DRIVER SUB PWB
DC COM PL17.4 PWB PL18.2
J164 DC330 077-100 PL18.2
DC COM
B9 B5 B11 2 +3.3VDC
EXIT 2 SENSOR
DC COM
1 1 PAPER SENSED 077-105
(1.4 H6)
TD J164 J631 P631 (L)+3.3VDC J522 J452 P452
1 1 B12 B4 B10 88 077-109
+5VDC
B8 B6 B10 3 1 1
4 1 1 077-902
+5VDC
(1.6 F4)
OPTION
FACE UP
DC330 077-004 4 GATE ELECTRICAL COMPONENTS & DRIVE TRANSMISSION
FACE UP GATE SOLENOID
SOLENOID PL17.5 <4475/5575/6675/7775> Exit 2 Drive Motor
ON (L) +24VDC P631 J631 J263 P263 3
40 A10 BLU A6 A10 1 2 Exit 2 Sensor
BLU
DC COM
5
A9 BLU A7 A9 BLU 2 1
INTLK F2
+24VDC
(1.12 H3)
The coil resistance of the Face Up Gate Solenoid is
3 60Ω±10%. (Coil Tem. 20 ℃)
NOTE:
1 Wire Color varies depending on the model. 4 On : Face Up on the exit side.
2275/3373/3375 : GRY Off : Exit 2 on the exit side.
<2275/3373/3375>
4475/5575 : WHT Wire Color varies depending on the model. Exit 2 Drive Motor
6 6675/7775 : VIO 5
4475/5575 : WHT
6675/7775 : VIO
2275/3373/3375:The Exit 2 Drive Motor winding resistance is 5.7Ω±10% Face Up Gate Solenoid
2 4475/5575:The Exit 2 Drive Motor winding resistance is 0.9±15%Ω(25℃) TD Test Point: Motor Driver Sub PWB J522-A10 (+) to GND (-)
6675/7775:The Exit 2 Drive Motor winding resistance is 1.5±15%Ω(25℃) 1 With sensor connected, approx. +1.24VDC
j0se731010

Chain 10 Fusing and Paper Transportation


7-149 7.3 BSD
7-150 7.3 BSD
Chain25 ESS
A B C D E F G H J
25.1 ESS FAIL CODE
ESS PWB 062-328
PL35.2 SD CARD
J1332 STD . PROGRAM PWBA Configuration
1 STD. FONT Fail
P300 DARTS3 PWB
SEE POWER PL35.2
CH1 IIT/IPS
P322 J322 J740 SCAN
DATA
J351 062-328 SEE CH5,6
SEE EPSV STD. PROGRAM
CH3 ROM (On Board)
OPTION
2 J342 PAGE MEMORY
USB FOR
SEE PSW 512MB(On Board) RISER2 PWB IMAGE COMP.
CH3 PL35.3 PWB (SELENE2) NOTE:
J332 PL35.3
J344 FONT ROM J3480 P3480 1 For the fail code for the controller, see Chapter 2 Controller FIP.
USB FOR (OPTION)(R2)
SEE PRINT 2
CH3 J330 Chip Fuse
1
Standard RAM
(M1)
GIGA BIT J340
3
ETHERNET J348 P348

BP PWB
PL18.2
HDD KIT 34.1
4 FAX DATA P309 J309 P1312 FAX DATA FAX DATA
(USB1.1) (USB1.1) (USB1.1) 34.2

USB CABLE
P310 +24VDC PL18.8/18.10
TX+/- (1.7 G1) 2
F501
HDD 1A
PL35.2 RX+/- S
LOW P335 J335 G ESS FAN
55
J313 P233 J233 PL18.2
5 P302 DC COM S D 1 BLU 4 1
4 HIGH G
124 MOT
HDD
+5VDC DC COM D
(1.3 F2) 4 BLU 1 4
DC COM
(1.4 J2)
BP PWB ESS PWB
P335 P335 PL18.2 PL35.2
VIDEO DATA
SEE CH6 CIE
ESS FAN +3.3VDC
6 FAIL(H)
J233 P233 +3.3VDC J313 J335 P335
3 2 3 125
BLU

j0se732501
A B C D E F G H J
25.2 ESS STATUS LED (1/4)
Illumination Status and Description of On Board Debug LEDs
1 LED Pattern LED Pattern
Number

点灯 消灯 On Off

Situation Problem Normal LongBoot Related


Diagnosis Diagnosis Fail Code
1 Initial status at power-on On: ESS failure ○ ○ -
2 CPU CORE initial settings completed On: ESS failure ○ ○ -
3 DDR initialization completed On: ESS failure ○ ○ -
2 4 Access window settings completed On: ESS failure ○ ○ -
5 Pre-DDR access waiting process completed On: ESS failure ○ ○ -
6 DDR memory Write check completed On: ESS failure ○ ○ -
7 DDR memory check completed On: ESS failure ○ ○ -
8 DDR memory zero-clearing completed On: ESS failure ○ ○ -

9 Copying a program to memory (Text) On: ESS failure ○ ○ -

10 Copying a program to memory (Base) On: ESS failure ○ ○ -


3
11 Stack point settings completed Blinking: ESS failure ○ ○ -
12 Hardware initialization started On: ESS failure ○ ○ -
13 I2C module initialization completed On: ESS failure ○ ○ -
14 Interrupt controller initialization completed On: ESS failure ○ ○ -
15 GIO settings completed On: ESS failure ○ ○ -
16 PCI configuration completed On: ESS failure ○ ○ -
4 17 MSR register initialization completed On: ESS failure ○ ○ -
18 HID0 register initialization completed On: ESS failure ○ ○ -
19 Debug serial initialization completed On: ESS failure ○ ○ -
20 RTC device initialization completed On: ESS failure - - -
21 PCI-Express module initialization completed On: ESS failure ○ ○ -
22 External PCI device initialization completed On: ESS failure - - -
23 USB Host module initialization completed On: ESS failure - - -
5 24 USB Device module initialization completed On: ESS failure - - -
25 Software initialization started On: ESS failure ○ ○ -
26 MacAddress retrieval and save completed On: ESS failure ○ ○ -
27 Memory area parameter settings completed On: ESS failure ○ ○ -
28 Command table initialization completed On: ESS failure ○ ○ -
29 Debug serial interrupt enabling completed On: ESS failure ○ ○ -
30 CPU CPIO interrupt enabling completed On: ESS failure ○ ○ -
6 31 Timer interrupt enabling completed On: ESS failure ○ ○ -
32 Other interrupt enabling completed On: ESS failure ○ ○ -
33 USB Host interrupt enabling completed On: ESS failure - - -
j0se732502

Chain25 ESS
7-151 7.3 BSD
7-152 7.3 BSD
Chain25 ESS
A B C D E F G H J
25.3 ESS STATUS LED (2/4)
Illumination Status and Description of On Board Debug LEDs Long
LED Pattern 通常 Boot 関連
1 診断 Fail Code
Number

点灯 消灯 診断

Situation Problem Normal LongBoot Related


Diagnosis Diagnosis Fail Code
34 SATA interrupt enabling completed On: ESS failure - - -
35 SDCARD module initialization completed On: ESS failure ○ ○ -
36 Jump to MiniOS section On: ESS failure ○ ○ -
37 Jump to ASIC Main section On: ESS failure ○ ○ -
2
Upper and lower LEDs are illuminated alternately.
38 DDR initialization failed Blinking: ESS failure ○ ○ -

Upper and lower LEDs are illuminated alternately.


39 DDR memory read/write test error Blinking: RAM failure ○ ○ -

Upper and lower LEDs are illuminated alternately.


40 PCI-Express cannot be recognized Blinking: ESS failure ○ ○ -

41 Pre-DDR access waiting process completed On: ESS failure - - -


3 (for CPU OFF recovery)
Pre-DDR access waiting process completed
42 (for CPU OFF recovery) On: ESS failure - - -

43 NVRAM write protect removal completed On: ESS failure - - -

44 Jump to CPU OFF recovery processing function On: ESS failure - - -


completed
45 Saved data checksum calculation completed On: ESS failure - - -
Checking checksum value comparison result
46 completed On: ESS failure - - -
4
47 Data Cache clear processing completed On: ESS failure - - -
48 ASIC initialization completed On: ESS failure - - -
49 Data Cache disabling completed On: ESS failure - - -
Upper and lower LEDs are illuminated alternately.
50 Stored data checksum error at recovery from the Blinking: ESS/RAM failure - - -
power saving mode
51 SD module initialization started Blinking: RAM/SDCARD failure ○ ○ 117-329
52 SD module register initialization completed Blinking: RAM/SDCARD failure ○ ○ 117-319
5
53 SD module interrupt settings completed Blinking: RAM/SDCARD failure ○ ○ 117-319
54 SD module clock initialization completed Blinking: RAM/SDCARD failure ○ ○ 117-319
55 SD card initialization command 1 completed Blinking: RAM/SDCARD failure ○ ○ 117-321
56 SD card clock enabling completed Blinking: RAM/SDCARD failure ○ ○ 117-321
57 SD card initialization completed Blinking: RAM/SDCARD failure ○ ○ 117-321
58 SD card unlocking completed Blinking: RAM/SDCARD failure ○ ○ 117-319
59 SD card information retrieval completed Blinking: RAM/SDCARD failure ○ ○ 117-319
6
60 SD card bus width settings completed Blinking: RAM/SDCARD failure ○ ○ 117-319
61 SD module initialization completed Blinking: RAM/SDCARD failure ○ ○ 117-319
62 SD card reading started Blinking: RAM/SDCARD failure ○ ○ 117-319
j0se732503
A B C D E F G H J
25.4 ESS STATUS LED (3/4)
Illumination Status and Description of On Board Debug LEDs
LED Pattern
1
Number

点灯 消灯

Situation Problem Normal LongBoot Related


Diagnosis Diagnosis Fail Code
63 SD module initial check completed Blinking: RAM/SDCARD failure ○ ○ 117-319
64 Program extraction to memory completed Blinking: RAM/SDCARD failure ○ ○ -
Upper and lower LEDs are illuminated alternately.
65 Program data decompression error Blinking: RAM/SDCARD failure ○ ○ 117-319
2 66 Absence of BackPlane detected On: BackPlane connection failure ○ ○ 16-327
67 Disconnection of UI cable detected On: UI cable connection failure ○ ○ 16-326
68 Disconnection of MCU cable detected On: MCU harness connection failure ○ ○ 16-328

69 Detected that an unknown device is connected as a On: Unsupported device detected as PCI ○ ○ 117-336
PCI option Option
Detected that an unknown device is connected as a On: Unsupported device detected as PCIEX
70 PciE option Option ○ ○ 117-337

71 Absence of SD card detected On: SD card connection failure ○ ○ 117-338


3
72 Diagnosis of IO ASIC started On: ASIC failure ○ ○ -
73 Diagnosis of Codec ASIC started On: ASIC failure ○ ○ -
116-380
74 Diagnosis of standard Font ROM started On: ASIC failure ○ ○ 116-310
16-338
16-339
75 Diagnosis of extended Font ROM started On: ASIC failure ○ ○ 16-341

76 SEEP diagnostics started On: SEEPROM failure - ○ 16-351


4 16-350
77 Timer diagnostics started On: Timer failure ○ ○ 16-343
78 Page Memory diagnosis started On: RAM failure - ○ 16-317
16-315
16-316
79 IIT IF diagnosis started On: IIT/ESS failure - ○ 16-317
16-318
16-348
80 RTC diagnosis started On: RTC failure - ○ 16-342
5
81 Lyra diagnosis started On: JPEG Card I failure - ○ -
82 Diagnosis of USB1.0 Host started On: ESS failure - ○ 16-371
83 Diagnosis of USB2.0 Host started On: ESS failure - ○ 16-364
84 Diagnosis of USB2.0 Device started On: ESS failure - ○ 16-365
16-366
85 HDD diagnosis started On: HDD/ESS failure - ○ 16-367
86 HDD (UFS) diagnosis started On: HDD failure - ○ 16-372~
382
6
87 Diagnosis of Image Ext. PWB (TORINO) started On: Torino/ESS failure - ○ 16-368
88 Diagnosis of Image Comp PWB (SELENE) started On: Selene/ESS failure - ○ 16-369
89 UI Check started On: ESS/UI failure - ○ 16-362
j0se732504

Chain25 ESS
7-153 7.3 BSD
7-154 7.3 BSD
Chain25 ESS
A B C D E F G H J
25.5 ESS STATUS LED (4/4)

1
Illumination Status and Description of On Board Debug LEDs
LED Pattern
Number

点灯 消灯

Situation Problem Normal LongBoot Related


Diagnosis Diagnosis Fail Code
90 MAC/PHY diagnostics started On: ESS failure - ○ 16-349
117-324
117-323
91 SD card (UFS) diagnostics started On: SD/ESS failure - ○ 117-321
2 117-320

92 Diagnosis of Standard ROM started On: Standard ROM failure - ○ 116-317


16-336
93 Transitioning to power saving Power saving in operation - - -
(Standby to Low Power)
94 Power saving in operation (Low Power) Power saving in operation - - -
95 Power saving in operation (CPU Off) Power saving in operation - - -
96 Power saving in operation (Semi Low Powerf) Power saving in operation - - -
3 Transitioning to power saving
97 (Semi Low Power to Sleep) Power saving in operation - - -

98 Recovering from power saving Power saving in operation - - -


(Low Power to Standby)
99 Recovering from power saving (Sleep to Standby) Power saving in operation - - -
Power saving in operation (Sleep)
100 [USB sleep processing started] Power saving in operation - - -

101 Power saving in operation (Sleep) Power saving in operation - - -


[USB sleep processing completed]
4 Power saving in operation (Sleep)
102 [USB sleep processing impossible] Power saving in operation - - -

103 Power saving in operation (CPU Off) Power saving in operation - - -


[Recovery from CPU Off 1]
104 Power saving in operation (CPU Off) Power saving in operation - - -
[Recovery from CPU Off 2]
105 Power saving in operation (Sleep) Power saving in operation - - -
[Power Save completed]
106 VxWORKS boot completed Normal ○ ○ -
Recovery from power saving status
5

j0se732505
A B C D E F G H J
34.1 FAX (G4) (FX ONLY)
FAX PWB RISER PWB G4 PWB
PL18.9 PL18.9 PL18.9
1
25.1 FAX DATA CNP353 CNP355 CNJ355 CNJ363 CNP364 CNJ376
(USB1.1)
ISDN 1

1.6 +5VDC
(FAX) P904 J904 J910 CNP352 OPTION
5 1
GRY GRY G4 PWB
1.6 DC COM PL18.9
2 On or (5V RTN)
6 2 CNJ364 CNP364
Off VIO VIO
CNJ376
1.8 +24VDC
(FAX) ISDN 2
ORN
3 ORN 5
1.8 DC COM
(24V RTN)
VIO
4 VIO
6
2
DC POWER
SUPPLY (F503)
3 PL18.8 G3 PWB
STANDBY PL18.9
1.4 FAX STBY +3.3VDC CNP363
+5VDC J651 +5VDC J651 (Always ON)
Always TO CNJ372
1 GRY 1 5 3
On GRY GRY
+3.3VDC Line 4
1.4 DC COM
(STBY 5V RTN) 3.3V RTN
VIO
2 VIO
3 4 VIO
4

SPEAKER OPTION
4 PL18.9
HAND SET
CNP356 PWB
PL18.9 Handset
RED
CNJ365 CNJ366 CNJ367
BLK

JP610
1

5 CNJ359
JP612 LINE
1 Line 1
EXTENSION PWB
PL18.9

CNP362 CNP361 CNJ361 CNJ360


Extension TEL (NOT USED)
6

j0se733401

Chain 34 FAX
7-155 7.3 BSD
7-156 7.3 BSD
Chain 34 FAX
A B C D E F G H J

34.2 FAX mini OPTION


FAX mini PWB RISER PWB AG3 PWB
PL18.11 PL18.11 PL18.11
1 SLOT 2 NCU
FAX DATA J355 P355 P363 J363 LINE2
25.1 J353
(USB1.1) DATA/SIGNAL
1 2
FG2
SPEAKER +5VDC
PL18.11 STBY +3.3VDC
+5VDC SQ REG.
+5VDC +5VDC
SPKR- J356 -
Volume STBY STBY
2 2 Control N.C
SPKR+ BLK AMP
RED
1 + +3.3VDC GND FG1

GND 3 FG3
AGND
+5VDC
1.6 +5VDC SQ
(FAX) P904 J904 J352 P352
5 1 AG3 PWB
On or Off GRY GRY GRY
F604 PL18.11
3 1.6 DC COM 1A
(5V RTN) +5VDC NCU
6 2 STBY +3.3VDC SLOT 3 LINE3
VIO VIO VIO
REG. P364 J364
AGND
2 FG2
N.C 3
GND
+5VDC +5VDC
Always On 1.4 DC COM STBY STBY +3.3VDC
(STBY 5V RTN)
2 4 REG.
VIO VIO VIO
+5VDC
4 GND
+24VDC
STBY
N.C
1.8 +24VDC SQ FG1
(FAX) GND GND
On or Off ORN ORN
3 ORN
5
F602
1.8 DC COM 1A
(24V RTN) 3 FG3
VIO VIO
4 VIO
6
NCU
+5VDC MJ1 LINE
FAX STBY 24V RTN STBY
Always On 1.4
+5VDC
5 GRY GRY
1 GRY
7
F601 OPTION (FX ONLY)
N.C 8 3.15A 2 HANDSET
MJ2 TEL
FG3

FG1
FG4 3
6
NOTE:
1 For details of Fax Fail Codes, see Chapter 2 Troubleshooting. 2 Surge absorber 3 This GND is located at a back corner of the PWB.
j0se733402

You might also like